Вы находитесь на странице: 1из 10

A R M Y COMBAT UNIFORM

USE CARE AND FIT MANUAL

Trouser Sizes (continued)

F O R W AR D

LARGE
X-Short Short Regular Long X-Long XX-Long

INSEAM
Up to 26 in 26 to 29 29 to 32 32 to 35 35 to 38 Over 38 in.

WAIST
35 to 39 in 35 to 39 in 35 to 39 in 35 to 39 in 35 to 39 in 35 to 39 in

NSN
8415-01-527-5269 8415-01-519-8532 8415-01-519-8435 8415-01-519-8434 8415-01-519-8436 8415-01-527-5273

This booklet provides care instructions for the Army Combat Uniform (ACU) Coat, Trousers, Patrol Cap, and Boots. The ACU provides the greatest protection when taken care of and worn properly.

X-LARGE
X-Short Short Regular Long X-Long XX-Long

INSEAM
Up to 26 in 26 to 29 29 to 32 32 to 35 35 to 38 Over 38 in.

WAIST
39 to 43 in 39 to 43 in 39 to 43 in 39 to 43 in 39 to 43 in 39 to 43 in

NSN
8415-01-527-5274 8415-01-519-8444 8415-01-519-8445 8415-01-519-8446 8415-01-527-5275 8415-01-527-5277

C AU T I O N

XX-LARGE
X-Short Short Regular Long X-Long XX-Long

INSEAM
Up to 26 in 26 to 29 29 to 32 32 to 35 35 to 38 Over 38 in.

WAIST
43 to 47 in 43 to 47 in 43 to 47 in 43 to 47 in 43 to 47 in 43 to 47 in

NSN
8415-01-527-5290 8415-01-527-5291 8415-01-519-8447 8415-01-527-5292 8415-01-527-5293 8415-01-527-5296

Use of commercial or heated press (dry cleaning, starch, or hot iron) will damage hook-and-loop areas and the zipper of this uniform.

CO AT The ACU Coat is a single-breasted design with long sleeves and a stand-up collar. The Coat has a zippered front closure reinforced with hook-and-loop fastener tape providing a smooth outer surface. The front has two angled chest pockets with hook-andloop closure flaps. Above each chest pocket, there are loop fastener tape strips. The name tape will be placed on the right, US Army tape on the left. Centered on the chest, between the breast pockets, is a loop fastener to hold the individuals rank insignia. The back of the coat contains an integrated bi-swing pleat.

Trouser Sizes

X-SMALL
X-Short Short Regular Long X-Long XX-Long

INSEAM
Up to 26 in 26 to 29 29 to 32 32 to 35 35 to 38 Over 38 in.

WAIST
Up to 27 in Up to 27 in Up to 27 in Up to 27 in Up to 27 in Up to 27 in

NSN
8415-01-519-8277 8415-01-519-8404 8415-01-519-8410 8415-01-519-8427 8415-01-519-8408 8415-01-519-8279

SMALL
X-Short Short Regular Long X-Long XX-Long

INSEAM
Up to 26 in 26 to 29 29 to 32 32 to 35 35 to 38 Over 38 in.

WAIST
27 to 31 in 27 to 31 in 27 to 31 in 27 to 31 in 27 to 31 in 27 to 31 in

NSN
8415-01-519-8416 8415-01-519-8414 8415-01-519-8423 8415-01-519-8418 8415-01-519-8419 8415-01-527-5247

The upper sleeves each contain loop fastener covered pockets to hold left and right Shoulder Sleeve Insignia, (unit and combat patches), skill tabs, and US Flag. The top flap of each sleeve pocket bears a piece of Identification Friend or Foe (IFF) tape. Below each sleeve pocket, there are openings secured by hook-and-loop fasteners for the elbow pads to be inserted. The left sleeve contains a three-channel pen/pencil pocket. The cuff openings can be adjusted by the use of hookand-loop fasteners.

MEDIUM
X-Short Short Regular Long X-Long XX-Long

INSEAM
Up to 26 in 26 to 29 29 to 32 32 to 35 35 to 38 Over 38 in.

WAIST
31 to 35 in 31 to 35 in 31 to 35 in 31 to 35 in 31 to 35 in 31 to 35 in

NSN
8415-01-519-8422 8415-01-519-8426 8415-01-519-8429 8415-01-519-8430 8415-01-519-8431 8415-01-527-5266

Coat Sizes (continued)

LARGE
XX-Short X-Short Short Regular Long X-Long XX-Long

HEIGHT
55 to 59 in 59 to 63 in 63 to 67 in 67 to 71 in 71 to 75 in 75 to 79 in Above 79 in

CHEST
41 to 45 in 41 to 45 in 41 to 45 in 41 to 45 in 41 to 45 in 41 to 45 in 41 to 45 in

NSN
8415-01-527-5219 8415-01-519-8514 8415-01-519-8532 8415-01-519-8599 8415-01-519-8607 8415-01-519-8608 8415-01-519-8611

X-LARGE
XX-Short X-Short Short Regular Long X-Long XX-Long

HEIGHT
55 to 59 in 59 to 63 in 63 to 67 in 67 to 71 in 71 to 75 in 75 to 79 in Above 79 in

CHEST
45 to 49 in 45 to 49 in 45 to 49 in 45 to 49 in 45 to 49 in 45 to 49 in 45 to 49 in

NSN
8415-01-527-5220 8415-01-527-5222 8415-01-527-5049 8415-01-519-8613 8415-01-519-8610 8415-01-519-8609 8415-01-527-5223

XX-LARGE
Regular Long X-Long XX-Long

HEIGHT
67 to 71 in 71 to 75 in 75 to 79 in Above 79 in

CHEST
49 to 53 in 49 to 53 in 49 to 53 in 49 to 53 in

NSN
8415-01-527-5051 8415-01-527-5053 8415-01-519-8612 8415-01-527-5224

SPECIAL FIT INSTRUCTIONS


Coat Sizes
The ACU should fit comfortably, should not be tight or binding. X-SMALL
XX-Short X-Short Short Regular Long X-Long

HEIGHT
55 to 59 in 59 to 63 in 63 to 67 in 67 to 71 in 71 to 75 in 75 to 79 in

CHEST
UP to 33 UP to 33 UP to 33 UP to 33 UP to 33 UP to 33 in in in in in in

NSN
8415-01-527-5215 8415-01-519-8487 8415-01-519-8491 8415-01-519-8497 8415-01-527-5047 8415-01-527-5048

COAT Coat Fit Instructions


1. Put on the uniform, close all fasteners. 2. Bend the arms at a 90 degree angle. 3. The elbow must be within the elbow pad area.

SMALL Outer Edge of Elbow Pad Area


XX-Short X-Short Short Regular Long X-Long

HEIGHT
55 to 59 in 59 to 63 in 63 to 67 in 67 to 71 in 71 to 75 in Above 75 in

CHEST
33 to 37 in 33 to 37 in 33 to 37 in 33 to 37 in 33 to 37 in 33 to 37 in

NSN
8415-01-519-8499 8415-01-519-8500 8415-01-519-8502 8415-01-519-8501 8415-01-519-8504 8415-01-519-8506

Elbow MEDIUM
XX-Short X-Short Short Regular Long X-Long XX-Long

HEIGHT
55 to 59 in 59 to 63 in 63 to 67 in 67 to 71 in 71 to 75 in 75 to 79 in Above 79 in

CHEST
37 to 41 in 37 to 41 in 37 to 41 in 37 to 41 in 37 to 41 in 37 to 41 in 37 to 41 in

NSN
8415-01-519-8505 8415-01-519-8507 8415-01-519-8509 8415-01-519-8510 8415-01-519-8512 8415-01-519-8513 8415-01-527-5218

Coat Fit Instructions Continued


4. Lower the arms to the side, the hem of the Coat should not extend past the pockets on the trousers. 5. The sleeves should not extend past the first knuckle of the persons thumb. Hem

Pocket Hot Weather Combat Boot

CAUTION
Exposing boots to excessive heat to dry, including hair dryers, heating vents, stoves etc will damage the boots. Alcohol or oil-based cleaners may damage your boots.

Repair and Wear Standards


Holes or tears render the boot unserviceable and the boots should be replaced. Your Combat Boots come with a replaceable rubber outsole. Replace the rubber outsole before wear reaches the softer midsole material or permanent damage to your boots will occur. The midsole is the soft cushioned material between the rubber outsole and the boot upper.

Sleeve Edge

First Knuckle of Thumb

TROUSER
The trousers have a four-button front fly and an adjustable waist drawstring. There are right and left hip pockets and two rear button pockets. The tilted cargo pockets on each leg are secured by hook-and-loop fasteners and an elastic drawstring with barrel lock. Below the cargo pockets, there are openings secured by hook-and-loop fasteners for the knee pads to be inserted. The left and right lower leg pockets are also secured by hook-and-loop fasteners, and the legs contain hem draw cords.

AR M Y C O M B AT B O O T
Temperate Weather & Hot Weather Combat Boots 1. Sizes: These boots are supplied in whole and half sizes 2 through 16 and widths N (B), R (D), W (EE), and XW (EEEE). In some instances, it may be necessary to select a slightly larger size than normally worn in order to allow for normal swelling of the feet and the use of insole inserts or cushioned socks. 2. Breaking-In: DO NOT soak boots in water or bake in an oven to break-in. Boots should be worn-in gradually at first with ever-increasing walking or marching distances while remaining comfortable. 3. Your Hot Weather Combat Boots are water-resistant, and are meant to be worn when it is most comfortable to the user. Your Temperate Weather Combat Boots are waterproof and are designed for wear in cooler temperatures above 32F. Boots may become damp or wet due to excessive perspiration or water coming over the top of the boot. If boots become wet, empty excess water, change socks, and continue to wear while changing socks regularly. Boots will dry much faster when worn than if left to stand and dry. 4. Trousers should be bloused over the outside and below the comfort collar of the boot. CLEANING INSTRUCTIONS Your Combat Boots are designed to be easy to care for. The nylon quarter side panels of your boots are as strong as leather and will last if cared for properly. To clean your Combat Boots, brush with stiff nylon bristle brush to clean and then rinse with warm water. You may use a water soluble cleaning product for stubborn stains.

PATROL CAP
1. Sizes: This cap is supplied in sizes 6 3/8 through 8, in 1/8 increments. 2. Cap: Camouflage, cotton/nylon, wind-resistant ripstop poplin water repellent cloth with a circular crown and pocket inside, conforming to type IV of MIL-C 43468, NSN 841 5-01196 9106 through 8415-01-196-9128.

Trouser Fit Instructions


1. With the uniform on, bend the knee to a 90 angle. 2. The knee cap must be within the knee pad area shown in diagram. Top of Pocket

Knee Cap

WASH INSTRUCTIONS
1. Hand or machine wash using permanent press cycle, cold water, and mild detergent. 2. DO NOT WRING OR TWIST. Rinse in clean cold water. 3. Dry at low heat (Do not exceed 130 degrees Fahrenheit) or hang dry. Bottom of Pocket

CAUTION
CHLORINE BLEACH or STARCH will damage the Cap .

Pocket (Inside top of Cap)

Loop (for Name Tape)

Trouser Fit Instructions Continued


3. The bottom of the calf pocket should not be below the top of the boot.

ACU WASH INSTRUCTIONS


1. Before washing, remove all patches from the coat, and all items from the pockets. Close all hook-and-loop fasteners to prevent snagging. 2. WASHING. Machine wash in cold water, using permanent press cycle, or hand wash using a mild detergent that does NOT contain optical brighteners. Rinse completely. DO NOT WRING OR TWIST. Hang dry or machine dry on low to medium setting, between 140 160 degrees Fahrenheit.

Bottom of Calf Pocket

CAUTION
Top of Boot The use of chlorine bleach, dry cleaning, starching, or commercially hot pressing the ACU will permanently damage the uniform.

CAUTION
Applying heat or iron to any hook and loop fastener area will permanently damage the fasteners.

REPAIR
Small rips and tears can be hand or machine stitched, or mended with the use of patches.

REPLACE GARMENT IF:


1. Rips or tears cannot be repaired. 2. Hook and loop fasteners are melted, frayed, or otherwise rendered unserviceable. 3. Zipper fails or becomes damaged.

Вам также может понравиться