Академический Документы
Профессиональный Документы
Культура Документы
0 TL3
Software-Update Guide V2.17
When you plug the USB drive containing the software update into the inverter, a message will appear on the display (see figure 1). To proceed with the update, confirm the notification with Yes. To cancel the update process and close the shown window, confirm with No. You can change the selection using the arrow buttons and confirm by pressing the Enter button. After copying of the software update to the device has been finished, the system automatically restarts itself and begins with the updates. During this process you can see the current status on the display. The complete update may take several minutes. When updating from an older software version (V1.xx), the update may take up to 30 minutes in total. Caution! Do not power off DC during the software update process and perform the update during daytime or at a sufficient DC power level! Do not remove the USB drive until the message from figure 1 appears and the update process has been completely finished! Otherwise the update of some critical components may fail, the software will be corrupted or the inverter will be damaged!
To control the success of the software update, please have a look at the software information dialog in the information menu and check the versions (see SW-Versions to check) of all single components.
SW-Versions to check
o PKT: o ARM: o CFG: o DSP-AC: o DSP-DC: V2.17 V2.20 (596C) V5.0602 (A134) V1.66 (D2E9) V1.54 (8678)
Checking the correct software version requires DC power supply because all system components have to be present (the update of the menu dialog may take some seconds). Please note that the software versions may vary according to the chosen country. In those cases check the Build-Code inside the brackets of each software version to verify that the update was successfully finished.
-2-
The software package on the USB drive is incomplete. Please copy respectively extract the desired software package to the used USB drive again and overwrite the existing data. Afterwards please continue the update.
Please get in touch with the KACO service department. -19 -21 -22
-3-