Академический Документы
Профессиональный Документы
Культура Документы
High- technology polymer modified elastomeric waterproofing membrane system for concrete and masonry surfaces.
Typical Properties Uses Brushbond FLX III when fully cured provides a seamless elastic waterproof membrane for use in wet areas, precast joints where tough elastomeric watertight membrane is required. Advantages Can be applied to damp substrates No primer required Elastomeric- able to bridge cracks Able to foot traffic when cured Factory pre-blended two component system ensure quality control at site Standard Compliance Brushbond FLX III conforms to the requirements of; DIN 1048, Part 1 Clause 4.7 ASTM E96 : 92 ASTM D412 : 92 ASTM C836 : 89 ASTM D2240 : 91 ASTM D146 : 90 clause 14 & BS 4550 Part 2 : clause 17 Description Brushbond FLX III is a two component polymer modified waterproof membrane which is supplied in ready mix kits. When mixed, an easily brush-able coating is produced. It can be simply be applied by a stiff brush, roller, or trowel to obtain the desired thickness. Brushbond FLX III consists of specially selected cements, graded hard wearing aggregates and additives supplied in powder form together with a liquid component of polymers providing exceptional toughness and durability. Preparation adhesion, resiliency, flexibility, Application Instructions Chloride Content Crack Bridging (ASTM C836) Resistance to water Penetration (DIN 1048) Tensile strength (N/mm ) (ASTM D412)
2
constructive solutions
Approx 1 Hour
______________________________________________ Adhesion to concrete after 10 days ambient curing : 0.5N/mm2 ______________________________________________ Shore A Hardness after 7 days ambient curing : 68 ______________________________________________ : 1.5 N/mm2
_____________________________________________
_____________________________________________ Sharp folding crack resistance @ 0.8 -1.0mm thick : No Cracking _____________________________________________ Touch Dry time for 500 micron wft On concrete : < 2hours ______________________________________________
All surfaces which are to receive Brushbond FLX III Technical Support The company provides a technical advisory service supported by a team of specialist in the field. coating, must be free from oil, grease, wax, dirt or any other form of foreign matter which might affect adhesion. Spalled and deeply disintegrated concrete should be
Page 1
constructive solutions
Page 2
* Denotes the trademark of Fosroc International Limited See separate datasheet This product is approved under the Green Label Singapore as Environmentally Friendly / Near Zero VOC Finish / Coating
Important note
Fosroc products are guaranteed against defective materials and manufacture and are sold subject to its standard Conditions for the Supply of Goods and Services, copies of which may be obtained on request. Whilst Fosroc endeavours to ensure that any advice, recommendation, specification of information it may give is accurate and correct, it cannot, because it has no direct or continuous control over where or how its products are applied, accept any liability either directly or indirectly arising from the use of its products, whether or not in accordance with any advice, specification, recommendation of information given by it.
Fosroc Singapore
30 Toh Guan Road #07-07, ODC Districentre Singapore 608840
email: Fosroc.Singapore@Fosroc.com
032 032 Environmentally Friendly / Near Zero VOC Finish / Coating
www.fosroc.com
Page 3