12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 12

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

COMPRESSION SPRINGS
Century Spring warehouses the largest inventory of
high-grade, straight, cylindrically-shaped compression
springs in the world. All the springs found in this section
of the catalog are fabricated from round wire.
Rectangular wire is sometimes employed to reduce the

solid (totally compressed) height or increase the space

efficiency of the design. Century Springs die springs are
made from rectangular wire for this reason. (See the
Die Spring section of this catalog.)

Selecting a Compression Spring:

Turn to the inventory page with the desired outside diameter

(O.D.). Outside diameters increase as page numbers increase
and are found in the left column of the page.

COMPRESSION SPRINGS

Next, find the length or rate (strength) you require.

These, too, are normally in increasing order.
Spring rate is the load (pounds) it takes to deflect
(compress) the spring one theoretical inch, i.e., if the
rate = 40 lbs./in., it would take 10 pounds to deflect it
1/4 inch, or 80 pounds for 2 inches, etc..
If the length or rate is not known but the installed
working length (W.L.) is, then select a spring say
30% longer than the W.L..
You must know the load at the W.L.. Just subtract the
W.L. from the springs selected free length and

multiply by its rate to obtain the load to compare with

your required value.
If the load required is not obtained, select a new
candidate with either an increase or decrease in rate
(strength) or free length.
Be certain that the tabulated solid length (completely
compressed) for your candidate spring indicates
enough room for deflection and, also, that the
deflection is not significantly greater than the
tabulated Maximum Suggested for stress reasons.
Note: If the spring needed for your application cannot be
found in our catalog inventory, we can fabricate it for you.
Often, there is no cost increase for this service as we have
low quantity requirements.

Design Information
The basic compression rate and wire stress for a compression
spring can be estimated with the following:

Note: One should not employ the curvature (k) correction

stress in an expression solving for deflection. Use the
uncorrected stress only or errors will occur. The uncorrected
stress can be used for static applications.
Large wire and bar stock s iz es also require an empiricallyderived reduction in the standard rate calculation of up to 9%.

12

For these reasons, refinements in large spring design should

be left to the experienced spring designer.
Where: D = Mean diameter, (O.D. - d) inches
d = Wire diameter, inches
G = Modulus (spring steel = 11.5x10 6,
stainless = 10x10 6), p.s.i.
K = Stress correction factor (see plot)
N = Number of total coils
n = Number of active coils (see table)
P = Applied load, pounds
p = Pitch, distance between centerlines
of wires of adjoining coils
R = Spring rate, pounds per inch (lbs./in.)
S = Wire stress, psi
= Deflection, inches
= 3.14

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 13

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Design Information (continued)

The suggested maximum allowable spring-wire stress
values can be derived from the Minimum Tensile Strength
(MTS) tables found in the Material Properties section of
this catalog. The MTS values vary with the spring-wire
diameter. Further, 30 to 45 percent of the MTS value,
depending on the material type, is used as a corrected
stress target to produce a long fatigue life. The table,
Properties of Common Spring Materials, found also in the
Material Properties section of this catalog, indicates the
appropriate percentage value of the MTS to use for a given
spring material.

WAHL CURVATURE STRESS CORRECTION

Spring Characteristics
Service Life
It should be noted that if critical force-versus-deflection
linearity is required, only the center 60 to 80 percent of the
available deflection range should be employed. Thus, reserve
at least the first and last 15 to 20 percent of the range for
potential spring-end and adjacent coil-contact effects. These
effects can be largely ignored for the majority of spring
applications.
The column Suggested Maximum Deflection found in the
following pages of inventory reflects the recommended inches
of travel to obtain a statistical service-life of approximately
100,000 cycles (deflections) with infrequent breakage. This
can be realized if the spring in question is not subjected to
shock loads, rapid cycling, temperature extremes, corrosion or
stress values above those previously recommended. If the
spring is statically loaded (not cycling), a near-infinite life can
be expected. Extended spring service-life can be expected by
applying recommendations found in the Material Properties
section of this catalog.

Materials
The highest grades of spring wire are used for fabricating our
springs. To create cost-effective warehousing of our stock
spring inventory for our customers, we offer material
certification for custom springs only. Certifications of
conformance for geometric tolerances set by the Spring
Manufacturers Institute (SMI) are available for our stock
springs upon request. See the Custom Spring section of this
catalog if material trace certifications or unique materials are
required.

COMPRESSION SPRINGS

For free custom spring designs, call or fax our Custom

Spring Department. For quick stress checks on stock or
custom spring designs, or technical information, call or fax
our Engineering Department.

Spring Steel is a stock inventory term covering:

Music wire
Hard-drawn (MB) wire
Oil-tempered wire
Additionally, stock compression-spring materials include:
Stainless Steel (300 series)
Beryllium Copper
Phosphor Bronze

13

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 14

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Spring Characteristics (continued)

Tolerances
Century Spring manufactures stock springs to commercial
tolerances defined by the SMI. Calculated rates and loads
based on the SMI geometric tolerances have an approximate
+/- ten percent. Low or high-index springs will have higher
values. Compression springs characteristically have an
hourglass shape when coiled on an automatic coiler;
therefore, outside/inside tolerancing is applied to end coils
only. This is an important consideration when selecting a
spring that fits over a rod or inside a cylinder. Call us if tighter
tolerance values are required.
Regarding angle tolerance, the plane of the ground end of a
spring is usually within three degrees of the perpendicular-tothe-body axis of the spring.
Direction of Helix (wind)
The wind direction of our stock springs varies, both RHW and
LHW. Stock springs are not sorted for wind direction. To
order springs wound to a specific direction, please see page
376 for more information or contact our Custom Division at
800-237-5225.

COMPRESSION SPRINGS
14

Ends
The compression spring ends configuration is indicated in the
Ends column of our inventory listings which are:
Closed (C) - The last coil at each end is bent back to touch
the previous coil to create a flat base.
Closed and Ground (C&G) - The closed ends of a spring
ground to a more accurate flat base. This will
also reduce the solid length.
Open (O) - The spring end coils remain open, maintaining
the spring machines helical wind shape.
Finish
The finishes available for our compression springs are
as indicated in the Finish column of our inventory listing
which include:
Zinc
Gold Irridite
Black Oxide
Passivated (upon request)
None (can be plated upon request)

Data Required For Compression Springs

CURRENT DESIGN

SPRING TO BE DESIGNED

ADDL. INFO IF AVAILABLE

Outside Diameter ________________in.

To work in __________________in. hole

Material _________________________

Free Length_____________________in.

To work over_____________in. dia. shaft

Wind: Optional____Right ____Left ____

Wire Dia. _____________________dec.

To support ___lbs. ____lbs. at _____in.

Finish __________________________

Material _________________________

Rate per in. __________________lbs.

Style of ends: Cl. & Grd. _____________

Total Coils ______(or pitch)_________in.

Max. solid height _________________in.

Closed only ____________

Finish ___________________________

Max. deflection ____________________

Open or Plain __________

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 15

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.036
0.036
0.040
0.040
0.054
0.054
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.057
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062
0.062

.91
.91
1.02
1.02
1.37
1.37
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.45
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57
1.57

10075
JJ-7
2924
10778
RR-6
10619
70000
70000S
70009
70009S
70018
70018S
70001
70001S
70010
70010S
70019
70019S
70002
70002S
70011
70011S
70020
70020S
70003
70003S
70012
70012S
70021
70021S
70004
70004S
70013
70013S
70022
70022S
70005
70005S
70014
70014S
70023
70023S
70006
70006S
70015
70015S
70024
70024S
70007
70007S
70016
70016S
70025
70025S
70008
70008S
70017
70017S
70026
70026S
FF-21
HH-3
3724
N-157
3723
S-1011
B1-7
12496
JJ-49
B1-2
J-36
N-13
10749
B-59-A
A14-23
A15-1
B-401
B-402
3623
3720

.59
.63
.66
.69
.25
.72
.13
.13
.13
.13
.13
.13
.19
.19
.19
.19
.19
.19
.25
.25
.25
.25
.25
.25
.31
.31
.31
.31
.31
.31
.38
.38
.38
.38
.38
.38
.44
.44
.44
.44
.44
.44
.50
.50
.50
.50
.50
.50
.56
.56
.56
.56
.56
.56
.63
.63
.63
.63
.63
.63
.13
.13
.13
.14
.16
.16
.16
.19
.25
.25
.25
.25
.28
.31
.34
.38
.50
.50
.69
.72

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

15.1
15.9
16.8
17.5
6.4
18.3
3.3
3.3
3.3
3.3
3.3
3.3
4.8
4.8
4.8
4.8
4.8
4.8
6.4
6.4
6.4
6.4
6.4
6.4
7.9
7.9
7.9
7.9
7.9
7.9
9.7
9.7
9.7
9.7
9.7
9.7
11.2
11.2
11.2
11.2
11.2
11.2
12.7
12.7
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
14.2
14.2
16.0
16.0
16.0
16.0
16.0
16.0
3.2
3.2
3.3
3.6
4.0
4.0
4.0
4.7
6.4
6.4
6.4
6.4
7.1
7.9
8.7
9.5
12.7
12.7
17.4
18.2

I.D.
Inches

.022
.024
.020
.028
.036
.038
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.045
.045
.043
.043
.041
.041
.048
.044
.042
.036
.052
.034
.032
.050
.048
.046
.044
.042
.046
.046
.052
.044
.046
.042
.044
.046

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

.6
.6
.5
.7
.9
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.2
1.1
1.1
.9
1.3
.9
.8
1.3
1.2
1.2
1.1
1.1
1.2
1.2
1.3
1.1
1.2
1.1
1.1
1.2

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

2.6
.46
1.6
.28
11
2.0
1.0
.17
6.2
1.1
1.6
.29
3.7
.66
3.3
.57
6.9
1.2
6.0
1.1
12
2.1
11
1.8
2.3
.40
2.0
.35
4.0
.70
3.5
.61
7.4
1.3
6.4
1.1
1.7
.30
1.5
.26
3.1
.54
2.7
.47
5.3
.92
4.6
.80
1.4
.24
1.2
.21
2.4
.42
2.1
.37
4.1
.72
3.6
.62
1.1
.19
.96
.17
2.0
.35
1.7
.31
3.4
.59
3.0
.52
.95
.17
.83
.14
1.7
.30
1.5
.26
2.8
.50
2.5
.43
.85
.15
.74
.13
1.5
.26
1.3
.23
2.5
.43
2.1
.37
.75
.13
.65
.11
1.3
.23
1.1
.20
2.2
.39
1.9
.34
.65
.11
.57
.10
1.2
.20
1.0
.18
2.0
.35
1.7
.30
4.1
.73
11
1.8
20
3.6
50
8.7
.33
.06
72
13
156
27
1.8
.31
2.6
.45
5.3
.94
5.8
1.0
7.0
1.2
3.0
.52
5.2
.90
.46
.08
5.5
.96
1.7
.30
4.4
.76
2.6
.46
1.0
.18

.15
.16
.13
.35
.09
.37
.07
.05
.06
.04
.05
.03
.11
.08
.10
.07
.08
.06
.15
.11
.13
.10
.11
.08
.19
.14
.17
.12
.14
.10
.23
.17
.20
.15
.17
.12
.26
.20
.23
.18
.20
.15
.30
.22
.26
.20
.23
.17
.34
.25
.31
.23
.26
.19
.39
.29
.34
.26
.29
.21
.07
.04
.05
.01
.07
.02
.02
.13
.09
.10
.12
.09
.16
.10
.19
.14
.30
.23
.28
.40

3.8
4.1
3.2
8.9
2.2
9.3
1.7
1.3
1.5
1.1
1.2
.88
2.8
2.1
2.5
1.9
2.0
1.4
3.8
2.8
3.3
2.5
2.8
2.0
4.7
3.6
4.2
3.2
3.6
2.6
5.8
4.4
5.0
3.8
4.3
3.1
6.7
5.1
5.9
4.5
5.1
3.8
7.5
5.7
6.7
5.1
5.9
4.3
8.6
6.5
7.7
5.9
6.6
4.8
9.9
7.5
8.8
6.6
7.3
5.3
1.8
1.1
1.3
.25
1.7
.59
.47
3.3
2.4
2.5
3.1
2.3
4.0
2.6
4.9
3.4
7.6
5.9
7.2
10

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.39
.25
1.4
.35
.56
.60
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.25
.17
.40
.26
.57
.37
.29
.46
1.0
.50
.02
1.7
2.9
.23
.24
.53
.71
.63
.47
.53
.09
.75
.51
1.0
.75
.41

1.7
1.1
6.4
1.6
2.5
2.7
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.1
.74
1.8
1.2
2.5
1.6
1.3
2.1
4.5
2.2
.10
7.4
13
1.0
1.1
2.4
3.2
2.8
2.1
2.4
.40
3.3
2.3
4.5
3.3
1.8

Inches

.35
.25
.50
.30
.16
.32
.04
.04
.05
.05
.06
.06
.06
.06
.07
.07
.08
.08
.07
.07
.08
.08
.10
.10
.08
.08
.10
.10
.12
.12
.10
.10
.12
.12
.14
.14
.11
.11
.14
.14
.17
.17
.12
.12
.15
.15
.19
.19
.13
.13
.17
.17
.21
.21
.15
.15
.19
.19
.22
.22
.06
.08
.08
.13
.09
.13
.11
.05
.07
.08
.13
.16
.12
.08
.06
.13
.20
.27
.24
.32

mm

Inches

8.9
6.2
12.6
7.7
4.1
8.1
1.0
1.0
1.2
1.2
1.4
1.4
1.4
1.4
1.8
1.8
2.0
2.0
1.7
1.7
2.1
2.1
2.5
2.5
2.0
2.0
2.6
2.6
3.1
3.1
2.4
2.4
3.0
3.0
3.6
3.6
2.7
2.7
3.4
3.4
4.2
4.2
3.0
3.0
3.8
3.8
4.7
4.7
3.3
3.3
4.3
4.3
5.2
5.2
3.8
3.8
4.8
4.8
5.7
5.7
1.4
2.1
2.0
3.3
2.2
3.2
2.9
1.4
1.8
2.0
3.2
4.1
3.1
2.1
1.5
3.3
5.1
6.7
6.2
8.1

0.007
0.006
0.010
0.006
0.009
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.006
0.006
0.007
0.007
0.008
0.008
0.007
0.009
0.010
0.013
0.005
0.014
0.015
0.006
0.007
0.008
0.009
0.010
0.008
0.008
0.005
0.009
0.008
0.010
0.009
0.008

mm

TOTAL
MATL
COILS

0.2
0.2
0.3
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.2
0.3
0.3
0.1
0.4
0.4
0.2
0.2
0.2
0.2
0.3
0.2
0.2
0.1
0.2
0.2
0.3
0.2
0.2

49.0
40.0
48.5
49.5
16.5
39.0
5.75
5.75
6.00
6.00
6.13
6.13
8.13
8.13
8.88
8.88
8.75
8.75
10.3
10.3
11.0
11.0
11.5
11.5
12.4
12.4
13.5
13.5
14.3
14.3
14.8
14.8
15.8
15.8
16.8
16.8
16.8
16.8
18.3
18.3
19.6
19.6
18.5
18.5
20.4
20.4
22.4
22.4
20.8
20.8
23.3
23.3
24.8
24.8
23.6
23.6
26.0
26.0
27.0
27.0
7.00
8.00
7.00
9.00
16.5
8.00
6.50
8.00
9.00
9.00
13.0
15.0
14.5
9.25
11.25
13.5
24.0
25.5
26.0
38.8

SST
SST
MW
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
MW
MW
MW
SST
MW
MW
SST
MW
MW
SST
MW
MW
SST
MW
MW
MW
MW
MW

E
N
D
S

C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

15

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 16

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.062
0.062
0.068
0.068
0.072
0.075
0.078
0.078
0.078
0.078
0.078
0.078
0.078
0.078
0.078
0.078
0.078
0.078
0.078
0.083
0.083
0.084
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088
0.088

1.57
1.57
1.73
1.73
1.83
1.91
1.98
1.98
1.98
1.98
1.98
1.98
1.98
1.98
1.98
1.98
1.98
1.98
1.98
2.11
2.11
2.13
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24
2.24

2534
N-18
10938
A10-13
A10-3
KK-29
N-2
N-11
N-78
S-1013
12526
M-6
S-904
LL-1
11146
DD-73
4345
10213
B4-1
LL-66
NN-81
B6-19
70027
70027S
70036
70036S
70047
70047S
KK-17
70028
70028S
70037
70037S
70048
70048S
70029
70029S
70038
70038S
70049
70049S
70030
70030S
70039
70039S
70050
70050S
12767
70031
70031S
70040
70040S
70051
70051S
70032
70032S
70041
70041S
70052
70052S
70033
70033S
70042
70042S
70053
70053S
70034
70034S
70043
70043S
70054
70054S
70035
70035S
70044
70044S
70055
70055S
70045
70045S

.91
.97
.31
.34
.50
.20
.19
.22
.25
.25
.25
.25
.28
.31
.34
.34
.50
1.13
1.50
.25
.88
.28
.13
.13
.13
.13
.13
.13
.19
.19
.19
.19
.19
.19
.19
.25
.25
.25
.25
.25
.25
.31
.31
.31
.31
.31
.31
.34
.38
.38
.38
.38
.38
.38
.44
.44
.44
.44
.44
.44
.50
.50
.50
.50
.50
.50
.56
.56
.56
.56
.56
.56
.63
.63
.63
.63
.63
.63
.69
.69

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

23.0
24.6
8.0
8.7
12.7
5.2
4.8
5.6
6.4
6.4
6.4
6.4
7.1
7.9
8.7
8.7
12.7
28.6
38.1
6.4
22.2
7.0
3.3
3.3
3.3
3.3
3.3
3.3
4.7
4.8
4.8
4.8
4.8
4.8
4.8
6.4
6.4
6.4
6.4
6.4
6.4
7.9
7.9
7.9
7.9
7.9
7.9
8.7
9.7
9.7
9.7
9.7
9.7
9.7
11.2
11.2
11.2
11.2
11.2
11.2
12.7
12.7
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
14.2
14.2
16.0
16.0
16.0
16.0
16.0
16.0
17.5
17.5

MATERIAL: MW - Music Wire

16

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.044
.052
.046
.052
.042
.059
.068
.058
.068
.050
.048
.044
.054
.046
.054
.058
.066
.054
.054
.055
.059
.074
.072
.072
.068
.068
.064
.064
.068
.072
.072
.068
.068
.064
.064
.072
.072
.068
.068
.064
.064
.072
.072
.068
.068
.064
.064
.056
.072
.072
.068
.068
.064
.064
.072
.072
.068
.068
.064
.064
.072
.072
.068
.068
.064
.064
.072
.072
.068
.068
.064
.064
.072
.072
.068
.068
.064
.064
.068
.068

RATE
mm

1.1
1.3
1.2
1.3
1.1
1.5
1.7
1.5
1.7
1.3
1.2
1.1
1.4
1.2
1.4
1.5
1.7
1.4
1.4
1.4
1.5
1.9
1.8
1.8
1.7
1.7
1.6
1.6
1.7
1.8
1.8
1.7
1.7
1.6
1.6
1.8
1.8
1.7
1.7
1.6
1.6
1.8
1.8
1.7
1.7
1.6
1.6
1.4
1.8
1.8
1.7
1.7
1.6
1.6
1.8
1.8
1.7
1.7
1.6
1.6
1.8
1.8
1.7
1.7
1.6
1.6
1.8
1.8
1.7
1.7
1.6
1.6
1.8
1.8
1.7
1.7
1.6
1.6
1.7
1.7

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

1.3
.23
.06
.01
8.1
1.4
2.6
.45
56
9.8
4.4
.76
.21
.04
9.5
1.7
.38
.07
24
4.3
49
8.5
56
9.8
12
2.1
61
11
12
2.0
5.1
.89
.19
.03
2.6
.45
2.9
.51
22
3.9
2.2
.38
.36
.06
5.8
1.0
5.0
.88
13
2.2
11
1.9
26
4.5
22
3.9
10
1.8
3.5
.62
3.1
.54
6.9
1.2
6.0
1.1
15
2.6
13
2.2
2.5
.44
2.2
.38
5.0
.88
4.4
.77
11
1.9
9.3
1.6
2.0
.36
1.8
.31
3.9
.68
3.4
.60
8.2
1.4
7.2
1.3
39
6.8
1.6
.27
1.4
.24
3.3
.58
2.9
.51
6.6
1.2
5.8
1.0
1.4
.24
1.2
.21
2.9
.50
2.5
.43
5.8
1.0
5.0
.88
1.2
.21
1.0
.18
2.4
.42
2.1
.37
4.9
.86
4.3
.75
1.0
.18
.91
.16
2.1
.38
1.9
.33
4.5
.78
3.9
.68
.95
.17
.83
.14
1.9
.32
1.6
.28
3.9
.67
3.4
.59
1.7
.30
1.5
.26

.45
.61
.10
.19
.05
.10
.12
.06
.21
.06
.05
.04
.07
.05
.12
.16
.32
.54
.31
.06
.39
.00
.07
.05
.06
.04
.05
.04
.07
.11
.08
.11
.08
.09
.06
.15
.11
.15
.11
.12
.09
.19
.14
.19
.14
.15
.11
.07
.25
.18
.22
.16
.19
.14
.27
.20
.26
.19
.22
.16
.32
.23
.31
.23
.25
.19
.37
.27
.34
.25
.28
.21
.40
.30
.40
.29
.33
.24
.43
.32

11
16
2.5
4.8
1.2
2.6
3.0
1.4
5.2
1.4
1.3
.95
1.9
1.2
3.1
4.1
8.2
14
7.8
1.5
9.9
.00
1.7
1.2
1.5
1.1
1.2
.90
1.9
2.7
2.0
2.7
2.0
2.2
1.6
3.9
2.9
3.7
2.7
3.0
2.2
4.8
3.5
4.8
3.5
3.9
2.8
1.7
6.2
4.6
5.6
4.1
4.8
3.5
7.0
5.1
6.6
4.8
5.5
4.0
8.1
6.0
7.8
5.7
6.5
4.7
9.3
6.8
8.7
6.4
7.2
5.3
10
7.5
10
7.4
8.3
6.1
11
8.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs.

.60
.04
.78
.49
2.6
.44
.02
.53
.08
1.4
2.4
2.1
.89
2.9
1.4
.82
.06
1.4
.89
1.3
.84
.00
.38
.24
.74
.47
1.3
.80
.74
.38
.24
.74
.47
1.3
.80
.38
.24
.74
.47
1.3
.80
.38
.24
.74
.47
1.3
.80
2.6
.38
.24
.74
.47
1.3
.80
.38
.24
.74
.47
1.3
.80
.38
.24
.74
.47
1.3
.80
.38
.24
.74
.47
1.3
.80
.38
.24
.74
.47
1.3
.80
.74
.47

ENDS: C - Closed

G - Ground
O - Open

2.7
.17
3.5
2.2
11
2.0
.11
2.3
.35
6.2
11
9.3
4.0
13
6.2
3.7
.27
6.2
4.0
5.9
3.8
.00
1.7
1.1
3.3
2.1
5.6
3.6
3.3
1.7
1.1
3.3
2.1
5.6
3.6
1.7
1.1
3.3
2.1
5.6
3.6
1.7
1.1
3.3
2.1
5.6
3.6
12
1.7
1.1
3.3
2.1
5.6
3.6
1.7
1.1
3.3
2.1
5.6
3.6
1.7
1.1
3.3
2.1
5.6
3.6
1.7
1.1
3.3
2.1
5.6
3.6
1.7
1.1
3.3
2.1
5.6
3.6
3.3
2.1

Inches

.46
.36
.17
.11
.15
.06
.07
.07
.05
.15
.14
.21
.13
.15
.14
.12
.18
.52
.41
.13
.44
.04
.04
.04
.05
.05
.07
.07
.06
.05
.05
.07
.07
.09
.09
.06
.06
.09
.09
.11
.11
.07
.07
.11
.11
.14
.14
.15
.08
.08
.12
.12
.16
.16
.09
.09
.14
.14
.18
.18
.10
.10
.16
.16
.20
.20
.11
.11
.17
.17
.22
.22
.12
.12
.19
.19
.25
.25
.21
.21

mm

11.6
9.0
4.3
2.7
3.8
1.5
1.8
1.8
1.1
3.7
3.4
5.4
3.2
3.9
3.7
3.0
4.5
13.1
10.4
3.4
11.3
1.0
1.0
1.0
1.4
1.4
1.7
1.7
1.5
1.3
1.3
1.9
1.9
2.3
2.3
1.5
1.5
2.3
2.3
2.9
2.9
1.8
1.8
2.7
2.7
3.4
3.4
3.9
2.1
2.1
3.1
3.1
4.0
4.0
2.3
2.3
3.5
3.5
4.5
4.5
2.6
2.6
4.0
4.0
5.1
5.1
2.8
2.8
4.3
4.3
5.6
5.6
3.1
3.1
4.9
4.9
6.3
6.3
5.3
5.3

WIRE DIA.
Inches

0.009
0.005
0.011
0.008
0.015
0.008
0.005
0.010
0.005
0.014
0.015
0.017
0.012
0.016
0.012
0.010
0.006
0.012
0.012
0.014
0.012
0.005
0.008
0.008
0.010
0.010
0.012
0.012
0.010
0.008
0.008
0.010
0.010
0.012
0.012
0.008
0.008
0.010
0.010
0.012
0.012
0.008
0.008
0.010
0.010
0.012
0.012
0.016
0.008
0.008
0.010
0.010
0.012
0.012
0.008
0.008
0.010
0.010
0.012
0.012
0.008
0.008
0.010
0.010
0.012
0.012
0.008
0.008
0.010
0.010
0.012
0.012
0.008
0.008
0.010
0.010
0.012
0.012
0.010
0.010

mm

TOTAL
MATL
COILS

0.2
0.1
0.3
0.2
0.4
0.2
0.1
0.3
0.1
0.4
0.4
0.4
0.3
0.4
0.3
0.3
0.2
0.3
0.3
0.4
0.3
0.1
0.2
0.2
0.3
0.3
0.3
0.3
0.3
0.2
0.2
0.3
0.3
0.3
0.3
0.2
0.2
0.3
0.3
0.3
0.3
0.2
0.2
0.3
0.3
0.3
0.3
0.4
0.2
0.2
0.3
0.3
0.3
0.3
0.2
0.2
0.3
0.3
0.3
0.3
0.2
0.2
0.3
0.3
0.3
0.3
0.2
0.2
0.3
0.3
0.3
0.3
0.2
0.2
0.3
0.3
0.3
0.3
0.3
0.3

49.8
70.0
14.5
12.5
9.00
6.50
13.0
6.25
8.00
9.50
8.00
11.5
9.50
8.50
11.0
11.0
28.5
42.0
33.0
8.50
36.0
7.00
4.00
4.00
4.38
4.38
4.63
4.63
5.00
5.25
5.25
6.38
6.38
6.63
6.63
6.63
6.63
8.00
8.00
8.38
8.38
7.63
7.63
9.75
9.75
10.3
10.3
8.50
9.38
9.38
11.1
11.1
12.3
12.3
10.3
10.3
12.6
12.6
13.8
13.8
11.6
11.6
14.6
14.6
15.8
15.8
13.0
13.0
16.1
16.1
17.3
17.3
14.1
14.1
18.4
18.4
19.6
19.6
19.9
19.9

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
SST
MW
MW
MW
MW
SST
MW
SST
MW
MW
SST
MW
MW
MW
MW
MW
SST
SST
SST
SPR
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C

F
N
S
H

N
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 17

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.088
0.088
0.088
0.088
0.088
0.088
0.092
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.094
0.100
0.100
0.100

2.24
2.24
2.24
2.24
2.24
2.24
2.34
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.39
2.54
2.54
2.54

70056
70056S
70046
70046S
70057
70057S
11161
EE-21
S-1010
3719
BB-5
O-23
2870
II-22
BB-21
N-79
JJ-68
N-99
11923
3648
M-118
II-96
O-148
DD-7
LL-37
10219
10083
O-56
OO-10
10874
S-1526
11113
M-56
N-315
10932
FF-33
LL-2
3778
N-15
V-92
11127
O-8
2541
N-40
N-26
N-149
3902
CC-92
N-7
10782
1904
A9-20
B-403
B-404
G-6
B-405
B-406
S-860
B15-14
N-101
HH-62
3066
B10-14
YY-9
G-14
S-1577
II-10
B2-3
3642
V V-24
OO-23
4214
OO-13
NN-25
DD-59
RR-21
G-40
A9-8
B2-43
12479

.69
.69
.75
.75
.75
.75
.50
.13
.14
.16
.17
.19
.19
.22
.22
.25
.25
.25
.25
.25
.25
.25
.28
.30
.31
.31
.31
.31
.31
.34
.34
.34
.34
.34
.34
.38
.38
.38
.41
.41
.44
.44
.44
.44
.44
.44
.44
.44
.47
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.56
.56
.56
.56
.59
.59
.63
.63
.63
.75
.75
.81
.94
1.00
1.13
1.19
1.31
.19
.20
.22

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

17.5
17.5
19.1
19.1
19.1
19.1
12.7
3.2
3.6
4.0
4.3
4.7
4.8
5.5
5.6
6.4
6.4
6.4
6.4
6.4
6.4
6.4
7.1
7.5
7.9
7.9
7.9
8.0
7.9
8.7
8.7
8.7
8.7
8.7
8.7
9.5
9.5
9.5
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
14.3
14.3
14.3
14.3
15.1
15.1
15.9
15.9
15.9
19.1
19.1
20.7
23.8
25.4
28.6
30.1
33.3
4.7
5.2
5.5

I.D.
Inches

.064
.064
.068
.068
.064
.064
.072
.066
.054
.068
.078
.074
.072
.074
.078
.084
.074
.070
.070
.066
.064
.052
.048
.068
.074
.072
.068
.070
.052
.064
.060
.058
.052
.066
.062
.070
.070
.066
.074
.058
.066
.064
.062
.062
.060
.058
.054
.050
.066
.078
.074
.074
.074
.070
.068
.066
.062
.068
.066
.064
.078
.074
.068
.066
.066
.054
.082
.070
.066
.074
.066
.074
.074
.064
.074
.074
.064
.076
.080
.074

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

1.6
1.6
1.7
1.7
1.6
1.6
1.8
1.7
1.4
1.7
2.0
1.9
1.8
1.9
2.0
2.1
1.9
1.8
1.8
1.7
1.6
1.3
1.2
1.7
1.9
1.8
1.7
1.8
1.3
1.6
1.5
1.5
1.3
1.7
1.6
1.8
1.8
1.7
1.9
1.5
1.7
1.6
1.6
1.6
1.5
1.5
1.4
1.3
1.7
2.0
1.9
1.9
1.9
1.8
1.7
1.7
1.6
1.7
1.7
1.6
2.0
1.9
1.7
1.7
1.7
1.4
2.1
1.8
1.7
1.9
1.7
1.9
1.9
1.6
1.9
1.9
1.6
1.9
2.0
1.9

Lbs./In.

3.5
3.0
1.6
1.4
3.1
2.7
1.6
48
144
24
2.3
2.7
7.2
1.9
2.7
.18
4.3
6.7
7.7
22
30
125
250
7.7
3.0
4.6
15
5.4
82
16
35
43
62
13
24
5.7
2.0
13
2.9
43
9.0
15
18
17
24
31
52
69
8.0
.64
1.6
2.6
1.8
3.5
7.4
6.7
12
6.1
5.8
7.4
.77
1.7
4.0
7.2
6.5
63
.24
3.2
9.0
.94
6.0
.62
.88
5.4
.57
.96
3.8
11
3.9
14

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

.61
.53
.28
.24
.54
.47
.29
8.4
25
4.2
.41
.47
1.3
.33
.47
.03
.75
1.2
1.4
3.8
5.2
22
44
1.4
.53
.81
2.7
.95
14
2.8
6.2
7.5
11
2.4
4.2
1.0
.34
2.4
.50
7.5
1.6
2.6
3.2
2.9
4.2
5.4
9.0
12
1.4
.11
.28
.45
.31
.61
1.3
1.2
2.2
1.1
1.0
1.3
.14
.29
.70
1.3
1.1
11
.04
.56
1.6
.16
1.0
.11
.15
.94
.10
.17
.66
1.9
.69
2.4

.36
.26
.46
.34
.40
.30
.33
.02
.01
.06
.12
.07
.10
.06
.09
.20
.10
.12
.13
.09
.07
.03
.03
.13
.15
.19
.10
.16
.06
.09
.06
.08
.06
.14
.10
.21
.16
.14
.24
.08
.21
.14
.14
.15
.12
.11
.09
.09
.23
.26
.32
.27
.33
.28
.20
.23
.20
.16
.23
.19
.44
.39
.27
.16
.28
.05
.43
.37
.21
.47
.31
.39
.50
.38
.72
.46
.54
.10
.12
.07

9.1
6.7
12
8.5
10
7.5
8.5
.63
.25
1.6
2.9
1.7
2.5
1.5
2.2
5.1
2.6
3.0
3.3
2.2
1.8
.72
.69
3.4
3.7
4.9
2.5
4.0
1.6
2.2
1.4
2.0
1.4
3.5
2.6
5.3
4.0
3.5
6.2
2.0
5.2
3.5
3.5
3.8
3.1
2.9
2.3
2.2
5.9
6.6
8.1
6.9
8.4
7.1
5.2
5.9
5.0
4.0
5.8
4.7
11
9.8
6.9
4.2
7.2
1.2
11
9.4
5.2
12
7.8
10
13
9.7
18
12
14
2.6
3.1
1.7

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.3
.80
.74
.47
1.3
.80
.55
1.2
1.4
1.5
.27
.18
.71
.11
.23
.04
.44
.78
1.0
1.9
2.1
3.5
6.8
1.0
.44
.88
1.5
.85
5.3
1.4
2.0
3.5
3.5
1.9
2.5
1.2
.31
1.9
.69
3.5
1.9
2.1
2.5
2.5
2.9
3.5
4.6
5.9
1.9
.17
.52
.69
.59
.97
1.5
1.6
2.4
.95
1.3
1.4
.34
.65
1.1
1.2
1.9
3.1
.10
1.2
1.9
.44
1.9
.24
.44
2.1
.40
.44
2.1
1.1
.49
.90

5.6
3.6
3.3
2.1
5.6
3.6
2.4
5.2
6.4
6.6
1.2
.80
3.1
.48
1.0
.16
2.0
3.4
4.5
8.2
9.1
16
30
4.6
2.0
3.9
6.6
3.8
24
6.1
8.7
15
16
8.2
11
5.3
1.4
8.2
3.1
15
8.2
9.1
11
11
13
15
21
26
8.2
.74
2.3
3.1
2.6
4.3
6.6
7.0
11
4.2
6.0
6.1
1.5
2.9
4.9
5.2
8.2
14
.46
5.3
8.2
2.0
8.2
1.1
2.0
9.1
1.8
2.0
9.1
5.0
2.2
4.0

Inches

.27
.27
.22
.22
.30
.30
.12
.07
.13
.08
.06
.12
.09
.16
.05
.05
.08
.13
.12
.11
.12
.17
.17
.14
.10
.12
.10
.16
.20
.17
.16
.20
.27
.15
.18
.15
.22
.15
.12
.20
.21
.20
.22
.24
.24
.26
.28
.35
.23
.09
.18
.13
.17
.22
.18
.27
.30
.18
.30
.35
.12
.18
.29
.22
.27
.20
.08
.24
.21
.26
.29
.42
.27
.43
.41
.25
.63
.08
.08
.08

mm

Inches

6.8
6.8
5.6
5.6
7.6
7.6
3.0
1.8
3.3
2.1
1.4
3.0
2.3
4.1
1.2
1.3
2.0
3.4
3.0
2.8
3.0
4.3
4.4
3.6
2.5
3.1
2.6
4.0
5.2
4.3
4.1
5.0
6.9
3.9
4.6
3.8
5.5
3.9
2.9
5.0
5.3
5.0
5.7
6.1
6.0
6.5
7.1
8.9
5.9
2.4
4.6
3.2
4.3
5.6
4.5
6.8
7.7
4.6
7.6
8.8
3.0
4.4
7.3
5.7
6.9
5.1
2.0
6.1
5.3
6.5
7.5
10.7
6.9
10.9
10.4
6.4
16.0
2.1
2.0
2.0

0.012
0.012
0.010
0.010
0.012
0.012
0.010
0.014
0.020
0.013
0.008
0.010
0.011
0.010
0.008
0.005
0.010
0.012
0.012
0.014
0.015
0.021
0.023
0.013
0.010
0.011
0.013
0.012
0.021
0.015
0.017
0.018
0.021
0.014
0.016
0.012
0.012
0.014
0.010
0.018
0.014
0.015
0.016
0.016
0.017
0.018
0.020
0.022
0.014
0.008
0.010
0.010
0.010
0.012
0.013
0.014
0.016
0.013
0.014
0.015
0.008
0.010
0.013
0.014
0.014
0.020
0.006
0.012
0.014
0.010
0.014
0.010
0.010
0.015
0.010
0.010
0.015
0.012
0.010
0.013

mm

TOTAL
MATL
COILS

0.3
0.3
0.3
0.3
0.3
0.3
0.3
0.4
0.5
0.3
0.2
0.3
0.3
0.3
0.2
0.1
0.3
0.3
0.3
0.4
0.4
0.5
0.6
0.3
0.3
0.3
0.3
0.3
0.5
0.4
0.4
0.5
0.5
0.4
0.4
0.3
0.3
0.4
0.3
0.5
0.4
0.4
0.4
0.4
0.4
0.5
0.5
0.6
0.4
0.2
0.3
0.3
0.3
0.3
0.3
0.4
0.4
0.3
0.4
0.4
0.2
0.3
0.3
0.4
0.4
0.5
0.2
0.3
0.4
0.3
0.4
0.3
0.3
0.4
0.3
0.3
0.4
0.3
0.3
0.3

21.4
21.4
20.9
20.9
23.9
23.9
11.0
4.00
5.50
5.25
6.00
11.0
7.13
15.0
5.00
9.00
7.00
10.1
9.00
7.00
7.00
7.00
6.50
10.0
9.00
10.0
7.00
12.0
8.75
10.3
8.50
10.0
12.0
10.0
10.3
11.5
17.0
10.0
10.5
10.0
14.0
12.0
13.0
14.0
13.0
13.3
13.0
15.0
15.5
10.8
17.0
11.5
15.8
17.5
12.5
18.0
18.0
13.0
20.5
22.0
14.0
16.5
21.3
15.0
18.5
10.0
12.0
19.0
14.0
24.5
20.0
41.0
26.0
27.5
40.0
24.0
41.0
6.00
7.00
6.00

MW
SST
MW
SST
MW
SST
BC
SST
SST
MW
MW
MW
MW
MW
SST
MW
SST
MW
MW
MW
MW
SST
MW
HD
SST
MW
MW
MW
MW
SST
SST
MW
SST
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
BC
MW
MW
MW
MW
MW
MW
MW
SST
MW
MW
MW
MW
MW
SST
MW
SST
SST
MW
MW
SST
MW
MW
SST
MW
SST
SST
MW
MW
MW
SST

E
N
D
S

F
N
S
H

C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
O
C
C
C
C
O
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
O
C
C
C
C
C
C

N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
N
GI
N
Z
Z
N
N
Z
N
N
N
Z
N
N
N
N
N
N
GI
N
N
Z
N
N
N
N
Z
Z
N
Z
N
Z
N
N
Z
Z
Z
Z
BO
Z
Z
N
N
Z
GI
Z
Z
N
N
N
N
N
Z
N
BO
N
N
N
N
N
Z
Z
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

17

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 18

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.100
0.100
0.100
0.100
0.100
0.100
0.105
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109
0.109

2.54
2.54
2.54
2.54
2.54
2.54
2.67
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77
2.77

10434
A9-16
OO-41
10007
OO-25
NN-7
BB-31
A9-10
N-17
EE-23
L-71
2500
B15-29
JJ-20
3722
JJ-1
N-9
V-70
B-21
O-118
O-5
A15-49
QQ-11
12527
B15-45
S-1089
G-16
BB-12
N-1
12531
BB-14
12454
J-48
LL-63
12534
OO-26
A12-33
KK-10
A9-17
GG-19
2937
1501
B2-27
S-829
L-2
N-69
V-16
B2-33
S-814
B-54
B15-50
N-19
L-72
N-6
AA-37
A-38
U-76
12529
G-82
DD-32
A9-21
PP-33
H-76
JJ-57
U-83
U-55
A10-37
W-54
MM-47
KK-5
B2-18
M-78
DD-45
GG-65
KK-13
3550
B18-150
2506
U-70
LL-80

.22
.25
.31
.34
.38
.44
.28
.13
.16
.17
.19
.19
.22
.25
.25
.25
.25
.25
.25
.28
.28
.28
.28
.30
.31
.31
.31
.31
.31
.31
.31
.34
.34
.34
.34
.34
.38
.38
.38
.38
.41
.44
.45
.47
.47
.47
.50
.50
.50
.50
.53
.53
.56
.56
.56
.59
.63
.63
.63
.63
.63
.66
.69
.75
.75
.81
.84
.88
.88
.94
1.00
1.09
1.13
1.13
1.13
1.19
1.25
1.25
1.31
1.31

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

5.6
6.4
7.9
8.7
9.5
11.1
7.0
3.2
4.0
4.4
4.7
4.8
5.6
6.4
6.4
6.4
6.4
6.4
6.4
7.1
7.1
7.1
7.1
7.5
7.9
7.9
7.9
7.9
7.9
7.9
7.9
8.7
8.7
8.7
8.7
8.7
9.5
9.5
9.5
9.5
10.3
11.1
11.5
11.9
11.9
11.9
12.7
12.7
12.7
12.7
13.5
13.5
14.3
14.3
14.3
15.1
15.9
15.9
15.9
15.9
15.9
16.7
17.4
19.1
19.1
20.6
21.4
22.2
22.2
23.8
25.4
27.8
28.6
28.6
28.6
30.2
31.8
31.8
33.3
33.3

MATERIAL: MW - Music Wire

18

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.086
.082
.076
.068
.060
.060
.089
.065
.101
.069
.093
.089
.091
.093
.089
.089
.085
.081
.079
.091
.085
.073
.067
.079
.095
.091
.085
.083
.081
.079
.069
.085
.069
.065
.093
.073
.093
.071
.069
.069
.087
.065
.077
.071
.069
.065
.089
.085
.063
.059
.087
.075
.095
.093
.089
.085
.085
.077
.069
.069
.067
.081
.079
.087
.085
.085
.083
.095
.089
.059
.091
.079
.085
.077
.077
.085
.087
.083
.077
.073

RATE
mm

2.2
2.1
1.9
1.7
1.5
1.5
2.3
1.7
2.6
1.8
2.4
2.3
2.3
2.4
2.3
2.3
2.2
2.1
2.0
2.3
2.2
1.9
1.7
2.0
2.4
2.3
2.2
2.1
2.1
2.0
1.8
2.2
1.8
1.7
2.4
1.9
2.4
1.8
1.8
1.8
2.2
1.7
2.0
1.8
1.8
1.7
2.3
2.2
1.6
1.5
2.2
1.9
2.4
2.4
2.3
2.2
2.2
2.0
1.8
1.8
1.7
2.1
2.0
2.2
2.2
2.2
2.1
2.4
2.3
1.5
2.3
2.0
2.2
2.0
2.0
2.2
2.2
2.1
2.0
1.9

Lbs./In.

.86
2.3
6.3
18
57
35
.86
227
.03
124
1.1
3.7
1.3
.99
2.5
4.3
5.3
5.9
25
1.3
6.5
33
59
15
.58
1.6
3.2
5.8
9.9
17.5
50
4.8
33
74
.66
22
.71
33
59
23
1.8
49
9.0
32
27
57
.81
4.4
51
95
2.5
15
.17
.48
.68
3.0
2.0
11
15
24
29
2.9
4.0
.97
1.7
1.9
2.3
.19
.85
34
.55
3.8
1.4
5.1
3.1
1.4
.77
1.9
5.9
8.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

.15
.40
1.1
3.1
10
6.1
.15
40
.005
22
.20
.65
.24
.17
.43
.74
.92
1.0
4.4
.24
1.1
5.8
10
2.6
.10
.29
.55
1.0
1.7
3.0
8.8
.85
5.7
13
.12
3.9
.13
5.7
10
4.1
.31
8.5
1.6
5.6
4.8
10
.14
.76
9.0
17
.44
2.7
.03
.08
.12
.52
.36
1.9
2.6
4.2
5.1
.51
.70
.17
.30
.33
.40
.03
.15
5.9
.10
.67
.25
.89
.54
.24
.14
.33
1.0
1.5

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

Lbs.

.16
.17
.11
.13
.05
.08
.20
.02
.10
.03
.12
.12
.13
.19
.16
.09
.12
.05
.05
.20
.16
.09
.05
.12
.24
.17
.17
.14
.16
.11
.08
.14
.08
.05
.26
.09
.29
.07
.07
.10
.24
.11
.20
.07
.15
.09
.31
.24
.08
.08
.32
.17
.42
.44
.32
.35
.40
.20
.18
.17
.16
.31
.33
.50
.49
.35
.36
.74
.45
.14
.51
.31
.46
.28
.47
.76
.90
.70
.37
.23

4.1
4.4
2.9
3.4
1.3
2.2
5.1
.38
2.6
.84
3.1
3.0
3.3
4.7
4.1
2.3
3.2
1.4
1.2
5.1
4.0
2.3
1.3
3.1
6.2
4.4
4.3
3.7
4.1
2.8
2.1
3.5
2.1
1.2
6.6
2.3
7.3
1.8
1.8
2.4
6.0
2.8
5.0
1.9
3.8
2.4
7.9
6.0
2.0
1.9
8.2
4.3
11
11
8.2
8.8
10
5.2
4.7
4.3
4.1
7.8
8.3
13
12
8.8
9.2
19
11
3.7
13
8.0
12
7.2
12
19
23
18
9.4
5.9

.14
.39
.71
2.3
2.9
2.9
.17
3.4
.003
4.1
.14
.44
.17
.18
.40
.38
.66
.32
1.2
.27
1.0
3.0
3.1
1.8
.14
.28
.53
.83
1.6
1.8
4.1
.66
2.7
3.6
.17
2.0
.20
2.4
4.1
2.2
.42
5.4
1.8
2.4
4.1
5.4
.25
1.0
4.1
7.2
.80
2.6
.07
.21
.22
1.0
.81
2.2
2.7
4.1
4.7
.90
1.3
.48
.84
.66
.83
.14
.38
4.9
.28
1.2
.66
1.4
1.4
1.0
.69
1.3
2.2
2.0

ENDS: C - Closed

G - Ground
O - Open

.62
1.8
3.2
10
13
13
.76
15
.01
18
.63
1.9
.77
.82
1.8
1.7
2.9
1.4
5.3
1.2
4.6
14
14
8.0
.63
1.3
2.4
3.7
7.2
8.0
18
2.9
12
16
.77
9.0
.91
11
18
9.9
1.9
24
7.9
11
18
24
1.1
4.6
18
32
3.5
11
.31
.94
.98
4.6
3.6
9.6
12
18
21
4.0
5.8
2.1
3.7
2.9
3.7
.63
1.7
22
1.3
5.3
2.9
6.4
6.4
4.6
3.1
5.8
9.6
9.0

Inches

.06
.08
.11
.19
.20
.25
.08
.11
.05
.11
.06
.07
.09
.06
.09
.06
.10
.20
.09
.08
.10
.14
.19
.14
.06
.07
.14
.13
.13
.12
.19
.11
.26
.20
.08
.20
.09
.19
.17
.28
.17
.30
.26
.19
.30
.26
.19
.13
.32
.33
.13
.22
.14
.12
.24
.17
.23
.22
.44
.30
.36
.35
.36
.25
.26
.22
.27
.14
.17
.66
.16
.35
.28
.37
.66
.32
.35
.36
.35
.41

mm

1.4
1.9
2.7
4.9
5.1
6.4
1.9
2.8
1.3
2.7
1.6
1.8
2.3
1.6
2.3
1.5
2.6
5.0
2.3
2.1
2.4
3.7
4.8
3.4
1.4
1.8
3.7
3.3
3.4
3.0
4.8
2.7
6.6
5.0
2.1
5.0
2.2
4.8
4.3
7.1
4.3
7.5
6.5
4.8
7.6
6.7
4.8
3.2
8.0
8.3
3.4
5.6
3.6
3.0
6.1
4.3
5.8
5.7
11.2
7.6
9.1
8.9
9.1
6.4
6.7
5.5
6.9
3.6
4.3
16.8
4.1
8.8
7.0
9.3
16.7
8.2
8.9
9.2
8.9
10.5

WIRE DIA.
Inches

0.007
0.009
0.012
0.016
0.020
0.020
0.008
0.022
0.004
0.020
0.008
0.010
0.009
0.008
0.010
0.010
0.012
0.014
0.015
0.009
0.012
0.018
0.021
0.015
0.007
0.009
0.012
0.013
0.014
0.015
0.020
0.012
0.020
0.022
0.008
0.018
0.008
0.019
0.020
0.020
0.011
0.022
0.016
0.019
0.020
0.022
0.010
0.012
0.023
0.025
0.011
0.017
0.007
0.008
0.010
0.012
0.012
0.016
0.020
0.020
0.021
0.014
0.015
0.011
0.012
0.012
0.013
0.007
0.010
0.025
0.009
0.015
0.012
0.016
0.016
0.012
0.011
0.013
0.016
0.018

mm

TOTAL
MATL
COILS

0.2
0.2
0.3
0.4
0.5
0.5
0.2
0.6
0.1
0.5
0.2
0.3
0.2
0.2
0.3
0.3
0.3
0.4
0.4
0.2
0.3
0.5
0.5
0.4
0.2
0.2
0.3
0.3
0.4
0.4
0.5
0.3
0.5
0.6
0.2
0.5
0.2
0.5
0.5
0.5
0.3
0.6
0.4
0.5
0.5
0.6
0.3
0.3
0.6
0.6
0.3
0.4
0.2
0.2
0.3
0.3
0.3
0.4
0.5
0.5
0.5
0.4
0.4
0.3
0.3
0.3
0.3
0.2
0.3
0.6
0.2
0.4
0.3
0.4
0.4
0.3
0.3
0.3
0.4
0.5

7.00
7.50
8.00
11.0
9.00
11.5
8.50
4.00
12.0
4.00
7.00
6.00
9.00
7.00
8.00
5.00
7.50
13.0
5.00
9.00
7.00
8.00
8.00
8.00
7.00
7.00
11.0
9.00
8.50
7.00
8.50
8.00
12.0
8.00
9.50
10.0
10.0
9.00
7.50
14.0
14.5
12.5
15.0
9.00
14.0
11.0
18.0
9.50
12.8
12.0
11.0
12.0
19.0
14.0
23.0
13.0
18.0
13.0
21.0
15.0
16.0
24.0
24.0
22.0
21.0
17.0
20.0
19.0
17.0
26.5
17.0
22.0
22.0
22.0
40.0
26.0
31.0
27.0
22.0
22.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
SST
MW
SST
SST
SST
SST
SST
MW
MW
MW
MW
SST
MW
SST
SST
MW
SST
MW
MW
MW
SST
MW
SST
SST
SST
SST
MW
MW
MW
SST
MW
SST
SST
SST
MW
SST
MW
SST
MW
MW
MW
SST
MW
MW
SST
MW
SST
MW
MW
MW
SST
MW
MW
MW
MW
MW
SST
MW
MW
MW
MW
SST
MW
SST
SST
MW
SST
SST
SST
SST
SST
SST
MW
MW
MW
MW
MW
SST

E
N
D
S

C
C
C
C
C
O
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
CG
C
C
C
C
C
CG
CG
C
C
C
C
C
C
C
C
CG
C

F
N
S
H

N
N
N
N
N
N
N
N
N
GI
N
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
N
GI
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
Z
N
N
Z
N
N
GI
N
N
N
N
N
N
Z
GI
N
GI
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 19

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.114
0.114
0.114
0.114
0.114
0.114
0.114
0.117
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120

2.90
2.90
2.90
2.90
2.90
2.90
2.90
2.97
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05

GG-7
OO-7
V-79
10442
B12-39
10909
A11-5
12747
70109
70109S
70131
70131S
70058
70058S
70074
70074S
70090
70090S
70110
70110S
B3-56
70132
70132S
70153
70153S
70171
70171S
70190
70190S
70059
70059S
70075
70075S
70091
70091S
70111
70111S
70133
70133S
70154
70154S
70172
70172S
70191
70191S
70060
70060S
70076
70076S
70092
70092S
70112
70112S
70134
70134S
70155
70155S
70173
70173S
70192
70192S
B3-57
70061
70061S
70077
70077S
70093
70093S
70113
70113S
70135
70135S
70156
70156S
70174
70174S
70193
70193S
70062
70062S

.16
.16
.25
.31
.44
1.00
1.34
.27
.19
.19
.19
.19
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.50
.50

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

4.0
4.0
6.4
7.9
11.1
25.4
34.1
6.8
4.8
4.8
4.8
4.8
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
11.1
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
12.7
12.7

I.D.
Inches

.090
.070
.082
.086
.074
.094
.068
.083
.088
.088
.084
.084
.100
.100
.096
.096
.092
.092
.088
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.092
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

2.3
1.8
2.1
2.2
1.9
2.4
1.7
2.1
2.2
2.2
2.1
2.1
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.3
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5

Lbs./In.

8.1
192
15
9.6
30
.91
12
21
26
22
41
35
3.2
2.8
6.3
5.5
11
9.8
18
15
15
28
25
46
40
70
61
108
94
2.5
2.1
5.0
4.3
8.8
7.7
14
12
22
19
35
31
54
47
83
72
2.0
1.7
4.0
3.5
7.0
6.1
11
9.7
18
16
28
25
41
36
65
57
5.8
1.7
1.5
3.4
2.9
6.0
5.2
9.4
8.2
15
13
24
21
36
32
55
48
1.5
1.3

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

1.4
34
2.6
1.7
5.3
.16
2.1
3.7
4.5
3.9
7.1
6.2
.56
.49
1.1
.96
2.0
1.7
3.1
2.7
2.6
5.0
4.3
8.1
7.0
12
11
19
16
.43
.38
.87
.76
1.5
1.3
2.4
2.1
3.8
3.3
6.2
5.4
9.5
8.2
15
13
.35
.31
.71
.61
1.2
1.1
2.0
1.7
3.2
2.7
5.0
4.3
7.3
6.3
11
9.9
1.0
.30
.26
.59
.51
1.0
.91
1.7
1.4
2.7
2.3
4.2
3.6
6.3
5.5
9.7
8.4
.26
.23

.08
.02
.07
.16
.09
.63
.33
.08
.08
.06
.07
.05
.17
.13
.15
.11
.13
.10
.11
.09
.09
.10
.08
.08
.06
.07
.05
.06
.05
.22
.16
.19
.14
.17
.12
.14
.11
.13
.10
.11
.08
.09
.07
.08
.06
.27
.20
.23
.17
.21
.16
.18
.14
.15
.12
.13
.10
.12
.09
.10
.07
.26
.32
.24
.28
.20
.25
.18
.21
.16
.18
.14
.16
.12
.14
.10
.12
.09
.37
.27

2.0
.46
1.9
4.1
2.2
16
8.4
2.0
2.0
1.5
1.7
1.3
4.4
3.2
3.8
2.8
3.3
2.5
2.9
2.2
2.2
2.5
1.9
2.1
1.6
1.8
1.4
1.5
1.1
5.7
4.1
4.8
3.5
4.3
3.1
3.6
2.8
3.2
2.5
2.7
2.1
2.3
1.8
1.9
1.5
7.0
5.1
5.9
4.4
5.4
3.9
4.5
3.5
3.9
3.0
3.4
2.6
3.0
2.3
2.5
1.9
6.5
8.2
6.0
7.1
5.2
6.3
4.6
5.3
4.1
4.6
3.5
4.0
3.1
3.5
2.7
2.9
2.2
9.4
6.9

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.63
3.5
1.1
1.6
2.6
.58
3.9
1.6
2.0
1.3
2.8
1.9
.55
.35
.94
.60
1.5
.94
2.0
1.3
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
1.5
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35

2.8
15
4.8
6.9
12
2.6
17
7.2
8.8
5.9
12
8.3
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
6.6
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6

Inches

.07
.11
.18
.12
.22
.17
.99
.14
.08
.08
.10
.10
.05
.05
.07
.07
.09
.09
.11
.11
.11
.13
.13
.14
.14
.16
.16
.17
.17
.06
.06
.08
.08
.10
.10
.13
.13
.15
.15
.17
.17
.19
.19
.20
.20
.07
.07
.10
.10
.12
.12
.15
.15
.18
.18
.20
.20
.23
.23
.25
.25
.14
.08
.08
.11
.11
.14
.14
.17
.17
.20
.20
.23
.23
.26
.26
.28
.28
.09
.09

mm

Inches

1.8
2.8
4.5
3.1
5.6
4.3
25.1
3.5
2.1
2.1
2.5
2.5
1.4
1.4
1.8
1.8
2.2
2.2
2.7
2.7
2.8
3.2
3.2
3.6
3.6
4.0
4.0
4.3
4.3
1.6
1.6
2.1
2.1
2.6
2.6
3.3
3.3
3.9
3.9
4.3
4.3
4.8
4.8
5.2
5.2
1.9
1.9
2.4
2.4
3.1
3.1
3.9
3.9
4.5
4.5
5.2
5.2
5.9
5.9
6.2
6.2
3.6
2.1
2.1
2.7
2.7
3.5
3.5
4.4
4.4
5.2
5.2
5.9
5.9
6.6
6.6
7.2
7.2
2.4
2.4

0.012
0.022
0.016
0.014
0.020
0.010
0.023
0.017
0.016
0.016
0.018
0.018
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.014
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010

mm

TOTAL
MATL
COILS

0.3
0.6
0.4
0.4
0.5
0.3
0.6
0.4
0.4
0.4
0.5
0.5
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.4
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3

5.00
4.00
10.3
7.75
10.0
16.0
42.0
7.00
5.25
5.25
5.50
5.50
5.38
5.38
5.75
5.75
6.13
6.13
6.75
6.75
6.88
7.00
7.00
7.00
7.00
7.13
7.13
7.00
7.00
6.38
6.38
6.75
6.75
7.25
7.25
8.00
8.00
8.50
8.50
8.50
8.50
8.63
8.63
8.50
8.50
7.38
7.38
7.88
7.88
8.63
8.63
9.50
9.50
9.88
9.88
10.1
10.1
10.6
10.6
10.3
10.3
10.0
8.38
8.38
9.00
9.00
9.75
9.75
10.9
10.9
11.3
11.3
11.6
11.6
11.9
11.9
11.8
11.8
9.25
9.25

SST
SST
MW
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

C
C
C
C
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

19

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 20

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120

3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05

70078
70078S
70094
70094S
70114
70114S
70136
70136S
70157
70157S
70175
70175S
70194
70194S
70063
70063S
70079
70079S
70095
70095S
70115
70115S
70137
70137S
70158
70158S
70176
70176S
70195
70195S
70064
70064S
70080
70080S
70096
70096S
70116
70116S
70138
70138S
70159
70159S
70177
70177S
70196
70196S
70065
70065S
70081
70081S
70097
70097S
70117
70117S
70139
70139S
70160
70160S
70178
70178S
70197
70197S
70066
70066S
70082
70082S
70098
70098S
70118
70118S
70140
70140S
70161
70161S
70179
70179S
70198
70198S
70067
70067S

.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.81
.81

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6

MATERIAL: MW - Music Wire

20

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100

RATE
mm

2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5

Lbs./In.

3.0
2.6
5.2
4.5
8.4
7.3
13
11
21
18
31
27
48
42
1.4
1.2
2.6
2.3
4.6
4.0
7.4
6.4
11
10
18
16
28
24
42
37
1.2
1.0
2.4
2.1
4.1
3.6
6.6
5.7
11
9.4
16
14
25
22
38
33
1.1
.95
2.1
1.8
3.7
3.3
5.9
5.1
9.4
8.2
15
13
22
19
34
29
1.0
.87
2.0
1.7
3.4
3.0
5.2
4.5
8.5
7.4
13
12
20
18
31
27
.90
.78

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.53
.46
.91
.80
1.5
1.3
2.3
2.0
3.7
3.2
5.4
4.7
8.4
7.3
.24
.21
.45
.39
.80
.70
1.3
1.1
2.0
1.7
3.2
2.8
4.9
4.3
7.4
6.4
.21
.18
.42
.36
.72
.63
1.2
1.0
1.9
1.6
2.9
2.5
4.4
3.8
6.6
5.7
.19
.17
.37
.32
.66
.57
1.0
.90
1.6
1.4
2.6
2.2
3.8
3.3
5.9
5.1
.18
.15
.35
.30
.60
.52
.90
.78
1.5
1.3
2.3
2.0
3.5
3.1
5.4
4.7
.16
.14

.31
.23
.28
.21
.24
.18
.21
.16
.18
.14
.16
.12
.13
.10
.39
.29
.36
.27
.32
.24
.27
.21
.24
.19
.21
.16
.18
.14
.15
.12
.46
.34
.39
.29
.36
.26
.30
.23
.26
.20
.23
.18
.20
.15
.17
.13
.50
.37
.45
.33
.40
.29
.34
.26
.30
.23
.26
.20
.23
.18
.19
.14
.55
.40
.47
.35
.44
.32
.39
.29
.33
.25
.28
.22
.25
.19
.21
.16
.61
.45

mm

8.0
5.8
7.2
5.3
6.0
4.6
5.4
4.1
4.6
3.5
4.1
3.1
3.4
2.6
10
7.3
9.2
6.8
8.2
6.0
6.8
5.2
6.2
4.7
5.3
4.0
4.5
3.4
3.8
2.9
12
8.5
10
7.3
9.1
6.7
7.7
5.9
6.6
5.0
5.9
4.5
5.1
3.9
4.3
3.3
13
9.4
11
8.3
10
7.4
8.6
6.6
7.5
5.8
6.5
5.0
5.9
4.5
4.8
3.7
14
10
12
8.8
11
8.1
9.8
7.5
8.4
6.4
7.2
5.5
6.3
4.8
5.2
4.0
16
11

Lbs.

.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35

ENDS: C - Closed

G - Ground
O - Open

4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6

Inches

.12
.12
.15
.15
.19
.19
.23
.23
.26
.26
.30
.30
.32
.32
.10
.10
.13
.13
.17
.17
.21
.21
.26
.26
.29
.29
.33
.33
.35
.35
.11
.11
.14
.14
.19
.19
.24
.24
.27
.27
.32
.32
.36
.36
.39
.39
.12
.12
.16
.16
.20
.20
.26
.26
.31
.31
.35
.35
.41
.41
.43
.43
.13
.13
.17
.17
.22
.22
.29
.29
.34
.34
.39
.39
.44
.44
.47
.47
.14
.14

mm

3.0
3.0
3.9
3.9
4.9
4.9
5.9
5.9
6.6
6.6
7.5
7.5
8.1
8.1
2.5
2.5
3.4
3.4
4.3
4.3
5.4
5.4
6.6
6.6
7.4
7.4
8.3
8.3
9.0
9.0
2.8
2.8
3.6
3.6
4.7
4.7
6.0
6.0
6.9
6.9
8.2
8.2
9.1
9.1
10.0
10.0
3.0
3.0
4.0
4.0
5.1
5.1
6.6
6.6
7.8
7.8
9.0
9.0
10.4
10.4
11.0
11.0
3.3
3.3
4.2
4.2
5.6
5.6
7.4
7.4
8.6
8.6
9.8
9.8
11.0
11.0
11.9
11.9
3.6
3.6

WIRE DIA.
Inches

0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010

mm

TOTAL
MATL
COILS

0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3

9.88
9.88
10.9
10.9
12.0
12.0
12.9
12.9
13.0
13.0
13.5
13.5
13.3
13.3
9.75
9.75
11.1
11.1
12.1
12.1
13.4
13.4
14.4
14.4
14.6
14.6
14.8
14.8
14.8
14.8
11.0
11.0
11.9
11.9
13.3
13.3
14.8
14.8
15.1
15.1
16.1
16.1
16.4
16.4
16.4
16.4
11.9
11.9
13.3
13.3
14.4
14.4
16.3
16.3
17.1
17.1
17.6
17.6
18.6
18.6
18.0
18.0
12.8
12.8
13.9
13.9
15.6
15.6
18.3
18.3
18.8
18.8
19.3
19.3
19.8
19.8
19.5
19.5
14.0
14.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 21

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120

3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05

70083
70083S
70099
70099S
70120
70120S
70142
70142S
70162
70162S
70180
70180S
70199
70199S
70068
70068S
70084
70084S
70100
70100S
70122
70122S
70144
70144S
70163
70163S
70182
70182S
70200
70200S
70101
70101S
70069
70069S
70085
70085S
70102
70102S
70124
70124S
70146
70146S
70164
70164S
70183
70183S
70201
70201S
70070
70070S
70086
70086S
70103
70103S
70125
70125S
70147
70147S
70165
70165S
70184
70184S
70202
70202S
70071
70071S
70087
70087S
70104
70104S
70126
70126S
70148
70148S
70166
70166S
70185
70185S
70203
70203S

.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
23.1
23.1
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7

I.D.
Inches

.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.092
.092
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.3
2.3
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8

Lbs./In.

1.8
1.6
3.1
2.7
5.0
4.3
7.9
6.9
12
11
18
16
28
25
.90
.78
1.7
1.5
2.9
2.5
4.6
4.0
7.3
6.3
11
9.8
17
15
26
23
8.6
7.5
.80
.70
1.5
1.3
2.7
2.4
4.3
3.7
6.8
5.9
11
9.2
16
14
24
21
.70
.61
1.5
1.3
2.5
2.2
4.1
3.5
6.4
5.6
9.9
8.6
15
13
23
20
.70
.61
1.3
1.1
2.2
1.9
3.5
3.1
5.7
4.9
8.8
7.7
13
12
20
17

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.32
.27
.54
.47
.88
.76
1.4
1.2
2.2
1.9
3.2
2.8
5.0
4.3
.16
.14
.30
.26
.51
.44
.80
.70
1.3
1.1
2.0
1.7
3.0
2.6
4.5
4.0
1.5
1.3
.14
.12
.26
.23
.47
.41
.75
.65
1.2
1.0
1.9
1.6
2.8
2.4
4.3
3.7
.12
.11
.26
.23
.44
.38
.71
.62
1.1
.97
1.7
1.5
2.6
2.3
4.0
3.5
.12
.11
.23
.20
.39
.34
.62
.54
.99
.86
1.5
1.3
2.3
2.0
3.5
3.1

.52
.38
.48
.35
.40
.30
.35
.27
.31
.23
.27
.21
.22
.17
.61
.45
.55
.40
.51
.37
.43
.33
.38
.29
.34
.26
.29
.22
.24
.19
.17
.13
.69
.50
.63
.46
.55
.40
.46
.35
.41
.31
.36
.27
.31
.24
.26
.20
.78
.57
.63
.46
.59
.43
.49
.37
.44
.33
.38
.29
.34
.26
.28
.21
.78
.57
.73
.53
.67
.49
.56
.43
.49
.38
.43
.33
.37
.28
.32
.24

mm

13
9.7
12
8.9
10
7.7
9.0
6.9
7.8
6.0
6.9
5.3
5.7
4.4
16
11
14
10
13
9.5
11
8.4
9.7
7.4
8.6
6.6
7.4
5.6
6.2
4.8
4.4
3.2
17
13
16
12
14
10
12
9.0
10
8.0
9.1
7.0
8.0
6.1
6.6
5.1
20
15
16
12
15
11
12
9.5
11
8.5
9.7
7.4
8.5
6.5
7.1
5.4
20
15
18
14
17
12
14
11
13
9.6
11
8.3
9.4
7.2
8.1
6.2

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
1.5
.94
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2

4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
6.6
4.2
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19

Inches

.18
.18
.24
.24
.30
.30
.36
.36
.41
.41
.47
.47
.50
.50
.14
.14
.19
.19
.25
.25
.32
.32
.39
.39
.45
.45
.50
.50
.55
.55
.10
.10
.16
.16
.21
.21
.27
.27
.34
.34
.41
.41
.48
.48
.54
.54
.58
.58
.17
.17
.21
.21
.29
.29
.36
.36
.44
.44
.51
.51
.58
.58
.62
.62
.17
.17
.24
.24
.32
.32
.41
.41
.49
.49
.56
.56
.63
.63
.69
.69

mm

Inches

4.6
4.6
6.0
6.0
7.6
7.6
9.1
9.1
10.5
10.5
12.0
12.0
12.8
12.8
3.6
3.6
4.9
4.9
6.4
6.4
8.2
8.2
9.8
9.8
11.4
11.4
12.8
12.8
13.9
13.9
2.6
2.6
3.9
3.9
5.4
5.4
6.8
6.8
8.7
8.7
10.5
10.5
12.1
12.1
13.8
13.8
14.7
14.7
4.4
4.4
5.4
5.4
7.3
7.3
9.2
9.2
11.1
11.1
12.8
12.8
14.6
14.6
15.7
15.7
4.4
4.4
6.2
6.2
8.1
8.1
10.4
10.4
12.4
12.4
14.2
14.2
16.1
16.1
17.6
17.6

0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.014
0.014
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024

mm

TOTAL
MATL
COILS

0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.4
0.4
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6

15.1
15.1
17.0
17.0
18.8
18.8
20.0
20.0
20.6
20.6
21.5
21.5
21.0
21.0
14.0
14.0
15.9
15.9
18.0
18.0
20.3
20.3
21.5
21.5
22.5
22.5
22.9
22.9
22.8
22.8
7.38
7.38
15.5
15.5
17.8
17.8
19.1
19.1
21.5
21.5
22.9
22.9
23.8
23.8
24.6
24.6
24.1
24.1
17.4
17.4
17.8
17.8
20.5
20.5
22.6
22.6
24.3
24.3
25.3
25.3
26.1
26.1
25.8
25.8
17.4
17.4
20.3
20.3
22.9
22.9
25.6
25.6
27.1
27.1
28.0
28.0
28.8
28.8
28.9
28.9

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

21

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 22

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.120
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125

3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.05
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18

70072
70072S
70088
70088S
70105
70105S
70127
70127S
70149
70149S
70167
70167S
70186
70186S
70204
70204S
70107
70107S
70129
70129S
70151
70151S
70169
70169S
70188
70188S
70073
70073S
70089
70089S
70108
70108S
70130
70130S
70152
70152S
70170
70170S
70189
70189S
70205
70205S
DD-65
10195
LL-57
DD-57
B14-3
B-83
N-4
S-1576
B15-7
DD-1
MM-80
B7-3
A10-4
A12-9
BB-49
B1-25
B1-8
FF-43
S-834
B5-53
2628
B1-20
M-14
B5-3
10814
J-68
KK-27
A10-9
10775
A12-38
B-7
BB-15
B2-6
B-3
CC-42
EE-33
M-37
B2-20

1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
.13
.13
.16
.19
.19
.19
.22
.22
.22
.22
.22
.22
.22
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.28
.28
.28
.28
.30
.31
.31
.31
.31
.31

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
3.2
3.2
4.0
4.8
4.8
4.8
5.6
5.6
5.6
5.6
5.6
5.6
5.6
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
7.1
7.1
7.1
7.1
7.5
7.9
7.9
7.9
7.9
7.9

MATERIAL: MW - Music Wire

22

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.100
.100
.096
.096
.092
.092
.088
.088
.084
.084
.080
.080
.076
.076
.072
.072
.105
.095
.085
.095
.087
.085
.111
.109
.104
.097
.097
.097
.075
.107
.105
.095
.093
.093
.093
.091
.089
.089
.087
.087
.085
.085
.079
.075
.105
.101
.097
.085
.093
.101
.101
.097
.095
.095

RATE
mm

2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
2.5
2.5
2.4
2.4
2.3
2.3
2.2
2.2
2.1
2.1
2.0
2.0
1.9
1.9
1.8
1.8
2.7
2.4
2.2
2.4
2.2
2.2
2.8
2.8
2.6
2.5
2.5
2.5
1.9
2.7
2.7
2.4
2.4
2.4
2.4
2.3
2.3
2.3
2.2
2.2
2.2
2.2
2.0
1.9
2.7
2.6
2.5
2.2
2.4
2.6
2.6
2.5
2.4
2.4

Lbs./In.

.60
.52
1.2
1.0
2.0
1.7
3.2
2.8
5.1
4.4
7.9
6.9
12
10
18
16
1.8
1.6
2.9
2.5
4.6
4.0
7.0
6.1
11
9.3
.50
.43
1.0
.87
1.7
1.5
2.7
2.4
4.2
3.6
6.5
5.6
9.7
8.4
15
13
3.2
36
99
11
52
66
.35
.65
1.9
6.5
10
13
112
1.0
1.2
12
16
12
10
22
23
21
23
30
39
31
76
187
1.5
3.3
10
40
12
2.3
2.4
3.7
8.4
9.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

Lbs.

.11
.09
.21
.18
.35
.31
.56
.49
.89
.77
1.4
1.2
2.1
1.8
3.1
2.7
.32
.27
.51
.44
.81
.70
1.2
1.1
1.9
1.6
.09
.08
.18
.15
.30
.26
.48
.42
.73
.63
1.1
.98
1.7
1.5
2.6
2.3
.55
6.4
17
1.9
9.2
12
.06
.11
.34
1.1
1.8
2.4
20
.18
.21
2.1
2.8
2.1
1.8
3.9
4.1
3.6
4.0
5.2
6.9
5.5
13
33
.27
.57
1.8
7.0
2.0
.40
.42
.65
1.5
1.7

.92
.67
.79
.58
.74
.54
.62
.47
.55
.42
.48
.37
.42
.32
.35
.27
.82
.60
.68
.52
.61
.46
.54
.41
.47
.36
1.1
.81
.94
.69
.85
.63
.72
.55
.67
.51
.59
.45
.51
.39
.43
.33
.08
.04
.04
.08
.06
.06
.16
.16
.12
.10
.09
.11
.04
.17
.14
.13
.12
.11
.10
.10
.10
.09
.09
.11
.06
.10
.07
.03
.21
.18
.14
.09
.15
.17
.20
.14
.17
.11

23
17
20
15
19
14
16
12
14
11
12
9.3
11
8.2
9.0
6.9
21
15
17
13
15
12
14
11
12
9.0
28
20
24
17
22
16
18
14
17
13
15
11
13
10
11
8.3
1.9
1.1
.93
1.9
1.5
1.4
4.0
3.9
3.2
2.5
2.3
2.7
1.1
4.3
3.6
3.3
3.0
2.8
2.6
2.6
2.6
2.2
2.3
2.7
1.6
2.5
1.8
.88
5.2
4.5
3.6
2.3
3.8
4.3
5.0
3.6
4.3
2.8

.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
.55
.35
.94
.60
1.5
.94
2.0
1.3
2.8
1.9
3.8
2.5
5.0
3.3
6.4
4.2
.24
1.6
3.7
.81
3.2
3.7
.05
.10
.24
.65
.91
1.4
4.9
.17
.17
1.6
1.9
1.3
1.1
2.3
2.4
1.8
2.1
3.2
2.4
3.1
5.5
6.5
.31
.58
1.4
3.7
1.7
.39
.47
1.1
1.4
1.1

ENDS: C - Closed

G - Ground
O - Open

2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
2.4
1.6
4.2
2.7
6.6
4.2
8.8
5.9
12
8.3
17
11
22
15
28
19
1.1
7.0
16
3.6
14
16
.24
.45
1.1
2.9
4.0
6.3
22
.76
.74
7.0
8.5
5.7
4.8
10
11
8.0
9.3
14
11
14
24
29
1.4
2.6
6.3
16
7.7
1.7
2.1
4.9
6.3
4.7

Inches

.20
.20
.26
.26
.35
.35
.45
.45
.54
.54
.62
.62
.72
.72
.77
.77
.39
.39
.49
.49
.59
.59
.70
.70
.78
.78
.24
.24
.31
.31
.40
.40
.52
.52
.65
.65
.75
.75
.86
.86
.92
.92
.05
.07
.10
.11
.11
.12
.06
.06
.09
.12
.09
.08
.18
.08
.11
.10
.10
.14
.15
.12
.15
.13
.15
.14
.15
.15
.16
.15
.08
.09
.10
.14
.15
.14
.11
.13
.14
.11

mm

5.1
5.1
6.6
6.6
8.9
8.9
11.4
11.4
13.8
13.8
15.8
15.8
18.2
18.2
19.5
19.5
9.9
9.9
12.5
12.5
15.0
15.0
17.7
17.7
19.8
19.8
6.0
6.0
7.8
7.8
10.2
10.2
13.2
13.2
16.6
16.6
19.1
19.1
21.7
21.7
23.2
23.2
1.3
1.7
2.5
2.9
2.9
3.0
1.6
1.6
2.4
3.0
2.3
2.1
4.4
2.1
2.8
2.5
2.6
3.5
3.7
3.1
3.8
3.3
3.9
3.5
3.8
3.9
4.1
3.8
1.9
2.3
2.5
3.6
3.8
3.7
2.9
3.4
3.6
2.7

WIRE DIA.
Inches

0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.010
0.010
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.010
0.015
0.020
0.015
0.019
0.020
0.007
0.008
0.011
0.014
0.014
0.014
0.025
0.009
0.010
0.015
0.016
0.016
0.016
0.017
0.018
0.018
0.019
0.019
0.020
0.020
0.023
0.025
0.010
0.012
0.014
0.020
0.016
0.012
0.012
0.014
0.015
0.015

mm

TOTAL
MATL
COILS

0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.4
0.5
0.4
0.5
0.5
0.2
0.2
0.3
0.4
0.4
0.4
0.6
0.2
0.3
0.4
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.3
0.3
0.4
0.5
0.4
0.3
0.3
0.4
0.4
0.4

20.0
20.0
21.8
21.8
25.1
25.1
28.1
28.1
30.1
30.1
31.1
31.1
32.5
32.5
32.0
32.0
27.8
27.8
30.9
30.9
32.9
32.9
34.9
34.9
35.5
35.5
23.6
23.6
25.6
25.6
28.8
28.8
32.5
32.5
36.3
36.3
37.6
37.6
38.9
38.9
38.1
38.1
5.00
3.50
4.00
6.50
5.00
5.00
8.00
7.00
8.00
7.50
5.50
5.00
7.00
8.00
10.0
6.50
6.50
7.50
8.13
6.25
7.50
7.25
8.00
7.25
6.50
7.00
7.00
5.00
7.50
7.50
6.00
7.00
8.25
11.0
9.50
8.50
8.50
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
MW
SST
MW
MW
MW
SST
MW
SST
SST
MW
MW
MW
MW
MW
MW
SST
SST
MW
MW
SST
SST
MW
SST
MW
MW
MW
SST
SST
MW
MW
MW
MW
SST
BC
MW
SST

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
CG
CG
C
C
C
C
CG
CG
CG
C
C
CG
C
CG
CG
C
CG
C
C
CG
C
C
CG

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
GI
N
N
N
N
Z
N
N
N
N
Z
N
BO
N
N
N
Z
N
Z
N
N
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 23

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125

3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18

B1-14
G-66
U-79
A13-23
L-91
L-1
TT-3
NN-60
KK-18
3196
FF-86
V-69
N-16
B6-5
G-18
A13-21
B-57
L-11
II-94
U-9
O-15
A11-11
O-7
B1-27
G-15
H-98
Q-93
UU-14
DD-69
LL-5
S-700
A12-7
10172
G-5
NN-85
N-14
M-113
B-60
B-82
F-74
NN-13
GG-51
F-88
V-43
S-846
B12-9
W-79
10832
2765
A10-21
A13-12
11400
DD-3
B5-67
10068
Q-81
11123
LL-23
B-407
B-408
U-85
S-202
3117
A14-11
B-409
G-90
S-320
F-100
A14-21
B-410
G-35
B-411
B-412
S-701
B5-7
10904
11117
A10-45
A13-10
F-67

.31
.31
.31
.31
.31
.31
.31
.31
.31
.34
.34
.34
.34
.34
.34
.34
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.41
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
8.7
8.7
8.7
8.7
8.7
8.7
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5

I.D.
Inches

.091
.091
.091
.089
.083
.081
.081
.077
.075
.101
.101
.095
.093
.085
.083
.079
.073
.099
.095
.095
.093
.091
.091
.089
.089
.085
.085
.085
.081
.081
.081
.079
.077
.075
.075
.095
.091
.089
.089
.089
.081
.095
.089
.087
.081
.079
.075
.105
.093
.083
.077
.075
.109
.107
.105
.105
.105
.105
.101
.099
.097
.095
.093
.093
.093
.093
.093
.093
.089
.089
.089
.085
.081
.081
.081
.107
.105
.095
.089
.089

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

2.3
2.3
2.3
2.3
2.1
2.1
2.1
2.0
1.9
2.6
2.6
2.4
2.4
2.2
2.1
2.0
1.9
2.5
2.4
2.4
2.4
2.3
2.3
2.3
2.3
2.2
2.2
2.2
2.1
2.1
2.1
2.0
2.0
1.9
1.9
2.4
2.3
2.3
2.3
2.3
2.1
2.4
2.3
2.2
2.1
2.0
1.9
2.7
2.4
2.1
2.0
1.9
2.8
2.7
2.7
2.7
2.7
2.7
2.6
2.5
2.5
2.4
2.4
2.4
2.4
2.4
2.4
2.4
2.3
2.3
2.3
2.2
2.1
2.1
2.1
2.7
2.7
2.4
2.3
2.3

Lbs./In.

16
14
11
16
41
49
45
93
81
3.9
2.8
5.5
12
22
45
50
113
2.7
6.8
6.8
10
11
13
13
14
22
17
33
34
38
33
54
56
102
70
7.8
11
14
14
15
33
4.2
13
15
27
37
62
1.3
7.7
23
47
64
.19
.83
.50
.33
1.1
1.2
2.2
3.0
3.7
7.3
7.8
6.1
7.1
7.3
6.7
6.9
9.5
11
14
18
27
24
26
.35
1.1
4.2
9.5
11

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

2.8
2.5
1.9
2.8
7.3
8.6
7.8
16
14
.68
.48
.96
2.1
3.9
7.9
8.7
20
.47
1.2
1.2
1.8
1.9
2.2
2.3
2.4
3.8
2.9
5.8
6.0
6.7
5.9
9.5
9.8
18
12
1.4
1.9
2.4
2.4
2.7
5.9
.74
2.2
2.7
4.7
6.5
11
.22
1.3
4.1
8.3
11
.03
.15
.09
.06
.19
.21
.39
.52
.64
1.3
1.4
1.1
1.2
1.3
1.2
1.2
1.7
1.9
2.5
3.2
4.8
4.2
4.5
.06
.19
.74
1.7
2.0

.14
.15
.11
.11
.10
.10
.07
.07
.05
.23
.22
.16
.16
.11
.09
.07
.06
.21
.15
.23
.18
.14
.18
.14
.16
.11
.08
.11
.13
.08
.10
.10
.11
.06
.06
.20
.20
.19
.20
.17
.10
.20
.21
.14
.12
.15
.07
.36
.25
.12
.13
.07
.34
.41
.28
.18
.39
.28
.35
.33
.30
.14
.25
.21
.27
.26
.19
.28
.19
.24
.19
.20
.18
.13
.19
.35
.42
.29
.26
.24

mm

3.6
3.7
2.7
2.8
2.6
2.5
1.8
1.7
1.4
5.9
5.5
4.1
4.0
2.8
2.4
1.8
1.6
5.4
3.9
5.7
4.7
3.6
4.6
3.4
4.0
2.9
1.9
2.8
3.4
2.1
2.4
2.6
2.8
1.6
1.6
5.1
5.1
4.8
5.0
4.4
2.4
5.0
5.3
3.5
3.0
3.7
1.8
9.2
6.3
3.1
3.3
1.7
8.6
10
7.1
4.6
9.8
7.1
9.0
8.5
7.7
3.7
6.2
5.3
6.8
6.7
4.8
7.0
4.8
6.1
4.9
5.1
4.5
3.4
4.8
8.8
11
7.4
6.6
6.1

ENDS: C - Closed

G - Ground
O - Open

Lbs.

2.3
2.1
1.1
1.8
4.2
4.8
3.2
6.2
4.4
.91
.60
.89
1.9
2.4
4.2
3.6
7.3
.57
1.1
1.5
1.9
1.5
2.3
1.8
2.2
2.4
1.2
3.7
4.6
3.2
3.2
5.5
6.2
6.5
4.4
1.6
2.1
2.6
2.7
2.7
3.2
.83
2.6
2.1
3.2
5.5
4.4
.46
1.9
2.8
6.2
4.4
.06
.34
.14
.06
.43
.34
.79
1.0
1.1
1.1
1.9
1.3
1.9
1.9
1.3
1.9
1.8
2.6
2.7
3.7
4.8
3.2
4.8
.12
.46
1.2
2.5
2.7

10
9.2
5.1
8.0
19
21
14
27
19
4.0
2.7
4.0
8.5
11
19
16
32
2.5
4.7
6.8
8.5
6.7
10
8.0
9.7
11
5.5
16
20
14
14
24
27
29
19
7.0
9.5
12
12
12
14
3.7
12
9.3
14
24
19
2.0
8.5
12
27
19
.28
1.5
.62
.26
1.9
1.5
3.5
4.5
5.0
4.7
8.5
5.7
8.5
8.5
5.7
8.5
8.0
11
12
16
21
14
21
.53
2.1
5.4
11
12

Inches

.14
.17
.20
.18
.19
.20
.18
.17
.23
.10
.13
.18
.14
.20
.18
.22
.23
.16
.15
.15
.16
.17
.18
.18
.22
.22
.30
.18
.24
.22
.24
.23
.25
.21
.23
.15
.20
.22
.20
.20
.22
.24
.23
.23
.29
.28
.25
.11
.20
.24
.31
.24
.16
.09
.22
.32
.12
.10
.15
.17
.20
.14
.20
.20
.21
.21
.18
.20
.24
.26
.21
.28
.31
.31
.31
.19
.12
.24
.27
.25

mm

Inches

3.5
4.2
5.2
4.5
4.8
5.2
4.5
4.3
5.7
2.5
3.2
4.6
3.7
5.1
4.5
5.7
5.9
4.1
3.8
3.8
4.1
4.3
4.5
4.7
5.5
5.6
7.6
4.6
6.1
5.6
6.1
5.8
6.2
5.4
5.7
3.8
5.2
5.5
5.0
5.0
5.6
6.1
5.8
5.8
7.3
7.2
6.4
2.7
5.1
6.1
7.8
6.2
4.1
2.3
5.6
8.1
2.9
2.5
3.7
4.2
5.0
3.6
5.0
5.1
5.4
5.3
4.7
5.1
6.2
6.6
5.4
7.1
8.0
8.0
7.8
4.7
2.9
6.1
6.9
6.4

0.017
0.017
0.017
0.018
0.021
0.022
0.022
0.024
0.025
0.012
0.012
0.015
0.016
0.020
0.021
0.023
0.026
0.013
0.015
0.015
0.016
0.017
0.017
0.018
0.018
0.020
0.020
0.020
0.022
0.022
0.022
0.023
0.024
0.025
0.025
0.015
0.017
0.018
0.018
0.018
0.022
0.015
0.018
0.019
0.022
0.023
0.025
0.010
0.016
0.021
0.024
0.025
0.008
0.009
0.010
0.010
0.010
0.010
0.012
0.013
0.014
0.015
0.016
0.016
0.016
0.016
0.016
0.016
0.018
0.018
0.018
0.020
0.022
0.022
0.022
0.009
0.010
0.015
0.018
0.018

mm

TOTAL
MATL
COILS

0.4
0.4
0.4
0.5
0.5
0.6
0.6
0.6
0.6
0.3
0.3
0.4
0.4
0.5
0.5
0.6
0.7
0.3
0.4
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.4
0.4
0.5
0.5
0.5
0.6
0.4
0.5
0.5
0.6
0.6
0.6
0.3
0.4
0.5
0.6
0.6
0.2
0.2
0.3
0.3
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.2
0.3
0.4
0.5
0.5

8.00
8.75
11.0
8.75
8.00
8.25
8.00
7.00
8.00
7.33
9.50
12.0
8.00
10.0
7.50
8.75
8.00
11.5
10.0
10.0
9.00
10.0
9.50
10.3
11.0
10.0
14.0
8.00
11.0
9.00
10.0
9.00
10.3
7.50
9.00
9.00
11.0
11.0
11.0
10.0
10.0
15.0
11.8
11.0
12.0
12.3
10.0
9.50
11.5
11.5
11.8
9.75
19.0
9.25
21.0
31.0
10.5
9.00
11.3
11.8
13.0
8.50
11.3
12.5
12.3
12.0
11.5
12.5
13.5
13.5
10.8
13.0
13.3
13.3
14.0
19.5
10.5
15.0
15.0
13.0

MW
MW
MW
SST
MW
MW
SST
MW
SST
MW
MW
MW
MW
SST
MW
SST
MW
SST
SST
MW
MW
SST
MW
SST
MW
SST
MW
MW
MW
SST
SST
MW
MW
MW
SST
MW
MW
MW
MW
MW
SST
MW
MW
SST
SST
MW
SST
MW
MW
SST
MW
SST
SST
MW
MW
MW
MW
SST
MW
MW
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
MW
MW
MW
SST
MW
MW
MW
MW
MW
MW

E
N
D
S

F
N
S
H

CG
C
C
C
C
C
CG
C
C
C
C
CG
C
CG
C
C
C
C
C
CG
C
CG
C
CG
C
C
C
C
CG
C
C
C
CG
C
CG
C
C
C
CG
C
CG
C
C
C
C
CG
CG
C
C
CG
C
CG
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
CG
CG
CG
C
C
C
C
C
CG
C
C
C
CG
C

GI
Z
N
N
GI
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
GI
Z
N
N
N
N
N
BO
N
N
N
Z
GI
Z
N
GI
Z
N
N
BO
N
N
Z
N
N
N
N
N
Z
N
N
N
Z
Z
N
N
GI
N
Z
N
N
N
N
Z
N
Z
Z
N
N
Z
N
N
N
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

23

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 24

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125

3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18

A-21
B10-25
J-69
L-79
S-1012
S-937
G-27
A-1
390
A-43
N-22
S-1445
J-89
B14-9
EE-61
S-1543
A10-20
F-5
B1-19
G-2
2544
903
J-64
S-11
3546
FF-51
A-80
A13-22
F-72
NN-9
J-75
B4-9
B12-7
S-1687
B4-4
915
JJ-27
A11-15
F-3
A13-50
OO-21
KK-31
S-702
B14-18
A10-24
10957
TT-9
B5-54
AA-70
1719
S-881
B4-3
S-792
10943
KK-41
OO-69
S-1511
B7-15
KK-82
Y-85
LL-89
MM-66
10745
391
354-A
G-7
II-59
M-143
OO-15
B-5
JJ-76
XX-42
3552
GG-67
H-56
2984
A11-62
2903
10474
S-3152

.53
.56
.56
.56
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.69
.69
.69
.69
.69
.69
.70
.72
.73
.73
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.81
.81
.81
.81
.84
.84
.84
.88
.88
.91
.91
.91
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.06
1.09
1.09
1.09
1.13
1.13
1.13
1.13
1.19

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

13.5
14.3
14.3
14.3
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.9
18.2
18.6
18.6
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
20.6
20.6
20.6
20.6
21.4
21.4
21.4
22.2
22.2
23.0
23.0
23.0
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
27.0
27.8
27.8
27.8
28.6
28.6
28.6
28.6
30.2

MATERIAL: MW - Music Wire

24

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.085
.097
.091
.083
.099
.089
.063
.105
.103
.103
.103
.099
.097
.097
.095
.095
.089
.089
.079
.075
.073
.069
.095
.095
.085
.105
.101
.089
.085
.079
.075
.095
.095
.095
.089
.101
.101
.093
.089
.087
.085
.085
.081
.081
.079
.101
.089
.079
.109
.105
.099
.095
.101
.091
.081
.105
.095
.091
.085
.085
.085
.065
.107
.103
.097
.097
.095
.095
.095
.093
.079
.093
.097
.085
.083
.099
.097
.085
.081
.101

RATE
mm

2.2
2.5
2.3
2.1
2.5
2.3
1.6
2.7
2.6
2.6
2.6
2.5
2.5
2.5
2.4
2.4
2.3
2.3
2.0
1.9
1.9
1.8
2.4
2.4
2.2
2.7
2.6
2.3
2.2
2.0
1.9
2.4
2.4
2.4
2.3
2.6
2.6
2.4
2.3
2.2
2.2
2.2
2.1
2.1
2.0
2.6
2.3
2.0
2.8
2.7
2.5
2.4
2.6
2.3
2.1
2.7
2.4
2.3
2.2
2.2
2.2
1.7
2.7
2.6
2.5
2.5
2.4
2.4
2.4
2.4
2.0
2.4
2.5
2.2
2.1
2.5
2.5
2.2
2.1
2.6

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

18
3.1
3.4
.60
7.3
1.3
15
2.7
2.3
.40
7.7
1.4
133
23
.95
.17
1.6
.28
1.2
.22
1.3
.23
1.3
.23
3.3
.58
3.1
.54
4.2
.74
4.4
.77
11
2.0
8.8
1.5
25
4.4
28
4.8
68
12
97
17
2.4
.42
2.4
.41
16
2.8
.35
.06
1.4
.25
6.8
1.2
12
2.2
22
3.9
26
4.5
4.3
.76
3.7
.65
4.0
.69
7.5
1.3
1.5
.26
1.6
.28
3.9
.68
7.0
1.2
8.9
1.6
11
1.9
12
2.0
15
2.6
20
3.5
20
3.5
1.3
.22
5.6
.98
19
3.3
.30
.05
.84
.15
1.3
.23
5.0
.87
1.0
.18
8.3
1.5
20
3.5
.30
.05
4.0
.69
5.4
.95
10
1.8
9.7
1.7
8.6
1.5
55
9.6
.42
.07
.96
.17
2.2
.39
1.9
.33
3.0
.53
2.1
.37
3.4
.60
3.5
.62
11
2.0
3.0
.53
2.1
.37
6.3
1.1
8.3
1.5
.94
.16
1.2
.22
9.8
1.7
19
3.3
.97
.17

.14
.36
.29
.18
.32
.23
.09
.50
.44
.47
.47
.35
.41
.40
.38
.24
.24
.31
.22
.10
.11
.09
.33
.30
.23
.39
.41
.26
.29
.24
.14
.24
.43
.27
.36
.55
.56
.32
.38
.36
.33
.31
.21
.24
.18
.55
.32
.28
.57
.63
.52
.32
.57
.28
.16
.53
.27
.42
.35
.38
.42
.13
.85
.73
.64
.66
.52
.57
.46
.54
.26
.42
.67
.39
.40
.68
.68
.37
.26
.59

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

3.5
9.0
7.4
4.5
8.2
5.9
2.2
13
11
12
12
8.8
10
10
9.6
6.1
6.0
7.8
5.5
2.5
2.7
2.3
8.3
7.7
5.8
9.8
10
6.7
7.5
6.2
3.5
6.2
11
6.7
9.2
14
14
8.3
9.7
9.0
8.4
7.9
5.4
6.1
4.7
14
8.1
7.0
14
16
13
8.1
14
7.0
4.1
13
6.7
11
8.9
9.6
11
3.3
21
18
16
17
13
14
12
14
6.7
11
17
9.8
10
17
17
9.5
6.5
15

Lbs.

2.4
1.2
2.1
2.7
.73
1.8
12
.47
.70
.58
.61
.45
1.4
1.2
1.6
1.1
2.7
2.7
5.5
2.8
7.3
8.9
.79
.72
3.7
.14
.58
1.8
3.7
5.5
3.5
1.1
1.6
1.1
2.7
.81
.91
1.3
2.7
3.2
3.6
3.7
3.2
4.8
3.6
.68
1.8
5.2
.17
.53
.68
1.6
.58
2.3
3.2
.16
1.1
2.3
3.7
3.7
3.6
7.2
.36
.70
1.4
1.2
1.6
1.2
1.6
1.9
3.0
1.3
1.4
2.4
3.3
.64
.84
3.7
4.8
.58

ENDS: C - Closed

G - Ground
O - Open

11
5.4
9.5
12
3.2
8.0
52
2.1
3.1
2.6
2.7
2.0
6.0
5.5
7.0
4.7
12
12
24
12
32
40
3.5
3.2
16
.60
2.6
8.0
16
24
16
4.7
7.0
4.7
12
3.6
4.0
5.7
12
14
16
16
14
21
16
3.0
8.0
23
.77
2.4
3.0
7.0
2.6
10
14
.70
4.7
10
16
16
16
32
1.6
3.1
6.3
5.5
7.0
5.3
7.0
8.5
13
5.7
6.3
11
15
2.8
3.7
16
21
2.6

Inches

.26
.21
.27
.38
.19
.30
.47
.13
.13
.16
.15
.28
.21
.22
.24
.21
.25
.31
.39
.53
.34
.36
.33
.35
.31
.30
.19
.32
.38
.44
.55
.20
.25
.23
.35
.20
.19
.30
.37
.38
.42
.40
.46
.44
.46
.23
.41
.51
.11
.14
.29
.21
.25
.25
.36
.35
.23
.35
.44
.47
.52
.71
.16
.20
.30
.34
.32
.44
.29
.38
.74
.38
.31
.60
.69
.45
.45
.47
.43
.26

mm

6.6
5.2
6.9
9.7
4.7
7.7
11.8
3.3
3.4
4.1
3.9
7.1
5.4
5.7
6.1
5.3
6.3
7.8
9.9
13.3
8.6
9.2
8.4
9.0
7.9
7.6
4.9
8.2
9.7
11.1
14.0
5.0
6.4
5.7
8.9
5.2
4.8
7.5
9.4
9.5
10.7
10.2
11.7
11.2
11.7
5.9
10.3
12.9
2.7
3.6
7.4
5.3
6.4
6.3
9.2
8.8
5.7
8.9
11.2
11.9
13.2
17.9
3.9
5.0
7.6
8.7
8.0
11.0
7.2
9.6
18.7
9.8
7.8
15.2
17.6
11.3
11.4
11.8
10.9
6.6

WIRE DIA.
Inches

0.020
0.014
0.017
0.021
0.013
0.018
0.031
0.010
0.011
0.011
0.011
0.013
0.014
0.014
0.015
0.015
0.018
0.018
0.023
0.025
0.026
0.028
0.015
0.015
0.020
0.010
0.012
0.018
0.020
0.023
0.025
0.015
0.015
0.015
0.018
0.012
0.012
0.016
0.018
0.019
0.020
0.020
0.022
0.022
0.023
0.012
0.018
0.023
0.008
0.010
0.013
0.015
0.012
0.017
0.022
0.010
0.015
0.017
0.020
0.020
0.020
0.030
0.009
0.011
0.014
0.014
0.015
0.015
0.015
0.016
0.023
0.016
0.014
0.020
0.021
0.013
0.014
0.020
0.022
0.012

mm

TOTAL
MATL
COILS

0.5
0.4
0.4
0.5
0.3
0.5
0.8
0.3
0.3
0.3
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.6
0.6
0.7
0.7
0.4
0.4
0.5
0.3
0.3
0.5
0.5
0.6
0.6
0.4
0.4
0.4
0.5
0.3
0.3
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.3
0.5
0.6
0.2
0.3
0.3
0.4
0.3
0.4
0.6
0.3
0.4
0.4
0.5
0.5
0.5
0.8
0.2
0.3
0.4
0.4
0.4
0.4
0.4
0.4
0.6
0.4
0.4
0.5
0.5
0.3
0.4
0.5
0.6
0.3

12.0
13.8
15.0
18.3
13.3
15.9
14.0
12.0
11.0
13.5
13.0
21.5
14.3
15.0
15.0
13.0
12.8
16.0
17.0
20.0
12.0
12.0
22.0
22.5
14.5
29.0
15.0
18.0
18.0
19.0
21.0
13.0
16.8
14.0
18.5
16.0
14.8
18.5
19.5
19.8
20.0
19.0
20.0
20.0
19.0
18.5
21.5
22.0
12.5
13.3
21.5
13.0
20.0
13.5
15.5
33.8
14.0
19.5
21.0
22.5
25.0
23.5
16.3
16.8
20.3
23.5
20.0
28.0
18.0
22.5
31.0
23.0
21.0
30.0
32.0
33.3
31.0
22.3
18.5
20.5

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
MW
MW
SST
SST
MW
MW
MW
MW
MW
SST
MW
MW
MW
SST
MW
MW
MW
SST
MW
MW
SST
SST
MW
MW
SST
SST
MW
MW
SST
SST
MW
SST
MW
MW
MW
SST
MW
MW
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
MW
MW
SST
MW
MW
MW
MW
MW
MW
MW
MW
SST
SST
MW
SST
MW
MW
SST
MW
MW
SST

E
N
D
S

F
N
S
H

C
C
C
CG
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
CG
C
C
C
CG
C
C
C
C
CG
C
CG
C
CG
CG
C
C
C
C
CG
C
CG
C
C
C
CG
C
C
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
C
C

N
N
Z
Z
N
N
N
N
Z
BO
N
N
N
N
N
N
N
Z
GI
N
Z
Z
N
N
Z
N
N
N
Z
N
N
N
N
N
N
Z
N
N
Z
GI
N
N
N
N
N
Z
N
GI
N
Z
N
N
N
Z
N
N
N
N
N
GI
N
N
N
Z
Z
BO
Z
Z
N
N
N
N
GI
N
Z
Z
N
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 25

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.125
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140

3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.18
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56

B15-63
S-1085
PP-9
AA-7
354-B
1827
KK-90
MM-82
FF-54
NN-94
2982
354-C
BB-34
Y-65
S-1474
10224
DD-49
J-84
U-93
Z-7
II-9
JJ-72
OO-19
L-97
GG-60
B8-8
AA-6
LL-69
A9-27
CC-91
NN-41
H-77
A-27
A12-1
O-80
J-26
12619
B2-23
A15-25
FF-22
M-129
A15-6
AA-42
GG-38
3762
H-95
S-1535
11375
3633
J-80
UU-4
B1-10
J-99
3793
V-40
B14-56
J-90
V-41
OO-22
2674
CC-19
J-55
11255
N-35
S-236
B18-144
S-191
S-1331
10025
XX-38
B15-46
2935
10994
Q-95
EE-30
AA-12
MM-5
10212
V-77
JJ-74

1.22
1.25
1.25
1.38
1.38
1.38
1.38
1.38
1.38
1.50
1.53
1.75
2.25
3.00
4.25
.16
.19
.20
.25
.25
.25
.25
.28
.28
.31
.31
.31
.31
.34
.34
.34
.34
.34
.35
.36
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.39
.41
.41
.41
.42
.44
.44
.44
.44
.44
.44
.44
.45
.47
.47
.50
.50
.50
.50
.53
.56
.56
.56
.58
.59
.59
.63
.63
.66
.66
.66
.69
.69
.70

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

31.0
31.8
31.8
34.9
34.9
34.9
34.9
34.9
34.9
38.1
38.9
44.5
57.2
76.2
108.0
4.0
4.8
5.2
6.4
6.4
6.4
6.4
7.1
7.1
7.9
7.9
7.9
7.9
8.7
8.7
8.7
8.7
8.7
8.9
9.1
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.9
10.3
10.3
10.3
10.7
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.5
11.9
11.9
12.7
12.7
12.7
12.7
13.5
14.3
14.3
14.3
14.7
15.1
15.1
15.9
15.9
16.7
16.7
16.7
17.4
17.4
17.9

I.D.
Inches

.099
.095
.065
.105
.097
.093
.089
.087
.085
.075
.095
.097
.085
.105
.105
.122
.116
.100
.118
.112
.096
.080
.120
.116
.112
.104
.100
.090
.098
.088
.088
.084
.082
.112
.100
.116
.116
.116
.114
.114
.110
.100
.100
.100
.084
.084
.078
.108
.104
.102
.100
.124
.116
.108
.106
.104
.102
.102
.100
.104
.100
.120
.116
.090
.088
.124
.104
.100
.094
.100
.120
.096
.100
.080
.116
.110
.076
.106
.102
.100

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

2.5
2.4
1.7
2.7
2.5
2.4
2.3
2.2
2.2
1.9
2.4
2.5
2.2
2.7
2.7
3.1
2.9
2.5
3.0
2.8
2.4
2.0
3.0
2.9
2.8
2.6
2.5
2.3
2.5
2.2
2.2
2.1
2.1
2.8
2.5
2.9
2.9
2.9
2.9
2.9
2.8
2.5
2.5
2.5
2.1
2.1
2.0
2.7
2.6
2.6
2.5
3.1
2.9
2.7
2.7
2.6
2.6
2.6
2.5
2.6
2.5
3.0
2.9
2.3
2.2
3.1
2.6
2.5
2.4
2.5
3.0
2.4
2.5
2.0
2.9
2.8
1.9
2.7
2.6
2.5

Lbs./In.

1.0
2.4
100
.47
1.6
2.3
4.9
6.6
7.9
13
3.1
1.2
5.7
.21
.08
1.2
4.2
67
1.6
3.8
102
155
1.0
2.0
2.7
14
27
49
27
57
66
78
110
4.0
41
2.8
2.6
2.2
4.0
4.0
5.7
21
13
18
157
126
162
7.0
14
14
17
.26
1.1
7.9
6.5
17
13
11
27
12
13
.65
1.1
41
64
.32
13
17
28
17
.33
19
13
65
1.1
2.2
90
9.9
13
17

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

.18
.43
18
.08
.28
.41
.86
1.1
1.4
2.3
.55
.22
.99
.04
.01
.21
.74
12
.29
.67
18
27
.18
.36
.47
2.4
4.7
8.6
4.7
10
11
14
19
.70
7.2
.50
.45
.38
.70
.70
1.0
3.6
2.3
3.1
28
22
28.3
1.2
2.4
2.4
3.0
.05
.19
1.4
1.1
2.9
2.3
1.9
4.7
2.1
2.3
.11
.18
7.2
11
.06
2.3
2.9
4.9
2.9
.06
3.3
2.3
11
.19
.38
16
1.7
2.3
2.9

Inches

.80
.43
.07
.72
.90
.81
.55
.48
.46
.33
.51
1.1
.64
2.5
3.2
.10
.12
.05
.15
.12
.04
.04
.19
.16
.16
.15
.12
.08
.09
.08
.07
.07
.05
.20
.05
.28
.27
.26
.26
.20
.23
.11
.16
.12
.05
.06
.045
.16
.18
.14
.13
.34
.25
.22
.22
.15
.22
.19
.12
.20
.21
.37
.32
.14
.07
.44
.12
.13
.18
.20
.36
.23
.25
.15
.47
.43
.09
.21
.22
.20

mm

20
11
1.8
18
23
21
14
12
12
8.4
13
29
16
64
82
2.5
2.9
1.3
3.8
3.1
1.1
1.1
4.7
4.1
4.0
3.8
3.2
2.0
2.4
2.0
1.7
1.8
1.4
5.2
1.4
7.1
6.9
6.6
6.5
5.1
5.9
2.7
3.9
3.1
1.3
1.6
1.14
4.1
4.5
3.5
3.3
8.7
6.2
5.5
5.5
3.7
5.5
4.9
3.2
5.2
5.3
9.4
8.1
3.7
1.8
11
3.1
3.4
4.5
5.0
9.2
5.9
6.3
3.9
12
11
2.2
5.3
5.5
5.0

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.81
1.1
7.2
.34
1.4
1.9
2.7
3.2
3.7
4.4
1.6
1.4
3.7
.52
.27
.12
.49
3.3
.25
.46
4.4
6.6
.19
.33
.42
2.1
3.3
4.0
2.5
4.4
4.4
5.5
6.0
.82
2.2
.79
.71
.57
1.0
.80
1.3
2.2
2.0
2.2
8.2
8.2
7.3
1.1
2.4
1.9
2.2
.09
.27
1.7
1.4
2.4
2.8
2.0
3.3
2.4
2.8
.24
.34
5.9
4.4
.14
1.6
2.2
4.9
3.3
.12
4.4
3.3
9.9
.52
.93
7.9
2.1
2.8
3.3

3.6
4.7
32
1.5
6.3
8.5
12
14
16
19
7.0
6.3
16
2.3
1.2
.52
2.2
15
1.1
2.1
19
30
.83
1.5
1.9
9.2
15
18
11
20
20
24
27
3.6
9.8
3.5
3.1
2.5
4.6
3.6
5.9
9.8
8.9
9.8
36
36
32.5
5.1
11
8.4
9.8
.40
1.2
7.7
6.2
11
13
9.0
15
11
12
1.1
1.5
26
20
.63
7.2
9.8
22
15
.53
19
15
44
2.3
4.1
35
9.1
13
15

Inches

.42
.34
.45
.21
.40
.54
.50
.51
.56
1.00
.31
.50
.76
.49
1.02
.06
.07
.08
.10
.13
.11
.18
.10
.12
.15
.16
.14
.21
.18
.23
.21
.25
.26
.13
.12
.10
.10
.11
.10
.10
.14
.18
.22
.19
.20
.22
.23
.15
.14
.17
.20
.09
.19
.15
.22
.14
.21
.25
.16
.18
.26
.13
.18
.28
.23
.09
.15
.20
.28
.22
.23
.31
.26
.47
.17
.23
.43
.15
.21
.22

mm

Inches

10.6
8.6
11.4
5.3
10.1
13.8
12.8
13.0
14.2
25.4
7.8
12.6
19.3
12.4
25.9
1.5
1.8
2.0
2.5
3.3
2.8
4.6
2.4
3.0
3.9
4.1
3.6
5.4
4.5
5.8
5.3
6.4
6.6
3.2
3.0
2.4
2.6
2.9
2.5
2.6
3.6
4.4
5.6
4.8
5.0
5.7
5.9
3.8
3.7
4.2
5.1
2.4
4.9
3.8
5.6
3.7
5.3
6.3
4.1
4.6
6.6
3.3
4.6
7.0
5.9
2.2
3.9
5.1
7.0
5.6
5.8
7.8
6.6
11.8
4.4
5.7
11.0
3.7
5.3
5.6

0.013
0.015
0.030
0.010
0.014
0.016
0.018
0.019
0.020
0.025
0.015
0.014
0.020
0.010
0.010
0.009
0.012
0.020
0.011
0.014
0.022
0.030
0.010
0.012
0.014
0.018
0.020
0.025
0.021
0.026
0.026
0.028
0.029
0.014
0.020
0.012
0.012
0.012
0.013
0.013
0.015
0.020
0.020
0.020
0.028
0.028
0.031
0.016
0.018
0.019
0.020
0.008
0.012
0.016
0.017
0.018
0.019
0.019
0.020
0.018
0.020
0.010
0.012
0.025
0.026
0.008
0.018
0.020
0.023
0.020
0.010
0.022
0.020
0.030
0.012
0.015
0.032
0.017
0.019
0.020

mm

0.3
0.4
0.8
0.3
0.4
0.4
0.5
0.5
0.5
0.6
0.4
0.4
0.5
0.3
0.3
0.2
0.3
0.5
0.3
0.4
0.6
0.8
0.3
0.3
0.4
0.5
0.5
0.6
0.5
0.7
0.7
0.7
0.7
0.4
0.5
0.3
0.3
0.3
0.3
0.3
0.4
0.5
0.5
0.5
0.7
0.7
0.8
0.4
0.5
0.5
0.5
0.2
0.3
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.5
0.3
0.3
0.6
0.7
0.2
0.5
0.5
0.6
0.5
0.3
0.6
0.5
0.8
0.3
0.4
0.8
0.4
0.5
0.5

TOTAL
MATL
COILS
31.0
21.5
14.0
20.0
27.5
33.0
27.0
26.0
27.0
39.0
19.5
34.5
37.0
48.0
101.0
5.50
5.00
4.00
8.00
8.25
4.00
5.00
8.50
9.00
11.0
8.00
7.00
8.50
7.50
8.75
8.00
9.00
8.00
8.00
4.88
7.00
7.50
8.50
7.00
7.00
8.50
7.75
11.0
8.50
6.00
7.00
7.50
8.25
8.00
8.75
9.00
10.8
15.0
8.25
12.0
7.00
10.0
12.0
7.00
9.00
12.0
12.0
14.0
11.0
8.00
10.0
7.50
9.00
11.0
10.0
22.0
13.0
12.0
15.5
13.5
15.0
13.5
8.50
10.0
10.0

MW
SST
SST
SST
MW
MW
MW
MW
MW
SST
MW
MW
MW
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
MW
SST
MW
MW
SST
SST
SST
SST
SST
SST
SST
SST
MW
MW
MW
MW
BC
MW
SST
SST
SST
MW
MW
SST
SST
MW
SST
SST
SST
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
SST
MW
SST
MW
SST
SST
MW
MW
MW
MW
MW
MW
SST
MW
SST
MW
MW
MW

E
N
D
S

C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
O
C
C
CG
C
CG
CG
C
CG
CG
CG
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
CG
C
CG
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
CL
C
C
C
C
CG
C
CG
CG
CG
C
C

F
N
S
H

N
N
N
N
Z
Z
N
Z
N
N
Z
Z
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
GI
N
Z
GI
N
N
N
N
N
Z
N
N
N
N
N
N
N
Z
Z
N
N
Z
N
Z
Z
N
Z
N
N
N
Z
N
N
N
N
N
Z
N
N
N
Z
N
GI
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

25

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 26

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.140
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148

3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.56
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76

Q-83
10968
RR-35
JJ-25
11464
RR-44
FF-53
3195
1831
3707
B5-69
S-393
A10-34
3773
11254
NN-55
BB-83
LL-19
PP-54
LL-91
4223
S-1020
B3-41
AA-68
1755
2638
N-108
A12-34
1922
O-128
70206
70206S
70225
70225S
70207
70207S
70226
70226S
70208
70208S
70227
70227S
70209
70209S
70228
70228S
70210
70210S
70229
70229S
70211
70211S
70230
70230S
70212
70212S
70231
70231S
70213
70213S
70232
70232S
70214
70214S
70233
70233S
70215
70215S
70234
70234S
70216
70216S
70235
70235S
70217
70217S
70236
70236S
70218
70218S

.72
.75
.75
.78
.81
.81
.88
.88
.91
.94
.94
.94
1.00
1.00
1.00
1.03
1.06
1.13
1.13
1.25
1.25
1.31
1.31
1.34
1.38
1.38
1.44
1.44
1.50
1.94
.25
.25
.25
.25
.31
.31
.31
.31
.38
.38
.38
.38
.44
.44
.44
.44
.50
.50
.50
.50
.56
.56
.56
.56
.63
.63
.63
.63
.69
.69
.69
.69
.75
.75
.75
.75
.81
.81
.81
.81
.88
.88
.88
.88
.94
.94
.94
.94
1.00
1.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

18.2
19.1
19.1
19.8
20.6
20.6
22.2
22.2
23.0
23.8
23.8
23.8
25.4
25.4
25.4
26.2
27.0
28.6
28.6
31.8
31.8
33.3
33.3
34.1
34.9
34.9
36.5
36.6
38.1
49.2
6.4
6.4
6.4
6.4
7.9
7.9
7.9
7.9
9.7
9.7
9.7
9.7
11.2
11.2
11.2
11.2
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
16.0
16.0
16.0
16.0
17.5
17.5
17.5
17.5
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6
22.4
22.4
22.4
22.4
23.9
23.9
23.9
23.9
25.4
25.4

MATERIAL: MW - Music Wire

26

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.092
.120
.100
.088
.114
.100
.120
.116
.116
.120
.118
.108
.116
.108
.102
.108
.096
.120
.108
.124
.110
.100
.080
.104
.108
.102
.092
.116
.108
.090
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106

RATE
mm

2.3
3.0
2.5
2.2
2.9
2.5
3.0
2.9
2.9
3.0
3.0
2.7
2.9
2.7
2.6
2.7
2.4
3.0
2.7
3.1
2.8
2.5
2.0
2.6
2.7
2.6
2.3
2.9
2.7
2.3
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

21

3.7
.09
.79
3.8
.39
1.1
.08
.18
.19
.06
.06
.39
.11
.62
.82
.58
1.2
.05
.31
.02
.22
.70
5.3
.86
.28
.62
1.8
.07
.30
1.2
6.0
5.2
8.7
7.6
4.7
4.1
6.7
5.8
3.7
3.2
5.3
4.6
3.1
2.7
4.6
4.0
2.7
2.3
4.0
3.4
2.4
2.1
3.5
3.0
2.1
1.9
3.1
2.7
1.9
1.7
2.8
2.4
1.8
1.5
2.6
2.2
1.6
1.4
2.3
2.0
1.6
1.4
2.2
1.9
1.4
1.2
2.0
1.7
1.3
1.1

.27
.59
.18
.21
.30
.34
.71
.67
.71
.71
.59
.51
.72
.49
.40
.52
.41
.85
.63
1.1
.76
.55
.33
.33
.84
.75
.55
1.1
.98
.56
.11
.08
.09
.07
.14
.10
.12
.09
.17
.13
.15
.12
.20
.15
.18
.14
.24
.18
.21
.16
.27
.20
.24
.18
.29
.23
.27
.20
.33
.25
.29
.22
.36
.27
.32
.25
.39
.30
.35
.27
.41
.31
.37
.28
.46
.35
.41
.31
.49
.37

.50
4.5
21
2.2
6.4
.47
1.0
1.1
.33
.34
2.2
.61
3.5
4.7
3.3
7.1
.26
1.8
.14
1.3
4.0
30
4.9
1.6
3.6
10
.43
1.7
7.1
34
30
50
43
27
23
38
33
21
18
31
27
18
16
26
23
15
13
23
20
14
12
20
17
12
11
18
15
11
9.6
16
14
10
8.8
15
13
9.3
8.1
13
12
8.9
7.7
13
11
7.9
6.9
11
10
7.4
6.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

6.7
15
4.6
5.3
7.5
8.7
18
17
18
18
15
13
18
12
10
13
10
21
16
27
19
14
8.3
8.3
21
19
14
27
25
14
2.7
2.1
2.4
1.8
3.5
2.6
3.1
2.4
4.4
3.3
3.9
3.0
5.1
3.9
4.6
3.5
6.0
4.6
5.3
4.1
6.7
5.1
6.0
4.6
7.5
5.7
6.7
5.2
8.3
6.4
7.5
5.7
9.1
6.9
8.2
6.3
9.8
7.5
9.0
6.9
10
7.9
9.4
7.2
12
8.9
10
8.0
12
9.5

Lbs.

5.6
.30
.82
4.4
.66
2.2
.33
.68
.78
.23
.20
1.1
.43
1.7
1.9
1.7
2.9
.22
1.1
.15
.96
2.2
9.9
1.6
1.4
2.7
5.6
.45
1.7
4.0
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4

ENDS: C - Closed

G - Ground
O - Open

25
1.3
3.6
20
2.9
9.8
1.5
3.0
3.5
1.0
.88
5.1
1.9
7.7
8.4
7.7
13
.98
4.9
.68
4.3
9.8
44
7.2
6.0
12
25
2.0
7.4
18
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11

Inches

.42
.16
.57
.52
.14
.42
.17
.20
.19
.23
.35
.36
.29
.27
.44
.29
.62
.28
.50
.17
.49
.64
.93
.32
.54
.62
.79
.38
.52
1.20
.13
.13
.14
.14
.15
.15
.17
.17
.18
.18
.20
.20
.20
.20
.23
.23
.23
.23
.26
.26
.25
.25
.29
.29
.28
.28
.31
.31
.30
.30
.34
.34
.33
.33
.37
.37
.35
.35
.40
.40
.37
.37
.42
.42
.40
.40
.46
.46
.43
.43

mm

10.7
4.1
14.5
13.2
3.6
10.7
4.3
5.2
4.9
5.8
8.9
9.1
7.2
6.9
11.1
7.3
15.6
7.1
12.6
4.3
12.4
16.3
23.6
8.2
13.6
15.8
20.1
9.8
13.1
30.5
3.2
3.2
3.6
3.6
3.8
3.8
4.3
4.3
4.5
4.5
5.1
5.1
5.1
5.1
5.8
5.8
5.8
5.8
6.5
6.5
6.4
6.4
7.2
7.2
7.0
7.0
8.0
8.0
7.7
7.7
8.7
8.7
8.3
8.3
9.4
9.4
8.9
8.9
10.2
10.2
9.3
9.3
10.7
10.7
10.3
10.3
11.7
11.7
10.9
10.9

WIRE DIA.
Inches

0.024
0.010
0.020
0.026
0.013
0.020
0.010
0.012
0.012
0.010
0.011
0.016
0.012
0.016
0.019
0.016
0.022
0.010
0.016
0.008
0.015
0.020
0.030
0.018
0.016
0.019
0.024
0.012
0.016
0.025
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021

mm

TOTAL
MATL
COILS

0.6
0.3
0.5
0.7
0.3
0.5
0.3
0.3
0.3
0.3
0.3
0.4
0.3
0.4
0.5
0.4
0.6
0.3
0.4
0.2
0.4
0.5
0.8
0.5
0.4
0.5
0.6
0.3
0.4
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5

16.5
15.0
27.5
20.0
10.0
20.0
16.0
16.0
15.0
22.0
31.0
21.5
22.8
16.0
22.0
17.0
27.0
27.0
30.0
20.0
31.5
31.0
31.0
17.0
32.5
31.8
32.0
31.0
31.3
47.0
6.00
6.00
6.13
6.13
7.13
7.13
7.38
7.38
8.50
8.50
8.75
8.75
9.63
9.63
9.88
9.88
10.9
10.9
11.1
11.1
12.0
12.0
12.4
12.4
13.1
13.1
13.6
13.6
14.4
14.4
14.9
14.9
15.5
15.5
16.1
16.1
16.6
16.6
17.5
17.5
17.4
17.4
18.3
18.3
19.3
19.3
20.0
20.0
20.5
20.5

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
SST
SST
SST
SST
MW
MW
MW
MW
MW
SST
SST
MW
SST
MW
SST
MW
MW
MW
MW
SST
MW
SST
MW
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

C
C
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
Z
N
N
N
N
N
Z
Z
Z
N
N
N
Z
N
N
N
N
Z
N
Z
N
N
N
Z
Z
GI
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 27

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.148
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156

3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.76
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96

70237
70237S
70220
70220S
70239
70239S
70221
70221S
70240
70240S
70223
70223S
70242
70242S
70224
70224S
70243
70243S
HH-70
HH-57
V-18
904
J-86
KK-7
H-18
B-46
3721
FF-37
U-16
EE-95
S-1038
B8-6
J-82
Q-11
U-90
N-5
S-301
LL-38
Y-67
2815
B4-6
S-1095
10111
N-28
O-37
EE-1
BB-73
O-104
B12-34
B3-37
H-97
MM-25
G-31
W-76
B12-29
B17-135
M-72
B15-11
B11-50
B15-37
B18-138
3726
2942
3729
2806
S-497
A10-42
B18-128
U-92
CC-18
GG-16
S-703
N-33
S-110
905
11261
B8-15
N-34
S-3205
U-88

1.00
1.00
1.13
1.13
1.13
1.13
1.25
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.50
1.50
1.50
1.50
.19
.25
.25
.25
.25
.28
.28
.28
.31
.31
.31
.31
.31
.31
.31
.31
.31
.34
.34
.34
.34
.34
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.44
.44
.44
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.56

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

25.4
25.4
28.7
28.7
28.7
28.7
31.8
31.8
31.8
31.8
35.1
35.1
35.1
35.1
38.1
38.1
38.1
38.1
4.8
6.4
6.4
6.4
6.4
7.1
7.1
7.1
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
8.7
8.7
8.7
8.7
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
11.1
11.1
11.1
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
14.3

I.D.
Inches

.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.106
.106
.102
.102
.116
.132
.126
.116
.106
.136
.106
.104
.142
.126
.126
.124
.120
.118
.114
.106
.090
.140
.140
.118
.118
.086
.114
.126
.124
.120
.116
.116
.116
.114
.112
.110
.106
.102
.100
.096
.080
.140
.138
.122
.116
.112
.136
.124
.116
.130
.124
.144
.138
.136
.128
.124
.116
.112
.104
.102
.096
.092
.112
.108
.078
.132

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.7
2.7
2.6
2.6
2.9
3.4
3.2
2.9
2.7
3.5
2.7
2.6
3.6
3.2
3.2
3.1
3.0
3.0
2.9
2.7
2.3
3.6
3.6
3.0
3.0
2.2
2.9
3.2
3.1
3.0
2.9
2.9
2.9
2.9
2.8
2.8
2.7
2.6
2.5
2.4
2.0
3.6
3.5
3.1
2.9
2.8
3.5
3.1
2.9
3.3
3.1
3.7
3.5
3.5
3.3
3.1
2.9
2.8
2.6
2.6
2.4
2.3
2.8
2.7
2.0
3.4

Lbs./In.

11
9.3
6.8
5.9
9.8
8.5
5.9
5.2
8.5
7.4
5.6
4.9
8.0
7.0
4.9
4.3
7.1
6.2
46
2.5
7.5
30
83
1.3
62
88
.09
3.7
5.2
8.6
17
12
17
62
153
.15
.14
13
12
244
21
2.1
7.6
7.2
18
9.4
7.1
23
22
31
45
59
94
84
365
.23
.30
6.4
11
28
1.2
4.3
18
2.2
5.5
.06
.31
1.3
1.2
3.8
9.4
14
33
52
97
127
13
24
230
1.2

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

1.9
1.6
1.2
1.0
1.7
1.5
1.0
.90
1.5
1.3
.98
.85
1.4
1.2
.87
.75
1.2
1.1
8.0
.43
1.3
5.3
15
.23
11
15
.01
.65
.91
1.5
2.9
2.1
2.9
11
27
.03
.03
2.2
2.1
43
3.6
.36
1.3
1.3
3.2
1.6
1.2
4.0
3.8
5.4
8.0
10
16
15
64
.04
.05
1.1
2.0
4.9
.20
.75
3.2
.38
.96
.01
.05
.22
.21
.67
1.6
2.5
5.8
9.0
17
22
2.2
4.3
40
.22

.44
.34
.53
.41
.48
.37
.61
.47
.55
.42
.65
.49
.59
.45
.73
.56
.66
.51
.07
.17
.11
.10
.06
.20
.09
.05
.21
.16
.19
.18
.09
.16
.12
.09
.05
.24
.23
.14
.17
.05
.17
.17
.20
.20
.16
.15
.11
.15
.18
.14
.12
.11
.08
.07
.03
.32
.29
.24
.21
.14
.37
.26
.16
.30
.28
.43
.40
.22
.23
.31
.21
.18
.18
.09
.09
.06
.25
.21
.05
.43

11
8.5
14
10
12
9.3
15
12
14
11
16
13
15
11
19
14
17
13
1.7
4.4
2.9
2.5
1.6
5.2
2.2
1.2
5.2
4.1
4.9
4.6
2.2
4.1
3.1
2.2
1.2
6.0
5.9
3.4
4.4
1.4
4.2
4.2
5.2
5.0
4.2
3.7
2.7
3.9
4.7
3.7
3.0
2.9
2.0
1.8
.84
8.1
7.3
6.0
5.2
3.6
9.3
6.7
4.2
7.5
7.2
11
10
5.5
5.9
7.8
5.4
4.7
4.6
2.2
2.4
1.5
6.2
5.3
1.3
11

ENDS: C - Closed

G - Ground
O - Open

Lbs.

4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.6
2.4
4.7
3.1
3.0
.43
.85
3.0
5.4
.27
5.4
4.0
.02
.60
1.0
1.6
1.5
1.9
2.1
5.4
7.3
.04
.03
1.7
2.1
13
3.4
.34
1.6
1.4
3.0
1.4
.74
3.4
3.9
4.5
5.4
6.7
7.5
6.1
12
.07
.09
1.5
2.4
3.9
.42
1.1
3.0
.64
1.6
.03
.12
.27
.28
1.2
2.0
2.6
6.0
4.5
9.1
7.3
3.1
5.1
12
.54

21
14
16
11
21
14
16
11
21
14
16
11
21
14
16
11
21
14
13
1.9
3.8
13
24
1.2
24
18
.08
2.7
4.4
6.9
6.5
8.6
9.2
24
33
.16
.15
7.6
9.3
59
15
1.5
6.9
6.2
13
6.0
3.3
15
18
20
24
30
33
27
54
.32
.38
6.7
10
18
1.9
5.0
13
2.8
6.9
.12
.55
1.2
1.3
5.2
8.8
12
27
20
40
32
14
23
54
2.4

Inches

.49
.49
.47
.47
.53
.53
.53
.53
.60
.60
.55
.55
.64
.64
.62
.62
.71
.71
.10
.08
.09
.12
.13
.06
.15
.16
.11
.15
.12
.11
.11
.15
.19
.18
.26
.11
.11
.15
.17
.25
.18
.21
.12
.18
.16
.23
.27
.17
.19
.17
.19
.22
.21
.27
.27
.09
.12
.17
.20
.18
.07
.18
.16
.12
.15
.07
.10
.06
.27
.19
.23
.25
.29
.283
.27
.27
.29
.25
.39
.13

mm

Inches

12.4
12.4
11.8
11.8
13.4
13.4
13.3
13.3
15.3
15.3
14.1
14.1
16.2
16.2
15.8
15.8
18.1
18.1
2.5
2.0
2.3
3.0
3.2
1.5
3.8
4.0
2.7
3.8
3.0
2.8
2.7
3.9
4.8
4.4
6.7
2.7
2.8
3.9
4.3
6.2
4.5
5.3
3.0
4.6
4.1
5.8
6.9
4.3
4.7
4.4
4.8
5.5
5.3
6.9
6.8
2.2
3.0
4.3
5.1
4.5
1.8
4.5
4.1
3.1
3.8
1.7
2.6
1.6
6.8
4.9
5.8
6.4
7.3
7.2
6.9
6.9
7.3
6.4
9.9
3.4

0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.021
0.021
0.023
0.023
0.020
0.012
0.015
0.020
0.025
0.010
0.025
0.026
0.007
0.015
0.015
0.016
0.018
0.019
0.021
0.025
0.033
0.008
0.008
0.019
0.019
0.035
0.021
0.015
0.016
0.018
0.020
0.020
0.020
0.021
0.022
0.023
0.025
0.027
0.028
0.030
0.038
0.008
0.009
0.017
0.020
0.022
0.010
0.016
0.020
0.013
0.016
0.006
0.009
0.010
0.014
0.016
0.020
0.022
0.026
0.028
0.030
0.032
0.022
0.024
0.039
0.012

mm

TOTAL
MATL
COILS

0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.5
0.6
0.6
0.5
0.3
0.4
0.5
0.6
0.3
0.6
0.7
0.2
0.4
0.4
0.4
0.5
0.5
0.5
0.6
0.8
0.2
0.2
0.5
0.5
0.9
0.5
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.7
0.7
0.8
1.0
0.2
0.2
0.4
0.5
0.6
0.3
0.4
0.5
0.3
0.4
0.2
0.2
0.3
0.4
0.4
0.5
0.6
0.7
0.7
0.8
0.8
0.6
0.6
1.0
0.3

21.3
21.3
22.1
22.1
23.0
23.0
25.0
25.0
26.1
26.1
26.4
26.4
27.8
27.8
29.6
29.6
31.0
31.0
4.00
5.50
5.00
5.00
5.00
5.00
6.00
5.00
14.3
9.00
7.00
6.00
5.00
8.00
8.00
6.00
8.00
12.5
13.0
7.00
8.00
7.00
7.50
13.0
6.50
10.0
7.00
10.5
13.5
7.00
8.50
7.50
7.50
8.00
6.50
8.00
7.00
10.0
12.0
9.00
10.0
7.00
6.00
10.0
7.00
8.50
8.25
10.0
10.5
5.25
18.0
11.0
10.5
10.5
11.0
9.1
8.00
7.50
13.0
10.5
10.0
10.0

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
MW
SST
MW
SST
MW
MW
MW
MW
SST
MW
SST
MW
MW
SST
SST
SST
MW
MW
MW
SST
MW
MW
MW
SST
SST
MW
MW
MW
MW
MW
MW
SST
SPR
MW
MW
MW
MW
MW
MW
MW
MW
HD
MW
SST
SST
SST
MW
MW
SST
SST
MW
SST
MW
SST
MW
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
C
CG
C
C
C
C
C
C
CG
C
C
CG
C
C
C
C
CG
C
C
C
CG
C
C
CG
C
CG
CG
CG
CG
C
C
CG
C
C
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
CG
CG
CG
C

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
Z
N
N
Z
Z
N
N
N
N
Z
Z
N
N
N
N
Z
N
N
Z
Z
N
N
N
N
GI
N
GI
N
N
N
N
N
N
N
N
N
GI
Z
Z
Z
Z
N
N
N
Z
N
N
N
Z
N
Z
N
N
GI
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

27

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 28

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156
0.156

3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96
3.96

2916
906
3923
3982
10074
A15-42
L-75
11112
EE-51
NN-66
392
11404
GG-52
10016
GG-45
S-704
S-859
S-1101
M-121
B2-32
U-17
WW-23
LL-82
CC-90
S-1179
H-57
LL-11
W-34
1837
2505
PP-30
JJ-84
II-50
S-705
KK-37
V-25
B7-6
10313
B15-67
CC-25
II-45
2658
OO-83
3777
V-31
1619
S-706
OO-17
Y-48
B15-20
S-1165
393
356-A
355-A
S-1025
PP-7
157-A
TT-27
158-A
2938
A9-36
PP-18
3823
S-1318
907
B9-47
JJ-48
356-B
355-B
157-B
N-86
158-B
OO-50
10612
O-153
S-1235
A10-15
EE-66
356-C
355-C

.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.66
.67
.69
.69
.69
.69
.69
.69
.69
.72
.75
.75
.75
.75
.75
.75
.75
.81
.81
.81
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.06
1.06
1.25
1.25
1.25
1.25
1.25
1.34
1.38
1.38
1.38
1.38
1.38
1.50
1.53
1.56
1.56
1.63
1.75
1.75
1.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
17.1
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
27.0
27.0
31.8
31.8
31.8
31.8
31.8
34.1
34.9
34.9
34.9
34.9
34.9
38.1
38.9
39.7
39.7
41.3
44.5
44.5
44.5

MATERIAL: MW - Music Wire

28

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.116
.110
.106
.106
.104
.102
.082
.128
.116
.110
.134
.130
.126
.116
.116
.112
.112
.108
.118
.136
.126
.124
.118
.116
.116
.112
.096
.118
.140
.136
.136
.124
.120
.112
.110
.116
.116
.100
.132
.132
.132
.130
.126
.124
.118
.112
.112
.096
.106
.102
.096
.134
.130
.128
.128
.128
.124
.124
.100
.136
.126
.116
.110
.094
.086
.084
.118
.130
.128
.124
.122
.100
.116
.086
.116
.112
.126
.136
.130
.128

RATE
mm

2.9
2.8
2.7
2.7
2.6
2.6
2.1
3.3
2.9
2.8
3.4
3.3
3.2
2.9
2.9
2.8
2.8
2.7
3.0
3.5
3.2
3.1
3.0
2.9
2.9
2.8
2.4
3.0
3.6
3.5
3.5
3.1
3.0
2.8
2.8
2.9
2.9
2.5
3.4
3.4
3.4
3.3
3.2
3.1
3.0
2.8
2.8
2.4
2.7
2.6
2.4
3.4
3.3
3.3
3.3
3.3
3.1
3.1
2.5
3.5
3.2
2.9
2.8
2.4
2.2
2.1
3.0
3.3
3.3
3.1
3.1
2.5
2.9
2.2
2.9
2.8
3.2
3.5
3.3
3.3

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

11
1.9
19
3.3
26
4.5
25
4.4
36
6.3
47
8.3
178
31
2.5
.44
11
2.0
14
2.5
1.2
.21
2.3
.41
1.7
.30
15
2.7
18
3.2
11
2.0
9.7
1.7
16
2.7
5.2
.91
.39
.07
1.9
.33
1.9
.34
7.9
1.4
6.1
1.1
11
1.9
11
1.9
40
7.0
3.8
.67
.17
.03
.36
.06
.31
.05
2.5
.43
3.6
.63
9.2
1.6
17
3.0
4.8
.84
5.0
.88
26
4.6
.59
.10
.74
.13
.21
.04
.83
.14
1.6
.28
2.2
.39
3.4
.60
12
2.0
7.7
1.4
45
7.8
21
3.6
27
4.8
25
4.4
.73
.13
1.2
.22
1.6
.28
.99
.17
1.2
.21
2.5
.45
1.4
.24
23
4.0
.26
.04
1.4
.24
3.8
.67
10
1.8
21
3.7
68
12
53
9.2
2.9
.51
.89
.16
1.2
.20
1.8
.32
1.6
.29
16
2.9
4.0
.70
43
7.6
2.4
.42
3.2
.56
1.0
.18
.12
.02
.70
.12
.90
.16

.28
.24
.14
.22
.17
.14
.06
.29
.26
.21
.47
.40
.36
.20
.16
.23
.27
.22
.33
.52
.45
.39
.22
.33
.19
.36
.15
.37
.65
.59
.57
.48
.43
.29
.26
.39
.39
.28
.60
.68
.34
.62
.59
.58
.47
.34
.34
.20
.26
.25
.24
.78
.74
.72
.72
.73
.61
.55
.32
.85
.63
.71
.45
.32
.20
.20
.81
1.0
1.0
.85
.86
.46
.75
.22
.74
.66
1.2
1.3
1.3
1.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

7.2
6.0
3.6
5.5
4.2
3.6
1.6
7.4
6.6
5.4
12
10
9.0
5.0
4.2
5.9
6.8
5.5
8.5
13
12
9.9
5.5
8.3
4.8
9.1
3.9
9.3
16
15
14
12
11
7.3
6.7
10
9.8
7.2
15
17
8.5
16
15
15
12
8.6
8.6
5.1
6.6
6.2
6.1
20
19
18
18
19
16
14
8.2
22
16
18
11
8.0
5.0
5.0
21
26
26
22
22
12
19
5.6
19
17
31
34
34
33

Lbs.

3.0
4.5
3.6
5.4
6.0
6.7
11
.74
3.0
3.0
.57
.93
.61
3.0
3.0
2.6
2.6
3.4
1.7
.20
.85
.75
1.7
2.0
2.0
3.8
6.1
1.4
.11
.21
.18
1.2
1.5
2.6
4.5
1.9
1.9
7.5
.35
.50
.07
.51
.96
1.3
1.6
3.9
2.6
9.1
5.4
6.7
6.1
.57
.93
1.2
.71
.88
1.6
.76
7.5
.22
.85
2.7
4.5
6.7
13
10
2.4
.93
1.2
1.6
1.4
7.5
3.0
9.6
1.8
2.1
1.3
.16
.93
1.2

ENDS: C - Closed

G - Ground
O - Open

13
20
16
24
27
30
50
3.3
13
13
2.5
4.1
2.7
13
13
12
12
15
7.7
.89
3.8
3.3
7.6
8.8
8.8
17
27
6.3
.47
.93
.78
5.2
6.8
12
20
8.4
8.6
33
1.6
2.2
.31
2.3
4.3
5.7
7.1
18
12
40
24
30
27
2.5
4.1
5.1
3.2
3.9
6.9
3.4
33
.97
3.8
12
20
30
59
46
11
4.1
5.1
6.9
6.3
33
13
43
7.9
9.4
5.6
.72
4.1
5.1

Inches

.23
.28
.26
.33
.27
.26
.44
.14
.22
.31
.10
.12
.27
.18
.16
.30
.34
.32
.32
.15
.23
.30
.21
.30
.21
.33
.48
.35
.10
.16
.18
.27
.32
.36
.30
.42
.43
.50
.24
.20
.54
.26
.29
.30
.41
.33
.41
.48
.38
.41
.66
.14
.19
.21
.28
.27
.26
.45
.60
.21
.30
.54
.46
.93
.74
1.03
.53
.24
.28
.35
.51
.81
.50
1.09
.82
.90
.42
.41
.30
.34

mm

5.9
7.0
6.7
8.3
6.8
6.5
11.3
3.5
5.6
7.9
2.4
3.0
6.9
4.6
4.1
7.7
8.7
8.2
8.2
3.8
5.7
7.5
5.3
7.6
5.3
8.4
12.2
8.9
2.6
4.1
4.6
6.9
8.2
9.1
7.6
10.7
10.8
12.8
6.1
5.0
13.7
6.6
7.2
7.5
10.4
8.4
10.5
12.2
9.5
10.3
16.8
3.5
4.7
5.3
7.1
6.8
6.7
11.4
15.1
5.3
7.6
13.7
11.7
23.6
18.7
26.1
13.5
6.2
7.0
8.8
13.1
20.4
12.7
27.6
20.8
22.9
10.7
10.4
7.6
8.7

WIRE DIA.
Inches

0.020
0.023
0.025
0.025
0.026
0.027
0.037
0.014
0.020
0.023
0.011
0.013
0.015
0.020
0.020
0.022
0.022
0.024
0.019
0.010
0.015
0.016
0.019
0.020
0.020
0.022
0.030
0.019
0.008
0.010
0.010
0.016
0.018
0.022
0.023
0.020
0.020
0.028
0.012
0.012
0.012
0.013
0.015
0.016
0.019
0.022
0.022
0.030
0.025
0.027
0.030
0.011
0.013
0.014
0.014
0.014
0.016
0.016
0.028
0.010
0.015
0.020
0.023
0.031
0.035
0.036
0.019
0.013
0.014
0.016
0.017
0.028
0.020
0.035
0.020
0.022
0.015
0.010
0.013
0.014

mm

TOTAL
MATL
COILS

0.5
0.6
0.6
0.6
0.7
0.7
0.9
0.4
0.5
0.6
0.3
0.3
0.4
0.5
0.5
0.6
0.6
0.6
0.5
0.3
0.4
0.4
0.5
0.5
0.5
0.6
0.8
0.5
0.2
0.3
0.3
0.4
0.5
0.6
0.6
0.5
0.5
0.7
0.3
0.3
0.3
0.3
0.4
0.4
0.5
0.6
0.6
0.8
0.6
0.7
0.8
0.3
0.3
0.4
0.4
0.4
0.4
0.4
0.7
0.3
0.4
0.5
0.6
0.8
0.9
0.9
0.5
0.3
0.4
0.4
0.4
0.7
0.5
0.9
0.5
0.6
0.4
0.3
0.3
0.4

10.6
11.0
10.5
12.0
10.3
9.50
11.0
8.75
10.0
12.5
7.75
8.00
17.0
8.00
7.00
12.8
14.5
13.5
16.0
14.0
14.0
17.5
10.0
15.0
9.50
15.0
15.0
18.5
13.0
15.0
17.0
16.0
18.0
15.3
12.0
21.0
20.3
18.0
19.0
15.5
44.0
19.0
18.0
17.5
20.5
14.0
17.8
15.0
14.0
15.0
22.0
11.5
13.3
14.0
19.0
18.0
15.5
27.0
20.3
20.0
19.0
26.0
19.0
30.0
20.0
28.5
27.0
17.8
18.8
20.8
29.3
27.8
25.0
30.0
40.0
40.0
27.0
40.0
22.0
23.5

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
SST
MW
MW
MW
SPR
SST
MW
SST
MW
MW
MW
MW
MW
SST
SST
SST
MW
MW
SST
SST
SST
SST
SST
MW
SST
SST
MW
MW
MW
MW
MW
SST
MW
MW
MW
MW
MW
MW
SST
MW
MW
MW
SST
MW
SST
MW
MW
MW
SST
MW
MW
MW
SST
MW
MW
MW
MW
MW
SST
MW
MW
SST
MW
SPR
MW
MW
MW
MW
MW
MW
MW
SPR
MW
SST
MW
MW
MW
MW

E
N
D
S

F
N
S
H

C
C
CG
C
CG
CG
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
C
CG
C
CG
C
CG
C
C
C
C
CG
C
C
CG
C
CG
C
C
C
C
C
C
C
C
C
C
C
CG
CG
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
CG
C
C
C
C
C
C
CG
C
C
C
C
C
C
C

Z
Z
N
Z
Z
GI
N
N
Z
N
Z
Z
N
Z
N
N
N
N
BO
N
N
N
N
N
N
N
N
N
N
Z
N
GI
Z
N
GI
Z
Z
GI
N
Z
N
GI
N
Z
N
Z
N
N
N
Z
N
Z
Z
Z
N
N
Z
N
Z
Z
N
N
GI
N
Z
Z
N
Z
Z
Z
Z
Z
N
Z
Z
N
Z
N
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 29

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.156
0.156
0.156
0.156
0.156
0.156
0.158
0.168
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172

3.96
3.96
3.96
3.96
3.96
3.96
4.01
4.27
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37

157-C
O-114
158-C
1575
10851
A10-63
10242
12749
S-1093
L-80
M-31
BB-45
KK-23
B5-8
CC-37
B-17
J-43
AA-77
NN-82
Y-92
W-1
A9-24
OO-38
A14-10
S-1202
A11-22
A15-19
B18-127
10768
N-301
GG-37
12654
OO-30
JJ-41
JJ-50
O-71
AA-3
DD-2
J-95
NN-18
NN-63
B5-21
B-56
EE-85
J-3
12642
S-1463
I-6
3795
JJ-66
B5-5
NN-23
FF-74
M-1
OO-65
U-57
V-47
A14-2
AA-45
TT-7
12528
A12-19
LL-45
O-120
12485
HH-24
KK-19
A-9
DD-25
PP-83
GG-40
KK-25
B4-29
10130
H-75
W-85
AA-22
Q-99
II-44
A14-26

1.75
1.75
1.75
2.88
3.31
3.75
.75
.47
.19
.19
.19
.22
.25
.25
.25
.25
.25
.25
.28
.28
.28
.31
.31
.31
.31
.31
.34
.34
.34
.34
.34
.34
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.41
.41
.42
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.45
.45
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

44.5
44.5
44.5
73.0
84.1
95.3
19.1
11.9
4.8
4.8
4.8
5.6
6.4
6.4
6.4
6.4
6.4
6.4
7.1
7.1
7.1
7.9
7.9
7.9
7.9
7.9
8.7
8.7
8.7
8.7
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.7
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.5
11.5
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5

I.D.
Inches

.124
.102
.100
.126
.110
.110
.116
.120
.152
.140
.114
.136
.144
.140
.132
.116
.116
.112
.156
.136
.108
.148
.148
.140
.128
.126
.140
.136
.122
.120
.102
.142
.148
.138
.132
.132
.122
.108
.142
.142
.126
.120
.116
.112
.096
.112
.160
.152
.144
.136
.136
.134
.132
.132
.132
.132
.132
.122
.118
.112
.124
.122
.146
.136
.122
.112
.152
.148
.144
.142
.140
.136
.134
.128
.122
.120
.112
.108
.102
.118

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

3.1
2.6
2.5
3.2
2.8
2.8
2.9
3.0
3.9
3.6
2.9
3.5
3.7
3.6
3.4
2.9
2.9
2.8
4.0
3.5
2.7
3.8
3.8
3.6
3.3
3.2
3.6
3.5
3.1
3.0
2.6
3.6
3.8
3.5
3.4
3.4
3.1
2.7
3.6
3.6
3.2
3.0
2.9
2.8
2.4
2.8
4.1
3.9
3.7
3.5
3.5
3.4
3.4
3.4
3.4
3.4
3.4
3.1
3.0
2.8
3.1
3.1
3.7
3.5
3.1
2.8
3.9
3.8
3.7
3.6
3.6
3.5
3.4
3.3
3.1
3.0
2.8
2.7
2.6
3.0

Lbs./In.

1.4
9.8
13
.25
3.7
3.3
14
21
1.2
8.3
103
13
5.6
9.9
16
64
118
136
.24
12
136
3.6
1.5
8.3
17
32
6.2
6.9
51
62
122
4.7
1.1
6.4
15
13
44
96
2.4
2.5
20
42
66
74
208
59
.06
.16
2.0
3.4
7.2
11
9.4
8.2
14
11
4.8
26
44
68
16
22
1.0
14
20
51
.30
.67
3.0
3.1
3.1
5.9
10
11
31
20
54
55
112
31

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.25
1.7
2.2
.04
.64
.57
2.4
3.7
.21
1.4
18
2.3
.98
1.7
2.8
11
21
24
.04
2.1
24
.64
.25
1.4
3.0
5.7
1.1
1.2
8.8
11
21
.82
.18
1.1
2.5
2.3
7.7
17
.41
.44
3.5
7.4
11
13
36
10
.01
.03
.35
.60
1.3
2.0
1.6
1.4
2.5
2.0
.85
4.6
7.6
12
2.9
3.9
.18
2.4
3.4
8.9
.05
.12
.53
.55
.54
1.0
1.8
1.9
5.4
3.5
9.5
9.6
20
5.5

1.1
.46
.59
1.3
.82
.92
.25
.22
.13
.09
.04
.10
.17
.14
.11
.05
.06
.06
.21
.16
.05
.18
.23
.17
.14
.13
.23
.22
.10
.06
.06
.24
.27
.24
.13
.21
.11
.07
.24
.26
.20
.13
.07
.11
.05
.09
.38
.20
.31
.21
.28
.14
.24
.22
.19
.16
.14
.13
.09
.12
.17
.18
.32
.15
.17
.16
.37
.35
.22
.37
.31
.34
.22
.26
.11
.19
.15
.12
.08
.20

mm

28
12
15
33
21
23
6.4
5.5
3.4
2.3
1.1
2.5
4.4
3.6
2.8
1.4
1.5
1.6
5.4
4.2
1.3
4.7
5.8
4.4
3.5
3.2
5.8
5.5
2.5
1.5
1.6
6.1
6.8
6.1
3.2
5.3
2.8
1.8
6.1
6.7
5.1
3.3
1.8
2.9
1.4
2.4
9.8
5.0
7.9
5.4
7.1
3.5
6.0
5.5
4.9
4.1
3.5
3.2
2.4
3.1
4.2
4.5
8.1
3.7
4.3
4.2
9.4
8.9
5.6
9.3
7.8
8.6
5.7
6.6
2.7
4.8
3.9
2.9
2.0
5.0

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.6
4.5
7.5
.32
3.0
3.0
3.4
4.6
.16
.76
4.4
1.3
.97
1.4
1.8
3.5
6.9
8.4
.05
1.9
6.7
.67
.33
1.4
2.4
4.1
1.4
1.5
4.9
3.7
7.7
1.1
.28
1.5
1.8
2.7
4.9
6.7
.57
.66
4.0
5.5
4.6
8.4
11
5.6
.02
.03
.62
.73
2.0
1.6
2.2
1.8
2.7
1.8
.67
3.3
4.1
8.4
2.7
3.9
.33
2.0
3.3
8.4
.11
.23
.67
1.1
.94
2.0
2.4
2.9
3.3
3.7
8.4
6.4
8.9
6.2

6.9
20
33
1.4
13
13
15
21
.70
3.4
19
5.9
4.3
6.3
8.1
15
30
37
.23
8.6
30
3.0
1.5
6.3
10
18
6.3
6.6
22
16
34
5.0
1.3
6.9
8.1
12
22
30
2.5
2.9
18
25
20
37
50
25
.10
.14
2.8
3.2
8.9
7.0
9.9
7.9
12
8.1
3.0
15
18
37
12
17
1.5
8.9
15
37
.49
1.0
3.0
5.1
4.2
8.9
10
13
15
16
37
28
40
27

Inches

.43
.93
1.02
1.59
1.02
1.14
.23
.25
.06
.10
.15
.09
.08
.07
.13
.20
.15
.18
.07
.12
.18
.06
.08
.08
.18
.13
.11
.13
.16
.16
.28
.11
.11
.14
.14
.16
.18
.22
.17
.14
.21
.21
.20
.26
.30
.24
.05
.24
.13
.23
.16
.13
.20
.22
.22
.16
.30
.20
.22
.27
.29
.28
.15
.11
.30
.30
.13
.15
.10
.14
.16
.16
.15
.24
.20
.30
.29
.38
.33
.27

mm

Inches

11.0
23.7
25.8
40.4
26.0
28.9
5.9
6.4
1.4
2.4
3.7
2.2
2.0
1.8
3.3
5.0
3.9
4.6
1.7
3.0
4.5
1.5
2.1
2.0
4.5
3.4
2.8
3.2
4.1
4.0
7.1
2.7
2.7
3.5
3.6
4.1
4.4
5.7
4.2
3.6
5.3
5.3
5.0
6.5
7.7
6.1
1.4
6.1
3.2
5.7
4.0
3.4
5.1
5.6
5.6
4.1
7.6
5.1
5.5
6.9
7.3
7.0
3.8
2.7
7.6
7.6
3.3
3.8
2.5
3.4
4.1
4.1
3.9
6.1
5.1
7.6
7.2
9.8
8.4
6.9

0.016
0.027
0.028
0.015
0.023
0.023
0.021
0.024
0.010
0.016
0.029
0.018
0.014
0.016
0.020
0.028
0.028
0.030
0.008
0.018
0.032
0.012
0.012
0.016
0.022
0.023
0.016
0.018
0.025
0.026
0.035
0.015
0.012
0.017
0.020
0.020
0.025
0.032
0.015
0.015
0.023
0.026
0.028
0.030
0.038
0.030
0.006
0.010
0.014
0.018
0.018
0.019
0.020
0.020
0.020
0.020
0.020
0.025
0.027
0.030
0.024
0.025
0.013
0.018
0.025
0.030
0.010
0.012
0.014
0.015
0.016
0.018
0.019
0.022
0.025
0.026
0.030
0.032
0.035
0.027

mm

0.4
0.7
0.7
0.4
0.6
0.6
0.5
0.6
0.3
0.4
0.7
0.5
0.4
0.4
0.5
0.7
0.7
0.8
0.2
0.5
0.8
0.3
0.3
0.4
0.6
0.6
0.4
0.5
0.6
0.7
0.9
0.4
0.3
0.4
0.5
0.5
0.6
0.8
0.4
0.4
0.6
0.7
0.7
0.8
1.0
0.8
0.2
0.3
0.4
0.5
0.5
0.5
0.5
0.5
0.5
0.5
0.5
0.6
0.7
0.8
0.6
0.6
0.3
0.5
0.6
0.8
0.3
0.3
0.4
0.4
0.4
0.5
0.5
0.6
0.6
0.7
0.8
0.8
0.9
0.7

TOTAL
MATL
COILS
26.0
33.5
35.3
105.0
43.5
48.5
10.0
9.50
4.50
5.00
5.00
4.75
4.50
4.50
5.50
6.00
4.50
5.00
7.50
5.50
5.50
4.00
7.00
5.00
7.00
5.75
6.00
6.00
5.50
5.00
8.00
6.00
8.00
7.00
6.00
7.00
6.00
7.00
10.0
9.50
8.00
7.00
6.00
7.50
8.00
8.00
8.00
23.0
9.00
12.5
7.75
6.00
9.00
10.0
9.00
7.00
14.0
8.00
7.00
8.00
11.0
10.0
10.5
5.00
11.0
10.0
12.0
11.5
6.00
8.00
9.00
9.00
7.00
11.0
7.00
11.5
9.50
12.0
9.50
10.0

MW
SST
MW
MW
SST
SST
MW
MW
SST
MW
SST
SST
MW
MW
SST
SST
MW
MW
MW
MW
SST
MW
MW
MW
SST
MW
MW
MW
MW
SST
SST
MW
SST
MW
SST
MW
MW
SST
MW
MW
MW
MW
SST
MW
SPR
SST
SST
MW
MW
SST
MW
SST
MW
MW
MW
SST
SST
SST
SST
MW
MW
MW
SST
MW
MW
MW
SST
SST
SST
MW
SST
MW
MW
MW
SST
SST
MW
MW
SPR
MW

E
N
D
S

F
N
S
H

C
C
C
C
C
C
C
C
C
C
CG
CG
C
CG
C
C
C
C
C
C
CG
C
CG
CG
C
CG
C
O
C
C
CG
C
C
C
C
C
C
CG
C
CG
C
C
C
C
CG
CG
C
C
CG
CG
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
CG
C
C
C
C
C
CG
C
CG
C
CG
CG
CG
CG
CG

Z
N
Z
Z
N
N
Z
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
GI
N
N
N
N
N
N
N
Z
N
Z
Z
N
Z
N
N
N
N
N
Z
N
N
BO
Z
N
N
N
Z
Z
Z
N
N
N
N
Z
N
N
N
Z
N
Z
N
N
N
Z
N
N
BO
BO
N
N
Z
N
N
GI

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

29

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 30

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172

4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37

A14-24
S-332
CC-41
DD-19
B-8
K-75
F-17
S-142
S-900
10265
B15-47
U-96
FF-39
S-487
W-67
L-28
A14-18
S-835
J-44
AA-65
A15-17
2520
N-109
B5-4
S-220
DD-58
FF-38
S-1227
BB-33
11364
FF-17
L-93
B7-48
B-13
PP-22
PP-26
WW-31
S-1069
11457
O-110
3582
MM-21
KK-15
A12-26
B-75
J-93
AA-29
A15-11
B10-38
W-36
G-56
1829
B-59
G-38
10186
V-56
S-1693
OO-42
Z-79
J-9
OO-81
S-1077
S-1346
A12-28
B2-36
10635
GG-31
A15-12
JJ-31
B2-2
B2-54
2874
Y-54
S-6
B11-47
10970
L-25
K-17
10764
12515

.53
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.69
.69
.69
.69
.72
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.81
.84
.88
.88
.88
.88
.88
.88
.89
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.06
1.09
1.09
1.13
1.13
1.13
1.16
1.16
1.16
1.22
1.25
1.25
1.25
1.25

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

13.5
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
18.2
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
20.6
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.6
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
27.0
27.8
27.8
28.6
28.6
28.6
29.4
29.4
29.4
31.0
31.8
31.8
31.8
31.8

MATERIAL: MW - Music Wire

30

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.108
.152
.148
.148
.132
.120
.120
.108
.156
.152
.136
.132
.120
.114
.088
.144
.136
.136
.128
.122
.120
.118
.112
.130
.120
.112
.112
.132
.132
.132
.128
.128
.122
.120
.098
.156
.146
.144
.144
.142
.140
.140
.132
.132
.130
.090
.152
.140
.152
.110
.142
.140
.138
.130
.128
.128
.124
.140
.108
.150
.148
.136
.132
.120
.118
.102
.108
.106
.102
.132
.122
.112
.136
.116
.110
.122
.140
.128
.124
.122

RATE
mm

2.7
3.9
3.8
3.8
3.4
3.0
3.0
2.7
4.0
3.9
3.5
3.4
3.0
2.9
2.2
3.7
3.5
3.5
3.3
3.1
3.0
3.0
2.8
3.3
3.0
2.8
2.8
3.4
3.4
3.4
3.3
3.3
3.1
3.0
2.5
4.0
3.7
3.7
3.7
3.6
3.6
3.6
3.4
3.4
3.3
2.3
3.9
3.6
3.9
2.8
3.6
3.6
3.5
3.3
3.3
3.3
3.1
3.6
2.7
3.8
3.8
3.5
3.4
3.0
3.0
2.6
2.7
2.7
2.6
3.4
3.1
2.8
3.5
2.9
2.8
3.1
3.6
3.3
3.1
3.1

Lbs./In.

65
.27
.37
.97
4.6
22
26
48
.13
.56
5.2
8.2
16
30
226
1.2
6.7
2.8
14
14
23
36
37
8.8
14
52
34
3.4
3.8
5.3
11
8.1
17
16
108
.13
.89
.87
1.6
2.4
2.3
1.8
6.7
5.5
8.1
139
.38
3.1
.29
43
1.3
1.8
2.3
4.8
8.3
5.9
9.8
2.1
37
.27
.73
3.6
4.4
13
24
59
27
39
37
4.1
9.3
27
2.1
14
24
9.4
1.7
8.3
6.9
9.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

11
.05
.07
.17
.80
3.9
4.6
8.4
.02
.10
.90
1.4
2.7
5.3
40
.20
1.2
.48
2.5
2.4
4.1
6.3
6.5
1.5
2.5
9.0
6.0
.59
.66
.92
1.9
1.4
3.0
2.8
19
.02
.16
.15
.27
.41
.40
.31
1.2
.96
1.4
24
.07
.54
.05
7.5
.24
.31
.40
.84
1.5
1.0
1.7
.36
6.4
.05
.13
.63
.77
2.3
4.2
10
4.7
6.8
6.6
.72
1.6
4.7
.37
2.5
4.1
1.7
.29
1.5
1.2
1.6

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

.16
.42
.32
.44
.25
.24
.21
.14
.50
.50
.39
.33
.21
.17
.07
.42
.20
.34
.25
.23
.24
.17
.15
.36
.24
.11
.16
.29
.33
.34
.22
.38
.29
.23
.09
.65
.58
.51
.43
.50
.53
.51
.27
.45
.39
.10
.66
.46
.67
.21
.62
.60
.59
.46
.43
.44
.31
.69
.18
.79
.84
.37
.41
.42
.26
.15
.27
.19
.22
.67
.36
.31
.63
.32
.39
.52
.86
.43
.45
.53

mm

3.9
11
8.2
11
6.4
6.0
5.3
3.6
13
13
9.9
8.5
5.3
4.3
1.7
11
5.1
8.6
6.4
5.7
6.0
4.4
3.8
9.1
6.1
2.8
4.1
7.3
8.3
8.7
5.6
9.7
7.3
5.9
2.3
16
15
13
11
13
13
13
6.9
11
9.9
2.5
17
12
17
5.4
16
15
15
12
11
11
8.0
17
4.7
20
21
9.4
11
11
6.6
3.8
6.9
4.8
5.7
17
9.0
7.8
16
8.1
9.8
13
22
11
11
13

Lbs.

10

45

.11
.12
.42
1.1
5.3
5.5
6.7
.07
.28
2.0
2.7
3.3
5.1
15
.48
1.3
.93
3.6
3.1
5.5
6.2
5.6
3.2
3.4
5.6
5.6
.96
1.2
1.8
2.4
3.1
4.9
3.7
9.7
.09
.52
.45
.67
1.2
1.2
.90
1.8
2.5
3.2
14
.25
1.4
.20
9.2
.83
1.1
1.3
2.2
3.6
2.6
3.1
1.4
6.7
.22
.61
1.3
1.8
5.5
6.2
8.9
7.2
7.3
8.3
2.7
3.3
8.4
1.3
4.6
9.2
4.9
1.4
3.6
3.1
4.9

.50
.53
1.9
5.1
23
25
30
.30
1.3
8.9
12
15
23
65
2.2
5.9
4.1
16
14
25
27
25
14
15
25
25
4.3
5.5
8.1
11
14
22
16
43
.38
2.3
2.0
3.0
5.2
5.3
4.0
8.1
11
14
61
1.1
6.3
.87
41
3.7
4.8
6.0
9.7
16
11
14
6.3
30
.96
2.7
5.9
8.1
25
27
40
32
33
37
12
15
37
5.9
20
41
22
6.3
16
14
22

ENDS: C - Closed

G - Ground
O - Open

Inches

.34
.14
.24
.13
.31
.33
.29
.38
.09
.09
.20
.20
.38
.38
.46
.21
.14
.29
.22
.40
.29
.27
.35
.24
.42
.27
.38
.40
.36
.28
.24
.34
.31
.38
.44
.10
.17
.24
.15
.15
.22
.24
.23
.30
.27
.62
.12
.18
.15
.43
.26
.27
.29
.42
.33
.44
.36
.24
.51
.21
.16
.23
.32
.49
.37
.60
.72
.54
.75
.38
.49
.54
.36
.60
.68
.54
.29
.33
.53
.55

mm

8.5
3.6
6.1
3.2
7.9
8.3
7.3
9.8
2.4
2.3
5.0
5.1
9.7
9.6
11.7
5.3
3.4
7.3
5.6
10.2
7.3
6.9
8.8
6.0
10.6
6.9
9.5
10.2
9.1
7.1
6.1
8.5
7.8
9.6
11.3
2.6
4.3
6.0
3.9
3.8
5.7
6.1
5.8
7.6
6.9
15.6
3.0
4.5
3.7
11.0
6.5
6.9
7.3
10.7
8.4
11.2
9.1
6.1
13.0
5.3
4.0
5.9
8.1
12.5
9.3
15.3
18.3
13.8
19.1
9.7
12.4
13.7
9.1
15.1
17.3
13.8
7.3
8.4
13.4
14.0

WIRE DIA.
Inches

0.032
0.010
0.012
0.012
0.020
0.026
0.026
0.032
0.008
0.010
0.018
0.020
0.026
0.029
0.042
0.014
0.018
0.018
0.022
0.025
0.026
0.027
0.030
0.021
0.026
0.030
0.030
0.020
0.020
0.020
0.022
0.022
0.025
0.026
0.037
0.008
0.013
0.014
0.014
0.015
0.016
0.016
0.020
0.020
0.021
0.041
0.010
0.016
0.010
0.031
0.015
0.016
0.017
0.021
0.022
0.022
0.024
0.016
0.032
0.011
0.012
0.018
0.020
0.026
0.027
0.035
0.032
0.033
0.035
0.020
0.025
0.030
0.018
0.028
0.031
0.025
0.016
0.022
0.024
0.025

mm

TOTAL
MATL
COILS

0.8
0.3
0.3
0.3
0.5
0.7
0.7
0.8
0.2
0.3
0.5
0.5
0.7
0.7
1.1
0.4
0.5
0.5
0.6
0.6
0.7
0.7
0.8
0.5
0.7
0.8
0.8
0.5
0.5
0.5
0.6
0.6
0.6
0.7
0.9
0.2
0.3
0.4
0.4
0.4
0.4
0.4
0.5
0.5
0.5
1.0
0.3
0.4
0.3
0.8
0.4
0.4
0.4
0.5
0.6
0.6
0.6
0.4
0.8
0.3
0.3
0.5
0.5
0.7
0.7
0.9
0.8
0.8
0.9
0.5
0.6
0.8
0.5
0.7
0.8
0.6
0.4
0.6
0.6
0.6

10.5
13.0
19.0
9.50
14.5
11.5
10.0
12.0
10.7
8.00
10.0
10.0
13.8
12.0
11.0
14.0
7.50
15.0
9.00
15.0
11.0
9.00
11.5
11.3
15.0
9.00
12.5
19.0
17.0
13.0
10.0
14.3
12.3
13.5
11.0
12.0
12.0
16.0
10.0
10.0
13.0
14.0
10.5
14.0
12.0
15.0
11.0
10.0
13.5
13.0
16.0
16.0
16.0
19.0
14.0
19.0
15.0
14.0
15.0
18.0
12.0
12.0
15.0
18.0
12.5
16.3
22.5
16.5
21.5
18.0
18.5
17.0
19.0
20.3
22.0
20.8
17.0
14.0
21.0
21.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
SST
MW
SST
MW
MW
SST
SST
MW
MW
MW
SST
SST
SPR
MW
SST
SST
MW
MW
MW
MW
SST
MW
SST
SST
SST
SST
SST
SST
SST
MW
MW
SST
SST
MW
SST
SST
SST
MW
MW
MW
SST
MW
MW
SPR
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
SST
MW
SST
SST
MW
SST
SST
MW
MW
SPR
SPR
SST
SST
MW
SST
MW
SST
SST
MW
MW
MW
MW
SST
MW

E
N
D
S

F
N
S
H

CG
C
C
C
C
C
C
CG
C
C
C
CG
C
C
CG
C
CG
C
C
C
CG
C
CG
CG
C
CG
CG
C
C
C
C
C
CG
C
C
C
C
C
C
CG
C
O
C
C
C
CG
C
C
C
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
C
C
CG
CG
CG
CL
C
C
C
C
CG
C
C
C
C
C

GI
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
Z
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
GI
Z
N
Z
Z
N
Z
N
N
N
N
Z
N
Z
Z
N
N
Z
N
N
BO
N
N
N
Z
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 31

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.172
0.175
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180

4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.37
4.45
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57

Q-79
LL-74
10261
10859
Y-61
B15-41
B18-185
Y-64
S-3214
3968
B15-44
FF-48
B3-49
70244
70244S
70259
70259S
70280
70280S
70301
70301S
70322
70322S
70343
70343S
A12-37
70363
70363S
70386
70386S
70407
70407S
B4-67
70245
70245S
70260
70260S
70281
70281S
70302
70302S
70323
70323S
70344
70344S
70364
70364S
70387
70387S
70408
70408S
70426
70426S
70246
70246S
70261
70261S
70282
70282S
70303
70303S
70324
70324S
70345
70345S
70365
70365S
70388
70388S
70409
70409S
70427
70427S
70444
70444S
70247
70247S
70262
70262S
70283

1.38
1.50
1.56
1.75
1.94
2.25
2.50
2.75
2.91
3.00
3.19
3.25
.47
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.30
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.44
.44
.44
.44
.44

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

34.9
38.1
39.7
44.5
49.2
57.2
63.5
69.9
73.8
76.2
81.0
82.6
11.9
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
7.5
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
11.2
11.2
11.2
11.2
11.2

I.D.
Inches

.142
.128
.122
.102
.136
.156
.122
.116
.134
.118
.146
.152
.103
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.136
.132
.132
.128
.128
.122
.122
.152
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156
.152
.152
.148

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

3.6
3.3
3.1
2.6
3.5
4.0
3.1
2.9
3.4
3.0
3.7
3.9
2.6
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
3.9
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8

Lbs./In.

.72
3.1
5.9
39
.92
.07
5.1
4.3
1.1
4.3
.33
.08
98
3.6
3.1
6.0
5.2
9.0
7.6
14
11
21
18
30
25
30
43
37
59
50
95
81
2.8
3.0
2.6
4.8
4.2
7.5
6.4
11
9.5
16
14
24
20
33
28
47
40
74
62
122
104
2.3
2.0
3.9
3.4
6.0
5.1
9.2
7.8
13
11
20
17
26
22
37
32
58
50
96
82
137
116
2.0
1.7
3.2
2.8
5.0

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.13
.54
1.0
6.9
.16
.01
.88
.75
.18
.75
.06
.01
17
.63
.55
1.1
.92
1.6
1.3
2.4
2.0
3.7
3.1
5.2
4.4
5.2
7.6
6.4
10
8.8
17
14
.50
.52
.45
.85
.74
1.3
1.1
2.0
1.7
2.8
2.4
4.2
3.6
5.7
4.9
8.2
7.0
13
11
21
18
.40
.35
.68
.59
1.0
.89
1.6
1.4
2.3
1.9
3.5
3.0
4.6
3.9
6.5
5.5
10
8.7
17
14
24
20
.35
.31
.56
.49
.87

.94
.77
.74
.21
1.2
2.1
.98
.99
1.5
1.3
2.6
2.8
.09
.18
.13
.17
.12
.15
.12
.14
.11
.12
.10
.12
.09
.08
.10
.08
.09
.07
.08
.06
.20
.22
.16
.21
.15
.18
.14
.17
.13
.16
.13
.15
.11
.14
.11
.11
.09
.10
.08
.08
.06
.28
.20
.26
.19
.23
.18
.21
.16
.20
.16
.17
.14
.17
.13
.14
.11
.13
.10
.10
.08
.09
.07
.32
.23
.31
.23
.27

mm

24
20
19
5.4
30
53
25
25
38
34
65
72
2.3
4.5
3.3
4.2
3.1
3.9
3.0
3.6
2.8
3.2
2.5
3.0
2.3
2.0
2.6
2.1
2.3
1.8
1.9
1.5
5.0
5.5
4.0
5.3
3.9
4.6
3.6
4.4
3.4
4.1
3.2
3.7
2.9
3.5
2.7
2.9
2.3
2.5
2.0
2.0
1.6
7.1
5.2
6.6
4.9
5.8
4.5
5.3
4.2
5.1
4.0
4.4
3.5
4.3
3.4
3.6
2.9
3.2
2.5
2.6
2.0
2.2
1.8
8.1
5.9
8.0
5.8
7.0

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.68
2.4
4.3
8.3
1.1
.15
4.9
4.2
1.6
5.7
.85
.24
8.9
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
2.3
4.5
3.0
5.3
3.6
7.3
4.9
.55
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4

3.0
11
19
37
4.8
.69
22
19
7.0
26
3.8
1.1
40
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
10
20
13
24
16
32
22
2.5
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
2.8
1.8
4.5
2.9
6.0

Inches

.44
.68
.83
.74
.76
.17
.93
1.76
.89
1.66
.44
.43
.36
.05
.05
.06
.06
.07
.07
.08
.08
.09
.09
.11
.11
.10
.12
.12
.13
.13
.15
.15
.10
.05
.05
.06
.06
.08
.08
.09
.09
.11
.11
.12
.12
.14
.14
.15
.15
.17
.17
.18
.18
.06
.06
.07
.07
.09
.09
.11
.11
.13
.13
.14
.14
.17
.17
.18
.18
.21
.21
.22
.22
.25
.25
.06
.06
.08
.08
.10

mm

Inches

11.0
17.3
21.0
18.7
19.2
4.3
23.5
44.8
22.7
42.2
11.2
10.9
9.1
1.1
1.1
1.4
1.4
1.8
1.8
2.1
2.1
2.3
2.3
2.7
2.7
2.5
3.0
3.0
3.3
3.3
3.8
3.8
2.6
1.3
1.3
1.6
1.6
2.0
2.0
2.3
2.3
2.8
2.8
3.1
3.1
3.6
3.6
3.9
3.9
4.4
4.4
4.7
4.7
1.4
1.4
1.8
1.8
2.3
2.3
2.7
2.7
3.2
3.2
3.5
3.5
4.2
4.2
4.5
4.5
5.2
5.2
5.6
5.6
6.3
6.3
1.6
1.6
2.1
2.1
2.6

0.015
0.022
0.025
0.035
0.018
0.008
0.025
0.028
0.019
0.027
0.013
0.010
0.036
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.014
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016

mm

TOTAL
MATL
COILS

0.4
0.6
0.6
0.9
0.5
0.2
0.6
0.7
0.5
0.7
0.3
0.3
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.4
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4

28.0
30.0
32.0
21.0
41.0
20.0
37.0
62.0
46.0
60.5
33.0
42.0
10.0
3.75
3.75
4.00
4.00
4.38
4.38
4.63
4.63
4.63
4.63
4.88
4.88
4.50
4.88
4.88
5.00
5.00
5.13
5.13
6.25
4.13
4.13
4.50
4.50
4.88
4.88
5.13
5.13
5.50
5.50
5.63
5.63
5.88
5.88
5.88
5.88
6.00
6.00
5.75
5.75
4.75
4.75
5.13
5.13
5.63
5.63
5.88
5.88
6.38
6.38
6.25
6.25
6.88
6.88
6.88
6.88
7.13
7.13
6.88
6.88
7.13
7.13
5.13
5.13
5.75
5.75
6.38

MW
SST
MW
SST
SST
MW
MW
SST
SST
MW
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

C
C
C
CG
C
C
CG
C
0
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
Z
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

31

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:22 AM Page 32

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180

4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57

70283S
70304
70304S
70325
70325S
70346
70346S
70366
70366S
70389
70389S
70410
70410S
70428
70428S
70445
70445S
70248
70248S
70263
70263S
70284
70284S
70305
70305S
70326
70326S
70347
70347S
70367
70367S
70390
70390S
70411
70411S
70429
70429S
70446
70446S
B2-34
70249
70249S
70264
70264S
70285
70285S
70306
70306S
70327
70327S
70348
70348S
70368
70368S
70391
70391S
70412
70412S
70430
70430S
70447
70447S
70250
70250S
70265
70265S
70286
70286S
70307
70307S
70328
70328S
70349
70349S
70369
70369S
70392
70392S
70413
70413S

.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.55
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.9
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0

MATERIAL: MW - Music Wire

32

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.134
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122

RATE
mm

3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
3.4
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

4.2
7.9
6.7
11
9.4
17
14
22
19
31
26
48
41
79
67
115
97
1.7
1.5
2.8
2.5
4.4
3.7
6.9
5.8
9.5
8.1
14
12
19
16
27
23
42
35
65
55
99
84
13
1.5
1.3
2.5
2.2
3.9
3.3
5.9
5.0
8.4
7.2
12
10
17
14
23
20
37
31
58
50
87
74
1.4
1.2
2.2
2.0
3.5
2.9
5.1
4.3
7.5
6.4
11
8.9
15
13
21
18
32
28

.74
1.4
1.2
1.9
1.6
3.0
2.5
3.8
3.3
5.4
4.6
8.5
7.2
14
12
20
17
.29
.26
.50
.43
.76
.65
1.2
1.0
1.7
1.4
2.5
2.1
3.3
2.8
4.7
4.0
7.3
6.2
11
9.7
17
15
2.3
.26
.23
.43
.38
.67
.57
1.0
.87
1.5
1.3
2.1
1.8
2.9
2.5
4.1
3.5
6.4
5.4
10
8.7
15
13
.24
.21
.39
.34
.60
.51
.88
.75
1.3
1.1
1.8
1.6
2.6
2.2
3.7
3.1
5.7
4.8

.21
.24
.19
.24
.19
.20
.16
.20
.16
.17
.13
.15
.12
.12
.10
.10
.08
.38
.28
.35
.26
.31
.24
.28
.22
.28
.22
.25
.19
.24
.18
.20
.16
.17
.14
.15
.12
.12
.10
.29
.43
.32
.41
.30
.35
.28
.33
.26
.31
.24
.29
.23
.27
.21
.23
.18
.20
.16
.17
.13
.14
.11
.46
.33
.45
.33
.39
.31
.38
.30
.35
.27
.33
.26
.30
.23
.25
.20
.22
.18

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

5.4
6.2
4.8
6.0
4.7
5.2
4.1
5.2
4.1
4.3
3.4
3.8
3.0
3.1
2.5
2.6
2.1
9.7
7.1
9.0
6.6
7.9
6.2
7.1
5.6
7.0
5.5
6.2
4.9
6.0
4.7
5.0
4.0
4.4
3.5
3.8
3.0
3.1
2.4
7.5
11
8.0
10
7.6
9.0
7.0
8.3
6.5
7.9
6.2
7.4
5.8
6.8
5.3
5.8
4.6
5.1
4.0
4.2
3.3
3.5
2.8
12
8.5
11
8.4
10
7.8
9.7
7.6
8.9
7.0
8.4
6.6
7.6
5.9
6.4
5.1
5.7
4.5

Lbs.

.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
3.9
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9

ENDS: C - Closed

G - Ground
O - Open

4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
18
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22

Inches

.10
.12
.12
.14
.14
.15
.15
.19
.19
.20
.20
.24
.24
.25
.25
.28
.28
.07
.07
.09
.09
.11
.11
.13
.13
.16
.16
.18
.18
.21
.21
.22
.22
.26
.26
.29
.29
.32
.32
.22
.08
.08
.10
.10
.12
.12
.15
.15
.17
.17
.20
.20
.23
.23
.25
.25
.29
.29
.32
.32
.35
.35
.08
.08
.10
.10
.13
.13
.16
.16
.19
.19
.22
.22
.25
.25
.28
.28
.32
.32

mm

2.6
3.0
3.0
3.6
3.6
3.9
3.9
4.7
4.7
5.1
5.1
6.0
6.0
6.4
6.4
7.2
7.2
1.8
1.8
2.2
2.2
2.8
2.8
3.3
3.3
4.0
4.0
4.5
4.5
5.3
5.3
5.7
5.7
6.7
6.7
7.4
7.4
8.1
8.1
5.7
1.9
1.9
2.4
2.4
3.0
3.0
3.7
3.7
4.4
4.4
5.1
5.1
5.9
5.9
6.4
6.4
7.5
7.5
8.1
8.1
9.0
9.0
2.0
2.0
2.6
2.6
3.4
3.4
4.1
4.1
4.8
4.8
5.7
5.7
6.3
6.3
7.0
7.0
8.2
8.2

WIRE DIA.
Inches

0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.023
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029

mm

TOTAL
MATL
COILS

0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.6
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7

6.38
6.50
6.50
7.13
7.13
7.00
7.00
7.75
7.75
7.75
7.75
8.13
8.13
7.88
7.88
8.13
8.13
5.75
5.75
6.25
6.25
6.88
6.88
7.13
7.13
7.88
7.88
8.00
8.00
8.63
8.63
8.63
8.63
9.13
9.13
9.13
9.13
9.13
9.13
9.75
6.25
6.25
6.88
6.88
7.50
7.50
8.13
8.13
8.63
8.63
9.13
9.13
9.63
9.63
9.75
9.75
10.1
10.1
10.0
10.0
10.1
10.1
6.50
6.50
7.38
7.38
8.25
8.25
9.00
9.00
9.50
9.50
10.1
10.1
10.4
10.4
10.6
10.6
11.1
11.1

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 33

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180

4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57

70431
70431S
70448
70448S
70251
70251S
70266
70266S
70287
70287S
70308
70308S
70329
70329S
70350
70350S
70371
70371S
70393
70393S
70414
70414S
70432
70432S
70449
70449S
70252
70252S
70267
70267S
70288
70288S
70309
70309S
70330
70330S
70351
70351S
70372
70372S
70394
70394S
B4-33
70415
70415S
70433
70433S
70450
70450S
70253
70253S
70269
70269S
70290
70290S
70311
70311S
70332
70332S
70352
70352S
70374
70374S
70395
70395S
70416
70416S
70434
70434S
70451
70451S
B4-36
70254
70254S
70270
70270S
70291
70291S
70312
70312S

.63
.63
.63
.63
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.88
.88
.88
.88
.88
.88
.88
.88

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

16.0
16.0
16.0
16.0
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4

I.D.
Inches

.116
.116
.110
.110
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.128
.156
.156
.152
.152
.148
.148
.144
.144

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
3.3
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7

Lbs./In.

51
43
77
66
1.2
1.0
2.0
1.8
3.1
2.6
4.6
3.9
6.7
5.7
9.6
8.1
13
11
19
16
29
25
47
40
69
58
1.1
.95
1.9
1.6
2.7
2.3
4.1
3.4
6.2
5.2
8.6
7.3
12
10
17
14
14
26
22
41
35
62
53
1.0
.88
1.7
1.5
2.6
2.2
3.9
3.3
5.6
4.8
7.6
6.5
11
9.4
16
13
24
21
37
32
57
49
17
1.0
.88
1.6
1.4
2.4
2.0
3.7
3.1

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

9.0
7.6
14
11
.21
.18
.35
.31
.53
.45
.80
.68
1.2
.99
1.7
1.4
2.3
2.0
3.3
2.8
5.1
4.3
8.3
7.0
12
10
.19
.17
.33
.28
.46
.39
.71
.60
1.1
.92
1.5
1.3
2.1
1.8
3.0
2.5
2.5
4.6
3.9
7.2
6.1
11
9.3
.18
.15
.30
.26
.46
.39
.68
.58
.98
.83
1.3
1.1
1.9
1.6
2.8
2.4
4.3
3.6
6.5
5.5
10
8.5
3.0
.18
.15
.27
.24
.41
.35
.64
.54

.19
.15
.15
.12
.53
.39
.50
.37
.45
.35
.42
.33
.39
.31
.36
.28
.34
.26
.28
.22
.25
.20
.20
.16
.17
.14
.58
.43
.54
.40
.51
.40
.47
.37
.43
.33
.40
.31
.37
.29
.31
.25
.25
.28
.22
.23
.19
.19
.15
.63
.46
.60
.44
.52
.41
.49
.39
.47
.37
.46
.36
.41
.32
.34
.26
.30
.24
.26
.20
.21
.16
.31
.63
.46
.65
.47
.58
.45
.53
.41

mm

4.8
3.8
3.9
3.1
14
9.9
13
9.3
11
8.8
11
8.4
10
7.8
9.2
7.2
8.6
6.7
7.1
5.6
6.3
5.0
5.2
4.1
4.4
3.5
15
11
14
10
13
10
12
9.4
11
8.5
10
8.0
9.4
7.3
7.9
6.3
6.4
7.0
5.5
6.0
4.7
4.8
3.8
16
12
15
11
13
10
13
9.8
12
9.3
12
9.1
10
8.1
8.5
6.7
7.6
6.0
6.6
5.2
5.3
4.2
7.9
16
12
16
12
15
11
13
10

ENDS: C - Closed

G - Ground
O - Open

Lbs.

9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
5.3
.64
.41
1.0
.64
1.4
.90
1.9
1.3

43
29
53
36
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
16
32
22
43
29
53
36
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
24
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7

Inches

.36
.36
.39
.39
.09
.09
.11
.11
.14
.14
.18
.18
.21
.21
.24
.24
.28
.28
.30
.30
.35
.35
.38
.38
.43
.43
.09
.09
.12
.12
.16
.16
.19
.19
.22
.22
.26
.26
.30
.30
.33
.33
.34
.38
.38
.42
.42
.47
.47
.10
.10
.13
.13
.16
.16
.20
.20
.24
.24
.29
.29
.32
.32
.35
.35
.41
.41
.46
.46
.50
.50
.33
.10
.10
.14
.14
.18
.18
.21
.21

mm

Inches

9.0
9.0
9.9
9.9
2.2
2.2
2.8
2.8
3.7
3.7
4.5
4.5
5.3
5.3
6.1
6.1
7.0
7.0
7.6
7.6
8.9
8.9
9.7
9.7
11.0
11.0
2.4
2.4
3.0
3.0
4.1
4.1
4.9
4.9
5.7
5.7
6.6
6.6
7.5
7.5
8.3
8.3
8.6
9.7
9.7
10.8
10.8
11.9
11.9
2.5
2.5
3.3
3.3
4.2
4.2
5.1
5.1
6.1
6.1
7.4
7.4
8.2
8.2
8.8
8.8
10.4
10.4
11.8
11.8
12.8
12.8
8.3
2.5
2.5
3.5
3.5
4.5
4.5
5.4
5.4

0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.026
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018

mm

TOTAL
MATL
COILS

0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.7
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5

11.1
11.1
11.1
11.1
7.25
7.25
8.00
8.00
9.00
9.00
9.75
9.75
10.5
10.5
11.0
11.0
11.5
11.5
11.5
11.5
12.1
12.1
11.9
11.9
12.4
12.4
7.75
7.75
8.50
8.50
10.0
10.0
10.8
10.8
11.1
11.1
11.9
11.9
12.4
12.4
12.6
12.6
13.0
13.1
13.1
13.3
13.3
13.4
13.4
8.25
8.25
9.13
9.13
10.3
10.3
11.1
11.1
12.0
12.0
13.3
13.3
13.4
13.4
13.4
13.4
14.1
14.1
14.5
14.5
14.4
14.4
12.5
8.25
8.25
9.75
9.75
11.1
11.1
11.8
11.8

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

33

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 34

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180

4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57

70333
70333S
70354
70354S
70375
70375S
70396
70396S
70417
70417S
70435
70435S
70453
70453S
70255
70255S
70272
70272S
70293
70293S
70314
70314S
70335
70335S
70355
70355S
70377
70377S
70398
70398S
70418
70418S
70436
70436S
70452
70452S
70256
70256S
70273
70273S
70294
70294S
70315
70315S
70336
70336S
70356
70356S
70378
70378S
70399
70399S
70419
70419S
70437
70437S
70454
70454S
70275
70275S
70296
70296S
70317
70317S
70338
70338S
70357
70357S
70379
70379S
70400
70400S
70420
70420S
70438
70438S
70455
70455S
70257
70257S

.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.25
1.25

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
31.8
31.8

MATERIAL: MW - Music Wire

34

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.156
.156

RATE
mm

3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.0
4.0

Lbs./In.

5.2
4.4
7.4
6.3
10
8.7
15
12
22
19
34
29
52
45
.90
.78
1.5
1.3
2.3
2.0
3.4
2.9
4.9
4.2
6.8
5.8
9.5
8.1
13
11
21
18
32
27
49
41
.80
.69
1.4
1.2
2.1
1.7
3.2
2.7
4.6
3.9
6.4
5.4
9.0
7.7
12
10
19
16
29
25
46
39
1.2
1.0
1.9
1.6
2.8
2.4
4.0
3.4
5.7
4.8
7.9
6.7
11
9.2
17
15
26
22
40
34
.70
.61

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.91
.77
1.3
1.1
1.8
1.5
2.6
2.2
3.9
3.3
5.9
5.0
9.2
7.8
.16
.14
.26
.23
.40
.34
.60
.51
.86
.73
1.2
1.0
1.7
1.4
2.3
1.9
3.6
3.1
5.5
4.7
8.5
7.3
.14
.12
.24
.20
.36
.31
.55
.47
.80
.68
1.1
.95
1.6
1.3
2.1
1.8
3.4
2.9
5.1
4.3
8.0
6.8
.21
.18
.33
.28
.49
.42
.70
.60
.99
.84
1.4
1.2
1.9
1.6
3.0
2.6
4.5
3.8
7.1
6.0
.12
.11

.50
.39
.47
.37
.43
.34
.36
.28
.33
.26
.29
.23
.23
.18
.71
.52
.67
.49
.59
.46
.57
.44
.53
.42
.51
.40
.47
.37
.41
.32
.35
.28
.31
.24
.24
.19
.80
.59
.74
.56
.66
.52
.61
.48
.58
.45
.54
.42
.50
.39
.43
.34
.38
.30
.33
.26
.26
.21
.84
.63
.71
.56
.69
.54
.65
.51
.61
.48
.57
.44
.49
.39
.42
.33
.37
.30
.29
.23
.91
.67

mm

13
10
12
9.3
11
8.6
9.2
7.2
8.3
6.5
7.3
5.7
5.8
4.6
18
13
17
12
15
12
14
11
14
11
13
10
12
9.3
10
8.2
8.9
7.0
7.8
6.1
6.2
4.9
20
15
19
14
17
13
15
12
15
11
14
11
13
9.9
11
8.7
9.6
7.6
8.4
6.6
6.6
5.2
21
16
18
14
17
14
17
13
16
12
14
11
12
9.8
11
8.5
9.5
7.5
7.5
5.9
23
17

Lbs.

2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.64
.41

ENDS: C - Closed

G - Ground
O - Open

12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
2.8
1.8

Inches

.26
.26
.30
.30
.34
.34
.37
.37
.44
.44
.50
.50
.54
.54
.11
.11
.14
.14
.18
.18
.23
.23
.27
.27
.32
.32
.37
.37
.41
.41
.47
.47
.54
.54
.58
.58
.12
.12
.15
.15
.20
.20
.24
.24
.29
.29
.34
.34
.38
.38
.44
.44
.50
.50
.57
.57
.61
.61
.17
.17
.21
.21
.26
.26
.32
.32
.38
.38
.43
.43
.48
.48
.56
.56
.64
.64
.68
.68
.13
.13

mm

6.5
6.5
7.5
7.5
8.7
8.7
9.4
9.4
11.1
11.1
12.8
12.8
13.8
13.8
2.7
2.7
3.6
3.6
4.6
4.6
5.7
5.7
6.9
6.9
8.1
8.1
9.3
9.3
10.5
10.5
12.0
12.0
13.6
13.6
14.7
14.7
3.0
3.0
3.9
3.9
5.0
5.0
6.1
6.1
7.3
7.3
8.6
8.6
9.8
9.8
11.1
11.1
12.8
12.8
14.5
14.5
15.6
15.6
4.3
4.3
5.4
5.4
6.7
6.7
8.1
8.1
9.6
9.6
11.0
11.0
12.3
12.3
14.2
14.2
16.3
16.3
17.3
17.3
3.4
3.4

WIRE DIA.
Inches

0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.012
0.012

mm

TOTAL
MATL
COILS

0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.3

12.8
12.8
13.5
13.5
14.3
14.3
14.3
14.3
15.1
15.1
15.8
15.8
15.5
15.5
9.00
9.00
10.0
10.0
11.3
11.3
12.5
12.5
13.5
13.5
14.5
14.5
15.3
15.3
15.9
15.9
16.3
16.3
16.8
16.8
16.5
16.5
9.88
9.88
10.9
10.9
12.4
12.4
13.3
13.3
14.4
14.4
15.4
15.4
16.0
16.0
16.8
16.8
17.4
17.4
17.9
17.9
17.5
17.5
12.0
12.0
13.3
13.3
14.6
14.6
16.0
16.0
17.1
17.1
18.0
18.0
18.6
18.6
19.3
19.3
20.0
20.0
19.5
19.5
11.0
11.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 35

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180

4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57

70276
70276S
70297
70297S
70318
70318S
70339
70339S
70358
70358S
70380
70380S
70401
70401S
70421
70421S
70439
70439S
70456
70456S
70277
70277S
70298
70298S
70319
70319S
70340
70340S
70360
70360S
70382
70382S
70403
70403S
70422
70422S
70440
70440S
70258
70258S
70278
70278S
70299
70299S
70320
70320S
70341
70341S
70361
70361S
70383
70383S
70404
70404S
70423
70423S
70441
70441S
70457
70457S
70300
70300S
70321
70321S
70342
70342S
70362
70362S
70384
70384S
70405
70405S
70424
70424S
70442
70442S
70458
70458S
70385
70385S

1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8

I.D.
Inches

.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.156
.156
.152
.152
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.148
.148
.144
.144
.140
.140
.136
.136
.132
.132
.128
.128
.122
.122
.116
.116
.110
.110
.132
.132

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
4.0
4.0
3.9
3.9
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
3.8
3.8
3.7
3.7
3.6
3.6
3.5
3.5
3.4
3.4
3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
3.4
3.4

Lbs./In.

1.1
.94
1.6
1.4
2.6
2.2
3.6
3.1
5.1
4.3
7.1
6.0
9.7
8.2
15
13
23
20
36
31
.98
.83
1.5
1.2
2.3
1.9
3.3
2.8
4.6
3.9
6.4
5.4
8.7
7.4
14
12
21
18
.60
.52
.89
.75
1.3
1.1
2.1
1.7
3.0
2.5
4.2
3.6
5.8
5.0
8.0
6.8
13
11
19
16
30
25
1.1
.93
1.7
1.5
2.5
2.1
3.6
3.1
5.0
4.3
6.9
5.8
11
9.1
16
14
25
22
4.4
3.7

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.19
.16
.28
.24
.45
.38
.63
.54
.89
.76
1.2
1.0
1.7
1.4
2.7
2.3
4.1
3.4
6.3
5.4
.17
.15
.25
.22
.40
.34
.57
.48
.81
.68
1.1
.95
1.5
1.3
2.4
2.0
3.6
3.1
.10
.09
.15
.13
.23
.19
.36
.31
.52
.44
.74
.63
1.0
.87
1.4
1.2
2.2
1.9
3.4
2.9
5.2
4.4
.19
.16
.31
.26
.44
.38
.64
.54
.88
.74
1.2
1.0
1.9
1.6
2.9
2.4
4.4
3.8
.76
.65

.92
.69
.85
.66
.75
.59
.73
.57
.68
.53
.63
.50
.55
.43
.48
.38
.42
.33
.33
.26
1.0
.78
.94
.73
.84
.66
.81
.63
.75
.59
.70
.55
.61
.48
.53
.42
.46
.37
1.1
.78
1.1
.85
1.0
.82
.94
.73
.89
.69
.82
.64
.77
.60
.66
.52
.58
.46
.50
.40
.40
.32
1.2
.97
1.1
.86
1.0
.81
.95
.75
.89
.70
.78
.61
.68
.54
.59
.47
.47
.37
1.0
.80

mm

23
17
22
17
19
15
18
14
17
13
16
13
14
11
12
9.6
11
8.4
8.4
6.7
26
20
24
19
21
17
20
16
19
15
18
14
16
12
13
11
12
9.3
27
20
29
22
27
21
24
19
23
18
21
16
19
15
17
13
15
12
13
10
10
8.1
32
25
28
22
26
21
24
19
23
18
20
16
17
14
15
12
12
9.5
26
20

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
.64
.41
1.0
.64
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
1.4
.90
1.9
1.3
2.6
1.7
3.5
2.3
4.5
3.0
5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
4.5
3.0

4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
2.8
1.8
4.5
2.9
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
6.0
4.0
8.5
5.7
12
7.7
15
10
20
13
24
16
32
22
43
29
53
36
20
13

Inches

.18
.18
.25
.25
.29
.29
.35
.35
.41
.41
.48
.48
.53
.53
.62
.62
.71
.71
.76
.76
.20
.20
.27
.27
.32
.32
.39
.39
.45
.45
.52
.52
.59
.59
.68
.68
.78
.78
.15
.15
.22
.22
.29
.29
.35
.35
.42
.42
.49
.49
.57
.57
.64
.64
.74
.74
.84
.84
.91
.91
.35
.35
.40
.40
.49
.49
.56
.56
.65
.65
.73
.73
.86
.86
.98
.98
1.05
1.05
.74
.74

mm

Inches

4.6
4.6
6.2
6.2
7.3
7.3
9.0
9.0
10.5
10.5
12.1
12.1
13.5
13.5
15.7
15.7
18.0
18.0
19.2
19.2
5.1
5.1
6.8
6.8
8.1
8.1
9.8
9.8
11.5
11.5
13.2
13.2
14.9
14.9
17.3
17.3
19.8
19.8
3.8
3.8
5.6
5.6
7.5
7.5
8.9
8.9
10.7
10.7
12.5
12.5
14.4
14.4
16.2
16.2
18.8
18.8
21.3
21.3
23.0
23.0
8.8
8.8
10.2
10.2
12.3
12.3
14.2
14.2
16.5
16.5
18.7
18.7
21.8
21.8
24.8
24.8
26.7
26.7
18.8
18.8

0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.012
0.012
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.024
0.024

mm

TOTAL
MATL
COILS

0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.6
0.6

13.0
13.0
15.4
15.4
15.9
15.9
17.6
17.6
18.8
18.8
19.9
19.9
20.5
20.5
21.4
21.4
22.1
22.1
21.6
21.6
14.4
14.4
16.8
16.8
17.6
17.6
19.3
19.3
20.5
20.5
21.6
21.6
22.6
22.6
23.5
23.5
24.4
24.4
12.5
12.5
15.6
15.6
18.4
18.4
19.4
19.4
21.0
21.0
22.4
22.4
23.6
23.6
24.5
24.5
25.5
25.5
26.3
26.3
25.9
25.9
21.6
21.6
22.4
22.4
24.3
24.3
25.5
25.5
27.1
27.1
28.3
28.3
29.6
29.6
30.5
30.5
30.0
30.0
30.9
30.9

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

35

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 36

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.180
0.184
0.184
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188

4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.57
4.67
4.67
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78

70406
70406S
70425
70425S
70443
70443S
70459
70459S
12764
B4-24
OO-60
AA-33
CC-5
V-75
U-15
PP-69
B1-22
FF-62
S-1460
B9-31
LL-15
II-2
A10-6
S-1280
EE-3
O-13
V-83
A-44
AA-2
G-60
O-119
EE-11
F-18
908
FF-7
A9-2
10063
V-14
G-70
F-76
DD-70
S-1007
M-119
2983
II-49
DD-12
J-96
2522
A15-7
A9-22
S-853
S-1003
F-66
F-16
II-86
WW-13
PP-98
II-14
B12-17
J-39
Y-78
3425
JJ-62
B5-6
10748
F-87
B1-11
AA-25
V V-5
919
O-28
A13-15
S-838
B5-66
OO-18
11362
EE-8
S-19
L-68
F-93

2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
.25
.86
.19
.19
.19
.19
.19
.22
.23
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.25
.28
.28
.28
.28
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.34
.34
.34
.34
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.41
.41

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
6.4
21.8
4.8
4.8
4.8
4.8
4.8
5.6
5.9
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
7.1
7.1
7.1
7.1
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
8.7
8.7
8.7
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
10.3
10.3

MATERIAL: MW - Music Wire

36

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.128
.128
.122
.122
.116
.116
.110
.110
.164
.138
.160
.156
.140
.140
.130
.148
.138
.158
.158
.150
.148
.144
.142
.138
.136
.136
.136
.132
.104
.154
.154
.142
.138
.170
.170
.164
.158
.158
.158
.156
.152
.152
.150
.148
.148
.144
.144
.128
.122
.166
.156
.152
.136
.122
.172
.168
.164
.156
.152
.150
.146
.144
.144
.142
.140
.136
.134
.132
.132
.124
.124
.122
.118
.164
.160
.160
.152
.152
.148
.144

RATE
mm

3.3
3.3
3.1
3.1
2.9
2.9
2.8
2.8
4.2
3.5
4.1
4.0
3.6
3.6
3.3
3.8
3.5
4.0
4.0
3.8
3.8
3.7
3.6
3.5
3.5
3.5
3.5
3.4
2.6
3.9
3.9
3.6
3.5
4.3
4.3
4.2
4.0
4.0
4.0
4.0
3.9
3.9
3.8
3.8
3.8
3.7
3.7
3.3
3.1
4.2
4.0
3.9
3.5
3.1
4.4
4.3
4.2
4.0
3.9
3.8
3.7
3.7
3.7
3.6
3.6
3.5
3.4
3.4
3.4
3.1
3.1
3.1
3.0
4.2
4.1
4.1
3.9
3.9
3.8
3.7

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

6.0
1.0
5.1
.89
9.4
1.6
7.9
1.4
14
2.5
12
2.1
22
3.9
19
3.3
.78
.14
7.4
1.3
11
1.9
8.4
1.5
110
19
64
11
258
45
15
2.6
38
6.6
7.2
1.3
4.5
.79
16
2.7
22
3.8
26
4.6
30
5.3
33
5.7
52
9.2
63
11
155
27
64
11
639 112
5.3
.93
8.1
1.4
13
2.3
38
6.6
.37
.07
.35
.06
1.2
.20
2.9
.50
1.6
.27
3.5
.62
5.5
.96
8.4
1.5
11
1.9
17
3.0
20
3.5
9.9
1.7
22
3.8
18
3.2
118
21
117
20
.86
.15
3.6
.64
6.4
1.1
39
6.8
114
20
.14
.02
.75
.13
1.1
.19
4.7
.82
8.2
1.4
8.8
1.5
20
3.5
25
4.4
19
3.3
19
3.3
23
4.0
33
5.7
33
5.8
29
5.1
42
7.4
101
18
132
23
83
14
121
21
1.1
.19
3.6
.62
1.5
.27
4.2
.73
6.4
1.1
6.9
1.2
11
1.9

.89
.70
.78
.61
.69
.54
.54
.43
.19
.51
.09
.10
.04
.04
.03
.10
.08
.15
.16
.14
.08
.08
.12
.09
.09
.08
.03
.07
.02
.16
.18
.10
.12
.24
.24
.23
.19
.15
.21
.16
.15
.11
.08
.13
.17
.10
.18
.07
.06
.27
.22
.19
.13
.06
.30
.30
.28
.26
.23
.25
.15
.13
.12
.20
.19
.16
.12
.11
.10
.09
.05
.08
.06
.31
.27
.28
.25
.19
.21
.19

23
18
20
16
17
14
14
11
4.7
13
2.3
2.6
.99
1.1
.69
2.5
2.1
3.8
4.0
3.5
2.0
2.2
3.2
2.4
2.4
2.1
.84
1.7
.55
4.1
4.6
2.5
3.0
6.2
6.2
5.7
4.9
3.7
5.3
4.0
3.7
2.9
2.1
3.2
4.4
2.6
4.6
1.7
1.6
6.8
5.7
4.9
3.4
1.6
7.6
7.7
7.1
6.7
5.7
6.3
3.7
3.4
3.0
5.1
4.8
4.0
2.9
2.8
2.5
2.3
1.3
2.1
1.6
7.9
6.9
7.1
6.4
4.9
5.2
4.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs.

5.3
3.6
7.3
4.9
9.7
6.5
12
8.0
.14
3.8
.97
.87
4.3
2.9
7.0
1.4
3.1
1.1
.72
2.2
1.7
2.2
3.8
3.1
4.9
5.1
5.1
4.2
14
.86
1.5
1.3
4.5
.09
.09
.26
.55
.23
.73
.87
1.2
1.2
1.4
2.5
1.7
2.2
3.3
7.7
7.3
.23
.81
1.2
5.1
7.3
.04
.23
.31
1.2
1.8
2.2
2.9
3.3
2.2
3.8
4.3
5.1
3.8
3.2
4.2
9.3
6.7
6.8
7.7
.34
.97
.43
1.1
1.2
1.4
2.0

ENDS: C - Closed

G - Ground
O - Open

24
16
32
22
43
29
53
36
.64
17
4.3
3.9
19
13
31
6.4
14
4.8
3.2
9.6
7.4
9.8
17
14
22
23
23
19
61
3.8
6.5
5.7
20
.40
.38
1.2
2.4
1.0
3.2
3.9
5.5
5.5
6.4
11
7.6
9.8
15
34
33
1.0
3.6
5.5
23
33
.18
1.0
1.4
5.5
8.2
9.6
13
15
9.8
17
19
23
17
14
19
41
30
30
34
1.5
4.3
1.9
4.7
5.5
6.3
8.9

Inches

.84
.84
.98
.98
1.12
1.12
1.19
1.19
.07
.35
.06
.08
.10
.11
.12
.12
.15
.08
.09
.09
.10
.12
.12
.14
.16
.14
.10
.14
.19
.12
.10
.18
.16
.07
.07
.09
.12
.17
.11
.08
.11
.10
.10
.11
.14
.13
.13
.17
.20
.08
.12
.13
.18
.23
.08
.06
.10
.11
.10
.12
.13
.13
.12
.16
.19
.20
.19
.27
.21
.22
.19
.23
.26
.10
.08
.13
.15
.13
.20
.22

mm

21.3
21.3
24.8
24.8
28.4
28.4
30.3
30.3
1.7
8.8
1.4
2.0
2.4
2.7
2.9
3.0
3.8
1.9
2.2
2.2
2.5
3.1
2.9
3.5
4.0
3.6
2.6
3.6
4.7
3.0
2.6
4.7
4.1
1.7
1.8
2.2
3.0
4.2
2.7
2.0
2.9
2.5
2.4
2.8
3.6
3.4
3.4
4.2
5.0
2.0
3.0
3.3
4.6
5.9
1.9
1.5
2.4
2.8
2.6
3.1
3.2
3.4
3.1
3.9
4.7
5.1
4.8
6.8
5.3
5.7
4.9
5.9
6.7
2.4
2.1
3.2
3.9
3.3
5.1
5.6

WIRE DIA.
Inches

0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.010
0.023
0.014
0.016
0.024
0.024
0.029
0.020
0.025
0.015
0.015
0.019
0.020
0.022
0.023
0.025
0.026
0.026
0.026
0.028
0.042
0.017
0.017
0.023
0.025
0.009
0.009
0.012
0.015
0.015
0.015
0.016
0.018
0.018
0.019
0.020
0.020
0.022
0.022
0.030
0.033
0.011
0.016
0.018
0.026
0.033
0.008
0.010
0.012
0.016
0.018
0.019
0.021
0.022
0.022
0.023
0.024
0.026
0.027
0.028
0.028
0.032
0.032
0.033
0.035
0.012
0.014
0.014
0.018
0.018
0.020
0.022

mm

TOTAL
MATL
COILS

0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.3
0.6
0.4
0.4
0.6
0.6
0.7
0.5
0.6
0.4
0.4
0.5
0.5
0.6
0.6
0.6
0.7
0.7
0.7
0.7
1.1
0.4
0.4
0.6
0.6
0.2
0.2
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.8
0.8
0.3
0.4
0.5
0.7
0.8
0.2
0.3
0.3
0.4
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.9
0.3
0.4
0.4
0.5
0.5
0.5
0.6

32.3
32.3
33.6
33.6
35.0
35.0
34.1
34.1
5.50
15.0
3.00
4.00
3.00
3.50
3.00
5.00
5.00
4.00
4.75
4.50
4.00
4.50
5.00
5.50
5.00
4.50
3.00
5.00
4.25
6.00
5.00
8.00
5.50
6.50
6.75
6.25
7.00
10.0
6.00
5.00
5.25
4.50
4.00
4.50
7.00
5.00
6.00
4.50
6.00
6.00
6.50
6.25
6.00
6.00
8.50
5.00
7.00
6.00
5.75
6.50
5.00
5.00
5.50
6.75
6.75
6.75
7.00
8.50
6.50
6.00
5.00
7.00
6.50
7.00
5.00
8.00
8.50
6.25
9.00
9.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
SST
MW
SST
MW
MW
MW
SST
SPR
SST
MW
SST
MW
MW
MW
SST
MW
SST
MW
SST
SST
SST
SST
MW
MW
SST
MW
MW
SPR
SST
SST
SST
MW
HD
SST
SST
MW
MW
MW
MW
MW
MW
SST
MW
MW
MW
SST
SST
SST
MW
SPR
SST
SST
MW
MW
SST
SST
SST
MW
MW

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
C
C
C
C
C
C
CG
C
C
CG
CG
C
C
C
CG
CG
C
C
CG
C
C
C
C
C
C
C
CG
C
C
C
C
CG
C
CG
C
CG
C
C
C
C
C
C
C
C
C
CG
CG
C
C
CG
CG
C
C
CG
C
C
C
C
CG
C
C
C
C
CG
C
C
C

N
N
N
N
N
N
N
N
N
BO
N
N
N
N
Z
N
N
N
N
Z
N
N
GI
N
N
N
N
N
N
N
N
N
Z
Z
N
N
GI
N
N
N
N
N
N
Z
Z
N
GI
Z
N
N
N
N
Z
Z
N
N
N
N
N
N
N
Z
N
N
N
Z
N
N
N
Z
Z
N
N
N
N
N
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 37

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188

4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78

J-33
L-49
J-20
Z-86
GG-14
J-83
F-4
JJ-29
11108
F-68
3449
S-1427
10679
10590
M-8
W-60A
4329
A9-9
F-98
S-1432
FF-2
F-71
Z-12
S-1512
2553
MM-26
Y-77
J-78
Q-22
GG-3
FF-59
II-63
M-125
A14-5
11355
GG-18
B5-11
3727
CC-61
K-13
B4-18
NN-29
3530
A13-1
920
FF-27
O-108
V V-69
3986
LL-42
B7-18
W-69
528
DD-9
EE-29
NN-3
B6-15
PP-82
S-709
F-22
B15-18
F-89
2637
NN-74
FF-29
J-21
KK-14
V V-11
H-8
Q-17
3835
EE-6
S-1328
S-831
L-18
2562
S-1269
N-93
S-1116
CC-17
PP-37

.41
.41
.41
.41
.41
.41
.41
.41
.41
.41
.41
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.47
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3

I.D.
Inches

.144
.142
.138
.136
.134
.134
.134
.132
.126
.124
.112
.166
.164
.162
.152
.152
.140
.138
.138
.130
.128
.124
.124
.164
.148
.148
.140
.138
.136
.130
.126
.118
.112
.168
.164
.160
.158
.154
.148
.148
.148
.146
.144
.144
.142
.140
.140
.140
.138
.138
.138
.134
.132
.128
.128
.128
.126
.124
.124
.122
.144
.136
.132
.132
.164
.158
.158
.158
.154
.150
.148
.148
.144
.144
.142
.140
.140
.138
.138
.134
.134

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

3.7
3.6
3.5
3.5
3.4
3.4
3.4
3.4
3.2
3.1
2.8
4.2
4.2
4.1
3.9
3.9
3.6
3.5
3.5
3.3
3.3
3.1
3.1
4.2
3.8
3.8
3.6
3.5
3.5
3.3
3.2
3.0
2.8
4.3
4.2
4.1
4.0
3.9
3.8
3.8
3.8
3.7
3.7
3.7
3.6
3.6
3.6
3.6
3.5
3.5
3.4
3.4
3.4
3.3
3.3
3.3
3.2
3.1
3.1
3.1
3.7
3.5
3.4
3.4
4.2
4.0
4.0
4.0
3.9
3.8
3.8
3.8
3.7
3.7
3.6
3.6
3.6
3.5
3.5
3.4
3.4

N/mm

Inches

10
21
44
27
57
31
37
34
47
81
139

1.8
3.8
7.7
4.8
10
5.4
6.4
5.9
8.2
14
24
.15
.14
.27
1.1
.87
2.2
3.3
3.9
8.7
7.4
11
11
.20
1.9
1.7
3.9
4.6
4.6
8.9
9.7
18
31
.04
.23
.16
.49
.41
1.4
1.1
1.4
1.6
1.5
2.1
2.0
4.8
3.9
2.8
4.6
3.6
3.4
3.1
5.9
6.5
5.3
7.4
8.3
7.7
8.8
11
5.2
4.0
4.8
3.7
.16
.21
.11
.42
.36
.77
1.4
1.9
2.5
1.3
2.0
1.9
2.6
2.2
2.7
4.1
5.4

.20
.18
.10
.12
.10
.18
.16
.13
.12
.08
.07
.36
.33
.33
.29
.25
.16
.16
.21
.09
.17
.11
.10
.34
.23
.26
.19
.17
.19
.09
.10
.08
.06
.38
.30
.32
.38
.27
.31
.28
.31
.21
.26
.28
.25
.10
.19
.18
.17
.22
.24
.16
.19
.14
.14
.18
.18
.14
.12
.12
.11
.22
.22
.20
.45
.34
.23
.43
.32
.35
.31
.16
.15
.30
.31
.27
.19
.24
.20
.24
.18

.84
.81
1.5
6.1
4.9
13
19
22
50
42
62
64
1.1
11
9.7
22
26
26
51
55
102
178
.26
1.3
.93
2.8
2.3
8.2
6.2
8.1
9.0
8.3
12
11
28
22
16
26
20
19
18.04
34
37
30
42
47
44
50
62
29
23
27
21
.93
1.2
.65
2.4
2.0
4.4
8.2
11
14
7.3
11
11
15
13
15
23
31

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

mm

5.0
4.5
2.6
3.2
2.5
4.7
4.0
3.2
3.1
2.1
1.9
9.1
8.4
8.5
7.5
6.3
4.0
4.1
5.3
2.4
4.3
2.7
2.5
8.7
5.9
6.6
4.9
4.4
4.9
2.3
2.6
2.1
1.5
9.7
7.7
8.1
9.7
6.9
7.8
7.1
7.9
5.4
6.6
7.0
6.3
2.6
4.9
4.5
4.4
5.7
6.0
4.1
4.8
3.5
3.6
4.7
4.6
3.6
3.1
3.0
2.9
5.7
5.7
5.1
12
8.6
5.9
11
8.2
9.0
7.8
3.9
3.9
7.6
7.8
7.0
4.9
6.1
5.1
6.2
4.7

ENDS: C - Closed

G - Ground
O - Open

Lbs.

2.0
3.8
4.6
3.4
5.7
5.7
5.7
4.2
5.7
6.7
10
.30
.27
.51
1.8
1.2
2.0
3.1
4.6
4.7
7.1
6.7
6.2
.39
2.5
2.5
4.3
4.6
5.1
4.7
5.7
8.3
10
.10
.39
.29
1.1
.63
2.5
1.7
2.5
1.9
2.1
3.3
2.8
2.9
4.3
2.9
4.6
4.6
4.6
2.9
6.3
5.2
4.2
7.7
8.5
6.2
6.2
7.3
3.3
5.1
6.1
4.2
.42
.40
.15
1.0
.66
1.5
2.5
1.7
2.2
2.2
3.5
3.0
2.9
3.1
3.1
5.7
5.7

8.8
17
20
15
25
25
25
19
25
30
46
1.3
1.2
2.3
8.0
5.5
8.7
14
20
21
32
30
28
1.7
11
11
19
20
23
21
25
37
46
.43
1.7
1.3
4.8
2.8
11
7.7
11
8.6
9.6
15
13
13
19
13
20
20
20
12.8
28
23
19
34
38
28
28
33
15
23
27
19
1.9
1.8
.68
4.5
2.9
6.9
11
7.4
9.8
9.8
16
13
13
14
14
25
25

Inches

.21
.17
.15
.18
.14
.22
.22
.22
.26
.26
.32
.08
.11
.10
.14
.15
.28
.21
.23
.22
.27
.30
.27
.09
.15
.16
.19
.20
.23
.19
.26
.28
.30
.12
.08
.18
.12
.23
.18
.22
.18
.19
.24
.18
.25
.17
.19
.22
.20
.24
.22
.297
.27
.30
.36
.30
.29
.35
.32
.35
.10
.25
.31
.31
.11
.23
.33
.14
.24
.21
.18
.12
.14
.24
.25
.29
.23
.28
.26
.30
.24

mm

Inches

5.3
4.2
3.8
4.6
3.6
5.5
5.5
5.5
6.7
6.5
8.2
2.0
2.7
2.6
3.7
3.9
7.2
5.2
5.7
5.5
6.9
7.7
6.9
2.2
3.8
4.1
4.9
5.1
5.9
4.8
6.7
7.1
7.7
3.0
2.1
4.6
3.0
5.8
4.6
5.6
4.6
4.8
6.1
4.6
6.4
4.3
4.9
5.5
5.1
6.0
5.6
7.4
6.8
7.6
9.1
7.6
7.3
8.9
8.1
8.8
2.5
6.4
7.8
7.8
2.7
5.7
8.4
3.4
6.0
5.3
4.6
3.0
3.6
6.1
6.4
7.3
5.8
7.0
6.7
7.5
6.2

0.022
0.023
0.025
0.026
0.027
0.027
0.027
0.028
0.031
0.032
0.038
0.011
0.012
0.013
0.018
0.018
0.024
0.025
0.025
0.029
0.030
0.032
0.032
0.012
0.020
0.020
0.024
0.025
0.026
0.029
0.031
0.035
0.038
0.010
0.012
0.014
0.015
0.017
0.020
0.020
0.020
0.021
0.022
0.022
0.023
0.024
0.024
0.024
0.025
0.025
0.025
0.027
0.028
0.030
0.030
0.030
0.031
0.032
0.032
0.033
0.022
0.026
0.028
0.028
0.012
0.015
0.015
0.015
0.017
0.019
0.020
0.020
0.022
0.022
0.023
0.024
0.024
0.025
0.025
0.027
0.027

mm

TOTAL
MATL
COILS

0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.7
0.8
0.8
1.0
0.3
0.3
0.3
0.5
0.5
0.6
0.6
0.6
0.7
0.8
0.8
0.8
0.3
0.5
0.5
0.6
0.6
0.7
0.7
0.8
0.9
1.0
0.3
0.3
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.69
0.7
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.6
0.7
0.7
0.7
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.7
0.7

8.50
6.25
5.00
7.00
5.25
8.00
7.00
7.75
8.50
7.00
8.50
6.00
8.03
7.00
7.00
7.50
10.8
8.25
8.00
6.50
9.00
8.50
7.50
6.25
6.50
7.00
7.00
7.00
8.00
6.50
7.50
8.00
7.00
11.0
5.75
12.0
7.00
12.5
8.00
10.0
8.00
8.00
11.0
8.25
10.0
6.00
7.00
8.00
7.00
8.50
8.75
11.0
8.50
9.00
12.0
9.00
9.25
10.0
9.00
9.50
4.50
8.75
10.0
11.0
8.00
14.0
21.0
8.00
14.0
11.0
8.00
6.00
6.50
10.9
10.0
12.0
8.50
11.0
9.50
10.0
8.00

SST
MW
MW
SST
MW
MW
MW
SST
SST
SPR
SPR
SST
SST
MW
MW
SST
MW
SST
MW
SST
MW
SPR
SST
SST
MW
MW
MW
MW
MW
SST
SST
SPR
SPR
SST
SST
SST
MW
MW
MW
MW
MW
SST
MW
MW
MW
SST
MW
SST
MW
MW
MW
SST
MW
SST
MW
MW
MW
SST
SST
SPR
MW
MW
MW
SST
MW
MW
SST
MW
MW
MW
MW
SST
SST
SST
MW
MW
SST
SST
SST
MW
MW

E
N
D
S

F
N
S
H

C
C
C
CG
CG
CG
C
CG
CG
C
CG
C
C
C
C
C
C
CG
C
C
CG
C
C
C
C
C
C
C
C
CG
C
CG
C
C
C
C
C
C
C
C
C
C
CG
CG
C
C
C
C
C
C
CG
CG
C
C
CG
C
CG
C
C
C
CG
C
C
CG
C
C
C
C
CG
C
C
CG
C
CG
C
CG
C
CG
C
C
C

N
N
Z
N
N
N
Z
N
N
Z
GI
N
N
N
N
N
N
N
Z
N
Z
Z
N
N
Z
N
Z
Z
Z
N
N
N
N
N
N
N
N
Z
Z
Z
N
N
Z
GI
Z
N
BO
N
Z
N
N
N
Z
N
N
N
N
N
N
Z
GI
Z
Z
N
Z
Z
N
N
Z
N
Z
N
N
N
Z
Z
N
N
N
Z
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

37

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 38

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188

4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78

II-3
Z-91
N-25
JJ-18
U-100
O-36
A9-15
Z-46
B14-43
B14-48
V-50
B1-9
F-73
B15-6
B4-5
10896
RR-13
N-314
OO-11
B9-63
PP-19
S-707
921
A-83
F-19
Q-71
AA-67
NN-84
S-710
10604
A9-18
PP-35
H-15
G-9
F-69
Q-18
YY-45
B5-23
A9-47
O-149
I-68
II-30
G-76
PP-15
A14-13
B9-36
2610
A-30
F-90
QQ-7
2809
S-1115
2584
10890
F-83
S-1333
KK-96
U-25
V-72
3927
10184
OO-57
A15-23
B7-14
S-708
A15-18
HH-42
NN-89
NN-42
F-85
S-711
U-77
A9-60
S-816
S-3
A15-16
F-70
EE-16
S-1502
S-1081

.56
.56
.56
.59
.59
.59
.59
.59
.59
.59
.59
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.72
.72
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.78
.78
.78
.81

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
18.2
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
19.8
19.8
19.8
20.6

MATERIAL: MW - Music Wire

38

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.130
.128
.118
.160
.160
.152
.148
.148
.146
.132
.130
.122
.122
.114
.138
.170
.164
.158
.156
.150
.144
.144
.142
.138
.138
.136
.128
.124
.124
.122
.168
.152
.148
.140
.136
.160
.158
.154
.152
.150
.148
.148
.142
.138
.132
.130
.124
.122
.122
.108
.158
.158
.156
.148
.136
.166
.160
.158
.156
.154
.152
.152
.144
.144
.144
.138
.128
.128
.126
.124
.124
.118
.168
.164
.158
.156
.136
.132
.126
.152

RATE
mm

3.3
3.3
3.0
4.1
4.1
3.9
3.8
3.8
3.7
3.4
3.3
3.1
3.1
2.9
3.5
4.3
4.2
4.0
4.0
3.8
3.7
3.7
3.6
3.5
3.5
3.5
3.3
3.1
3.1
3.1
4.3
3.9
3.8
3.6
3.5
4.1
4.0
3.9
3.9
3.8
3.8
3.8
3.6
3.5
3.4
3.3
3.1
3.1
3.1
2.7
4.0
4.0
4.0
3.8
3.5
4.2
4.1
4.0
4.0
3.9
3.9
3.9
3.7
3.7
3.7
3.5
3.3
3.3
3.2
3.1
3.1
3.0
4.3
4.2
4.0
4.0
3.5
3.4
3.2
3.9

Lbs./In.

52
50
91
1.1
1.7
6.1
3.1
4.8
6.0
22
18
44
54
87
16
.16
.54
1.8
.86
6.5
6.2
8.1
13
11
12
14
33
54
38
51
.24
3.4
8.1
13
18
.53
1.6
2.6
3.9
4.9
3.8
4.9
10
22
23
27
45
52
48
105
1.8
1.8
1.7
4.9
15
.48
.93
.73
2.1
2.7
3.6
2.5
7.5
7.7
6.5
12
23
20
25
34
31
59
.30
.69
.94
1.2
14
22
24
1.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

9.0
8.8
16
.19
.31
1.1
.55
.84
1.1
3.8
3.2
7.6
9.4
15
2.8
.03
.09
.31
.15
1.1
1.1
1.4
2.2
2.0
2.1
2.5
5.7
9.5
6.7
8.9
.04
.60
1.4
2.3
3.1
.09
.28
.46
.68
.85
.67
.85
1.7
3.9
3.9
4.7
7.9
9.1
8.4
18
.31
.31
.30
.85
2.7
.08
.16
.13
.36
.48
.63
.43
1.3
1.4
1.1
2.1
4.0
3.5
4.4
5.9
5.4
10
.05
.12
.16
.22
2.5
3.8
4.2
.30

.14
.15
.09
.41
.48
.30
.27
.35
.34
.26
.17
.16
.14
.11
.29
.52
.48
.47
.27
.33
.30
.27
.30
.27
.28
.26
.24
.12
.16
.14
.53
.36
.31
.33
.29
.39
.51
.40
.47
.45
.39
.43
.38
.21
.28
.26
.21
.20
.15
.11
.55
.40
.49
.46
.33
.63
.57
.45
.56
.55
.51
.50
.44
.43
.34
.38
.30
.26
.22
.20
.20
.14
.66
.56
.53
.53
.36
.29
.24
.47

mm

3.5
3.9
2.2
10
12
7.6
6.9
8.9
8.7
6.5
4.4
4.0
3.5
2.8
7.4
13
12
12
6.9
8.5
7.5
6.9
7.7
6.8
7.0
6.6
6.0
3.2
4.2
3.7
13
9.2
7.9
8.4
7.3
10
13
10
12
11
10
11
9.7
5.3
7.1
6.6
5.3
5.0
3.9
2.9
14
10
13
12
8.4
16
14
11
14
14
13
13
11
11
8.6
9.6
7.6
6.7
5.7
5.0
5.2
3.6
17
14
14
14
9.2
7.3
6.1
12

Lbs.

7.0
7.7
7.7
.44
.84
1.8
.85
1.7
2.0
5.5
3.2
6.8
7.3
9.7
4.6
.08
.26
.83
.24
2.2
1.8
2.2
3.8
3.1
3.3
3.7
7.7
6.7
6.2
7.3
.13
1.2
2.5
4.3
5.1
.21
.81
1.0
1.8
2.2
1.5
2.1
3.8
4.6
6.3
7.0
9.3
10
7.3
12
.99
.72
.85
2.2
5.1
.30
.53
.33
1.1
1.5
1.8
1.2
3.3
3.3
2.2
4.6
6.8
5.2
5.7
6.7
6.2
8.3
.20
.39
.50
.66
5.1
6.3
5.7
.80

ENDS: C - Closed

G - Ground
O - Open

31
34
34
1.9
3.7
8.2
3.8
7.4
9.1
25
14
30
33
43
20
.37
1.1
3.7
1.0
9.6
8.2
9.8
17
14
15
17
34
30
28
33
.57
5.5
11
19
23
.92
3.6
4.6
8.2
9.6
6.6
9.2
17
20
28
31
41
45
33
54
4.4
3.2
3.8
9.9
23
1.3
2.3
1.5
5.1
6.6
8.2
5.5
15
15
9.8
20
30
23
25
30
28
37
.88
1.7
2.2
2.9
23
28
25
3.6

Inches

.23
.27
.28
.18
.11
.14
.32
.22
.25
.34
.42
.38
.38
.41
.28
.11
.14
.15
.35
.15
.33
.24
.24
.33
.35
.36
.36
.30
.39
.40
.13
.20
.18
.25
.31
.29
.18
.17
.20
.19
.30
.26
.25
.23
.33
.33
.38
.40
.41
.52
.17
.15
.22
.26
.34
.11
.18
.30
.19
.20
.21
.25
.26
.25
.29
.33
.45
.47
.43
.48
.46
.44
.12
.12
.25
.25
.36
.36
.46
.34

mm

5.9
6.9
7.1
4.6
2.8
3.7
8.1
5.6
6.4
8.5
10.7
9.6
9.6
10.3
7.1
2.7
3.7
3.9
8.9
3.9
8.4
6.1
6.0
8.3
8.9
9.2
9.1
7.7
10.0
10.1
3.2
5.0
4.6
6.4
7.8
7.5
4.6
4.3
5.0
4.8
7.5
6.6
6.4
5.7
8.4
8.3
9.8
10.1
10.5
13.2
4.2
3.8
5.7
6.6
8.6
2.8
4.6
7.6
4.9
5.2
5.3
6.4
6.7
6.4
7.3
8.3
11.4
11.8
11.0
12.2
11.8
11.1
3.0
3.0
6.3
6.3
9.2
9.2
11.6
8.7

WIRE DIA.
Inches

0.029
0.030
0.035
0.014
0.014
0.018
0.020
0.020
0.021
0.028
0.029
0.033
0.033
0.037
0.025
0.009
0.012
0.015
0.016
0.019
0.022
0.022
0.023
0.025
0.025
0.026
0.030
0.032
0.032
0.033
0.010
0.018
0.020
0.024
0.026
0.014
0.015
0.017
0.018
0.019
0.020
0.020
0.023
0.025
0.028
0.029
0.032
0.033
0.033
0.040
0.015
0.015
0.016
0.020
0.026
0.011
0.014
0.015
0.016
0.017
0.018
0.018
0.022
0.022
0.022
0.025
0.030
0.030
0.031
0.032
0.032
0.035
0.010
0.012
0.015
0.016
0.026
0.028
0.031
0.018

mm

TOTAL
MATL
COILS

0.7
0.8
0.9
0.4
0.4
0.5
0.5
0.5
0.5
0.7
0.7
0.8
0.8
0.9
0.6
0.2
0.3
0.4
0.4
0.5
0.6
0.6
0.6
0.6
0.6
0.7
0.8
0.8
0.8
0.8
0.3
0.5
0.5
0.6
0.7
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.7
0.7
0.8
0.8
0.8
1.0
0.4
0.4
0.4
0.5
0.7
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.6
0.6
0.6
0.6
0.8
0.8
0.8
0.8
0.8
0.9
0.3
0.3
0.4
0.4
0.7
0.7
0.8
0.5

7.00
8.00
8.00
12.0
8.00
7.00
16.0
11.0
12.0
12.0
14.5
11.5
10.5
11.0
10.3
11.0
11.0
10.1
21.0
8.00
14.0
10.0
9.25
12.0
13.0
13.0
11.0
9.50
11.3
11.0
11.5
10.0
8.00
10.5
10.8
20.0
11.0
10.0
10.0
10.0
14.8
12.0
11.0
8.00
11.8
11.3
11.0
11.0
11.5
13.0
10.0
9.00
13.0
12.0
12.0
9.00
12.0
19.0
11.0
11.0
10.5
13.0
12.0
11.5
12.0
13.0
15.0
15.5
14.0
14.0
13.5
12.5
10.7
9.00
15.5
15.5
13.0
12.0
14.8
18.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
SST
MW
MW
MW
SST
SST
MW
MW
SST
SST
HD
SPR
MW
SST
SST
MW
SST
MW
MW
SST
MW
SST
MW
MW
MW
SPR
SST
SPR
SST
SST
MW
MW
MW
SST
MW
SST
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
HD
SPR
MW
SST
MW
MW
MW
SST
SST
SST
MW
MW
MW
SST
MW
MW
SST
MW
MW
SST
SST
SPR
SST
SPR
MW
SST
SST
SST
MW
MW
SST
SST

E
N
D
S

F
N
S
H

C
C
CG
C
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
C
CG
C
C
C
C
C
C
C
CG
C
C
C
C
C
CG
C
C
C
CG
C
CG
CG
C
CG
C
CG
CG
C
C
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
CG
CG
C
CG
CG
CG
CG
C
C
CG
C
C
C
CG
C
C
CG
C

Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
N
Z
N
N
Z
N
N
N
N
Z
N
N
N
BO
N
N
N
N
BO
GI
N
Z
N
Z
Z
Z
N
GI
N
Z
N
N
N
N
Z
Z
N
N
Z
N
N
N
N
N
Z
N
N
N
N
N
N
Z
Z
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 39

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188

4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78

UU-5
II-26
M-40
A14-16
2970
KK-99
A10-57
B5-70
KK-12
3026
F-80
F-75
GG-49
922
B14-61
S-1161
S-1340
B1-18
L-87
S-712
B12-27
O-85
J-91
B14-23
F-51
V-86
J-58
F-77
FF-65
S-1334
V-27
F-95
H-67
Q-55
152-A
153-A
Q-69
353-A
N-37
352-A
B15-2
154-A
FF-57
V-9
10171
2597
K-85
155-A
3692
L-88
LL-55
B15-52
156-A
S-713
B10-20
1509
G-72
A-88
YY-10
W-23
LL-51
M-68
10801
3241
B9-44
B14-24
M-3
10005
GG-17
AA-91
B-50
A11-9
152-B
153-B
10225
353-B
10678
352-B
3588
UU-64

.81
.81
.81
.81
.81
.81
.84
.84
.84
.84
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.91
.91
.94
.94
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.06
1.09
1.09
1.13
1.13
1.19
1.22
1.22
1.25
1.28
1.28
1.31
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
21.4
21.4
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.0
23.0
23.0
23.8
23.8
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.0
27.8
27.8
28.6
28.6
30.2
31.0
31.0
31.8
32.5
32.5
33.3
34.1
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9

I.D.
Inches

.152
.142
.138
.136
.134
.098
.160
.156
.152
.138
.136
.122
.160
.156
.152
.144
.142
.136
.126
.124
.124
.110
.108
.154
.138
.138
.136
.124
.152
.142
.142
.124
.144
.166
.162
.160
.160
.156
.156
.152
.152
.148
.148
.148
.146
.146
.144
.142
.140
.138
.138
.138
.132
.124
.124
.144
.144
.158
.154
.138
.152
.142
.154
.120
.138
.156
.128
.142
.148
.136
.162
.134
.162
.160
.158
.156
.154
.152
.152
.152

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

3.9
3.6
3.5
3.5
3.4
2.5
4.1
4.0
3.9
3.5
3.5
3.1
4.1
4.0
3.9
3.7
3.6
3.5
3.2
3.1
3.1
2.8
2.7
3.9
3.5
3.5
3.5
3.1
3.9
3.6
3.6
3.1
3.7
4.2
4.1
4.1
4.1
4.0
4.0
3.9
3.9
3.8
3.8
3.8
3.7
3.7
3.7
3.6
3.6
3.5
3.5
3.5
3.4
3.1
3.1
3.7
3.7
4.0
3.9
3.5
3.9
3.6
3.9
3.0
3.5
4.0
3.3
3.6
3.8
3.5
4.1
3.4
4.1
4.1
4.0
4.0
3.9
3.9
3.9
3.9

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

3.4
.60
8.5
1.5
24
4.1
10
1.8
16
2.7
179
31
.86
.15
2.2
.38
1.7
.30
12
2.1
13
2.3
35
6.2
.32
.06
1.3
.24
3.1
.53
6.5
1.1
9.9
1.7
12
2.2
31
5.5
26
4.5
27
4.8
67
12
77
14
3.0
.53
8.3
1.4
11
1.9
12
2.1
29
5.1
1.5
.26
5.7
.99
6.1
1.1
25
4.4
4.1
.73
.17
.03
.99
.17
1.2
.22
.43
.07
2.0
.35
2.3
.41
3.0
.52
2.0
.35
4.2
.74
2.7
.47
2.7
.47
3.5
.61
4.2
.74
6.8
1.2
7.0
1.2
6.5
1.1
9.4
1.7
10
1.8
9.3
1.6
15
2.7
22
3.9
26
4.5
8.2
1.4
4.6
.81
.73
.13
1.8
.32
6.0
1.1
2.2
.38
5.3
.93
2.1
.36
36
6.3
12
2.2
1.4
.25
16
2.8
5.1
.89
2.5
.43
4.4
.76
.80
.14
6.5
1.1
.71
.12
.91
.16
1.3
.23
1.4
.25
1.6
.28
2.1
.37
1.7
.30
1.9
.33

.36
.45
.19
.34
.37
.09
.71
.60
.50
.39
.40
.21
.43
.60
.60
.34
.25
.41
.27
.24
.24
.17
.16
.52
.43
.43
.42
.23
.56
.44
.52
.26
.53
.77
.79
.78
.63
.66
.56
.62
.61
.60
.62
.62
.58
.63
.49
.54
.52
.48
.45
.49
.42
.28
.26
.41
.61
.76
.78
.50
.56
.48
.50
.31
.37
.91
.49
.75
.68
.37
.62
.63
1.1
1.1
.80
.92
.97
.87
1.0
.65

mm

9.2
11
4.9
8.7
9.3
2.4
18
15
13
9.9
10
5.3
11
15
15
8.6
6.5
11
6.9
6.2
6.2
4.3
3.9
13
11
11
11
5.9
14
11
13
6.7
14
20
20
20
16
17
14
16
15
15
16
16
15
16
12
14
13
12
11
12
11
7.2
6.6
10
16
19
20
13
14
12
13
7.9
9.4
23
12
19
17
9.4
16
16
28
27
20
23
25
22
25
17

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.2
3.8
4.6
3.6
5.7
17
.61
1.3
.85
4.6
5.1
7.3
.14
.81
1.8
2.2
2.5
5.1
8.5
6.2
6.7
11
12
1.6
3.6
4.6
5.1
6.7
.85
2.5
3.2
6.7
2.2
.13
.78
.97
.27
1.3
1.3
1.8
1.2
2.5
1.7
1.7
2.0
2.7
3.3
3.8
3.4
4.6
4.6
4.6
6.3
6.2
6.7
3.3
2.8
.56
1.4
3.1
1.2
2.5
1.0
11
4.6
1.3
7.7
3.8
1.7
1.6
.49
4.1
.78
.97
1.1
1.3
1.6
1.8
1.7
1.2

5.5
17
20
16
25
74
2.7
5.8
3.8
20
23
33
.61
3.6
8.2
9.8
11
23
38
28
30
50
53
6.9
16
20
23
30
3.8
11
14
30
9.8
.59
3.5
4.3
1.2
5.8
5.8
8.2
5.5
11
7.4
7.4
8.9
12
15
17
15
20
20
20
28
28
30
15
13
2.5
6.3
14
5.5
11
4.6
49
20
5.8
34
17
7.4
7.2
2.2
18
3.5
4.3
4.8
5.8
6.9
8.2
7.7
5.5

Inches

.20
.32
.19
.47
.41
.61
.14
.18
.34
.36
.39
.53
.45
.27
.21
.29
.25
.38
.43
.54
.53
.70
.72
.17
.48
.38
.41
.54
.38
.39
.41
.61
.39
.23
.14
.16
.37
.20
.18
.24
.28
.29
.36
.38
.43
.37
.31
.36
.48
.40
.38
.40
.48
.61
.59
.26
.42
.30
.28
.55
.28
.39
.23
.61
.31
.26
.63
.48
.39
.91
.15
.50
.18
.21
.20
.26
.31
.32
.38
.32

mm

Inches

5.0
8.0
4.8
11.9
10.3
15.4
3.5
4.7
8.7
9.0
9.9
13.4
11.4
6.9
5.4
7.3
6.4
9.7
11.0
13.6
13.4
17.8
18.3
4.3
12.1
9.7
10.5
13.8
9.6
9.9
10.5
15.4
9.9
5.8
3.6
4.1
9.4
5.1
4.5
6.2
7.1
7.4
9.1
9.7
10.8
9.3
7.8
9.2
12.2
10.2
9.5
10.2
12.3
15.4
15.0
6.7
10.6
7.6
7.1
14.0
7.1
9.9
5.7
15.5
7.9
6.5
16.0
12.3
9.9
23.1
3.8
12.7
4.5
5.2
5.2
6.6
7.8
8.1
9.6
8.0

0.018
0.023
0.025
0.026
0.027
0.045
0.014
0.016
0.018
0.025
0.026
0.033
0.014
0.016
0.018
0.022
0.023
0.026
0.031
0.032
0.032
0.039
0.040
0.017
0.025
0.025
0.026
0.032
0.018
0.023
0.023
0.032
0.022
0.011
0.013
0.014
0.014
0.016
0.016
0.018
0.018
0.020
0.020
0.020
0.021
0.021
0.022
0.023
0.024
0.025
0.025
0.025
0.028
0.032
0.032
0.022
0.022
0.015
0.017
0.025
0.018
0.023
0.017
0.034
0.025
0.016
0.030
0.023
0.020
0.026
0.013
0.027
0.013
0.014
0.015
0.016
0.017
0.018
0.018
0.018

mm

TOTAL
MATL
COILS

0.5
0.6
0.6
0.7
0.7
1.1
0.4
0.4
0.5
0.6
0.7
0.8
0.4
0.4
0.5
0.6
0.6
0.7
0.8
0.8
0.8
1.0
1.0
0.4
0.6
0.6
0.7
0.8
0.5
0.6
0.6
0.8
0.6
0.3
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.7
0.8
0.8
0.6
0.6
0.4
0.4
0.6
0.5
0.6
0.4
0.9
0.6
0.4
0.8
0.6
0.5
0.7
0.3
0.7
0.3
0.4
0.4
0.4
0.4
0.5
0.5
0.5

10.0
12.8
7.50
17.0
14.0
13.5
8.75
10.5
18.0
13.3
14.0
15.0
31.0
16.0
10.8
12.0
10.0
14.8
13.0
15.8
16.5
17.0
17.0
10.0
18.0
14.3
14.9
16.0
20.0
16.0
17.0
18.0
17.8
21.0
9.75
10.5
26.5
11.5
10.0
12.5
15.5
13.5
18.0
18.0
19.3
16.5
13.0
14.8
19.0
16.0
15.0
16.0
16.3
18.0
17.5
11.0
18.0
19.0
15.5
21.0
14.5
17.0
12.3
17.0
12.5
15.0
21.0
20.0
19.5
34.0
10.5
17.5
12.8
13.8
12.5
15.3
17.0
16.8
20.0
16.5

SST
MW
MW
MW
MW
SPR
PB
MW
SST
MW
MW
HD
SST
MW
MW
SST
SST
MW
MW
SST
SPR
SPR
SPR
MW
MW
MW
MW
SPR
SST
SST
MW
SPR
SST
SST
MW
MW
MW
MW
MW
MW
SST
MW
SST
SST
MW
MW
MW
MW
MW
MW
MW
MW
MW
SST
SPR
MW
MW
SST
MW
SST
SST
SST
SST
MW
MW
MW
MW
MW
SST
SST
SST
PB
MW
MW
MW
MW
MW
MW
MW
SST

E
N
D
S

C
C
CG
C
C
CG
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
CG
C
C
CG
C
C
C
C
C
C
C
C
CG
C
C
C
CG
C
C
C
CG
C
CG
C
C
C
C
C
C
CG
CG
CG
C
C
C/G
C
C
C
C
C
C
CG
C
C
CG
C
CG
C
CG
C
C
C
C
C
C
C
C
C
C
C

F
N
S
H

N
N
Z
Z
GI
Z
N
N
N
Z
Z
Z
N
Z
Z
N
N
N
N
N
Z
N
N
N
Z
N
Z
Z
N
N
N
Z
N
N
Z
Z
N
Z
Z
Z
N
Z
N
N
Z
Z
Z
Z
Z
N
Z
N
Z
N
N
Z
Z
N
Z
N
N
N
N
Z
Z
N
N
Z
N
N
N
N
Z
Z
Z
Z
Z
Z
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

39

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 40

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.188
0.195
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203

4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.78
4.95
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16

154-B
GG-28
B9-70
Q-19
155-B
S-1157
156-B
12024
S-1105
J-74
A10-61
S-1317
S-1071
923
B2-17
11194
11264
11206
Z-3
11240
N-122
EE-47
152-C
153-C
353-C
352-C
154-C
2503
NN-34
PP-84
155-C
11407
156-C
A15-48
10003
2631
Y-86
S-1351
N-50
EE-14
B14-42
JJ-87
3575
N-27
S-1237
TT-44
B15-43
V V-54
O-72
B4-62
N-75
G-74
Z-66
3706
DD-4
V-13
W-29
10918
O-109
S-1255
2521
DD-54
GG-44
CC-49
W-21
MM-50
NN-37
PP-66
AA-19
B-93
M-36
Z-70
10900
O-88
DD-62
10839
GG-61
GG-59
S-1578
A12-25

1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.44
1.44
1.44
1.44
1.44
1.50
1.50
1.50
1.50
1.56
1.63
1.63
1.69
1.69
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.88
1.88
1.88
1.88
1.94
2.00
2.25
2.25
2.50
2.53
2.75
2.75
3.00
3.13
4.00
.47
.13
.19
.25
.25
.28
.28
.28
.31
.31
.31
.31
.31
.34
.38
.38
.38
.38
.38
.41
.44
.44
.44
.47
.47
.47
.47
.47
.47
.47
.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
36.5
36.5
36.5
36.5
36.5
38.1
38.1
38.1
38.1
39.7
41.3
41.3
42.8
42.8
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
47.6
47.6
47.6
47.6
49.2
50.8
57.2
57.2
63.5
64.3
69.9
69.9
76.2
79.4
101.6
11.9
3.2
4.8
6.4
6.4
7.1
7.1
7.1
7.9
7.9
7.9
7.9
7.9
8.7
9.5
9.5
9.5
9.5
9.5
10.3
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
11.9
11.9
12.7

MATERIAL: MW - Music Wire

40

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.148
.148
.148
.144
.142
.138
.132
.150
.152
.138
.136
.134
.132
.148
.148
.138
.124
.138
.168
.128
.148
.128
.162
.160
.156
.152
.148
.148
.148
.146
.142
.136
.132
.122
.142
.130
.122
.118
.138
.168
.160
.130
.130
.150
.128
.128
.136
.140
.148
.171
.163
.175
.187
.123
.169
.143
.123
.173
.167
.167
.143
.131
.167
.163
.163
.159
.153
.153
.143
.163
.153
.143
.179
.175
.163
.159
.151
.143
.137
.181

RATE
mm

3.8
3.8
3.8
3.7
3.6
3.5
3.4
3.8
3.9
3.5
3.5
3.4
3.4
3.8
3.8
3.5
3.1
3.5
4.3
3.3
3.8
3.3
4.1
4.1
4.0
3.9
3.8
3.8
3.8
3.7
3.6
3.5
3.4
3.1
3.6
3.3
3.1
3.0
3.5
4.3
4.1
3.3
3.3
3.8
3.3
3.3
3.5
3.6
3.8
4.3
4.1
4.4
4.7
3.1
4.3
3.6
3.1
4.4
4.2
4.2
3.6
3.3
4.2
4.1
4.1
4.0
3.9
3.9
3.6
4.1
3.9
3.6
4.5
4.4
4.1
4.0
3.8
3.6
3.5
4.6

Lbs./In.

3.0
2.7
2.9
4.1
5.0
6.4
11
2.3
.94
5.6
5.2
7.5
8.0
2.1
1.8
5.6
19
5.8
.15
11
2.5
25
.56
.69
1.1
1.7
2.3
3.5
2.1
2.4
3.9
6.4
8.3
25
4.4
8.3
18
24
4.7
.08
.50
6.0
5.5
1.3
5.8
6.8
2.7
2.2
1.1
1.1
33
2.2
.09
283
1.8
65
246
2.2
7.9
14
100
158
2.3
7.7
5.4
11
16
14
23
8.3
12
44
.95
1.0
6.5
6.9
13
32
62
.60

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.53
.47
.50
.72
.87
1.1
1.9
.40
.16
.98
.91
1.3
1.4
.38
.31
.98
3.4
1.0
.03
1.9
.43
4.3
.10
.12
.19
.29
.41
.61
.37
.42
.68
1.1
1.5
4.4
.77
1.5
3.2
4.3
.83
.01
.09
1.0
.96
.23
1.0
1.2
.47
.39
.19
.19
5.8
.38
.02
50
.32
11
43
.38
1.4
2.4
18
28
.41
1.3
.95
2.0
2.8
2.5
4.1
1.5
2.2
7.8
.17
.18
1.1
1.2
2.3
5.6
11
.10

.83
.93
.88
.81
.76
.48
.59
.63
.86
.54
.66
.51
.53
.98
.90
.54
.49
.53
1.4
.71
1.0
.31
1.4
1.4
1.2
1.1
1.1
.73
1.2
1.2
.97
.79
.76
.27
.86
.84
.40
.32
.97
1.7
1.9
.92
1.1
1.7
.89
1.1
1.4
1.3
1.6
.36
.05
.10
.16
.04
.08
.07
.04
.19
.20
.08
.07
.05
.13
.20
.22
.20
.16
.15
.06
.28
.19
.11
.38
.32
.24
.24
.18
.17
.10
.41

mm

21
24
22
21
19
12
15
16
22
14
17
13
14
25
23
14
12
13
36
18
26
8.0
35
36
30
28
27
18
30
29
25
20
19
6.9
22
21
10
8.1
25
43
49
23
27
42
23
29
36
33
40
9.0
1.1
2.6
4.0
1.0
2.0
1.9
1.1
4.9
5.2
2.1
1.8
1.4
3.2
5.1
5.5
5.1
4.1
3.8
1.5
7.1
4.8
2.8
9.7
8.0
6.1
6.2
4.6
4.3
2.6
10

Lbs.

2.5
2.5
2.5
3.3
3.8
3.1
6.3
1.4
.81
3.1
3.4
3.8
4.2
2.1
1.6
3.1
9.3
3.1
.21
7.7
2.5
7.7
.78
.97
1.3
1.8
2.5
2.5
2.5
2.8
3.8
5.1
6.3
6.8
3.8
7.0
7.3
7.7
4.6
.13
.96
5.5
5.8
2.2
5.2
7.7
3.8
2.9
1.7
.38
1.5
.22
.01
11
.14
4.8
11
.42
1.6
1.1
7.2
8.4
.30
1.6
1.2
2.3
2.6
2.1
1.4
2.3
2.3
4.8
.36
.33
1.6
1.7
2.3
5.4
6.4
.25

ENDS: C - Closed

G - Ground
O - Open

11
11
11
15
17
14
28
6.4
3.6
14
15
17
19
9.4
7.2
14
41
14
.95
34
11
34
3.5
4.3
5.8
8.2
11
11
11
12
17
23
28
30
17
31
33
34
20
.56
4.2
24
26
9.6
23
34
17
13
7.4
1.7
6.7
.98
.07
50
.63
22
47
1.9
7.2
5.1
32
37
1.3
6.9
5.2
10
11
9.5
6.4
10
10
22
1.6
1.5
6.9
7.4
10
24
28
1.1

Inches

.38
.40
.38
.46
.48
.53
.65
.34
.58
.56
.78
.63
.76
.52
.60
.56
.76
.55
.20
.90
.46
.45
.22
.26
.32
.39
.48
.34
.52
.60
.60
.70
.81
.61
.52
.96
.94
.84
.78
.32
.34
1.33
1.45
.61
1.44
1.41
1.59
1.10
.86
.07
.08
.09
.09
.20
.20
.15
.20
.12
.11
.08
.16
.20
.22
.15
.16
.18
.21
.23
.35
.15
.25
.20
.08
.15
.16
.23
.29
.30
.23
.09

mm

9.7
10.2
9.7
11.7
12.3
13.3
16.5
8.7
14.6
14.3
19.8
16.1
19.2
13.2
15.2
14.3
19.3
14.0
5.1
22.9
11.7
11.4
5.5
6.5
8.1
9.9
12.1
8.6
13.2
15.2
15.2
17.8
20.6
15.5
13.3
24.3
23.9
21.3
19.7
8.1
8.5
33.9
36.8
15.4
36.6
35.8
40.3
28.0
21.8
1.8
2.0
2.2
2.3
5.1
5.2
3.8
5.1
3.0
2.7
2.1
4.0
5.0
5.5
3.7
4.1
4.5
5.4
5.7
8.8
3.8
6.4
5.0
2.1
3.9
4.1
5.7
7.3
7.6
5.9
2.2

WIRE DIA.
Inches

0.020
0.020
0.020
0.022
0.023
0.025
0.028
0.019
0.018
0.025
0.026
0.027
0.028
0.020
0.020
0.025
0.032
0.025
0.010
0.030
0.020
0.030
0.013
0.014
0.016
0.018
0.020
0.020
0.020
0.021
0.023
0.026
0.028
0.033
0.023
0.029
0.033
0.035
0.025
0.010
0.014
0.029
0.029
0.019
0.030
0.030
0.026
0.024
0.020
0.012
0.020
0.014
0.008
0.040
0.017
0.030
0.040
0.015
0.018
0.018
0.030
0.036
0.018
0.020
0.020
0.022
0.025
0.025
0.030
0.020
0.025
0.030
0.012
0.014
0.020
0.022
0.026
0.030
0.033
0.011

mm

TOTAL
MATL
COILS

0.5
0.5
0.5
0.6
0.6
0.6
0.7
0.5
0.5
0.6
0.7
0.7
0.7
0.5
0.5
0.6
0.8
0.6
0.3
0.8
0.5
0.8
0.3
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.6
0.7
0.7
0.8
0.6
0.7
0.8
0.9
0.6
0.3
0.4
0.7
0.7
0.5
0.8
0.8
0.7
0.6
0.5
0.3
0.5
0.4
0.2
1.0
0.4
0.8
1.0
0.4
0.5
0.5
0.8
0.9
0.5
0.5
0.5
0.6
0.6
0.6
0.8
0.5
0.6
0.8
0.3
0.4
0.5
0.6
0.7
0.8
0.8
0.3

18.0
20.0
19.0
20.0
20.0
20.0
22.3
17.0
31.0
22.5
29.0
23.5
26.0
25.0
29.0
22.5
22.8
22.0
19.0
29.0
22.0
14.0
15.8
17.3
19.0
20.8
22.8
16.0
25.0
27.5
25.0
26.0
28.0
18.5
22.8
33.0
27.5
24.0
30.0
32.0
23.0
45.0
49.0
32.0
47.0
46.0
60.0
45.0
42.0
6.00
3.00
5.25
10.5
5.00
11.0
5.00
5.00
7.00
5.00
3.50
4.25
4.50
11.0
6.25
8.00
7.00
7.50
9.00
10.5
6.50
10.0
6.50
6.00
9.88
7.00
10.3
10.0
9.00
7.00
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
MW
MW
MW
SST
MW
SST
SST
SST
SST
SST
SST
MW
MW
SST
MW
SST
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
MW
SST
MW
MW
SPR
SST
MW
SST
MW
MW
MW
MW
SST
MW
MW
SST
SST
SST
SST
SST
MW
SPR
SST
SST
SST
MW
MW
SST
MW
SPR
SST
SST
SST
MW
SST
MW
SST
MW
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

F
N
S
H

C
CG
CG
C
C
C
C
C
C
CG
C
CG
C
C
C
CG
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
CG
CG
C
CG
C
CG
C
C
C
CG
C
C
C
C
C
CG
C
C
C
CG
C
CG
CG
C
C
C
C
C
C
C
CG
C
C
CG
C
C
CG
CG
C
C
C
CG
C
C
CG
C

Z
N
Z
Z
Z
N
Z
N
N
N
N
N
N
Z
N
N
N
N
N
Z
N
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
N
Z
Z
N
N
Z
N
Z
BO
Z
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
GI
Z
N
Z
Z
N
N
N
GI
N
BO
N
N
N
N
N
Z
N
GI
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 41

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203

5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16

B18-190
S-1552
S-1083
B12-54
HH-34
H-80
B14-4
G-61
S-1380
B8-21
NN-93
O-81
N-110
G-26
B15-30
Q-7
2501
LL-43
LL-56
3997
W-78
EE-42
GG-32
11428
Q-23
OO-82
A13-53
2748
3782
B4-10
A10-23
JJ-71
MM-3
CC-38
RR-38
BB-84
S-1120
B10-12
AA-23
O-19
AA-1
A11-7
B-95
4291
4171
NN-45
3290
Z-83
B10-17
HH-10
FF-34
BB-24
3235
J-79
II-42
K-98
FF-49
B12-51
B4-16
L-94
HH-95
AA-38
J-31
A-14
12535
2561
3249
B-1
S-1500
B2-35
12692
11459
HH-8
I-81
A15-63
2811
S-839
A13-60
Z-35
B10-43

.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.56
.56
.56
.56
.56
.56
.56
.59
.63
.63
.63
.63
.63
.63
.63
.69
.69
.69
.69
.69
.69
.69
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.81
.81
.81
.84
.84
.88
.88
.88
.94
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.13
1.13

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
23.8
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
27.0
27.0
27.0
27.0
27.0
27.0
27.0
28.6
28.6

I.D.
Inches

.181
.179
.175
.175
.173
.165
.165
.163
.159
.157
.155
.155
.153
.143
.139
.123
.143
.171
.171
.161
.139
.137
.123
.101
.167
.179
.173
.155
.155
.153
.147
.123
.179
.173
.171
.149
.147
.131
.123
.153
.143
.121
.179
.173
.165
.163
.159
.159
.153
.151
.143
.123
.149
.127
.163
.163
.143
.163
.147
.173
.143
.133
.159
.183
.147
.167
.151
.145
.145
.141
.139
.177
.153
.153
.151
.147
.143
.139
.145
.141

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

4.6
4.5
4.4
4.4
4.4
4.2
4.2
4.1
4.0
4.0
3.9
3.9
3.9
3.6
3.5
3.1
3.6
4.3
4.3
4.1
3.5
3.5
3.1
2.6
4.2
4.5
4.4
3.9
3.9
3.9
3.7
3.1
4.5
4.4
4.3
3.8
3.7
3.3
3.1
3.9
3.6
3.1
4.5
4.4
4.2
4.1
4.0
4.0
3.9
3.8
3.6
3.1
3.8
3.2
4.1
4.1
3.6
4.1
3.7
4.4
3.6
3.4
4.0
4.6
3.7
4.2
3.8
3.7
3.7
3.6
3.5
4.5
3.9
3.9
3.8
3.7
3.6
3.5
3.7
3.6

Lbs./In.

.66
.99
.68
.74
1.1
4.4
4.0
5.4
9.9
8.6
12
18
18
28
38
121
32
2.4
2.1
7.1
35
43
84
427
2.2
.48
1.9
18
8.3
9.1
15
142
.62
.95
1.2
18
17
175
85
11
22
94
.71
.91
5.5
1.8
7.6
4.4
18
11
21
57
12
58
4.7
2.7
15
1.7
11
.52
16
40
5.2
.09
16
2.5
8.8
10
23
17
24
.71
5.8
6.2
9.9
8.2
9.9
13
8.4
27

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.12
.17
.12
.13
.19
.76
.70
.95
1.7
1.5
2.1
3.1
3.2
4.9
6.7
21
5.6
.42
.37
1.2
6.0
7.6
15
75
.38
.08
.32
3.2
1.5
1.6
2.7
25
.11
.17
.21
3.1
3.0
31
15
1.9
3.9
16
.12
.16
.96
.32
1.3
.76
3.2
2.0
3.7
10
2.0
10
.82
.47
2.7
.30
2.0
.09
2.9
6.9
.90
.02
2.9
.44
1.5
1.8
4.1
3.0
4.2
.12
1.0
1.1
1.7
1.4
1.7
2.3
1.5
4.7

.42
.36
.31
.32
.31
.31
.30
.29
.21
.27
.26
.23
.23
.17
.15
.09
.22
.42
.39
.36
.17
.16
.12
.05
.36
.48
.36
.22
.31
.31
.26
.08
.58
.49
.45
.30
.23
.05
.13
.38
.32
.12
.64
.53
.37
.33
.41
.42
.23
.28
.23
.15
.38
.16
.50
.47
.32
.36
.35
.52
.30
.20
.60
.74
.36
.68
.54
.42
.19
.44
.24
.65
.49
.46
.48
.45
.40
.36
.46
.30

mm

11
9.3
7.9
8.1
7.7
7.8
7.6
7.3
5.3
6.9
6.6
5.8
6.0
4.3
3.9
2.4
5.7
11
9.8
9.2
4.3
4.0
3.1
1.2
9.1
12
9.1
5.5
8.0
7.9
6.5
2.0
15
12
11
7.7
6.0
1.2
3.4
9.8
8.2
3.1
16
13
9.3
8.4
10
11
6.0
7.1
5.9
3.8
9.6
4.0
13
12
8.0
9.2
8.8
13
7.5
5.0
15
19
9.1
17
14
11
4.8
11
6.2
16
13
12
12
11
10
9.1
12
7.5

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.28
.36
.21
.24
.33
1.3
1.2
1.6
2.1
2.3
3.1
4.0
4.2
4.8
5.8
11
7.2
1.0
.80
2.6
5.8
6.8
10
19
.78
.23
.66
4.0
2.6
2.8
4.0
11
.36
.47
.54
5.3
4.0
8.4
11
4.2
7.2
11
.46
.48
2.0
.61
3.1
1.8
4.2
3.2
4.8
8.5
4.4
9.2
2.3
1.3
4.8
.62
4.0
.27
4.8
7.7
3.1
.07
5.9
1.7
4.8
4.4
4.4
7.7
5.8
.46
2.8
2.8
4.8
3.7
3.9
4.8
3.8
7.9

1.2
1.6
.94
1.1
1.5
5.9
5.4
6.9
9.2
10
14
18
19
21
26
50
32
4.5
3.6
12
26
30
45
87
3.5
1.0
3.0
18
12
13
18
50
1.6
2.1
2.4
24
18
37
50
19
32
51
2.0
2.1
8.9
2.7
14
8.2
19
14
22
38
20
41
10
5.6
22
2.8
18
1.2
22
34
14
.29
26
7.6
21
19
19
34
26
2.0
13
13
21
16
18
21
17
35

Inches

.08
.08
.19
.18
.20
.15
.20
.18
.18
.23
.24
.16
.19
.33
.29
.36
.30
.14
.14
.20
.31
.33
.44
.40
.23
.14
.12
.18
.31
.29
.32
.32
.11
.20
.24
.30
.32
.18
.48
.28
.36
.45
.11
.23
.16
.42
.23
.33
.19
.31
.38
.60
.41
.46
.22
.34
.45
.48
.41
.36
.45
.47
.31
.23
.36
.23
.43
.52
.31
.56
.45
.14
.45
.40
.36
.62
.66
.70
.67
.36

mm

Inches

2.0
2.1
4.8
4.6
5.0
3.9
5.1
4.6
4.5
5.8
6.1
4.1
4.8
8.4
7.3
9.1
7.6
3.7
3.7
5.1
7.9
8.4
11.2
10.0
5.9
3.7
3.1
4.6
7.9
7.3
8.2
8.1
2.7
5.0
6.1
7.5
8.2
4.6
12.2
7.0
9.1
11.5
2.7
5.7
4.1
10.7
5.9
8.4
4.8
7.9
9.5
15.2
10.3
11.6
5.6
8.6
11.4
12.2
10.3
9.1
11.4
12.0
7.8
5.8
9.2
5.7
10.9
13.3
7.8
14.2
11.4
3.5
11.4
10.2
9.2
15.6
16.9
17.9
16.9
9.3

0.011
0.012
0.014
0.014
0.015
0.019
0.019
0.020
0.022
0.023
0.024
0.024
0.025
0.030
0.032
0.040
0.030
0.016
0.016
0.021
0.032
0.033
0.040
0.051
0.018
0.012
0.015
0.024
0.024
0.025
0.028
0.040
0.012
0.015
0.016
0.027
0.028
0.036
0.040
0.025
0.030
0.041
0.012
0.015
0.019
0.020
0.022
0.022
0.025
0.026
0.030
0.040
0.027
0.038
0.020
0.020
0.030
0.020
0.028
0.015
0.030
0.035
0.022
0.010
0.028
0.018
0.026
0.029
0.029
0.031
0.032
0.013
0.025
0.025
0.026
0.028
0.030
0.032
0.029
0.031

mm

TOTAL
MATL
COILS

0.3
0.3
0.4
0.4
0.4
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.8
0.8
1.0
0.8
0.4
0.4
0.5
0.8
0.8
1.0
1.3
0.5
0.3
0.4
0.6
0.6
0.6
0.7
1.0
0.3
0.4
0.4
0.7
0.7
0.9
1.0
0.6
0.8
1.0
0.3
0.4
0.5
0.5
0.6
0.6
0.6
0.7
0.8
1.0
0.7
1.0
0.5
0.5
0.8
0.5
0.7
0.4
0.8
0.9
0.6
0.3
0.7
0.5
0.7
0.7
0.7
0.8
0.8
0.3
0.6
0.6
0.7
0.7
0.8
0.8
0.7
0.8

6.00
5.75
12.5
13.0
12.0
8.00
9.50
8.00
7.00
10.0
9.00
6.75
7.50
10.0
9.00
9.00
9.00
8.00
8.00
8.50
9.75
10.0
11.0
7.75
13.0
11.0
7.25
6.50
12.0
11.5
11.5
8.00
8.00
12.0
14.0
10.0
10.5
5.00
12.0
11.0
12.0
11.0
8.00
14.0
7.50
20.0
9.50
15.0
7.50
11.0
11.5
15.0
14.0
12.0
10.0
16.0
15.0
24.0
14.5
23.0
14.0
13.5
13.0
22.0
12.0
11.5
15.5
18.0
11.0
17.0
13.0
9.50
17.0
16.0
14.0
22.0
22.1
22.0
22.0
11.8

SST
SST
SST
MW
MW
SST
MW
SST
SST
MW
MW
MW
MW
MW
SST
SPR
MW
MW
SST
MW
SST
SPR
SST
SST
MW
MW
SST
MW
MW
SST
SST
SPR
SST
SST
MW
MW
SST
SPR
SPR
MW
MW
SST
MW
MW
MW
SST
MW
MW
MW
SST
SST
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
MW
MW
SST
SST
MW
SST
SST
SST
SST
MW
MW
SST
SST
SST
MW

E
N
D
S

C
C
C
CG
C
CG
C
C
C
CG
C
CG
C
C
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
C
C
C
C
C
CG
CG
CG
CG
CG
C
C
C
C
C
CG
CG
C
C
CG
C
CG
C
C
CG
CG
CG
C
C
CG
C
C
C
C
C
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
C
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
Z
Z
N
N
Z
N
N
N
N
N
Z
N
Z
Z
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
Z
Z
N
Z
Z
N
N
N
N
Z
N
GI
Z
N
N
N
Z
N
Z
N
N
N
Z
Z
N
N
N
N
N
N
N
N
Z
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

41

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 42

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.203
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210

5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.16
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33

PP-23
12285
V V-23
BB-26
B2-25
W-74
Q-90
S-481
3201
10754
V-5
10026
3012
2884
10891
12018
S-3140
70460
70460S
70476
70476S
70498
70498S
70461
70461S
70477
70477S
70499
70499S
70462
70462S
70478
70478S
70500
70500S
70463
70463S
70479
70479S
70501
70501S
70464
70464S
70480
70480S
70502
70502S
70465
70465S
70481
70481S
70503
70503S
70466
70466S
70482
70482S
70504
70504S
12549
70467
70467S
70483
70483S
70505
70505S
70468
70468S
70484
70484S
70506
70506S
70469
70469S
70485
70485S
70507
70507S
70470
70470S

1.16
1.19
1.22
1.22
1.25
1.25
1.31
1.31
1.34
1.41
1.50
1.50
1.56
1.75
1.78
2.25
4.00
.25
.25
.25
.25
.25
.25
.31
.31
.31
.31
.31
.31
.38
.38
.38
.38
.38
.38
.44
.44
.44
.44
.44
.44
.50
.50
.50
.50
.50
.50
.56
.56
.56
.56
.56
.56
.63
.63
.63
.63
.63
.63
.67
.69
.69
.69
.69
.69
.69
.75
.75
.75
.75
.75
.75
.81
.81
.81
.81
.81
.81
.88
.88

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

29.4
30.2
31.0
31.0
31.8
31.8
33.3
33.3
34.1
35.7
38.1
38.1
39.7
44.5
45.2
57.2
101.6
6.4
6.4
6.4
6.4
6.4
6.4
7.9
7.9
7.9
7.9
7.9
7.9
9.7
9.7
9.7
9.7
9.7
9.7
11.2
11.2
11.2
11.2
11.2
11.2
12.7
12.7
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
14.2
14.2
16.0
16.0
16.0
16.0
16.0
16.0
17.1
17.5
17.5
17.5
17.5
17.5
17.5
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6
20.6
20.6
22.4
22.4

MATERIAL: MW - Music Wire

42

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.133
.123
.143
.143
.157
.143
.171
.165
.163
.141
.153
.151
.155
.159
.153
.101
.143
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.170
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174

RATE
mm

3.4
3.1
3.6
3.6
4.0
3.6
4.3
4.2
4.1
3.6
3.9
3.8
3.9
4.0
3.9
2.6
3.6
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.3
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

29
5.1
61
11
14
2.5
10
1.7
5.5
.97
9.8
1.7
.82
.14
1.4
.25
2.7
.47
9.3
1.6
5.0
.87
7.4
1.3
4.6
.81
2.5
.44
3.0
.53
107
19
3.3
.57
11
1.9
9.4
1.6
22
3.8
18
3.2
41
7.2
35
6.1
8.6
1.5
7.3
1.3
17
2.9
14
2.5
32
5.5
27
4.7
6.8
1.2
5.8
1.0
13
2.3
11
2.0
25
4.4
21
3.7
5.8
1.0
4.9
.86
11
2.0
9.7
1.7
21
3.7
18
3.1
5.1
.89
4.3
.76
9.9
1.7
8.4
1.5
18
3.2
16
2.7
4.5
.79
3.8
.67
8.7
1.5
7.4
1.3
16
2.8
14
2.4
4.0
.70
3.4
.60
7.8
1.4
6.6
1.2
14
2.5
12
2.1
5.6
.98
3.6
.63
3.1
.54
6.9
1.2
5.9
1.0
13
2.3
11
1.9
3.3
.58
2.8
.49
6.3
1.1
5.4
.94
12
2.1
10
1.7
3.0
.53
2.6
.45
5.8
1.0
5.0
.87
11
1.9
9.1
1.6
2.8
.49
2.4
.42

.26
.19
.51
.48
.64
.49
1.0
.92
.87
.54
.85
.64
.87
1.2
.91
.19
1.5
.15
.12
.14
.11
.11
.09
.19
.15
.18
.14
.15
.12
.24
.19
.22
.18
.18
.15
.29
.22
.26
.21
.22
.17
.33
.25
.30
.24
.25
.20
.37
.29
.35
.27
.29
.23
.41
.32
.39
.30
.33
.26
.41
.46
.36
.43
.34
.36
.28
.50
.39
.48
.37
.39
.31
.55
.43
.51
.40
.43
.34
.59
.46

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

6.7
4.7
13
12
16
13
25
23
22
14
22
16
22
30
23
4.9
38
3.8
3.0
3.5
2.7
2.8
2.2
4.9
3.8
4.5
3.6
3.7
2.9
6.2
4.8
5.7
4.5
4.7
3.7
7.3
5.7
6.7
5.2
5.5
4.4
8.3
6.5
7.7
6.0
6.4
5.1
9.4
7.3
8.8
6.9
7.3
5.7
11
8.2
9.8
7.7
8.3
6.5
10
12
9.2
11
8.6
9.1
7.2
13
10
12
9.5
10
7.9
14
11
13
10
11
8.6
15
12

Lbs.

7.7
11
7.2
4.8
3.5
4.8
.82
1.3
2.3
5.0
4.2
4.8
4.0
3.0
2.7
21
4.8
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
2.3
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1

ENDS: C - Closed

G - Ground
O - Open

34
50
32
22
16
22
3.7
5.8
10
22
19
21
18
13
12
92
22
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
10
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9

Inches

.65
.68
.57
.66
.36
.69
.31
.39
.34
.87
.58
.49
.50
.56
.88
1.43
1.89
.07
.07
.10
.10
.12
.12
.08
.08
.11
.11
.14
.14
.09
.09
.13
.13
.16
.16
.10
.10
.14
.14
.18
.18
.11
.11
.16
.16
.20
.20
.12
.12
.17
.17
.22
.22
.13
.13
.19
.19
.24
.24
.18
.14
.14
.21
.21
.27
.27
.15
.15
.22
.22
.29
.29
.16
.16
.24
.24
.31
.31
.17
.17

mm

16.4
17.3
14.5
16.8
9.1
17.5
7.9
9.9
8.6
22.0
14.6
12.5
12.8
14.2
22.2
36.3
48.0
1.8
1.8
2.4
2.4
3.0
3.0
2.1
2.1
2.8
2.8
3.5
3.5
2.3
2.3
3.2
3.2
4.1
4.1
2.6
2.6
3.6
3.6
4.6
4.6
2.8
2.8
4.0
4.0
5.1
5.1
3.1
3.1
4.4
4.4
5.6
5.6
3.4
3.4
4.7
4.7
6.2
6.2
4.6
3.6
3.6
5.2
5.2
6.8
6.8
3.9
3.9
5.6
5.6
7.3
7.3
4.2
4.2
6.0
6.0
7.8
7.8
4.4
4.4

WIRE DIA.
Inches

0.035
0.040
0.030
0.030
0.023
0.030
0.016
0.019
0.020
0.031
0.025
0.026
0.024
0.022
0.025
0.051
0.030
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.020
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018

mm

TOTAL
MATL
COILS

0.9
1.0
0.8
0.8
0.6
0.8
0.4
0.5
0.5
0.8
0.6
0.7
0.6
0.6
0.6
1.3
0.8
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5

17.5
16.0
18.0
22.0
14.5
22.0
19.5
20.5
16.0
27.0
22.0
18.0
20.0
24.5
35.0
28.0
62.0
4.00
4.00
4.38
4.38
4.50
4.50
4.50
4.50
5.00
5.00
5.38
5.38
5.13
5.13
5.75
5.75
6.25
6.25
5.63
5.63
6.50
6.50
7.00
7.00
6.13
6.13
7.13
7.13
7.75
7.75
6.75
6.75
7.88
7.88
8.50
8.50
7.38
7.38
8.50
8.50
9.38
9.38
8.00
7.88
7.88
9.38
9.38
10.3
10.3
8.50
8.50
10.0
10.0
11.0
11.0
9.13
9.13
10.8
10.8
11.8
11.8
9.63
9.63

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
MW
MW
MW
SPR
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

C
C
C
CG
C
C
CG
CG
C
C
C
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
Z
N
N
N
Z
N
Z
Z
Z
GI
GI
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 43

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.210
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219

5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.33
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56

70486
70486S
70508
70508S
70488
70488S
70510
70510S
70471
70471S
70489
70489S
70511
70511S
70491
70491S
70513
70513S
70472
70472S
70492
70492S
70514
70514S
70494
70494S
70516
70516S
70473
70473S
70495
70495S
70517
70517S
70474
70474S
70496
70496S
70518
70518S
70475
70475S
70497
70497S
70519
70519S
S-863
MM-39
II-38
G-21
S-1531
S-1547
A-15
B9-29
I-67
A10-18
S-1553
B14-38
10355
S-1342
Q-6
EE-12
BB-7
HH-39
LL-41
10690
B14-17
3883
M-34
G-12
QQ-14
J-73
12754
PP-90
A13-54
U-98
2626
B9-33
B-16
3992

.88
.88
.88
.88
.94
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.13
1.13
1.13
1.13
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
.22
.25
.25
.31
.31
.31
.31
.31
.31
.31
.33
.34
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.41
.41
.41
.42
.44
.44
.44
.44
.44
.44
.44

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

22.4
22.4
22.4
22.4
23.9
23.9
23.9
23.9
25.4
25.4
25.4
25.4
25.4
25.4
28.7
28.7
28.7
28.7
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
5.6
6.4
6.4
7.9
7.9
7.9
7.9
7.9
7.9
7.9
8.3
8.7
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.7
11.1
11.1
11.1
11.1
11.1
11.1
11.1

I.D.
Inches

.166
.166
.158
.158
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.174
.174
.166
.166
.158
.158
.179
.179
.173
.197
.195
.193
.179
.177
.169
.167
.195
.179
.185
.177
.175
.159
.145
.139
.199
.181
.179
.165
.161
.157
.143
.137
.171
.199
.191
.183
.181
.181
.175
.169

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

4.2
4.2
4.0
4.0
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.4
4.4
4.2
4.2
4.0
4.0
4.5
4.5
4.4
5.0
5.0
4.9
4.5
4.5
4.3
4.2
5.0
4.5
4.7
4.5
4.4
4.0
3.7
3.5
5.1
4.6
4.5
4.2
4.1
4.0
3.6
3.5
4.3
5.1
4.9
4.6
4.6
4.6
4.4
4.3

Lbs./In.

5.8
4.9
11
8.9
5.3
4.5
9.7
8.2
2.4
2.0
4.7
4.0
8.6
7.3
4.4
3.7
8.0
6.8
1.9
1.6
3.7
3.1
6.8
5.8
3.6
3.1
6.5
5.5
1.6
1.4
3.0
2.6
5.6
4.8
1.4
1.2
2.9
2.5
5.1
4.3
1.2
1.0
2.5
2.1
4.5
3.8
13
15
15
.26
1.2
1.6
5.1
14
19
27
1.2
5.8
4.9
16
8.8
25
97
143
.20
6.9
9.7
27
66
50
126
114
9.2
.39
1.1
2.4
7.8
3.9
7.0
9.6

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.0
.86
1.8
1.6
.93
.79
1.7
1.4
.42
.36
.81
.69
1.5
1.3
.77
.65
1.4
1.2
.33
.28
.65
.55
1.2
1.0
.63
.54
1.1
.97
.28
.24
.53
.45
.99
.84
.25
.21
.51
.43
.89
.76
.21
.18
.44
.37
.79
.67
2.3
2.6
2.7
.05
.21
.29
.89
2.5
3.4
4.7
.20
1.0
.85
2.7
1.5
4.4
17
25
.03
1.2
1.7
4.7
12
8.7
22
20
1.6
.07
.19
.41
1.4
.68
1.2
1.7

.52
.40
.44
.35
.57
.44
.48
.37
.69
.54
.64
.50
.54
.42
.68
.53
.58
.45
.87
.68
.81
.63
.68
.53
.83
.65
.71
.56
1.0
.81
.99
.78
.82
.65
1.2
.93
1.0
.81
.91
.71
1.4
1.1
1.2
.94
1.0
.81
.11
.15
.11
.18
.25
.24
.15
.17
.14
.11
.26
.18
.27
.11
.20
.14
.08
.07
.30
.18
.22
.18
.06
.15
.07
.09
.18
.37
.31
.28
.24
.27
.27
.16

mm

13
10
11
8.8
14
11
12
9.5
18
14
16
13
14
11
17
14
15
12
22
17
21
16
17
14
21
17
18
14
26
21
25
20
21
16
30
24
26
21
23
18
35
27
30
24
26
21
2.8
3.8
2.8
4.6
6.2
6.1
3.9
4.4
3.5
2.8
6.7
4.6
6.9
2.7
5.1
3.4
2.1
1.9
7.5
4.6
5.7
4.7
1.6
3.8
1.8
2.4
4.6
9.3
7.9
7.0
6.1
6.8
6.9
4.1

ENDS: C - Closed

G - Ground
O - Open

Lbs.

3.0
2.0
4.6
3.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.7
1.1
3.0
2.0
4.6
3.1
1.4
2.2
1.7
.05
.29
.39
.77
2.5
2.6
3.0
.31
1.1
1.3
1.7
1.8
3.4
8.0
11
.06
1.2
2.2
5.0
4.1
7.4
9.2
11
1.7
.14
.33
.65
1.9
1.0
1.9
1.6

13
8.9
21
14
13
8.9
21
14
7.4
4.9
13
8.9
21
14
13
8.9
21
14
7.4
4.9
13
8.9
21
14
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
7.4
4.9
13
8.9
21
14
6.4
9.7
7.7
.21
1.3
1.7
3.4
11
12
13
1.4
4.8
5.9
7.4
7.8
15
35
47
.26
5.5
9.7
22
18
33
41
47
7.4
.64
1.5
2.9
8.3
4.6
8.5
7.0

Inches

.24
.24
.31
.31
.26
.26
.33
.33
.20
.20
.28
.28
.37
.37
.30
.30
.39
.39
.24
.24
.35
.35
.46
.46
.35
.35
.47
.47
.28
.28
.41
.41
.54
.54
.31
.31
.43
.43
.59
.59
.36
.36
.49
.49
.66
.66
.10
.10
.14
.13
.07
.07
.16
.09
.18
.13
.07
.16
.10
.11
.18
.24
.22
.26
.11
.11
.10
.16
.15
.19
.27
.31
.24
.07
.13
.16
.11
.17
.17
.28

mm

Inches

6.0
6.0
7.9
7.9
6.5
6.5
8.5
8.5
5.0
5.0
7.2
7.2
9.4
9.4
7.5
7.5
10.0
10.0
6.1
6.1
8.8
8.8
11.6
11.6
9.0
9.0
12.1
12.1
7.0
7.0
10.5
10.5
13.7
13.7
7.9
7.9
10.9
10.9
14.9
14.9
9.0
9.0
12.4
12.4
16.8
16.8
2.5
2.5
3.5
3.4
1.7
1.8
4.1
2.4
4.4
3.3
1.7
4.1
2.6
2.7
4.5
6.1
5.6
6.6
2.8
2.9
2.5
4.1
3.7
4.7
6.8
7.8
6.1
1.8
3.2
4.1
2.9
4.3
4.2
7.0

0.022
0.022
0.026
0.026
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.018
0.018
0.022
0.022
0.026
0.026
0.020
0.020
0.023
0.011
0.012
0.013
0.020
0.021
0.025
0.026
0.012
0.020
0.017
0.021
0.022
0.030
0.037
0.040
0.010
0.019
0.020
0.027
0.029
0.031
0.038
0.041
0.024
0.010
0.014
0.018
0.019
0.019
0.022
0.025

mm

TOTAL
MATL
COILS

0.6
0.6
0.7
0.7
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.6
0.7
0.7
0.5
0.5
0.6
0.3
0.3
0.3
0.5
0.5
0.6
0.7
0.3
0.5
0.4
0.5
0.6
0.8
0.9
1.0
0.3
0.5
0.5
0.7
0.7
0.8
1.0
1.0
0.6
0.3
0.4
0.5
0.5
0.5
0.6
0.6

10.8
10.8
12.0
12.0
11.6
11.6
12.9
12.9
10.9
10.9
12.9
12.9
14.3
14.3
13.5
13.5
15.1
15.1
13.3
13.3
15.8
15.8
17.5
17.5
16.1
16.1
18.3
18.3
15.4
15.4
18.8
18.8
20.8
20.8
17.3
17.3
19.5
19.5
22.6
22.6
19.8
19.8
22.3
22.3
25.4
25.4
4.00
4.00
5.00
11.0
4.50
4.50
7.00
4.50
6.00
5.00
4.50
7.00
5.00
4.00
7.00
8.00
6.00
6.50
10.0
5.00
5.00
6.00
4.00
6.00
6.00
7.50
9.00
6.00
8.00
9.00
5.00
8.00
7.50
10.0

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
SST
SST
MW
MW
SST
SST
MW
MW
SST
MW
SST
SST
SPR
MW
SST
MW
MW
SST
MW
SPR
SST
MW
MW
MW
SST
MW
MW
SST
MW

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
C
C
C
CG
C
CG
C
C
C
C
C
CG
CG
CG
C
C
CG
CG
C
CG
C
CG
C
C
C
CG
C
C
CG
C

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
BO
N
N
N
N
GI
N
N
N
N
N
Z
N
N
GI
Z
N
N
GI
N
Z
Z
N
N
N
N
N
Z
N
N
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

43

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 44

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219

5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56

H-71
HH-46
L-29
XX-21
B15-4
2703
A11-20
EE-86
B-66
10314
3161
H-20
10353
EE-24
KK-83
H-78
Q-4
S-858
10828
3837
Z-82
LL-31
B17-123
10583
RR-5
B7-11
BB-11
BB-95
B-81
MM-7
B9-25
A9-12
EE-99
S-192
S-1208
A10-14
11419
NN-70
Q-80
OO-27
A9-34
H-5
M-21
Q-70
S-714
2667
B14-1
3790
I-69
EE-20
MM-19
S-5
GG-68
EE-35
AA-89
MM-33
B5-68
2912
2882
S-946
A-93
NN-69
I-78
BB-46
EE-46
LL-86
B8-13
J-18
NN-31
11363
B8-12
XX-59
LL-30
G-37
1900
S-715
3544
3709
II-81
V-10

.44
.44
.44
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.53
.53
.53
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

11.1
11.1
11.1
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1

MATERIAL: MW - Music Wire

44

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.141
.139
.139
.145
.145
.143
.133
.191
.187
.179
.179
.179
.177
.175
.175
.169
.169
.165
.161
.139
.139
.119
.203
.193
.163
.163
.159
.155
.155
.139
.199
.197
.179
.161
.149
.147
.141
.179
.169
.159
.147
.189
.179
.175
.175
.171
.171
.169
.169
.159
.159
.155
.149
.119
.195
.179
.169
.167
.159
.157
.149
.193
.191
.189
.187
.183
.147
.139
.125
.125
.195
.189
.185
.179
.175
.175
.173
.169
.169
.167

RATE
mm

3.6
3.5
3.5
3.7
3.7
3.6
3.4
4.9
4.7
4.5
4.5
4.5
4.5
4.4
4.4
4.3
4.3
4.2
4.1
3.5
3.5
3.0
5.2
4.9
4.1
4.1
4.0
3.9
3.9
3.5
5.1
5.0
4.5
4.1
3.8
3.7
3.6
4.5
4.3
4.0
3.7
4.8
4.5
4.4
4.4
4.3
4.3
4.3
4.3
4.0
4.0
3.9
3.8
3.0
5.0
4.5
4.3
4.2
4.0
4.0
3.8
4.9
4.9
4.8
4.7
4.6
3.7
3.5
3.2
3.2
5.0
4.8
4.7
4.5
4.4
4.4
4.4
4.3
4.3
4.2

Lbs./In.

N/mm

107
112
214
78
72
126
200

19
20
37
14
13
22
35

.46
1.7
7.3
5.1
4.2
4.6
7.7
4.8
11
13
15
30
214
128
266
.10
1.0
18
20
17
22
41
80
.16
.17
4.2
26
38
66
67
4.9
11
19
56
.66
4.2
4.8
6.1
8.3
13
7.7
9.6
15
22
21
38
310
.27
4.9
14
12
27
27
33
.37
.24
1.2
1.1
1.3
36
71
230
153
.15
.71
.75
4.9
5.5
5.1
6.7
9.0
5.6
7.9

.08
.30
1.3
.89
.73
.81
1.3
.84
2.0
2.2
2.7
5.2
37
22
47
.02
.18
3.2
3.4
3.0
3.9
7.2
14
.03
.03
.73
4.5
6.7
11
12
.85
1.9
3.3
9.9
.12
.73
.84
1.1
1.5
2.3
1.3
1.7
2.7
3.8
3.7
6.6
54
.05
.85
2.4
2.0
4.6
4.7
5.8
.07
.04
.21
.19
.24
6.3
12
40
27
.03
.13
.13
.85
.96
.89
1.2
1.6
.98
1.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

.09
.09
.05
.10
.12
.10
.06
.29
.35
.30
.33
.32
.27
.25
.26
.24
.28
.22
.21
.05
.08
.05
.46
.43
.20
.28
.20
.18
.13
.13
.43
.40
.36
.16
.18
.12
.14
.41
.36
.24
.14
.40
.43
.38
.31
.37
.29
.30
.38
.27
.31
.23
.18
.06
.49
.45
.19
.38
.25
.19
.22
.51
.32
.54
.50
.42
.22
.15
.07
.10
.44
.53
.41
.45
.51
.38
.49
.44
.38
.37

mm

2.3
2.3
1.3
2.6
3.0
2.6
1.6
7.4
8.8
7.6
8.3
8.1
7.0
6.4
6.6
6.0
7.0
5.5
5.2
1.3
2.1
1.3
12
11
5.1
7.2
5.1
4.5
3.4
3.3
11
10
9.2
4.0
4.5
3.0
3.5
10
9.2
6.0
3.5
10
11
9.7
7.9
9.3
7.4
7.6
9.5
6.7
7.9
5.7
4.6
1.5
12
11
4.9
9.7
6.5
4.7
5.5
13
8.2
14
13
11
5.6
3.8
1.9
2.6
11
13
10
11
13
9.5
12
11
9.5
9.5

Lbs.

9.9
9.9
11
8.0
8.5
13
12
.13
.60
2.2
1.6
1.3
1.3
1.9
1.2
2.7
3.5
3.3
6.1
11
11
13
.04
.45
3.7
5.5
3.4
4.0
5.4
11
.07
.07
1.5
4.1
6.8
7.9
9.3
2.0
4.0
4.5
7.9
.26
1.8
1.8
1.9
3.0
3.7
2.3
3.6
4.1
6.7
4.7
6.8
19
.13
2.2
2.7
4.4
6.7
5.0
7.2
.19
.08
.66
.54
.56
7.8
11
17
16
.06
.38
.31
2.2
2.8
1.9
3.3
4.0
2.1
3.0

ENDS: C - Closed

G - Ground
O - Open

44
44
47
35
38
57
54
.60
2.7
9.7
7.3
5.9
5.7
8.5
5.5
12
16
15
27
47
47
59
.20
2.0
16
25
15
18
24
47
.31
.31
6.7
18
30
35
41
8.9
18
20
35
1.2
7.9
8.2
8.5
14
17
10
16
18
30
21
30
82
.59
9.7
12
20
30
22
32
.83
.35
2.9
2.4
2.5
35
47
74
70
.28
1.7
1.4
9.7
12
8.5
15
18
9.3
13

Inches

.29
.28
.20
.30
.31
.27
.30
.21
.15
.14
.18
.18
.23
.15
.24
.20
.23
.25
.23
.24
.28
.45
.08
.10
.25
.24
.33
.35
.22
.40
.13
.17
.20
.23
.35
.32
.37
.18
.23
.33
.32
.23
.20
.24
.20
.26
.19
.33
.25
.36
.30
.40
.35
.40
.17
.16
.20
.26
.29
.29
.44
.18
.36
.15
.19
.27
.47
.44
.42
.47
.31
.23
.34
.18
.24
.23
.23
.29
.38
.34

mm

7.3
7.1
5.1
7.5
7.8
6.8
7.6
5.3
3.9
3.6
4.4
4.6
5.7
3.9
6.1
5.1
5.7
6.3
5.9
6.1
7.1
11.4
1.9
2.5
6.4
6.0
8.4
8.9
5.7
10.2
3.2
4.2
5.1
5.9
8.9
8.2
9.4
4.6
5.7
8.4
8.2
5.7
5.1
6.1
5.2
6.6
4.9
8.3
6.4
9.1
7.6
10.2
8.9
10.2
4.3
4.1
5.1
6.5
7.2
7.5
11.1
4.6
9.2
3.8
4.9
6.9
11.9
11.2
10.7
11.9
7.9
5.7
8.6
4.6
6.1
5.9
5.8
7.3
9.5
8.6

WIRE DIA.
Inches

0.039
0.040
0.040
0.037
0.037
0.038
0.043
0.014
0.016
0.020
0.020
0.020
0.021
0.022
0.022
0.025
0.025
0.027
0.029
0.040
0.040
0.050
0.008
0.013
0.028
0.028
0.030
0.032
0.032
0.040
0.010
0.011
0.020
0.029
0.035
0.036
0.039
0.020
0.025
0.030
0.036
0.015
0.020
0.022
0.022
0.024
0.024
0.025
0.025
0.030
0.030
0.032
0.035
0.050
0.012
0.020
0.025
0.026
0.030
0.031
0.035
0.013
0.014
0.015
0.016
0.018
0.036
0.040
0.047
0.047
0.012
0.015
0.017
0.020
0.022
0.022
0.023
0.025
0.025
0.026

mm

TOTAL
MATL
COILS

1.0
1.0
1.0
0.9
0.9
1.0
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
1.0
1.0
1.3
0.2
0.3
0.7
0.7
0.8
0.8
0.8
1.0
0.3
0.3
0.5
0.7
0.9
0.9
1.0
0.5
0.6
0.8
0.9
0.4
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.8
0.8
0.8
0.9
1.3
0.3
0.5
0.6
0.7
0.8
0.8
0.9
0.3
0.4
0.4
0.4
0.5
0.9
1.0
1.2
1.2
0.3
0.4
0.4
0.5
0.6
0.6
0.6
0.6
0.6
0.7

7.33
7.00
5.00
7.00
8.25
6.00
6.00
14.0
8.50
6.00
7.75
9.00
9.75
7.00
10.0
8.00
8.00
8.25
7.00
5.00
7.00
9.00
8.50
6.50
8.00
8.50
11.0
11.0
7.00
10.0
11.8
14.0
9.00
7.00
10.0
8.00
9.50
8.00
9.00
10.0
9.00
15.0
9.00
10.0
8.25
9.75
7.00
12.0
10.0
12.0
10.0
11.5
10.0
8.00
13.0
8.00
7.00
9.88
8.50
8.50
12.5
13.0
25.0
9.00
11.0
14.0
13.0
11.0
8.00
10.0
25.0
14.0
19.0
8.00
10.0
9.50
10.0
10.5
14.0
12.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SPR
SST
SPR
MW
SST
SST
MW
MW
MW
MW
MW
SST
SST
SST
MW
SST
MW
SPR
SPR
SPR
MW
MW
SST
MW
SST
SST
SST
SPR
MW
SST
MW
SST
SST
SPR
SST
MW
MW
SST
SPR
MW
MW
SST
SST
MW
MW
MW
MW
SST
MW
SST
SST
SPR
SST
MW
SST
MW
MW
SST
SPR
SST
SST
MW
SST
SST
SPR
SPR
SPR
SST
MW
MW
SST
MW
MW
SST
MW
MW
SST
SST

E
N
D
S

F
N
S
H

CG
CG
CG
C
CG
C
C
C
C
C
C
CG
C
CG
C
C
C
C
C
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
C
C
C
CG
C
CG
C
CG
C
CG
CG
C
C
C
C
C
C
CG
CG
CG
C
CG
CG
C
CG
C
CG
C
C
CG
C
C
C
C
C
CG
CG
C
CG
C
C
C
C
C
C
CG
C
C
C

N
N
Z
N
N
Z
N
N
N
Z
Z
Z
BO
N
N
N
N
N
N
Z
Z
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
Z
N
Z
Z
N
Z
N
N
N
N
N
N
Z
N
N
N
N
N
GI
N
N
N
GI
N
N
N
Z
N
N
Z
N
Z
Z
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 45

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219

5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56

HH-43
TT-39
11303
A9-5
S-874
HH-16
V-61
MM-81
Z-85
1503
S-1555
V V-38
H-48
II-58
10733
B-15
DD-38
S-716
S-1169
S-1079
2771
2900
V-59
2529
HH-52
2801
Z-27
AA-15
W-42
G-58
J-70
A9-52
2627
159-A
160-A
4299
O-101
A-65
351-A
12453
161-A
K-39
RR-39
2675
O-46
162-A
A10-32
Z-89
J-2
KK-94
B15-13
S-1054
FF-19
Z-40
2618
10574
10065
11399
2861
S-145
3779
U-20
A10-48
FF-91
O-84
S-891
159-B
160-B
1699
351-B
161-B
3865
M-147
162-B
G-89
10898
11463
S-260
2515
I-25

.75
.75
.75
.78
.78
.78
.81
.81
.81
.81
.81
.81
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.94
.94
.94
.94
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.06
1.06
1.06
1.09
1.13
1.13
1.16
1.16
1.19
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.31
1.31
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.50
1.50
1.50
1.50
1.50

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

19.1
19.1
19.1
19.8
19.8
19.8
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.8
23.8
23.8
23.8
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
27.0
27.0
27.0
27.8
28.6
28.6
29.4
29.4
30.2
31.8
31.8
31.8
31.8
31.8
31.8
32.5
33.3
33.3
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
38.1
38.1
38.1
38.1
38.1

I.D.
Inches

.159
.159
.149
.155
.143
.099
.179
.155
.151
.149
.143
.129
.165
.153
.193
.185
.179
.175
.171
.169
.167
.163
.161
.139
.139
.181
.173
.191
.167
.157
.157
.173
.161
.187
.183
.183
.183
.181
.179
.175
.173
.171
.169
.167
.165
.163
.149
.183
.165
.151
.141
.163
.159
.159
.147
.171
.183
.179
.171
.171
.163
.141
.181
.175
.163
.191
.187
.183
.179
.179
.173
.173
.173
.163
.161
.195
.183
.171
.169
.169

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

4.0
4.0
3.8
3.9
3.6
2.5
4.5
3.9
3.8
3.8
3.6
3.3
4.2
3.9
4.9
4.7
4.5
4.4
4.3
4.3
4.2
4.1
4.1
3.5
3.5
4.6
4.4
4.9
4.2
4.0
4.0
4.4
4.1
4.7
4.6
4.6
4.6
4.6
4.5
4.4
4.4
4.3
4.3
4.2
4.2
4.1
3.8
4.6
4.2
3.8
3.6
4.1
4.0
4.0
3.7
4.3
4.6
4.5
4.3
4.3
4.1
3.6
4.6
4.4
4.1
4.9
4.7
4.6
4.5
4.5
4.4
4.4
4.4
4.1
4.1
5.0
4.6
4.3
4.3
4.3

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

19
3.4
18
3.1
35
6.1
23
4.0
49
8.6
514
90
2.8
.49
16
2.9
23
4.1
51
9.0
49
8.6
118
21
15
2.7
20
3.6
.64
.11
.79
.14
2.6
.45
4.3
.75
8.6
1.5
5.6
.98
18
3.2
9.8
1.7
11
1.9
58
10
53
9.4
2.0
.36
7.3
1.3
.44
.08
5.0
.87
14
2.4
13
2.3
4.4
.78
11
1.9
1.6
.28
2.4
.42
2.0
.34
1.9
.33
.58
.10
3.3
.58
3.7
.66
5.5
.96
5.1
.89
7.7
1.3
6.3
1.1
8.6
1.5
11
2.0
27
4.7
.48
.08
9.8
1.7
22
3.8
36
6.2
10
1.8
9.6
1.7
17
3.0
26
4.6
4.0
.70
1.7
.30
2.5
.44
3.1
.54
3.6
.63
10
1.8
38
6.7
1.0
.18
3.2
.56
9.9
1.7
.43
.08
1.2
.20
1.7
.30
1.5
.27
2.4
.42
3.9
.68
3.1
.54
4.9
.86
8.1
1.4
6.8
1.2
.29
.05
1.7
.30
3.5
.61
4.8
.84
3.8
.67

.35
.26
.19
.35
.18
.06
.51
.30
.30
.20
.18
.13
.32
.31
.67
.55
.56
.45
.29
.48
.24
.46
.38
.25
.20
.63
.30
.72
.47
.43
.41
.49
.52
.70
.66
.78
.77
.28
.65
.68
.60
.49
.51
.55
.57
.49
.27
.40
.51
.32
.28
.37
.47
.39
.41
.76
.94
.86
.67
.69
.54
.26
.84
.60
.55
1.2
.97
.92
.94
.91
.85
.91
.45
.68
.60
1.3
.94
.71
.82
.93

mm

8.9
6.5
4.9
9.0
4.5
1.4
13
7.6
7.6
5.0
4.5
3.2
8.2
8.0
17
14
14
11
7.3
12
6.2
12
9.7
6.4
5.0
16
7.6
18
12
11
10
12
13
18
17
20
19
7.1
17
17
15
12
13
14
15
12
6.9
10
13
8.2
7.0
9.4
12
9.9
11
19
24
22
17
17
14
6.6
21
15
14
29
25
23
24
23
21
23
11
17
15
34
24
18
21
23

ENDS: C - Closed

G - Ground
O - Open

Lbs.

6.7
30
4.5
20
6.8
30
8.1
36
8.6
38
28
127
1.4
6.4
4.9
22
7.0
31
10
45
8.6
38
15
66
5.0
22
6.4
28
.43
1.9
.44
1.9
1.4
6.4
1.9
8.5
2.5
11
2.7
12
4.4
20
4.4
20
4.1
18
15
65
11
47
1.3
5.7
2.2
9.7
.31
1.4
2.3
10
5.9
26
5.5
24
2.2
9.7
5.7
25
1.1
5.0
1.6
7.1
1.5
6.7
1.4
6.3
.16
.72
2.2
9.7
2.5
11
3.3
15
2.5
11
4.0
18
3.4
15
5.0
22
5.5
25
7.2
32
.19
.84
5.0
22
7.0
31
9.9
44
3.7
16
4.5
20
6.7
30
11
48
3.0
14
1.6
7.1
2.2
9.7
2.1
9.2
2.5
11
5.5
25
9.9
44
.86
3.8
1.9
8.5
5.5
25
.49
2.2
1.1
5.0
1.6
7.1
1.4
6.4
2.2
9.7
3.3
15
2.8
13
2.2
9.7
5.5
25
4.1
18
.38
1.7
1.6
7.1
2.5
11
4.0
18
3.6
16

Inches

.33
.35
.41
.38
.42
.60
.24
.51
.51
.34
.46
.56
.24
.50
.12
.32
.26
.26
.23
.35
.21
.42
.41
.56
.56
.28
.22
.22
.47
.51
.53
.29
.45
.16
.19
.23
.23
.72
.24
.32
.29
.34
.33
.46
.42
.40
.53
.67
.35
.58
.70
.39
.54
.36
.65
.43
.25
.29
.58
.44
.43
.70
.44
.33
.44
.22
.20
.25
.44
.31
.39
.47
.29
.53
.64
.18
.25
.46
.48
.58

mm

Inches

8.4
8.8
10.4
9.8
10.6
15.2
6.1
13.0
13.0
8.7
11.6
14.3
6.2
12.6
3.1
8.2
6.6
6.7
5.8
8.9
5.3
10.7
10.3
14.2
14.2
7.0
5.5
5.6
11.9
13.0
13.4
7.4
11.4
4.1
4.9
5.7
5.9
18.3
6.0
8.2
7.4
8.5
8.3
11.6
10.6
10.1
13.3
16.9
8.9
14.7
17.8
10.0
13.7
9.1
16.5
11.0
6.4
7.4
14.6
11.3
11.0
17.8
11.3
8.4
11.2
5.7
5.2
6.3
11.2
7.7
9.8
11.8
7.3
13.3
16.2
4.5
6.4
11.6
12.1
14.6

0.030
0.030
0.035
0.032
0.038
0.060
0.020
0.032
0.034
0.035
0.038
0.045
0.027
0.033
0.013
0.017
0.020
0.022
0.024
0.025
0.026
0.028
0.029
0.040
0.040
0.019
0.023
0.014
0.026
0.031
0.031
0.023
0.029
0.016
0.018
0.018
0.018
0.019
0.020
0.022
0.023
0.024
0.025
0.026
0.027
0.028
0.035
0.018
0.027
0.034
0.039
0.028
0.030
0.030
0.036
0.024
0.018
0.020
0.024
0.024
0.028
0.039
0.019
0.022
0.028
0.014
0.016
0.018
0.020
0.020
0.023
0.023
0.023
0.028
0.029
0.012
0.018
0.024
0.025
0.025

mm

TOTAL
MATL
COILS

0.8
0.8
0.9
0.8
1.0
1.5
0.5
0.8
0.9
0.9
1.0
1.1
0.7
0.8
0.3
0.4
0.5
0.6
0.6
0.6
0.7
0.7
0.7
1.0
1.0
0.5
0.6
0.4
0.7
0.8
0.8
0.6
0.7
0.4
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.9
0.5
0.7
0.9
1.0
0.7
0.8
0.8
0.9
0.6
0.5
0.5
0.6
0.6
0.7
1.0
0.5
0.6
0.7
0.4
0.4
0.5
0.5
0.5
0.6
0.6
0.6
0.7
0.7
0.3
0.5
0.6
0.6
0.6

11.0
10.5
10.8
12.0
11.0
10.0
11.0
16.0
15.0
8.75
11.0
11.5
9.00
15.0
8.50
18.0
12.0
11.0
8.50
14.0
7.00
15.0
14.0
13.0
14.0
13.5
8.50
14.8
18.0
16.5
17.0
12.7
15.5
9.00
9.75
11.5
12.0
37.0
10.8
13.8
11.8
13.0
12.0
16.5
14.5
13.3
15.0
36.0
13.0
16.0
18.0
13.0
18.0
12.0
17.0
18.0
13.0
13.5
23.0
17.5
14.5
17.0
22.3
14.0
14.8
15.0
11.8
12.8
21.0
14.3
15.8
19.3
11.5
17.8
21.0
13.8
13.0
18.0
18.0
22.0

MW
SST
SST
MW
SST
SST
SST
HD
SPR
MW
SST
SPR
MW
SPR
SST
SST
SST
SST
SST
SST
MW
MW
SST
MW
SPR
MW
SST
SST
SST
MW
MW
SST
MW
MW
MW
MW
MW
SST
MW
MW
MW
SST
MW
MW
MW
MW
SPR
SST
MW
SPR
SPR
SST
SST
MW
MW
MW
MW
MW
MW
SST
MW
SPR
SST
SST
MW
SST
MW
MW
MW
MW
MW
MW
SST
MW
SST
MW
MW
SST
MW
MW

E
N
D
S

CG
C
C
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
C
C
C
C
C
CG
C
CG
CG
C
CG
C
C
C
CG
CG
CG
CG
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
CG
C
CG
C
CG
CG
C
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C

F
N
S
H

N
N
N
N
N
N
N
Z
N
Z
N
Z
Z
Z
N
N
N
N
N
N
Z
Z
N
Z
Z
Z
N
N
N
N
GI
N
Z
Z
Z
Z
N
N
Z
Z
Z
N
Z
Z
Z
Z
N
N
GI
N
N
N
N
N
Z
N
Z
Z
GI
N
Z
N
N
N
Z
N
Z
Z
Z
Z
Z
Z
N
Z
N
N
Z
N
Z
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

45

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 46

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.219
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234

5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.56
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94

AA-97
KK-50
S-159
GG-63
10664
10288
159-C
160-C
351-C
161-C
162-C
MM-2
FF-46
10267
10436
10640
G-30
CC-15
G-8
Z-14
V V-8
S-1530
AA-26
10572
O-41
H-3
HH-30
FF-10
V V-64
I-75
O-107
10616
G-4
11450
II-21
A-68
B18-142
A13-19
A14-17
S-1118
B5-20
B15-69
YY-48
M-132
RR-61
II-93
2708
GG-21
B3-64
A12-36
S-813
3564
V V-57
B1-3
NN-64
B14-44
U-41
B9-35
B7-21
Z-97
3891
CC-45
3991
B2-1
12763
B12-13
12585
12491
A12-29
A12-24
B4-2
NN-10
WW-48
A13-18
PP-74
Z-93
JJ-3
JJ-94
MM-73
A13-28

1.50
1.53
1.56
1.63
1.72
1.75
1.75
1.75
1.75
1.75
1.75
1.88
1.94
2.19
2.28
2.44
5.00
.16
.16
.16
.25
.28
.28
.31
.31
.31
.31
.31
.31
.31
.34
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.42
.42
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.45
.45
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

38.1
38.9
39.7
41.3
43.6
44.5
44.5
44.5
44.5
44.5
44.5
47.6
49.2
55.6
57.9
61.9
127.0
4.0
4.0
4.0
6.4
7.1
7.1
7.9
7.9
7.9
7.9
7.9
7.9
7.9
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
10.7
10.7
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.5
11.5
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7

MATERIAL: MW - Music Wire

46

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.159
.199
.175
.179
.183
.189
.187
.183
.179
.173
.163
.171
.159
.163
.143
.133
.181
.198
.190
.164
.194
.190
.188
.210
.194
.178
.176
.170
.170
.138
.186
.174
.208
.208
.202
.194
.194
.188
.188
.162
.156
.152
.148
.190
.188
.178
.170
.154
.170
.164
.202
.186
.184
.182
.176
.174
.174
.156
.154
.154
.144
.134
.132
.172
.170
.190
.172
.170
.210
.174
.220
.194
.192
.190
.190
.184
.182
.182
.182
.180

RATE
mm

4.0
5.1
4.4
4.5
4.6
4.8
4.7
4.6
4.5
4.4
4.1
4.3
4.0
4.1
3.6
3.4
4.6
5.0
4.8
4.2
4.9
4.8
4.8
5.3
4.9
4.5
4.5
4.3
4.3
3.5
4.7
4.4
5.3
5.3
5.1
4.9
4.9
4.8
4.8
4.1
4.0
3.9
3.8
4.8
4.8
4.5
4.3
3.9
4.3
4.2
5.1
4.7
4.7
4.6
4.5
4.4
4.4
4.0
3.9
3.9
3.7
3.4
3.4
4.4
4.3
4.8
4.4
4.3
5.3
4.4
5.6
4.9
4.9
4.8
4.8
4.7
4.6
4.6
4.6
4.6

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

8.6
1.5
.07
.01
2.4
.42
1.9
.34
1.0
.18
.57
.10
.90
.16
1.3
.23
1.9
.32
3.0
.53
6.2
1.1
4.6
.80
4.7
.82
3.4
.59
16
2.8
38
6.6
.33
.06
5.4
.95
21
3.7
238
42
10
1.8
31
5.4
19
3.3
1.1
.19
6.7
1.2
34
5.9
39
6.9
91
16
37
6.4
339
59
18
3.2
35
6.1
.35
.06
1.0
.18
3.6
.64
4.1
.71
2.0
.34
13
2.2
16
2.7
68
12
138
24
141
25
175
31
10
1.8
11
1.9
15
2.6
37
6.4
89
16
37
6.4
48
8.3
1.3
.23
13
2.3
15
2.7
18
3.2
18
3.2
23
4.0
61
11
128
22
144
25
92
16
175
31
251
44
577 101
45
7.9
46
8.0
9.4
1.7
40
6.9
49
8.5
.45
.08
37
6.4
.03
.01
7.8
1.4
6.3
1.1
7.8
1.4
8.8
1.5
8.8
1.5
7.9
1.4
8.1
1.4
12
2.0
19
3.3

.78
1.3
.80
1.1
1.3
1.5
1.2
1.2
1.2
1.1
.89
.81
.87
1.1
.58
.35
3.6
.05
.06
.03
.13
.06
.11
.25
.18
.15
.15
.06
.06
.05
.13
.12
.21
.30
.29
.24
.10
.16
.20
.10
.07
.08
.07
.18
.25
.15
.15
.11
.17
.13
.29
.27
.24
.15
.19
.17
.07
.07
.07
.10
.08
.05
.03
.15
.17
.29
.18
.11
.36
.17
.41
.26
.25
.23
.31
.28
.24
.21
.24
.16

20
33
20
28
34
38
32
31
30
28
23
21
22
27
15
8.8
91
1.3
1.4
.68
3.4
1.5
2.8
6.2
4.6
3.9
3.7
1.5
1.4
1.2
3.2
3.1
5.4
7.5
7.3
6.0
2.4
4.1
5.0
2.6
1.7
1.9
1.7
4.5
6.2
3.9
3.8
2.7
4.2
3.4
7.5
6.9
6.1
3.8
4.9
4.3
1.8
1.9
1.8
2.6
2.0
1.3
.82
3.9
4.3
7.3
4.5
2.9
9.2
4.4
10
6.6
6.3
5.8
7.8
7.0
6.1
5.4
6.2
4.2

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs.

6.7
.09
1.9
2.2
1.4
.85
1.1
1.6
2.2
3.3
5.5
3.7
4.1
3.6
9.2
13
1.2
.29
1.2
6.4
1.4
1.8
2.1
.27
1.2
5.2
5.7
5.5
2.0
16
2.3
4.3
.07
.31
1.0
.96
.19
2.1
3.1
6.9
9.3
11
12
1.8
2.6
2.3
5.5
9.4
6.1
6.4
.39
3.5
3.7
2.8
3.5
3.8
4.3
9.3
10
9.4
14
13
19
7.0
7.7
2.7
7.0
5.5
.16
6.3
.01
2.0
1.6
1.8
2.7
2.4
1.9
1.7
2.8
3.1

ENDS: C - Closed

G - Ground
O - Open

30
.38
8.5
9.7
6.2
3.8
5.0
7.1
9.7
15
25
17
18
16
41
58
5.2
1.3
5.3
28
6.0
8.0
9.1
1.2
5.4
23
26
25
9.1
72
10
19
.33
1.4
4.6
4.3
.83
9.1
14
31
42
48
51
8.0
12
10
24
42
27
28
1.7
15
17
12
15
17
19
42
45
42
62
56
83
31
34
12
31
25
.73
28
.05
9.1
7.0
8.0
12
11
8.5
7.7
12
14

Inches

.69
.24
.42
.36
.38
.27
.25
.31
.38
.48
.66
.38
1.07
1.13
1.33
1.16
1.43
.10
.10
.11
.10
.09
.09
.07
.13
.14
.15
.16
.26
.26
.13
.17
.16
.08
.09
.14
.28
.12
.11
.25
.20
.25
.24
.13
.16
.25
.26
.28
.26
.28
.14
.17
.18
.14
.25
.27
.15
.21
.22
.27
.32
.39
.29
.20
.22
.13
.22
.22
.11
.20
.09
.10
.15
.13
.13
.23
.26
.29
.20
.16

mm

17.5
6.1
10.6
9.1
9.6
6.9
6.3
7.8
9.5
12.1
16.7
9.8
27.1
28.8
33.8
29.5
36.2
2.6
2.5
2.7
2.5
2.2
2.3
1.7
3.3
3.6
3.7
4.1
6.5
6.7
3.4
4.2
4.1
2.0
2.2
3.6
7.1
2.9
2.8
6.4
5.2
6.2
6.0
3.4
4.1
6.4
6.5
7.1
6.5
7.1
3.7
4.3
4.4
3.6
6.3
6.9
3.8
5.4
5.6
6.9
8.0
9.8
7.4
5.1
5.7
3.2
5.5
5.5
2.7
5.2
2.3
2.5
3.7
3.4
3.4
5.7
6.6
7.3
5.0
4.1

WIRE DIA.
Inches

0.030
0.010
0.022
0.020
0.018
0.015
0.016
0.018
0.020
0.023
0.028
0.024
0.030
0.028
0.038
0.043
0.019
0.018
0.022
0.035
0.020
0.022
0.023
0.012
0.020
0.028
0.029
0.032
0.032
0.048
0.024
0.030
0.013
0.013
0.016
0.020
0.020
0.023
0.023
0.036
0.039
0.041
0.043
0.022
0.023
0.028
0.032
0.040
0.032
0.035
0.016
0.024
0.025
0.026
0.029
0.030
0.030
0.039
0.040
0.040
0.045
0.050
0.051
0.031
0.032
0.022
0.031
0.032
0.012
0.030
0.007
0.020
0.021
0.022
0.022
0.025
0.026
0.026
0.026
0.027

mm

TOTAL
MATL
COILS

0.8
0.3
0.6
0.5
0.5
0.4
0.4
0.5
0.5
0.6
0.7
0.6
0.8
0.7
1.0
1.1
0.5
0.5
0.6
0.9
0.5
0.6
0.6
0.3
0.5
0.7
0.7
0.8
0.8
1.2
0.6
0.8
0.3
0.3
0.4
0.5
0.5
0.6
0.6
0.9
1.0
1.0
1.1
0.6
0.6
0.7
0.8
1.0
0.8
0.9
0.4
0.6
0.6
0.7
0.7
0.8
0.8
1.0
1.0
1.0
1.1
1.3
1.3
0.8
0.8
0.6
0.8
0.8
0.3
0.8
0.2
0.5
0.5
0.6
0.6
0.6
0.7
0.7
0.7
0.7

22.0
23.0
18.0
17.0
20.0
17.0
14.5
16.0
17.8
19.8
22.5
16.0
34.5
39.5
34.0
26.0
74.0
4.75
3.50
3.00
4.00
3.00
4.00
4.50
5.50
5.00
5.00
4.00
7.00
5.50
4.50
5.50
11.5
5.00
4.50
7.00
14.0
5.00
4.75
6.00
5.25
6.00
5.50
5.00
6.00
8.00
7.00
7.00
7.00
7.00
8.00
6.00
6.00
5.50
8.50
8.00
4.00
5.50
5.50
6.75
7.00
7.75
4.75
5.50
6.00
5.75
6.00
5.75
8.00
5.75
12.0
5.00
6.00
6.00
6.00
9.00
10.0
10.0
7.50
6.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
SST
MW
MW
MW
MW
MW
MW
MW
MW
MW
SST
MW
SPR
SPR
MW
MW
SST
SST
SST
SST
SST
MW
MW
MW
MW
SPR
HD
SPR
SST
SST
SST
MW
MW
SST
MW
SST
MW
SST
SPR
SPR
SST
SST
MW
SST
MW
SST
MW
SST
SST
MW
MW
SST
MW
MW
SST
SPR
SPR
SST
SPR
SPR
SPR
MW
MW
MW
MW
SPR
MW
MW
MW
MW
SST
SST
MW
MW
SST
SST
SST
SST

E
N
D
S

F
N
S
H

C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
C
C
CG
C
C
CG
CG
C
C
CG
C
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
C
CG
C
C
C
C
C
CG
CG
C
C
CG
CG
CG
CG
CG
C
CL
C
CG
C
C
C
C
C
CG
C
CG
C
CG
CG
C
C
CG

Z
N
N
Z
BO
GI
Z
Z
Z
Z
Z
Z
N
GI
GI
Z
GI
N
N
N
N
N
N
N
N
N
Z
N
Z
N
N
N
N
N
Z
N
GI
N
GI
N
N
Z
N
N
Z
N
Z
N
GI
N
N
Z
Z
N
N
N
N
N
N
N
Z
N
Z
N
N
Z
N
N
Z
N
N
N
N
N
N
GI
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 47

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234

5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94

B17-127
K-9
JJ-58
S-1692
II-18
S-3003
A12-42
B-28
3518
A13-13
Y-98
1505
DD-39
2963
FF-71
A10-8
S-1461
11216
3529
M-102
CC-65
HH-47
10930
LL-98
A-85
B1-13
II-13
A10-12
W-63
3216
S-832
S-929
12031
JJ-67
M-81
Z-19
W-96
B2-26
CC-14
II-95
PP-2
A9-14
YY-20
FF-1
V V-62
B7-24
J-85
11315
B-12
GG-4
11260
DD-10
W-77
I-92
B5-27
M-32
V V-2
YY-63
II-87
B-65
A14-14
S-3134
B2-24
3632
A14-53
Y-93
DD-75
10011
11163
B11-31
HH-15
NN-90
RR-22
HH-90
S-936
A-57
O-40
A14-19
L-98
A13-5

.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.53
.53
.53
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.72
.72
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.5
18.2
18.2
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1

I.D.
Inches

.178
.176
.174
.170
.170
.168
.156
.152
.150
.150
.144
.140
.134
.212
.206
.196
.192
.190
.164
.160
.154
.202
.198
.192
.188
.182
.180
.178
.170
.166
.166
.164
.208
.190
.170
.156
.126
.144
.214
.194
.194
.190
.190
.180
.174
.174
.166
.166
.158
.154
.150
.194
.182
.174
.168
.168
.194
.188
.186
.182
.180
.174
.158
.154
.150
.146
.134
.200
.214
.182
.174
.168
.168
.204
.202
.198
.192
.190
.190
.188

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

4.5
4.5
4.4
4.3
4.3
4.3
4.0
3.9
3.8
3.8
3.7
3.6
3.4
5.4
5.2
5.0
4.9
4.8
4.2
4.1
3.9
5.1
5.0
4.9
4.8
4.6
4.6
4.5
4.3
4.2
4.2
4.2
5.3
4.8
4.3
4.0
3.2
3.7
5.4
4.9
4.9
4.8
4.8
4.6
4.4
4.4
4.2
4.2
4.0
3.9
3.8
4.9
4.6
4.4
4.3
4.3
4.9
4.8
4.7
4.6
4.6
4.4
4.0
3.9
3.8
3.7
3.4
5.1
5.4
4.6
4.4
4.3
4.3
5.2
5.1
5.0
4.9
4.8
4.8
4.8

N/mm

Inches

mm

19
20
22
32
32
46
80
141
253
112
175
268
481

3.3
3.4
3.8
5.6
5.6
8.0
14
25
44
20
31
47
84
.11
.13
.60
.46
1.4
12
7.8
11
.11
.39
1.5
1.2
2.4
3.2
2.4
4.6
7.0
6.1
10
.13
1.3
7.1
9.1
53
28
.02
.38
.52
1.1
.65
2.3
3.4
3.2
5.3
4.0
7.6
11
22
.51
1.6
3.4
5.3
3.6
.30
.75
.75
1.9
2.5
3.2
8.7
11
14
20
51
.29
.03
2.2
2.4
3.5
3.6
.08
.17
.33
.44
.87
.62
1.1

.27
.27
.20
.16
.22
.12
.11
.08
.05
.10
.08
.06
.04
.47
.41
.37
.29
.23
.14
.17
.15
.31
.40
.19
.38
.21
.26
.32
.19
.16
.18
.11
.49
.36
.14
.17
.07
.09
.50
.38
.45
.29
.35
.35
.32
.34
.22
.21
.19
.16
.09
.44
.30
.32
.20
.27
.39
.39
.36
.26
.32
.23
.24
.16
.14
.12
.08
.52
.62
.33
.36
.30
.27
.48
.57
.55
.44
.36
.46
.32

6.9
6.8
5.0
4.1
5.6
3.1
2.8
1.9
1.2
2.4
2.0
1.5
.93
12
10
9.4
7.4
5.8
3.5
4.3
3.7
7.8
10
4.8
9.6
5.2
6.5
8.2
4.9
4.2
4.5
2.7
12
9.2
3.4
4.3
1.7
2.2
13
9.5
11
7.3
8.9
8.9
8.2
8.6
5.6
5.3
4.8
4.0
2.3
11
7.7
8.2
5.1
6.9
9.8
9.9
9.2
6.7
8.3
5.9
6.1
4.0
3.6
3.0
2.2
13
16
8.4
9.1
7.7
6.9
12
15
14
11
9.2
12
8.2

.63
.77
3.4
2.6
7.8
68
45
64
.61
2.2
8.4
7.1
14
18
14
27
40
35
60
.76
7.4
41
52
304
159
.11
2.1
3.0
6.3
3.7
13
20
18
30
23
43
63
126
2.9
9.2
20
30
21
1.7
4.3
4.3
11
14
18
50
63
77
112
288
1.7
.20
13
14
20
21
.46
.99
1.9
2.5
4.9
3.5
6.3

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

ENDS: C - Closed

G - Ground
O - Open

Lbs.

5.2
23
5.3
23
4.3
19
5.1
23
7.0
31
5.6
25
8.7
39
11
48
12
51
11
48
14
62
16
71
18
78
.29
1.3
.31
1.4
1.3
5.6
.77
3.4
1.8
8.0
9.5
42
7.5
33
9.4
42
.19
.83
.89
3.9
1.6
7.0
2.7
12
2.8
12
4.7
21
4.5
20
5.1
23
6.6
29
6.1
27
6.4
28
.37
1.7
2.7
12
5.5
25
8.7
39
21
91
14
62
.06
.24
.81
3.6
1.3
5.9
1.8
8.0
1.3
5.8
4.7
21
6.3
28
6.2
28
6.6
29
4.8
21
8.1
36
10
45
12
51
1.3
5.7
2.8
12
6.3
28
6.0
27
5.6
25
.66
2.9
1.7
7.4
1.5
6.9
2.8
12
4.7
21
4.3
19
12
53
10
45
11
48
13
59
24
109
.87
3.9
.12
.55
4.2
19
4.9
22
6.0
27
5.6
25
.22
.99
.57
2.5
1.0
4.6
1.1
4.9
1.8
8.0
1.6
7.3
2.1
9.1

Inches

.21
.23
.26
.26
.28
.23
.27
.25
.19
.29
.32
.28
.25
.07
.13
.16
.24
.13
.21
.33
.36
.26
.16
.13
.18
.18
.21
.24
.26
.27
.27
.21
.10
.17
.24
.37
.43
.34
.13
.25
.18
.15
.28
.26
.27
.29
.34
.42
.38
.40
.34
.22
.26
.27
.30
.36
.30
.30
.32
.23
.22
.26
.42
.44
.39
.40
.35
.17
.10
.23
.36
.41
.40
.27
.18
.20
.31
.18
.29
.18

mm

Inches

5.2
5.9
6.5
6.5
7.1
5.9
6.9
6.2
4.8
7.5
8.0
7.2
6.4
1.7
3.2
4.1
6.1
3.4
5.3
8.5
9.1
6.5
4.1
3.2
4.7
4.5
5.3
6.0
6.5
6.9
6.9
5.3
2.6
4.3
6.1
9.4
11.0
8.6
3.3
6.4
4.6
3.9
7.0
6.5
6.9
7.2
8.6
10.6
9.7
10.2
8.5
5.6
6.6
6.9
7.5
9.2
7.6
7.6
8.2
5.9
5.5
6.5
10.6
11.2
9.9
10.1
8.9
4.3
2.4
5.8
9.1
10.5
10.1
6.9
4.5
5.0
7.8
4.7
7.3
4.7

0.028
0.029
0.030
0.032
0.032
0.033
0.039
0.041
0.042
0.042
0.045
0.047
0.050
0.011
0.014
0.019
0.021
0.022
0.035
0.037
0.040
0.016
0.018
0.021
0.023
0.026
0.027
0.028
0.032
0.034
0.034
0.035
0.013
0.022
0.032
0.039
0.054
0.045
0.010
0.020
0.020
0.022
0.022
0.027
0.030
0.030
0.034
0.034
0.038
0.040
0.042
0.020
0.026
0.030
0.033
0.033
0.020
0.023
0.024
0.026
0.027
0.030
0.038
0.040
0.042
0.044
0.050
0.017
0.010
0.026
0.030
0.033
0.033
0.015
0.016
0.018
0.021
0.022
0.022
0.023

mm

TOTAL
MATL
COILS

0.7
0.7
0.8
0.8
0.8
0.8
1.0
1.0
1.1
1.1
1.1
1.2
1.3
0.3
0.4
0.5
0.5
0.6
0.9
0.9
1.0
0.4
0.5
0.5
0.6
0.7
0.7
0.7
0.8
0.9
0.9
0.9
0.3
0.6
0.8
1.0
1.4
1.1
0.3
0.5
0.5
0.6
0.6
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.1
0.5
0.7
0.8
0.8
0.8
0.5
0.6
0.6
0.7
0.7
0.8
1.0
1.0
1.1
1.1
1.3
0.4
0.3
0.7
0.8
0.8
0.8
0.4
0.4
0.5
0.5
0.6
0.6
0.6

7.33
8.00
7.50
7.00
7.75
6.00
7.00
6.00
4.50
7.00
7.00
6.00
5.00
5.00
8.00
7.50
11.5
6.00
6.00
9.00
9.00
15.0
8.00
5.00
8.00
6.75
6.75
8.50
8.00
8.00
8.00
6.00
7.00
6.75
6.50
9.50
8.00
7.50
12.0
11.5
9.00
7.00
11.5
8.50
9.00
9.50
10.0
11.3
10.0
10.0
7.00
10.0
9.00
9.00
9.00
11.0
14.0
12.0
12.5
8.00
8.00
8.50
10.0
10.0
9.25
9.00
7.00
9.00
8.50
7.75
12.0
12.5
11.0
17.0
10.0
10.0
13.6
8.33
12.0
8.00

MW
MW
SST
SST
MW
SST
SST
SPR
SPR
SST
SPR
HD
SPR
MW
SST
MW
SST
SST
MW
SST
SST
SST
SST
SST
MW
SST
MW
MW
SST
SPR
SST
SST
MW
MW
SPR
SST
SST
SPR
SST
SST
SST
SST
MW
MW
MW
MW
SPR
SST
SST
SPR
SPR
MW
SST
MW
SPR
SST
SST
MW
SST
SST
MW
SST
MW
SPR
SST
SPR
MW
MW
MW
MW
MW
SPR
SST
MW
SST
MW
MW
SST
MW
SST

E
N
D
S

F
N
S
H

CG
CG
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
C
C
C
CG
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
C
C
CG
CG
C
C
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
C
C
C
C
CG
CG
C
C
CG
CG
CG
C
C
C
CG
CG
C
C
C
C
C
CG
C
CG

Z
N
N
N
N
N
N
GI
N
N
Z
Z
Z
GI
N
N
N
N
Z
N
N
N
N
N
Z
N
N
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
Z
N
N
N
N
N
N
Z
N
N
GI
N
N
Z
N
Z
N
Z
Z
Z
BO
N
N
N
N
Z
Z
N
BO
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

47

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 48

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234

5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94

W-33
10158
A11-38
EE-25
O-112
B5-15
2533
3549
3661
OO-85
S-1339
B5-44
V-44
OO-74
S-1177
L-67
A9-7
3000
B5-19
LL-27
H-72
JJ-79
GG-26
JJ-36
4200
B14-57
W-16
G-47
Q-21
DD-17
DD-52
LL-71
B5-62
FF-83
B10-1
GG-30
S-3155
HH-20
II-82
O-100
H-6
3562
W-90
GG-87
1565
2699
2939
K-88
N-131
HH-1
10438
M-99
S-3126
3783
HH-69
BB-82
I-10
3526
1926
EE-7
3551
10198
B-90
A-34
3848
L-22
G-69
K-10
S-796
U-33
W-58
OO-61
B3-65
A11-27
S-3123
S-213
B1-41
S-212
CC-81
Q-91

.75
.75
.75
.75
.75
.75
.78
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.84
.84
.84
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.94
.94
.97
.97
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.09
1.13
1.13
1.13
1.13
1.19
1.19
1.19
1.19
1.19
1.19
1.22
1.23
1.25
1.25
1.25
1.25
1.25
1.25
1.25

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

19.1
19.1
19.1
19.1
19.1
19.1
19.8
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
21.4
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.0
23.8
23.8
24.6
24.6
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.8
28.6
28.6
28.6
28.6
30.2
30.2
30.2
30.2
30.2
30.2
31.0
31.3
31.8
31.8
31.8
31.8
31.8
31.8
31.8

MATERIAL: MW - Music Wire

48

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.186
.184
.180
.176
.172
.156
.174
.192
.190
.190
.190
.190
.186
.178
.174
.164
.162
.154
.152
.204
.182
.164
.154
.150
.194
.192
.184
.180
.170
.170
.154
.154
.210
.190
.166
.198
.194
.170
.166
.160
.152
.202
.202
.194
.192
.188
.186
.182
.176
.174
.168
.164
.164
.162
.158
.154
.204
.190
.194
.158
.180
.208
.182
.160
.150
.184
.178
.176
.174
.174
.154
.174
.174
.210
.188
.186
.182
.182
.164
.148

RATE
mm

4.7
4.7
4.6
4.5
4.4
4.0
4.4
4.9
4.8
4.8
4.8
4.8
4.7
4.5
4.4
4.2
4.1
3.9
3.9
5.2
4.6
4.2
3.9
3.8
4.9
4.9
4.7
4.6
4.3
4.3
3.9
3.9
5.3
4.8
4.2
5.0
4.9
4.3
4.2
4.1
3.9
5.1
5.1
4.9
4.9
4.8
4.7
4.6
4.5
4.4
4.3
4.2
4.2
4.1
4.0
3.9
5.2
4.8
4.9
4.0
4.6
5.3
4.6
4.1
3.8
4.7
4.5
4.5
4.4
4.4
3.9
4.4
4.4
5.3
4.8
4.7
4.6
4.6
4.2
3.8

Lbs./In.

5.0
6.2
11
11
20
53
15
2.4
3.5
2.8
3.4
5.4
4.1
13
11
25
36
59
59
.80
15
20
34
66
2.0
3.4
5.9
13
18
12
63
92
.34
3.8
25
1.0
1.1
14
16
35
56
.83
.88
1.5
3.2
3.9
4.7
5.8
7.1
8.6
17
23
17
26
29
37
.56
3.5
2.6
33
5.7
.27
6.6
25
53
4.0
6.7
6.6
7.0
7.6
34
7.6
9.1
.15
4.7
2.9
4.8
5.3
15
50

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.87
1.1
1.9
2.0
3.5
9.2
2.7
.42
.62
.50
.60
.95
.72
2.2
2.0
4.4
6.3
10
10
.14
2.7
3.5
6.0
12
.36
.60
1.0
2.3
3.2
2.1
11
16
.06
.67
4.3
.17
.20
2.4
2.8
6.2
9.8
.14
.15
.26
.56
.68
.82
1.0
1.2
1.5
3.1
4.0
3.0
4.5
5.1
6.5
.10
.62
.46
5.8
1.0
.05
1.2
4.4
9.2
.71
1.2
1.2
1.2
1.3
5.9
1.3
1.6
.03
.82
.51
.84
.93
2.6
8.8

.46
.43
.29
.34
.35
.18
.42
.50
.53
.47
.53
.50
.46
.41
.37
.27
.21
.17
.18
.69
.27
.32
.24
.16
.59
.65
.42
.35
.30
.36
.22
.11
.77
.47
.27
.61
.52
.38
.38
.23
.18
.78
.80
.66
.73
.68
.66
.48
.52
.46
.34
.30
.37
.29
.28
.25
.82
.75
.78
.25
.64
.90
.63
.32
.22
.62
.68
.58
.61
.59
.28
.59
.69
1.0
.44
.80
.58
.53
.43
.24

mm

12
11
7.3
8.6
8.9
4.5
11
13
13
12
13
13
12
10
9.5
7.0
5.2
4.3
4.6
17
6.9
8.0
6.2
4.2
15
17
11
8.9
7.7
9.2
5.6
2.8
20
12
6.8
16
13
9.6
9.7
5.8
4.6
20
20
17
19
17
17
12
13
12
8.8
7.6
9.4
7.3
7.1
6.4
21
19
20
6.3
16
23
16
8.1
5.6
16
17
15
15
15
7.1
15
18
25
11
20
15
13
11
6.2

Lbs.

2.3
2.6
3.1
3.8
7.0
9.3
6.3
1.2
1.9
1.3
1.8
2.7
1.9
5.2
4.3
6.8
7.4
10
11
.55
4.2
6.4
8.4
11
1.2
2.2
2.5
4.7
5.5
4.4
14
10
.26
1.8
6.6
.61
.59
5.1
6.1
8.0
10
.64
.70
.96
2.4
2.6
3.1
2.8
3.7
3.9
6.0
6.8
6.4
7.4
8.1
9.4
.46
2.6
2.0
8.1
3.6
.25
4.2
8.0
12
2.5
4.6
3.8
4.3
4.5
9.4
4.5
6.3
.15
2.1
2.3
2.8
2.8
6.4
12

ENDS: C - Closed

G - Ground
O - Open

10
12
14
17
31
42
28
5.3
8.3
5.9
8.0
12
8.5
23
19
30
33
45
48
2.4
19
28
37
48
5.3
9.9
11
21
25
20
62
45
1.2
8.0
29
2.7
2.6
23
27
36
45
2.9
3.1
4.3
10
12
14
12
16
18
27
30
28
33
36
42
2.0
12
9.1
36
16
1.1
19
36
51
11
21
17
19
20
42
20
28
.67
9.1
10
12
12
28
55

Inches

.29
.33
.24
.32
.34
.41
.36
.32
.29
.34
.24
.19
.35
.31
.41
.46
.38
.42
.47
.16
.20
.48
.60
.48
.29
.22
.30
.26
.38
.51
.40
.34
.13
.24
.40
.32
.42
.45
.51
.44
.45
.22
.19
.34
.25
.32
.34
.36
.48
.54
.50
.49
.55
.54
.53
.56
.21
.29
.24
.48
.46
.22
.36
.63
.63
.39
.50
.54
.57
.60
.60
.63
.51
.25
.25
.44
.43
.39
.67
.69

mm

7.3
8.3
6.2
8.1
8.7
10.4
9.1
8.0
7.3
8.7
6.1
4.7
8.8
7.8
10.3
11.6
9.8
10.7
12.0
4.0
5.1
12.2
15.2
12.3
7.4
5.6
7.6
6.5
9.8
13.0
10.2
8.6
3.4
6.1
10.1
8.2
10.7
11.4
13.0
11.3
11.5
5.7
4.9
8.6
6.4
8.2
8.5
9.2
12.2
13.7
12.6
12.4
14.0
13.7
13.5
14.2
5.3
7.3
6.1
12.1
11.7
5.6
9.2
16.0
16.0
9.8
12.8
13.6
14.5
15.2
15.2
16.0
13.0
6.4
6.4
11.3
10.9
9.9
16.9
17.5

WIRE DIA.
Inches

0.024
0.025
0.027
0.029
0.031
0.039
0.030
0.021
0.022
0.022
0.022
0.022
0.024
0.028
0.030
0.035
0.036
0.040
0.041
0.015
0.026
0.035
0.040
0.042
0.020
0.021
0.025
0.027
0.032
0.032
0.040
0.040
0.012
0.022
0.034
0.018
0.020
0.032
0.034
0.037
0.041
0.016
0.016
0.020
0.021
0.023
0.024
0.026
0.029
0.030
0.033
0.035
0.035
0.036
0.038
0.040
0.015
0.022
0.020
0.038
0.027
0.013
0.026
0.037
0.042
0.025
0.028
0.029
0.030
0.030
0.040
0.030
0.030
0.012
0.023
0.024
0.026
0.026
0.035
0.043

mm

TOTAL
MATL
COILS

0.6
0.6
0.7
0.7
0.8
1.0
0.8
0.5
0.6
0.6
0.6
0.6
0.6
0.7
0.8
0.9
0.9
1.0
1.0
0.4
0.7
0.9
1.0
1.1
0.5
0.5
0.6
0.7
0.8
0.8
1.0
1.0
0.3
0.6
0.9
0.5
0.5
0.8
0.9
0.9
1.0
0.4
0.4
0.5
0.5
0.6
0.6
0.7
0.7
0.8
0.8
0.9
0.9
0.9
1.0
1.0
0.4
0.6
0.5
1.0
0.7
0.3
0.7
0.9
1.1
0.6
0.7
0.7
0.8
0.8
1.0
0.8
0.8
0.3
0.6
0.6
0.7
0.7
0.9
1.1

11.0
12.0
9.00
11.0
10.0
10.5
11.0
14.0
12.0
14.5
11.0
8.50
14.5
10.0
12.5
13.0
10.7
10.5
11.5
9.50
6.75
13.8
15.0
10.5
13.5
10.5
11.0
8.50
12.0
15.0
10.0
7.50
10.0
10.0
11.8
17.0
20.0
14.0
15.0
12.0
11.0
13.0
11.0
16.0
11.0
13.0
13.0
13.0
16.5
18.0
14.0
14.0
15.8
14.0
14.0
14.0
13.0
12.0
11.0
12.5
17.0
16.0
13.0
16.0
14.0
15.5
17.0
17.5
19.0
20.0
15.0
20.0
17.0
20.0
10.0
17.5
15.5
14.0
18.0
16.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
SST
MW
SPR
MW
MW
MW
MW
SST
MW
MW
MW
SST
SPR
SPR
SPR
SPR
SST
MW
SST
SST
SST
MW
MW
SST
MW
SPR
SST
MW
SPR
MW
SST
SPR
MW
SST
SST
SST
SPR
SST
MW
SST
SST
MW
MW
MW
SST
SST
MW
SPR
SPR
SST
SPR
SST
SST
SST
MW
MW
SST
MW
MW
MW
SPR
SPR
SST
MW
SST
SST
MW
SST
MW
MW
MW
SST
SST
SST
SST
SST
SPR

E
N
D
S

F
N
S
H

C
C
CG
CG
C
CG
C
C
C
C
CG
CG
CG
C
C
CG
CG
CG
CG
C
C
CG
CG
C
C
CG
C
C
CG
C
CG
C
C
C
CG
C
C
CG
CG
CG
CG
C
C
C
C
C
C
C
CG
CG
C
CG
CG
C
CG
CG
C
C
C
CG
CG
C
C
C
C
CG
C
C
CG
CG
CG
C
CG
C
C
C
C
C
C
CG

N
Z
N
N
GI
N
Z
Z
Z
BO
N
Z
N
N
N
Z
N
Z
N
N
N
N
N
N
Z
Z
N
N
N
N
N
N
N
N
Z
N
N
N
N
Z
N
GI
N
N
Z
Z
Z
N
N
GI
N
BO
N
Z
N
N
N
Z
Z
N
Z
N
N
GI
Z
N
GI
N
N
GI
N
Z
N
BO
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 49

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.234
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240

5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
5.94
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10

S-88
B9-41
W-6
B3-43
DD-46
S-1540
QQ-47
S-224
B5-26
CC-3
L-51
DD-95
TT-68
2804
3976
O-51
10431
3680
B4-21
2653
B12-68
O-42
11306
B2-68
3636
12738
70520
70520S
70536
70536S
70553
70553S
70577
70577S
70521
70521S
70537
70537S
70554
70554S
70578
70578S
70620
70620S
70642
70642S
70660
70660S
70679
70679S
70700
70700S
70720
70720S
12732
70522
70522S
70538
70538S
70555
70555S
70579
70579S
70600
70600S
70621
70621S
70643
70643S
70661
70661S
70680
70680S
70701
70701S
70721
70721S
70742
70742S
70761

1.28
1.31
1.31
1.33
1.44
1.50
1.50
1.50
1.50
1.50
1.69
1.81
1.88
2.00
2.22
2.25
2.25
2.44
2.50
2.53
2.56
2.75
3.25
3.33
4.50
7.25
.25
.25
.25
.25
.25
.25
.25
.25
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.31
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

32.5
33.3
33.3
33.7
36.5
38.1
38.1
38.1
38.1
38.1
42.8
46.0
47.6
50.8
56.4
57.2
57.2
61.9
63.5
64.3
65.1
69.9
82.6
84.5
114.3
184.2
6.4
6.4
6.4
6.4
6.4
6.4
6.4
6.4
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
7.9
9.5
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7

I.D.
Inches

.186
.192
.176
.180
.194
.206
.192
.186
.160
.154
.206
.188
.194
.164
.132
.204
.172
.182
.174
.164
.184
.150
.184
.158
.162
.156
.208
.208
.204
.204
.200
.200
.196
.196
.208
.208
.204
.204
.200
.200
.196
.196
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.204
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

4.7
4.9
4.5
4.6
4.9
5.2
4.9
4.7
4.1
3.9
5.2
4.8
4.9
4.2
3.4
5.2
4.4
4.6
4.4
4.2
4.7
3.8
4.7
4.0
4.1
4.0
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
5.2
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8

Lbs./In.

4.1
3.0
5.4
5.1
1.2
.50
1.3
2.8
20
30
.13
2.1
.97
11
68
.29
7.2
4.6
5.0
14
2.4
15
1.1
8.9
6.1
9.3
6.2
5.3
9.5
8.0
13
11
19
16
4.8
4.1
7.4
6.2
9.8
8.3
15
12
28
24
40
34
63
53
88
75
127
108
155
132
8.7
3.9
3.3
5.9
5.0
7.7
6.6
12
10
17
14
24
20
33
28
52
44
70
60
101
86
121
103
151
128
215

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.71
.53
.95
.89
.20
.09
.23
.50
3.5
5.2
.02
.36
.17
2.0
12
.05
1.3
.81
.88
2.5
.41
2.7
.19
1.6
1.1
1.6
1.1
.92
1.7
1.4
2.2
1.9
3.3
2.8
.84
.71
1.3
1.1
1.7
1.5
2.6
2.2
4.9
4.2
7.0
6.0
11
9.4
15
13
22
19
27
23
1.5
.68
.58
1.0
.88
1.4
1.1
2.1
1.8
2.9
2.5
4.1
3.5
5.7
4.9
9.1
7.7
12
10
18
15
21
18
26
22
38

.57
.78
.67
.79
1.0
.99
1.0
.82
.40
.34
1.1
.99
1.4
.83
.28
1.8
.97
.90
1.3
.49
1.6
.71
2.0
.97
1.7
1.0
.17
.13
.15
.12
.16
.12
.14
.11
.21
.17
.20
.16
.20
.16
.18
.14
.14
.11
.14
.11
.12
.09
.10
.08
.09
.07
.09
.07
.11
.26
.21
.25
.19
.26
.20
.22
.17
.21
.16
.17
.14
.17
.14
.14
.11
.13
.10
.12
.09
.11
.09
.10
.08
.09

mm

15
20
17
20
26
25
26
21
10
8.6
27
25
35
21
7.0
47
25
23
32
12
40
18
50
25
43
25
4.2
3.3
3.9
3.1
4.0
3.2
3.6
2.8
5.4
4.3
5.0
3.9
5.2
4.0
4.6
3.6
3.7
2.9
3.6
2.8
3.0
2.4
2.7
2.1
2.3
1.9
2.2
1.8
2.8
6.7
5.2
6.3
4.9
6.6
5.1
5.5
4.3
5.2
4.1
4.4
3.4
4.4
3.4
3.7
2.9
3.3
2.7
2.9
2.3
2.9
2.3
2.6
2.1
2.2

ENDS: C - Closed

G - Ground
O - Open

Lbs.

2.3
2.4
3.6
4.0
1.2
.50
1.4
2.3
8.0
10
.14
2.1
1.4
9.5
19
.53
7.0
4.2
6.3
6.8
3.7
11
2.2
8.7
10
9.3
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
.97
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19

10
10
16
18
5.2
2.2
6.1
10
36
45
.60
9.1
6.0
42
83
2.4
31
19
28
30
17
48
9.7
39
46
42
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
18
12
25
17
33
22
41
28
52
35
60
41
4.3
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85

Inches

.34
.24
.64
.54
.42
.17
.46
.45
.73
.80
.62
.48
.48
.91
1.35
.41
.78
.49
.91
.75
.73
1.60
1.30
1.81
1.94
1.99
.05
.05
.06
.06
.08
.08
.08
.08
.06
.06
.07
.07
.09
.09
.09
.09
.11
.11
.14
.14
.15
.15
.17
.17
.19
.19
.20
.20
.06
.07
.07
.08
.08
.10
.10
.10
.10
.12
.12
.13
.13
.15
.15
.17
.17
.19
.19
.21
.21
.23
.23
.25
.25
.26

mm

Inches

8.5
6.1
16.2
13.7
10.7
4.3
11.7
11.4
18.6
20.3
15.6
12.3
12.2
23.1
34.3
10.3
19.7
12.4
23.1
19.1
18.4
40.5
33.0
45.8
49.4
50.5
1.4
1.4
1.6
1.6
1.9
1.9
2.1
2.1
1.5
1.5
1.8
1.8
2.2
2.2
2.4
2.4
2.9
2.9
3.5
3.5
3.8
3.8
4.3
4.3
4.7
4.7
5.1
5.1
1.5
1.7
1.7
2.0
2.0
2.4
2.4
2.6
2.6
3.0
3.0
3.2
3.2
3.9
3.9
4.3
4.3
4.9
4.9
5.4
5.4
5.8
5.8
6.3
6.3
6.6

0.024
0.021
0.029
0.027
0.020
0.014
0.021
0.024
0.037
0.040
0.014
0.023
0.020
0.035
0.051
0.015
0.031
0.026
0.030
0.035
0.025
0.042
0.025
0.038
0.036
0.039
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.018
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045

mm

TOTAL
MATL
COILS

0.6
0.5
0.7
0.7
0.5
0.4
0.5
0.6
0.9
1.0
0.4
0.6
0.5
0.9
1.3
0.4
0.8
0.7
0.8
0.9
0.6
1.1
0.6
1.0
0.9
1.0
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
0.5
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1

13.0
11.5
21.0
19.0
20.0
11.0
21.0
17.8
19.8
19.0
43.0
20.0
23.0
26.0
25.5
26.0
24.0
17.8
29.3
21.5
28.0
38.0
51.0
46.5
53.0
50.0
3.38
3.38
3.50
3.50
3.75
3.75
3.75
3.75
3.75
3.75
3.88
3.88
4.25
4.25
4.25
4.25
4.38
4.38
4.75
4.75
4.63
4.63
4.88
4.88
4.88
4.88
5.00
5.00
3.38
4.13
4.13
4.38
4.38
4.75
4.75
4.63
4.63
4.88
4.88
4.88
4.88
5.25
5.25
5.25
5.25
5.50
5.50
5.63
5.63
5.75
5.75
5.88
5.88
5.75

SST
MW
SST
MW
SST
SST
SST
SST
SPR
SPR
MW
SST
SST
MW
SPR
MW
MW
MW
MW
SPR
MW
SST
SST
SPR
MW
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

F
N
S
H

C
CG
C
C
C
C
C
C
CG
C
C
C
C
CG
C
C
C
C
C
CG
C
CG
C
CL
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

N
Z
N
BO
N
N
N
N
N
N
N
N
N
Z
Z
N
GI
Z
N
Z
Z
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

49

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 50

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240

6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10

70761S
70523
70523S
70539
70539S
70556
70556S
70580
70580S
70601
70601S
70622
70622S
70644
70644S
70662
70662S
70681
70681S
70702
70702S
70722
70722S
70743
70743S
70762
70762S
70524
70524S
70540
70540S
70557
70557S
70581
70581S
70602
70602S
70623
70623S
70645
70645S
12730
70663
70663S
70682
70682S
70703
70703S
70723
70723S
70744
70744S
70763
70763S
70525
70525S
70541
70541S
70558
70558S
70582
70582S
70603
70603S
70624
70624S
70646
70646S
70664
70664S
70683
70683S
70704
70704S
70724
70724S
70745
70745S
70764
70764S

.38
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

9.7
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2

MATERIAL: MW - Music Wire

50

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150

RATE
mm

3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

183
3.3
2.8
5.0
4.3
6.5
5.5
9.9
8.4
14
12
20
17
27
23
43
37
59
50
84
72
100
85
123
105
176
149
2.9
2.5
4.4
3.7
5.7
4.8
8.8
7.4
12
10
17
15
24
20
31
36
31
50
43
72
61
85
72
106
90
149
127
2.5
2.1
3.9
3.3
5.1
4.3
7.8
6.6
11
9.1
14
12
21
18
32
27
44
37
63
54
74
63
94
80
130
111

32
.58
.49
.88
.74
1.1
.97
1.7
1.5
2.5
2.1
3.5
3.0
4.8
4.1
7.5
6.4
10
8.7
15
13
17
15
22
18
31
26
.51
.43
.76
.65
.99
.84
1.5
1.3
2.1
1.8
3.0
2.6
4.1
3.5
5.4
6.4
5.4
8.8
7.5
13
11
15
13
19
16
26
22
.44
.37
.67
.57
.88
.75
1.4
1.2
1.9
1.6
2.5
2.1
3.6
3.1
5.6
4.8
7.7
6.5
11
9.4
13
11
16
14
23
19

.07
.31
.24
.29
.23
.31
.24
.27
.21
.24
.19
.20
.16
.21
.16
.17
.14
.16
.13
.14
.11
.14
.11
.13
.10
.11
.09
.36
.28
.34
.26
.35
.28
.30
.24
.28
.22
.24
.19
.24
.19
.16
.21
.16
.18
.15
.16
.13
.16
.13
.15
.12
.13
.10
.41
.32
.38
.30
.39
.31
.34
.27
.32
.25
.28
.22
.27
.21
.23
.18
.21
.17
.19
.15
.18
.15
.17
.13
.15
.12

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

1.8
7.9
6.2
7.4
5.8
7.8
6.1
6.8
5.3
6.2
4.8
5.2
4.1
5.2
4.1
4.4
3.5
4.0
3.2
3.5
2.8
3.5
2.8
3.2
2.6
2.8
2.2
9.0
7.1
8.5
6.7
9.0
7.0
7.7
6.0
7.2
5.6
6.0
4.7
6.1
4.8
4.2
5.2
4.1
4.7
3.7
4.1
3.3
4.1
3.2
3.7
3.0
3.2
2.6
10
8.2
9.6
7.5
10
7.8
8.7
6.8
8.1
6.3
7.2
5.7
6.9
5.5
6.0
4.7
5.4
4.3
4.7
3.8
4.6
3.7
4.2
3.4
3.7
3.0

Lbs.

13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
5.0
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13

ENDS: C - Closed

G - Ground
O - Open

57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
22
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57

Inches

.26
.07
.07
.09
.09
.11
.11
.12
.12
.13
.13
.14
.14
.17
.17
.19
.19
.22
.22
.24
.24
.27
.27
.28
.28
.29
.29
.08
.08
.09
.09
.12
.12
.13
.13
.14
.14
.15
.15
.19
.19
.22
.21
.21
.25
.25
.27
.27
.30
.30
.31
.31
.33
.33
.09
.09
.10
.10
.13
.13
.14
.14
.15
.15
.17
.17
.21
.21
.23
.23
.27
.27
.29
.29
.33
.33
.34
.34
.37
.37

mm

6.6
1.8
1.8
2.2
2.2
2.7
2.7
2.9
2.9
3.3
3.3
3.5
3.5
4.4
4.4
4.8
4.8
5.6
5.6
6.2
6.2
6.7
6.7
7.1
7.1
7.4
7.4
2.0
2.0
2.3
2.3
3.0
3.0
3.2
3.2
3.6
3.6
3.9
3.9
4.9
4.9
5.5
5.4
5.4
6.2
6.2
6.8
6.8
7.5
7.5
7.9
7.9
8.4
8.4
2.2
2.2
2.6
2.6
3.2
3.2
3.5
3.5
3.9
3.9
4.4
4.4
5.3
5.3
5.9
5.9
6.9
6.9
7.5
7.5
8.4
8.4
8.7
8.7
9.3
9.3

WIRE DIA.
Inches

mm

0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045

1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1

FINISH: Z - Zinc

TOTAL
MATL
COILS
5.75
4.50
4.50
4.75
4.75
5.38
5.38
5.25
5.25
5.38
5.38
5.38
5.38
6.00
6.00
5.88
5.88
6.25
6.25
6.38
6.38
6.63
6.63
6.63
6.63
6.50
6.50
4.88
4.88
5.13
5.13
5.88
5.88
5.75
5.75
5.88
5.88
5.88
5.88
6.63
6.63
6.75
6.63
6.63
7.00
7.00
7.00
7.00
7.38
7.38
7.38
7.38
7.38
7.38
5.38
5.38
5.63
5.63
6.25
6.25
6.25
6.25
6.38
6.38
6.63
6.63
7.25
7.25
7.25
7.25
7.75
7.75
7.75
7.75
8.25
8.25
8.13
8.13
8.13
8.13

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 51

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240

6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10

B3-61
70526
70526S
70542
70542S
70560
70560S
70561
70561S
70583
70583S
70604
70604S
70625
70625S
70647
70647S
70665
70665S
70684
70684S
70705
70705S
70725
70725S
70746
70746S
70765
70765S
70527
70527S
70543
70543S
70562
70562S
70584
70584S
70605
70605S
70626
70626S
70648
70648S
70666
70666S
70685
70685S
70706
70706S
70726
70726S
70747
70747S
70766
70766S
70528
70528S
70544
70544S
70563
70563S
70585
70585S
B4-35
70606
70606S
70627
70627S
70649
70649S
70667
70667S
70686
70686S
70707
70707S
70727
70727S
70748
70748S

.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

15.1
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1

I.D.
Inches

.150
.208
.208
.204
.204
.200
.200
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0

Lbs./In.

159
2.3
2.0
3.5
2.9
5.1
4.3
3.3
2.8
6.9
5.9
9.6
8.1
13
11
18
16
28
24
39
33
57
48
67
57
85
72
115
98
2.0
1.7
3.1
2.6
4.1
3.4
6.1
5.2
8.7
7.4
11
9.4
17
14
25
21
35
30
51
43
59
50
75
64
102
87
1.9
1.6
2.8
2.4
3.7
3.1
5.6
4.7
4.7
7.8
6.6
10
8.5
15
13
22
19
31
27
46
39
55
47
65
55

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

28
.40
.34
.60
.51
.89
.76
.58
.49
1.2
1.0
1.7
1.4
2.2
1.9
3.2
2.7
4.9
4.2
6.8
5.8
9.9
8.4
12
9.9
15
13
20
17
.35
.30
.54
.46
.71
.60
1.1
.91
1.5
1.3
1.9
1.6
2.9
2.5
4.4
3.7
6.1
5.2
8.9
7.6
10
8.8
13
11
18
15
.33
.28
.49
.42
.65
.55
.97
.83
.82
1.4
1.2
1.8
1.5
2.7
2.3
3.8
3.3
5.5
4.7
8.1
6.9
9.7
8.2
11
9.6

Inches

.12
.45
.35
.42
.33
.39
.31
.46
.46
.38
.30
.36
.28
.32
.25
.30
.24
.27
.21
.24
.19
.21
.16
.20
.16
.18
.15
.17
.13
.51
.40
.47
.37
.49
.39
.43
.34
.39
.31
.37
.29
.34
.27
.30
.24
.27
.21
.23
.18
.23
.18
.21
.17
.19
.15
.54
.42
.52
.41
.54
.42
.48
.37
.37
.44
.34
.41
.32
.37
.29
.34
.27
.29
.23
.25
.20
.25
.20
.24
.19

mm

3.0
11
8.9
11
8.4
9.9
7.8
12
12
9.7
7.6
9.1
7.1
8.2
6.5
7.7
6.1
6.8
5.3
6.0
4.8
5.3
4.2
5.2
4.1
4.7
3.7
4.2
3.3
13
10
12
9.4
13
9.8
11
8.6
10
7.8
9.4
7.4
8.6
6.8
7.6
6.0
6.7
5.4
5.9
4.7
5.8
4.6
5.3
4.2
4.7
3.8
14
11
13
10
14
11
12
9.5
9.5
11
8.7
10
8.2
9.3
7.3
8.7
6.8
7.5
6.0
6.5
5.1
6.2
5.0
6.2
4.9

ENDS: C - Closed

G - Ground
O - Open

Lbs.

19
1.0
.68
1.5
.97
2.0
1.3
1.5
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11

85
4.6
3.0
6.5
4.3
8.9
5.9
6.8
5.7
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47

Inches

.32
.09
.09
.11
.11
.13
.13
.17
.17
.15
.15
.17
.17
.19
.19
.23
.23
.26
.26
.29
.29
.32
.32
.36
.36
.37
.37
.40
.40
.10
.10
.12
.12
.15
.15
.16
.16
.18
.18
.21
.21
.25
.25
.28
.28
.32
.32
.35
.35
.39
.39
.40
.40
.44
.44
.10
.10
.12
.12
.16
.16
.17
.17
.18
.20
.20
.23
.23
.26
.26
.31
.31
.35
.35
.38
.38
.42
.42
.46
.46

mm

Inches

8.0
2.3
2.3
2.7
2.7
3.2
3.2
4.3
4.3
3.8
3.8
4.3
4.3
4.9
4.9
5.8
5.8
6.5
6.5
7.4
7.4
8.1
8.1
9.0
9.0
9.3
9.3
10.1
10.1
2.5
2.5
3.0
3.0
3.7
3.7
4.1
4.1
4.6
4.6
5.4
5.4
6.3
6.3
7.1
7.1
8.2
8.2
8.8
8.8
9.9
9.9
10.3
10.3
11.1
11.1
2.6
2.6
3.1
3.1
4.0
4.0
4.4
4.4
4.5
5.0
5.0
5.8
5.8
6.7
6.7
7.8
7.8
8.9
8.9
9.5
9.5
10.5
10.5
11.6
11.6

0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042

mm

TOTAL
MATL
COILS

1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1

7.00
5.63
5.63
6.00
6.00
6.25
6.25
8.50
8.50
6.75
6.75
7.00
7.00
7.38
7.38
7.88
7.88
8.00
8.00
8.38
8.38
8.38
8.38
8.88
8.88
8.75
8.75
8.88
8.88
6.25
6.25
6.50
6.50
7.38
7.38
7.38
7.38
7.50
7.50
8.13
8.13
8.50
8.50
8.75
8.75
9.25
9.25
9.13
9.13
9.75
9.75
9.63
9.63
9.75
9.75
6.38
6.38
6.88
6.88
7.88
7.88
7.88
7.88
8.00
8.13
8.13
8.75
8.75
9.13
9.13
9.63
9.63
10.0
10.0
9.88
9.88
10.4
10.4
10.9
10.9

MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

51

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 52

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240

6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10

70767
70767S
70529
70529S
70545
70545S
70564
70564S
70586
70586S
70607
70607S
70628
70628S
70650
70650S
70668
70668S
70687
70687S
70708
70708S
70728
70728S
70749
70749S
70768
70768S
70530
70530S
70546
70546S
70565
70565S
70588
70588S
70608
70608S
70629
70629S
70651
70651S
70669
70669S
70688
70688S
70709
70709S
70729
70729S
70750
70750S
70769
70769S
70547
70547S
70567
70567S
70590
70590S
70610
70610S
70631
70631S
70652
70652S
70670
70670S
70689
70689S
70710
70710S
70730
70730S
70751
70751S
70770
70770S
70531
70531S

.75
.75
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
1.00
1.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

19.1
19.1
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
25.4
25.4

MATERIAL: MW - Music Wire

52

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208

RATE
mm

3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

93
79
1.7
1.4
2.6
2.2
3.4
2.8
5.1
4.3
7.2
6.1
9.2
7.8
14
12
20
17
29
24
42
36
49
41
60
51
85
72
1.6
1.4
2.4
2.0
3.1
2.6
4.7
4.0
6.5
5.5
8.2
7.0
13
11
19
16
26
22
38
32
45
39
56
48
78
66
2.2
1.9
3.2
2.7
4.4
3.7
5.9
5.0
7.8
6.6
12
9.9
17
15
24
21
35
30
42
36
51
43
72
62
1.4
1.2

16
14
.30
.25
.46
.39
.59
.50
.89
.76
1.3
1.1
1.6
1.4
2.4
2.1
3.5
3.0
5.0
4.3
7.4
6.3
8.5
7.3
11
8.9
15
13
.28
.24
.42
.36
.54
.46
.82
.70
1.1
.97
1.4
1.2
2.2
1.9
3.3
2.8
4.6
3.9
6.7
5.7
8.0
6.8
9.8
8.3
14
12
.39
.33
.56
.48
.77
.65
1.0
.88
1.4
1.2
2.0
1.7
3.0
2.6
4.2
3.6
6.1
5.2
7.3
6.2
8.9
7.6
13
11
.25
.21

.21
.16
.61
.47
.56
.44
.60
.47
.52
.41
.48
.37
.45
.35
.41
.32
.37
.29
.32
.26
.28
.22
.28
.22
.26
.21
.22
.18
.64
.50
.61
.48
.64
.50
.56
.44
.53
.41
.50
.39
.44
.35
.40
.32
.35
.28
.31
.25
.30
.24
.28
.22
.24
.19
.66
.52
.62
.49
.60
.47
.58
.45
.52
.41
.48
.38
.43
.34
.38
.30
.34
.27
.32
.26
.31
.24
.26
.21
.74
.58

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

5.2
4.1
15
12
14
11
15
12
13
10
12
9.5
11
8.9
10
8.1
9.5
7.5
8.2
6.5
7.1
5.6
7.1
5.6
6.6
5.3
5.7
4.5
16
13
15
12
16
13
14
11
13
10
13
9.9
11
8.8
10
8.0
8.9
7.1
7.8
6.2
7.6
6.1
7.1
5.6
6.2
4.9
17
13
16
12
15
12
15
12
13
10
12
9.6
11
8.7
9.7
7.7
8.6
6.8
8.2
6.6
7.8
6.2
6.7
5.3
19
15

Lbs.

19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68

ENDS: C - Closed

G - Ground
O - Open

85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0

Inches

.48
.48
.11
.11
.13
.13
.17
.17
.18
.18
.21
.21
.24
.24
.29
.29
.33
.33
.38
.38
.40
.40
.46
.46
.49
.49
.51
.51
.12
.12
.14
.14
.18
.18
.20
.20
.22
.22
.26
.26
.30
.30
.35
.35
.40
.40
.44
.44
.49
.49
.51
.51
.55
.55
.15
.15
.18
.18
.21
.21
.24
.24
.28
.28
.33
.33
.37
.37
.43
.43
.48
.48
.52
.52
.56
.56
.59
.59
.13
.13

mm

12.1
12.1
2.8
2.8
3.3
3.3
4.3
4.3
4.7
4.7
5.3
5.3
6.2
6.2
7.3
7.3
8.4
8.4
9.6
9.6
10.3
10.3
11.6
11.6
12.4
12.4
13.0
13.0
2.9
2.9
3.5
3.5
4.6
4.6
5.0
5.0
5.6
5.6
6.7
6.7
7.7
7.7
8.9
8.9
10.2
10.2
11.2
11.2
12.3
12.3
13.1
13.1
14.0
14.0
3.8
3.8
4.4
4.4
5.2
5.2
6.1
6.1
7.0
7.0
8.3
8.3
9.4
9.4
11.0
11.0
12.1
12.1
13.2
13.2
14.1
14.1
14.9
14.9
3.3
3.3

WIRE DIA.
Inches

0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016

mm

TOTAL
MATL
COILS

1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4

10.6
10.6
6.88
6.88
7.25
7.25
8.50
8.50
8.38
8.38
8.63
8.63
9.38
9.38
9.88
9.88
10.4
10.4
10.8
10.8
10.6
10.6
11.4
11.4
11.6
11.6
11.4
11.4
7.25
7.25
7.75
7.75
9.00
9.00
8.88
8.88
9.25
9.25
10.1
10.1
10.5
10.5
11.0
11.0
11.5
11.5
11.6
11.6
12.1
12.1
12.3
12.3
12.3
12.3
8.25
8.25
8.75
8.75
9.38
9.38
10.0
10.0
10.6
10.6
11.3
11.3
11.6
11.6
12.4
12.4
12.5
12.5
13.0
13.0
13.3
13.3
13.0
13.0
8.00
8.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 53

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240

6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10

70548
70548S
70568
70568S
70591
70591S
70611
70611S
70632
70632S
70653
70653S
70671
70671S
70690
70690S
70711
70711S
70731
70731S
70752
70752S
70771
70771S
70570
70570S
70593
70593S
70613
70613S
70634
70634S
70654
70654S
70673
70673S
70692
70692S
70712
70712S
70732
70732S
70753
70753S
70772
70772S
70532
70532S
70549
70549S
70571
70571S
70594
70594S
70614
70614S
70635
70635S
70655
70655S
70674
70674S
70693
70693S
70713
70713S
70733
70733S
70754
70754S
70773
70773S
70573
70573S
70596
70596S
70616
70616S
70637
70637S

1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1

I.D.
Inches

.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.200
.200
.196
.196
.192
.192
.188
.188

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

2.1
.37
1.8
.31
2.8
.48
2.3
.41
4.2
.74
3.6
.63
5.8
1.0
4.9
.86
7.4
1.3
6.3
1.1
11
2.0
9.5
1.7
16
2.8
14
2.4
23
4.0
19
3.4
33
5.7
28
4.9
39
6.9
33
5.8
48
8.4
41
7.1
67
12
57
10
2.7
.47
2.3
.40
3.6
.63
3.1
.54
4.9
.86
4.2
.73
6.4
1.1
5.4
.95
9.7
1.7
8.2
1.4
14
2.5
12
2.1
20
3.4
17
2.9
29
5.1
25
4.3
35
6.1
30
5.2
42
7.4
36
6.3
59
10
50
8.8
1.1
.19
.94
.16
1.7
.30
1.4
.25
2.2
.38
1.8
.32
3.3
.58
2.8
.49
4.6
.80
3.9
.68
5.9
1.0
5.0
.88
8.8
1.5
7.5
1.3
13
2.3
11
1.9
18
3.1
15
2.7
26
4.5
22
3.9
31
5.4
26
4.6
38
6.6
32
5.6
53
9.3
45
7.9
2.2
.39
1.9
.33
2.9
.51
2.5
.43
3.9
.68
3.3
.58
5.2
.91
4.4
.77

.70
.54
.73
.57
.63
.49
.59
.46
.55
.43
.50
.40
.47
.37
.41
.32
.36
.29
.35
.28
.33
.26
.28
.22
.74
.58
.73
.57
.70
.55
.64
.50
.58
.46
.53
.42
.47
.38
.41
.32
.39
.31
.37
.29
.32
.26
.94
.73
.86
.67
.93
.73
.80
.63
.75
.59
.69
.54
.64
.50
.58
.45
.52
.41
.45
.36
.44
.35
.41
.33
.36
.29
.91
.71
.91
.71
.88
.69
.78
.62

mm

18
14
18
14
16
12
15
12
14
11
13
10
12
9.4
10
8.2
9.1
7.3
8.8
7.0
8.3
6.6
7.2
5.7
19
15
19
15
18
14
16
13
15
12
14
11
12
9.5
10
8.2
9.9
7.9
9.4
7.5
8.2
6.5
24
19
22
17
24
18
20
16
19
15
18
14
16
13
15
12
13
10
11
9.2
11
8.9
11
8.4
9.1
7.3
23
18
23
18
22
17
20
16

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7

6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
8.9
5.9
12
7.8
15
10
18
12

Inches

.16
.16
.20
.20
.21
.21
.25
.25
.29
.29
.34
.34
.40
.40
.46
.46
.50
.50
.55
.55
.59
.59
.62
.62
.20
.20
.24
.24
.28
.28
.33
.33
.38
.38
.45
.45
.52
.52
.56
.56
.61
.61
.66
.66
.69
.69
.15
.15
.18
.18
.24
.24
.26
.26
.30
.30
.35
.35
.42
.42
.48
.48
.56
.56
.61
.61
.68
.68
.72
.72
.77
.77
.24
.24
.29
.29
.34
.34
.39
.39

mm

Inches

3.9
3.9
5.0
5.0
5.4
5.4
6.2
6.2
7.3
7.3
8.7
8.7
10.2
10.2
11.6
11.6
12.7
12.7
14.0
14.0
14.9
14.9
15.7
15.7
5.1
5.1
6.1
6.1
7.1
7.1
8.3
8.3
9.7
9.7
11.4
11.4
13.1
13.1
14.1
14.1
15.5
15.5
16.7
16.7
17.6
17.6
3.9
3.9
4.6
4.6
6.1
6.1
6.6
6.6
7.5
7.5
8.8
8.8
10.6
10.6
12.1
12.1
14.2
14.2
15.4
15.4
17.1
17.1
18.4
18.4
19.4
19.4
6.0
6.0
7.4
7.4
8.6
8.6
9.8
9.8

0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026

mm

TOTAL
MATL
COILS

0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7

8.63
8.63
9.88
9.88
9.75
9.75
10.3
10.3
11.0
11.0
11.8
11.8
12.5
12.5
13.0
13.0
13.1
13.1
13.8
13.8
14.0
14.0
13.8
13.8
10.0
10.0
11.0
11.0
11.6
11.6
12.5
12.5
13.1
13.1
14.0
14.0
14.8
14.8
14.6
14.6
15.3
15.3
15.6
15.6
15.4
15.4
9.63
9.63
10.1
10.1
12.0
12.0
11.9
11.9
12.4
12.4
13.4
13.4
14.4
14.4
14.9
14.9
16.0
16.0
16.0
16.0
16.9
16.9
17.3
17.3
17.0
17.0
11.9
11.9
13.3
13.3
14.1
14.1
14.9
14.9

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

53

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 54

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240

6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10

70656
70656S
70675
70675S
70694
70694S
70714
70714S
70734
70734S
70755
70755S
70533
70533S
70550
70550S
70574
70574S
70597
70597S
70617
70617S
70638
70638S
70657
70657S
70676
70676S
70695
70695S
70715
70715S
70735
70735S
70756
70756S
70774
70774S
70534
70534S
70551
70551S
70575
70575S
70598
70598S
70618
70618S
70639
70639S
70658
70658S
70677
70677S
70696
70696S
70716
70716S
70736
70736S
70757
70757S
70775
70775S
70535
70535S
70552
70552S
70576
70576S
70599
70599S
70619
70619S
70640
70640S
70659
70659S
70678
70678S

1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8

MATERIAL: MW - Music Wire

54

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.208
.208
.204
.204
.200
.200
.196
.196
.192
.192
.188
.188
.182
.182
.176
.176

RATE
mm

4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
4.9
4.9
4.8
4.8
4.6
4.6
4.5
4.5

Lbs./In.

7.8
6.6
12
9.9
16
14
23
20
28
23
34
29
.90
.77
1.4
1.2
1.8
1.5
2.8
2.4
3.7
3.2
4.9
4.2
7.3
6.2
11
9.1
15
12
21
18
25
22
31
26
43
37
.80
.68
1.2
1.0
1.5
1.3
2.4
2.0
3.3
2.8
4.2
3.5
6.2
5.2
9.2
7.8
12
11
18
15
22
18
27
23
37
31
.70
.60
1.0
.85
1.3
1.1
2.1
1.7
2.8
2.3
3.6
3.1
5.4
4.6
8.0
6.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.4
1.2
2.0
1.7
2.8
2.4
4.1
3.5
4.8
4.1
6.0
5.1
.16
.13
.25
.21
.31
.27
.49
.42
.65
.55
.86
.73
1.3
1.1
1.9
1.6
2.6
2.2
3.7
3.2
4.5
3.8
5.4
4.6
7.6
6.5
.14
.12
.21
.18
.26
.22
.41
.35
.57
.48
.73
.62
1.1
.92
1.6
1.4
2.2
1.8
3.1
2.6
3.8
3.2
4.6
3.9
6.5
5.5
.12
.10
.18
.15
.23
.20
.36
.31
.48
.41
.63
.54
.94
.80
1.4
1.2

.72
.57
.65
.51
.58
.46
.51
.40
.49
.39
.46
.37
1.1
.89
1.0
.82
1.1
.87
.94
.74
.92
.72
.83
.66
.77
.61
.70
.55
.63
.50
.55
.44
.53
.43
.51
.40
.44
.35
1.3
1.0
1.2
.95
1.3
1.0
1.1
.88
1.1
.82
.98
.77
.91
.72
.81
.64
.75
.59
.66
.53
.63
.50
.59
.47
.52
.41
1.5
1.2
1.5
1.1
1.5
1.2
1.3
1.0
1.2
.97
1.1
.89
1.0
.82
.94
.74

mm

18
14
16
13
15
12
13
10
13
10
12
9.3
29
23
26
21
28
22
24
19
23
18
21
17
20
15
18
14
16
13
14
11
14
11
13
10
11
8.9
33
26
31
24
34
26
29
22
27
21
25
20
23
18
21
16
19
15
17
13
16
13
15
12
13
10
37
29
37
29
38
30
33
26
32
25
29
23
27
21
24
19

Lbs.

5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0
9.2
6.3
12
7.9
14
9.2
16
11
19
13
1.0
.68
1.5
.97
2.0
1.3
2.6
1.8
3.4
2.3
4.1
2.7
5.6
3.8
7.5
5.0

ENDS: C - Closed

G - Ground
O - Open

25
17
33
22
41
28
52
35
60
41
70
47
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22
41
28
52
35
60
41
70
47
85
57
4.6
3.0
6.5
4.3
8.9
5.9
12
7.8
15
10
18
12
25
17
33
22

Inches

.46
.46
.53
.53
.62
.62
.67
.67
.75
.75
.80
.80
.18
.18
.21
.21
.28
.28
.30
.30
.35
.35
.41
.41
.49
.49
.57
.57
.67
.67
.73
.73
.81
.81
.87
.87
.91
.91
.20
.20
.24
.24
.33
.33
.35
.35
.40
.40
.47
.47
.57
.57
.65
.65
.78
.78
.86
.86
.94
.94
1.00
1.00
1.06
1.06
.22
.22
.28
.28
.37
.37
.39
.39
.46
.46
.53
.53
.64
.64
.74
.74

mm

11.7
11.7
13.4
13.4
15.8
15.8
17.0
17.0
19.1
19.1
20.3
20.3
4.6
4.6
5.4
5.4
7.2
7.2
7.6
7.6
9.0
9.0
10.3
10.3
12.4
12.4
14.4
14.4
16.9
16.9
18.5
18.5
20.4
20.4
22.1
22.1
23.1
23.1
5.1
5.1
6.2
6.2
8.3
8.3
8.9
8.9
10.1
10.1
12.0
12.0
14.4
14.4
16.5
16.5
19.8
19.8
21.8
21.8
23.7
23.7
25.3
25.3
26.9
26.9
5.7
5.7
7.2
7.2
9.3
9.3
10.0
10.0
11.7
11.7
13.5
13.5
16.3
16.3
18.7
18.7

WIRE DIA.
Inches

0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.016
0.016
0.018
0.018
0.020
0.020
0.022
0.022
0.024
0.024
0.026
0.026
0.029
0.029
0.032
0.032

mm

TOTAL
MATL
COILS

0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.4
0.4
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8

15.9
15.9
16.5
16.5
17.8
17.8
17.6
17.6
18.8
18.8
19.0
19.0
11.4
11.4
11.9
11.9
14.1
14.1
13.6
13.6
14.8
14.8
15.6
15.6
16.9
16.9
17.8
17.8
19.0
19.0
19.1
19.1
20.1
20.1
20.8
20.8
20.3
20.3
12.5
12.5
13.5
13.5
16.3
16.3
15.9
15.9
16.6
16.6
18.1
18.1
19.5
19.5
20.3
20.3
22.3
22.3
22.6
22.6
23.4
23.4
23.8
23.8
23.5
23.5
14.0
14.0
15.8
15.8
18.3
18.3
17.9
17.9
19.3
19.3
20.5
20.5
22.1
22.1
23.0
23.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 55

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.240
0.245
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250

6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.10
6.22
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35

70697
70697S
70717
70717S
70737
70737S
70758
70758S
70776
70776S
70698
70698S
70718
70718S
70738
70738S
70759
70759S
70777
70777S
A12-23
70699
70699S
70719
70719S
70739
70739S
70760
70760S
70778
70778S
70740
70740S
70741
70741S
12691
B8-29
10200
A15-20
K-78
Q-94
10269
U-24
CC-26
L-40
DD-33
G-83
DD-63
F-49
S-116
MM-9
A9-3
AA-16
O-158
F-94
B15-10
A15-8
RR-25
PP-17
Z-2
CC-63
LL-85
EE-49
PP-55
II-41
11366
BB-22
AA-39
3566
10218
A15-14
10958
A-26
A-84
F-15
II-33
B-89
12744
WW-57
FF-73

2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.34
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
3.25
3.25
5.25
5.25
3.67
.16
.19
.19
.22
.25
.25
.25
.25
.25
.28
.28
.28
.28
.31
.31
.31
.31
.31
.31
.31
.34
.34
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.41
.41
.41
.44

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
59.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
82.6
82.6
133.4
133.4
93.2
4.0
4.8
4.8
5.6
6.4
6.4
6.4
6.4
6.4
7.1
7.1
7.1
7.1
7.9
7.9
7.9
7.9
7.9
7.9
7.9
8.7
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
10.3
10.3
10.3
11.1

I.D.
Inches

.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.164
.170
.170
.164
.164
.160
.160
.156
.156
.150
.150
.160
.160
.160
.160
.175
.182
.214
.164
.174
.222
.220
.200
.186
.178
.220
.214
.210
.188
.226
.210
.190
.190
.188
.186
.186
.172
.170
.164
.210
.210
.208
.202
.202
.198
.194
.188
.186
.180
.180
.166
.226
.202
.200
.198
.198
.196
.192
.162
.222

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
4.2
4.3
4.3
4.2
4.2
4.1
4.1
4.0
4.0
3.8
3.8
4.1
4.1
4.1
4.1
4.4
4.6
5.4
4.2
4.4
5.6
5.6
5.1
4.7
4.5
5.6
5.4
5.3
4.8
5.7
5.3
4.8
4.8
4.8
4.7
4.7
4.4
4.3
4.2
5.3
5.3
5.3
5.1
5.1
5.0
4.9
4.8
4.7
4.6
4.6
4.2
5.7
5.1
5.1
5.0
5.0
5.0
4.9
4.1
5.6

Lbs./In.

11
9.3
16
13
19
16
23
20
32
27
9.7
8.2
14
12
17
14
20
17
28
24
8.3
8.8
7.4
12
10
15
13
18
15
25
22
22
18
17
14
6.1
191
8.1
369
159
.48
2.2
16
73
123
.98
4.0
6.3
56
.32
5.5
42
27
44
58
48
105
265
185
3.7
6.7
5.8
10
14
19
19
27
42
54
43
126
.37
9.0
12
19
13
14
21
119
1.1

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

1.9
1.6
2.7
2.3
3.3
2.8
4.0
3.4
5.6
4.8
1.7
1.4
2.4
2.0
2.9
2.5
3.6
3.0
5.0
4.2
1.4
1.5
1.3
2.2
1.8
2.6
2.2
3.2
2.7
4.4
3.8
3.8
3.2
2.9
2.5
1.1
33
1.4
65
28
.08
.39
2.9
13
22
.17
.71
1.1
9.8
.06
.96
7.3
4.8
7.7
10
8.5
18
46
32
.64
1.2
1.0
1.8
2.4
3.4
3.3
4.8
7.4
9.5
7.6
22
.06
1.6
2.2
3.4
2.2
2.4
3.7
21
.18

.85
.67
.75
.60
.72
.57
.68
.54
.59
.47
.95
.76
.85
.68
.82
.66
.76
.61
.67
.53
.56
1.1
.84
.95
.76
.91
.73
.87
.69
.75
.60
.63
.50
.81
.65
1.0
.03
.11
.03
.05
.09
.17
.10
.09
.06
.18
.17
.16
.08
.20
.21
.10
.13
.10
.09
.11
.08
.04
.06
.23
.19
.23
.21
.23
.20
.17
.16
.11
.16
.10
.08
.30
.24
.26
.20
.21
.19
.19
.10
.34

22
17
19
15
18
15
17
14
15
12
24
19
22
17
21
17
19
15
17
14
14
27
21
24
19
23
18
22
18
19
15
16
13
21
16
25
.83
2.7
.80
1.2
2.2
4.2
2.5
2.3
1.4
4.5
4.4
4.1
2.0
5.2
5.4
2.4
3.4
2.5
2.3
2.7
2.0
.91
1.6
5.7
4.8
5.8
5.3
5.9
5.1
4.3
4.1
2.9
4.2
2.4
2.1
7.6
6.2
6.5
5.1
5.3
4.8
4.8
2.5
8.6

ENDS: C - Closed

G - Ground
O - Open

Lbs.

9.2
6.3
12
7.9
14
9.2
16
11
19
13
9.2
6.3
12
7.9
14
9.2
16
11
19
13
4.6
9.2
6.3
12
7.9
14
9.2
16
11
19
13
14
9.2
14
9.2
6.1
6.2
.86
12
7.7
.04
.37
1.6
6.5
7.0
.17
.70
1.0
4.4
.07
1.2
4.0
3.6
4.4
5.2
5.2
8.2
9.5
12
.82
1.3
1.3
2.1
3.2
3.9
3.3
4.4
4.8
8.9
4.1
10
.11
2.2
3.2
3.9
2.6
2.6
3.9
12
.36

41
28
52
35
60
41
70
47
85
57
41
28
52
35
60
41
70
47
85
57
21
41
28
52
35
60
41
70
47
85
57
60
41
60
41
27
28
3.8
52
34
.18
1.7
7.3
29
31
.76
3.1
4.5
20
.29
5.2
18
16
20
23
23
37
42
52
3.7
5.7
5.9
9.5
14
17
15
20
21
40
18
45
.49
9.7
14
17
12
12
18
52
1.6

Inches

.88
.88
.96
.96
1.05
1.05
1.13
1.13
1.20
1.20
.98
.98
1.08
1.08
1.20
1.20
1.27
1.27
1.35
1.35
1.79
1.07
1.07
1.20
1.20
1.32
1.32
1.42
1.42
1.50
1.50
.93
.93
1.18
1.18
1.26
.10
.08
.15
.14
.16
.08
.15
.16
.14
.11
.11
.12
.16
.11
.10
.13
.18
.14
.18
.16
.20
.18
.22
.15
.09
.15
.17
.14
.16
.16
.19
.16
.21
.28
.23
.11
.14
.15
.16
.16
.22
.22
.29
.10

mm

Inches

22.2
22.2
24.5
24.5
26.7
26.7
28.8
28.8
30.6
30.6
24.8
24.8
27.5
27.5
30.4
30.4
32.1
32.1
34.3
34.3
45.4
27.2
27.2
30.5
30.5
33.4
33.4
36.1
36.1
38.0
38.0
23.6
23.6
30.0
30.0
32.0
2.6
2.1
3.8
3.6
4.2
2.1
3.8
4.1
3.7
2.7
2.7
3.0
3.9
2.7
2.5
3.3
4.6
3.5
4.5
4.1
5.0
4.6
5.5
3.8
2.3
3.7
4.3
3.7
4.0
4.1
4.7
4.1
5.3
7.1
5.9
2.7
3.7
3.8
4.0
4.0
5.5
5.5
7.3
2.5

0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.038
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.040
0.040
0.040
0.040
0.035
0.034
0.018
0.043
0.038
0.014
0.015
0.025
0.032
0.036
0.015
0.018
0.020
0.031
0.012
0.020
0.030
0.030
0.031
0.032
0.032
0.039
0.040
0.043
0.020
0.020
0.021
0.024
0.024
0.026
0.028
0.031
0.032
0.035
0.035
0.042
0.012
0.024
0.025
0.026
0.026
0.027
0.029
0.044
0.014

mm

TOTAL
MATL
COILS

0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.0
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.0
1.0
1.0
1.0
0.9
0.9
0.5
1.1
1.0
0.4
0.4
0.6
0.8
0.9
0.4
0.5
0.5
0.8
0.3
0.5
0.8
0.8
0.8
0.8
0.8
1.0
1.0
1.1
0.5
0.5
0.5
0.6
0.6
0.7
0.7
0.8
0.8
0.9
0.9
1.1
0.3
0.6
0.6
0.7
0.7
0.7
0.7
1.1
0.4

25.0
25.0
25.4
25.4
26.3
26.3
27.0
27.0
26.8
26.8
27.9
27.9
28.5
28.5
29.9
29.9
30.1
30.1
30.0
30.0
46.0
30.6
30.6
31.6
31.6
32.9
32.9
33.9
33.9
33.3
33.3
23.3
23.3
29.5
29.5
35.0
3.00
3.50
3.50
3.75
10.8
4.50
5.00
4.00
4.00
7.00
5.00
5.00
4.00
8.00
5.00
4.33
6.00
4.50
4.50
5.00
5.00
3.50
5.00
6.50
4.50
6.00
6.00
5.00
5.00
5.75
6.00
5.00
6.00
7.00
5.50
8.00
6.00
6.00
5.00
6.00
7.00
6.50
6.50
6.00

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SPR
MW
SPR
SST
MW
MW
MW
MW
SPR
SST
MW
MW
SST
SST
SST
SST
MW
SST
SPR
SPR
SST
SPR
SPR
SST
SST
MW
MW
MW
MW
SST
SST
SST
MW
SPR
SST
MW
SST
MW
MW
SST
MW
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
C
C
C
CG
CG
C
C
C
C
C
CG
CG
CG
C
CG
CG
C
CG
C
CG
C
C
C
C
CG
CG
CG
CG
C
CG
C
CG
CG
C
CG
C
C
CG
C

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
Z
N
GI
N
Z
N
GI
N
N
N
N
N
Z
N
Z
Z
N
N
GI
N
N
N
Z
Z
N
N
N
N
Z
Z
N
N
N
GI
Z
N
Z
N
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

55

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:23 AM Page 56

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250

6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35

CC-43
L-14
2821
AA-13
B18-156
F-97
B5-24
F-25
A12-22
V-98
4278
BB-74
G-98
L-92
F-23
J-71
J-72
B15-3
S-794
V-100
H-94
S-717
BB-16
HH-84
B15-68
GG-46
3985
F-13
S-1178
Z-53
B2-9
2532
HH-13
XX-63
12734
B9-16
NN-59
2556
529
NN-15
NN-73
FF-13
A9-11
B1-48
O-155
BB-9
518
FF-81
I-83
NN-48
L-100
OO-58
S-163
Q-14
2929
S-31
2611
A-23
A14-9
NN-39
EE-41
H-92
S-836
O-62
AA-11
S-1239
J-10
F-50
926
S-1109
M-100
B7-5
10277
F-12
F-96
O-54
B14-58
W-59
10756
10959

.44
.44
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.47
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.52
.53
.53
.53
.53
.53
.53
.53
.53
.53
.53
.53
.53
.55
.56
.56
.56
.56
.56
.59
.59
.59
.59
.59
.59
.59
.59
.59
.63

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.1
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.9
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.1
15.9

MATERIAL: MW - Music Wire

56

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.210
.210
.206
.206
.202
.200
.194
.184
.228
.212
.210
.210
.206
.190
.184
.172
.168
.120
.210
.210
.208
.206
.204
.204
.204
.202
.200
.200
.200
.200
.200
.198
.196
.196
.192
.192
.190
.186
.180
.180
.180
.180
.178
.172
.172
.170
.168
.160
.158
.142
.130
.210
.214
.192
.180
.180
.176
.172
.172
.170
.170
.166
.166
.150
.170
.218
.206
.194
.186
.154
.208
.206
.200
.198
.184
.180
.180
.172
.170
.222

RATE
mm

5.3
5.3
5.2
5.2
5.1
5.1
4.9
4.7
5.8
5.4
5.3
5.3
5.2
4.8
4.7
4.4
4.3
3.0
5.3
5.3
5.3
5.2
5.2
5.2
5.2
5.1
5.1
5.1
5.1
5.1
5.1
5.0
5.0
5.0
4.9
4.9
4.8
4.7
4.6
4.6
4.6
4.6
4.5
4.4
4.4
4.3
4.3
4.1
4.0
3.6
3.3
5.3
5.4
4.9
4.6
4.6
4.5
4.4
4.4
4.3
4.3
4.2
4.2
3.8
4.3
5.5
5.2
4.9
4.7
3.9
5.3
5.2
5.1
5.0
4.7
4.6
4.6
4.4
4.3
5.6

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

3.3
.58
2.3
.41
8.1
1.4
7.1
1.2
12
2.1
14
2.5
20
3.5
48
8.3
.26
.05
1.9
.34
3.8
.66
2.8
.49
7.2
1.3
22
3.8
42
7.3
71
12
89
16
1351 237
3.5
.61
3.2
.55
3.1
.54
6.6
1.2
7.5
1.3
4.6
.81
4.4
.76
10
1.8
16
2.9
12
2.2
14
2.5
11
1.9
9.9
1.7
12
2.0
8.6
1.5
11
2.0
17
3.0
19
3.3
22
3.8
29
5.1
42
7.4
54
9.5
28
4.8
31
5.5
49
8.6
64
11
79
14
58
10
85
15
144
25
126
22
353
62
429
75
4.7
.83
1.8
.31
13
2.4
54
9.5
32
5.6
70
12
54
9.4
59
10
79
14
50
8.8
75
13
77
13
160
28
79
14
.91
.16
4.1
.72
12
2.0
26
4.6
134
23
3.4
.60
5.7
1.0
6.2
1.1
13
2.3
30
5.3
31
5.4
27
4.8
52
9.2
76
13
.99
.17

.28
.24
.30
.28
.28
.25
.24
.12
.37
.30
.31
.31
.23
.19
.14
.12
.11
.03
.35
.32
.30
.26
.26
.28
.29
.32
.21
.28
.16
.22
.30
.29
.26
.26
.21
.29
.26
.18
.15
.12
.19
.19
.14
.14
.11
.15
.12
.09
.11
.06
.05
.38
.37
.27
.12
.19
.15
.15
.15
.12
.17
.14
.13
.08
.12
.40
.36
.28
.27
.11
.43
.44
.32
.30
.19
.21
.24
.16
.13
.47

7.1
6.0
7.5
7.2
7.1
6.3
6.2
3.0
9.4
7.5
7.8
7.8
6.0
4.7
3.5
3.2
2.9
.65
8.8
8.1
7.5
6.5
6.5
7.2
7.4
8.1
5.4
7.2
4.2
5.5
7.6
7.4
6.5
6.5
5.3
7.3
6.6
4.5
3.7
3.0
4.7
4.9
3.6
3.5
2.8
3.9
3.0
2.3
2.8
1.4
1.3
9.5
9.4
6.9
3.0
4.8
3.8
3.9
3.8
3.0
4.3
3.4
3.4
2.1
3.0
10
9.2
7.2
6.9
2.8
11
11
8.1
7.7
4.8
5.3
6.0
4.0
3.2
12

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs.

.91
4.1
.56
2.5
2.4
11
2.0
9.0
3.3
15
3.5
16
4.9
22
5.7
25
.09
.42
.57
2.5
1.2
5.2
.86
3.8
1.7
7.5
4.0
18
5.7
25
8.8
39
10
45
34
153
1.2
5.3
1.0
4.5
.90
4.0
1.7
7.5
1.9
8.6
1.3
5.8
1.3
5.7
3.3
15
3.5
16
3.5
16
2.3
10
2.3
10
3.0
13
3.4
15
2.2
9.8
3.0
13
3.6
16
5.4
24
5.7
25
5.2
23
6.2
28
6.4
29
5.1
23
6.0
27
7.0
31
8.8
39
8.8
39
8.9
39
10
45
13
59
14
63
20
87
21
96
1.8
7.9
.66
2.9
3.6
16
6.4
29
6.0
27
10
47
8.2
37
8.8
39
9.5
42
8.6
38
10
45
10
45
13
58
9.5
42
.37
1.6
1.5
6.7
3.3
14
7.2
32
15
66
1.5
6.5
2.5
11
2.0
8.7
3.9
17
5.7
25
6.4
29
6.4
29
8.2
37
9.5
42
.47
2.1

ENDS: C - Closed

G - Ground
O - Open

Inches

.16
.20
.14
.15
.13
.16
.13
.21
.10
.17
.16
.16
.12
.20
.23
.27
.29
.33
.16
.18
.20
.15
.16
.22
.21
.17
.15
.18
.15
.18
.20
.21
.24
.24
.20
.20
.24
.26
.29
.25
.32
.28
.25
.29
.29
.32
.34
.30
.37
.32
.45
.14
.16
.26
.25
.32
.22
.30
.31
.32
.36
.33
.37
.45
.28
.16
.20
.28
.27
.38
.17
.15
.28
.20
.28
.32
.35
.31
.29
.10

mm

4.1
5.1
3.6
3.9
3.4
4.1
3.4
5.4
2.5
4.3
4.1
4.1
3.1
5.0
5.9
6.9
7.3
8.3
3.9
4.6
5.2
3.8
4.1
5.5
5.3
4.3
3.8
4.4
3.8
4.4
5.1
5.3
6.2
6.2
5.0
5.2
6.1
6.5
7.2
6.2
8.0
7.1
6.4
7.4
7.4
8.1
8.6
7.7
9.3
8.2
11.4
3.6
4.1
6.6
6.2
8.0
5.6
7.7
7.9
8.1
9.1
8.3
9.3
11.4
7.1
4.1
5.0
7.1
6.9
9.8
4.3
3.9
7.0
5.0
7.1
8.0
8.9
7.9
7.4
2.4

WIRE DIA.
Inches

0.020
0.020
0.022
0.022
0.024
0.025
0.028
0.033
0.011
0.019
0.020
0.020
0.022
0.030
0.033
0.039
0.041
0.065
0.020
0.020
0.021
0.022
0.023
0.023
0.023
0.024
0.025
0.025
0.025
0.025
0.025
0.026
0.027
0.027
0.029
0.029
0.030
0.032
0.035
0.035
0.035
0.035
0.036
0.039
0.039
0.040
0.041
0.045
0.046
0.054
0.060
0.020
0.018
0.029
0.035
0.035
0.037
0.039
0.039
0.040
0.040
0.042
0.042
0.050
0.040
0.016
0.022
0.028
0.032
0.048
0.021
0.022
0.025
0.026
0.033
0.035
0.035
0.039
0.040
0.014

mm

TOTAL
MATL
COILS

0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.8
0.3
0.5
0.5
0.5
0.6
0.8
0.8
1.0
1.0
1.7
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.89
0.9
0.9
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.2
1.4
1.5
0.5
0.5
0.7
0.9
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.3
1.0
0.4
0.6
0.7
0.8
1.2
0.5
0.6
0.6
0.7
0.8
0.9
0.9
1.0
1.0
0.4

7.00
9.00
5.50
6.00
5.50
5.50
6.00
5.50
8.00
9.00
7.00
8.00
5.50
6.50
6.00
7.00
7.00
5.00
6.75
8.00
8.75
5.75
6.00
8.50
9.00
6.00
5.00
6.00
5.00
6.00
7.00
7.00
9.00
8.00
6.75
7.00
7.00
7.00
7.13
6.00
9.00
8.00
7.00
7.50
6.50
8.00
7.25
6.75
8.00
6.00
7.50
6.00
8.00
9.00
6.00
8.00
6.00
7.75
8.00
7.00
9.00
7.75
7.75
9.00
7.00
9.00
8.00
9.00
7.50
8.00
8.00
7.00
10.0
6.50
7.50
9.00
10.0
8.00
7.25
5.75

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SST
MW
MW
MW
MW
MW
SPR
MW
SST
MW
SST
SST
SST
SPR
SPR
SPR
SPR
SST
MW
SST
SST
SST
SST
SST
MW
MW
MW
SST
SST
MW
MW
SST
MW
SST
MW
MW
HD
HD
SPR
SST
SST
SPR
SPR
SPR
SST
HD
SPR
SPR
SST
SST
MW
SST
MW
SPR
SST
MW
SST
SPR
SPR
SST
SST
SST
SPR
SPR
SST
SST
MW
MW
SST
SST
MW
MW
MW
HD
SPR
SPR
SST
SPR
SST

E
N
D
S

C
C
C
C
CG
C
CG
C
C
CG
C
CG
CG
CG
C
CG
CG
CG
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
CG
C
CG
CG
CL
C
C
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
C
CG
C
C
CG
CG
CG
C
CG
CG
C
CG
CG
C
C
C
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
C

F
N
S
H

N
N
Z
Z
N
Z
N
Z
Z
N
Z
N
N
N
Z
Z
N
N
N
N
N
N
N
N
N
Z
Z
Z
N
N
N
Z
N
Z
N
Z
N
Z
Z
Z
N
N
N
N
Z
N
Z
Z
N
N
N
N
N
Z
Z
N
Z
N
GI
N
N
N
N
Z
Z
N
N
Z
Z
N
N
N
Z
Z
Z
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 57

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250

6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35

A-62
MM-96
BB-61
GG-47
A15-2
AA-30
S-718
O-60
10383
W-5
1931
JJ-95
PP-11
F-10
212
A14-28
Y-10
A13-9
10475
N-8
B7-7
10554
935
2524
Z-56
A10-54
EE-81
W-49
S-317
RR-46
KK-98
10609
F-1
B1-44
HH-32
KK-24
J-98
J-49
B18-139
HH-94
AA-27
3584
B1-4
V-22
B15-53
B3-46
W-53
J-54
S-719
Q-89
A15-45
B2-12
A14-20
F-41
2977
N-60
Q-67
3733
K-58
S-720
H-19
W-83
F-9
K-90
B2-15
B14-10
G-13
K-28
A15-10
NN-75
G-63
HH-63
B14-36
TT-64
O-86
LL-58
F-26
KK-26
12713
K-16

.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.66
.66
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.72
.72
.73
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.77
.78
.78
.78
.78
.78
.78

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
16.7
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
18.2
18.6
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.4
19.8
19.8
19.8
19.8
19.8
19.8

I.D.
Inches

.214
.214
.210
.210
.206
.206
.206
.200
.194
.194
.192
.190
.186
.186
.182
.182
.176
.164
.160
.202
.198
.196
.188
.186
.186
.184
.176
.176
.220
.210
.206
.202
.200
.198
.190
.190
.188
.186
.178
.174
.170
.166
.164
.212
.172
.168
.210
.206
.206
.206
.204
.204
.202
.198
.194
.188
.188
.186
.186
.186
.186
.184
.184
.180
.180
.176
.174
.168
.166
.160
.158
.150
.146
.130
.220
.206
.192
.190
.174
.168

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.4
5.4
5.3
5.3
5.2
5.2
5.2
5.1
4.9
4.9
4.9
4.8
4.7
4.7
4.6
4.6
4.5
4.2
4.1
5.1
5.0
5.0
4.8
4.7
4.7
4.7
4.5
4.5
5.6
5.3
5.2
5.1
5.1
5.0
4.8
4.8
4.8
4.7
4.5
4.4
4.3
4.2
4.2
5.4
4.4
4.3
5.3
5.2
5.2
5.2
5.2
5.2
5.1
5.0
4.9
4.8
4.8
4.7
4.7
4.7
4.7
4.7
4.7
4.6
4.6
4.5
4.4
4.3
4.2
4.1
4.0
3.8
3.7
3.3
5.6
5.2
4.9
4.8
4.4
4.3

Lbs./In.

1.1
3.5
3.2
4.2
5.7
3.3
5.2
5.4
12
12
21
18
19
24
27
30
56
81
114
7.5
9.4
7.9
21
22
14
23
40
54
.54
3.3
3.1
6.4
8.2
8.3
13
11
17
21
49
36
50
66
74
3.0
51
39
1.6
1.9
4.1
4.5
4.9
3.7
6.9
8.3
10
18
18
18
17
16
15
18
22
29
39
27
33
74
52
66
101
107
169
340
.56
4.7
9.3
13
47
49

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.18
.60
.55
.73
1.0
.58
.91
.94
2.0
2.0
3.7
3.2
3.4
4.2
4.8
5.3
9.8
14
20
1.3
1.6
1.4
3.7
3.9
2.5
4.0
7.0
9.4
.09
.58
.54
1.1
1.4
1.5
2.3
1.9
3.0
3.6
8.6
6.4
8.8
12
13
.53
8.9
6.8
.29
.34
.72
.80
.85
.65
1.2
1.5
1.8
3.2
3.2
3.2
3.0
2.9
2.5
3.2
3.9
5.1
6.9
4.8
5.7
13
9.1
12
18
19
30
59
.10
.83
1.6
2.3
8.2
8.7

.41
.41
.47
.30
.45
.39
.32
.35
.37
.28
.26
.33
.25
.21
.23
.20
.14
.14
.12
.44
.42
.34
.31
.23
.30
.23
.19
.13
.51
.39
.45
.34
.43
.32
.34
.30
.26
.35
.14
.21
.18
.23
.16
.54
.17
.20
.49
.38
.41
.56
.39
.50
.48
.47
.44
.36
.36
.29
.30
.30
.36
.29
.26
.22
.23
.26
.23
.14
.20
.19
.14
.13
.11
.08
.59
.54
.39
.46
.24
.21

mm

10
10
12
7.7
11
10
8.3
8.9
9.5
7.1
6.6
8.3
6.3
5.4
5.8
5.2
3.4
3.7
3.0
11
11
8.6
7.9
5.9
7.7
5.9
4.8
3.3
13
9.9
11
8.7
11
8.0
8.7
7.5
6.5
8.8
3.6
5.3
4.5
5.8
4.0
14
4.4
5.1
12
9.7
10
14
10
13
12
12
11
9.2
9.2
7.2
7.7
7.5
9.1
7.4
6.5
5.6
5.7
6.5
5.9
3.5
5.0
4.8
3.6
3.2
2.8
2.1
15
14
9.9
12
6.2
5.2

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.43
1.9
1.4
6.2
1.5
6.5
1.3
5.7
2.5
11
1.3
5.8
1.7
7.5
1.9
8.3
4.3
19
3.3
15
5.4
24
6.0
27
4.8
21
5.2
23
6.2
28
6.2
28
7.6
34
12
52
13
59
3.3
15
3.9
17
2.7
12
6.6
29
5.2
23
4.4
19
5.3
23
7.6
34
7.1
32
.27
1.2
1.3
5.7
1.4
6.1
2.2
9.7
3.5
16
2.6
12
4.4
20
3.2
14
4.4
20
7.2
32
7.0
31
7.7
34
8.9
39
15
67
12
52
1.6
7.3
8.8
39
7.8
35
.81
3.6
.74
3.3
1.7
7.5
2.5
11
1.9
8.6
1.9
8.3
3.3
15
3.9
17
4.5
20
6.6
29
6.6
29
5.2
23
5.2
23
4.8
21
5.2
23
5.3
23
5.7
25
6.4
29
8.9
40
7.1
32
7.7
34
10
45
10
45
12
55
14
63
13
59
19
83
28
123
.33
1.5
2.5
11
3.6
16
6.0
27
11
50
10
45

Inches

.22
.12
.16
.12
.15
.23
.17
.28
.25
.22
.22
.27
.27
.29
.34
.28
.26
.38
.41
.18
.21
.32
.28
.30
.35
.31
.33
.24
.18
.16
.24
.21
.23
.21
.35
.39
.29
.32
.25
.36
.36
.40
.41
.15
.39
.53
.26
.37
.20
.18
.19
.25
.19
.26
.31
.28
.31
.35
.37
.34
.38
.36
.35
.33
.30
.41
.40
.37
.44
.54
.44
.63
.52
.60
.20
.20
.32
.32
.37
.45

mm

Inches

5.5
3.0
4.1
3.0
3.9
5.9
4.3
7.0
6.4
5.7
5.5
6.9
6.9
7.3
8.6
7.1
6.6
9.7
10.3
4.6
5.4
8.1
7.1
7.7
8.9
8.0
8.5
6.1
4.6
4.1
6.1
5.3
5.7
5.4
8.8
9.9
7.5
8.1
6.4
9.2
9.1
10.1
10.4
3.9
9.9
13.5
6.6
9.3
5.0
4.6
4.8
6.4
4.9
6.6
7.8
7.1
7.9
8.9
9.3
8.7
9.8
9.2
8.8
8.4
7.6
10.3
10.1
9.4
11.2
13.7
11.1
15.9
13.2
15.2
5.0
5.0
8.1
8.0
9.4
11.5

0.018
0.018
0.020
0.020
0.022
0.022
0.022
0.025
0.028
0.028
0.029
0.030
0.032
0.032
0.034
0.034
0.037
0.043
0.045
0.024
0.026
0.027
0.031
0.032
0.032
0.033
0.037
0.037
0.015
0.020
0.022
0.024
0.025
0.026
0.030
0.030
0.031
0.032
0.036
0.038
0.040
0.042
0.043
0.019
0.039
0.041
0.020
0.022
0.022
0.022
0.023
0.023
0.024
0.026
0.028
0.031
0.031
0.032
0.032
0.032
0.032
0.033
0.033
0.035
0.035
0.037
0.038
0.041
0.042
0.045
0.046
0.050
0.052
0.060
0.015
0.022
0.029
0.030
0.038
0.041

mm

TOTAL
MATL
COILS

0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.7
0.7
0.8
0.8
0.8
0.9
0.9
0.9
1.1
1.1
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
0.4
0.5
0.6
0.6
0.6
0.7
0.8
0.8
0.8
0.8
0.9
1.0
1.0
1.1
1.1
0.5
1.0
1.0
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.9
0.9
0.9
1.0
1.0
1.1
1.1
1.2
1.3
1.3
1.5
0.4
0.6
0.7
0.8
1.0
1.0

12.0
5.50
8.00
6.00
7.00
9.50
6.75
10.0
9.00
8.00
6.50
8.00
8.50
8.00
9.00
8.25
7.00
8.88
8.00
7.50
8.25
10.8
8.00
8.50
11.0
8.50
9.00
6.50
11.0
7.00
10.0
7.75
8.00
8.25
10.5
12.0
8.50
9.00
7.00
9.50
9.00
9.50
9.50
7.00
9.00
12.0
12.0
16.7
8.00
8.25
8.25
10.0
8.00
9.00
10.0
9.00
9.00
10.0
10.5
9.75
12.0
10.0
9.50
9.50
7.50
11.0
10.5
8.00
10.5
11.0
9.50
12.5
10.0
10.0
12.0
8.00
11.0
10.5
8.75
11.0

SST
MW
MW
SST
MW
SST
SST
SST
MW
SST
MW
MW
SST
HD
HD
SPR
SPR
SPR
SPR
MW
MW
MW
MW
HD
SST
SST
SPR
SST
SST
SST
SST
SST
MW
SST
MW
MW
SST
MW
SPR
SST
SST
MW
SPR
MW
SPR
SST
SST
MW
SST
MW
SST
SST
MW
MW
MW
MW
MW
HD
HD
SST
HD
SST
SPR
SPR
MW
SST
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
MW
MW
SST
MW
MW
SPR

E
N
D
S

CG
C
CG
CG
CG
C
C
C
CG
CG
C
C
CG
C
C
CG
CG
CG
C
CG
CG
C
C
C
CG
C
CG
CG
C
C
C
C
C
CG
C
C
C
C
CG
CG
CG
CG
CG
C
C
C
C
CG
C
CG
CG
CL
CG
C
C
CG
C
C
C
C
CG
C
C
CG
C
CG
CG
C
CG
C
CG
CG
CG
CG
C
C
CG
CG
C
CG

F
N
S
H

N
Z
N
N
N
N
N
N
N
N
Z
N
N
Z
Z
GI
Z
N
Z
Z
N
Z
Z
Z
N
N
N
N
N
N
N
N
Z
N
Z
N
N
Z
Z
N
N
GI
GI
Z
N
N
N
N
N
N
N
N
GI
Z
Z
Z
N
Z
GI
N
N
N
Z
Z
N
N
N
N
N
N
Z
N
N
Z
Z
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

57

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 58

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250

6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35

S-60
B-69
A11-18
J-92
B14-65
YY-14
4289
HH-5
F-8
B-58
BB-23
3866
A11-24
A15-21
AA-99
S-486
S-9
J-23
F-40
H-10
S-1313
AA-21
W-62
2948
F-91
A13-3
FF-98
OO-4
S-721
927
10285
B7-27
928
S-723
3874
B14-11
10412
11899
10149
O-314
KK-43
B5-65
FF-89
L-84
F-39
FF-50
2833
S-930
B-47
3519
DD-43
3115
W-47
151-A
3811
HH-67
W-9
4111
12667
3614
Q-68
12786
10019
FF-11
M-18
MM-37
3567
A-41
QQ-66
S-722
K-3
B15-54
10753
201-A
2565
EE-5
I-66
S-724
A13-2
JJ-90

.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.84
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.0
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4

MATERIAL: MW - Music Wire

58

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.230
.218
.204
.202
.202
.196
.194
.186
.184
.182
.180
.172
.172
.172
.156
.124
.100
.198
.186
.182
.224
.220
.200
.198
.198
.196
.194
.190
.186
.182
.180
.180
.168
.166
.114
.184
.174
.160
.210
.202
.198
.196
.190
.190
.186
.180
.160
.158
.150
.138
.210
.214
.214
.210
.210
.210
.210
.208
.206
.204
.204
.196
.194
.190
.190
.190
.188
.186
.186
.186
.184
.182
.180
.180
.172
.170
.170
.166
.164
.150

RATE
mm

5.8
5.5
5.2
5.1
5.1
5.0
4.9
4.7
4.7
4.6
4.6
4.4
4.4
4.4
4.0
3.1
2.5
5.0
4.7
4.6
5.7
5.6
5.1
5.0
5.0
5.0
4.9
4.8
4.7
4.6
4.6
4.6
4.3
4.2
2.9
4.7
4.4
4.1
5.3
5.1
5.0
5.0
4.8
4.8
4.7
4.6
4.1
4.0
3.8
3.5
5.3
5.4
5.4
5.3
5.3
5.3
5.3
5.3
5.2
5.2
5.2
5.0
4.9
4.8
4.8
4.8
4.8
4.7
4.7
4.7
4.7
4.6
4.6
4.6
4.4
4.3
4.3
4.2
4.2
3.8

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.10
.02
.72
.13
5.3
.93
5.2
.90
5.5
.96
8.6
1.5
8.1
1.4
14
2.5
20
3.4
25
4.5
19
3.3
35
6.2
39
6.9
35
6.1
93
16
376
66
941 165
7.3
1.3
17
2.9
27
4.8
.38
.07
.81
.14
4.8
.83
6.7
1.2
7.3
1.3
7.4
1.3
12
2.0
12
2.0
14
2.4
21
3.7
25
4.3
23
4.0
49
8.7
43
7.6
850 149
49
8.6
33
5.8
76
13
1.7
.29
4.4
.78
6.5
1.1
6.3
1.1
9.9
1.7
11
1.9
15
2.5
20
3.6
71
12
73
13
103
18
176
31
1.7
.29
1.3
.22
1.2
.20
2.8
.49
2.4
.41
3.4
.59
1.5
.26
1.9
.33
3.8
.66
3.1
.55
4.0
.71
6.3
1.1
9.0
1.6
8.1
1.4
13
2.3
15
2.6
18
3.2
11
2.0
22
3.9
12
2.1
15
2.5
14
2.5
20
3.5
21
3.7
25
4.4
23
4.1
44
7.7
37
6.4
47
8.3
89
16

.69
.60
.55
.55
.58
.51
.48
.33
.29
.24
.32
.25
.22
.24
.16
.08
.05
.54
.31
.23
.75
.67
.49
.59
.54
.40
.42
.52
.35
.29
.26
.28
.21
.24
.05
.11
.25
.17
.65
.64
.60
.56
.52
.55
.36
.30
.26
.18
.15
.18
.71
.78
.78
.68
.78
.38
.72
.67
.67
.68
.72
.62
.54
.49
.45
.41
.36
.46
.32
.41
.36
.44
.33
.42
.34
.32
.21
.28
.25
.18

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

18
15
14
14
15
13
12
8.5
7.3
6.2
8.1
6.3
5.7
6.0
4.1
2.0
1.2
14
7.9
5.8
19
17
12
15
14
10
11
13
9.0
7.4
6.6
7.2
5.2
6.0
1.2
2.7
6.3
4.4
17
16
15
14
13
14
9.1
7.5
6.6
4.6
3.9
4.6
18
20
20
17
20
9.7
18
17
17
17
18
16
14
13
11
10
9.2
12
8.2
10
9.2
11
8.3
11
8.6
8.1
5.4
7.0
6.2
4.5

Lbs.

.07
.43
2.9
2.8
3.2
4.4
3.8
4.8
5.7
6.2
6.0
8.8
8.8
8.2
15
30
44
3.9
5.2
6.2
.29
.54
2.3
3.9
3.9
2.9
4.9
6.0
4.8
6.2
6.4
6.4
10
10
39
5.3
8.2
13
1.1
2.8
3.9
3.5
5.1
6.0
5.2
6.0
18
13
16
32
1.2
.99
.92
1.9
1.8
1.3
1.1
1.3
2.5
2.1
2.9
3.9
4.9
4.0
6.0
6.0
6.6
5.2
7.2
4.8
5.3
6.2
6.4
8.9
8.5
7.5
9.5
10
12
16

ENDS: C - Closed

G - Ground
O - Open

.31
1.9
13
13
14
19
17
21
25
28
27
39
39
37
67
132
196
17
23
28
1.3
2.4
10
17
17
13
22
27
21
28
29
29
45
45
172
23
36
59
4.9
13
17
16
23
27
23
27
82
59
70
142
5.3
4.4
4.1
8.5
8.2
5.7
4.8
5.6
11
9.4
13
17
22
18
27
27
29
23
32
21
23
28
29
40
38
33
42
45
52
70

Inches

.12
.21
.20
.26
.23
.30
.34
.34
.38
.36
.46
.47
.43
.43
.52
.63
.75
.26
.38
.31
.13
.14
.28
.28
.29
.28
.28
.35
.39
.37
.41
.40
.49
.55
.54
.20
.44
.54
.29
.30
.31
.38
.42
.39
.42
.39
.52
.55
.58
.73
.26
.23
.22
.20
.22
.16
.28
.33
.21
.32
.24
.38
.34
.42
.34
.29
.31
.51
.30
.44
.43
.53
.49
.46
.66
.68
.44
.62
.59
.70

mm

3.0
5.4
5.0
6.7
5.8
7.5
8.5
8.7
9.6
9.1
11.6
11.9
10.9
10.9
13.1
16.0
19.1
6.6
9.6
7.8
3.3
3.4
7.0
7.1
7.3
7.0
7.1
8.8
10.0
9.5
10.4
10.2
12.5
13.9
13.8
5.0
11.1
13.7
7.2
7.5
7.9
9.6
10.7
9.9
10.6
10.0
13.3
14.0
14.6
18.5
6.6
5.7
5.5
5.0
5.6
4.1
7.1
8.3
5.3
8.2
6.1
9.6
8.5
10.7
8.6
7.2
7.9
13.0
7.7
11.2
10.9
13.4
12.4
11.8
16.8
17.3
11.2
15.7
14.9
17.8

WIRE DIA.
Inches

0.010
0.016
0.023
0.024
0.024
0.027
0.028
0.032
0.033
0.034
0.035
0.039
0.039
0.039
0.047
0.063
0.075
0.026
0.032
0.034
0.013
0.015
0.025
0.026
0.026
0.027
0.028
0.030
0.032
0.034
0.035
0.035
0.041
0.042
0.068
0.033
0.038
0.045
0.020
0.024
0.026
0.027
0.030
0.030
0.032
0.035
0.045
0.046
0.050
0.056
0.020
0.018
0.018
0.020
0.020
0.020
0.020
0.021
0.022
0.023
0.023
0.027
0.028
0.030
0.030
0.030
0.031
0.032
0.032
0.032
0.033
0.034
0.035
0.035
0.039
0.040
0.040
0.042
0.043
0.050

mm

TOTAL
MATL
COILS

0.3
0.4
0.6
0.6
0.6
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.2
1.6
1.9
0.7
0.8
0.9
0.3
0.4
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
0.9
1.0
1.1
1.7
0.8
1.0
1.1
0.5
0.6
0.7
0.7
0.8
0.8
0.8
0.9
1.1
1.2
1.3
1.4
0.5
0.5
0.5
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.8
0.9
0.9
0.9
1.0
1.0
1.0
1.1
1.1
1.3

11.0
12.3
8.50
10.0
9.50
10.0
12.0
10.8
10.5
9.50
12.0
12.0
11.0
11.0
11.0
10.0
10.0
10.0
10.8
9.00
9.00
8.00
11.0
10.8
10.0
10.3
9.00
11.5
11.3
11.0
10.8
11.5
11.0
12.0
8.00
5.00
11.5
11.0
13.3
11.3
11.0
13.0
13.0
12.0
12.0
11.3
11.6
11.0
11.5
13.0
12.0
11.5
11.0
8.75
10.0
7.00
13.0
14.5
9.50
13.0
10.5
13.0
11.0
14.0
10.3
9.50
9.00
15.0
8.50
12.8
12.0
15.5
13.0
12.3
16.0
17.0
11.0
13.8
13.7
13.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
MW
MW
MW
MW
MW
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SST
SST
MW
HD
SPR
SST
SST
SST
MW
MW
SST
MW
MW
SST
HD
SPR
SPR
HD
SST
SPR
SST
SPR
SPR
MW
MW
MW
MW
MW
MW
SPR
SST
MW
SST
SST
MW
SST
MW
SST
MW
MW
SST
SST
MW
MW
MW
MW
MW
MW
SST
MW
MW
MW
SPR
MW
SST
SST
SPR
SPR
MW
MW
SST
SPR
SST
SPR
SST

E
N
D
S

F
N
S
H

C
C
CG
C
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
C
CG
C
CG
C
CG
C
CG
C
C
CG
C
CG
C
C
C
C
C
C
C
C
CG
CG
C
CG
CG
C
C
C
C
C
C
C
C
CG
C
CG
C
C
CG
C
CG
C
C
C
C
C
CG
C
C
C
CG
CG
C
CG
C

N
N
GI
Z
N
N
Z
N
Z
N
N
Z
N
N
GI
N
N
Z
Z
GI
N
N
N
Z
Z
N
Z
GI
N
Z
Z
N
Z
N
Z
N
Z
N
Z
Z
N
N
Z
Z
Z
N
Z
N
N
Z
N
GI
N
Z
GI
N
N
Z
N
Z
N
N
Z
N
Z
Z
Z
BO
Z
N
N
N
N
Z
Z
N
GI
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 59

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250

6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35

A10-25
10179
S-999
2621
A15-15
YY-3
TT-19
11468
WW-33
HH-65
F-21
A9-19
F-31
12407
3274
AA-35
S-197
2834
2877
4288
II-5
1890
3561
DD-8
S-1156
S-975
YY-17
A14-39
EE-34
HH-55
LL-70
S-322
O-102
BB-30
L-30
CC-87
B2-39
7
S-138
Y-81
F-14
CC-4
A14-3
S-725
B10-6
CC-57
4296
M-148
S-331
151-B
3780
J-47
PP-99
201-B
II-66
S-1023
10877
2980
JJ-21
3938
B4-12
929
524
10423
MM-49
12253
S-726
BB-25
S-1506
3583
H-70
B2-31
10159
12411
10770
S-1240
I-63
OO-54
151-C
JJ-99

1.03
1.03
1.03
1.03
1.05
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.16
1.16
1.19
1.19
1.23
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.31
1.31
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.41
1.44
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.56
1.58
1.59
1.59
1.63
1.63
1.63
1.63
1.69
1.69
1.75
1.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

26.2
26.2
26.2
26.2
26.6
27.0
27.0
27.0
27.0
27.0
27.0
27.0
27.0
27.8
27.8
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
29.4
29.4
29.4
30.2
30.2
31.3
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
33.3
33.3
34.1
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
35.7
36.5
36.5
36.6
38.1
38.1
38.1
38.1
38.1
38.1
38.1
39.7
40.1
40.5
40.5
41.3
41.3
41.3
41.3
42.8
42.8
44.5
44.5

I.D.
Inches

.214
.202
.188
.172
.170
.210
.204
.204
.202
.186
.184
.178
.156
.224
.174
.230
.222
.216
.216
.216
.210
.200
.198
.190
.186
.180
.178
.174
.150
.214
.190
.156
.212
.170
.150
.226
.210
.204
.202
.202
.198
.190
.170
.166
.162
.190
.182
.166
.214
.210
.194
.190
.190
.180
.170
.160
.210
.210
.190
.156
.156
.198
.182
.178
.170
.170
.166
.156
.206
.210
.168
.190
.224
.224
.190
.186
.188
.170
.210
.210

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.4
5.1
4.8
4.4
4.3
5.3
5.2
5.2
5.1
4.7
4.7
4.5
4.0
5.7
4.4
5.8
5.6
5.5
5.5
5.5
5.3
5.1
5.0
4.8
4.7
4.6
4.5
4.4
3.8
5.4
4.8
4.0
5.4
4.3
3.8
5.7
5.3
5.2
5.1
5.1
5.0
4.8
4.3
4.2
4.1
4.8
4.6
4.2
5.4
5.3
4.9
4.8
4.8
4.6
4.3
4.1
5.3
5.3
4.8
4.0
4.0
5.0
4.6
4.5
4.3
4.3
4.2
4.0
5.2
5.3
4.3
4.8
5.7
5.7
4.8
4.7
4.8
4.3
5.3
5.3

Lbs./In.

.56
4.6
12
25
30
2.1
2.5
3.5
3.8
13
16
15
88
.19
26
.04
.23
1.0
.45
.50
1.5
4.5
6.9
6.5
13
16
18
24
93
.58
9.9
66
.89
27
140
.18
1.6
3.0
2.6
3.2
4.9
4.8
27
29
39
9.9
14
36
1.1
2.0
6.0
5.0
11
15
27
44
1.0
1.3
3.6
47
51
2.7
10
12
22
22
23
41
2.2
.99
18
4.3
.17
.19
5.0
6.3
5.7
22
1.3
1.1

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.10
.80
2.1
4.4
5.3
.36
.45
.61
.66
2.3
2.7
2.7
15
.03
4.6
.01
.04
.17
.08
.09
.25
.78
1.2
1.1
2.2
2.8
3.1
4.2
16
.10
1.7
12
.16
4.7
25
.03
.28
.52
.45
.56
.85
.83
4.8
5.0
6.7
1.7
2.5
6.2
.19
.35
1.0
.87
1.9
2.6
4.8
7.7
.18
.23
.63
8.2
8.9
.47
1.8
2.1
3.9
3.9
4.1
7.1
.39
.17
3.1
.76
.03
.03
.87
1.1
1.0
3.9
.22
.19

.64
.52
.36
.35
.30
.62
.72
.55
.73
.39
.37
.41
.17
.85
.31
.85
.86
.91
.72
.75
.81
.78
.57
.59
.38
.38
.37
.34
.17
.78
.60
.21
.81
.33
.12
1.1
.95
.70
.84
.87
.81
.50
.35
.35
.32
.60
.44
.31
.87
.96
.82
.66
.38
.60
.35
.28
1.0
1.1
.57
.32
.30
.85
.61
.58
.43
.43
.44
.35
.75
1.1
.49
.84
1.4
1.4
.88
.76
.94
.43
1.39
1.2

mm

16
13
9.2
8.8
7.5
16
18
14
18
10
9.3
11
4.3
22
7.9
21
22
23
18
19
20
20
14
15
9.7
9.5
9.3
8.7
4.3
20
15
5.4
21
8.3
3.0
27
24
18
21
22
20
13
8.8
9.0
8.2
15
11
7.8
22
24
21
17
9.6
15
8.8
7.2
25
27
14
8.2
7.5
22
15
15
11
11
11
8.8
19
29
12
21
35
35
22
19
24
11
6.2
30

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.36
2.4
4.4
8.8
8.9
1.3
1.8
1.9
2.7
5.2
5.7
6.4
15
.16
8.2
.03
.20
.91
.32
.38
1.2
3.5
3.9
3.8
4.8
6.0
6.5
8.2
16
.45
6.0
14
.72
8.9
17
.19
1.5
2.1
2.2
2.8
3.9
2.4
9.5
10
12
6.0
6.2
11
.93
1.9
4.9
3.3
4.0
8.9
9.5
12
1.0
1.4
2.0
15
15
2.3
6.2
7.0
9.5
9.5
10
14
1.7
1.1
8.6
3.6
.23
.26
4.3
4.8
5.4
9.5
1.8
1.3

1.6
11
20
39
39
5.7
8.2
8.6
12
23
25
28
67
.73
36
.14
.89
4.1
1.4
1.7
5.2
15
17
17
21
27
29
36
70
2.0
27
63
3.2
39
74
.84
6.7
9.3
9.6
12
17
11
42
45
55
27
28
48
4.2
8.5
22
14
18
40
42
55
4.5
6.3
9.1
67
67
10
28
31
42
42
45
63
7.5
5.0
38
16
1.0
1.1
19
21
24
42
8.0
5.7

Inches

.40
.26
.34
.66
.59
.22
.34
.27
.34
.42
.45
.65
.54
.25
.53
.28
.26
.21
.41
.37
.32
.35
.30
.54
.42
.48
.50
.58
.64
.38
.39
.61
.38
.60
.50
.19
.30
.33
.41
.38
.39
.75
.66
.76
.79
.39
.56
.67
.23
.25
.46
.72
.36
.61
.70
.70
.41
.35
.87
.94
.87
.65
.74
.85
.80
.80
.90
.94
.31
.44
1.11
.75
.25
.25
.75
.74
.74
.80
.36
.36

mm

Inches

10.1
6.7
8.7
16.8
15.0
5.6
8.6
6.9
8.5
10.6
11.5
16.5
13.7
6.3
13.5
7.1
6.7
5.4
10.4
9.5
8.1
8.9
7.6
13.7
10.6
12.2
12.8
14.7
16.2
9.6
9.9
15.5
9.7
15.2
12.7
4.7
7.6
8.5
10.4
9.8
9.9
19.1
16.8
19.2
20.1
9.9
14.2
17.1
5.9
6.4
11.7
18.3
9.1
15.6
17.8
17.7
10.4
8.8
22.1
23.9
22.1
16.5
18.8
21.5
20.3
20.3
22.9
23.9
7.8
11.2
28.1
19.1
6.5
6.4
19.1
18.7
18.9
20.3
9.0
9.1

0.018
0.024
0.031
0.039
0.040
0.020
0.023
0.023
0.024
0.032
0.033
0.036
0.047
0.013
0.038
0.010
0.014
0.017
0.017
0.017
0.020
0.025
0.026
0.030
0.032
0.035
0.036
0.038
0.050
0.018
0.030
0.047
0.019
0.040
0.050
0.012
0.020
0.023
0.024
0.024
0.026
0.030
0.040
0.042
0.044
0.030
0.034
0.042
0.018
0.020
0.028
0.030
0.030
0.035
0.040
0.045
0.020
0.020
0.030
0.047
0.047
0.026
0.034
0.036
0.040
0.040
0.042
0.047
0.022
0.020
0.041
0.030
0.013
0.013
0.030
0.032
0.031
0.040
0.020
0.020

mm

TOTAL
MATL
COILS

0.5
0.6
0.8
1.0
1.0
0.5
0.6
0.6
0.6
0.8
0.8
0.9
1.2
0.3
1.0
0.3
0.4
0.4
0.4
0.4
0.5
0.6
0.7
0.8
0.8
0.9
0.9
1.0
1.3
0.5
0.8
1.2
0.5
1.0
1.3
0.3
0.5
0.6
0.6
0.6
0.7
0.8
1.0
1.1
1.1
0.8
0.9
1.1
0.5
0.5
0.7
0.8
0.8
0.9
1.0
1.1
0.5
0.5
0.8
1.2
1.2
0.7
0.9
0.9
1.0
1.0
1.1
1.2
0.6
0.5
1.0
0.8
0.3
0.3
0.8
0.8
0.8
1.0
0.5
0.5

21.0
11.0
11.0
16.0
13.8
10.0
13.8
10.8
13.0
13.0
12.8
18.0
11.5
18.0
14.0
27.0
17.8
11.5
23.0
21.0
15.0
13.0
10.5
17.0
12.0
13.8
14.0
15.3
12.8
20.0
13.0
13.0
19.0
15.0
10.0
14.5
14.0
13.5
16.0
15.0
14.0
25.0
16.5
17.0
18.0
13.0
15.5
16.0
12.0
11.5
15.5
24.0
11.0
16.5
16.5
15.5
20.5
16.3
29.0
20.0
18.5
24.0
20.8
22.5
20.0
20.0
20.5
20.0
13.0
21.0
27.0
24.0
18.5
18.5
24.0
22.0
24.0
20.0
16.8
17.0

SST
HD
SST
HD
SST
SST
SST
SST
MW
SPR
SPR
SPR
SPR
MW
SPR
SST
SST
MW
MW
MW
MW
MW
MW
SST
SST
SST
SST
SPR
SST
SST
MW
SST
MW
SST
SPR
MW
MW
HD
SST
MW
MW
MW
SPR
SST
SPR
MW
SPR
SPR
SST
MW
MW
MW
SST
MW
SPR
SST
MW
MW
SST
SPR
SPR
MW
HD
SPR
SPR
SPR
SST
SST
SST
MW
SPR
SST
SST
MW
MW
SST
MW
SPR
MW
SST

E
N
D
S

C
CG
CG
C
C
C
C
C
C
CG
C
CG
CG
C
CG
C
C
C
C
C
C
C
C
C
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
C
C
C
C
C
CG
CG
C
CG
CG
C
CG
C
C
C
CG
C
C
C
CG
CG
C
CG
CG
CG
C
C
C
CG
CG
C
CG
C
C
CG
C
C
C
C
C
CG
CG
C
C

F
N
S
H

N
N
N
Z
N
N
N
N
N
N
Z
N
Z
N
Z
N
N
Z
Z
Z
Z
Z
Z
N
N
N
N
N
N
N
N
N
Z
N
Z
N
N
Z
N
N
Z
N
N
N
N
Z
Z
Z
N
Z
Z
Z
N
Z
Z
N
N
Z
N
Z
N
Z
Z
N
GI
GI
N
N
N
Z
GI
N
N
N
N
N
Z
GI
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

59

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 60

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.250
0.262
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266

6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.35
6.65
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76

G-96
12620
B2-4
11349
J-61
201-C
A12-18
1941
2746
10937
3005
11109
10860
F-61
3730
2566
B2-45
10191
4251
3511
A14-35
L-60
S-3183
10430
F-99
O-43
B10-41
4119
OO-56
O-55
A-79
LL-17
W-55
11477
12743
12505
S-1001
S-1504
2822
3946
B10-55
12708
12798
W-46
J-77
EE-27
B5-63
CC-52
O-27
S-1389
I-84
U-72
EE-26
Y-5
S-1112
S-815
B2-38
FF-5
10790
A9-6
NN-43
12032
KK-45
3416
3232
S-1024
S-1484
I-36
L-65
W-61
10802
10096
B-55
JJ-15
MM-13
BB-29
B9-40
S-1212
S-406
RR-7

1.75
1.75
1.75
1.75
1.75
1.75
1.78
1.78
1.78
1.78
1.81
1.88
1.88
1.94
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.02
2.13
2.22
2.25
2.34
2.38
2.50
2.66
2.69
2.75
2.78
3.00
3.03
3.13
3.38
3.75
4.00
4.75
4.88
4.88
6.50
.86
.19
.22
.28
.31
.31
.31
.31
.31
.34
.38
.38
.38
.38
.39
.44
.44
.44
.44
.47
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

44.5
44.5
44.5
44.5
44.5
44.5
45.2
45.2
45.2
45.2
46.0
47.6
47.6
49.2
50.8
50.8
50.8
50.8
50.8
50.8
50.8
51.2
54.0
56.4
57.2
59.5
60.3
63.5
67.5
68.2
69.9
70.6
76.2
77.0
79.4
85.7
95.3
101.6
120.7
123.8
123.8
165.1
21.8
4.8
5.6
7.1
7.9
7.9
7.9
7.9
7.9
8.7
9.5
9.5
9.5
9.5
9.9
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7

MATERIAL: MW - Music Wire

60

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.210
.200
.200
.190
.182
.180
.200
.182
.176
.170
.174
.210
.188
.142
.216
.214
.206
.200
.200
.198
.178
.170
.168
.180
.192
.192
.200
.190
.170
.202
.194
.190
.166
.160
.178
.170
.198
.200
.170
.180
.174
.178
.166
.232
.176
.236
.246
.220
.206
.206
.196
.206
.214
.210
.202
.160
.210
.242
.206
.184
.184
.240
.230
.226
.214
.204
.196
.226
.226
.218
.216
.208
.206
.206
.206
.196
.194
.192
.192
.160

RATE
mm

5.3
5.1
5.1
4.8
4.6
4.6
5.1
4.6
4.5
4.3
4.4
5.3
4.8
3.6
5.5
5.4
5.2
5.1
5.1
5.0
4.5
4.3
4.3
4.6
4.9
4.9
5.1
4.8
4.3
5.1
4.9
4.8
4.2
4.1
4.5
4.3
5.0
5.1
4.3
4.6
4.4
4.5
4.2
5.9
4.5
6.0
6.2
5.6
5.2
5.2
5.0
5.2
5.4
5.3
5.1
4.1
5.3
6.1
5.2
4.7
4.7
6.1
5.8
5.7
5.4
5.2
5.0
5.7
5.7
5.5
5.5
5.3
5.2
5.2
5.2
5.0
4.9
4.9
4.9
4.1

Lbs./In.

1.4
2.3
4.7
3.3
8.7
12
2.3
10
15
19
17
1.1
5.3
83
.68
.55
2.3
2.7
1.9
2.7
11
17
14
16
3.1
4.3
3.8
4.7
12
2.0
4.0
2.6
17
22
5.6
9.5
.91
.73
6.3
3.4
4.8
2.5
80
5.2
277
1.4
.17
10
45
31
59
30
8.4
19
35
345
22
.20
20
90
58
.53
2.0
3.1
19
31
77
3.2
3.4
11
8.9
26
26
18
20
31
31
30
50
238

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

Lbs.

.24
.41
.82
.58
1.5
2.0
.40
1.8
2.7
3.3
3.0
.18
.93
15
.12
.10
.40
.48
.33
.47
1.9
2.9
2.4
2.7
.55
.75
.66
.81
2.1
.35
.71
.46
2.9
3.9
.98
1.7
.16
.13
1.1
.59
.85
.44
14
.92
48
.24
.03
1.8
7.9
5.5
10
5.2
1.5
3.4
6.0
60
3.8
.04
3.4
16
10
.09
.35
.55
3.4
5.4
13
.56
.60
2.0
1.6
4.5
4.6
3.1
3.4
5.4
5.3
5.3
8.8
42

1.4
1.2
.74
.81
.71
.77
1.2
.60
.68
.51
.47
1.5
1.0
.25
1.7
1.6
1.1
1.3
1.3
1.4
.64
.57
.70
.42
1.3
1.3
.92
1.3
.77
1.7
1.2
1.4
.66
.60
1.2
1.0
2.2
2.5
1.5
1.9
1.7
2.9
.27
.11
.04
.19
.23
.18
.13
.12
.10
.19
.19
.16
.13
.05
.21
.31
.19
.11
.13
.37
.32
.31
.19
.14
.07
.36
.35
.27
.25
.20
.15
.26
.29
.18
.19
.15
.13
.08

36
29
19
20
18
20
30
15
17
13
12
37
27
6.3
43
39
28
32
32
34
16
15
18
11
33
32
23
33
20
42
31
36
17
15
32
25
56
62
38
48
43
73
6.8
2.8
.99
4.9
5.9
4.6
3.2
3.1
2.6
4.8
4.9
4.1
3.4
1.3
5.4
7.8
4.9
2.7
3.3
9.3
8.2
7.8
4.9
3.4
1.9
9.0
9.0
6.9
6.3
5.0
3.7
6.6
7.3
4.7
4.9
3.8
3.4
1.9

1.9
2.7
3.5
2.6
6.2
8.9
2.7
6.2
10
9.5
8.2
1.5
5.6
21
1.2
.85
2.5
3.5
2.4
3.6
7.0
9.5
9.5
6.4
4.1
5.4
3.5
6.0
9.5
3.3
4.9
3.7
11
13
7.0
9.5
2.0
1.8
9.5
6.4
8.2
7.2
21
.59
11
.26
.04
1.9
5.6
3.8
6.1
5.6
1.6
3.1
4.6
18
4.6
.06
3.8
9.6
7.6
.20
.65
.96
3.7
4.2
5.7
1.1
1.2
3.1
2.2
5.1
3.8
4.7
5.6
5.7
5.9
4.5
6.7
18

ENDS: C - Closed

G - Ground
O - Open

8.5
12
16
12
28
40
12
28
47
42
36
6.8
25
92
5.2
3.8
11
16
11
16
31
42
42
29
18
24
16
27
42
15
22
17
48
59
31
42
8.9
7.9
42
29
36
32
94
2.6
48
1.2
.18
8.3
25
17
27
25
7.2
14
20
78
20
.27
17
43
34
.87
2.9
4.3
16
18
25
5.1
5.3
14
9.8
23
17
21
25
25
26
20
30
80

Inches

.34
.60
.34
.95
.82
.76
.61
.73
.78
.93
.81
.42
.83
1.16
.29
.45
.34
.53
.73
.65
.89
1.04
1.25
.60
.96
.73
.40
.80
1.38
.57
.64
1.35
1.39
1.53
1.69
1.80
1.53
1.55
2.60
2.31
2.55
3.64
.56
.08
.18
.09
.08
.13
.15
.17
.18
.15
.18
.14
.16
.27
.17
.13
.18
.25
.31
.10
.14
.16
.14
.16
.18
.15
.14
.14
.15
.17
.15
.24
.20
.25
.31
.35
.22
.42

mm

8.6
15.2
8.6
24.0
20.7
19.3
15.6
18.6
19.7
23.6
20.5
10.7
21.1
29.5
7.3
11.4
8.7
13.3
18.4
16.5
22.6
26.4
31.8
15.1
24.3
18.4
10.2
20.2
35.1
14.5
16.4
34.3
35.2
38.9
43.0
45.7
39.0
39.4
66.0
58.7
64.7
92.4
14.3
1.9
4.6
2.3
2.0
3.4
3.8
4.2
4.4
3.8
4.6
3.6
4.1
6.7
4.3
3.4
4.6
6.2
7.8
2.6
3.7
4.1
3.6
3.9
4.4
3.7
3.6
3.7
3.8
4.4
3.8
6.1
5.0
6.2
7.8
8.9
5.6
10.8

WIRE DIA.
Inches

mm

0.020
0.025
0.025
0.030
0.034
0.035
0.025
0.034
0.037
0.040
0.038
0.020
0.031
0.054
0.017
0.018
0.022
0.025
0.025
0.026
0.036
0.040
0.041
0.035
0.029
0.029
0.025
0.030
0.040
0.024
0.028
0.030
0.042
0.045
0.036
0.040
0.026
0.025
0.040
0.035
0.038
0.036
0.048
0.017
0.045
0.015
0.010
0.023
0.030
0.030
0.035
0.030
0.026
0.028
0.032
0.053
0.028
0.012
0.030
0.041
0.041
0.013
0.018
0.020
0.026
0.031
0.035
0.020
0.020
0.024
0.025
0.029
0.030
0.030
0.030
0.035
0.036
0.037
0.037
0.053

0.5
0.6
0.6
0.8
0.9
0.9
0.6
0.9
0.9
1.0
1.0
0.5
0.8
1.4
0.4
0.5
0.6
0.6
0.6
0.7
0.9
1.0
1.0
0.9
0.7
0.7
0.6
0.8
1.0
0.6
0.7
0.8
1.1
1.1
0.9
1.0
0.7
0.6
1.0
0.9
1.0
0.9
1.2
0.4
1.1
0.4
0.3
0.6
0.8
0.8
0.9
0.8
0.7
0.7
0.8
1.3
0.7
0.3
0.8
1.0
1.0
0.3
0.5
0.5
0.7
0.8
0.9
0.5
0.5
0.6
0.6
0.7
0.8
0.8
0.8
0.9
0.9
0.9
0.9
1.3

FINISH: Z - Zinc

TOTAL
MATL
COILS
16.0
23.0
12.5
31.5
24.0
20.8
23.5
20.5
20.0
23.3
20.3
20.0
25.8
21.5
16.0
24.0
14.5
20.0
28.0
24.0
24.8
26.0
30.5
16.0
32.0
24.0
15.0
25.5
34.5
22.8
22.0
44.0
32.0
33.0
46.0
44.0
58.0
61.0
65.0
66.0
67.0
100.0
11.8
3.50
4.00
5.00
7.00
4.75
4.00
4.50
5.00
5.00
7.00
5.00
5.00
5.00
5.00
10.0
6.00
6.00
7.50
6.75
7.00
7.00
4.50
5.00
4.00
6.25
6.00
5.00
6.00
5.00
5.00
7.00
6.50
7.00
8.50
8.50
6.00
7.00

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
MW
SST
SPR
MW
MW
SPR
MW
SPR
SPR
MW
MW
SPR
MW
MW
MW
MW
MW
MW
SPR
SPR
SST
SPR
MW
MW
MW
MW
SPR
MW
MW
MW
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
MW
MW
MW
SPR
SST
MW
MW
MW
SST
SPR
MW
SST
SST
SST
SST
MW
SST
SST
SPR
SST
MW
MW
MW
MW
SST
SST
SST
SST
MW
SST
MW
SST
MW
MW
SST
SPR
SST
SST
SPR

E
N
D
S

F
N
S
H

C
C
CL
CG
C
C
C
C
C
CG
C
C
C
CG
C
C
C
C
C
C
CG
CG
CG
C
C
C
C
C
CG
C
C
C
C
CG
C
C
C
C
CG
CG
CG
C
CG
C
CG
C
C
C
C
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
C
C
CG
C
C
C
C
CG
C
CG
C
CG
CG
CG
C
CG
CG

N
N
N
N
Z
Z
N
Z
Z
N
Z
Z
BO
Z
GI
Z
Z
Z
Z
Z
N
Z
N
Z
Z
N
Z
Z
BO
Z
N
N
Z
Z
N
N
N
N
GI
GI
Z
N
N
Z
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
N
N
N
N
N
N
Z
N
N
GI
N
Z
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 61

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266

6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76

W-14
NN-49
O-146
UU-40
N-62
B-53
A-73
JJ-45
JJ-91
3713
A11-60
L-85
B11-33
A10-35
O-143
II-99
H-27
S-156
B8-34
3568
UU-37
N-12
A13-51
II-88
B11-52
10897
A9-64
L-90
HH-71
3104
A-50
A-28
A-72
4292
Y-76
A15-22
S-211
FF-28
Q-66
S-907
LL-46
N-128
V V-17
Y-72
S-1585
XX-67
S-1527
3774
3732
NN-71
OO-9
AA-41
KK-65
L-43
S-203
2895
JJ-69
12586
10537
B7-19
A9-58
S-1151
A15-28
N-43
4195
V V-14
2523
10350
B7-12
EE-43
3612
Y-60
10485
S-1329
10190
LL-81
3524
A-40
B8-2
TT-62

.50
.50
.53
.53
.53
.53
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.63
.63
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.72
.75
.75
.75
.75
.75
.75
.75
.75
.81
.81
.81
.84
.84
.88
.88
.88
.88
.88
.94
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.06
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.16
1.16
1.16
1.19
1.19
1.22
1.25
1.28
1.31

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

12.7
12.7
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.9
15.9
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
22.2
22.2
23.8
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.0
27.8
28.6
28.6
28.6
28.6
28.6
28.6
28.6
29.4
29.4
29.4
29.4
30.2
30.2
31.0
31.8
32.5
33.3

I.D.
Inches

.146
.142
.202
.202
.196
.180
.238
.210
.210
.202
.202
.192
.230
.204
.186
.172
.208
.204
.212
.208
.186
.248
.238
.216
.208
.184
.180
.168
.184
.238
.236
.226
.216
.212
.206
.202
.196
.222
.220
.198
.222
.206
.236
.196
.184
.180
.176
.216
.192
.146
.206
.226
.208
.206
.202
.198
.166
.216
.202
.210
.204
.190
.194
.236
.228
.220
.208
.176
.176
.166
.198
.196
.182
.172
.218
.212
.172
.216
.198
.206

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

3.7
3.6
5.1
5.1
5.0
4.6
6.0
5.3
5.3
5.1
5.1
4.9
5.8
5.2
4.7
4.4
5.3
5.2
5.4
5.3
4.7
6.3
6.0
5.5
5.3
4.7
4.6
4.3
4.7
6.0
6.0
5.7
5.5
5.4
5.2
5.1
5.0
5.6
5.6
5.0
5.6
5.2
6.0
5.0
4.7
4.6
4.5
5.5
4.9
3.7
5.2
5.7
5.3
5.2
5.1
5.0
4.2
5.5
5.1
5.3
5.2
4.8
4.9
6.0
5.8
5.6
5.3
4.5
4.5
4.2
5.0
5.0
4.6
4.4
5.5
5.4
4.4
5.5
5.0
5.2

N/mm

Inches

376
491
26
24
30
95

66
86
4.5
4.2
5.2
17
.15
1.4
1.7
4.2
2.9
7.2
.14
3.6
12
26
2.3
5.3
1.6
2.3
6.1
.01
.04
.62
2.2
11
13
22
7.0
.10
.05
.23
.89
.90
1.7
2.1
3.0
.59
1.1
3.4
.39
3.4
.05
3.9
5.0
6.6
8.9
.51
3.3
44
1.3
.26
1.4
2.2
1.6
2.5
18
.59
1.7
1.0
1.2
3.0
2.6
.05
.16
.51
.99
7.7
6.7
11
2.9
2.1
4.2
7.9
.54
1.0
9.1
.65
3.0
.68

.07
.06
.18
.21
.21
.12
.46
.28
.28
.29
.27
.17
.34
.20
.12
.09
.39
.14
.31
.40
.24
.57
.45
.36
.40
.15
.14
.13
.24
.62
.47
.49
.50
.40
.39
.39
.33
.59
.29
.28
.57
.29
.64
.27
.31
.27
.23
.54
.38
.11
.53
.73
.63
.44
.48
.56
.15
.66
.58
.68
.55
.42
.44
.89
.80
.63
.65
.29
.33
.24
.50
.56
.34
.29
.85
.69
.27
.89
.34
.53

.87
8.2
9.5
24
17
41
.82
20
70
150
13
30
9.0
13
35
.05
.25
3.5
13
61
72
127
40
.58
.29
1.3
5.1
5.2
9.8
12
17
3.4
6.2
19
2.2
20
.31
22
29
37
51
2.9
19
251
7.1
1.5
8.1
13
9.4
14
105
3.3
9.8
5.7
6.8
17
15
.31
.90
2.9
5.7
44
38
63
16
12
24
45
3.1
6.0
52
3.7
17
3.9

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

mm

1.7
1.4
4.5
5.2
5.2
3.0
12
7.2
7.2
7.3
6.9
4.4
8.7
5.2
3.0
2.3
10
3.5
7.8
10
6.1
15
11
9.2
10
3.8
3.6
3.2
6.1
16
12
12
13
10
9.8
9.9
8.4
15
7.4
7.1
15
7.3
16
7.0
8.0
6.9
5.9
14
9.6
2.7
13
19
16
11
12
14
3.8
17
15
17
14
11
11
22
20
16
16
7.3
8.3
6.0
13
14
8.6
7.5
22
18
7.0
23
8.7
14

ENDS: C - Closed

G - Ground
O - Open

Lbs.

25
111
27
121
4.6
20
4.9
22
6.1
27
11
49
.41
1.8
2.3
10
2.7
12
6.8
30
4.6
20
7.2
32
.28
1.3
4.2
18
8.4
37
13
59
5.1
23
4.2
18
2.8
12
5.1
23
8.4
37
.03
.13
.11
.50
1.3
5.7
5.1
23
9.0
40
10
46
16
71
9.6
43
.36
1.6
.14
.60
.64
2.9
2.5
11
2.1
9.1
3.8
17
4.6
20
5.7
25
2.0
8.8
1.8
8.1
5.4
24
1.3
5.6
5.6
25
.20
.88
6.1
27
9.0
40
10
45
12
52
1.6
6.9
7.2
32
26
118
3.8
17
1.1
4.8
5.1
23
5.6
25
4.6
20
7.9
35
16
71
2.2
9.8
5.7
25
3.9
17
3.7
17
7.2
32
6.6
29
.28
1.2
.72
3.2
1.8
8.1
3.7
16
13
56
13
56
15
66
8.1
36
6.6
29
8.1
36
13
59
2.6
12
4.1
18
14
63
3.3
15
5.9
26
2.1
9.2

Inches

.42
.40
.19
.26
.28
.29
.10
.28
.28
.22
.27
.28
.25
.23
.28
.28
.23
.19
.20
.26
.40
.11
.24
.33
.23
.30
.32
.42
.45
.13
.29
.27
.25
.35
.30
.35
.39
.22
.16
.31
.27
.23
.24
.39
.53
.60
.56
.40
.52
.63
.39
.27
.36
.30
.45
.44
.53
.38
.45
.38
.51
.57
.59
.24
.32
.26
.48
.65
.73
.73
.43
.60
.82
.71
.34
.34
.71
.35
.41
.78

mm

Inches

10.7
10.2
4.9
6.5
7.1
7.4
2.5
7.1
7.1
5.7
6.8
7.0
6.4
5.9
7.1
7.2
5.9
4.7
5.1
6.6
10.2
2.9
6.0
8.3
5.9
7.6
8.1
10.6
11.5
3.2
7.2
6.7
6.4
8.9
7.6
8.9
9.8
5.6
4.1
7.8
6.8
5.7
6.1
9.8
13.5
15.3
14.3
10.2
13.2
16.0
9.9
6.9
9.2
7.6
11.4
11.2
13.3
9.5
11.4
9.6
13.0
14.5
15.1
6.1
8.2
6.7
12.2
16.6
18.6
18.4
10.8
15.1
20.8
17.9
8.5
8.6
17.9
8.9
10.4
19.8

0.060
0.062
0.032
0.032
0.035
0.043
0.014
0.028
0.028
0.032
0.032
0.037
0.018
0.031
0.040
0.047
0.029
0.031
0.027
0.029
0.040
0.009
0.014
0.025
0.029
0.041
0.043
0.049
0.041
0.014
0.015
0.020
0.025
0.027
0.030
0.032
0.035
0.022
0.023
0.034
0.022
0.030
0.015
0.035
0.041
0.043
0.045
0.025
0.037
0.060
0.030
0.020
0.029
0.030
0.032
0.034
0.050
0.025
0.032
0.028
0.031
0.038
0.036
0.015
0.019
0.023
0.029
0.045
0.045
0.050
0.034
0.035
0.042
0.047
0.024
0.027
0.047
0.025
0.034
0.030

mm

TOTAL
MATL
COILS

1.5
1.6
0.8
0.8
0.9
1.1
0.4
0.7
0.7
0.8
0.8
0.9
0.5
0.8
1.0
1.2
0.7
0.8
0.7
0.7
1.0
0.2
0.4
0.6
0.7
1.0
1.1
1.2
1.0
0.4
0.4
0.5
0.6
0.7
0.8
0.8
0.9
0.6
0.6
0.9
0.6
0.8
0.4
0.9
1.0
1.1
1.1
0.6
0.9
1.5
0.8
0.5
0.7
0.8
0.8
0.9
1.3
0.6
0.8
0.7
0.8
1.0
0.9
0.4
0.5
0.6
0.7
1.1
1.1
1.3
0.9
0.9
1.1
1.2
0.6
0.7
1.2
0.6
0.9
0.8

7.00
6.50
6.00
7.00
8.00
6.75
6.00
9.00
9.00
7.00
8.33
7.50
14.0
6.50
6.00
6.00
8.00
5.00
7.50
8.00
10.0
11.8
16.0
12.0
8.00
7.25
7.50
8.50
11.0
8.00
18.0
12.3
10.0
13.0
10.0
11.0
11.0
9.00
6.00
9.00
11.3
6.50
15.0
10.0
13.0
14.0
11.5
16.0
14.0
10.5
13.0
12.5
11.5
9.00
13.0
13.0
10.5
14.0
14.0
13.5
15.5
15.0
15.5
15.0
16.0
10.5
15.5
14.5
16.3
14.5
11.5
17.0
18.5
15.0
13.0
11.5
15.0
13.0
11.0
25.0

SST
SST
SST
SPR
SPR
SPR
MW
SST
MW
MW
SST
SPR
MW
SST
SST
SST
MW
SST
SST
MW
SST
SST
SPR
SST
MW
SST
SST
SPR
SPR
MW
MW
SST
MW
MW
SST
SST
SST
MW
SST
SST
SST
MW
SST
SPR
SST
SPR
SST
MW
SPR
SPR
SST
MW
MW
MW
SST
MW
SPR
MW
MW
MW
SST
SST
SPR
SST
MW
SST
MW
SPR
SPR
SST
MW
MW
SPR
SST
MW
MW
SPR
MW
SPR
MW

E
N
D
S

CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
C
C
CG
CG
C
CG
C
CG
C
C
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
C
CG
C
C
C
C
CG
CG
C
CG
CG
CG
CG
C
C
C
C
CG
CG
C
CG
CG
C
CG
C
C
C
C
C
CG
CG
CG
C
CG
C
CG
C
C
CG
C
C
C

F
N
S
H

N
N
N
N
N
Z
GI
N
N
Z
N
Z
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
GI
GI
Z
Z
N
Z
Z
N
N
N
Z
N
N
N
Z
N
N
N
Z
N
Z
Z
N
N
Z
Z
Z
N
Z
N
Z
Z
N
N
N
Z
N
Z
N
Z
N
N
N
Z
GI
Z
N
Z
Z
Z
Z
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

61

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 62

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.266
0.275
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281

6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.76
6.99
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14

M-26
V V-59
3264
3844
S-1494
10952
12418
YY-57
11191
11418
2886
1515
S-1354
3198
NN-33
3528
2530
B11-56
10043
A10-2
DD-66
3300
3784
10755
10892
YY-52
U-44
K-91
II-28
3312
OO-5
3915
11462
UU-55
10435
A16-69
10688
10684
12653
OO-62
DD-26
V V-63
A9-56
L-83
11439
933
WW-46
930
I-72
II-51
10744
Z-13
NN-17
J-12
MM-61
NN-14
2913
EE-13
RR-56
3900
AA-20
B-79
S-1058
A9-1
DD-18
10945
A-63
J-66
W-87
A12-10
JJ-70
2555
U-65
MM-97
W-13
Z-77
W-22
HH-6
OO-2
B-2

1.38
1.38
1.38
1.38
1.38
1.41
1.44
1.44
1.47
1.50
1.53
1.53
1.56
1.56
1.63
1.69
1.78
1.88
1.88
1.88
1.94
2.00
2.00
2.06
2.13
2.13
2.25
2.25
2.28
2.31
2.31
2.50
3.00
4.00
4.06
.94
.22
.25
.25
.25
.28
.28
.31
.31
.34
.38
.38
.38
.38
.41
.41
.41
.41
.41
.44
.44
.44
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.53

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

34.9
34.9
34.9
34.9
34.9
35.7
36.5
36.5
37.3
38.1
38.9
38.9
39.7
39.7
41.3
42.8
45.2
47.6
47.6
47.6
49.2
50.8
50.8
52.4
54.0
54.0
57.2
57.2
57.9
58.7
58.7
63.5
76.2
101.6
103.2
23.8
5.6
6.4
6.4
6.4
7.1
7.1
7.9
7.9
8.7
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
13.5

MATERIAL: MW - Music Wire

62

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.236
.232
.206
.206
.170
.184
.218
.200
.186
.186
.200
.196
.204
.202
.222
.212
.220
.204
.196
.170
.192
.210
.190
.192
.222
.176
.214
.158
.166
.212
.146
.190
.190
.212
.184
.177
.231
.221
.221
.217
.217
.211
.257
.229
.221
.201
.175
.173
.131
.249
.225
.211
.147
.139
.251
.243
.211
.211
.209
.201
.201
.187
.173
.237
.217
.215
.203
.189
.257
.253
.241
.225
.219
.173
.241
.241
.231
.221
.217
.211

RATE
mm

6.0
5.9
5.2
5.2
4.3
4.7
5.5
5.1
4.7
4.7
5.1
5.0
5.2
5.1
5.6
5.4
5.6
5.2
5.0
4.3
4.9
5.3
4.8
4.9
5.6
4.5
5.4
4.0
4.2
5.4
3.7
4.8
4.8
5.4
4.7
4.5
5.9
5.6
5.6
5.5
5.5
5.4
6.5
5.8
5.6
5.1
4.4
4.4
3.3
6.3
5.7
5.4
3.7
3.5
6.4
6.2
5.4
5.4
5.3
5.1
5.1
4.7
4.4
6.0
5.5
5.5
5.2
4.8
6.5
6.4
6.1
5.7
5.6
4.4
6.1
6.1
5.9
5.6
5.5
5.4

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

.38
.07
.79
.14
4.3
.75
3.9
.68
39
6.8
28
4.9
3.1
.54
11
2.0
24
4.2
25
4.3
8.0
1.4
12
2.2
6.9
1.2
9.2
1.6
1.3
.22
2.0
.34
.73
.13
6.8
1.2
18
3.1
88
15
7.6
1.3
3.7
.65
9.9
1.7
7.7
1.3
1.0
.18
25
4.4
1.9
.32
52
9.1
24
4.2
2.5
.43
77
14
9.0
1.6
9.0
1.6
.88
.15
7.9
1.4
80
14
33
5.9
29
5.1
49
8.6
49
8.5
22
3.8
72
13
.34
.06
11
2.0
29
5.1
75
13
319
56
348
61
2601 456
.68
.12
18
3.2
32
5.5
985 173
1315 230
.34
.06
1.6
.29
48
8.5
36
6.3
41
7.2
66
12
47
8.2
136
24
260
45
2.3
.40
9.6
1.7
37
6.5
78
14
104
18
.12
.02
.31
.05
1.8
.32
11
1.9
19
3.3
265
46
2.2
.39
3.2
.57
5.9
1.0
8.4
1.5
13
2.3
41
7.2

1.2
1.2
.66
.60
.37
.34
1.1
.47
.37
.37
.67
.69
.60
.74
1.2
.85
.83
.91
.34
.17
.88
1.2
.78
.88
1.5
.47
1.5
.38
.53
1.6
.34
.86
1.2
2.4
1.2
.27
.09
.09
.11
.10
.09
.08
.22
.18
.12
.11
.06
.05
.02
.25
.24
.17
.03
.03
.24
.28
.12
.15
.15
.13
.16
.09
.07
.26
.08
.19
.10
.12
.33
.33
.32
.28
.30
.07
.39
.39
.33
.24
.26
.14

29
29
17
15
9.3
8.7
28
12
9.5
9.3
17
17
15
19
31
22
21
23
8.7
4.4
22
32
20
22
39
12
38
9.6
13
41
8.7
22
30
61
31
6.9
2.4
2.3
2.8
2.4
2.3
2.0
5.6
4.6
3.1
2.9
1.4
1.3
.43
6.5
6.0
4.4
.89
.74
6.2
7.0
3.0
3.8
3.9
3.3
4.0
2.4
1.7
6.6
2.1
4.8
2.6
3.1
8.3
8.3
8.0
7.0
7.6
1.7
9.9
9.9
8.4
6.1
6.6
3.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs.

.44
.91
2.8
2.3
14
9.6
3.16
5.4
9.0
9.0
5.4
8.4
4.2
6.8
1.6
1.7
.60
6.2
6.1
15
6.7
4.6
7.7
6.7
1.6
12
2.8
20
13
4.0
26
7.7
11
2.1
9.6
22
3.1
2.7
5.4
4.7
1.9
5.8
.08
2.1
3.6
8.5
18
18
44
.17
4.3
5.4
34
38
.08
.46
5.8
5.4
6.3
8.5
7.4
13
18
.59
.81
7.1
7.9
13
.04
.10
.57
3.0
5.6
18
.88
1.3
2.0
2.0
3.5
5.8

ENDS: C - Closed

G - Ground
O - Open

2.0
4.0
12
10
63
43
14.1
24
40
40
24
37
18
30
7.0
7.4
2.7
28
27
67
30
20
34
30
7.1
52
12
88
57
18
118
34
48
9.4
43
96
14
12
24
21
8.6
26
.34
9.3
16
38
80
79
196
.77
19
24
153
170
.36
2.0
26
24
28
38
33
57
79
2.6
3.6
31
35
57
.17
.46
2.5
13
25
79
3.9
5.6
8.7
8.9
15
26

Inches

.23
.22
.72
.78
.90
.65
.34
.50
.65
.64
.53
.57
.50
.51
.40
.84
.96
.56
.46
.50
1.04
.59
1.10
1.07
.48
.99
.75
1.46
1.75
.70
1.77
1.20
1.14
1.59
1.93
.54
.10
.16
.14
.13
.19
.18
.09
.13
.16
.26
.27
.32
.30
.15
.17
.21
.34
.36
.20
.16
.21
.19
.25
.28
.28
.26
.30
.21
.38
.20
.20
.31
.17
.17
.19
.22
.20
.30
.14
.14
.20
.29
.27
.19

mm

5.7
5.6
18.3
19.8
22.9
16.4
8.5
12.6
16.5
16.3
13.4
14.5
12.6
13.0
10.1
21.3
24.3
14.2
11.6
12.8
26.3
14.9
28.0
27.3
12.3
25.1
19.2
37.0
44.5
17.8
45.0
30.4
29.0
40.5
48.9
13.7
2.5
4.0
3.4
3.3
4.9
4.4
2.3
3.3
4.0
6.6
6.7
8.2
7.6
3.9
4.3
5.3
8.5
9.0
5.0
4.1
5.3
4.9
6.4
7.1
7.1
6.6
7.5
5.3
9.8
5.0
5.0
7.9
4.4
4.4
4.7
5.7
5.1
7.5
3.6
3.6
5.1
7.4
6.9
4.9

WIRE DIA.
Inches

0.015
0.017
0.030
0.030
0.048
0.041
0.024
0.033
0.040
0.040
0.033
0.035
0.031
0.032
0.022
0.027
0.023
0.031
0.035
0.048
0.037
0.028
0.038
0.037
0.022
0.045
0.026
0.054
0.050
0.027
0.060
0.038
0.038
0.027
0.041
0.049
0.025
0.030
0.030
0.032
0.032
0.035
0.012
0.026
0.030
0.040
0.053
0.054
0.075
0.016
0.028
0.035
0.067
0.071
0.015
0.019
0.035
0.035
0.036
0.040
0.040
0.047
0.054
0.022
0.032
0.033
0.039
0.046
0.012
0.014
0.020
0.028
0.031
0.054
0.020
0.020
0.025
0.030
0.032
0.035

mm

TOTAL
MATL
COILS

0.4
0.4
0.8
0.8
1.2
1.0
0.6
0.8
1.0
1.0
0.8
0.9
0.8
0.8
0.6
0.7
0.6
0.8
0.9
1.2
0.9
0.7
1.0
0.9
0.6
1.1
0.7
1.4
1.3
0.7
1.5
1.0
1.0
0.7
1.0
1.2
0.6
0.8
0.8
0.8
0.8
0.9
0.3
0.7
0.8
1.0
1.3
1.4
1.9
0.4
0.7
0.9
1.7
1.8
0.4
0.5
0.9
0.9
0.9
1.0
1.0
1.2
1.4
0.6
0.8
0.8
1.0
1.2
0.3
0.4
0.5
0.7
0.8
1.4
0.5
0.5
0.6
0.8
0.8
0.9

14.0
12.0
23.0
25.0
18.8
14.8
13.0
14.0
15.3
15.0
16.0
16.3
15.0
15.0
18.0
31.0
40.5
17.0
12.0
10.5
28.0
20.0
28.0
28.0
22.0
21.0
28.0
27.0
35.0
25.0
29.5
30.5
30.0
58.0
47.0
11.0
3.00
4.25
3.50
4.00
6.00
4.00
6.50
5.00
4.25
5.50
5.00
5.00
4.00
8.50
5.00
6.00
5.00
5.00
12.0
7.50
5.00
5.50
6.00
6.00
7.00
5.50
5.50
9.50
11.0
5.00
5.00
6.75
13.5
11.3
8.25
7.00
6.50
5.50
7.00
6.00
7.00
9.75
8.50
5.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
MW
MW
SST
SPR
MW
SPR
SPR
SPR
SPR
MW
SST
MW
SST
MW
MW
MW
SPR
SPR
SST
MW
SPR
SST
SST
SST
MW
SPR
SST
MW
SPR
SPR
MW
SST
SPR
MW
MW
SST
MW
SPR
SST
SPR
MW
SST
SST
HD
SPR
HD
SPR
SST
MW
SST
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SST
SST
SST
SST
SST
MW
SPR
SPR
SST
MW
SST
MW
MW
SST
SST
MW
SST
SST
SST
HD

E
N
D
S

C
C
C
C
CG
C
C
C
C
C
CG
CG
C
C
CG
CG
C
C
C
CG
CG
C
C
C
CG
C
C
CG
CG
C
CG
C
CG
C
CG
CG
C
C
C
CG
CG
C
C
CG
C
C
CG
C
CG
C
C
C
CG
CG
C
C
C
CG
C
C
CG
CG
CG
CG
C
C
CG
CG
C
C
C
C
CG
CG
CG
C
C
CG
CG
CG

F
N
S
H

Z
Z
Z
N
N
N
N
Z
Z
Z
GI
GI
N
Z
N
Z
Z
Z
Z
N
N
Z
Z
N
N
N
Z
Z
N
Z
Z
Z
Z
N
N
Z
N
N
N
N
N
Z
N
N
N
Z
Z
Z
N
N
N
N
Z
N
N
N
Z
N
Z
Z
N
N
N
N
N
Z
Z
N
N
Z
N
Z
N
N
N
Z
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 63

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281

7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14

B2-37
S-1078
3467
A9-50
LL-21
DD-36
K-6
Q-13
M-25
S-1181
S-1076
J-57
10845
S-1366
S-1044
11836
B9-4
A9-28
GG-33
3888
Y-32
B-76
A9-53
BB-18
12652
3543
B9-42
JJ-77
10885
S-1252
3592
DD-91
HH-17
XX-12
AA-32
A-100
10170
DD-41
DD-53
4294
3710
S-927
M-130
G-20
B-91
G-67
V V-68
S-914
I-97
HH-49
JJ-65
W-94
S-363
O-64
3703
3609
EE-28
S-1190
A10-19
OO-64
Q-88
AA-17
3531
U-14
G-53
HH-28
CC-28
S-107
10827
2632
M-128
A10-44
3522
932
PP-27
I-80
4208
Z-84
B4-64
3649

.55
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.59
.63
.63
.63
.63
.63
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.81
.81
.81
.84
.88
.88
.88
.88
.88
.88
.88
.91
.91
.94
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

13.9
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
20.6
20.6
20.6
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.8
23.8
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4

I.D.
Inches

.201
.231
.229
.219
.219
.205
.201
.187
.179
.177
.173
.233
.231
.187
.185
.185
.237
.219
.205
.201
.195
.223
.219
.257
.247
.233
.233
.231
.221
.219
.217
.215
.205
.187
.181
.233
.231
.201
.249
.231
.225
.225
.219
.217
.217
.201
.199
.249
.245
.229
.201
.253
.251
.219
.191
.249
.241
.223
.213
.211
.209
.181
.201
.199
.245
.245
.241
.225
.251
.251
.251
.245
.237
.225
.225
.221
.219
.211
.205
.199

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.1
5.9
5.8
5.6
5.6
5.2
5.1
4.7
4.5
4.5
4.4
5.9
5.9
4.7
4.7
4.7
6.0
5.6
5.2
5.1
5.0
5.7
5.6
6.5
6.3
5.9
5.9
5.9
5.6
5.6
5.5
5.5
5.2
4.7
4.6
5.9
5.9
5.1
6.3
5.9
5.7
5.7
5.6
5.5
5.5
5.1
5.1
6.3
6.2
5.8
5.1
6.4
6.4
5.6
4.9
6.3
6.1
5.7
5.4
5.4
5.3
4.6
5.1
5.1
6.2
6.2
6.1
5.7
6.4
6.4
6.4
6.2
6.0
5.7
5.7
5.6
5.6
5.4
5.2
5.1

Lbs./In.

46
9.7
13
19
21
30
66
100
158
169
182
6.6
4.2
79
89
89
8.6
15
29
44
54
10
13
.10
1.3
8.0
2.3
8.4
11
15
18
14
34
100
104
4.3
5.1
67
1.1
5.1
9.1
10
9.2
9.8
12
31
37
1.1
1.2
6.0
29
.42
.19
10.6
56
.46
2.0
12
15
18
21
79
29
37
1.3
1.1
1.4
5.8
.62
.32
.43
.58
1.9
3.9
5.0
7.1
9.7
12
21
37

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

8.0
1.7
2.3
3.3
3.7
5.3
12
17
28
30
32
1.2
.74
14
16
16
1.5
2.7
5.0
7.7
9.4
1.8
2.2
.02
.23
1.4
.41
1.5
2.0
2.6
3.1
2.4
5.9
17
18
.76
.90
12
.19
.90
1.6
1.8
1.6
1.7
2.1
5.4
6.4
.20
.21
1.0
5.1
.07
.03
1.9
9.8
.08
.35
2.0
2.7
3.2
3.6
14
5.1
6.4
.22
.19
.25
1.0
.11
.06
.08
.10
.34
.68
.87
1.2
1.7
2.1
3.7
6.4

Inches

.17
.22
.19
.31
.28
.23
.13
.14
.10
.09
.10
.42
.37
.16
.15
.15
.26
.36
.24
.19
.18
.32
.31
.48
.55
.37
.35
.37
.40
.27
.36
.34
.20
.14
.15
.49
.48
.12
.53
.51
.48
.29
.41
.37
.38
.26
.24
.52
.62
.39
.29
.69
.50
.375
.21
.65
.69
.28
.50
.32
.31
.18
.40
.25
.77
.75
.70
.51
.78
.78
.82
.73
.71
.52
.59
.50
.61
.49
.35
.35

mm

4.4
5.5
4.9
7.9
7.0
5.8
3.3
3.5
2.4
2.4
2.5
11
9.3
4.1
3.9
3.9
6.7
9.2
6.1
4.9
4.6
8.0
8.0
12
14
9.3
8.9
9.5
10
6.8
9.3
8.7
5.2
3.5
3.7
12
12
3.0
14
13
12
7.3
10
9.3
9.7
6.5
6.0
13
16
10
7.4
17
13
9.53
5.4
17
17
7.1
13
8.1
7.8
4.6
10
6.3
19
19
18
13
20
20
21
19
18
13
15
13
15
12
8.9
8.8

ENDS: C - Closed

G - Ground
O - Open

Lbs.

8.0
2.1
2.5
5.9
5.9
6.9
8.5
14
15
16
18
2.8
1.6
13
14
14
2.3
5.6
6.9
8.5
9.9
3.2
3.9
.05
.72
2.9
.82
3.1
4.6
3.9
6.5
4.7
6.9
14
15
2.1
2.5
8.0
.59
2.6
4.4
2.9
3.8
3.6
4.7
8.0
8.6
.59
.76
2.4
8.5
.29
.09
4.0
12
.30
1.4
3.2
7.7
5.8
6.3
14
12
9.2
.98
.83
1.0
2.9
.48
.25
.35
.42
1.4
2.0
2.9
3.6
5.9
5.8
7.4
13

36
9.3
11
26
26
31
38
60
67
71
79
12
6.9
57
60
60
10
25
31
38
44
14
18
.20
3.2
13
3.7
14
20
18
29
21
31
60
67
9.4
11
36
2.6
12
19
13
17
16
21
36
38
2.6
3.4
10
38
1.3
.41
18.1
53
1.3
6.1
14
34
26
28
63
53
41
4.4
3.7
4.5
13
2.2
1.1
1.6
1.9
6.2
9.1
13
16
26
26
33
56

Inches

.32
.15
.13
.23
.22
.30
.24
.35
.33
.34
.38
.17
.23
.38
.38
.38
.12
.26
.32
.32
.34
.25
.25
.20
.14
.16
.34
.18
.29
.22
.27
.33
.29
.35
.45
.23
.24
.26
.11
.24
.22
.22
.34
.38
.35
.38
.41
.11
.16
.23
.44
.13
.32
.280
.45
.22
.19
.22
.35
.35
.40
.50
.44
.41
.17
.19
.24
.32
.11
.23
.18
.27
.29
.48
.35
.33
.36
.50
.46
.41

mm

Inches

8.1
3.8
3.3
5.9
5.5
7.7
6.1
9.0
8.4
8.6
9.6
4.4
5.7
9.6
9.8
9.8
2.9
6.7
8.2
8.1
8.7
6.3
6.3
5.2
3.5
4.0
8.5
4.4
7.2
5.5
6.9
8.4
7.2
9.0
11.4
5.8
6.0
6.6
2.8
6.0
5.7
5.5
8.7
9.8
8.9
9.7
10.4
2.8
4.1
5.8
11.2
3.2
8.0
7.08
11.4
5.7
4.8
5.7
8.9
8.9
10.1
12.7
11.2
10.4
4.3
4.8
6.1
8.0
2.9
5.7
4.6
6.7
7.3
12.1
8.9
8.4
9.3
12.7
11.6
10.4

0.040
0.025
0.026
0.031
0.031
0.038
0.040
0.047
0.051
0.052
0.054
0.024
0.025
0.047
0.048
0.048
0.022
0.031
0.038
0.040
0.043
0.029
0.031
0.012
0.017
0.024
0.024
0.025
0.030
0.031
0.032
0.033
0.038
0.047
0.050
0.024
0.025
0.040
0.016
0.025
0.028
0.028
0.031
0.032
0.032
0.040
0.041
0.016
0.018
0.026
0.040
0.014
0.015
0.031
0.045
0.016
0.020
0.029
0.034
0.035
0.036
0.050
0.040
0.041
0.018
0.018
0.020
0.028
0.015
0.015
0.015
0.018
0.022
0.028
0.028
0.030
0.031
0.035
0.038
0.041

mm

TOTAL
MATL
COILS

1.0
0.6
0.7
0.8
0.8
1.0
1.0
1.2
1.3
1.3
1.4
0.6
0.6
1.2
1.2
1.2
0.6
0.8
1.0
1.0
1.1
0.7
0.8
0.3
0.4
0.6
0.6
0.6
0.8
0.8
0.8
0.8
1.0
1.2
1.3
0.6
0.6
1.0
0.4
0.6
0.7
0.7
0.8
0.8
0.8
1.0
1.0
0.4
0.5
0.7
1.0
0.4
0.4
0.8
1.1
0.4
0.5
0.7
0.9
0.9
0.9
1.3
1.0
1.0
0.5
0.5
0.5
0.7
0.4
0.4
0.4
0.5
0.6
0.7
0.7
0.8
0.8
0.9
1.0
1.0

7.00
14.0
5.00
6.50
6.00
8.00
6.00
7.50
6.50
6.50
7.00
6.25
9.00
8.00
8.00
8.00
4.25
7.50
8.50
8.00
8.00
7.50
8.00
16.0
7.00
5.50
14.0
6.00
8.50
7.00
7.50
9.00
7.50
7.50
9.00
8.50
8.50
5.50
6.00
8.50
8.00
6.75
10.0
12.0
10.0
9.50
9.00
6.00
8.00
7.75
11.0
8.00
20.0
9.00
10.0
13.0
8.50
6.75
10.3
10.0
10.0
10.0
11.0
10.0
8.50
9.50
11.0
10.3
7.50
14.0
11.0
14.8
12.0
16.0
11.5
11.0
10.8
14.3
12.0
10.0

SST
SST
HD
MW
MW
SST
SPR
SPR
SST
SST
SST
MW
SST
SST
SST
SST
MW
MW
SST
SPR
SST
SST
SST
SST
MW
MW
MW
MW
MW
SST
MW
SST
SST
SPR
SPR
MW
MW
SST
SST
MW
MW
SST
SST
HD
HD
SST
SST
SST
SST
SST
SPR
SST
SST
SST
SPR
MW
MW
SST
MW
SPR
SPR
SST
MW
SPR
MW
MW
MW
SST
SST
MW
MW
SST
MW
MW
SST
SST
MW
SPR
SPR
MW

E
N
D
S

F
N
S
H

C
C
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
C
C
C
CG
C
C
CG
C
C
CG
CG
CG
C
C
C
C
C
CG
C
C
CG
C
CG
C
C
C
C
CG
C
C
CG
CG
C
C
C
CG
CG
C
CG
CG
CG
C
C
C
C
CG
C
C
CG
C
C
C
CG
C
CG
CG
CG

N
N
Z
GI
N
N
Z
Z
N
N
N
GI
N
N
N
N
BO
GI
N
Z
N
N
N
N
Z
Z
N
Z
GI
N
Z
N
N
Z
N
Z
N
N
N
N
GI
N
N
N
N
N
N
N
N
N
Z
N
N
N
Z
Z
N
N
N
N
GI
N
GI
GI
N
BO
Z
N
N
Z
N
N
Z
Z
N
N
Z
N
N
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

63

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 64

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.281
0.296
0.296
0.296
0.296
0.296

7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.14
7.52
7.52
7.52
7.52
7.52

S-998
BB-51
S-1053
934
BB-90
KK-88
10983
11352
H-13
Q-92
2630
L-7
H-59
HH-99
3995
EE-57
3510
2839
3767
3450
A13-52
1729
DD-20
O-83
410
3806
I-65
4212
A11-56
3585
NN-99
B10-46
1637
1927
B11-49
NN-65
10911
W-4
OO-92
4
3772
AA-9
3630
HH-9
2964
2655
LL-47
S-1075
NN-72
JJ-85
HH-41
L-60-A
S-1145
2795
HH-59
BB-91
10433
UU-67
S-1338
3622
K-33
L-38
S-1368
NN-12
12331
B10-35
10812
B11-65
B10-33
909
2897
RR-34
B-51
3521
4307
A11-21
DD-42
B3-50
10894
J-59

1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.09
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.19
1.19
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.31
1.31
1.34
1.34
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.41
1.44
1.50
1.50
1.50
1.56
1.63
1.63
1.63
1.63
1.63
1.63
1.75
1.75
1.84
2.00
2.00
2.00
2.03
2.06
2.44
2.50
2.53
2.63
2.63
3.13
3.25
3.50
3.63
5.00
.22
.25
.25
.25
.25

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.8
27.8
27.8
28.6
28.6
28.6
28.6
28.6
28.6
30.2
30.2
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
33.3
33.3
34.1
34.1
34.1
34.9
34.9
34.9
34.9
34.9
34.9
35.7
35.7
36.5
38.1
38.1
38.1
39.7
41.3
41.3
41.3
41.3
41.3
41.3
44.5
44.5
46.8
50.8
50.8
50.8
51.6
52.4
61.9
63.5
64.3
66.7
66.7
79.4
82.6
88.9
92.1
127.0
5.6
6.4
6.4
6.4
6.4

MATERIAL: MW - Music Wire

64

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.181
.181
.177
.173
.173
.157
.219
.211
.237
.201
.245
.229
.211
.243
.225
.221
.215
.213
.211
.233
.209
.265
.245
.243
.231
.225
.225
.219
.215
.195
.181
.211
.165
.237
.199
.229
.191
.161
.251
.225
.221
.221
.181
.181
.219
.215
.221
.217
.201
.171
.181
.231
.231
.223
.221
.211
.199
.243
.241
.153
.233
.225
.215
.201
.225
.223
.243
.183
.225
.213
.209
.207
.217
.207
.231
.230
.256
.252
.232
.226

RATE
mm

4.6
4.6
4.5
4.4
4.4
4.0
5.6
5.4
6.0
5.1
6.2
5.8
5.4
6.2
5.7
5.6
5.5
5.4
5.4
5.9
5.3
6.7
6.2
6.2
5.9
5.7
5.7
5.6
5.5
5.0
4.6
5.4
4.2
6.0
5.1
5.8
4.9
4.1
6.4
5.7
5.6
5.6
4.6
4.6
5.6
5.5
5.6
5.5
5.1
4.3
4.6
5.9
5.9
5.7
5.6
5.4
5.1
6.2
6.1
3.9
5.9
5.7
5.5
5.1
5.7
5.7
6.2
4.6
5.7
5.4
5.3
5.3
5.5
5.3
5.9
5.8
6.5
6.4
5.9
5.7

Lbs./In.

63
81
90
149
104
202
8.4
9.3
1.2
22
.92
4.4
11
.82
4.8
6.7
10
9.3
13
2.6
8.4
.04
1.0
.80
2.0
5.2
4.7
7.1
9.3
36
56
16
173
2.4
33
3.6
33
125
.39
4.4
4.1
8.2
43
73
6.1
10
7.0
5.3
10
95
33
2.0
.83
4.0
5.3
7.0
17
.65
.75
157
1.8
2.6
3.8
8.6
2.6
3.7
.31
30
27
4.5
3.6
7.7
6.1
5.0
.56
82
5.4
7.1
73
104

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

11
14
16
26
18
35
1.5
1.6
.22
3.8
.16
.77
2.0
.14
.85
1.2
1.8
1.6
2.3
.45
1.5
.01
.18
.14
.34
.91
.83
1.2
1.6
6.4
9.8
2.8
30
.42
5.7
.63
5.8
22
.07
.76
.72
1.4
7.5
13
1.1
1.8
1.2
.93
1.8
17
5.8
.36
.15
.70
.92
1.2
3.0
.11
.13
28
.32
.45
.66
1.5
.45
.64
.05
5.3
4.8
.78
.64
1.4
1.1
.88
.10
14
.94
1.2
13
18

.23
.19
.18
.13
.18
.14
.47
.44
.71
.39
.88
.78
.52
.86
.73
.71
.66
.56
.44
.85
.49
1.2
1.1
.95
.95
.84
.84
.79
.55
.29
.27
.36
.13
.94
.28
.98
.36
.19
1.2
.94
.75
.65
.43
.21
.88
.70
.76
.82
.50
.21
.43
1.1
.68
1.1
1.0
.77
.54
1.4
1.4
.27
1.6
1.3
1.1
.87
1.4
1.3
1.9
.51
.16
1.6
1.4
.88
1.1
1.9
3.4
.05
.16
.14
.06
.05

mm

5.7
4.8
4.5
3.2
4.6
3.5
12
11
18
9.9
22
20
13
22
18
18
17
14
11
22
13
30
27
24
24
21
21
20
14
7.3
6.9
9.1
3.4
24
7.1
25
9.2
4.8
30
24
19
17
11
5.3
22
18
19
21
13
5.3
11
29
17
27
26
20
14
36
35
6.8
40
34
28
22
35
33
48
13
4.1
39
36
22
27
48
87
1.4
3.9
3.6
1.4
1.3

Lbs.

14
15
16
19
19
28
3.9
4.2
.87
8.5
.81
3.4
5.8
.71
3.5
4.7
6.7
5.2
5.8
2.2
4.2
.04
1.1
.76
1.8
4.4
4.0
5.6
5.1
11
15
5.8
23
2.3
9.2
3.5
12
24
.46
4.1
3.0
5.4
18
15
5.3
7.1
5.4
4.3
5.1
20
14
2.3
.56
4.3
5.4
5.4
9.2
.92
1.0
42
2.8
3.5
4.1
7.5
3.6
4.8
.58
15
4.4
7.0
5.2
6.8
6.5
9.4
1.9
4.5
.83
1.0
4.1
5.2

ENDS: C - Closed

G - Ground
O - Open

63
67
71
84
84
124
18
18
3.9
38
3.6
15
26
3.1
16
21
30
23
26
9.7
19
.19
4.9
3.4
8
19
18
25
23
47
67
26
103
10
41
16
53
106
2.0
18
14
24
81
67
24
31
24
19
23
88
63
10
2.5
19
24
24
41
4.1
4.6
187
13
15
18
33
16
22
2.6
68
19
31
23
30
29
42
8.5
20
3.7
4.4
18
23

Inches

.60
.55
.55
.54
.65
.74
.34
.59
.35
.56
.22
.31
.53
.27
.40
.42
.46
.57
.46
.34
.69
.09
.20
.30
.31
.38
.41
.47
.46
.52
.75
.39
.61
.24
.45
.36
.74
.84
.20
.43
.63
.33
.95
.60
.53
.46
.41
.58
1.00
.77
1.08
.49
.95
.55
.48
.70
.79
.32
.36
1.15
.44
.67
.92
1.16
.67
.59
.61
1.23
.11
1.07
1.70
1.00
.61
1.48
1.58
.10
.10
.11
.13
.11

mm

15.2
14.0
13.9
13.7
16.5
18.9
8.7
14.9
8.9
14.2
5.5
7.9
13.3
6.8
10.1
10.7
11.7
14.5
11.6
8.5
17.6
2.2
5.0
7.7
7.8
9.6
10.3
11.8
11.7
13.1
19.1
9.8
15.5
6.1
11.5
9.2
18.9
21.3
5.0
11.0
16.0
8.4
24.1
15.2
13.4
11.7
10.3
14.6
25.4
19.6
27.3
12.4
24.1
14.0
12.2
17.8
20.0
8.2
9.1
29.3
11.3
17.1
23.3
29.5
17.1
14.9
15.4
31.1
2.8
27.2
43.2
25.4
15.4
37.6
40.0
2.5
2.4
2.8
3.3
2.7

WIRE DIA.
Inches

0.050
0.050
0.052
0.054
0.054
0.062
0.031
0.035
0.022
0.040
0.018
0.026
0.035
0.019
0.028
0.030
0.033
0.034
0.035
0.024
0.036
0.008
0.018
0.019
0.025
0.028
0.028
0.031
0.033
0.043
0.050
0.035
0.058
0.022
0.041
0.026
0.045
0.060
0.015
0.028
0.030
0.030
0.050
0.050
0.031
0.033
0.030
0.032
0.040
0.055
0.050
0.025
0.025
0.029
0.030
0.035
0.041
0.019
0.020
0.064
0.024
0.028
0.033
0.040
0.028
0.029
0.019
0.049
0.028
0.034
0.036
0.037
0.032
0.037
0.025
0.033
0.020
0.022
0.032
0.035

mm

TOTAL
MATL
COILS

1.3
1.3
1.3
1.4
1.4
1.6
0.8
0.9
0.6
1.0
0.5
0.7
0.9
0.5
0.7
0.8
0.8
0.9
0.9
0.6
0.9
0.2
0.5
0.5
0.6
0.7
0.7
0.8
0.8
1.1
1.3
0.9
1.5
0.6
1.0
0.7
1.1
1.5
0.4
0.7
0.8
0.8
1.3
1.3
0.8
0.8
0.8
0.8
1.0
1.4
1.3
0.6
0.6
0.7
0.8
0.9
1.0
0.5
0.5
1.6
0.6
0.7
0.8
1.0
0.7
0.7
0.5
1.2
0.7
0.9
0.9
0.9
0.8
0.9
0.6
0.8
0.5
0.6
0.8
0.9

12.0
11.0
10.5
9.00
12.0
12.0
11.0
15.8
16.0
14.0
11.0
11.0
15.0
13.0
13.3
13.0
13.0
15.8
13.0
13.0
19.3
10.0
10.0
15.0
11.3
12.5
13.5
14.0
14.0
12.0
15.0
11.0
10.5
10.0
11.0
13.0
15.5
14.0
12.0
14.5
20.0
11.0
19.0
12.0
16.0
13.0
12.5
18.0
25.0
14.0
21.5
18.5
37.0
18.0
16.0
20.0
19.3
16.0
17.0
17.0
17.5
23.0
27.8
29.0
23.0
19.3
32.0
24.0
4.00
30.5
47.3
26.0
18.0
39.0
62.0
3.00
3.75
4.00
3.00
3.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SST
HD
SPR
SPR
SST
SST
SST
SPR
MW
MW
SPR
SST
MW
MW
MW
MW
SPR
MW
SST
MW
MW
MW
B
MW
MW
MW
SPR
SPR
SPR
SPR
SPR
MW
SPR
MW
SPR
SST
MW
MW
MW
MW
MW
SPR
MW
MW
MW
SST
SST
SPR
SST
MW
SST
MW
MW
SST
SPR
SST
SST
MW
MW
MW
SST
SST
MW
MW
SST
SPR
MW
MW
SPR
SPR
MW
MW
MW
SST
SST
SST
SST
SST

E
N
D
S

F
N
S
H

CG
CG
CG
C
CG
CG
CG
C
CG
CG
C
C
CG
C
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
C
C
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
C
C
CG
CG
CG
C
C
C
C
C
CG
CG
C
C
CG
C
CG
C
CG
C
C
C
C
CG
C
C
C
CG

N
N
N
Z
Z
N
N
N
N
Z
Z
N
N
N
Z
N
Z
Z
Z
Z
N
TI
N
N
BO
GI
Z
Z
N
Z
Z
N
Z
GI
Z
N
N
N
N
Z
Z
Z
Z
N
Z
Z
Z
N
N
Z
N
N
N
Z
GI
N
N
N
N
Z
Z
Z
N
N
Z
Z
N
Z
N
Z
Z
Z
Z
Z
Z
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 65

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296

7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52

GG-22
HH-19
Q-16
B-19
W-88
M-11
12647
B3-48
B-9
II-100
XX-6
O-127
F-47
W-10
EE-75
W-32
Q-78
B18-131
NN-1
WW-34
V-15
JJ-59
G-77
B8-5
M-55
B12-41
K-72
2966
A10-22
11137
A15-34
A11-39
A15-31
L-5
B1-24
A11-6
A10-10
Z-98
II-98
B-70
JJ-98
A-13
PP-13
L-73
O-82
Z-16
A13-59
A11-10
LL-60
10834
II-84
NN-58
B15-35
NN-62
JJ-24
XX-29
PP-70
A15-9
AA-8
S-296
B18-136
K-1
I-71
Z-43
2563
K-97
B15-59
M-22
10962
W-20
12422
A11-63
3734
W-95
BB-85
3914
S-1420
J-5
Q-73
V-63

.25
.25
.28
.28
.28
.30
.30
.30
.31
.31
.31
.31
.34
.34
.34
.34
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.41
.44
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.53
.56
.56
.56
.56

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

6.4
6.4
7.1
7.1
7.1
7.5
7.5
7.5
7.9
7.9
7.9
7.9
8.7
8.7
8.7
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3

I.D.
Inches

.224
.216
.258
.214
.202
.226
.236
.214
.248
.214
.176
.172
.266
.244
.236
.214
.196
.278
.266
.266
.256
.254
.248
.230
.222
.220
.202
.196
.256
.240
.230
.218
.212
.202
.246
.244
.236
.234
.232
.226
.210
.274
.264
.254
.244
.238
.214
.210
.276
.272
.272
.272
.272
.264
.260
.254
.252
.250
.244
.244
.236
.234
.232
.230
.218
.212
.208
.204
.194
.162
.272
.252
.232
.232
.202
.188
.248
.246
.242
.232

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.7
5.5
6.6
5.4
5.1
5.7
6.0
5.4
6.3
5.4
4.5
4.4
6.8
6.2
6.0
5.4
5.0
7.1
6.8
6.8
6.5
6.5
6.3
5.8
5.6
5.6
5.1
5.0
6.5
6.1
5.8
5.5
5.4
5.1
6.2
6.2
6.0
5.9
5.9
5.7
5.3
7.0
6.7
6.5
6.2
6.0
5.4
5.3
7.0
6.9
6.9
6.9
6.9
6.7
6.6
6.5
6.4
6.4
6.2
6.2
6.0
5.9
5.9
5.8
5.5
5.4
5.3
5.2
4.9
4.1
6.9
6.4
5.9
5.9
5.1
4.8
6.3
6.2
6.1
5.9

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

91
16
130
23
2.9
.51
107
19
195
34
42
7.3
18
3.1
122
21
10
1.8
107
19
933 163
818 143
.93
.16
9.6
1.7
20
3.6
86
15
238
42
.03
.01
.54
.09
.46
.08
1.2
.21
2.9
.51
5.1
.89
27
4.7
68
12
78
14
130
23
199
35
2.2
.38
5.7
1.0
31
5.4
69
12
96
17
120
21
9.9
1.7
13
2.3
18
3.2
21
3.7
20
3.6
40
7.0
75
13
.30
.05
.94
.17
4.4
.78
10
1.8
13
2.3
61
11
67
12
.20
.04
.18
.03
.13
.02
.14
.03
.22
.04
.46
.08
2.3
.41
3.9
.67
5.4
.95
7.8
1.4
3.8
.67
9.6
1.7
18
3.1
14
2.5
27
4.8
19
3.2
65
11
67
12
84
15
118
21
147
26
592 104
.24
.04
2.9
.50
18
3.2
16
2.8
100
17
213
37
6.8
1.2
7.0
1.2
6.5
1.1
14
2.5

.07
.06
.19
.08
.06
.12
.15
.09
.18
.08
.03
.03
.25
.19
.16
.10
.06
.23
.24
.23
.18
.23
.21
.18
.10
.09
.09
.07
.27
.10
.22
.10
.09
.11
.20
.25
.19
.18
.20
.14
.13
.40
.35
.34
.21
.29
.13
.14
.44
.39
.36
.36
.39
.32
.39
.32
.37
.32
.25
.23
.29
.25
.16
.24
.12
.13
.13
.10
.10
.05
.43
.36
.29
.26
.13
.08
.27
.39
.32
.29

1.7
1.5
4.7
1.9
1.6
3.1
3.7
2.3
4.6
1.9
.66
.83
6.2
4.7
4.1
2.4
1.5
5.9
6.1
5.7
4.4
5.8
5.3
4.6
2.4
2.3
2.4
1.9
6.8
2.5
5.5
2.6
2.3
2.8
5.1
6.4
4.8
4.5
5.1
3.5
3.2
10
8.8
8.7
5.4
7.5
3.4
3.6
11
9.8
9.1
9.0
10
8.2
10
8.3
9.3
8.0
6.4
5.9
7.3
6.4
4.1
6.0
2.9
3.3
3.2
2.6
2.5
1.3
11
9.0
7.4
6.6
3.3
2.2
7.0
9.8
8.1
7.4

ENDS: C - Closed

G - Ground
O - Open

Lbs.

6.0
27
7.6
34
.54
2.4
8.2
36
12
54
5.2
23
2.6
12
11
50
1.9
8.3
8.2
36
24
108
27
119
.23
1.0
1.8
8.0
3.3
15
8.2
36
14
64
.01
.03
.13
.58
.10
.46
.21
.92
.66
2.9
1.1
4.7
4.9
22
6.5
29
7.0
31
12
54
14
64
.58
2.6
.56
2.5
6.7
30
7.1
31
8.8
39
13
58
2.0
8.9
3.3
15
3.4
15
3.8
17
4.1
18
5.5
25
9.4
42
.12
.54
.33
1.5
1.5
6.7
2.2
10
3.9
17
8.2
36
9.4
42
.09
.40
.07
.31
.05
.20
.05
.23
.09
.38
.15
.67
.91
4.0
1.3
5.6
2.0
8.8
2.5
11
.97
4.3
2.2
10
5.1
23
3.6
16
4.4
20
4.4
19
7.6
34
8.8
39
11
48
12
54
14
64
31
138
.10
.45
1.0
4.5
5.2
23
4.1
18
13
58
18
80
1.9
8.3
2.7
12
2.1
9.2
4.1
18

Inches

.16
.14
.10
.16
.19
.16
.15
.21
.12
.16
.21
.25
.10
.16
.18
.23
.23
.14
.14
.15
.20
.15
.17
.18
.16
.16
.24
.25
.14
.31
.17
.18
.19
.27
.14
.12
.15
.16
.19
.18
.24
.07
.12
.13
.12
.17
.23
.26
.06
.11
.14
.14
.11
.18
.11
.13
.13
.10
.25
.16
.17
.25
.16
.26
.23
.23
.26
.25
.31
.37
.10
.18
.24
.24
.31
.32
.14
.18
.24
.26

mm

Inches

4.1
3.6
2.4
4.2
4.8
4.0
3.8
5.2
3.0
4.2
5.3
6.3
2.5
4.0
4.6
5.7
5.7
3.7
3.4
3.8
5.1
3.7
4.3
4.6
4.0
4.1
6.0
6.4
3.6
7.8
4.2
4.5
4.8
6.9
3.5
3.0
3.8
3.9
4.7
4.4
6.0
1.7
3.0
3.2
3.1
4.4
5.7
6.6
1.5
2.9
3.6
3.7
2.7
4.5
2.7
3.2
3.4
2.6
6.3
4.0
4.2
6.3
4.1
6.7
5.9
5.9
6.7
6.4
7.8
9.4
2.6
4.5
6.1
6.1
7.8
8.2
3.7
4.4
6.2
6.5

0.036
0.040
0.019
0.041
0.047
0.035
0.030
0.041
0.024
0.041
0.060
0.062
0.015
0.026
0.030
0.041
0.050
0.009
0.015
0.015
0.020
0.021
0.024
0.033
0.037
0.038
0.047
0.050
0.020
0.028
0.033
0.039
0.042
0.047
0.025
0.026
0.030
0.031
0.032
0.035
0.043
0.011
0.016
0.021
0.026
0.029
0.041
0.043
0.010
0.012
0.012
0.012
0.012
0.016
0.018
0.021
0.022
0.023
0.026
0.026
0.030
0.031
0.032
0.033
0.039
0.042
0.044
0.046
0.051
0.067
0.012
0.022
0.032
0.032
0.047
0.054
0.024
0.025
0.027
0.032

mm

TOTAL
MATL
COILS

0.9
1.0
0.5
1.0
1.2
0.9
0.8
1.0
0.6
1.0
1.5
1.6
0.4
0.7
0.8
1.0
1.3
0.2
0.4
0.4
0.5
0.5
0.6
0.8
0.9
1.0
1.2
1.3
0.5
0.7
0.8
1.0
1.1
1.2
0.6
0.7
0.8
0.8
0.8
0.9
1.1
0.3
0.4
0.5
0.7
0.7
1.0
1.1
0.3
0.3
0.3
0.3
0.3
0.4
0.5
0.5
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
1.0
1.1
1.1
1.2
1.3
1.7
0.3
0.6
0.8
0.8
1.2
1.4
0.6
0.6
0.7
0.8

3.50
3.50
5.00
4.00
4.00
4.50
5.00
4.00
4.00
4.00
3.50
4.00
5.50
5.00
5.00
4.50
4.50
15.0
8.00
9.00
10.0
6.00
6.00
5.50
4.25
4.25
5.00
5.00
7.00
10.0
5.00
4.50
4.50
5.75
4.50
4.50
5.00
5.00
5.00
5.00
5.50
5.00
6.50
5.00
4.75
6.00
5.50
6.00
5.00
8.50
10.8
11.0
8.00
10.0
5.00
5.00
5.00
4.50
9.50
5.00
5.50
7.00
5.00
7.00
5.00
5.50
6.00
5.50
6.00
5.50
7.50
7.00
6.50
6.50
6.50
6.00
5.00
6.00
8.00
7.00

SPR
SST
MW
SST
SST
SST
SST
MW
SST
SST
SPR
SPR
MW
SST
MW
SST
SPR
MW
MW
MW
SST
SST
SST
SPR
SPR
SPR
SST
SPR
MW
MW
MW
SST
SST
SPR
SST
MW
SST
SST
SST
SPR
SST
MW
MW
MW
SST
MW
SST
SST
MW
SST
SST
MW
MW
SST
MW
SST
MW
MW
SST
SST
MW
MW
SPR
SPR
SPR
SST
SPR
SPR
SST
SST
MW
SST
MW
SST
SPR
SPR
SST
MW
MW
SST

E
N
D
S

C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
C
C
CG
C
C
C
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
C
C
C
C
C
C
C
C
C
CG
CG
C
CG
C
CG
C
C
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
C
C
CG
C

F
N
S
H

N
N
N
N
N
N
N
GI
N
N
N
N
Z
N
Z
N
N
Z
N
Z
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
GI
N
N
N
GI
N
N
N
Z
N
N
N
N
Z
N
N
N
N
N
N
N
Z
N
N
N
Z
Z
N
Z
Z
N
Z
Z
N
N
N
N
Z
N
Z
Z
N
N
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

65

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 66

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296

7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52

S-1372
O-126
J-65
S-1696
12404
B1-70
M-103
B8-17
H-74
4283
10854
B12-36
3193
II-24
B3-60
AA-98
L-81
10077
A12-39
A11-19
F-65
BB-19
3861
I-16
NN-61
S-1015
OO-6
EE-91
H-26
JJ-32
B9-1
II-34
MM-14
II-47
MM-29
RR-9
A14-1
F-42
F-43
NN-19
A10-16
B1-16
J-88
4396
S-3010
3172
KK-16
KK-3
W-75
G-25
10727
MM-22
S-124
3892
O-76
OO-33
I-45
Q-86
J-6
HH-21
O-157
10432
3523
L-57
10869
A-19
10221
A-96
B5-18
I-44
S-842
A13-25
A15-58
J-13
B5-12
F-30
G-24
N-45
V-67
2714

.56
.56
.56
.58
.59
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.72
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.84
.84

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

14.3
14.3
14.3
14.7
15.1
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4

MATERIAL: MW - Music Wire

66

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.226
.216
.202
.234
.268
.248
.246
.228
.202
.270
.262
.252
.246
.246
.246
.240
.232
.228
.216
.204
.202
.196
.192
.188
.256
.240
.236
.224
.216
.192
.254
.246
.238
.236
.236
.222
.212
.204
.202
.196
.264
.252
.238
.180
.268
.266
.256
.256
.252
.252
.244
.236
.236
.224
.216
.216
.206
.202
.202
.256
.246
.200
.176
.260
.256
.256
.246
.232
.232
.232
.232
.220
.208
.206
.204
.202
.202
.198
.262
.256

RATE
mm

5.7
5.5
5.1
5.9
6.8
6.3
6.2
5.8
5.1
6.9
6.7
6.4
6.2
6.2
6.2
6.1
5.9
5.8
5.5
5.2
5.1
5.0
4.9
4.8
6.5
6.1
6.0
5.7
5.5
4.9
6.5
6.2
6.0
6.0
6.0
5.6
5.4
5.2
5.1
5.0
6.7
6.4
6.0
4.6
6.8
6.8
6.5
6.5
6.4
6.4
6.2
6.0
6.0
5.7
5.5
5.5
5.2
5.1
5.1
6.5
6.2
5.1
4.5
6.6
6.5
6.5
6.2
5.9
5.9
5.9
5.9
5.6
5.3
5.2
5.2
5.1
5.1
5.0
6.7
6.5

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

23
64
112
16

4.1
11
20
2.7
.10
1.2
.94
3.7
19
.06
.21
.96
1.4
.85
.76
1.3
3.2
3.7
10
11
16
16
18
26
.38
1.7
2.4
5.3
5.5
18
.67
.72
1.7
2.2
1.9
3.6
7.9
13
14
12
.12
.63
1.5
42
.06
.09
.15
.21
.44
.72
.94
1.2
1.6
4.2
6.4
7.7
9.6
13
11
.47
.94
14
27
.17
.34
.21
.99
2.0
2.0
1.6
1.8
3.8
8.0
7.2
9.9
11
11
12
.14
.28

.22
.12
.12
.24
.49
.27
.37
.25
.11
.51
.51
.40
.37
.41
.41
.39
.25
.25
.19
.17
.14
.15
.16
.11
.50
.28
.37
.20
.24
.15
.49
.46
.47
.41
.46
.30
.21
.16
.16
.19
.58
.40
.49
.09
.62
.61
.45
.51
.54
.53
.51
.45
.39
.25
.22
.19
.21
.17
.20
.60
.37
.17
.12
.63
.56
.59
.53
.38
.38
.47
.41
.30
.23
.26
.21
.20
.21
.20
.67
.65

.55
6.9
5.4
21
107
.33
1.2
5.5
8.0
4.9
4.3
7.2
18
21
58
66
90
89
102
148
2.2
9.9
14
30
31
104
3.8
4.1
9.6
12
11.2
21
45
74
83
67
.68
3.6
8.8
238
.34
.52
.84
1.2
2.5
4.1
5.3
6.9
8.9
24
37
44
55
75
64
2.7
5.4
80
155
.99
1.9
1.2
5.6
12
12
9.3
10
22
46
41
57
65
63
67
.79
1.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

5.7
3.0
2.9
6.2
12
6.8
9.4
6.3
2.9
13
13
10
9.5
10
10
9.9
6.3
6.4
4.9
4.4
3.7
3.9
4.0
2.9
13
7.2
9.4
5.0
6.2
3.7
12
12
12
10
12
7.5
5.3
4.2
4.0
4.7
15
10
12
2.4
16
16
11
13
14
13
13
11
9.8
6.3
5.7
4.7
5.3
4.4
5.1
15
9.4
4.4
3.1
16
14
15
13
9.7
9.6
12
10
7.6
5.9
6.6
5.5
5.1
5.3
5.2
17
16

Lbs.

5.2
7.6
13
3.8
.27
1.9
2.0
5.3
12
.17
.62
2.2
3.0
2.0
1.8
2.8
4.4
5.3
11
11
13
14
16
17
1.1
2.8
5.1
6.0
7.6
15
1.9
1.9
4.5
5.1
3.8
6.1
9.4
12
13
13
.40
1.4
4.3
22
.21
.32
.38
.61
1.3
2.2
2.7
3.1
3.4
6.0
8.1
8.1
11
13
13
1.6
2.0
14
19
.63
1.1
.70
3.0
4.4
4.4
4.3
4.1
6.6
11
11
12
13
13
14
.53
1.0

ENDS: C - Closed

G - Ground
O - Open

23
34
58
17
1.2
8.3
8.9
24
54
.75
2.8
9.6
13
8.9
8.0
12
20
24
50
51
58
61
71
76
4.8
12
23
27
34
68
8.4
8.5
20
23
17
27
42
54
58
56
1.8
6.4
19
98
.94
1.4
1.7
2.7
6.0
9.6
12
14
15
27
36
36
51
58
58
7.2
8.9
61
84
2.8
4.8
3.1
13
20
20
19
18
29
48
48
54
58
58
61
2.4
4.6

Inches

.23
.20
.33
.22
.11
.14
.16
.24
.27
.11
.12
.11
.16
.20
.21
.21
.24
.27
.23
.35
.38
.40
.47
.38
.16
.17
.20
.27
.32
.42
.12
.23
.22
.24
.23
.35
.34
.39
.40
.50
.14
.13
.23
.41
.13
.14
.30
.24
.21
.15
.24
.30
.27
.28
.32
.32
.39
.38
.47
.14
.19
.40
.66
.18
.16
.22
.18
.29
.29
.34
.32
.34
.41
.44
.43
.47
.43
.49
.17
.20

mm

5.8
5.1
8.4
5.5
2.7
3.7
4.1
6.0
6.9
2.8
3.0
2.8
4.1
5.1
5.4
5.3
6.1
6.9
5.8
8.8
9.6
10.2
11.9
9.6
4.1
4.3
5.0
6.9
8.1
10.6
2.9
5.7
5.5
6.1
5.7
8.9
8.5
9.9
10.1
12.7
3.5
3.4
5.9
10.3
3.3
3.5
7.6
6.1
5.3
3.9
6.1
7.6
6.9
7.1
8.1
8.1
10.0
9.6
11.9
3.6
4.8
10.1
16.8
4.6
4.1
5.6
4.4
7.3
7.3
8.7
8.1
8.7
10.3
11.1
10.8
11.9
11.0
12.4
4.3
5.0

WIRE DIA.
Inches

0.035
0.040
0.047
0.031
0.014
0.024
0.025
0.034
0.047
0.013
0.017
0.022
0.025
0.025
0.025
0.028
0.032
0.034
0.040
0.046
0.047
0.050
0.052
0.054
0.020
0.028
0.030
0.036
0.040
0.052
0.021
0.025
0.029
0.030
0.030
0.037
0.042
0.046
0.047
0.050
0.016
0.022
0.029
0.058
0.014
0.015
0.020
0.020
0.022
0.022
0.026
0.030
0.030
0.036
0.040
0.040
0.045
0.047
0.047
0.020
0.025
0.048
0.060
0.018
0.020
0.020
0.025
0.032
0.032
0.032
0.032
0.038
0.044
0.045
0.046
0.047
0.047
0.049
0.017
0.020

mm

TOTAL
MATL
COILS

0.9
1.0
1.2
0.8
0.4
0.6
0.6
0.9
1.2
0.3
0.4
0.6
0.6
0.6
0.6
0.7
0.8
0.9
1.0
1.2
1.2
1.3
1.3
1.4
0.5
0.7
0.8
0.9
1.0
1.3
0.5
0.6
0.7
0.8
0.8
0.9
1.1
1.2
1.2
1.3
0.4
0.6
0.7
1.5
0.4
0.4
0.5
0.5
0.6
0.6
0.7
0.8
0.8
0.9
1.0
1.0
1.1
1.2
1.2
0.5
0.6
1.2
1.5
0.5
0.5
0.5
0.6
0.8
0.8
0.8
0.8
1.0
1.1
1.1
1.2
1.2
1.2
1.2
0.4
0.5

6.50
5.00
6.00
6.00
6.50
5.00
6.50
7.00
5.75
7.50
6.00
5.00
5.50
7.00
8.50
7.50
6.50
7.00
5.75
7.50
7.00
8.00
9.00
7.00
7.00
6.00
6.50
6.50
8.00
8.00
5.50
8.00
7.50
7.00
7.50
8.50
8.00
7.50
7.50
10.0
7.50
6.00
8.00
7.00
8.25
8.25
15.0
11.0
8.50
6.00
8.25
10.0
8.00
7.00
8.00
7.00
8.75
8.00
9.00
6.00
6.50
8.25
11.0
9.00
7.00
10.0
7.00
9.00
9.00
10.8
9.00
9.00
9.25
9.75
9.25
9.00
9.25
9.00
9.00
8.75

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SST
SPR
SST
MW
SST
SST
SPR
SST
MW
SST
MW
MW
SST
MW
SST
HD
SPR
MW
SST
HD
SST
SPR
SST
MW
SST
MW
SPR
SST
SST
MW
SST
MW
MW
MW
SST
SPR
SPR
HD
SST
SST
SST
MW
SPR
SST
MW
MW
MW
MW
MW
MW
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
MW
SST
SPR
SPR
HD
SST
SST
MW
SPR
SPR
MW
SST
SST
SPR
SST
SPR
HD
SPR
SST
MW
HD

E
N
D
S

F
N
S
H

CG
CG
C
C
C
C
CG
CG
CG
C
C
CG
C
C
CG
CG
C
C
CG
CG
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
C
CG
C
CG
C
CG
C
C
CG
C
CG
CG
CG
C
C
CG
C
C
C
C
CG
C
C
CG
C
CG
CG
C
C
C
CG
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
C
C
C

N
N
Z
N
N
N
N
N
N
N
N
N
Z
N
Z
N
N
Z
GI
N
Z
N
Z
N
N
N
Z
N
N
N
Z
N
GI
N
Z
N
GI
Z
Z
N
N
N
Z
Z
N
Z
N
N
N
N
N
N
N
Z
N
Z
N
GI
Z
N
N
BO
GI
Z
N
N
Z
BO
N
Z
N
N
GI
N
N
Z
GI
N
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 67

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296

7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52

A14-49
AA-60
A12-8
EE-63
GG-93
BB-100
2782
B14-16
S-1288
A13-6
HH-51
A10-60
GG-2
B1-12
AA-50
2812
A11-29
B11-40
K-4
F-34
B11-48
V-4
GG-50
Z-5
S-1497
JJ-42
JJ-13
A14-31
3667
A15-64
B14-32
B11-30
B2-29
Z-76
10266
PP-81
Z-49
G-62
JJ-43
2643
3763
3875
2666
B9-43
S-230
M-87
UU-46
S-10
L-55
KK-33
G-49
S-1306
S-37
M-112
A15-29
JJ-19
S-1088
H-53
CC-29
10627
S-1117
3628
S-793
MM-31
A11-42
B8-31
B9-45
3219
QQ-46
LL-59
S-40
S-1312
3749
4324
Q-25
3839
XX-52
Y-79
CC-67
O-63

.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.94
.94
.94
.94
.94
.94
.97
.97
.97
.97
.98
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.06
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.19
1.19
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.8
23.8
23.8
23.8
23.8
23.8
24.6
24.6
24.6
24.6
25.0
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.0
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
29.4
30.2
30.2
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5

I.D.
Inches

.242
.202
.270
.260
.260
.258
.256
.256
.256
.250
.248
.244
.236
.232
.220
.214
.212
.208
.206
.204
.204
.172
.266
.234
.220
.216
.216
.202
.230
.230
.222
.220
.210
.272
.266
.250
.246
.244
.242
.240
.236
.236
.232
.226
.224
.206
.206
.202
.196
.186
.172
.220
.152
.254
.250
.176
.268
.252
.248
.232
.232
.220
.220
.216
.210
.234
.256
.254
.236
.236
.172
.258
.256
.242
.236
.232
.216
.186
.236
.188

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

6.1
5.1
6.9
6.6
6.6
6.6
6.5
6.5
6.5
6.4
6.3
6.2
6.0
5.9
5.6
5.4
5.4
5.3
5.2
5.2
5.2
4.4
6.8
5.9
5.6
5.5
5.5
5.1
5.8
5.8
5.6
5.6
5.3
6.9
6.8
6.4
6.2
6.2
6.1
6.1
6.0
6.0
5.9
5.7
5.7
5.2
5.2
5.1
5.0
4.7
4.4
5.6
3.9
6.5
6.4
4.5
6.8
6.4
6.3
5.9
5.9
5.6
5.6
5.5
5.3
5.9
6.5
6.5
6.0
6.0
4.4
6.6
6.5
6.1
6.0
5.9
5.5
4.7
6.0
4.8

Lbs./In.

6.3
36
.32
.73
.60
1.0
2.2
2.7
2.1
4.3
2.1
4.5
9.1
13
20
24
31
42
38
56
37
221
.47
7.8
19
27
16
44
12
13
19
22
36
.29
.51
.89
3.7
3.3
4.9
3.0
12
7.6
9.0
15
14
34
43
33
52
77
242
20
365
1.5
1.1
105
.10
1.8
2.5
7.1
8.8
18
16
16
30
9.0
1.3
1.4
4.7
5.0
126
1.3
1.4
3.2
3.9
8.1
20
84
6.5
62

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.1
6.3
.06
.13
.11
.18
.38
.48
.37
.76
.38
.79
1.6
2.2
3.5
4.2
5.4
7.4
6.6
9.8
6.6
39
.08
1.4
3.4
4.8
2.8
7.7
2.0
2.3
3.4
3.8
6.3
.05
.09
.16
.65
.59
.85
.52
2.1
1.3
1.6
2.7
2.4
5.9
7.6
5.7
9.1
13
42
3.5
64
.26
.19
18
.02
.31
.43
1.2
1.5
3.2
2.8
2.8
5.3
1.6
.23
.25
.82
.87
22
.23
.24
.57
.68
1.4
3.5
15
1.1
11

.40
.23
.76
.65
.64
.68
.54
.60
.52
.57
.58
.50
.37
.48
.33
.34
.28
.26
.28
.22
.28
.12
.80
.60
.34
.30
.34
.28
.58
.37
.33
.32
.28
.87
.86
.49
.53
.67
.70
.49
.42
.67
.62
.34
.40
.32
.26
.30
.28
.23
.11
.33
.10
.81
.65
.22
.79
.82
.83
.69
.47
.53
.42
.47
.33
.42
.98
.93
.71
.68
.20
.71
1.0
.85
.71
.55
.41
.23
.53
.29

mm

10
5.9
19
17
16
17
14
15
13
14
15
13
9.5
12
8.3
8.7
7.2
6.5
7.2
5.5
7.0
3.1
20
15
8.6
7.5
8.6
7.0
15
9.3
8.5
8.2
7.1
22
22
13
14
17
18
12
11
17
16
8.5
10
8.1
6.7
7.5
7.1
5.9
2.8
8.3
2.5
21
17
5.6
20
21
21
18
12
14
11
12
8.5
11
25
24
18
17
5.1
18
26
21
18
14
10
5.7
13
7.4

ENDS: C - Closed

G - Ground
O - Open

Lbs.

2.5
8.4
.24
.48
.39
.68
1.2
1.6
1.1
2.5
1.2
2.2
3.4
6.2
6.6
8.3
8.8
11
11
12
10
27
.38
4.7
6.6
8.1
5.5
12
6.7
4.9
6.5
7.0
10
.25
.43
.44
2.0
2.2
3.4
1.5
5.1
5.1
5.5
5.2
5.6
11
11
9.6
14
18
27
6.6
36
1.2
.72
23
.08
1.4
2.0
4.9
4.1
9.7
6.6
7.6
10
3.8
1.3
1.3
3.3
3.4
25
.93
1.4
2.7
2.7
4.4
8.1
19
3.4
18

11
37
1.1
2.1
1.7
3.0
5.2
7.2
4.8
11
5.5
10
15
27
29
37
39
48
48
54
46
119
1.7
21
29
36
24
54
30
22
29
31
45
1.1
1.9
2.0
8.9
9.9
15
6.5
23
23
25
23
25
48
51
43
64
80
119
29
159
5.3
3.2
102
.35
6.4
9.1
22
18
43
29
34
45
17
5.6
6.0
15
15
112
4.1
6.2
12
12
20
36
85
15
80

Inches

.20
.61
.11
.23
.23
.20
.16
.12
.15
.15
.30
.22
.24
.27
.40
.53
.41
.44
.47
.47
.60
.59
.14
.34
.37
.40
.60
.52
.36
.33
.37
.38
.45
.08
.14
.51
.24
.33
.30
.51
.24
.33
.38
.32
.38
.56
.52
.71
.68
.74
.54
.36
.81
.25
.41
.84
.34
.24
.30
.43
.35
.44
.44
.60
.52
.28
.21
.26
.48
.39
.90
.17
.22
.41
.54
.42
.56
.72
.32
.86

mm

Inches

5.1
15.5
2.9
5.7
5.9
5.1
4.1
3.0
3.8
3.8
7.6
5.6
6.1
6.8
10.1
13.5
10.4
11.2
12.0
12.0
15.2
15.0
3.4
8.7
9.4
10.2
15.2
13.1
9.2
8.4
9.4
9.7
11.5
2.1
3.6
12.9
6.0
8.5
7.5
13.0
6.1
8.4
9.8
8.0
9.6
14.3
13.1
17.9
17.1
18.9
13.8
9.2
20.6
6.4
10.4
21.3
8.5
6.1
7.6
11.0
8.9
11.1
11.1
15.2
13.1
7.1
5.3
6.5
12.2
9.9
22.8
4.2
5.6
10.3
13.7
10.6
14.2
18.2
8.0
21.9

0.027
0.047
0.013
0.018
0.018
0.019
0.020
0.020
0.020
0.023
0.024
0.026
0.030
0.032
0.038
0.041
0.042
0.044
0.045
0.046
0.046
0.062
0.015
0.031
0.038
0.040
0.040
0.047
0.033
0.033
0.037
0.038
0.043
0.012
0.015
0.023
0.025
0.026
0.027
0.028
0.030
0.030
0.032
0.035
0.036
0.045
0.045
0.047
0.050
0.055
0.062
0.038
0.072
0.021
0.023
0.060
0.014
0.022
0.024
0.032
0.032
0.038
0.038
0.040
0.043
0.031
0.020
0.021
0.030
0.030
0.062
0.019
0.020
0.027
0.030
0.032
0.040
0.055
0.030
0.054

mm

TOTAL
MATL
COILS

0.7
1.2
0.3
0.5
0.5
0.5
0.5
0.5
0.5
0.6
0.6
0.7
0.8
0.8
1.0
1.0
1.1
1.1
1.1
1.2
1.2
1.6
0.4
0.8
1.0
1.0
1.0
1.2
0.8
0.8
0.9
1.0
1.1
0.3
0.4
0.6
0.6
0.7
0.7
0.7
0.8
0.8
0.8
0.9
0.9
1.1
1.1
1.2
1.3
1.4
1.6
1.0
1.8
0.5
0.6
1.5
0.4
0.6
0.6
0.8
0.8
1.0
1.0
1.0
1.1
0.8
0.5
0.5
0.8
0.8
1.6
0.5
0.5
0.7
0.8
0.8
1.0
1.4
0.8
1.4

7.50
13.0
7.75
11.5
12.0
9.50
7.00
6.00
6.50
6.50
11.5
8.50
8.00
8.33
9.50
12.0
9.75
10.0
10.5
9.25
13.0
9.50
8.00
11.0
9.75
10.0
14.0
11.0
10.0
9.00
10.0
10.0
10.5
6.00
8.50
21.0
8.50
11.9
10.0
17.3
7.00
10.0
11.0
9.00
10.5
11.5
10.5
14.0
13.5
12.5
8.75
9.50
10.3
11.0
17.8
14.0
23.0
10.0
11.5
13.5
10.0
11.5
11.5
14.0
12.0
9.00
10.5
11.3
15.0
13.0
13.5
7.75
10.0
14.0
18.0
12.0
13.0
13.0
10.5
16.0

SST
SST
MW
MW
SST
SST
HD
MW
SST
MW
SST
SST
SST
MW
SST
HD
SST
SPR
SST
SPR
SPR
SPR
SST
MW
SST
SPR
SST
SST
MW
SPR
SPR
SPR
SPR
SST
MW
SST
SST
MW
MW
MW
MW
MW
MW
SST
SST
SST
SPR
SST
SPR
SST
SPR
SST
SST
MW
SST
SST
SST
SST
MW
MW
SST
MW
SST
SST
SPR
SST
MW
MW
MW
SST
SST
SST
MW
MW
MW
HD
SPR
SPR
SST
SPR

E
N
D
S

CG
CG
C
C
C
C
C
CG
C
CG
C
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
C
CG
C
C
CG
C
CG
C
C
C
C
C
C
C
C
C
C
CG
CG
C
C
C
CG
C
CG
CG
C
C
CG
CG
C
C
C
CG
C
CG
CG
C
CG
CG
CG
C
C
CG
C
C
C
C
CG
C
C
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
Z
N
N
N
Z
N
N
N
Z
N
N
N
N
Z
N
N
N
N
N
Z
N
N
Z
N
Z
Z
Z
Z
N
N
N
N
N
N
N
Z
N
N
Z
N
N
N
N
Z
Z
N
Z
N
N
GI
N
N
Z
Z
N
N
N
Z
Z
GI
Z
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

67

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 68

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.296
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300

7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.52
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62

M-96
B7-9
S-3076
I-77
AA-57
WW-56
3855
KK-28
4319
A13-46
A12-70
2889
B15-57
A11-13
11405
Q-54
K-86
H-83
4280
11408
B9-10
11900
A13-8
10057
A14-36
2840
S-1558
3532
A-37
U-36
F-29
S-1433
10203
AA-55
QQ-64
3603
B12-15
1747
M-124
3366
2633
11476
A10-68
B4-14
S-1006
10071
B10-7
B15-62
S-1026
S-880
Q-15
3651
S-1127
B8-18
10625
S-190
2531
S-1441
S-1581
S-1014
10647
2570
10513
B4-65
70779
70779S
70802
70802S
70825
70825S
70847
70847S
70868
70868S
70887
70887S
70906
70906S
70925
70925S

1.28
1.31
1.31
1.31
1.31
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.63
1.63
1.66
1.69
1.72
1.72
1.75
1.75
1.75
1.75
1.75
1.78
1.81
1.88
1.88
1.88
1.94
1.94
1.95
2.00
2.00
2.09
2.16
2.16
2.28
2.56
2.56
2.63
2.75
2.75
2.78
3.00
3.00
3.25
3.41
3.88
7.50
7.50
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

32.5
33.3
33.3
33.3
33.3
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
41.3
41.3
42.1
42.8
43.6
43.6
44.5
44.5
44.5
44.5
44.5
45.2
46.0
47.6
47.6
47.6
49.2
49.2
49.6
50.8
50.8
53.2
54.8
54.8
57.9
65.1
65.1
66.7
69.9
69.9
70.6
76.2
76.2
82.6
86.5
98.4
190.5
190.5
8.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7

MATERIAL: MW - Music Wire

68

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.182
.244
.238
.206
.176
.258
.240
.236
.234
.218
.218
.214
.210
.200
.248
.202
.196
.256
.238
.226
.226
.222
.212
.206
.206
.228
.228
.222
.170
.224
.172
.256
.252
.246
.246
.232
.214
.244
.218
.216
.172
.236
.212
.172
.234
.208
.218
.204
.202
.238
.218
.200
.224
.244
.176
.202
.226
.200
.204
.202
.236
.224
.214
.254
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216

RATE
mm

4.6
6.2
6.0
5.2
4.5
6.6
6.1
6.0
5.9
5.5
5.5
5.4
5.3
5.1
6.3
5.1
5.0
6.5
6.0
5.7
5.7
5.6
5.4
5.2
5.2
5.8
5.8
5.6
4.3
5.7
4.4
6.5
6.4
6.2
6.2
5.9
5.4
6.2
5.5
5.5
4.4
6.0
5.4
4.4
5.9
5.3
5.5
5.2
5.1
6.0
5.5
5.1
5.7
6.2
4.5
5.1
5.7
5.1
5.2
5.1
6.0
5.7
5.4
6.5
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5

Lbs./In.

129
3.7
5.4
32
98
1.2
4.3
6.2
4.7
15
20
16
24
34
2.6
28
40
.72
4.1
8.8
9.3
11
17
26
23
5.9
4.5
9.3
105
8.6
126
.99
1.9
2.5
1.6
6.6
16
3.3
12
14
109
4.4
13
111
3.5
18
10
17
16
1.4
9.6
16
5.8
2.6
33
12
3.2
13
11
16
2.0
2.0
3.6
4.7
8.6
7.3
15
13
26
22
33
28
46
39
64
55
78
66
107
91

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

23
.65
.95
5.7
17
.22
.76
1.1
.82
2.6
3.4
2.8
4.3
5.9
.46
4.9
7.0
.13
.71
1.5
1.6
1.9
3.0
4.6
4.1
1.0
.79
1.6
18
1.5
22
.17
.34
.44
.28
1.2
2.7
.58
2.2
2.4
19
.77
2.3
19
.61
3.2
1.8
3.0
2.8
.25
1.7
2.9
1.0
.45
5.8
2.0
.56
2.3
1.9
2.7
.36
.35
.62
.82
1.5
1.3
2.7
2.3
4.5
3.8
5.7
4.8
8.0
6.8
11
9.6
14
12
19
16

.16
.90
.57
.35
.25
1.1
.96
.82
.82
.48
.53
.54
.41
.38
1.1
.44
.34
1.2
1.0
.86
.59
.55
.50
.44
.46
.95
.83
.70
.26
.70
.21
1.1
1.1
1.2
1.2
.93
.56
1.0
.61
.81
.34
1.2
.66
.24
1.1
.58
.74
.71
.75
1.3
.79
.84
.97
1.3
.74
1.1
1.6
.99
1.0
.78
2.5
3.0
2.5
.22
.25
.19
.21
.17
.20
.16
.19
.15
.16
.13
.15
.12
.14
.11
.12
.10

mm

4.1
23
15
9.0
6.3
29
24
21
21
12
14
14
11
9.7
27
11
8.7
30
26
22
15
14
13
11
12
24
21
18
6.7
18
5.4
28
29
30
31
24
14
25
15
20
8.6
29
17
6.1
27
15
19
18
19
32
20
21
25
33
19
27
40
25
26
20
63
76
62
5.5
6.3
4.9
5.4
4.3
5.0
4.0
4.8
3.7
4.2
3.3
3.8
3.0
3.6
2.9
3.1
2.4

Lbs.

21
3.3
3.1
11
24
1.4
4.2
5.1
3.8
7.1
10
8.7
10
13
2.8
12
14
.85
4.2
7.6
5.5
6.1
8.8
11
11
5.6
3.7
6.5
28
6.0
27
1.1
2.2
3.0
2.0
6.2
8.7
3.3
7.6
11
37
5.1
8.8
27
3.8
11
7.6
12
12
1.8
7.6
14
5.6
3.3
24
12
5.0
13
11
12
5.1
6.0
8.7
1.0
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7

ENDS: C - Closed

G - Ground
O - Open

94
15
14
51
108
6.2
19
23
17
31
47
39
45
58
12
54
61
3.8
19
34
25
27
39
51
48
25
17
29
124
27
119
4.8
9.6
13
8.8
27
39
15
34
50
165
23
39
119
17
48
34
54
54
8.1
34
61
25
15
108
54
22
58
51
54
23
27
39
4.5
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39

Inches

.60
.29
.33
.61
.99
.19
.38
.36
.56
.54
.51
.74
.62
.72
.29
.75
.75
.32
.46
.59
.53
.54
.66
.77
.72
.68
.80
.68
1.26
.65
.99
.25
.23
.35
.51
.49
.73
.34
.72
.74
1.05
.51
.84
1.12
.64
.88
.83
1.24
1.27
1.02
.88
1.54
.85
.39
1.50
1.72
1.44
1.68
1.62
1.32
.99
2.59
2.90
.13
.09
.09
.11
.11
.13
.13
.14
.14
.16
.16
.18
.18
.19
.19
.19
.19

mm

15.2
7.3
8.5
15.4
25.1
4.8
9.6
9.1
14.2
13.6
12.9
18.7
15.8
18.3
7.3
19.1
19.1
8.1
11.8
14.9
13.3
13.6
16.8
19.4
18.3
17.2
20.3
17.4
32.0
16.5
25.2
6.4
5.9
8.9
13.0
12.4
18.5
8.6
18.3
18.8
26.8
13.0
21.3
28.3
16.1
22.4
21.1
31.5
32.2
25.8
22.3
39.0
21.5
9.9
38.1
43.6
36.4
42.7
41.2
33.4
25.1
65.8
73.7
3.2
2.2
2.2
2.7
2.7
3.3
3.3
3.6
3.6
4.0
4.0
4.5
4.5
4.8
4.8
4.8
4.8

WIRE DIA.
Inches

0.057
0.026
0.029
0.045
0.060
0.019
0.028
0.030
0.031
0.039
0.039
0.041
0.043
0.048
0.024
0.047
0.050
0.020
0.029
0.035
0.035
0.037
0.042
0.045
0.045
0.034
0.034
0.037
0.063
0.036
0.062
0.020
0.022
0.025
0.025
0.032
0.041
0.026
0.039
0.040
0.062
0.030
0.042
0.062
0.031
0.044
0.039
0.046
0.047
0.029
0.039
0.048
0.036
0.026
0.060
0.047
0.035
0.048
0.046
0.047
0.030
0.036
0.041
0.023
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042

mm

TOTAL
MATL
COILS

1.4
0.7
0.7
1.1
1.5
0.5
0.7
0.8
0.8
1.0
1.0
1.0
1.1
1.2
0.6
1.2
1.3
0.5
0.7
0.9
0.9
0.9
1.1
1.1
1.1
0.9
0.9
0.9
1.6
0.9
1.6
0.5
0.6
0.6
0.6
0.8
1.0
0.7
1.0
1.0
1.6
0.8
1.1
1.6
0.8
1.1
1.0
1.2
1.2
0.7
1.0
1.2
0.9
0.7
1.5
1.2
0.9
1.2
1.2
1.2
0.8
0.9
1.0
0.6
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1

10.5
11.0
10.5
13.5
16.5
9.00
12.5
12.0
17.0
13.8
12.0
17.0
14.5
15.0
11.0
16.0
15.0
15.0
15.0
15.8
15.0
14.5
15.8
16.0
16.0
19.9
22.5
18.5
19.0
18.0
15.0
11.5
10.5
13.0
19.5
14.3
17.8
12.0
17.5
17.5
17.0
16.0
20.0
17.0
19.5
20.0
21.3
26.0
26.0
34.0
22.5
32.0
22.5
15.0
25.0
36.5
40.0
35.0
35.3
27.0
33.0
71.0
70.8
5.50
3.88
3.88
4.13
4.13
4.38
4.38
4.38
4.38
4.50
4.50
4.63
4.63
4.75
4.75
4.50
4.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
MW
SST
SPR
SPR
MW
MW
MW
MW
SST
MW
SPR
SPR
SST
MW
SST
SST
SST
MW
MW
SPR
SST
SST
SPR
SST
MW
SST
SPR
HD
SPR
SPR
SST
MW
MW
MW
MW
SPR
MW
SPR
MW
MW
MW
SST
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SST
MW
PB
SST
MW
SST
SST
SST
MW
SPR
SPR
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
C
CG
CG
C
C
CG
C
CG
C
C
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
C
CG
CG
C
CG
C
CG
C
C
CG
C
C
C
CG
C
C
C
CG
CG
CG
C
C
CG
CG
C
C
C
CG
CG
C
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
N
N
N
N
Z
Z
GI
Z
N
Z
Z
Z
N
Z
N
N
N
Z
Z
N
N
N
GI
N
Z
N
GI
N
GI
Z
N
Z
Z
Z
Z
N
Z
GI
Z
Z
GI
N
N
N
Z
N
N
N
N
N
Z
N
N
N
N
Z
N
N
N
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 69

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300

7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62

70944
70944S
70963
70963S
70984
70984S
71005
71005S
70780
70780S
70803
70803S
70826
70826S
70848
70848S
70869
70869S
70888
70888S
70907
70907S
70926
70926S
70945
70945S
70964
70964S
70985
70985S
71006
71006S
B4-69
70781
70781S
70804
70804S
70827
70827S
70849
70849S
70870
70870S
70889
70889S
70908
70908S
70927
70927S
70946
70946S
70965
70965S
70986
70986S
71007
71007S
70782
70782S
70805
70805S
70828
70828S
70850
70850S
70871
70871S
70890
70890S
70909
70909S
70928
70928S
70947
70947S
70966
70966S
70987
70987S
71008

.38
.38
.38
.38
.38
.38
.38
.38
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

9.7
9.7
9.7
9.7
9.7
9.7
9.7
9.7
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2

I.D.
Inches

.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.258
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.6
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

124
105
159
135
190
161
228
194
7.2
6.1
13
11
21
18
27
23
38
33
53
45
65
56
89
76
105
89
132
112
156
133
187
159
2.7
6.6
5.6
11
9.6
18
15
23
20
33
28
46
39
55
47
70
60
91
78
112
95
133
113
158
134
6.0
5.1
10
8.6
16
13
20
17
29
24
39
33
48
41
60
51
78
66
97
83
116
98
137

22
18
28
24
33
28
40
34
1.3
1.1
2.3
2.0
3.6
3.1
4.8
4.0
6.7
5.7
9.3
7.9
11
9.7
16
13
18
16
23
20
27
23
33
28
.47
1.1
.97
2.0
1.7
3.1
2.6
4.1
3.5
5.8
4.9
8.1
6.9
9.7
8.3
12
10
16
14
20
17
23
20
28
24
1.0
.89
1.8
1.5
2.7
2.3
3.5
3.0
5.0
4.3
6.8
5.8
8.4
7.2
11
8.9
14
12
17
14
20
17
24

.13
.10
.11
.09
.11
.08
.09
.07
.30
.23
.25
.20
.24
.19
.22
.18
.20
.16
.18
.14
.17
.14
.14
.11
.15
.12
.13
.11
.13
.10
.11
.09
.31
.33
.25
.29
.23
.28
.22
.26
.21
.23
.18
.21
.17
.20
.16
.18
.15
.17
.14
.16
.13
.15
.12
.13
.11
.36
.28
.33
.26
.32
.25
.30
.24
.26
.21
.25
.20
.23
.18
.21
.17
.20
.16
.18
.15
.17
.14
.15

ENDS: C - Closed

mm

3.2
2.6
2.8
2.3
2.7
2.1
2.3
1.9
7.5
5.9
6.4
5.0
6.2
4.9
5.7
4.5
5.0
4.0
4.6
3.6
4.3
3.4
3.6
2.9
3.8
3.0
3.4
2.7
3.3
2.6
2.9
2.3
7.8
8.3
6.5
7.4
5.8
7.2
5.7
6.6
5.2
5.8
4.6
5.3
4.2
5.1
4.1
4.6
3.7
4.4
3.5
4.0
3.2
3.8
3.0
3.4
2.7
9.1
7.1
8.3
6.5
8.1
6.4
7.7
6.0
6.7
5.3
6.3
5.0
5.9
4.7
5.4
4.3
5.1
4.1
4.6
3.7
4.4
3.5
3.9

G - Ground
O - Open

Lbs.

16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
.83
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21

70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
3.7
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94

Inches

.22
.22
.22
.22
.23
.23
.24
.24
.09
.09
.11
.11
.15
.15
.16
.16
.18
.18
.19
.19
.21
.21
.20
.20
.24
.24
.25
.25
.26
.26
.27
.27
.16
.10
.10
.13
.13
.16
.16
.17
.17
.19
.19
.21
.21
.23
.23
.24
.24
.26
.26
.28
.28
.29
.29
.31
.31
.10
.10
.13
.13
.17
.17
.19
.19
.21
.21
.24
.24
.26
.26
.27
.27
.30
.30
.31
.31
.32
.32
.34

mm

Inches

5.6
5.6
5.7
5.7
5.9
5.9
6.2
6.2
2.3
2.3
2.9
2.9
3.7
3.7
4.0
4.0
4.4
4.4
4.9
4.9
5.3
5.3
5.2
5.2
6.1
6.1
6.3
6.3
6.7
6.7
7.0
7.0
4.1
2.4
2.4
3.2
3.2
4.1
4.1
4.4
4.4
4.9
4.9
5.4
5.4
5.8
5.8
6.1
6.1
6.7
6.7
7.0
7.0
7.5
7.5
7.8
7.8
2.6
2.6
3.4
3.4
4.4
4.4
4.8
4.8
5.3
5.3
6.0
6.0
6.5
6.5
6.8
6.8
7.6
7.6
7.8
7.8
8.1
8.1
8.6

0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.021
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051

mm

1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.5
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3

TOTAL
MATL
COILS
4.88
4.88
4.75
4.75
4.75
4.75
4.75
4.75
4.13
4.13
4.38
4.38
4.88
4.88
4.88
4.88
5.00
5.00
5.13
5.13
5.25
5.25
4.88
4.88
5.38
5.38
5.25
5.25
5.38
5.38
5.38
5.38
6.75
4.38
4.38
4.88
4.88
5.38
5.38
5.38
5.38
5.50
5.50
5.63
5.63
5.75
5.75
5.75
5.75
5.88
5.88
5.88
5.88
6.00
6.00
6.00
6.00
4.63
4.63
5.13
5.13
5.75
5.75
5.88
5.88
6.00
6.00
6.25
6.25
6.38
6.38
6.38
6.38
6.63
6.63
6.50
6.50
6.50
6.50
6.63

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

69

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 70

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300

7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62

71008S
B4-34
70783
70783S
70806
70806S
70829
70829S
70851
70851S
70872
70872S
70891
70891S
70910
70910S
70929
70929S
70948
70948S
70967
70967S
70988
70988S
71009
71009S
70784
70784S
70807
70807S
70823
70823S
70830
70830S
70852
70852S
70873
70873S
70892
70892S
70911
70911S
70930
70930S
70949
70949S
70968
70968S
70989
70989S
71010
71010S
70785
70785S
70808
70808S
70831
70831S
70853
70853S
70874
70874S
70893
70893S
70912
70912S
70931
70931S
70950
70950S
70969
70969S
70990
70990S
71011
71011S
70786
70786S
70809
70809S

.56
.56
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.81
.81
.81
.81

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

14.2
14.3
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6

MATERIAL: MW - Music Wire

70

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.198
.224
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.242
.242
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248

RATE
mm

5.0
5.7
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

116
37
5.0
4.3
9.0
7.6
14
12
18
15
26
22
35
30
43
37
52
44
68
58
86
73
102
87
121
103
4.6
3.9
7.9
6.7
9.0
7.7
13
11
16
14
23
19
30
26
38
32
46
39
62
52
77
65
90
77
107
91
4.1
3.4
7.5
6.3
11
9.7
15
13
21
18
28
24
34
29
42
36
55
47
69
59
82
70
97
82
3.7
3.1
6.9
5.8

20
6.5
.88
.74
1.6
1.3
2.4
2.1
3.2
2.7
4.5
3.8
6.1
5.2
7.5
6.4
9.1
7.7
12
10
15
13
18
15
21
18
.81
.68
1.4
1.2
1.6
1.3
2.2
1.9
2.8
2.4
4.0
3.4
5.3
4.5
6.7
5.7
8.0
6.8
11
9.2
13
11
16
13
19
16
.71
.60
1.3
1.1
2.0
1.7
2.6
2.2
3.6
3.1
4.9
4.2
6.0
5.1
7.3
6.2
9.6
8.2
12
10
14
12
17
14
.64
.54
1.2
1.0

.12
.26
.43
.33
.37
.29
.36
.28
.34
.26
.29
.23
.27
.22
.26
.21
.25
.20
.23
.18
.21
.16
.20
.16
.17
.14
.46
.36
.42
.33
.47
.40
.40
.32
.38
.30
.33
.26
.32
.25
.29
.23
.28
.22
.25
.20
.23
.18
.22
.18
.20
.16
.53
.41
.44
.35
.44
.35
.41
.32
.36
.29
.34
.27
.32
.26
.31
.24
.28
.23
.26
.20
.24
.19
.22
.17
.58
.46
.48
.38

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

3.1
6.6
11
8.5
9.4
7.4
9.2
7.2
8.5
6.7
7.5
6.0
7.0
5.5
6.6
5.2
6.3
5.0
5.8
4.6
5.2
4.2
5.0
4.0
4.4
3.5
12
9.2
11
8.4
12
10
10
8.1
9.6
7.5
8.4
6.7
8.1
6.4
7.4
5.9
7.2
5.7
6.5
5.2
5.9
4.7
5.6
4.5
5.0
4.0
13
10
11
8.9
11
8.8
10
8.1
9.2
7.3
8.7
6.9
8.2
6.5
7.8
6.2
7.2
5.8
6.5
5.2
6.2
4.9
5.5
4.4
15
12
12
9.6

Lbs.

14
9.6
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
4.2
3.1
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2

ENDS: C - Closed

G - Ground
O - Open

63
43
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
19
14
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8

Inches

.34
.25
.11
.11
.15
.15
.19
.19
.20
.20
.23
.23
.26
.26
.28
.28
.29
.29
.33
.33
.33
.33
.35
.35
.37
.37
.12
.12
.16
.16
.22
.22
.20
.20
.22
.22
.25
.25
.29
.29
.30
.30
.33
.33
.35
.35
.36
.36
.38
.38
.40
.40
.13
.13
.16
.16
.21
.21
.23
.23
.27
.27
.30
.30
.33
.33
.35
.35
.38
.38
.39
.39
.41
.41
.43
.43
.14
.14
.17
.17

mm

8.6
6.3
2.9
2.9
3.7
3.7
4.8
4.8
5.2
5.2
5.8
5.8
6.5
6.5
7.0
7.0
7.5
7.5
8.3
8.3
8.4
8.4
8.9
8.9
9.4
9.4
3.0
3.0
4.0
4.0
5.6
5.6
5.1
5.1
5.6
5.6
6.3
6.3
7.2
7.2
7.6
7.6
8.3
8.3
8.9
8.9
9.1
9.1
9.6
9.6
10.2
10.2
3.3
3.3
4.1
4.1
5.4
5.4
5.9
5.9
6.8
6.8
7.7
7.7
8.3
8.3
8.8
8.8
9.7
9.7
9.8
9.8
10.4
10.4
11.0
11.0
3.5
3.5
4.4
4.4

WIRE DIA.
Inches

mm

0.051
0.038
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.029
0.029
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026

1.3
1.0
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7

FINISH: Z - Zinc

TOTAL
MATL
COILS
6.63
6.50
5.13
5.13
5.63
5.63
6.25
6.25
6.38
6.38
6.50
6.50
6.75
6.75
6.88
6.88
7.00
7.00
7.25
7.25
7.00
7.00
7.13
7.13
7.25
7.25
5.38
5.38
6.00
6.00
7.63
7.63
6.75
6.75
6.88
6.88
7.13
7.13
7.50
7.50
7.50
7.50
7.75
7.75
7.75
7.75
7.63
7.63
7.75
7.75
7.88
7.88
5.88
5.88
6.25
6.25
7.13
7.13
7.25
7.25
7.63
7.63
8.00
8.00
8.13
8.13
8.25
8.25
8.50
8.50
8.25
8.25
8.38
8.38
8.50
8.50
6.25
6.25
6.63
6.63

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
GI
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 71

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300

7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62

70832
70832S
70854
70854S
70875
70875S
70894
70894S
70913
70913S
70932
70932S
70951
70951S
70970
70970S
70991
70991S
71012
71012S
70787
70787S
70810
70810S
70833
70833S
70855
70855S
70876
70876S
70895
70895S
70914
70914S
70933
70933S
70952
70952S
70971
70971S
70992
70992S
71013
71013S
70789
70789S
70811
70811S
70834
70834S
70856
70856S
70877
70877S
70896
70896S
70915
70915S
70934
70934S
70953
70953S
70972
70972S
70993
70993S
71014
71014S
70790
70790S
70812
70812S
70835
70835S
70857
70857S
70878
70878S
70897
70897S

.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4

I.D.
Inches

.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

10
8.9
14
12
19
16
26
22
32
27
38
32
51
43
63
54
75
64
89
75
3.3
2.8
6.1
5.1
9.7
8.2
12
10
18
15
23
20
29
25
34
29
46
39
58
49
68
58
81
69
3.3
2.8
5.5
4.7
9.0
7.6
11
9.5
16
14
22
19
27
23
32
27
42
36
54
46
64
54
75
64
3.0
2.6
5.1
4.3
8.4
7.1
10
8.8
15
13
21
18

1.8
1.6
2.4
2.0
3.3
2.8
4.5
3.9
5.5
4.7
6.6
5.6
9.0
7.6
11
9.4
13
11
16
13
.58
.49
1.1
.90
1.7
1.4
2.2
1.8
3.1
2.6
4.0
3.4
5.1
4.3
5.9
5.0
8.1
6.9
10
8.6
12
10
14
12
.58
.49
.96
.82
1.6
1.3
2.0
1.7
2.8
2.4
3.8
3.3
4.8
4.0
5.6
4.8
7.4
6.3
9.4
8.0
11
9.5
13
11
.53
.45
.88
.75
1.5
1.2
1.8
1.5
2.7
2.3
3.6
3.1

.48
.38
.45
.35
.40
.31
.37
.29
.35
.28
.34
.27
.31
.24
.28
.22
.27
.21
.24
.19
.65
.51
.55
.43
.52
.41
.49
.39
.43
.34
.41
.33
.38
.30
.38
.30
.34
.27
.31
.24
.29
.23
.26
.21
.65
.51
.60
.47
.56
.44
.55
.43
.46
.37
.44
.35
.41
.33
.40
.32
.37
.30
.33
.26
.32
.25
.28
.22
.71
.56
.65
.51
.60
.47
.59
.47
.50
.40
.46
.37

mm

12
9.6
11
9.0
10
8.0
9.4
7.5
9.0
7.1
8.6
6.9
7.8
6.2
7.1
5.7
6.8
5.4
6.0
4.8
16
13
14
11
13
10
13
9.9
11
8.7
11
8.4
9.7
7.7
9.6
7.7
8.6
6.9
7.8
6.2
7.4
5.9
6.6
5.3
16
13
15
12
14
11
14
11
12
9.4
11
8.8
10
8.3
10
8.1
9.4
7.5
8.4
6.7
8.0
6.4
7.1
5.7
18
14
17
13
15
12
15
12
13
10
12
9.3

ENDS: C - Closed

G - Ground
O - Open

Lbs.

5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5

22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29

Inches

.23
.23
.25
.25
.28
.28
.32
.32
.35
.35
.37
.37
.41
.41
.42
.42
.44
.44
.47
.47
.15
.15
.19
.19
.24
.24
.27
.27
.30
.30
.35
.35
.37
.37
.40
.40
.44
.44
.45
.45
.47
.47
.50
.50
.15
.15
.20
.20
.26
.26
.29
.29
.32
.32
.37
.37
.39
.39
.43
.43
.47
.47
.47
.47
.50
.50
.53
.53
.16
.16
.22
.22
.27
.27
.31
.31
.34
.34
.38
.38

mm

Inches

5.8
5.8
6.3
6.3
7.2
7.2
8.1
8.1
8.8
8.8
9.5
9.5
10.3
10.3
10.6
10.6
11.2
11.2
11.8
11.8
3.8
3.8
4.8
4.8
6.2
6.2
6.8
6.8
7.7
7.7
8.9
8.9
9.3
9.3
10.3
10.3
11.1
11.1
11.3
11.3
12.0
12.0
12.6
12.6
3.8
3.8
5.1
5.1
6.6
6.6
7.3
7.3
8.1
8.1
9.3
9.3
9.9
9.9
10.8
10.8
11.9
11.9
11.9
11.9
12.8
12.8
13.4
13.4
4.1
4.1
5.5
5.5
7.0
7.0
7.8
7.8
8.6
8.6
9.7
9.7

0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038

mm

TOTAL
MATL
COILS

0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0

7.63
7.63
7.75
7.75
8.13
8.13
8.38
8.38
8.63
8.63
8.88
8.88
9.00
9.00
8.88
8.88
9.00
9.00
9.13
9.13
6.75
6.75
7.25
7.25
8.13
8.13
8.38
8.38
8.63
8.63
9.25
9.25
9.13
9.13
9.63
9.63
9.75
9.75
9.50
9.50
9.63
9.63
9.75
9.75
6.75
6.75
7.75
7.75
8.63
8.63
9.00
9.00
9.13
9.13
9.63
9.63
9.75
9.75
10.1
10.1
10.4
10.4
10.0
10.0
10.3
10.3
10.4
10.4
7.25
7.25
8.38
8.38
9.13
9.13
9.63
9.63
9.63
9.63
10.0
10.0

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

71

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 72

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300

7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62

70916
70916S
70935
70935S
70954
70954S
70973
70973S
70994
70994S
71015
71015S
70792
70792S
70814
70814S
70837
70837S
70859
70859S
70879
70879S
70898
70898S
70917
70917S
70936
70936S
70955
70955S
70974
70974S
70995
70995S
71016
71016S
70793
70793S
70815
70815S
70838
70838S
70860
70860S
70880
70880S
70899
70899S
70918
70918S
70937
70937S
70956
70956S
70975
70975S
70996
70996S
71017
71017S
70795
70795S
70817
70817S
70840
70840S
70862
70862S
70881
70881S
70900
70900S
70919
70919S
70938
70938S
70957
70957S
70976
70976S

1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1

MATERIAL: MW - Music Wire

72

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206

RATE
mm

5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

25
22
30
26
40
34
50
43
59
50
70
60
2.7
2.3
4.6
3.9
7.6
6.5
9.5
8.1
13
11
19
16
22
19
28
23
36
31
44
38
52
44
62
52
2.4
2.0
4.3
3.7
6.6
5.6
8.6
7.3
12
10
16
14
20
17
24
20
32
27
39
36
46
39
55
47
2.2
1.9
3.8
3.2
6.1
5.2
7.7
6.5
11
9.2
15
13
18
15
22
19
29
25
35
30

4.4
3.8
5.3
4.5
7.0
6.0
8.8
7.5
10
8.8
12
10
.47
.40
.81
.68
1.3
1.1
1.7
1.4
2.4
2.0
3.3
2.8
3.9
3.3
4.8
4.1
6.3
5.4
7.7
6.6
9.2
7.8
11
9.2
.42
.36
.75
.64
1.2
.98
1.5
1.3
2.1
1.8
2.9
2.4
3.4
2.9
4.2
3.6
5.6
4.8
6.9
5.9
8.1
6.9
9.6
8.2
.39
.33
.67
.57
1.1
.91
1.3
1.1
1.9
1.6
2.6
2.2
3.1
2.6
3.8
3.3
5.1
4.3
6.2
5.3

.44
.35
.43
.34
.39
.31
.35
.28
.34
.27
.30
.24
.79
.62
.72
.57
.66
.52
.64
.50
.56
.45
.51
.41
.50
.40
.47
.37
.43
.35
.40
.32
.38
.30
.34
.27
.89
.70
.77
.60
.76
.60
.71
.56
.63
.50
.59
.47
.57
.45
.53
.42
.49
.39
.45
.36
.43
.34
.38
.31
.97
.76
.87
.68
.83
.65
.79
.62
.70
.56
.64
.51
.63
.50
.59
.47
.54
.43
.50
.40

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

11
8.9
11
8.6
9.9
7.9
9.0
7.2
8.6
6.8
7.6
6.1
20
16
18
14
17
13
16
13
14
11
13
10
13
10
12
9.4
11
8.8
10
8.1
9.7
7.7
8.7
6.9
23
18
19
15
19
15
18
14
16
13
15
12
14
11
14
11
12
9.9
11
9.1
11
8.7
9.8
7.8
25
19
22
17
21
17
20
16
18
14
16
13
16
13
15
12
14
11
13
10

Lbs.

11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12

ENDS: C - Closed

G - Ground
O - Open

50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53

Inches

.41
.41
.45
.45
.49
.49
.50
.50
.53
.53
.56
.56
.17
.17
.23
.23
.29
.29
.33
.33
.37
.37
.41
.41
.46
.46
.48
.48
.53
.53
.55
.55
.59
.59
.62
.62
.19
.19
.24
.24
.33
.33
.36
.36
.41
.41
.47
.47
.51
.51
.54
.54
.59
.59
.61
.61
.65
.65
.69
.69
.20
.20
.27
.27
.35
.35
.39
.39
.45
.45
.50
.50
.56
.56
.58
.58
.64
.64
.67
.67

mm

10.4
10.4
11.3
11.3
12.4
12.4
12.7
12.7
13.5
13.5
14.2
14.2
4.3
4.3
5.9
5.9
7.4
7.4
8.3
8.3
9.4
9.4
10.5
10.5
11.6
11.6
12.3
12.3
13.6
13.6
14.0
14.0
14.9
14.9
15.9
15.9
4.7
4.7
6.2
6.2
8.4
8.4
9.0
9.0
10.4
10.4
11.8
11.8
12.8
12.8
13.7
13.7
14.9
14.9
15.5
15.5
16.5
16.5
17.5
17.5
5.1
5.1
6.9
6.9
9.0
9.0
9.9
9.9
11.3
11.3
12.7
12.7
14.1
14.1
14.8
14.8
16.3
16.3
17.0
17.0

WIRE DIA.
Inches

0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047

mm

TOTAL
MATL
COILS

1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2

10.3
10.3
10.6
10.6
10.9
10.9
10.6
10.6
10.9
10.9
11.0
11.0
7.75
7.75
9.00
9.00
9.75
9.75
10.3
10.3
10.6
10.6
10.9
10.9
11.4
11.4
11.5
11.5
11.9
11.9
11.8
11.8
12.0
12.0
12.3
12.3
8.50
8.50
9.38
9.38
11.0
11.0
11.1
11.1
11.8
11.8
12.3
12.3
12.6
12.6
12.9
12.9
13.0
13.0
13.0
13.0
13.3
13.3
13.5
13.5
9.13
9.13
10.4
10.4
11.8
11.8
12.1
12.1
12.8
12.8
13.1
13.1
13.9
13.9
13.9
13.9
14.3
14.3
14.3
14.3

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 73

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300

7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62

70997
70997S
71018
71018S
70796
70796S
70818
70818S
70841
70841S
70863
70863S
70882
70882S
70901
70901S
70920
70920S
70939
70939S
70958
70958S
12758
70977
70977S
70998
70998S
71019
71019S
70797
70797S
70819
70819S
70842
70842S
70864
70864S
70883
70883S
70902
70902S
70921
70921S
70940
70940S
70959
70959S
70978
70978S
70999
70999S
71020
71020S
70798
70798S
70820
70820S
70843
70843S
70865
70865S
70884
70884S
70903
70903S
70922
70922S
70941
70941S
70960
70960S
70979
70979S
71000
71000S
71021
71021S
70799
70799S
70821

1.38
1.38
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

35.1
35.1
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2

I.D.
Inches

.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

42
35
49
42
2.1
1.7
3.5
3.0
5.5
4.6
7.1
6.0
9.9
8.4
14
12
16
14
20
17
26
22
27
32
27
38
32
45
38
1.7
1.5
3.0
2.6
4.7
4.0
6.0
5.1
8.4
7.1
11
9.5
14
12
16
14
22
18
28
23
32
28
38
32
1.5
1.2
2.6
2.2
4.0
3.4
5.3
4.5
7.3
6.2
9.6
8.2
12
10
14
12
19
16
24
20
28
24
33
28
1.3
1.1
2.4

7.3
6.2
8.6
7.3
.36
.31
.61
.52
.95
.81
1.2
1.0
1.7
1.5
2.4
2.0
2.8
2.4
3.5
3.0
4.6
3.9
4.8
5.7
4.8
6.7
5.7
7.9
6.7
.30
.26
.53
.45
.81
.69
1.1
.89
1.5
1.3
2.0
1.7
2.4
2.1
2.9
2.4
3.8
3.2
4.8
4.1
5.7
4.8
6.7
5.7
.25
.22
.46
.39
.70
.60
.93
.79
1.3
1.1
1.7
1.4
2.1
1.8
2.5
2.1
3.3
2.8
4.2
3.6
4.9
4.2
5.8
4.9
.23
.19
.42

.48
.38
.43
.34
1.0
.81
.94
.74
.92
.73
.86
.68
.76
.61
.70
.56
.70
.55
.65
.51
.60
.48
.44
.55
.44
.53
.42
.47
.37
1.2
.97
1.1
.87
1.1
.85
1.0
.80
.90
.71
.85
.68
.81
.64
.78
.62
.72
.57
.65
.51
.62
.49
.55
.44
1.5
1.2
1.3
1.0
1.3
.99
1.1
.90
1.0
.82
1.0
.79
.94
.74
.89
.71
.83
.66
.74
.59
.71
.57
.64
.51
1.6
1.3
1.4

mm

12
9.7
11
8.6
26
21
24
19
23
18
22
17
19
15
18
14
18
14
16
13
15
12
11
14
11
13
11
12
9.5
31
25
28
22
27
22
26
20
23
18
22
17
20
16
20
16
18
15
16
13
16
13
14
11
37
29
32
25
32
25
29
23
26
21
25
20
24
19
23
18
21
17
19
15
18
14
16
13
41
32
35

ENDS: C - Closed

G - Ground
O - Open

Lbs.

20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
12
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3
2.2
5.0
3.4
6.1
4.1
7.5
5.1
9.6
6.5
11
7.5
13
8.7
16
11
18
12
20
14
21
14
2.1
1.4
3.3

89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
53
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15
9.8
22
15
27
18
34
23
43
29
50
33
57
39
70
47
79
53
89
60
94
63
9.5
6.3
15

Inches

.72
.72
.75
.75
.21
.21
.29
.29
.39
.39
.42
.42
.48
.48
.54
.54
.61
.61
.64
.64
.70
.70
.74
.72
.72
.77
.77
.82
.82
.24
.24
.33
.33
.44
.44
.48
.48
.55
.55
.64
.64
.69
.69
.75
.75
.83
.83
.83
.83
.89
.89
.94
.94
.28
.28
.37
.37
.50
.50
.54
.54
.63
.63
.74
.74
.79
.79
.85
.85
.94
.94
.95
.95
1.01
1.01
1.07
1.07
.31
.31
.40

mm

Inches

18.2
18.2
19.1
19.1
5.4
5.4
7.3
7.3
9.8
9.8
10.7
10.7
12.2
12.2
13.6
13.6
15.4
15.4
16.1
16.1
17.7
17.7
18.8
18.4
18.4
19.6
19.6
20.7
20.7
6.2
6.2
8.3
8.3
11.2
11.2
12.2
12.2
14.0
14.0
16.3
16.3
17.4
17.4
19.1
19.1
21.0
21.0
21.2
21.2
22.6
22.6
24.0
24.0
7.1
7.1
9.4
9.4
12.8
12.8
13.6
13.6
15.9
15.9
18.7
18.7
19.9
19.9
21.5
21.5
23.9
23.9
24.0
24.0
25.7
25.7
27.2
27.2
7.8
7.8
10.1

0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026

mm

TOTAL
MATL
COILS

1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7

14.6
14.6
14.8
14.8
9.63
9.63
11.1
11.1
12.9
12.9
13.1
13.1
13.8
13.8
14.1
14.1
15.1
15.1
15.1
15.1
15.5
15.5
15.8
15.4
15.4
15.8
15.8
16.0
16.0
11.1
11.1
12.6
12.6
14.8
14.8
15.0
15.0
15.8
15.8
16.9
16.9
17.1
17.1
17.9
17.9
18.4
18.4
17.8
17.8
18.1
18.1
18.5
18.5
12.8
12.8
14.3
14.3
16.8
16.8
16.8
16.8
17.9
17.9
19.4
19.4
19.6
19.6
20.1
20.1
20.9
20.9
20.1
20.1
20.6
20.6
21.0
21.0
14.0
14.0
15.3

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

73

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 74

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.300
0.304
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312

7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.62
7.72
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92

70821S
70844
70844S
70866
70866S
70885
70885S
70904
70904S
70923
70923S
70942
70942S
70961
70961S
70980
70980S
71001
71001S
71022
71022S
70800
70800S
70822
70822S
70845
70845S
70867
70867S
70886
70886S
70905
70905S
70924
70924S
70943
70943S
70962
70962S
70981
70981S
71002
71002S
71023
71023S
70982
70982S
71003
71003S
71024
71024S
12640
70983
70983S
71004
71004S
71025
71025S
A9-39
II-25
KK-86
NN-86
A15-5
EE-4
S-1267
A-81
12482
GG-15
Y-74
B15-32
CC-58
II-11
PP-41
10274
EE-48
11356
OO-35
O-87
Z-78
2915

2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.75
2.75
2.88
3.00
3.00
3.00
3.00
3.00
3.00
.78
.19
.22
.25
.25
.25
.31
.31
.31
.31
.34
.34
.38
.38
.38
.38
.38
.38
.38
.38
.38
.38

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
69.9
69.9
73.0
76.2
76.2
76.2
76.2
76.2
76.2
19.8
4.8
5.6
6.4
6.4
6.4
7.9
7.9
7.9
7.9
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5
9.5

MATERIAL: MW - Music Wire

74

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.256
.256
.248
.248
.240
.240
.236
.236
.230
.230
.224
.224
.220
.220
.216
.216
.210
.210
.206
.206
.202
.202
.198
.198
.206
.206
.202
.202
.198
.198
.260
.206
.206
.202
.202
.198
.198
.190
.252
.260
.258
.252
.232
.288
.262
.248
.202
.234
.184
.292
.272
.272
.268
.266
.266
.264
.256
.242
.228

RATE
mm

6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
6.5
6.5
6.3
6.3
6.1
6.1
6.0
6.0
5.8
5.8
5.7
5.7
5.6
5.6
5.5
5.5
5.3
5.3
5.2
5.2
5.1
5.1
5.0
5.0
5.2
5.2
5.1
5.1
5.0
5.0
6.6
5.2
5.2
5.1
5.1
5.0
5.0
4.8
6.4
6.6
6.6
6.4
5.9
7.3
6.7
6.3
5.1
5.9
4.7
7.4
6.9
6.9
6.8
6.8
6.8
6.7
6.5
6.1
5.8

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

2.0
.36
3.6
.63
3.0
.53
4.8
.84
4.1
.71
6.5
1.1
5.5
.96
8.8
1.5
7.5
1.3
11
1.8
9.0
1.6
13
2.2
11
1.9
17
2.9
14
2.5
21
3.7
18
3.1
25
4.3
21
3.7
29
5.1
25
4.4
1.2
.21
1.0
.18
2.1
.37
1.8
.32
3.2
.57
2.8
.48
4.3
.74
3.6
.63
5.9
1.0
5.0
.87
8.0
1.4
6.8
1.2
9.5
1.7
8.1
1.4
12
2.0
9.9
1.7
15
2.7
13
2.3
19
3.3
16
2.8
22
3.9
19
3.3
26
4.6
22
3.9
17
3.0
15
2.5
20
3.5
17
3.0
24
4.2
20
3.5
.33
.06
16
2.7
13
2.3
18
3.2
16
2.7
22
3.8
18
3.2
93
16
45
7.9
17
2.9
17
2.9
16
2.7
80
14
.26
.04
12
2.1
46
8.0
344
60
47
8.3
632 111
.23
.04
1.5
.27
2.1
.37
6.9
1.2
2.8
.49
3.3
.58
5.8
1.0
13
2.3
51
8.9
76
13

1.1
1.4
1.1
1.3
1.0
1.2
.93
1.1
.87
1.1
.84
1.0
.80
.93
.74
.84
.67
.81
.64
.72
.57
1.8
1.4
1.5
1.2
1.6
1.2
1.4
1.1
1.3
1.0
1.2
.96
1.2
.93
1.1
.87
1.0
.81
.94
.75
.90
.72
.80
.64
1.0
.83
.99
.79
.88
.71
2.3
1.1
.90
1.1
.87
.97
.77
.22
.07
.10
.12
.10
.09
.23
.19
.09
.05
.14
.04
.33
.20
.24
.29
.17
.23
.23
.24
.10
.12

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

27
36
28
32
25
30
24
28
22
27
21
25
20
24
19
21
17
21
16
18
15
46
36
39
31
39
31
36
29
33
26
31
24
30
24
28
22
26
21
24
19
23
18
20
16
26
21
25
20
22
18
57
29
23
28
22
25
20
5.6
1.7
2.6
2.9
2.5
2.3
5.9
4.7
2.3
1.3
3.6
1.1
8.3
5.0
6.0
7.3
4.3
5.7
5.9
6.0
2.6
3.0

Lbs.

2.2
9.8
5.0
22
3.4
15
6.1
27
4.1
18
7.5
34
5.1
23
9.6
43
6.5
29
11
50
7.5
33
13
57
8.7
39
16
70
11
47
18
79
12
53
20
89
14
60
21
94
14
63
2.1
9.5
1.4
6.3
3.3
15
2.2
9.8
5.0
22
3.4
15
6.1
27
4.1
18
7.5
34
5.1
23
9.6
43
6.5
29
11
50
7.5
33
13
57
8.7
39
16
70
11
47
18
79
12
53
20
89
14
60
21
94
14
63
18
79
12
53
20
89
14
60
21
94
14
63
.73
3.3
18
79
12
53
20
89
14
60
21
94
14
63
21
92
3.1
14
1.7
7.5
1.9
8.4
1.6
7.0
7.2
32
.06
.26
2.2
9.9
4.2
19
17
76
6.7
30
28
124
.07
.33
.30
1.3
.50
2.2
2.0
8.8
.47
2.1
.74
3.3
1.3
5.9
3.0
13
5.2
23
8.9
40

ENDS: C - Closed

G - Ground
O - Open

Inches

.40
.56
.56
.59
.59
.70
.70
.80
.80
.88
.88
.94
.94
1.04
1.04
1.06
1.06
1.13
1.13
1.20
1.20
.34
.34
.44
.44
.61
.61
.65
.65
.77
.77
.87
.87
.96
.96
1.02
1.02
1.13
1.13
1.17
1.17
1.25
1.25
1.33
1.33
1.29
1.29
1.37
1.37
1.45
1.45
.62
1.39
1.39
1.49
1.49
1.58
1.58
.46
.12
.12
.14
.15
.16
.08
.13
.14
.22
.20
.29
.05
.18
.14
.09
.21
.15
.14
.14
.14
.25

mm

10.1
14.2
14.2
14.9
14.9
17.8
17.8
20.3
20.3
22.2
22.2
23.9
23.9
26.4
26.4
26.9
26.9
28.8
28.8
30.4
30.4
8.5
8.5
11.1
11.1
15.4
15.4
16.6
16.6
19.4
19.4
22.2
22.2
24.4
24.4
25.9
25.9
28.6
28.6
29.7
29.7
31.7
31.7
33.7
33.7
32.7
32.7
34.8
34.8
36.9
36.9
15.7
35.4
35.4
38.0
38.0
40.2
40.2
11.8
3.0
3.0
3.4
3.8
4.1
2.1
3.2
3.7
5.6
5.0
7.3
1.3
4.6
3.6
2.2
5.3
3.8
3.7
3.6
3.6
6.4

WIRE DIA.
Inches

0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.022
0.022
0.026
0.026
0.030
0.030
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.047
0.047
0.049
0.049
0.051
0.051
0.020
0.047
0.047
0.049
0.049
0.051
0.051
0.057
0.030
0.026
0.027
0.030
0.040
0.012
0.025
0.032
0.055
0.039
0.064
0.010
0.020
0.020
0.022
0.023
0.023
0.024
0.028
0.035
0.042

mm

TOTAL
MATL
COILS

0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.2
1.2
1.2
1.2
1.3
1.3
0.5
1.2
1.2
1.2
1.2
1.3
1.3
1.4
0.8
0.7
0.7
0.8
1.0
0.3
0.6
0.8
1.4
1.0
1.6
0.3
0.5
0.5
0.6
0.6
0.6
0.6
0.7
0.9
1.1

15.3
18.6
18.6
18.4
18.4
20.0
20.0
21.0
21.0
21.9
21.9
22.4
22.4
23.1
23.1
22.5
22.5
23.1
23.1
23.5
23.5
15.3
15.3
16.9
16.9
20.3
20.3
20.4
20.4
21.9
21.9
23.0
23.0
24.0
24.0
24.3
24.3
25.0
25.0
24.9
24.9
25.5
25.5
26.0
26.0
27.4
27.4
28.0
28.0
28.5
28.5
30.0
29.6
29.6
30.5
30.5
31.0
31.0
8.00
3.00
3.50
4.00
5.00
4.00
5.75
4.00
3.50
4.00
5.00
4.50
4.00
8.00
6.00
4.00
8.00
6.50
5.00
5.00
4.00
5.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
PB
SST
SST
MW
SST
SST
SST
MW
SPR
SST
SST
SPR
SST
MW
SST
MW
MW
SST
SST
MW
SPR
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
C
C
C
CG
CG
CG
C
C
C
CG
C
CG
C
CG
CG
C

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
Z
Z
N
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 75

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312

7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92

EE-9
S-1086
K-93
S-1125
3688
JJ-22
FF-3
KK-92
A11-23
A14-25
LL-16
S-484
B9-30
H-96
II-23
2920
NN-6
J-27
A10-36
DD-85
J-52
10487
4231
4199
H-69
B14-5
S-727
B2-28
PP-31
10229
931
L-8
10856
DD-34
S-1265
HH-29
CC-11
MM-65
S-27
S-1016
A-24
2850
YY-41
10931
3853
K-76
B7-13
MM-15
H-66
LL-73
10509
A11-67
S-388
530
PP-97
QQ-67
Y-20
PP-53
FF-85
WW-32
A14-22
S-1065
S-1226
2846
PP-67
I-42
2700
A15-41
XX-25
4245
HH-73
BB-2
KK-22
B7-2
W-70
B9-38
L-39
O-48
Z-32
3516

.38
.38
.38
.38
.41
.41
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

9.5
9.5
9.5
9.5
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4

I.D.
Inches

.226
.218
.218
.214
.272
.244
.280
.252
.246
.236
.232
.230
.230
.212
.212
.180
.272
.252
.250
.242
.238
.284
.282
.276
.272
.270
.268
.266
.256
.248
.238
.236
.230
.192
.238
.232
.232
.212
.210
.282
.278
.272
.272
.268
.264
.262
.262
.252
.204
.192
.220
.266
.262
.260
.258
.256
.246
.244
.236
.236
.230
.204
.188
.272
.272
.238
.230
.230
.256
.254
.242
.232
.232
.226
.220
.220
.216
.212
.188
.184

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.7
5.5
5.5
5.4
6.9
6.2
7.1
6.4
6.2
6.0
5.9
5.8
5.8
5.4
5.4
4.6
6.9
6.4
6.4
6.1
6.0
7.2
7.2
7.0
6.9
6.9
6.8
6.8
6.5
6.3
6.0
6.0
5.8
4.9
6.0
5.9
5.9
5.4
5.3
7.2
7.1
6.9
6.9
6.8
6.7
6.7
6.7
6.4
5.2
4.9
5.6
6.8
6.7
6.6
6.6
6.5
6.2
6.2
6.0
6.0
5.8
5.2
4.8
6.9
6.9
6.0
5.8
5.8
6.5
6.5
6.1
5.9
5.9
5.7
5.6
5.6
5.5
5.4
4.8
4.7

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

101
18
131
23
94
17
158
28
2.3
.40
26
4.6
.91
.16
11
2.0
26
4.6
39
6.8
41
7.1
43
7.5
82
14
167
29
136
24
697 122
2.0
.36
11
2.0
18
3.1
29
5.2
43
7.6
1.0
.18
.51
.09
1.2
.21
1.4
.24
2.3
.40
4.8
.84
7.4
1.3
13
2.3
17
3.0
37
6.5
42
7.4
51
8.9
291
51
28
4.9
36
6.3
52
9.1
148
26
121
21
.44
.08
.49
.09
4.6
.81
.73
.13
3.9
.69
6.7
1.2
5.9
1.0
9.5
1.7
12
2.0
237
42
258
45
76
13
4.4
.78
5.3
.93
7.0
1.2
9.6
1.7
11
1.9
26
4.6
30
5.2
27
4.7
32
5.5
41
7.1
124
22
278
49
2.3
.40
2.3
.40
16
2.9
45
7.9
48
8.5
7.7
1.4
7.5
1.3
18
3.2
23
4.1
41
7.1
53
9.3
54
9.5
53
9.2
64
11
67
12
197
35
243
43

.09
.09
.09
.08
.27
.18
.33
.23
.18
.16
.18
.18
.10
.08
.10
.04
.33
.26
.20
.17
.14
.43
.37
.36
.32
.35
.28
.32
.31
.25
.23
.15
.16
.08
.21
.20
.15
.09
.11
.43
.37
.34
.28
.42
.40
.39
.30
.37
.07
.08
.15
.47
.36
.44
.25
.36
.18
.17
.23
.20
.20
.13
.09
.52
.52
.32
.18
.16
.46
.43
.28
.31
.19
.18
.20
.22
.21
.19
.12
.11

mm

2.4
2.2
2.4
2.1
6.8
4.5
8.3
5.8
4.5
4.1
4.6
4.6
2.6
2.1
2.4
1.1
8.3
6.6
5.1
4.2
3.6
11
9.5
9.0
8.1
9.0
7.2
8.0
7.8
6.2
5.9
3.8
4.1
2.0
5.2
5.1
3.8
2.2
2.9
11
9.3
8.5
7.2
11
10
9.8
7.6
9.3
1.8
2.2
3.9
12
9.0
11
6.3
9.1
4.5
4.3
6.0
5.0
5.2
3.3
2.2
13
13
8.2
4.7
4.1
12
11
7.2
8.0
4.8
4.6
5.1
5.6
5.2
4.9
3.1
2.9

ENDS: C - Closed

G - Ground
O - Open

Lbs.

9.6
12
8.8
13
.61
4.7
.30
2.6
4.6
6.24
7.3
7.8
8.3
14
13
30
.67
2.9
3.6
4.9
6.2
.45
.19
.42
.44
.80
1.4
2.3
4.0
4.2
8.5
6.3
8.3
23
5.8
7.3
7.8
13
14
.19
.18
1.5
.21
1.7
2.7
2.3
2.8
4.2
17
22
12
2.1
1.9
3.1
2.4
4.0
4.6
5.0
6.3
6.3
8.3
16
24
1.2
1.2
5.3
8.3
7.8
3.6
3.2
5.2
7.3
7.8
9.6
11
12
13
13
24
28

43
52
39
58
2.7
21
1.3
11
21
27.72
32
35
37
62
58
136
3.0
13
16
22
27
2.0
.84
1.9
1.9
3.6
6.1
10
18
19
38
28
37
104
26
32
35
58
61
.85
.80
6.9
.92
7.4
12
10
13
19
77
98
52
9.3
8.4
14
11
18
21
22
28
28
37
72
107
5.3
5.3
24
37
35
16
14
23
32
35
43
49
52
59
58
107
124

Inches

.19
.21
.28
.22
.14
.20
.11
.21
.17
.12
.24
.25
.18
.25
.26
.31
.14
.21
.16
.21
.22
.07
.13
.14
.18
.15
.12
.12
.14
.22
.20
.23
.25
.36
.26
.26
.26
.25
.31
.13
.20
.10
.28
.14
.14
.18
.11
.20
.27
.36
.35
.16
.17
.18
.16
.18
.20
.20
.26
.23
.29
.38
.39
.14
.14
.33
.27
.24
.22
.26
.30
.36
.26
.29
.35
.39
.41
.43
.56
.54

mm

Inches

4.9
5.4
7.2
5.6
3.6
5.2
2.8
5.3
4.3
3.0
6.1
6.4
4.7
6.4
6.7
7.8
3.6
5.3
3.9
5.3
5.6
1.8
3.2
3.7
4.6
3.7
3.1
3.1
3.6
5.7
5.2
5.8
6.2
9.1
6.6
6.6
6.6
6.4
7.8
3.2
5.0
2.5
7.1
3.6
3.7
4.4
2.9
5.0
6.9
9.1
8.8
3.9
4.4
4.6
4.1
4.6
5.0
5.2
6.5
5.8
7.3
9.6
9.8
3.6
3.6
8.5
6.8
6.0
5.7
6.6
7.6
9.1
6.6
7.4
8.8
9.9
10.4
10.8
14.2
13.8

0.043
0.047
0.047
0.049
0.020
0.034
0.016
0.030
0.033
0.038
0.040
0.041
0.041
0.050
0.050
0.066
0.020
0.030
0.031
0.035
0.037
0.014
0.015
0.018
0.020
0.021
0.022
0.023
0.028
0.032
0.037
0.038
0.041
0.060
0.037
0.040
0.040
0.050
0.051
0.015
0.017
0.020
0.020
0.022
0.024
0.025
0.025
0.030
0.054
0.060
0.046
0.023
0.025
0.026
0.027
0.028
0.033
0.034
0.038
0.038
0.041
0.054
0.062
0.020
0.020
0.037
0.041
0.041
0.028
0.029
0.035
0.040
0.040
0.043
0.046
0.046
0.048
0.050
0.062
0.064

mm

TOTAL
MATL
COILS

1.1
1.2
1.2
1.2
0.5
0.9
0.4
0.8
0.8
1.0
1.0
1.0
1.0
1.3
1.3
1.7
0.5
0.8
0.8
0.9
0.9
0.4
0.4
0.5
0.5
0.5
0.6
0.6
0.7
0.8
0.9
1.0
1.0
1.5
0.9
1.0
1.0
1.3
1.3
0.4
0.4
0.5
0.5
0.6
0.6
0.6
0.6
0.8
1.4
1.5
1.2
0.6
0.6
0.7
0.7
0.7
0.8
0.9
1.0
1.0
1.0
1.4
1.6
0.5
0.5
0.9
1.0
1.0
0.7
0.7
0.9
1.0
1.0
1.1
1.2
1.2
1.2
1.3
1.6
1.6

4.50
4.50
6.00
4.50
6.00
5.00
6.00
6.00
5.00
5.25
6.00
6.13
4.50
5.00
5.25
4.63
6.00
6.00
5.00
5.00
5.00
4.00
7.50
7.00
8.00
7.00
4.50
4.25
5.00
6.00
5.50
5.00
6.00
6.00
6.00
6.50
5.50
5.00
6.00
7.50
10.5
4.00
13.0
5.50
5.00
6.00
4.50
6.50
5.00
6.00
6.50
5.75
5.88
6.00
5.00
5.50
5.00
5.00
6.75
6.00
7.00
7.00
6.25
6.00
6.00
9.00
6.50
5.75
7.00
8.00
7.50
9.00
6.50
6.75
7.50
8.50
8.50
8.50
8.00
8.50

SPR
SST
SPR
SST
MW
SST
MW
SST
SPR
SST
SST
SST
SPR
SPR
SST
SPR
SST
SST
SST
SST
SPR
MW
MW
MW
SST
MW
SST
MW
MW
SPR
MW
SST
SPR
SPR
SST
SST
SPR
SST
SST
SST
SST
MW
SST
MW
MW
MW
MW
MW
SPR
SST
SPR
MW
SST
MW
SST
MW
SPR
SPR
SST
SST
SPR
SST
SST
MW
MW
SST
HD
SST
MW
MW
SPR
SST
SPR
SPR
SST
SPR
SPR
SST
SST
SPR

E
N
D
S

CG
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
C
C
C
C
C
CG
C
C
CG
C
CG
C
CG
CG
C
CG
C
CG
CG
C
C
C
C
C
C
C
CG
CG
CG
CG
C
C
C
C
C
C
C
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG

F
N
S
H

Z
N
Z
N
Z
N
N
N
GI
N
N
N
N
Z
N
Z
N
N
N
N
N
N
N
Z
N
N
N
N
N
Z
Z
N
N
N
N
N
N
N
N
N
N
Z
N
Z
Z
Z
N
N
N
N
Z
N
N
Z
N
Z
N
Z
N
N
GI
N
N
Z
Z
N
Z
N
GI
Z
GI
N
Z
N
N
Z
Z
N
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

75

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 76

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312

7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92

10013
KK-74
4246
S-1072
S-23
10422
FF-25
B12-32
S-728
WW-44
2539
FF-93
II-29
Z-65
3245
3190
946
S-730
W-17
2978
S-146
S-934
2585
B1-5
B12-1
O-123
B17-125
O-32
S-204
FF-45
NN-30
S-877
BB-62
2617
CC-56
3678
V V-35
LL-52
S-476
MM-38
2614
2949
J-81
M-89
Q-43
EE-37
10544
S-729
II-17
S-731
W-71
S-244
3735
S-231
S-1587
N-138
H-63
U-12
B1-23
S-394
W-98
1651
GG-34
GG-62
CC-2
B17-126
202-A
W-93
10917
1789
II-15
N-123
S-732
K-94
10201
G-10
S-733
3736
3764
S-1580

.69
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.78
.78
.81
.81
.81
.81
.84
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.91
.91
.94
.94
.94
.94
.94
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

17.5
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
19.8
19.8
20.6
20.6
20.6
20.6
21.4
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.0
23.0
23.0
23.8
23.8
23.8
23.8
23.8
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2

MATERIAL: MW - Music Wire

76

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.236
.240
.282
.282
.278
.274
.272
.272
.268
.268
.266
.264
.264
.262
.258
.248
.248
.248
.246
.244
.242
.242
.238
.236
.228
.220
.216
.210
.272
.252
.252
.218
.214
.188
.244
.240
.240
.222
.244
.232
.208
.272
.272
.272
.272
.272
.270
.268
.252
.248
.188
.276
.230
.222
.222
.214
.278
.278
.260
.248
.238
.230
.204
.218
.284
.284
.280
.278
.272
.272
.272
.272
.248
.246
.242
.232
.228
.226
.188
.252

RATE
mm

6.0
6.1
7.2
7.2
7.1
7.0
6.9
6.9
6.8
6.8
6.8
6.7
6.7
6.7
6.6
6.3
6.3
6.3
6.2
6.2
6.1
6.1
6.0
6.0
5.8
5.6
5.5
5.3
6.9
6.4
6.4
5.5
5.4
4.8
6.2
6.1
6.1
5.6
6.2
5.9
5.3
6.9
6.9
6.9
6.9
6.9
6.9
6.8
6.4
6.3
4.8
7.0
5.8
5.6
5.6
5.4
7.1
7.1
6.6
6.3
6.0
5.8
5.2
5.5
7.2
7.2
7.1
7.1
6.9
6.9
6.9
6.9
6.3
6.2
6.1
5.9
5.8
5.7
4.8
6.4

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

24
15

4.3
2.7
.06
.04
.14
.15
.08
.27
.56
.60
.65
.34
.70
.69
1.2
1.7
2.3
2.0
2.3
1.7
2.2
2.5
3.5
3.6
6.1
10
12
24
.14
1.5
1.5
9.8
8.7
31
1.8
2.2
2.9
9.9
1.7
3.2
16
.32
.14
.34
.23
.23
.25
.47
1.5
1.7
28
.12
4.5
5.5
5.8
8.9
.08
.12
.76
1.7
2.1
2.9
15
6.6
.06
.07
.17
.12
.27
.36
.20
.11
1.4
1.2
2.5
2.9
4.0
3.8
43
.45

.27
.34
.59
.56
.61
.60
.31
.57
.43
.60
.58
.46
.56
.53
.53
.46
.45
.35
.35
.38
.39
.35
.43
.30
.26
.20
.19
.11
.52
.54
.54
.21
.26
.15
.45
.42
.35
.19
.47
.36
.24
.72
.62
.72
.70
.68
.64
.51
.56
.41
.15
.72
.33
.32
.31
.28
.71
.79
.49
.39
.48
.30
.18
.31
.87
.88
.82
.83
.66
.75
.80
.68
.48
.57
.36
.47
.37
.38
.10
.40

.35
.24
.81
.85
.46
1.5
3.2
3.5
3.7
1.9
4.0
4.0
6.6
9.8
13
11
13
9.9
13
14
20
21
35
57
69
137
.82
8.7
8.7
56
50
175
10
13
16
56
9.7
18
89
1.8
.80
1.9
1.3
1.3
1.4
2.7
8.7
9.6
161
.69
26
32
33
51
.46
.68
4.3
10
12
16
88
37
.35
.38
.97
.67
1.6
2.1
1.1
.62
8.2
7.1
14
17
23
22
247
2.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

7.0
8.6
15
14
16
15
7.9
14
11
15
15
12
14
13
14
12
11
8.8
9.0
9.6
9.9
8.8
11
7.7
6.5
5.2
4.8
2.7
13
14
14
5.3
6.7
3.7
12
11
8.8
4.9
12
9.2
6.2
18
16
18
18
17
16
13
14
10
3.8
18
8.3
8.2
7.8
7.0
18
20
12
10
12
7.7
4.7
7.9
22
22
21
21
17
19
20
17
12
15
9.2
12
9.4
9.6
2.6
10

Lbs.

6.7
30
5.2
23
.20
.90
.13
.60
.50
2.2
.51
2.3
.14
.64
.88
3.9
1.4
6.1
2.1
9.1
2.1
9.5
.89
4.0
2.2
9.9
2.1
9.2
3.5
16
4.5
20
5.9
26
3.9
17
4.6
21
3.7
17
4.9
22
4.9
22
8.5
38
6.3
28
8.9
40
12
52
13
59
15
65
.43
1.9
4.7
21
4.7
21
12
52
13
58
26
114
4.7
21
5.3
24
5.7
25
11
49
4.6
20
6.6
30
22
96
1.3
5.9
.49
2.2
1.4
6.2
.93
4.1
.89
4.0
.91
4.1
1.4
6.1
4.8
22
3.9
17
24
107
.49
2.2
8.3
37
10
46
10
46
14
62
.33
1.5
.53
2.4
2.1
9.5
3.9
17
5.8
26
4.9
22
16
72
12
52
.30
1.4
.33
1.5
.80
3.5
.55
2.5
1.0
4.6
1.5
6.9
.92
4.1
.42
1.9
3.9
17
4.1
18
5.2
23
7.8
35
8.4
37
8.3
37
26
114
1.0
4.6

ENDS: C - Closed

G - Ground
O - Open

Inches

.30
.38
.17
.20
.14
.15
.44
.18
.15
.15
.17
.29
.19
.23
.22
.29
.26
.26
.30
.37
.35
.29
.31
.31
.36
.37
.38
.31
.26
.24
.24
.38
.49
.60
.36
.40
.32
.34
.37
.48
.46
.16
.26
.16
.18
.20
.23
.17
.24
.30
.59
.19
.41
.47
.46
.59
.22
.15
.20
.29
.46
.64
.49
.51
.13
.12
.11
.17
.17
.15
.20
.32
.33
.43
.35
.52
.49
.62
.47
.63

mm

7.7
9.6
4.2
5.0
3.5
3.7
11.2
4.6
3.8
3.9
4.4
7.3
4.9
5.7
5.5
7.3
6.7
6.7
7.5
9.5
8.9
7.3
8.0
8.0
9.1
9.3
9.8
7.8
6.6
6.1
6.1
9.6
12.4
15.4
9.1
10.1
8.2
8.6
9.5
12.2
11.6
4.1
6.6
3.9
4.6
5.1
5.9
4.2
6.1
7.5
15.0
4.8
10.4
12.0
11.7
14.9
5.7
3.9
5.1
7.3
11.7
16.2
12.3
12.8
3.2
3.0
2.7
4.3
4.2
3.8
5.1
8.1
8.3
10.9
8.9
13.2
12.5
15.8
11.8
16.0

WIRE DIA.
Inches

0.038
0.036
0.015
0.015
0.017
0.019
0.020
0.020
0.022
0.022
0.023
0.024
0.024
0.025
0.027
0.032
0.032
0.032
0.033
0.034
0.035
0.035
0.037
0.038
0.042
0.046
0.048
0.051
0.020
0.030
0.030
0.047
0.049
0.062
0.034
0.036
0.036
0.045
0.034
0.040
0.052
0.020
0.020
0.020
0.020
0.020
0.021
0.022
0.030
0.032
0.062
0.018
0.041
0.045
0.045
0.049
0.017
0.017
0.026
0.032
0.037
0.041
0.054
0.047
0.014
0.014
0.016
0.017
0.020
0.020
0.020
0.020
0.032
0.033
0.035
0.040
0.042
0.043
0.062
0.030

mm

TOTAL
MATL
COILS

1.0
0.9
0.4
0.4
0.4
0.5
0.5
0.5
0.6
0.6
0.6
0.6
0.6
0.6
0.7
0.8
0.8
0.8
0.8
0.9
0.9
0.9
0.9
1.0
1.1
1.2
1.2
1.3
0.5
0.8
0.8
1.2
1.2
1.6
0.9
0.9
0.9
1.1
0.9
1.0
1.3
0.5
0.5
0.5
0.5
0.5
0.5
0.6
0.8
0.8
1.6
0.5
1.0
1.1
1.1
1.2
0.4
0.4
0.7
0.8
0.9
1.0
1.4
1.2
0.4
0.4
0.4
0.4
0.5
0.5
0.5
0.5
0.8
0.8
0.9
1.0
1.1
1.1
1.6
0.8

8.00
9.50
10.0
12.0
7.00
6.75
22.0
8.00
5.75
6.00
6.50
11.0
7.00
8.00
7.00
9.00
7.25
7.25
8.00
11.0
9.00
8.25
8.50
8.25
8.50
8.00
8.00
6.00
12.0
8.00
8.00
8.00
10.0
9.75
9.50
11.0
9.00
7.50
10.0
12.0
8.75
7.00
12.0
6.75
8.00
9.00
10.0
6.50
8.00
8.25
9.50
9.50
10.0
10.5
10.3
11.0
12.0
8.00
7.75
8.00
11.5
14.5
9.00
10.8
8.00
7.50
5.75
9.00
7.25
6.50
9.00
15.0
9.25
13.0
9.00
13.0
10.8
13.5
7.50
20.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
MW
SST
SST
PB
MW
MW
SST
MW
MW
SST
MW
MW
MW
MW
MW
SST
SPR
SPR
SST
SST
MW
SST
SPR
SPR
SPR
SPR
SST
MW
MW
SST
SST
HD
SST
SPR
SPR
SPR
SST
SPR
MW
MW
SST
MW
SST
MW
MW
SST
MW
SST
SST
SST
SPR
SST
SST
SPR
MW
SST
SST
SST
SST
SPR
SST
SST
MW
MW
MW
MW
SST
MW
SST
SST
SST
SPR
SPR
HD
SST
SPR
HD
SST

E
N
D
S

CG
C
C
C
C
C
CG
C
C
C
C
C
C
C
C
CG
C
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
C
C
C
C
C
C
C
CG
C
CG
C
CG
CG
CG
C
C
C
CG
C
C
C
CG
CG
C
C
C
C
C
C
C
C
C
CG
C
CG
C
C
CG
C

F
N
S
H

Z
N
Z
N
N
N
N
N
N
N
Z
N
Z
Z
Z
GI
Z
N
N
Z
N
N
Z
N
N
Z
Z
Z
N
Z
N
N
N
Z
N
Z
N
N
N
Z
Z
Z
N
N
N
N
Z
N
N
N
N
N
Z
N
N
N
Z
N
N
N
N
Z
N
N
N
N
Z
Z
N
Z
N
N
N
N
Z
N
N
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 77

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312

7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92

S-790
Z-51
GG-12
S-996
AA-10
A9-67
3296
V-62
3092
W-57
11162
10910
2791
CC-33
S-483
A9-41
3514
3746
HH-97
S-791
10147
S-788
S-36
S-1182
K-43
10732
B-49
L-95
S-1686
2807
10504
1859
N-38
11368
10049
S-3114
G-3
AA-84
A9-46
3715
2
S-495
S-734
3615
S-3131
1543
10294
10021
1857
10328
3533
10193
10024
NN-78
L-59
NN-79
1697
B11-19
202-B
10903
12736
B2-10
3138
113
10508
1781
4136
12702
BB-10
QQ-69
12751
Q-46
B10-44
2576
LL-93
B3-69
10736
2759
3
S-44

1.03
1.03
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.19
1.19
1.19
1.19
1.20
1.22
1.22
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.31
1.31
1.31
1.31
1.31
1.31
1.31
1.31
1.31
1.31
1.31
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.40
1.41
1.44
1.44
1.44
1.44
1.47
1.47
1.48
1.50
1.50
1.50
1.50

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

26.2
26.2
27.0
27.0
27.0
27.0
27.0
27.0
27.0
27.0
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
29.4
30.2
30.2
30.2
30.2
30.5
31.0
31.0
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
33.3
33.3
33.3
33.3
33.3
33.3
33.3
33.3
33.3
33.3
33.3
34.1
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.6
35.7
36.5
36.5
36.5
36.5
37.3
37.3
37.6
38.1
38.1
38.1
38.1

I.D.
Inches

.232
.186
.284
.276
.272
.254
.252
.246
.208
.204
.274
.272
.272
.272
.262
.258
.256
.252
.246
.242
.236
.204
.186
.262
.238
.230
.222
.168
.228
.260
.196
.194
.274
.272
.264
.262
.260
.252
.250
.246
.230
.230
.228
.218
.210
.198
.258
.256
.252
.250
.250
.248
.246
.218
.208
.192
.190
.274
.280
.256
.256
.256
.252
.250
.248
.242
.228
.254
.252
.268
.254
.248
.238
.262
.212
.252
.270
.266
.266
.252

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

5.9
4.7
7.2
7.0
6.9
6.5
6.4
6.2
5.3
5.2
7.0
6.9
6.9
6.9
6.7
6.6
6.5
6.4
6.2
6.1
6.0
5.2
4.7
6.7
6.0
5.8
5.6
4.3
5.8
6.6
5.0
4.9
7.0
6.9
6.7
6.7
6.6
6.4
6.4
6.2
5.8
5.8
5.8
5.5
5.3
5.0
6.6
6.5
6.4
6.4
6.4
6.3
6.2
5.5
5.3
4.9
4.8
7.0
7.1
6.5
6.5
6.5
6.4
6.4
6.3
6.1
5.8
6.5
6.4
6.8
6.5
6.3
6.0
6.7
5.4
6.4
6.9
6.8
6.8
6.4

N/mm

Inches

15
244

2.6
43
.06
.08
.07
1.1
1.2
1.4
15
9.9
.17
.17
.23
.27
.36
.72
.59
1.2
1.4
1.3
2.3
10
18
.60
1.5
5.1
4.3
49
4.3
.50
19
24
.14
.16
.50
.60
.38
.76
.81
1.0
3.0
2.0
3.1
4.4
6.8
20
.53
.61
.67
.63
.89
.86
1.1
4.4
7.0
16
31
.10
.07
.64
.40
.39
.66
.91
.75
1.3
4.4
.46
.56
.14
.46
.75
2.2
.28
5.0
.53
.18
.19
.32
.72

.49
.11
.94
.79
.60
.68
.70
.54
.18
.29
.92
.90
.93
.97
.80
.83
.72
.70
.54
.64
.50
.28
.21
.55
.61
.29
.44
.13
.34
.91
.19
.23
1.0
1.0
.93
.55
.83
.80
.78
.75
.49
.53
.48
.45
.36
.18
.93
.92
.82
.71
.85
.80
.71
.49
.36
.25
.14
1.1
1.2
1.0
.82
.80
.90
.93
.77
.72
.35
.82
.91
1.0
.86
.83
.50
1.0
.46
.88
1.2
1.1
1.2
.79

.35
.43
.40
6.4
6.9
8.0
85
56
.96
.99
1.3
1.5
2.1
4.1
3.4
6.9
8.0
7.4
13
58
104
3.4
8.8
29
25
279
25
2.9
110
134
.81
.91
2.9
3.4
2.2
4.3
4.6
6.0
17
11
18
25
39
114
3.0
3.5
3.8
3.6
5.1
4.9
6.5
25
40
93
180
.57
.40
3.7
2.3
2.2
3.8
5.2
4.3
7.3
25
2.6
3.2
.81
2.6
4.3
12
1.6
29
3.1
1.0
1.1
1.8
4.1

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

mm

13
2.8
24
20
15
17
18
14
4.6
7.3
23
23
23
25
20
21
18
18
14
16
13
7.1
5.4
14
16
7.3
11
3.3
8.6
23
4.9
5.8
26
26
24
14
21
20
20
19
12
13
12
11
9.0
4.5
24
23
21
18
22
20
18
13
9.3
6.4
3.4
27
30
25
21
20
23
23
19
18
9.0
21
23
27
22
21
13
26
12
22
31
27
31
20

ENDS: C - Closed

G - Ground
O - Open

Lbs.

7.3
27
.33
.34
.24
4.4
4.8
4.3
15
16
.88
.89
1.2
1.5
1.7
3.4
2.4
4.8
4.3
4.7
6.7
16
22
1.9
5.4
8.3
11
37
8.4
2.6
21
31
.84
.92
2.7
1.9
1.8
3.5
3.6
4.5
8.3
6.0
8.4
11
14
20
2.8
3.2
3.1
2.6
4.4
3.9
4.6
12
15
23
24
.61
.48
3.7
1.8
1.8
3.4
4.8
3.3
5.2
8.9
2.2
2.9
.85
2.3
3.6
6.2
1.6
13
2.7
1.2
1.2
2.2
3.2

32
119
1.4
1.5
1.1
20
22
19
69
72
3.9
4.0
5.4
6.6
7.3
15
11
22
19
21
30
72
98
8.4
24
37
49
164
37
12
94
137
3.7
4.1
12
8.4
8.0
15
16
20
37
26
37
50
61
90
12
14
14
11
19
17
21
55
65
104
109
2.7
2.1
16
8.2
7.9
15
21
15
23
40
9.6
13
3.8
10
16
27
7.2
58
12
5.5
5.2
9.8
14

Inches

.52
.57
.13
.27
.46
.29
.32
.35
.47
.70
.20
.23
.20
.16
.33
.30
.41
.32
.38
.49
.49
.70
.91
.23
.57
.37
.65
.86
.42
.31
.70
.65
.21
.24
.24
.23
.42
.45
.42
.50
.62
.72
.60
.80
.73
.63
.38
.39
.50
.61
.46
.51
.50
.80
.78
.93
.61
.29
.19
.38
.56
.57
.47
.45
.61
.60
.50
.58
.50
.39
.58
.61
.46
.45
.93
.60
.29
.42
.28
.42

mm

Inches

13.2
14.4
3.2
6.9
11.7
7.4
8.0
8.8
11.9
17.8
5.2
5.7
5.1
4.1
8.3
7.5
10.3
8.0
9.6
12.4
12.5
17.7
23.2
5.7
14.6
9.4
16.6
21.9
10.7
7.8
17.7
16.5
5.3
6.1
6.1
5.7
10.6
11.4
10.6
12.7
15.6
18.4
15.2
20.3
18.5
15.9
9.6
10.0
12.6
15.4
11.6
13.0
12.6
20.3
19.8
23.6
15.5
7.2
4.9
9.6
14.2
14.6
12.0
11.4
15.4
15.1
12.8
14.7
12.6
9.9
14.7
15.4
11.7
11.4
23.5
15.2
7.5
10.7
7.2
10.7

0.040
0.063
0.014
0.018
0.020
0.029
0.030
0.033
0.052
0.054
0.019
0.020
0.020
0.020
0.025
0.027
0.028
0.030
0.033
0.035
0.038
0.054
0.063
0.025
0.037
0.041
0.045
0.072
0.042
0.026
0.058
0.059
0.019
0.020
0.024
0.025
0.026
0.030
0.031
0.033
0.041
0.041
0.042
0.047
0.051
0.057
0.027
0.028
0.030
0.031
0.031
0.032
0.033
0.047
0.052
0.060
0.061
0.019
0.016
0.028
0.028
0.028
0.030
0.031
0.032
0.035
0.042
0.029
0.030
0.022
0.029
0.032
0.037
0.025
0.050
0.030
0.021
0.023
0.023
0.030

mm

TOTAL
MATL
COILS

1.0
1.6
0.4
0.5
0.5
0.7
0.8
0.8
1.3
1.4
0.5
0.5
0.5
0.5
0.6
0.7
0.7
0.8
0.8
0.9
1.0
1.4
1.6
0.6
0.9
1.0
1.1
1.8
1.1
0.7
1.5
1.5
0.5
0.5
0.6
0.6
0.7
0.8
0.8
0.8
1.0
1.0
1.1
1.2
1.3
1.4
0.7
0.7
0.8
0.8
0.8
0.8
0.8
1.2
1.3
1.5
1.5
0.5
0.4
0.7
0.7
0.7
0.8
0.8
0.8
0.9
1.1
0.7
0.8
0.6
0.7
0.8
0.9
0.6
1.3
0.8
0.5
0.6
0.6
0.8

13.0
8.00
8.00
14.0
22.0
9.00
9.50
10.5
9.00
13.0
9.75
10.3
9.00
8.00
12.0
10.0
13.5
9.50
10.5
14.0
13.0
12.0
14.5
8.00
15.5
9.00
14.5
12.0
10.0
11.8
11.0
10.0
10.0
11.0
9.00
8.00
15.0
14.0
13.5
15.0
14.0
17.7
13.3
17.0
14.3
10.0
13.0
13.0
15.5
18.5
13.8
16.0
14.0
17.0
15.0
14.5
9.00
15.0
11.0
12.5
19.0
19.5
15.8
13.5
18.0
16.0
11.0
19.0
16.5
16.8
19.0
18.0
12.5
17.0
17.5
19.0
13.0
17.3
11.3
13.0

SST
SPR
MW
SST
SST
MW
MW
SST
SPR
SST
MW
SST
MW
MW
SST
MW
MW
MW
SST
SST
SPR
SST
SST
SST
SST
SPR
SPR
HD
SST
MW
SPR
MW
SST
SST
MW
SST
MW
MW
SST
SPR
HD
SST
SST
HD
SST
SPR
MW
MW
MW
MW
MW
SPR
SPR
SPR
SST
SPR
SPR
MW
MW
MW
MW
MW
MW
MW
MW
SPR
SPR
MW
SST
SST
MW
SPR
SPR
MW
SST
MW
MW
MW
MW
SST

E
N
D
S

CG
C
C
C
C
C
C
CG
CG
CG
C
C
C
CG
C
C
C
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
C
C
C
C
C
C
C
C
CG
CG
C
CG
C
CG
CG
C
C
C
C
C
C
CG
C
CG
CG
C
C
CG
C
C
C
C
CG
C
C
C
C
C
CG
C
C
C
CG
C
C
C
C
C
C
C

F
N
S
H

N
N
N
N
N
Z
Z
N
Z
N
Z
N
GI
Z
N
N
Z
Z
N
N
Z
N
N
N
N
Z
Z
Z
N
Z
Z
Z
N
N
GI
N
Z
Z
N
Z
Z
N
N
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
Z
N
Z
N
N
N
Z
Z
Z
Z
Z
N
N
N
N
Z
Z
Z
N
N
GI
Z
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

77

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 78

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.312
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328

7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
7.92
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33

6
K-23
3908
S-735
N-70
B14-31
936
11237
11383
2823
S-180
PP-65
J-100
WW-59
116
10127
10916
10535
A15-38
12432
202-C
FF-42
4196
JJ-100
10100
HH-93
3395
1937
B15-25
3183
OO-87
10481
U-54
1942
J-87
S-910
9
S-297
3128
937
4122
S-821
S-1030
Z-61
12262
12196
G-28
A9-62
F-58
S-218
B9-58
S-1684
KK-11
Y-13
M-115
F-57
4109
1573
12498
10479
B2-60
10222
3087
10092
10772
10978
10686
3858
2866
12409
12408
A9-4
10844
3761
Y-91
B2-16
B2-5
G-39
FF-14
NN-50

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.59
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.66
1.72
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.78
1.88
1.88
1.94
1.94
1.94
2.00
2.00
2.00
2.00
2.00
2.13
2.16
2.25
2.25
2.31
2.34
2.38
2.50
2.50
2.75
2.75
2.88
3.00
3.00
3.13
3.25
3.25
3.38
3.44
3.66
4.00
4.00
5.00
6.50
7.44
7.50
7.50
9.00
10.0
10.5
10.5
.22
.25
.25
.28
.28
.30
.31
.31
.31

mm

38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.9
40.5
41.3
41.3
41.3
41.3
41.3
41.3
41.3
42.1
43.6
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
45.2
47.6
47.6
49.2
49.2
49.2
50.8
50.8
50.8
50.8
50.8
54.0
54.8
57.2
57.2
58.7
59.5
60.3
63.5
63.5
69.9
69.9
73.0
76.2
76.2
79.4
82.6
82.6
85.7
87.4
92.9
101.6
101.6
127.0
165.1
188.9
190.5
190.5
228.6
254.0
266.7
266.7
5.6
6.4
6.4
7.1
7.1
7.5
7.9
7.9
7.9

MATERIAL: MW - Music Wire

78

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.244
.242
.228
.228
.222
.220
.218
.208
.198
.240
.264
.272
.242
.242
.230
.228
.208
.202
.256
.250
.280
.272
.260
.232
.222
.212
.198
.196
.180
.248
.242
.230
.260
.232
.232
.264
.218
.218
.214
.204
.232
.240
.228
.228
.256
.216
.218
.250
.208
.260
.202
.274
.252
.248
.216
.224
.220
.242
.276
.272
.276
.216
.224
.230
.242
.248
.236
.228
.218
.220
.216
.232
.238
.228
.264
.264
.264
.280
.268
.204

RATE
mm

6.2
6.1
5.8
5.8
5.6
5.6
5.5
5.3
5.0
6.1
6.7
6.9
6.1
6.1
5.8
5.8
5.3
5.1
6.5
6.4
7.1
6.9
6.6
5.9
5.6
5.4
5.0
5.0
4.6
6.3
6.1
5.8
6.6
5.9
5.9
6.7
5.5
5.5
5.4
5.2
5.9
6.1
5.8
5.8
6.5
5.5
5.5
6.4
5.3
6.6
5.1
7.0
6.4
6.3
5.5
5.7
5.6
6.1
7.0
6.9
7.0
5.5
5.7
5.8
6.1
6.3
6.0
5.8
5.5
5.6
5.5
5.9
6.0
5.8
6.7
6.7
6.7
7.1
6.8
5.2

Lbs./In.

6.7
6.5
17
14
27
26
29
37
87
8.5
1.4
.92
6.3
6.3
13
17
37
48
1.6
5.3
.39
.97
2.8
7.6
23
29
48
78
126
6.1
5.1
11
2.0
10
9.9
1.4
18
20
28
44
10
4.1
9.9
13
1.9
22
17
3.0
24
.86
36
.23
1.7
2.3
12
8.5
13
4.2
.21
.36
.21
15
5.5
2.6
1.5
1.6
2.9
2.7
5.1
4.4
5.3
206
260
558
19
39
39
14
12
491

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

Lbs.

1.2
1.1
3.1
2.5
4.7
4.6
5.1
6.5
15
1.5
.24
.16
1.1
1.1
2.2
3.1
6.4
8.5
.29
.93
.07
.17
.49
1.3
4.0
5.1
8.4
14
22
1.1
.89
2.0
.35
1.8
1.7
.25
3.1
3.5
5.0
7.8
1.8
.71
1.7
2.3
.34
3.8
2.9
.52
4.2
.15
6.2
.04
.30
.40
2.1
1.5
2.3
.73
.04
.06
.04
2.6
.96
.46
.26
.28
.50
.47
.89
.77
.93
36
46
98
3.4
6.8
6.8
2.4
2.1
86

.75
.75
.51
.58
.41
.44
.43
.41
.23
.93
1.2
1.4
.78
.83
.65
.51
.42
.38
1.0
1.0
1.6
1.5
1.1
.79
.48
.47
.42
.27
.24
.97
1.0
.74
1.5
.75
.73
1.2
.70
.58
.49
.39
.76
1.2
.85
.69
1.7
.60
.69
1.8
.65
1.9
.51
2.3
1.9
1.7
1.1
1.2
.87
1.3
2.9
3.1
3.4
.89
1.9
3.2
3.6
3.7
2.3
3.3
2.5
2.7
2.5
.05
.04
.02
.12
.10
.10
.19
.11
.05

19
19
13
15
10
11
11
11
5.9
24
31
35
20
21
17
13
11
9.5
26
26
39
38
29
20
12
12
11
6.9
6.1
25
26
19
39
19
19
31
18
15
12
9.9
19
30
22
17
42
15
18
45
16
49
13
58
48
44
28
31
22
32
73
78
87
23
47
81
90
93
59
84
62
67
63
1.3
1.0
.60
3.1
2.6
2.6
4.7
2.8
1.2

5.0
22
4.9
22
8.9
40
8.4
37
11
49
12
52
12
55
15
69
20
90
7.9
35
1.7
7.5
1.3
5.7
4.9
22
5.2
23
8.3
37
8.9
40
15
69
18
81
1.7
7.5
5.3
24
.61
2.7
1.5
6.5
3.2
14
6.0
27
11
49
14
62
20
90
21
94
30
136
5.9
26
5.2
23
8.3
37
3.1
14
7.8
35
7.3
32
1.8
7.9
12
55
12
52
14
62
17
77
7.8
35
4.8
21
8.4
37
8.9
40
3.2
14
13
59
12
52
5.3
24
15
69
1.7
7.4
18
81
.52
2.3
3.2
14
3.9
17
13
59
10
46
12
52
5.2
23
.61
2.7
1.1
4.9
.73
3.2
13
59
10
46
8.3
37
5.2
23
5.9
26
6.7
30
8.9
40
12
55
12
52
13
59
10
46
10
46
13
59
2.3
10
4.0
18
4.0
18
2.5
11
1.3
5.7
23
103

ENDS: C - Closed

G - Ground
O - Open

Inches

.55
.58
.67
.70
.61
.74
.75
.99
.71
.56
.36
.24
.56
.63
.78
.67
1.00
1.05
.64
.44
.20
.25
.34
.96
.74
.95
1.20
.91
1.16
.46
.81
.86
.42
.83
.72
.34
1.14
.90
.93
1.03
.84
.99
.92
.82
.64
1.01
1.03
.71
1.40
.81
1.31
.60
.90
.94
1.78
1.54
1.31
.95
.56
.58
.56
1.49
2.33
3.26
2.51
1.47
2.05
3.65
3.64
3.73
3.89
.17
.18
.19
.16
.14
.14
.10
.20
.25

mm

14.0
14.7
17.1
17.9
15.4
18.7
19.1
25.1
18.1
14.2
9.1
6.1
14.2
16.0
19.8
17.1
25.4
26.5
16.2
11.2
5.0
6.4
8.6
24.4
18.9
24.1
30.4
23.2
29.3
11.6
20.4
21.9
10.6
21.1
18.3
8.5
28.9
23.0
23.6
26.1
21.3
25.1
23.5
20.8
16.4
25.6
26.3
18.1
35.7
20.6
33.2
15.2
22.9
23.8
45.1
39.1
33.3
24.2
14.2
14.6
14.2
37.8
59.2
82.8
63.8
37.4
52.1
92.8
92.5
94.6
98.8
4.3
4.6
4.8
4.1
3.7
3.7
2.6
5.1
6.3

WIRE DIA.
Inches

0.034
0.035
0.042
0.042
0.045
0.046
0.047
0.052
0.057
0.036
0.024
0.020
0.035
0.035
0.041
0.042
0.052
0.055
0.028
0.031
0.016
0.020
0.026
0.040
0.045
0.050
0.057
0.058
0.066
0.032
0.035
0.041
0.026
0.040
0.040
0.024
0.047
0.047
0.049
0.054
0.040
0.036
0.042
0.042
0.028
0.048
0.047
0.031
0.052
0.026
0.055
0.019
0.030
0.032
0.048
0.044
0.046
0.035
0.018
0.020
0.018
0.048
0.044
0.041
0.035
0.032
0.038
0.042
0.047
0.046
0.048
0.048
0.045
0.050
0.032
0.032
0.032
0.024
0.030
0.062

mm

TOTAL
MATL
COILS

0.9
0.9
1.1
1.1
1.1
1.2
1.2
1.3
1.4
0.9
0.6
0.5
0.9
0.9
1.0
1.1
1.3
1.4
0.7
0.8
0.4
0.5
0.7
1.0
1.1
1.3
1.4
1.5
1.7
0.8
0.9
1.0
0.7
1.0
1.0
0.6
1.2
1.2
1.2
1.4
1.0
0.9
1.1
1.1
0.7
1.2
1.2
0.8
1.3
0.7
1.4
0.5
0.8
0.8
1.2
1.1
1.2
0.9
0.5
0.5
0.5
1.2
1.1
1.0
0.9
0.8
1.0
1.1
1.2
1.2
1.2
1.2
1.1
1.3
0.8
0.8
0.8
0.6
0.8
1.6

15.3
15.5
15.0
15.8
13.5
15.0
15.0
18.0
12.5
15.5
15.0
12.0
16.0
18.0
18.0
15.0
18.3
18.0
22.8
13.3
11.3
11.5
12.0
23.0
15.5
19.0
21.0
14.8
16.5
13.3
22.0
20.0
16.0
19.8
18.0
14.0
23.3
18.3
18.0
18.0
20.0
26.5
22.0
19.5
22.0
21.0
22.0
22.0
27.0
30.3
23.8
30.5
29.0
28.3
37.0
35.0
27.5
26.3
30.0
27.8
30.0
30.0
53.0
79.5
70.8
45.0
53.0
86.0
76.5
80.0
80.0
3.50
3.00
2.75
5.00
3.50
3.50
3.25
5.75
4.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

HD
SST
SPR
SST
SPR
SPR
HD
SPR
HD
MW
SST
MW
SST
SPR
HD
SPR
SPR
SPR
SST
MW
MW
MW
MW
SST
SPR
SPR
SPR
SPR
SPR
MW
SPR
SPR
MW
SPR
SST
SST
HD
SST
SPR
HD
SPR
SST
SST
SPR
MW
SPR
SST
MW
SPR
SST
SPR
SST
SST
SST
SPR
HD
SPR
SPR
MW
MW
MW
SPR
SPR
SPR
SPR
MW
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
MW
MW
SST

E
N
D
S

C
C
C
C
CG
C
C
C
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
C
C
C
C
C
C
CG
CG
C
C
C
C
C
C
C
CG
CG
C
C
C
C
C
C
CG
CG
C
CG
CG
C
CG
C
CG
C
C
C
CG
CG
C
C
C
C
C
C
CG
CG
C
C
C
C
C
C
C
CG
C
C
CG
C
CL
C
C
CG

F
N
S
H

Z
N
Z
N
GI
Z
Z
Z
Z
Z
N
Z
N
N
Z
Z
N
Z
N
Z
Z
Z
Z
N
Z
N
Z
Z
N
Z
Z
Z
N
Z
N
N
Z
N
Z
Z
Z
N
N
GI
Z
Z
N
Z
GI
N
N
N
N
N
N
Z
N
Z
Z
Z
N
Z
Z
Z
Z
N
N
Z
Z
Z
N
N
N
Z
N
Z
Z
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 79

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328

8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33

H-58
EE-32
XX-44
MM-69
S-4
I-38
II-31
KK-1
GG-24
2944
A10-27
S-817
V V-43
3669
Y-71
O-117
2578
W-86
A10-51
B4-11
3717
J-76
2673
11132
I-11
O-1
2671
CC-97
A-17
BB-97
L-36
S-1429
W-65
FF-47
S-797
A13-45
LL-94
B3-44
O-142
Z-92
I-76
B15-56
S-893
CC-77
A12-32
S-3143
U-40
A9-43
2872
12500
MM-17
I-19
S-3000
KK-46
Y-88
10022
2546
A-86
K-68
2919
RR-24
WW-61
FF-95
A9-13
K-100
OO-29
10588
JJ-40
L-74
B5-13
4103
G-34
11189
MM-58
S-917
3207
1821
4182
H-73
GG-91

.34
.38
.38
.38
.41
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.50
.50
.50
.50
.50
.50
.50
.56
.56
.56
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.69
.69
.69
.69
.69
.69
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.81
.84
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.91
.94
.97
.97

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

8.7
9.5
9.5
9.7
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
12.7
12.7
12.7
12.7
12.7
12.7
12.7
14.3
14.3
14.3
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
18.2
18.2
18.3
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
20.6
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.0
23.0
23.8
24.6
24.6

I.D.
Inches

.296
.270
.264
.208
.280
.276
.268
.268
.258
.256
.256
.252
.246
.244
.238
.264
.262
.238
.236
.236
.192
.184
.264
.238
.226
.302
.288
.242
.300
.278
.278
.270
.264
.258
.258
.242
.204
.282
.246
.244
.236
.302
.274
.272
.262
.246
.234
.278
.270
.228
.300
.296
.272
.268
.268
.266
.258
.248
.248
.234
.234
.216
.268
.232
.248
.198
.280
.280
.264
.264
.230
.214
.186
.288
.270
.234
.218
.220
.282
.276

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

7.5
6.9
6.7
5.3
7.1
7.0
6.8
6.8
6.6
6.5
6.5
6.4
6.2
6.2
6.0
6.7
6.7
6.0
6.0
6.0
4.9
4.7
6.7
6.0
5.7
7.7
7.3
6.1
7.6
7.1
7.1
6.9
6.7
6.6
6.6
6.1
5.2
7.2
6.2
6.2
6.0
7.7
7.0
6.9
6.7
6.2
5.9
7.1
6.9
5.8
7.6
7.5
6.9
6.8
6.8
6.8
6.6
6.3
6.3
5.9
5.9
5.5
6.8
5.9
6.3
5.0
7.1
7.1
6.7
6.7
5.8
5.4
4.7
7.3
6.9
5.9
5.5
5.6
7.2
7.0

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.92
.16
8.3
1.4
29
5.1
429
75
4.9
.86
12
2.1
22
3.9
5.5
.96
25
4.4
52
9.1
34
6.0
27
4.7
40
7.0
64
11
116
20
12
2.0
17
2.9
57
9.9
31
5.5
72
13
437
77
768 134
27
4.8
61
11
101
18
.19
.03
3.9
.69
42
7.4
.25
.04
4.0
.71
4.5
.79
8.3
1.4
15
2.5
19
3.3
15
2.6
35
6.2
245
43
2.4
.41
30
5.3
55
9.6
51
8.9
.19
.03
6.6
1.2
6.9
1.2
14
2.5
40
7.0
53
9.2
4.5
.78
5.9
1.0
73
13
.20
.03
.56
.10
4.7
.83
9.8
1.7
5.5
.96
6.3
1.1
12
2.1
26
4.5
27
4.7
53
9.2
52
9.2
117
21
5.5
.96
50
8.8
21
3.6
175
31
2.8
.50
1.8
.32
8.3
1.5
6.3
1.1
55
9.5
127
22
430
75
.79
.14
4.3
.75
45
7.9
92
16
66
12
1.1
.19
3.5
.62

.25
.20
.14
.05
.26
.25
.21
.14
.18
.11
.15
.21
.19
.13
.09
.24
.27
.17
.18
.16
.07
.05
.21
.17
.13
.46
.37
.22
.49
.43
.46
.34
.28
.25
.31
.26
.09
.45
.24
.16
.20
.57
.34
.50
.28
.19
.22
.40
.44
.18
.58
.61
.50
.32
.45
.41
.40
.29
.26
.22
.21
.16
.48
.23
.34
.15
.66
.61
.48
.52
.25
.15
.08
.67
.59
.26
.26
.25
.63
.58

mm

6.3
5.1
3.5
1.2
6.7
6.5
5.3
3.5
4.7
2.7
3.8
5.3
4.8
3.4
2.3
6.2
6.7
4.4
4.5
3.9
1.8
1.2
5.2
4.3
3.3
12
9.5
5.5
12
11
12
8.6
7.0
6.4
8.0
6.6
2.4
11
6.2
4.0
5.2
14
8.7
13
7.2
4.8
5.7
10
11
4.6
15
16
13
8.1
11
10
10
7.3
6.6
5.7
5.4
4.0
12
6.0
8.5
3.8
17
16
12
13
6.2
3.9
2.0
17
15
6.7
6.7
6.4
16
15

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.23
1.7
4.0
21
1.3
3.0
4.6
.76
4.7
5.4
5.1
5.6
7.5
8.5
10
2.8
4.4
9.8
5.6
11
32
35
5.6
10
13
.09
1.5
9.1
.12
1.7
2.1
2.8
4.0
4.7
4.7
9.1
23
1.1
7.5
8.5
10
.11
2.3
3.4
4.1
7.5
12
1.8
2.6
13
.12
.35
2.4
3.1
2.5
2.6
4.9
7.4
6.9
12
11
18
2.6
12
6.9
26
1.9
1.1
4.0
3.2
13
19
34
.52
2.5
12
24
17
.68
2.0

1.0
7.4
18
94
5.7
13
21
3.4
21
24
23
25
33
38
46
13
20
44
25
50
142
158
25
46
59
.39
6.6
41
.55
7.6
9.2
12
18
21
21
41
103
4.7
33
38
46
.49
10
15
18
33
53
8.0
12
59
.51
1.5
11
14
11
12
22
33
31
53
49
82
12
52
31
117
8.3
5.0
18
14
59
86
152
2.3
11
53
108
74
3.0
9.0

Inches

.10
.17
.16
.30
.14
.10
.12
.30
.18
.18
.16
.23
.24
.21
.19
.26
.23
.27
.32
.28
.41
.36
.13
.33
.31
.13
.10
.30
.14
.20
.16
.20
.22
.21
.25
.34
.37
.21
.29
.27
.32
.12
.18
.19
.23
.28
.38
.18
.28
.44
.17
.14
.25
.18
.30
.34
.35
.32
.28
.38
.34
.50
.30
.39
.34
.59
.22
.26
.32
.36
.49
.46
.57
.24
.32
.47
.55
.65
.33
.23

mm

Inches

2.4
4.4
4.1
7.6
3.7
2.6
3.0
7.6
4.4
4.5
4.1
5.8
6.0
5.3
4.9
6.5
5.9
6.9
8.2
7.0
10.4
9.1
3.4
8.3
7.8
3.3
2.5
7.6
3.6
5.1
4.1
5.2
5.7
5.3
6.2
8.7
9.4
5.3
7.3
6.9
8.2
3.0
4.6
4.8
5.9
7.0
9.6
4.4
7.0
11.1
4.3
3.5
6.4
4.6
7.6
8.7
8.9
8.1
7.1
9.6
8.7
12.8
7.6
9.9
8.6
14.9
5.5
6.7
8.1
9.1
12.4
11.6
14.4
6.1
8.0
11.9
14.0
16.5
8.5
5.9

0.016
0.029
0.032
0.060
0.024
0.026
0.030
0.030
0.035
0.036
0.036
0.038
0.041
0.042
0.045
0.032
0.033
0.045
0.046
0.046
0.068
0.072
0.032
0.045
0.051
0.013
0.020
0.043
0.014
0.025
0.025
0.029
0.032
0.035
0.035
0.043
0.062
0.023
0.041
0.042
0.046
0.013
0.027
0.028
0.033
0.041
0.047
0.025
0.029
0.050
0.014
0.016
0.028
0.030
0.030
0.031
0.035
0.040
0.040
0.047
0.047
0.056
0.030
0.048
0.040
0.065
0.024
0.024
0.032
0.032
0.049
0.057
0.071
0.020
0.029
0.047
0.055
0.054
0.023
0.026

mm

TOTAL
MATL
COILS

0.4
0.7
0.8
1.5
0.6
0.7
0.8
0.8
0.9
0.9
0.9
1.0
1.0
1.1
1.1
0.8
0.8
1.1
1.2
1.2
1.7
1.8
0.8
1.1
1.3
0.3
0.5
1.1
0.4
0.6
0.6
0.7
0.8
0.9
0.9
1.1
1.6
0.6
1.0
1.1
1.2
0.3
0.7
0.7
0.8
1.0
1.2
0.6
0.7
1.3
0.4
0.4
0.7
0.8
0.8
0.8
0.9
1.0
1.0
1.2
1.2
1.4
0.8
1.2
1.0
1.7
0.6
0.6
0.8
0.8
1.2
1.4
1.8
0.5
0.7
1.2
1.4
1.4
0.6
0.7

5.00
6.00
4.00
4.00
5.00
4.00
4.00
10.0
5.00
4.00
4.50
6.00
5.75
5.00
4.25
7.00
6.00
6.00
7.00
6.00
6.00
5.00
4.00
6.25
6.00
9.00
4.00
7.00
9.00
7.00
6.50
6.00
6.00
6.00
7.00
8.00
6.00
8.00
7.00
5.50
7.00
8.00
5.75
6.75
6.00
5.75
8.00
6.00
8.50
7.75
11.0
7.50
8.00
6.00
9.00
10.0
9.00
8.00
7.00
8.00
7.25
8.00
9.00
8.00
8.50
9.00
8.00
10.0
9.00
11.3
9.00
8.00
7.00
12.0
10.0
9.00
9.00
11.0
13.5
8.00

SST
SST
HD
SST
SST
MW
MW
MW
SST
SPR
SST
SST
SST
SPR
SPR
SPR
HD
SST
SPR
SPR
SPR
SPR
MW
SPR
SST
MW
MW
SPR
MW
MW
MW
SST
SPR
SST
SST
SPR
SST
MW
SST
SPR
SST
SST
SST
MW
SST
SST
SPR
SST
MW
SPR
MW
MW
SST
SST
SST
MW
MW
SPR
SST
HD
SST
SPR
SST
SST
SST
SST
MW
SST
HD
SPR
SPR
SPR
HD
MW
SST
HD
MW
SPR
SST
SST

E
N
D
S

C
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
C
C
CG
C
C
CG
CG
CG
CG
C
CG
C
CG
C
C
CG
C
C
CG
C
C
C
C
C
C
CG
C
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
C
CG
C
CG
C
CG
C
C
C
C
C
C

F
N
S
H

N
N
Z
N
N
GI
Z
Z
N
Z
N
N
N
Z
N
GI
Z
N
N
Z
Z
N
GI
Z
N
GI
Z
Z
Z
Z
N
N
Z
N
N
N
N
Z
N
Z
N
N
N
N
N
N
Z
N
Z
N
Z
N
N
N
N
Z
Z
Z
N
Z
N
Z
N
N
N
N
N
N
N
N
Z
Z
Z
N
N
Z
Z
Z
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

79

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:24 AM Page 80

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328
0.328

8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33
8.33

HH-38
I-9
WW-53
CC-69
2581
10040
10536
B4-25
J-16
O-103
A-69
Y-96
B14-28
10255
W-27
CC-51
HH-27
A-98
S-229
Q-40
S-413
OO-72
3606
NN-36
B7-26
11101
3958
1507
I-3
PP-34
3565
MM-74
NN-27
EE-90
HH-2
10876
10576
10720
OO-97
2783
S-186
3644
11452
1905
10534
S-825
12468
KK-59
MM-72
S-1159
12251
V V-70
K-30
O-59
Q-47
A11-57
L-54
RR-69
12212
N-104
Q-36
12406
LL-24
2695
L-3
G-94
11806
II-53
B11-11
B18-129
B10-62
3286
L-61
10035
11292
B-92
S-3025
OO-75
B11-23
B17-173

1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.06
1.09
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.19
1.19
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.28
1.28
1.31
1.31
1.38
1.38
1.38
1.41
1.41
1.47
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.59
1.59
1.69
1.69
1.75
1.75
1.88
1.88
1.88
1.91
1.94
1.94
1.94
1.94
2.00
2.00
2.00
2.25
2.31
2.44
2.50
2.69
2.75
2.75
3.00
3.22

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.0
27.8
27.8
27.8
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
30.2
30.2
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
32.5
32.5
33.3
33.3
34.9
34.9
34.9
35.7
35.7
37.3
37.3
38.1
38.1
38.1
38.1
38.1
38.1
40.5
40.5
42.8
42.8
44.5
44.5
47.6
47.6
47.6
48.4
49.2
49.2
49.2
49.2
50.8
50.8
50.8
57.2
58.7
61.9
63.5
68.2
69.9
69.9
76.2
81.8

MATERIAL: MW - Music Wire

80

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.282
.274
.254
.248
.242
.238
.238
.238
.224
.256
.276
.232
.290
.278
.220
.268
.268
.256
.242
.238
.228
.228
.220
.268
.248
.234
.226
.204
.230
.288
.272
.264
.248
.188
.148
.288
.258
.246
.208
.266
.204
.296
.234
.146
.266
.236
.284
.228
.288
.278
.268
.266
.252
.250
.260
.256
.234
.184
.244
.218
.278
.246
.208
.184
.220
.280
.216
.214
.280
.246
.234
.248
.222
.220
.272
.276
.288
.208
.236
.238

RATE
mm

7.2
7.0
6.5
6.3
6.1
6.0
6.0
6.0
5.7
6.5
7.0
5.9
7.4
7.1
5.6
6.8
6.8
6.5
6.1
6.0
5.8
5.8
5.6
6.8
6.3
5.9
5.7
5.2
5.8
7.3
6.9
6.7
6.3
4.8
3.8
7.3
6.6
6.2
5.3
6.8
5.2
7.5
5.9
3.7
6.8
6.0
7.2
5.8
7.3
7.1
6.8
6.8
6.4
6.4
6.6
6.5
5.9
4.7
6.2
5.5
7.1
6.2
5.3
4.7
5.6
7.1
5.5
5.4
7.1
6.2
5.9
6.3
5.6
5.6
6.9
7.0
7.3
5.3
6.0
6.0

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.4
.25
3.3
.58
14
2.4
19
3.4
33
5.7
37
6.5
27
4.8
33
5.7
71
13
13
2.3
2.0
.35
40
7.0
.63
.11
2.2
.39
59
10
6.8
1.2
4.6
.80
11
2.0
28
5.0
18
3.2
39
6.8
119
21
99
17
6.0
1.1
13
2.3
40
6.9
46
8.0
150
26
40
7.0
.70
.12
4.1
.72
5.3
.93
11
2.0
251
44
777 136
.87
.15
7.6
1.3
16
2.7
143
25
7.9
1.4
109
19
.41
.07
35
6.2
823 144
3.7
.65
21
3.6
.98
.17
35
6.1
.87
.15
1.8
.32
2.7
.47
3.0
.52
8.5
1.5
8.6
1.5
5.0
.88
14
2.4
21
3.7
149
26
16
2.8
31
5.4
.88
.15
9.5
1.7
65
11
146
26
29
5.1
1.1
.20
34
6.0
37
6.5
1.2
.22
12
2.2
29
5.0
9.6
1.7
25
4.3
25
4.4
1.3
.22
1.1
.19
.20
.03
37
6.5
15
2.6
9.3
1.6

.70
.69
.41
.38
.39
.28
.38
.44
.21
.42
.70
.32
.87
.79
.27
.68
.67
.48
.30
.47
.32
.11
.17
.52
.55
.30
.31
.23
.33
.99
.92
.70
.61
.13
.08
1.1
.62
.51
.15
.64
.21
1.2
.34
.08
.89
.50
1.2
.38
1.1
.98
1.0
.88
.70
.80
.96
.39
.56
.24
.54
.49
1.3
.83
.35
.24
.57
1.5
.54
.52
1.6
.64
.41
.77
.63
.62
1.8
2.0
2.0
.56
.76
1.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

18
18
10
9.8
9.8
7.1
9.7
11
5.3
11
18
8.1
22
20
6.7
17
17
12
7.7
12
8.1
2.8
4.2
13
14
7.6
7.8
5.7
8.5
25
23
18
15
3.3
2.0
27
16
13
3.7
16
5.4
31
8.6
2.0
23
13
29
9.6
29
25
26
22
18
20
24
10
14
6.1
14
12
34
21
8.8
6.2
14
38
14
13
41
16
10
20
16
16
45
52
51
14
19
29

Lbs.

.99
2.3
5.5
7.4
13
10
10
14
15
5.4
1.4
13
.55
1.8
16
4.6
3.1
5.4
8.6
8.5
12
13
17
3.1
7.4
12
14
34
13
.69
3.8
3.7
6.9
33
62
.93
4.7
8.0
21
5.1
23
.50
12
64
3.3
10
1.1
13
.98
1.8
2.7
2.6
6.0
6.9
4.8
5.4
12
35
8.5
15
1.2
8.0
22
35
17
1.7
18
19
2.0
8.0
12
7.4
16
16
2.2
2.2
.40
21
11
10

ENDS: C - Closed

G - Ground
O - Open

4.4
10
25
33
56
46
46
64
66
24
6.2
56
2.4
7.9
69
21
14
24
38
38
55
59
74
14
33
53
62
151
59
3.1
17
17
31
146
276
4.1
21
35
94
23
103
2.2
53
284
15
46
5.1
59
4.4
8.0
12
12
27
31
21
24
53
158
38
66
5.2
35
99
158
74
7.6
82
86
8.8
35
53
33
70
69
9.9
9.7
1.8
94
50
46

Inches

.30
.31
.33
.40
.41
.45
.56
.45
.47
.38
.36
.52
.23
.30
.59
.29
.32
.38
.37
.65
.58
.28
.49
.29
.54
.47
.61
.59
.56
.26
.31
.40
.60
.70
.99
.22
.42
.57
.54
.29
.68
.17
.56
1.00
.52
.64
.31
.70
.22
.31
.50
.62
.59
.70
.58
.36
.80
1.26
.59
1.27
.55
.86
1.02
1.28
1.22
.43
1.26
1.28
.40
.65
.61
.72
1.33
1.22
.73
.66
.75
1.50
.99
1.35

mm

7.6
7.9
8.5
10.2
10.4
11.4
14.3
11.4
11.9
9.6
9.2
13.1
5.8
7.6
15.1
7.2
8.0
9.6
9.3
16.6
14.6
7.0
12.3
7.2
13.7
11.9
15.5
15.0
14.3
6.6
7.8
10.2
15.2
17.8
25.1
5.6
10.7
14.6
13.7
7.4
17.3
4.3
14.3
25.4
13.2
16.4
7.8
17.8
5.6
7.9
12.6
15.7
15.0
17.8
14.7
9.1
20.3
32.0
14.9
32.1
14.0
21.9
25.9
32.5
30.9
11.0
32.0
32.6
10.2
16.4
15.5
18.3
33.7
30.9
18.5
16.7
19.1
38.1
25.1
34.3

WIRE DIA.
Inches

0.023
0.027
0.037
0.040
0.043
0.045
0.045
0.045
0.052
0.036
0.026
0.048
0.019
0.025
0.054
0.030
0.030
0.036
0.043
0.045
0.050
0.050
0.054
0.030
0.040
0.047
0.051
0.062
0.049
0.020
0.028
0.032
0.040
0.070
0.090
0.020
0.035
0.041
0.060
0.031
0.062
0.016
0.047
0.091
0.031
0.046
0.022
0.050
0.020
0.025
0.030
0.031
0.038
0.039
0.034
0.036
0.047
0.072
0.042
0.055
0.025
0.041
0.060
0.072
0.054
0.024
0.056
0.057
0.024
0.041
0.047
0.040
0.053
0.054
0.028
0.026
0.020
0.060
0.046
0.045

mm

TOTAL
MATL
COILS

0.6
0.7
0.9
1.0
1.1
1.1
1.1
1.1
1.3
0.9
0.7
1.2
0.5
0.6
1.4
0.8
0.8
0.9
1.1
1.1
1.3
1.3
1.4
0.8
1.0
1.2
1.3
1.6
1.2
0.5
0.7
0.8
1.0
1.8
2.3
0.5
0.9
1.0
1.5
0.8
1.6
0.4
1.2
2.3
0.8
1.2
0.6
1.3
0.5
0.6
0.8
0.8
1.0
1.0
0.9
0.9
1.2
1.8
1.1
1.4
0.6
1.0
1.5
1.8
1.4
0.6
1.4
1.4
0.6
1.0
1.2
1.0
1.3
1.4
0.7
0.7
0.5
1.5
1.2
1.1

12.0
10.5
9.00
10.0
8.50
9.00
11.5
10.0
9.00
9.50
14.0
10.8
12.0
11.0
11.0
8.50
10.5
10.5
8.50
14.5
11.5
5.50
8.00
8.50
13.5
10.0
12.0
9.50
11.5
12.0
10.0
11.5
14.0
10.0
11.0
10.0
12.0
13.0
8.00
8.25
11.0
9.50
11.0
11.0
15.8
14.0
14.0
14.0
10.0
11.5
16.5
19.0
14.5
18.0
17.0
9.00
17.0
17.5
14.0
23.0
22.0
20.0
17.0
17.8
22.5
17.0
22.5
22.5
15.8
15.8
13.0
18.0
24.0
22.5
25.0
24.3
36.5
25.0
21.5
30.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
SST
SPR
MW
SPR
SPR
MW
SPR
SPR
MW
SPR
MW
MW
SST
MW
SST
HD
SST
SST
SST
SPR
HD
SST
SPR
SPR
SPR
MW
SPR
SST
MW
SST
SST
SPR
SPR
SST
SST
SPR
SST
MW
SST
MW
HD
SPR
MW
SST
MW
SPR
SST
SST
SST
MW
SST
SPR
SPR
SPR
SPR
HD
SPR
SPR
SST
SPR
SPR
HD
SPR
MW
SPR
SPR
MW
SPR
SPR
SPR
SPR
SST
SST
MW
SST
SST
SPR
SPR

E
N
D
S

C
C
CG
CG
C
C
C
CG
CG
C
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
C
CG
C
C
C
CG
C
C
CG
C
CG
CG
CG
C
C
CG
C
C
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
C
CG
C
C
C
CG
CG
CG

F
N
S
H

N
Z
N
Z
Z
Z
Z
N
Z
GI
N
GI
N
N
N
Z
N
N
N
N
N
Z
Z
N
N
Z
Z
Z
N
N
Z
N
N
N
GI
N
N
Z
N
Z
N
N
Z
Z
Z
N
Z
N
N
N
N
Z
N
Z
N
Z
Z
Z
GI
Z
N
Z
Z
Z
GI
Z
Z
GI
N
Z
Z
Z
Z
N
N
N
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 81

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.328
0.328
0.328
0.328
0.338
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343

8.33
8.33
8.33
8.33
8.59
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71

1934
S-3074
S-3099
K-54
12753
W-99
S-855
S-1324
U-95
PP-51
DD-77
GG-54
U-74
2731
B7-25
G-52
B-71
O-53
NN-40
B14-33
MM-76
V-55
A-5
I-28
1925
2950
A12-3
W-97
Q-98
11451
N-39
BB-56
2568
II-43
S-114
I-86
3453
MM-64
10882
MM-35
DD-30
G-93
BB-39
B17-145
L-89
H-88
A10-69
3509
Q-97
II-32
B-67
JJ-61
1655
10730
S-1040
S-3122
11342
K-71
KK-76
G-87
Q-30
A-60-A
MM-68
N-46
OO-94
S-3119
3814
S-1043
B2-11
L-78
11214
S-901
S-898
S-478
B2-64
B-68
RR-64
4114
K-89
B9-46

3.38
4.13
4.25
4.25
1.48
.16
.19
.25
.28
.28
.31
.31
.31
.31
.34
.34
.38
.38
.38
.38
.38
.38
.41
.41
.44
.44
.45
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.53
.53
.53
.53
.53
.56
.56
.56
.56
.56
.56
.56
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.66
.66
.69
.69
.69
.69
.69

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

85.7
104.8
108.0
108.0
37.7
4.0
4.8
6.4
7.1
7.1
7.9
7.9
7.9
7.9
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.3
11.1
11.1
11.5
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.0
16.7
16.7
16.7
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4

I.D.
Inches

.254
.274
.274
.258
.274
.295
.285
.273
.283
.243
.315
.295
.283
.275
.303
.261
.315
.293
.283
.277
.233
.231
.263
.245
.281
.275
.263
.275
.265
.305
.301
.295
.287
.283
.279
.275
.273
.263
.251
.243
.243
.235
.183
.313
.299
.293
.285
.283
.283
.279
.279
.259
.189
.309
.309
.301
.293
.291
.279
.261
.303
.293
.279
.273
.269
.261
.253
.247
.253
.267
.263
.261
.245
.241
.221
.291
.271
.263
.261
.261

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

6.5
7.0
7.0
6.6
7.0
7.5
7.2
6.9
7.2
6.2
8.0
7.5
7.2
7.0
7.7
6.6
8.0
7.4
7.2
7.0
5.9
5.9
6.7
6.2
7.1
7.0
6.7
7.0
6.7
7.7
7.6
7.5
7.3
7.2
7.1
7.0
6.9
6.7
6.4
6.2
6.2
6.0
4.6
8.0
7.6
7.4
7.2
7.2
7.2
7.1
7.1
6.6
4.8
7.8
7.8
7.6
7.4
7.4
7.1
6.6
7.7
7.4
7.1
6.9
6.8
6.6
6.4
6.3
6.4
6.8
6.7
6.6
6.2
6.1
5.6
7.4
6.9
6.7
6.6
6.6

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

4.3
.76
.80
.14
.63
.11
2.0
.34
5.3
.92
6.5
1.1
46
8.0
32
5.6
19
3.3
211
37
.31
.05
9.8
1.7
8.3
1.4
65
11
3.9
.68
49
8.6
.52
.09
7.6
1.3
19
3.3
13
2.4
192
34
212
37
33
5.8
130
23
22
3.8
33
5.7
48
8.4
19
3.4
16
2.8
2.4
.43
1.7
.29
4.3
.75
14
2.5
3.3
.58
13
2.3
19
3.3
25
4.3
23
4.0
89
16
84
15
79
14
110
19
1177 206
.25
.04
2.9
.51
8.7
1.5
5.3
.93
11
1.9
6.7
1.2
9.4
1.6
10
1.8
36
6.2
716 125
1.4
.24
1.0
.18
1.2
.21
3.3
.57
4.3
.76
14
2.5
37
6.5
1.1
.20
1.9
.34
8.7
1.5
18
3.2
23
4.1
37
6.4
45
7.8
57
10
24
4.2
18
3.1
22
3.9
21
3.7
58
10
66
12
197
35
3.7
.64
14
2.4
38
6.6
23
4.1
37
6.5

1.4
2.8
3.1
2.4
.74
.04
.06
.08
.16
.06
.20
.20
.10
.07
.27
.14
.29
.23
.23
.17
.07
.08
.19
.10
.22
.14
.15
.22
.10
.40
.36
.36
.26
.07
.27
.23
.20
.22
.17
.15
.15
.14
.04
.36
.39
.30
.31
.37
.29
.32
.28
.22
.06
.47
.46
.37
.39
.39
.27
.21
.45
.35
.40
.26
.23
.20
.23
.20
.14
.35
.30
.33
.21
.19
.16
.48
.37
.19
.31
.21

35
72
79
61
19
.91
1.5
1.9
4.1
1.4
5.1
5.2
2.6
1.8
6.8
3.5
7.4
5.8
5.7
4.3
1.8
2.0
4.7
2.5
5.7
3.6
3.8
5.7
2.5
10
9.2
9.0
6.5
1.7
6.8
5.8
5.0
5.6
4.2
3.8
3.8
3.4
.99
9.2
9.9
7.5
8.0
9.3
7.4
8.0
7.0
5.5
1.5
12
12
9.5
10
9.8
6.8
5.3
11
8.9
10
6.6
5.8
5.0
5.7
5.0
3.5
8.8
7.6
8.3
5.3
4.9
4.0
12
9.5
4.8
7.8
5.3

ENDS: C - Closed

G - Ground
O - Open

Lbs.

5.9
26
2.3
10
2.0
8.8
4.7
21
3.9
17
.23
1.0
2.7
12
2.4
11
3.1
14
12
53
.06
.28
2.0
8.9
.84
3.7
4.6
21
1.0
4.6
6.8
30
.15
.67
1.7
7.7
4.3
19
2.3
10
14
62
17
74
6.1
27
13
57
4.9
22
4.6
21
7.1
32
4.3
19
1.6
7.0
.98
4.4
.60
2.7
1.5
6.7
3.6
16
.21
.95
3.6
16
4.3
19
4.8
21
5.1
23
15
66
13
57
12
53
15
67
46
204
.09
.40
1.1
5.0
2.6
11
1.7
7.4
4.0
18
2.0
8.7
2.9
13
2.8
12
7.7
34
41
183
.65
2.9
.46
2.1
.45
2.0
1.3
5.7
1.7
7.5
3.9
17
7.6
34
.51
2.3
.68
3.0
3.5
16
4.8
21
5.3
24
7.2
32
10
45
11
50
3.3
15
6.1
27
6.7
30
7.0
31
12
54
13
56
31
139
1.8
7.8
5.2
23
7.1
32
7.2
32
7.6
34

Inches

1.05
.90
1.12
1.44
.42
.12
.08
.18
.12
.18
.11
.11
.21
.14
.08
.21
.08
.13
.15
.21
.30
.25
.22
.22
.16
.17
.23
.20
.37
.10
.14
.14
.14
.44
.20
.20
.21
.28
.22
.31
.30
.32
.38
.17
.14
.13
.22
.17
.24
.22
.26
.25
.44
.09
.10
.19
.17
.18
.21
.25
.18
.28
.22
.21
.20
.27
.36
.31
.50
.30
.29
.33
.34
.37
.40
.21
.29
.26
.31
.25

mm

Inches

26.5
23.0
28.5
36.4
10.6
3.0
1.9
4.4
3.0
4.4
2.8
2.7
5.3
3.5
1.9
5.2
2.1
3.2
3.8
5.2
7.7
6.4
5.6
5.6
3.9
4.3
5.8
5.2
9.4
2.5
3.5
3.7
3.6
11.0
5.1
5.2
5.3
7.1
5.6
7.9
7.6
8.2
9.7
4.3
3.6
3.2
5.5
4.2
6.1
5.5
6.5
6.4
11.3
2.4
2.6
4.8
4.3
4.5
5.3
6.2
4.6
7.0
5.7
5.3
5.2
6.8
9.1
7.9
12.6
7.7
7.4
8.3
8.7
9.4
10.1
5.3
7.3
6.6
7.8
6.2

0.037
0.027
0.027
0.035
0.032
0.024
0.029
0.035
0.030
0.050
0.014
0.024
0.030
0.034
0.020
0.041
0.014
0.025
0.030
0.033
0.055
0.056
0.040
0.049
0.031
0.034
0.040
0.034
0.039
0.019
0.021
0.024
0.028
0.030
0.032
0.034
0.035
0.040
0.046
0.050
0.050
0.054
0.080
0.015
0.022
0.025
0.029
0.030
0.030
0.032
0.032
0.042
0.077
0.017
0.017
0.021
0.025
0.026
0.032
0.041
0.020
0.025
0.032
0.035
0.037
0.041
0.045
0.048
0.045
0.038
0.040
0.041
0.049
0.051
0.061
0.026
0.036
0.040
0.041
0.041

mm

TOTAL
MATL
COILS

0.9
0.7
0.7
0.9
0.8
0.6
0.7
0.9
0.8
1.3
0.4
0.6
0.8
0.9
0.5
1.0
0.4
0.6
0.8
0.8
1.4
1.4
1.0
1.2
0.8
0.9
1.0
0.9
1.0
0.5
0.5
0.6
0.7
0.8
0.8
0.9
0.9
1.0
1.2
1.3
1.3
1.4
2.0
0.4
0.6
0.6
0.7
0.8
0.8
0.8
0.8
1.1
2.0
0.4
0.4
0.5
0.6
0.7
0.8
1.0
0.5
0.6
0.8
0.9
0.9
1.0
1.1
1.2
1.1
1.0
1.0
1.0
1.2
1.3
1.5
0.7
0.9
1.0
1.0
1.0

27.3
32.5
40.5
40.0
12.0
4.00
2.50
4.00
4.00
3.50
7.00
3.50
6.00
3.00
3.75
5.00
5.00
4.00
4.00
6.25
4.50
4.50
5.50
4.50
4.00
4.00
4.75
5.00
8.50
4.25
6.50
5.00
4.00
13.5
5.25
5.00
5.00
7.00
4.75
6.25
6.00
6.00
4.75
10.3
5.50
4.00
7.50
5.50
7.00
6.75
7.00
6.00
5.75
4.50
5.00
8.00
6.75
6.75
5.50
6.00
8.00
10.0
7.00
6.00
5.50
5.50
7.00
6.50
10.0
8.00
7.25
8.00
7.00
7.25
6.50
7.00
8.00
5.50
7.50
6.00

SPR
SST
SST
SST
SPR
SST
SST
SST
MW
SST
MW
MW
SST
SPR
MW
SPR
MW
SST
MW
SPR
SST
SST
SST
SPR
MW
SPR
SPR
SST
SST
MW
SST
SST
MW
MW
SST
SST
SPR
SST
MW
SPR
SST
SST
SPR
MW
MW
MW
SST
MW
SST
SST
HD
SST
SPR
MW
SST
SST
SST
MW
SPR
SPR
MW
SST
SST
SPR
SST
SST
SPR
SST
SST
SPR
SST
SST
SST
SST
MW
SST
SPR
SPR
SST
SPR

E
N
D
S

C
C
C
C
C
C
C
C
CG
CG
C
C
C
C
CG
CG
C
C
C
CG
C
CG
CG
CG
C
C
C
C
C
C
CG
C
C
C
C
C
C
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
C
CG
C
CG
CG
C
C
C
CG
CG
C
CG
C
C
CG
C
CG
C
C
CG
CL
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG

F
N
S
H

Z
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
Z
N
Z
N
N
N
N
N
Z
Z
N
N
N
N
N
N
Z
N
N
N
GI
N
N
Z
N
N
N
N
Z
N
N
Z
N
N
N
N
Z
N
N
N
N
N
N
Z
N
N
N
GI
N
N
Z
N
N
N
N
N
N
N
Z
N
Z
Z
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

81

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 82

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343

8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71

YY-59
B-86
10106
S-1094
S-1002
1527
S-309
PP-58
H-79
GG-98
A10-47
10804
S-1180
I-20
GG-70
CC-100
Z-57
B-100
B14-35
FF-69
S-3127
OO-36
10817
I-90
12641
A-92
KK-84
M-120
WW-49
XX-22
S-1232
3020
A-6
B5-17
A10-66
OO-59
S-3105
II-76
HH-25
S-3081
BB-72
L-77
Z-1
A15-39
Q-62
11398
B6-23
O-78
10064
3520
MM-95
MM-86
B12-25
H-82
2604
O-145
Z-4
U-37
JJ-86
L-69
PP-29
PP-28
L-13
3658
11469
11277
B4-13
B-94
3639
S-1163
1
S-313
10375
B-14
K-22
2786
K-14
S-268
S-3097
Q-5

.69
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.81
.81
.81
.81
.81
.81
.81
.81
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.94
.94
.94
.94
.94
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

17.4
18.2
18.3
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.0
23.8
23.8
23.8
23.8
23.8
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2

MATERIAL: MW - Music Wire

82

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.241
.299
.263
.317
.303
.297
.293
.287
.283
.275
.269
.267
.267
.257
.243
.239
.229
.227
.223
.223
.219
.303
.275
.255
.241
.311
.287
.277
.277
.277
.273
.235
.223
.279
.219
.311
.303
.303
.293
.293
.293
.285
.283
.281
.273
.269
.269
.269
.261
.243
.203
.199
.191
.261
.249
.245
.293
.273
.259
.247
.203
.263
.249
.305
.303
.285
.283
.279
.267
.267
.261
.261
.255
.253
.247
.241
.231
.225
.173
.295

RATE
mm

6.1
7.6
6.7
8.1
7.7
7.5
7.4
7.3
7.2
7.0
6.8
6.8
6.8
6.5
6.2
6.1
5.8
5.8
5.7
5.7
5.6
7.7
7.0
6.5
6.1
7.9
7.3
7.0
7.0
7.0
6.9
6.0
5.7
7.1
5.6
7.9
7.7
7.7
7.4
7.4
7.4
7.2
7.2
7.1
6.9
6.8
6.8
6.8
6.6
6.2
5.2
5.1
4.9
6.6
6.3
6.2
7.4
6.9
6.6
6.3
5.2
6.7
6.3
7.7
7.7
7.2
7.2
7.1
6.8
6.8
5.5
6.6
6.5
6.4
6.3
6.1
5.9
5.7
4.4
7.5

Lbs./In.

130
2.2
33
.14
1.5
2.7
3.6
6.1
8.3
9.4
17
18
15
29
79
62
100
108
117
113
145
1.5
14
33
49
.60
2.9
17
17
7.6
12
84
137
13
160
.29
.79
.34
3.9
3.8
2.4
4.4
6.0
7.8
7.6
12
16
16
20
65
242
307
315
11
39
59
2.5
11
21
42
201
20
34
.79
1.4
3.8
5.4
7.7
15
9.7
17.9
13
22
26
37
39
66
94
543
1.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

23
.39
5.8
.02
.26
.48
.63
1.1
1.4
1.7
2.9
3.1
2.7
5.0
14
11
17
19
21
20
25
.27
2.5
5.7
8.5
.10
.51
2.9
2.9
1.3
2.0
15
24
2.2
28
.05
.14
.06
.68
.66
.43
.77
1.1
1.4
1.3
2.1
2.9
2.7
3.4
11
42
54
55
1.8
6.8
10
.44
1.9
3.6
7.4
35
3.6
5.9
.14
.24
.66
.95
1.4
2.6
1.7
3.1
2.2
3.9
4.5
6.5
6.8
12
17
95
.26

.10
.56
.21
.62
.61
.58
.48
.39
.36
.44
.34
.35
.37
.29
.15
.22
.19
.18
.18
.19
.15
.63
.44
.27
.26
.69
.49
.24
.24
.47
.39
.19
.16
.31
.15
.70
.67
.42
.67
.46
.67
.60
.49
.42
.51
.44
.34
.36
.39
.27
.13
.10
.12
.21
.41
.22
.69
.42
.40
.28
.15
.35
.34
.81
.84
.66
.73
.50
.56
.53
.58
.47
.42
.36
.33
.34
.27
.20
.09
.74

mm

2.6
14
5.5
16
15
15
12
10
9.1
11
8.7
8.8
9.5
7.3
3.8
5.5
4.7
4.6
4.7
4.8
3.9
16
11
6.9
6.6
18
12
6.0
6.0
12
9.8
4.8
4.0
7.8
3.8
18
17
11
17
12
17
15
13
11
13
11
8.7
9.2
9.9
6.9
3.3
2.7
2.9
5.3
10
5.5
17
11
10
7.2
3.8
8.9
8.6
21
21
17
19
13
14
13
11
12
11
9.2
8.3
8.8
6.7
5.2
2.4
19

Lbs.

13
1.2
7.1
.09
.91
1.6
1.7
2.4
3.0
4.2
5.7
6.1
5.7
8.2
12
13
19
20
22
22
22
.96
6.4
8.8
13
.41
1.4
3.9
3.9
3.6
4.5
16
22
3.9
24
.20
.53
.14
2.6
1.7
1.6
2.6
3.0
3.3
3.8
5.3
5.7
5.7
7.6
18
32
32
36
2.2
16
13
1.7
4.5
8.2
12
30
7.1
11
.64
1.1
2.5
4.0
3.9
8.5
5.1
7.6
6.0
9.4
9.4
12
13
18
19
51
1.1

ENDS: C - Closed

G - Ground
O - Open

60
5.5
32
.39
4.0
7.0
7.7
11
13
19
25
27
25
37
53
60
83
87
96
96
99
4.3
29
39
56
1.8
6.3
17
17
16
20
71
96
17
105
.91
2.3
.63
11
7.7
7.2
12
13
15
17
24
25
25
34
79
141
143
161
9.8
70
57
7.6
20
36
54
132
32
51
2.8
5.1
11
18
17
38
23
39
27
42
42
54
60
78
86
225
4.9

Inches

.26
.15
.28
.13
.14
.17
.18
.17
.18
.31
.28
.30
.34
.32
.30
.42
.48
.49
.54
.56
.48
.15
.22
.33
.46
.12
.32
.20
.20
.35
.26
.49
.48
.22
.50
.18
.21
.46
.19
.18
.21
.28
.26
.22
.37
.37
.28
.33
.39
.38
.63
.54
.76
.70
.42
.37
.25
.28
.46
.48
.67
.34
.52
.19
.16
.34
.27
.27
.38
.48
.46
.53
.53
.43
.48
.61
.62
.53
.77
.29

mm

6.5
3.9
7.1
3.3
3.6
4.4
4.6
4.3
4.6
7.8
7.2
7.7
8.7
8.2
7.6
10.6
12.3
12.5
13.7
14.1
12.2
3.8
5.6
8.4
11.7
3.0
8.2
5.0
5.0
8.8
6.7
12.3
12.2
5.7
12.6
4.5
5.3
11.7
4.8
4.4
5.2
7.0
6.5
5.5
9.3
9.4
7.2
8.5
9.9
9.5
16.0
13.7
19.3
17.7
10.7
9.3
6.4
7.1
11.7
12.2
16.9
8.6
13.1
4.8
4.1
8.7
6.9
6.9
9.7
12.1
11.7
13.5
13.4
10.9
12.2
15.5
15.6
13.5
19.4
7.3

WIRE DIA.
Inches

0.051
0.022
0.040
0.013
0.020
0.023
0.025
0.028
0.030
0.034
0.037
0.038
0.038
0.043
0.050
0.052
0.057
0.058
0.060
0.060
0.062
0.020
0.034
0.044
0.051
0.016
0.028
0.033
0.033
0.033
0.035
0.054
0.060
0.032
0.062
0.016
0.020
0.020
0.025
0.025
0.025
0.029
0.030
0.031
0.035
0.037
0.037
0.037
0.041
0.050
0.070
0.072
0.076
0.041
0.047
0.049
0.025
0.035
0.042
0.048
0.070
0.040
0.047
0.019
0.020
0.029
0.030
0.032
0.038
0.038
0.041
0.041
0.044
0.045
0.048
0.051
0.056
0.059
0.085
0.024

mm

TOTAL
MATL
COILS

1.3
0.6
1.0
0.3
0.5
0.6
0.6
0.7
0.8
0.9
0.9
1.0
1.0
1.1
1.3
1.3
1.4
1.5
1.5
1.5
1.6
0.5
0.9
1.1
1.3
0.4
0.7
0.8
0.8
0.8
0.9
1.4
1.5
0.8
1.6
0.4
0.5
0.5
0.6
0.6
0.6
0.7
0.8
0.8
0.9
0.9
0.9
0.9
1.0
1.3
1.8
1.8
1.9
1.0
1.2
1.2
0.6
0.9
1.1
1.2
1.8
1.0
1.2
0.5
0.5
0.7
0.8
0.8
1.0
1.0
1.0
1.0
1.1
1.1
1.2
1.3
1.4
1.5
2.2
0.6

5.00
6.00
6.00
9.00
6.00
6.50
6.25
6.00
6.00
8.00
7.75
8.00
8.00
7.50
6.00
8.00
8.50
8.50
9.00
9.25
7.75
6.50
6.50
7.50
9.00
6.50
10.5
5.00
5.00
9.50
7.50
8.00
8.00
6.00
8.00
10.0
9.50
22.0
6.50
6.00
8.25
9.50
7.50
7.00
10.5
9.00
7.70
8.00
9.50
7.50
9.00
7.50
10.0
16.0
9.00
7.50
9.00
8.00
10.0
9.00
9.50
8.50
10.0
9.00
7.00
10.8
9.00
8.50
9.00
11.5
10.3
12.0
11.0
9.50
10.0
12.0
11.0
9.00
9.00
12.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SPR
SST
SST
MW
SST
SST
SST
SST
SPR
SPR
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SST
MW
MW
SST
SST
MW
SST
SST
SST
SPR
SST
HD
HD
SPR
SPR
SST
SST
MW
MW
SST
SST
MW
SST
SST
SST
SST
SPR
SPR
SPR
MW
SPR
SST
SPR
SPR
MW
SPR
MW
SST
SPR
SPR
SST
SPR
SPR
MW
MW
MW
MW
HD
MW
SST
HD
SST
SPR
SST
SPR
SPR
SPR
SST
SST
MW

E
N
D
S

F
N
S
H

CG
C
C
C
C
C
C
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
C
C
CG
C
CG
C
CG
C
C
C
C
C
CG
CG
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
CG
C
C
CG
CG
C
C
C
C
CG
CG
C
C
C
C
C
CG
CG
CG
CG
CG
CG
CG

Z
N
N
N
N
Z
N
N
N
N
N
BO
N
N
N
N
Z
N
N
Z
N
N
Z
N
N
N
N
N
N
GI
N
Z
Z
N
Z
N
N
N
N
N
N
GI
N
N
N
N
N
GI
Z
Z
N
N
N
Z
Z
N
N
N
Z
Z
N
Z
Z
GI
N
N
N
Z
Z
N
Z
N
Z
N
N
Z
GI
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 83

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343
0.343

8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71
8.71

PP-25
S-1056
S-1456
A14-6
S-1695
S-1347
L-53
4202
I-21
CC-85
OO-70
M-76
S-1057
10387
10273
W-11
S-1223
12499
11256
CC-7
11257
B2-40
3842
3505
B9-23
L-44
3884
3457
L-32
2594
10519
S-3101
1951
12630
3890
UU-47
5
S-879
11453
B2-53
12405
11546
10188
QQ-36
S-1099
A15-36
S-210
S-452
S-15
HH-58
KK-73
S-1384
S-1492
2933
2683
11199
1819
B14-27
M-10
A-76
CC-71
3442
11466
V V-30
10437
11722
Q-38
S-225
3691
10868
B15-49
J-29
LL-29
3896
11880
QQ-52
10105
1723
S-434
4113

1.03
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.06
1.13
1.13
1.13
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.31
1.38
1.38
1.38
1.44
1.44
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.53
1.56
1.56
1.56
1.56
1.59
1.63
1.63
1.63
1.63
1.75
1.81
1.81
1.91
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.13
2.13
2.16
2.16
2.25
2.28
2.34
2.44
2.50
2.50
2.53
2.63
3.00
3.00
3.13
3.13
4.13
4.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

26.2
27.0
27.0
27.0
27.0
27.0
27.0
27.0
27.0
27.0
28.6
28.6
28.6
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
33.3
34.9
34.9
34.9
36.5
36.5
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.9
38.9
39.7
39.7
39.7
39.7
40.5
41.3
41.3
41.3
41.3
44.5
46.0
46.0
48.4
50.8
50.8
50.8
50.8
50.8
50.8
50.8
54.0
54.0
54.8
54.8
57.2
57.9
59.5
61.9
63.5
63.5
64.3
66.7
76.2
76.2
79.4
79.4
104.8
120.7

I.D.
Inches

.283
.291
.281
.277
.273
.269
.263
.253
.253
.235
.283
.273
.267
.299
.219
.273
.279
.275
.273
.259
.259
.255
.159
.273
.257
.295
.289
.279
.293
.249
.259
.293
.283
.283
.273
.269
.249
.249
.219
.213
.311
.257
.303
.271
.247
.241
.287
.303
.273
.263
.243
.303
.247
.227
.227
.293
.279
.275
.271
.263
.263
.209
.293
.249
.293
.289
.291
.191
.289
.243
.297
.257
.263
.239
.291
.253
.289
.279
.253
.281

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

7.2
7.4
7.1
7.0
6.9
6.8
6.7
6.4
6.4
6.0
7.2
6.9
6.8
7.6
5.6
6.9
7.1
7.0
6.9
6.6
6.6
6.5
4.0
6.9
6.5
7.5
7.3
7.1
7.4
6.3
6.6
7.4
7.2
7.2
6.9
6.8
6.3
6.3
5.6
5.4
7.9
6.5
7.7
6.9
6.3
6.1
7.3
7.7
6.9
6.7
6.2
7.7
6.3
5.8
5.8
7.4
7.1
7.0
6.9
6.7
6.7
5.3
7.4
6.3
7.4
7.3
7.4
4.9
7.3
6.2
7.5
6.5
6.7
6.1
7.4
6.4
7.3
7.1
6.4
7.1

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

4.2
.74
2.2
.39
4.2
.74
6.8
1.2
11
1.9
8.6
1.5
19
3.3
25
4.3
17
2.9
72
13
4.2
.74
9.2
1.6
10
1.8
1.3
.22
128
22
7.1
1.2
4.4
.76
8.7
1.5
11
2.0
15
2.6
18
3.2
23
4.0
724 127
7.4
1.3
16
2.8
1.6
.28
2.2
.39
7.7
1.4
1.4
.24
27
4.7
14
2.4
1.4
.25
3.5
.60
3.8
.66
7.0
1.2
6.3
1.1
23
3.9
19
3.3
113
20
96
17
.35
.06
17
3.0
.49
.09
5.6
.97
18
3.1
23
4.0
1.6
.27
.20
.04
6.4
1.1
9.4
1.7
27
4.7
.46
.08
14
2.5
40
7.0
50
8.8
.70
.12
3.1
.55
4.3
.76
4.4
.77
7.8
1.4
9.4
1.7
73
13
.69
.12
15
2.6
.78
.14
2.2
.39
.87
.15
128
22
1.6
.28
22
3.9
.61
.11
8.3
1.4
5.5
.97
18
3.2
.76
.13
6.9
1.2
.73
.13
2.3
.40
6.8
1.2
1.6
.27

.67
.78
.72
.58
.42
.62
.38
.41
.40
.22
.71
.52
.56
.97
.19
.63
.82
.49
.59
.55
.42
.39
.09
.83
.55
1.0
1.0
.70
1.0
.42
.59
1.2
1.1
1.1
.68
.83
.50
.57
.21
.28
1.4
.51
1.2
.91
.64
.55
1.1
.98
.70
.75
.47
1.4
.79
.49
.39
1.3
1.4
1.1
1.2
.91
.75
.41
1.5
.76
1.5
1.5
1.6
.29
1.9
.57
2.0
1.1
1.3
.79
2.3
1.4
2.2
1.7
1.4
3.1

mm

17
20
18
15
11
16
9.6
10
10
5.6
18
13
14
25
4.7
16
21
13
15
14
11
9.9
2.2
21
14
26
25
18
27
11
15
29
27
28
17
21
13
15
5.3
7.2
35
13
31
23
16
14
27
25
18
19
12
36
20
12
9.9
33
35
27
30
23
19
10
38
19
39
37
39
7.4
47
14
50
27
33
20
58
34
55
43
35
79

ENDS: C - Closed

G - Ground
O - Open

Lbs.

2.8
1.7
3.0
3.9
4.5
5.3
7.1
10
6.7
16
3.0
4.8
5.7
1.2
24
4.5
3.6
4.3
6.6
8.2
7.7
8.8
64
6.1
8.8
1.6
2.2
5.4
1.4
11
8.2
1.6
3.7
4.2
4.8
5.2
11
11
24
27
.47
8.8
.60
5.1
11
13
1.7
.20
4.5
7.1
13
.65
11
20
20
.91
4.4
4.6
5.2
7.1
7.1
29
1.0
11
1.2
3.2
1.3
37
3.0
13
1.2
8.8
7.1
14
1.8
9.4
1.6
3.9
9.4
4.9

13
7.7
14
17
20
24
32
45
30
71
13
21
25
5.5
105
20
16
19
30
36
34
39
285
27
39
7.2
9.8
24
6.4
51
36
7.3
17
19
21
23
51
47
105
120
2.1
39
2.7
23
50
56
7.4
.87
20
32
57
2.9
50
87
87
4.0
19
21
23
32
32
131
4.6
51
5.2
14
6.0
166
13
57
5.4
39
32
63
7.8
42
7.0
17
42
22

Inches

.36
.29
.34
.31
.32
.43
.36
.54
.66
.49
.30
.35
.42
.22
.59
.39
.42
.32
.33
.55
.46
.47
1.01
.46
.62
.26
.38
.30
.39
.56
.62
.34
.42
.39
.47
.67
.71
.69
.65
.94
.17
.58
.34
.65
.79
.87
.53
.65
.46
.64
.76
.32
.96
1.13
.93
.70
.61
.61
.79
.76
.68
1.41
.64
.94
.64
.38
.70
1.48
.49
.95
.53
1.03
1.04
1.38
.70
1.40
.97
.80
1.41
.96

mm

Inches

9.1
7.3
8.7
8.0
8.0
10.8
9.1
13.7
16.9
12.3
7.6
8.9
10.6
5.6
15.0
9.8
10.6
8.2
8.4
13.9
11.7
12.0
25.7
11.6
15.8
6.7
9.6
7.7
9.9
14.3
15.7
8.7
10.7
9.9
12.0
16.9
17.9
17.5
16.5
24.0
4.4
14.7
8.6
16.5
20.1
22.0
13.5
16.5
11.6
16.3
19.4
8.1
24.4
28.7
23.6
17.8
15.4
15.5
20.1
19.3
17.3
35.7
16.2
23.9
16.2
9.6
17.7
37.6
12.3
24.1
13.4
26.2
26.4
35.0
17.8
35.4
24.7
20.3
35.9
24.4

0.030
0.026
0.031
0.033
0.035
0.037
0.040
0.045
0.045
0.054
0.030
0.035
0.038
0.022
0.062
0.035
0.032
0.034
0.035
0.042
0.042
0.044
0.092
0.035
0.043
0.024
0.027
0.032
0.025
0.047
0.042
0.025
0.030
0.030
0.035
0.037
0.047
0.047
0.062
0.065
0.016
0.043
0.020
0.036
0.048
0.051
0.028
0.020
0.035
0.040
0.050
0.020
0.048
0.058
0.058
0.025
0.032
0.034
0.036
0.040
0.040
0.067
0.025
0.047
0.025
0.027
0.026
0.076
0.027
0.050
0.023
0.043
0.040
0.052
0.026
0.045
0.027
0.032
0.045
0.031

mm

TOTAL
MATL
COILS

0.8
0.7
0.8
0.8
0.9
0.9
1.0
1.1
1.1
1.4
0.8
0.9
1.0
0.6
1.6
0.9
0.8
0.9
0.9
1.1
1.1
1.1
2.3
0.9
1.1
0.6
0.7
0.8
0.6
1.2
1.1
0.6
0.8
0.8
0.9
0.9
1.2
1.2
1.6
1.7
0.4
1.1
0.5
0.9
1.2
1.3
0.7
0.5
0.9
1.0
1.3
0.5
1.2
1.5
1.5
0.6
0.8
0.9
0.9
1.0
1.0
1.7
0.6
1.2
0.6
0.7
0.7
1.9
0.7
1.3
0.6
1.1
1.0
1.3
0.7
1.1
0.7
0.8
1.1
0.8

11.0
10.0
11.0
9.50
8.00
11.5
9.00
11.0
13.8
9.00
10.0
10.0
11.0
10.0
9.50
11.0
12.0
8.50
8.50
13.0
10.0
9.75
11.0
12.0
13.5
10.0
13.0
8.50
14.6
12.0
13.8
12.8
13.0
12.0
12.5
17.0
14.0
14.8
10.5
14.5
9.75
12.5
16.0
17.0
16.5
17.0
18.0
31.5
12.0
16.0
15.3
15.0
20.0
19.5
16.0
27.0
18.0
17.0
21.0
19.0
16.0
21.0
24.5
20.0
24.5
13.0
25.8
19.5
17.0
18.0
22.0
24.0
26.0
25.5
26.0
30.0
35.0
24.0
30.3
30.0

MW
SST
SST
SST
SST
SST
SPR
SPR
SST
SPR
SST
SPR
SST
MW
SPR
SST
SST
SST
MW
SPR
SST
SST
SPR
MW
SPR
SST
MW
MW
MW
HD
SPR
SST
MW
MW
SPR
SPR
HD
SST
HD
SPR
MW
SPR
MW
SPR
SST
SST
SST
SST
SST
SPR
SPR
SST
SST
SPR
SPR
MW
MW
SPR
SPR
SPR
SPR
SPR
SST
HD
MW
MW
MW
SST
MW
SPR
MW
SPR
SPR
SPR
SST
SST
MW
SPR
SST
MW

E
N
D
S

F
N
S
H

C
C
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
C
C
CG
C
C
C
C
C
C
CG
C
C
C
C
C
C
C
CG
CG
CG
C
CG
C
C
CG
CG
C
C
C
CG
CG
C
CG
CG
CG
C
C
C
C
CG
C
CG
C
CG
C
C
C
CG
C
C
C
CG
CG
C
C
C
C
C
C
C

Z
N
N
N
N
N
Z
Z
N
Z
N
N
N
Z
Z
N
N
N
Z
GI
N
N
GI
Z
N
N
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
Z
N
N
N
N
N
N
Z
N
N
Z
Z
Z
Z
Z
N
Z
N
Z
N
N
Z
Z
N
N
Z
BO
N
Z
N
Z
N
N
Z
N
N
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

83

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 84

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.343
0.343
0.343
0.350
0.350
0.350
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

8.71
8.71
8.71
8.89
8.89
8.89
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

B8-55
10546
1912
B4-63
12705
12752
MM-63
2899
I-27
L-66
I-53
AA-93
PP-39
HH-45
B1-1
10849
G-54
M-142
2502
71064
71064S
NN-35
TT-33
J-14
LL-67
G-51
K-87
10956
II-83
G-45
I-15
FF-41
S-1505
S-1100
AA-95
JJ-56
71027
71027S
71046
71046S
71065
71065S
71083
71083S
71101
71101S
71119
71119S
71137
71137S
71155
71155S
71174
71174S
71196
71196S
71218
71218S
71240
71240S
71262
71262S
M-71
EE-72
A10-31
S-133
LL-6
A-52
10076
71028
71028S
1627
A15-13
71047
71047S
10073
3571
71066
71066S
71084

4.88
5.25
5.75
.62
1.30
1.87
.25
.25
.25
.25
.25
.25
.34
.34
.38
.38
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.41
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

123.8
133.4
146.1
15.8
32.9
47.5
6.4
6.4
6.4
6.4
6.4
6.4
8.7
8.7
9.5
9.5
9.5
9.5
9.5
9.7
9.7
10.3
10.3
10.3
10.3
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.2
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7

MATERIAL: MW - Music Wire

84

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.247
.243
.263
.286
.260
.308
.340
.330
.296
.284
.280
.266
.320
.300
.314
.296
.292
.286
.256
.296
.296
.300
.288
.278
.270
.250
.222
.314
.298
.282
.280
.276
.266
.262
.262
.250
.308
.308
.302
.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.286
.276
.244
.234
.320
.310
.308
.308
.308
.306
.306
.302
.302
.298
.296
.296
.296
.290

RATE
mm

6.3
6.2
6.7
7.3
6.6
7.8
8.6
8.4
7.5
7.2
7.1
6.8
8.1
7.6
8.0
7.5
7.4
7.3
6.5
7.5
7.5
7.6
7.3
7.1
6.9
6.4
5.6
8.0
7.6
7.2
7.1
7.0
6.8
6.7
6.7
6.4
7.8
7.8
7.7
7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.3
7.0
6.2
5.9
8.1
7.9
7.8
7.8
7.8
7.8
7.8
7.7
7.7
7.6
7.5
7.5
7.5
7.4

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

8.4
1.5
8.5
1.5
2.5
.44
4.3
.75
24
4.2
.49
.09
.07
.01
.60
.10
43
7.5
91
16
99
17
201
35
1.3
.23
13
2.3
3.5
.62
25
4.3
28
4.9
40
7.1
182
32
25
4.4
21
3.7
7.1
1.2
19
3.3
32
5.5
84
15
187
33
594 104
4.7
.83
5.5
.95
41
7.1
45
7.9
47
8.2
67
12
60
11
93
16
187
33
10
1.8
8.7
1.5
15
2.6
12
2.2
21
3.6
18
3.1
28
4.9
24
4.2
38
6.6
32
5.6
45
7.9
38
6.7
57
10
48
8.5
77
13
65
11
93
16
79
14
109
19
93
16
127
22
108
19
175
31
149
26
238
42
202
35
27
4.7
56
9.8
93
16
258
45
1.0
.17
7.5
1.3
8.9
1.6
9.1
1.6
7.7
1.4
10
1.8
9.3
1.6
13
2.2
11
1.9
13
2.2
17
3.0
18
3.1
15
2.7
24
4.2

1.4
1.5
2.8
.21
.38
1.5
.18
.16
.09
.06
.06
.05
.22
.21
.24
.21
.16
.13
.10
.20
.16
.23
.16
.12
.11
.09
.05
.32
.16
.16
.15
.17
.15
.14
.13
.09
.27
.21
.26
.21
.25
.19
.23
.18
.21
.17
.21
.17
.19
.15
.17
.14
.16
.13
.16
.12
.14
.11
.13
.10
.11
.09
.20
.14
.15
.09
.34
.33
.31
.30
.24
.30
.22
.31
.24
.31
.30
.29
.22
.26

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

37
38
72
5.2
9.7
37
4.6
4.1
2.2
1.6
1.6
1.3
5.7
5.3
6.0
5.3
4.0
3.4
2.6
5.2
4.1
5.7
4.1
3.0
2.7
2.2
1.3
8.1
4.0
3.9
3.8
4.3
3.9
3.7
3.4
2.2
6.9
5.4
6.7
5.2
6.3
4.9
5.7
4.6
5.4
4.3
5.3
4.2
4.8
3.8
4.4
3.5
4.1
3.3
4.0
3.2
3.6
2.9
3.2
2.6
2.9
2.3
5.1
3.5
3.8
2.2
8.5
8.3
7.9
7.7
6.1
7.5
5.7
7.7
6.1
8.0
7.5
7.2
5.7
6.7

Lbs.

12
54
13
57
7.1
32
.88
3.9
9.2
41
.72
3.2
.01
.06
.10
.42
3.7
16
5.8
26
6.4
28
10
45
.29
1.3
2.7
12
.84
3.7
5.1
23
4.4
20
5.4
24
19
84
5.1
23
3.4
15
1.6
7.1
3.1
14
3.8
17
9.0
40
16
71
31
137
1.5
6.6
.87
3.9
6.3
28
6.8
30
7.8
35
10
45
8.7
39
12
55
16
71
2.8
12
1.9
8.3
3.8
17
2.6
11
5.1
23
3.4
15
6.3
28
4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33
13
59
9.0
40
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
5.4
24
7.8
35
14
61
22
99
.33
1.5
2.5
11
2.8
12
2.8
12
1.9
8.3
3.1
14
2.1
9.2
3.8
17
2.6
11
3.9
18
5.1
23
5.1
23
3.4
15
6.3
28

ENDS: C - Closed

G - Ground
O - Open

Inches

1.85
2.25
2.23
.42
.47
.40
.07
.09
.13
.11
.16
.14
.12
.14
.14
.12
.17
.19
.21
.12
.12
.18
.24
.29
.18
.25
.29
.12
.28
.21
.18
.21
.24
.29
.25
.30
.10
.10
.11
.11
.13
.13
.15
.15
.17
.17
.18
.18
.19
.19
.20
.20
.21
.21
.22
.22
.24
.24
.25
.25
.27
.27
.19
.19
.32
.32
.17
.13
.10
.10
.10
.14
.11
.12
.12
.19
.18
.14
.14
.16

mm

46.9
57.2
56.6
10.6
12.0
10.1
1.8
2.3
3.3
2.9
4.1
3.6
3.0
3.4
3.5
3.0
4.3
4.7
5.3
3.0
3.0
4.6
6.2
7.3
4.6
6.3
7.4
3.1
7.1
5.4
4.6
5.3
6.0
7.5
6.2
7.7
2.5
2.5
2.9
2.9
3.3
3.3
3.8
3.8
4.2
4.2
4.6
4.6
4.8
4.8
5.1
5.1
5.4
5.4
5.6
5.6
6.0
6.0
6.5
6.5
6.9
6.9
4.7
4.8
8.1
8.0
4.2
3.2
2.6
2.6
2.6
3.4
2.7
3.1
3.1
4.7
4.5
3.6
3.6
4.1

WIRE DIA.
Inches

0.048
0.050
0.040
0.032
0.045
0.021
0.010
0.015
0.032
0.038
0.040
0.047
0.020
0.030
0.023
0.032
0.034
0.037
0.052
0.032
0.032
0.030
0.036
0.041
0.045
0.055
0.069
0.023
0.031
0.039
0.040
0.042
0.047
0.049
0.049
0.055
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.037
0.042
0.058
0.063
0.020
0.025
0.026
0.026
0.026
0.027
0.027
0.029
0.029
0.031
0.032
0.032
0.032
0.035

mm

TOTAL
MATL
COILS

1.2
1.3
1.0
0.8
1.1
0.5
0.3
0.4
0.8
1.0
1.0
1.2
0.5
0.8
0.6
0.8
0.9
0.9
1.3
0.8
0.8
0.8
0.9
1.0
1.1
1.4
1.8
0.6
0.8
1.0
1.0
1.1
1.2
1.2
1.2
1.4
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.9
1.1
1.5
1.6
0.5
0.6
0.7
0.7
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.8
0.9

37.5
44.0
54.8
13.0
9.50
18.0
6.00
5.00
3.00
3.00
3.00
3.00
6.00
4.50
5.00
3.75
4.00
4.00
4.00
3.75
3.75
6.00
5.75
6.00
4.00
4.50
4.25
4.25
8.00
4.50
4.50
5.00
5.00
6.00
5.00
4.50
3.75
3.75
3.88
3.88
4.00
4.00
4.25
4.25
4.38
4.38
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.63
4.63
4.63
4.63
4.63
4.63
5.00
4.50
5.50
5.00
7.25
4.00
4.00
4.00
4.00
4.00
4.00
4.25
4.25
5.00
4.50
4.38
4.38
4.63

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
MW
SST
MW
SST
MW
HD
SPR
SST
SST
SST
MW
MW
MW
SPR
SPR
MW
MW
SST
SST
SPR
SPR
SST
SPR
SPR
MW
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
PB
SST
SST
MW
MW
MW
SST
MW
SST
MW
SST
MW
MW
MW
SST
MW

E
N
D
S

F
N
S
H

C
C
C
CG
C
C
C
C
C
CG
C
CG
CG
CG
C
CG
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG

Z
Z
GI
BO
N
N
N
Z
N
Z
N
N
N
Z
Z
Z
N
N
Z
N
N
N
Z
Z
N
Z
Z
N
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
Z
Z
N
N
Z
N
N
N
Z
Z
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 85

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

71084S
10122
K-79
71102
71102S
71120
71120S
A10-7
WW-67
B12-23
B-45
71138
71138S
L-70
71156
71156S
AA-96
71175
71175S
A13-16
71197
71197S
71219
71219S
71241
71241S
71263
71263S
3656
B5-10
M-82
A13-20
A13-14
Y-14
KK-89
12622
S-26
12646
71029
71029S
71048
71048S
71067
71067S
71085
71085S
71103
71103S
71121
71121S
71139
71139S
71157
71157S
71176
71176S
71198
71198S
71220
71220S
71242
71242S
71264
71264S
U-97
B18-132
10486
10029
HH-96
B4-68
3247
A14-48
A11-54
BB-17
KK-47
N-88
A12-5
G-65
S-923
3859

.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.53
.53
.53
.55
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.59
.63
.63
.63
.63

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.9
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.2
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9

I.D.
Inches

.290
.285
.284
.284
.284
.280
.280
.278
.278
.278
.276
.276
.276
.270
.270
.270
.266
.266
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.200
.318
.300
.294
.268
.264
.260
.260
.258
.294
.308
.308
.302
.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.332
.312
.294
.284
.284
.274
.234
.316
.276
.266
.264
.180
.322
.318
.312
.310

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

7.4
7.2
7.2
7.2
7.2
7.1
7.1
7.1
7.1
7.1
7.0
7.0
7.0
6.9
6.9
6.9
6.8
6.8
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
5.1
8.1
7.6
7.5
6.8
6.7
6.6
6.6
6.6
7.5
7.8
7.8
7.7
7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
8.4
7.9
7.5
7.2
7.2
7.0
5.9
8.0
7.0
6.8
6.7
4.6
8.2
8.1
7.9
7.9

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

20
3.6
27
4.7
32
5.5
33
5.8
28
4.9
39
6.8
33
5.8
37
6.5
28
4.9
42
7.4
35
6.1
47
8.3
40
7.0
56
9.9
65
11
56
9.7
66
12
79
14
67
12
77
13
92
16
78
14
108
19
92
16
148
26
126
22
201
35
171
30
1084 190
3.6
.63
7.3
1.3
15
2.5
56
9.8
113
20
101
18
101
18
74
13
9.4
1.6
8.1
1.4
6.9
1.2
11
1.9
9.4
1.6
16
2.8
14
2.4
21
3.7
18
3.1
28
5.0
24
4.2
34
5.9
29
5.0
42
7.3
35
6.2
56
9.7
47
8.3
69
12
58
10
80
14
68
12
94
16
80
14
128
22
109
19
173
30
147
26
.45
.08
5.1
.89
16
2.9
30
5.3
20
3.4
44
7.7
291
51
3.8
.66
31
5.5
50
8.8
51
8.9
1074 188
1.4
.24
3.2
.56
2.0
.35
2.0
.35

.21
.21
.17
.24
.19
.24
.19
.18
.23
.17
.21
.23
.18
.16
.20
.16
.17
.19
.15
.14
.18
.15
.17
.13
.15
.12
.14
.11
.04
.43
.35
.26
.17
.10
.11
.12
.16
.33
.34
.27
.35
.27
.32
.25
.30
.24
.28
.23
.28
.22
.26
.21
.24
.19
.22
.17
.21
.17
.19
.15
.17
.14
.16
.13
.48
.45
.25
.19
.28
.26
.08
.47
.24
.20
.23
.05
.50
.48
.42
.36

mm

5.3
5.3
4.4
6.2
4.9
6.2
4.9
4.7
5.9
4.4
5.2
5.8
4.7
4.1
5.2
4.1
4.2
4.9
3.9
3.6
4.7
3.7
4.2
3.4
3.8
3.1
3.5
2.8
1.0
11
8.9
6.6
4.4
2.6
2.9
3.1
4.2
8.4
8.7
6.8
8.8
6.9
8.1
6.3
7.7
6.2
7.2
5.8
7.1
5.6
6.6
5.3
6.1
4.8
5.6
4.4
5.4
4.3
4.9
3.9
4.4
3.5
4.0
3.2
12
12
6.3
4.9
7.1
6.7
2.1
12
6.0
5.2
5.8
1.3
13
12
11
9.2

ENDS: C - Closed

G - Ground
O - Open

Lbs.

4.3
5.6
5.5
8.1
5.5
9.4
6.4
6.8
6.6
7.3
7.2
11
7.3
9.0
13
9.0
11
15
10
11
17
12
18
12
22
15
27
18
44
1.6
2.5
3.8
9.6
12
11
12
12
3.1
2.8
1.9
3.8
2.6
5.1
3.4
6.3
4.3
8.1
5.5
9.4
6.4
11
7.3
13
9.0
15
10
17
12
18
12
22
15
27
18
.21
2.3
4.0
5.8
5.5
12
24
1.8
7.3
10
12
54
.68
1.6
.84
.73

19
25
24
36
24
42
28
30
29
32
32
48
33
40
59
40
48
67
45
48
76
51
80
54
99
67
121
82
197
6.9
11
17
43
52
51
54
54
14
12
8.3
17
11
23
15
28
19
36
24
42
28
48
33
59
40
67
45
76
51
80
54
99
67
121
82
.95
10
18
26
24
52
106
8.0
33
45
52
241
3.0
6.9
3.8
3.2

Inches

.16
.19
.21
.18
.18
.20
.20
.21
.27
.21
.29
.21
.21
.23
.22
.22
.26
.23
.23
.24
.25
.25
.26
.26
.28
.28
.30
.30
.36
.08
.18
.17
.25
.20
.25
.25
.36
.22
.11
.11
.13
.13
.15
.15
.18
.18
.19
.19
.22
.22
.23
.23
.24
.24
.25
.25
.26
.26
.28
.28
.31
.31
.33
.33
.08
.11
.17
.19
.27
.28
.38
.10
.25
.28
.34
.54
.12
.11
.20
.26

mm

Inches

4.1
4.7
5.3
4.6
4.6
5.0
5.0
5.2
6.8
5.2
7.5
5.3
5.3
5.7
5.6
5.6
6.6
5.8
5.8
6.0
6.2
6.2
6.5
6.5
7.2
7.2
7.7
7.7
9.1
2.1
4.6
4.2
6.4
5.2
6.4
6.4
9.1
5.5
2.7
2.7
3.3
3.3
3.8
3.8
4.4
4.4
4.9
4.9
5.5
5.5
5.7
5.7
6.1
6.1
6.4
6.4
6.7
6.7
7.1
7.1
7.9
7.9
8.4
8.4
2.1
2.7
4.2
4.8
6.8
7.1
9.6
2.4
6.4
7.2
8.5
13.7
3.1
2.8
5.2
6.7

0.035
0.037
0.038
0.038
0.038
0.040
0.040
0.041
0.041
0.041
0.042
0.042
0.042
0.045
0.045
0.045
0.047
0.047
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.080
0.021
0.030
0.033
0.046
0.048
0.050
0.050
0.051
0.033
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.014
0.024
0.033
0.038
0.038
0.043
0.063
0.022
0.042
0.047
0.048
0.090
0.019
0.021
0.024
0.025

mm

0.9
0.9
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
2.0
0.5
0.8
0.8
1.2
1.2
1.3
1.3
1.3
0.8
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.4
0.6
0.8
1.0
1.0
1.1
1.6
0.6
1.1
1.2
1.2
2.3
0.5
0.5
0.6
0.6

TOTAL
MATL
COILS
4.63
5.00
4.50
4.75
4.75
4.88
4.88
5.00
6.50
5.00
6.00
5.00
5.00
5.00
4.88
4.88
5.50
4.88
4.88
5.00
5.00
5.00
5.00
5.00
5.13
5.13
5.13
5.13
4.50
4.00
6.00
5.00
5.33
4.25
5.00
5.00
6.00
6.50
4.13
4.13
4.50
4.50
4.63
4.63
5.00
5.00
5.13
5.13
5.38
5.38
5.38
5.38
5.38
5.38
5.38
5.38
5.38
5.38
5.50
5.50
5.63
5.63
5.63
5.63
5.00
4.50
5.00
5.00
6.00
5.50
5.00
4.33
6.00
6.00
7.00
6.00
5.50
4.25
7.50
9.50

SST
SPR
SST
MW
SST
MW
SST
SST
SPR
SPR
SPR
MW
SST
SST
MW
SST
SPR
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
SST
SST
SPR
SST
SPR
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SPR
SPR
SST
MW
SPR
MW
SST
SST
SPR
SST
MW
MW
SST
MW

E
N
D
S

CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
C
C
C

F
N
S
H

N
Z
N
N
N
N
N
N
Z
N
Z
N
N
N
N
N
Z
N
N
Z
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
GI
Z
N
Z
Z
N
N
N
N
N
Z
N
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

85

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 86

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

B1-45
B12-28
FF-66
10815
3047
4267
GG-77
L-99
K-65
S-1262
V-66
A11-16
B7-4
10878
71030
71030S
71049
71049S
71068
71068S
71086
71086S
71104
71104S
71122
71122S
71140
71140S
71158
71158S
71177
71177S
71199
71199S
71221
71221S
71243
71243S
71265
71265S
JJ-53
10954
12695
B5-16
B4-8
J-25
W-45
A13-11
N-68
3668
BB-79
OO-37
71031
71031S
71050
71050S
71069
71069S
71087
71087S
71105
71105S
71123
71123S
71141
71141S
71159
71159S
71178
71178S
71200
71200S
71222
71222S
71244
71244S
71266
71266S
11223
B12-8

.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.66
.67
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.69
.72
.72

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.7
16.7
17.1
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
17.5
18.2
18.2

MATERIAL: MW - Music Wire

86

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.308
.308
.300
.296
.296
.280
.280
.280
.280
.278
.270
.268
.268
.266
.308
.308
.302
.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.284
.266
.236
.314
.312
.310
.280
.274
.270
.268
.250
.240
.308
.308
.302
.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.318
.270

RATE
mm

7.8
7.8
7.6
7.5
7.5
7.1
7.1
7.1
7.1
7.1
6.9
6.8
6.8
6.8
7.8
7.8
7.7
7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.2
6.8
6.0
8.0
7.9
7.9
7.1
7.0
6.9
6.8
6.4
6.1
7.8
7.8
7.7
7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
8.1
6.9

Lbs./In.

N/mm

6.3
7.1
8.3
14
12
41
28
18
15
29
32
47
49
58
7.2
6.1
9.9
8.4
15
12
19
16
25
21
30
25
38
32
49
42
61
52
71
60
83
70
113
96
153
130
23
42
134
4.2
1.3
5.5
20
32
24
52
66
100
6.6
5.6
8.6
7.3
13
11
16
14
22
19
27
23
34
28
44
37
54
46
63
53
73
62
100
85
134
114
1.3
45

1.1
1.2
1.5
2.5
2.2
7.2
5.0
3.1
2.7
5.1
5.6
8.2
8.6
10
1.3
1.1
1.7
1.5
2.6
2.2
3.2
2.8
4.4
3.7
5.2
4.4
6.6
5.6
8.6
7.3
11
9.1
12
11
14
12
20
17
27
23
4.0
7.4
23
.74
.22
.96
3.5
5.6
4.2
9.2
11.6
17
1.2
.98
1.5
1.3
2.3
1.9
2.9
2.4
3.9
3.3
4.7
4.0
5.9
5.0
7.7
6.5
9.4
8.0
11
9.4
13
11
17
15
23
20
.23
7.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

.29
.39
.34
.26
.42
.16
.24
.33
.29
.23
.27
.21
.21
.19
.38
.30
.39
.30
.35
.27
.34
.27
.32
.26
.32
.25
.29
.23
.27
.22
.25
.20
.24
.19
.22
.17
.20
.16
.18
.14
.26
.26
.18
.48
.38
.45
.32
.25
.24
.19
.190
.15
.42
.33
.45
.35
.40
.31
.39
.31
.37
.29
.35
.28
.32
.26
.30
.24
.28
.22
.27
.22
.25
.20
.22
.18
.20
.16
.54
.21

mm

Lbs.

7.5
9.9
8.7
6.5
11
4.2
6.1
8.3
7.2
5.9
6.7
5.2
5.3
4.8
9.8
7.7
9.8
7.7
8.8
7.0
8.7
6.9
8.2
6.6
8.1
6.4
7.3
5.8
6.9
5.5
6.3
5.0
6.1
4.9
5.5
4.4
5.0
4.0
4.5
3.6
6.5
6.5
4.5
12
9.5
11
8.2
6.3
6.0
5.0
4.83
3.7
11
8.4
11
8.9
10
7.9
9.8
7.8
9.3
7.4
9.0
7.1
8.2
6.5
7.7
6.1
7.1
5.7
6.9
5.5
6.2
5.0
5.7
4.5
5.2
4.1
14
5.4

1.9
8.3
2.8
12
2.8
13
3.7
16
5.1
23
6.8
30
6.8
30
5.8
26
4.3
19
6.8
30
8.4
37
9.6
43
10
45
11
48
2.8
12
1.9
8.3
3.8
17
2.6
11
5.1
23
3.4
15
6.3
28
4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33
13
59
9.0
40
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
5.8
26
11
48
24
105
2.0
9.1
.47
2.1
2.5
11
6.4
28
7.9
35
5.7
25
10
45
12.5
55.6
15
65
2.8
12
1.9
8.3
3.8
17
2.6
11
5.1
23
3.4
15
6.3
28
4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33
13
59
9.0
40
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
.71
3.2
9.6
43

ENDS: C - Closed

G - Ground
O - Open

Inches

.12
.12
.20
.19
.18
.23
.24
.30
.34
.24
.36
.28
.29
.33
.12
.12
.14
.14
.16
.16
.19
.19
.21
.21
.23
.23
.24
.24
.26
.26
.27
.27
.29
.29
.31
.31
.34
.34
.36
.36
.23
.40
.50
.13
.31
.14
.28
.27
.45
.32
.50
.54
.12
.12
.15
.15
.17
.17
.21
.21
.23
.23
.25
.25
.26
.26
.28
.28
.29
.29
.31
.31
.33
.33
.36
.36
.40
.40
.18
.28

mm

3.0
3.0
5.0
4.9
4.5
5.8
6.1
7.6
8.6
6.0
9.1
7.0
7.3
8.4
3.0
3.0
3.6
3.6
4.0
4.0
4.8
4.8
5.4
5.4
5.8
5.8
6.0
6.0
6.7
6.7
6.9
6.9
7.3
7.3
7.8
7.8
8.6
8.6
9.2
9.2
5.8
10.2
12.6
3.2
7.9
3.7
7.1
6.9
11.4
8.2
12.7
13.7
3.1
3.1
3.9
3.9
4.3
4.3
5.2
5.2
5.9
5.9
6.4
6.4
6.5
6.5
7.1
7.1
7.5
7.5
7.9
7.9
8.4
8.4
9.3
9.3
10.1
10.1
4.5
7.1

WIRE DIA.
Inches

0.026
0.026
0.030
0.032
0.032
0.040
0.040
0.040
0.040
0.041
0.045
0.046
0.046
0.047
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.038
0.047
0.062
0.023
0.024
0.025
0.040
0.043
0.045
0.046
0.055
0.060
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.021
0.045

mm

TOTAL
MATL
COILS

0.7
0.7
0.8
0.8
0.8
1.0
1.0
1.0
1.0
1.0
1.1
1.2
1.2
1.2
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.0
1.2
1.6
0.6
0.6
0.6
1.0
1.1
1.1
1.2
1.4
1.5
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.5
1.1

4.50
4.50
5.50
5.00
5.50
4.75
6.00
7.50
8.50
5.75
8.00
6.00
6.25
6.00
4.50
4.50
4.88
4.88
4.88
4.88
5.38
5.38
5.63
5.63
5.75
5.75
5.63
5.63
5.88
5.88
5.75
5.75
5.88
5.88
6.00
6.00
6.13
6.13
6.13
6.13
6.00
7.50
8.00
4.50
12.0
4.75
7.00
6.25
9.00
6.00
9.00
9.00
4.63
4.63
5.25
5.25
5.25
5.25
5.88
5.88
6.13
6.13
6.25
6.25
6.13
6.13
6.25
6.25
6.25
6.25
6.38
6.38
6.50
6.50
6.63
6.63
6.75
6.75
7.50
6.25

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
SPR
MW
SPR
SPR
SST
SST
SST
SPR
SST
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
MW
MW
MW
MW
SST
SST
SST
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SPR

E
N
D
S

CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG

F
N
S
H

N
N
N
Z
Z
Z
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
GI

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 87

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

B7-54
3596
B12-18
M-110
71032
71032S
B12-22
71051
71051S
CC-50
BB-71
10014
71070
71070S
71088
71088S
B3-35
71106
71106S
S-1158
71124
71124S
3785
71142
71142S
A14-44
10027
G-22
H-29
71160
71160S
71179
71179S
AA-94
71201
71201S
2612
71223
71223S
DD-100
71245
71245S
M-107
71267
71267S
BB-52
B-85
A13-17
S-1533
KK-49
10447
71033
71033S
71052
71052S
71071
71071S
71089
71089S
71107
71107S
71125
71125S
71143
71143S
71161
71161S
71180
71180S
71202
71202S
71224
71224S
71246
71246S
71268
71268S
B-73
J-51
B7-1

.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.78
.78
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.81

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
19.8
19.8
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6

I.D.
Inches

.268
.210
.316
.310
.308
.308
.306
.302
.302
.300
.300
.296
.296
.296
.290
.290
.290
.284
.284
.280
.280
.280
.276
.276
.276
.274
.270
.270
.270
.270
.270
.266
.266
.266
.262
.262
.260
.258
.258
.252
.250
.250
.242
.242
.242
.300
.298
.292
.290
.260
.258
.308
.308
.302
.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.308
.308
.304

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

6.8
5.3
8.0
7.9
7.8
7.8
7.8
7.7
7.7
7.6
7.6
7.5
7.5
7.5
7.4
7.4
7.4
7.2
7.2
7.1
7.1
7.1
7.0
7.0
7.0
7.0
6.9
6.9
6.9
6.9
6.9
6.8
6.8
6.8
6.7
6.7
6.6
6.6
6.6
6.4
6.4
6.4
6.1
6.1
6.1
7.6
7.6
7.4
7.4
6.6
6.6
7.8
7.8
7.7
7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.8
7.8
7.7

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

49
331
2.9
5.0
6.1
5.1
6.4
7.9
6.7
7.1
3.6
11
12
10
15
13
14
21
18
20
24
21
28
31
26
33
38
18
33
40
34
39
33
33
57
48
51
66
56
68
90
77
117
121
103
9.7
8.3
14
10
51
67
5.6
4.8
7.3
6.2
11
9.4
14
12
19
16
22
19
28
24
36
31
45
38
52
44
61
51
82
70
111
94
5.3
5.9
4.6

8.6
58
.51
.88
1.1
.90
1.1
1.4
1.2
1.2
.63
1.9
2.1
1.8
2.6
2.2
2.4
3.7
3.1
3.5
4.3
3.6
4.9
5.4
4.6
5.7
6.7
3.2
5.8
7.0
5.9
6.9
5.8
5.9
10
8.5
8.9
12
9.8
12
16
13
21
21
18
1.7
1.5
2.4
1.8
8.9
12
.98
.83
1.3
1.1
1.9
1.7
2.4
2.0
3.3
2.8
3.9
3.3
4.9
4.1
6.4
5.4
7.8
6.7
9.1
7.7
11
9.0
14
12
19
16
.92
1.0
.81

.21
.11
.61
.49
.46
.36
.48
.48
.38
.40
.45
.48
.43
.34
.42
.34
.45
.39
.31
.32
.39
.31
.28
.35
.28
.26
.25
.26
.27
.33
.27
.38
.31
.30
.30
.24
.24
.27
.22
.21
.25
.20
.17
.22
.18
.29
.37
.44
.43
.24
.19
.49
.39
.52
.41
.46
.36
.46
.37
.43
.34
.42
.33
.39
.31
.36
.29
.34
.27
.33
.26
.30
.24
.27
.22
.25
.20
.35
.47
.61

mm

5.3
2.8
15
12
12
9.2
12
12
9.7
10
11
12
11
8.6
11
8.5
12
9.8
7.8
8.2
9.8
7.8
7.1
8.9
7.1
6.5
6.4
6.5
6.9
8.5
6.8
9.6
7.8
7.7
7.6
6.0
6.1
6.9
5.5
5.3
6.3
5.0
4.3
5.7
4.6
7.4
9.5
11
11
6.1
4.9
13
9.9
13
10
12
9.2
12
9.3
11
8.7
11
8.5
9.9
7.9
9.3
7.4
8.6
6.8
8.3
6.6
7.5
6.0
6.9
5.5
6.3
5.0
9.0
12
15

ENDS: C - Closed

G - Ground
O - Open

Lbs.

10
37
1.8
2.5
2.8
1.9
3.1
3.8
2.6
2.8
1.6
5.1
5.1
3.4
6.3
4.3
6.3
8.1
5.5
6.4
9.4
6.4
7.8
11
7.3
8.4
9.6
4.7
9.0
13
9.0
15
10
10
17
12
12
18
12
14
22
15
20
27
18
2.8
3.1
6.1
4.3
12
13
2.8
1.9
3.8
2.6
5.1
3.4
6.3
4.3
8.1
5.5
9.4
6.4
11
7.3
13
9.0
15
10
17
12
18
12
22
15
27
18
1.9
2.8
2.8

45
164
8.0
11
12
8.3
14
17
11
13
7.3
23
23
15
28
19
28
36
24
28
42
28
35
48
33
37
43
21
40
59
40
66
45
45
76
51
54
80
54
64
99
67
87
121
82
13
14
27
19
54
57
12
8.3
17
11
23
15
28
19
36
24
42
28
48
33
59
40
67
45
76
51
80
54
99
67
121
82
8.3
12
13

Inches

.33
.60
.11
.15
.13
.13
.14
.16
.16
.21
.30
.19
.18
.18
.21
.21
.23
.24
.24
.32
.27
.27
.34
.27
.27
.29
.32
.50
.32
.30
.30
.37
.37
.38
.34
.34
.40
.36
.36
.41
.39
.39
.44
.43
.43
.15
.22
.20
.26
.40
.41
.13
.13
.17
.17
.19
.19
.23
.23
.26
.26
.28
.28
.29
.29
.32
.32
.33
.33
.36
.36
.38
.38
.42
.42
.46
.46
.16
.16
.20

mm

Inches

8.5
15.2
2.8
3.8
3.2
3.2
3.6
4.1
4.1
5.3
7.6
4.9
4.6
4.6
5.4
5.4
5.8
6.0
6.0
8.1
6.7
6.7
8.5
6.9
6.9
7.4
8.0
12.6
8.0
7.7
7.7
9.4
9.4
9.6
8.6
8.6
10.2
9.1
9.1
10.3
10.0
10.0
11.2
10.9
10.9
3.8
5.5
5.2
6.7
10.2
10.4
3.4
3.4
4.3
4.3
4.8
4.8
5.9
5.9
6.5
6.5
7.1
7.1
7.5
7.5
8.1
8.1
8.5
8.5
9.0
9.0
9.7
9.7
10.7
10.7
11.6
11.6
4.0
4.0
5.2

0.046
0.075
0.022
0.025
0.026
0.026
0.027
0.029
0.029
0.030
0.030
0.032
0.032
0.032
0.035
0.035
0.035
0.038
0.038
0.040
0.040
0.040
0.042
0.042
0.042
0.043
0.045
0.045
0.045
0.045
0.045
0.047
0.047
0.047
0.049
0.049
0.050
0.051
0.051
0.054
0.055
0.055
0.059
0.059
0.059
0.030
0.031
0.034
0.035
0.050
0.051
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.026
0.026
0.028

mm

TOTAL
MATL
COILS

1.2
1.9
0.6
0.6
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.8
0.8
0.9
0.9
0.9
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.3
1.4
1.4
1.4
1.5
1.5
1.5
0.8
0.8
0.9
0.9
1.3
1.3
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.7
0.7
0.7

6.25
8.00
5.00
5.00
4.88
4.88
5.25
5.50
5.50
6.00
10.0
6.00
5.63
5.63
6.13
6.13
6.50
6.25
6.25
7.00
6.63
6.63
7.00
6.50
6.50
6.75
7.00
11.0
7.00
6.75
6.75
7.88
7.88
8.00
6.88
6.88
8.00
7.00
7.00
7.50
7.13
7.13
7.50
7.25
7.25
5.00
6.00
6.00
7.50
8.00
7.00
5.13
5.13
5.88
5.88
5.88
5.88
6.63
6.63
6.75
6.75
7.00
7.00
7.00
7.00
7.13
7.13
7.13
7.13
7.25
7.25
7.50
7.50
7.63
7.63
7.75
7.75
5.00
5.00
7.25

SPR
SPR
MW
MW
MW
SST
MW
MW
SST
SST
SST
MW
MW
SST
MW
SST
MW
MW
SST
SST
MW
SST
SPR
MW
SST
SPR
SPR
SST
SST
MW
SST
MW
SST
SST
MW
SST
SPR
MW
SST
SST
MW
SST
SPR
MW
SST
SST
SST
MW
SST
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
MW

E
N
D
S

C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG

F
N
S
H

N
Z
N
GI
N
N
GI
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
Z
N
N
Z
Z
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
Z
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

87

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 88

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

A13-26
H-64
4238
B1-15
MM-48
N-3
4279
S-1279
Z-55
XX-69
J-11
B17-133
W-19
10095
A13-49
O-93
QQ-68
GG-10
S-1257
A11-25
W-44
H-22
L-82
O-34
71034
71034S
71053
71053S
71072
71072S
71090
71090S
71108
71108S
71126
71126S
71144
71144S
71162
71162S
71181
71181S
71203
71203S
71225
71225S
71247
71247S
71269
71269S
Y-24
B2-14
M-133
JJ-82
1929
F-59
A9-59
S-179
KK-87
F-60
S-373
71035
71035S
71054
71054S
71073
71073S
71091
71091S
71109
71109S
71127
71127S
71145
71145S
71163
71163S
71182
71182S
71204

.81
.81
.81
.81
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.93
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94
.94

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

20.6
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
23.0
23.7
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9
23.9

MATERIAL: MW - Music Wire

88

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.294
.290
.288
.266
.304
.226
.310
.310
.310
.306
.302
.300
.296
.294
.294
.290
.282
.280
.278
.268
.266
.252
.252
.230
.308
.308
.302
.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.290
.258
.330
.316
.310
.308
.302
.298
.296
.270
.150
.308
.308
.302
.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262

RATE
mm

7.5
7.4
7.3
6.8
7.7
5.7
7.9
7.9
7.9
7.8
7.7
7.6
7.5
7.5
7.5
7.4
7.2
7.1
7.1
6.8
6.8
6.4
6.4
5.8
7.8
7.8
7.7
7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.4
6.6
8.4
8.0
7.9
7.8
7.7
7.6
7.5
6.9
3.8
7.8
7.8
7.7
7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

10
1.8
12
2.0
18
3.1
44
7.7
6.1
1.1
172
30
4.3
.75
3.3
.57
3.7
.66
5.6
.97
4.0
.71
5.9
1.0
7.5
1.3
9.8
1.7
11
1.9
16
2.8
13
2.3
13
2.2
19
3.3
31
5.4
37
6.4
50
8.7
51
8.9
149
26
5.0
.87
4.2
.74
6.7
1.2
5.7
1.0
10
1.7
8.5
1.5
13
2.2
11
1.9
17
3.0
14
2.5
20
3.6
17
3.0
25
4.4
21
3.7
33
5.8
28
4.9
33
5.7
28
4.9
48
8.3
41
7.1
55
9.6
47
8.2
75
13
64
11
101
18
86
15
9.1
1.6
6.3
1.1
.22
.04
2.2
.39
3.9
.68
4.4
.78
5.7
.99
5.6
.97
7.8
1.4
32
5.6
1576 276
4.6
.80
3.9
.68
6.1
1.1
5.2
.91
9.5
1.7
8.0
1.4
12
2.1
10
1.8
16
2.8
13
2.4
19
3.3
16
2.8
23
4.0
20
3.4
30
5.3
26
4.5
38
6.6
32
5.6
44
7.7

.37
.40
.28
.25
.57
.15
.57
.50
.44
.56
.59
.65
.46
.41
.37
.29
.45
.48
.36
.31
.28
.29
.30
.16
.56
.44
.57
.45
.51
.41
.50
.40
.48
.38
.46
.37
.43
.34
.40
.32
.46
.37
.36
.28
.32
.26
.30
.24
.27
.22
.51
.40
.79
.78
.63
.62
.68
.56
.65
.42
.05
.61
.48
.63
.49
.54
.43
.53
.42
.51
.41
.49
.39
.47
.37
.44
.35
.40
.32
.39

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

9.3
10
7.1
6.3
14
3.9
15
13
11
14
15
17
12
10
9.4
7.3
11
12
9.1
7.8
7.1
7.3
7.6
4.2
14
11
15
11
13
10
13
10
12
9.6
12
9.3
11
8.7
10
8.2
12
9.3
9.1
7.2
8.3
6.6
7.5
6.0
6.9
5.5
13
10
20
20
16
16
17
14
17
11
1.3
15
12
16
13
14
11
14
11
13
10
13
10
12
9.5
11
8.9
10
8.0
9.8

Lbs.

3.8
4.6
5.0
11
3.5
27
2.5
1.7
1.7
3.1
2.4
3.9
3.4
4.0
4.0
4.6
5.9
6.0
6.8
9.6
10
14
15
24
2.8
1.9
3.8
2.6
5.1
3.4
6.3
4.3
8.1
5.5
9.4
6.4
11
7.3
13
9.0
15
10
17
12
18
12
22
15
27
18
4.6
2.5
.17
1.7
2.5
2.8
3.8
3.1
5.1
13
81
2.8
1.9
3.8
2.6
5.1
3.4
6.3
4.3
8.1
5.5
9.4
6.4
11
7.3
13
9.0
15
10
17

ENDS: C - Closed

G - Ground
O - Open

17
20
22
48
15
118
11
7.3
7.3
14
11
17
15
18
18
20
26
27
30
43
45
64
68
109
12
8.3
17
11
23
15
28
19
36
24
42
28
48
33
59
40
66
45
76
51
80
54
99
67
121
82
20
11
.78
7.7
11
12
17
14
23
59
361
12
8.3
17
11
23
15
28
19
36
24
42
28
48
33
59
40
67
45
76

Inches

.21
.26
.25
.34
.20
.54
.16
.15
.16
.18
.29
.23
.22
.26
.21
.21
.38
.40
.32
.37
.35
.51
.57
.52
.15
.15
.18
.18
.20
.20
.24
.24
.28
.28
.30
.30
.32
.32
.35
.35
.42
.42
.38
.38
.41
.41
.45
.45
.49
.49
.32
.54
.15
.15
.17
.18
.20
.28
.27
.41
.84
.15
.15
.19
.19
.21
.21
.25
.25
.29
.29
.32
.32
.34
.34
.37
.37
.38
.38
.40

mm

5.2
6.7
6.4
8.7
5.0
13.6
4.1
3.8
4.1
4.6
7.4
5.7
5.7
6.7
5.4
5.3
9.7
10.2
8.1
9.3
9.0
13.0
14.4
13.2
3.7
3.7
4.5
4.5
5.1
5.1
6.1
6.1
7.0
7.0
7.6
7.6
8.0
8.0
8.9
8.9
10.7
10.7
9.6
9.6
10.4
10.4
11.4
11.4
12.6
12.6
8.0
13.6
3.8
3.9
4.4
4.6
5.2
7.1
6.9
10.3
21.3
3.9
3.9
4.9
4.9
5.3
5.3
6.4
6.4
7.4
7.4
8.0
8.0
8.5
8.5
9.4
9.4
9.6
9.6
10.3

WIRE DIA.
Inches

0.033
0.035
0.036
0.047
0.028
0.067
0.025
0.025
0.025
0.027
0.029
0.030
0.032
0.033
0.033
0.035
0.039
0.040
0.041
0.046
0.047
0.054
0.054
0.065
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.035
0.051
0.015
0.022
0.025
0.026
0.029
0.031
0.032
0.045
0.105
0.026
0.026
0.029
0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049

mm

TOTAL
MATL
COILS

0.8
0.9
0.9
1.2
0.7
1.7
0.6
0.6
0.6
0.7
0.7
0.8
0.8
0.8
0.8
0.9
1.0
1.0
1.0
1.2
1.2
1.4
1.4
1.7
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.9
1.3
0.4
0.6
0.6
0.7
0.7
0.8
0.8
1.1
2.7
0.7
0.7
0.7
0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2

6.25
7.50
6.00
7.25
6.00
8.00
5.50
6.00
5.50
5.75
9.00
7.50
7.00
7.00
6.50
6.00
8.75
10.0
7.75
8.00
7.50
9.50
10.5
8.00
5.63
5.63
6.13
6.13
6.25
6.25
6.88
6.88
7.25
7.25
7.50
7.50
7.50
7.50
7.75
7.75
9.00
9.00
7.75
7.75
8.00
8.00
8.13
8.13
8.38
8.38
9.00
9.50
9.00
6.00
5.88
6.00
7.00
8.00
7.50
8.00
8.00
5.88
5.88
6.63
6.63
6.50
6.50
7.25
7.25
7.63
7.63
7.88
7.88
8.00
8.00
8.25
8.25
8.00
8.00
8.25

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SPR
SPR
MW
SST
MW
SST
SST
MW
MW
MW
SST
SPR
SPR
SPR
SST
SST
SST
SST
SST
SST
SPR
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
MW
MW
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
C
CG
C
CG
C
CG
C
C
C
CG
CG
C
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
C
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
Z
Z
GI
N
N
Z
N
N
Z
Z
Z
N
Z
GI
GI
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
Z
Z
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 89

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

71204S
71226
71226S
71248
71248S
71270
71270S
PP-49
I-8
NN-67
EE-64
L-56
10058
B5-43
2794
71036
71036S
11735
10912
71055
71055S
II-37
PP-63
71074
71074S
II-57
71092
71092S
71110
71110S
3446
71128
71128S
4281
Z-59
B12-30
B1-63
71146
71146S
XX-45
10104
71164
71164S
1587
71183
71183S
71205
71205S
71227
71227S
71249
71249S
2813
A13-34
AA-24
S-1282
JJ-35
KK-95
12330
S-1582
A14-29
S-857
10866
L-86
10162
K-34
2508
QQ-50
10108
B12-42
10316
S-1124
S-1285
WW-41
S-1586
3898
71037
71037S
71056
71056S

.94
.94
.94
.94
.94
.94
.94
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.03
1.06
1.06
1.06
1.09
1.09
1.09
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

23.9
23.9
23.9
23.9
23.9
23.9
23.9
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
26.2
27.0
27.0
27.0
27.8
27.8
27.8
27.8
27.8
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.7
28.7
28.7
28.7

I.D.
Inches

.262
.258
.258
.250
.250
.242
.242
.280
.224
.328
.320
.318
.316
.316
.308
.308
.308
.308
.306
.302
.302
.300
.300
.296
.296
.290
.290
.290
.284
.284
.280
.280
.280
.278
.278
.278
.276
.276
.276
.272
.270
.270
.270
.268
.266
.266
.262
.262
.258
.258
.250
.250
.270
.268
.260
.310
.278
.266
.294
.288
.272
.266
.248
.338
.310
.304
.302
.302
.296
.296
.278
.276
.272
.270
.242
.236
.308
.308
.302
.302

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.1
5.7
8.3
8.1
8.1
8.0
8.0
7.8
7.8
7.8
7.8
7.8
7.7
7.7
7.6
7.6
7.5
7.5
7.4
7.4
7.4
7.2
7.2
7.1
7.1
7.1
7.1
7.1
7.1
7.0
7.0
7.0
6.9
6.9
6.9
6.9
6.8
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.9
6.8
6.6
7.9
7.1
6.8
7.5
7.3
6.9
6.8
6.3
8.6
7.9
7.7
7.7
7.7
7.5
7.5
7.1
7.0
6.9
6.9
6.1
6.0
7.8
7.8
7.7
7.7

Lbs./In.

38
51
43
70
59
93
79
10
178
.15
.98
2.1
2.2
2.2
1.4
4.1
3.4
4.0
5.2
5.9
5.0
3.6
5.8
8.5
7.2
11
11
9.5
15
13
14
18
15
14
13
19
18
21
18
27
27
28
24
26
35
30
41
35
48
41
65
55
27
27
38
2.6
11
29
7.9
8.5
23
19
44
.02
3.0
1.9
4.9
4.6
7.2
7.8
14
12
19
21
64
101
3.7
3.1
5.2
4.4

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

6.6
8.9
7.6
12
10
16
14
1.8
31
.03
.17
.36
.39
.39
.24
.71
.60
.69
.91
1.0
.88
.64
1.0
1.5
1.3
1.9
2.0
1.7
2.6
2.2
2.5
3.1
2.6
2.5
2.3
3.4
3.1
3.7
3.2
4.6
4.8
4.9
4.2
4.6
6.2
5.3
7.2
6.1
8.4
7.1
11
9.6
4.8
4.7
6.7
.46
1.9
5.1
1.4
1.5
4.0
3.3
7.7
.00
.53
.34
.86
.81
1.3
1.4
2.5
2.0
3.3
3.6
11
18
.65
.55
.91
.77

.31
.35
.28
.32
.25
.29
.23
.45
.17
.73
.82
.75
.81
.81
.58
.68
.54
.70
.59
.65
.51
.64
.49
.60
.47
.43
.57
.45
.54
.43
.48
.53
.42
.51
.53
.38
.41
.51
.41
.34
.35
.47
.38
.39
.43
.34
.41
.33
.38
.30
.34
.27
.49
.36
.32
.63
.57
.38
.47
.55
.39
.49
.36
.85
.82
.76
.78
.83
.71
.47
.52
.60
.45
.43
.29
.22
.75
.59
.74
.58

mm

7.8
8.9
7.1
8.1
6.5
7.4
5.9
11
4.2
18
21
19
21
21
15
17
14
18
15
16
13
16
12
15
12
11
14
12
14
11
12
13
11
13
13
9.5
10
13
10
8.6
9.0
12
9.6
9.9
11
8.6
11
8.4
9.5
7.6
8.7
7.0
12
9.1
8.1
16
14
9.6
12
14
9.9
13
9.2
22
21
19
20
21
18
12
13
15
11
11
7.4
5.7
19
15
19
15

ENDS: C - Closed

G - Ground
O - Open

Lbs.

12
51
18
80
12
54
22
99
15
67
27
121
18
82
4.6
21
29
131
.11
.47
.81
3.6
1.6
6.9
1.8
8.0
1.8
8.0
.80
3.6
2.8
12
1.9
8.3
2.8
12
3.1
14
3.8
17
2.6
11
2.3
10
2.8
13
5.1
23
3.4
15
4.6
20
6.3
28
4.3
19
8.1
36
5.5
24
6.8
30
9.4
42
6.4
28
7.1
32
6.8
30
7.3
32
7.3
33
11
48
7.3
33
9.0
40
9.6
43
13
59
9.0
40
10
45
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
13
59
9.6
43
12
54
1.7
7.3
6.3
28
11
48
3.8
17
4.7
21
9.0
40
9.4
42
16
71
.02
.07
2.5
11
1.5
6.5
3.8
17
3.8
17
5.1
23
3.7
16
7.3
32
7.0
31
8.4
37
9.0
40
18
82
23
101
2.8
12
1.9
8.3
3.8
17
2.6
11

Inches

.40
.43
.43
.47
.47
.52
.52
.52
.68
.27
.18
.14
.15
.13
.42
.17
.17
.20
.16
.20
.20
.36
.21
.22
.22
.28
.27
.27
.30
.30
.44
.34
.34
.49
.43
.35
.38
.36
.36
.37
.45
.39
.39
.46
.40
.40
.43
.43
.45
.45
.50
.50
.41
.41
.50
.18
.49
.47
.28
.34
.42
.60
.69
.28
.20
.36
.25
.20
.29
.24
.49
.53
.44
.50
.65
.62
.18
.18
.21
.21

mm

Inches

10.3
11.0
11.0
12.0
12.0
13.3
13.3
13.2
17.3
6.9
4.6
3.5
3.9
3.4
10.6
4.2
4.2
5.0
4.1
5.0
5.0
9.1
5.3
5.7
5.7
7.1
6.8
6.8
7.7
7.7
11.2
8.5
8.5
12.5
10.9
8.9
9.6
9.1
9.1
9.5
11.4
10.0
10.0
11.7
10.1
10.1
10.9
10.9
11.5
11.5
12.7
12.7
10.3
10.5
12.7
4.4
12.5
11.9
7.1
8.7
10.6
15.2
17.4
7.0
5.1
9.2
6.5
5.1
7.3
6.1
12.5
13.3
11.2
12.6
16.5
15.7
4.5
4.5
5.4
5.4

0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.040
0.068
0.016
0.020
0.021
0.022
0.022
0.026
0.026
0.026
0.026
0.027
0.029
0.029
0.030
0.030
0.032
0.032
0.035
0.035
0.035
0.038
0.038
0.040
0.040
0.040
0.041
0.041
0.041
0.042
0.042
0.042
0.044
0.045
0.045
0.045
0.046
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.045
0.046
0.050
0.025
0.041
0.047
0.033
0.036
0.044
0.047
0.056
0.011
0.025
0.028
0.029
0.029
0.032
0.032
0.041
0.042
0.044
0.045
0.059
0.062
0.026
0.026
0.029
0.029

mm

TOTAL
MATL
COILS

1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.0
1.7
0.4
0.5
0.5
0.6
0.6
0.7
0.7
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.8
0.9
0.9
0.9
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.1
1.2
1.3
0.6
1.0
1.2
0.8
0.9
1.1
1.2
1.4
0.3
0.6
0.7
0.7
0.7
0.8
0.8
1.0
1.1
1.1
1.1
1.5
1.6
0.7
0.7
0.7
0.7

8.25
8.50
8.50
8.63
8.63
8.88
8.88
13.0
9.00
16.0
8.00
5.50
6.00
6.00
15.0
6.38
6.38
6.50
6.00
6.75
6.75
11.0
7.00
7.00
7.00
8.00
7.63
7.63
8.00
8.00
10.0
8.38
8.38
11.0
10.5
8.50
9.00
8.50
8.50
8.50
9.00
8.75
8.75
10.0
8.50
8.50
8.75
8.75
8.88
8.88
9.13
9.13
9.00
9.00
10.0
7.00
12.0
10.0
7.50
9.50
9.50
12.8
12.3
24.0
7.00
13.0
7.75
6.50
8.00
7.50
11.0
12.5
10.0
10.0
11.0
10.0
6.75
6.75
7.38
7.38

SST
MW
SST
MW
SST
MW
SST
SPR
SPR
SST
MW
MW
MW
MW
MW
MW
SST
MW
MW
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
SPR
MW
SST
SPR
SST
SPR
SST
MW
SST
SPR
SPR
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SST
SST
SPR
SST
SST
SPR
SST
SST
SST
MW
SST
MW
MW
MW
SPR
SPR
SST
SST
SST
SST
HD
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
C
CG
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
C
C
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
Z
N
N
N
N
GI
N
Z
N
N
Z
N
N
N
N
N
N
N
Z
N
N
N
N
Z
N
N
Z
N
N
N
N
N
Z
Z
N
N
Z
N
N
N
N
N
N
N
N
Z
N
N
N
N
Z
N
N
GI
N
N
N
Z
N
Z
Z
GI
N
Z
N
N
N
N
Z
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

89

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 90

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

71075
71075S
71093
71093S
71111
71111S
71129
71129S
71147
71147S
71165
71165S
71184
71184S
71206
71206S
71228
71228S
71250
71250S
71271
71271S
PP-77
F-35
YY-43
3664
71038
71038S
S-1272
71057
71057S
NN-46
71076
71076S
12502
71094
71094S
S-1281
TT-38
71112
71112S
71130
71130S
71148
71148S
71166
71166S
71185
71185S
71207
71207S
71229
71229S
71251
71251S
71272
71272S
10450
HH-85
S-1270
MM-83
3265
F-62
12503
V V-53
S-3185
2871
O-44
A13-31
3930
3601
V V-67
S-789
71040
71040S
71058
71058S
71077
71077S
71095

1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.19
1.19
1.19
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.31
1.31
1.31
1.31
1.31
1.31
1.31
1.33
1.34
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
28.7
29.4
30.2
30.2
30.2
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
33.3
33.3
33.3
33.3
33.3
33.3
33.3
33.7
34.1
34.1
34.9
34.9
34.9
34.9
34.9
35.1
35.1
35.1
35.1
35.1
35.1
35.1

MATERIAL: MW - Music Wire

90

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.300
.308
.292
.270
.308
.308
.302
.302
.302
.300
.296
.296
.292
.290
.290
.286
.284
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.302
.328
.278
.276
.274
.270
.268
.248
.280
.284
.236
.292
.284
.270
.258
.240
.308
.308
.302
.302
.296
.296
.290

RATE
mm

7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.6
7.8
7.4
6.9
7.8
7.8
7.7
7.7
7.7
7.6
7.5
7.5
7.4
7.4
7.4
7.3
7.2
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.7
8.3
7.1
7.0
7.0
6.9
6.8
6.3
7.1
7.2
6.0
7.4
7.2
6.9
6.6
6.1
7.8
7.8
7.7
7.7
7.5
7.5
7.4

Lbs./In.

7.5
6.4
9.8
8.3
13
11
16
13
19
16
25
21
31
27
36
31
42
36
57
48
77
65
4.7
3.6
5.1
15
3.3
2.8
4.5
4.6
3.9
5.8
6.8
5.8
8.0
8.8
7.4
9.4
9.1
12
10
14
12
17
14
22
19
28
24
32
27
37
32
51
43
68
58
2.6
.18
10
17
18
23
23
56
9.0
10
74
7.5
13
19
27
67
3.0
2.6
4.2
3.5
6.3
5.3
7.9

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.3
1.1
1.7
1.5
2.3
1.9
2.7
2.3
3.3
2.8
4.3
3.7
5.5
4.6
6.3
5.4
7.4
6.3
10
8.5
13
11
.83
.62
.89
2.6
.57
.48
.78
.81
.68
1.0
1.2
1.0
1.4
1.5
1.3
1.6
1.6
2.1
1.8
2.4
2.1
3.0
2.5
3.8
3.3
4.9
4.1
5.6
4.8
6.5
5.6
8.9
7.5
12
10
.45
.03
1.7
3.0
3.2
4.0
4.1
9.9
1.6
1.8
13
1.3
2.3
3.3
4.7
12
.53
.45
.73
.62
1.1
.93
1.4

.68
.54
.65
.52
.62
.50
.60
.48
.58
.46
.54
.43
.48
.38
.47
.37
.43
.34
.39
.31
.36
.28
.60
.78
.71
.47
.85
.67
.57
.83
.66
.49
.75
.59
.51
.73
.58
.54
.64
.68
.54
.67
.54
.64
.51
.60
.48
.54
.43
.53
.42
.48
.38
.44
.35
.40
.32
.88
1.1
.68
.46
.46
.42
.41
.30
.71
.80
.31
.59
.45
.50
.48
.29
.92
.73
.92
.73
.82
.65
.81

mm

17
14
17
13
16
13
15
12
15
12
14
11
12
9.8
12
9.5
11
8.6
9.9
7.9
9.1
7.2
15
20
18
12
22
17
15
21
17
12
19
15
13
18
15
14
16
17
14
17
14
16
13
15
12
14
11
13
11
12
9.7
11
8.9
10
8.2
22
28
17
12
12
11
10
7.6
18
20
7.8
15
11
13
12
7.3
23
18
23
18
21
16
21

Lbs.

5.1
23
3.4
15
6.3
28
4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33
13
59
9.0
40
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
2.8
13
2.8
12
3.6
16
6.9
30
2.8
12
1.9
8.3
2.6
11
3.8
17
2.6
11
2.8
13
5.1
23
3.4
15
4.1
18
6.3
28
4.3
19
5.1
23
5.8
26
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33
13
59
9.0
40
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
2.3
10
.20
.89
6.8
30
7.8
35
8.4
37
9.6
43
9.6
43
17
75
6.4
28
8.1
36
23
101
4.4
20
5.8
26
9.6
43
13
57
19
86
2.8
12
1.9
8.3
3.8
17
2.6
11
5.1
23
3.4
15
6.3
28

ENDS: C - Closed

G - Ground
O - Open

Inches

.25
.25
.30
.30
.34
.34
.37
.37
.39
.39
.43
.43
.44
.44
.47
.47
.50
.50
.56
.56
.61
.61
.24
.21
.48
.72
.19
.19
.25
.24
.24
.21
.26
.26
.31
.32
.32
.35
.49
.37
.37
.40
.40
.43
.43
.48
.48
.48
.48
.51
.51
.55
.55
.61
.61
.67
.67
.41
.22
.53
.47
.45
.51
.50
.62
.52
.42
.87
.32
.38
.59
.74
.66
.20
.20
.25
.25
.28
.28
.35

mm

6.3
6.3
7.6
7.6
8.6
8.6
9.3
9.3
10.0
10.0
11.0
11.0
11.2
11.2
12.0
12.0
12.8
12.8
14.1
14.1
15.5
15.5
6.1
5.3
12.1
18.3
4.9
4.9
6.3
6.0
6.0
5.3
6.7
6.7
7.8
8.1
8.1
8.9
12.5
9.3
9.3
10.2
10.2
10.8
10.8
12.1
12.1
12.2
12.2
13.1
13.1
14.1
14.1
15.5
15.5
17.0
17.0
10.3
5.7
13.5
12.0
11.5
13.0
12.6
15.6
13.2
10.6
22.0
8.2
9.7
14.9
18.8
16.8
5.2
5.2
6.4
6.4
7.2
7.2
8.9

WIRE DIA.
Inches

0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.030
0.026
0.034
0.045
0.026
0.026
0.029
0.029
0.029
0.030
0.032
0.032
0.034
0.035
0.035
0.037
0.038
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.029
0.016
0.041
0.042
0.043
0.045
0.046
0.056
0.040
0.038
0.062
0.034
0.038
0.045
0.051
0.060
0.026
0.026
0.029
0.029
0.032
0.032
0.035

mm

TOTAL
MATL
COILS

0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.8
0.7
0.9
1.1
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.9
0.9
0.9
0.9
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.7
0.4
1.0
1.1
1.1
1.1
1.2
1.4
1.0
1.0
1.6
0.9
1.0
1.1
1.3
1.5
0.7
0.7
0.7
0.7
0.8
0.8
0.9

7.75
7.75
8.50
8.50
8.88
8.88
9.13
9.13
9.38
9.38
9.63
9.63
9.38
9.38
9.63
9.63
9.88
9.88
10.1
10.1
10.4
10.4
8.00
7.00
13.0
15.0
7.38
7.38
7.50
8.13
8.13
7.00
8.25
8.25
8.00
9.13
9.13
9.50
12.0
9.63
9.63
10.0
10.0
10.1
10.1
10.6
10.6
10.3
10.3
10.5
10.5
10.9
10.9
11.1
11.1
11.4
11.4
13.0
13.0
13.0
10.3
10.5
11.0
9.75
11.0
13.0
11.0
13.0
9.50
9.00
12.0
14.5
11.0
7.88
7.88
8.75
8.75
8.88
8.88
10.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SPR
SPR
MW
SST
SST
MW
SST
SST
MW
SST
SST
MW
SST
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SPR
SPR
SPR
SST
SPR
SST
MW
SPR
SPR
SPR
SPR
SPR
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
C
C
CG
CG
CG
C
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
GI
Z
Z
N
Z
N
Z
N
GI
Z
Z
GI
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 91

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

71095S
71113
71113S
71131
71131S
71149
71149S
71167
71167S
71186
71186S
71208
71208S
71230
71230S
71252
71252S
71273
71273S
S-827
A14-43
S-1284
2802
3742
N-52
10724
N-47
HH-12
71041
71041S
71059
71059S
HH-87
S-1286
1597
71078
71078S
K-26
S-1567
71096
71096S
G-88
B3-67
71114
71114S
A13-4
GG-85
71132
71132S
71150
71150S
S-1308
71168
71168S
2615
71187
71187S
71209
71209S
71231
71231S
71253
71253S
71274
71274S
JJ-16
S-1653
A15-54
F-63
S-850
A13-41
RR-8
W-31
B8-56
10245
10623
FF-96
71042
71042S
71060

1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.44
1.44
1.44
1.44
1.44
1.47
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.53
1.53
1.63
1.63
1.69
1.69
1.69
1.69
1.75
1.75
1.75
1.75
1.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.1
35.7
36.5
36.5
36.5
36.5
36.5
37.3
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.9
38.9
38.9
41.3
41.3
42.8
42.8
42.8
42.8
44.5
44.5
44.5
44.5
44.5

I.D.
Inches

.290
.284
.284
.280
.280
.276
.276
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.294
.294
.286
.270
.256
.246
.278
.236
.312
.308
.308
.302
.302
.300
.298
.296
.296
.296
.294
.292
.290
.290
.286
.286
.284
.284
.284
.280
.280
.280
.276
.276
.272
.270
.270
.268
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.240
.298
.294
.270
.298
.248
.298
.268
.268
.266
.324
.310
.308
.308
.302

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.5
7.5
7.3
6.9
6.5
6.2
7.1
6.0
7.9
7.8
7.8
7.7
7.7
7.6
7.6
7.5
7.5
7.5
7.5
7.4
7.4
7.4
7.3
7.3
7.2
7.2
7.2
7.1
7.1
7.1
7.0
7.0
6.9
6.9
6.9
6.8
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
6.1
7.6
7.5
6.9
7.6
6.3
7.6
6.8
6.8
6.8
8.2
7.9
7.8
7.8
7.7

Lbs./In.

6.7
10
8.7
13
11
16
13
20
17
25
21
29
25
34
28
45
39
61
52
5.4
5.2
8.5
17
28
73
11
68
1.3
2.8
2.3
3.8
3.3
2.6
4.0
5.1
5.5
4.6
3.5
4.7
7.2
6.1
8.3
6.0
9.3
7.9
9.8
9.0
12
9.9
15
12
14
18
15
20
23
19
27
23
31
26
42
35
56
47
103
4.0
6.0
17
3.5
51
2.3
12
14
29
.38
1.4
2.4
2.0
3.3

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.2
1.8
1.5
2.2
1.9
2.8
2.4
3.5
3.0
4.4
3.7
5.1
4.3
5.9
5.0
8.0
6.8
11
9.0
.94
.92
1.5
3.0
4.9
13
1.9
12
.22
.48
.41
.67
.57
.45
.69
.89
.95
.81
.60
.83
1.3
1.1
1.4
1.1
1.6
1.4
1.7
1.6
2.0
1.7
2.5
2.2
2.4
3.1
2.7
3.5
4.0
3.4
4.6
3.9
5.4
4.6
7.3
6.2
9.7
8.3
18
.71
1.0
3.0
.62
8.9
.41
2.1
2.5
5.1
.07
.25
.42
.36
.57

.64
.79
.63
.75
.60
.69
.55
.67
.53
.61
.48
.59
.47
.53
.43
.49
.39
.45
.36
.70
.72
.59
.77
.49
.24
.68
.34
1.2
1.0
.79
1.0
.79
1.1
.79
1.0
.94
.74
.96
.87
.89
.71
.61
.84
.87
.69
.60
.71
.81
.65
.75
.60
.62
.74
.59
.71
.66
.53
.64
.51
.58
.46
.54
.43
.49
.39
.19
.77
.94
.55
.88
.33
1.2
.80
.73
.38
1.6
1.4
1.2
.91
1.2

mm

16
20
16
19
15
17
14
17
14
15
12
15
12
14
11
12
9.9
11
9.1
18
18
15
19
12
6.2
17
8.5
30
26
20
25
20
27
20
26
24
19
24
22
23
18
16
21
22
18
15
18
21
16
19
15
16
19
15
18
17
13
16
13
15
12
14
11
12
10
4.8
20
24
14
22
8.5
30
20
19
9.6
39
36
29
23
30

ENDS: C - Closed

G - Ground
O - Open

Lbs.

4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33
13
59
9.0
40
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
3.8
17
3.8
17
5.1
23
13
59
14
61
18
79
7.3
32
23
101
1.5
6.7
2.8
12
1.9
8.3
3.8
17
2.6
11
2.8
12
3.1
14
5.1
23
5.1
23
3.4
15
3.3
15
4.1
18
6.3
28
4.3
19
5.1
23
5.1
23
8.1
36
5.5
24
5.8
26
6.4
28
9.4
42
6.4
28
11
48
7.3
33
8.4
37
13
59
9.0
40
14
63
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
19
86
3.1
14
5.6
25
9.6
43
3.1
14
17
75
2.8
12
9.6
43
10
45
11
48
.58
2.6
2.0
9.0
2.8
12
1.9
8.3
3.8
17

Inches

.35
.41
.41
.44
.44
.45
.45
.52
.52
.53
.53
.56
.56
.61
.61
.67
.67
.74
.74
.37
.34
.38
.63
.78
.60
.61
.87
.31
.22
.22
.27
.27
.42
.32
.37
.32
.32
.54
.43
.38
.38
.39
.54
.44
.44
.43
.52
.47
.47
.49
.49
.57
.56
.56
.58
.56
.56
.61
.61
.65
.65
.72
.72
.80
.80
.54
.35
.37
.63
.38
.67
.50
.81
.78
.52
.20
.34
.24
.24
.30

mm

Inches

8.9
10.4
10.4
11.2
11.2
11.5
11.5
13.1
13.1
13.4
13.4
14.3
14.3
15.4
15.4
17.1
17.1
18.7
18.7
9.3
8.6
9.6
16.0
19.8
15.2
15.4
22.0
7.9
5.5
5.5
6.9
6.9
10.7
8.1
9.3
8.0
8.0
13.6
10.8
9.6
9.6
9.9
13.6
11.2
11.2
10.9
13.2
11.8
11.8
12.4
12.4
14.5
14.3
14.3
14.6
14.3
14.3
15.4
15.4
16.5
16.5
18.3
18.3
20.2
20.2
13.7
8.9
9.4
16.0
9.6
17.1
12.6
20.4
19.9
13.1
5.0
8.6
6.2
6.2
7.7

0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.033
0.033
0.037
0.045
0.052
0.057
0.041
0.062
0.024
0.026
0.026
0.029
0.029
0.030
0.031
0.032
0.032
0.032
0.033
0.034
0.035
0.035
0.037
0.037
0.038
0.038
0.038
0.040
0.040
0.040
0.042
0.042
0.044
0.045
0.045
0.046
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.060
0.031
0.033
0.045
0.031
0.056
0.031
0.046
0.046
0.047
0.018
0.025
0.026
0.026
0.029

mm

TOTAL
MATL
COILS

0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.8
0.8
0.9
1.1
1.3
1.4
1.0
1.6
0.6
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.8
0.8
0.8
0.9
0.9
0.9
0.9
0.9
1.0
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.5
0.8
0.8
1.1
0.8
1.4
0.8
1.2
1.2
1.2
0.5
0.6
0.7
0.7
0.7

10.0
10.8
10.8
11.0
11.0
10.8
10.8
11.5
11.5
11.3
11.3
11.5
11.5
11.9
11.9
12.3
12.3
12.5
12.5
10.0
10.3
10.3
13.0
15.0
9.50
13.8
14.0
12.0
8.38
8.38
9.38
9.38
13.0
10.3
10.5
9.88
9.88
16.3
12.5
10.8
10.8
10.5
13.5
11.6
11.6
11.3
13.0
11.6
11.6
11.6
11.6
13.0
12.5
12.5
12.5
12.0
12.0
12.4
12.4
12.8
12.8
13.1
13.1
13.5
13.5
8.00
10.3
10.3
13.0
11.3
12.0
16.0
17.5
17.0
10.0
11.0
12.5
9.38
9.38
10.5

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SST
SST
MW
SPR
SPR
SPR
SPR
MW
MW
SST
MW
SST
SST
SST
MW
MW
SST
SPR
SST
MW
SST
SST
SST
MW
SST
SPR
SST
MW
SST
MW
SST
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SST
MW
SPR
SST
SPR
SST
SST
SPR
SPR
SST
MW
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
C
C
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
C
CG
C
CG
CG
C
CG
C
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
Z
Z
N
N
N
N
N
N
N
Z
N
N
GI
N
N
N
N
N
N
N
GI
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
Z
N
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

91

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 92

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

71060S
71079
71079S
71097
71097S
71115
71115S
71133
71133S
71151
71151S
71169
71169S
HH-89
71188
71188S
K-45
71210
71210S
71232
71232S
71254
71254S
71275
71275S
2629
11571
S-852
S-100
B14-21
A-61
10110
71043
71043S
71061
71061S
11884
10185
71080
71080S
71098
71098S
71116
71116S
71134
71134S
HH-14
71152
71152S
71170
71170S
H-40
71189
71189S
71211
71211S
71233
71233S
71255
71255S
71276
71276S
B14-50
10205
71044
71044S
S-3048
71063
71063S
10112
71081
71081S
71099
71099S
71117
71117S
71135
71135S
71153
71153S

1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.78
1.81
1.88
1.88
1.88
1.94
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.03
2.06
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
45.2
46.0
47.6
47.6
47.6
49.2
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
51.6
52.4
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2

MATERIAL: MW - Music Wire

92

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.302
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.268
.266
.266
.264
.262
.262
.258
.258
.250
.250
.242
.242
.290
.280
.312
.260
.250
.288
.310
.308
.308
.302
.302
.302
.296
.296
.296
.290
.290
.284
.284
.280
.280
.280
.276
.276
.270
.270
.266
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.244
.278
.308
.308
.302
.302
.302
.298
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276

RATE
mm

7.7
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.8
6.7
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.4
7.1
7.9
6.6
6.4
7.3
7.9
7.8
7.8
7.7
7.7
7.7
7.5
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.1
7.0
7.0
6.9
6.9
6.8
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
6.2
7.1
7.8
7.8
7.7
7.7
7.7
7.6
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0

Lbs./In.

2.8
4.6
3.9
6.2
5.3
8.3
7.0
9.8
8.3
12
10
15
13
12
19
16
16
22
19
26
22
35
30
47
40
5.0
11
.59
15
26
3.8
.63
2.1
1.8
2.8
2.4
1.8
2.7
4.0
3.4
5.3
4.5
7.4
6.2
8.6
7.3
5.3
10
8.8
13
11
12
17
14
20
17
23
19
31
26
41
35
43
11
1.9
1.6
2.7
2.5
2.1
3.4
3.7
3.1
4.7
4.0
6.5
5.5
7.6
6.4
9.1
7.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.49
.81
.68
1.1
.92
1.4
1.2
1.7
1.5
2.1
1.8
2.7
2.3
2.1
3.4
2.9
2.8
3.9
3.3
4.6
3.9
6.2
5.2
8.2
7.0
.87
2.0
.10
2.6
4.6
.66
.11
.37
.31
.49
.42
.31
.47
.70
.60
.93
.79
1.3
1.1
1.5
1.3
.93
1.8
1.5
2.3
2.0
2.1
2.9
2.5
3.4
2.9
4.0
3.4
5.3
4.5
7.1
6.1
7.5
1.8
.33
.28
.48
.44
.37
.60
.65
.55
.82
.70
1.1
.96
1.3
1.1
1.6
1.3

.92
1.1
.88
1.0
.81
.98
.78
.96
.76
.91
.73
.86
.69
.81
.78
.62
.73
.76
.60
.69
.55
.63
.51
.58
.46
.92
.60
1.4
.78
.61
1.2
1.3
1.3
1.0
1.4
1.1
1.4
1.4
1.3
1.0
1.2
.95
1.1
.88
1.1
.87
1.2
1.0
.83
1.0
.80
.86
.90
.71
.87
.69
.79
.63
.73
.58
.67
.53
.44
.69
1.5
1.2
.94
1.5
1.2
1.4
1.4
1.1
1.4
1.1
1.3
1.0
1.2
.99
1.2
.95

mm

23
28
22
26
21
25
20
24
19
23
18
22
17
20
20
16
19
19
15
17
14
16
13
15
12
23
15
35
20
15
30
34
34
26
35
27
37
35
33
26
30
24
28
22
28
22
29
26
21
25
20
22
23
18
22
18
20
16
19
15
17
14
11
18
37
29
24
39
31
35
35
28
34
27
32
25
32
25
30
24

Lbs.

2.6
11
5.1
23
3.4
15
6.3
28
4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33
13
59
9.0
40
9.7
43
15
67
10
45
12
52
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
4.6
20
6.8
30
.82
3.6
11
51
16
71
4.5
20
.83
3.7
2.8
12
1.9
8.3
3.8
17
2.6
11
2.6
11
3.8
17
5.1
23
3.4
15
6.3
28
4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
6.1
27
11
48
7.3
33
13
59
9.0
40
10
45
15
67
10
45
17
76
12
51
18
80
12
54
22
99
15
67
27
121
18
82
19
83
7.3
32
2.8
12
1.9
8.3
2.6
11
3.8
17
2.6
11
4.7
21
5.1
23
3.4
15
6.3
28
4.3
19
8.1
36
5.5
24
9.4
42
6.4
28
11
48
7.3
33

ENDS: C - Closed

G - Ground
O - Open

Inches

.30
.36
.36
.42
.42
.49
.49
.54
.54
.58
.58
.64
.64
.94
.65
.65
.91
.70
.70
.75
.75
.84
.84
.92
.92
.55
.52
.50
1.00
1.09
.76
.68
.27
.27
.35
.35
.55
.61
.40
.40
.49
.49
.54
.54
.60
.60
.84
.65
.65
.73
.73
.89
.73
.73
.79
.79
.85
.85
.95
.95
1.05
1.05
.99
.57
.30
.30
.35
.38
.38
.40
.43
.43
.54
.54
.60
.60
.68
.68
.73
.73

mm

7.7
9.1
9.1
10.8
10.8
12.4
12.4
13.7
13.7
14.7
14.7
16.3
16.3
24.0
16.6
16.6
23.2
17.7
17.7
18.9
18.9
21.3
21.3
23.4
23.4
14.0
13.2
12.6
25.4
27.6
19.2
17.1
6.9
6.9
8.8
8.8
14.0
15.4
10.3
10.3
12.3
12.3
13.8
13.8
15.2
15.2
21.3
16.4
16.4
18.6
18.6
22.7
18.7
18.7
20.1
20.1
21.5
21.5
24.1
24.1
26.6
26.6
25.0
14.6
7.5
7.5
8.8
9.8
9.8
10.2
11.0
11.0
13.7
13.7
15.3
15.3
17.1
17.1
18.5
18.5

WIRE DIA.
Inches

0.029
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.046
0.047
0.047
0.048
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.035
0.040
0.024
0.050
0.055
0.036
0.025
0.026
0.026
0.029
0.029
0.029
0.032
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.040
0.042
0.042
0.045
0.045
0.047
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.058
0.041
0.026
0.026
0.029
0.029
0.029
0.031
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042

mm

TOTAL
MATL
COILS

0.7
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.9
1.0
0.6
1.3
1.4
0.9
0.6
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.5
1.0
0.7
0.7
0.7
0.7
0.7
0.8
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1

10.5
11.3
11.3
12.1
12.1
12.9
12.9
13.5
13.5
13.8
13.8
14.3
14.3
19.5
13.9
13.9
18.0
14.3
14.3
14.6
14.6
15.3
15.3
15.6
15.6
14.8
12.0
20.5
20.0
19.8
21.0
26.0
10.4
10.4
12.0
12.0
18.0
18.0
12.6
12.6
13.9
13.9
14.3
14.3
15.0
15.0
21.0
15.4
15.4
16.3
16.3
19.0
15.6
15.6
16.1
16.1
16.6
16.6
17.3
17.3
17.8
17.8
16.0
14.0
11.4
11.4
11.0
13.3
13.3
13.0
13.5
13.5
15.4
15.4
15.9
15.9
16.9
16.9
17.4
17.4

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
SST
SST
SPR
SPR
MW
MW
SST
MW
SST
MW
MW
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
MW
SST
SST
MW
SST
MW
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
GI
N
N
N
N
N
N
N
N
Z
N
N
N
Z
Z
Z
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 93

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14

71171
71171S
71190
71190S
10347
71212
71212S
71234
71234S
71256
71256S
71277
71277S
U-61A
12229
S-1589
71082
71082S
71100
71100S
71118
71118S
71136
71136S
71154
71154S
3600
71172
71172S
71191
71191S
3788
71213
71213S
12473
71235
71235S
71257
71257S
71278
71278S
LL-12
B10-53
3940
71173
71173S
71192
71192S
71214
71214S
71236
71236S
71258
71258S
71279
71279S
4318
10642
LL-32
12154
71193
71193S
71215
71215S
71237
71237S
71259
71259S
71280
71280S
12805
71194
71194S
71216
71216S
71238
71238S
71260
71260S
71281

2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.28
2.34
2.34
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.63
2.69
2.69
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.81
2.88
2.88
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.9
59.5
59.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
66.7
68.2
68.2
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
71.4
73.0
73.0
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6

I.D.
Inches

.270
.270
.266
.266
.264
.262
.262
.258
.258
.250
.250
.242
.242
.272
.304
.284
.296
.296
.290
.290
.284
.284
.280
.280
.276
.276
.270
.270
.270
.266
.266
.264
.262
.262
.260
.258
.258
.250
.250
.242
.242
.180
.274
.252
.270
.270
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.272
.270
.240
.274
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.290
.266
.266
.262
.262
.258
.258
.250
.250
.242

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

6.9
6.9
6.8
6.8
6.7
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
6.9
7.7
7.2
7.5
7.5
7.4
7.4
7.2
7.2
7.1
7.1
7.0
7.0
6.9
6.9
6.9
6.8
6.8
6.7
6.7
6.7
6.6
6.6
6.6
6.4
6.4
6.1
6.1
4.6
7.0
6.4
6.9
6.9
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
6.9
6.9
6.1
7.0
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.4
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

12
10
15
13
22
17
15
20
17
27
23
36
31
10
1.7
3.7
3.3
2.8
4.2
3.6
5.8
4.9
6.7
5.7
8.2
6.9
10
11
9.0
13
11
10
15
13
15
18
15
24
20
32
27
262
9.7
21
9.6
8.2
12
10
14
12
16
14
22
19
29
25
7.4
7.6
25
5.8
11
9.4
13
11
15
13
20
17
27
23
2.0
10
8.6
12
10
14
12
19
16
25

2.1
1.7
2.6
2.2
3.9
3.0
2.6
3.5
3.0
4.7
4.0
6.3
5.4
1.8
.30
.64
.58
.49
.74
.63
1.0
.86
1.2
1.0
1.4
1.2
1.8
1.8
1.6
2.3
2.0
1.8
2.7
2.3
2.7
3.1
2.7
4.2
3.6
5.6
4.8
46
1.7
3.7
1.7
1.4
2.1
1.8
2.5
2.1
2.8
2.4
3.8
3.3
5.1
4.3
1.3
1.3
4.3
1.0
1.9
1.6
2.2
1.9
2.6
2.2
3.5
3.0
4.7
4.0
.35
1.8
1.5
2.1
1.8
2.4
2.0
3.2
2.8
4.3

1.1
.90
1.0
.81
.52
.99
.79
.90
.72
.83
.66
.76
.60
.89
1.9
1.4
1.5
1.2
1.5
1.2
1.4
1.1
1.4
1.1
1.3
1.1
1.3
1.3
1.0
1.1
.90
1.1
1.1
.88
.80
1.0
.80
.92
.74
.85
.68
.22
.86
.72
1.4
1.1
1.2
.99
1.2
.97
1.1
.88
1.0
.81
.94
.75
1.2
1.3
.78
1.5
1.4
1.1
1.3
1.1
1.2
.96
1.1
.89
1.0
.82
2.0
1.5
1.2
1.4
1.1
1.3
1.0
1.2
.96
1.1

mm

29
23
26
20
13
25
20
23
18
21
17
19
15
22
48
36
39
31
38
31
36
28
36
28
34
27
34
32
25
29
23
29
28
22
20
25
20
23
19
22
17
5.7
22
18
35
28
32
25
31
25
28
22
26
21
24
19
31
32
20
37
35
28
34
27
31
24
28
23
26
21
51
38
30
37
29
33
27
31
24
28

ENDS: C - Closed

G - Ground
O - Open

Lbs.

13
9.0
15
10
12
17
12
18
12
22
15
27
18
9.0
3.3
5.2
5.1
3.4
6.3
4.3
8.1
5.5
9.4
6.4
11
7.3
13
13
9.0
15
10
12
17
12
12
18
12
22
15
27
18
59
8.4
15
13
9.0
15
10
17
12
18
12
22
15
27
18
9.0
9.6
19
8.4
15
10
17
12
18
12
22
15
27
18
4.0
15
10
17
12
18
12
22
15
27

59
40
67
45
52
76
51
80
54
99
67
121
82
40
15
23
23
15
28
19
36
24
42
28
48
33
59
59
40
67
45
52
76
51
54
80
54
99
67
121
82
260
37
68
59
40
67
45
76
51
80
54
99
67
121
82
40
43
86
37
67
45
76
51
80
54
99
67
121
82
18
67
45
76
51
80
54
99
67
121

Inches

.81
.81
.82
.82
.65
.88
.88
.95
.95
1.06
1.06
1.17
1.17
.88
.45
.91
.48
.48
.60
.60
.67
.67
.75
.75
.80
.80
.99
.89
.89
.90
.90
1.30
.97
.97
1.10
1.04
1.04
1.17
1.17
1.29
1.29
1.85
.82
1.20
.97
.97
.98
.98
1.06
1.06
1.14
1.14
1.28
1.28
1.42
1.42
1.16
1.26
1.62
1.25
1.07
1.07
1.15
1.15
1.24
1.24
1.39
1.39
1.53
1.53
1.23
1.16
1.16
1.24
1.24
1.34
1.34
1.49
1.49
1.66

mm

Inches

20.6
20.6
20.7
20.7
16.5
22.4
22.4
24.1
24.1
26.9
26.9
29.6
29.6
22.4
11.4
23.2
12.1
12.1
15.1
15.1
17.0
17.0
19.1
19.1
20.3
20.3
25.1
22.7
22.7
23.0
23.0
32.9
24.7
24.7
27.9
26.4
26.4
29.7
29.7
32.8
32.8
46.9
20.8
30.5
24.7
24.7
24.9
24.9
26.9
26.9
29.0
29.0
32.5
32.5
36.0
36.0
29.3
32.0
41.1
31.7
27.2
27.2
29.2
29.2
31.4
31.4
35.3
35.3
39.0
39.0
31.1
29.4
29.4
31.6
31.6
34.0
34.0
37.7
37.7
42.1

0.045
0.045
0.047
0.047
0.048
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.044
0.028
0.038
0.032
0.032
0.035
0.035
0.038
0.038
0.040
0.040
0.042
0.042
0.045
0.045
0.045
0.047
0.047
0.048
0.049
0.049
0.050
0.051
0.051
0.055
0.055
0.059
0.059
0.090
0.043
0.054
0.045
0.045
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.044
0.045
0.060
0.043
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.035
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059

mm

TOTAL
MATL
COILS

1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.1
0.7
1.0
0.8
0.8
0.9
0.9
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.3
1.4
1.4
1.5
1.5
2.3
1.1
1.4
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.1
1.1
1.5
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.9
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5

18.0
18.0
17.4
17.4
13.5
18.0
18.0
18.6
18.6
19.3
19.3
19.8
19.8
19.0
16.0
24.0
14.9
14.9
17.0
17.0
17.6
17.6
18.8
18.8
19.0
19.0
21.0
19.9
19.9
19.3
19.3
27.0
19.9
19.9
22.0
20.4
20.4
21.3
21.3
21.9
21.9
20.5
18.0
22.3
21.6
21.6
20.9
20.9
21.6
21.6
22.4
22.4
23.3
23.3
24.0
24.0
25.3
27.0
27.0
29.0
22.8
22.8
23.5
23.5
24.3
24.3
25.3
25.3
26.0
26.0
34.0
24.6
24.6
25.4
25.4
26.3
26.3
27.0
27.0
28.1

MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
MW
SST
MW
SST
SPR
MW
SST
SPR
MW
SST
MW
SST
MW
SST
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG

N
N
N
N
Z
N
N
N
N
N
N
N
N
Z
GI
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
Z
N
N
Z
N
N
N
N
N
N
Z
BO
Z
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
Z
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

93

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 94

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.360
0.362
0.364
0.370
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375

9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.14
9.19
9.25
9.40
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53

71281S
10850
71195
71195S
71217
71217S
71239
71239S
71261
71261S
71282
71282S
UU-54
2907
L-33
11422
11515
3053
12265
12117
2623
12202
12745
12694
B4-61
BB-89*
4104
3289
10183
S-1315
K-20
K-69
A-32
A10-38
S-166
10634
B2-47
H-4
10132
V-38
B4-17
3666
AA-66
O-61
F-33
TT-36
A-20
2583
N-36
PP-71
NN-38
B12-33
4254
K-5
CC-46
S-1184
BB-6
10153
S-837
EE-50
938
K-96
MM-77
FF-18
PP-4
S-312
939
S-1477
S-1119
3618
S-867
10813
S-3086
Z-58
F-28
UU-62
10136
10613
BB-37
F-45

3.25
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.75
4.00
4.13
4.38
4.81
4.88
5.25
6.25
6.50
7.63
1.19
2.25
.88
.19
.25
.28
.31
.38
.38
.38
.38
.38
.38
.41
.42
.44
.44
.44
.44
.47
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.53
.53
.53
.53
.53
.56
.56

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

82.6
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
95.3
101.6
104.8
111.1
122.2
123.8
133.4
158.8
165.1
193.7
30.1
57.2
22.2
4.8
6.4
7.1
7.9
9.5
9.5
9.5
9.5
9.5
9.5
10.3
10.7
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
13.5
13.5
13.5
13.5
14.3
14.3

I.D.
Inches

.242
.280
.266
.266
.262
.262
.258
.258
.250
.250
.242
.242
.290
.180
.266
.300
.292
.266
.236
.282
.284
.264
.290
.264
.314
.335
.291
.299
.347
.315
.305
.293
.285
.273
.265
.315
.279
.291
.285
.285
.279
.327
.305
.295
.285
.283
.275
.335
.335
.335
.333
.331
.329
.323
.311
.303
.301
.293
.293
.293
.281
.281
.275
.275
.265
.265
.251
.251
.247
.209
.323
.321
.311
.303
.285
.281
.215
.215
.345
.323

RATE
mm

6.1
7.1
6.8
6.8
6.7
6.7
6.6
6.6
6.4
6.4
6.1
6.1
7.4
4.6
6.8
7.6
7.4
6.8
6.0
7.2
7.2
6.7
7.4
6.7
8.0
8.5
7.4
7.6
8.8
8.0
7.7
7.4
7.2
6.9
6.7
8.0
7.1
7.4
7.2
7.2
7.1
8.3
7.7
7.5
7.2
7.2
7.0
8.5
8.5
8.5
8.5
8.4
8.4
8.2
7.9
7.7
7.6
7.4
7.4
7.4
7.1
7.1
7.0
7.0
6.7
6.7
6.4
6.4
6.3
5.3
8.2
8.2
7.9
7.7
7.2
7.1
5.5
5.5
8.8
8.2

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

21
3.6
5.0
.88
9.4
1.6
8.6
1.4
11
1.9
9.3
1.6
13
2.2
11
1.9
17
3.0
15
2.5
23
4.0
19
3.4
2.0
.35
148
26
6.1
1.1
.91
.16
1.7
.31
5.4
.94
32
5.7
2.1
.37
2.0
.36
3.8
.66
7.7
1.4
18
3.2
5.5
.96
8.9
1.6
121
21
39
6.9
.78
.14
25
4.3
27
4.8
32
5.5
66
11
127
22
116
20
20
3.5
87
15
42
7.4
66
11
82
14
87
15
3.3
.58
16
2.8
33
5.7
94
16
52
9.0
58
10
2.1
.36
1.8
.31
.82
.14
.90
.16
1.9
.34
1.7
.29
2.6
.45
8.1
1.4
20
3.4
17
3.0
31
5.5
32
5.5
44
7.6
99
17
57
9.9
65
11
105
18
100
18
112
20
231
40
201
35
349
61
1096 192
5.4
.94
6.0
1.1
17
2.9
21
3.6
55
9.6
66
12
765 134
706 124
.45
.08
7.7
1.4

.89
1.3
1.6
1.3
1.6
1.2
1.4
1.1
1.3
1.0
1.2
.96
2.3
.40
1.8
3.2
2.5
2.0
.70
3.0
2.9
3.1
.76
.92
.41
.10
.06
.09
.25
.11
.16
.17
.14
.09
.10
.14
.13
.17
.14
.11
.13
.34
.25
.20
.10
.19
.17
.39
.39
.32
.29
.37
.30
.27
.28
.23
.26
.23
.21
.16
.11
.18
.17
.11
.15
.13
.09
.10
.06
.06
.33
.37
.20
.23
.17
.16
.06
.06
.47
.34

mm

23
32
41
32
40
32
36
29
33
26
31
24
59
10
46
81
64
51
18
76
73
78
19
23
10
2.4
1.6
2.3
6.3
2.8
4.1
4.3
3.6
2.3
2.5
3.4
3.2
4.3
3.6
2.9
3.2
8.6
6.5
5.1
2.5
4.8
4.3
9.9
9.9
8.0
7.4
9.3
7.7
6.8
7.0
5.8
6.6
5.7
5.3
4.1
2.7
4.7
4.3
2.8
3.9
3.3
2.4
2.6
1.6
1.5
8.4
9.4
5.1
5.9
4.3
4.0
1.4
1.5
12
8.8

Lbs.

18
6.4
15
10
17
12
18
12
22
15
27
18
4.6
59
11
2.9
4.4
11
23
6.3
5.8
12
5.8
17
2.3
.86
7.5
3.6
.19
2.7
4.4
5.4
9.2
12
12
2.7
11
7.1
9.2
9.2
11
1.1
4.1
6.5
9.2
9.8
9.7
.80
.70
.26
.26
.70
.51
.69
2.2
4.5
4.5
7.0
6.6
7.0
10
10
11
12
15
15
22
21
23
66
1.8
2.2
3.3
4.8
9.2
10
43
43
.21
2.7

82
28
67
45
76
51
80
54
99
67
121
82
20
260
48
13
20
48
101
28
26
52
26
74
10
3.8
34
16
.87
12
20
24
41
52
52
12
50
31
41
41
50
5.0
18
29
41
44
43
3.6
3.1
1.2
1.2
3.1
2.3
3.0
10
20
20
31
29
31
47
47
49
52
69
65
97
92
100
295
7.9
9.9
15
21
41
47
190
190
.95
12

Inches

1.66
.88
1.24
1.24
1.34
1.34
1.43
1.43
1.60
1.60
1.78
1.78
1.23
3.13
1.88
1.17
1.19
2.12
1.67
1.99
1.81
3.36
.43
.95
.18
.07
.13
.19
.06
.12
.18
.21
.20
.20
.28
.13
.26
.19
.20
.18
.26
.13
.21
.24
.21
.25
.30
.11
.11
.19
.21
.13
.20
.23
.22
.17
.24
.23
.21
.23
.24
.26
.28
.23
.33
.28
.31
.31
.32
.37
.12
.16
.13
.18
.27
.28
.40
.42
.09
.13

mm

42.1
22.4
31.5
31.5
33.9
33.9
36.4
36.4
40.7
40.7
45.1
45.1
31.1
79.4
47.8
29.7
30.2
53.7
42.5
50.5
45.8
85.3
11.0
24.1
4.6
1.8
3.2
4.8
1.6
3.0
4.4
5.2
5.1
5.2
7.0
3.3
6.7
4.8
5.2
4.6
6.7
3.2
5.3
6.1
5.4
6.4
7.6
2.8
2.8
4.7
5.3
3.4
5.0
5.9
5.7
4.3
6.1
5.7
5.2
5.7
6.0
6.6
7.0
5.7
8.4
7.2
7.9
7.9
8.1
9.5
3.0
4.1
3.3
4.6
6.9
7.2
10.2
10.7
2.3
3.3

WIRE DIA.
Inches

0.059
0.040
0.047
0.047
0.049
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.035
0.090
0.047
0.030
0.034
0.047
0.062
0.039
0.038
0.048
0.036
0.050
0.028
0.020
0.042
0.038
0.014
0.030
0.035
0.041
0.045
0.051
0.055
0.030
0.048
0.042
0.045
0.045
0.048
0.024
0.035
0.040
0.045
0.046
0.050
0.020
0.020
0.020
0.021
0.022
0.023
0.026
0.032
0.036
0.037
0.041
0.041
0.041
0.047
0.047
0.050
0.050
0.055
0.055
0.062
0.062
0.064
0.083
0.026
0.027
0.032
0.036
0.045
0.047
0.080
0.080
0.015
0.026

mm

TOTAL
MATL
COILS

1.5
1.0
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
0.9
2.3
1.2
0.8
0.9
1.2
1.6
1.0
1.0
1.2
0.9
1.3
0.7
0.5
1.1
1.0
0.4
0.8
0.9
1.0
1.1
1.3
1.4
0.8
1.2
1.1
1.1
1.1
1.2
0.6
0.9
1.0
1.1
1.2
1.3
0.5
0.5
0.5
0.5
0.6
0.6
0.7
0.8
0.9
0.9
1.0
1.0
1.0
1.2
1.2
1.3
1.3
1.4
1.4
1.6
1.6
1.6
2.1
0.7
0.7
0.8
0.9
1.1
1.2
2.0
2.0
0.4
0.7

28.1
22.0
26.4
26.4
27.3
27.3
28.1
28.1
29.1
29.1
30.1
30.1
34.0
34.8
40.0
38.0
34.0
45.0
27.0
50.0
46.5
69.0
11.0
18.0
5.50
2.50
3.00
4.00
3.50
3.00
4.00
5.00
4.50
4.00
5.00
3.25
4.50
4.50
4.50
4.00
4.50
5.33
5.00
5.00
4.75
5.50
6.00
4.50
4.50
8.25
9.00
6.00
7.50
8.00
6.00
4.75
5.50
5.50
5.00
4.50
4.00
5.50
5.50
4.50
6.00
5.00
5.00
5.00
4.00
4.50
4.50
5.00
4.00
5.00
5.00
5.00
5.00
5.25
5.00
4.00

*Rate is calculated only.

MATERIAL: MW - Music Wire

94

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

ENDS: C - Closed

G - Ground
O - Open

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
SPR
MW
SPR
HD
SPR
SPR
SPR
SPR
MW
MW
SST
SST
SPR
SPR
MW
SST
SPR
SST
SPR
SST
SST
SST
SPR
SST
SPR
SPR
SPR
MW
SST
SPR
SPR
SPR
SST
MW
SST
MW
MW
MW
MW
MW
SST
SST
SST
SPR
SST
SPR
HD
SPR
SST
SPR
SPR
SST
HD
SST
SST
MW
SST
MW
SST
SPR
HD
SPR
SPR
SPR
SST
MW

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
CG
CG
C
C
C
C
C
C
C
CG
C
C
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
C
C
C
CG
CG
C
C
C
C
CG
C
C
C
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
C
CG
CG
C
C

N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
Z
Z
Z
GI
Z
Z
Z
N
BO
N
N
Z
Z
Z
N
GI
N
N
N
N
N
N
N
Z
Z
N
Z
N
N
Z
Z
N
Z
N
BO
N
N
Z
Z
N
N
N
Z
N
N
Z
N
N
N
Z
N
Z
N
N
Z
N
Z
N
Z
Z
Z
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 95

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375

9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53

10581
2654
1891
O-75
J-56
I-33
B15-17
W-15
S-908
B14-7
B12-48
OO-63
HH-80
O-90
12433
G-95
10305
Z-8
2603
KK-38
BB-54
516
H-60-A
S-3027
G-97
RR-12
507
F-46
K-70
11311
S-1689
1785
12655
2769
12429
12421
S-892
3637
B12-26
A15-3
I-85
KK-8
H-11
A12-15
4252
FF-52
S-7
B2-7
GG-99
G-99
A-51
526
A-70
I-12
B2-70
291
S-740
12234
B15-61
F-37
II-79
2557
4358
367
KK-39
10905
S-342
A10-11
L-45
940
F-7
10243
S-1455
I-64
S-1450
QQ-15
F-52
JJ-81
363
11288

.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.64
.66
.66
.66
.69
.69
.69
.69
.69
.69
.69
.69
.69
.70
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.81
.81
.81
.81
.81
.81
.84
.84
.88
.88
.88

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.3
16.7
16.7
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.9
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2

I.D.
Inches

.317
.299
.285
.283
.281
.277
.211
.323
.301
.289
.347
.335
.331
.327
.323
.323
.317
.315
.303
.295
.289
.281
.281
.273
.263
.255
.251
.249
.231
.225
.325
.323
.323
.211
.327
.321
.311
.305
.305
.297
.283
.271
.251
.333
.343
.341
.335
.333
.325
.323
.319
.313
.297
.295
.295
.293
.291
.291
.285
.283
.281
.279
.275
.267
.247
.343
.325
.285
.267
.329
.323
.305
.301
.297
.267
.289
.285
.335
.329
.325

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

8.1
7.6
7.2
7.2
7.1
7.0
5.4
8.2
7.6
7.3
8.8
8.5
8.4
8.3
8.2
8.2
8.1
8.0
7.7
7.5
7.3
7.1
7.1
6.9
6.7
6.5
6.4
6.3
5.9
5.7
8.3
8.2
8.2
5.4
8.3
8.2
7.9
7.7
7.7
7.5
7.2
6.9
6.4
8.5
8.7
8.7
8.5
8.5
8.3
8.2
8.1
8.0
7.5
7.5
7.5
7.4
7.4
7.4
7.2
7.2
7.1
7.1
7.0
6.8
6.3
8.7
8.3
7.2
6.8
8.4
8.2
7.7
7.6
7.5
6.8
7.3
7.2
8.5
8.4
8.3

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

7.6
1.3
26
4.6
41
7.2
45
7.9
50
8.8
80
14
646 113
2.4
.42
15
2.7
38
6.7
.59
.10
1.5
.26
1.7
.30
1.6
.28
5.2
.90
2.4
.42
3.5
.61
4.7
.83
15
2.7
17
2.9
34
5.9
46
8.0
36
6.3
68
12
145
25
119
21
160
28
186
33
278
49
421
74
5.7
1.0
5.2
.90
5.6
.98
704 123
3.7
.64
6.0
1.1
4.1
.71
11
1.9
14
2.4
21
3.6
28
4.9
62
11
173
30
.55
.10
.34
.06
.24
.04
.75
.13
.55
.10
2.8
.50
5.2
.90
3.7
.64
7.7
1.3
17
3.0
24
4.3
24
4.3
23
4.0
22
3.9
24
4.2
30
5.2
36
6.3
31
5.4
35
6.1
65
11
67
12
146
26
.33
.06
1.7
.29
24
4.2
67
12
2.6
.46
4.8
.83
9.1
1.6
7.8
1.4
13
2.3
32
5.6
27
4.7
30
5.2
.89
.16
2.6
.46
2.7
.48

.41
.22
.23
.22
.19
.15
.07
.35
.31
.21
.56
.51
.46
.41
.47
.40
.34
.39
.37
.34
.24
.23
.27
.17
.11
.15
.14
.12
.11
.08
.28
.50
.47
.09
.54
.49
.34
.40
.32
.29
.25
.21
.13
.40
.61
.54
.57
.45
.56
.52
.55
.42
.34
.27
.37
.31
.32
.31
.31
.27
.30
.35
.18
.22
.16
.63
.56
.36
.22
.66
.56
.48
.45
.47
.16
.30
.31
.72
.73
.58

mm

10
5.5
5.7
5.5
5.0
3.8
1.8
8.8
8.0
5.4
14
13
12
10
12
10
8.5
9.8
9.5
8.5
6.1
5.8
6.9
4.4
2.9
3.7
3.5
3.1
2.9
2.2
7.1
13
12
2.3
14
13
8.5
10
8.2
7.5
6.4
5.4
3.2
10
15
14
14
11
14
13
14
11
8.5
6.8
9.4
7.8
8.1
7.9
7.9
6.9
7.7
9.0
4.6
5.5
4.2
16
14
9.1
5.5
17
14
12
11
12
4.2
7.6
7.9
18
18
15

ENDS: C - Closed

G - Ground
O - Open

Lbs.

3.1
5.6
9.2
9.8
9.8
12
45
.82
4.9
8.1
.33
.75
.78
.65
2.4
.96
1.2
1.8
5.8
5.5
8.1
10
9.8
12
16
17
22
23
32
36
1.6
2.6
2.7
64
2.0
3.0
1.4
4.4
4.4
6.1
7.0
13
22
.22
.21
.13
.42
.24
1.6
2.7
2.0
3.2
5.7
6.5
9.0
7.0
7.1
7.5
9.2
9.8
9.3
12
12
15
24
.21
.92
8.6
15
1.7
2.7
4.4
3.5
6.1
5.3
8.1
9.2
.64
1.9
1.6

14
25
41
44
44
53
201
3.7
22
36
1.4
3.3
3.5
2.9
11
4.3
5.2
8.1
26
25
36
47
44
52
73
77
97
102
142
159
7.1
11
12
285
8.9
13
6.0
20
20
27
31
58
97
.97
.91
.57
1.9
1.1
7.1
12
9.1
14
25
29
40
31
31
34
41
44
41
55
52
65
107
.92
4.1
38
65
7.8
12
20
16
27
23
36
41
2.8
8.5
7.1

Inches

.15
.19
.27
.28
.31
.29
.49
.25
.22
.24
.07
.12
.17
.22
.16
.22
.29
.24
.25
.29
.26
.34
.35
.34
.34
.48
.45
.38
.50
.45
.13
.16
.15
.55
.14
.16
.35
.28
.21
.24
.44
.36
.37
.31
.14
.21
.18
.31
.18
.16
.20
.22
.25
.24
.28
.32
.33
.34
.38
.37
.45
.40
.35
.46
.48
.15
.23
.41
.41
.15
.16
.28
.36
.34
.65
.34
.38
.16
.15
.18

mm

Inches

3.9
4.8
6.9
7.0
7.8
7.5
12.5
6.3
5.6
6.0
1.8
3.0
4.2
5.5
4.0
5.6
7.4
6.1
6.4
7.4
6.6
8.8
9.0
8.7
8.5
12.2
11.5
9.6
12.8
11.4
3.2
4.0
3.8
13.9
3.7
4.1
8.9
7.1
5.3
6.2
11.1
9.2
9.4
7.7
3.7
5.4
4.6
7.7
4.4
4.0
5.0
5.7
6.4
6.1
7.1
8.1
8.3
8.5
9.7
9.3
11.3
10.1
8.9
11.7
12.2
3.8
5.7
10.3
10.3
3.8
4.1
7.1
9.2
8.7
16.5
8.7
9.7
4.1
3.8
4.6

0.029
0.038
0.045
0.046
0.047
0.049
0.082
0.026
0.037
0.043
0.014
0.020
0.022
0.024
0.026
0.026
0.029
0.030
0.036
0.040
0.043
0.047
0.047
0.051
0.056
0.060
0.062
0.063
0.072
0.075
0.025
0.026
0.026
0.082
0.024
0.027
0.032
0.035
0.035
0.039
0.046
0.052
0.062
0.021
0.016
0.017
0.020
0.021
0.025
0.026
0.028
0.031
0.039
0.040
0.040
0.041
0.042
0.042
0.045
0.046
0.047
0.048
0.050
0.054
0.064
0.016
0.025
0.045
0.054
0.023
0.026
0.035
0.037
0.039
0.054
0.043
0.045
0.020
0.023
0.025

mm

TOTAL
MATL
COILS

0.7
1.0
1.1
1.2
1.2
1.2
2.1
0.7
0.9
1.1
0.4
0.5
0.6
0.6
0.7
0.7
0.7
0.8
0.9
1.0
1.1
1.2
1.2
1.3
1.4
1.5
1.6
1.6
1.8
1.9
0.6
0.7
0.7
2.1
0.6
0.7
0.8
0.9
0.9
1.0
1.2
1.3
1.6
0.5
0.4
0.4
0.5
0.5
0.6
0.7
0.7
0.8
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.2
1.2
1.2
1.3
1.4
1.6
0.4
0.6
1.1
1.4
0.6
0.7
0.9
0.9
1.0
1.4
1.1
1.1
0.5
0.6
0.6

5.25
5.00
6.00
6.00
5.50
5.00
6.00
8.50
6.00
5.50
4.00
5.00
6.50
8.00
5.00
8.50
9.00
8.00
6.00
7.25
6.00
6.33
7.50
5.75
5.00
7.00
6.33
6.00
7.00
6.00
4.00
5.00
4.75
5.67
5.00
5.00
10.0
7.00
6.00
6.25
8.50
7.00
6.00
13.5
8.00
11.5
8.00
13.5
6.00
5.00
7.00
6.25
6.50
6.00
6.00
6.75
6.75
7.00
7.50
7.00
8.50
8.25
6.00
7.50
7.50
8.25
9.00
8.00
7.50
5.50
5.25
8.00
9.75
8.75
12.0
7.00
7.50
7.00
5.50
6.25

MW
SPR
SPR
SPR
SST
SPR
SPR
MW
SST
SPR
MW
SST
MW
SST
MW
MW
MW
MW
MW
SST
SPR
HD
SPR
SST
SPR
MW
HD
HD
SPR
SPR
SST
MW
MW
MW
MW
MW
SST
SPR
SPR
SPR
SPR
SPR
SPR
MW
MW
SST
SST
MW
SST
MW
SST
HD
SST
SPR
MW
HD
SST
SPR
SPR
HD
SPR
MW
SPR
HD
SPR
MW
SST
SST
SPR
MW
MW
SPR
SST
SPR
SST
SPR
SPR
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
C
C
CG
C
CG
CG
C
C
C
C
C
CG
C
CG
C
CG
CG
C
CG
C
C
C
C
CG
CG
CG
C
C
C
C
C
C
C
C
CG
CG
C
CG
CG
C
C
C
C
CL
C
C
CG
C
CG
CG
C
C
C
C
C
C
C
CG
C
C
CG
C
CG
C
CG
C
C
CG
CG
CG
CG
C
C
C
C
C

F
N
S
H

Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
GI
N
Z
Z
Z
N
Z
Z
Z
N
N
N
Z
Z
N
Z
N
Z
N
Z
GI
N
N
Z
N
N
N
Z
Z
N
Z
N
N
N
N
N
N
Z
N
GI
N
Z
N
Z
N
Z
Z
Z
Z
Z
Z
N
N
N
N
Z
Z
Z
N
Z
N
Z
Z
N
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

95

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 96

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375

9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53

3093
S-46
I-89
DD-90
2571
S-736
N-95
UU-33
S-741
3616
B14-59
Y-25
885
B9-15
S-492
B3-38
K-42
10263
A11-58
F-38
O-45
12310
S-1008
2928
B11-36
A-78
H-7
3230
HH-74
U-26
S-737
10763
O-156
3577
3595
S-742
XX-64
TT-58
B15-39
200
Z-37
L-10
10220
B3-42
4290
10067
GG-92
Z-48
2542
10038
B11-61
11871
A10-70
S-913
S-3039
B11-22
U-3
11755
519
F-44
10078
FF-90
N-111
501
S-851
HH-44
2661
II-55
GG-84
B10-37
S-1146
TT-61
S-738
10017
3677
S-743
3847
10797
GG-11
LL-61

.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.94
.94
.94
.94
.94
.94
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.06
1.06
1.06
1.06
1.09
1.09
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.19
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.0
23.0
23.8
23.8
23.8
23.8
23.8
23.8
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.0
27.0
27.0
27.0
27.8
27.8
27.8
27.8
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
29.4
30.2
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5

MATERIAL: MW - Music Wire

96

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.319
.317
.315
.315
.313
.311
.305
.297
.291
.281
.271
.255
.215
.317
.305
.269
.335
.325
.315
.285
.281
.279
.273
.251
.319
.335
.327
.315
.315
.315
.311
.305
.297
.293
.291
.291
.289
.285
.285
.281
.281
.249
.231
.215
.313
.321
.307
.297
.285
.281
.325
.323
.265
.249
.327
.315
.309
.307
.293
.285
.279
.265
.251
.231
.319
.315
.293
.277
.265
.293
.325
.319
.311
.307
.293
.291
.281
.279
.275
.275

RATE
mm

8.1
8.1
8.0
8.0
8.0
7.9
7.7
7.5
7.4
7.1
6.9
6.5
5.5
8.1
7.7
6.8
8.5
8.3
8.0
7.2
7.1
7.1
6.9
6.4
8.1
8.5
8.3
8.0
8.0
8.0
7.9
7.7
7.5
7.4
7.4
7.4
7.3
7.2
7.2
7.1
7.1
6.3
5.9
5.5
8.0
8.2
7.8
7.5
7.2
7.1
8.3
8.2
6.7
6.3
8.3
8.0
7.8
7.8
7.4
7.2
7.1
6.7
6.4
5.9
8.1
8.0
7.4
7.0
6.7
7.4
8.3
8.1
7.9
7.8
7.4
7.4
7.1
7.1
7.0
7.0

Lbs./In.

3.6
1.4
4.1
3.9
3.3
7.2
4.8
16
19
33
69
86
328
4.6
6.0
52
1.1
4.8
5.4
23
33
36
38
77
2.1
.48
1.2
4.4
5.0
3.0
6.2
5.4
11
14
17
16
17
18
18
27
22
166
174
353
4.7
1.4
7.7
12
23
25
3.3
1.2
50
84
.66
3.5
5.3
7.5
13
21
26
44
75
154
1.3
3.5
11
19
38
12
1.9
1.9
4.8
4.8
14
12
23
22
28
19

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.63
.25
.71
.68
.57
1.3
.84
2.8
3.4
5.8
12
15
57
.81
1.0
9.2
.20
.83
.95
4.1
5.8
6.4
6.6
13
.37
.08
.21
.76
.88
.52
1.1
.95
1.9
2.4
3.0
2.8
2.9
3.2
3.2
4.6
3.8
29
30
62
.82
.24
1.3
2.0
4.1
4.4
.57
.22
8.8
15
.12
.62
.93
1.3
2.3
3.6
4.5
7.6
13
27
.22
.62
1.9
3.3
6.7
2.1
.33
.34
.84
.85
2.4
2.2
4.1
3.8
5.0
3.4

.63
.35
.61
.59
.47
.46
.46
.38
.37
.32
.19
.22
.13
.69
.56
.27
.77
.50
.73
.39
.32
.31
.31
.26
.63
.76
.74
.72
.54
.63
.53
.58
.55
.55
.57
.44
.48
.46
.48
.40
.45
.14
.18
.12
.75
.63
.52
.52
.39
.42
.72
.73
.31
.26
.71
.80
.73
.57
.53
.45
.43
.33
.27
.21
.70
.86
.64
.55
.40
.58
.84
.86
.69
.81
.52
.57
.45
.49
.41
.57

mm

16
9.0
15
15
12
12
12
9.7
9.4
8.0
4.8
5.5
3.3
18
14
6.8
20
13
18
10
8.0
7.8
7.9
6.5
16
19
19
18
14
16
14
15
14
14
15
11
12
12
12
10
12
3.5
4.7
3.1
19
16
13
13
10
11
18
19
7.8
6.5
18
20
19
14
14
11
11
8.5
6.9
5.2
18
22
16
14
10
15
21
22
17
21
13
14
11
12
11
14

Lbs.

2.3
.50
2.5
2.3
1.5
3.3
2.2
6.1
7.1
10
13
19
43
3.2
3.3
14
.86
2.4
4.0
9.2
10
11
12
20
1.3
.36
.88
3.1
2.7
1.9
3.3
3.1
6.1
7.5
9.8
7.1
8.1
8.4
8.6
10
9.8
23
32
43
3.5
.88
3.9
6.1
9.2
10
2.4
.91
15
22
.47
2.8
3.9
4.2
7.0
9.2
11
15
21
32
.90
3.0
7.0
10
15
7.0
1.6
1.6
3.3
3.9
7.0
7.1
10
10
12
11

ENDS: C - Closed

G - Ground
O - Open

10
2.2
11
10
6.8
15
9.7
27
31
47
58
83
190
14
15
62
3.8
11
18
41
47
50
52
88
5.9
1.6
3.9
14
12
8.3
15
14
27
33
43
31
36
37
38
47
44
102
142
190
16
3.9
18
27
41
47
11
4.0
69
96
2.1
13
17
19
31
41
50
65
92
142
4.0
14
31
46
69
31
7.1
7.3
15
17
31
31
47
46
52
49

Inches

.25
.52
.27
.29
.40
.24
.42
.33
.36
.42
.39
.48
.72
.21
.35
.45
.14
.14
.21
.45
.42
.43
.45
.68
.34
.25
.26
.29
.24
.38
.26
.42
.43
.45
.43
.40
.47
.54
.50
.49
.47
.41
.72
.76
.28
.43
.29
.37
.41
.52
.18
.36
.55
.61
.42
.33
.36
.29
.46
.50
.50
.55
.62
.86
.46
.33
.49
.64
.69
.49
.23
.39
.31
.44
.45
.48
.54
.53
.56
.70

mm

6.3
13.3
6.9
7.2
10.2
6.1
10.7
8.4
9.1
10.7
9.9
12.2
18.3
5.4
8.9
11.4
3.6
3.7
5.3
11.4
10.7
11.0
11.3
17.3
8.5
6.2
6.7
7.2
6.1
9.5
6.7
10.7
10.9
11.5
10.8
10.1
12.0
13.7
12.6
12.5
11.9
10.4
18.3
19.3
7.1
11.0
7.3
9.4
10.3
13.1
4.4
9.2
14.0
15.6
10.7
8.4
9.2
7.3
11.7
12.6
12.8
14.0
15.7
21.9
11.6
8.4
12.5
16.2
17.5
12.5
5.7
10.0
7.9
11.2
11.5
12.3
13.7
13.4
14.3
17.8

WIRE DIA.
Inches

0.028
0.029
0.030
0.030
0.031
0.032
0.035
0.039
0.042
0.047
0.052
0.060
0.080
0.029
0.035
0.053
0.020
0.025
0.030
0.045
0.047
0.048
0.051
0.062
0.028
0.020
0.024
0.030
0.030
0.030
0.032
0.035
0.039
0.041
0.042
0.042
0.043
0.045
0.045
0.047
0.047
0.063
0.072
0.080
0.031
0.027
0.034
0.039
0.045
0.047
0.025
0.026
0.055
0.063
0.024
0.030
0.033
0.034
0.041
0.045
0.048
0.055
0.062
0.072
0.028
0.030
0.041
0.049
0.055
0.041
0.025
0.028
0.032
0.034
0.041
0.042
0.047
0.048
0.050
0.050

mm

TOTAL
MATL
COILS

0.7
0.7
0.8
0.8
0.8
0.8
0.9
1.0
1.1
1.2
1.3
1.5
2.0
0.7
0.9
1.3
0.5
0.6
0.8
1.1
1.2
1.2
1.3
1.6
0.7
0.5
0.6
0.8
0.8
0.8
0.8
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.6
1.8
2.0
0.8
0.7
0.9
1.0
1.1
1.2
0.6
0.7
1.4
1.6
0.6
0.8
0.8
0.9
1.0
1.1
1.2
1.4
1.6
1.8
0.7
0.8
1.0
1.2
1.4
1.0
0.6
0.7
0.8
0.9
1.0
1.1
1.2
1.2
1.3
1.3

7.75
17.0
9.00
8.50
12.0
6.50
12.0
7.50
7.50
8.00
6.50
8.00
9.00
7.33
10.0
8.50
6.00
4.75
7.00
9.00
8.00
8.00
8.75
11.0
12.0
11.3
10.0
8.50
7.00
11.5
7.25
11.0
10.0
10.0
9.00
8.50
10.0
11.0
10.0
9.50
10.0
6.50
10.0
8.50
9.00
15.0
7.50
9.50
9.00
10.0
6.00
13.0
10.0
9.75
16.5
10.0
10.0
8.50
10.3
10.0
10.5
10.0
10.0
11.0
16.3
10.0
12.0
13.0
12.5
11.0
8.00
13.0
8.75
12.0
10.0
10.5
10.5
11.0
11.3
14.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
SST
SPR
SST
HD
SPR
SST
HD
MW
SST
SPR
SST
MW
MW
SPR
SPR
SPR
SST
HD
MW
SST
SST
MW
SST
MW
SST
SST
SPR
MW
MW
SST
SPR
SPR
SST
HD
SST
SPR
SPR
SPR
MW
MW
SST
SPR
SPR
SPR
MW
SST
SPR
SST
SST
MW
SPR
SPR
HD
SPR
SPR
SST
SST
HD
SST
MW
SPR
SST
SPR
SPR
SST
MW
SST
SPR
SPR
SST
SPR
SST
SPR
SST

E
N
D
S

C
C
CG
C
C
C
CG
C
C
C
C
CG
CG
CG
CG
CG
C
C
CG
C
C
C
CG
CG
CG
C
C
C
C
C
C
C
C
C
C
C
C
C
C
C
CG
CG
CG
C
CG
C
C
CG
CG
C
C
C
CG
CG
C
C
C
CG
C
C
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
C
C
C
C
C
C
CG
CG
CG

F
N
S
H

Z
N
Z
N
Z
N
N
Z
N
Z
Z
N
Z
GI
N
N
N
Z
N
Z
Z
Z
N
GI
N
N
N
Z
N
N
N
N
GI
GI
GI
N
Z
GI
N
Z
N
N
GI
N
Z
Z
N
GI
Z
Z
Z
N
Z
N
N
N
Z
Z
Z
Z
Z
N
N
Z
N
N
GI
N
Z
N
N
Z
N
Z
Z
N
Z
N
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 97

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375

9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53

B-11
V-60
10032
12400
UU-68
3507
S-207
S-282
H-44
S-1067
12712
10579
3936
N-125
FF-87
FF-94
4183
111
S-1421
30
S-14
2551
S-739
3820
G-73
S-744
S-1216
2554
J-50
10001
MM-42
3712
YY-56
B2-46
4268
2650
L-46
10998
10167
UU-59
S-1442
3904
3316
TT-63
525
12480
114
12293
3037
3941
11587
CC-94
4363
S-1382
10192
10284
S-442
OO-91
384
3605
17
II-77
12759
B2-52
2579
3631
B18-172
11225
I-37
MM-57
12686
14
2788
4180
K-57
3928
3557
12471
S-1122
S-1621

1.28
1.31
1.31
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.39
1.41
1.41
1.44
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.56
1.56
1.56
1.56
1.59
1.69
1.69
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.78
1.78
1.81
1.81
1.88
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.03
2.06
2.19
2.25
2.25
2.25
2.25
2.38
2.38
2.38
2.38
2.50
2.53

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

32.5
33.3
33.3
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.3
35.7
35.7
36.5
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
39.7
39.7
39.7
39.7
40.5
42.8
42.8
44.5
44.5
44.5
44.5
44.5
44.5
44.5
45.2
45.2
46.0
46.0
47.6
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
51.6
52.4
55.6
57.2
57.2
57.2
57.2
60.3
60.3
60.3
60.3
63.5
64.3

I.D.
Inches

.263
.305
.285
.341
.327
.315
.293
.257
.247
.231
.307
.335
.313
.315
.315
.281
.341
.325
.321
.319
.317
.315
.311
.299
.293
.291
.287
.285
.285
.281
.275
.263
.245
.213
.335
.299
.295
.275
.319
.231
.215
.335
.325
.325
.307
.305
.293
.281
.287
.251
.287
.285
.281
.335
.319
.315
.311
.295
.293
.285
.281
.281
.281
.279
.275
.263
.251
.233
.247
.315
.317
.251
.251
.247
.327
.307
.293
.275
.251
.285

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

6.7
7.7
7.2
8.7
8.3
8.0
7.4
6.5
6.3
5.9
7.8
8.5
8.0
8.0
8.0
7.1
8.7
8.3
8.2
8.1
8.1
8.0
7.9
7.6
7.4
7.4
7.3
7.2
7.2
7.1
7.0
6.7
6.2
5.4
8.5
7.6
7.5
7.0
8.1
5.9
5.5
8.5
8.3
8.3
7.8
7.7
7.4
7.1
7.3
6.4
7.3
7.2
7.1
8.5
8.1
8.0
7.9
7.5
7.4
7.2
7.1
7.1
7.1
7.1
7.0
6.7
6.4
5.9
6.3
8.0
8.1
6.4
6.4
6.3
8.3
7.8
7.4
7.0
6.4
7.2

Lbs./In.

29
4.3
15
.22
.96
3.7
8.6
51
68
142
6.1
.51
5.4
3.1
3.8
13
.19
1.7
3.0
2.6
2.1
2.6
3.9
8.2
9.7
10
16
16
12
20
24
33
78
325
.49
7.3
8.5
27
2.6
93
166
.57
1.0
.84
3.7
3.7
8.2
15
11
46
11
11
19
.56
1.5
2.0
2.0
5.8
7.1
11
12
10
14
15
17
36
44
73
50
2.6
1.9
34
39
45
1.0
2.7
5.5
14
23
7.9

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

5.1
.76
2.6
.04
.17
.64
1.5
8.8
12
25
1.1
.09
.95
.54
.66
2.3
.03
.31
.53
.46
.37
.45
.69
1.4
1.7
1.8
2.8
2.7
2.1
3.5
4.3
5.9
14
57
.09
1.3
1.5
4.7
.46
16
29
.10
.18
.15
.65
.64
1.4
2.6
1.9
8.1
2.0
1.9
3.3
.10
.26
.35
.36
1.0
1.3
1.9
2.1
1.8
2.5
2.5
3.1
6.4
7.7
13
8.8
.45
.34
5.9
6.8
7.8
.18
.47
.95
2.4
4.1
1.4

.33
.86
.62
1.1
1.1
1.1
.76
.35
.35
.21
.97
1.1
.82
.88
.72
.64
1.2
1.2
.66
1.2
1.1
1.1
.84
.68
.68
.69
.50
.59
.73
.73
.45
.49
.44
.14
1.3
.77
.77
.44
1.3
.34
.24
1.5
1.4
1.3
1.1
1.1
.85
.71
.79
.47
.76
.79
.55
1.5
1.6
1.5
1.4
1.1
.98
1.2
.88
.94
.74
1.1
.93
.62
.47
.42
.48
1.6
1.3
.65
.56
.54
2.0
1.6
1.5
.85
.76
1.1

mm

8.4
22
16
28
27
27
19
9.0
8.9
5.3
25
29
21
22
18
16
31
31
17
30
29
27
21
17
17
17
13
15
18
19
11
12
11
3.5
33
20
20
11
32
8.7
6.1
38
34
33
29
29
22
18
20
12
19
20
14
39
39
38
36
29
25
30
22
24
19
27
24
16
12
11
12
40
32
16
14
14
52
40
37
22
19
28

ENDS: C - Closed

G - Ground
O - Open

Lbs.

9.6
3.7
9.2
.24
1.0
3.9
6.6
18
24
30
5.9
.59
4.5
2.7
2.7
8.5
.23
2.2
2.0
3.2
2.4
2.8
3.3
5.6
6.6
7.1
8.1
9.2
8.6
15
11
16
35
44
.63
5.6
6.5
12
3.3
32
40
.86
1.4
1.1
4.2
4.1
7.0
10
8.6
22
8.6
8.6
10
.86
2.3
3.0
2.9
6.5
7.0
13
10
9.8
10
15
16
23
21
31
24
4.1
2.5
22
22
24
2.0
4.2
8.0
12
18
8.6

42
17
41
1.1
4.5
17
29
79
107
133
26
2.6
20
12
12
38
1.0
9.6
8.9
14
11
12
15
25
29
31
36
41
38
65
49
73
155
197
2.8
25
29
52
15
142
178
3.8
6.0
4.8
19
18
31
47
38
97
38
38
47
3.8
10
13
13
29
31
57
47
44
47
69
72
101
92
136
107
18
11
97
97
107
9.1
19
36
52
79
38

Inches

.95
.46
.63
.26
.31
.32
.57
.68
.88
.76
.37
.26
.28
.33
.29
.80
.28
.26
.22
.31
.38
.42
.36
.44
.49
.56
.48
.61
.63
.61
.58
.84
.85
.77
.27
.52
.58
.64
.31
1.22
1.20
.24
.40
.46
.54
.53
.67
.73
.68
1.05
.70
.68
.59
.22
.45
.51
.58
.76
.75
.81
.93
.87
.75
.86
.85
.78
.99
1.40
1.15
.39
.41
1.46
1.23
1.34
.34
.71
.90
1.05
1.74
.97

mm

Inches

24.2
11.6
16.0
6.5
7.9
8.2
14.6
17.2
22.4
19.2
9.5
6.6
7.1
8.4
7.2
20.3
7.2
6.7
5.7
7.8
9.6
10.7
9.1
11.1
12.5
14.1
12.3
15.4
16.0
15.5
14.6
21.3
21.5
19.6
6.9
13.3
14.7
16.2
7.8
31.1
30.5
6.1
10.2
11.7
13.8
13.3
16.9
18.5
17.3
26.8
17.9
17.1
14.9
5.6
11.4
13.0
14.6
19.3
19.0
20.6
23.6
22.1
19.1
21.9
21.6
19.9
25.2
35.6
29.3
9.9
10.3
37.0
31.3
34.1
8.5
18.1
22.9
26.7
44.1
24.6

0.056
0.035
0.045
0.017
0.024
0.030
0.041
0.059
0.064
0.072
0.034
0.020
0.031
0.030
0.030
0.047
0.017
0.025
0.027
0.028
0.029
0.030
0.032
0.038
0.041
0.042
0.044
0.045
0.045
0.047
0.050
0.056
0.065
0.081
0.020
0.038
0.040
0.050
0.028
0.072
0.080
0.020
0.025
0.025
0.034
0.035
0.041
0.047
0.044
0.062
0.044
0.045
0.047
0.020
0.028
0.030
0.032
0.040
0.041
0.045
0.047
0.047
0.047
0.048
0.050
0.056
0.062
0.071
0.064
0.030
0.029
0.062
0.062
0.064
0.024
0.034
0.041
0.050
0.062
0.045

mm

TOTAL
MATL
COILS

1.4
0.9
1.1
0.4
0.6
0.8
1.0
1.5
1.6
1.8
0.9
0.5
0.8
0.8
0.8
1.2
0.4
0.6
0.7
0.7
0.7
0.8
0.8
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.3
1.4
1.7
2.1
0.5
1.0
1.0
1.3
0.7
1.8
2.0
0.5
0.6
0.6
0.9
0.9
1.0
1.2
1.1
1.6
1.1
1.1
1.2
0.5
0.7
0.8
0.8
1.0
1.0
1.1
1.2
1.2
1.2
1.2
1.3
1.4
1.6
1.8
1.6
0.8
0.7
1.6
1.6
1.6
0.6
0.9
1.0
1.3
1.6
1.1

17.0
13.0
13.0
14.0
12.0
9.75
13.0
11.5
13.8
10.5
10.0
12.0
8.00
10.0
8.50
17.0
15.8
9.50
7.25
10.0
12.0
13.0
10.3
11.5
12.0
12.3
10.0
12.5
14.0
12.0
11.5
15.0
13.0
9.50
12.5
12.8
13.5
11.8
10.0
17.0
14.0
11.0
15.0
17.5
15.0
15.0
15.3
15.5
15.5
17.0
15.0
15.0
12.5
10.0
16.0
16.0
18.0
19.0
17.3
17.0
18.8
18.5
16.0
17.0
17.0
14.0
16.0
19.8
18.0
13.0
13.0
22.5
20.0
20.0
13.0
20.0
22.0
21.0
28.0
20.5

HD
SST
SPR
MW
SST
MW
SST
SST
SPR
SST
MW
MW
MW
SST
SST
SPR
MW
MW
SST
MW
SST
MW
SST
SPR
SST
SST
SST
SPR
SST
MW
SST
SPR
MW
SPR
MW
SPR
SPR
HD
MW
HD
SST
MW
MW
MW
HD
SST
HD
SPR
SPR
SPR
SPR
SST
SPR
SST
MW
MW
SST
SPR
HD
MW
HD
SST
HD
MW
MW
MW
SST
SPR
SPR
MW
SST
HD
SPR
SPR
MW
SPR
MW
SPR
SST
SST

E
N
D
S

F
N
S
H

CG
CG
C
C
C
C
C
CG
CG
CG
C
C
C
C
C
CG
C
C
C
C
C
C
C
CG
CG
C
C
C
CG
C
CG
CG
CG
CG
C
C
C
C
C
CG
C
C
C
C
C
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
C
C
C
CG
CG
CG
C

GI
N
Z
N
N
Z
N
N
GI
N
N
Z
Z
N
N
GI
N
Z
N
Z
N
Z
N
Z
N
N
N
Z
N
Z
N
Z
Z
N
BO
Z
N
Z
Z
Z
N
Z
Z
Z
Z
N
Z
GI
GI
Z
N
N
Z
N
Z
Z
N
N
Z
Z
Z
N
Z
N
Z
Z
N
Z
Z
GI
N
Z
Z
Z
GI
Z
Z
Z
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

97

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 98

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.375
0.380
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390

9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.53
9.65
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91

11733
I-48
11981
B2-49
12537
12201
12257
10002
B17-177
1713
10921
3134
S-1335
12007
2545
2947
3921
12210
4301
B4-7
10600
10173
3103
517
12649
508
A12-31
K-73
10472
FF-12
A13-57
DD-61
DD-79
O-49
MM-30
10946
O-77
W-8
G-79
H-84
71283
71283S
71298
71298S
S-144
71284
71284S
71299
71299S
K-64
10331
WW-8
M-84
FF-99
S-47
71285
71285S
71300
71300S
I-23
AA-28
71286
71286S
71301
71301S
B5-64
PP-91
71287
71287S
2862
71302
71302S
B9-5
3604
K-82
71288
71288S
71303
71303S
11290

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

2.59
2.63
2.66
2.75
2.91
3.00
3.00
3.00
3.19
3.34
3.38
3.47
3.50
3.50
3.50
3.63
3.75
3.75
3.75
4.00
4.00
4.50
7.50
9.00
10.5
12.0
1.00
.25
.31
.34
.38
.38
.41
.44
.44
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.56
.56
.56
.56
.56
.59
.63
.63
.63
.63
.63
.63
.63
.63
.69
.69
.69
.69
.69
.69
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.81
.81
.81
.81
.81

mm

65.9
66.7
67.5
69.9
73.9
76.2
76.2
76.2
81.0
84.9
85.7
88.1
88.9
88.9
88.9
92.1
95.3
95.3
95.3
101.6
101.6
114.3
190.5
228.6
266.7
304.8
25.4
6.4
7.9
8.7
9.5
9.5
10.3
11.1
11.1
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
14.2
14.2
14.2
14.2
14.3
15.1
15.9
15.9
15.9
15.9
16.0
16.0
16.0
16.0
17.4
17.4
17.5
17.5
17.5
17.5
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6
20.6

MATERIAL: MW - Music Wire

98

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.250
.295
.295
.291
.231
.313
.291
.281
.281
.299
.273
.267
.313
.295
.263
.293
.247
.245
.231
.329
.275
.275
.251
.281
.299
.251
.338
.310
.346
.290
.320
.286
.320
.326
.310
.340
.330
.324
.316
.310
.304
.304
.296
.296
.220
.304
.304
.296
.296
.336
.328
.360
.344
.270
.266
.304
.304
.296
.296
.328
.310
.304
.304
.296
.296
.372
.310
.304
.304
.296
.296
.296
.278
.272
.266
.304
.304
.296
.296
.348

RATE
mm

6.4
7.5
7.5
7.4
5.9
8.0
7.4
7.1
7.1
7.6
6.9
6.8
8.0
7.5
6.7
7.4
6.3
6.2
5.9
8.4
7.0
7.0
6.4
7.1
7.6
6.4
8.6
7.9
8.8
7.4
8.1
7.3
8.1
8.3
7.9
8.6
8.4
8.2
8.0
7.9
7.7
7.7
7.5
7.5
5.6
7.7
7.7
7.5
7.5
8.5
8.3
9.1
8.7
6.9
6.8
7.7
7.7
7.5
7.5
8.3
7.9
7.7
7.7
7.5
7.5
9.4
7.9
7.7
7.7
7.5
7.5
7.5
7.1
6.9
6.8
7.7
7.7
7.5
7.5
8.8

Lbs./In.

N/mm

33
5.7
5.8
1.0
6.1
1.1
6.4
1.1
56
9.7
1.5
.26
6.5
1.1
10
1.8
6.6
1.2
2.7
.47
11
2.0
13
2.4
1.4
.25
4.7
.82
16
2.8
3.2
.56
22
3.8
23
4.1
40
6.9
3.7
.65
6.2
1.1
6.9
1.2
12
2.0
2.6
.44
1.1
.19
5.9
1.0
1.1
.19
75
13
1.2
.22
114
20
28
4.8
118
21
21
3.8
7.3
1.3
25
4.3
4.1
.72
6.2
1.1
9.4
1.6
15
2.7
25
4.4
42
7.3
35
6.2
59
10
50
8.8
920 161
36
6.4
31
5.4
51
9.0
44
7.6
3.2
.56
14
2.5
.48
.08
1.4
.24
148
26
105
18
32
5.6
27
4.7
45
8.0
39
6.8
8.2
1.4
19
3.3
29
5.0
24
4.2
41
7.1
34
6.0
.03
.01
12
2.2
26
4.6
22
3.9
35
6.1
35
6.0
29
5.1
95
17
120
21
150
26
24
4.2
20
3.6
34
5.9
29
5.0
1.2
.22

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.69 17
1.1
28
1.1
27
1.1
28
.57 15
2.2
57
1.2
29
1.0
26
1.6
40
2.1
53
1.1
28
1.1
28
2.1
54
1.4
36
1.0
26
2.1
54
1.1
28
1.1
27
.80 20
.53 14
1.8
46
1.7
43
1.9
48
4.2 107
5.1 129
3.7
94
.82 21
.08
2.0
.13
3.2
.09
2.4
.15
3.9
.10
2.6
.20
5.0
.25
6.2
.22
5.5
.33
8.4
.29
7.4
.27
6.8
.28
7.1
.24
6.0
.26
6.6
.21
5.2
.24
6.0
.19
4.8
.05
1.3
.30
7.5
.24
6.0
.27
6.9
.22
5.5
.35
8.8
.30
7.6
.54 14
.44 11
.13
3.3
.19
4.8
.34
8.6
.27
6.9
.31
7.8
.25
6.2
.49 12
.31
7.9
.38
9.6
.30
7.7
.35
8.8
.27
7.0
.68 17
.39
9.9
.41 10
.33
8.4
.29
7.4
.41 10
.32
8.2
.17
4.2
.21
5.4
.14
3.6
.45 11
.36
9.1
.42 11
.33
8.4
.67 17

Lbs.

22
6.5
6.5
7.1
32
3.3
7.5
10
10
5.6
12
15
3.0
6.5
16
6.8
24
25
32
2.0
11
12
22
10
5.6
22
.90
5.9
.15
11
4.3
12
4.3
1.8
5.3
1.4
1.8
2.5
4.3
5.9
11
7.3
14
9.5
46
11
7.3
14
9.5
1.1
4.3
.26
.60
19
20
11
7.3
14
9.5
4.0
5.9
11
7.3
14
9.5
.02
4.9
11
7.3
10
14
9.5
16
25
21
11
7.3
14
9.5
.82

ENDS: C - Closed

G - Ground
O - Open

100
29
29
31
142
15
34
47
47
25
55
65
13
29
73
30
107
111
142
8.7
50
52
97
47
25
97
4.0
26
.68
47
19
53
19
8.0
24
6.0
8.0
11
19
26
48
32
62
42
205
48
32
62
42
4.9
19
1.2
2.7
85
88
48
32
62
42
18
26
48
32
62
42
.10
22
48
32
45
62
42
70
113
94
48
32
62
42
3.6

Inches

mm

1.56 39.7
.79 20.1
.76 19.3
.78 19.7
2.02 51.2
.78 19.7
.90 22.9
1.06 26.9
1.50 38.2
1.23 31.2
1.43 36.3
1.65 41.8
.71 18.1
.96 24.4
1.72 43.6
1.52 38.5
2.50 63.4
2.54 64.4
2.66 67.7
.13
3.2
2.20 55.9
2.00 50.8
3.91 99.2
3.88 98.5
2.74 69.5
7.44 189.0
.18
4.5
.12
3.0
.19
4.7
.19
4.8
.13
3.3
.21
5.3
.15
3.8
.19
4.9
.22
5.6
.14
3.5
.21
5.3
.23
5.9
.22
5.6
.20
5.1
.21
5.3
.21
5.3
.24
6.0
.24
6.0
.38
9.7
.23
5.7
.23
5.7
.25
6.4
.25
6.4
.22
5.5
.12
3.1
.08
2.1
.18
4.7
.39
9.9
.43 11.0
.25
6.3
.25
6.3
.28
7.0
.28
7.0
.20
5.1
.24
6.1
.26
6.7
.26
6.7
.29
7.5
.29
7.5
.07
1.8
.36
9.1
.28
7.1
.28
7.1
.38
9.6
.33
8.4
.33
8.4
.34
8.5
.35
9.0
.37
9.4
.30
7.5
.30
7.5
.33
8.5
.33
8.5
.15
3.7

WIRE DIA.
Inches

mm

0.063
0.040
0.040
0.042
0.072
0.031
0.042
0.047
0.047
0.038
0.051
0.054
0.031
0.040
0.056
0.041
0.064
0.065
0.072
0.023
0.050
0.050
0.062
0.047
0.038
0.062
0.021
0.040
0.022
0.050
0.035
0.052
0.035
0.032
0.040
0.025
0.030
0.033
0.037
0.040
0.043
0.043
0.047
0.047
0.085
0.043
0.043
0.047
0.047
0.027
0.031
0.015
0.023
0.060
0.062
0.043
0.043
0.047
0.047
0.031
0.040
0.043
0.043
0.047
0.047
0.009
0.040
0.043
0.043
0.047
0.047
0.047
0.056
0.059
0.062
0.043
0.043
0.047
0.047
0.021

1.6
1.0
1.0
1.1
1.8
0.8
1.1
1.2
1.2
1.0
1.3
1.4
0.8
1.0
1.4
1.0
1.6
1.7
1.8
0.6
1.3
1.3
1.6
1.2
1.0
1.6
0.5
1.0
0.6
1.3
0.9
1.3
0.9
0.8
1.0
0.6
0.8
0.8
0.9
1.0
1.1
1.1
1.2
1.2
2.2
1.1
1.1
1.2
1.2
0.7
0.8
0.4
0.6
1.5
1.6
1.1
1.1
1.2
1.2
0.8
1.0
1.1
1.1
1.2
1.2
0.2
1.0
1.1
1.1
1.2
1.2
1.2
1.4
1.5
1.6
1.1
1.1
1.2
1.2
0.5

FINISH: Z - Zinc

TOTAL
MATL
COILS
24.0
18.8
18.0
18.5
27.0
24.0
20.5
21.5
32.0
31.3
27.0
29.5
22.0
23.0
29.7
36.0
39.0
39.0
37.0
4.50
44.0
40.0
62.0
81.5
71.0
119.0
7.50
3.00
7.50
3.75
3.75
4.00
4.25
6.00
5.50
4.50
6.00
6.00
6.00
5.00
4.88
4.88
5.00
5.00
4.50
5.25
5.25
5.38
5.38
7.00
4.00
4.50
8.00
5.50
7.00
5.75
5.75
5.88
5.88
5.50
6.00
6.13
6.13
6.25
6.25
7.00
8.00
6.50
6.50
7.00
7.00
7.00
6.00
6.00
6.00
6.88
6.88
7.13
7.13
6.00

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
SST
SPR
MW
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
MW
SPR
SPR
SPR
HD
SPR
HD
MW
SST
MW
SST
SPR
SST
SPR
SST
SPR
SST
MW
SPR
SPR
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
MW
SST
MW
SPR
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
SPR
MW
HD
MW
SST
MW
SST
SST

E
N
D
S

F
N
S
H

CG
C
C
CG
C
C
C
C
CG
C
C
C
C
C
C
C
CG
CG
CG
C
CG
CG
C
C
O
C
C
CG
C
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C

Z
N
Z
N
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
N
Z
N
Z
Z
Z
Z
N
Z
Z
N
Z
N
N
N
N
N
Z
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
BO
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
Z
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 99

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390

9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91

NN-47
HH-18
A-91
CC-78
11448
10919
B10-16
H-31
3845
B15-34
AA-44
3781
71289
71289S
71304
71304S
S-1694
3576
A10-26
BB-8
MM-43
71290
71290S
71305
71305S
10955
S-912
U-30
A12-14
EE-98
A-82
O-154
71291
71291S
71306
71306S
PP-6
B9-28
B10-23
H-61
S-1130
4134
71292
71292S
71307
71307S
K-7
G-55
3243
A-90
A10-5
YY-67
B4-19
71293
71293S
71308
71308S
S-304
3002
U-56
12132
S-894
QQ-54
3850
10037
A-89
71294
71294S
71309
71309S
LL-77
NN-54
HH-54
MM-84
71295
71295S
71310
71310S
3073
12638

.81
.81
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.94
.94
.94
.94
.94
.94
.97
.97
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.06
1.06
1.13
1.13
1.13
1.13
1.13
1.13
1.19
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.44
1.47
1.47
1.50
1.50
1.50
1.50
1.50
1.53
1.69

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

20.6
20.6
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.4
22.4
22.4
22.4
23.0
23.0
23.0
23.8
23.8
23.9
23.9
23.9
23.9
24.6
24.6
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
27.0
27.0
28.6
28.6
28.7
28.7
28.7
28.7
30.2
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
34.1
34.9
34.9
34.9
35.1
35.1
35.1
35.1
36.5
37.3
37.3
38.1
38.1
38.1
38.1
38.1
38.9
42.8

I.D.
Inches

.334
.326
.342
.340
.332
.330
.322
.320
.310
.310
.290
.266
.304
.304
.296
.296
.334
.320
.306
.350
.230
.304
.304
.296
.296
.344
.308
.262
.346
.344
.320
.308
.304
.304
.296
.296
.290
.272
.274
.262
.360
.260
.304
.304
.296
.296
.316
.308
.290
.262
.340
.346
.344
.304
.304
.296
.296
.266
.264
.264
.262
.260
.318
.330
.328
.308
.304
.304
.296
.296
.308
.322
.276
.308
.304
.304
.296
.296
.296
.312

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

8.5
8.3
8.7
8.6
8.4
8.4
8.2
8.1
7.9
7.9
7.4
6.8
7.7
7.7
7.5
7.5
8.5
8.1
7.8
8.9
5.8
7.7
7.7
7.5
7.5
8.7
7.8
6.7
8.8
8.7
8.1
7.8
7.7
7.7
7.5
7.5
7.4
6.9
7.0
6.7
9.1
6.6
7.7
7.7
7.5
7.5
8.0
7.8
7.4
6.7
8.6
8.8
8.7
7.7
7.7
7.5
7.5
6.8
6.7
6.7
6.7
6.6
8.1
8.4
8.3
7.8
7.7
7.7
7.5
7.5
7.8
8.2
7.0
7.8
7.7
7.7
7.5
7.5
7.5
7.9

Lbs./In.

2.8
6.3
1.6
2.7
4.8
5.5
14
6.0
17
13
34
100
22
19
29
24
4.0
4.7
15
.75
395
20
17
28
24
1.5
12
73
1.2
.49
8.8
13
19
16
27
23
24
84
54
99
.15
107
17
14
24
20
7.2
9.8
23
103
1.9
.68
1.1
15
13
21
18
43
76
79
82
52
6.8
4.2
2.9
9.2
13
11
19
16
8.3
4.6
34
8.1
12
10
17
15
13
6.1

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.49
1.1
.28
.47
.84
.97
2.5
1.0
3.0
2.2
5.9
18
3.8
3.2
5.0
4.2
.71
.82
2.6
.13
69
3.5
3.0
5.0
4.2
.26
2.1
13
.22
.09
1.5
2.2
3.3
2.8
4.7
4.0
4.2
15
9.5
17
.03
19
2.9
2.5
4.1
3.5
1.3
1.7
4.1
18
.33
.12
.20
2.6
2.2
3.6
3.1
7.5
13
14
14
9.1
1.2
.73
.50
1.6
2.3
2.0
3.3
2.8
1.5
.81
6.0
1.4
2.1
1.8
3.0
2.6
2.3
1.1

.57
.50
.66
.57
.50
.47
.29
.56
.37
.47
.32
.21
.49
.39
.49
.39
.53
.48
.45
.77
.10
.53
.43
.49
.39
.77
.53
.30
.78
.55
.48
.53
.58
.46
.52
.42
.45
.22
.30
.23
.96
.23
.65
.52
.59
.47
.65
.65
.48
.22
.82
.96
1.0
.73
.58
.67
.54
.35
.29
.28
.28
.34
.94
.94
1.0
.69
.81
.64
.75
.59
.76
.82
.48
.83
.88
.70
.82
.65
.76
.90

mm

14
13
17
14
13
12
7.3
14
9.3
12
8.0
5.3
13
10
12
9.9
13
12
11
20
2.7
14
11
13
9.9
20
14
7.5
20
14
12
14
15
12
13
11
11
5.6
7.7
5.9
24
5.8
17
13
15
12
16
16
12
5.7
21
24
26
19
15
17
14
8.9
7.4
7.2
7.2
8.6
24
24
25
17
20
16
19
15
19
21
12
21
22
18
21
17
19
23

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.6
3.2
1.1
1.5
2.4
2.6
4.1
3.4
6.3
5.9
11
21
11
7.3
14
9.5
2.1
2.2
6.8
.58
41
11
7.3
14
9.5
1.1
6.3
22
.96
.27
4.3
6.8
11
7.3
14
9.5
11
18
16
23
.14
24
11
7.3
14
9.5
4.7
6.3
11
23
1.5
.65
1.1
11
7.3
14
9.5
15
22
22
23
18
6.4
3.9
2.9
6.3
11
7.3
14
9.5
6.3
3.8
17
6.8
11
7.3
14
9.5
10
5.5

7.1
14
4.8
6.8
11
12
18
15
28
26
47
94
48
32
62
42
9.5
10
30
2.6
185
48
32
62
42
5.1
28
97
4.3
1.2
19
30
48
32
62
42
47
81
73
103
.64
108
48
32
62
42
21
28
50
103
6.8
2.9
5.1
48
32
62
42
67
98
98
103
78
28
17
13
28
48
32
62
42
28
17
74
30
48
32
62
42
45
24

Inches

.25
.24
.22
.17
.20
.21
.20
.32
.28
.32
.40
.50
.32
.32
.38
.38
.20
.43
.35
.17
.56
.34
.34
.38
.38
.20
.37
.66
.19
.45
.30
.43
.35
.35
.40
.40
.53
.46
.54
.58
.17
.65
.39
.39
.44
.44
.39
.47
.64
.56
.19
.29
.24
.43
.43
.49
.49
.90
.66
.71
.74
.94
.40
.27
.37
.45
.46
.46
.53
.53
.49
.37
.80
.60
.50
.50
.57
.57
.71
.55

mm

Inches

6.2
6.1
5.5
4.3
5.2
5.3
5.2
8.0
7.1
8.1
10.2
12.6
8.1
8.1
9.7
9.7
5.0
10.9
8.8
4.2
14.2
8.6
8.6
9.7
9.7
5.0
9.4
16.7
4.7
11.4
7.6
10.9
9.0
9.0
10.1
10.1
13.3
11.6
13.6
14.6
4.2
16.5
10.0
10.0
11.2
11.2
9.9
12.0
16.2
14.2
4.8
7.3
6.0
10.9
10.9
12.4
12.4
22.8
16.8
18.0
18.7
23.9
10.1
6.9
9.4
11.5
11.7
11.7
13.4
13.4
12.5
9.5
20.3
15.4
12.7
12.7
14.5
14.5
17.9
13.9

0.028
0.032
0.024
0.025
0.029
0.030
0.034
0.035
0.040
0.040
0.050
0.062
0.043
0.043
0.047
0.047
0.028
0.035
0.042
0.020
0.080
0.043
0.043
0.047
0.047
0.023
0.041
0.064
0.022
0.023
0.035
0.041
0.043
0.043
0.047
0.047
0.050
0.059
0.058
0.064
0.015
0.065
0.043
0.043
0.047
0.047
0.037
0.041
0.050
0.064
0.025
0.022
0.023
0.043
0.043
0.047
0.047
0.062
0.063
0.063
0.064
0.065
0.036
0.030
0.031
0.041
0.043
0.043
0.047
0.047
0.041
0.034
0.057
0.041
0.043
0.043
0.047
0.047
0.047
0.039

mm

TOTAL
MATL
COILS

0.7
0.8
0.6
0.6
0.7
0.8
0.9
0.9
1.0
1.0
1.3
1.6
1.1
1.1
1.2
1.2
0.7
0.9
1.1
0.5
2.0
1.1
1.1
1.2
1.2
0.6
1.0
1.6
0.6
0.6
0.9
1.0
1.1
1.1
1.2
1.2
1.3
1.5
1.5
1.6
0.4
1.7
1.1
1.1
1.2
1.2
0.9
1.0
1.3
1.6
0.6
0.6
0.6
1.1
1.1
1.2
1.2
1.6
1.6
1.6
1.6
1.7
0.9
0.8
0.8
1.0
1.1
1.1
1.2
1.2
1.0
0.9
1.4
1.0
1.1
1.1
1.2
1.2
1.2
1.0

7.75
6.50
8.00
5.75
6.00
6.00
5.00
9.00
7.00
8.00
8.00
8.00
7.38
7.38
8.13
8.13
6.00
12.3
8.25
7.25
7.00
7.88
7.88
8.13
8.13
7.50
9.00
10.3
7.50
18.5
7.50
9.50
8.25
8.25
8.50
8.50
10.5
7.75
9.25
9.00
10.0
9.00
9.13
9.13
9.38
9.38
9.50
10.5
11.8
8.75
7.50
12.0
9.25
10.0
10.0
10.4
10.4
14.5
10.5
10.3
10.5
14.5
10.0
8.00
12.0
11.0
10.8
10.8
11.3
11.3
12.0
10.0
14.0
13.8
11.6
11.6
12.1
12.1
15.0
13.0

SST
SST
MW
SST
SST
SST
SPR
SST
SPR
SST
SST
HD
MW
SST
MW
SST
SST
HD
SST
SST
SPR
MW
SST
MW
SST
MW
SST
SST
MW
MW
SPR
SPR
MW
SST
MW
SST
SST
SPR
SST
SPR
SST
SPR
MW
SST
MW
SST
SST
SST
SPR
HD
SST
MW
MW
MW
SST
MW
SST
SST
SPR
SPR
SPR
SST
MW
MW
MW
SST
MW
SST
MW
SST
SST
SST
SPR
SPR
MW
SST
MW
SST
SPR
SST

E
N
D
S

F
N
S
H

C
C
C
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
C
C
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
C
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C

N
N
N
N
N
N
N
N
Z
N
N
Z
N
N
N
N
N
GI
N
N
BO
N
N
N
N
Z
N
N
Z
Z
Z
GI
N
N
N
N
N
Z
N
Z
N
Z
N
N
N
N
N
N
Z
N
N
Z
N
N
N
N
N
N
Z
Z
Z
N
Z
Z
Z
N
N
N
N
N
N
N
GI
BO
N
N
N
N
Z
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

99

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:25 AM Page 100

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.390
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406

9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
9.91
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31

L-34
BB-76
71296
71296S
71311
71311S
2922
H-86
3314
TT-29
I-50
10086
2607
71297
71297S
71312
71312S
2764
2943
2883
GG-86
EE-96
11396
S-1337
3392
10901
11465
BB-78
B-62
12533
J-41
A-66
M-24
S-1096
W-28
BB-42
JJ-12
EE-89
N-63
A10-55
GG-69
K-95
J-17
I-98
B7-22
10843
3629
A12-13
B11-32
H-1
XX-35
XX-47
OO-45
3718
J-4
I-55
A-2
S-1480
O-2
10798
11086
Q-39
S-865
N-31
B15-12
V-6
S-1195
A9-63
BB-13
3569
S-1231
B10-2
YY-46
PP-3
V-7
NN-88
S-16
II-89
FF-8
10857

1.75
1.75
1.75
1.75
1.75
1.75
1.81
1.88
1.88
1.88
1.88
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.03
2.13
2.25
2.50
2.69
3.25
3.38
3.50
4.75
.38
.38
.41
.41
.41
.41
.44
.44
.44
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.54
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.66
.69
.69
.69
.69
.72
.72
.75
.75
.75
.75
.75
.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

44.5
44.5
44.5
44.5
44.5
44.5
46.0
47.6
47.6
47.6
47.6
50.8
50.8
50.8
50.8
50.8
50.8
50.8
51.6
54.0
57.2
63.5
68.2
82.6
85.7
88.9
120.7
9.5
9.5
10.3
10.3
10.3
10.3
11.1
11.1
11.1
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.7
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
16.7
17.4
17.4
17.4
17.4
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1

MATERIAL: MW - Music Wire

100

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.350
.346
.304
.304
.296
.296
.348
.350
.296
.290
.276
.310
.308
.304
.304
.296
.296
.296
.338
.296
.326
.210
.282
.288
.298
.314
.326
.368
.336
.370
.370
.348
.306
.356
.350
.306
.358
.348
.334
.332
.326
.282
.272
.242
.328
.278
.232
.364
.360
.354
.352
.350
.346
.324
.316
.358
.358
.350
.346
.330
.308
.358
.344
.300
.284
.284
.276
.342
.346
.344
.336
.278
.342
.326
.352
.346
.344
.332
.326
.298

RATE
mm

8.9
8.8
7.7
7.7
7.5
7.5
8.8
8.9
7.5
7.4
7.0
7.9
7.8
7.7
7.7
7.5
7.5
7.5
8.6
7.5
8.3
5.3
7.2
7.3
7.6
8.0
8.3
9.3
8.5
9.4
9.4
8.8
7.8
9.0
8.9
7.8
9.1
8.8
8.5
8.4
8.3
7.2
6.9
6.1
8.3
7.1
5.9
9.2
9.1
9.0
8.9
8.9
8.8
8.2
8.0
9.1
9.1
8.9
8.8
8.4
7.8
9.1
8.7
7.6
7.2
7.2
7.0
8.7
8.8
8.7
8.5
7.1
8.7
8.3
8.9
8.8
8.7
8.4
8.3
7.6

Lbs./In.

.33
.53

N/mm

.06
.09
10
1.8
8.9
1.6
15
2.5
12
2.2
.40
.07
.35
.06
17
3.0
14
2.5
28
5.0
5.1
.90
6.4
1.1
9.8
1.7
8.3
1.5
13
2.2
11
1.9
9.7
1.7
1.5
.27
11
1.9
2.0
.36
184
32
17
3.0
10
1.8
7.5
1.3
3.8
.67
1.24
.218
.94
.16
21
3.7
1.5
.26
.86
.15
6.3
1.1
72
13
2.2
.39
7.3
1.3
66
12
1.9
.33
6.3
1.1
16
2.8
15
2.7
25
4.4
161
28
297
52
678 119
27
4.7
172
30
846 148
2.1
.37
1.8
.31
2.6
.46
4.9
.85
3.3
.57
4.4
.77
17
2.9
56
9.8
1.4
.25
1.4
.25
4.7
.83
5.5
.96
16
2.8
31
5.4
3.4
.60
2.8
.49
76
13
162
28
108
19
141
25
3.6
.63
4.1
.72
3.1
.55
9.4
1.6
151
26
4.8
.84
16
2.7
1.8
.31
3.1
.55
2.4
.43
9.3
1.6
11
1.9
51
8.9

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

Lbs.

1.4
1.4
1.0
.82
.96
.77
1.5
1.6
.58
.75
.58
1.2
1.3
1.1
.88
1.1
.88
1.0
1.7
.95
1.6
.30
.83
1.1
1.3
1.4
2.55
.28
.19
.33
.30
.26
.15
.26
.28
.16
.36
.33
.28
.30
.24
.13
.09
.06
.21
.13
.06
.43
.42
.38
.38
.34
.35
.28
.15
.38
.40
.43
.41
.33
.24
.49
.28
.16
.12
.18
.16
.30
.48
.35
.41
.15
.43
.36
.48
.45
.38
.45
.43
.27

36
37
26
21
24
19
37
39
15
19
15
31
32
28
22
28
22
27
43
24
40
7.6
21
28
32
36
64.77
7.1
4.9
8.3
7.6
6.6
3.8
6.7
7.2
4.2
9.0
8.3
7.1
7.5
6.2
3.2
2.2
1.5
5.3
3.3
1.5
11
11
9.7
9.6
8.6
8.9
7.0
3.9
9.6
10
11
10
8.3
6.0
13
7.2
4.1
3.1
4.6
4.0
7.7
12
8.8
10
3.8
11
9.2
12
11
9.6
12
11
6.8

.46
.77
11
7.3
14
9.5
.58
.54
10
11
17
6.3
8.0
11
7.3
14
9.5
10
2.6
10
3.2
55
14
11
9.5
5.4
3.16
.26
4.1
.49
.26
1.7
11
.58
2.1
11
.66
2.1
4.4
4.5
6.1
20
25
40
5.6
22
51
.92
.76
.99
1.8
1.1
1.5
4.6
8.6
.54
.57
2.0
2.3
5.2
7.3
1.7
.78
12
19
19
22
1.1
2.0
1.1
3.8
22
2.1
5.7
.84
1.4
.92
4.2
4.8
14

ENDS: C - Closed

G - Ground
O - Open

2.1
3.4
48
32
62
42
2.6
2.4
45
47
74
28
36
48
32
62
42
45
11
45
14
246
63
50
42
24
14.12
1.2
18
2.2
1.1
7.3
48
2.6
9.2
48
2.9
9.2
20
20
27
91
113
179
25
99
226
4.1
3.4
4.4
8.2
4.9
6.9
20
38
2.4
2.5
9.0
10
23
33
7.5
3.5
54
87
87
98
4.9
8.8
4.8
17
99
9.2
25
3.7
6.3
4.1
19
21
61

Inches

.34
.31
.57
.57
.66
.66
.36
.32
.61
.80
.94
.75
.74
.60
.60
.74
.74
.94
.29
.86
.54
1.89
1.19
1.25
1.10
.76
.83
.10
.14
.08
.11
.15
.24
.18
.14
.25
.14
.17
.18
.20
.20
.33
.30
.37
.18
.35
.44
.11
.14
.18
.15
.22
.21
.29
.19
.22
.19
.17
.18
.22
.36
.13
.34
.27
.37
.40
.39
.35
.20
.34
.25
.38
.29
.25
.27
.30
.37
.30
.32
.41

mm

8.6
7.8
14.5
14.5
16.7
16.7
9.1
8.1
15.5
20.3
23.9
19.1
18.7
15.3
15.3
18.8
18.8
23.9
7.3
21.9
13.8
48.0
30.2
31.7
28.0
19.3
21.1
2.4
3.6
2.1
2.7
3.7
6.0
4.4
3.6
6.4
3.7
4.4
4.6
5.2
5.1
8.3
7.7
9.4
4.5
8.9
11.0
2.7
3.5
4.6
3.8
5.7
5.3
7.3
4.9
5.5
4.9
4.3
4.6
5.6
9.0
3.4
8.7
6.7
9.3
10.1
9.9
8.9
5.1
8.7
6.2
9.8
7.3
6.4
6.9
7.6
9.4
7.5
8.1
10.3

WIRE DIA.
Inches

0.020
0.022
0.043
0.043
0.047
0.047
0.021
0.020
0.047
0.050
0.057
0.040
0.041
0.043
0.043
0.047
0.047
0.047
0.026
0.047
0.032
0.090
0.054
0.051
0.046
0.038
0.032
0.019
0.035
0.018
0.018
0.029
0.050
0.025
0.028
0.050
0.024
0.029
0.036
0.037
0.040
0.062
0.067
0.082
0.039
0.064
0.087
0.021
0.023
0.026
0.027
0.028
0.030
0.041
0.045
0.024
0.024
0.028
0.030
0.038
0.049
0.024
0.031
0.053
0.061
0.061
0.065
0.032
0.030
0.031
0.035
0.064
0.032
0.040
0.027
0.030
0.031
0.037
0.040
0.054

mm

TOTAL
MATL
COILS

0.5
0.6
1.1
1.1
1.2
1.2
0.5
0.5
1.2
1.3
1.4
1.0
1.0
1.1
1.1
1.2
1.2
1.2
0.7
1.2
0.8
2.3
1.4
1.3
1.2
1.0
0.8
0.5
0.9
0.5
0.5
0.7
1.3
0.6
0.7
1.3
0.6
0.7
0.9
0.9
1.0
1.6
1.7
2.1
1.0
1.6
2.2
0.5
0.6
0.7
0.7
0.7
0.8
1.0
1.1
0.6
0.6
0.7
0.8
1.0
1.2
0.6
0.8
1.3
1.5
1.5
1.7
0.8
0.8
0.8
0.9
1.6
0.8
1.0
0.7
0.8
0.8
0.9
1.0
1.4

16.0
13.0
13.3
13.3
14.0
14.0
16.0
15.0
12.0
16.0
16.5
18.8
17.0
14.0
14.0
15.8
15.8
20.0
11.0
18.3
16.0
21.0
21.0
23.5
23.0
20.0
25.0
5.00
4.00
3.50
5.00
5.00
4.75
6.00
4.00
5.00
6.00
5.00
5.00
5.50
5.00
5.25
4.50
4.50
4.50
5.50
5.00
4.00
6.00
6.00
4.50
7.00
7.00
7.00
4.25
8.00
8.00
5.00
6.00
5.75
7.25
4.50
10.0
5.00
5.00
6.50
6.00
10.0
6.75
10.0
6.00
6.00
8.00
6.25
10.0
9.00
11.0
7.00
8.00
7.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
MW
HD
SST
SPR
SPR
MW
MW
SST
MW
SST
HD
MW
SPR
SST
SPR
HD
SST
SPR
SPR
SST
SST
SPR
SST
MW
MW
SPR
SST
SST
SPR
SST
MW
SPR
SPR
SPR
HD
SPR
SST
SPR
SPR
SPR
SST
MW
SST
SST
MW
MW
SPR
SPR
MW
MW
SST
MW
SPR
SST
MW
SST
SST
SPR
SPR
SST
MW
SST
MW
SST
SPR
MW
SST
MW
MW
SST
SST
SST
SPR

E
N
D
S

F
N
S
H

C
C
CG
CG
CG
CG
C
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
C
C
CG
C
C
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
CG
C
CG
CG
C
CG
C
C
CG
C
CG
CG
C
C
C
CG
CG

Z
N
N
N
N
N
Z
Z
Z
N
GI
N
GI
N
N
N
N
Z
Z
Z
N
N
Z
N
Z
N
N
N
Z
N
N
N
N
N
N
N
N
Z
Z
N
Z
Z
GI
N
Z
N
GI
N
N
N
N
Z
N
Z
Z
BO
N
N
N
BO
N
N
N
N
N
N
N
Z
N
Z
N
N
Z
N
N
Z
N
N
N
GI

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 101

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406

10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31

4327
K-81
A12-27
10811
S-1323
10155
A-53
A10-30
N-49
PP-96
2865
1559
V-52
10125
PP-73
GG-82
I-96
GG-90
S-134
3745
10539
1545
U-11
B-4
2863
L-58
G-64
W-3
10963
U-86
S-1152
S-265
S-477
S-1046
V-65
3607
3624
3919
941
A-49
3901
QQ-39
EE-55
M-108
JJ-96
3794
H-41
3696
S-119
B8-50
O-57
B12-31
3508
N-117
FF-84
FF-40
3766
A15-46
S-1682
Y-35
A12-16
B11-70
3538
12530
B2-67
I-39
V-33
A9-45
Z-62
EE-53
4250
S-471
1533
10216
12242
942
B3-39
3621
H-45
I-18

.75
.75
.80
.81
.81
.81
.81
.81
.81
.81
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.94
.94
.94
.94
.94
.97
.97
.98
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.06
1.06
1.06
1.06
1.06
1.09
1.09
1.13
1.13
1.13
1.19
1.19
1.19
1.19
1.20
1.25
1.25
1.25
1.28
1.31
1.31
1.31
1.31
1.34
1.38
1.38
1.44
1.44
1.50
1.50
1.59
1.63
1.63
1.63
1.69
1.72

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

19.1
19.1
20.3
20.6
20.6
20.6
20.6
20.6
20.6
20.6
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.8
23.8
23.8
23.8
23.8
24.6
24.6
25.0
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.0
27.0
27.0
27.0
27.0
27.8
27.8
28.6
28.6
28.6
30.2
30.2
30.2
30.2
30.6
31.8
31.8
31.8
32.5
33.3
33.3
33.3
33.3
34.1
34.9
34.9
36.5
36.5
38.1
38.1
40.5
41.3
41.3
41.3
42.8
43.6

I.D.
Inches

.282
.278
.364
.382
.370
.366
.324
.304
.286
.286
.382
.364
.356
.336
.326
.324
.310
.288
.262
.246
.322
.362
.354
.330
.324
.302
.356
.344
.262
.372
.368
.362
.358
.354
.342
.338
.326
.322
.306
.282
.278
.278
.306
.356
.342
.312
.298
.282
.262
.338
.328
.356
.332
.236
.336
.326
.324
.306
.368
.356
.330
.326
.336
.330
.330
.304
.282
.322
.322
.302
.336
.308
.328
.304
.282
.326
.282
.280
.312
.298

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

7.2
7.1
9.2
9.7
9.4
9.3
8.2
7.7
7.3
7.3
9.7
9.2
9.0
8.5
8.3
8.2
7.9
7.3
6.7
6.2
8.2
9.2
9.0
8.4
8.2
7.7
9.0
8.7
6.7
9.4
9.3
9.2
9.1
9.0
8.7
8.6
8.3
8.2
7.8
7.2
7.1
7.1
7.8
9.0
8.7
7.9
7.6
7.2
6.7
8.6
8.3
9.0
8.4
6.0
8.5
8.3
8.2
7.8
9.3
9.0
8.4
8.3
8.5
8.4
8.4
7.7
7.2
8.2
8.2
7.7
8.5
7.8
8.3
7.7
7.2
8.3
7.2
7.1
7.9
7.6

Lbs./In.

116
151

20
26
.49
.09
.28
.53

15
35
78
62
.07
.78
1.3
11
11
10
24
66
150
283
14
1.0
1.7
8.6
19
39
1.5
4.5
230
.26
.70
1.1
.46
.65
3.6
7.5
10
11
28
95
67
93
27
1.1
5.8
22
28
75
167
5.3
11
.66
7.4
324
6.0
6.7
20
22
.30
1.2
6.7
11
5.6
7.1
7.1
21
45
7.3
12
22
3.8
20
6.4
22
47
7.1
45
51
8.9
17

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

.09
.02
.05
.09
2.7
6.1
14
11
.01
.14
.22
1.8
1.9
1.8
4.2
12
26
50
2.4
.18
.30
1.5
3.3
6.9
.26
.78
40
.05
.12
.20
.08
.11
.63
1.3
1.8
1.9
5.0
17
12
16
4.8
.19
1.0
3.8
4.9
13
29
.93
2.0
.11
1.3
57
1.1
1.2
3.4
3.9
.05
.21
1.2
1.9
.99
1.2
1.2
3.7
7.9
1.3
2.0
3.8
.67
3.6
1.1
3.8
8.3
1.3
7.9
8.9
1.6
3.0

Inches

.18
.15
.53
.72
.63
.60
.43
.33
.22
.26
.76
.68
.63
.39
.51
.51
.44
.25
.19
.14
.48
.74
.70
.60
.35
.31
.74
.62
.13
.85
.87
.84
.54
.51
.68
.73
.61
.56
.50
.21
.30
.33
.40
.81
.57
.45
.46
.27
.17
.74
.50
.69
.65
.15
.68
.71
.33
.49
.97
.96
.79
.57
.73
.88
.88
.54
.42
.72
.60
.53
.98
.50
.88
.53
.43
1.1
.45
.58
.79
.72

mm

4.5
3.8
13
18
16
15
11
8.4
5.7
6.5
19
17
16
9.8
13
13
11
6.4
4.7
3.6
12
19
18
15
8.9
7.9
19
16
3.3
22
22
21
14
13
17
18
15
14
13
5.5
7.5
8.5
10
21
14
11
12
6.9
4.2
19
13
17
17
3.7
17
18
8.4
12
25
24
20
14
18
22
22
14
11
18
15
13
25
13
22
14
11
28
11
15
20
18

ENDS: C - Closed

G - Ground
O - Open

Lbs.

20
22

91
99
1.1
.28
.79
1.4
29
51
78
71
.23
2.4
3.5
18
25
23
46
74
124
179
29
3.3
5.4
23
29
54
5.0
12
132
.97
2.7
4.3
1.1
1.5
11
24
27
27
63
91
88
138
48
4.0
15
43
57
91
124
17
25
2.0
21
212
18
21
29
48
1.3
5.1
24
27
18
28
28
51
85
23
31
51
17
46
25
51
91
34
91
132
31
54

.26
.06
.18
.32
6.5
12
17
16
.05
.53
.79
4.1
5.7
5.3
10
17
28
40
6.6
.74
1.2
5.1
6.5
12
1.1
2.8
30
.22
.61
.96
.25
.33
2.4
5.4
6.1
6.1
14
20
20
31
11
.90
3.3
9.7
13
20
28
3.9
5.6
.45
4.8
48
4.1
4.7
6.5
11
.29
1.1
5.3
6.1
4.1
6.2
6.2
12
19
5.3
7.0
12
3.8
10
5.6
12
20
7.8
20
30
7.1
12

Inches

.40
.38
.27
.10
.18
.21
.31
.42
.42
.56
.12
.19
.25
.25
.32
.37
.43
.50
.58
.64
.34
.20
.23
.34
.31
.42
.23
.22
.54
.15
.13
.17
.46
.49
.32
.27
.38
.44
.50
.53
.70
.54
.46
.25
.26
.42
.58
.56
.61
.34
.31
.44
.38
.77
.35
.48
.30
.54
.24
.29
.46
.36
.33
.44
.44
.62
.74
.62
.42
.60
.46
.53
.49
.61
.81
.54
.84
.82
.89
1.00

mm

Inches

10.2
9.8
6.9
2.4
4.6
5.3
7.8
10.7
10.7
14.1
3.0
4.9
6.4
6.2
8.1
9.4
11.0
12.7
14.6
16.3
8.5
5.0
5.9
8.7
7.8
10.6
5.7
5.5
13.7
3.9
3.4
4.2
11.6
12.5
8.1
6.9
9.7
11.2
12.7
13.4
17.9
13.8
11.7
6.4
6.5
10.7
14.7
14.2
15.5
8.6
7.9
11.1
9.6
19.4
8.9
12.2
7.6
13.8
6.0
7.3
11.6
9.1
8.4
11.1
11.1
15.9
18.9
15.7
10.7
15.2
11.6
13.4
12.4
15.5
20.5
13.7
21.3
20.8
22.7
25.4

0.062
0.064
0.021
0.012
0.018
0.020
0.041
0.051
0.060
0.060
0.012
0.021
0.025
0.035
0.040
0.041
0.048
0.059
0.072
0.080
0.042
0.022
0.026
0.038
0.041
0.052
0.025
0.031
0.072
0.017
0.019
0.022
0.024
0.026
0.032
0.034
0.040
0.042
0.050
0.062
0.064
0.064
0.050
0.025
0.032
0.047
0.054
0.062
0.072
0.034
0.039
0.025
0.037
0.085
0.035
0.040
0.041
0.050
0.019
0.025
0.038
0.040
0.035
0.038
0.038
0.051
0.062
0.042
0.042
0.052
0.035
0.049
0.039
0.051
0.062
0.040
0.062
0.063
0.047
0.054

mm

TOTAL
MATL
COILS

1.6
1.6
0.5
0.3
0.5
0.5
1.0
1.3
1.5
1.5
0.3
0.5
0.6
0.9
1.0
1.0
1.2
1.5
1.8
2.0
1.1
0.6
0.7
1.0
1.0
1.3
0.6
0.8
1.8
0.4
0.5
0.6
0.6
0.7
0.8
0.9
1.0
1.1
1.3
1.6
1.6
1.6
1.3
0.6
0.8
1.2
1.4
1.6
1.8
0.9
1.0
0.6
0.9
2.2
0.9
1.0
1.0
1.3
0.5
0.6
1.0
1.0
0.9
1.0
1.0
1.3
1.6
1.1
1.1
1.3
0.9
1.2
1.0
1.3
1.6
1.0
1.6
1.6
1.2
1.4

6.50
6.00
12.0
7.00
10.0
9.50
7.50
8.25
7.00
9.25
9.00
8.25
9.00
6.00
8.00
9.00
9.00
7.50
8.00
8.00
8.00
8.00
8.00
9.00
6.50
8.00
8.00
7.00
6.50
9.00
6.00
6.50
18.0
18.0
9.00
7.00
9.50
10.5
9.00
7.50
11.0
8.50
9.25
10.0
7.00
9.00
10.8
9.00
7.50
9.00
8.00
17.5
9.25
9.00
9.00
12.0
6.25
11.0
11.5
10.5
11.0
9.00
9.50
10.5
10.5
12.3
12.0
14.8
10.0
11.5
13.0
9.75
12.5
12.0
13.0
12.5
13.5
13.0
19.0
18.5

SPR
SPR
MW
SST
SST
MW
SPR
SPR
SST
SPR
MW
MW
SST
SPR
SST
SST
SPR
SST
SST
SPR
SST
MW
SST
HD
SPR
SPR
SST
SST
HD
SST
SST
SST
SST
SST
SST
MW
SPR
SPR
MW
SPR
SPR
MW
SPR
SST
HD
SPR
SST
SPR
SST
SPR
SPR
MW
HD
SPR
SPR
SST
SPR
SPR
SST
MW
MW
SPR
HD
MW
MW
SPR
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
MW
SPR
MW
SPR
SPR

E
N
D
S

F
N
S
H

CG
CG
C
C
CG
C
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
C
CG
CG
CG
C
C
CG
C
CG
C
CG
C
CG
C
C
C
C
C
C
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
C
C
CG
CG
C
CG
C
CG
C
CG
C
C
C
CG
CG
C
CL
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG

Z
N
N
N
N
Z
GI
GI
N
Z
Z
Z
N
GI
N
N
Z
N
N
Z
N
Z
N
Z
Z
Z
N
N
Z
N
N
N
N
N
N
GI
Z
Z
Z
Z
Z
Z
N
N
GI
Z
N
Z
N
N
GI
N
Z
N
N
N
GI
N
N
N
N
N
Z
N
N
Z
N
Z
BO
N
BO
N
Z
Z
Z
Z
N
Z
Z
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

101

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 102

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.406
0.410
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420

10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.31
10.41
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67

FF-76
NN-44
S-935
8
FF-88
11131
NN-53
2860
12235
GG-58
10533
12735
3646
11443
115
10873
A9-30
3602
3574
B14-40
4220
4176
EE-93
2507
11415
11307
4261
11480
4216
22
1914
LL-99
10575
10699
3613
3802
11948
10380
11833
10908
12683
H-25
K-83
B10-50
JJ-92
LL-95
MM-67
PP-10
XX-51
DD-21
A9-42
S-1090
L-17
M-105
II-27
11291
10972
JJ-5
10099
S-400
S-1073
2691
B-52
YY-44
HH-31
3899
JJ-23
S-1464
I-30
O-74
10426
H-33
L-76
A10-39
B18-160
71313
71313S
71327
71327S
GG-23

1.75
1.75
1.75
1.75
1.75
1.78
1.78
1.78
1.78
1.88
1.88
1.91
2.00
2.00
2.00
2.03
2.06
2.13
2.31
2.34
2.38
2.38
2.38
2.44
2.50
2.50
2.56
2.59
2.75
2.75
2.81
3.25
3.31
4.00
4.25
4.38
4.38
7.25
8.25
8.50
2.75
.28
.31
.31
.31
.31
.31
.34
.34
.38
.38
.38
.38
.38
.41
.41
.41
.41
.41
.44
.44
.44
.44
.44
.44
.44
.44
.44
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

44.5
44.5
44.5
44.5
44.5
45.2
45.2
45.2
45.2
47.6
47.6
48.5
50.8
50.8
50.8
51.6
52.4
54.0
58.7
59.5
60.3
60.3
60.3
61.9
63.5
63.5
65.1
65.9
69.9
69.9
71.4
82.6
84.1
101.6
108.0
111.1
111.1
184.2
209.6
215.9
69.9
7.1
7.9
7.9
7.9
7.9
7.9
8.7
8.7
9.5
9.5
9.5
9.5
9.5
10.3
10.3
10.3
10.3
10.3
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.1
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7

MATERIAL: MW - Music Wire

102

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.346
.346
.324
.282
.186
.342
.306
.298
.284
.346
.294
.302
.336
.322
.312
.294
.310
.312
.314
.274
.346
.308
.306
.250
.312
.306
.344
.346
.344
.312
.312
.282
.262
.332
.322
.316
.306
.262
.256
.260
.310
.338
.340
.340
.338
.326
.320
.340
.312
.340
.334
.320
.306
.296
.382
.338
.328
.300
.332
.376
.370
.338
.330
.330
.326
.312
.300
.276
.336
.316
.312
.280
.380
.378
.372
.350
.350
.344
.344
.340

RATE
mm

8.8
8.8
8.2
7.2
4.7
8.7
7.8
7.6
7.2
8.8
7.5
7.7
8.5
8.2
7.9
7.5
7.9
7.9
8.0
7.0
8.8
7.8
7.8
6.4
7.9
7.8
8.7
8.8
8.7
7.9
7.9
7.2
6.7
8.4
8.2
8.0
7.8
6.7
6.5
6.6
7.9
8.6
8.6
8.6
8.6
8.3
8.1
8.6
7.9
8.6
8.5
8.1
7.8
7.5
9.7
8.6
8.3
7.6
8.4
9.6
9.4
8.6
8.4
8.4
8.3
7.9
7.6
7.0
8.5
8.0
7.9
7.1
9.7
9.6
9.4
8.9
8.9
8.7
8.7
8.6

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

3.1
.55
1.7
.30
6.3
1.1
37
6.5
738 129
3.4
.59
12
2.2
21
3.6
44
7.7
1.7
.30
21
3.7
24
4.1
3.8
.67
6.2
1.1
10
1.8
22
3.8
9.2
1.6
8.4
1.5
8.6
1.5
39
6.8
1.7
.30
12
2.1
12
2.2
77
14
7.2
1.3
9.7
1.7
1.4
.24
1.7
.30
1.6
.28
7.3
1.3
8.7
1.5
22
3.8
37
6.5
2.3
.40
3.3
.58
3.8
.66
6.0
1.1
21
3.6
20
3.5
23
4.0
15
2.7
74
13
59
10
67
12
64
11
117
20
156
27
116
20
108
19
59
10
61
11
51
8.9
137
24
266
47
1.3
.22
16
2.9
87
15
158
28
29
5.0
2.3
.40
2.0
.34
37
6.5
89
16
64
11
52
9.1
165
29
158
28
395
69
27
4.8
186
32
99
17
355
62
.71
.12
.87
.15
1.9
.33
19
3.3
16
2.8
23
3.9
19
3.3
20
3.4

1.2
1.3
.97
.55
.12
1.3
.88
.92
.44
1.4
.72
.52
1.5
1.1
.95
.65
1.1
1.2
1.1
.63
1.9
.91
.88
.68
1.3
1.1
1.9
2.1
2.2
1.3
1.1
.94
.80
2.1
2.9
2.3
1.8
1.4
1.6
1.4
.97
.09
.09
.09
.09
.08
.06
.05
.12
.09
.12
.13
.09
.07
.31
.16
.10
.11
.17
.35
.26
.17
.10
.12
.17
.08
.11
.07
.25
.06
.13
.08
.34
.33
.33
.29
.23
.31
.25
.28

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

31
32
25
14
3.1
34
22
23
11
36
18
13
37
29
24
17
28
29
27
16
48
23
22
17
34
27
48
54
55
34
29
24
20
54
74
57
46
36
40
35
25
2.2
2.4
2.2
2.3
1.9
1.6
1.2
2.9
2.4
3.0
3.2
2.3
1.8
7.8
4.1
2.4
2.9
4.2
8.9
6.7
4.3
2.5
3.1
4.3
2.0
2.7
1.7
6.3
1.5
3.4
1.9
8.6
8.4
8.4
7.4
5.9
7.9
6.3
7.1

Lbs.

3.8
2.1
6.1
20
89
4.6
11
19
19
2.4
15
12
5.7
7.0
9.7
14
10
9.7
9.1
24
3.2
11
11
52
9.7
10
2.6
3.6
3.4
9.7
9.7
20
30
4.8
9.7
8.6
11
30
31
31
15
6.3
5.5
5.9
5.9
8.8
9.9
5.5
12
5.5
7.3
6.4
12
19
.39
2.6
8.3
18
4.7
.81
.52
6.3
8.3
7.8
8.8
13
17
27
6.8
11
13
27
.24
.29
.63
5.5
3.7
7.0
4.7
5.5

ENDS: C - Closed

G - Ground
O - Open

17
9.5
27
91
396
20
48
84
87
11
68
54
25
31
43
64
45
43
41
109
14
49
48
232
43
46
11
16
15
43
43
91
132
21
43
38
48
132
139
138
67
28
24
26
26
39
44
24
55
24
32
28
55
83
1.7
12
37
80
21
3.6
2.3
28
37
35
39
59
76
120
30
50
59
119
1.1
1.3
2.8
24
16
31
21
24

Inches

mm

.27
6.9
.48 12.2
.56 14.3
.99 25.2
1.43 36.3
.37
9.3
.90 22.9
.84 21.4
.79 20.1
.45 11.4
1.05 26.7
.68 17.2
.49 12.4
.76 19.2
.83 21.2
.86 21.8
.96 24.4
.94 23.9
.83 21.0
1.39 35.2
.48 12.2
.88 22.4
.90 22.9
1.76 44.6
1.13 28.7
1.01 25.7
.67 16.9
.48 12.2
.59 15.0
1.12 28.3
.96 24.5
1.61 40.9
2.16 54.9
.94 24.0
1.26 32.0
1.62 41.1
1.75 44.5
3.74 95.1
4.37 111.0
3.72 94.6
.78 19.7
.12
3.1
.12
3.0
.16
4.1
.16
4.2
.14
3.6
.15
3.8
.14
3.6
.22
5.5
.12
3.0
.15
3.8
.25
6.4
.29
7.2
.22
5.5
.10
2.5
.25
6.2
.15
3.8
.27
6.9
.24
6.1
.09
2.2
.18
4.4
.21
5.2
.15
3.8
.16
4.0
.20
5.1
.19
4.8
.33
8.4
.29
7.3
.21
5.3
.16
4.0
.24
6.2
.30
7.6
.16
4.1
.17
4.3
.17
4.3
.14
3.6
.14
3.6
.17
4.2
.17
4.2
.20
5.1

WIRE DIA.
Inches

0.030
0.030
0.041
0.062
0.110
0.032
0.050
0.054
0.061
0.030
0.056
0.052
0.035
0.042
0.047
0.056
0.048
0.047
0.046
0.066
0.030
0.049
0.050
0.078
0.047
0.050
0.031
0.030
0.031
0.047
0.047
0.062
0.072
0.037
0.042
0.045
0.050
0.072
0.075
0.073
0.050
0.041
0.040
0.040
0.041
0.047
0.050
0.040
0.054
0.040
0.043
0.050
0.057
0.062
0.019
0.041
0.046
0.060
0.044
0.022
0.025
0.041
0.045
0.045
0.047
0.054
0.060
0.072
0.042
0.052
0.054
0.070
0.020
0.021
0.024
0.035
0.035
0.038
0.038
0.040

mm

TOTAL
MATL
COILS

0.8
0.8
1.0
1.6
2.8
0.8
1.3
1.4
1.5
0.8
1.4
1.3
0.9
1.1
1.2
1.4
1.2
1.2
1.2
1.7
0.8
1.2
1.3
2.0
1.2
1.3
0.8
0.8
0.8
1.2
1.2
1.6
1.8
0.9
1.1
1.1
1.3
1.8
1.9
1.9
1.3
1.0
1.0
1.0
1.0
1.2
1.3
1.0
1.4
1.0
1.1
1.3
1.4
1.6
0.5
1.0
1.2
1.5
1.1
0.6
0.6
1.0
1.1
1.1
1.2
1.4
1.5
1.8
1.1
1.3
1.4
1.8
0.5
0.5
0.6
0.9
0.9
1.0
1.0
1.0

9.00
15.0
13.8
16.0
13.0
10.5
18.0
15.5
13.0
15.0
17.8
12.0
13.0
17.0
16.8
15.3
20.0
20.0
18.0
20.0
15.0
17.0
18.0
21.5
23.0
20.3
20.5
15.0
18.0
22.8
19.5
26.0
30.0
25.5
30.0
35.0
35.0
52.0
57.3
51.0
14.5
3.00
3.00
3.00
3.00
3.00
3.00
2.50
4.00
3.00
3.50
5.00
4.00
3.50
4.25
6.00
3.25
4.50
5.50
4.00
6.00
4.00
3.25
3.50
4.25
3.50
4.50
4.00
5.00
3.00
4.50
4.25
7.00
7.00
6.00
4.00
4.00
4.38
4.38
5.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
MW
SST
HD
SPR
MW
SPR
MW
SPR
MW
SPR
SPR
MW
HD
HD
SST
SPR
HD
HD
SPR
MW
SPR
SPR
MW
HD
SST
MW
MW
MW
HD
SPR
SPR
SPR
SPR
MW
SPR
SPR
SPR
SST
SPR
MW
SPR
SST
SPR
SST
SST
SST
SST
SST
SST
SPR
SST
SST
SST
MW
SST
SST
SPR
SPR
SST
SST
SPR
SPR
SST
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
MW
MW
MW
MW
SST
MW
SST
SST

E
N
D
S

F
N
S
H

CG
C
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
C
C
CG
CG
CG
CG
C
C
C
CG
C
C
CG
C
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
C
CG
C
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG

N
Z
N
Z
N
Z
Z
Z
Z
N
Z
N
GI
Z
Z
N
GI
GI
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
GI
Z
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
BO
N
N
Z
N
N
N
Z
N
N
Z
N
Z
Z
Z
Z
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 103

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420

10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67

3948
71339
71339S
71351
71351S
71362
71362S
71371
71371S
71386
71386S
71397
71397S
71408
71408S
EE-97
71419
71419S
1803
F-36
71328
71328S
71340
71340S
Z-33
H-62
M-116
XX-60
GG-57
11198
3756
A11-52
LL-78
3653
OO-89
S-387
B11-13
B-96
3369
FF-78
B10-30
A-95
71314
71314S
71329
71329S
71341
71341S
71352
71352S
71363
71363S
71373
71373S
71387
71387S
71398
71398S
71409
71409S
71420
71420S
S-798
3503
B12-50
2921
S-1062
S-3181
10187
10779
J-42
10449
S-8
U-4
S-845
71315
71315S
A9-61
Q-87
71330

.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.56
.56
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.69
.69
.69
.69
.69
.69
.69
.69
.72
.75
.75
.75
.75
.75
.75
.75
.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
14.2
14.2
14.2
14.2
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.7
17.4
17.4
17.4
17.4
17.4
17.4
17.4
17.4
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1

I.D.
Inches

.338
.336
.336
.330
.330
.326
.326
.324
.324
.318
.318
.310
.310
.302
.302
.300
.294
.294
.330
.312
.344
.344
.336
.336
.370
.356
.346
.334
.200
.390
.270
.210
.210
.364
.348
.336
.336
.332
.322
.310
.292
.270
.350
.350
.344
.344
.336
.336
.330
.330
.326
.326
.324
.324
.318
.318
.310
.310
.302
.302
.294
.294
.334
.388
.384
.366
.356
.338
.326
.322
.312
.348
.380
.376
.350
.350
.350
.348
.348
.344

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

8.6
8.5
8.5
8.4
8.4
8.3
8.3
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.6
7.5
7.5
8.4
7.9
8.7
8.7
8.5
8.5
9.4
9.0
8.8
8.5
5.1
9.9
6.9
5.3
5.3
9.2
8.8
8.5
8.5
8.4
8.2
7.9
7.4
6.9
8.9
8.9
8.7
8.7
8.5
8.5
8.4
8.4
8.3
8.3
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
8.5
9.9
9.8
9.3
9.0
8.6
8.3
8.2
7.9
8.8
9.7
9.6
8.9
8.9
8.9
8.8
8.8
8.7

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

27
4.7
34
6.0
29
5.1
43
7.6
37
6.4
54
9.5
46
8.0
61
11
52
9.0
74
13
63
11
95
17
81
14
137
24
116
20
158
28
183
32
155
27
44
7.8
82
14
20
3.5
17
3.0
31
5.4
26
4.6
1.2
.20
13
2.2
12
2.1
23
4.0
3498 613
.28
.05
366
64
2769 485
2769 485
4.9
.85
15
2.6
24
4.2
27
4.8
22
3.8
40
7.0
77
13
134
24
212
37
15
2.5
12
2.2
18
3.2
15
2.7
28
4.8
23
4.1
34
6.0
29
5.1
41
7.2
35
6.1
45
7.9
38
6.7
57
9.9
48
8.5
75
13
64
11
103
18
88
15
137
24
117
20
20
3.5
.57
.10
.37
.06
4.2
.73
6.4
1.1
18
3.2
34
5.9
54
9.4
71
12
10
1.7
.78
.14
1.3
.23
14
2.4
12
2.1
10
1.8
8.9
1.6
8.5
1.5
14
2.5

.23
.28
.22
.27
.21
.24
.19
.23
.18
.21
.17
.20
.16
.17
.14
.11
.16
.13
.26
.16
.35
.28
.30
.24
.34
.23
.36
.28
.02
.50
.09
.03
.03
.46
.27
.27
.25
.33
.27
.18
.15
.14
.38
.30
.39
.31
.34
.27
.34
.27
.32
.25
.31
.25
.27
.22
.26
.21
.23
.18
.21
.17
.34
.60
.52
.53
.47
.32
.28
.20
.19
.49
.61
.61
.27
.46
.37
.47
.50
.49

6.0
7.0
5.6
6.8
5.4
6.1
4.9
5.8
4.6
5.3
4.2
5.2
4.1
4.4
3.5
2.9
4.0
3.2
6.6
4.1
8.9
7.1
7.7
6.1
8.7
5.9
9.1
7.2
.63
13
2.3
.73
.73
12
7.0
6.8
6.3
8.5
6.7
4.6
3.9
3.5
9.6
7.6
9.9
7.8
8.7
6.9
8.6
6.8
8.1
6.4
7.8
6.2
7.0
5.5
6.6
5.2
5.9
4.7
5.3
4.2
8.6
15
13
13
12
8.2
7.2
5.0
4.8
13
15
15
6.7
12
9.4
12
13
12

ENDS: C - Closed

G - Ground
O - Open

Lbs.

6.3
9.4
6.4
12
7.8
13
8.8
14
9.4
16
11
19
13
24
16
18
29
19
12
13
7.0
4.7
9.4
6.4
.40
3.0
4.2
6.4
87
.14
32
80
80
2.2
4.0
6.4
6.8
7.3
11
14
20
29
5.5
3.7
7.0
4.7
9.4
6.4
12
7.8
13
8.8
14
9.4
16
11
19
13
24
16
29
19
6.8
.34
.19
2.2
3.0
5.9
9.4
11
13
4.9
.47
.80
3.7
5.5
3.7
4.2
4.2
7.0

28
42
28
51
35
58
39
62
42
69
47
86
58
106
72
80
128
87
51
59
31
21
42
28
1.8
13
19
28
388
.61
145
354
354
9.9
18
28
30
32
47
62
91
130
24
16
31
21
42
28
51
35
58
39
62
42
69
47
86
58
106
72
128
87
30
1.5
.85
9.7
13
26
42
47
59
22
2.1
3.6
16
24
16
19
19
31

Inches

.24
.18
.18
.21
.21
.21
.21
.22
.22
.24
.24
.27
.27
.28
.28
.27
.30
.30
.25
.32
.18
.18
.19
.19
.22
.12
.20
.28
.44
.10
.38
.42
.42
.17
.20
.25
.25
.26
.34
.30
.35
.49
.16
.16
.19
.19
.21
.21
.24
.24
.25
.25
.25
.25
.27
.27
.31
.31
.33
.33
.35
.35
.26
.09
.17
.16
.21
.23
.33
.29
.35
.23
.14
.14
.15
.18
.18
.28
.25
.22

mm

Inches

6.0
4.7
4.7
5.3
5.3
5.4
5.4
5.5
5.5
6.0
6.0
6.8
6.8
7.1
7.1
6.9
7.6
7.6
6.3
8.2
4.6
4.6
4.9
4.9
5.6
3.0
5.2
7.1
11.2
2.5
9.5
10.7
10.7
4.3
5.0
6.4
6.4
6.7
8.7
7.7
8.9
12.4
4.1
4.1
4.8
4.8
5.3
5.3
6.0
6.0
6.3
6.3
6.4
6.4
7.0
7.0
7.9
7.9
8.4
8.4
9.0
9.0
6.6
2.2
4.2
4.1
5.3
5.7
8.4
7.5
8.9
5.7
3.6
3.6
3.9
4.7
4.7
7.1
6.4
5.5

0.041
0.042
0.042
0.045
0.045
0.047
0.047
0.048
0.048
0.051
0.051
0.055
0.055
0.059
0.059
0.060
0.063
0.063
0.045
0.054
0.038
0.038
0.042
0.042
0.025
0.032
0.037
0.043
0.110
0.015
0.075
0.105
0.105
0.028
0.036
0.042
0.042
0.044
0.049
0.055
0.064
0.075
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.047
0.047
0.048
0.048
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.043
0.016
0.018
0.027
0.032
0.041
0.047
0.049
0.054
0.036
0.020
0.022
0.035
0.035
0.035
0.036
0.036
0.038

mm

1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.5
1.6
1.6
1.1
1.4
1.0
1.0
1.1
1.1
0.6
0.8
0.9
1.1
2.8
0.4
1.9
2.7
2.7
0.7
0.9
1.1
1.1
1.1
1.2
1.4
1.6
1.9
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.1
0.4
0.5
0.7
0.8
1.0
1.2
1.2
1.4
0.9
0.5
0.6
0.9
0.9
0.9
0.9
0.9
1.0

TOTAL
MATL
COILS
4.75
4.38
4.38
4.63
4.63
4.50
4.50
4.50
4.50
4.63
4.63
4.88
4.88
4.75
4.75
4.50
4.75
4.75
4.50
5.00
4.75
4.75
4.63
4.63
8.75
3.75
5.50
5.50
4.00
5.50
5.00
4.00
4.00
5.00
4.50
5.00
5.00
6.00
6.00
5.50
5.50
6.50
4.63
4.63
5.00
5.00
5.00
5.00
5.25
5.25
5.25
5.25
5.25
5.25
5.38
5.38
5.63
5.63
5.63
5.63
5.63
5.63
6.00
4.50
8.25
5.00
5.50
5.50
6.00
5.00
5.50
6.25
6.00
5.50
4.33
5.25
5.25
6.75
7.00
5.75

SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SPR
MW
SST
MW
SST
SST
SST
SST
SST
SPR
SST
SPR
SPR
SPR
MW
SST
SST
SPR
SST
SPR
SPR
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
MW
MW
SST
SST
SPR
SPR
SPR
MW
SST
SST
SST
MW
SST
SPR
SPR
MW

E
N
D
S

C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
C
C
C
CG
C
C
CG
CG
CG
C
CG
CG

F
N
S
H

Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
N
N
N
N
N
Z
N
Z
N
N
Z
N
N
N
N
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
N
N
Z
Z
Z
GI
N
N
N
N
N
N
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

103

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 104

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420

10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67

71330S
AA-56
B14-22
S-3007
I-35
71342
71342S
U-50
71353
71353S
71364
71364S
71374
71374S
CC-12
71388
71388S
3816
2959
71399
71399S
71410
71410S
GG-97
S-1316
71421
71421S
71430
71430S
2876
OO-40
L-63
HH-61
L-12
A9-54
10553
S-1205
10521
1679
10880
B2-42
S-1542
3593
10298
S-1050
12506
Q-76
Z-96
S-1052
S-482
71316
71316S
71331
71331S
71343
71343S
71354
71354S
71365
71365S
71376
71376S
71389
71389S
71400
71400S
71411
71411S
71422
71422S
S-132
S-833
B2-51
KK-79
3587
S-1068
2547
M-38
OO-71
Q-77

.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.81
.81
.81
.81
.81
.84
.84
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.91
.91
.94
.94
.94
1.00
1.00
1.00
1.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
20.6
20.6
20.6
20.6
20.6
21.4
21.4
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
23.0
23.0
23.1
23.8
23.8
23.8
25.4
25.4
25.4
25.4

MATERIAL: MW - Music Wire

104

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.344
.344
.342
.340
.338
.336
.336
.334
.330
.330
.326
.326
.324
.324
.320
.318
.318
.312
.310
.310
.310
.302
.302
.296
.296
.294
.294
.286
.286
.284
.260
.380
.376
.352
.352
.300
.276
.338
.338
.286
.312
.338
.312
.310
.296
.296
.278
.276
.260
.260
.350
.350
.344
.344
.336
.336
.330
.330
.326
.326
.324
.324
.318
.318
.310
.310
.302
.302
.294
.294
.296
.272
.288
.384
.374
.344
.380
.362
.360
.352

RATE
mm

8.7
8.7
8.7
8.6
8.6
8.5
8.5
8.5
8.4
8.4
8.3
8.3
8.2
8.2
8.1
8.1
8.1
7.9
7.9
7.9
7.9
7.7
7.7
7.5
7.5
7.5
7.5
7.3
7.3
7.2
6.6
9.7
9.6
8.9
8.9
7.6
7.0
8.6
8.6
7.3
7.9
8.6
7.9
7.9
7.5
7.5
7.1
7.0
6.6
6.6
8.9
8.9
8.7
8.7
8.5
8.5
8.4
8.4
8.3
8.3
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
7.5
6.9
7.3
9.8
9.5
8.7
9.7
9.2
9.1
8.9

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

12
11
14
17
11
22
19
18
27
23
34
29
37
32
25
46
39
55
67
62
52
83
70
83
80
109
93
144
123
140
263

2.1
1.9
2.5
2.9
1.9
3.9
3.3
3.2
4.8
4.1
6.0
5.1
6.5
5.6
4.4
8.0
6.8
9.6
12
11
9.2
14
12
15
14
19
16
25
21
24
46
.16
.16
.84
.64
15
25
1.9
2.2
17
10
1.1
7.9
9.4
13
20
22
21
41
38
1.8
1.5
2.1
1.8
3.2
2.8
4.0
3.4
4.9
4.2
5.4
4.6
6.7
5.7
9.1
7.7
12
10
16
13
10
24
18
.05
.19
1.2
.08
.42
.29
1.2

.39
.47
.36
.33
.34
.43
.34
.40
.42
.34
.38
.31
.37
.30
.30
.34
.27
.24
.21
.32
.25
.29
.23
.24
.23
.26
.21
.24
.19
.18
.14
.64
.64
.54
.47
.20
.19
.52
.47
.24
.23
.38
.41
.26
.26
.16
.21
.22
.16
.17
.55
.44
.57
.45
.51
.40
.50
.40
.47
.37
.45
.36
.41
.33
.37
.30
.35
.28
.32
.25
.32
.21
.23
.76
.73
.62
.78
.71
.63
.57

.89
.92
4.8
3.7
88
144
11
12
97
59
6.4
45
54
73
115
126
122
235
215
10
8.5
12
10
19
16
23
20
28
24
31
26
38
32
52
44
69
58
91
77
58
138
110
.29
1.1
7.1
.45
2.4
1.6
6.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

9.9
12
9.2
8.5
8.6
11
8.6
10
11
8.5
9.8
7.8
9.4
7.5
7.6
8.7
6.9
6.1
5.3
8.0
6.4
7.3
5.8
6.0
5.9
6.7
5.3
6.0
4.8
4.7
3.5
16
16
14
12
5.2
4.8
13
12
6.1
5.7
9.7
10
6.6
6.5
4.1
5.2
5.7
4.0
4.3
14
11
14
12
13
10
13
10
12
9.4
12
9.2
10
8.3
9.5
7.5
8.8
7.0
8.1
6.4
8.1
5.4
5.9
19
19
16
20
18
16
15

Lbs.

4.7
5.0
5.1
5.5
3.6
9.4
6.4
7.3
12
7.8
13
8.8
14
9.4
7.5
16
11
13
14
19
13
24
16
20
19
29
19
34
23
26
37
.57
.59
2.6
1.7
18
27
5.6
5.8
23
13
2.5
18
14
19
19
26
27
37
37
5.5
3.7
7.0
4.7
9.4
6.4
12
7.8
13
8.8
14
9.4
16
11
19
13
24
16
29
19
19
29
24
.22
.78
4.4
.35
1.7
1.0
3.8

ENDS: C - Closed

G - Ground
O - Open

21
22
23
24
16
42
28
32
51
35
58
39
62
42
34
69
47
59
62
86
58
106
72
88
83
128
87
153
104
115
163
2.5
2.6
12
7.7
80
120
25
26
104
59
11
82
62
83
83
116
120
163
163
24
16
31
21
42
28
51
35
58
39
62
42
69
47
86
58
106
72
128
87
83
130
105
.97
3.5
20
1.5
7.6
4.6
17

Inches

.22
.27
.22
.26
.41
.24
.24
.34
.28
.28
.28
.28
.29
.29
.45
.32
.32
.41
.33
.35
.35
.38
.38
.47
.43
.42
.42
.44
.44
.48
.56
.14
.18
.27
.34
.39
.54
.33
.37
.54
.34
.49
.46
.39
.47
.34
.57
.61
.60
.64
.20
.20
.24
.24
.27
.27
.31
.31
.32
.32
.33
.33
.36
.36
.40
.40
.44
.44
.47
.47
.56
.63
.53
.18
.21
.32
.22
.29
.38
.24

mm

5.5
6.8
5.7
6.6
10.4
6.1
6.1
8.7
7.0
7.0
7.2
7.2
7.3
7.3
11.4
8.1
8.1
10.3
8.4
8.9
8.9
9.7
9.7
11.8
11.0
10.6
10.6
11.3
11.3
12.1
14.2
3.6
4.5
6.9
8.6
9.9
13.7
8.3
9.4
13.6
8.6
12.5
11.7
9.8
11.8
8.7
14.4
15.5
15.2
16.3
5.1
5.1
6.2
6.2
6.9
6.9
7.9
7.9
8.2
8.2
8.4
8.4
9.2
9.2
10.1
10.1
11.1
11.1
12.0
12.0
14.2
16.0
13.4
4.6
5.3
8.2
5.6
7.4
9.5
6.0

WIRE DIA.
Inches

0.038
0.038
0.039
0.040
0.041
0.042
0.042
0.043
0.045
0.045
0.047
0.047
0.048
0.048
0.050
0.051
0.051
0.054
0.055
0.055
0.055
0.059
0.059
0.062
0.062
0.063
0.063
0.067
0.067
0.068
0.080
0.020
0.022
0.034
0.034
0.060
0.072
0.041
0.041
0.067
0.054
0.041
0.054
0.055
0.062
0.062
0.071
0.072
0.080
0.080
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.047
0.047
0.048
0.048
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.062
0.074
0.067
0.018
0.023
0.038
0.020
0.029
0.030
0.034

mm

TOTAL
MATL
COILS

1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.3
1.4
1.4
1.4
1.4
1.5
1.5
1.6
1.6
1.6
1.6
1.7
1.7
1.7
2.0
0.5
0.6
0.9
0.9
1.5
1.8
1.0
1.0
1.7
1.4
1.0
1.4
1.4
1.6
1.6
1.8
1.8
2.0
2.0
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.6
1.9
1.7
0.5
0.6
1.0
0.5
0.7
0.8
0.9

5.75
7.00
5.75
5.50
9.00
5.75
5.75
7.00
6.13
6.13
6.00
6.00
6.00
6.00
9.00
6.25
6.25
6.50
6.00
6.38
6.38
6.50
6.50
7.50
7.00
6.63
6.63
6.63
6.63
7.00
7.00
6.00
7.00
8.00
10.0
6.50
7.50
8.00
8.00
8.00
6.25
12.0
7.50
7.00
7.50
5.50
8.00
8.50
7.50
8.00
5.75
5.75
6.38
6.38
6.50
6.50
6.88
6.88
6.88
6.88
6.88
6.88
7.13
7.13
7.25
7.25
7.38
7.38
7.50
7.50
9.00
8.50
8.00
9.00
8.00
8.50
10.0
9.00
12.5
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SST
SST
SPR
MW
SST
SPR
MW
SST
MW
SST
MW
SST
HD
MW
SST
SPR
SPR
MW
SST
MW
SST
HD
SST
MW
SST
MW
SST
SPR
SST
MW
SST
SST
SST
SPR
SST
SST
SPR
SST
SPR
SST
MW
SPR
SST
SST
SST
SST
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SST
SPR
SST
MW
SST
MW
MW
SST
SPR

E
N
D
S

F
N
S
H

CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
C
CG
CG

N
GI
N
N
GI
N
N
Z
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
N
N
N
N
N
N
N
GI
N
Z
N
N
N
Z
N
N
Z
N
GI
N
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
BO
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 105

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420

10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67

71317
71317S
71332
71332S
I-40
I-29
71344
71344S
10404
71355
71355S
71366
71366S
71377
71377S
Z-18
71390
71390S
71401
71401S
71412
71412S
71423
71423S
71431
71431S
S-177
71438
71438S
10729
MM-36
3650
B9-2
2543
S-52
B3-47
CC-98
3937
10477
B-99
10589
10094
71318
71318S
3617
10596
71333
71333S
71345
71345S
71356
71356S
71367
71367S
71378
71378S
71391
71391S
71402
71402S
71413
71413S
71424
71424S
12240
71432
71432S
3589
71439
71439S
A9-70
12643
3662
3548
A11-47
B9-24
3527
3675
4257
Q-61

1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.03
1.06
1.13
1.13
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.28
1.38
1.38
1.41
1.41
1.44

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
26.2
27.0
28.6
28.6
30.1
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
32.5
34.9
34.9
35.7
35.7
36.5

I.D.
Inches

.350
.350
.344
.344
.340
.336
.336
.336
.330
.330
.330
.326
.326
.324
.324
.322
.318
.318
.310
.310
.302
.302
.294
.294
.286
.286
.276
.276
.276
.360
.340
.310
.332
.356
.310
.304
.370
.276
.310
.382
.378
.352
.350
.350
.348
.346
.344
.344
.336
.336
.330
.330
.326
.326
.324
.324
.318
.318
.310
.310
.302
.302
.294
.294
.290
.286
.286
.276
.276
.276
.274
.268
.340
.312
.294
.332
.326
.332
.326
.374

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

8.9
8.9
8.7
8.7
8.6
8.5
8.5
8.5
8.4
8.4
8.4
8.3
8.3
8.2
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
7.3
7.3
7.0
7.0
7.0
9.1
8.6
7.9
8.4
9.0
7.9
7.7
9.4
7.0
7.9
9.7
9.6
8.9
8.9
8.9
8.8
8.8
8.7
8.7
8.5
8.5
8.4
8.4
8.3
8.3
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
7.4
7.3
7.3
7.0
7.0
7.0
7.0
6.8
8.6
7.9
7.5
8.4
8.3
8.4
8.3
9.5

Lbs./In.

8.7
7.4
11
9.4
8.3
10
16
14
20
20
17
25
21
27
23
23
33
28
45
38
59
50
78
66
103
87
113
139
118
4.3
13
45
18
3.2
25
37
1.5
91
35
.37
.26
3.7
6.9
5.8
5.6
6.3
8.5
7.2
13
11
16
13
19
16
21
18
26
22
35
30
46
39
61
51
63
80
68
114
108
92
107
146
11
31
58
18
14
17
13
.53

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.5
1.3
1.9
1.6
1.5
1.8
2.8
2.4
3.5
3.5
3.0
4.4
3.7
4.7
4.0
4.0
5.8
4.9
7.8
6.6
10
8.8
14
12
18
15
20
24
21
.76
2.3
7.8
3.2
.56
4.3
6.5
.26
16
6.1
.07
.05
.64
1.2
1.0
.99
1.1
1.5
1.3
2.3
1.9
2.8
2.4
3.3
2.8
3.7
3.2
4.5
3.8
6.1
5.2
8.1
6.9
11
9.0
11
14
12
20
19
16
19
26
1.9
5.4
10
3.2
2.5
3.1
2.3
.09

.63
.50
.64
.51
.60
.58
.59
.47
.41
.58
.46
.52
.42
.51
.41
.46
.47
.38
.44
.35
.40
.32
.37
.29
.33
.27
.24
.29
.23
.84
.44
.31
.43
.77
.44
.41
.95
.32
.40
1.0
.87
.84
.80
.64
.76
.74
.82
.65
.72
.57
.73
.58
.69
.55
.66
.52
.60
.48
.55
.44
.52
.41
.48
.38
.36
.43
.34
.36
.38
.30
.26
.22
.53
.59
.36
.43
.67
.44
.70
1.1

mm

16
13
16
13
15
15
15
12
10
15
12
13
11
13
10
12
12
9.6
11
8.8
10
8.1
9.4
7.5
8.5
6.8
6.1
7.4
5.8
21
11
7.9
11
20
11
10
24
8.1
10
27
22
21
20
16
19
19
21
17
18
15
18
15
17
14
17
13
15
12
14
11
13
10
12
9.6
9.1
11
8.7
9.0
9.5
7.5
6.7
5.5
13
15
9.1
11
17
11
18
29

ENDS: C - Closed

G - Ground
O - Open

Lbs.

5.5
3.7
7.0
4.7
5.0
6.0
9.4
6.4
8.3
12
7.8
13
8.8
14
9.4
11
16
11
19
13
24
16
29
19
34
23
27
40
27
3.6
5.9
14
7.8
2.5
11
15
1.4
29
14
.39
.22
3.1
5.5
3.7
4.3
4.7
7.0
4.7
9.4
6.4
12
7.8
13
8.8
14
9.4
16
11
19
13
24
16
29
19
23
34
23
40
40
27
28
32
5.9
18
21
7.8
9.4
7.8
9.4
.60

24
16
31
21
22
26
42
28
37
51
35
58
39
62
42
47
69
47
86
58
106
72
128
87
153
104
120
180
120
16
26
62
35
11
48
68
6.3
129
62
1.7
1.0
14
24
16
19
21
31
21
42
28
51
35
58
39
62
42
69
47
86
58
106
72
128
87
101
153
104
180
180
120
125
141
26
82
92
35
42
35
42
2.7

Inches

.22
.22
.26
.26
.40
.42
.30
.30
.34
.34
.34
.35
.35
.36
.36
.44
.40
.40
.45
.45
.49
.49
.53
.53
.56
.56
.65
.62
.62
.20
.32
.50
.33
.35
.69
.58
.21
.86
.54
.20
.38
.41
.26
.26
.34
.35
.32
.32
.35
.35
.41
.41
.43
.43
.43
.43
.48
.48
.54
.54
.59
.59
.65
.65
.72
.69
.69
.72
.76
.76
.73
.68
.36
.59
.66
.33
.59
.34
.56
.31

mm

Inches

5.7
5.7
6.6
6.6
10.2
10.7
7.6
7.6
8.6
8.7
8.7
8.8
8.8
9.1
9.1
11.2
10.2
10.2
11.4
11.4
12.4
12.4
13.4
13.4
14.3
14.3
16.5
15.8
15.8
5.0
8.1
12.6
8.4
8.9
17.5
14.7
5.2
21.9
13.6
5.2
9.6
10.4
6.7
6.7
8.7
8.9
8.1
8.1
8.9
8.9
10.3
10.3
10.9
10.9
11.0
11.0
12.3
12.3
13.6
13.6
15.0
15.0
16.4
16.4
18.2
17.4
17.4
18.3
19.2
19.2
18.5
17.4
9.1
15.1
16.8
8.4
14.9
8.7
14.3
7.9

0.035
0.035
0.038
0.038
0.040
0.042
0.042
0.042
0.045
0.045
0.045
0.047
0.047
0.048
0.048
0.049
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.072
0.030
0.040
0.055
0.044
0.032
0.055
0.058
0.025
0.072
0.055
0.019
0.021
0.034
0.035
0.035
0.036
0.037
0.038
0.038
0.042
0.042
0.045
0.045
0.047
0.047
0.048
0.048
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.067
0.067
0.072
0.072
0.072
0.073
0.076
0.040
0.054
0.063
0.044
0.047
0.044
0.047
0.023

mm

TOTAL
MATL
COILS

0.9
0.9
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.8
0.8
1.0
1.4
1.1
0.8
1.4
1.5
0.6
1.8
1.4
0.5
0.5
0.9
0.9
0.9
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.8
1.8
1.8
1.9
1.9
1.0
1.4
1.6
1.1
1.2
1.1
1.2
0.6

6.38
6.38
6.88
6.88
10.0
10.0
7.13
7.13
7.50
7.63
7.63
7.38
7.38
7.50
7.50
9.00
7.88
7.88
8.13
8.13
8.25
8.25
8.38
8.38
8.38
8.38
9.00
8.63
8.63
6.50
7.00
8.00
7.50
10.0
11.5
10.0
7.25
12.0
9.75
9.75
17.0
11.0
7.50
7.50
9.50
9.50
8.38
8.38
8.38
8.38
9.00
9.00
9.13
9.13
9.00
9.00
9.50
9.50
9.75
9.75
10.0
10.0
10.3
10.3
11.0
10.3
10.3
10.0
10.5
10.5
10.0
9.00
8.00
10.0
10.5
7.50
11.5
7.75
12.0
12.5

MW
SST
MW
SST
SPR
SPR
MW
SST
SPR
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
MW
SST
SPR
MW
SST
HD
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
MW
SST
SST
SST
SPR
MW
SPR
SPR
HD
SPR
SPR
SST

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
C
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
C

N
N
N
N
N
BO
N
N
Z
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
Z
Z
N
N
N
Z
Z
N
N
Z
N
N
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
Z
N
N
N
N
Z
Z
Z
Z
Z
Z
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

105

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 106

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420

10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67

S-1489
A13-30
S-402
S-1204
RR-40
11305
71319
71319S
10230
71334
71334S
71346
71346S
71357
71357S
S-3137
71368
71368S
71379
71379S
71392
71392S
A16-68
YY-69
71403
71403S
71414
71414S
CC-82
S-1395
71425
71425S
71433
71433S
71440
71440S
S-841
I-56
11239
71320
71320S
12110
71335
71335S
71347
71347S
71358
71358S
71369
71369S
71380
71380S
3432
71393
71393S
71404
71404S
71415
71415S
71426
71426S
71434
71434S
71441
71441S
1898
A-56
CC-89
S-131
B9-20
71322
71322S
71336
71336S
3555
71348
71348S
71359
71359S
71370

1.44
1.44
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.56
1.63
1.63
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.78
1.81
1.88
1.94
1.97
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

36.5
36.5
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
39.7
41.3
41.3
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
45.2
46.0
47.6
49.2
50.0
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8

MATERIAL: MW - Music Wire

106

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.312
.198
.258
.380
.368
.364
.350
.350
.344
.344
.344
.336
.336
.330
.330
.326
.326
.326
.324
.324
.318
.318
.318
.312
.310
.310
.302
.302
.300
.296
.294
.294
.286
.286
.276
.276
.338
.292
.256
.350
.350
.350
.344
.344
.336
.336
.330
.330
.326
.326
.324
.324
.320
.318
.318
.310
.310
.302
.302
.294
.294
.286
.286
.276
.276
.304
.300
.260
.326
.380
.350
.350
.344
.344
.336
.336
.336
.330
.330
.326

RATE
mm

7.9
5.0
6.6
9.7
9.3
9.2
8.9
8.9
8.7
8.7
8.7
8.5
8.5
8.4
8.4
8.3
8.3
8.3
8.2
8.2
8.1
8.1
8.1
7.9
7.9
7.9
7.7
7.7
7.6
7.5
7.5
7.5
7.3
7.3
7.0
7.0
8.6
7.4
6.5
8.9
8.9
8.9
8.7
8.7
8.5
8.5
8.4
8.4
8.3
8.3
8.2
8.2
8.1
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
7.3
7.3
7.0
7.0
7.7
7.6
6.6
8.3
9.7
8.9
8.9
8.7
8.7
8.5
8.5
8.5
8.4
8.4
8.3

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

5.2
151
28
.22
.04
.89
.16
1.7
.30
5.6
.98
4.8
.83
7.4
1.3
7.1
1.2
6.0
1.1
11
1.8
8.9
1.6
13
2.3
11
1.9
16
2.7
16
2.7
13
2.3
17
3.0
15
2.6
21
3.7
18
3.1
13
2.2
26
4.6
29
5.0
24
4.2
38
6.6
32
5.6
32
5.6
44
7.8
50
8.7
42
7.4
65
11
55
9.7
88
15
75
13
7.3
1.3
44
7.7
148
26
4.9
.85
4.1
.72
4.2
.73
6.3
1.1
5.4
.94
9.2
1.6
7.8
1.4
11
2.0
9.7
1.7
14
2.4
11
2.0
15
2.6
13
2.2
23
4.0
17
3.0
15
2.6
24
4.2
21
3.6
32
5.6
27
4.8
42
7.3
36
6.2
55
9.6
47
8.2
74
13
63
11
34
6.0
30
5.3
110
19
7.5
1.3
.36
.06
4.3
.75
3.7
.64
5.7
.99
4.8
.84
6.8
1.2
7.8
1.4
6.6
1.2
9.9
1.7
8.4
1.5
12
2.0

.42
.10
.24
1.2
1.1
1.2
.98
.78
.69
.98
.78
.89
.71
.89
.71
.57
.84
.67
.81
.64
.74
.59
.62
.51
.68
.54
.63
.50
.53
.42
.58
.46
.53
.42
.46
.36
.82
.49
.26
1.1
.90
.95
1.1
.88
1.0
.82
1.0
.80
.97
.77
.94
.75
.47
.89
.71
.80
.64
.74
.59
.69
.55
.62
.50
.54
.43
.67
.59
.35
1.1
1.7
1.3
1.0
1.2
.98
1.4
1.2
.96
1.2
.92
1.1

30
862
161

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

11
2.6
6.0
29
28
30
25
20
17
25
20
23
18
23
18
14
21
17
21
16
19
15
16
13
17
14
16
13
13
11
15
12
13
11
12
9.2
21
12
6.7
29
23
24
28
22
26
21
26
20
25
20
24
19
12
23
18
20
16
19
15
17
14
16
13
14
11
17
15
9.0
27
43
32
26
31
25
35
31
24
30
23
29

Lbs.

12
89
38

55
398
168
.26
1.1
.99
4.4
2.0
9.0
5.5
24
3.7
16
5.0
22
7.0
31
4.7
21
9.4
42
6.4
28
12
51
7.8
35
8.8
39
13
58
8.8
39
14
62
9.4
42
16
69
11
47
7.9
35
13
59
19
86
13
58
24
106
16
72
17
75
19
83
29
128
19
87
34
153
23
104
40
180
27
120
5.9
26
22
96
39
174
5.5
24
3.7
16
4.0
18
7.0
31
4.7
21
9.4
42
6.4
28
12
51
7.8
35
13
58
8.8
39
14
62
9.4
42
11
47
16
69
11
47
19
86
13
58
24
106
16
72
29
128
19
87
34
153
23
104
40
180
27
120
23
101
18
80
39
174
8.0
36
.61
2.7
5.5
24
3.7
16
7.0
31
4.7
21
9.4
42
9.4
42
6.4
28
12
51
7.8
35
13
58

ENDS: C - Closed

G - Ground
O - Open

Inches

.50
1.17
.85
.34
.39
.32
.31
.31
.39
.37
.37
.41
.41
.48
.48
.45
.51
.51
.51
.51
.57
.57
.88
.68
.63
.63
.69
.69
.78
.68
.76
.76
.81
.81
.89
.89
.45
.90
.98
.34
.34
.42
.40
.40
.46
.46
.53
.53
.56
.56
.58
.58
.49
.67
.67
.72
.72
.80
.80
.87
.87
.94
.94
1.04
1.04
.70
.90
1.24
.87
.26
.38
.38
.44
.44
.59
.53
.53
.60
.60
.65

mm

12.7
29.6
21.6
8.6
9.9
8.2
7.8
7.8
9.9
9.3
9.3
10.5
10.5
12.1
12.1
11.3
12.8
12.8
13.0
13.0
14.4
14.4
22.4
17.1
16.1
16.1
17.6
17.6
19.8
17.3
19.2
19.2
20.6
20.6
22.6
22.6
11.3
22.8
25.0
8.7
8.7
10.7
10.1
10.1
11.7
11.7
13.4
13.4
14.3
14.3
14.6
14.6
12.4
17.0
17.0
18.3
18.3
20.4
20.4
22.2
22.2
23.8
23.8
26.3
26.3
17.7
22.9
31.5
22.1
6.6
9.6
9.6
11.1
11.1
14.9
13.5
13.5
15.1
15.1
16.4

WIRE DIA.
Inches

0.054
0.111
0.081
0.020
0.026
0.028
0.035
0.035
0.038
0.038
0.038
0.042
0.042
0.045
0.045
0.047
0.047
0.047
0.048
0.048
0.051
0.051
0.051
0.054
0.055
0.055
0.059
0.059
0.060
0.062
0.063
0.063
0.067
0.067
0.072
0.072
0.041
0.064
0.082
0.035
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.047
0.047
0.048
0.048
0.050
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.058
0.060
0.080
0.047
0.020
0.035
0.035
0.038
0.038
0.042
0.042
0.042
0.045
0.045
0.047

mm

TOTAL
MATL
COILS

1.4
2.8
2.1
0.5
0.7
0.7
0.9
0.9
1.0
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.2
1.3
1.3
1.3
1.4
1.4
1.4
1.5
1.5
1.5
1.6
1.6
1.6
1.7
1.7
1.8
1.8
1.0
1.6
2.1
0.9
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.5
1.5
2.0
1.2
0.5
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.2

9.25
10.5
10.5
16.0
14.0
10.5
8.75
8.75
9.25
9.63
9.63
9.88
9.88
10.6
10.6
9.50
10.8
10.8
10.6
10.6
11.1
11.1
17.3
11.5
11.5
11.5
11.8
11.8
13.0
11.0
12.0
12.0
12.1
12.1
12.4
12.4
11.0
14.0
12.0
9.75
9.75
11.0
10.5
10.5
11.0
11.0
11.8
11.8
12.0
12.0
12.0
12.0
9.75
13.1
13.1
13.1
13.1
13.6
13.6
13.9
13.9
14.0
14.0
14.4
14.4
12.0
15.0
15.5
17.5
12.0
10.8
10.8
11.5
11.5
14.0
12.6
12.6
13.3
13.3
13.8

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SST
SST
MW
MW
MW
SST
SPR
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SPR
MW
SST
MW
SST
SST
SST
MW
SST
MW
SST
MW
SST
SST
SPR
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SPR
SPR
SST
MW
MW
SST
MW
SST
MW
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
Z
GI
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
N
N
N
N
Z
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 107

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420
0.420

10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67
10.67

71370S
71381
71381S
71394
71394S
71405
71405S
71416
71416S
71427
71427S
71435
71435S
71442
71442S
4374
71324
71324S
S-1410
71337
71337S
71349
71349S
71360
71360S
71383
71383S
71395
71395S
71406
71406S
71417
71417S
71428
71428S
71436
71436S
71443
71443S
4243
10568
10615
71326
71326S
71338
71338S
71350
71350S
71361
71361S
71385
71385S
71396
71396S
71407
71407S
71418
71418S
71429
71429S
71437
71437S
71444
71444S
3431
3634
12147
A9-51
3857
11679
3495
10379
10512
B15-60
4127
1529
10760
10605
3979
11289

2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.06
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.38
2.38
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.63
2.66
2.66
2.75
3.19
3.25
3.56
3.75
4.13
4.88
4.94
6.00
7.13
7.75
8.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
52.4
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
60.3
60.3
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
66.7
67.5
67.5
69.9
81.0
82.6
90.5
95.3
104.8
123.8
125.4
152.4
181.0
196.9
203.2

I.D.
Inches

.326
.324
.324
.318
.318
.310
.310
.302
.302
.294
.294
.286
.286
.276
.276
.276
.350
.350
.346
.344
.344
.336
.336
.330
.330
.324
.324
.318
.318
.310
.310
.302
.302
.294
.294
.286
.286
.276
.276
.360
.268
.370
.350
.350
.344
.344
.336
.336
.330
.330
.324
.324
.318
.318
.310
.310
.302
.302
.294
.294
.286
.286
.276
.276
.260
.284
.340
.338
.348
.346
.292
.276
.280
.308
.332
.324
.328
.336
.236
.338

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

RATE
mm

8.3
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
7.3
7.3
7.0
7.0
7.0
8.9
8.9
8.8
8.7
8.7
8.5
8.5
8.4
8.4
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
7.3
7.3
7.0
7.0
9.1
6.8
9.4
8.9
8.9
8.7
8.7
8.5
8.5
8.4
8.4
8.2
8.2
8.1
8.1
7.9
7.9
7.7
7.7
7.5
7.5
7.3
7.3
7.0
7.0
6.6
7.2
8.6
8.6
8.8
8.8
7.4
7.0
7.1
7.8
8.4
8.2
8.3
8.5
6.0
8.6

Lbs./In.

9.8
13
11
16
13
21
18
28
24
36
31
48
40
64
55
62
3.8
3.2
5.2
5.0
4.3
7.2
6.1
8.7
7.4
11
9.4
14
12
18
16
25
21
32
27
42
36
57
48
1.5
62
.62
3.4
2.9
4.5
3.8
6.5
5.5
7.9
6.7
9.9
8.4
12
10
17
14
22
19
29
24
38
32
51
43
76
35
4.8
4.9
2.2
2.0
24
31
40
12
4.4
5.0
2.7
1.4
50
1.5

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

1.7
2.3
1.9
2.7
2.3
3.7
3.1
4.9
4.1
6.4
5.4
8.3
7.1
11
9.6
11
.67
.57
.91
.88
.74
1.3
1.1
1.5
1.3
1.9
1.7
2.4
2.1
3.2
2.7
4.3
3.6
5.6
4.8
7.4
6.3
9.9
8.4
.26
11
.11
.60
.51
.79
.67
1.1
.96
1.4
1.2
1.7
1.5
2.2
1.8
2.9
2.5
3.8
3.3
5.0
4.3
6.6
5.6
8.9
7.5
13
6.1
.83
.86
.39
.35
4.2
5.5
7.0
2.1
.77
.87
.47
.24
8.7
.26

Inches

mm

.90 23
1.1
27
.86 22
1.0
25
.80 20
.92 23
.73 19
.86 22
.68 17
.79 20
.63 16
.72 18
.58 15
.63 16
.50 13
.47 12
1.4
37
1.1
29
.85 21
1.4
36
1.1
28
1.3
33
1.0
26
1.3
34
1.1
27
1.3
32
1.0
25
1.1
29
.90 23
1.1
27
.84 21
.97 25
.77 20
.90 23
.72 18
.82 21
.65 17
.71 18
.56 14
1.9
48
.55 14
2.1
53
1.6
41
1.3
33
1.6
39
1.2
31
1.5
37
1.2
29
1.5
37
1.2
30
1.4
36
1.1
28
1.3
32
1.0
25
1.2
30
.94 24
1.1
28
.87 22
1.0
25
.80 20
.91 23
.73 19
.80 20
.63 16
.51 13
1.0
26
1.2
31
1.3
33
1.9
49
2.2
57
.90 23
.92 23
.67 17
1.2
30
1.8
45
2.8
71
3.3
83
4.5 115
1.1
28
3.9 100

ENDS: C - Closed

G - Ground
O - Open

Lbs.

8.8
14
9.4
16
11
19
13
24
16
29
19
34
23
40
27
29
5.5
3.7
4.4
7.0
4.7
9.4
6.4
12
7.8
14
9.4
16
11
19
13
24
16
29
19
34
23
40
27
2.8
34
1.3
5.5
3.7
7.0
4.7
9.4
6.4
12
7.8
14
9.4
16
11
19
13
24
16
29
19
34
23
40
27
39
36
5.9
6.3
4.3
4.4
22
29
27
14
7.8
14
8.9
6.2
55
5.9

39
62
42
69
47
86
58
106
72
128
87
153
104
180
120
129
24
16
19
31
21
42
28
51
35
62
42
69
47
86
58
106
72
128
87
153
104
180
120
13
150
5.8
24
16
31
21
42
28
51
35
62
42
69
47
86
58
106
72
128
87
153
104
180
120
174
160
26
28
19
20
96
129
119
62
35
62
39
28
247
26

Inches

mm

Inches

.65 16.4
.65 16.5
.65 16.5
.74 18.8
.74 18.8
.81 20.6
.81 20.6
.91 23.0
.91 23.0
.99 25.2
.99 25.2
1.06 27.0
1.06 27.0
1.17 29.7
1.17 29.7
1.21 30.6
.42 10.7
.42 10.7
.41 10.3
.48 12.3
.48 12.3
.57 14.4
.57 14.4
.67 17.0
.67 17.0
.74 18.7
.74 18.7
.82 20.7
.82 20.7
.92 23.4
.92 23.4
1.01 25.7
1.01 25.7
1.10 28.0
1.10 28.0
1.18 30.0
1.18 30.0
1.31 33.4
1.31 33.4
.48 12.2
1.59 40.4
.40 10.2
.46 11.7
.46 11.7
.53 13.5
.53 13.5
.62 15.9
.62 15.9
.73 18.6
.73 18.6
.82 20.7
.82 20.7
.90 22.8
.90 22.8
1.01 25.7
1.01 25.7
1.11 28.3
1.11 28.3
1.22 31.0
1.22 31.0
1.31 33.2
1.31 33.2
1.45 36.8
1.45 36.8
1.72 43.7
1.50 38.0
.64 16.3
.70 17.7
.79 20.1
.96 24.4
1.54 39.0
2.30 58.5
1.54 39.1
1.34 34.1
1.14 29.1
1.51 38.4
2.16 54.9
2.59 65.9
5.52 140.2
1.91 48.4

0.047
0.048
0.048
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.072
0.035
0.035
0.037
0.038
0.038
0.042
0.042
0.045
0.045
0.048
0.048
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.030
0.076
0.025
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.048
0.048
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.080
0.068
0.040
0.041
0.036
0.037
0.064
0.072
0.070
0.056
0.044
0.048
0.046
0.042
0.092
0.041

mm

1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.8
0.9
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
0.8
1.9
0.6
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.2
1.2
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.0
1.7
1.0
1.0
0.9
0.9
1.6
1.8
1.8
1.4
1.1
1.2
1.2
1.1
2.3
1.0

TOTAL
MATL
COILS
13.8
13.5
13.5
14.5
14.5
14.8
14.8
15.4
15.4
15.8
15.8
15.9
15.9
16.3
16.3
16.8
12.0
12.0
10.0
12.8
12.8
13.5
13.5
14.9
14.9
15.4
15.4
16.0
16.0
16.8
16.8
17.1
17.1
17.5
17.5
17.6
17.6
18.3
18.3
15.0
210.0
15.0
13.1
13.1
14.0
14.0
14.9
14.9
16.3
16.3
17.0
17.0
17.6
17.6
18.4
18.4
18.9
18.9
19.4
19.4
19.5
19.5
20.1
20.1
21.5
22.0
16.0
17.0
21.0
26.0
24.0
31.0
22.0
24.0
25.0
31.5
47.0
61.8
60.0
45.5

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SPR
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
MW
SPR
SPR
SPR
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
CG
CG
CG
CG
C

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
GI
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

107

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 108

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.420
0.420
0.432
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437

10.67
10.67
10.97
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10

11666
S-424
B3-63
S-1266
12611
11454
A15-44
S-1144
3984
S-876
3920
S-157
S-196
JJ-30
N-84
FF-60
WW-68
2659
S-1039
11219
TT-43
2989
12661
10250
AA-88
K-25
S-1557
B9-21
S-3172
B-48
4206
11182
3371
B-88
2993
4309
4275
S-1063
S-3062
B11-67
A12-6
2517
G-78
JJ-64
S-897
A11-48
A11-69
12513
S-128
S-920
913
11397
10795
3977
S-1031
3791
S-745
10253
513
OO-98
V V-34
10592
S-404
A-36
10439
10870
3068
F-56
A9-44
11370
3182
2648
3211
1563
B11-62
3988
S-1283
S-746
S-750
F-64

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

9.50
15.8
1.23
.31
.31
.31
.34
.38
.41
.41
.44
.44
.44
.47
.47
.47
.47
.47
.47
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.56
.56
.56
.56
.56
.59
.63
.63
.63
.63
.63
.63
.66
.66
.66
.69
.69
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.81
.81
.81
.81
.81
.81
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88

mm

241.3
400.1
31.3
7.9
7.9
7.9
8.7
9.5
10.3
10.3
11.1
11.1
11.1
11.9
11.9
11.9
11.9
11.9
11.9
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
14.3
14.3
14.3
14.3
14.3
15.1
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
17.4
17.5
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2

MATERIAL: MW - Music Wire

108

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.322
.346
.280
.407
.391
.387
.355
.381
.361
.355
.353
.327
.327
.377
.369
.337
.313
.311
.277
.411
.397
.377
.377
.367
.357
.355
.337
.287
.391
.363
.293
.387
.373
.327
.313
.303
.313
.381
.373
.373
.359
.343
.325
.405
.385
.345
.287
.337
.397
.385
.381
.377
.367
.367
.361
.353
.353
.331
.329
.329
.329
.327
.311
.297
.367
.361
.355
.287
.281
.277
.387
.377
.385
.383
.383
.375
.363
.353
.327
.317

RATE
mm

8.2
8.8
7.1
10.3
9.9
9.8
9.0
9.7
9.2
9.0
9.0
8.3
8.3
9.6
9.4
8.6
8.0
7.9
7.0
10.4
10.1
9.6
9.6
9.3
9.1
9.0
8.6
7.3
9.9
9.2
7.4
9.8
9.5
8.3
8.0
7.7
8.0
9.7
9.5
9.5
9.1
8.7
8.3
10.3
9.8
8.8
7.3
8.6
10.1
9.8
9.7
9.6
9.3
9.3
9.2
9.0
9.0
8.4
8.4
8.4
8.4
8.3
7.9
7.5
9.3
9.2
9.0
7.3
7.1
7.0
9.8
9.6
9.8
9.7
9.7
9.5
9.2
9.0
8.3
8.1

Lbs./In.

2.0
.32
132
.21
.99
3.6
26
4.5
23
34
36
104
69
6.1
10
45
133
143
446
.12
.91
8.6
7.5
15
17
28
54
274
1.4
15
263
1.6
10
70
133
142
100
5.6
9.8
11
18
30
114
.28
2.1
33
317
48
.68
1.6
4.3
5.8
7.4
9.4
12
29
18
40
48
47
36
47
93
173
6.0
13
11
190
228
270
1.6
3.4
3.1
2.2
2.2
1.6
10
15
41
69

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

.34
.06
23
.04
.17
.62
4.5
.78
4.1
6.0
6.3
18
12
1.1
1.8
7.8
23
25
78
.02
.16
1.5
1.3
2.6
3.0
4.9
9.4
48
.24
2.5
46
.28
1.8
12
23
25
17
.98
1.7
2.0
3.1
5.2
20
.05
.36
5.8
56
8.4
.12
.29
.75
1.0
1.3
1.6
2.0
5.0
3.1
7.0
8.4
8.2
6.3
8.3
16
30
1.1
2.4
1.9
33
40
47
.27
.60
.55
.39
.39
.29
1.8
2.6
7.1
12

Inches

mm

5.4 137
11
274
.23
5.9
.21
5.3
.13
3.3
.19
4.7
.16
4.0
.22
5.6
.21
5.3
.17
4.2
.18
4.6
.12
3.1
.11
2.7
.33
8.5
.28
7.1
.21
5.5
.14
3.6
.14
3.5
.08
2.0
.41 10
.38
9.7
.35
8.9
.31
8.0
.26
6.6
.30
7.6
.20
5.1
.18
4.5
.09
2.2
.38
9.7
.31
7.9
.11
2.7
.36
9.2
.31
7.8
.18
4.6
.14
3.6
.16
4.1
.19
4.9
.34
8.7
.29
7.4
.27
6.9
.30
7.6
.31
7.8
.12
3.2
.54 14
.50 13
.24
6.2
.10
2.5
.30
7.5
.61 15
.54 14
.58 15
.57 14
.48 12
.40 10
.39
9.9
.23
5.8
.34
8.7
.30
7.7
.27
6.8
.26
6.5
.32
8.1
.29
7.2
.20
5.1
.15
3.8
.51 13
.36
9.2
.44 11
.17
4.2
.15
3.9
.13
3.3
.64 16
.63 16
.72 18
.69 17
.66 17
.41 10
.41 10
.42 11
.31
7.9
.25
6.4

Lbs.

11
3.4
31
.04
.13
.67
4.1
.99
4.9
5.7
6.5
13
7.5
2.0
2.8
9.6
19
20
35
.05
.35
3.0
2.4
3.8
5.1
5.7
9.6
24
.53
4.5
28
.58
3.1
13
19
23
19
1.9
2.8
3.1
5.2
9.1
14
.15
1.0
8.0
31
14
.42
.89
2.5
3.3
3.6
3.8
4.6
6.5
6.1
12
13
12
11
13
19
26
3.1
4.9
4.8
31
35
35
.99
2.2
2.3
1.5
1.5
.67
4.2
6.1
13
17

ENDS: C - Closed

G - Ground
O - Open

47
15
137
.19
.56
3.0
18
4.4
22
25
29
56
33
9.1
13
43
85
89
157
.22
1.5
13
10
17
23
25
43
107
2.4
20
124
2.6
14
56
85
101
85
8.5
13
14
23
40
63
.66
4.6
36
140
63
1.9
3.9
11
15
16
17
20
29
27
54
57
53
51
60
84
115
14
22
21
140
156
157
4.4
9.7
10
6.8
6.5
3.0
19
27
56
77

Inches

mm

4.12 104.5
4.96 125.9
.68 17.4
.11
2.7
.18
4.7
.13
3.2
.18
4.7
.15
3.9
.19
4.8
.15
3.8
.17
4.3
.22
5.6
.33
8.4
.14
3.4
.19
4.7
.25
6.4
.31
7.9
.32
8.0
.36
9.1
.09
2.3
.12
3.0
.15
3.8
.15
3.8
.18
4.7
.20
5.1
.21
5.2
.23
5.7
.41 10.5
.15
3.8
.18
4.6
.36
9.1
.20
5.1
.17
4.3
.28
7.0
.31
7.9
.40 10.2
.37
9.4
.14
3.6
.16
4.1
.13
3.3
.23
5.9
.28
7.2
.24
6.0
.12
3.0
.16
4.0
.27
6.9
.38
9.5
.31
8.0
.14
3.6
.21
5.3
.17
4.3
.18
4.6
.21
5.3
.19
4.9
.21
5.3
.23
5.9
.27
6.9
.42 10.8
.41 10.3
.32
8.2
.43 11.0
.39
9.8
.38
9.6
.49 12.4
.30
7.6
.21
5.3
.37
9.4
.53 13.3
.55 13.9
.50 12.7
.20
5.2
.21
5.3
.16
4.0
.19
4.8
.22
5.5
.47 11.8
.20
5.2
.30
7.7
.44 11.2
.42 10.7

WIRE DIA.
Inches

mm

0.049
0.037
0.076
0.015
0.023
0.025
0.041
0.028
0.038
0.041
0.042
0.055
0.055
0.030
0.034
0.050
0.062
0.063
0.080
0.013
0.020
0.030
0.030
0.035
0.040
0.041
0.050
0.075
0.023
0.037
0.072
0.025
0.032
0.055
0.062
0.067
0.062
0.028
0.032
0.032
0.039
0.047
0.056
0.016
0.026
0.046
0.075
0.050
0.020
0.026
0.028
0.030
0.035
0.035
0.038
0.042
0.042
0.053
0.054
0.054
0.054
0.055
0.063
0.070
0.035
0.038
0.041
0.075
0.078
0.080
0.025
0.030
0.026
0.027
0.027
0.031
0.037
0.042
0.055
0.060

1.2
0.9
1.9
0.4
0.6
0.6
1.0
0.7
1.0
1.0
1.1
1.4
1.4
0.8
0.9
1.3
1.6
1.6
2.0
0.3
0.5
0.8
0.8
0.9
1.0
1.0
1.3
1.9
0.6
0.9
1.8
0.6
0.8
1.4
1.6
1.7
1.6
0.7
0.8
0.8
1.0
1.2
1.4
0.4
0.7
1.2
1.9
1.3
0.5
0.7
0.7
0.8
0.9
0.9
1.0
1.1
1.1
1.3
1.4
1.4
1.4
1.4
1.6
1.8
0.9
1.0
1.0
1.9
2.0
2.0
0.6
0.8
0.7
0.7
0.7
0.8
0.9
1.1
1.4
1.5

FINISH: Z - Zinc

TOTAL
MATL
COILS
84.0
133.0
9.00
6.00
7.00
4.00
4.50
4.50
4.00
3.75
4.00
4.00
5.00
4.50
4.50
5.00
5.00
5.00
4.50
6.00
5.00
4.00
4.00
4.25
5.00
4.00
4.50
5.50
5.50
5.00
5.00
7.00
4.25
5.00
5.00
6.00
6.00
4.00
4.00
4.00
5.00
6.00
4.25
6.50
6.00
5.00
5.00
5.25
6.00
7.00
5.00
5.00
6.00
5.50
5.50
4.50
5.50
7.00
6.50
6.00
8.00
7.00
6.00
6.00
7.50
5.50
8.00
7.00
7.00
6.25
7.00
7.00
5.00
7.00
7.00
14.0
5.50
6.25
7.00
7.00

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SST
SST
SST
SST
SPR
SST
SPR
SST
SPR
SST
SST
SST
SST
SST
SPR
SPR
SST
SST
SST
MW
SST
SPR
SST
SST
SST
SPR
SST
SPR
SPR
MW
HD
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
MW
SST
SST
SPR
MW
SST
SST
MW
MW
SST
SPR
SST
SPR
SST
SPR
HD
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
MW
MW
MW
MW
MW
MW
SST
SST
SST
SPR

E
N
D
S

CG
C
CG
C
C
C
CG
C
C
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
C
C
C
C
CG
C
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
C
C
CG
C
CG
CG
C
CG
C
CG
C
C
C
C
C
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
C
C
CG
C
CG
CG
CG
C
CG
C
CG
C
C
CG
C
C
CG

F
N
S
H

GI
N
N
N
N
N
N
N
Z
N
Z
N
N
N
N
N
Z
Z
N
N
N
Z
N
Z
N
N
N
N
N
N
Z
N
Z
N
Z
Z
Z
N
N
N
N
Z
N
Z
N
N
Z
N
N
N
Z
Z
N
Z
N
Z
N
Z
Z
N
Z
N
N
Z
Z
N
Z
Z
N
N
Z
Z
Z
Z
N
Z
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 109

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437

11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10

UU-66
3212
S-1352
S-1374
2582
HH-100
A-74
A-99
B10-3
S-848
U-63
S-787
S-862
10206
S-1253
MM-78
1930
3996
S-1059
HH-35
S-747
EE-82
4151
943
12657
10936
S-751
Z-87
J-19
10312
A9-26
B10-31
520
Q-41
3454
509
3534
10862
10765
10480
V-3
B15-70
S-1164
10762
B9-61
11126
J-60
12295
3725
S-1679
QQ-56
10883
S-1467
3166
S-748
10202
S-409
S-1297
S-752
11337
N-133
S-810
A11-3
K-60
3598
A13-36
1892
12118
A11-53
11166
L-47
4258
10518
3579
3830
3184
10495
B3-34
B10-66
10249

.88
.88
.88
.91
.91
.91
.94
.94
.94
.94
.94
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.06
1.06
1.06
1.06
1.08
1.09
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.16
1.16
1.16
1.19
1.19
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.31
1.31
1.34
1.34
1.34
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.41
1.42
1.44
1.44

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

22.2
22.2
22.2
23.0
23.0
23.0
23.8
23.8
23.8
23.8
23.8
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.0
27.0
27.0
27.0
27.4
27.8
27.8
27.8
28.6
28.6
28.6
28.6
28.6
29.4
29.4
29.4
30.2
30.2
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
33.3
33.3
34.1
34.1
34.1
34.1
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
35.7
36.1
36.5
36.5

I.D.
Inches

.313
.293
.277
.343
.327
.293
.397
.387
.373
.367
.353
.381
.369
.397
.389
.381
.377
.371
.357
.357
.353
.353
.345
.343
.343
.327
.327
.305
.295
.293
.397
.355
.355
.347
.313
.313
.311
.295
.369
.393
.377
.359
.377
.343
.343
.307
.293
.345
.327
.251
.369
.313
.355
.353
.353
.347
.343
.329
.327
.313
.309
.293
.363
.343
.377
.359
.313
.309
.347
.343
.337
.335
.327
.311
.287
.373
.343
.293
.363
.329

RATE
mm

8.0
7.4
7.0
8.7
8.3
7.4
10.1
9.8
9.5
9.3
9.0
9.7
9.4
10.1
9.9
9.7
9.6
9.4
9.1
9.1
9.0
9.0
8.8
8.7
8.7
8.3
8.3
7.7
7.5
7.4
10.1
9.0
9.0
8.8
8.0
8.0
7.9
7.5
9.4
10.0
9.6
9.1
9.6
8.7
8.7
7.8
7.4
8.8
8.3
6.4
9.4
8.0
9.0
9.0
9.0
8.8
8.7
8.4
8.3
8.0
7.8
7.4
9.2
8.7
9.6
9.1
8.0
7.8
8.8
8.7
8.6
8.5
8.3
7.9
7.3
9.5
8.7
7.4
9.2
8.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

Inches

14
28
39
3.8
7.5
19
.39
.07
1.2
.20
4.5
.79
5.8
1.0
14
2.5
2.2
.39
5.2
.91
.39
.07
1.5
.26
2.5
.43
3.5
.60
6.4
1.1
8.5
1.5
12
2.0
13
2.2
9.0
1.6
16
2.9
23
4.1
24
4.1
34
5.9
34
5.9
77
13
80
14
132
23
.39
.07
8.7
1.5
11
2.0
14
2.5
53
9.3
80
14
78
14
110
19
3.6
.64
1.3
.24
3.1
.54
5.3
.92
3.0
.52
24
4.1
19
3.3
100
17
105
18
12
2.1
28
4.8
293
51
4.9
.85
57
9.9
10
1.8
6.7
1.2
9.6
1.7
16
2.9
7.8
1.4
26
4.5
26
4.6
45
7.8
51
9.0
76
13
1.8
.32
23
4.1
1.4
.24
9.1
1.6
45
7.8
46
8.1
9.3
1.6
9.5
1.7
15
2.7
21
3.7
21
3.8
53
9.3
95
17
1.4
.24
9.1
1.6
79
14
7.3
1.3
31
5.4

.24
.18
.16
.40
.44
.24
.72
.74
.67
.61
.45
.77
.66
.78
.83
.77
.76
.52
.63
.46
.49
.54
.52
.39
.53
.40
.37
.28
.29
.21
.81
.60
.54
.53
.36
.24
.36
.23
.74
.95
.77
.63
.79
.38
.45
.22
.27
.60
.49
.18
.88
.32
.56
.67
.63
.49
.55
.46
.48
.40
.41
.34
.78
.39
.88
.58
.59
.45
.80
.65
.66
.51
.63
.53
.33
.78
.65
.35
.61
.41

80
158
223
21
43
108

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

mm

6.1
4.5
4.0
10
11
6.2
18
19
17
16
12
20
17
20
21
20
19
13
16
12
12
14
13
9.8
14
10
9.5
7.1
7.4
5.4
21
15
14
14
9.1
6.1
9.0
5.8
19
24
19
16
20
9.8
11
5.6
6.8
15
12
4.5
22
8.0
14
17
16
12
14
12
12
10
10
8.7
20
9.8
22
15
15
11
20
16
17
13
16
13
8.4
20
17
8.9
16
10

ENDS: C - Closed

G - Ground
O - Open

Lbs.

19
28
35
8.5
19
26
.28
.85
3.1
3.6
6.5
1.7
3.4
.31
1.2
1.9
2.6
3.4
5.3
5.3
6.1
4.8
8.5
9.1
13
13
13
22
23
28
.32
5.2
6.1
7.5
19
19
28
25
2.7
1.3
2.4
3.3
2.4
9.1
8.5
22
28
7.2
13
51
4.3
18
5.7
4.5
6.1
8.0
4.3
12
13
18
21
26
1.4
9.1
1.2
5.2
26
21
7.5
6.1
10
11
13
28
31
1.1
5.9
28
4.5
13

85
124
157
38
83
116
1.3
3.8
14
16
29
7.7
15
1.4
5.4
8.5
12
15
24
24
27
22
38
40
56
60
56
96
104
124
1.4
23
27
33
85
85
123
112
12
5.7
10
15
10
40
38
97
124
32
60
229
19
80
25
20
27
36
19
53
56
80
93
116
6.3
40
5.4
23
118
93
33
27
45
48
60
123
140
4.7
26
124
20
57

Inches

.43
.50
.56
.32
.41
.61
.22
.20
.26
.25
.29
.20
.27
.22
.17
.21
.24
.20
.36
.26
.34
.46
.44
.38
.33
.50
.50
.53
.71
.65
.22
.43
.36
.36
.59
.50
.47
.64
.34
.14
.24
.47
.24
.33
.40
.52
.68
.55
.58
.93
.31
.51
.31
.58
.40
.36
.71
.50
.59
.62
.70
.79
.54
.33
.47
.34
.68
.77
.55
.73
.60
.56
.72
.64
.90
.62
.75
.86
.32
.49

mm

Inches

11.0
12.8
14.2
8.1
10.5
15.5
5.6
5.1
6.5
6.2
7.5
5.0
6.8
5.6
4.3
5.3
6.1
5.0
9.1
6.6
8.5
11.7
11.1
9.6
8.4
12.6
12.6
13.4
18.0
16.5
5.6
10.9
9.1
9.1
15.0
12.6
12.0
16.2
8.6
3.6
6.1
11.9
6.1
8.4
10.1
13.2
17.4
14.0
14.7
23.6
7.8
13.0
7.8
14.7
10.1
9.1
17.9
12.7
15.0
15.7
17.9
20.1
13.6
8.4
11.8
8.7
17.3
19.5
14.0
18.5
15.2
14.2
18.2
16.2
22.9
15.8
19.1
21.9
8.2
12.3

0.062
0.072
0.080
0.047
0.055
0.072
0.020
0.025
0.032
0.035
0.042
0.028
0.034
0.020
0.024
0.028
0.030
0.033
0.040
0.040
0.042
0.042
0.046
0.047
0.047
0.055
0.055
0.066
0.071
0.072
0.020
0.041
0.041
0.045
0.062
0.062
0.063
0.071
0.034
0.022
0.030
0.039
0.030
0.047
0.047
0.065
0.072
0.046
0.055
0.093
0.034
0.062
0.041
0.042
0.042
0.045
0.047
0.054
0.055
0.062
0.064
0.072
0.037
0.047
0.030
0.039
0.062
0.064
0.045
0.047
0.050
0.051
0.055
0.063
0.075
0.032
0.047
0.072
0.037
0.054

mm

TOTAL
MATL
COILS

1.6
1.8
2.0
1.2
1.4
1.8
0.5
0.6
0.8
0.9
1.1
0.7
0.9
0.5
0.6
0.7
0.8
0.8
1.0
1.0
1.1
1.1
1.2
1.2
1.2
1.4
1.4
1.7
1.8
1.8
0.5
1.0
1.0
1.1
1.6
1.6
1.6
1.8
0.9
0.6
0.8
1.0
0.8
1.2
1.2
1.7
1.8
1.2
1.4
2.4
0.9
1.6
1.0
1.1
1.1
1.1
1.2
1.4
1.4
1.6
1.6
1.8
0.9
1.2
0.8
1.0
1.6
1.6
1.1
1.2
1.3
1.3
1.4
1.6
1.9
0.8
1.2
1.8
0.9
1.4

7.00
7.00
7.00
6.75
7.50
8.50
10.0
8.00
7.00
7.00
7.00
7.00
7.00
10.0
6.00
6.50
7.00
6.00
8.00
6.50
7.00
10.0
8.50
7.00
7.00
9.00
8.00
8.00
10.0
8.00
10.0
9.50
7.75
8.00
9.50
7.00
7.50
8.00
10.0
5.50
7.00
12.0
7.00
7.00
7.50
7.00
9.50
11.0
10.5
10.0
8.00
8.25
7.50
12.8
8.50
8.00
15.0
9.25
9.75
10.0
11.0
11.0
14.5
7.00
14.5
7.75
11.0
12.0
11.3
14.5
12.0
10.0
13.0
10.1
12.0
18.5
15.0
12.0
7.75
9.00

HD
SPR
SST
SST
MW
SST
MW
SST
SPR
SST
SPR
SST
SST
MW
SST
SST
MW
SPR
SST
SST
SST
SPR
SPR
HD
MW
SPR
SST
SST
SST
SPR
MW
SPR
HD
SST
HD
HD
MW
SST
SPR
MW
SST
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
MW
SST
SST
SPR
SST
SPR
SST
SST
SST
SST
SPR
SST
PB
SPR
MW
SPR
MW
SPR
SST
HD
SPR
SPR
SPR
MW
SPR
SPR
SPR
SPR
SPR
SPR

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
C
C
C
CG
C
CG
C
C
C
C
CG
CG
C
CG
CG
C
C
C
C
CG
CG
C
CG
C
CG
C
C
CG
C
CG
C
C
CG
C
CG
CG
C
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
C
C
CG
C
CG
CG
CG
C
C
CG
CG
CG

Z
Z
N
N
Z
N
BO
N
Z
N
GI
N
N
Z
N
N
Z
Z
N
N
N
Z
Z
Z
N
N
N
N
N
Z
BO
N
Z
N
Z
Z
Z
N
Z
N
N
N
N
Z
N
Z
Z
Z
Z
N
GI
N
N
Z
N
Z
N
N
N
N
Z
N
N
N
Z
N
Z
Z
N
Z
Z
Z
GI
Z
GI
Z
Z
N
Z
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

109

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 110

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.437
0.443
0.447
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453

11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.10
11.25
11.35
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51

A-55
J-24
1753
12223
S-749
S-1295
A11-36
CC-10
S-753
B11-54
10262
3273
12423
10129
10895
10232
10126
S-1379
OO-77
10752
12428
3123
S-1274
B11-27
TT-56
10767
4154
10374
10389
112
4163
KK-78
Q-49
3652
S-854
16
S-1154
3553
502
527
2527
4248
13
S-840
2816
11334
11889
3728
12452
10403
11968
2552
4150
4152
3217
10180
2965
3690
1928
10089
12476
12085
10098
11490
S-1685
1641
12795
A16-65
K-44
B-24
S-1538
10036
3768
EE-15
S-272
EE-67
OO-78
B2-30
B15-8
A14-38

1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.56
1.56
1.56
1.63
1.63
1.63
1.63
1.66
1.69
1.69
1.69
1.69
1.69
1.75
1.75
1.78
1.81
1.88
1.88
1.88
1.94
2.00
2.00
2.00
2.00
2.00
2.00
2.13
2.13
2.25
2.25
2.44
2.47
2.50
2.50
2.50
2.59
2.75
2.78
2.88
3.00
3.13
3.22
3.38
3.44
3.44
3.75
3.75
4.25
5.00
5.00
5.16
6.25
8.63
1.44
.88
.31
.34
.36
.38
.38
.44
.44
.44
.44
.45
.47
.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
39.7
39.7
39.7
41.3
41.3
41.3
41.3
42.1
42.8
42.8
42.8
42.8
42.8
44.5
44.5
45.2
46.0
47.6
47.6
47.6
49.2
50.8
50.8
50.8
50.8
50.8
50.8
54.0
54.0
57.2
57.2
61.9
62.7
63.5
63.5
63.5
65.9
69.9
70.6
73.0
76.2
79.4
81.8
85.7
87.3
87.3
95.3
95.3
108.0
127.0
127.0
131.0
158.8
219.1
36.5
22.2
7.9
8.7
9.1
9.5
9.5
11.1
11.1
11.1
11.1
11.5
11.9
12.7

MATERIAL: MW - Music Wire

110

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.297
.399
.397
.365
.353
.349
.347
.337
.327
.325
.293
.253
.401
.355
.345
.397
.393
.393
.337
.293
.387
.385
.375
.337
.287
.361
.287
.267
.389
.369
.357
.217
.327
.375
.343
.329
.329
.323
.293
.375
.353
.389
.355
.297
.295
.341
.313
.277
.341
.375
.325
.285
.343
.313
.293
.321
.357
.323
.297
.287
.289
.357
.343
.341
.309
.343
.347
.329
.355
.271
.341
.371
.339
.383
.379
.333
.325
.377
.329
.343

RATE
mm

7.5
10.1
10.1
9.3
9.0
8.9
8.8
8.6
8.3
8.3
7.4
6.4
10.2
9.0
8.8
10.1
10.0
10.0
8.6
7.4
9.8
9.8
9.5
8.6
7.3
9.2
7.3
6.8
9.9
9.4
9.1
5.5
8.3
9.5
8.7
8.4
8.4
8.2
7.4
9.5
9.0
9.9
9.0
7.5
7.5
8.7
8.0
7.0
8.7
9.5
8.3
7.2
8.7
8.0
7.4
8.2
9.1
8.2
7.5
7.3
7.3
9.1
8.7
8.7
7.8
8.7
8.8
8.4
9.0
6.9
8.7
9.4
8.6
9.7
9.6
8.5
8.3
9.6
8.4
8.7

Lbs./In.

73

N/mm

13
.44
.08
.71
.12
5.8
1.0
8.1
1.4
10
1.8
13
2.3
21
3.6
21
3.8
27
4.7
88
15
262
46
.46
.08
8.7
1.5
11
1.9
.63
.11
.94
.16
.63
.11
12
2.1
83
15
.94
.17
1.1
.19
2.4
.43
39
6.8
86
15
3.4
.59
79
14
146
26
.82
.14
3.1
.54
6.5
1.1
860 151
13
2.3
1.4
.25
6.6
1.2
16
2.8
14
2.5
15
2.7
52
9.0
2.3
.42
6.0
1.1
.48
.08
4.9
.86
33
5.8
40
7.1
8.9
1.6
26
4.6
66
12
7.2
1.3
1.3
.22
13
2.4
46
8.1
9.0
1.6
22
3.9
32
5.5
10
1.7
2.3
.41
8.6
1.5
35
6.1
38
6.7
28
4.9
1.8
.32
3.4
.59
3.7
.64
12
2.1
2.4
.42
10
1.8
92
16
84
15
1843 323
52
9.2
29
5.1
163
29
10
1.8
22
3.8
136
24
178
31
24
4.2
118
21
74
13

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

Lbs.

.35
9.0
1.3
34
1.4
34
.72 18
.76 19
.69 17
.62 16
.49 13
.59 15
.53 13
.32
8.0
.21
5.2
1.4
36
.70 18
.80 20
1.5
37
1.4
37
1.4
36
.85 22
.34
8.6
1.4
36
1.4
35
1.1
27
.26
6.7
.36
9.2
1.1
29
.40 10
.31
7.8
1.5
39
1.2
30
.87 22
.10
2.5
.85 22
1.5
37
1.1
29
.79 20
.83 21
.86 22
.54 14
1.4
35
1.1
27
1.8
47
1.2
31
.73 19
.93 24
1.1
27
.73 19
.57 15
1.3
34
2.2
55
1.1
27
.70 18
1.0
26
.86 22
.89 23
1.5
39
2.3
59
1.5
38
.74 19
.83 21
1.1
27
3.1
78
2.7
69
2.6
67
1.6
41
5.3 134
.72 18
.24
6.2
.12
3.0
.03
.65
.04
.94
.17
4.3
.09
2.3
.28
7.1
.19
4.8
.12
2.9
.11
2.7
.27
6.9
.16
4.0
.17
4.2

26
.60
.95
4.1
6.1
7.0
8.0
10
13
14
28
54
.65
6.1
8.5
.93
1.4
.89
10
28
1.3
1.5
2.6
10
31
3.8
31
45
1.3
3.7
5.7
85
11
2.1
7.4
13
12
13
28
2.8
6.5
.88
6.1
24
37
9.7
19
38
9.7
2.8
14
33
9.1
19
28
15
5.4
13
26
31
30
5.7
9.1
9.7
20
13
7.4
22
9.9
47
1.9
4.9
14
2.9
4.1
16
19
6.5
18
12

ENDS: C - Closed

G - Ground
O - Open

115
2.7
4.2
18
27
31
36
45
56
63
124
239
2.9
27
38
4.1
6.1
3.9
45
124
5.9
6.8
12
45
140
17
140
199
5.6
16
25
378
50
9.2
33
57
53
58
124
12
29
3.9
27
107
167
43
85
168
43
12
63
145
40
85
124
67
24
57
115
140
134
25
40
43
88
56
33
100
44
209
8.6
22
64
13
18
70
85
29
82
54

Inches

.81
.15
.15
.31
.45
.42
.43
.48
.63
.70
.79
1.06
.14
.43
.60
.16
.18
.21
.75
.83
.29
.30
.31
.30
.98
.61
1.13
1.17
.27
.43
.48
.99
1.09
.53
.87
.89
.86
1.14
1.31
.41
.63
.41
.67
1.42
1.44
.84
1.09
1.72
.96
.57
1.23
1.82
.75
1.30
1.94
1.86
1.12
1.94
1.54
2.03
2.59
1.36
1.79
1.84
2.32
2.42
.72
.37
.17
.27
.32
.21
.26
.16
.13
.24
.26
.18
.31
.25

mm

20.4
3.9
3.8
7.8
11.5
10.6
10.9
12.1
16.1
17.8
20.1
26.9
3.4
10.9
15.2
4.1
4.5
5.3
19.1
21.0
7.3
7.6
7.9
7.6
24.8
15.4
28.6
29.7
6.9
10.8
12.2
25.1
27.6
13.4
22.1
22.6
21.9
29.0
33.4
10.5
16.0
10.4
16.9
36.0
36.5
21.3
27.6
43.7
24.4
14.6
31.3
46.3
19.1
33.1
49.4
47.1
28.4
49.2
39.1
51.4
65.8
34.5
45.4
46.6
58.9
61.5
18.3
9.4
4.4
6.9
8.2
5.2
6.5
4.0
3.3
6.1
6.5
4.6
7.9
6.4

WIRE DIA.
Inches

0.070
0.019
0.020
0.036
0.042
0.044
0.045
0.050
0.055
0.056
0.072
0.092
0.018
0.041
0.046
0.020
0.022
0.022
0.050
0.072
0.025
0.026
0.031
0.050
0.075
0.038
0.075
0.085
0.024
0.034
0.040
0.110
0.055
0.031
0.047
0.054
0.054
0.057
0.072
0.032
0.042
0.024
0.041
0.070
0.071
0.048
0.062
0.080
0.048
0.031
0.056
0.076
0.047
0.062
0.072
0.058
0.040
0.057
0.070
0.075
0.074
0.040
0.047
0.048
0.064
0.047
0.048
0.059
0.049
0.091
0.056
0.041
0.057
0.035
0.037
0.060
0.064
0.038
0.062
0.055

mm

TOTAL
MATL
COILS

1.8
0.5
0.5
0.9
1.1
1.1
1.1
1.3
1.4
1.4
1.8
2.3
0.5
1.0
1.2
0.5
0.6
0.6
1.3
1.8
0.6
0.7
0.8
1.3
1.9
1.0
1.9
2.2
0.6
0.9
1.0
2.8
1.4
0.8
1.2
1.4
1.4
1.4
1.8
0.8
1.1
0.6
1.0
1.8
1.8
1.2
1.6
2.0
1.2
0.8
1.4
1.9
1.2
1.6
1.8
1.5
1.0
1.4
1.8
1.9
1.9
1.0
1.2
1.2
1.6
1.2
1.2
1.5
1.2
2.3
1.4
1.0
1.4
0.9
0.9
1.5
1.6
1.0
1.6
1.4

11.5
7.00
6.50
8.50
9.75
9.50
9.50
9.50
11.5
11.5
11.0
11.5
6.50
9.50
12.0
7.00
7.00
8.50
15.0
11.5
10.5
10.5
9.00
6.00
13.0
16.0
14.0
13.8
10.3
11.5
11.0
9.00
19.8
16.0
17.5
15.5
15.0
20.0
17.3
11.8
14.0
16.0
15.3
20.3
20.3
16.5
17.5
21.5
20.0
17.5
21.0
24.0
15.0
20.0
27.0
32.0
27.0
34.0
22.0
27.0
34.0
34.0
37.0
37.3
35.3
51.5
14.0
5.25
3.50
3.00
5.75
4.00
3.50
4.50
3.50
4.00
4.00
3.75
5.00
4.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
MW
SPR
SST
SST
SPR
SPR
SST
SPR
SPR
SPR
MW
SPR
SPR
MW
MW
SST
SPR
SPR
MW
MW
SST
SPR
SPR
SPR
SPR
SPR
MW
HD
SPR
SPR
SPR
HD
SST
HD
SST
MW
HD
HD
SPR
MW
HD
SST
MW
HD
SPR
SPR
SPR
MW
SPR
SPR
HD
HD
SPR
SPR
MW
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
MW
MW
MW
SPR
SST
SST
SPR
SPR
SST
SST
SST
SST
MW
SPR
SST

E
N
D
S

CG
C
C
CG
C
CG
CG
CG
CG
C
CG
CG
C
C
C
C
C
C
CG
CG
C
C
C
CG
CG
CG
C
CG
C
C
C
CG
CG
C
C
C
C
CG
C
C
C
C
C
CG
CG
C
CG
CG
CG
C
C
CG
C
C
CG
CG
C
CG
CG
CG
C
CG
C
C
C
CG
C
C
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG

F
N
S
H

N
N
Z
GI
N
N
N
N
N
Z
Z
Z
GI
Z
Z
Z
Z
N
N
GI
N
GI
N
N
Z
N
Z
Z
N
Z
Z
Z
GI
Z
N
Z
N
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
GI
Z
N
Z
N
N
Z
Z
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 111

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453

11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51

B1-6
RR-16
K-80
JJ-2
12517
B1-31
U-60
1767
S-1098
S-1472
PP-93
N-105
B10-67
K-40
B7-17
A14-42
A11-61
YY-66
A14-30
B12-19
B14-49
S-3174
B14-54
A14-32
10072
A13-55
10227
3441
10055
FF-64
1952
M-144
B1-40
S-1434
3907
H-91
12424
S-1191
PP-24
LL-97
10143
K-36
A11-34
A13-42
CC-35
DD-22
QQ-70
A14-45
10746
1761
12417
12435
A13-27
10194
LL-54
S-93
2830
N-142
10215
A14-58
3765
10085
B1-60
TT-60
OO-16
A11-46
A15-51
H-50
B12-35
S-206
S-1419
A15-24
11720
A11-30
H-34
Z-39
10346
J-22
B17-138
B8-54

.50
.50
.53
.53
.56
.56
.56
.56
.56
.59
.63
.63
.63
.63
.63
.63
.66
.69
.69
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.81
.81
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.91
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.09
1.13
1.13
1.13
1.13
1.13
1.19
1.19
1.19
1.22
1.22

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

12.7
12.7
13.5
13.5
14.3
14.3
14.3
14.3
14.3
15.1
15.9
15.9
15.9
15.9
15.9
15.9
16.7
17.4
17.4
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
20.6
20.6
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.8
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.8
28.6
28.6
28.6
28.6
28.6
30.2
30.2
30.2
31.0
31.0

I.D.
Inches

.341
.341
.383
.373
.389
.363
.345
.337
.325
.379
.397
.391
.381
.377
.373
.367
.321
.417
.377
.389
.369
.409
.381
.375
.371
.363
.351
.345
.341
.333
.401
.389
.367
.371
.345
.423
.407
.393
.393
.377
.369
.367
.363
.361
.353
.353
.351
.343
.329
.407
.407
.405
.377
.419
.409
.403
.395
.393
.391
.375
.373
.371
.361
.319
.293
.369
.343
.407
.359
.389
.411
.373
.369
.361
.341
.361
.345
.345
.367
.329

RATE
mm

8.7
8.7
9.7
9.5
9.9
9.2
8.8
8.6
8.3
9.6
10.1
9.9
9.7
9.6
9.5
9.3
8.2
10.6
9.6
9.9
9.4
10.4
9.7
9.5
9.4
9.2
8.9
8.8
8.7
8.5
10.2
9.9
9.3
9.4
8.8
10.7
10.3
10.0
10.0
9.6
9.4
9.3
9.2
9.2
9.0
9.0
8.9
8.7
8.4
10.3
10.3
10.3
9.6
10.6
10.4
10.2
10.0
10.0
9.9
9.5
9.5
9.4
9.2
8.1
7.4
9.4
8.7
10.3
9.1
9.9
10.4
9.5
9.4
9.2
8.7
9.2
8.8
8.8
9.3
8.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

90
70
12
17
8.1
35
59
88
102
13
2.6
5.1
17
15
19
18
118
.32
12
5.8
21
.46
8.4
16
15
22
30
35
56
77
2.8
3.3
22
14
32
.06
1.7
2.2
1.3
10
16
14
20
21
27
24
25
39
53
1.7
1.7
2.0
11
.41
.56
2.1
2.7
2.2
3.9
10
6.5
14
17
72
168
12
36
.66
12
2.7
.60
11
13
18
35
21
15
19
11
53

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

16
12
2.1
3.0
1.4
6.1
10
15
18
2.3
.45
.90
2.9
2.6
3.3
3.1
21
.06
2.2
1.0
3.8
.08
1.5
2.7
2.5
3.9
5.2
6.1
9.9
13
.49
.57
3.8
2.5
5.6
.01
.30
.39
.22
1.8
2.8
2.5
3.6
3.6
4.8
4.3
4.4
6.8
9.2
.30
.30
.35
1.9
.07
.10
.36
.47
.39
.69
1.8
1.1
2.4
3.0
13
29
2.1
6.4
.12
2.0
.47
.11
1.9
2.3
3.1
6.1
3.7
2.6
3.4
2.0
9.2

.15
.20
.31
.31
.39
.22
.21
.24
.19
.31
.42
.47
.24
.30
.29
.37
.19
.54
.35
.51
.29
.51
.44
.32
.40
.33
.35
.29
.24
.22
.63
.51
.31
.38
.33
.64
.74
.61
.46
.42
.39
.47
.38
.38
.36
.38
.42
.31
.33
.77
.80
.79
.43
.89
.77
.64
.77
.73
.80
.46
.60
.43
.46
.32
.20
.48
.36
.82
.55
.79
.96
.50
.49
.46
.39
.37
.32
.54
.55
.33

mm

3.9
5.0
7.9
8.0
9.8
5.7
5.3
6.1
4.8
7.9
11
12
6.1
7.7
7.3
9.3
4.8
14
9.0
13
7.5
13
11
8.2
10
8.4
8.9
7.4
6.2
5.6
16
13
7.8
9.7
8.3
16
19
15
12
11
10
12
9.6
9.6
9.1
9.7
11
8.0
8.4
20
20
20
11
23
20
16
20
19
20
12
15
11
12
8.2
5.2
12
9.1
21
14
20
24
13
12
12
10
9.3
8.2
14
14
8.4

ENDS: C - Closed

G - Ground
O - Open

Lbs.

14
61
14
61
3.7
16
5.5
24
3.1
14
7.7
34
12
55
21
94
19
85
4.1
18
1.1
4.7
2.4
11
4.0
18
4.4
20
5.5
24
6.5
29
22
99
.17
.77
4.4
20
2.9
13
6.3
28
.23
1.0
3.7
17
5.1
23
5.9
26
7.2
32
10
46
10
45
14
61
17
75
1.8
7.8
1.7
7.4
6.8
30
5.5
24
10
47
.04
.16
1.2
5.5
1.3
6.0
.58
2.6
4.4
20
6.3
28
6.8
30
7.7
34
7.7
34
9.8
44
9.3
41
10
46
12
54
17
77
1.3
5.8
1.3
6.0
1.6
7.1
4.7
21
.37
1.6
.43
1.9
1.3
5.9
2.0
9.1
1.6
7.2
3.1
14
4.8
21
3.9
17
5.9
26
7.7
34
23
103
34
153
5.9
26
13
58
.54
2.4
6.3
28
2.1
9.5
.58
2.6
5.5
24
6.3
28
8.3
37
14
61
7.7
34
4.8
21
10
46
6.3
28
17
77

Inches

.25
.29
.16
.20
.18
.20
.28
.29
.35
.20
.21
.16
.14
.17
.19
.26
.40
.14
.19
.21
.21
.24
.20
.20
.29
.25
.36
.46
.39
.36
.16
.27
.23
.23
.49
.24
.14
.27
.42
.25
.25
.30
.28
.28
.40
.35
.41
.37
.50
.14
.14
.14
.22
.11
.23
.13
.23
.27
.20
.23
.40
.26
.32
.60
.64
.28
.43
.24
.52
.30
.17
.27
.29
.34
.48
.28
.86
.65
.32
.56

mm

Inches

6.4
7.5
4.0
5.1
4.5
5.1
7.2
7.4
8.9
5.2
5.3
3.9
3.7
4.3
4.8
6.6
10.1
3.7
4.8
5.3
5.3
6.1
5.0
5.0
7.3
6.3
9.1
11.7
10.0
9.1
4.0
6.9
5.7
5.7
12.3
6.1
3.5
6.9
10.7
6.3
6.4
7.6
7.1
7.2
10.2
8.9
10.4
9.4
12.6
3.5
3.5
3.7
5.7
2.8
5.9
3.2
5.9
6.9
5.1
5.9
10.2
6.5
8.2
15.3
16.3
7.1
10.8
6.2
13.1
7.7
4.3
6.9
7.5
8.6
12.1
7.0
21.9
16.5
8.2
14.2

0.056
0.056
0.035
0.040
0.032
0.045
0.054
0.058
0.064
0.037
0.028
0.031
0.036
0.038
0.040
0.043
0.066
0.018
0.038
0.032
0.042
0.022
0.036
0.039
0.041
0.045
0.051
0.054
0.056
0.060
0.026
0.032
0.043
0.041
0.054
0.015
0.023
0.030
0.030
0.038
0.042
0.043
0.045
0.046
0.050
0.050
0.051
0.055
0.062
0.023
0.023
0.024
0.038
0.017
0.022
0.025
0.029
0.030
0.031
0.039
0.040
0.041
0.046
0.067
0.080
0.042
0.055
0.023
0.047
0.032
0.021
0.040
0.042
0.046
0.056
0.046
0.054
0.054
0.043
0.062

mm

TOTAL
MATL
COILS

1.4
1.4
0.9
1.0
0.8
1.1
1.4
1.5
1.6
0.9
0.7
0.8
0.9
1.0
1.0
1.1
1.7
0.5
1.0
0.8
1.1
0.6
0.9
1.0
1.0
1.1
1.3
1.4
1.4
1.5
0.7
0.8
1.1
1.0
1.4
0.4
0.6
0.8
0.8
1.0
1.1
1.1
1.1
1.2
1.3
1.3
1.3
1.4
1.6
0.6
0.6
0.6
1.0
0.4
0.6
0.6
0.7
0.8
0.8
1.0
1.0
1.0
1.2
1.7
2.0
1.1
1.4
0.6
1.2
0.8
0.5
1.0
1.1
1.2
1.4
1.2
1.4
1.4
1.1
1.6

4.50
5.25
4.50
5.00
4.50
4.50
5.25
5.00
5.50
4.50
6.50
5.00
4.00
4.50
4.75
6.00
6.00
7.00
5.00
5.50
5.00
10.0
5.50
5.00
6.00
5.50
7.00
7.50
6.00
6.00
5.00
7.50
5.25
5.50
8.00
15.0
5.00
8.00
14.0
5.50
6.00
7.00
6.25
6.00
7.00
7.00
8.00
6.75
8.00
5.00
5.00
5.00
6.00
5.50
9.50
5.00
7.00
8.00
6.50
6.00
10.0
6.25
7.00
9.00
8.00
6.75
7.75
9.50
11.0
8.50
7.00
6.75
7.00
7.25
8.50
6.00
15.0
12.0
7.50
8.00

SPR
SPR
SPR
SPR
MW
SPR
SPR
MW
SST
SST
MW
SST
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SST
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
MW
SST
SPR
SST
SPR
SST
MW
SST
MW
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
SST
MW
MW
MW
SPR
MW
MW
SST
MW
SST
MW
SST
SPR
SPR
SST
SPR
SST
SST
SPR
MW
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SST

E
N
D
S

CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
CG
C
CG
CG
C
C
CG
C
C
CG
CG
C
C
C
C
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
CG
N
C
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
CG
CG
C
CG
CG
C

F
N
S
H

GI
N
N
N
Z
N
N
Z
N
N
N
N
Z
N
Z
GI
Z
N
N
N
Z
N
N
N
Z
N
Z
Z
GI
N
Z
N
N
N
Z
N
GI
N
N
N
Z
Z
GI
N
Z
N
Z
N
N
Z
N
N
N
N
Z
N
Z
N
GI
N
Z
GI
N
GI
N
N
GI
Z
N
N
N
GI
Z
GI
GI
N
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

111

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 112

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.453
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455

11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.51
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56

A14-60
S-1278
A11-41
CC-93
BB-81
OO-80
A14-27
12414
12434
S-1601
WW-42
12651
A11-70
2849
S-245
3640
S-453
S-480
S-386
B1-58
10406
3610
10116
S-264
B14-12
10879
LL-14
10018
K-11
11346
Z-64
B14-39
10144
S-875
B1-37
S-1349
K-51
3775
12241
S-97
B-61
S-67
S-1486
10922
S-811
11887
B17-169
B-25
HH-75
11743
10330
3798
Z-28
11538
12377
V-58
4107
2878
3684
W-40
11990
11817
S-414
1731
11676
4172
71445
71445S
71455
71455S
71446
71446S
71456
71456S
71447
71447S
71457
71457S
71448
71448S

1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.28
1.28
1.31
1.31
1.34
1.38
1.38
1.38
1.41
1.44
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.56
1.63
1.69
1.69
1.69
1.75
1.78
1.81
1.81
1.88
1.88
1.88
1.94
1.94
2.00
2.13
2.25
2.34
2.47
2.50
2.50
2.50
2.50
2.53
2.63
2.72
2.75
2.75
3.00
3.50
5.00
.50
.50
.50
.50
.63
.63
.63
.63
.75
.75
.75
.75
.88
.88

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
32.5
32.5
33.3
33.3
34.1
34.9
34.9
34.9
35.7
36.5
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.9
39.7
41.3
42.8
42.8
42.8
44.5
45.2
46.0
46.0
47.6
47.6
47.6
49.2
49.2
50.8
54.0
57.2
59.5
62.7
63.5
63.5
63.5
63.5
64.3
66.7
69.0
69.9
69.9
76.2
88.9
127.0
12.7
12.7
12.7
12.7
16.0
16.0
16.0
16.0
19.1
19.1
19.1
19.1
22.4
22.4

MATERIAL: MW - Music Wire

112

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.369
.363
.359
.353
.351
.333
.309
.399
.395
.365
.273
.407
.293
.405
.361
.345
.343
.363
.369
.375
.419
.405
.403
.395
.379
.377
.373
.363
.363
.363
.349
.347
.343
.343
.367
.407
.345
.329
.329
.293
.329
.369
.363
.309
.385
.355
.329
.379
.373
.345
.345
.269
.375
.353
.357
.355
.353
.289
.265
.359
.373
.363
.359
.293
.335
.285
.377
.377
.363
.363
.377
.377
.363
.363
.377
.377
.363
.363
.377
.377

RATE
mm

9.4
9.2
9.1
9.0
8.9
8.5
7.8
10.1
10.0
9.3
6.9
10.3
7.4
10.3
9.2
8.8
8.7
9.2
9.4
9.5
10.6
10.3
10.2
10.0
9.6
9.6
9.5
9.2
9.2
9.2
8.9
8.8
8.7
8.7
9.3
10.3
8.8
8.4
8.4
7.4
8.4
9.4
9.2
7.8
9.8
9.0
8.4
9.6
9.5
8.8
8.8
6.8
9.5
9.0
9.1
9.0
9.0
7.3
6.7
9.1
9.5
9.2
9.1
7.4
8.5
7.2
9.6
9.6
9.2
9.2
9.6
9.6
9.2
9.2
9.6
9.6
9.2
9.2
9.6
9.6

Lbs./In.

9.5
13
17
16
16
38
69
1.3
2.1
12
263
.88
123
.81
13
26
23
6.9
6.8
7.2
.13
1.1
1.4
1.8
5.1
5.7
7.5
12
12
11
18
18
24
22
10
.52
20
42
39
126
32
8.2
6.3
50
2.2
12
25
3.7
3.9
13
14
219
3.6
11
7.9
11
9.8
85
125
5.1
3.1
4.6
4.8
63
17
38
23
19
41
35
18
15
32
27
14
12
26
22
12
10

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.7
2.2
3.1
2.8
2.8
6.7
12
.24
.36
2.0
46
.15
21
.14
2.3
4.5
4.1
1.2
1.2
1.3
.02
.19
.25
.31
.89
1.0
1.3
2.0
2.1
1.9
3.2
3.2
4.2
3.8
1.8
.09
3.5
7.3
6.9
22
5.7
1.4
1.1
8.7
.38
2.1
4.4
.66
.68
2.2
2.5
38
.63
1.9
1.4
2.0
1.7
15
22
.89
.54
.80
.84
11
2.9
6.7
4.0
3.4
7.2
6.1
3.1
2.6
5.6
4.7
2.5
2.1
4.5
3.8
2.1
1.8

.62
.58
.50
.57
.60
.44
.37
1.0
1.0
.58
.19
1.1
.30
1.1
.58
.48
.52
.82
.87
.70
1.3
1.3
1.3
1.2
.80
.77
.73
.67
.65
.68
.61
.59
.55
.56
.68
1.3
.61
.44
.47
.27
.57
.72
1.2
.54
1.5
.83
.73
1.2
1.3
.96
.88
.24
1.4
.90
1.2
.89
1.0
.46
.44
1.6
1.8
1.7
1.7
.81
.95
1.1
.31
.24
.28
.22
.39
.31
.36
.28
.49
.39
.44
.35
.58
.46

mm

16
15
13
14
15
11
9.4
26
26
15
4.7
29
7.6
28
15
12
13
21
22
18
32
33
33
29
20
20
19
17
16
17
15
15
14
14
17
34
15
11
12
6.9
15
18
29
14
37
21
18
29
33
24
22
6.1
36
23
30
23
26
12
11
41
45
43
44
21
24
28
7.8
6.2
7.0
5.6
10
7.9
9.1
7.2
12
9.9
11
9.0
15
12

Lbs.

5.9
7.2
8.8
9.3
9.8
17
25
1.4
2.1
6.8
49
.99
37
.88
7.7
12
12
5.6
5.9
5.1
.16
1.4
1.9
2.1
4.1
4.4
5.5
7.7
7.7
7.2
11
11
13
12
6.8
.68
12
18
18
34
18
5.9
7.2
27
3.1
9.9
18
4.3
5.1
12
12
52
5.1
9.8
9.4
9.9
9.8
39
56
8.2
5.5
7.7
8.2
51
16
42
7.0
4.7
11
7.7
7.0
4.7
11
7.7
7.0
4.7
11
7.7
7.0
4.7

ENDS: C - Closed

G - Ground
O - Open

26
32
39
41
44
75
113
6.1
9.2
30
219
4.4
163
3.9
34
55
54
25
26
23
.71
6.3
8.3
9.1
18
20
24
34
34
32
49
49
58
54
30
3.0
55
82
82
153
82
26
32
120
14
44
82
19
23
55
55
232
23
44
42
44
44
175
247
37
24
34
37
228
71
187
31
21
51
34
31
21
51
34
31
21
51
34
31
21

Inches

.34
.41
.38
.48
.51
.60
.79
.26
.28
.40
.86
.18
.90
.25
.38
.51
.54
.59
.43
.33
.23
.20
.20
.28
.31
.32
.36
.47
.42
.42
.62
.56
.59
.57
.44
.24
.62
.71
.74
.88
.87
.42
.63
1.15
.43
.66
.99
.44
.62
.86
.91
1.10
.59
.78
.84
.65
.85
1.39
2.01
.94
.76
.95
.99
1.60
1.18
3.36
.16
.16
.20
.20
.18
.18
.23
.23
.20
.20
.26
.26
.22
.22

mm

8.5
10.3
9.6
12.1
13.0
15.2
20.1
6.5
7.0
10.1
21.7
4.7
22.9
6.4
9.6
13.0
13.6
14.9
10.9
8.4
5.7
5.2
5.1
7.0
8.0
8.2
9.1
12.0
10.6
10.6
15.8
14.1
15.0
14.4
11.1
6.1
15.8
18.1
18.9
22.4
22.0
10.7
16.0
29.3
10.8
16.8
25.2
11.3
15.7
21.9
23.0
28.0
14.9
19.7
21.3
16.5
21.6
35.4
50.9
23.9
19.3
24.0
25.1
40.6
30.0
85.3
4.0
4.0
5.0
5.0
4.6
4.6
5.8
5.8
5.2
5.2
6.6
6.6
5.7
5.7

WIRE DIA.
Inches

0.042
0.045
0.047
0.050
0.051
0.060
0.072
0.027
0.029
0.044
0.090
0.023
0.080
0.024
0.046
0.054
0.055
0.045
0.042
0.039
0.017
0.024
0.025
0.029
0.037
0.038
0.040
0.045
0.045
0.045
0.052
0.053
0.055
0.055
0.043
0.023
0.054
0.062
0.062
0.080
0.062
0.042
0.045
0.072
0.034
0.049
0.062
0.037
0.040
0.054
0.054
0.092
0.039
0.050
0.048
0.049
0.050
0.082
0.094
0.047
0.040
0.045
0.047
0.080
0.059
0.084
0.039
0.039
0.046
0.046
0.039
0.039
0.046
0.046
0.039
0.039
0.046
0.046
0.039
0.039

mm

TOTAL
MATL
COILS

1.1
1.1
1.2
1.3
1.3
1.5
1.8
0.7
0.7
1.1
2.3
0.6
2.0
0.6
1.2
1.4
1.4
1.1
1.1
1.0
0.4
0.6
0.6
0.7
0.9
1.0
1.0
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.1
0.6
1.4
1.6
1.6
2.0
1.6
1.1
1.1
1.8
0.9
1.2
1.6
0.9
1.0
1.4
1.4
2.3
1.0
1.3
1.2
1.2
1.3
2.1
2.4
1.2
1.0
1.1
1.2
2.0
1.5
2.1
1.0
1.0
1.2
1.2
1.0
1.0
1.2
1.2
1.0
1.0
1.2
1.2
1.0
1.0

8.00
8.00
8.00
9.50
10.0
10.0
11.0
8.50
8.50
8.00
9.50
7.00
11.3
9.50
8.25
9.50
9.75
13.0
10.3
8.50
12.3
7.50
7.00
8.50
8.50
8.50
9.00
9.50
9.25
9.25
11.0
10.5
10.8
10.3
9.00
10.5
11.5
10.5
11.0
10.0
13.0
9.00
14.0
16.0
12.5
12.5
16.0
12.0
15.5
15.0
15.8
12.0
15.0
14.5
16.5
13.3
16.0
17.0
21.0
20.0
19.0
21.0
21.0
20.0
19.0
39.0
4.00
4.00
4.25
4.25
4.63
4.63
5.00
5.00
5.25
5.25
5.63
5.63
5.75
5.75

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SST
SPR
SST
SST
SPR
SST
SST
MW
SST
SPR
SST
SPR
MW
SST
SPR
SST
SST
SST
SPR
SST
MW
MW
SST
SST
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
SPR
SST
SPR
HD
SPR
SST
HD
SST
SST
SPR
SST
SPR
SPR
HD
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
MW
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

F
N
S
H

CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
C
CG
CG
C
C
C
C
C
CG
CG
CG
C
CG
CG
CG
O
C
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

N
N
GI
N
N
N
N
N
N
N
Z
N
Z
Z
N
Z
N
N
N
N
N
Z
BO
N
N
N
GI
Z
N
N
GI
N
Z
N
N
N
N
Z
Z
N
Z
N
N
Z
N
N
Z
N
GI
Z
Z
Z
Z
Z
Z
Z
Z
Z
GI
N
GI
Z
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 113

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.455
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468

11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.56
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89

71458
71458S
71449
71449S
71459
71459S
71450
71450S
71460
71460S
71451
71451S
71461
71461S
71452
71452S
71462
71462S
71454
71454S
71464
71464S
S-864
DD-28
A10-53
PP-57
I-99
S-1409
G-42
MM-87
OO-51
S-35
3638
3800
B17-148
S-812
S-3130
S-3006
A15-37
I-7
A10-40
3877
L-41
I-91
S-451
S-1091
K-32
B14-70
CC-55
3203
MM-100
10800
A11-65
CC-86
S-50
O-47
A15-33
1613
S-473
3643
A14-15
3257
A-75
K-84
B14-8
11201
12105
I-54
J-60-A
10738
UU-45
12324
PP-100
10258
3515
1511
2598
2934
PP-60
S-3144

.88
.88
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
.25
.31
.34
.44
.44
.50
.50
.50
.53
.53
.53
.56
.59
.59
.63
.63
.63
.63
.69
.69
.69
.72
.72
.72
.75
.75
.75
.78
.78
.81
.81
.81
.81
.81
.81
.83
.83
.83
.84
.88
.88
.88
.88
.91
.91
.94
.94
.94
.94
.94
.94
.97
.97
1.00
1.00
1.00
1.00
1.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

22.4
22.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
6.4
7.9
8.7
11.1
11.1
12.7
12.7
12.7
13.5
13.5
13.5
14.3
15.1
15.1
15.9
15.9
15.9
15.9
17.4
17.4
17.4
18.2
18.2
18.2
19.1
19.1
19.1
19.8
19.8
20.6
20.6
20.6
20.6
20.6
20.6
21.0
21.0
21.0
21.4
22.2
22.2
22.2
22.2
23.0
23.0
23.8
23.8
23.8
23.8
23.8
23.8
24.6
24.6
25.4
25.4
25.4
25.4
25.4

I.D.
Inches

.363
.363
.377
.377
.363
.363
.377
.377
.363
.363
.377
.377
.363
.363
.377
.377
.363
.363
.377
.377
.363
.363
.378
.288
.436
.388
.356
.410
.348
.344
.408
.392
.344
.384
.400
.398
.422
.420
.414
.398
.410
.400
.382
.392
.358
.340
.408
.390
.384
.416
.348
.422
.420
.416
.408
.384
.374
.416
.406
.384
.396
.412
.356
.348
.310
.408
.360
.406
.404
.366
.344
.342
.308
.324
.276
.410
.408
.408
.408
.394

RATE
mm

9.2
9.2
9.6
9.6
9.2
9.2
9.6
9.6
9.2
9.2
9.6
9.6
9.2
9.2
9.6
9.6
9.2
9.2
9.6
9.6
9.2
9.2
9.6
7.3
11.1
9.9
9.0
10.4
8.8
8.7
10.4
10.0
8.7
9.8
10.2
10.1
10.7
10.7
10.5
10.1
10.4
10.2
9.7
10.0
9.1
8.6
10.4
9.9
9.8
10.6
8.8
10.7
10.7
10.6
10.4
9.8
9.5
10.6
10.3
9.8
10.1
10.5
9.0
8.8
7.9
10.4
9.1
10.3
10.3
9.3
8.7
8.7
7.8
8.2
7.0
10.4
10.4
10.4
10.4
10.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

21
3.8
18
3.2
11
1.8
9.0
1.6
19
3.3
16
2.8
8.2
1.4
7.0
1.2
15
2.5
12
2.2
6.8
1.2
5.7
1.0
12
2.1
10
1.8
5.8
1.0
4.9
.86
10
1.8
8.7
1.5
5.5
.96
4.7
.82
9.5
1.7
8.1
1.4
69
12
1549 271
.45
.08
17
2.9
202
35
6.0
1.0
159
28
106
19
2.5
.43
13
2.3
127
22
39
6.8
12
2.1
5.9
1.0
1.3
.23
1.6
.28
4.5
.79
9.2
1.6
3.3
.57
7.8
1.4
21
3.7
6.1
1.1
47
8.3
71
12
4.0
.69
12
2.1
13
2.2
2.8
.48
57
10
.68
.12
.94
.17
1.8
.31
3.0
.53
7.2
1.3
21
3.7
2.5
.44
3.1
.54
12
2.1
4.6
.81
3.0
.52
29
5.1
68
12
200
35
2.7
.48
29
5.0
3.2
.56
4.5
.80
22
3.9
46
8.1
57
9.9
168
29
104
18
474
83
2.2
.38
2.5
.44
3.2
.55
2.8
.50
7.8
1.4

.53
.42
.66
.53
.61
.49
.85
.68
.78
.62
1.0
.82
.95
.76
1.2
.97
1.1
.89
1.3
1.0
1.2
.95
.10
.03
.26
.26
.07
.33
.10
.17
.32
.32
.20
.16
.29
.35
.49
.48
.36
.36
.51
.44
.31
.43
.25
.26
.56
.41
.46
.63
.27
.61
.62
.64
.63
.39
.38
.67
.60
.50
.53
.69
.43
.22
.17
.68
.42
.72
.71
.45
.37
.33
.21
.25
.12
.75
.75
.78
.76
.50

13
11
17
13
16
12
22
17
20
16
26
21
24
19
31
25
28
22
32
26
30
24
2.6
.73
6.7
6.6
1.7
8.5
2.4
4.3
8.2
8.1
5.0
4.0
7.4
8.8
12
12
9.1
9.2
13
11
7.8
11
6.4
6.7
14
10
12
16
6.8
15
16
16
16
10
9.7
17
15
13
13
18
11
5.7
4.4
17
11
18
18
12
9.3
8.4
5.4
6.4
3.1
19
19
20
19
13

ENDS: C - Closed

G - Ground
O - Open

Lbs.

11
7.7
7.0
4.7
11
7.7
7.0
4.7
11
7.7
7.0
4.7
11
7.7
7.0
4.7
11
7.7
7.0
4.7
11
7.7
7.0
44
.12
4.3
13
2.0
15
18
.79
4.3
25
6.1
3.4
2.1
.64
.76
1.6
3.3
1.7
3.4
6.6
2.6
12
19
2.2
4.9
5.7
1.7
15
.41
.58
1.1
1.9
2.8
8.0
1.7
1.8
6.1
2.4
2.1
13
15
34
1.9
12
2.3
3.2
10
17
19
36
26
57
1.6
1.9
2.5
2.2
3.9

51
34
31
21
51
34
31
21
51
34
31
21
51
34
31
21
51
34
31
21
51
34
31
197
.53
19
59
8.9
68
80
3.5
19
111
27
15
9.1
2.9
3.4
7.2
15
7.4
15
29
12
53
82
9.8
22
25
7.8
68
1.8
2.6
5.0
8.5
13
36
7.6
8.1
27
11
9.1
56
68
153
8.3
53
10
14
45
75
84
158
117
255
7.3
8.3
11
9.7
18

Inches

.29
.29
.25
.25
.32
.32
.30
.30
.39
.39
.35
.35
.45
.45
.39
.39
.52
.52
.40
.40
.55
.55
.14
.27
.08
.18
.17
.11
.21
.31
.21
.21
.28
.19
.14
.25
.14
.14
.13
.19
.18
.20
.22
.29
.30
.42
.20
.21
.25
.15
.38
.21
.20
.18
.18
.42
.28
.16
.23
.28
.32
.18
.45
.39
.53
.23
.43
.22
.22
.41
.50
.50
.64
.58
.67
.25
.26
.22
.24
.21

mm

Inches

7.4
7.4
6.3
6.3
8.2
8.2
7.6
7.6
9.9
9.9
8.8
8.8
11.5
11.5
9.9
9.9
13.1
13.1
10.3
10.3
13.9
13.9
3.4
6.9
2.0
4.6
4.3
2.8
5.3
7.9
5.3
5.3
7.1
4.8
3.5
6.2
3.5
3.7
3.3
4.9
4.6
5.2
5.5
7.2
7.7
10.6
5.0
5.4
6.4
3.8
9.5
5.3
5.0
4.5
4.6
10.7
7.2
4.0
5.9
7.2
8.0
4.6
11.4
9.9
13.5
5.7
11.0
5.5
5.7
10.4
12.6
12.8
16.3
14.6
17.1
6.3
6.5
5.6
6.0
5.4

0.046
0.046
0.039
0.039
0.046
0.046
0.039
0.039
0.046
0.046
0.039
0.039
0.046
0.046
0.039
0.039
0.046
0.046
0.039
0.039
0.046
0.046
0.045
0.090
0.016
0.040
0.056
0.029
0.060
0.062
0.030
0.038
0.062
0.042
0.034
0.035
0.023
0.024
0.027
0.035
0.029
0.034
0.043
0.038
0.055
0.064
0.030
0.039
0.042
0.026
0.060
0.023
0.024
0.026
0.030
0.042
0.047
0.026
0.031
0.042
0.036
0.028
0.056
0.060
0.079
0.030
0.054
0.031
0.032
0.051
0.062
0.063
0.080
0.072
0.096
0.029
0.030
0.030
0.030
0.037

mm

TOTAL
MATL
COILS

1.2
1.2
1.0
1.0
1.2
1.2
1.0
1.0
1.2
1.2
1.0
1.0
1.2
1.2
1.0
1.0
1.2
1.2
1.0
1.0
1.2
1.2
1.1
2.3
0.4
1.0
1.4
0.7
1.5
1.6
0.8
1.0
1.6
1.1
0.9
0.9
0.6
0.6
0.7
0.9
0.7
0.9
1.1
1.0
1.4
1.6
0.8
1.0
1.1
0.7
1.5
0.6
0.6
0.7
0.8
1.1
1.2
0.7
0.8
1.1
0.9
0.7
1.4
1.5
2.0
0.8
1.4
0.8
0.8
1.3
1.6
1.6
2.0
1.8
2.4
0.7
0.8
0.8
0.8
0.9

6.38
6.38
6.38
6.38
7.00
7.00
7.63
7.63
8.50
8.50
8.88
8.88
9.88
9.88
10.0
10.0
11.3
11.3
10.4
10.4
11.9
11.9
3.00
3.00
4.00
4.50
3.00
3.75
3.50
5.00
7.00
4.50
4.50
3.50
4.00
6.00
5.00
5.00
3.75
4.50
5.25
5.00
5.00
7.50
5.50
6.50
5.50
5.50
6.00
4.75
6.25
8.00
7.00
5.75
6.00
10.0
6.00
5.00
6.50
6.75
7.75
5.50
8.00
5.50
6.75
6.50
8.00
7.00
6.00
8.00
8.00
8.00
8.00
8.00
7.00
7.50
7.50
6.25
7.00
5.75

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SST
SST
SST
SPR
SST
SST
HD
SST
SST
MW
SPR
SPR
SST
SST
SST
SST
SST
SST
SPR
SPR
SST
SST
SST
MW
SPR
SST
MW
SST
SST
SST
SST
SST
SPR
SST
MW
SST
HD
SST
MW
SST
SST
SPR
SST
SPR
MW
MW
SPR
SST
SPR
HD
SPR
SPR
MW
MW
MW
MW
SST

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
C
C
C
C
C
C
C
CG
CG
CG
CG
C
CG
CG
C
CG
C
C
C
CG
CG
CG
C
C
CG
C
C
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
C
C
CG

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
Z
Z
Z
N
N
N
N
N
N
Z
Z
N
N
N
Z
Z
N
Z
N
N
N
N
N
BO
N
Z
N
GI
N
Z
N
N
Z
N
N
Z
BO
N
N
Z
Z
Z
Z
Z
Z
Z
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

113

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 114

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468

11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89

S-1344
3504
S-3079
3708
PP-20
10780
NN-51
A11-12
EE-92
10641
3962
A10-29
2981
10421
Z-44
S-488
HH-88
AA-78
3591
S-1341
B3-33
11770
Y-56
11376
QQ-65
2720
10470
A-25
N-56
M-111
Z-50
10097
L-42
F-55
TT-54
KK-77
RR-67
S-1697
3086
10555
S-1167
10696
A13-65
B8-57
12470
3966
10855
S-1447
CC-48
S-181
S-214
S-3063
FF-77
12426
DD-82
3737
HH-92
12494
YY-64
S-785
OO-93
10887
S-38
B12-69
3769
N-41
10156
11726
B2-44
10951
12484
3978
S-994
1893
3554
S-65
A13-38
S-918
RR-37
3714

1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.06
1.06
1.09
1.09
1.11
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.16
1.16
1.19
1.19
1.19
1.19
1.22
1.22
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.31
1.31
1.31
1.31
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.41
1.44
1.44
1.44
1.44
1.47
1.50
1.50
1.50
1.53
1.56
1.59
1.59
1.63
1.67
1.69
1.75
1.75
1.75
1.75
1.75
1.78
1.80
1.81
1.81
1.94

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.0
27.0
27.8
27.8
28.2
28.6
28.6
28.6
28.6
28.6
28.6
29.4
29.4
29.4
30.2
30.2
30.2
30.2
31.0
31.0
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
33.3
33.3
33.3
33.3
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
35.7
36.5
36.5
36.5
36.5
37.3
38.1
38.1
38.1
38.9
39.7
40.5
40.5
41.3
42.5
42.8
44.5
44.5
44.5
44.5
44.5
45.2
45.6
46.0
46.0
49.2

MATERIAL: MW - Music Wire

114

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.386
.358
.344
.338
.328
.398
.368
.408
.374
.344
.258
.398
.324
.296
.398
.394
.378
.368
.348
.324
.408
.404
.338
.374
.352
.282
.264
.368
.362
.360
.436
.398
.386
.378
.378
.378
.370
.368
.344
.292
.394
.386
.372
.288
.284
.414
.408
.392
.384
.380
.378
.324
.288
.412
.328
.400
.376
.372
.348
.410
.418
.408
.398
.348
.228
.324
.268
.384
.370
.388
.388
.338
.334
.318
.248
.322
.358
.398
.324
.388

RATE
mm

9.8
9.1
8.7
8.6
8.3
10.1
9.3
10.4
9.5
8.7
6.6
10.1
8.2
7.5
10.1
10.0
9.6
9.3
8.8
8.2
10.4
10.3
8.6
9.5
8.9
7.2
6.7
9.3
9.2
9.1
11.1
10.1
9.8
9.6
9.6
9.6
9.4
9.3
8.7
7.4
10.0
9.8
9.4
7.3
7.2
10.5
10.4
10.0
9.8
9.7
9.6
8.2
7.3
10.5
8.3
10.2
9.6
9.4
8.8
10.4
10.6
10.4
10.1
8.8
5.8
8.2
6.8
9.8
9.4
9.9
9.9
8.6
8.5
8.1
6.3
8.2
9.1
10.1
8.2
9.9

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

10
1.8
34
5.9
46
8.1
71
12
100
17
2.6
.46
18
3.1
2.5
.43
21
3.7
71
12
552
97
3.1
.55
89
16
217
38
6.6
1.2
5.9
1.0
9.7
1.7
15
2.7
46
8.0
77
14
2.3
.40
2.3
.40
52
9.2
19
3.2
30
5.2
340
60
508
89
14
2.5
21
3.7
23
4.0
.06
.01
6.6
1.2
5.0
.87
9.7
1.7
8.2
1.4
11
1.9
11
1.9
15
2.7
45
7.9
180
31
6.9
1.2
6.7
1.2
10
1.7
249
44
323
57
1.3
.23
1.9
.33
5.7
1.0
6.3
1.1
9.8
1.7
7.5
1.3
60
11
217
38
1.2
.21
54
9.4
3.9
.69
8.3
1.4
8.2
1.4
34
6.0
1.6
.28
.80
.14
1.7
.30
3.3
.58
27
4.8
786 138
54
9.5
240
42
6.4
1.1
11
2.0
8.2
1.4
4.5
.78
30
5.3
31
5.4
68
12
417
73
59
10
22
3.9
3.3
.58
57
9.9
4.7
.82

.53
.37
.37
.29
.24
.65
.54
.85
.41
.25
.12
.76
.30
.20
.54
.67
.63
.58
.49
.32
.89
.84
.37
.43
.50
.22
.13
.66
.54
.52
.92
.54
.74
.77
.69
.65
.71
.59
.40
.26
.57
.85
.72
.19
.16
1.1
1.1
.75
.91
.67
.84
.41
.20
1.1
.42
.88
.91
.69
.48
1.2
1.3
1.2
1.0
.59
.13
.46
.19
.95
.86
.65
1.2
.68
.68
.61
.27
.44
.54
1.0
.65
1.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

13
9.5
9.3
7.3
6.2
16
14
22
10
6.5
3.1
19
7.5
5.1
14
17
16
15
13
8.1
23
21
9.4
11
13
5.5
3.4
17
14
13
23
14
19
20
17
16
18
15
10
6.6
15
22
18
4.9
4.0
29
28
19
23
17
21
10
5.2
28
11
22
23
18
12
30
32
30
26
15
3.3
12
4.9
24
22
16
30
17
17
15
6.9
11
14
26
17
29

Lbs.

5.3
13
17
21
24
1.7
9.6
2.1
8.5
18
68
2.4
26
44
3.6
3.9
6.1
8.8
23
25
2.0
1.9
19
8.0
15
73
68
9.6
11
12
.05
3.6
3.7
7.5
5.6
7.0
7.7
9.0
18
47
3.9
5.7
7.2
48
51
1.5
2.1
4.3
5.7
6.6
6.3
25
44
1.4
23
3.4
7.5
5.7
16
1.9
1.0
2.0
3.3
16
102
25
46
6.1
9.6
5.3
5.3
21
21
41
113
26
12
3.3
37
5.3

ENDS: C - Closed

G - Ground
O - Open

24
56
75
92
108
7.5
42
9.3
38
80
304
11
117
195
16
18
27
39
101
110
9.1
8.5
86
36
66
326
302
42
50
53
.24
16
16
33
25
31
34
40
80
208
18
25
32
213
226
6.7
9.2
19
25
29
28
110
197
6.1
101
15
33
25
72
8.3
4.5
9.0
15
72
456
110
206
27
43
24
24
92
94
184
503
114
53
15
163
24

Inches

.31
.41
.56
.49
.53
.39
.45
.21
.31
.40
.81
.33
.65
.73
.25
.30
.50
.55
.48
.65
.27
.32
.55
.31
.58
.74
.84
.53
.50
.51
.33
.25
.51
.45
.56
.37
.54
.45
.56
.95
.27
.40
.59
.81
.74
.24
.29
.29
.46
.36
.54
.79
.81
.29
.77
.31
.51
.74
.60
.28
.25
.31
.35
.72
1.32
.86
1.40
.46
.59
.35
.54
1.04
1.05
.98
1.43
.95
.52
.35
.94
.48

mm

7.8
10.5
14.2
12.4
13.3
9.8
11.4
5.3
7.8
10.2
20.7
8.4
16.5
18.6
6.2
7.5
12.6
14.0
12.2
16.5
6.9
8.1
14.0
7.8
14.7
18.9
21.4
13.3
12.8
13.0
8.3
6.2
13.0
11.4
14.3
9.4
13.7
11.4
14.2
24.0
6.8
10.2
15.0
20.6
18.7
6.0
7.2
7.5
11.7
9.2
13.7
20.1
20.6
7.5
19.6
7.8
12.9
18.9
15.2
7.1
6.4
7.8
8.9
18.3
33.5
21.9
35.6
11.7
14.9
8.9
13.7
26.4
26.6
24.8
36.3
24.1
13.3
8.9
23.8
12.2

WIRE DIA.
Inches

0.041
0.055
0.062
0.065
0.070
0.035
0.050
0.030
0.047
0.062
0.105
0.035
0.072
0.086
0.035
0.037
0.045
0.050
0.060
0.072
0.030
0.032
0.065
0.047
0.058
0.093
0.102
0.050
0.053
0.054
0.016
0.035
0.041
0.045
0.045
0.045
0.049
0.050
0.062
0.088
0.037
0.041
0.048
0.090
0.092
0.027
0.030
0.038
0.042
0.044
0.045
0.072
0.090
0.028
0.070
0.034
0.046
0.048
0.060
0.029
0.025
0.030
0.035
0.060
0.120
0.072
0.100
0.042
0.049
0.040
0.040
0.065
0.067
0.075
0.110
0.073
0.055
0.035
0.072
0.040

mm

TOTAL
MATL
COILS

1.0
1.4
1.6
1.7
1.8
0.9
1.3
0.8
1.2
1.6
2.7
0.9
1.8
2.2
0.9
0.9
1.1
1.3
1.5
1.8
0.8
0.8
1.7
1.2
1.5
2.4
2.6
1.3
1.3
1.4
0.4
0.9
1.0
1.1
1.1
1.1
1.2
1.3
1.6
2.2
0.9
1.0
1.2
2.3
2.3
0.7
0.8
1.0
1.1
1.1
1.1
1.8
2.3
0.7
1.8
0.9
1.2
1.2
1.5
0.7
0.6
0.8
0.9
1.5
3.0
1.8
2.5
1.1
1.2
1.0
1.0
1.7
1.7
1.9
2.8
1.9
1.4
0.9
1.8
1.0

6.50
7.50
8.00
7.50
7.50
11.0
9.00
7.00
6.50
6.50
7.75
9.50
9.00
8.50
6.00
7.00
10.0
10.0
8.00
9.00
8.00
10.0
8.50
6.50
10.0
8.00
8.25
10.5
9.50
9.50
19.5
6.00
12.5
10.0
11.5
8.25
11.0
9.00
9.00
10.8
6.25
9.75
12.3
9.00
8.00
8.75
8.50
7.75
10.0
8.25
11.0
11.0
9.00
9.50
11.0
8.00
11.0
14.5
10.0
8.50
9.00
9.25
9.00
12.0
11.0
12.0
14.0
11.0
12.0
7.75
12.5
15.0
14.8
13.0
13.0
12.0
9.50
9.00
13.0
12.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SPR
MW
SST
MW
SPR
SST
SST
SPR
MW
SPR
SPR
SPR
SPR
MW
SPR
MW
SPR
SPR
SST
SST
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
MW
SST
SST
SST
SST
SST
SST
SST
SST
SST
SPR
SST
SPR
SPR
SST
SST
SST
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
MW
MW
SST
SST
SST
MW
SPR

E
N
D
S

C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
CG
C
CG
C
CG
C
CG
C
C
C
C
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
C
CG
C
CG
CG

F
N
S
H

N
Z
N
Z
Z
N
Z
N
Z
N
N
N
Z
Z
Z
N
Z
Z
Z
N
N
Z
N
N
Z
Z
Z
N
Z
Z
Z
Z
Z
GI
Z
N
N
N
Z
Z
N
Z
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
Z
N
N
GI
N
N
N
N
N
GI
N
Z
GI
N
Z
Z
Z
N
GI
Z
N
N
N
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 115

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.468
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480

11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
11.89
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19

A15-61
RR-62
S-1404
3573
KK-34
2852
10923
4300
S-1104
3225
A13-32
10062
12
3693
S-1536
NN-91
S-1153
3014
S-496
2818
4210
11522
11893
S-242
3032
11822
1571
12243
71465
71465S
71476
71476S
71490
71490S
71504
71504S
71518
71518S
71532
71532S
71546
71546S
71560
71560S
71575
71575S
71588
71588S
71603
71603S
71618
71618S
71466
71466S
71477
71477S
71491
71491S
71505
71505S
71519
71519S
71533
71533S
71547
71547S
71561
71561S
71576
71576S
71589
71589S
71604
71604S
71619
71619S
12785
12746
71467
71467S

O.D.

FREE LENGTH
Inches

1.94
2.00
2.00
2.00
2.00
2.00
2.06
2.13
2.13
2.34
2.41
2.50
2.50
2.50
2.56
2.63
2.63
2.88
3.06
3.06
3.50
3.50
3.50
3.50
4.00
4.94
8.00
10.3
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.73
.75
.75

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

49.2
50.8
50.8
50.8
50.8
50.8
52.4
54.0
54.0
59.5
61.1
63.5
63.5
63.5
65.1
66.7
66.7
73.0
77.8
77.8
88.9
88.9
88.9
88.9
101.6
125.4
203.2
260.4
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.7
18.6
19.1
19.1

I.D.
Inches

.376
.418
.378
.372
.348
.340
.334
.360
.268
.308
.304
.388
.360
.342
.360
.396
.388
.318
.374
.338
.366
.344
.326
.308
.258
.360
.348
.360
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.386
.392
.410
.410

RATE
mm

9.6
10.6
9.6
9.4
8.8
8.6
8.5
9.1
6.8
7.8
7.7
9.9
9.1
8.7
9.1
10.1
9.9
8.1
9.5
8.6
9.3
8.7
8.3
7.8
6.6
9.1
8.8
9.1
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
9.8
10.0
10.4
10.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

8.7
.51
5.1
9.4
20
37
45
13
201
64
68
3.2
11
24
7.5
2.0
2.4
37
3.8
25
8.3
17
30
33
126
4.9
6.2
2.3
16
13
20
17
28
24
35
30
59
50
72
61
103
87
123
104
180
153
256
217
289
246
447
380
12
10
15
13
22
18
28
24
45
38
56
48
78
67
95
81
135
114
191
163
216
183
330
280
35
14
9.9
8.4

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

1.5
.09
.90
1.6
3.6
6.4
7.9
2.2
35
11
12
.57
1.9
4.3
1.3
.35
.42
6.6
.67
4.3
1.4
2.9
5.2
5.8
22
.86
1.1
.40
2.7
2.3
3.5
3.0
4.9
4.2
6.1
5.2
10
8.8
13
11
18
15
21
18
31
27
45
38
51
43
78
66
2.1
1.8
2.6
2.2
3.8
3.2
4.9
4.2
7.9
6.7
9.8
8.3
14
12
17
14
24
20
33
28
38
32
58
49
6.1
2.5
1.7
1.5

Inches

mm

.86 22
1.7
42
1.3
32
1.3
34
.76 19
.75 19
.50 13
.94 24
.30
7.5
.55 14
.56 14
1.6
42
1.1
29
.77 20
1.4
35
1.8
46
1.8
46
.79 20
2.0
50
.84 21
1.2
31
1.1
27
.80 20
1.0
26
.58 15
2.4
62
2.6
67
5.2 132
.31
7.8
.24
6.2
.31
7.8
.24
6.2
.30
7.5
.24
6.0
.29
7.4
.23
5.9
.23
5.9
.18
4.7
.24
6.0
.19
4.8
.21
5.2
.16
4.2
.21
5.3
.17
4.2
.17
4.3
.14
3.4
.14
3.6
.11
2.8
.13
3.4
.11
2.7
.11
2.9
.09
2.3
.40 10
.31
8.0
.41 10
.33
8.3
.38
9.8
.31
7.8
.36
9.2
.29
7.3
.30
7.7
.24
6.2
.31
7.8
.24
6.2
.27
6.8
.21
5.4
.27
6.8
.21
5.4
.23
5.8
.18
4.6
.19
4.8
.15
3.8
.18
4.6
.14
3.6
.15
3.9
.12
3.1
.33
8.5
.40 10
.49 12
.39
9.8

ENDS: C - Closed

G - Ground
O - Open

Lbs.

7.5
.84
6.5
13
15
27
22
12
60
36
38
5.3
12
19
10
3.6
4.4
30
7.4
21
10
18
24
33
74
12
16
12
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
12
5.8
4.8
3.3

33
3.7
29
56
68
121
100
53
265
158
170
24
53
84
46
16
19
132
33
92
45
80
105
148
328
53
72
53
21
15
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
21
15
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
51
26
21
15

Inches

mm

Inches

.49 12.6
.35
8.9
.73 18.6
.62 15.8
.84 21.3
.77 19.5
.87 22.1
.89 22.6
1.45 36.8
1.41 35.9
1.52 38.5
.66 16.8
1.04 26.4
1.07 27.2
1.19 30.2
.58 14.6
.80 20.3
1.65 41.9
1.10 28.1
1.24 31.4
.98 24.9
1.36 34.6
1.38 35.2
2.28 57.9
3.26 82.7
2.05 52.1
2.85 72.4
4.16 105.6
.12
3.1
.12
3.1
.14
3.6
.14
3.6
.16
4.1
.16
4.1
.18
4.6
.18
4.6
.21
5.3
.21
5.3
.24
6.1
.24
6.1
.25
6.4
.25
6.4
.28
7.2
.28
7.2
.28
7.2
.28
7.2
.31
7.8
.31
7.8
.31
8.0
.31
8.0
.33
8.5
.33
8.5
.14
3.6
.14
3.6
.17
4.2
.17
4.2
.19
4.8
.19
4.8
.20
5.1
.20
5.1
.24
6.2
.24
6.2
.28
7.0
.28
7.0
.30
7.5
.30
7.5
.33
8.4
.33
8.4
.34
8.5
.34
8.5
.36
9.1
.36
9.1
.37
9.4
.37
9.4
.41 10.3
.41 10.3
.21
5.4
.33
8.4
.16
4.0
.16
4.0

0.046
0.025
0.045
0.048
0.060
0.064
0.067
0.054
0.100
0.080
0.082
0.040
0.054
0.063
0.054
0.036
0.040
0.075
0.047
0.065
0.051
0.062
0.071
0.080
0.105
0.054
0.060
0.054
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.047
0.044
0.035
0.035

mm

TOTAL
MATL
COILS

1.2
0.6
1.1
1.2
1.5
1.6
1.7
1.4
2.5
2.0
2.1
1.0
1.4
1.6
1.4
0.9
1.0
1.9
1.2
1.7
1.3
1.6
1.8
2.0
2.7
1.4
1.5
1.4
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
1.2
1.1
0.9
0.9

10.8
13.0
15.3
13.0
14.0
12.0
12.0
15.5
14.5
17.8
18.5
16.5
18.3
16.0
22.0
15.0
19.0
22.0
23.5
18.0
18.3
21.0
19.5
28.5
31.0
37.0
46.5
77.0
3.50
3.50
3.75
3.75
3.88
3.88
4.00
4.00
4.13
4.13
4.38
4.38
4.25
4.25
4.50
4.50
4.25
4.25
4.25
4.25
4.25
4.25
4.13
4.13
4.00
4.00
4.38
4.38
4.50
4.50
4.50
4.50
4.75
4.75
5.00
5.00
5.00
5.00
5.25
5.25
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
4.50
6.50
4.50
4.50

SST
SST
SST
MW
SST
MW
SPR
SPR
SST
SPR
SPR
SPR
HD
SPR
SST
SST
SST
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SPR
MW
SST

E
N
D
S

CG
C
C
CG
CG
CG
C
C
CG
CG
CG
CG
C
C
CG
C
C
CG
CG
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG

F
N
S
H

N
N
N
Z
N
Z
Z
Z
N
Z
N
Z
Z
Z
N
N
N
Z
N
Z
Z
GI
N
N
Z
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

115

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 116

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480

12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19

71478
71478S
71492
71492S
71506
71506S
71520
71520S
71534
71534S
71548
71548S
71562
71562S
71577
71577S
71590
71590S
71605
71605S
71620
71620S
71468
71468S
71479
71479S
71493
71493S
71507
71507S
71521
71521S
71535
71535S
71549
71549S
71563
71563S
71578
71578S
71591
71591S
71606
71606S
71621
71621S
71469
71469S
71480
71480S
71494
71494S
71508
71508S
71522
71522S
71536
71536S
71550
71550S
71564
71564S
71579
71579S
71592
71592S
71607
71607S
71622
71622S
71470
71470S
71481
71481S
71495
71495S
71509
71509S
71523
71523S

.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8

MATERIAL: MW - Music Wire

116

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378

RATE
mm

10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

13
11
18
15
22
19
37
32
47
40
63
53
78
66
107
91
150
128
169
144
257
218
8.3
7.1
11
8.9
15
13
19
16
30
26
38
32
51
43
66
56
88
75
124
105
139
118
210
179
7.2
6.1
9.3
7.9
13
11
17
14
26
22
35
30
45
38
57
48
76
65
106
90
119
101
180
153
5.7
4.8
7.5
6.4
10
8.5
13
11
20
17

2.2
1.9
3.2
2.7
3.9
3.3
6.5
5.6
8.2
7.0
11
9.4
14
12
19
16
26
22
30
25
45
38
1.5
1.2
1.8
1.6
2.6
2.2
3.3
2.8
5.3
4.5
6.7
5.7
8.9
7.6
11
9.7
15
13
22
18
24
21
37
31
1.3
1.1
1.6
1.4
2.3
1.9
3.0
2.5
4.6
3.9
6.1
5.2
7.8
6.7
10
8.5
13
11
19
16
21
18
32
27
1.0
.85
1.3
1.1
1.8
1.5
2.3
1.9
3.6
3.0

.49
.39
.46
.37
.46
.37
.37
.29
.36
.29
.33
.27
.33
.26
.29
.23
.24
.19
.23
.18
.20
.15
.58
.46
.59
.47
.55
.44
.53
.42
.45
.36
.45
.36
.41
.33
.39
.31
.34
.27
.29
.23
.28
.22
.24
.19
.67
.53
.66
.53
.64
.51
.60
.47
.53
.42
.49
.39
.47
.38
.45
.36
.40
.32
.34
.27
.33
.26
.28
.22
.85
.67
.82
.65
.83
.66
.78
.62
.67
.54

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

12
9.9
12
9.3
12
9.3
9.3
7.4
9.3
7.4
8.5
6.8
8.4
6.7
7.3
5.8
6.1
4.8
5.8
4.6
5.0
3.9
15
12
15
12
14
11
14
11
11
9.1
11
9.1
10
8.4
9.9
7.9
8.8
7.0
7.4
5.8
7.1
5.6
6.1
4.8
17
14
17
13
16
13
15
12
13
11
12
9.9
12
9.5
11
9.1
10
8.1
8.6
6.8
8.3
6.5
7.1
5.6
21
17
21
17
21
17
20
16
17
14

Lbs.

6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3

ENDS: C - Closed

G - Ground
O - Open

27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
21
15
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
21
15
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
21
15
27
19
37
25
45
31
61
41

Inches

.18
.18
.21
.21
.24
.24
.27
.27
.31
.31
.34
.34
.38
.38
.39
.39
.41
.41
.43
.43
.47
.47
.18
.18
.20
.20
.23
.23
.26
.26
.31
.31
.36
.36
.39
.39
.43
.43
.44
.44
.48
.48
.49
.49
.54
.54
.19
.19
.22
.22
.26
.26
.28
.28
.34
.34
.38
.38
.43
.43
.47
.47
.49
.49
.53
.53
.55
.55
.60
.60
.22
.22
.25
.25
.31
.31
.34
.34
.41
.41

mm

4.6
4.6
5.3
5.3
6.0
6.0
6.8
6.8
7.9
7.9
8.6
8.6
9.6
9.6
10.0
10.0
10.5
10.5
10.8
10.8
11.8
11.8
4.4
4.4
5.1
5.1
5.9
5.9
6.6
6.6
7.8
7.8
9.1
9.1
9.9
9.9
10.8
10.8
11.3
11.3
12.1
12.1
12.5
12.5
13.6
13.6
4.8
4.8
5.5
5.5
6.5
6.5
7.1
7.1
8.7
8.7
9.6
9.6
10.9
10.9
12.0
12.0
12.6
12.6
13.5
13.5
13.9
13.9
15.2
15.2
5.6
5.6
6.4
6.4
7.9
7.9
8.6
8.6
10.4
10.4

WIRE DIA.
Inches

mm

0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051

1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3

FINISH: Z - Zinc

TOTAL
MATL
COILS
4.75
4.75
5.00
5.00
5.25
5.25
5.25
5.25
5.63
5.63
5.75
5.75
6.00
6.00
5.88
5.88
5.75
5.75
5.75
5.75
5.75
5.75
5.00
5.00
5.25
5.25
5.50
5.50
5.75
5.75
6.00
6.00
6.50
6.50
6.63
6.63
6.75
6.75
6.63
6.63
6.63
6.63
6.63
6.63
6.63
6.63
5.38
5.38
5.75
5.75
6.13
6.13
6.25
6.25
6.75
6.75
6.88
6.88
7.25
7.25
7.50
7.50
7.38
7.38
7.38
7.38
7.38
7.38
7.38
7.38
6.25
6.25
6.63
6.63
7.38
7.38
7.50
7.50
8.00
8.00

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 117

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480

12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19

71537
71537S
71551
71551S
71565
71565S
71580
71580S
71593
71593S
71608
71608S
71623
71623S
71566
71566S
71471
71471S
71482
71482S
71496
71496S
71510
71510S
71524
71524S
71538
71538S
71552
71552S
71567
71567S
71581
71581S
71594
71594S
71609
71609S
71624
71624S
71483
71483S
71497
71497S
71511
71511S
71525
71525S
71539
71539S
71553
71553S
71568
71568S
71472
71472S
71484
71484S
71498
71498S
71512
71512S
71526
71526S
71540
71540S
71554
71554S
71569
71569S
71582
71582S
71595
71595S
71610
71610S
71625
71625S
71473
71473S

1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
41.4
41.4
41.4
41.4
41.4
41.4
41.4
41.4
41.4
41.4
41.4
41.4
41.4
41.4
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8

I.D.
Inches

.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.354
.354
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.410
.410

RATE
mm

9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
9.0
9.0
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.4
10.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

27
23
35
30
45
38
59
50
82
70
92
78
139
118
43
36
4.7
4.0
6.0
5.1
8.5
7.2
11
9.4
17
14
22
19
29
24
38
32
48
41
67
57
75
64
113
96
5.5
4.7
7.7
6.5
9.8
8.3
15
13
20
17
26
22
34
29
4.0
3.4
5.2
4.4
7.3
6.2
9.3
7.9
14
12
19
16
24
21
32
27
41
35
57
48
64
54
95
81
3.5
3.0

4.7
4.0
6.1
5.2
7.9
6.7
10
8.7
14
12
16
14
24
21
7.5
6.4
.82
.70
1.1
.89
1.5
1.3
1.9
1.6
2.9
2.5
3.9
3.3
5.0
4.3
6.6
5.6
8.4
7.2
12
10
13
11
20
17
.96
.82
1.3
1.1
1.7
1.5
2.6
2.2
3.5
3.0
4.5
3.8
6.0
5.1
.70
.60
.91
.77
1.3
1.1
1.6
1.4
2.5
2.1
3.3
2.8
4.3
3.6
5.5
4.7
7.1
6.1
9.9
8.4
11
9.5
17
14
.61
.52

.63
.51
.60
.48
.57
.45
.52
.42
.44
.34
.42
.33
.36
.29
.60
.48
1.0
.82
1.0
.82
.97
.77
.92
.73
.82
.65
.78
.62
.73
.58
.68
.54
.63
.51
.54
.42
.52
.41
.45
.35
1.1
.89
1.1
.85
1.0
.83
.93
.74
.86
.68
.83
.66
.75
.60
1.2
.96
1.2
.94
1.1
.90
1.1
.87
.96
.77
.92
.73
.87
.69
.81
.64
.75
.60
.63
.50
.61
.48
.53
.42
1.4
1.1

mm

16
13
15
12
14
11
13
11
11
8.7
11
8.4
9.2
7.3
15
12
26
21
26
21
25
20
23
19
21
17
20
16
19
15
17
14
16
13
14
11
13
10
11
8.9
28
23
27
22
26
21
24
19
22
17
21
17
19
15
31
24
30
24
29
23
28
22
24
19
23
19
22
18
20
16
19
15
16
13
16
12
13
11
35
28

ENDS: C - Closed

G - Ground
O - Open

Lbs.

17
12
21
14
25
17
30
21
36
24
39
26
50
34
25
17
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
4.8
3.3

76
52
94
63
113
77
136
92
160
107
173
116
224
150
113
77
21
15
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
27
19
37
25
45
31
61
41
76
52
94
63
113
77
21
15
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
21
15

Inches

.46
.46
.51
.51
.57
.57
.60
.60
.64
.64
.67
.67
.73
.73
.59
.59
.25
.25
.29
.29
.35
.35
.38
.38
.48
.48
.54
.54
.60
.60
.65
.65
.70
.70
.76
.76
.78
.78
.86
.86
.31
.31
.37
.37
.42
.42
.53
.53
.58
.58
.66
.66
.70
.70
.28
.28
.33
.33
.39
.39
.44
.44
.54
.54
.61
.61
.69
.69
.75
.75
.81
.81
.86
.86
.90
.90
.99
.99
.32
.32

mm

Inches

11.7
11.7
12.9
12.9
14.4
14.4
15.3
15.3
16.2
16.2
16.9
16.9
18.5
18.5
15.0
15.0
6.4
6.4
7.5
7.5
8.8
8.8
9.7
9.7
12.1
12.1
13.6
13.6
15.2
15.2
16.6
16.6
17.9
17.9
19.2
19.2
19.7
19.7
21.9
21.9
8.0
8.0
9.5
9.5
10.7
10.7
13.4
13.4
14.8
14.8
16.7
16.7
17.8
17.8
7.2
7.2
8.3
8.3
9.9
9.9
11.1
11.1
13.8
13.8
15.5
15.5
17.4
17.4
19.0
19.0
20.6
20.6
21.9
21.9
22.8
22.8
25.2
25.2
8.0
8.0

0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.063
0.063
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.035
0.035

mm

TOTAL
MATL
COILS

1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
1.6
1.6
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
0.9
0.9

8.38
8.38
8.63
8.63
9.00
9.00
9.00
9.00
8.88
8.88
9.00
9.00
9.00
9.00
9.38
9.38
7.25
7.25
7.75
7.75
8.25
8.25
8.50
8.50
9.38
9.38
9.75
9.75
10.1
10.1
10.4
10.4
10.5
10.5
10.5
10.5
10.5
10.5
10.6
10.6
8.25
8.25
8.88
8.88
9.38
9.38
10.4
10.4
10.6
10.6
11.1
11.1
11.1
11.1
8.13
8.13
8.63
8.63
9.25
9.25
9.75
9.75
10.6
10.6
11.1
11.1
11.6
11.6
11.9
11.9
12.1
12.1
12.0
12.0
12.1
12.1
12.3
12.3
9.00
9.00

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

117

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 118

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480

12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19

71485
71485S
71499
71499S
71513
71513S
71527
71527S
71541
71541S
71555
71555S
71570
71570S
71583
71583S
71596
71596S
71611
71611S
71626
71626S
71486
71486S
71500
71500S
71514
71514S
71528
71528S
71542
71542S
71556
71556S
71571
71571S
71584
71584S
71597
71597S
71612
71612S
71627
71627S
71474
71474S
71487
71487S
71501
71501S
71515
71515S
71529
71529S
71543
71543S
71557
71557S
71572
71572S
71585
71585S
71598
71598S
71613
71613S
71628
71628S
71488
71488S
71502
71502S
71516
71516S
71530
71530S
71544
71544S
71558
71558S

2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9

MATERIAL: MW - Music Wire

118

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.410
.410
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.404
.404
.396
.396
.390
.390
.378
.378
.370
.370
.362
.362

RATE
mm

10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.3
10.3
10.1
10.1
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

4.5
3.8
6.4
5.4
8.1
6.8
12
11
16
14
21
18
27
23
35
30
49
42
55
47
82
70
4.2
3.6
5.7
4.8
7.1
6.0
11
9.3
15
12
19
16
24
21
31
26
43
37
48
41
72
61
2.8
2.4
3.8
3.2
5.4
4.5
6.4
5.4
9.9
8.4
13
11
17
14
22
18
28
24
39
33
43
37
65
55
3.4
2.9
4.8
4.1
5.8
4.9
8.8
7.4
12
10
15
13

.79
.67
1.1
.95
1.4
1.2
2.2
1.9
2.9
2.4
3.7
3.1
4.8
4.1
6.2
5.2
8.6
7.3
9.6
8.2
14
12
.73
.62
1.0
.85
1.2
1.0
1.9
1.6
2.5
2.2
3.3
2.8
4.3
3.6
5.4
4.6
7.6
6.4
8.5
7.2
13
11
.49
.42
.66
.56
.94
.80
1.1
.95
1.7
1.5
2.3
1.9
2.9
2.5
3.8
3.2
4.9
4.1
6.8
5.7
7.6
6.4
11
9.6
.60
.51
.84
.72
1.0
.86
1.5
1.3
2.1
1.7
2.7
2.3

1.4
1.1
1.3
1.0
1.3
1.0
1.1
.88
1.0
.83
1.0
.79
.93
.74
.87
.69
.73
.58
.71
.56
.61
.48
1.5
1.2
1.5
1.2
1.4
1.1
1.3
1.0
1.2
.94
1.1
.90
1.0
.84
.98
.78
.83
.66
.80
.63
.70
.55
1.7
1.4
1.6
1.3
1.5
1.2
1.6
1.3
1.4
1.1
1.3
1.1
1.3
1.0
1.2
.94
1.1
.87
.93
.73
.90
.71
.78
.62
1.8
1.4
1.7
1.4
1.7
1.4
1.6
1.2
1.5
1.2
1.4
1.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

35
27
33
26
32
25
28
22
27
21
25
20
24
19
22
18
19
15
18
14
16
12
37
30
37
29
37
29
32
25
30
24
29
23
27
21
25
20
21
17
20
16
18
14
44
35
42
33
39
31
40
32
35
28
34
27
32
26
30
24
28
22
24
19
23
18
20
16
46
37
44
35
44
35
40
32
37
30
35
28

Lbs.

6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
4.8
3.3
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
6.2
4.2
8.3
5.6
10
6.9
14
9.3
17
12
21
14

ENDS: C - Closed

G - Ground
O - Open

27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
21
15
27
19
37
25
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
27
19
37
25
45
31
61
41
76
52
94
63

Inches

.37
.37
.44
.44
.49
.49
.61
.61
.69
.69
.77
.77
.84
.84
.91
.91
.98
.98
1.02
1.02
1.12
1.12
.39
.39
.48
.48
.55
.55
.68
.68
.76
.76
.86
.86
.94
.94
1.02
1.02
1.09
1.09
1.13
1.13
1.26
1.26
.38
.38
.43
.43
.50
.50
.60
.60
.74
.74
.84
.84
.95
.95
1.03
1.03
1.12
1.12
1.21
1.21
1.25
1.25
1.39
1.39
.47
.47
.55
.55
.65
.65
.82
.82
.91
.91
1.03
1.03

mm

9.3
9.3
11.1
11.1
12.4
12.4
15.4
15.4
17.5
17.5
19.5
19.5
21.4
21.4
23.2
23.2
24.9
24.9
25.8
25.8
28.5
28.5
9.9
9.9
12.1
12.1
13.9
13.9
17.2
17.2
19.2
19.2
21.7
21.7
23.8
23.8
26.0
26.0
27.7
27.7
28.7
28.7
31.9
31.9
9.6
9.6
10.9
10.9
12.8
12.8
15.1
15.1
18.8
18.8
21.3
21.3
24.2
24.2
26.2
26.2
28.5
28.5
30.6
30.6
31.7
31.7
35.2
35.2
11.8
11.8
13.9
13.9
16.4
16.4
20.7
20.7
23.2
23.2
26.0
26.0

WIRE DIA.
Inches

0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.038
0.038
0.042
0.042
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059

mm

TOTAL
MATL
COILS

1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
1.0
1.0
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5

9.63
9.63
10.4
10.4
10.9
10.9
11.9
11.9
12.5
12.5
13.0
13.0
13.4
13.4
13.6
13.6
13.6
13.6
13.8
13.8
13.9
13.9
10.3
10.3
11.4
11.4
12.1
12.1
13.3
13.3
13.8
13.8
14.5
14.5
14.9
14.9
15.3
15.3
15.1
15.1
15.3
15.3
15.5
15.5
10.8
10.8
11.3
11.3
12.0
12.0
13.3
13.3
14.5
14.5
15.3
15.3
16.1
16.1
16.4
16.4
16.8
16.8
16.8
16.8
16.9
16.9
17.1
17.1
12.3
12.3
13.0
13.0
14.4
14.4
16.0
16.0
16.6
16.6
17.4
17.4

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 119

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.480
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484

12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.19
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29

71573
71573S
71586
71586S
71599
71599S
71614
71614S
71629
71629S
71475
71475S
71489
71489S
71503
71503S
12726
71517
71517S
71531
71531S
71545
71545S
71559
71559S
71574
71574S
71587
71587S
71600
71600S
71615
71615S
71630
71630S
71601
71601S
71616
71616S
71631
71631S
71602
71602S
71617
71617S
71632
71632S
H-35
AA-63
UU-69
A10-50
S-1575
L-6
S-1042
OO-86
GG-88
S-45
DD-83
N-87
A-77
U-34
3868
KK-57
3807
A9-55
N-112
GG-1
BB-93
10847
H-28
Y-18
2660
12236
11384
CC-84
A11-68
1757
AA-81
S-1009
FF-58

2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.25
3.25
3.25
3.25
3.25
3.25
3.50
3.50
3.50
3.50
3.50
3.50
.25
.25
.25
.31
.34
.34
.34
.38
.38
.41
.41
.41
.41
.41
.47
.47
.47
.47
.48
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.56
.56
.56
.56

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
82.6
82.6
82.6
82.6
82.6
82.6
88.9
88.9
88.9
88.9
88.9
88.9
6.4
6.4
6.4
7.9
8.7
8.7
8.7
9.5
9.5
10.3
10.3
10.3
10.3
10.3
11.9
11.9
11.9
11.9
12.3
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
14.3
14.3
14.3
14.3

I.D.
Inches

.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.410
.410
.404
.404
.396
.396
.390
.390
.390
.378
.378
.370
.370
.362
.362
.354
.354
.346
.346
.336
.336
.332
.332
.318
.318
.336
.336
.332
.332
.318
.318
.336
.336
.332
.332
.318
.318
.388
.384
.376
.424
.404
.390
.360
.414
.394
.402
.384
.376
.374
.364
.404
.404
.372
.348
.416
.444
.434
.428
.402
.394
.382
.376
.374
.384
.338
.410
.410
.404
.394

RATE
mm

9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
10.4
10.4
10.3
10.3
10.1
10.1
9.9
9.9
9.9
9.6
9.6
9.4
9.4
9.2
9.2
9.0
9.0
8.8
8.8
8.5
8.5
8.4
8.4
8.1
8.1
8.5
8.5
8.4
8.4
8.1
8.1
8.5
8.5
8.4
8.4
8.1
8.1
9.9
9.8
9.6
10.8
10.3
9.9
9.1
10.5
10.0
10.2
9.8
9.6
9.5
9.2
10.3
10.3
9.4
8.8
10.6
11.3
11.0
10.9
10.2
10.0
9.7
9.6
9.5
9.8
8.6
10.4
10.4
10.3
10.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

20
17
25
21
35
30
39
33
58
50
2.3
2.0
3.1
2.6
4.4
3.8
5.1
5.3
4.5
8.0
6.8
11
9.1
14
12
18
15
23
20
32
27
36
30
53
45
29
25
33
28
49
42
27
23
30
26
45
38
92
97
134
12
37
84
167
10
61
16
97
102
67
163
17
18
72
189
9.2
1.0
2.2
6.2
14
20
40
61
67
32
174
15
4.8
16
21

3.5
3.0
4.4
3.7
6.1
5.2
6.8
5.8
10
8.7
.40
.34
.55
.46
.77
.66
.89
.93
.79
1.4
1.2
1.9
1.6
2.4
2.1
3.1
2.6
4.0
3.4
5.6
4.7
6.3
5.3
9.3
7.9
5.1
4.4
5.7
4.9
8.6
7.3
4.7
4.0
5.3
4.5
7.9
6.7
16
17
23
2.2
6.5
15
29
1.8
11
2.8
17
18
12
29
2.9
3.2
13
33
1.6
.18
.39
1.1
2.4
3.5
7.0
11
12
5.7
30
2.6
.84
2.8
3.6

1.3
1.0
1.2
.97
1.0
.81
.99
.78
.87
.68
2.1
1.7
2.0
1.6
1.9
1.5
1.3
1.9
1.5
1.7
1.4
1.6
1.3
1.5
1.2
1.4
1.2
1.3
1.1
1.1
.89
1.1
.86
.95
.75
1.2
.97
1.2
.93
1.0
.81
1.3
1.0
1.3
1.0
1.1
.88
.10
.09
.08
.22
.13
.10
.10
.24
.11
.18
.09
.11
.16
.10
.25
.26
.18
.11
.34
.40
.37
.40
.30
.28
.25
.19
.25
.27
.14
.37
.28
.30
.33

mm

33
26
31
25
26
21
25
20
22
17
53
42
50
40
48
38
34
49
39
44
35
41
32
39
31
37
29
34
27
29
23
28
22
24
19
31
25
30
24
26
21
34
27
32
26
28
22
2.4
2.3
2.1
5.6
3.3
2.5
2.5
6.0
2.9
4.6
2.3
2.9
4.0
2.5
6.3
6.7
4.5
2.9
8.6
10
9.4
10
7.5
7.0
6.2
4.8
6.4
6.8
3.6
9.5
7.2
7.5
8.4

ENDS: C - Closed

G - Ground
O - Open

Lbs.

25
17
30
21
36
24
39
26
50
34
4.8
3.3
6.2
4.2
8.3
5.6
6.9
10
6.9
14
9.3
17
12
21
14
25
17
30
21
36
24
39
26
50
34
36
24
39
26
50
34
36
24
39
26
50
34
8.8
8.7
11
2.8
4.8
8.3
16
2.4
6.8
2.9
8.7
12
11
16
4.2
4.8
13
21
3.1
.41
.83
2.5
4.1
5.6
9.8
12
17
8.7
25
5.6
1.4
4.8
6.8

113
77
136
92
160
107
173
116
224
150
21
15
27
19
37
25
31
45
31
61
41
76
52
94
63
113
77
136
92
160
107
173
116
224
150
160
107
173
116
224
150
160
107
173
116
224
150
39
39
49
12
21
37
73
11
30
13
39
52
47
70
19
21
57
95
14
1.8
3.7
11
18
25
44
52
75
39
111
25
6.0
21
30

Inches

1.12
1.12
1.23
1.23
1.31
1.31
1.37
1.37
1.52
1.52
.44
.44
.50
.50
.59
.59
.64
.70
.70
.89
.89
.99
.99
1.11
1.11
1.24
1.24
1.33
1.33
1.43
1.43
1.48
1.48
1.64
1.64
1.54
1.54
1.60
1.60
1.77
1.77
1.66
1.66
1.72
1.72
1.90
1.90
.14
.15
.16
.09
.16
.14
.22
.14
.18
.23
.15
.19
.25
.21
.22
.16
.25
.27
.14
.10
.13
.10
.21
.23
.26
.24
.25
.25
.37
.19
.28
.21
.23

mm

Inches

28.4
28.4
31.3
31.3
33.4
33.4
34.8
34.8
38.6
38.6
11.2
11.2
12.7
12.7
14.9
14.9
16.3
17.7
17.7
22.5
22.5
25.1
25.1
28.3
28.3
31.6
31.6
33.8
33.8
36.3
36.3
37.6
37.6
41.7
41.7
39.1
39.1
40.6
40.6
45.0
45.0
42.1
42.1
43.7
43.7
48.3
48.3
3.7
3.8
4.1
2.3
4.1
3.6
5.5
3.6
4.6
5.7
3.8
4.8
6.3
5.3
5.6
4.1
6.4
6.9
3.5
2.5
3.3
2.5
5.2
5.7
6.5
6.2
6.3
6.4
9.3
4.7
7.0
5.3
5.7

0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.035
0.035
0.038
0.038
0.042
0.042
0.045
0.045
0.045
0.051
0.051
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.074
0.074
0.081
0.081
0.072
0.072
0.074
0.074
0.081
0.081
0.072
0.072
0.074
0.074
0.081
0.081
0.048
0.050
0.054
0.030
0.040
0.047
0.062
0.035
0.045
0.041
0.050
0.054
0.055
0.060
0.040
0.040
0.056
0.068
0.034
0.020
0.025
0.028
0.041
0.045
0.051
0.054
0.055
0.050
0.073
0.037
0.037
0.040
0.045

mm

TOTAL
MATL
COILS

1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
0.9
0.9
1.0
1.0
1.1
1.1
1.1
1.1
1.1
1.3
1.3
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
1.9
1.9
2.1
2.1
1.8
1.8
1.9
1.9
2.1
2.1
1.8
1.8
1.9
1.9
2.1
2.1
1.2
1.3
1.4
0.8
1.0
1.2
1.6
0.9
1.1
1.0
1.3
1.4
1.4
1.5
1.0
1.0
1.4
1.7
0.9
0.5
0.6
0.7
1.0
1.1
1.3
1.4
1.4
1.3
1.9
0.9
0.9
1.0
1.1

17.8
17.8
18.4
18.4
18.3
18.3
18.5
18.5
18.8
18.8
12.6
12.6
13.1
13.1
14.0
14.0
14.3
15.5
15.5
17.4
17.4
18.0
18.0
18.9
18.9
19.8
19.8
19.9
19.9
19.9
19.9
20.0
20.0
20.3
20.3
21.4
21.4
21.6
21.6
21.9
21.9
23.0
23.0
23.3
23.3
23.5
23.5
3.00
3.00
3.00
3.00
3.00
3.00
3.50
4.00
3.00
4.50
3.00
3.50
4.50
3.50
4.50
4.00
4.50
4.00
4.00
4.00
4.25
3.50
5.00
5.00
5.00
4.50
4.50
5.00
5.00
4.00
7.50
4.25
5.00

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SST
SST
MW
SST
SPR
SST
SST
SST
SST
SST
SPR
HD
SPR
SPR
SST
SPR
SST
SST
SST
SST
MW
SST
SST
SPR
SPR
MW
SST
SST
MW
SST
SST
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
GI
N
Z
N
N
N
N
N
N
N
N
Z
N
Z
N
N
N
N
Z
N
N
Z
N
Z
N
N
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

119

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 120

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484

12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29

XX-37
10993
N-134
W-35
11197
10781
PP-87
2625
B9-12
S-866
S-1401
S-1560
W-60
N-85
FF-35
II-75
JJ-97
10934
3594
S-1539
10899
12425
1653
12215
W-64
10557
I-31
H-90
4285
CC-1
G-75
PP-80
B12-21
YY-53
TT-40
S-399
II-90
1525
S-3135
10491
1885
11815
3088
OO-66
DD-94
12304
TT-42
YY-31
10598
Z-47
RR-60
A-94
B5-35
L-21
S-1092
A-35
H-47
XX-68
10351
S-1126
H-39
A-39
S-822
10558
S-294
10695
11403
A11-31
A15-60
A9-37
A13-67
S-802
1871
B10-61
11983
CC-9
S-945
3832
12226
3903

.56
.56
.59
.59
.63
.63
.63
.63
.69
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.78
.78
.81
.81
.84
.84
.84
.88
.88
.88
.88
.88
.91
.94
.94
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.09
1.09
1.13
1.13
1.13
1.13
1.16
1.19
1.19
1.22
1.22
1.22
1.25
1.25
1.25
1.28
1.28
1.28
1.31
1.34
1.34
1.35
1.38
1.38
1.38
1.38
1.38
1.38

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

14.3
14.3
15.1
15.1
15.9
15.9
15.9
15.9
17.4
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
20.6
20.6
21.4
21.4
21.4
22.2
22.2
22.2
22.2
22.2
23.0
23.8
23.8
23.8
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.8
27.8
28.6
28.6
28.6
28.6
29.4
30.2
30.2
31.0
31.0
31.0
31.8
31.8
31.8
32.5
32.5
32.5
33.3
34.1
34.1
34.3
34.9
34.9
34.9
34.9
34.9
34.9

MATERIAL: MW - Music Wire

120

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.390
.372
.420
.414
.420
.384
.384
.372
.436
.414
.360
.304
.448
.436
.432
.404
.376
.358
.340
.426
.334
.430
.350
.424
.416
.346
.446
.440
.360
.300
.266
.418
.402
.394
.392
.358
.350
.418
.410
.394
.394
.388
.384
.384
.384
.374
.360
.360
.356
.294
.274
.300
.400
.390
.434
.420
.386
.382
.360
.426
.340
.420
.390
.356
.416
.376
.376
.392
.350
.340
.354
.392
.340
.376
.400
.394
.384
.340
.334
.264

RATE
mm

9.9
9.4
10.7
10.5
10.7
9.8
9.8
9.4
11.1
10.5
9.1
7.7
11.4
11.1
11.0
10.3
9.6
9.1
8.6
10.8
8.5
10.9
8.9
10.8
10.6
8.8
11.3
11.2
9.1
7.6
6.8
10.6
10.2
10.0
10.0
9.1
8.9
10.6
10.4
10.0
10.0
9.9
9.8
9.8
9.8
9.5
9.1
9.1
9.0
7.5
7.0
7.6
10.2
9.9
11.0
10.7
9.8
9.7
9.1
10.8
8.6
10.7
9.9
9.0
10.6
9.6
9.6
10.0
8.9
8.6
9.0
10.0
8.6
9.6
10.2
10.0
9.8
8.6
8.5
6.7

Lbs./In.

N/mm

28
4.9
90
16
3.3
.57
5.2
.91
3.9
.68
44
7.7
31
5.5
72
13
3.7
.64
5.2
.91
82
14
383
67
.14
.02
1.4
.25
2.0
.35
9.3
1.6
38
6.7
71
13
138
24
2.0
.35
285
50
3.2
.56
80
14
3.1
.54
6.2
1.1
107
19
.31
.05
.31
.05
47
8.2
270
47
641 112
4.1
.72
12
2.0
15
2.7
18
3.1
48
8.4
67
12
2.1
.36
6.6
1.1
14
2.4
17
3.1
15
2.7
17
3.0
27
4.8
24
4.3
33
5.8
41
7.2
94
16
54
9.5
332
58
535
94
270
47
10
1.8
16
2.8
1.0
.18
1.8
.32
14
2.5
22
3.8
35
6.2
1.7
.30
60
11
2.9
.51
6.8
1.2
42
7.4
4.6
.80
28
4.9
21
3.7
13
2.3
55
9.5
65
11
47
8.1
10
1.8
79
14
26
4.5
10
1.8
7.6
1.3
13
2.4
55
9.7
66
12
503
88

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

.28
.14
.37
.35
.41
.21
.29
.25
.47
.51
.20
.11
.53
.61
.59
.47
.30
.26
.26
.59
.10
.66
.27
.63
.50
.22
.70
.59
.37
.17
.003
.66
.47
.45
.41
.36
.33
.60
.58
.52
.58
.57
.55
.34
.38
.37
.40
.18
.35
.16
.13
.17
.57
.48
.93
.74
.65
.45
.47
.94
.40
.89
.62
.45
.67
.42
.52
.55
.38
.39
.43
.71
.32
.45
.57
.90
.65
.46
.43
.16

mm

Lbs.

7.1
3.6
9.4
8.8
10
5.3
7.5
6.3
12
13
5.1
2.9
13
15
15
12
7.7
6.5
6.6
15
2.6
17
6.9
16
13
5.6
18
15
9.4
4.3
.08
17
12
11
10
9.1
8.3
15
15
13
15
15
14
8.6
9.6
9.3
10
4.7
8.9
4.2
3.4
4.3
15
12
23
19
16
11
12
24
10
23
16
12
17
11
13
14
9.6
10
11
18
8.2
12
15
23
16
12
11
4.0

7.8
13
1.2
1.8
1.6
9.3
9.3
18
1.7
2.6
16
43
.07
.86
1.2
4.4
12
18
36
1.2
29
2.1
22
2.0
3.1
24
.22
.18
17
46
1.9
2.7
5.5
6.8
7.3
17
22
1.2
3.8
7.3
10
8.8
9.3
9.3
9.3
12
16
17
19
54
72
46
5.9
7.7
.93
1.3
9.3
9.8
17
1.6
24
2.6
4.2
19
3.1
12
11
7.3
21
26
20
7.3
26
12
5.9
6.8
8.7
26
29
79

ENDS: C - Closed

G - Ground
O - Open

35
57
5.4
8.0
7.0
41
41
80
7.7
12
73
192
.33
3.8
5.2
19
52
81
159
5.1
128
9.4
97
8.8
14
106
.97
.82
77
204
8.6
12
25
30
32
76
97
5.5
17
32
45
39
41
41
41
54
73
77
85
241
319
204
26
34
4.2
6.0
42
44
74
7.1
106
11
19
85
14
52
49
32
91
113
89
32
113
52
26
30
39
113
128
351

Inches

.28
.28
.22
.25
.22
.23
.28
.25
.10
.21
.31
.50
.22
.14
.16
.28
.32
.39
.43
.20
.33
.15
.47
.21
.20
.43
.17
.28
.50
.69
.87
.25
.25
.32
.26
.47
.54
.40
.22
.32
.27
.38
.43
.30
.33
.44
.50
.31
.51
.76
.84
.69
.34
.31
.20
.38
.44
.43
.68
.25
.72
.26
.60
.69
.24
.41
.51
.33
.57
.76
.62
.39
.65
.43
.34
.45
.46
.86
.90
1.10

mm

7.2
7.1
5.7
6.2
5.5
5.7
7.0
6.4
2.6
5.3
7.9
12.6
5.6
3.7
4.0
7.1
8.2
10.0
11.0
5.0
8.3
3.8
11.9
5.3
5.2
10.9
4.3
7.1
12.6
17.5
22.1
6.3
6.2
8.0
6.7
12.0
13.6
10.1
5.6
8.0
6.9
9.8
10.8
7.6
8.3
11.2
12.6
7.9
13.0
19.3
21.3
17.5
8.5
7.8
5.1
9.8
11.2
11.0
17.3
6.3
18.3
6.5
15.2
17.5
6.0
10.3
13.0
8.3
14.5
19.2
15.7
9.9
16.5
11.0
8.5
11.4
11.7
21.9
22.9
27.9

WIRE DIA.
Inches

0.047
0.056
0.032
0.035
0.032
0.050
0.050
0.056
0.024
0.035
0.062
0.090
0.018
0.024
0.026
0.040
0.054
0.063
0.072
0.029
0.075
0.027
0.067
0.030
0.034
0.069
0.019
0.022
0.062
0.092
0.109
0.033
0.041
0.045
0.046
0.063
0.067
0.033
0.037
0.045
0.045
0.048
0.050
0.050
0.050
0.055
0.062
0.062
0.064
0.095
0.105
0.092
0.042
0.047
0.025
0.032
0.049
0.051
0.062
0.029
0.072
0.032
0.047
0.064
0.034
0.054
0.054
0.046
0.067
0.072
0.065
0.046
0.072
0.054
0.042
0.045
0.050
0.072
0.075
0.110

mm

TOTAL
MATL
COILS

1.2
1.4
0.8
0.9
0.8
1.3
1.3
1.4
0.6
0.9
1.6
2.3
0.5
0.6
0.7
1.0
1.4
1.6
1.8
0.7
1.9
0.7
1.7
0.8
0.9
1.8
0.5
0.6
1.6
2.3
2.8
0.8
1.0
1.1
1.2
1.6
1.7
0.8
0.9
1.1
1.1
1.2
1.3
1.3
1.3
1.4
1.6
1.6
1.6
2.4
2.7
2.3
1.1
1.2
0.6
0.8
1.2
1.3
1.6
0.7
1.8
0.8
1.2
1.6
0.9
1.4
1.4
1.2
1.7
1.8
1.7
1.2
1.8
1.4
1.1
1.1
1.3
1.8
1.9
2.8

5.00
4.00
7.00
6.00
5.75
4.50
5.50
4.50
3.33
6.00
5.00
5.50
11.3
5.00
5.00
6.00
6.00
6.25
6.00
6.75
4.33
4.50
7.00
6.00
5.00
6.25
8.00
11.8
8.00
7.50
8.00
6.50
6.00
6.00
5.75
7.50
8.00
11.0
6.00
7.00
6.00
8.00
8.50
6.00
6.50
7.00
8.00
5.00
8.00
8.00
8.00
7.50
7.00
6.50
7.00
11.0
9.00
7.50
10.0
7.50
10.0
7.00
12.8
9.75
6.00
7.50
8.50
7.00
8.50
10.5
9.50
8.50
9.00
8.00
7.00
10.0
9.25
12.0
12.0
10.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
HD
SPR
SST
SST
SPR
SPR
MW
MW
SST
SST
SST
SST
SST
SST
SST
SPR
SPR
MW
SST
SPR
MW
HD
MW
SST
SPR
MW
SST
SPR
SST
HD
SPR
SPR
SST
SST
SST
SPR
SPR
SST
SPR
MW
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SST
SST
SST
SPR
SST
SPR
SST
SST
SST
SPR
SPR
SST
HD
SPR
SPR
SST
SST
HD
SPR
SPR

E
N
D
S

C
C
CG
C
C
CG
CG
CG
C
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
C
C
CG
CG
CG
C
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
C
C
C
CG
C
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG

F
N
S
H

Z
Z
N
N
N
N
Z
Z
Z
N
N
N
N
N
N
N
GI
Z
GI
N
N
N
Z
Z
N
Z
N
N
Z
N
N
N
N
N
N
N
N
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
Z
N
Z
N
N
N
N
N
Z
Z
Z
N
N
N
N
Z
N
Z
N
N
N
N
N
N
Z
Z
Z
N
N
Z
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 121

Inches

mm

CENTURY
STOCK
NUMBER

0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.484
0.485
0.492
0.500
0.500
0.500
0.500

12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.29
12.32
12.50
12.70
12.70
12.70
12.70

B14-47
B9-8
YY-60
A15-66
2620
S-1376
3570
12219
3665
S-1490
A13-40
S-1413
2729
H-42
PP-56
B9-69
F-48
3153
Q-75
O-96
B15-36
S-223
4286
10039
10833
J-40
11244
S-1268
4226
10356
10320
S-843
II-40
11270
2888
3240
10493
10282
XX-66
H-46
2790
10413
10723
N-82
10853
A-29
S-323
10949
V V-29
B9-68
4369
11484
10417
B10-60
10773
2646
10694
S-1565
2784
10244
11633
10713
B17-196
12489
12706
11658
12071
12316
2685
N-42
1693
12206
12308
S-3182
12693
12715
B8-11
G-100
G-19
S-1097

O.D.

FREE LENGTH
Inches

1.41
1.44
1.44
1.47
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.53
1.56
1.56
1.59
1.63
1.63
1.63
1.63
1.63
1.69
1.69
1.69
1.69
1.72
1.75
1.75
1.81
1.81
1.81
1.81
1.84
1.88
1.88
1.91
1.94
2.00
2.00
2.00
2.00
2.06
2.19
2.25
2.25
2.25
2.38
2.44
2.44
2.50
2.50
2.50
2.50
2.81
3.00
3.00
3.00
3.03
3.06
3.38
3.50
4.44
4.63
5.25
5.63
12.0
1.00
.97
.25
.38
.38
.38

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

35.7
36.5
36.5
37.3
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.9
38.9
39.7
39.7
40.5
41.3
41.3
41.3
41.3
41.3
42.8
42.8
42.8
42.8
43.6
44.5
44.5
46.0
46.0
46.0
46.0
46.8
47.6
47.6
48.4
49.2
50.8
50.8
50.8
50.8
52.4
55.6
57.2
57.2
57.2
60.3
61.9
61.9
63.5
63.5
63.5
63.5
71.4
76.2
76.2
76.2
77.0
77.8
85.7
88.9
112.7
117.5
133.4
142.9
304.8
25.4
24.6
6.4
9.5
9.5
9.5

I.D.
Inches

.418
.396
.392
.364
.356
.414
.408
.408
.404
.402
.390
.382
.376
.370
.364
.364
.360
.340
.260
.432
.388
.412
.374
.372
.404
.384
.360
.340
.324
.408
.360
.340
.264
.288
.360
.324
.388
.376
.360
.360
.356
.376
.360
.424
.324
.434
.390
.348
.340
.360
.390
.400
.394
.384
.452
.388
.360
.410
.376
.360
.322
.388
.360
.350
.350
.324
.364
.386
.384
.360
.374
.388
.384
.422
.277
.402
.402
.464
.450
.448

RATE
mm

10.6
10.1
10.0
9.2
9.0
10.5
10.4
10.4
10.3
10.2
9.9
9.7
9.6
9.4
9.2
9.2
9.1
8.6
6.6
11.0
9.9
10.5
9.5
9.4
10.3
9.8
9.1
8.6
8.2
10.4
9.1
8.6
6.7
7.3
9.1
8.2
9.9
9.6
9.1
9.1
9.0
9.6
9.1
10.8
8.2
11.0
9.9
8.8
8.6
9.1
9.9
10.2
10.0
9.8
11.5
9.9
9.1
10.4
9.6
9.1
8.2
9.9
9.1
8.9
8.9
8.2
9.2
9.8
9.8
9.1
9.5
9.9
9.8
10.7
7.0
10.2
10.2
11.8
11.4
11.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

2.9
.50
14
2.5
13
2.2
29
5.1
33
5.7
1.3
.23
4.2
.74
6.8
1.2
6.7
1.2
6.5
1.1
14
2.5
10
1.8
17
3.0
22
3.8
31
5.4
20
3.6
35
6.2
63
11
628 110
.49
.09
6.8
1.2
2.9
.51
16
2.8
17
3.0
8.0
1.4
16
2.8
33
5.8
51
8.9
85
15
6.8
1.2
29
5.1
47
8.2
366
64
210
37
24
4.1
112
20
8.4
1.5
19
3.4
28
4.9
19
3.3
33
5.7
15
2.7
28
4.9
1.2
.21
59
10
.46
.08
5.6
.98
30
5.3
46
8.1
24
4.2
5.7
1.0
5.8
1.0
6.6
1.2
9.5
1.7
.06
.01
9.7
1.7
22
3.8
3.3
.59
9.2
1.6
19
3.4
59
10
6.8
1.2
25
4.4
23
4.0
22
3.9
45
7.8
9.4
1.6
4.6
.80
5.0
.87
10
1.8
6.9
1.2
2.6
.45
3.4
.59
.10
.02
441
77
13
2.3
90
16
.45
.08
5.2
.92
1.8
.31

Inches

mm

1.1
27
.48 12
.61 15
.51 13
.59 15
.84 21
1.0
27
.65 17
.76 19
.80 20
.59 15
.84 21
.68 17
.63 16
.52 13
.66 17
.49 12
.40 10
.13
3.4
1.1
28
.86 22
1.2
31
.77 20
.75 19
.64 16
.55 14
.52 13
.47 12
.41 10
.65 17
.60 15
.51 13
.22
5.5
.28
7.2
.74 19
.31
7.9
1.1
27
.60 15
.62 16
.87 22
.59 15
.75 19
.62 16
1.6
40
.55 14
1.7
43
1.3
33
.75 19
.55 14
.72 18
1.4
36
1.0
26
1.1
28
.92 23
2.1
53
1.3
32
.80 20
1.1
29
1.3
32
.89 23
.61 15
1.3
33
.69 18
1.3
34
1.4
35
.77 20
1.4
35
2.0
52
1.9
47
1.7
44
1.8
45
3.4
86
2.7
70
8.1 206
.15
3.7
.65 17
.10
2.5
.27
6.8
.28
7.0
.22
5.6

ENDS: C - Closed

G - Ground
O - Open

Lbs.

3.0
6.8
7.8
15
19
1.1
4.4
4.4
5.1
5.2
8.3
8.7
12
14
16
13
17
26
83
.53
5.8
3.5
12
13
5.1
8.7
17
24
35
4.4
17
24
79
59
17
35
8.8
12
17
16
19
12
17
1.9
32
.77
7.3
23
26
17
8.0
5.9
7.3
8.7
.12
12
17
3.8
12
17
36
8.8
17
30
30
35
13
9.3
9.3
17
12
8.6
9.3
.82
65
8.6
9.1
.12
1.4
.39

14
30
34
66
85
4.9
20
20
23
23
37
39
52
60
70
60
77
113
369
2.4
26
16
54
57
23
39
77
106
154
20
77
106
351
263
77
154
39
52
77
73
85
52
77
8.6
144
3.4
32
101
113
77
36
26
32
39
.54
54
77
17
52
77
159
39
77
135
135
154
58
42
41
77
54
38
41
3.6
288
38
40
.53
6.4
1.7

Inches

.28
.29
.41
.57
.77
.66
.42
.27
.37
.34
.38
.66
.59
.68
.60
.84
.62
.77
1.01
.44
.67
.36
.69
.70
.29
.40
.65
.83
1.00
.30
.79
.90
1.43
1.27
.93
.80
.62
.59
.74
.93
.83
.65
.74
.33
1.24
.33
.71
1.09
1.01
.85
.79
.50
.56
.61
.27
.60
.93
.37
1.07
1.09
1.46
.74
.88
1.37
1.34
1.76
1.68
1.23
1.25
1.86
1.49
1.87
1.78
3.91
.83
.32
.15
.11
.10
.16

mm

Inches

7.1
7.3
10.5
14.5
19.5
16.7
10.6
6.8
9.4
8.6
9.6
16.8
15.1
17.4
15.2
21.3
15.7
19.7
25.6
11.2
17.1
9.1
17.5
17.8
7.4
10.2
16.5
21.0
25.4
7.7
20.1
22.9
36.3
32.4
23.6
20.3
15.8
15.1
18.9
23.6
21.1
16.5
18.9
8.4
31.5
8.3
17.9
27.6
25.6
21.7
20.0
12.8
14.3
15.6
6.9
15.2
23.6
9.4
27.1
27.6
37.0
18.9
22.4
34.9
34.0
44.7
42.7
31.1
31.8
47.2
37.7
47.5
45.1
99.2
21.1
8.0
3.7
2.7
2.5
4.0

0.033
0.044
0.046
0.060
0.064
0.035
0.038
0.038
0.040
0.041
0.047
0.051
0.054
0.057
0.060
0.060
0.062
0.072
0.112
0.026
0.048
0.036
0.055
0.056
0.040
0.050
0.062
0.072
0.080
0.038
0.062
0.072
0.110
0.098
0.062
0.080
0.048
0.054
0.062
0.062
0.064
0.054
0.062
0.030
0.080
0.025
0.047
0.068
0.072
0.062
0.047
0.042
0.045
0.050
0.016
0.048
0.062
0.037
0.054
0.062
0.081
0.048
0.062
0.067
0.067
0.080
0.060
0.049
0.050
0.062
0.055
0.048
0.050
0.031
0.104
0.045
0.049
0.018
0.025
0.026

mm

0.8
1.1
1.2
1.5
1.6
0.9
1.0
1.0
1.0
1.0
1.2
1.3
1.4
1.4
1.5
1.5
1.6
1.8
2.8
0.7
1.2
0.9
1.4
1.4
1.0
1.3
1.6
1.8
2.0
1.0
1.6
1.8
2.8
2.5
1.6
2.0
1.2
1.4
1.6
1.6
1.6
1.4
1.6
0.8
2.0
0.6
1.2
1.7
1.8
1.6
1.2
1.1
1.1
1.3
0.4
1.2
1.6
0.9
1.4
1.6
2.1
1.2
1.6
1.7
1.7
2.0
1.5
1.2
1.3
1.6
1.4
1.2
1.3
0.8
2.6
1.1
1.2
0.5
0.6
0.7

TOTAL
MATL
COILS
8.50
6.50
8.00
9.50
12.0
17.8
10.0
7.00
8.25
8.25
8.00
12.0
11.0
11.0
10.0
14.0
10.0
10.8
9.00
16.0
14.0
10.0
12.5
12.5
7.25
8.00
10.5
11.5
12.5
7.00
11.8
12.5
13.0
13.0
14.0
10.0
13.0
10.0
12.0
15.0
12.0
12.0
12.0
11.0
15.5
13.0
15.0
16.0
14.0
13.8
16.8
11.0
12.5
12.3
16.0
11.5
15.0
10.0
18.8
16.5
18.0
15.5
13.3
19.5
20.0
22.0
28.0
24.0
24.0
30.0
26.0
38.0
34.5
125.0
8.00
7.00
3.00
5.00
3.00
5.00

SPR
SPR
SPR
SST
HD
SST
SPR
SPR
SPR
SST
SPR
SST
HD
SPR
SPR
SPR
SPR
SPR
SPR
MW
SST
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SST
SST
SPR
HD
SPR
SPR
SPR
SPR
SST
SST
MW
SPR
SST
SPR
SPR
SPR
SPR
SPR
MW
MW
SPR
SPR
SPR
HD
SPR
SPR
SPR
SPR
SST
SST
MW
SPR
MW
MW
SST

E
N
D
S

F
N
S
H

CG
CG
C
CG
CG
C
C
CG
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
C
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
C
C
CG
CG
C
C
CG
CG
CG
C
C
CG
C
C
C
C
CG
CG
CG
C
C
C

N
Z
Z
N
Z
N
Z
Z
Z
N
GI
N
Z
Z
GI
N
Z
Z
Z
N
N
N
Z
N
Z
N
Z
N
GI
Z
Z
N
N
Z
Z
Z
GI
Z
Z
N
Z
Z
Z
N
N
N
N
Z
Z
Z
Z
Z
Z
N
N
Z
GI
N
GI
BO
Z
Z
Z
N
N
Z
Z
Z
Z
Z
Z
Z
Z
N
N
Z
GI
N
Z
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

121

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 122

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500

12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70

L-4
LL-83
BB-92
10884
H-54
S-351
3751
4179
S-108
2931
S-905
4118
Y-41
S-118
NN-4
B1-33
3215
G-11
O-52
L-52
F-78
EE-22
LL-26
V V-37
S-1304
JJ-37
XX-62
S-1398
3611
12673
O-79
A14-55
Q-12
A14-46
PP-94
A11-35
AA-74
OO-8
3831
S-1302
3905
A15-4
B14-37
10976
10102
2606
CC-8
B-22
S-99
11444
S-1457
3825
LL-4
B5-9
EE-78
1881
1932
G-85
B14-6
3967
PP-89
B3-68
S-754
3545
GG-27
S-1211
10133
3572
10141
10283
B1-34
B18-161
B10-40
B14-41
12583
K-62
S-341
10466
3599
12728

.38
.38
.41
.44
.44
.44
.44
.50
.50
.50
.50
.50
.50
.50
.50
.50
.53
.53
.53
.55
.56
.56
.56
.56
.56
.56
.56
.56
.59
.59
.59
.61
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.66
.69
.69
.69
.69
.69
.72
.72
.72
.72
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.78
.78
.78
.81

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

9.5
9.5
10.3
11.1
11.1
11.1
11.1
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.9
14.3
14.3
14.3
14.3
14.3
14.3
14.3
14.3
15.1
15.1
15.1
15.5
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
17.4
17.4
17.4
17.4
17.4
18.2
18.2
18.2
18.2
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
20.6

MATERIAL: MW - Music Wire

122

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.402
.356
.432
.468
.448
.422
.386
.462
.460
.456
.444
.432
.430
.406
.400
.388
.460
.398
.310
.300
.456
.420
.420
.416
.392
.380
.316
.310
.430
.426
.412
.420
.436
.424
.424
.422
.420
.420
.416
.412
.410
.404
.394
.392
.376
.370
.356
.394
.410
.410
.408
.372
.320
.424
.416
.376
.376
.296
.278
.438
.432
.426
.416
.410
.410
.410
.406
.398
.392
.392
.392
.388
.370
.344
.340
.316
.448
.418
.352
.444

RATE
mm

10.2
9.0
11.0
11.9
11.4
10.7
9.8
11.7
11.7
11.6
11.3
11.0
10.9
10.3
10.2
9.9
11.7
10.1
7.9
7.6
11.6
10.7
10.7
10.6
10.0
9.7
8.0
7.9
10.9
10.8
10.5
10.7
11.1
10.8
10.8
10.7
10.7
10.7
10.6
10.5
10.4
10.3
10.0
10.0
9.6
9.4
9.0
10.0
10.4
10.4
10.4
9.4
8.1
10.8
10.6
9.6
9.6
7.5
7.1
11.1
11.0
10.8
10.6
10.4
10.4
10.4
10.3
10.1
10.0
10.0
10.0
9.9
9.4
8.7
8.6
8.0
11.4
10.6
8.9
11.3

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

90
16
493
86
8.3
1.4
.17
.03
6.2
1.1
7.5
1.3
87
15
.56
.10
.60
.11
1.0
.18
3.4
.60
19
3.3
11
1.9
33
5.7
39
6.9
72
13
.69
.12
36
6.3
766 134
1123 197
1.0
.18
8.2
1.4
17
2.9
23
4.1
48
8.4
55
9.6
607 106
681 119
11
1.9
14
2.4
19
3.3
19
3.3
4.3
.75
13
2.4
12
2.1
15
2.6
13
2.2
15
2.6
16
2.7
20
3.5
31
5.5
20
3.4
45
7.9
55
9.7
126
22
125
22
143
25
56
9.9
14
2.4
12
2.2
24
4.2
129
23
342
60
12
2.1
21
3.6
101
18
84
15
897 157
1236 216
4.0
.69
6.0
1.1
9.0
1.6
15
2.6
31
5.5
23
4.0
18
3.2
25
4.4
23
4.0
46
8.0
34
6.0
35
6.1
54
9.4
83
15
140
24
199
35
433
76
1.5
.26
14
2.5
139
24
1.9
.33

.10
.05
.27
.31
.33
.20
.15
.39
.38
.37
.36
.17
.31
.23
.23
.16
.43
.23
.06
.05
.43
.32
.30
.25
.22
.20
.08
.07
.42
.40
.35
.26
.43
.30
.35
.29
.39
.33
.37
.31
.23
.35
.22
.20
.13
.16
.16
.19
.42
.39
.29
.14
.13
.35
.28
.23
.20
.07
.06
.56
.50
.53
.37
.31
.31
.36
.32
.41
.25
.33
.30
.23
.23
.21
.17
.11
.63
.38
.27
.60

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

2.5
1.3
6.9
7.9
8.3
5.2
3.8
9.8
9.7
9.3
9.1
4.3
7.9
5.8
5.8
4.2
11
5.7
1.6
1.4
11
8.2
7.5
6.3
5.6
5.1
2.0
1.8
11
10
8.8
6.7
11
7.5
8.9
7.3
9.8
8.4
9.4
7.9
5.7
8.9
5.7
5.2
3.4
3.9
4.1
4.8
11
10
7.5
3.6
3.4
8.9
7.1
5.9
5.1
1.8
1.6
14
13
13
9.3
7.9
7.9
9.2
8.1
10
6.2
8.3
7.7
5.9
5.9
5.3
4.3
2.8
16
9.7
6.8
15

Lbs.

9.1
25
2.2
.05
2.0
1.5
13
.22
.23
.38
1.2
3.2
3.3
7.5
9.0
12
.30
8.1
49
61
.44
2.6
5.0
5.7
11
11
48
49
4.5
5.5
6.6
5.0
1.8
4.0
4.3
4.3
4.9
5.0
5.7
6.2
7.0
6.8
10
11
17
19
23
11
5.8
4.9
7.0
19
45
4.3
5.7
23
17
64
79
2.2
3.0
4.8
5.4
9.8
7.0
6.6
8.0
9.2
11
11
11
13
19
29
34
48
.92
5.4
37
1.1

ENDS: C - Closed

G - Ground
O - Open

40
110
9.9
.23
9.0
6.8
59
.96
1.0
1.7
5.5
14
15
33
40
52
1.3
36
218
271
2.0
12
22
26
47
49
214
218
20
24
29
22
8.2
18
19
19
22
22
26
27
31
30
45
50
75
86
103
47
26
22
31
82
201
19
26
104
75
287
351
9.8
13
21
24
43
31
29
36
41
50
50
47
56
86
130
149
214
4.1
24
167
5.0

Inches

.20
.29
.14
.13
.08
.23
.23
.11
.12
.13
.14
.14
.14
.19
.23
.22
.10
.31
.38
.40
.13
.24
.17
.21
.24
.36
.41
.40
.18
.19
.22
.16
.19
.15
.17
.16
.24
.18
.25
.20
.18
.28
.24
.30
.25
.29
.36
.28
.27
.29
.21
.27
.54
.17
.18
.28
.37
.48
.56
.19
.20
.22
.24
.18
.21
.27
.24
.34
.27
.38
.30
.28
.37
.51
.48
.51
.15
.21
.44
.21

mm

5.0
7.3
3.5
3.3
2.0
5.9
5.8
2.9
3.0
3.4
3.6
3.5
3.6
4.8
5.7
5.7
2.5
7.8
9.7
10.2
3.4
6.1
4.3
5.3
6.2
9.1
10.5
10.3
4.4
4.7
5.6
4.1
4.9
3.9
4.3
4.0
6.1
4.6
6.4
5.0
4.6
7.0
6.1
7.5
6.3
7.4
9.1
7.1
6.9
7.4
5.3
6.9
13.7
4.3
4.5
7.1
9.4
12.3
14.1
4.9
5.0
5.6
6.1
4.6
5.4
6.9
6.0
8.7
6.9
9.6
7.5
7.1
9.5
12.9
12.2
12.9
3.8
5.2
11.3
5.3

WIRE DIA.
Inches

mm

0.049
0.072
0.034
0.016
0.026
0.039
0.057
0.019
0.020
0.022
0.028
0.034
0.035
0.047
0.050
0.056
0.020
0.051
0.095
0.100
0.022
0.040
0.040
0.042
0.054
0.060
0.092
0.095
0.035
0.037
0.044
0.040
0.032
0.038
0.038
0.039
0.040
0.040
0.042
0.044
0.045
0.048
0.053
0.054
0.062
0.065
0.072
0.053
0.045
0.045
0.046
0.064
0.090
0.038
0.042
0.062
0.062
0.102
0.111
0.031
0.034
0.037
0.042
0.045
0.045
0.045
0.047
0.051
0.054
0.054
0.054
0.056
0.065
0.078
0.080
0.092
0.026
0.041
0.074
0.028

1.2
1.8
0.9
0.4
0.7
1.0
1.4
0.5
0.5
0.6
0.7
0.9
0.9
1.2
1.3
1.4
0.5
1.3
2.4
2.5
0.6
1.0
1.0
1.1
1.4
1.5
2.3
2.4
0.9
0.9
1.1
1.0
0.8
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.2
1.3
1.4
1.6
1.7
1.8
1.3
1.1
1.1
1.2
1.6
2.3
1.0
1.1
1.6
1.6
2.6
2.8
0.8
0.9
0.9
1.1
1.1
1.1
1.1
1.2
1.3
1.4
1.4
1.4
1.4
1.7
2.0
2.0
2.3
0.7
1.0
1.9
0.7

FINISH: Z - Zinc

TOTAL
MATL
COILS
3.00
3.00
4.00
7.00
3.00
6.00
4.00
5.00
5.00
5.00
4.00
3.00
4.00
4.00
4.50
4.00
5.00
5.00
4.00
4.00
5.00
6.00
4.25
4.00
4.50
6.00
4.50
4.25
4.00
4.00
5.00
4.00
5.00
4.00
4.50
4.00
5.00
4.50
5.00
4.50
4.00
5.75
4.50
4.50
4.00
4.50
5.00
4.25
6.00
6.50
4.50
4.25
6.00
4.50
4.25
4.50
5.00
4.75
5.00
5.25
4.75
5.00
4.75
4.00
4.75
5.00
5.00
6.75
5.00
6.00
5.50
5.00
5.75
6.50
6.00
5.50
5.75
5.00
6.00
6.50

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SST
MW
MW
SST
SPR
MW
SST
MW
SST
SPR
SPR
SST
SPR
SST
MW
SPR
SST
SPR
MW
SST
SPR
SPR
SST
SPR
SPR
SST
MW
MW
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
SST
SST
HD
HD
SPR
SST
HD
SST
SST
SST
SPR
SPR
SPR
SPR
MW
SPR
SPR
SPR
MW
SST
MW
SST
MW
SPR
SST
SPR
HD
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
MW
MW

E
N
D
S

F
N
S
H

C
C
CG
C
CG
CG
CG
C
C
C
C
C
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
C
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C

Z
Z
N
Z
Z
N
Z
BO
N
Z
N
Z
Z
N
N
N
Z
N
N
Z
Z
N
GI
GI
N
N
Z
N
Z
Z
Z
GI
N
N
GI
N
N
N
Z
N
Z
N
N
Z
Z
Z
N
N
N
N
N
N
GI
N
N
Z
Z
N
N
Z
N
Z
N
Z
N
N
Z
Z
Z
Z
N
GI
Z
N
N
Z
N
GI
GI
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 123

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500

12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70

S-167
H-51
A11-33
YY-34
S-1572
JJ-88
B14-29
12325
K-47
10323
A15-40
J-62
10836
B14-52
S-1411
N-135
S-757
A11-40
3810
S-761
MM-40
L-48
Z-63
GG-39
2819
A10-49
A9-31
S-390
S-1482
A15-30
A14-40
A14-61
S-1510
10669
L-31
A14-37
O-38
NN-83
3953
GG-95
YY-35
MM-89
WW-35
10056
10326
Z-45
S-755
A11-44
10020
A13-7
3635
S-1479
10069
Q-10
10041
2976
10146
S-758
510
S-762
3821
3897
2994
3834
S-498
10093
12170
1725
3809
NN-97
M-101
A14-8
2961
S-1392
S-3154
S-90
12472
S-803
11395
B7-66

.81
.81
.81
.81
.81
.81
.81
.81
.81
.81
.84
.84
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.89
.91
.91
.91
.92
.94
.94
.94
.94
.94
.97
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.06
1.09
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.2
22.6
23.0
23.0
23.0
23.4
23.8
23.8
23.8
23.8
23.8
24.6
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
27.0
27.8
27.8
27.8
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6

I.D.
Inches

.442
.432
.424
.412
.412
.408
.394
.392
.340
.316
.432
.372
.464
.414
.410
.400
.390
.386
.380
.374
.372
.340
.300
.280
.230
.372
.460
.428
.398
.420
.416
.406
.392
.318
.300
.412
.380
.340
.444
.432
.426
.424
.424
.422
.422
.418
.416
.416
.414
.408
.406
.406
.404
.400
.398
.392
.390
.390
.376
.374
.366
.356
.350
.336
.420
.250
.436
.398
.380
.422
.410
.408
.440
.422
.412
.410
.400
.378
.376
.340

RATE
mm

11.2
11.0
10.8
10.5
10.5
10.4
10.0
10.0
8.6
8.0
11.0
9.4
11.8
10.5
10.4
10.2
9.9
9.8
9.7
9.5
9.4
8.6
7.6
7.1
5.8
9.4
11.7
10.9
10.1
10.7
10.6
10.3
10.0
8.1
7.6
10.5
9.7
8.6
11.3
11.0
10.8
10.8
10.8
10.7
10.7
10.6
10.6
10.6
10.5
10.4
10.3
10.3
10.3
10.2
10.1
10.0
9.9
9.9
9.6
9.5
9.3
9.0
8.9
8.5
10.7
6.4
11.1
10.1
9.7
10.7
10.4
10.4
11.2
10.7
10.5
10.4
10.2
9.6
9.6
8.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

2.0
.35
5.5
.96
9.0
1.6
16
2.9
17
2.9
8.9
1.6
42
7.4
34
6.0
138
24
337
59
3.7
.66
86
15
.16
.03
13
2.3
9.1
1.6
25
4.3
32
5.7
44
7.6
44
7.7
56
9.7
73
13
159
28
488
86
887 155
2455 430
36
6.4
.26
.05
5.4
.94
19
3.3
10
1.8
12
2.1
21
3.6
20
3.5
360
63
372
65
15
2.7
24
4.2
144
25
1.4
.25
4.7
.83
6.7
1.2
8.7
1.5
7.6
1.3
9.7
1.7
9.7
1.7
6.5
1.1
10
1.8
13
2.3
15
2.6
17
3.0
13
2.2
15
2.6
18
3.2
22
3.8
13
2.4
23
4.0
31
5.5
27
4.8
45
7.8
47
8.3
55
9.6
82
14
118
21
148
26
8.2
1.4
1331 233
2.9
.52
13
2.4
27
4.8
8.5
1.5
4.9
.87
14
2.4
.94
.17
6.9
1.2
16
2.9
19
3.2
16
2.9
30
5.3
33
5.7
159
28

.60
.54
.45
.37
.37
.41
.25
.33
.23
.14
.62
.21
.69
.44
.47
.36
.34
.30
.35
.30
.25
.21
.12
.09
.05
.25
.71
.64
.48
.45
.46
.39
.45
.13
.15
.44
.37
.23
.78
.63
.55
.68
.56
.48
.66
.61
.53
.43
.42
.44
.62
.51
.46
.41
.44
.49
.38
.41
.38
.35
.39
.30
.24
.24
.57
.08
.84
.55
.46
.54
.51
.52
.68
.62
.37
.36
.55
.50
.52
.21

mm

15
14
11
9.5
9.3
10
6.4
8.3
5.8
3.6
16
5.5
17
11
12
9.2
8.7
7.7
8.9
7.6
6.5
5.4
2.9
2.2
1.3
6.4
18
16
12
11
12
9.9
11
3.3
3.9
11
9.3
5.9
20
16
14
17
14
12
17
16
14
11
11
11
16
13
12
10
11
12
9.6
10
9.6
9.0
9.8
7.7
6.0
6.2
14
2.1
21
14
12
14
13
13
17
16
9.5
9.1
14
13
13
5.4

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.2
3.0
4.0
6.2
6.2
3.6
11
11
31
48
2.3
19
.11
5.8
4.3
9.0
11
13
15
17
19
34
57
77
130
9.1
.19
3.4
9.0
4.7
5.4
8.0
9.0
47
57
6.6
8.7
34
1.1
3.0
3.7
5.9
4.3
4.6
6.4
3.9
5.4
5.7
6.2
7.5
7.8
7.5
8.5
9.0
5.9
11
12
11
17
17
21
25
28
36
4.7
109
2.5
7.4
13
4.6
2.5
7.0
.64
4.3
6.2
6.6
9.0
15
17
34

5.3
13
18
27
27
16
47
50
140
214
10
82
.49
26
19
40
50
59
68
74
82
149
252
343
579
40
.83
15
40
21
24
36
40
208
252
29
39
149
4.8
13
16
26
19
21
28
18
24
26
27
33
35
33
38
40
26
50
53
50
75
74
94
110
124
160
21
486
11
33
56
21
11
31
2.9
19
27
29
40
67
75
149

Inches

.21
.20
.19
.26
.22
.40
.27
.32
.56
.60
.22
.41
.19
.28
.41
.30
.39
.34
.42
.46
.38
.64
.60
.66
.81
.64
.20
.22
.36
.21
.23
.27
.49
.64
.73
.25
.60
.60
.22
.22
.20
.25
.27
.25
.25
.39
.29
.23
.24
.28
.38
.35
.36
.38
.56
.43
.37
.43
.54
.50
.57
.58
.53
.66
.28
.88
.22
.51
.60
.23
.59
.30
.45
.24
.26
.27
.45
.53
.60
.64

mm

Inches

5.3
5.2
4.8
6.7
5.6
10.2
6.7
8.2
14.2
15.2
5.6
10.4
4.8
7.1
10.3
7.6
9.8
8.7
10.7
11.6
9.8
16.3
15.2
16.8
20.6
16.3
5.1
5.5
9.1
5.3
5.9
6.8
12.3
16.2
18.4
6.4
15.2
15.2
5.7
5.6
5.2
6.3
6.8
6.5
6.5
9.9
7.5
5.9
6.0
7.0
9.6
9.0
9.1
9.5
14.2
11.0
9.4
10.8
13.6
12.8
14.5
14.6
13.3
16.7
7.1
22.2
5.7
13.0
15.2
5.9
14.9
7.6
11.3
6.2
6.7
6.9
11.4
13.6
15.4
16.3

0.029
0.034
0.038
0.044
0.044
0.046
0.053
0.054
0.080
0.092
0.034
0.064
0.018
0.043
0.045
0.050
0.055
0.057
0.060
0.063
0.064
0.080
0.100
0.110
0.135
0.064
0.020
0.036
0.051
0.040
0.042
0.047
0.054
0.091
0.100
0.044
0.060
0.080
0.028
0.034
0.037
0.038
0.038
0.039
0.039
0.041
0.042
0.042
0.043
0.046
0.047
0.047
0.048
0.050
0.051
0.054
0.055
0.055
0.062
0.063
0.067
0.072
0.075
0.082
0.040
0.125
0.032
0.051
0.060
0.039
0.045
0.046
0.030
0.039
0.044
0.045
0.050
0.061
0.062
0.080

mm

TOTAL
MATL
COILS

0.7
0.9
1.0
1.1
1.1
1.2
1.3
1.4
2.0
2.3
0.9
1.6
0.5
1.1
1.1
1.3
1.4
1.4
1.5
1.6
1.6
2.0
2.5
2.8
3.4
1.6
0.5
0.9
1.3
1.0
1.1
1.2
1.4
2.3
2.5
1.1
1.5
2.0
0.7
0.9
0.9
1.0
1.0
1.0
1.0
1.0
1.1
1.1
1.1
1.2
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.4
1.6
1.6
1.7
1.8
1.9
2.1
1.0
3.2
0.8
1.3
1.5
1.0
1.1
1.2
0.8
1.0
1.1
1.1
1.3
1.5
1.6
2.0

6.25
5.00
5.00
5.00
5.00
8.75
5.00
6.00
7.00
6.50
6.50
5.25
9.50
5.50
8.00
6.00
6.00
6.00
7.00
6.25
6.00
7.00
6.00
6.00
6.00
10.0
9.00
6.00
7.00
5.25
5.50
5.75
8.00
6.00
7.25
5.75
10.0
7.50
8.00
5.50
5.50
5.50
6.00
5.50
5.50
8.50
6.00
5.50
5.50
6.00
8.00
6.50
6.50
6.50
10.0
8.00
6.75
6.75
7.75
7.00
8.50
8.00
7.00
8.00
6.00
7.00
7.00
10.0
10.0
6.00
13.0
6.50
14.0
6.25
5.00
5.00
8.00
8.75
9.75
7.00

SST
SST
SST
SST
SST
SST
SPR
SPR
SST
SPR
SST
SPR
SST
SST
SST
SPR
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SST
SST
SST
SPR
SST
SPR
SST
SPR
SST
SPR
MW
SST
SST
MW
SPR
SPR
MW
SPR
SST
SPR
SPR
SPR
HD
SST
SPR
SPR
SPR
SPR
SPR
SST
HD
SST
SPR
HD
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
MW
SST
SST
SST
SPR
SST
HD
SPR

E
N
D
S

C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
C
C
C
CG
CG
CG
CG
C
C
C
C
CG
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
CG
C

F
N
S
H

N
N
N
N
N
N
Z
Z
N
Z
N
Z
N
N
N
Z
N
GI
GI
N
N
Z
N
Z
Z
Z
N
N
N
N
N
Z
N
Z
N
N
N
Z
Z
N
N
N
Z
GI
GI
Z
N
GI
Z
N
Z
N
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
GI
N
Z
N
Z
Z
Z
N
N
Z
N
N
N
Z
N
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

123

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:26 AM Page 124

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500

12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70

3748
S-112
12650
S-328
S-499
12632
3491
W-100
10774
S-1
S-922
FF-97
II-91
LL-28
A14-59
3619
3755
S-756
3787
RR-70
S-759
3512
S-763
12197
EE-79
Y-36
3863
FF-82
L-62
H-87
1605
10181
11347
I-34
S-1399
A15-32
YY-29
XX-70
4161
3242
503
A15-50
K-49
S-1292
10135
S-1293
11745
3878
521
B6-1
S-1290
S-1296
S-806
10081
S-122
S-247
11421
S-243
10059
S-760
2536
3944
S-764
K-56
3080
J-30
4229
S-384
12252
3040
4201
S-193
BB-58
S-3100
F-53
HH-56
4124
12189
S-1365
3364

1.13
1.13
1.14
1.16
1.16
1.17
1.19
1.19
1.19
1.19
1.19
1.19
1.22
1.22
1.23
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.31
1.31
1.31
1.31
1.31
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.56
1.56
1.56
1.56
1.59
1.63
1.63
1.63
1.63
1.63
1.63
1.63
1.63

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

28.6
28.6
29.0
29.4
29.4
29.7
30.2
30.2
30.2
30.2
30.2
30.2
31.0
31.0
31.3
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
33.3
33.3
33.3
33.3
33.3
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
39.7
39.7
39.7
39.7
40.5
41.3
41.3
41.3
41.3
41.3
41.3
41.3
41.3

MATERIAL: MW - Music Wire

124

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.290
.230
.410
.438
.422
.406
.446
.430
.412
.406
.374
.260
.440
.360
.420
.442
.440
.416
.410
.402
.390
.374
.374
.352
.340
.440
.422
.400
.372
.340
.454
.446
.444
.436
.426
.416
.402
.400
.398
.396
.356
.406
.450
.406
.424
.424
.424
.420
.418
.418
.418
.418
.418
.418
.406
.396
.396
.392
.390
.390
.374
.374
.374
.356
.332
.332
.212
.452
.390
.380
.318
.434
.440
.436
.426
.416
.392
.386
.384
.366

RATE
mm

7.4
5.8
10.4
11.1
10.7
10.3
11.3
10.9
10.5
10.3
9.5
6.6
11.2
9.1
10.7
11.2
11.2
10.6
10.4
10.2
9.9
9.5
9.5
8.9
8.6
11.2
10.7
10.2
9.4
8.6
11.5
11.3
11.3
11.1
10.8
10.6
10.2
10.2
10.1
10.1
9.0
10.3
11.4
10.3
10.8
10.8
10.8
10.7
10.6
10.6
10.6
10.6
10.6
10.6
10.3
10.1
10.1
10.0
9.9
9.9
9.5
9.5
9.5
9.0
8.4
8.4
5.4
11.5
9.9
9.7
8.1
11.0
11.2
11.1
10.8
10.6
10.0
9.8
9.8
9.3

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

420
74
1708 299
10
1.8
1.6
.28
7.4
1.3
13
2.2
1.4
.25
4.1
.73
11
2.0
9.6
1.7
30
5.3
836 146
1.4
.25
47
8.2
8.7
1.5
.97
.17
3.2
.56
8.1
1.4
13
2.2
9.8
1.7
21
3.6
39
6.8
35
6.1
93
16
93
16
1.4
.25
5.7
.99
9.9
1.7
29
5.1
77
13
.44
.08
.90
.16
1.2
.22
.95
.17
4.7
.83
7.5
1.3
9.0
1.6
12
2.2
13
2.4
12
2.0
58
10
14
2.4
.87
.15
12
2.1
5.5
.97
5.0
.88
6.1
1.1
7.6
1.3
5.3
.92
6.8
1.2
6.4
1.1
4.1
.71
4.1
.72
7.3
1.3
8.2
1.4
14
2.4
11
1.9
17
3.0
20
3.5
17
2.9
34
5.9
29
5.1
29
5.0
55
9.6
114
20
153
27
1957 343
.39
.07
19
3.3
25
4.3
175
31
3.0
.52
1.9
.33
2.3
.41
1.8
.32
6.2
1.1
20
3.4
17
3.0
13
2.2
40
6.9

.17
.07
.68
.84
.59
.79
.97
.76
.58
.77
.50
.12
.92
.46
.57
.87
.96
.66
.56
.76
.54
.62
.48
.29
.36
1.0
.82
.66
.54
.41
1.1
1.1
1.1
.85
.78
.72
.74
.73
.71
.75
.43
.58
1.2
.63
.77
.79
.70
.66
1.0
.74
.79
1.0
1.0
.73
.91
.70
.85
.62
.60
.67
.52
.60
.58
.45
.34
.25
.08
1.3
.64
.62
.27
.92
1.4
1.1
1.0
.93
.57
.78
.70
.53

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

4.2
1.7
17
21
15
20
25
19
15
19
13
3.0
23
12
14
22
24
17
14
19
14
16
12
7.3
9.1
26
21
17
14
10
28
27
29
22
20
18
19
18
18
19
11
15
31
16
20
20
18
17
26
19
20
27
27
19
23
18
22
16
15
17
13
15
15
11
8.6
6.4
2.0
32
16
16
6.8
23
35
27
25
24
15
20
18
14

Lbs.

70
117
7.0
1.3
4.3
10
1.4
3.1
6.6
7.3
15
98
1.3
21
5.0
.85
3.1
5.4
7.0
7.5
11
24
17
27
34
1.4
4.6
6.5
16
31
.48
.97
1.4
.80
3.7
5.4
6.7
9.0
9.5
8.8
25
8.0
1.1
7.5
4.3
4.0
4.3
5.0
5.4
5.0
5.0
4.3
4.3
5.4
7.5
9.5
9.5
11
12
11
18
18
17
25
39
39
154
.49
12
15
47
2.7
2.6
2.5
1.8
5.7
11
13
8.8
21

ENDS: C - Closed

G - Ground
O - Open

311
521
31
5.9
19
44
6.2
14
29
33
66
435
5.7
95
22
3.8
14
24
31
33
50
107
74
119
149
6.3
21
29
70
140
2.2
4.3
6.2
3.6
16
24
30
40
42
39
110
36
4.7
33
19
18
19
22
24
22
22
19
19
24
33
42
42
47
53
50
79
79
74
110
172
172
683
2.2
53
68
208
12
12
11
8.0
26
50
59
39
94

Inches

.92
.95
.36
.32
.23
.38
.22
.26
.31
.42
.69
1.02
.30
.72
.25
.38
.20
.34
.36
.49
.51
.63
.61
.67
.84
.30
.35
.65
.77
.88
.27
.30
.25
.53
.26
.36
.64
.50
.51
.62
.83
.35
.23
.40
.32
.28
.27
.32
.45
.35
.32
.45
.45
.32
.47
.49
.65
.49
.52
.59
.63
.71
.71
.79
.90
.71
1.30
.31
.55
.65
.93
.26
.24
.27
.63
.44
.54
.70
.93
.80

mm

23.3
24.0
9.1
8.1
5.9
9.6
5.5
6.7
7.8
10.7
17.6
25.9
7.6
18.2
6.4
9.6
5.0
8.5
9.1
12.4
12.9
16.0
15.6
16.9
21.3
7.6
8.9
16.5
19.5
22.4
6.7
7.5
6.4
13.4
6.6
9.1
16.2
12.7
13.0
15.8
21.0
9.0
5.7
10.1
8.2
7.0
6.8
8.1
11.5
8.9
8.1
11.5
11.5
8.1
11.9
12.5
16.5
12.3
13.3
15.0
16.0
18.0
18.0
20.1
22.9
18.1
32.9
7.8
14.0
16.6
23.7
6.7
6.1
6.9
16.0
11.2
13.7
17.9
23.6
20.4

WIRE DIA.
Inches

0.105
0.135
0.045
0.031
0.039
0.047
0.027
0.035
0.044
0.047
0.063
0.120
0.030
0.070
0.040
0.029
0.030
0.042
0.045
0.049
0.055
0.063
0.063
0.074
0.080
0.030
0.039
0.050
0.064
0.080
0.023
0.027
0.028
0.032
0.037
0.042
0.049
0.050
0.051
0.052
0.072
0.047
0.025
0.047
0.038
0.038
0.038
0.040
0.041
0.041
0.041
0.041
0.041
0.041
0.047
0.052
0.052
0.054
0.055
0.055
0.063
0.063
0.063
0.072
0.084
0.084
0.144
0.024
0.055
0.060
0.091
0.033
0.030
0.032
0.037
0.042
0.054
0.057
0.058
0.067

mm

TOTAL
MATL
COILS

2.7
3.4
1.1
0.8
1.0
1.2
0.7
0.9
1.1
1.2
1.6
3.0
0.8
1.8
1.0
0.7
0.8
1.1
1.1
1.2
1.4
1.6
1.6
1.9
2.0
0.8
1.0
1.3
1.6
2.0
0.6
0.7
0.7
0.8
0.9
1.1
1.2
1.3
1.3
1.3
1.8
1.2
0.6
1.2
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.0
1.2
1.3
1.3
1.4
1.4
1.4
1.6
1.6
1.6
1.8
2.1
2.1
3.7
0.6
1.4
1.5
2.3
0.8
0.8
0.8
0.9
1.1
1.4
1.4
1.5
1.7

8.75
7.00
8.00
9.25
6.00
8.00
7.00
6.50
7.00
9.00
10.0
8.50
10.0
10.3
6.25
12.0
5.50
7.00
7.00
10.0
8.25
9.00
8.75
8.00
10.5
10.0
8.00
12.0
12.0
11.0
10.5
10.0
8.00
15.5
7.00
7.50
12.0
10.0
10.0
12.0
10.5
7.50
8.00
7.50
7.50
7.25
7.00
7.00
10.0
7.50
7.75
11.0
11.0
7.75
10.0
9.50
12.5
9.00
9.50
9.75
10.0
11.3
10.3
11.0
10.8
8.50
9.00
12.0
10.0
11.0
10.3
7.00
8.00
7.50
17.0
9.50
9.00
12.3
15.0
11.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SPR
SST
SST
MW
MW
SST
SPR
SST
SST
SPR
MW
SST
SPR
MW
MW
SST
SPR
SST
SST
MW
SST
SPR
SPR
MW
SPR
SPR
SPR
SST
MW
MW
SST
SST
SST
SST
SPR
SPR
SPR
SPR
HD
SPR
MW
SST
SPR
SST
SPR
SPR
HD
SST
SST
SST
SST
SPR
SST
SST
HD
SST
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
MW
SST
SPR
SPR
SPR
SPR
SST
SPR

E
N
D
S

F
N
S
H

CG
CG
CG
C
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
C
C
C
C
CG
C
C
C
C
CG
CG
C
C
CG
CG
C
C
C
C
C
C
C
CG
CG
CG
C
CG
C
C
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
C
C
CG
C
C

Z
N
N
N
N
N
Z
N
Z
N
N
Z
N
N
Z
Z
Z
N
Z
N
N
Z
N
Z
Z
Z
Z
Z
Z
N
Z
N
N
N
N
N
Z
Z
Z
Z
Z
GI
N
N
Z
N
Z
Z
Z
N
N
N
N
GI
N
N
Z
N
GI
N
Z
Z
N
Z
Z
Z
N
N
Z
Z
BO
N
Z
N
Z
Z
Z
Z
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 125

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500

12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70

11159
B14-55
A10-58
QQ-58
511
JJ-89
359
11582
10311
K-99
B14-69
QQ-53
3580
A12-40
3608
10384
11772
10603
12317
12724
4232
K-53
FF-55
B10-63
3994
O-95
15
2721
AA-87
12233
3004
S-765
4215
504
2652
3160
12684
S-39
3558
Q-61-A
10033
YY-62
4322
12020
3776
J-34
3159
10042
4266
12599
EE-59
24
3035
S-1133
11928
12287
12302
11843
2601
1645
3256
3741
1793
11
M-77
4110
11033
2918
11876
10
2751
3231
3819
HH-82
12123
S-1238
11766
WW-60
10693
10290

1.66
1.69
1.72
1.75
1.75
1.75
1.75
1.75
1.81
1.81
1.84
1.88
1.88
1.88
1.88
1.88
1.91
1.91
1.91
1.92
1.94
1.97
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.03
2.03
2.06
2.13
2.13
2.13
2.19
2.25
2.25
2.31
2.31
2.31
2.38
2.38
2.44
2.50
2.50
2.50
2.50
2.50
2.50
2.53
2.59
2.63
2.63
2.63
2.63
2.63
2.75
2.75
2.81
2.88
2.88
2.97
3.00
3.00
3.00
3.00
3.00
3.25
3.28
3.69
3.81
3.88
4.00
4.13

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

42.1
42.8
43.6
44.5
44.5
44.5
44.5
44.5
46.0
46.0
46.8
47.6
47.6
47.6
47.6
47.6
48.4
48.4
48.4
48.8
49.2
50.0
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
51.6
51.6
52.4
54.0
54.0
54.0
55.6
57.2
57.2
58.7
58.7
58.7
60.3
60.3
61.9
63.5
63.5
63.5
63.5
63.5
63.5
64.3
65.9
66.7
66.7
66.7
66.7
66.7
69.9
69.9
71.4
73.0
73.0
75.4
76.2
76.2
76.2
76.2
76.2
82.6
83.3
93.6
96.8
98.4
101.6
104.8

I.D.
Inches

.330
.410
.394
.420
.376
.368
.356
.354
.384
.356
.322
.406
.396
.394
.392
.380
.440
.392
.374
.438
.356
.406
.424
.420
.418
.408
.406
.406
.400
.388
.376
.374
.372
.356
.462
.362
.330
.406
.402
.388
.312
.460
.340
.398
.356
.356
.372
.366
.376
.424
.400
.376
.376
.376
.356
.376
.424
.426
.416
.406
.376
.376
.376
.356
.300
.374
.340
.372
.410
.406
.404
.404
.366
.400
.372
.372
.354
.420
.398
.356

RATE
mm

8.4
10.4
10.0
10.7
9.6
9.3
9.0
9.0
9.8
9.0
8.2
10.3
10.1
10.0
10.0
9.7
11.2
10.0
9.5
11.1
9.0
10.3
10.8
10.7
10.6
10.4
10.3
10.3
10.2
9.9
9.6
9.5
9.4
9.0
11.7
9.2
8.4
10.3
10.2
9.9
7.9
11.7
8.6
10.1
9.0
9.0
9.4
9.3
9.6
10.8
10.2
9.6
9.6
9.6
9.0
9.6
10.8
10.8
10.6
10.3
9.6
9.6
9.6
9.0
7.6
9.5
8.6
9.4
10.4
10.3
10.3
10.3
9.3
10.2
9.4
9.4
9.0
10.7
10.1
9.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

100
6.3
13
3.4
24
34
43
48
13
35
144
6.3
8.9
11
9.2
15
1.4
14
32
1.6
55
5.6
2.6
4.7
3.0
5.1
7.2
5.8
5.9
13
24
21
34
38
.14
28
91
3.1
11
10
124
.23
69
13
32
58
20
34
17
3.0
13
16
21
13
38
17
2.1
1.5
3.6
4.9
14
14
19
28
102
15
50
20
3.1
4.6
6.4
3.8
21
5.5
15
10
24
2.0
2.8
26

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

18
1.1
2.2
.60
4.1
6.0
7.6
8.3
2.2
6.2
25
1.1
1.6
1.8
1.6
2.6
.25
2.4
5.6
.28
9.6
.98
.46
.83
.53
.89
1.3
1.0
1.0
2.3
4.2
3.6
6.0
6.6
.02
4.9
16
.53
2.0
1.8
22
.04
12
2.4
5.6
10
3.6
6.0
3.0
.53
2.3
2.8
3.7
2.3
6.6
3.0
.37
.26
.63
.85
2.5
2.4
3.3
4.9
18
2.6
8.8
3.6
.55
.80
1.1
.67
3.7
.96
2.5
1.8
4.2
.35
.83
4.5

.40
1.1
.84
1.2
.72
.59
.57
.54
.84
.66
.32
1.2
1.1
.95
.90
.80
1.6
.82
.55
1.6
.45
1.2
1.5
1.1
1.3
1.3
1.1
1.2
1.2
.97
.70
.81
.54
.65
1.7
.82
.61
1.0
1.1
1.1
.41
2.0
.49
.71
.78
.43
.91
.62
.98
1.9
.68
1.1
.80
1.2
.65
1.0
2.0
2.0
2.0
1.6
1.2
1.2
.90
.88
.41
1.2
.67
.91
2.0
1.7
1.3
1.8
1.0
1.6
1.3
1.7
1.1
2.3
2.3
.97

mm

10
29
21
30
18
15
14
14
21
17
8.0
30
28
24
23
20
41
21
14
41
11
31
38
27
33
33
28
32
30
25
18
21
14
17
44
21
16
26
28
29
10
52
12
18
20
11
23
16
25
49
17
27
20
31
17
25
50
50
51
42
31
31
23
22
10
30
17
23
51
43
34
46
26
42
32
43
27
59
58
25

ENDS: C - Closed

G - Ground
O - Open

Lbs.

40
7.0
11
4.1
17
20
25
26
11
23
46
7.4
9.7
10
8.3
12
2.3
11
18
2.6
25
6.9
4.0
5.0
3.9
6.6
8.0
7.2
6.9
13
17
17
19
25
.24
23
56
3.1
13
12
51
.46
34
9.5
25
25
19
21
17
5.9
9.0
17
17
16
25
17
4.1
2.9
7.1
8.0
17
17
17
25
42
18
34
19
6.3
7.8
8.5
7.0
21
9.0
19
17
26
4.7
11
25

178
31
47
18
75
90
110
115
48
103
203
33
43
45
37
52
10
50
79
12
110
31
18
22
17
29
36
32
31
56
75
74
82
110
1.1
103
249
14
56
52
228
2.0
149
42
110
110
82
94
75
26
40
75
75
71
110
75
18
13
32
36
75
75
75
110
187
79
149
82
28
35
38
31
94
40
82
77
115
21
48
110

Inches

1.06
.54
.64
.56
.85
.84
1.03
1.02
.97
1.15
.98
.71
.79
.66
.97
1.08
.30
.65
.72
.31
.86
.73
.49
.44
.70
.71
.64
.75
.83
.81
.78
.91
.74
1.15
.29
1.14
1.15
1.10
.49
.87
1.46
.22
1.08
.51
1.26
.76
1.04
.90
1.04
.49
.48
1.18
.87
1.24
1.08
1.12
.63
.67
.63
.82
1.30
1.32
.96
1.48
2.40
1.32
1.50
1.11
.99
.90
.77
1.18
1.27
1.00
1.41
1.70
1.75
.78
1.26
1.53

mm

Inches

27.0
13.7
16.2
14.2
21.7
21.4
26.2
26.0
24.7
29.3
24.9
17.9
20.0
16.8
24.7
27.4
7.6
16.5
18.4
7.9
21.9
18.5
12.5
11.2
17.7
18.1
16.1
19.1
21.0
20.6
19.7
23.2
18.7
29.3
7.4
28.9
29.2
28.1
12.4
22.0
37.0
5.6
27.4
13.0
32.0
19.2
26.4
23.0
26.4
12.5
12.1
29.9
22.0
31.5
27.4
28.3
15.9
16.9
16.0
20.9
33.1
33.5
24.4
37.5
61.0
33.6
38.1
28.2
25.1
22.9
19.5
29.9
32.3
25.4
35.8
43.1
44.5
19.8
32.1
38.9

0.085
0.045
0.053
0.040
0.062
0.066
0.072
0.073
0.058
0.072
0.089
0.047
0.052
0.053
0.054
0.060
0.030
0.054
0.063
0.031
0.072
0.047
0.038
0.040
0.041
0.046
0.047
0.047
0.050
0.056
0.062
0.063
0.064
0.072
0.019
0.069
0.085
0.047
0.049
0.056
0.094
0.020
0.080
0.051
0.072
0.072
0.064
0.067
0.062
0.038
0.050
0.062
0.062
0.062
0.072
0.062
0.038
0.037
0.042
0.047
0.062
0.062
0.062
0.072
0.100
0.063
0.080
0.064
0.045
0.047
0.048
0.048
0.067
0.050
0.064
0.064
0.073
0.040
0.051
0.072

mm

TOTAL
MATL
COILS

2.2
1.1
1.3
1.0
1.6
1.7
1.8
1.9
1.5
1.8
2.3
1.2
1.3
1.3
1.4
1.5
0.8
1.4
1.6
0.8
1.8
1.2
1.0
1.0
1.0
1.2
1.2
1.2
1.3
1.4
1.6
1.6
1.6
1.8
0.5
1.8
2.2
1.2
1.2
1.4
2.4
0.5
2.0
1.3
1.8
1.8
1.6
1.7
1.6
1.0
1.3
1.6
1.6
1.6
1.8
1.6
1.0
0.9
1.1
1.2
1.6
1.6
1.6
1.8
2.5
1.6
2.0
1.6
1.1
1.2
1.2
1.2
1.7
1.3
1.6
1.6
1.9
1.0
1.3
1.8

12.5
12.0
12.0
13.0
12.8
11.8
13.3
13.0
16.8
16.0
11.0
14.0
15.0
12.5
17.0
17.0
10.0
12.0
10.5
10.0
11.0
15.5
12.0
10.0
16.0
15.5
12.5
15.0
16.5
14.5
12.5
13.5
10.5
15.0
14.3
16.5
13.5
23.5
10.0
15.5
15.5
10.0
13.5
10.0
17.5
10.5
16.3
12.5
16.8
12.0
9.50
18.0
14.0
19.0
15.0
17.0
16.5
18.0
15.0
17.5
20.0
20.3
15.5
19.5
24.0
20.0
17.8
16.3
22.0
18.3
15.0
23.5
19.0
20.0
22.0
26.5
24.0
18.5
24.8
21.3

SPR
SPR
SPR
MW
HD
SPR
HD
SPR
SPR
SPR
SPR
HD
HD
SST
SPR
SPR
MW
SPR
SPR
MW
SPR
SPR
SST
SPR
SPR
SPR
HD
HD
SST
SPR
SPR
SST
SPR
HD
MW
SPR
MW
SST
MW
SST
SPR
SST
SPR
SPR
HD
HD
SPR
SPR
SPR
MW
SPR
HD
SPR
SST
SPR
SPR
SPR
SST
MW
SPR
HD
HD
HD
HD
SPR
SPR
HD
SPR
SPR
HD
HD
SPR
SPR
SPR
SPR
SST
SPR
SST
BC
SPR

E
N
D
S

CG
CG
CG
C
C
C
C
CG
CG
CG
CG
C
CG
CG
C
C
CG
CG
C
CG
C
CG
C
C
C
CG
C
C
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
C
CG
C
CG
CG
CG
CG
C
C
CG
C
CG
C
CG
C
CG
C
C
C
CG
CG
CG
CG
CG
C
C
CG

F
N
S
H

Z
N
N
Z
Z
N
Z
N
Z
GI
Z
Z
Z
N
Z
Z
GI
Z
Z
GI
Z
Z
N
Z
Z
Z
Z
Z
N
GI
Z
N
Z
Z
Z
Z
Z
N
Z
N
Z
N
Z
Z
GI
Z
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
N
Z
Z
Z
GI
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
GI
GI
N
Z
N
N
GI

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

125

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 126

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.500
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515

12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
12.70
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08

12139
3476
11651
K-37
12690
B15-55
3251
12218
S-1277
12688
3998
880
886
3155
514
V-21
O-115
A14-4
B15-16
B15-65
B2-41
3258
2657
3136
W-37
2640
A15-70
3389
DD-96
FF-20
Y-23
S-1060
3841
OO-79
KK-48
B3-36
K-29
WW-43
S-1171
Y-30
10838
12481
11107
S-235
2715
S-1051
B10-64
S-1613
11338
S-1032
3972
10460
2526
3535
10809
2560
Z-24
10718
S-1139
2709
10178
S-407
2513
O-69
3046
S-1162
3924
2696
12292
S-1501
11621
11753
4357
12748
10926
K-35
S-397
3689
3475
12603

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

4.19
4.50
4.75
4.75
5.50
5.50
5.50
5.94
6.50
9.00
10.5
12.0
12.0
14.0
16.0
.50
.56
.56
.56
.63
.63
.63
.69
.75
.75
.78
.81
.81
.81
.88
.88
.88
.94
.97
1.00
1.00
1.00
1.00
1.00
1.06
1.06
1.06
1.13
1.13
1.13
1.13
1.16
1.19
1.19
1.25
1.25
1.30
1.38
1.41
1.50
1.50
1.50
1.50
1.50
1.53
1.56
1.56
1.56
1.56
1.56
1.63
1.63
1.63
1.66
1.81
1.88
1.97
2.00
2.00
2.00
2.13
2.16
2.22
2.25
2.33

mm

106.4
114.3
120.7
120.7
139.7
139.7
139.7
150.8
165.1
228.6
266.7
304.8
304.8
355.6
406.4
12.7
14.3
14.3
14.3
15.9
15.9
15.9
17.4
19.1
19.1
19.8
20.6
20.6
20.6
22.2
22.2
22.2
23.8
24.6
25.4
25.4
25.4
25.4
25.4
27.0
27.0
27.0
28.6
28.6
28.6
28.6
29.4
30.2
30.2
31.8
31.8
32.9
34.9
35.7
38.1
38.1
38.1
38.1
38.1
38.9
39.7
39.7
39.7
39.7
39.7
41.3
41.3
41.3
42.1
46.0
47.6
50.0
50.8
50.8
50.8
54.0
54.8
56.4
57.2
59.1

MATERIAL: MW - Music Wire

126

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.424
.356
.408
.318
.406
.406
.364
.336
.392
.376
.356
.376
.340
.392
.392
.371
.437
.401
.355
.481
.443
.345
.345
.407
.407
.391
.411
.391
.355
.455
.415
.405
.331
.435
.455
.443
.419
.379
.355
.453
.447
.425
.457
.453
.387
.305
.379
.407
.341
.459
.391
.397
.427
.421
.485
.451
.451
.433
.411
.361
.433
.433
.395
.395
.355
.439
.391
.381
.399
.459
.411
.433
.453
.421
.399
.409
.329
.439
.355
.379

RATE
mm

10.8
9.0
10.4
8.1
10.3
10.3
9.2
8.5
10.0
9.6
9.0
9.6
8.6
10.0
10.0
9.4
11.1
10.2
9.0
12.2
11.3
8.8
8.8
10.3
10.3
9.9
10.4
9.9
9.0
11.6
10.5
10.3
8.4
11.0
11.6
11.3
10.6
9.6
9.0
11.5
11.4
10.8
11.6
11.5
9.8
7.7
9.6
10.3
8.7
11.7
9.9
10.1
10.8
10.7
12.3
11.5
11.5
11.0
10.4
9.2
11.0
11.0
10.0
10.0
9.0
11.2
9.9
9.7
10.1
11.7
10.4
11.0
11.5
10.7
10.1
10.4
8.4
11.2
9.0
9.6

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.4
.25
29
5.1
1.8
.32
40
7.0
2.4
.43
2.6
.46
8.9
1.6
42
7.4
3.2
.55
4.2
.74
7.4
1.3
3.1
.54
9.0
1.6
1.9
.34
1.4
.24
296
52
8.9
1.6
74
13
318
56
.78
.14
2.4
.42
629 110
290
51
36
6.2
25
4.4
87
15
19
3.3
57
10
131
23
3.1
.55
22
3.9
20
3.4
272
48
4.6
.80
3.4
.60
6.8
1.2
10
1.8
63
11
124
22
2.0
.34
2.4
.42
7.6
1.3
1.5
.26
1.4
.25
48
8.4
367
64
53
9.3
14
2.4
175
31
.42
.07
48
8.4
27
4.8
9.4
1.6
12
2.2
.08
.01
1.7
.29
2.7
.47
5.7
.99
9.2
1.6
69
12
3.2
.56
4.2
.74
22
3.8
19
3.4
79
14
2.5
.44
25
4.4
36
6.3
17
3.0
1.1
.19
7.6
1.3
6.4
1.1
1.5
.26
6.8
1.2
16
2.8
9.1
1.6
101
18
1.8
.32
64
11
30
5.2

3.0
.85
2.9
1.2
3.3
3.1
2.4
.85
3.4
4.0
3.3
5.4
3.8
5.9
8.2
.08
.33
.17
.10
.55
.27
.06
.13
.31
.37
.26
.45
.29
.23
.69
.39
.44
.17
.63
.85
.72
.60
.34
.25
.81
.75
.59
.86
.81
.52
.17
.41
.65
.24
.75
.34
.49
.68
.87
1.4
1.2
.98
.92
.82
.43
.99
1.1
.90
.72
.41
1.2
.65
.80
.79
1.5
1.0
.82
1.7
1.1
.83
1.1
.45
1.5
.51
1.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

75
22
74
30
84
78
62
22
85
102
85
138
95
149
209
2.1
8.3
4.4
2.6
14
6.7
1.6
3.4
7.8
9.4
6.7
11
7.3
5.9
17
9.9
11
4.4
16
22
18
15
8.7
6.3
21
19
15
22
21
13
4.4
10
16
6.0
19
8.7
12
17
22
34
30
25
23
21
11
25
28
23
18
10
29
16
20
20
37
26
21
43
29
21
27
11
39
13
25

Lbs.

4.3
25
5.3
47
8.0
8.0
22
36
11
17
25
17
34
11
11
24
2.9
13
33
.43
.63
39
39
11
9.3
23
8.4
16
31
2.2
8.7
8.5
47
2.9
2.9
4.9
6.3
22
31
1.6
1.8
4.5
1.3
1.1
25
63
22
9.0
42
.31
16
13
6.4
11
.11
2.0
2.6
5.2
7.6
29
3.1
4.7
20
14
33
2.9
16
29
14
1.6
7.9
5.2
2.5
7.8
14
9.7
45
2.8
33
30

ENDS: C - Closed

G - Ground
O - Open

19
110
23
208
36
36
96
160
47
75
110
75
149
50
50
107
13
57
146
1.9
2.8
173
173
49
41
101
37
73
136
9.6
39
38
209
13
13
22
28
96
136
7.1
7.9
20
5.7
5.0
111
282
96
40
185
1.4
73
59
29
48
.50
8.8
12
23
34
130
14
21
88
62
146
13
73
127
60
7.3
35
23
11
35
60
43
200
13
146
133

Inches

.87
1.44
1.84
3.46
1.60
1.46
3.06
1.89
2.16
3.91
4.93
5.24
7.34
4.03
5.59
.25
.23
.24
.34
.07
.36
.38
.45
.30
.38
.29
.36
.37
.54
.19
.30
.44
.64
.34
.15
.23
.40
.58
.56
.25
.32
.47
.26
.32
.48
.84
.58
.54
.78
.50
.42
.47
.37
.35
.15
.32
.26
.40
.68
.83
.57
.45
.66
.66
.88
.48
.74
.74
.70
.22
.83
.37
.31
.61
.78
.69
1.33
.68
1.06
.99

mm

22.2
36.6
46.7
87.8
40.6
37.0
77.7
47.9
54.9
99.2
125.3
133.1
186.4
102.4
142.0
6.4
5.9
6.0
8.6
1.8
9.1
9.7
11.3
7.5
9.6
7.3
9.2
9.4
13.7
4.8
7.6
11.2
16.4
8.6
3.8
5.7
10.1
14.7
14.2
6.3
8.0
12.0
6.6
8.1
12.2
21.3
14.7
13.7
19.9
12.8
10.6
12.0
9.5
9.0
3.8
8.1
6.5
10.2
17.2
21.0
14.6
11.5
16.8
16.8
22.4
12.1
18.9
18.7
17.7
5.7
21.1
9.4
7.9
15.5
19.9
17.5
33.9
17.4
26.9
25.0

WIRE DIA.
Inches

mm

0.038
0.072
0.046
0.091
0.047
0.047
0.068
0.082
0.054
0.062
0.072
0.062
0.080
0.054
0.054
0.072
0.039
0.057
0.080
0.017
0.036
0.085
0.085
0.054
0.054
0.062
0.052
0.062
0.080
0.030
0.050
0.055
0.092
0.040
0.030
0.036
0.048
0.068
0.080
0.031
0.034
0.045
0.029
0.031
0.064
0.105
0.068
0.054
0.087
0.028
0.062
0.059
0.044
0.047
0.015
0.032
0.032
0.041
0.052
0.077
0.041
0.041
0.060
0.060
0.080
0.038
0.062
0.067
0.058
0.028
0.052
0.041
0.031
0.047
0.058
0.053
0.093
0.038
0.080
0.068

1.0
1.8
1.2
2.3
1.2
1.2
1.7
2.1
1.4
1.6
1.8
1.6
2.0
1.4
1.4
1.8
1.0
1.4
2.0
0.4
0.9
2.2
2.2
1.4
1.4
1.6
1.3
1.6
2.0
0.8
1.3
1.4
2.3
1.0
0.8
0.9
1.2
1.7
2.0
0.8
0.9
1.1
0.7
0.8
1.6
2.7
1.7
1.4
2.2
0.7
1.6
1.5
1.1
1.2
0.4
0.8
0.8
1.0
1.3
2.0
1.0
1.0
1.5
1.5
2.0
1.0
1.6
1.7
1.5
0.7
1.3
1.0
0.8
1.2
1.5
1.3
2.4
1.0
2.0
1.7

FINISH: Z - Zinc

TOTAL
MATL
COILS
23.0
19.0
40.0
38.0
33.0
31.0
45.0
23.0
40.0
62.0
68.5
83.5
90.8
74.0
102.0
3.50
5.00
4.13
4.25
3.25
10.0
3.50
5.25
5.50
7.00
4.75
7.00
6.00
6.75
5.25
6.00
8.00
7.00
8.50
5.00
5.25
8.25
7.50
7.00
8.00
9.25
9.50
8.00
9.25
7.50
8.00
8.50
10.0
8.00
18.0
6.75
8.00
7.50
7.50
9.00
10.0
7.00
8.75
12.0
10.8
14.0
10.0
11.0
11.0
11.0
11.5
11.0
11.0
12.0
8.00
16.0
8.00
10.0
12.0
12.5
13.0
14.3
17.0
13.3
13.5

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
HD
SPR
SPR
HD
SPR
SPR
SPR
SST
SPR
SPR
HD
HD
SPR
HD
SPR
SST
SPR
SPR
MW
SST
SPR
SPR
SPR
SPR
MW
SST
SPR
SST
MW
SPR
SST
HD
SST
MW
MW
SST
SPR
SST
MW
SPR
MW
MW
SST
MW
SST
SPR
SST
SPR
SST
SPR
SST
SPR
MW
MW
HD
SPR
SPR
SST
SPR
SPR
SST
MW
SST
SPR
SST
HD
MW
SPR
SST
SPR
SPR
MW
SPR
SPR
SST
SST
SPR
SPR
MW

E
N
D
S

F
N
S
H

CG
C
CG
CG
C
CG
CG
CG
CG
C
CG
C
C
C
C
CG
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
C
C
C
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
C
C
CG
CG
C
CG
C

Z
Z
Z
GI
BO
Z
Z
Z
N
Z
Z
Z
Z
Z
Z
GI
N
GI
N
Z
N
Z
Z
Z
Z
Z
N
Z
N
Z
N
N
GI
N
N
N
N
Z
N
Z
Z
N
Z
N
Z
N
Z
N
Z
N
Z
N
Z
Z
N
Z
Z
Z
N
Z
Z
N
Z
N
Z
N
Z
Z
N
N
Z
Z
Z
N
Z
N
N
Z
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 127

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.515
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531

13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.08
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49

S-278
3429
A13-37
11635
3838
2558
3140
12300
2510
B-26
11557
10928
10705
11517
12298
11431
1609
S-188
1809
N-81
3050
2851
B10-36
I-14
S-17
PP-32
G-57
S-823
2670
M-131
L-35
F-54
YY-58
N-132
3906
CC-53
2586
4269
B11-51
10260
1953
S-919
2592
B11-37
S-446
2787
2559
V-29
S-895
10734
3836
2636
JJ-17
S-1412
2896
I-47
A12-12
A12-30
11204
S-81
11208
S-916
10034
11200
B10-39
12401
12497
10691
12313
B7-10
10585
B12-47
1751
S-57
2616
S-1449
2689
S-1348
S-136
S-18

O.D.

FREE LENGTH
Inches

2.50
2.63
2.66
2.69
2.69
2.69
2.75
3.00
3.25
3.28
3.59
4.00
5.31
5.50
6.00
7.63
8.50
8.75
12.0
.28
.31
.44
.44
.50
.50
.56
.56
.63
.63
.63
.63
.66
.69
.69
.72
.75
.75
.75
.75
.75
.78
.78
.78
.81
.81
.81
.84
.84
.88
.88
.88
.91
.94
.94
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.03
1.06
1.06
1.06
1.08
1.13
1.13
1.13
1.19
1.19
1.22
1.22
1.22
1.25
1.25

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

63.5
66.7
67.5
68.2
68.2
68.2
69.9
76.2
82.6
83.3
91.3
101.6
134.9
139.7
152.4
193.7
215.9
222.3
304.8
7.1
7.9
11.1
11.1
12.7
12.7
14.3
14.3
15.9
15.9
15.9
15.9
16.7
17.4
17.4
18.2
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
23.0
23.8
23.8
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
26.2
27.0
27.0
27.0
27.4
28.6
28.6
28.6
30.2
30.2
31.0
31.0
31.0
31.8
31.8

I.D.
Inches

.411
.265
.369
.415
.387
.265
.437
.395
.399
.433
.387
.347
.315
.421
.421
.411
.391
.391
.391
.437
.467
.485
.441
.441
.437
.387
.371
.481
.465
.459
.407
.405
.463
.407
.451
.467
.449
.437
.403
.349
.487
.387
.321
.467
.407
.345
.423
.407
.467
.449
.427
.417
.471
.449
.429
.407
.471
.471
.467
.443
.407
.405
.381
.469
.441
.321
.473
.463
.435
.469
.407
.405
.281
.437
.385
.423
.407
.321
.461
.387

RATE
mm

10.4
6.7
9.4
10.5
9.8
6.7
11.1
10.0
10.1
11.0
9.8
8.8
8.0
10.7
10.7
10.4
9.9
9.9
9.9
11.1
11.9
12.3
11.2
11.2
11.1
9.8
9.4
12.2
11.8
11.7
10.3
10.3
11.8
10.3
11.5
11.9
11.4
11.1
10.2
8.9
12.4
9.8
8.2
11.9
10.3
8.8
10.7
10.3
11.9
11.4
10.8
10.6
12.0
11.4
10.9
10.3
12.0
12.0
11.9
11.3
10.3
10.3
9.7
11.9
11.2
8.2
12.0
11.8
11.0
11.9
10.3
10.3
7.1
11.1
9.8
10.7
10.3
8.2
11.7
9.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

6.1
1.1
438
77
25
4.3
5.6
.98
11
2.0
382
67
4.2
.74
11
1.9
12
2.1
3.8
.67
12
2.1
40
7.0
54
9.5
2.4
.41
3.6
.63
1.8
.31
5.3
.93
4.6
.81
2.9
.51
62
11
12
2.1
1.5
.27
19
3.3
30
5.2
27
4.7
107
19
186
33
.75
.13
6.9
1.2
5.9
1.0
73
13
88
15
7.8
1.4
69
12
7.8
1.4
4.0
.71
14
2.4
15
2.7
53
9.2
386
68
.68
.12
99
17
646 113
4.0
.71
72
13
320
56
23
3.9
45
7.8
3.5
.62
8.6
1.5
32
5.6
28
5.0
1.9
.32
8.6
1.5
22
3.8
21
3.6
1.6
.28
1.5
.27
1.7
.30
10
1.8
33
5.8
64
11
120
21
1.6
.27
8.9
1.6
432
76
1.4
.24
2.0
.34
11
1.9
2.7
.47
51
9.0
47
8.1
1234 216
7.8
1.4
61
11
14
2.4
26
4.5
314
55
4.4
.77
45
7.8

Inches

mm

1.5
38
.24
6.2
.95 24
1.6
40
1.1
28
.39
9.9
1.1
27
1.4
34
1.6
41
1.4
35
1.5
38
.95 24
1.1
28
3.3
84
2.2
55
4.3 110
3.1
78
3.3
85
7.0 177
.12
3.1
.21
5.3
.32
8.2
.22
5.7
.21
5.3
.26
6.7
.15
3.8
.16
4.1
.43 11
.40 10
.45 11
.21
5.2
.19
4.8
.39
9.9
.23
5.9
.44 11
.56 14
.51 13
.42 11
.31
8.0
.11
2.9
.63 16
.22
5.6
.10
2.6
.63 16
.21
5.3
.15
3.7
.47 12
.34
8.5
.67 17
.59 15
.30
7.6
.44 11
.70 18
.55 14
.41 10
.19
4.9
.74 19
.73 19
.70 18
.57 15
.45 11
.25
6.2
.22
5.6
.75 19
.68 17
.15
3.9
.81 21
.72 18
.62 16
.80 20
.31
7.9
.36
9.1
.08
2.2
.72 18
.40 10
.72 18
.60 15
.20
5.0
.67 17
.49 12

ENDS: C - Closed

G - Ground
O - Open

Lbs.

9.2
107
24
8.7
12
150
4.5
15
19
5.2
18
38
60
7.8
7.8
7.6
16
15
20
7.6
2.5
.50
4.2
6.2
7.1
16
30
.32
2.8
2.6
15
17
3.0
16
3.4
2.3
7.0
6.5
16
44
.43
22
67
2.5
15
47
10
15
2.4
5.1
9.5
12
1.3
4.7
9.0
4.0
1.2
1.1
1.2
5.8
15
16
26
1.2
6.1
67
1.1
1.4
6.7
2.1
16
17
105
5.6
24
9.7
15
62
3.0
22

41
476
105
39
55
665
20
66
83
23
80
168
265
35
35
34
73
69
91
34
11
2.2
19
28
32
70
133
1.4
12
12
67
74
13
71
15
10
31
29
73
197
1.9
98
296
11
67
210
47
67
10
22
42
55
5.7
21
40
18
5.3
5.0
5.4
26
67
70
117
5.3
27
296
5.0
6.3
30
9.5
71
74
466
25
109
43
69
275
13
98

Inches

mm

Inches

.94 23.8
1.94 49.2
1.46 37.1
.90 22.9
1.60 40.6
2.19 55.6
.40 10.2
1.20 30.5
.96 24.3
.53 13.5
1.60 40.6
2.14 54.4
3.90 99.1
1.50 38.2
.99 25.1
3.30 83.9
2.79 70.9
2.79 70.9
5.02 127.6
.14
3.6
.10
2.4
.12
2.9
.21
5.4
.16
4.0
.19
4.8
.41 10.5
.40 10.2
.20
5.1
.17
4.2
.18
4.6
.28
7.1
.28
7.2
.17
4.3
.31
7.9
.28
7.1
.19
4.9
.18
4.7
.33
8.4
.38
9.8
.46 11.6
.15
3.8
.40 10.1
.58 14.7
.16
4.1
.28
7.1
.56 14.2
.38
9.6
.37
9.4
.16
4.1
.25
6.2
.31
7.9
.40 10.1
.24
6.1
.23
5.7
.36
9.1
.74 18.9
.26
6.7
.27
6.9
.30
7.5
.31
7.8
.47 11.8
.32
8.0
.45 11.4
.28
7.1
.35
8.9
.73 18.5
.25
6.5
.34
8.6
.44 11.3
.20
5.1
.43 11.0
.43 10.8
.78 19.8
.47 11.9
.66 16.7
.50 12.7
.62 15.7
.87 22.0
.23
5.8
.70 17.8

0.052
0.125
0.073
0.050
0.064
0.125
0.039
0.060
0.058
0.041
0.064
0.084
0.100
0.047
0.047
0.052
0.062
0.062
0.062
0.047
0.032
0.023
0.045
0.045
0.047
0.072
0.080
0.025
0.033
0.036
0.062
0.063
0.034
0.062
0.040
0.032
0.041
0.047
0.064
0.091
0.022
0.072
0.105
0.032
0.062
0.093
0.054
0.062
0.032
0.041
0.052
0.057
0.030
0.041
0.051
0.062
0.030
0.030
0.032
0.044
0.062
0.063
0.075
0.031
0.045
0.105
0.029
0.034
0.048
0.031
0.062
0.063
0.125
0.047
0.073
0.054
0.062
0.105
0.035
0.072

mm

TOTAL
MATL
COILS

1.3
3.2
1.9
1.3
1.6
3.2
1.0
1.5
1.5
1.0
1.6
2.1
2.5
1.2
1.2
1.3
1.6
1.6
1.6
1.2
0.8
0.6
1.1
1.1
1.2
1.8
2.0
0.6
0.8
0.9
1.6
1.6
0.9
1.6
1.0
0.8
1.0
1.2
1.6
2.3
0.6
1.8
2.7
0.8
1.6
2.4
1.4
1.6
0.8
1.0
1.3
1.4
0.8
1.0
1.3
1.6
0.8
0.8
0.8
1.1
1.6
1.6
1.9
0.8
1.1
2.7
0.7
0.9
1.2
0.8
1.6
1.6
3.2
1.2
1.9
1.4
1.6
2.7
0.9
1.8

17.0
15.5
19.0
18.0
25.0
17.5
9.25
20.0
16.5
12.0
24.0
24.5
39.0
31.0
21.0
62.5
45.0
45.0
80.0
3.00
3.00
4.00
4.75
3.50
4.00
5.75
5.00
7.00
4.00
5.00
4.50
4.50
4.00
5.00
6.00
5.00
4.50
6.00
6.00
5.00
5.75
5.50
5.50
5.00
4.50
6.00
7.00
6.00
5.00
6.00
5.00
7.00
7.00
5.50
6.00
12.0
7.75
8.00
8.25
6.00
7.50
5.00
6.00
8.00
7.75
7.00
7.75
10.0
8.25
5.50
6.00
6.75
6.25
9.00
9.00
9.25
10.0
8.25
5.50
9.75

SST
SPR
SST
SPR
SPR
MW
SPR
SPR
MW
HD
SPR
SPR
SPR
SPR
SPR
HD
SPR
SST
MW
SPR
SPR
MW
SPR
SST
SST
SPR
SST
SST
SPR
SST
SST
HD
SPR
SPR
SPR
MW
MW
SPR
SST
SPR
MW
SST
SPR
SPR
SST
SPR
HD
SST
SST
SPR
SPR
HD
MW
SST
SPR
HD
MW
MW
SST
SST
SST
SST
SPR
SST
SPR
SPR
MW
SPR
HD
SST
SPR
SPR
SPR
SST
HD
SST
HD
SST
SST
SST

E
N
D
S

C
CG
C
CG
CG
CG
C
CG
CG
C
CG
C
CG
CG
CG
C
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
C
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
C
C
C
C
CG
CG
CG
C
CG
CG
C
CG
C
C
C
CG
CG
C
CG
CG
CG
CG
C
CG

F
N
S
H

N
Z
N
Z
Z
Z
Z
Z
Z
N
N
Z
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
N
N
Z
N
N
Z
N
N
Z
GI
Z
Z
Z
Z
Z
N
Z
Z
N
Z
N
N
Z
Z
N
N
Z
Z
Z
Z
N
Z
N
N
Z
N
N
N
N
Z
N
N
N
N
Z
Z
N
Z
N
Z
N
Z
N
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

127

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 128

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.531
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540

13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.49
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72

S-847
S-990
A13-63
B1-68
OO-20
Z-26
S-1493
3191
3685
B18-192
2572
10700
B12-56
3956
S-1487
10137
S-1509
B5-46
3477
4390
10803
2904
QQ-30
3415
3478
I-58
11390
10303
11246
11134
FF-32
10629
12519
2901
3974
U-46
3671
11938
S-3129
11761
10532
S-968
4364
S-1367
10743
2967
11818
11560
11547
S-3089
12067
3676
3699
11234
11243
S-1566
2770
10824
12273
71633
71633S
71646
71646S
71659
71659S
71672
71672S
71685
71685S
71698
71698S
71634
71634S
71647
71647S
71660
71660S
71673
71673S
71686

1.28
1.28
1.31
1.31
1.31
1.34
1.38
1.38
1.41
1.41
1.44
1.44
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.56
1.63
1.63
1.63
1.63
1.63
1.63
1.66
1.69
1.75
1.78
1.88
1.88
1.88
2.00
2.03
2.09
2.13
2.19
2.22
2.25
2.38
2.44
2.50
2.50
2.50
2.78
2.81
2.88
3.38
3.44
4.06
4.13
4.19
4.81
5.75
6.25
6.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.50
.63
.63
.63
.63
.63
.63
.63
.63
.63

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

32.5
32.5
33.3
33.3
33.3
34.1
34.9
34.9
35.7
35.7
36.5
36.5
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.9
39.7
41.3
41.3
41.3
41.3
41.3
41.3
42.1
42.8
44.5
45.2
47.6
47.6
47.6
50.8
51.6
53.2
54.0
55.6
56.4
57.2
60.3
61.9
63.5
63.5
63.5
70.6
71.4
73.0
85.7
87.3
103.2
104.8
106.4
122.2
146.1
158.8
165.1
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
12.7
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0

MATERIAL: MW - Music Wire

128

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.467
.441
.453
.415
.311
.471
.473
.403
.387
.321
.435
.423
.385
.321
.477
.461
.461
.443
.421
.327
.453
.361
.483
.467
.445
.411
.401
.371
.407
.431
.471
.403
.467
.391
.347
.449
.385
.367
.466
.413
.383
.405
.407
.407
.469
.449
.407
.403
.401
.407
.359
.395
.405
.437
.407
.333
.337
.403
.437
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414

RATE
mm

11.9
11.2
11.5
10.5
7.9
12.0
12.0
10.2
9.8
8.2
11.0
10.7
9.8
8.2
12.1
11.7
11.7
11.3
10.7
8.3
11.5
9.2
12.3
11.9
11.3
10.4
10.2
9.4
10.3
10.9
12.0
10.2
11.9
9.9
8.8
11.4
9.8
9.3
11.8
10.5
9.7
10.3
10.3
10.3
11.9
11.4
10.3
10.2
10.2
10.3
9.1
10.0
10.3
11.1
10.3
8.5
8.6
10.2
11.1
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5

Lbs./In.

.69
12
7.0
26
353
1.6
1.4
30
57
301
12
10
71
301
1.2
3.5
1.7
8.9
14
282
3.5
107
.49
2.0
3.5
19
28
61
21
8.1
1.3
22
2.1
31
119
2.5
42
53
1.1
14
30
9.6
15
16
1.9
4.1
16
12
13
6.8
64
14
9.5
3.3
14
74
43
5.8
3.3
21
18
31
26
57
49
76
64
105
90
137
116
16
14
24
20
43
37
57
49
79

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.12
2.1
1.2
4.5
62
.29
.24
5.2
10
53
2.2
1.8
12
53
.20
.62
.30
1.6
2.4
49
.62
19
.09
.35
.62
3.4
4.9
11
3.6
1.4
.23
3.8
.37
5.4
21
.44
7.4
9.3
.18
2.5
5.2
1.7
2.7
2.7
.34
.71
2.8
2.1
2.3
1.2
11
2.5
1.7
.59
2.4
13
7.5
1.0
.57
3.7
3.1
5.4
4.6
10
8.5
13
11
18
16
24
20
2.9
2.4
4.2
3.6
7.6
6.5
10
8.5
14

.72
.52
.62
.51
.21
1.1
1.2
.59
.41
.22
.90
.74
.34
.22
1.2
.89
1.1
.70
.83
.22
1.2
.35
1.4
1.3
1.0
.70
.65
.52
.77
1.0
1.5
.81
1.6
.71
.39
1.4
.57
.64
1.7
.96
.86
.80
1.0
.96
1.7
1.2
1.0
1.3
1.4
1.1
.62
1.5
1.8
2.3
1.2
.71
1.2
3.0
2.3
.33
.26
.31
.25
.25
.20
.24
.19
.22
.17
.20
.16
.42
.34
.40
.32
.33
.27
.31
.25
.29

mm

18
13
16
13
5.3
28
30
15
10
5.6
23
19
8.8
5.6
31
23
27
18
21
5.5
29
9.0
35
32
26
18
17
13
20
27
37
21
41
18
9.8
36
15
16
44
24
22
20
27
24
42
32
26
34
35
27
16
38
45
57
30
18
32
76
59
8.3
6.6
7.9
6.3
6.4
5.1
6.0
4.8
5.5
4.4
5.1
4.0
11
8.5
10
8.1
8.5
6.8
8.0
6.3
7.4

Lbs.

.49
6.2
4.4
13
73
1.8
1.6
18
23
67
11
7.5
24
67
1.4
3.2
1.8
6.2
11
61
4.1
38
.68
2.5
3.6
14
18
32
16
8.5
1.9
18
3.4
22
46
3.6
24
34
1.8
14
25
7.7
16
15
3.2
5.1
16
16
18
7.2
39
21
17
7.6
16
52
53
18
7.6
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23

ENDS: C - Closed

G - Ground
O - Open

2.2
28
19
58
327
8.1
7.3
78
104
296
50
34
109
296
6.3
14
8.2
28
50
273
18
169
3.0
11
16
61
82
142
71
38
8.5
78
15
96
203
16
109
152
8.0
61
113
34
71
67
14
22
71
72
82
32
175
93
74
34
71
233
237
78
34
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102

Inches

.57
.26
.23
.46
1.10
.24
.20
.64
.65
1.00
.36
.70
.58
1.00
.20
.28
.42
.32
.61
.92
.35
.84
.23
.29
.60
.60
.72
1.00
.74
.60
.30
.83
.28
.95
1.22
.57
.95
1.27
.40
.80
1.28
1.45
.96
.84
.26
.47
.93
1.44
1.38
1.81
1.38
1.63
1.59
.96
1.05
2.23
3.72
2.72
.99
.14
.14
.17
.17
.21
.21
.22
.22
.25
.25
.27
.27
.16
.16
.20
.20
.24
.24
.26
.26
.29

mm

14.4
6.6
5.9
11.8
27.9
6.1
5.2
16.3
16.5
25.3
9.1
17.8
14.8
25.3
5.1
7.1
10.7
8.1
15.4
23.3
8.9
21.3
5.8
7.3
15.3
15.2
18.2
25.4
18.9
15.2
7.6
21.1
7.1
24.0
31.0
14.6
24.1
32.3
10.2
20.2
32.4
36.8
24.4
21.3
6.7
12.0
23.6
36.6
35.1
46.1
35.0
41.5
40.4
24.5
26.8
56.6
94.4
69.1
25.1
3.6
3.6
4.4
4.4
5.3
5.3
5.7
5.7
6.4
6.4
6.8
6.8
4.2
4.2
5.0
5.0
6.2
6.2
6.6
6.6
7.4

WIRE DIA.
Inches

0.032
0.045
0.039
0.058
0.110
0.030
0.029
0.064
0.072
0.105
0.048
0.054
0.073
0.105
0.027
0.035
0.035
0.044
0.055
0.102
0.039
0.085
0.024
0.032
0.043
0.060
0.065
0.080
0.062
0.050
0.030
0.064
0.032
0.070
0.092
0.041
0.073
0.082
0.033
0.059
0.074
0.063
0.062
0.062
0.031
0.041
0.062
0.064
0.065
0.062
0.086
0.068
0.063
0.047
0.062
0.099
0.097
0.064
0.047
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063

mm

TOTAL
MATL
COILS

0.8
1.1
1.0
1.5
2.8
0.8
0.7
1.6
1.8
2.7
1.2
1.4
1.9
2.7
0.7
0.9
0.9
1.1
1.4
2.6
1.0
2.2
0.6
0.8
1.1
1.5
1.7
2.0
1.6
1.3
0.8
1.6
0.8
1.8
2.3
1.0
1.9
2.1
0.8
1.5
1.9
1.6
1.6
1.6
0.8
1.0
1.6
1.6
1.7
1.6
2.2
1.7
1.6
1.2
1.6
2.5
2.5
1.6
1.2
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6

17.8
5.75
6.00
8.00
10.0
7.00
7.00
10.0
9.00
9.50
7.50
13.0
8.00
9.50
6.50
7.00
11.0
7.25
11.0
9.00
9.00
10.0
8.50
8.00
14.0
10.0
11.0
12.5
12.0
12.0
9.00
13.0
7.75
13.5
12.3
14.0
12.0
15.5
12.0
13.5
17.3
22.0
15.5
13.5
7.50
10.5
15.0
21.5
21.3
28.3
16.0
24.0
25.3
20.5
17.0
22.5
38.0
42.5
21.0
3.50
3.50
3.75
3.75
3.88
3.88
3.88
3.88
4.00
4.00
4.00
4.00
4.00
4.00
4.25
4.25
4.50
4.50
4.50
4.50
4.63

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
MW
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
SST
HD
SPR
SST
SPR
SPR
SPR
SPR
MW
SPR
MW
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SST
MW
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
HD
SST
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
C
CG
C
CG
CG
C
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
Z
GI
N
N
GI
Z
Z
Z
GI
Z
Z
N
Z
N
N
Z
Z
N
Z
N
Z
Z
N
Z
Z
Z
GI
N
Z
GI
Z
Z
N
Z
Z
N
Z
Z
N
Z
N
GI
Z
Z
Z
Z
N
Z
Z
GI
Z
Z
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 129

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540

13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72

71686S
71699
71699S
71635
71635S
71648
71648S
71661
71661S
71674
71674S
71687
71687S
71700
71700S
71636
71636S
71649
71649S
71662
71662S
71675
71675S
71688
71688S
71701
71701S
71637
71637S
71650
71650S
71663
71663S
71676
71676S
71689
71689S
71702
71702S
71638
71638S
71652
71652S
71664
71664S
71677
71677S
71690
71690S
71703
71703S
71639
71639S
71651
71651S
71665
71665S
71678
71678S
71691
71691S
71704
71704S
71640
71640S
71653
71653S
71666
71666S
71679
71679S
71692
71692S
71705
71705S
71641
71641S
71654
71654S
71667

.63
.63
.63
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

16.0
16.0
16.0
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8

I.D.
Inches

.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432

RATE
mm

10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

67
102
87
13
11
20
17
35
30
46
39
63
54
81
69
11
9.5
16
14
29
25
38
33
53
45
68
57
9.7
8.2
14
12
25
21
33
28
45
38
58
49
7.6
6.5
11
9.4
20
17
26
22
35
30
45
38
6.3
5.3
9.1
7.7
16
14
21
18
29
24
37
31
5.3
4.5
7.7
6.6
14
12
18
15
24
21
31
26
4.6
3.9
6.7
5.7
12

12
18
15
2.3
2.0
3.4
2.9
6.1
5.2
8.0
6.8
11
9.4
14
12
2.0
1.7
2.9
2.4
5.1
4.4
6.7
5.7
9.2
7.8
12
10
1.7
1.4
2.5
2.1
4.4
3.8
5.8
4.9
7.9
6.7
10
8.6
1.3
1.1
1.9
1.6
3.4
2.9
4.5
3.8
6.1
5.2
7.8
6.7
1.1
.93
1.6
1.4
2.8
2.4
3.7
3.1
5.0
4.3
6.4
5.4
.93
.79
1.4
1.2
2.4
2.0
3.1
2.6
4.3
3.6
5.4
4.6
.81
.69
1.2
1.0
2.1

.23
.27
.21
.52
.41
.50
.39
.42
.33
.39
.31
.36
.29
.34
.27
.61
.49
.59
.47
.50
.40
.47
.37
.43
.35
.41
.32
.71
.57
.69
.55
.58
.46
.54
.43
.51
.40
.47
.38
.91
.72
.87
.70
.74
.59
.70
.56
.65
.52
.61
.49
1.1
.88
1.1
.85
.90
.72
.85
.68
.80
.63
.75
.60
1.3
1.0
1.3
1.0
1.1
.85
1.0
.80
.94
.75
.88
.70
1.5
1.2
1.4
1.1
1.2

mm

5.9
6.8
5.4
13
10
13
10
11
8.4
9.9
7.9
9.2
7.3
8.6
6.8
16
12
15
12
13
10
12
9.5
11
8.8
10
8.2
18
14
17
14
15
12
14
11
13
10
12
9.6
23
18
22
18
19
15
18
14
17
13
16
12
28
22
27
21
23
18
22
17
20
16
19
15
33
26
32
25
27
21
26
20
24
19
22
18
38
30
37
29
31

ENDS: C - Closed

G - Ground
O - Open

Lbs.

15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15

69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65

Inches

.29
.31
.31
.18
.18
.22
.22
.27
.27
.30
.30
.33
.33
.36
.36
.20
.20
.24
.24
.30
.30
.33
.33
.38
.38
.40
.40
.22
.22
.26
.26
.34
.34
.37
.37
.42
.42
.45
.45
.26
.26
.32
.32
.40
.40
.44
.44
.50
.50
.54
.54
.30
.30
.36
.36
.47
.47
.51
.51
.58
.58
.64
.64
.33
.33
.41
.41
.53
.53
.59
.59
.67
.67
.73
.73
.37
.37
.46
.46
.59

mm

Inches

7.4
7.9
7.9
4.7
4.7
5.5
5.5
6.9
6.9
7.6
7.6
8.4
8.4
9.1
9.1
5.1
5.1
6.1
6.1
7.7
7.7
8.5
8.5
9.6
9.6
10.2
10.2
5.6
5.6
6.7
6.7
8.6
8.6
9.4
9.4
10.6
10.6
11.5
11.5
6.5
6.5
8.0
8.0
10.1
10.1
11.2
11.2
12.8
12.8
13.8
13.8
7.6
7.6
9.2
9.2
11.8
11.8
13.1
13.1
14.8
14.8
16.2
16.2
8.5
8.5
10.4
10.4
13.4
13.4
14.9
14.9
17.0
17.0
18.5
18.5
9.5
9.5
11.7
11.7
15.1

0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054

mm

TOTAL
MATL
COILS

1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4

4.63
4.63
4.63
4.50
4.50
4.75
4.75
5.00
5.00
5.13
5.13
5.25
5.25
5.38
5.38
4.88
4.88
5.25
5.25
5.63
5.63
5.75
5.75
6.00
6.00
6.00
6.00
5.38
5.38
5.75
5.75
6.25
6.25
6.38
6.38
6.63
6.63
6.75
6.75
6.25
6.25
6.88
6.88
7.38
7.38
7.63
7.63
8.00
8.00
8.13
8.13
7.25
7.25
7.88
7.88
8.63
8.63
8.88
8.88
9.25
9.25
9.50
9.50
8.13
8.13
8.88
8.88
9.75
9.75
10.1
10.1
10.6
10.6
10.9
10.9
9.13
9.13
10.0
10.0
11.0

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

129

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 130

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.540
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546

13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.72
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87

71667S
71680
71680S
71693
71693S
71706
71706S
71642
71642S
71655
71655S
71668
71668S
71681
71681S
71694
71694S
71707
71707S
71643
71643S
71656
71656S
71669
71669S
71682
71682S
71695
71695S
71708
71708S
71644
71644S
71657
71657S
71670
71670S
71683
71683S
71696
71696S
71709
71709S
71645
71645S
71658
71658S
71671
71671S
71684
71684S
71697
71697S
71710
71710S
S-56
A9-48
YY-68
S-830
K-27
MM-60
G-91
12194
B6-8
B1-21
S-1114
B7-8
S-1579
A14-34
O-98
A11-8
GG-80
S-1370
O-151
3178
10051
U-29
A11-26
B11-3
M-109

2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
.28
.31
.31
.34
.38
.41
.41
.41
.44
.44
.44
.47
.50
.53
.53
.53
.53
.56
.56
.56
.56
.59
.59
.63
.66

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
7.1
7.9
7.9
8.7
9.5
10.3
10.3
10.3
11.1
11.1
11.1
11.9
12.7
13.5
13.5
13.5
13.5
14.3
14.3
14.3
14.3
15.1
15.1
15.9
16.7

MATERIAL: MW - Music Wire

130

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.458
.458
.448
.448
.432
.432
.424
.424
.414
.414
.406
.406
.484
.454
.422
.436
.452
.446
.414
.346
.500
.450
.446
.456
.452
.436
.418
.376
.346
.506
.478
.462
.422
.460
.446
.438
.480

RATE
mm

11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
11.6
11.6
11.4
11.4
11.0
11.0
10.8
10.8
10.5
10.5
10.3
10.3
12.3
11.5
10.7
11.1
11.5
11.3
10.5
8.8
12.7
11.4
11.3
11.6
11.5
11.1
10.6
9.6
8.8
12.9
12.1
11.7
10.7
11.7
11.3
11.1
12.2

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

10
1.8
16
2.7
13
2.3
21
3.7
18
3.1
27
4.7
23
4.0
4.1
.72
3.5
.61
5.9
1.0
5.0
.88
11
1.8
8.9
1.6
14
2.4
12
2.0
19
3.3
16
2.8
24
4.1
20
3.5
3.7
.64
3.1
.55
5.3
.93
4.5
.79
9.4
1.6
8.0
1.4
12
2.1
10
1.8
17
2.9
14
2.5
21
3.7
18
3.1
3.3
.58
2.8
.49
4.8
.84
4.1
.72
8.5
1.5
7.2
1.3
11
1.9
9.4
1.6
15
2.6
13
2.2
19
3.3
16
2.8
3.0
.53
2.6
.45
4.4
.77
3.7
.66
7.8
1.4
6.6
1.2
10
1.8
8.6
1.5
14
2.4
12
2.0
18
3.1
15
2.6
4.3
.75
23
4.0
187
33
49
8.6
49
8.6
44
7.6
123
21
1080 189
1.1
.20
55
9.6
64
11
24
4.2
33
5.8
49
8.6
72
13
383
67
1080 189
.34
.06
8.3
1.5
14
2.4
83
15
19
3.4
22
3.8
40
7.1
2.8
.49

.97
1.2
.92
1.1
.87
1.0
.81
1.7
1.3
1.6
1.3
1.4
1.1
1.3
1.0
1.2
.98
1.2
.92
1.9
1.5
1.8
1.4
1.5
1.2
1.5
1.2
1.4
1.1
1.3
1.0
2.1
1.6
2.0
1.6
1.7
1.4
1.6
1.3
1.5
1.2
1.4
1.1
2.3
1.8
2.2
1.7
1.9
1.5
1.8
1.4
1.7
1.3
1.6
1.2
.13
.13
.08
.12
.14
.18
.14
.05
.33
.13
.12
.26
.21
.21
.21
.10
.05
.42
.33
.37
.19
.29
.29
.24
.44

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

25
29
23
28
22
26
21
43
34
41
33
35
28
33
27
31
25
29
23
48
38
46
37
39
31
37
30
35
28
33
26
53
42
51
41
43
35
41
33
39
31
36
29
57
46
56
44
48
38
45
36
42
34
40
32
3.2
3.3
2.1
3.1
3.6
4.5
3.6
1.3
8.5
3.4
3.1
6.5
5.2
5.3
5.4
2.5
1.3
11
8.4
9.5
4.7
7.4
7.4
6.1
11

Lbs.

9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
6.9
4.7
9.7
6.5
15
9.8
18
12
23
15
27
19
.54
2.9
16
6.1
6.9
7.8
18
57
.38
7.3
7.8
6.1
6.9
10
15
37
57
.14
2.7
5.2
16
5.7
6.4
9.7
1.2

ENDS: C - Closed

G - Ground
O - Open

44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
31
21
43
29
65
44
80
54
102
69
122
83
2.4
13
69
27
31
35
78
252
1.7
33
35
27
31
46
67
165
252
.64
12
23
69
25
28
43
5.5

Inches

.59
.66
.66
.75
.75
.82
.82
.41
.41
.51
.51
.65
.65
.73
.73
.83
.83
.91
.91
.45
.45
.55
.55
.72
.72
.80
.80
.92
.92
1.01
1.01
.49
.49
.60
.60
.78
.78
.88
.88
1.00
1.00
1.10
1.10
.52
.52
.65
.65
.85
.85
.95
.95
1.09
1.09
1.18
1.18
.16
.18
.19
.22
.14
.18
.25
.35
.10
.19
.15
.17
.16
.22
.32
.43
.35
.14
.15
.19
.26
.17
.30
.23
.21

mm

15.1
16.8
16.8
19.0
19.0
20.8
20.8
10.4
10.4
12.9
12.9
16.6
16.6
18.6
18.6
21.2
21.2
23.2
23.2
11.3
11.3
14.0
14.0
18.3
18.3
20.4
20.4
23.4
23.4
25.5
25.5
12.4
12.4
15.3
15.3
19.9
19.9
22.5
22.5
25.4
25.4
27.9
27.9
13.3
13.3
16.5
16.5
21.6
21.6
24.1
24.1
27.6
27.6
30.0
30.0
3.9
4.7
4.7
5.6
3.6
4.4
6.3
8.9
2.6
4.9
3.8
4.3
4.2
5.6
8.1
10.8
8.9
3.6
3.9
4.8
6.7
4.4
7.6
5.8
5.4

WIRE DIA.
Inches

0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.041
0.041
0.046
0.046
0.054
0.054
0.058
0.058
0.063
0.063
0.067
0.067
0.031
0.046
0.062
0.055
0.047
0.050
0.066
0.100
0.023
0.048
0.050
0.045
0.047
0.055
0.064
0.085
0.100
0.020
0.034
0.042
0.062
0.043
0.050
0.054
0.033

mm

TOTAL
MATL
COILS

1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.0
1.0
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
0.8
1.2
1.6
1.4
1.2
1.3
1.7
2.5
0.6
1.2
1.3
1.1
1.2
1.4
1.6
2.2
2.5
0.5
0.9
1.1
1.6
1.1
1.3
1.4
0.8

11.0
11.4
11.4
11.9
11.9
12.3
12.3
10.0
10.0
11.0
11.0
12.1
12.1
12.6
12.6
13.3
13.3
13.6
13.6
10.9
10.9
12.0
12.0
13.4
13.4
13.9
13.9
14.6
14.6
15.0
15.0
11.9
11.9
13.1
13.1
14.5
14.5
15.3
15.3
15.9
15.9
16.4
16.4
12.8
12.8
14.1
14.1
15.8
15.8
16.4
16.4
17.3
17.3
17.6
17.6
4.00
4.00
3.00
4.00
3.00
3.50
3.75
3.50
4.50
3.00
3.00
3.75
3.50
4.00
5.00
4.00
3.50
6.00
3.50
4.50
4.25
4.00
5.00
4.25
6.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SST
SPR
SST
SST
SST
SST
SPR
MW
SST
SST
SST
SST
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
SST
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
C
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
Z
N
N
N
N
N
N
Z
N
N
N
N
Z
Z
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 131

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546

13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87

2953
BB-69
G-92
A9-68
A13-24
B6-68
A13-48
JJ-93
10054
B14-34
S-1408
K-61
3597
WW-64
A14-57
10662
A11-59
A15-57
S-1194
B1-30
A-60
G-81
S-1633
S-1049
G-50
L-26
A13-61
S-869
10176
S-1061
A15-27
S-271
B1-55
YY-70
12327
B9-32
V V-65
AA-86
10630
H-36
A15-68
A9-57
K-55
11706
W-56
10465
I-94
YY-49
RR-50
S-932
S-1137
S-2
OO-99
S-3208
S-1593
1897
FF-92
XX-48
2707
S-1160
A15-26
10142
A-33
QQ-45
3627
I-4
S-1074
10759
A14-62
BB-94
DD-55
S-1435
B1-62
W-50
S-1066
10138
H-52
10210
1591
MM-53

.69
.69
.69
.69
.69
.72
.72
.75
.75
.75
.75
.75
.75
.75
.78
.81
.81
.81
.81
.81
.81
.84
.84
.88
.88
.88
.91
.94
.94
1.00
1.00
1.00
1.00
1.00
1.09
1.13
1.13
1.13
1.16
1.19
1.19
1.19
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.31
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.44
1.44
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.63
1.63
1.66

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

17.4
17.4
17.4
17.4
17.4
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
20.6
20.6
20.6
20.6
20.6
20.6
21.4
21.4
22.2
22.2
22.2
23.0
23.8
23.8
25.4
25.4
25.4
25.4
25.4
27.8
28.6
28.6
28.6
29.4
30.2
30.2
30.2
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
33.3
34.1
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
36.5
36.5
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
41.3
41.3
42.1

I.D.
Inches

.498
.486
.470
.452
.434
.476
.468
.466
.456
.454
.434
.422
.420
.402
.434
.504
.464
.456
.422
.418
.356
.482
.464
.422
.402
.402
.416
.484
.452
.472
.456
.438
.434
.412
.426
.468
.422
.366
.488
.484
.470
.470
.452
.434
.422
.476
.490
.456
.454
.452
.452
.438
.362
.458
.436
.498
.472
.472
.422
.422
.418
.418
.418
.402
.376
.482
.466
.452
.418
.488
.486
.470
.466
.464
.438
.422
.386
.402
.398
.426

RATE
mm

12.6
12.3
11.9
11.5
11.0
12.1
11.9
11.8
11.6
11.5
11.0
10.7
10.7
10.2
11.0
12.8
11.8
11.6
10.7
10.6
9.0
12.2
11.8
10.7
10.2
10.2
10.6
12.3
11.5
12.0
11.6
11.1
11.0
10.5
10.8
11.9
10.7
9.3
12.4
12.3
11.9
11.9
11.5
11.0
10.7
12.1
12.4
11.6
11.5
11.5
11.5
11.1
9.2
11.6
11.1
12.6
12.0
12.0
10.7
10.7
10.6
10.6
10.6
10.2
9.6
12.2
11.8
11.5
10.6
12.4
12.3
11.9
11.8
11.8
11.1
10.7
9.8
10.2
10.1
10.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

.79
1.9
7.2
14
39
8.1
11
14
19
6.4
42
36
67
121
36
.55
7.9
14
65
55
319
1.9
10
47
90
84
61
2.1
7.5
5.9
12
18
29
59
32
5.7
37
126
1.3
.62
4.8
4.1
7.0
20
28
2.0
.52
12
11
6.9
11
15
96
8.0
14
.52
2.0
3.9
30
25
48
33
27
48
96
1.2
2.9
5.4
31
1.5
.94
4.4
6.3
3.4
5.9
27
51
40
61
23

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.14
.33
1.3
2.5
6.8
1.4
2.0
2.5
3.3
1.1
7.3
6.3
12
21
6.2
.10
1.4
2.4
11
9.6
56
.34
1.8
8.2
16
15
11
.37
1.3
1.0
2.1
3.1
5.1
10
5.7
.99
6.6
22
.23
.11
.84
.71
1.2
3.5
5.0
.34
.09
2.1
2.0
1.2
1.9
2.6
17
1.4
2.5
.09
.36
.69
5.2
4.4
8.4
5.8
4.7
8.5
17
.22
.51
.94
5.4
.25
.16
.77
1.1
.60
1.0
4.7
8.9
7.1
11
4.0

.54
.49
.51
.41
.28
.38
.35
.32
.35
.24
.26
.35
.34
.19
.31
.68
.57
.44
.22
.29
.15
.60
.45
.31
.24
.25
.29
.75
.44
.57
.51
.55
.40
.33
.44
.75
.41
.31
.92
.64
.77
.91
.72
.58
.52
.86
.87
.55
.58
.77
.63
.66
.15
.71
.73
1.1
.93
.86
.52
.58
.36
.52
.63
.47
.39
1.0
.98
.80
.55
1.2
1.1
.83
.72
1.1
.58
.58
.54
.57
.41
.58

mm

14
12
13
10
7.1
9.7
8.9
8.2
8.8
6.2
6.6
8.8
8.6
4.8
7.8
17
14
11
5.7
7.5
3.9
15
11
8.0
6.0
6.5
7.4
19
11
15
13
14
10
8.5
11
19
11
7.8
23
16
20
23
18
15
13
22
22
14
15
20
16
17
3.7
18
19
29
24
22
13
15
9.1
13
16
12
9.8
26
25
20
14
30
29
21
18
28
15
15
14
14
10
15

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.42
.93
3.7
5.7
11
3.1
4.0
4.6
6.5
1.6
11
13
23
23
11
.37
4.5
6.1
15
16
49
1.1
4.6
15
21
21
18
1.6
3.3
3.4
6.1
9.7
12
20
14
4.2
16
39
1.2
.39
3.7
3.7
5.0
12
15
1.7
.45
6.5
6.5
5.3
6.9
9.7
14
5.7
10
.59
1.9
3.4
16
15
17
17
17
23
37
1.3
2.8
4.3
17
1.7
1.1
3.7
4.6
3.7
3.5
16
27
23
25
13

1.9
4.1
16
25
48
14
18
20
29
7.0
48
56
101
102
48
1.7
20
27
65
71
218
5.1
20
65
95
95
79
7.1
15
15
27
43
51
87
63
19
69
173
5.4
1.8
16
16
22
51
65
7.5
2.0
29
29
24
31
43
62
25
46
2.6
8.5
15
69
65
76
76
76
102
165
5.6
13
19
76
7.6
4.8
16
20
17
15
69
122
102
110
59

Inches

.15
.20
.18
.28
.27
.14
.16
.20
.20
.51
.31
.40
.32
.36
.28
.14
.25
.23
.28
.35
.57
.25
.19
.34
.40
.41
.37
.19
.49
.22
.25
.38
.34
.44
.42
.25
.43
.81
.23
.55
.24
.27
.47
.45
.48
.36
.39
.27
.32
.48
.35
.43
1.10
.34
.55
.23
.44
.28
.51
.53
.42
.54
.64
.76
.85
.38
.46
.63
.58
.22
.36
.25
.26
.41
.92
.62
.96
.79
.65
.50

mm

Inches

3.8
5.0
4.6
7.2
6.8
3.6
4.0
5.1
5.1
12.9
7.8
10.2
8.0
9.1
7.1
3.5
6.2
5.7
7.1
8.9
14.5
6.3
4.9
8.7
10.1
10.5
9.5
4.7
12.5
5.6
6.3
9.6
8.7
11.1
10.7
6.4
11.0
20.6
5.9
14.0
6.0
6.8
11.9
11.4
12.2
9.1
9.8
6.9
8.2
12.1
9.0
11.0
28.0
8.7
14.0
5.8
11.3
7.0
13.0
13.4
10.6
13.8
16.3
19.2
21.6
9.8
11.7
16.1
14.6
5.5
9.1
6.3
6.6
10.4
23.3
15.7
24.4
20.1
16.5
12.6

0.024
0.030
0.038
0.047
0.056
0.035
0.039
0.040
0.045
0.046
0.056
0.062
0.063
0.072
0.056
0.021
0.041
0.045
0.062
0.064
0.095
0.032
0.041
0.062
0.072
0.072
0.065
0.031
0.047
0.037
0.045
0.054
0.056
0.067
0.060
0.039
0.062
0.090
0.029
0.031
0.038
0.038
0.047
0.056
0.062
0.035
0.028
0.045
0.046
0.047
0.047
0.054
0.092
0.044
0.055
0.024
0.037
0.037
0.062
0.062
0.064
0.064
0.064
0.072
0.085
0.032
0.040
0.047
0.064
0.029
0.030
0.038
0.040
0.041
0.054
0.062
0.080
0.072
0.074
0.060

mm

TOTAL
MATL
COILS

0.6
0.8
1.0
1.2
1.4
0.9
1.0
1.0
1.1
1.2
1.4
1.6
1.6
1.8
1.4
0.5
1.0
1.1
1.6
1.6
2.4
0.8
1.0
1.6
1.8
1.8
1.7
0.8
1.2
0.9
1.1
1.4
1.4
1.7
1.5
1.0
1.6
2.3
0.7
0.8
1.0
1.0
1.2
1.4
1.6
0.9
0.7
1.1
1.2
1.2
1.2
1.4
2.3
1.1
1.4
0.6
0.9
0.9
1.6
1.6
1.6
1.6
1.6
1.8
2.2
0.8
1.0
1.2
1.6
0.7
0.8
1.0
1.0
1.0
1.4
1.6
2.0
1.8
1.9
1.5

6.25
6.50
4.75
6.00
4.75
4.00
4.00
4.00
4.50
10.0
4.50
6.50
5.00
5.00
5.00
5.50
6.00
5.00
4.50
5.50
6.00
7.75
4.75
5.50
5.50
5.75
5.75
6.00
9.50
5.00
5.50
7.00
6.00
6.50
7.00
6.50
7.00
9.00
7.00
17.8
6.25
7.00
9.00
8.00
7.75
10.3
12.8
6.00
6.00
9.00
6.50
8.00
12.0
6.75
9.00
8.50
12.0
6.50
8.25
8.50
6.50
8.50
10.0
9.50
10.0
11.0
10.5
12.5
9.00
6.50
11.0
6.50
6.50
10.0
17.0
9.00
12.0
11.0
8.75
8.25

MW
MW
SST
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SST
MW
HD
SST
MW
SPR
SST
SST
SST
SPR
HD
SST
SST
SST
SST
SPR
SST
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
MW
SST
SST
SST
SPR
SST
SPR
SST
SPR
SST
SST
SST
SST
SST
SST
SST
MW
SPR
SST
HD
SST
SPR
SPR
SPR
HD
HD
SPR
SST
SPR
SPR
SST
MW
SST
SPR
SST
SST
HD
SST
SPR
SPR
SST

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
C
C
C
CG
CG
C
C
C
CG
C
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG

Z
BO
N
N
N
N
N
N
GI
Z
N
N
Z
Z
N
Z
Z
N
N
N
Z
N
N
N
N
N
GI
N
Z
N
N
N
GI
Z
GI
Z
N
N
N
N
N
N
N
Z
N
Z
N
N
N
N
N
N
N
N
N
Z
N
N
Z
N
GI
Z
Z
Z
Z
N
N
Z
GI
N
N
N
Z
N
N
Z
N
Z
Z
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

131

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 132

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.546
0.551
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562

13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
13.87
14.00
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27

10587
12238
S-972
G-46
S-78
12280
11474
N-118
12217
3817
S-325
Q-44
11650
12309
S-200
J-35
WW-37
12049
UU-57
11593
2595
12291
B17-197
A14-70
11626
4003
B3-62
S-209
A9-35
S-221
2956
JJ-38
II-20
3253
S-1459
JJ-8
K-19
DD-89
A15-43
S-1529
U-61
S-436
B1-32
S-1350
Q-48
B15-33
12685
3990
S-219
12750
S-33
U-32
B-6
S-921
S-1548
3197
4189
BB-68
S-1138
LL-84
S-3121
S-32
XX-40
S-22
3975
B11-58
Z-30
10649
S-87
10128
H-49
J-37
TT-66
N-136
2535
10352
10820
3799
3315
JJ-75

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

1.69
1.69
1.69
1.75
1.75
1.78
1.78
1.81
1.84
1.88
1.94
2.00
2.00
2.09
2.13
2.22
2.50
2.56
2.63
2.81
2.94
3.19
4.06
4.50
5.25
19.0
3.44
.31
.31
.31
.34
.41
.41
.47
.50
.50
.50
.50
.53
.53
.53
.53
.59
.63
.63
.63
.63
.63
.63
.63
.66
.66
.66
.66
.69
.72
.72
.75
.75
.75
.75
.75
.75
.75
.75
.81
.81
.81
.81
.88
.88
.88
.88
.91
.91
.94
.94
.94
.94
.94

mm

42.8
42.8
42.8
44.5
44.5
45.2
45.2
46.0
46.8
47.6
49.2
50.8
50.8
53.2
54.0
56.4
63.5
65.1
66.7
71.4
74.6
81.0
103.2
114.3
133.4
482.6
87.3
7.9
7.9
7.9
8.7
10.3
10.3
11.9
12.7
12.7
12.7
12.7
13.5
13.5
13.5
13.5
15.1
15.9
15.9
15.9
15.9
15.9
15.9
15.9
16.7
16.7
16.7
16.7
17.4
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6
22.2
22.2
22.2
22.2
23.0
23.0
23.8
23.8
23.8
23.8
23.8

MATERIAL: MW - Music Wire

132

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.456
.446
.388
.464
.412
.494
.446
.376
.472
.362
.452
.466
.352
.354
.402
.364
.470
.452
.446
.386
.434
.446
.412
.420
.456
.422
.301
.472
.460
.452
.512
.468
.402
.452
.518
.502
.478
.438
.458
.446
.442
.434
.448
.530
.512
.502
.500
.446
.438
.438
.468
.460
.418
.376
.434
.498
.438
.520
.506
.504
.502
.478
.470
.418
.402
.516
.514
.462
.460
.454
.438
.428
.352
.502
.428
.494
.482
.478
.448
.442

RATE
mm

11.6
11.3
9.9
11.8
10.5
12.5
11.3
9.6
12.0
9.2
11.5
11.8
8.9
9.0
10.2
9.2
11.9
11.5
11.3
9.8
11.0
11.3
10.5
10.7
11.6
10.7
7.6
12.0
11.7
11.5
13.0
11.9
10.2
11.5
13.2
12.8
12.1
11.1
11.6
11.3
11.2
11.0
11.4
13.5
13.0
12.8
12.7
11.3
11.1
11.1
11.9
11.7
10.6
9.6
11.0
12.6
11.1
13.2
12.9
12.8
12.8
12.1
11.9
10.6
10.2
13.1
13.1
11.7
11.7
11.5
11.1
10.9
8.9
12.8
10.9
12.5
12.2
12.1
11.4
11.2

Lbs./In.

4.6
9.2
43
1.6
25
.36
9.2
81
2.6
110
3.9
1.7
108
103
40
73
4.6
5.4
5.9
36
8.0
4.1
14
8.6
1.7
1.8
245
25
58
72
1.0
36
263
58
.68
3.0
16
99
23
40
75
113
59
.17
1.6
2.7
3.9
39
74
74
18
22
119
308
62
2.2
49
.51
1.8
.99
1.7
10
9.1
58
175
.64
.56
17
21
13
42
60
398
.79
68
2.6
3.3
4.0
17
37

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

.81
1.6
7.6
.28
4.3
.06
1.6
14
.45
19
.67
.29
19
18
7.0
13
.80
.94
1.0
6.4
1.4
.72
2.5
1.5
.30
.31
43
4.4
10
13
.18
6.4
46
10
.12
.53
2.8
17
4.1
7.0
13
20
10
.03
.28
.48
.68
6.8
13
13
3.2
3.8
21
54
11
.39
8.5
.09
.32
.17
.29
1.8
1.6
10
31
.11
.10
2.9
3.7
2.3
7.4
10
70
.14
12
.46
.57
.70
2.9
6.4

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

1.2
30
.90 23
.65 16
.93 24
.74 19
1.4
35
.90 23
.46 12
1.4
36
.41 10
1.2
31
1.2
31
.48 12
.49 12
.53 14
.59 15
.86 22
1.4
35
1.4
36
.85 22
1.4
37
2.0
51
1.4
34
1.8
45
3.7
95
8.8 222
.42 11
.11
2.8
.15
3.7
.13
3.4
.18
4.6
.18
4.7
.09
2.2
.18
4.7
.37
9.5
.34
8.7
.29
7.4
.14
3.7
.27
6.9
.26
6.5
.17
4.4
.14
3.5
.20
5.1
.53 13
.50 13
.46 12
.47 12
.32
8.1
.19
4.9
.19
4.9
.37
9.4
.37
9.4
.19
4.7
.14
3.4
.25
6.4
.51 13
.31
7.9
.62 16
.59 15
.47 12
.54 14
.46 12
.45 11
.25
6.2
.17
4.4
.65 17
.63 16
.48 12
.38
9.6
.39
9.9
.36
9.0
.32
8.1
.15
3.8
.56 14
.39
9.8
.67 17
.58 15
.52 13
.43 11
.37
9.5

Lbs.

5.5
8.3
28
1.5
18
.49
8.3
37
3.6
45
4.7
2.1
52
50
21
43
3.9
7.4
8.3
31
12
8.3
20
15
6.5
16
102
2.8
8.5
9.5
.19
6.7
23
11
.25
1.0
4.6
14
6.3
10
13
16
12
.09
.79
1.3
1.8
12
14
14
6.7
8.0
22
42
16
1.1
15
.32
1.1
.46
.91
4.8
4.1
14
30
.42
.35
8.0
8.0
5.2
15
19
59
.44
26
1.7
1.9
2.1
7.2
14

ENDS: C - Closed

G - Ground
O - Open

24
37
125
6.7
82
2.2
37
165
16
199
21
9.2
231
224
95
192
17
33
37
138
51
37
87
68
29
69
453
12
38
42
.83
30
101
47
1.1
4.6
21
63
28
46
58
70
53
.39
3.5
5.6
8.1
55
63
63
30
36
99
185
70
5.1
67
1.4
4.8
2.1
4.0
21
18
64
135
1.9
1.6
36
36
23
67
85
262
2.0
117
7.7
8.4
9.2
32
61

Inches

mm

.50 12.6
.50 12.7
1.03 26.1
.82 20.8
.82 20.8
.42 10.6
.55 14.0
.98 24.8
.41 10.3
1.10 28.0
.71 17.9
.76 19.3
1.46 37.0
1.44 36.6
.79 20.1
1.48 37.6
.30
7.7
.59 14.9
.73 18.4
1.52 38.6
.95 24.2
1.05 26.7
1.36 34.5
1.43 36.4
1.31 33.1
6.73 170.9
2.56 65.1
.20
5.1
.17
4.2
.18
4.5
.16
4.1
.20
5.1
.32
8.1
.21
5.2
.13
3.2
.16
4.0
.21
5.3
.22
5.5
.26
6.6
.28
7.0
.23
5.7
.22
5.7
.23
5.8
.10
2.4
.13
3.2
.17
4.2
.16
3.9
.30
7.7
.25
6.3
.31
7.9
.21
5.4
.26
6.5
.34
8.7
.47 11.8
.30
7.7
.21
5.3
.34
8.7
.13
3.2
.16
4.1
.28
7.2
.21
5.3
.20
5.0
.30
7.6
.50 12.8
.40 10.2
.16
4.1
.19
4.7
.30
7.6
.31
7.8
.49 12.3
.37
9.4
.47 11.9
.63 16.0
.35
8.8
.37
9.4
.27
6.9
.36
9.1
.42 10.7
.51 13.0
.36
9.1

WIRE DIA.
Inches

mm

0.045
0.050
0.079
0.041
0.067
0.026
0.050
0.085
0.037
0.092
0.047
0.040
0.097
0.096
0.072
0.091
0.038
0.047
0.050
0.080
0.056
0.050
0.067
0.063
0.045
0.062
0.125
0.045
0.051
0.055
0.025
0.047
0.080
0.055
0.022
0.030
0.042
0.062
0.052
0.058
0.060
0.064
0.057
0.016
0.025
0.030
0.031
0.058
0.062
0.062
0.047
0.051
0.072
0.093
0.064
0.032
0.062
0.021
0.028
0.029
0.030
0.042
0.046
0.072
0.080
0.023
0.024
0.050
0.051
0.054
0.062
0.067
0.105
0.030
0.067
0.034
0.040
0.042
0.057
0.060

1.1
1.3
2.0
1.0
1.7
0.7
1.3
2.2
0.9
2.3
1.2
1.0
2.5
2.4
1.8
2.3
1.0
1.2
1.3
2.0
1.4
1.3
1.7
1.6
1.1
1.6
3.2
1.1
1.3
1.4
0.6
1.2
2.0
1.4
0.6
0.8
1.1
1.6
1.3
1.5
1.5
1.6
1.4
0.4
0.6
0.8
0.8
1.5
1.6
1.6
1.2
1.3
1.8
2.4
1.6
0.8
1.6
0.5
0.7
0.7
0.8
1.1
1.2
1.8
2.0
0.6
0.6
1.3
1.3
1.4
1.6
1.7
2.7
0.8
1.7
0.9
1.0
1.1
1.4
1.5

FINISH: Z - Zinc

TOTAL
MATL
COILS
11.0
10.0
13.0
19.0
11.3
15.0
10.0
11.5
10.0
12.0
15.0
19.0
15.0
15.0
10.0
16.3
7.00
12.5
14.5
18.0
17.0
20.0
20.3
22.8
29.0
107.0
20.5
3.50
3.25
3.25
5.50
3.25
4.00
3.75
4.75
4.25
4.00
3.50
5.00
4.75
3.75
3.50
4.00
5.00
4.00
4.50
4.00
5.25
4.00
4.00
4.50
5.00
4.75
5.00
4.75
6.50
5.50
5.00
4.75
8.75
6.00
4.67
6.50
7.00
5.00
6.00
6.75
6.00
5.00
9.00
6.00
6.00
6.00
10.5
5.50
7.00
9.00
10.0
9.00
6.00

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SST
SST
SST
MW
SPR
SPR
SPR
HD
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
HD
SPR
SST
SPR
SST
MW
SST
SPR
SPR
SST
SST
SPR
SST
SST
SST
SST
SST
SPR
SST
SST
SST
SST
SPR
SST
SST
SST
SST
SPR
SST
SST
SPR
HD
SST
SST
MW
SST
SST
SST
SST
SPR
MW
SST
SPR
SST
SPR
SPR
SPR
SST
SST
MW
SPR
SST
SPR
SPR
SPR

E
N
D
S

CG
CG
CG
C
C
C
C
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
CG
C
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
C
C
CG
C
CG
CG
C
CG
C
CG
C
CG
CG
CG
CG

F
N
S
H

N
Z
N
N
N
Z
Z
Z
Z
Z
N
N
Z
Z
N
N
N
N
Z
GI
GI
N
Z
N
Z
Z
N
N
Z
N
Z
N
N
Z
N
N
GI
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
Z
Z
N
N
N
N
N
N
N
Z
Z
N
Z
N
N
GI
Z
N
N
GI
Z
N
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 133

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562

14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27

10217
3222
12660
L-19
10343
S-1141
S-1028
S-1305
Y-27
S-1027
3881
S-358
12294
11747
515
S-3128
3578
A14-33
11544
S-1242
2750
10950
S-801
A11-50
830
B14-68
O-89
10047
B9-34
12561
WW-40
3871
DD-87
S-1534
S-1369
3563
S-925
S-1303
3822
10103
3019
12403
12026
Y-19
1943
10246
S-861
3886
S-421
29
Q-29
S-1691
Y-22
S-819
3204
A9-29
G-44
11365
2800
S-1129
3851
2925
B14-62
3731
2941
TT-53
3983
2722
S-115
12593
12333
2873
A13-44
B18-168
2639
S-170
3716
12659
3218
V V-60

.94
.97
.98
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.06
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.13
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.31
1.34
1.34
1.34
1.38
1.38
1.38
1.38
1.38
1.38
1.38
1.41
1.41
1.41
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.56
1.63
1.63
1.63
1.63
1.66
1.66
1.69
1.72
1.75
1.75
1.75
1.75
1.78
1.81
1.81
1.81
1.88

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

23.8
24.6
25.0
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.0
28.6
28.6
28.6
28.6
28.6
28.6
28.6
28.6
31.0
31.8
31.8
31.8
31.8
31.8
31.8
33.3
34.1
34.1
34.1
34.9
34.9
34.9
34.9
34.9
34.9
34.9
35.7
35.7
35.7
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
39.7
41.3
41.3
41.3
41.3
42.1
42.1
42.8
43.6
44.5
44.5
44.5
44.5
45.2
46.0
46.0
46.0
47.6

I.D.
Inches

.428
.510
.510
.502
.494
.494
.492
.488
.482
.468
.466
.464
.458
.456
.454
.454
.452
.452
.426
.418
.402
.400
.438
.492
.352
.518
.516
.512
.478
.462
.410
.402
.402
.388
.522
.512
.478
.474
.466
.460
.402
.512
.398
.352
.512
.510
.460
.452
.436
.418
.378
.526
.512
.418
.504
.400
.506
.480
.456
.442
.438
.402
.502
.512
.510
.460
.438
.492
.428
.422
.458
.502
.478
.404
.380
.428
.508
.480
.478
.502

RATE
mm

10.9
13.0
13.0
12.8
12.5
12.5
12.5
12.4
12.2
11.9
11.8
11.8
11.6
11.6
11.5
11.5
11.5
11.5
10.8
10.6
10.2
10.2
11.1
12.5
8.9
13.2
13.1
13.0
12.1
11.7
10.4
10.2
10.2
9.9
13.3
13.0
12.1
12.0
11.8
11.7
10.2
13.0
10.1
8.9
13.0
13.0
11.7
11.5
11.1
10.6
9.6
13.4
13.0
10.6
12.8
10.2
12.9
12.2
11.6
11.2
11.1
10.2
12.8
13.0
13.0
11.7
11.1
12.5
10.9
10.7
11.6
12.8
12.1
10.3
9.7
10.9
12.9
12.2
12.1
12.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

60
1.2
1.1
1.9
2.6
3.0
3.2
5.4
7.4
11
14
15
20
14
22
16
22
21
57
71
78
110
26
2.9
318
.43
.51
.73
4.5
11
70
88
131
134
.31
.40
4.9
7.9
10
12
70
.56
78
262
.56
.34
7.9
13
25
45
108
.03
.63
38
.53
68
.45
2.2
7.2
15
23
58
1.9
.48
.33
5.3
17
1.9
23
31
13
.61
3.4
52
94
23
.39
1.7
3.9
1.1

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

10
.21
.20
.34
.46
.53
.56
.95
1.3
1.9
2.5
2.7
3.5
2.5
3.8
2.8
3.9
3.6
9.9
13
14
19
4.6
.52
56
.07
.09
.13
.80
2.0
12
15
23
23
.05
.07
.86
1.4
1.8
2.1
12
.10
14
46
.10
.06
1.4
2.2
4.4
7.9
19
.01
.11
6.6
.09
12
.08
.38
1.3
2.6
4.0
10
.34
.08
.06
.92
3.0
.33
4.0
5.3
2.3
.11
.60
9.1
17
4.0
.07
.30
.69
.19

Inches

.32
.80
.81
.79
.73
.77
.79
.61
.60
.63
.54
.50
.46
.58
.47
.58
.64
.48
.35
.29
.38
.27
.54
.78
.20
.95
.94
.93
.75
.68
.37
.35
.23
.27
1.1
.95
.88
.70
.75
.70
.43
1.1
.41
.24
1.1
.97
.87
.77
.59
.49
.37
.87
1.2
.56
.98
.43
1.1
.90
.76
.86
.67
.52
1.4
1.4
1.2
.91
.88
1.3
.77
.67
.68
1.3
1.3
.53
.63
.77
1.4
1.0
1.3
1.6

mm

8.1
20
21
20
18
20
20
16
15
16
14
13
12
15
12
15
16
12
8.9
7.4
9.6
6.8
14
20
5.1
24
24
23
19
17
9.5
8.8
5.8
6.9
28
24
22
18
19
18
11
28
11
6.2
29
25
22
20
15
12
9.5
22
31
14
25
11
27
23
19
22
17
13
34
35
31
23
22
33
20
17
17
32
34
13
16
20
35
26
33
40

ENDS: C - Closed

G - Ground
O - Open

Lbs.

19

85
4.3
4.1
6.8
8.5
10
11
15
20
30
34
34
40
37
45
42
64
45
88
93
131
131
63
10
283
1.8
2.2
3.0
15
33
116
135
135
161
1.6
1.7
19
25
34
38
135
2.7
145
283
2.8
1.4
30
43
66
99
180
.12
3.4
93
2.3
131
2.1
8.6
24
58
67
135
12
2.9
1.8
21
67
11
80
91
40
3.4
20
122
262
80
2.4
7.8
23
7.7

.97
.92
1.5
1.9
2.3
2.5
3.3
4.4
6.7
7.6
7.6
9.0
8.3
10
9.5
14
10
20
21
29
29
14
2.3
64
.41
.48
.68
3.4
7.5
26
30
30
36
.35
.38
4.3
5.5
7.6
8.5
30
.62
33
64
.63
.32
6.9
9.7
15
22
40
.03
.76
21
.52
29
.47
1.9
5.4
13
15
30
2.6
.66
.40
4.8
15
2.5
18
21
9.0
.77
4.5
27
59
18
.54
1.7
5.1
1.7

Inches

.40
.17
.18
.21
.27
.23
.21
.19
.22
.29
.29
.27
.31
.42
.40
.38
.36
.35
.51
.43
.62
.53
.48
.28
.81
.18
.18
.20
.38
.45
.61
.64
.48
.61
.14
.30
.37
.28
.36
.41
.76
.24
.78
.95
.24
.41
.51
.61
.52
.74
.92
.54
.20
.70
.46
.75
.45
.60
.74
.63
.59
.88
.21
.26
.41
.71
.74
.34
.74
.88
.42
.47
.43
.83
1.09
.80
.43
.78
.47
.30

mm

Inches

10.2
4.3
4.5
5.3
6.9
5.8
5.3
4.7
5.6
7.5
7.3
6.8
7.9
10.8
10.1
9.6
9.1
8.8
13.0
11.0
15.8
13.4
12.2
7.1
20.7
4.5
4.7
5.1
9.6
11.4
15.4
16.3
12.2
15.5
3.6
7.7
9.3
7.0
9.1
10.4
19.3
6.0
19.8
24.0
6.0
10.4
13.0
15.4
13.2
18.7
23.4
13.6
5.1
17.8
11.6
19.0
11.4
15.4
18.8
16.0
15.0
22.4
5.3
6.7
10.5
18.1
18.9
8.7
18.7
22.2
10.6
12.0
10.9
21.1
27.7
20.4
10.9
19.8
11.9
7.6

0.067
0.026
0.026
0.030
0.034
0.034
0.035
0.037
0.040
0.047
0.048
0.049
0.052
0.053
0.054
0.054
0.055
0.055
0.068
0.072
0.080
0.081
0.062
0.035
0.105
0.022
0.023
0.025
0.042
0.050
0.076
0.080
0.080
0.087
0.020
0.025
0.042
0.044
0.048
0.051
0.080
0.025
0.082
0.105
0.025
0.026
0.051
0.055
0.063
0.072
0.092
0.018
0.025
0.072
0.029
0.081
0.028
0.041
0.053
0.060
0.062
0.080
0.030
0.025
0.026
0.051
0.062
0.035
0.067
0.070
0.052
0.030
0.042
0.079
0.091
0.067
0.027
0.041
0.042
0.030

mm

TOTAL
MATL
COILS

1.7
0.7
0.7
0.8
0.9
0.9
0.9
0.9
1.0
1.2
1.2
1.2
1.3
1.3
1.4
1.4
1.4
1.4
1.7
1.8
2.0
2.1
1.6
0.9
2.7
0.6
0.6
0.6
1.1
1.3
1.9
2.0
2.0
2.2
0.5
0.6
1.1
1.1
1.2
1.3
2.0
0.6
2.1
2.7
0.6
0.7
1.3
1.4
1.6
1.8
2.3
0.5
0.6
1.8
0.7
2.1
0.7
1.0
1.3
1.5
1.6
2.0
0.8
0.6
0.7
1.3
1.6
0.9
1.7
1.8
1.3
0.8
1.1
2.0
2.3
1.7
0.7
1.0
1.1
0.8

6.00
5.50
5.75
6.00
7.00
5.75
6.00
5.00
5.50
6.25
6.00
5.50
6.00
8.00
6.33
7.00
6.50
6.33
6.50
6.00
8.00
6.50
7.75
7.00
7.75
7.00
7.00
7.00
9.00
8.00
8.00
8.00
6.00
7.00
6.00
11.0
7.75
6.25
7.50
8.00
9.50
8.50
9.50
9.00
8.50
14.8
10.0
10.0
8.25
9.25
10.0
28.8
7.00
9.75
14.8
9.25
15.0
13.8
14.0
10.5
9.50
11.0
6.00
9.50
15.0
14.0
12.0
9.75
11.0
11.5
8.00
14.8
10.3
10.5
12.0
11.0
15.0
19.0
10.0
9.00

SPR
MW
MW
MW
SPR
SST
SST
SST
SPR
SST
SPR
SST
SPR
SPR
HD
SST
MW
SST
SPR
SST
HD
SST
SST
SPR
HD
MW
MW
MW
SPR
SPR
SPR
HD
SPR
SST
SST
MW
SST
SST
SPR
SPR
SPR
MW
SPR
SPR
MW
MW
SST
SPR
SST
HD
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
HD
SPR
MW
MW
MW
SST
SPR
MW
SST
SPR
SPR
MW
SST
SST
MW
SST
MW
SPR
SPR
MW

E
N
D
S

CG
C
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
C
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
C
C
CG
C
CG
C
CG
C
C
CG
C
CG
C
C
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
CG
C
C

F
N
S
H

Z
Z
GI
Z
Z
N
N
N
Z
N
GI
N
Z
Z
Z
N
Z
N
N
N
Z
N
N
Z
Z
Z
N
Z
Z
N
Z
Z
N
N
N
GI
N
N
Z
Z
Z
N
N
Z
Z
Z
N
Z
N
Z
N
N
N
N
Z
N
N
N
Z
N
Z
Z
N
Z
Z
N
Z
Z
N
N
Z
Z
N
N
Z
N
Z
Z
Z
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

133

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 134

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.562
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578

14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.27
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68

S-1172
10927
B2-55
B14-19
12607
11748
11440
10066
B11-46
2898
11874
B8-48
11568
3556
10337
4368
S-1219
3969
887
10563
4372
11209
12597
10308
11279
2987
20
11580
S-1107
3695
12601
1813
2737
1887
3438
S-1176
11287
10342
10234
10786
10385
10296
4166
4392
L-20
WW-69
S-1103
BB-80
Z-99
10394
I-41
G-32
2718
B14-2
3659
J-15
A-45
12200
12329
3513
A9-49
10929
2960
S-1064
Y-38
S-1330
12662
RR-63
10826
12740
B3-45
Q-34
S-1656
11373
S-818
10881
I-43
S-1041
B9-67
OO-55

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

1.88
1.88
1.88
1.88
2.00
2.00
2.00
2.00
2.00
2.06
2.09
2.16
2.22
2.25
2.31
2.31
2.38
2.38
2.38
2.44
2.44
2.63
2.70
2.75
2.75
2.94
3.00
3.09
3.13
3.16
3.50
3.50
3.75
3.75
4.00
4.44
4.50
4.88
5.25
5.50
10.0
10.0
12.8
15.0
.47
.50
.50
.59
.63
.66
.69
.75
.75
.75
.75
.81
.81
.88
.88
.91
.91
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.13
1.13
1.19
1.25
1.25
1.25
1.28

mm

47.6
47.6
47.6
47.6
50.8
50.8
50.8
50.8
50.8
52.4
53.2
54.8
56.4
57.2
58.7
58.7
60.3
60.3
60.3
61.9
61.9
66.7
68.6
69.9
69.9
74.6
76.2
78.6
79.4
80.2
88.9
88.9
95.3
95.3
101.6
112.7
114.3
123.8
133.4
139.7
254.0
254.0
323.9
381.0
11.9
12.7
12.7
15.1
15.9
16.7
17.4
19.1
19.1
19.1
19.1
20.6
20.6
22.2
22.2
23.0
23.0
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
28.6
28.6
30.2
31.8
31.8
31.8
32.5

MATERIAL: MW - Music Wire

134

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.462
.432
.422
.384
.490
.460
.438
.412
.412
.502
.452
.362
.458
.426
.428
.394
.482
.472
.402
.388
.336
.502
.338
.418
.366
.278
.454
.448
.434
.462
.384
.302
.418
.352
.368
.374
.448
.402
.322
.422
.438
.432
.460
.460
.494
.516
.502
.418
.538
.410
.388
.524
.518
.484
.474
.454
.418
.514
.430
.460
.428
.526
.520
.520
.510
.508
.508
.506
.504
.502
.448
.458
.456
.496
.428
.398
.512
.482
.444
.478

RATE
mm

11.7
11.0
10.7
9.8
12.4
11.7
11.1
10.5
10.5
12.8
11.5
9.2
11.6
10.8
10.9
10.0
12.2
12.0
10.2
9.9
8.5
12.8
8.6
10.6
9.3
7.1
11.5
11.4
11.0
11.7
9.8
7.7
10.6
8.9
9.3
9.5
11.4
10.2
8.2
10.7
11.1
11.0
11.7
11.7
12.5
13.1
12.8
10.6
13.7
10.4
9.9
13.3
13.2
12.3
12.0
11.5
10.6
13.1
10.9
11.7
10.9
13.4
13.2
13.2
13.0
12.9
12.9
12.9
12.8
12.8
11.4
11.6
11.6
12.6
10.9
10.1
13.0
12.2
11.3
12.1

Lbs./In.

7.3
21
48
85
2.1
6.1
15
39
33
.61
7.2
112
7.2
20
22
56
1.3
5.3
38
50
192
.61
177
23
74
563
6.3
9.1
9.4
3.7
41
272
14
109
58
48
4.8
18
113
7.8
3.9
4.8
1.3
1.3
25
2.0
9.5
138
.15
237
320
.65
2.4
16
29
52
104
3.1
84
42
71
1.2
1.0
1.8
2.6
3.3
4.5
5.1
4.5
5.4
35
24
26
3.3
63
130
2.3
4.2
24
6.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

1.3
3.8
8.5
15
.36
1.1
2.6
6.9
5.8
.11
1.3
20
1.3
3.5
3.8
9.8
.23
.93
6.6
8.7
34
.11
31
4.1
13
99
1.1
1.6
1.7
.65
7.1
48
2.4
19
10
8.3
.84
3.1
20
1.4
.68
.83
.24
.24
4.4
.36
1.7
24
.03
42
56
.11
.41
2.7
5.1
9.0
18
.54
15
7.3
13
.20
.18
.31
.46
.59
.79
.89
.79
.95
6.1
4.2
4.5
.58
11
23
.40
.74
4.2
1.2

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

1.0
26
.81 21
.42 11
.48 12
1.6
41
1.3
33
.94 24
.64 16
.71 18
1.6
40
1.2
31
.49 13
1.3
32
1.2
32
.88 22
.63 16
1.6
40
1.2
30
.81 20
.78 20
.39 10
2.2
55
.42 11
.95 24
.71 18
.24
6.2
1.6
40
1.3
33
1.7
42
2.1
53
1.4
35
.40 10
1.6
41
.81 21
.88 22
.90 23
2.5
62
1.7
44
.79 20
2.6
67
3.9 100
3.7
93
6.3 160
6.3 160
.19
4.7
.28
7.2
.32
8.1
.19
4.9
.41 10
.14
3.6
.15
3.7
.48 12
.57 14
.45 11
.30
7.7
.29
7.3
.27
6.8
.72 18
.28
7.1
.43 11
.34
8.7
.81 21
.74 19
.83 21
.80 20
.77 20
.79 20
.63 16
.75 19
.68 17
.45 11
.53 13
.52 13
.76 19
.36
9.2
.31
7.8
1.0
26
.65 17
.51 13
.78 20

Lbs.

7.6
17
21
41
3.3
7.8
14
25
23
.96
8.8
55
9.0
25
19
35
2.1
6.3
30
39
76
1.3
74
22
52
138
10
12
16
7.8
55
109
22
89
51
43
12
30
90
21
15
17
8.5
8.5
4.7
.57
3.0
27
.06
34
47
.31
1.3
7.0
8.8
15
28
2.2
24
18
24
.94
.76
1.5
2.1
2.6
3.5
3.2
3.4
3.7
15
13
13
2.5
23
40
2.3
2.8
12
5.3

ENDS: C - Closed

G - Ground
O - Open

34
77
91
183
15
35
63
112
105
4.3
39
246
40
111
85
155
9.3
28
135
172
337
5.8
328
99
232
614
45
53
70
35
246
483
99
395
225
191
53
135
398
91
67
77
38
38
21
2.6
13
119
.26
151
207
1.4
6.0
31
39
66
123
9.8
105
79
109
4.2
3.4
6.5
9.4
12
16
14
15
17
69
56
59
11
102
177
10
12
55
24

Inches

.50
.83
.56
1.16
.40
.71
.74
.90
.94
.47
.88
1.50
.73
1.00
.87
1.16
.80
.50
1.36
1.52
1.75
.47
1.90
1.15
1.96
2.27
.96
.91
1.28
1.05
2.14
2.70
1.87
1.97
2.33
2.07
1.57
2.64
3.90
2.73
2.91
2.99
2.91
2.91
.17
.22
.18
.40
.22
.38
.50
.27
.18
.24
.23
.31
.48
.16
.44
.35
.53
.16
.26
.17
.20
.23
.21
.22
.25
.25
.55
.42
.43
.37
.53
.74
.23
.60
.74
.50

mm

12.7
21.1
14.2
29.4
10.1
18.1
18.9
22.9
23.8
12.0
22.4
38.1
18.5
25.5
22.1
29.3
20.3
12.6
34.5
38.7
44.5
12.0
48.4
29.3
49.8
57.7
24.4
23.2
32.5
26.7
54.3
68.5
47.5
50.0
59.1
52.5
39.8
67.1
99.1
69.3
74.0
75.9
73.8
73.8
4.3
5.5
4.6
10.2
5.6
9.6
12.7
6.9
4.6
6.0
5.9
7.9
12.2
4.1
11.3
9.0
13.3
4.0
6.6
4.4
5.2
5.8
5.3
5.5
6.4
6.3
14.0
10.7
10.8
9.4
13.3
18.9
5.9
15.2
18.7
12.7

WIRE DIA.
Inches

0.050
0.065
0.070
0.089
0.036
0.051
0.062
0.075
0.075
0.030
0.055
0.100
0.052
0.068
0.067
0.084
0.040
0.045
0.080
0.087
0.113
0.030
0.112
0.072
0.098
0.142
0.054
0.057
0.064
0.050
0.089
0.130
0.072
0.105
0.097
0.094
0.057
0.080
0.120
0.070
0.062
0.065
0.051
0.051
0.042
0.031
0.038
0.080
0.020
0.084
0.095
0.027
0.030
0.047
0.052
0.062
0.080
0.032
0.074
0.059
0.075
0.026
0.029
0.029
0.034
0.035
0.035
0.036
0.037
0.038
0.065
0.060
0.061
0.041
0.075
0.090
0.033
0.048
0.067
0.050

mm

TOTAL
MATL
COILS

1.3
1.7
1.8
2.3
0.9
1.3
1.6
1.9
1.9
0.8
1.4
2.5
1.3
1.7
1.7
2.1
1.0
1.1
2.0
2.2
2.9
0.8
2.8
1.8
2.5
3.6
1.4
1.4
1.6
1.3
2.3
3.3
1.8
2.7
2.5
2.4
1.4
2.0
3.0
1.8
1.6
1.7
1.3
1.3
1.1
0.8
1.0
2.0
0.5
2.1
2.4
0.7
0.8
1.2
1.3
1.6
2.0
0.8
1.9
1.5
1.9
0.7
0.7
0.7
0.9
0.9
0.9
0.9
0.9
1.0
1.7
1.5
1.5
1.0
1.9
2.3
0.8
1.2
1.7
1.3

10.0
11.8
8.00
12.0
10.0
14.0
12.0
12.0
12.5
14.8
16.0
15.0
13.0
14.8
13.0
13.8
19.0
10.0
16.0
17.5
15.5
14.8
16.0
16.0
20.0
16.0
16.8
15.0
20.0
20.0
23.0
20.8
26.0
18.8
24.0
22.0
26.5
32.0
32.5
39.0
46.0
46.0
56.0
56.0
3.00
6.00
3.75
5.00
11.0
4.50
5.25
9.00
5.00
5.00
4.50
5.00
6.00
5.00
6.00
5.00
7.00
5.00
8.00
5.00
6.00
5.50
5.00
5.00
5.75
5.50
7.50
7.00
7.00
9.00
7.00
8.25
6.00
12.5
10.0
10.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SPR
SPR
MW
SPR
SST
SPR
SST
MW
SPR
SPR
SPR
MW
SPR
SPR
SST
SPR
HD
SPR
SPR
MW
HD
SPR
SPR
SPR
HD
SPR
SST
SPR
MW
SPR
SPR
MW
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
MW
SST
SST
MW
SPR
SPR
MW
MW
SPR
SPR
SPR
SST
SPR
SPR
MW
SPR
SST
MW
SST
SST
SST
MW
SPR
SPR
SPR
MW
SST
SST
SST
SST
SPR
SST
SST
SST
SST

E
N
D
S

CG
C
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
C
C
CG
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
C
C
C
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
C
C
C
C
C
C
CG
CG
CG
CG
CG
C
CG
C
CG

F
N
S
H

N
Z
N
Z
Z
Z
N
Z
N
Z
N
N
N
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
Z
Z
Z
N
Z
Z
Z
N
Z
Z
Z
Z
N
Z
N
N
Z
Z
N
Z
Z
N
GI
Z
N
Z
Z
Z
Z
N
Z
N
N
N
GI
Z
Z
Z
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 135

Inches

mm

CENTURY
STOCK
NUMBER

0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.578
0.590
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593

14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.68
14.99
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06

S-1498
3112
S-139
GG-89
WW-30
A-97
10672
B12-59
4116
S-887
S-199
4321
12209
NN-56
2797
3870
10858
4230
12634
12249
3317
M-92
11888
12231
11317
10382
12299
12214
3200
10419
S-49
10473
12063
S-1453
11313
S-472
2829
10490
10306
10987
10965
S-3041
3345
12296
10087
12081
4187
S-3043
4016
12524
3789
N-51
10334
A-47
NN-92
11341
I-79
3540
3586
10784
2540
3502
10280
Y-66
G-29
3843
11309
10538
S-906
N-130
N-120
S-828
S-872
M-134
3541
B15-19
S-943
S-928
10252
S-62

O.D.

FREE LENGTH
Inches

1.31
1.31
1.34
1.38
1.38
1.41
1.44
1.44
1.50
1.53
1.56
1.63
1.63
1.69
1.75
1.81
1.81
1.88
1.97
2.00
2.00
2.00
2.03
2.03
2.13
2.25
2.28
2.34
2.38
2.38
2.50
2.56
2.59
2.63
2.66
3.13
3.13
3.16
3.31
3.75
3.75
4.75
5.00
5.38
5.38
5.50
7.50
7.63
23.5
1.50
.44
.47
.50
.53
.56
.56
.56
.59
.59
.59
.59
.63
.63
.63
.63
.63
.63
.66
.69
.75
.75
.75
.75
.75
.75
.78
.78
.78
.78
.78

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

33.3
33.3
34.1
34.9
34.9
35.7
36.5
36.5
38.1
38.9
39.7
41.3
41.3
42.8
44.5
46.0
46.0
47.6
50.0
50.8
50.8
50.8
51.6
51.6
54.0
57.2
57.9
59.5
60.3
60.3
63.5
65.1
65.9
66.7
67.5
79.4
79.4
80.2
84.1
95.3
95.3
120.7
127.0
136.5
136.5
139.7
190.5
193.7
596.9
38.1
11.1
11.9
12.7
13.5
14.3
14.3
14.3
15.1
15.1
15.1
15.1
15.9
15.9
15.9
15.9
15.9
15.9
16.7
17.4
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
19.8
19.8
19.8

I.D.
Inches

.478
.468
.526
.450
.328
.338
.438
.396
.470
.398
.488
.470
.434
.398
.338
.488
.448
.474
.506
.484
.428
.266
.430
.428
.378
.496
.418
.478
.518
.444
.396
.454
.482
.434
.434
.516
.484
.422
.368
.368
.358
.454
.438
.462
.454
.454
.458
.454
.408
.386
.497
.499
.459
.393
.523
.503
.483
.503
.491
.473
.449
.529
.503
.503
.485
.483
.465
.419
.453
.517
.515
.513
.499
.453
.433
.509
.485
.465
.423
.409

RATE
mm

12.1
11.9
13.4
11.4
8.3
8.6
11.1
10.1
11.9
10.1
12.4
11.9
11.0
10.1
8.6
12.4
11.4
12.0
12.9
12.3
10.9
6.8
10.9
10.9
9.6
12.6
10.6
12.1
13.2
11.3
10.1
11.5
12.2
11.0
11.0
13.1
12.3
10.7
9.3
9.3
9.1
11.5
11.1
11.7
11.5
11.5
11.6
11.5
10.4
9.8
12.6
12.7
11.7
10.0
13.3
12.8
12.3
12.8
12.5
12.0
11.4
13.4
12.8
12.8
12.3
12.3
11.8
10.6
11.5
13.1
13.1
13.0
12.7
11.5
11.0
12.9
12.3
11.8
10.7
10.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

7.6
1.3
18
3.2
.97
.17
29
5.0
539
94
443
78
34
5.9
131
23
12
2.1
94
16
6.2
1.1
11
1.9
37
6.5
80
14
443
78
4.1
.72
17
3.0
8.3
1.4
1.9
.33
4.3
.75
36
6.3
1259 220
34
5.9
40
7.0
110
19
3.5
.61
37
6.4
6.1
1.1
.55
.10
21
3.6
53
9.3
9.7
1.7
5.1
.90
22
3.9
23
4.1
.61
.11
1.6
.28
28
5.0
86
15
90
16
124
22
4.6
.78
11
1.9
5.4
.94
7.0
1.2
6.2
1.1
4.2
.73
4.2
.74
5.7
1.0
255
45
13
2.4
12
2.2
199
35
800 140
2.4
.42
14
2.5
42
7.4
14
2.5
20
3.6
41
7.2
109
19
2.4
.43
20
3.6
18
3.2
14
2.4
42
7.4
65
11
231
40
70
12
5.2
.91
5.7
.99
8.9
1.6
11
2.0
143
25
145
25
11
1.9
17
2.9
53
9.3
229
40
484
85

Inches

mm

.86 22
.56 14
1.2
30
.53 14
.18
4.6
.20
5.0
.59 15
.31
8.0
.81 21
.39 10
.93 24
.92 23
.58 15
.46 12
.20
5.0
1.3
33
.92 23
1.1
27
1.6
40
1.4
35
.68 17
.13
3.4
.70 18
.62 16
.49 13
1.3
34
.80 20
1.3
33
1.9
48
.90 23
.72 18
1.4
37
1.4
37
.92 23
.93 24
2.7
68
1.6
40
.97 25
.72 18
.69 17
.55 14
2.7
69
1.8
46
2.3
57
2.1
53
2.4
61
3.2
81
3.3
84
6.2 156
.22
5.6
.17
4.4
.21
5.3
.09
2.3
.07
1.7
.30
7.6
.37
9.4
.24
6.1
.35
8.8
.34
8.6
.29
7.4
.19
4.9
.42 11
.29
7.4
.31
7.8
.25
6.3
.24
6.1
.24
6.2
.16
4.0
.26
6.6
.56 14
.56 14
.44 11
.50 13
.13
3.3
.28
7.0
.46 12
.45 11
.28
7.1
.15
3.8
.08
2.0

ENDS: C - Closed

G - Ground
O - Open

Lbs.

6.5
10
1.1
15
98
88
20
41
9.8
37
5.7
9.8
22
37
88
5.3
16
8.8
3.0
5.9
24
170
24
24
54
4.7
30
7.8
1.1
19
38
14
7.4
20
22
1.6
2.5
27
62
62
69
12
20
12
15
15
13
14
35
56
2.3
2.6
18
53
.72
5.2
10
5.0
6.9
12
21
1.0
6.0
5.6
3.4
10
16
37
18
2.9
3.1
4.0
5.7
18
40
4.9
7.5
15
34
39

29
46
5.1
68
437
390
89
183
44
164
26
44
97
164
390
24
71
39
13
26
109
754
105
109
240
21
131
35
4.7
82
170
62
33
90
97
7.3
11
122
276
276
305
54
89
54
66
66
60
62
157
250
10
11
80
235
3.2
23
45
22
31
53
94
4.5
27
25
15
45
70
164
81
13
14
18
26
81
179
22
34
66
153
171

Inches

mm

Inches

.45 11.4
.39
9.8
.17
4.3
.48 12.2
1.13 28.6
1.08 27.4
.68 17.3
.86 22.0
.54 13.7
.86 21.7
.38
9.7
.54 13.7
.72 18.3
.99 25.1
1.08 27.4
.52 13.1
.76 19.4
.61 15.5
.40 10.1
.61 15.5
.90 22.9
1.72 43.6
.89 22.6
.83 21.0
1.40 35.6
.43 10.9
1.20 30.5
.60 15.2
.47 12.0
.91 23.0
1.55 39.3
1.12 28.3
.58 14.6
.99 25.1
1.06 27.0
.45 11.4
1.54 39.1
1.33 33.7
2.23 56.7
2.13 54.0
2.03 51.6
2.05 52.0
1.82 46.2
1.42 36.1
1.55 39.4
1.67 42.5
2.10 53.3
2.17 55.1
9.56 242.9
.74 18.8
.26
6.7
.26
6.6
.27
6.8
.35
8.9
.26
6.7
.19
4.9
.22
5.6
.25
6.3
.26
6.5
.30
7.6
.32
8.2
.21
5.3
.17
4.3
.17
4.3
.38
9.6
.22
5.6
.35
8.9
.41 10.5
.35
8.9
.19
4.8
.20
5.0
.21
5.2
.25
6.4
.32
8.0
.40 10.2
.19
4.8
.33
8.4
.30
7.6
.47 11.9
.32
8.2

0.050
0.055
0.026
0.064
0.125
0.120
0.070
0.091
0.054
0.090
0.045
0.054
0.072
0.090
0.120
0.045
0.065
0.052
0.036
0.047
0.075
0.156
0.074
0.075
0.100
0.041
0.080
0.050
0.030
0.067
0.091
0.062
0.048
0.072
0.072
0.031
0.047
0.078
0.105
0.105
0.110
0.062
0.070
0.058
0.062
0.062
0.060
0.062
0.085
0.102
0.048
0.047
0.067
0.100
0.035
0.045
0.055
0.045
0.051
0.060
0.072
0.032
0.045
0.045
0.054
0.055
0.064
0.087
0.070
0.038
0.039
0.040
0.047
0.070
0.080
0.042
0.054
0.064
0.085
0.092

mm

1.3
1.4
0.7
1.6
3.2
3.0
1.8
2.3
1.4
2.3
1.1
1.4
1.8
2.3
3.0
1.1
1.7
1.3
0.9
1.2
1.9
4.0
1.9
1.9
2.5
1.0
2.0
1.3
0.8
1.7
2.3
1.6
1.2
1.8
1.8
0.8
1.2
2.0
2.7
2.7
2.8
1.6
1.8
1.5
1.6
1.6
1.5
1.6
2.2
2.6
1.2
1.2
1.7
2.5
0.9
1.1
1.4
1.1
1.3
1.5
1.8
0.8
1.1
1.1
1.4
1.4
1.6
2.2
1.8
1.0
1.0
1.0
1.2
1.8
2.0
1.1
1.4
1.6
2.2
2.3

TOTAL
MATL
COILS
9.00
7.00
5.50
7.50
9.00
9.00
9.75
8.50
9.00
9.50
7.50
10.0
10.0
11.0
9.00
11.5
11.8
10.8
10.0
13.0
12.0
11.0
12.0
11.0
14.0
9.50
15.0
12.0
14.8
12.5
16.0
18.0
12.0
13.8
14.8
13.5
31.8
17.0
21.3
20.3
18.5
32.0
26.0
23.5
24.0
27.0
34.0
34.0
111.5
7.25
5.50
5.50
3.00
3.50
6.50
4.25
4.00
4.50
5.00
5.00
4.50
5.50
3.75
3.75
7.00
4.00
4.50
4.75
5.00
5.00
5.00
4.00
5.33
3.50
5.00
4.50
6.00
4.67
4.50
3.50

SST
SPR
SST
SST
SPR
HD
SPR
SPR
SPR
SST
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
MW
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
MW
SPR
SST
SPR
SPR
SST
SPR
SST
HD
SPR
SPR
HD
HD
SST
SPR
SPR
HD
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
HD
HD
SPR
SPR
HD
SPR
SST
SST
SPR
SPR
SPR
SST
SST
SST
SST
SST
SST
MW
SPR
SST
SST
SPR
SST

E
N
D
S

F
N
S
H

CG
CG
C
CG
CG
CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
C
C
CG
C
C
C
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
CG

N
Z
N
N
Z
Z
Z
Z
Z
N
N
Z
Z
N
Z
Z
N
Z
Z
Z
Z
N
N
Z
Z
Z
Z
Z
Z
Z
N
Z
GI
N
Z
N
Z
BO
Z
Z
Z
N
Z
Z
N
Z
BO
N
Z
N
Z
N
Z
GI
N
N
GI
Z
Z
N
Z
Z
Z
N
N
GI
N
Z
N
N
N
N
N
N
Z
N
N
N
Z
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

135

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 136

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593

15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06

I-46
3547
2940
3840
12277
S-1393
B-98
3918
11196
12689
S-3096
3091
1923
A13-58
10366
GG-42
BB-65
A11-66
S-375
K-46
3536
3320
S-1362
4297
S-1356
10174
B12-65
G-60A
S-295
11226
Q-35
12560
2719
4247
V-28
KK-53
2890
10531
S-237
2686
3228
10608
I-88
1691
S-428
S-412
Q-58
10113
3060
S-856
3268
10030
10717
3057
A11-49
JJ-83
3500
12186
H-81
12078
3539
LL-68
M-146
10506
MM-91
NN-87
S-820
12446
12739
S-1488
WW-62
12467
3326
11614
10783
11136
1695
237
K-38
S-432

.81
.84
.84
.84
.88
.88
.88
.88
.91
.92
.94
.94
.97
1.00
1.00
1.00
1.00
1.03
1.03
1.13
1.13
1.13
1.13
1.13
1.16
1.19
1.19
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.28
1.34
1.38
1.41
1.44
1.47
1.50
1.50
1.56
1.56
1.56
1.56
1.63
1.63
1.63
1.63
1.63
1.63
1.72
1.75
1.75
1.78
1.81
1.84
1.88
1.94
1.97
2.00
2.00
2.00
2.06
2.09
2.13
2.25
2.25
2.44
2.50
2.53
2.56
2.75
2.75
2.75
3.00
3.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

20.6
21.4
21.4
21.4
22.2
22.2
22.2
22.2
23.0
23.4
23.8
23.8
24.6
25.4
25.4
25.4
25.4
26.2
26.2
28.6
28.6
28.6
28.6
28.6
29.4
30.2
30.2
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
32.5
34.1
34.9
35.7
36.5
37.3
38.1
38.1
39.7
39.7
39.7
39.7
41.3
41.3
41.3
41.3
41.3
41.3
43.6
44.5
44.5
45.2
46.0
46.8
47.6
49.2
50.0
50.8
50.8
50.8
52.4
53.2
54.0
57.2
57.2
61.9
63.5
64.3
65.1
69.9
69.9
69.9
76.2
76.2

MATERIAL: MW - Music Wire

136

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.531
.463
.459
.449
.513
.469
.467
.449
.463
.451
.473
.469
.289
.531
.519
.453
.443
.531
.469
.469
.467
.449
.433
.411
.433
.499
.457
.433
.427
.411
.357
.531
.517
.505
.449
.433
.423
.469
.459
.383
.433
.463
.449
.413
.501
.483
.465
.323
.513
.485
.459
.449
.433
.383
.457
.501
.469
.493
.517
.459
.529
.533
.489
.413
.413
.313
.465
.511
.547
.531
.449
.453
.449
.449
.343
.469
.457
.449
.499
.449

RATE
mm

13.5
11.8
11.7
11.4
13.0
11.9
11.9
11.4
11.8
11.5
12.0
11.9
7.3
13.5
13.2
11.5
11.3
13.5
11.9
11.9
11.9
11.4
11.0
10.4
11.0
12.7
11.6
11.0
10.8
10.4
9.1
13.5
13.1
12.8
11.4
11.0
10.7
11.9
11.7
9.7
11.0
11.8
11.4
10.5
12.7
12.3
11.8
8.2
13.0
12.3
11.7
11.4
11.0
9.7
11.6
12.7
11.9
12.5
13.1
11.7
13.4
13.5
12.4
10.5
10.5
8.0
11.8
13.0
13.9
13.5
11.4
11.5
11.4
11.4
8.7
11.9
11.6
11.4
12.7
11.4

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

2.4
.41
44
7.6
57
10
78
14
4.4
.76
35
6.2
51
8.9
84
15
48
8.3
73
13
31
5.4
28
4.8
2982 522
1.9
.33
4.5
.78
61
11
93
16
1.9
.33
25
4.3
25
4.3
30
5.3
43
7.6
63
11
148
26
76
13
8.6
1.5
30
5.3
47
8.3
65
11
111
19
355
62
1.6
.28
3.9
.68
6.5
1.1
68
12
62
11
95
17
19
3.3
23
4.0
200
35
67
12
25
4.4
34
6.0
93
16
6.1
1.1
10
1.8
22
3.8
710 124
2.4
.42
6.0
1.1
23
4.1
34
6.0
47
8.3
215
38
28
4.9
2.4
.43
18
3.1
6.1
1.1
1.6
.27
27
4.6
.85
.15
.96
.17
5.8
1.0
76
13
55
9.6
502
88
11
2.0
3.7
.65
.48
.08
.93
.16
26
4.6
24
4.2
27
4.8
27
4.7
275
48
9.2
1.6
17
2.9
25
4.3
1.5
.25
15
2.7

.63
.38
.32
.27
.60
.38
.30
.25
.33
.39
.40
.50
.05
.83
.75
.30
.26
.86
.55
.55
.68
.49
.43
.27
.36
.79
.58
.39
.44
.36
.21
1.0
.97
.86
.29
.46
.36
.75
.74
.30
.43
.66
.62
.42
.98
.91
.73
.16
1.2
.90
.77
.62
.61
.28
.68
.97
.81
1.2
1.4
.68
1.5
1.7
1.3
.51
.66
.23
1.1
1.2
2.0
1.9
.75
.81
.78
.80
.35
1.6
1.6
.85
1.5
1.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

16
9.6
8.1
6.9
15
9.8
7.6
6.4
8.3
9.8
10
13
1.3
21
19
7.6
6.5
22
14
14
17
12
11
6.9
9.0
20
15
9.9
11
9.2
5.3
26
25
22
7.4
12
9.2
19
19
7.7
11
17
16
11
25
23
18
4.1
30
23
20
16
16
7.2
17
25
21
30
34
17
37
42
32
13
17
5.8
29
31
50
49
19
21
20
20
8.9
40
40
22
37
33

Lbs.

1.5
17
18
21
2.6
14
15
21
16
28
12
14
156
1.6
3.3
18
24
1.6
14
14
21
21
27
40
27
6.8
17
18
29
40
75
1.7
3.8
5.6
20
29
34
14
17
61
29
17
21
39
6.0
9.5
16
116
2.9
5.4
18
21
29
61
19
2.4
14
7.1
2.1
18
1.2
1.6
7.3
39
36
115
13
4.5
.94
1.8
20
20
21
21
96
14
26
21
2.1
20

ENDS: C - Closed

G - Ground
O - Open

6.7
74
80
94
12
60
67
94
69
126
55
61
693
7.0
15
81
106
7.3
60
60
93
94
120
179
120
30
78
82
128
179
332
7.5
17
25
88
128
153
63
76
270
128
74
94
173
27
42
70
515
13
24
80
94
128
270
84
11
64
32
9.4
80
5.5
7.2
33
173
161
512
57
20
4.2
8.0
88
87
94
94
428
64
117
94
9.5
88

Inches

.18
.39
.37
.40
.28
.34
.32
.38
.34
.39
.39
.44
.76
.17
.24
.39
.41
.17
.43
.43
.44
.60
.64
.75
.56
.38
.61
.80
.75
.82
1.00
.22
.29
.35
.40
.72
.68
.59
.64
1.00
.76
.59
.72
.90
.35
.50
.67
1.22
.44
.73
.70
.72
.90
.95
.66
.78
.62
.61
.46
.64
.42
.27
.70
1.15
1.26
1.75
.93
.39
.17
.31
.79
.84
.86
.95
1.74
1.15
1.00
.94
1.54
1.27

mm

4.5
9.9
9.4
10.1
7.1
8.7
8.0
9.6
8.7
9.9
9.9
11.2
19.3
4.3
6.1
9.8
10.5
4.3
11.0
11.0
11.2
15.2
16.3
19.1
14.2
9.6
15.5
20.3
19.0
20.8
25.5
5.5
7.2
8.9
10.1
18.3
17.3
15.0
16.2
25.3
19.3
14.9
18.3
22.9
8.9
12.6
17.1
30.9
11.2
18.5
17.9
18.3
22.9
24.0
16.7
19.9
15.7
15.6
11.6
16.2
10.6
6.9
17.8
29.2
32.0
44.5
23.6
9.9
4.4
7.9
20.1
21.3
21.9
24.2
44.1
29.1
25.5
23.8
39.0
32.2

WIRE DIA.
Inches

0.031
0.065
0.067
0.072
0.040
0.062
0.063
0.072
0.065
0.071
0.060
0.062
0.152
0.031
0.037
0.070
0.075
0.031
0.062
0.062
0.063
0.072
0.080
0.091
0.080
0.047
0.068
0.080
0.083
0.091
0.118
0.031
0.038
0.044
0.072
0.080
0.085
0.062
0.067
0.105
0.080
0.065
0.072
0.090
0.046
0.055
0.064
0.135
0.040
0.054
0.067
0.072
0.080
0.105
0.068
0.046
0.062
0.050
0.038
0.067
0.032
0.030
0.052
0.090
0.090
0.140
0.064
0.041
0.023
0.031
0.072
0.070
0.072
0.072
0.125
0.062
0.068
0.072
0.047
0.072

mm

TOTAL
MATL
COILS

0.8
1.7
1.7
1.8
1.0
1.6
1.6
1.8
1.7
1.8
1.5
1.6
3.9
0.8
0.9
1.8
1.9
0.8
1.6
1.6
1.6
1.8
2.0
2.3
2.0
1.2
1.7
2.0
2.1
2.3
3.0
0.8
1.0
1.1
1.8
2.0
2.2
1.6
1.7
2.7
2.0
1.7
1.8
2.3
1.2
1.4
1.6
3.4
1.0
1.4
1.7
1.8
2.0
2.7
1.7
1.2
1.6
1.3
1.0
1.7
0.8
0.8
1.3
2.3
2.3
3.6
1.6
1.0
0.6
0.8
1.8
1.8
1.8
1.8
3.2
1.6
1.7
1.8
1.2
1.8

4.75
6.00
5.50
5.50
7.00
5.50
5.00
5.25
5.25
5.50
5.50
7.00
5.00
5.50
5.50
5.50
5.50
5.50
7.00
7.00
7.00
8.25
8.00
7.25
7.00
7.00
9.00
10.0
9.00
9.00
8.50
6.00
6.50
7.00
5.50
9.00
8.00
9.50
9.50
9.50
8.50
9.00
10.0
10.0
7.50
9.00
9.50
9.00
11.0
13.5
10.5
10.0
11.3
9.00
9.75
16.0
10.0
11.3
12.0
9.50
12.0
8.00
13.5
11.8
14.0
12.5
14.5
8.50
6.50
9.00
11.0
12.0
12.0
12.3
14.0
17.5
14.8
13.0
31.7
17.5

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
HD
SPR
SPR
SPR
SST
SPR
HD
SST
MW
SST
SPR
SPR
SST
SPR
SST
SPR
SST
SST
SST
MW
HD
SST
SPR
SST
SPR
SPR
SST
SST
SPR
SST
SST
MW
SPR
SST
SPR
SPR
SPR
SST
HD
SPR
SPR
HD
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
HD
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
MW
SST
SPR
SPR
SST
SST
SST
SPR
MW
SST
SST
SPR
HD
SPR
SPR
SPR
MW
SPR
SPR
SST

E
N
D
S

C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
C
CG
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
CG
CG
C
CG

F
N
S
H

N
GI
Z
Z
Z
N
Z
Z
N
Z
N
Z
Z
N
Z
N
Z
N
N
N
Z
Z
N
Z
N
Z
Z
N
N
Z
N
N
Z
Z
N
Z
Z
Z
N
Z
Z
N
Z
Z
N
N
N
Z
Z
N
Z
Z
GI
Z
GI
N
Z
Z
N
Z
Z
N
N
Z
N
N
N
N
Z
N
N
Z
Z
GI
Z
Z
Z
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 137

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.593
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600

15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.06
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24

11729
3090
11795
2772
3950
11663
10560
10228
1611
10636
11769
1815
1521
12178
10681
2902
71711
71711S
71712
71712S
71729
71729S
71741
71741S
71753
71753S
71765
71765S
71779
71779S
71791
71791S
71803
71803S
71819
71819S
71713
71713S
71730
71730S
71742
71742S
71754
71754S
71766
71766S
71780
71780S
71792
71792S
71804
71804S
71820
71820S
71835
71835S
71850
71850S
71714
71714S
71731
71731S
71743
71743S
71755
71755S
71767
71767S
71781
71781S
71793
71793S
71805
71805S
71821
71821S
71836
71836S
71851
71851S

3.00
3.00
3.03
3.13
3.50
3.50
3.50
4.00
4.00
4.00
4.31
5.38
5.50
5.75
6.00
6.25
.50
.50
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

76.2
76.2
77.0
79.4
88.9
88.9
88.9
101.6
101.6
101.6
109.5
136.5
139.7
146.1
152.4
158.8
12.7
12.7
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4

I.D.
Inches

.433
.383
.451
.499
.449
.445
.393
.527
.383
.367
.433
.411
.411
.413
.411
.423
.510
.510
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404

RATE
mm

11.0
9.7
11.5
12.7
11.4
11.3
10.0
13.4
9.7
9.3
11.0
10.4
10.4
10.5
10.4
10.7
13.0
13.0
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

27
90
15
2.0
27
21
58
.49
88
88
22
33
31
24
19
19
23
20
18
15
28
24
40
34
53
45
63
54
80
68
109
92
203
173
263
223
15
12
23
19
33
28
42
36
52
44
65
55
78
66
159
135
204
173
292
248
388
330
12
10
19
16
28
23
35
30
45
38
50
43
68
58
131
111
166
141
237
201
314
267

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

4.8
16
2.6
.34
4.8
3.6
10
.08
15
15
3.8
5.8
5.5
4.2
3.3
3.3
4.1
3.5
3.2
2.7
4.9
4.2
7.0
6.0
9.3
7.9
11
9.4
14
12
19
16
36
30
46
39
2.5
2.2
4.0
3.4
5.8
4.9
7.4
6.3
9.1
7.7
11
9.6
14
12
28
24
36
30
51
43
68
58
2.1
1.8
3.3
2.8
4.8
4.1
6.2
5.2
7.8
6.6
8.8
7.4
12
10
23
19
29
25
42
35
55
47

1.1
.68
1.3
2.0
.78
1.1
.91
3.2
.69
.82
1.3
1.7
1.3
1.6
2.1
1.8
.34
.28
.45
.36
.38
.30
.35
.28
.32
.26
.33
.26
.31
.25
.27
.21
.20
.16
.18
.14
.55
.45
.46
.37
.42
.34
.40
.32
.40
.32
.38
.31
.36
.30
.26
.20
.23
.18
.20
.15
.18
.14
.66
.54
.55
.44
.50
.40
.49
.39
.47
.37
.49
.40
.43
.34
.32
.25
.29
.23
.24
.19
.22
.17

mm

27
17
34
51
20
28
23
82
17
21
34
43
33
41
53
46
8.7
7.1
12
9.2
9.6
7.6
8.8
7.0
8.1
6.5
8.4
6.7
7.9
6.3
6.8
5.4
5.2
4.1
4.6
3.6
14
11
12
9.4
11
8.5
10
8.2
10
8.1
9.8
7.8
9.2
7.5
6.6
5.2
5.9
4.7
5.0
3.9
4.5
3.5
17
14
14
11
13
10
12
9.8
12
9.4
12
10
11
8.6
8.0
6.3
7.3
5.7
6.2
4.8
5.6
4.3

ENDS: C - Closed

G - Ground
O - Open

Lbs.

29
61
20
3.9
21
23
53
1.6
61
72
29
56
40
39
40
34
7.9
5.5
8.2
5.5
11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
8.0
5.5
11
7.1
14
9.4
17
12
21
14
25
17
28
20
41
28
48
32
57
38
69
46
7.9
5.5
11
7.1
14
9.4
17
12
21
14
24
17
29
20
41
28
48
32
57
38
69
46

128
270
90
17
94
102
235
7.0
270
322
128
250
179
173
176
153
35
25
36
25
47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
36
25
47
32
62
42
76
51
92
62
110
75
126
87
184
123
211
142
256
169
307
203
35
25
47
32
62
42
76
51
92
62
108
75
130
87
184
123
211
142
256
169
307
203

Inches

1.44
1.97
1.35
1.13
.86
1.26
2.28
.76
2.00
2.94
1.76
2.32
2.46
2.97
3.91
2.72
.16
.16
.17
.17
.18
.18
.22
.22
.24
.24
.28
.28
.29
.29
.32
.32
.33
.33
.35
.35
.20
.20
.20
.20
.25
.25
.27
.27
.31
.31
.34
.34
.39
.39
.38
.38
.40
.40
.44
.44
.47
.47
.22
.22
.23
.23
.28
.28
.30
.30
.33
.33
.39
.39
.42
.42
.44
.44
.45
.45
.49
.49
.53
.53

mm

Inches

36.6
50.0
34.3
28.7
21.9
32.0
57.8
19.3
50.7
74.6
44.7
59.0
62.4
75.4
99.4
69.1
4.0
4.0
4.4
4.4
4.7
4.7
5.6
5.6
6.2
6.2
7.0
7.0
7.4
7.4
8.0
8.0
8.5
8.5
8.9
8.9
5.0
5.0
5.1
5.1
6.3
6.3
6.9
6.9
7.8
7.8
8.5
8.5
9.8
9.8
9.8
9.8
10.3
10.3
11.1
11.1
11.8
11.8
5.6
5.6
5.8
5.8
7.0
7.0
7.7
7.7
8.4
8.4
10.0
10.0
10.7
10.7
11.1
11.1
11.3
11.3
12.6
12.6
13.4
13.4

0.080
0.105
0.071
0.047
0.072
0.074
0.100
0.033
0.105
0.113
0.080
0.091
0.091
0.090
0.091
0.085
0.045
0.045
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098

mm

TOTAL
MATL
COILS

2.0
2.7
1.8
1.2
1.8
1.9
2.5
0.8
2.7
2.9
2.0
2.3
2.3
2.3
2.3
2.2
1.1
1.1
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5

18.0
18.8
19.0
24.0
12.0
17.0
22.8
22.0
19.0
26.0
22.0
25.5
27.0
33.0
43.0
32.0
3.50
3.50
3.88
3.88
3.75
3.75
4.00
4.00
4.13
4.13
4.38
4.38
4.38
4.38
4.38
4.38
4.13
4.13
4.13
4.13
4.38
4.38
4.13
4.13
4.50
4.50
4.63
4.63
4.88
4.88
5.00
5.00
5.38
5.38
4.75
4.75
4.75
4.75
4.75
4.75
4.75
4.75
4.88
4.88
4.63
4.63
5.00
5.00
5.13
5.13
5.25
5.25
5.88
5.88
5.88
5.88
5.38
5.38
5.25
5.25
5.38
5.38
5.38
5.38

SPR
SPR
SPR
HD
SPR
SPR
SPR
SPR
SPR
SPR
SPR
MW
HD
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

GI
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

137

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 138

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600

15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24

71715
71715S
71732
71732S
71744
71744S
71756
71756S
71768
71768S
71782
71782S
71794
71794S
71806
71806S
71822
71822S
71837
71837S
71852
71852S
71716
71716S
71733
71733S
71745
71745S
71757
71757S
71769
71769S
71783
71783S
71795
71795S
71807
71807S
71823
71823S
71838
71838S
71853
71853S
71717
71717S
71718
71718S
71719
71719S
71734
71734S
71746
71746S
71758
71758S
71770
71770S
71784
71784S
71796
71796S
71808
71808S
71824
71824S
71839
71839S
71854
71854S
71720
71720S
71735
71735S
71747
71747S
71759
71759S
71771
71771S

1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5

MATERIAL: MW - Music Wire

138

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.510
.510
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474

RATE
mm

13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
13.0
13.0
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

9.9
8.7
16
14
24
20
30
26
38
32
45
38
55
47
112
95
142
121
202
172
267
227
8.0
6.8
13
11
19
16
24
20
31
26
35
30
45
38
86
73
109
93
155
131
204
173
7.1
6.0
6.5
5.5
7.5
6.4
10
8.7
15
13
19
16
24
20
29
25
36
31
70
59
89
75
125
107
165
140
5.5
4.7
8.7
7.4
13
11
16
14
20
17

1.7
1.5
2.8
2.4
4.2
3.6
5.3
4.5
6.7
5.7
7.9
6.7
9.6
8.2
20
17
25
21
35
30
47
40
1.4
1.2
2.3
1.9
3.2
2.8
4.2
3.6
5.3
4.5
6.1
5.2
7.9
6.7
15
13
19
16
27
23
36
30
1.2
1.1
1.1
.97
1.3
1.1
1.8
1.5
2.6
2.2
3.4
2.9
4.2
3.6
5.1
4.3
6.3
5.4
12
10
16
13
22
19
29
25
.96
.82
1.5
1.3
2.3
1.9
2.8
2.4
3.6
3.0

.75
.64
.65
.52
.58
.46
.56
.45
.55
.43
.55
.44
.51
.42
.37
.29
.33
.26
.28
.22
.26
.20
.97
.81
.82
.65
.75
.60
.71
.57
.68
.54
.71
.57
.65
.51
.48
.38
.43
.34
.37
.29
.34
.26
1.1
.92
1.2
1.0
1.1
.87
1.0
.82
.93
.74
.89
.71
.86
.69
.86
.68
.81
.64
.59
.47
.54
.42
.46
.36
.42
.33
1.4
1.2
1.2
.97
1.1
.86
1.1
.84
1.0
.81

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

19
16
17
13
15
12
14
11
14
11
14
11
13
11
9.4
7.4
8.5
6.7
7.2
5.6
6.6
5.1
25
21
21
17
19
15
18
14
17
14
18
14
17
13
12
9.6
11
8.7
9.4
7.4
8.6
6.7
27
23
30
25
28
22
26
21
24
19
23
18
22
17
22
17
21
16
15
12
14
11
12
9.1
11
8.3
35
30
31
25
27
22
27
21
26
21

Lbs.

7.4
5.5
11
7.1
14
9.4
17
12
21
14
25
17
28
20
41
28
48
32
57
38
69
46
7.8
5.5
11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
57
38
69
46
7.6
5.5
7.6
5.5
8.2
5.5
11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
57
38
69
46
7.6
5.5
11
7.1
14
9.4
17
12
21
14

ENDS: C - Closed

G - Ground
O - Open

33
25
47
32
62
42
76
51
92
62
110
75
126
87
184
123
211
142
256
169
307
203
34
25
47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
256
169
307
203
34
25
34
25
36
25
47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
256
169
307
203
34
25
47
32
62
42
76
51
92
62

Inches

.25
.24
.25
.25
.30
.30
.33
.33
.37
.37
.42
.42
.49
.49
.49
.49
.50
.50
.54
.54
.58
.58
.28
.28
.29
.29
.35
.35
.39
.39
.43
.43
.50
.50
.57
.57
.58
.58
.60
.60
.66
.66
.70
.70
.31
.31
.33
.33
.30
.30
.34
.34
.41
.41
.46
.46
.51
.51
.58
.58
.67
.67
.68
.68
.70
.70
.76
.76
.82
.82
.37
.37
.38
.38
.45
.45
.52
.52
.57
.57

mm

6.3
6.1
6.4
6.4
7.5
7.5
8.4
8.4
9.4
9.4
10.6
10.6
12.3
12.3
12.3
12.3
12.7
12.7
13.7
13.7
14.6
14.6
7.1
7.1
7.3
7.3
8.9
8.9
9.9
9.9
10.8
10.8
12.8
12.8
14.4
14.4
14.7
14.7
15.1
15.1
16.6
16.6
17.7
17.7
7.9
7.9
8.3
8.3
7.6
7.6
8.6
8.6
10.3
10.3
11.6
11.6
13.0
13.0
14.7
14.7
16.9
16.9
17.2
17.2
17.8
17.8
19.3
19.3
20.8
20.8
9.4
9.4
9.6
9.6
11.5
11.5
13.1
13.1
14.6
14.6

WIRE DIA.
Inches

mm

0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.045
0.045
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063

1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.1
1.1
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6

FINISH: Z - Zinc

TOTAL
MATL
COILS
5.50
5.38
5.13
5.13
5.38
5.38
5.63
5.63
5.88
5.88
6.25
6.25
6.75
6.75
6.00
6.00
5.88
5.88
5.88
5.88
5.88
5.88
6.25
6.25
5.88
5.88
6.38
6.38
6.63
6.63
6.75
6.75
7.50
7.50
7.88
7.88
7.13
7.13
7.00
7.00
7.13
7.13
7.13
7.13
6.88
6.88
7.25
7.25
6.63
6.63
6.88
6.88
7.38
7.38
7.75
7.75
8.13
8.13
8.63
8.63
9.25
9.25
8.38
8.38
8.25
8.25
8.25
8.25
8.38
8.38
8.25
8.25
7.75
7.75
8.25
8.25
8.75
8.75
9.13
9.13

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 139

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600

15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24

71785
71785S
71797
71797S
71809
71809S
71825
71825S
71840
71840S
71855
71855S
71721
71721S
71736
71736S
71748
71748S
71760
71760S
71772
71772S
71786
71786S
71798
71798S
71810
71810S
71826
71826S
71841
71841S
71856
71856S
71722
71722S
71737
71737S
71749
71749S
71761
71761S
71773
71773S
71787
71787S
71799
71799S
71811
71811S
71827
71827S
71842
71842S
71857
71857S
71723
71723S
71738
71738S
71750
71750S
71762
71762S
71774
71774S
71788
71788S
71800
71800S
71812
71812S
71828
71828S
71843
71843S
71858
71858S
71724
71724S

1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9

I.D.
Inches

.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510

RATE
mm

11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

24
20
30
26
59
50
75
64
105
90
138
118
5.3
4.5
7.6
6.5
11
9.5
14
12
18
15
21
18
27
23
51
43
65
55
91
77
119
101
4.7
4.0
6.7
5.7
9.9
8.4
13
11
16
13
18
16
25
21
45
38
57
48
80
68
105
89
4.2
3.5
5.9
5.0
8.9
7.6
11
9.6
14
12
16
14
22
19
40
34
51
43
71
61
93
79
3.6
3.1

4.1
3.5
5.3
4.5
10
8.8
13
11
18
16
24
21
.92
.79
1.3
1.1
2.0
1.7
2.5
2.1
3.1
2.6
3.7
3.1
4.7
4.0
8.9
7.6
11
9.6
16
14
21
18
.82
.70
1.2
.99
1.7
1.5
2.2
1.9
2.7
2.3
3.2
2.7
4.3
3.7
7.8
6.7
9.9
8.5
14
12
18
16
.73
.62
1.0
.88
1.6
1.3
2.0
1.7
2.5
2.1
2.9
2.4
3.9
3.3
7.0
6.0
8.9
7.5
12
11
16
14
.63
.54

1.1
.84
.98
.77
.70
.55
.64
.50
.55
.43
.50
.39
1.6
1.2
1.4
1.1
1.2
.99
1.2
.96
1.2
.93
1.2
.94
1.1
.86
.81
.64
.74
.58
.63
.49
.58
.45
1.7
1.4
1.6
1.3
1.4
1.1
1.4
1.1
1.3
1.1
1.3
1.1
1.2
.94
.92
.73
.84
.66
.72
.56
.66
.51
2.0
1.6
1.8
1.4
1.6
1.2
1.5
1.2
1.5
1.2
1.5
1.2
1.3
1.0
1.0
.81
.94
.74
.81
.63
.74
.58
2.2
1.8

mm

27
21
25
20
18
14
16
13
14
11
13
9.9
39
31
35
28
32
25
31
24
30
24
30
24
28
22
21
16
19
15
16
13
15
11
44
35
40
32
36
28
35
28
34
27
34
27
30
24
23
18
21
17
18
14
17
13
50
40
45
36
40
32
38
31
37
30
39
31
34
27
26
21
24
19
21
16
19
15
57
46

ENDS: C - Closed

G - Ground
O - Open

Lbs.

25
17
29
20
41
28
48
32
57
38
69
46
8.2
5.5
11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
57
38
69
46
8.2
5.5
11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
57
38
69
46
8.2
5.5
11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
57
38
69
46
8.0
5.5

110
75
130
87
184
123
211
142
256
169
307
203
36
25
47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
256
169
307
203
36
25
47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
256
169
307
203
36
25
47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
256
169
307
203
36
25

Inches

.68
.68
.77
.77
.77
.77
.80
.80
.87
.87
.94
.94
.38
.38
.42
.42
.51
.51
.58
.58
.65
.65
.75
.75
.85
.85
.87
.87
.89
.89
.98
.98
1.05
1.05
.42
.42
.47
.47
.56
.56
.63
.63
.72
.72
.83
.83
.91
.91
.96
.96
.99
.99
1.09
1.09
1.18
1.18
.46
.46
.51
.51
.61
.61
.69
.69
.78
.78
.92
.92
1.00
1.00
1.05
1.05
1.09
1.09
1.20
1.20
1.30
1.30
.52
.52

mm

Inches

17.2
17.2
19.7
19.7
19.5
19.5
20.2
20.2
22.2
22.2
24.0
24.0
9.7
9.7
10.6
10.6
12.9
12.9
14.6
14.6
16.4
16.4
18.9
18.9
21.5
21.5
22.1
22.1
22.7
22.7
24.8
24.8
26.8
26.8
10.7
10.7
11.8
11.8
14.3
14.3
16.1
16.1
18.2
18.2
21.1
21.1
23.1
23.1
24.4
24.4
25.1
25.1
27.7
27.7
29.9
29.9
11.7
11.7
12.9
12.9
15.5
15.5
17.6
17.6
19.8
19.8
23.4
23.4
25.4
25.4
26.7
26.7
27.8
27.8
30.4
30.4
33.0
33.0
13.3
13.3

0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045

mm

TOTAL
MATL
COILS

1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1

10.1
10.1
10.8
10.8
9.50
9.50
9.38
9.38
9.50
9.50
9.63
9.63
8.50
8.50
8.50
8.50
9.25
9.25
9.75
9.75
10.3
10.3
11.1
11.1
11.8
11.8
10.8
10.8
10.5
10.5
10.6
10.6
10.8
10.8
9.38
9.38
9.50
9.50
10.3
10.3
10.8
10.8
11.4
11.4
12.4
12.4
12.6
12.6
11.9
11.9
11.6
11.6
11.9
11.9
12.0
12.0
10.3
10.3
10.4
10.4
11.1
11.1
11.8
11.8
12.4
12.4
13.8
13.8
13.9
13.9
13.0
13.0
12.9
12.9
13.0
13.0
13.3
13.3
11.6
11.6

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

139

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 140

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600
0.600

15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24
15.24

71739
71739S
71751
71751S
71763
71763S
71775
71775S
71789
71789S
71801
71801S
71813
71813S
71829
71829S
71844
71844S
71859
71859S
71725
71725S
71740
71740S
71752
71752S
71764
71764S
71776
71776S
71790
71790S
71802
71802S
71814
71814S
71830
71830S
71845
71845S
71860
71860S
71726
71726S
71727
71727S
71777
71777S
71815
71815S
71831
71831S
71846
71846S
71861
71861S
12675
71728
71728S
71778
71778S
71816
71816S
71832
71832S
71847
71847S
71862
71862S
71817
71817S
71833
71833S
71848
71848S
71863
71863S
71818
71818S
71834

2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.25
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.75
3.75
3.75
3.75
3.75
3.75
3.75
3.75
4.00
4.00
4.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
82.6
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
95.3
95.3
95.3
95.3
95.3
95.3
95.3
95.3
101.6
101.6
101.6

MATERIAL: MW - Music Wire

140

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.502
.502
.490
.490
.482
.482
.474
.474
.466
.466
.456
.456
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.510
.510
.474
.474
.438
.438
.430
.430
.416
.416
.404
.404
.510
.510
.510
.474
.474
.438
.438
.430
.430
.416
.416
.404
.404
.438
.438
.430
.430
.416
.416
.404
.404
.438
.438
.430

RATE
mm

12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
12.8
12.8
12.4
12.4
12.2
12.2
12.0
12.0
11.8
11.8
11.6
11.6
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
13.0
13.0
12.0
12.0
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
13.0
13.0
13.0
12.0
12.0
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
11.1
11.1
10.9
10.9
10.6
10.6
10.3
10.3
11.1
11.1
10.9

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

5.3
4.5
8.0
6.8
9.8
8.3
13
11
15
13
20
17
36
31
46
39
64
55
84
71
3.3
2.8
4.8
4.1
7.3
6.2
9.0
7.6
12
10
14
12
18
15
33
28
42
35
59
50
77
65
2.9
2.4
3.3
2.8
10
8.7
32
27
38
33
54
46
70
60
2.2
2.8
2.4
10
8.5
29
25
36
30
50
42
65
55
27
23
33
28
46
39
61
51
25
22
31

.93
.79
1.4
1.2
1.7
1.5
2.3
1.9
2.6
2.2
3.5
3.0
6.3
5.4
8.0
6.8
11
9.6
15
13
.58
.49
.84
.72
1.3
1.1
1.6
1.3
2.1
1.8
2.4
2.0
3.2
2.7
5.8
4.9
7.3
6.2
10
8.7
13
11
.50
.43
.58
.49
1.8
1.5
5.5
4.7
6.7
5.7
9.4
8.0
12
10
.39
.49
.42
1.8
1.5
5.1
4.3
6.2
5.3
8.7
7.4
11
9.7
4.7
4.0
5.8
4.9
8.1
6.9
11
9.0
4.4
3.8
5.4

2.0
1.6
1.7
1.4
1.8
1.4
1.6
1.3
1.6
1.3
1.5
1.2
1.1
.90
1.0
.82
.89
.70
.82
.64
2.4
2.0
2.2
1.7
1.9
1.5
1.9
1.5
1.8
1.4
1.8
1.4
1.6
1.3
1.3
.99
1.1
.90
.98
.76
.90
.70
2.6
2.3
2.5
2.0
2.0
1.6
1.3
1.0
1.2
.98
1.1
.83
.98
.76
2.5
2.9
2.3
2.1
1.6
1.4
1.1
1.3
1.1
1.2
.90
1.1
.83
1.5
1.2
1.4
1.1
1.2
.97
1.1
.89
1.6
1.3
1.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

51
40
44
35
44
35
41
32
42
33
37
29
29
23
26
21
23
18
21
16
62
50
56
44
48
38
48
39
45
36
46
37
41
33
32
25
29
23
25
19
23
18
67
58
63
50
52
41
33
26
32
25
27
21
25
19
63
73
59
52
42
36
28
34
27
29
23
27
21
39
31
37
29
32
25
29
23
41
33
39

Lbs.

11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
57
38
69
46
8.0
5.5
11
7.1
14
9.4
17
12
21
14
25
17
29
20
41
28
48
32
57
38
69
46
7.5
5.5
8.2
5.5
21
14
41
28
48
32
57
38
69
46
5.5
8.1
5.5
21
14
41
28
48
32
57
38
69
46
41
28
48
32
57
38
69
46
41
28
48

ENDS: C - Closed

G - Ground
O - Open

47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
256
169
307
203
36
25
47
32
62
42
76
51
92
62
110
75
130
87
184
123
211
142
256
169
307
203
33
25
36
25
92
62
184
123
211
142
256
169
307
203
25
36
25
92
62
184
123
211
142
256
169
307
203
184
123
211
142
256
169
307
203
184
123
211

Inches

.56
.56
.67
.67
.78
.78
.83
.83
.99
.99
1.09
1.09
1.15
1.15
1.19
1.19
1.31
1.31
1.42
1.42
.56
.56
.60
.60
.72
.72
.84
.84
.91
.91
1.06
1.06
1.19
1.19
1.25
1.25
1.29
1.29
1.41
1.41
1.53
1.53
.63
.63
.56
.56
1.03
1.03
1.30
1.30
1.39
1.39
1.53
1.53
1.65
1.65
.69
.64
.64
1.04
1.04
1.39
1.39
1.49
1.49
1.63
1.63
1.78
1.78
1.49
1.49
1.58
1.58
1.75
1.75
1.90
1.90
1.57
1.57
1.69

mm

14.2
14.2
16.9
16.9
19.9
19.9
21.2
21.2
25.1
25.1
27.7
27.7
29.3
29.3
30.2
30.2
33.3
33.3
36.1
36.1
14.3
14.3
15.2
15.2
18.3
18.3
21.4
21.4
23.0
23.0
27.0
27.0
30.2
30.2
31.6
31.6
32.7
32.7
35.9
35.9
38.9
38.9
16.0
16.0
14.3
14.3
26.2
26.2
32.9
32.9
35.4
35.4
38.8
38.8
42.0
42.0
17.6
16.3
16.3
26.4
26.4
35.2
35.2
37.8
37.8
41.5
41.5
45.1
45.1
37.8
37.8
40.2
40.2
44.4
44.4
48.2
48.2
39.9
39.9
42.9

WIRE DIA.
Inches

0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.049
0.049
0.055
0.055
0.059
0.059
0.063
0.063
0.067
0.067
0.072
0.072
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.045
0.045
0.063
0.063
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.045
0.045
0.045
0.063
0.063
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.081
0.081
0.085
0.085
0.092
0.092
0.098
0.098
0.081
0.081
0.085

mm

TOTAL
MATL
COILS

1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.2
1.2
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.8
1.8
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.1
1.1
1.6
1.6
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
1.1
1.1
1.1
1.6
1.6
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
2.1
2.1
2.2
2.2
2.3
2.3
2.5
2.5
2.1
2.1
2.2

11.4
11.4
12.1
12.1
13.3
13.3
13.3
13.3
14.8
14.8
15.1
15.1
14.3
14.3
14.0
14.0
14.3
14.3
14.5
14.5
12.5
12.5
12.3
12.3
13.1
13.1
14.3
14.3
14.4
14.4
15.9
15.9
16.5
16.5
15.4
15.4
15.1
15.1
15.4
15.4
15.6
15.6
14.0
14.0
12.5
12.5
16.4
16.4
16.0
16.0
16.4
16.4
16.6
16.6
16.9
16.9
15.4
14.3
14.3
16.5
16.5
17.1
17.1
17.5
17.5
17.8
17.8
18.1
18.1
18.4
18.4
18.6
18.6
19.0
19.0
19.4
19.4
19.4
19.4
19.9

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 141

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.600
0.600
0.600
0.600
0.600
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609

15.24
15.24
15.24
15.24
15.24
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47

71834S
71849
71849S
71864
71864S
2574
EE-76
AA-52
J-53
NN-100
O-73
Q-37
I-100
J-32
K-41
WW-36
UU-65
B15-26
10758
B10-58
QQ-60
B17-120
Q-56
BB-98
10618
S-1108
10009
10953
2780
N-30
PP-43
12258
2682
S-1690
1769
4146
S-1700
12778
J-63
11032
S-266
2785
N-67
2779
11449
L-37
3889
S-926
Q-33
B15-64
G-48
11245
S-3209
12594
10611
S-1564
S-259
3107
B-63
A12-21
S-1332
2803
NN-95
XX-57
A10-64
YY-39
N-77
12508
11230
11583
3833
3003
12134
B8-49
3537
B10-19
3322
B8-44
RR-48
B14-64

4.00
4.00
4.00
4.00
4.00
.31
.38
.41
.41
.44
.44
.44
.44
.47
.50
.50
.50
.56
.56
.63
.63
.63
.66
.69
.69
.69
.69
.72
.75
.75
.75
.75
.75
.80
.81
.81
.82
.88
.88
.88
.91
.91
.94
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.08
1.09
1.11
1.13
1.13
1.13
1.13
1.13
1.16
1.16
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.31
1.31
1.38
1.38
1.44

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

101.6
101.6
101.6
101.6
101.6
7.9
9.5
10.3
10.3
11.1
11.1
11.1
11.1
11.9
12.7
12.7
12.7
14.3
14.3
15.9
15.9
15.9
16.7
17.4
17.4
17.4
17.5
18.2
19.1
19.1
19.1
19.1
19.1
20.3
20.6
20.6
20.9
22.2
22.2
22.2
23.0
23.0
23.8
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.4
27.8
28.2
28.6
28.6
28.6
28.6
28.6
29.4
29.4
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
33.3
33.3
34.9
34.9
36.5

I.D.
Inches

.430
.416
.416
.404
.404
.569
.485
.549
.465
.521
.501
.459
.409
.569
.539
.501
.489
.509
.507
.521
.475
.385
.503
.545
.537
.489
.469
.523
.539
.525
.449
.445
.427
.469
.549
.439
.465
.509
.499
.463
.499
.497
.469
.427
.563
.539
.519
.519
.475
.467
.465
.485
.531
.301
.535
.449
.545
.527
.513
.507
.389
.533
.449
.549
.509
.465
.485
.513
.513
.511
.475
.429
.339
.553
.399
.501
.459
.469
.465
.501

RATE
mm

10.9
10.6
10.6
10.3
10.3
14.5
12.3
13.9
11.8
13.2
12.7
11.7
10.4
14.5
13.7
12.7
12.4
12.9
12.9
13.2
12.1
9.8
12.8
13.8
13.6
12.4
11.9
13.3
13.7
13.3
11.4
11.3
10.8
11.9
13.9
11.2
11.8
12.9
12.7
11.8
12.7
12.6
11.9
10.8
14.3
13.7
13.2
13.2
12.1
11.9
11.8
12.3
13.5
7.6
13.6
11.4
13.8
13.4
13.0
12.9
9.9
13.5
11.4
13.9
12.9
11.8
12.3
13.0
13.0
13.0
12.1
10.9
8.6
14.0
10.1
12.7
11.7
11.9
11.8
12.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

26
4.6
43
7.6
37
6.4
57
9.9
48
8.4
.56
.10
130
23
2.4
.42
221
39
18
3.1
31
5.4
130
23
1090 191
1.1
.20
5.7
1.0
31
5.4
113
20
26
4.5
28
4.9
15
2.7
73
13
801 140
12
2.0
1.6
.27
6.4
1.1
24
4.3
73
13
6.8
1.2
3.3
.57
6.2
1.1
133
23
127
22
236
41
64
11
2.4
.42
130
23
72
13
18
3.1
26
4.5
64
11
23
4.0
28
4.9
55
9.6
164
29
.24
.04
3.8
.67
6.6
1.2
7.1
1.3
29
5.0
59
10
55
9.7
37
6.5
5.3
.93
2020 354
4.1
.72
53
9.3
1.4
.24
5.9
1.0
6.2
1.1
16
2.8
421
74
1.8
.32
88
15
1.5
.26
7.3
1.3
42
7.3
28
4.9
8.6
1.5
9.1
1.61
12
2.1
24
4.2
123
21
815 143
.80
.14
271
47
15
2.6
37
6.5
44
7.7
39
6.9
14
2.5

1.2
1.3
1.0
1.2
.95
.21
.11
.24
.09
.24
.22
.14
.05
.39
.36
.23
.11
.29
.28
.34
.24
.08
.29
.46
.47
.33
.26
.42
.52
.52
.21
.24
.23
.28
.65
.26
.27
.39
.38
.31
.41
.37
.35
.34
.74
.73
.64
.73
.50
.31
.37
.53
.67
.08
.79
.43
.87
.75
.69
.68
.14
.70
.32
.99
.74
.50
.47
.82
.68
.64
.55
.31
.14
1.1
.22
.62
.56
.43
.49
.65

mm

31
34
26
31
24
5.4
2.7
6.1
2.2
6.1
5.6
3.5
1.2
9.9
9.1
5.8
2.9
7.3
7.2
8.6
6.2
2.0
7.2
12
12
8.3
6.6
11
13
13
5.4
6.1
5.9
7.1
16
6.5
6.8
9.9
9.7
8.0
10
9.5
8.8
8.5
19
18
16
19
13
7.9
9.5
13
17
2.0
20
11
22
19
18
17
3.6
18
8.1
25
19
13
12
21
17.3
16
14
7.9
3.5
28
5.6
16
14
11
12
17

ENDS: C - Closed

G - Ground
O - Open

Lbs.

32
57
38
69
46

142
256
169
307
203
.12

14
.58
19
4.2
6.9
18
52
.44
2.1
7.1
13
7.4
7.9
5.1
18
63
3.3
.73
3.0
8.0
19
2.8
1.7
3.2
28
30
55
18
1.6
34
19
7.0
9.9
20
9.3
10
19
55
.17
2.8
4.2
5.2
14
19
21
19
3.6
158
3.3
23
1.2
4.4
4.3
11
60
1.3
28
1.5
5.4
21
13
7.1
6.19
7.5
13
38
113
.87
59
9.3
21
19
19
9.3

.53
62
2.6
86
19
31
80
229
1.9
9.1
32
57
33
35
23
78
280
15
3.2
13
36
85
13
7.6
14
125
134
244
79
6.9
149
86
31
44
90
41
46
85
244
.77
12
19
23
64
83
92
87
16
705
15
102
5.3
20
19
49
266
5.7
125
6.6
24
92
59
31
27.5
33
59
169
504
3.9
264
42
93
85
86
42

Inches

1.69
1.85
1.85
2.01
2.01
.10
.25
.17
.22
.20
.22
.30
.30
.08
.14
.27
.18
.20
.26
.17
.30
.45
.37
.22
.18
.36
.35
.30
.23
.23
.40
.45
.46
.35
.17
.51
.43
.28
.28
.41
.33
.34
.49
.58
.26
.21
.36
.27
.50
.39
.47
.34
.23
.96
.24
.68
.26
.28
.43
.28
.61
.45
.52
.20
.45
.58
.37
.38
.37
.34
.70
.68
1.01
.20
.80
.42
.75
.49
.54
.38

mm

Inches

42.9
47.0
47.0
51.0
51.0
2.5
6.3
4.2
5.5
5.0
5.5
7.6
7.6
2.0
3.6
6.9
4.6
5.1
6.5
4.2
7.7
11.4
9.4
5.7
4.6
9.1
8.9
7.6
5.8
5.9
10.2
11.5
11.6
8.9
4.2
13.0
11.0
7.0
7.0
10.5
8.4
8.5
12.4
14.6
6.7
5.3
9.1
6.9
12.8
9.9
11.9
8.7
5.9
24.5
6.1
17.3
6.5
7.0
11.0
7.1
15.4
11.5
13.2
5.0
11.4
14.6
9.4
9.8
9.5
8.7
17.9
17.1
25.7
5.0
20.4
10.6
19.1
12.4
13.7
9.6

0.085
0.092
0.092
0.098
0.098
0.020
0.062
0.030
0.072
0.044
0.054
0.075
0.100
0.020
0.035
0.054
0.060
0.050
0.051
0.044
0.067
0.112
0.053
0.032
0.036
0.060
0.070
0.043
0.035
0.042
0.080
0.082
0.091
0.070
0.030
0.085
0.072
0.050
0.055
0.073
0.055
0.056
0.070
0.091
0.023
0.035
0.045
0.045
0.067
0.071
0.072
0.062
0.039
0.154
0.037
0.080
0.032
0.041
0.048
0.051
0.110
0.038
0.080
0.030
0.050
0.072
0.062
0.048
0.048
0.049
0.067
0.090
0.135
0.028
0.105
0.054
0.075
0.070
0.072
0.054

mm

TOTAL
MATL
COILS

2.2
2.3
2.3
2.5
2.5
0.5
1.6
0.8
1.8
1.1
1.4
1.9
2.5
0.5
0.9
1.4
1.5
1.3
1.3
1.1
1.7
2.8
1.3
0.8
0.9
1.5
1.8
1.1
0.9
1.1
2.0
2.1
2.3
1.8
0.8
2.2
1.8
1.3
1.4
1.9
1.4
1.4
1.8
2.3
0.6
0.9
1.1
1.1
1.7
1.8
1.8
1.6
1.0
3.9
0.9
2.0
0.8
1.0
1.2
1.3
2.8
1.0
2.0
0.8
1.3
1.8
1.6
1.2
1.2
1.2
1.7
2.3
3.4
0.7
2.7
1.4
1.9
1.8
1.8
1.4

19.9
20.1
20.1
20.5
20.5
4.00
3.00
4.50
3.00
3.50
4.00
4.00
3.00
3.00
4.00
4.00
3.00
4.00
4.00
3.75
4.50
4.00
7.00
7.00
4.00
6.00
5.00
6.00
5.50
5.50
5.00
5.50
5.00
5.00
4.50
6.00
5.00
4.50
5.00
5.67
5.00
5.00
6.00
6.33
10.5
5.00
7.00
6.00
7.50
5.50
6.50
5.50
5.00
6.25
5.50
8.50
7.00
5.75
9.00
5.50
5.50
11.0
6.50
5.50
9.00
8.00
6.00
7.00
6.75
6.00
9.50
7.50
7.50
7.00
7.50
6.75
10.0
7.00
7.50
7.00

SST
MW
SST
MW
SST
MW
SPR
MW
SST
SST
SST
SST
SPR
MW
SPR
SST
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SST
SPR
SPR
HD
SST
SPR
SPR
MW
SST
HD
SPR
SST
SST
SPR
SST
SST
SPR
SPR
MW
MW
SPR
SPR
SST
SST
SST
HD
MW
SST
SPR
SPR
SST
SST
SPR
SPR
MW
SST
HD
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
C
C
C
CG
C
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
C
C
C
CG
C
C
C
CG
CG
CG
CG
CG
C
CG
C
CG
C
C
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG

N
N
N
N
N
Z
Z
N
N
N
N
N
Z
N
GI
N
Z
Z
BO
N
Z
N
N
N
Z
N
Z
N
Z
N
Z
Z
Z
N
Z
Z
N
N
Z
N
N
Z
Z
Z
N
Z
Z
N
N
N
N
N
N
GI
Z
N
N
Z
Z
N
N
Z
GI
N
Z
Z
N
Z
Z
N
Z
Z
Z
N
Z
N
Z
N
N
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

141

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 142

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.609
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625

15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.47
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88

S-1192
LL-92
S-1406
S-1311
S-938
11310
Q-60
S-485
11653
YY-30
A15-67
S-1143
11511
10189
10846
S-1213
B10-15
2537
S-885
11581
S-494
1517
JJ-78
11886
11939
12510
12256
S-24
S-277
11792
10564
10961
11689
11487
10501
B14-45
S-74
S-3255
10711
V V-56
11622
B2-63
11249
11657
11958
11790
WW-50
4105
2867
11840
12142
3660
10769
11556
2710
S-215
10863
3199
3280
TT-65
3311
S-61
2796
3162
11585
1811
3805
12323
S-228
S-175
S-391
H-24
K-31
PP-47
3506
2511
B-97
11369
4320
10123

1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.53
1.56
1.56
1.63
1.63
1.63
1.63
1.63
1.66
1.69
1.69
1.75
1.75
1.75
1.81
1.84
1.84
1.84
1.88
2.00
2.00
2.00
2.03
2.13
2.25
2.25
2.28
2.34
2.38
2.41
2.41
2.50
2.50
2.50
2.50
2.53
2.59
2.59
2.75
2.75
2.75
2.78
2.88
3.25
3.25
3.38
3.50
3.50
3.50
3.53
3.75
3.75
4.13
4.38
4.50
4.50
4.53
4.88
5.00
7.34
8.50
.28
.38
.41
.44
.44
.53
.53
.53
.59
.63
.63

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.9
38.9
39.7
39.7
41.3
41.3
41.3
41.3
41.3
42.1
42.8
42.8
44.5
44.5
44.5
46.0
46.8
46.8
46.8
47.6
50.8
50.8
50.8
51.6
54.0
57.2
57.2
57.9
59.5
60.3
61.1
61.1
63.5
63.5
63.5
63.5
64.3
65.9
65.9
69.9
69.9
69.9
70.6
73.0
82.6
82.6
85.7
88.9
88.9
88.9
89.7
95.3
95.3
104.8
111.1
114.3
114.3
115.1
123.8
127.0
186.5
215.9
7.1
9.5
10.3
11.1
11.1
13.5
13.5
13.5
15.1
15.9
15.9

MATERIAL: MW - Music Wire

142

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.425
.527
.521
.501
.501
.489
.451
.519
.449
.503
.403
.501
.467
.427
.369
.297
.499
.513
.365
.489
.465
.413
.545
.445
.409
.483
.419
.519
.439
.421
.505
.561
.501
.399
.463
.409
.339
.519
.373
.525
.519
.485
.413
.399
.531
.461
.529
.527
.471
.467
.525
.525
.485
.559
.513
.485
.427
.513
.465
.427
.399
.439
.415
.415
.421
.427
.485
.467
.497
.501
.567
.515
.529
.465
.569
.517
.481
.571
.563
.497

RATE
mm

10.8
13.4
13.2
12.7
12.7
12.4
11.5
13.2
11.4
12.8
10.2
12.7
11.9
10.8
9.4
7.6
12.7
13.0
9.3
12.4
11.8
10.5
13.8
11.3
10.4
12.3
10.6
13.2
11.2
10.7
12.8
14.2
12.7
10.1
11.8
10.4
8.6
13.2
9.5
13.3
13.2
12.3
10.5
10.1
13.5
11.7
13.4
13.4
12.0
11.9
13.3
13.3
12.3
14.2
13.0
12.3
10.8
13.0
11.8
10.8
10.1
11.2
10.5
10.5
10.7
10.8
12.3
11.9
12.6
12.7
14.4
13.1
13.4
11.8
14.5
13.1
12.2
14.5
14.3
12.6

Lbs./In.

N/mm

118
21
3.9
.68
3.2
.57
11
2.0
9.6
1.7
13
2.3
32
5.6
5.2
.91
33
5.8
11
1.9
147
26
8.3
1.5
29
5.1
71
12
323
57
1293 226
9.7
1.7
3.9
.69
355
62
14
2.5
24
4.2
114
20
.98
.17
49
8.6
91
16
16
2.8
108
19
3.6
.63
57
9.9
82
14
6.2
1.1
.50
.09
7.9
1.4
105
18
27
4.6
91
16
487
85
3.9
.68
235
41
1.9
.34
3.3
.58
12
2.1
71
12
171
30
1.0
.17
28
4.9
2.2
.38
1.8
.32
16
2.8
21
3.7
1.1
.19
2.5
.44
11
1.9
.28
.05
2.7
.47
7.1
1.2
43
7.5
2.5
.45
11
1.9
28
4.9
80
14
15
2.6
36
6.4
40
6.9
34
6.0
28
4.8
4.3
.76
4.6
.81
1.7
.30
106
18
3.3
.59
62
11
12
2.0
364
64
4.2
.73
33
5.7
131
23
.67
.12
4.2
.74
39
6.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.32
8.1
1.1
29
1.1
27
.78 20
.92 23
.87 22
.51 13
1.1
27
.41 10
.80 20
.38
9.7
1.1
27
.68 17
.53 14
.24
6.0
.12
3.1
1.0
26
1.1
27
.23
5.7
.91 23
.80 20
.43 11
1.5
37
.61 16
.44 11
1.1
28
.41 10
1.5
38
.55 14
.53 13
1.3
34
1.9
49
1.2
30
.57 14
.81 21
.57 14
.21
5.3
1.4
36
.34
8.6
1.9
49
1.8
45
1.6
41
.69 17
.35
8.8
1.8
45
.80 20
1.8
45
2.1
54
1.7
42
.93 24
1.8
45
1.9
48
1.3
32
3.1
77
2.6
66
1.9
48
.91 23
2.6
65
1.9
49
1.3
33
.74 19
1.6
41
1.8
45
1.2
30
1.3
32
2.0
51
3.0
75
3.6
91
5.8 147
.10
2.4
.25
6.4
.15
3.7
.20
5.0
.08
1.9
.42 11
.26
6.6
.15
3.9
.38
9.7
.49 12
.27
6.9

Lbs.

38
4.4
3.4
8.8
8.8
12
16
5.5
14
8.8
56
8.8
20
38
77
156
9.9
4.2
80
13
19
49
1.4
30
40
18
44
5.4
31
43
8.4
.97
9.3
59
22
52
102
5.5
80
3.7
5.8
19
49
59
1.8
22
3.9
3.9
27
20
1.9
4.8
14
.86
7.0
13
39
6.5
20
36
59
24
65
47
43
55
13
16
9.8
10
.84
9.0
2.3
27
1.7
8.6
20
.26
2.1
11

ENDS: C - Closed

G - Ground
O - Open

167
20
15
39
39
51
72
24
61
39
250
39
88
168
341
693
44
19
357
57
86
216
6.4
134
179
78
198
24
140
192
37
4.3
42
264
96
229
454
24
356
16
26
86
216
264
7.9
100
17
18
119
88
8.5
21
62
3.8
31
59
175
29
90
162
264
107
289
210
192
244
57
73
44
45
3.7
40
10
122
7.7
38
90
1.1
9.1
47

Inches

.69
.36
.44
.41
.46
.63
.99
.34
1.12
.48
1.08
.51
.78
1.09
1.08
1.41
.61
.62
1.07
.66
.79
1.05
.35
.90
1.40
.74
.95
.50
.85
1.13
.61
.19
.59
1.68
.88
1.40
1.35
.43
1.42
.59
.54
.87
1.57
1.05
.82
.89
.44
.62
1.03
.92
1.09
.49
.85
.33
.91
1.12
1.68
.96
1.84
2.18
2.10
2.76
2.72
2.52
2.54
2.62
2.05
3.76
2.58
.19
.12
.17
.24
.24
.11
.27
.27
.21
.14
.35

mm

17.5
9.1
11.2
10.3
11.7
16.0
25.1
8.6
28.4
12.1
27.5
13.0
19.8
27.7
27.4
35.7
15.4
15.8
27.1
16.8
20.1
26.8
8.9
22.9
35.6
18.8
24.1
12.6
21.6
28.7
15.5
4.7
15.1
42.7
22.3
35.6
34.3
10.9
36.0
14.9
13.7
22.0
39.8
26.7
20.8
22.6
11.2
15.6
26.1
23.4
27.7
12.5
21.7
8.3
23.2
28.3
42.8
24.4
46.6
55.5
53.3
70.2
69.0
64.1
64.5
66.4
52.0
95.6
65.4
4.7
3.1
4.2
6.1
6.1
2.8
6.9
6.9
5.3
3.5
8.9

WIRE DIA.
Inches

0.092
0.041
0.044
0.054
0.054
0.060
0.079
0.045
0.080
0.053
0.103
0.054
0.071
0.091
0.120
0.156
0.055
0.048
0.122
0.060
0.072
0.098
0.032
0.082
0.100
0.063
0.095
0.045
0.085
0.094
0.052
0.024
0.054
0.105
0.073
0.100
0.135
0.045
0.118
0.042
0.045
0.062
0.098
0.105
0.039
0.074
0.040
0.041
0.069
0.071
0.042
0.042
0.062
0.025
0.048
0.062
0.091
0.048
0.072
0.091
0.105
0.085
0.097
0.097
0.094
0.091
0.062
0.071
0.056
0.062
0.029
0.055
0.048
0.080
0.028
0.054
0.072
0.027
0.031
0.064

mm

TOTAL
MATL
COILS

2.3
1.0
1.1
1.4
1.4
1.5
2.0
1.1
2.0
1.3
2.6
1.4
1.8
2.3
3.0
3.9
1.4
1.2
3.1
1.5
1.8
2.5
0.8
2.1
2.5
1.6
2.4
1.1
2.2
2.4
1.3
0.6
1.4
2.7
1.9
2.5
3.4
1.1
3.0
1.1
1.1
1.6
2.5
2.7
1.0
1.9
1.0
1.0
1.8
1.8
1.1
1.1
1.6
0.6
1.2
1.6
2.3
1.2
1.8
2.3
2.7
2.2
2.5
2.5
2.4
2.3
1.6
1.8
1.4
1.6
0.7
1.4
1.2
2.0
0.7
1.4
1.8
0.7
0.8
1.6

7.50
7.75
10.0
7.50
8.50
10.5
12.5
7.50
14.0
8.00
10.5
9.50
10.0
12.0
9.00
9.00
10.0
13.0
8.75
10.0
11.0
10.8
10.0
11.0
14.0
10.8
10.0
10.0
10.0
12.0
11.8
6.75
11.0
15.0
12.0
14.0
10.0
9.50
12.0
13.0
12.0
13.0
16.0
10.0
20.0
12.0
10.0
14.0
15.0
13.0
25.0
11.8
13.8
12.0
18.0
18.0
18.5
19.0
25.5
24.0
19.0
32.5
28.0
26.0
26.0
27.8
32.0
53.0
45.0
3.00
3.25
3.00
5.00
3.00
3.00
4.00
3.75
6.75
3.50
5.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SST
SST
SST
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SPR
SST
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
MW
SPR
SST
SST
SPR
SPR
MW
SPR
SPR
SPR
SPR
SST
SST
SPR
SST
SPR
MW
SPR
SPR
SPR
SPR
SST
SPR
MW
SPR
SPR
SPR
SPR
MW
HD
SST
SPR
SPR
HD
SST
SPR
SST
MW
SPR
SPR
MW
HD
SPR
SST
SST
SST
SST
SST
SPR
MW
HD
HD
SST
MW
SPR

E
N
D
S

CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
CG
C
C
CG
CG
C
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
C
CG
CG
CG
C
C
CG
C
C
CG

F
N
S
H

N
GI
N
N
N
Z
N
N
Z
Z
Z
N
Z
GI
N
N
Z
GI
N
N
N
Z
Z
N
Z
N
Z
N
N
Z
Z
Z
Z
Z
Z
Z
N
N
Z
N
GI
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
GI
Z
Z
N
N
Z
GI
N
Z
N
Z
Z
N
Z
Z
Z
N
N
N
N
N
Z
Z
GI
N
N
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 143

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625

15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88

B9-39
XX-56
A9-66
522
918
CC-24
S-766
S-286
10279
4205
S-58
K-59
A11-43
S-826
10888
S-68
2831
B12-58
3911
3192
10982
A9-69
W-30
AA-75
3129
3031
2799
B11-59
11456
N-53
S-767
12121
S-770
EE-40
S-367
944
2745
10354
BB-88
B15-24
S-1451
L-64
12289
3856
12469
10747
4317
S-1588
S-890
S-1423
12190
L-50
2972
12137
3980
S-117
10750
B15-58
NN-52
S-1055
B11-60
12267
2757
10050
S-768
1915
1909
S-771
10121
12768
10620
3137
A10-41
B6-14
B18-146
B11-64
11838
10632
3818
G-41

.66
.69
.72
.75
.75
.75
.75
.75
.75
.75
.78
.78
.81
.81
.84
.88
.88
.88
.88
.88
.88
.91
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.06
1.06
1.06
1.06
1.06
1.09
1.09
1.13
1.13
1.13
1.13
1.13
1.13
1.16
1.16
1.16
1.19
1.19
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.31
1.34
1.38
1.38
1.38

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

16.7
17.4
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.8
19.8
20.6
20.6
21.4
22.2
22.2
22.2
22.2
22.2
22.2
23.0
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.0
27.0
27.0
27.0
27.0
27.8
27.8
28.6
28.6
28.6
28.6
28.6
28.6
29.4
29.4
29.4
30.2
30.2
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
33.3
34.1
34.9
34.9
34.9

I.D.
Inches

.521
.545
.561
.543
.543
.525
.515
.481
.465
.415
.501
.445
.519
.425
.589
.549
.531
.515
.501
.439
.431
.543
.551
.505
.563
.539
.533
.529
.521
.517
.515
.509
.499
.485
.481
.465
.455
.471
.547
.535
.509
.491
.435
.371
.495
.415
.575
.507
.491
.481
.425
.415
.551
.525
.329
.561
.537
.537
.485
.481
.501
.545
.523
.515
.515
.511
.501
.499
.497
.475
.443
.431
.349
.487
.437
.501
.517
.481
.431
.415

RATE
mm

13.2
13.8
14.2
13.8
13.8
13.3
13.1
12.2
11.8
10.5
12.7
11.3
13.2
10.8
15.0
13.9
13.5
13.1
12.7
11.2
10.9
13.8
14.0
12.8
14.3
13.7
13.5
13.4
13.2
13.1
13.1
12.9
12.7
12.3
12.2
11.8
11.6
12.0
13.9
13.6
12.9
12.5
11.0
9.4
12.6
10.5
14.6
12.9
12.5
12.2
10.8
10.5
14.0
13.3
8.4
14.2
13.6
13.6
12.3
12.2
12.7
13.8
13.3
13.1
13.1
13.0
12.7
12.7
12.6
12.1
11.3
10.9
8.9
12.4
11.1
12.7
13.1
12.2
10.9
10.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

19
3.3
8.0
1.4
2.3
.41
10
1.8
6.8
1.2
16
2.8
27
4.8
50
8.7
182
32
414
73
69
12
154
27
23
4.0
247
43
.17
.03
4.7
.82
7.3
1.3
14
2.5
30
5.2
238
42
219
38
7.4
1.3
1.5
.26
28
4.8
2.1
.37
5.5
.97
13
2.3
11
2.0
14
2.4
13
2.3
19
3.3
11
2.0
32
5.6
50
8.8
50
8.7
121
21
159
28
51
9.0
3.3
.58
10
1.8
14
2.5
28
4.9
157
28
757 133
27
4.7
220
39
.58
.10
14
2.5
26
4.6
33
5.8
136
24
355
62
1.4
.24
12
2.1
1338 234
1.3
.22
5.5
.96
4.2
.74
45
7.8
29
5.2
30
5.2
6.1
1.1
10
1.8
14
2.4
15
2.5
19
3.4
24
4.2
23
4.1
27
4.8
61
11
118
21
173
30
860 151
38
6.6
150
26
40
6.9
11
1.9
29
5.2
133
23
178
31

.40
.47
.57
.42
.50
.46
.33
.32
.15
.14
.19
.24
.35
.19
.73
.69
.50
.49
.46
.17
.20
.58
.49
.45
.78
.68
.46
.61
.58
.62
.48
.36
.43
.37
.38
.23
.29
.42
.79
.56
.63
.53
.28
.13
.59
.24
.94
.65
.61
.55
.28
.16
.73
.61
.11
.93
.88
.81
.39
.56
.46
.65
.84
.71
.62
.55
.58
.58
.55
.52
.33
.27
.14
.49
.28
.35
.83
.67
.35
.33

mm

10
12
14
11
13
12
8.4
8.1
3.8
3.6
4.7
6.1
8.9
4.8
18
17
13
12
12
4.4
5.0
15
13
11
20
17
12
15
15
16
12
9.2
11
9.4
9.7
5.8
7.3
11
20
14
16
13
7.0
3.2
15
6.2
24
17
16
14
7.0
4.2
19
16
2.7
24
22
21
9.9
14
12
17
21
18
16
14
15
15
14
13
8.3
6.8
3.5
13
7.1
8.8
21
17
8.8
8.3

ENDS: C - Closed

G - Ground
O - Open

Lbs.

7.4
3.8
1.3
4.3
3.4
7.3
9.0
16
27
58
13
37
8.1
47
.12
3.2
3.6
7.0
14
41
43
4.3
.73
12
1.7
3.8
6.1
6.9
8.1
8.2
9.0
4.0
14
19
19
27
46
21
2.6
5.7
8.8
15
43
96
16
54
.54
9.3
16
18
37
58
1.0
7.3
143
1.2
4.8
3.4
17
16
14
4.0
8.7
9.6
9.0
11
14
14
15
32
38
46
118
19
42
14
9.1
20
46
58

33
17
5.9
19
15
32
40
70
122
258
57
165
36
208
.55
14
16
31
61
182
190
19
3.2
55
7.3
17
27
31
36
36
40
18
60
83
84
122
204
94
12
25
39
65
193
429
70
239
2.4
41
72
81
166
258
4.5
32
637
5.3
22
15
77
73
61
18
39
43
40
48
61
60
67
141
171
205
525
83
188
61
41
88
205
258

Inches

.26
.20
.15
.21
.25
.25
.29
.43
.32
.53
.22
.54
.23
.55
.12
.18
.38
.39
.37
.47
.53
.19
.44
.35
.19
.32
.21
.26
.36
.38
.34
.64
.41
.42
.43
.48
.43
.62
.27
.23
.44
.54
.67
.76
.49
.74
.19
.47
.50
.58
.85
.58
.43
.30
1.00
.26
.31
.37
.42
.63
.37
.20
.41
.40
.40
.41
.43
.49
.51
.56
.68
.68
1.00
.48
.66
.31
.43
.70
.82
.95

mm

Inches

6.6
5.1
3.8
5.2
6.2
6.4
7.3
11.0
8.1
13.3
5.5
13.7
5.8
14.0
3.0
4.6
9.6
9.8
9.4
11.8
13.6
4.9
11.3
8.8
4.7
8.2
5.3
6.7
9.2
9.6
8.7
16.2
10.4
10.7
11.0
12.2
10.8
15.6
6.9
5.7
11.0
13.6
16.9
19.4
12.4
18.7
4.8
12.0
12.8
14.6
21.6
14.7
10.8
7.6
25.4
6.5
7.8
9.5
10.7
16.0
9.4
5.1
10.4
10.1
10.1
10.5
11.0
12.4
13.0
14.3
17.3
17.2
25.4
12.3
16.7
7.9
11.0
17.8
20.9
24.0

0.052
0.040
0.032
0.041
0.041
0.050
0.055
0.072
0.080
0.105
0.062
0.090
0.053
0.100
0.018
0.038
0.047
0.055
0.062
0.093
0.097
0.041
0.037
0.060
0.031
0.043
0.046
0.048
0.052
0.054
0.055
0.058
0.063
0.070
0.072
0.080
0.085
0.077
0.039
0.045
0.058
0.067
0.095
0.127
0.065
0.105
0.025
0.059
0.067
0.072
0.100
0.105
0.037
0.050
0.148
0.032
0.044
0.044
0.070
0.072
0.062
0.040
0.051
0.055
0.055
0.057
0.062
0.063
0.064
0.075
0.091
0.097
0.138
0.069
0.094
0.062
0.054
0.072
0.097
0.105

mm

TOTAL
MATL
COILS

1.3
1.0
0.8
1.0
1.0
1.3
1.4
1.8
2.0
2.7
1.6
2.3
1.3
2.5
0.5
1.0
1.2
1.4
1.6
2.4
2.5
1.0
0.9
1.5
0.8
1.1
1.2
1.2
1.3
1.4
1.4
1.5
1.6
1.8
1.8
2.0
2.2
2.0
1.0
1.1
1.5
1.7
2.4
3.2
1.7
2.7
0.6
1.5
1.7
1.8
2.5
2.7
0.9
1.3
3.8
0.8
1.1
1.1
1.8
1.8
1.6
1.0
1.3
1.4
1.4
1.4
1.6
1.6
1.6
1.9
2.3
2.5
3.5
1.8
2.4
1.6
1.4
1.8
2.5
2.7

5.00
4.00
4.75
4.00
5.00
5.00
4.25
6.00
4.00
5.00
3.50
6.00
4.33
5.50
5.50
4.75
7.00
7.00
6.00
5.00
5.50
4.75
11.0
5.75
5.00
6.50
4.50
5.50
6.00
7.00
5.25
10.0
5.50
6.00
6.00
5.00
5.00
8.00
7.00
5.00
7.50
8.00
7.00
6.00
7.50
7.00
6.50
8.00
7.50
8.00
8.50
5.50
11.5
6.00
6.75
7.00
7.00
8.50
6.00
8.75
6.00
5.00
7.00
7.25
6.25
6.25
7.00
6.75
7.00
6.50
7.50
7.00
7.25
7.00
7.00
5.00
8.00
9.75
8.50
9.00

SPR
SST
SST
HD
HD
SPR
SST
SST
SPR
SPR
SST
SPR
SST
SST
SST
SST
HD
SPR
HD
SPR
SST
SPR
SPR
SPR
MW
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
HD
MW
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
MW
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SST
SPR
SPR
MW
SPR
SST
SPR
SPR
SST
HD
MW
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR

E
N
D
S

CG
C
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
C
CG
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
Z
Z
Z
N
N
Z
Z
N
N
N
N
N
N
Z
Z
Z
Z
N
Z
Z
N
Z
Z
GI
N
Z
GI
N
Z
N
N
N
Z
Z
Z
Z
N
N
N
GI
Z
Z
N
Z
N
N
N
Z
Z
Z
Z
N
N
Z
Z
N
N
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
Z
N
GI
N
Z
Z
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

143

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 144

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625

15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88

3879
A10-59
S-1225
10452
11473
523
S-1186
4213
S-769
S-772
S-773
XX-58
11304
11445
3917
3252
11688
4128
3887
4125
S-774
882
S-3259
B18-134
S-1568
11124
3209
4295
B32-32
11852
S-775
B8-28
12272
11767
11295
B18-153
S-1470
4260
916
2672
11438
S-809
47
Q-42
2512
2838
S-776
1787
23
12279
S-1371
S-871
1791
11654
S-91
21
1607
3246
51
B9-65
11181
12135
S-1681
1906
11340
19
3499
3694
3797
2528
S-3132
2596
4156
2820
12107
S-1037
12314
S-364
S-419
925

1.44
1.44
1.44
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.63
1.63
1.69
1.69
1.69
1.75
1.75
1.75
1.78
1.78
1.81
1.81
1.84
1.88
1.91
2.00
2.00
2.00
2.09
2.09
2.19
2.22
2.25
2.25
2.25
2.25
2.25
2.31
2.38
2.44
2.44
2.44
2.50
2.50
2.50
2.50
2.50
2.53
2.53
2.56
2.63
2.75
2.75
2.75
2.75
2.81
2.88
2.88
3.00
3.00
3.00
3.00
3.00
3.13
3.13
3.19
3.25
3.50
3.50
3.50
3.50
3.75
4.00
4.19
4.50
4.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

36.5
36.5
36.5
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
41.3
41.3
42.8
42.8
42.8
44.5
44.5
44.5
45.2
45.2
46.0
46.0
46.8
47.6
48.4
50.8
50.8
50.8
53.2
53.2
55.6
56.4
57.2
57.2
57.2
57.2
57.2
58.7
60.3
61.9
61.9
61.9
63.5
63.5
63.5
63.5
63.5
64.3
64.3
65.1
66.7
69.9
69.9
69.9
69.9
71.4
73.0
73.0
76.2
76.2
76.2
76.2
76.2
79.4
79.4
81.0
82.6
88.9
88.9
88.9
88.9
95.3
101.6
106.4
114.3
114.3

MATERIAL: MW - Music Wire

144

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.551
.481
.455
.477
.555
.543
.531
.529
.515
.499
.481
.481
.451
.435
.529
.465
.531
.445
.355
.481
.481
.443
.565
.329
.497
.443
.443
.531
.483
.567
.481
.475
.501
.465
.459
.425
.559
.501
.481
.415
.401
.355
.415
.483
.415
.385
.481
.465
.465
.453
.329
.463
.329
.495
.375
.517
.515
.481
.385
.415
.529
.475
.565
.531
.501
.465
.465
.513
.395
.461
.415
.573
.531
.399
.389
.375
.515
.465
.449
.415

RATE
mm

14.0
12.2
11.6
12.1
14.1
13.8
13.5
13.4
13.1
12.7
12.2
12.2
11.5
11.0
13.4
11.8
13.5
11.3
9.0
12.2
12.2
11.3
14.4
8.4
12.6
11.3
11.3
13.5
12.3
14.4
12.2
12.1
12.7
11.8
11.7
10.8
14.2
12.7
12.2
10.5
10.2
9.0
10.5
12.3
10.5
9.8
12.2
11.8
11.8
11.5
8.4
11.8
8.4
12.6
9.5
13.1
13.1
12.2
9.8
10.5
13.4
12.1
14.4
13.5
12.7
11.8
11.8
13.0
10.0
11.7
10.5
14.6
13.5
10.1
9.9
9.5
13.1
11.8
11.4
10.5

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

1.5
.26
29
5.0
64
11
32
5.6
1.4
.25
3.4
.60
5.3
.92
6.9
1.2
12
2.1
19
3.4
32
5.6
28
5.0
82
14
157
28
3.6
.63
40
7.1
3.5
.61
103
18
541
95
33
5.7
26
4.6
72
13
1.2
.21
794 139
15
2.7
66
12
65
11
8.1
1.4
19
3.3
.87
.15
23
4.0
29
5.0
13
2.3
33
5.8
37
6.5
81
14
1.4
.25
13
2.3
20
3.5
113
20
134
23
483
85
104
18
16
2.8
124
22
209
37
18
3.1
29
5.1
32
5.7
36
6.3
460
81
32
5.6
508
89
12
2.1
212
37
5.8
1.0
4.4
.78
18
3.1
162
28
72
13
3.6
.63
20
3.4
.80
.14
4.0
.71
9.2
1.6
26
4.6
24
4.2
5.9
1.0
118
21
29
5.1
64
11
.31
.05
3.8
.67
97
17
122
21
122
21
5.9
1.0
18
3.1
16
2.8
65
11

.99
.71
.48
.68
1.1
1.1
1.1
1.0
.77
.70
.59
.67
.40
.39
.95
.68
1.1
.36
.21
.62
.71
.53
1.4
.15
.93
.58
.59
.80
.95
1.8
.83
.79
1.0
.83
.82
.62
1.5
1.0
1.0
.51
.50
.21
.56
1.2
.65
.58
1.1
.94
.85
.95
.28
.84
.39
1.3
.40
1.6
1.7
1.1
.51
.74
1.9
1.2
2.1
1.6
1.5
1.0
1.1
1.7
.61
1.4
.85
3.2
1.7
1.0
.64
.69
1.6
1.5
1.6
.89

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

25
18
12
17
29
29
27
25
20
18
15
17
10
9.8
24
17
28
9.2
5.2
16
18
14
34
3.9
24
15
15
20
24
45
21
20
26
21
21
16
39
26
26
13
13
5.3
14
31
17
15
27
24
22
24
7.1
21
9.8
33
10
40
43
29
13
19
48
30
53
41
38
26
29
44
16
36
21
80
43
25
16
18
41
37
42
23

Lbs.

1.5
20
31
22
1.7
3.8
5.7
6.9
9.0
14
19
19
33
61
3.4
27
3.8
37
111
20
19
38
1.7
122
14
38
38
6.5
18
1.6
19
23
14
27
31
50
2.2
14
20
58
68
100
58
19
81
120
19
27
27
34
129
27
196
16
84
9.1
7.6
20
82
54
6.9
23
1.7
6.5
14
27
27
10
73
41
54
.97
6.5
97
78
84
9.6
26
26
58

ENDS: C - Closed

G - Ground
O - Open

6.5
90
137
97
7.4
17
25
31
40
60
84
84
146
270
15
122
17
165
494
90
84
171
7.4
541
63
171
171
29
81
6.9
84
101
61
122
136
224
9.8
61
90
258
300
445
258
86
361
535
84
122
122
151
574
119
871
70
374
41
34
90
366
239
31
101
7.4
29
61
122
122
45
324
184
239
4.3
29
430
349
374
43
114
116
258

Inches

.44
.72
.72
.74
.36
.37
.42
.42
.45
.55
.67
.65
.76
.67
.67
.88
.59
.81
1.28
.72
.76
1.09
.18
1.63
.64
1.16
1.09
.31
.85
.22
.85
.86
.68
1.04
1.12
1.43
.23
.74
1.04
1.37
1.62
1.37
1.47
1.17
1.37
1.60
1.03
1.24
1.14
1.38
2.07
1.01
2.15
.98
1.69
.77
1.05
1.08
1.95
1.81
.62
1.20
.24
.56
.99
1.34
1.44
.84
2.07
1.31
2.00
.34
.59
2.26
2.30
2.75
.83
1.60
2.86
2.31

mm

11.3
18.3
18.4
18.8
9.1
9.4
10.7
10.7
11.5
14.0
16.9
16.5
19.3
16.9
17.1
22.4
14.9
20.6
32.6
18.3
19.2
27.7
4.6
41.4
16.3
29.5
27.7
7.8
21.6
5.5
21.5
21.9
17.3
26.4
28.5
36.2
5.9
18.9
26.5
34.7
41.2
34.8
37.3
29.8
34.7
40.5
26.1
31.5
29.0
35.0
52.6
25.7
54.5
24.8
42.9
19.6
26.5
27.4
49.5
46.0
15.8
30.5
6.1
14.3
25.2
34.0
36.6
21.3
52.6
33.3
50.7
8.6
14.9
57.4
58.4
69.9
21.0
40.6
72.6
58.7

WIRE DIA.
Inches

0.037
0.072
0.085
0.074
0.035
0.041
0.047
0.048
0.055
0.063
0.072
0.072
0.087
0.095
0.048
0.080
0.047
0.090
0.135
0.072
0.072
0.091
0.030
0.148
0.064
0.091
0.091
0.047
0.071
0.029
0.072
0.075
0.062
0.080
0.083
0.100
0.033
0.062
0.072
0.105
0.112
0.135
0.105
0.071
0.105
0.120
0.072
0.080
0.080
0.086
0.148
0.081
0.148
0.065
0.125
0.054
0.055
0.072
0.120
0.105
0.048
0.075
0.030
0.047
0.062
0.080
0.080
0.056
0.115
0.082
0.105
0.026
0.047
0.113
0.118
0.125
0.055
0.080
0.088
0.105

mm

TOTAL
MATL
COILS

0.9
1.8
2.2
1.9
0.9
1.0
1.2
1.2
1.4
1.6
1.8
1.8
2.2
2.4
1.2
2.0
1.2
2.3
3.4
1.8
1.8
2.3
0.8
3.8
1.6
2.3
2.3
1.2
1.8
0.7
1.8
1.9
1.6
2.0
2.1
2.5
0.8
1.6
1.8
2.7
2.8
3.4
2.7
1.8
2.7
3.1
1.8
2.0
2.0
2.2
3.8
2.1
3.8
1.7
3.2
1.4
1.4
1.8
3.0
2.7
1.2
1.9
0.8
1.2
1.6
2.0
2.0
1.4
2.9
2.1
2.7
0.7
1.2
2.9
3.0
3.2
1.4
2.0
2.2
2.7

11.0
10.0
8.50
10.0
9.25
8.00
8.00
7.75
7.25
7.75
8.25
9.00
7.75
7.00
13.0
11.0
12.5
8.00
9.50
9.00
9.50
11.0
6.00
10.0
10.0
11.8
12.0
6.50
12.0
7.50
10.8
11.5
11.0
13.0
13.5
14.3
7.00
11.0
13.5
13.0
14.5
10.0
14.0
15.5
12.0
13.0
13.3
14.5
13.3
16.0
14.0
12.5
14.5
14.0
13.5
13.3
18.0
15.0
16.3
17.3
13.0
16.0
8.00
11.0
15.0
15.8
17.0
15.0
18.0
16.0
19.0
12.0
11.5
20.0
19.5
22.0
14.0
20.0
32.5
21.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SST
SPR
MW
HD
SST
SPR
SST
SST
SST
SST
SST
MW
HD
HD
SPR
SPR
SPR
SPR
SST
HD
SST
SPR
SST
HD
SPR
SPR
SST
MW
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
HD
SPR
SPR
SST
HD
SPR
MW
MW
SST
SPR
HD
SPR
SST
SST
MW
SPR
SST
HD
SPR
SPR
HD
SST
SPR
SPR
SST
SPR
HD
HD
HD
SPR
SPR
MW
SST
MW
HD
MW
SPR
SST
HD
SST
SST
HD

E
N
D
S

C
CG
CG
CG
C
C
C
C
C
C
C
CG
C
CG
C
CG
CG
C
CG
C
C
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
C
CG
C
C
C
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
C

F
N
S
H

Z
Z
N
Z
Z
Z
N
Z
N
N
N
N
N
Z
Z
Z
Z
Z
Z
Z
N
Z
N
N
N
Z
Z
Z
N
N
N
N
Z
Z
Z
Z
N
Z
Z
Z
Z
N
Z
N
Z
Z
N
Z
Z
Z
N
N
Z
Z
N
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
N
Z
GI
Z
Z
N
Z
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 145

Inches

mm

CENTURY
STOCK
NUMBER

0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.625
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640

15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
15.88
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26

1899
12419
12441
874
3803
870
1657
3334
1944
888
10542
10150
4143
881
878
876
S-3045
S-105
B10-13
O-70
S-1187
3181
10124
B15-27
3248
S-1106
QQ-61
3221
10595
S-889
KK-30
S-1428
BB-96
10134
10789
GG-94
MM-52
S-3197
10787
UU-53
3144
H-30
2763
S-1571
A15-35
GG-48
2669
B7-58
11901
A14-68
A14-69
S-1248
10240
11158
10408
3387
A14-41
10559
2705
S-411
G-59
A13-47
B6-67
10082
10418
3894
Q-50
3738
Q-9
B11-45
11732
3001
A15-47
1553
B17-157
10617
MM-85
11797
S-1206
A15-65

O.D.

FREE LENGTH
Inches

4.81
4.84
4.94
5.00
5.00
5.00
6.00
6.00
7.00
9.00
9.50
9.75
11.9
12.0
12.0
12.0
15.0
.34
.38
.41
.41
.44
.50
.50
.63
.63
.69
.69
.69
.75
.75
.75
.84
.88
.88
.94
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.13
1.16
1.16
1.19
1.19
1.19
1.25
1.25
1.25
1.25
1.28
1.31
1.36
1.38
1.38
1.44
1.47
1.50
1.50
1.50
1.50
1.50
1.53
1.56
1.59
1.63
1.63
1.75
1.75
1.81
1.81
1.84
1.88
2.00

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

122.2
123.0
125.4
127.0
127.0
127.0
152.4
152.4
177.8
228.6
241.3
247.7
301.6
304.8
304.8
304.8
381.0
8.7
9.5
10.3
10.3
11.1
12.7
12.7
15.9
15.9
17.4
17.4
17.4
19.1
19.1
19.1
21.4
22.2
22.2
23.8
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
26.2
26.2
28.6
29.4
29.4
30.2
30.2
30.2
31.8
31.8
31.8
31.8
32.5
33.3
34.5
34.9
34.9
36.5
37.3
38.1
38.1
38.1
38.1
38.1
38.9
39.7
40.5
41.3
41.3
44.5
44.5
46.0
46.0
46.8
47.6
50.8

I.D.
Inches

.449
.443
.441
.443
.441
.415
.517
.481
.455
.465
.477
.443
.481
.501
.481
.465
.491
.582
.508
.516
.506
.512
.516
.500
.564
.560
.522
.518
.430
.542
.540
.430
.490
.512
.470
.532
.520
.468
.470
.550
.546
.528
.474
.468
.548
.520
.396
.558
.552
.548
.530
.506
.538
.528
.516
.480
.530
.536
.440
.530
.480
.528
.560
.516
.480
.480
.452
.450
.572
.390
.574
.560
.556
.590
.514
.530
.380
.540
.558
.558

RATE
mm

11.4
11.3
11.2
11.3
11.2
10.5
13.1
12.2
11.6
11.8
12.1
11.3
12.2
12.7
12.2
11.8
12.5
14.8
12.9
13.1
12.9
13.0
13.1
12.7
14.3
14.2
13.3
13.2
10.9
13.8
13.7
10.9
12.4
13.0
11.9
13.5
13.2
11.9
11.9
14.0
13.9
13.4
12.0
11.9
13.9
13.2
10.1
14.2
14.0
13.9
13.5
12.9
13.7
13.4
13.1
12.2
13.5
13.6
11.2
13.5
12.2
13.4
14.2
13.1
12.2
12.2
11.5
11.4
14.5
9.9
14.6
14.2
14.1
15.0
13.1
13.5
9.7
13.7
14.2
14.2

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

24
4.3
27
4.7
27
4.7
24
4.2
25
4.4
41
7.1
2.8
.49
5.8
1.0
15
2.6
8.4
1.5
6.1
1.1
15
2.5
4.0
.70
2.1
.36
3.5
.62
6.2
1.1
1.9
.34
3.1
.54
57
10
110
19
134
23
126
22
55
9.6
110
19
9.2
1.6
3.7
.65
44
7.8
51
9.0
368
64
9.2
1.6
22
3.8
397
70
37
6.4
42
7.4
111
19
13
2.3
32
5.6
117
21
110
19
7.0
1.2
5.2
.91
18
3.1
175
31
126
22
11
1.9
19
3.3
688 120
6.9
1.2
7.8
1.4
8.4
1.5
19
3.4
27
4.7
24
4.2
18
3.1
31
5.5
56
9.8
18
3.1
15
2.6
228
40
9.1
1.6
42
7.3
13
2.3
4.9
.85
20
3.5
42
7.3
48
8.4
73
13
80
14
2.0
.36
321
56
1.5
.27
2.9
.51
3.7
.65
.44
.08
18
3.2
5.3
.92
344
60
5.5
.96
1.6
.29
2.1
.37

2.1
1.4
1.5
1.6
1.6
1.4
3.2
3.0
2.2
3.3
3.6
2.6
5.0
6.7
5.7
4.4
8.4
.22
.09
.12
.12
.12
.19
.15
.37
.35
.26
.25
.14
.46
.32
.13
.24
.35
.27
.61
.38
.27
.29
.69
.55
.56
.24
.25
.51
.61
.12
.61
.66
.66
.46
.59
.32
.56
.43
.48
.54
.54
.22
.92
.60
.70
.81
.67
.64
.56
.42
.46
1.2
.28
1.4
1.3
1.1
1.5
.77
.96
.29
1.3
1.3
1.6

mm

53
36
38
41
40
36
82
77
56
83
91
67
128
169
145
112
214
5.6
2.4
3.1
3.0
3.0
4.8
3.9
9.3
8.8
6.6
6.3
3.6
12
8.2
3.4
6.2
8.9
6.9
16
9.7
6.7
7.4
17
14
14
6.1
6.3
13
16
3.1
16
17
17
12
15
8.0
14
11
12
14
14
5.5
23
15
18
20
17
16
14
11
12
32
7.2
35
33
29
39
20
24
7.2
33
34
40

ENDS: C - Closed

G - Ground
O - Open

Lbs.

51
38
40
38
40
58
9.1
17
33
27
22
38
20
14
20
27
16
.68
5.4
13
16
15
10
17
3.4
1.3
12
13
53
4.2
7.1
53
8.9
15
30
8.1
12
31
32
4.8
2.9
9.9
42
31
5.6
12
84
4.2
5.2
5.6
8.8
16
7.5
9.9
13
27
9.4
8.0
49
8.4
25
9.3
3.9
13
27
27
30
37
2.5
90
2.1
3.8
4.2
.67
14
5.0
98
7.1
2.2
3.3

225
171
176
171
176
258
41
77
146
122
97
171
90
61
90
122
72
3.0
24
60
70
65
46
76
15
5.7
51
57
234
19
32
234
40
65
134
36
54
138
143
21
13
44
186
138
25
52
376
19
23
25
39
70
33
44
60
120
42
35
220
37
112
41
17
60
120
120
135
163
11
402
9.2
17
19
3.0
62
22
437
32
9.8
15

Inches

2.18
2.37
2.62
2.64
2.76
3.43
1.42
2.99
2.98
3.72
3.33
4.32
4.32
3.78
4.86
4.92
5.19
.12
.28
.19
.20
.19
.31
.25
.17
.28
.30
.24
.50
.29
.20
.47
.60
.32
.47
.32
.30
.47
.51
.32
.45
.34
.44
.45
.21
.42
.77
.24
.23
.29
.28
.47
.26
.34
.34
.64
.32
.29
.60
.45
.72
.43
.26
.47
.80
.72
1.08
1.05
.21
1.25
.23
.32
.34
.21
.54
.85
1.43
.50
.53
.41

mm

Inches

55.3
60.1
66.6
67.0
70.1
87.1
36.0
75.9
75.6
94.5
84.6
109.8
109.7
96.1
123.4
125.0
131.9
3.1
7.1
4.7
5.1
4.9
7.9
6.2
4.3
7.1
7.5
6.2
12.7
7.3
5.1
12.0
15.2
8.1
11.9
8.2
7.6
12.0
13.0
8.0
11.3
8.5
11.1
11.5
5.3
10.7
19.6
6.0
5.9
7.3
7.0
11.9
6.5
8.5
8.7
16.3
8.0
7.3
15.2
11.5
18.3
11.0
6.6
11.8
20.3
18.3
27.5
26.5
5.4
31.8
5.9
8.0
8.5
5.4
13.6
21.7
36.3
12.7
13.5
10.4

0.088
0.091
0.092
0.091
0.092
0.105
0.054
0.072
0.085
0.080
0.074
0.091
0.072
0.062
0.072
0.080
0.067
0.029
0.066
0.062
0.067
0.064
0.062
0.070
0.038
0.040
0.059
0.061
0.105
0.049
0.050
0.105
0.075
0.064
0.085
0.054
0.060
0.086
0.085
0.045
0.047
0.056
0.083
0.086
0.046
0.060
0.122
0.041
0.044
0.046
0.055
0.067
0.051
0.056
0.062
0.080
0.055
0.052
0.100
0.055
0.080
0.056
0.040
0.062
0.080
0.080
0.094
0.095
0.034
0.125
0.033
0.040
0.042
0.025
0.063
0.055
0.130
0.050
0.041
0.041

mm

TOTAL
MATL
COILS

2.2
2.3
2.3
2.3
2.3
2.7
1.4
1.8
2.2
2.0
1.9
2.3
1.8
1.6
1.8
2.0
1.7
0.7
1.7
1.6
1.7
1.6
1.6
1.8
1.0
1.0
1.5
1.5
2.7
1.2
1.3
2.7
1.9
1.6
2.2
1.4
1.5
2.2
2.2
1.1
1.2
1.4
2.1
2.2
1.2
1.5
3.1
1.0
1.1
1.2
1.4
1.7
1.3
1.4
1.6
2.0
1.4
1.3
2.5
1.4
2.0
1.4
1.0
1.6
2.0
2.0
2.4
2.4
0.9
3.2
0.8
1.0
1.1
0.6
1.6
1.4
3.3
1.3
1.0
1.0

24.8
26.0
27.5
29.0
29.0
32.7
25.3
41.5
34.0
45.5
44.0
46.5
59.0
60.0
66.0
60.0
77.0
3.25
4.25
3.00
3.00
3.00
4.00
3.50
3.50
6.00
4.00
4.00
4.75
6.00
4.00
4.50
8.00
5.00
5.50
6.00
5.00
5.50
6.00
6.00
8.50
6.00
4.25
5.25
4.50
7.00
5.33
4.75
5.25
5.25
5.00
7.00
4.00
6.00
5.50
8.00
5.75
5.50
6.00
8.25
9.00
6.75
5.50
7.50
10.0
9.00
11.5
11.0
6.25
10.0
7.00
7.88
7.00
7.50
8.50
14.5
11.0
10.0
12.0
10.0

MW
SPR
SPR
HD
SPR
HD
SPR
HD
SPR
HD
SPR
SPR
HD
HD
HD
HD
SST
SST
SST
SPR
SST
SPR
HD
SST
SPR
SST
SPR
SPR
SST
SST
SPR
SST
SST
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
MW
SST
SST
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
HD
SPR
HD
SPR
SPR
SPR
SPR
SPR
SPR
SST
MW
SPR
SPR
SPR
SPR
SST
SST

E
N
D
S

F
N
S
H

CG
CG
C
CG
CG
CG
C
CG
C
C
C
C
C
C
C
C
CG
C
CG
CG
CG
CG
C
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
CG
CG
C
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
C
CG
CG
C
CG

Z
N
N
Z
Z
Z
Z
GI
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
Z
N
GI
Z
N
Z
N
GI
GI
N
N
Z
N
N
Z
N
N
Z
N
N
Z
Z
Z
Z
N
N
BO
Z
N
N
N
N
N
Z
Z
Z
Z
N
Z
Z
N
N
N
N
GI
Z
Z
N
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

145

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 146

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.640
0.653
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656

16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.26
16.59
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66

10335
11750
12580
4316
S-321
3808
LL-96
2926
RR-11
10522
11374
11596
2624
S-805
12455
S-3037
10414
11800
10771
3437
3154
1593
3332
1531
11691
10152
12682
10241
B4-70
3645
II-97
1763
S-883
12266
A-48
OO-48
A11-28
S-1264
S-1210
I-59
S-1403
A15-69
S-1135
S-479
B11-57
A14-64
A14-52
S-135
A14-63
S-1391
S-1102
B9-57
H-9
10327
S-269
11228
1601
Y-26
10453
B12-5
S-425
B1-64
10794
4330
11566
11420
10264
10712
11129
10960
A15-56
10807
B15-42
S-171
S-1402
B8-36
2608
12305
10196
10663

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

2.00
2.00
2.00
2.13
2.19
2.25
2.38
2.47
2.50
2.63
2.63
2.69
2.91
2.94
3.00
3.25
3.31
3.50
4.00
4.50
4.50
4.88
6.00
8.00
9.75
11.0
.69
.34
.38
.38
.44
.47
.53
.56
.66
.69
.69
.69
.75
.75
.75
.75
.81
.81
.84
1.00
1.00
1.00
1.03
1.03
1.06
1.06
1.13
1.13
1.13
1.13
1.13
1.13
1.19
1.25
1.28
1.28
1.31
1.31
1.34
1.38
1.38
1.41
1.41
1.41
1.47
1.47
1.50
1.50
1.50
1.53
1.53
1.63
1.69
1.69

mm

50.8
50.8
50.8
54.0
55.6
57.2
60.3
62.7
63.5
66.7
66.7
68.2
73.8
74.6
76.2
82.6
84.1
88.9
101.6
114.3
114.3
123.8
152.4
203.2
247.7
279.4
17.4
8.7
9.5
9.5
11.1
11.9
13.5
14.3
16.7
17.4
17.4
17.4
19.1
19.1
19.1
19.1
20.6
20.6
21.4
25.4
25.4
25.4
26.2
26.2
27.0
27.0
28.6
28.6
28.6
28.6
28.6
28.6
30.2
31.8
32.5
32.5
33.3
33.3
34.1
34.9
34.9
35.7
35.7
35.7
37.3
37.3
38.1
38.1
38.1
38.9
38.9
41.3
42.8
42.8

MATERIAL: MW - Music Wire

146

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.546
.516
.480
.530
.316
.430
.480
.532
.568
.516
.496
.370
.430
.558
.480
.430
.430
.526
.478
.530
.480
.400
.496
.500
.458
.570
.527
.496
.600
.574
.574
.562
.546
.556
.296
.576
.560
.474
.574
.564
.532
.504
.592
.544
.520
.568
.542
.512
.562
.474
.576
.572
.562
.548
.548
.526
.476
.406
.522
.548
.548
.540
.564
.536
.496
.512
.466
.612
.592
.590
.572
.564
.532
.446
.430
.456
.432
.446
.612
.606

RATE
mm

13.9
13.1
12.2
13.5
8.0
10.9
12.2
13.5
14.4
13.1
12.6
9.4
10.9
14.2
12.2
10.9
10.9
13.4
12.1
13.5
12.2
10.2
12.6
12.7
11.6
14.5
13.4
12.6
15.2
14.6
14.6
14.3
13.9
14.1
7.5
14.6
14.2
12.0
14.6
14.3
13.5
12.8
15.0
13.8
13.2
14.4
13.8
13.0
14.3
12.0
14.6
14.5
14.3
13.9
13.9
13.4
12.1
10.3
13.3
13.9
13.9
13.7
14.3
13.6
12.6
13.0
11.8
15.5
15.0
15.0
14.5
14.3
13.5
11.3
10.9
11.6
11.0
11.3
15.5
15.4

Lbs./In.

N/mm

3.2
.56
12
2.1
36
6.3
8.2
1.4
956 167
104
18
30
5.2
6.1
1.1
1.3
.23
10
1.8
20
3.5
278
49
71
12
1.6
.27
24
4.2
58
10
67
12
7.7
1.3
18
3.1
3.9
.68
19
3.3
92
16
5.2
.91
5.6
.98
13
2.3
.28
.05
32
5.6
411
72
3.1
.54
17
3.1
15
2.7
18
3.1
28
4.9
17
3.0
13992 2450
5.2
.92
15
2.6
136
24
7.6
1.3
8.2
1.4
44
7.7
67
12
2.4
.42
24
4.3
60
11
8.3
1.5
26
4.5
42
7.4
12
2.2
106
18
4.2
.74
4.3
.75
10
1.8
12
2.2
13
2.3
33
5.8
87
15
1172 205
30
5.2
14
2.5
13
2.4
19
3.3
7.2
1.3
12
2.1
56
9.8
43
7.5
111
19
.29
.05
2.1
.36
1.7
.29
4.9
.86
4.2
.73
10
1.8
121
21
318
56
99
17
201
35
116
20
.20
.03
.34
.06

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

Lbs.

1.4
36
1.1
28
.74 19
1.1
29
.16
4.1
.55 14
.85 22
1.5
37
2.1
53
1.3
34
.91 23
.39 10
.80 20
2.4
61
1.1
29
.90 23
.85 22
1.4
35
1.6
40
2.4
62
1.4
36
.87 22
2.9
73
3.2
82
2.8
71
9.5 241
.31
7.8
.06
1.6
.26
6.7
.21
5.4
.25
6.4
.25
6.2
.31
7.8
.35
8.8
.02
.40
.45 11
.41 10
.19
4.7
.51 13
.52 13
.28
7.1
.32
8.0
.64 16
.37
9.5
.28
7.2
.57 14
.40 10
.43 11
.50 13
.32
8.2
.81 21
.79 20
.60 15
.70 18
.63 16
.45 12
.41 10
.08
1.9
.55 14
.62 16
.61 15
.56 14
.76 19
.74 19
.47 12
.45 11
.38
9.6
1.2
32
1.0
25
1.2
30
.85 21
1.1
28
.76 19
.43 11
.19
4.8
.45 12
.32
8.2
.47 12
1.5
37
1.4
37

4.5
13
27
9.4
156
57
25
8.9
2.7
13
18
109
57
3.7
27
53
57
10
28
9.4
27
81
15
18
38
2.6
9.9
26
.82
3.7
3.9
4.3
8.6
6.0
218
2.3
6.2
25
3.9
4.3
12
21
1.5
9.1
17
4.8
10
18
6.2
34
3.4
3.4
6.2
8.7
8.2
15
35
89
16
8.7
8.2
11
5.4
8.7
26
19
42
.36
2.1
1.9
4.1
4.6
7.7
52
61
45
65
55
.29
.50

ENDS: C - Closed

G - Ground
O - Open

20
60
120
42
693
253
112
40
12
60
82
485
253
17
120
234
253
46
124
42
120
358
66
81
167
12
44
117
3.6
16
17
19
38
27
968
10
27
113
17
19
55
94
6.9
41
76
21
45
80
27
152
15
15
27
39
36
67
156
394
73
39
36
48
24
39
117
86
185
1.6
9.2
8.6
18
21
34
229
270
199
288
243
1.3
2.2

Inches

mm

.59 14.9
.68 17.3
.98 24.9
.55 14.0
1.66 42.2
1.61 40.8
.96 24.4
.65 16.5
.41 10.5
.81 20.5
.81 20.6
2.20 56.0
2.00 50.7
.55 14.1
1.36 34.5
2.10 53.3
2.00 50.7
.74 18.8
1.78 45.3
1.10 27.9
1.57 40.0
3.00 76.2
3.13 79.6
2.54 64.5
4.23 107.5
1.33 33.8
.38
9.6
.22
5.6
.11
2.8
.16
4.2
.16
4.2
.22
5.7
.21
5.4
.22
5.5
.54 13.7
.24
6.1
.19
4.9
.50 12.7
.21
5.2
.23
5.8
.25
6.3
.40 10.1
.17
4.3
.24
6.2
.31
7.8
.20
5.0
.27
6.9
.50 12.8
.21
5.4
.59 15.0
.25
6.4
.27
6.9
.24
6.0
.41 10.3
.36
9.3
.37
9.5
.72 18.3
.50 12.7
.45 11.5
.32
8.2
.30
7.7
.41 10.3
.25
6.4
.57 14.5
.68 17.3
.54 13.7
.86 21.7
.17
4.2
.19
4.9
.24
6.1
.23
5.9
.37
9.3
.74 18.9
1.00 25.3
.68 17.2
.95 24.1
1.01 25.6
1.16 29.3
.22
5.5
.24
6.0

WIRE DIA.
Inches

0.047
0.062
0.080
0.055
0.162
0.105
0.080
0.054
0.036
0.062
0.072
0.135
0.105
0.041
0.080
0.105
0.105
0.057
0.081
0.055
0.080
0.120
0.072
0.070
0.091
0.035
0.063
0.080
0.028
0.041
0.041
0.047
0.055
0.050
0.180
0.040
0.048
0.091
0.041
0.046
0.062
0.076
0.032
0.056
0.068
0.044
0.057
0.072
0.047
0.091
0.040
0.042
0.047
0.054
0.054
0.065
0.090
0.125
0.067
0.054
0.054
0.058
0.046
0.060
0.080
0.072
0.095
0.022
0.032
0.033
0.042
0.046
0.062
0.105
0.113
0.100
0.112
0.105
0.022
0.025

mm

TOTAL
MATL
COILS

1.2
1.6
2.0
1.4
4.1
2.7
2.0
1.4
0.9
1.6
1.8
3.4
2.7
1.0
2.0
2.7
2.7
1.4
2.1
1.4
2.0
3.0
1.8
1.8
2.3
0.9
1.6
2.0
0.7
1.0
1.0
1.2
1.4
1.3
4.6
1.0
1.2
2.3
1.0
1.2
1.6
1.9
0.8
1.4
1.7
1.1
1.4
1.8
1.2
2.3
1.0
1.1
1.2
1.4
1.4
1.7
2.3
3.2
1.7
1.4
1.4
1.5
1.2
1.5
2.0
1.8
2.4
0.6
0.8
0.8
1.1
1.2
1.6
2.7
2.9
2.5
2.8
2.7
0.6
0.6

12.5
11.0
11.3
10.0
10.3
14.0
12.0
12.0
10.5
13.0
11.3
15.3
18.0
12.5
16.0
19.0
19.0
12.0
22.0
19.0
19.8
25.0
42.5
35.3
46.5
37.0
5.00
2.75
3.00
3.00
3.00
3.75
4.00
4.25
3.00
5.00
4.00
5.50
4.00
5.00
4.00
5.25
4.25
4.25
4.50
4.50
4.75
6.00
4.50
6.50
5.25
6.50
5.00
6.50
5.75
5.75
8.00
4.00
6.75
6.00
5.75
6.00
5.50
9.50
7.50
6.50
8.00
6.50
5.00
6.25
5.50
8.00
12.0
9.50
6.00
9.50
9.00
11.0
8.75
8.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
HD
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
HD
SPR
SPR
SPR
SST
SPR
SST
HD
SST
HD
SST
SPR
HD
SPR
SST
SST
SST
SST
SST
SST
SST
SST
SPR
SST
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
MW
HD
SPR
SST
SST
SPR
SST
SST
SST
SPR
SPR
MW
MW

E
N
D
S

CG
CG
C
CG
CG
C
CG
CG
C
CG
CG
CG
C
C
C
C
CG
C
CG
C
CG
CG
C
C
CG
C
C
CG
C
C
C
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C

F
N
S
H

Z
Z
N
Z
N
Z
N
Z
Z
Z
N
Z
Z
N
Z
N
Z
Z
GI
Z
Z
Z
Z
Z
GI
Z
N
Z
N
Z
N
Z
N
Z
Z
GI
N
N
N
N
N
N
N
N
Z
N
GI
N
GI
N
N
N
GI
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
N
Z
Z
Z
Z
N
N
N
Z
N
N
N
Z
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:27 AM Page 147

Inches

mm

CENTURY
STOCK
NUMBER

0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.656
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660

16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.66
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76

1715
4186
A14-12
10157
S-1148
11882
11723
B18-179
4256
11682
3130
2656
N-124
2514
S-1121
11616
1635
10997
S-3179
S-1525
11393
11811
3337
2684
4265
1883
2805
1825
10289
12116
4019
71865
71865S
71877
71877S
71889
71889S
71901
71901S
71913
71913S
71866
71866S
71878
71878S
71890
71890S
71902
71902S
71914
71914S
71867
71867S
71879
71879S
71891
71891S
71903
71903S
71915
71915S
71868
71868S
71880
71880S
71892
71892S
71904
71904S
71916
71916S
71869
71869S
71881
71881S
71893
71893S
71905
71905S
71917

O.D.

FREE LENGTH
Inches

1.75
1.75
1.75
1.78
1.88
1.91
1.97
2.00
2.00
2.03
2.06
2.25
2.50
2.53
2.63
2.84
2.88
3.06
3.31
3.50
3.50
3.59
4.00
4.94
6.00
6.50
6.63
7.75
9.50
11.1
18.5
.63
.63
.63
.63
.63
.63
.63
.63
.63
.63
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

44.5
44.5
44.5
45.2
47.6
48.4
50.0
50.8
50.8
51.6
52.4
57.2
63.5
64.3
66.7
72.2
73.0
77.8
84.1
88.9
88.9
91.3
101.6
125.4
152.4
165.1
168.3
196.9
241.3
281.8
469.9
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8

I.D.
Inches

.600
.562
.396
.354
.432
.560
.552
.576
.560
.530
.530
.546
.574
.548
.574
.414
.496
.446
.446
.594
.562
.428
.542
.532
.532
.532
.340
.332
.512
.474
.522
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516

RATE
mm

15.2
14.3
10.1
9.0
11.0
14.2
14.0
14.6
14.2
13.5
13.5
13.9
14.6
13.9
14.6
10.5
12.6
11.3
11.3
15.1
14.3
10.9
13.8
13.5
13.5
13.5
8.6
8.4
13.0
12.0
13.3
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

.55
.10
5.2
.91
316
55
967 169
122
21
6.8
1.2
7.9
1.4
1.7
.31
6.5
1.1
12
2.1
12
2.1
6.2
1.1
1.9
.33
6.8
1.2
1.9
.33
161
28
32
5.7
87
15
50
8.8
.29
.05
2.3
.40
85
15
6.4
1.1
4.6
.80
2.7
.47
3.4
.59
227
40
261
46
4.9
.86
9.6
1.7
2.0
.35
23
4.1
20
3.5
36
6.3
31
5.4
56
9.7
47
8.3
71
12
60
11
94
16
80
14
18
3.2
15
2.7
29
5.1
25
4.3
45
7.8
38
6.6
56
9.9
48
8.4
75
13
63
11
15
2.7
13
2.3
24
4.2
20
3.6
37
6.5
32
5.5
47
8.2
40
7.0
62
11
53
9.2
13
2.3
11
2.0
21
3.6
18
3.1
32
5.6
27
4.7
40
7.0
34
6.0
53
9.3
45
7.9
10
1.8
8.8
1.5
16
2.8
14
2.4
25
4.3
21
3.7
31
5.4
26
4.6
41
7.2

Inches

mm

1.5
38
1.2
30
.27
7.0
.15
3.7
.48 12
.97 25
.98 25
1.6
41
1.0
26
1.1
29
1.1
28
1.5
38
2.0
52
1.8
45
2.0
52
.50 13
.81 21
.64 16
1.0
26
2.9
74
2.7
69
.80 20
1.6
40
2.9
73
3.5
88
3.9
98
.71 18
.66 17
3.9 100
3.8
97
8.2 209
.41 10
.33
8.3
.35
8.9
.28
7.1
.34
8.6
.27
6.9
.32
8.2
.26
6.5
.28
7.2
.22
5.7
.53 13
.42 11
.44 11
.35
8.9
.43 11
.34
8.6
.40 10
.32
8.1
.36
9.1
.28
7.2
.63 16
.50 13
.53 13
.42 11
.51 13
.41 10
.48 12
.39
9.8
.43 11
.34
8.7
.73 19
.58 15
.61 15
.49 12
.60 15
.47 12
.57 14
.45 11
.51 13
.40 10
.93 24
.74 19
.78 20
.62 16
.77 19
.61 16
.73 19
.58 15
.65 17

ENDS: C - Closed

G - Ground
O - Open

Lbs.

.81
6.2
87
142
59
6.6
7.8
2.8
6.6
14
14
9.2
3.9
12
3.9
81
26
56
52
.83
6.1
68
10
13
9.2
13
161
172
19
37
16
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27

3.6
27
385
634
263
29
35
12
29
61
61
41
17
54
17
359
117
247
229
3.7
27
303
45
58
41
58
717
767
86
163
73
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119

Inches

.27
.42
1.27
1.21
1.34
.34
.42
.40
.40
.69
.69
.65
.45
.55
.45
1.88
1.00
1.47
2.10
.60
.79
2.28
.80
1.57
2.54
2.05
5.37
5.43
3.06
5.37
4.96
.17
.17
.20
.20
.24
.24
.27
.27
.29
.29
.20
.20
.22
.22
.28
.28
.30
.30
.32
.32
.21
.21
.25
.25
.31
.31
.34
.34
.37
.37
.23
.23
.27
.27
.34
.34
.37
.37
.41
.41
.27
.27
.31
.31
.39
.39
.44
.44
.48

mm

Inches

6.8
10.7
32.2
30.7
34.1
8.5
10.6
10.2
10.1
17.6
17.4
16.4
11.5
14.1
11.5
47.6
25.4
37.3
53.3
15.4
20.0
57.9
20.3
39.8
64.6
52.0
136.4
137.8
77.7
136.4
125.9
4.4
4.4
5.1
5.1
6.2
6.2
6.8
6.8
7.3
7.3
5.0
5.0
5.6
5.6
7.0
7.0
7.7
7.7
8.2
8.2
5.4
5.4
6.3
6.3
7.8
7.8
8.5
8.5
9.4
9.4
5.9
5.9
6.8
6.8
8.6
8.6
9.4
9.4
10.3
10.3
6.8
6.8
7.9
7.9
10.0
10.0
11.1
11.1
12.1

0.028
0.047
0.130
0.151
0.112
0.048
0.052
0.040
0.048
0.063
0.063
0.055
0.041
0.054
0.041
0.121
0.080
0.105
0.105
0.031
0.047
0.114
0.057
0.062
0.062
0.062
0.158
0.162
0.072
0.091
0.067
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072

mm

TOTAL
MATL
COILS

0.7
1.2
3.3
3.8
2.8
1.2
1.3
1.0
1.2
1.6
1.6
1.4
1.0
1.4
1.0
3.1
2.0
2.7
2.7
0.8
1.2
2.9
1.4
1.6
1.6
1.6
4.0
4.1
1.8
2.3
1.7
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8

8.50
8.00
9.75
8.00
12.0
7.00
8.00
10.0
7.25
11.0
11.0
11.8
10.0
10.3
10.0
14.5
11.5
14.0
20.0
18.5
15.8
20.0
13.0
24.3
40.0
32.0
34.0
33.5
41.5
59.0
73.0
3.50
3.50
3.63
3.63
3.88
3.88
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.38
4.38
4.50
4.50
4.50
4.50
4.38
4.38
4.50
4.50
4.88
4.88
5.00
5.00
5.13
5.13
4.75
4.75
4.88
4.88
5.38
5.38
5.50
5.50
5.63
5.63
5.50
5.50
5.63
5.63
6.25
6.25
6.50
6.50
6.63

MW
SPR
SST
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
MW
SST
SPR
SPR
HD
SST
SST
HD
SPR
SPR
HD
SPR
HD
HD
HD
SPR
SPR
HD
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

F
N
S
H

C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
C
CG
CG
C
C
CG
C
C
C
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

Z
Z
N
GI
N
N
Z
N
Z
Z
Z
Z
N
Z
N
Z
Z
Z
N
N
GI
Z
Z
Z
Z
Z
Z
Z
Z
Z
BO
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

147

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 148

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.660
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671

16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
16.76
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04

71917S
71870
71870S
71882
71882S
71894
71894S
71906
71906S
71918
71918S
71871
71871S
71883
71883S
71895
71895S
71907
71907S
71919
71919S
71872
71872S
71884
71884S
71896
71896S
71908
71908S
71920
71920S
71873
71873S
71885
71885S
71897
71897S
71909
71909S
71921
71921S
71874
71874S
71886
71886S
71898
71898S
71910
71910S
71922
71922S
71875
71875S
71887
71887S
71899
71899S
71911
71911S
71923
71923S
71876
71876S
71888
71888S
71900
71900S
71912
71912S
71924
71924S
B9-6
10520
N-80
B10-21
S-21
1865
S-924
S-1452
2911

1.25
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
.38
.38
.41
.47
.59
.59
.75
.75
.81

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

31.8
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
9.5
9.5
10.3
11.9
15.1
15.1
19.1
19.1
20.6

MATERIAL: MW - Music Wire

148

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.562
.562
.550
.550
.534
.534
.526
.526
.516
.516
.589
.511
.461
.575
.601
.527
.575
.527
.489

RATE
mm

13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
14.3
14.3
14.0
14.0
13.6
13.6
13.4
13.4
13.1
13.1
15.0
13.0
11.7
14.6
15.3
13.4
14.6
13.4
12.4

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

35
6.1
8.5
1.5
7.2
1.3
13
2.3
11
2.0
20
3.5
17
3.0
26
4.5
22
3.8
34
5.9
28
5.0
7.2
1.3
6.1
1.1
11
2.0
9.6
1.7
17
3.0
15
2.5
22
3.8
18
3.2
28
4.9
24
4.2
6.3
1.1
5.3
.93
9.8
1.7
8.3
1.5
15
2.6
13
2.2
19
3.3
16
2.8
25
4.3
21
3.6
5.5
.96
4.7
.82
8.6
1.5
7.3
1.3
13
2.3
11
1.9
17
2.9
14
2.5
22
3.8
18
3.2
5.0
.87
4.2
.74
7.8
1.4
6.6
1.2
12
2.0
9.9
1.7
15
2.6
12
2.2
19
3.4
16
2.9
4.5
.79
3.8
.67
7.0
1.2
6.0
1.0
11
1.9
9.0
1.6
13
2.3
11
2.0
18
3.1
15
2.6
4.1
.72
3.5
.61
6.4
1.1
5.4
.95
9.7
1.7
8.2
1.4
12
2.1
10
1.8
16
2.8
14
2.4
16
2.8
380
67
838 147
28
4.9
2.5
.43
90
16
13
2.3
52
9.1
238
42

.52
1.1
.90
.95
.76
.94
.75
.89
.71
.80
.63
1.3
1.1
1.1
.89
1.1
.88
1.1
.84
.95
.75
1.5
1.2
1.3
1.0
1.3
1.0
1.2
.97
1.1
.86
1.7
1.4
1.5
1.2
1.4
1.2
1.4
1.1
1.2
.98
1.9
1.5
1.6
1.3
1.6
1.3
1.5
1.2
1.4
1.1
2.1
1.7
1.8
1.4
1.8
1.4
1.7
1.4
1.5
1.2
2.3
1.9
2.0
1.6
2.0
1.6
1.9
1.5
1.7
1.3
.21
.07
.06
.22
.38
.23
.47
.34
.15

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

13
29
23
24
19
24
19
23
18
20
16
34
27
28
23
28
22
27
21
24
19
39
31
33
26
32
26
31
25
28
22
44
35
37
30
37
29
35
28
32
25
49
39
42
33
41
33
39
31
35
28
54
43
46
37
45
36
43
35
39
31
60
47
50
40
50
40
48
38
43
34
5.4
1.7
1.5
5.5
9.7
5.9
12
8.6
3.8

Lbs.

18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
9.6
6.5
13
8.6
19
13
23
15
27
18
3.4
26
51
6.0
.95
21
6.0
18
36

ENDS: C - Closed

G - Ground
O - Open

80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
43
29
56
38
84
57
101
68
119
80
15
114
225
27
4.2
93
27
79
160

Inches

.48
.31
.31
.36
.36
.46
.46
.50
.50
.55
.55
.34
.34
.40
.40
.52
.52
.57
.57
.63
.63
.39
.39
.44
.44
.58
.58
.64
.64
.70
.70
.42
.42
.49
.49
.64
.64
.70
.70
.78
.78
.46
.46
.53
.53
.70
.70
.77
.77
.86
.86
.50
.50
.58
.58
.76
.76
.84
.84
.93
.93
.53
.53
.62
.62
.82
.82
.90
.90
1.01
1.01
.16
.22
.32
.19
.21
.36
.20
.36
.38

mm

12.1
7.8
7.8
9.1
9.1
11.6
11.6
12.8
12.8
13.9
13.9
8.7
8.7
10.1
10.1
13.2
13.2
14.5
14.5
16.0
16.0
9.8
9.8
11.2
11.2
14.8
14.8
16.2
16.2
17.8
17.8
10.7
10.7
12.4
12.4
16.2
16.2
17.7
17.7
19.9
19.9
11.7
11.7
13.4
13.4
17.8
17.8
19.6
19.6
21.7
21.7
12.6
12.6
14.7
14.7
19.2
19.2
21.3
21.3
23.5
23.5
13.5
13.5
15.7
15.7
20.8
20.8
23.0
23.0
25.6
25.6
4.2
5.6
8.0
4.9
5.3
9.1
5.0
9.1
9.5

WIRE DIA.
Inches

0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.049
0.049
0.055
0.055
0.063
0.063
0.067
0.067
0.072
0.072
0.041
0.080
0.105
0.048
0.035
0.072
0.048
0.072
0.091

mm

TOTAL
MATL
COILS

1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.2
1.2
1.4
1.4
1.6
1.6
1.7
1.7
1.8
1.8
1.0
2.0
2.7
1.2
0.9
1.8
1.2
1.8
2.3

6.63
6.25
6.25
6.50
6.50
7.25
7.25
7.50
7.50
7.63
7.63
7.00
7.00
7.25
7.25
8.25
8.25
8.50
8.50
8.75
8.75
7.88
7.88
8.00
8.00
9.25
9.25
9.50
9.50
9.75
9.75
8.63
8.63
8.88
8.88
10.1
10.1
10.4
10.4
10.9
10.9
9.38
9.38
9.63
9.63
11.1
11.1
11.5
11.5
11.9
11.9
10.1
10.1
10.5
10.5
12.0
12.0
12.5
12.5
12.9
12.9
10.9
10.9
11.3
11.3
13.0
13.0
13.5
13.5
14.0
14.0
3.00
2.75
3.00
3.00
5.00
4.00
4.00
5.00
4.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
SST
SST
SST
MW
SST
SST
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
N
Z
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 149

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.671
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687

17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.04
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45

K-59A
N-127
XX-19
10010
B7-70
10467
RR-66
BB-66
3758
10725
11316
S-784
2999
J-38
4270
3275
12582
10837
4262
S-786
2577
2858
2693
S-1468
10701
B10-69
O-116
10757
11703
3319
S-104
B2-61
S-13
3893
3698
10682
10545
25
10357
S-1541
S-360
12518
S-64
12086
12183
10235
3036
B-20
12598
11662
S-808
4209
10562
11744
S-1363
2613
11351
12013
11988
1709
12065
S-334
S-3120
QQ-43
A-12
K-52
W-48
S-168
Q-57
2975
3250
I-52
S-1110
11348
2845
S-1610
3849
S-1299
Z-10
DD-40

.88
.88
.94
1.06
1.09
1.13
1.13
1.13
1.13
1.19
1.19
1.25
1.25
1.25
1.25
1.25
1.30
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.56
1.56
1.56
1.59
1.63
1.69
1.73
1.75
1.75
1.81
1.84
1.84
1.88
1.88
1.91
1.91
1.94
2.00
2.00
2.03
2.13
2.22
2.31
2.50
2.53
2.56
2.58
2.91
3.00
3.31
3.50
4.25
5.00
6.13
7.00
8.41
.47
.56
.63
.63
.69
.72
.72
.75
.75
.75
.75
.81
.81
.81
.81
.88
.88
.91
.94

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

22.2
22.2
23.8
27.0
27.8
28.6
28.6
28.6
28.6
30.2
30.2
31.8
31.8
31.8
31.8
31.8
32.9
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
39.7
39.7
39.7
40.5
41.3
42.8
43.9
44.5
44.5
46.0
46.8
46.8
47.6
47.6
48.4
48.4
49.2
50.8
50.8
51.6
54.0
56.4
58.7
63.5
64.3
65.1
65.5
73.8
76.2
84.1
88.9
108.0
127.0
155.6
177.8
213.5
11.9
14.3
15.9
15.9
17.4
18.2
18.2
19.1
19.1
19.1
19.1
20.6
20.6
20.6
20.6
22.2
22.2
23.0
23.8

I.D.
Inches

.543
.487
.561
.527
.603
.611
.563
.511
.451
.537
.511
.589
.563
.563
.555
.487
.475
.607
.527
.563
.561
.561
.527
.511
.489
.601
.563
.467
.561
.511
.431
.563
.577
.543
.559
.447
.441
.511
.431
.583
.511
.447
.577
.541
.517
.445
.547
.581
.581
.563
.419
.569
.483
.551
.589
.541
.611
.577
.575
.511
.551
.637
.639
.527
.521
.579
.611
.585
.607
.593
.589
.503
.623
.579
.577
.541
.571
.553
.601
.627

RATE
mm

13.8
12.4
14.2
13.4
15.3
15.5
14.3
13.0
11.5
13.6
13.0
15.0
14.3
14.3
14.1
12.4
12.1
15.4
13.4
14.3
14.2
14.2
13.4
13.0
12.4
15.3
14.3
11.9
14.2
13.0
10.9
14.3
14.7
13.8
14.2
11.4
11.2
13.0
10.9
14.8
13.0
11.4
14.7
13.7
13.1
11.3
13.9
14.8
14.8
14.3
10.6
14.5
12.3
14.0
15.0
13.7
15.5
14.7
14.6
13.0
14.0
16.2
16.2
13.4
13.2
14.7
15.5
14.9
15.4
15.1
15.0
12.8
15.8
14.7
14.7
13.7
14.5
14.0
15.3
15.9

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

31
134
9.4
42
1.5
1.0
9.1
51
207
33
63
3.5
11
9.5
8.6
106
141
1.3
40
9.1
8.3
8.3
31
41
72
1.3
5.8
109
9.4
29
226
12
4.6
13
7.6
167
183
30
210
1.9
31
162
3.3
8.0
24
135
9.4
2.5
2.7
5.2
166
8.2
44
7.1
1.3
7.4
.24
1.3
1.0
8.8
7.2
1.3
.25
132
155
19
3.9
17
3.9
8.9
16
163
2.3
11
17
39
20
38
4.6
1.0

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

5.4
24
1.6
7.4
.26
.18
1.6
8.9
36
5.8
11
.62
1.9
1.7
1.5
19
25
.22
7.0
1.6
1.5
1.5
5.5
7.2
13
.23
1.0
19
1.6
5.0
40
2.0
.80
2.4
1.3
29
32
5.3
37
.33
5.4
28
.59
1.4
4.2
24
1.6
.44
.47
.91
29
1.4
7.7
1.2
.24
1.3
.04
.22
.18
1.5
1.3
.24
.04
23
27
3.4
.68
2.9
.69
1.6
2.8
29
.41
2.0
2.9
6.8
3.5
6.7
.81
.18

Inches

mm

.46 12
.26
6.5
.44 11
.45 11
.86 22
.91 23
.75 19
.48 12
.27
6.9
.49 12
.41 10
1.0
26
.78 20
.84 21
.60 15
.35
8.9
.32
8.0
1.2
30
.47 12
.88 22
1.0
26
1.0
26
.84 21
.58 15
.50 13
1.3
32
.91 23
.46 12
.96 24
.67 17
.31
7.9
.74 19
1.2
31
1.0
26
1.2
30
.38
9.7
.37
9.5
.86 22
.37
9.4
1.4
35
.78 20
.39 10
1.6
39
.93 24
.95 24
.48 12
1.4
35
1.8
46
2.0
51
1.6
42
.49 12
.88 22
.90 23
1.6
42
2.8
71
2.0
51
3.7
14
4.0 101
4.5 115
2.9
74
1.6
41
.36
9.2
.35
8.9
.19
4.9
.18
4.6
.43 11
.51 13
.39 10
.51 13
.52 13
.42 11
.22
5.7
.65 17
.50 13
.53 13
.37
9.5
.51 13
.39
9.8
.65 16
.73 18

ENDS: C - Closed

G - Ground
O - Open

Lbs.

14
34
4.2
19
1.3
.94
6.8
24
56
16
26
3.5
8.5
8.0
5.1
37
45
1.5
19
8.0
8.5
8.5
26
24
36
1.6
5.3
50
9.0
19
71
8.5
5.7
14
9.1
64
69
26
77
2.6
24
64
5.2
7.4
23
65
13
4.5
5.4
8.5
81
7.2
40
12
3.8
15
.89
5.1
4.7
26
12
.49
.09
25
28
8.3
2.0
6.6
2.0
4.6
6.7
36
1.5
5.7
8.8
15
10
15
3.0
.75

63
153
18
84
5.7
4.2
30
107
251
72
114
16
38
36
23
165
199
6.8
84
36
38
38
117
107
160
7.3
24
223
40
84
314
38
25
63
40
283
305
114
344
12
107
283
23
33
102
290
57
20
24
38
361
32
176
52
17
65
3.9
23
21
114
52
2.2
.39
112
125
37
8.8
29
8.9
20
30
162
6.8
25
39
65
46
66
13
3.3

Inches

.42
.51
.50
.52
.24
.22
.38
.56
.85
.40
.52
.25
.36
.36
.65
.74
.78
.24
.47
.43
.48
.48
.56
.64
.82
.30
.65
.99
.44
.96
1.08
.41
.40
.70
.62
1.09
1.15
1.00
1.26
.53
.80
1.23
.45
1.07
.92
1.36
.74
.52
.50
.65
1.73
.41
1.53
.87
.51
1.15
.16
1.03
1.61
2.76
.86
.11
.21
.32
.33
.24
.21
.20
.24
.24
.25
.46
.16
.31
.28
.44
.36
.32
.26
.21

mm

Inches

10.6
12.9
12.6
13.3
6.0
5.5
9.6
14.2
21.7
10.2
13.2
6.2
9.3
9.3
16.6
18.7
19.9
6.1
11.9
11.0
12.2
12.2
14.2
16.3
20.8
7.6
16.5
25.3
11.2
24.4
27.4
10.3
10.1
17.9
15.6
27.7
29.2
25.4
32.0
13.4
20.3
31.3
11.3
27.2
23.5
34.4
18.9
13.1
12.6
16.5
44.0
10.4
38.8
22.1
13.0
29.1
4.0
26.3
40.8
70.1
21.8
2.7
5.3
8.1
8.4
6.2
5.3
5.2
6.1
6.0
6.2
11.7
4.1
7.9
7.2
11.1
9.2
8.1
6.6
5.3

0.064
0.092
0.055
0.072
0.034
0.030
0.054
0.080
0.110
0.067
0.080
0.041
0.054
0.054
0.058
0.092
0.098
0.032
0.072
0.054
0.055
0.055
0.072
0.080
0.091
0.035
0.054
0.102
0.055
0.080
0.120
0.054
0.047
0.064
0.056
0.112
0.115
0.080
0.120
0.044
0.080
0.112
0.047
0.065
0.077
0.113
0.062
0.045
0.045
0.054
0.126
0.051
0.094
0.060
0.041
0.065
0.030
0.047
0.048
0.080
0.060
0.025
0.024
0.080
0.083
0.054
0.038
0.051
0.040
0.047
0.049
0.092
0.032
0.054
0.055
0.073
0.058
0.067
0.043
0.030

mm

TOTAL
MATL
COILS

1.6
2.3
1.4
1.8
0.9
0.8
1.4
2.0
2.8
1.7
2.0
1.0
1.4
1.4
1.5
2.3
2.5
0.8
1.8
1.4
1.4
1.4
1.8
2.0
2.3
0.9
1.4
2.6
1.4
2.0
3.0
1.4
1.2
1.6
1.4
2.8
2.9
2.0
3.0
1.1
2.0
2.8
1.2
1.7
2.0
2.9
1.6
1.1
1.1
1.4
3.2
1.3
2.4
1.5
1.0
1.7
0.8
1.2
1.2
2.0
1.5
0.6
0.6
2.0
2.1
1.4
1.0
1.3
1.0
1.2
1.2
2.3
0.8
1.4
1.4
1.9
1.5
1.7
1.1
0.8

5.50
5.50
8.00
6.25
7.00
6.25
7.00
7.00
7.75
6.00
6.50
6.00
6.75
6.75
10.3
7.00
7.00
6.50
6.50
7.00
8.75
8.75
7.75
8.00
9.00
8.50
11.0
9.75
8.00
12.0
9.00
6.50
7.50
10.0
10.0
9.75
10.0
11.5
10.5
12.0
10.0
10.0
9.50
16.5
12.0
12.0
12.0
11.5
11.0
12.0
13.8
7.00
15.3
13.5
12.5
17.5
18
22.0
32.5
34.5
13.3
3.25
7.75
4.00
4.00
4.50
4.50
4.00
5.00
5.00
4.00
5.00
4.00
5.75
5.13
6.00
5.25
4.75
6.00
6.00

SPR
SST
SPR
HD
SPR
MW
SST
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
MW
MW
MW
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
HD
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
HD
MW
SPR
SST
SPR
SPR
SPR
SST
HD
SST
SST
SPR
SPR
SPR
SST
SST
SPR
HD
SPR
SST
SST
SST
SPR
SPR
SPR
SST
SST
HD
SST
SPR
SST
SPR
MW

E
N
D
S

C
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
C
CG
C
C
C
CG
CG
CG
C
CG
C
CG
C
CG
C
CG
CG
CG
C
CG
CG
C

F
N
S
H

Z
N
Z
Z
N
Z
N
N
Z
GI
Z
N
Z
N
Z
Z
N
Z
Z
N
GI
GI
GI
N
Z
Z
Z
N
Z
Z
N
GI
N
Z
Z
Z
Z
Z
Z
N
N
N
N
Z
GI
GI
Z
Z
N
Z
N
N
Z
Z
N
Z
N
N
GI
Z
Z
N
N
Z
Z
N
N
N
N
Z
Z
Z
N
N
Z
N
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

149

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 150

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687

17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45

3949
S-800
12332
11105
3654
11345
3349
3350
12148
3943
MM-93
1950
AA-82
B5-38
S-1291
4117
4221
10079
K-15
11312
S-1624
11707
S-961
3114
Z-41
S-1471
I-32
10295
505
B8-58
28
11192
11680
12025
11367
EE-94
S-267
S-950
S-1004
S-1357
S-1424
2734
S-1387
B9-49
11537
11649
11611
A-64
2910
S-276
KK-75
1917
12172
B9-54
S-3107
12099
AA-62
11559
10872
11865
S-71
10416
B2-65
11111
12596
S-1620
I-60
10468
12595
2580
GG-79
12220
3022
3039
3097
3964
S-3138
10012
S-59
10411

.94
.97
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.09
1.13
1.13
1.13
1.13
1.19
1.19
1.22
1.22
1.22
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.31
1.31
1.34
1.38
1.38
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.53
1.56
1.63
1.63
1.63
1.63
1.63
1.69
1.75
1.75
1.81
1.81
1.84
1.88
1.91
1.91
1.94
1.94
2.00
2.00
2.00
2.00
2.06
2.13
2.13
2.19
2.25
2.25
2.28
2.38

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

23.8
24.6
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
27.8
28.6
28.6
28.6
28.6
30.2
30.2
31.0
31.0
31.0
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
33.3
33.3
34.1
34.9
34.9
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.9
39.7
41.3
41.3
41.3
41.3
41.3
42.8
44.5
44.5
46.0
46.0
46.7
47.6
48.4
48.4
49.2
49.2
50.8
50.8
50.8
50.8
52.4
54.0
54.0
55.6
57.2
57.2
57.9
60.3

MATERIAL: MW - Music Wire

150

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.563
.617
.605
.617
.595
.579
.573
.571
.501
.363
.307
.603
.547
.605
.579
.527
.519
.431
.579
.511
.607
.569
.561
.579
.579
.563
.559
.557
.543
.537
.505
.505
.461
.481
.527
.447
.623
.601
.607
.605
.585
.561
.553
.551
.543
.537
.517
.477
.447
.447
.507
.497
.567
.545
.503
.475
.427
.565
.619
.571
.503
.391
.527
.505
.583
.521
.563
.503
.593
.579
.547
.525
.477
.567
.527
.573
.567
.531
.535
.579

RATE
mm

14.3
15.7
15.4
15.7
15.1
14.7
14.6
14.5
12.7
9.2
7.8
15.3
13.9
15.4
14.7
13.4
13.2
10.9
14.7
13.0
15.4
14.5
14.2
14.7
14.7
14.3
14.2
14.1
13.8
13.6
12.8
12.8
11.7
12.2
13.4
11.4
15.8
15.3
15.4
15.4
14.9
14.2
14.0
14.0
13.8
13.6
13.1
12.1
11.4
11.4
12.9
12.6
14.4
13.8
12.8
12.1
10.8
14.4
15.7
14.5
12.8
9.9
13.4
12.8
14.8
13.2
14.3
12.8
15.1
14.7
13.9
13.3
12.1
14.4
13.4
14.6
14.4
13.5
13.6
14.7

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

18
3.2
2.3
.40
7.5
1.3
3.1
.55
6.1
1.1
8.5
1.5
14
2.5
15
2.5
128
22
2281 399
5087 891
8.3
1.5
43
7.6
6.7
1.2
14
2.4
66
12
82
14
631 111
7.1
1.2
95
17
3.0
.53
13
2.2
20
3.5
11
1.9
8.4
1.5
19
3.3
20
3.5
28
5.0
39
6.8
35
6.2
89
16
67
12
248
43
162
28
41
7.1
327
57
.67
.12
3.8
.66
2.4
.41
4.0
.71
8.2
1.4
21
3.6
21
3.7
26
4.5
28
4.8
33
5.8
69
12
118
21
252
44
219
38
42
7.3
87
15
7.6
1.3
31
5.5
61
11
103
18
380
67
12
2.0
1.1
.20
8.0
1.4
54
9.5
734 129
41
7.1
36
6.3
4.4
.78
34
6.0
9.5
1.7
49
8.6
2.7
.48
6.9
1.2
10
1.8
46
8.1
104
18
9.4
1.7
38
6.6
6.7
1.2
8.2
1.4
39
6.9
19
3.3
9.6
1.7

.46
.79
.52
.81
.72
.62
.59
.57
.29
.07
.05
.51
.37
.59
.56
.38
.36
.14
.70
.33
.98
.78
.61
.75
.87
.62
.69
.51
.47
.55
.40
.49
.26
.31
.58
.23
1.2
1.1
1.2
.91
.80
.88
.70
.63
.67
.63
.44
.45
.30
.32
.81
.46
.91
.57
.56
.46
.24
1.0
1.4
1.2
.62
.18
.62
.42
1.3
.77
1.2
.74
1.4
1.5
.88
.56
.51
1.2
.67
1.4
1.3
.60
1.1
.86

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

12
20
13
21
18
16
15
14
7.4
1.9
1.2
13
9.3
15
14
9.7
9.0
3.7
18
8.3
25
20
15
19
22
16
18
13
12
14
10
13
6.5
7.9
15
5.9
29
29
31
23
20
22
18
16
17
16
11
11
7.7
8.0
21
12
23
14
14
12
6.2
26
37
29
16
4.6
16
11
32
19
32
19
37
38
22
14
13
31
17
37
33
15
28
22

Lbs.

8.4
37
1.8
8.0
3.9
18
2.5
11
4.4
20
5.3
24
8.4
37
8.2
37
38
167
167
742
244 1084
4.2
19
16
71
3.9
18
7.8
35
25
112
29
129
91
406
5.0
22
31
139
2.9
13
9.9
44
12
55
8.3
37
7.3
33
12
52
14
61
14
64
18
82
20
87
35
157
33
146
64
284
50
225
24
105
76
337
.77
3.4
4.2
19
2.9
13
3.7
16
6.6
29
18
81
15
66
16
73
18
82
21
93
30
134
53
237
76
337
69
308
34
152
40
178
6.8
30
18
79
34
150
47
210
93
412
12
53
1.7
7.4
9.2
41
34
150
133
593
25
112
15
67
5.6
25
26
117
12
52
36
161
4.0
18
10
46
9.2
41
26
116
53
237
11
51
25
112
9.8
43
11
48
23
104
20
90
8.3
37

ENDS: C - Closed

G - Ground
O - Open

Inches

.48
.18
.21
.19
.28
.38
.41
.44
.56
.81
.95
.21
.42
.22
.27
.48
.50
.70
.49
.51
.24
.44
.38
.40
.38
.37
.45
.37
.52
.53
.75
.82
.79
.82
.62
.84
.29
.27
.28
.22
.36
.41
.47
.48
.65
.60
.68
1.00
1.02
1.02
.70
.81
.72
.57
.92
1.17
1.07
.61
.31
.59
.92
1.18
.76
1.46
.64
.83
.62
1.20
.55
.49
1.12
.73
1.21
.60
.72
.63
.60
.70
.91
.38

mm

12.2
4.4
5.2
4.9
7.0
9.6
10.5
11.0
14.2
20.6
24.1
5.3
10.7
5.5
6.9
12.2
12.8
17.9
12.3
12.9
6.1
11.2
9.6
10.1
9.6
9.4
11.4
9.5
13.3
13.3
19.1
20.8
20.1
20.9
15.7
21.3
7.3
6.8
7.1
5.5
9.1
10.4
11.9
12.1
16.5
15.2
17.3
25.3
25.9
25.9
17.7
20.5
18.3
14.4
23.4
29.6
27.2
15.5
7.8
15.1
23.4
30.1
19.3
37.0
16.2
21.1
15.7
30.4
14.0
12.3
28.4
18.5
30.7
15.2
18.3
15.9
15.2
17.8
23.2
9.6

WIRE DIA.
Inches

0.062
0.035
0.041
0.035
0.046
0.054
0.057
0.058
0.093
0.162
0.190
0.042
0.070
0.041
0.054
0.080
0.084
0.128
0.054
0.088
0.040
0.059
0.063
0.054
0.054
0.062
0.064
0.065
0.072
0.075
0.091
0.091
0.113
0.103
0.080
0.120
0.032
0.043
0.040
0.041
0.051
0.063
0.067
0.068
0.072
0.075
0.085
0.105
0.120
0.120
0.090
0.095
0.060
0.071
0.092
0.106
0.130
0.061
0.034
0.058
0.092
0.148
0.080
0.091
0.052
0.083
0.062
0.092
0.047
0.054
0.070
0.081
0.105
0.060
0.080
0.057
0.060
0.078
0.076
0.054

mm

TOTAL
MATL
COILS

1.6
0.9
1.0
0.9
1.2
1.4
1.4
1.5
2.4
4.1
4.8
1.1
1.8
1.0
1.4
2.0
2.1
3.3
1.4
2.2
1.0
1.5
1.6
1.4
1.4
1.6
1.6
1.7
1.8
1.9
2.3
2.3
2.9
2.6
2.0
3.0
0.8
1.1
1.0
1.0
1.3
1.6
1.7
1.7
1.8
1.9
2.2
2.7
3.0
3.0
2.3
2.4
1.5
1.8
2.3
2.7
3.3
1.5
0.9
1.5
2.3
3.8
2.0
2.3
1.3
2.1
1.6
2.3
1.2
1.4
1.8
2.1
2.7
1.5
2.0
1.4
1.5
2.0
1.9
1.4

6.75
5.00
4.00
4.50
6.00
7.00
6.25
6.50
6.00
5.00
5.00
4.00
5.00
4.25
5.00
6.00
6.00
5.50
8.00
5.75
6.00
7.50
6.00
6.25
7.00
6.00
7.00
5.75
6.25
7.00
7.25
9.00
7.00
7.00
7.75
7.00
9.00
6.25
7.00
5.25
6.00
6.50
7.00
7.00
8.00
8.00
7.00
9.50
8.50
8.50
7.75
8.50
12.0
7.00
9.00
11.0
8.25
9.00
8.00
9.25
10.0
8.00
8.50
15.0
11.3
10.0
10.0
12.0
11.8
9.00
16.0
8.00
10.5
10.0
9.00
11.0
10.0
8.00
12.0
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SPR
MW
SPR
SST
HD
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SST
SST
SPR
SST
SPR
SST
SST
SPR
SPR
HD
SST
HD
HD
SPR
SPR
SST
SPR
SST
SST
SST
SST
SST
MW
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
PB
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
HD
MW
SST
SST
SPR
MW
MW
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR

E
N
D
S

C
CG
C
C
CG
CG
C
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
CG
CG
CL
C
C
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG

F
N
S
H

Z
N
Z
Z
Z
N
Z
Z
Z
Z
N
Z
N
N
N
Z
Z
Z
N
N
N
Z
N
Z
N
N
Z
Z
Z
N
Z
Z
Z
Z
N
Z
N
N
N
N
N
GI
N
N
Z
GI
Z
N
Z
N
N
Z
Z
N
N
Z
N
Z
Z
N
N
N
N
Z
N
N
N
Z
N
Z
Z
Z
Z
Z
Z
Z
N
Z
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 151

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.687
0.690
0.690
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703

17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.45
17.53
17.53
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86

B8-43
11984
11972
11296
S-372
S-1592
11687
12022
2739
S-3250
B17-165
10654
2998
12282
3674
10556
DD-86
12221
12416
4375
18
3353
12023
3206
3089
11416
506
35
12187
3925
11529
10707
11821
358
364
2836
3961
12592
3384
512
71925
71925S
JJ-55
Q-53
S-489
K-12
MM-41
S-795
4144
I-62
OO-68
QQ-42
Q-64
PP-79
3846
4224
3880
2516
EE-70
10427
XX-53
12216
11429
H-32
K-21
S-368
3590
3916
H-14
11739
LL-62
10471
10526
11760
2575
B15-23
S-12
S-1247
2644
A10-46

O.D.

FREE LENGTH
Inches

2.38
2.38
2.41
2.50
2.50
2.50
2.50
2.50
2.50
2.53
2.53
2.59
2.66
2.69
2.69
2.75
2.75
2.78
2.91
2.97
3.00
3.00
3.25
3.31
3.31
3.38
3.63
4.00
4.41
4.50
4.63
4.63
5.25
5.75
6.00
6.56
9.50
12.1
16.0
16.0
.69
.69
.50
.50
.50
.50
.53
.59
.63
.63
.66
.69
.69
.69
.75
.75
.75
.75
.75
.78
.81
.84
.88
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.03
1.06
1.06
1.09
1.09
1.13
1.13
1.13
1.13
1.13

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

60.3
60.3
61.1
63.5
63.5
63.5
63.5
63.5
63.5
64.3
64.3
65.9
67.5
68.2
68.2
69.9
69.9
70.6
73.8
75.4
76.2
76.2
82.6
84.1
84.1
85.7
92.1
101.6
111.9
114.3
117.5
117.5
133.4
146.1
152.4
166.7
241.3
308.0
406.4
406.4
17.5
17.5
12.7
12.7
12.7
12.7
13.5
15.1
15.9
15.9
16.7
17.4
17.4
17.4
19.1
19.1
19.1
19.1
19.1
19.8
20.6
21.4
22.2
25.4
25.4
25.4
25.4
25.4
26.2
26.2
26.2
27.0
27.0
27.8
27.8
28.6
28.6
28.6
28.6
28.6

I.D.
Inches

.569
.511
.565
.611
.575
.573
.569
.559
.417
.571
.543
.569
.623
.603
.495
.601
.547
.515
.529
.505
.593
.543
.555
.613
.593
.605
.543
.477
.527
.577
.571
.543
.507
.543
.543
.537
.543
.425
.563
.563
.588
.588
.635
.635
.621
.503
.603
.609
.605
.595
.443
.643
.621
.559
.645
.623
.579
.557
.463
.653
.579
.621
.503
.629
.621
.559
.521
.519
.541
.519
.443
.507
.391
.453
.443
.575
.573
.533
.453
.427

RATE
mm

14.5
13.0
14.4
15.5
14.6
14.6
14.5
14.2
10.6
14.5
13.8
14.5
15.8
15.3
12.6
15.3
13.9
13.1
13.4
12.8
15.1
13.8
14.1
15.6
15.1
15.4
13.8
12.1
13.4
14.7
14.5
13.8
12.9
13.8
13.8
13.6
13.8
10.8
14.3
14.3
14.9
14.9
16.1
16.1
15.8
12.8
15.3
15.5
15.4
15.1
11.3
16.3
15.8
14.2
16.4
15.8
14.7
14.1
11.8
16.6
14.7
15.8
12.8
16.0
15.8
14.2
13.2
13.2
13.7
13.2
11.3
12.9
9.9
11.5
11.3
14.6
14.6
13.5
11.5
10.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

4.5
.78
43
7.5
6.8
1.2
.93
.16
4.6
.80
4.9
.86
8.3
1.4
9.1
1.6
270
47
3.4
.60
12
2.1
4.5
.78
.44
.08
2.8
.49
46
8.1
1.9
.34
11
1.9
40
7.0
26
4.6
33
5.8
3.0
.52
12
2.2
8.4
1.5
.70
.12
1.8
.32
1.7
.30
10
1.8
42
7.3
16
2.9
4.7
.83
3.9
.68
7.2
1.3
15
2.6
6.4
1.1
6.2
1.1
6.0
1.1
4.4
.78
38
6.7
1.6
.28
1.3
.23
107
19
91
16
4.5
.78
2.5
.43
4.1
.71
656 115
19
3.3
11
1.9
9.9
1.7
19
3.4
1091 191
.95
.17
5.0
.87
53
9.4
.83
.15
4.2
.74
40
7.1
82
14
534
93
.72
.13
18
3.1
7.0
1.2
166
29
1.4
.25
6.1
1.1
27
4.7
108
19
113
20
38
6.7
150
26
546
96
141
25
1300 228
428
75
513
90
26
4.6
14
2.5
65
11
485
85
680 119

1.4
.77
1.6
1.9
1.8
1.8
1.3
1.5
.38
1.4
1.4
1.6
2.2
1.5
.89
2.3
1.5
.77
.93
1.1
2.0
1.5
1.8
2.7
2.5
2.3
1.8
1.3
1.5
1.9
2.6
2.6
2.3
2.9
3.0
3.9
4.2
2.5
7.7
9.5
.09
.07
.36
.32
.25
.07
.32
.41
.33
.39
.08
.48
.46
.32
.55
.55
.30
.32
.13
.64
.35
.55
.25
.71
.59
.50
.32
.32
.38
.24
.17
.30
.11
.20
.25
.51
.61
.42
.17
.16

mm

36
20
39
49
45
45
33
39
9.7
36
35
42
55
39
23
57
37
20
23
27
50
38
45
68
63
58
45
33
39
47
67
65
59
73
76
100
106
62
196
241
2.3
1.8
9.0
8.2
6.5
1.8
8.1
10
8.4
10
2.1
12
12
8.0
14
14
7.7
8.2
3.2
16
8.8
14
6.4
18
15
13
8.1
8.0
9.7
6.0
4.2
7.7
2.9
5.0
6.3
13
15
11
4.4
4.0

ENDS: C - Closed

G - Ground
O - Open

Lbs.

6.4
33
10
1.8
8.2
8.7
11
14
103
4.9
16
7.3
.95
4.2
41
4.4
16
31
24
35
5.9
18
15
1.9
4.4
3.9
18
53
25
8.8
10
18
34
18
18
24
18
95
13
13
9.7
6.6
1.6
.80
1.0
45
6.1
4.4
3.3
7.7
91
.46
2.3
17
.45
2.3
12
26
68
.46
6.2
3.8
42
1.0
3.6
13
34
36
15
36
91
43
148
84
127
13
8.7
28
84
108

28
148
47
8.1
37
39
48
61
458
22
72
33
4.2
19
183
19
71
138
108
157
26
82
67
8.4
20
18
82
237
112
39
46
82
152
82
82
105
82
421
56
56
43
29
7.1
3.5
4.6
202
27
19
15
34
404
2.0
10
75
2.0
10
54
117
302
2.1
28
17
187
4.5
16
59
153
158
65
158
404
190
658
372
565
60
39
123
372
478

Inches

mm

Inches

.94 24.0
1.00 25.3
.85 21.7
.56 14.2
.71 18.0
.73 18.5
.62 15.7
.83 21.1
1.69 42.9
1.10 28.0
1.15 29
.94 24.0
.49 12.4
.38
9.6
1.42 36.0
.50 12.6
.98 24.9
.95 24.0
.99 25.1
1.46 37.0
.56 14.3
1.19 30.2
1.02 26.0
.63 16.0
.84 21.3
.48 12.2
1.37 34.7
2.44 62.0
1.44 36.6
.77 19.6
1.15 29.1
1.80 45.7
2.88 73.2
2.07 52.6
2.16 54.9
2.63 66.7
2.92 74.1
8.65 219.6
3.50 89.0
4.28 108.7
.12
3.1
.12
3.1
.14
3.7
.18
4.5
.25
6.2
.30
7.6
.18
4.4
.19
4.8
.29
7.5
.22
5.5
.52 13.2
.21
5.3
.23
5.7
.32
8.2
.20
5.2
.20
5.1
.31
7.9
.29
7.4
.54 13.7
.14
3.5
.47 11.8
.21
5.2
.55 14.0
.29
7.3
.16
4.2
.50 12.8
.55 13.9
.55 14.0
.65 16.5
.55 14.0
.78 19.8
.61 15.6
.94 23.8
.78 19.8
.81 20.7
.35
8.9
.52 13.2
.53 13.5
.72 18.3
.86 21.9

0.059
0.088
0.061
0.038
0.056
0.057
0.059
0.064
0.135
0.058
0.072
0.059
0.032
0.042
0.096
0.043
0.070
0.086
0.079
0.091
0.047
0.072
0.066
0.037
0.047
0.041
0.072
0.105
0.080
0.055
0.058
0.072
0.090
0.072
0.072
0.075
0.072
0.131
0.062
0.062
0.051
0.051
0.034
0.034
0.041
0.100
0.050
0.047
0.049
0.054
0.130
0.030
0.041
0.072
0.029
0.040
0.062
0.073
0.120
0.025
0.062
0.041
0.100
0.037
0.041
0.072
0.091
0.092
0.081
0.092
0.130
0.098
0.156
0.125
0.130
0.064
0.065
0.085
0.125
0.138

mm

TOTAL
MATL
COILS

1.5
2.2
1.5
1.0
1.4
1.4
1.5
1.6
3.4
1.5
1.8
1.5
0.8
1.1
2.4
1.1
1.8
2.2
2.0
2.3
1.2
1.8
1.7
0.9
1.2
1.0
1.8
2.7
2.0
1.4
1.5
1.8
2.3
1.8
1.8
1.9
1.8
3.3
1.6
1.6
1.3
1.3
0.9
0.9
1.0
2.5
1.3
1.2
1.2
1.4
3.3
0.8
1.0
1.8
0.7
1.0
1.6
1.9
3.0
0.6
1.6
1.0
2.5
0.9
1.0
1.8
2.3
2.3
2.1
2.3
3.3
2.5
4.0
3.2
3.3
1.6
1.7
2.2
3.2
3.5

16.0
11.3
14.0
13.8
12.7
12.8
10.5
13.0
12.5
19.0
16.0
16.0
14.3
8.00
14.8
11.5
14.0
11.0
11.5
16.0
11.0
15.5
15.5
16.0
17.0
10.8
18.0
23.3
18.0
13.0
18.8
25.0
32.0
27.8
29.0
35.0
39.5
66.0
55.5
68.0
2.38
2.38
3.25
4.25
5.00
3.00
3.50
4.00
5.00
4.00
4.00
6.00
4.50
4.50
6.00
5.00
4.00
4.00
4.50
4.50
6.50
4.00
5.50
7.75
4.00
7.00
6.00
6.00
8.00
5.00
6.00
6.25
6.00
6.25
6.25
5.50
8.00
6.25
5.75
6.25

SST
SPR
SPR
MW
SST
SST
SPR
SPR
SPR
SST
HD
SST
MW
SPR
SPR
SPR
SST
SPR
SPR
SPR
HD
HD
SPR
SPR
SPR
HD
HD
HD
SPR
SPR
SPR
SPR
SPR
HD
HD
MW
SPR
SPR
HD
HD
MW
SST
SST
SST
SST
SPR
SST
SST
SPR
SST
SPR
MW
SST
SST
MW
SPR
HD
MW
SST
MW
SPR
SPR
SST
SST
SST
SST
HD
SPR
SST
SPR
SPR
SPR
SPR
SPR
MW
SPR
SST
SST
SPR
SPR

E
N
D
S

CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
C
C
CG
C
C
C
C
CG
CG
C
CG
CG
CG
C
C
CG
C
CG
C
C
CG
CG
C
C
C
CG
CG
CG
C
CG
CG
C
C
CG
C
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
Z
Z
Z
N
N
Z
Z
Z
N
N
N
Z
Z
Z
Z
N
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
GI
Z
Z
Z
Z
N
N
N
N
N
N
N
N
Z
N
Z
Z
N
N
Z
Z
Z
Z
N
Z
Z
Z
N
N
N
N
Z
Z
N
Z
Z
Z
N
Z
Z
N
N
N
Z
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

151

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 152

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.703
0.710
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718

17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
17.86
18.03
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24

2573
11878
11293
3951
AA-69
2676
B11-66
11943
10139
10920
3164
S-1680
10631
11378
3517
AA-76
A10-67
A15-62
11675
S-1289
B12-60
S-1309
12141
3581
GG-100
1711
3559
3813
S-1000
S-251
S-280
4263
12501
12557
4348
4373
10573
NN-96
3462
3422
3672
S-1495
12335
10415
12274
3063
GG-43
12039
10523
S-1200
11274
11273
11344
11725
3052
12450
10446
12283
S-3013
3481
10270
12171
3705
12806
B2-48
S-1381
S-20
S-216
HH-91
KK-80
MM-79
MM-71
1945
12261
S-125
3750
S-3142
S-3180
W-38
QQ-31

1.19
1.19
1.19
1.25
1.25
1.25
1.25
1.28
1.31
1.31
1.34
1.41
1.41
1.41
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.63
1.66
1.75
1.78
1.81
1.86
1.91
1.94
1.94
1.97
2.00
2.13
2.19
2.22
2.38
2.53
2.56
2.69
2.72
2.75
2.84
3.06
3.38
3.50
3.50
3.50
4.13
4.13
4.13
4.25
4.41
4.50
6.00
6.00
8.13
8.75
.63
.41
.44
.50
.50
.59
.59
.63
.63
.66
.66
.66
.69
.69
.75
.75
.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

30.2
30.2
30.2
31.8
31.8
31.8
31.8
32.5
33.3
33.3
34.1
35.7
35.7
35.7
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
41.3
42.1
44.5
45.2
46.0
47.2
48.4
49.2
49.2
50.0
50.8
54.0
55.6
56.4
60.3
64.3
65.1
68.2
69.0
69.9
72.2
77.8
85.7
88.9
88.9
88.9
104.8
104.8
104.8
108.0
111.9
114.3
152.4
152.4
206.4
222.3
15.9
10.3
11.1
12.7
12.7
15.1
15.1
15.9
15.9
16.7
16.7
16.7
17.4
17.4
19.1
19.1
19.1

MATERIAL: MW - Music Wire

152

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.639
.601
.533
.613
.543
.517
.453
.567
.569
.513
.575
.623
.619
.559
.559
.483
.631
.617
.583
.579
.571
.569
.569
.559
.553
.521
.507
.519
.641
.519
.521
.579
.543
.545
.521
.521
.573
.503
.543
.463
.557
.579
.583
.477
.577
.513
.643
.543
.583
.559
.521
.507
.407
.613
.579
.493
.463
.553
.563
.583
.391
.489
.573
.526
.666
.616
.592
.532
.612
.606
.638
.578
.612
.612
.532
.590
.536
.636
.634
.616

RATE
mm

16.2
15.3
13.5
15.6
13.8
13.1
11.5
14.4
14.5
13.0
14.6
15.8
15.7
14.2
14.2
12.3
16.0
15.7
14.8
14.7
14.5
14.5
14.5
14.2
14.0
13.2
12.9
13.2
16.3
13.2
13.2
14.7
13.8
13.8
13.2
13.2
14.6
12.8
13.8
11.8
14.1
14.7
14.8
12.1
14.7
13.0
16.3
13.8
14.8
14.2
13.2
12.9
10.3
15.6
14.7
12.5
11.8
14.0
14.3
14.8
9.9
12.4
14.6
13.4
16.9
15.6
15.0
13.5
15.5
15.4
16.2
14.7
15.5
15.5
13.5
15.0
13.6
16.2
16.1
15.6

Lbs./In.

1.2
6.2
79
6.9
62
118
428
30
28
83
15
2.6
2.7
24
24
168
1.8
4.7
14
16
22
20
23
29
17
123
92
56
.67
49
48
10
36
14
49
51
12
105
35
201
18
5.8
7.0
114
7.9
41
.34
22
5.3
7.9
36
33
336
2.3
5.0
50
66
9.2
7.6
3.9
198
22
2.4
218
3.4
14
70
192
17
32
4.2
75
19
17
120
25
199
5.7
4.2
5.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

.22
1.1
14
1.2
11
21
75
5.3
4.9
15
2.7
.46
.48
4.2
4.1
29
.32
.82
2.5
2.7
3.9
3.4
3.9
5.1
2.9
22
16
9.9
.12
8.6
8.3
1.8
6.3
2.5
8.6
8.9
2.1
18
6.1
35
3.2
1.0
1.2
20
1.4
7.2
.06
3.9
.93
1.4
6.3
5.8
59
.40
.88
8.7
12
1.6
1.3
.68
35
3.9
.43
38
.60
2.5
12
34
3.0
5.7
.73
13
3.4
3.0
21
4.3
35
1.0
.73
1.0

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.96 24
.83 21
.37
9.4
.74 19
.37
9.5
.43 11
.20
5.0
.54 14
.55 14
.47 12
.77 19
1.1
28
1.1
28
.71 18
.76 19
.34
8.7
1.2
32
.89 23
.79 20
.74 19
.66 17
.74 19
.68 17
.86 22
.45 11
.28
7.1
.65 17
.63 16
1.4
36
.67 17
.67 17
1.1
29
.68 17
.39
9.8
.70 18
.68 17
1.1
28
.43 11
.71 18
.37
9.4
1.0
26
1.5
38
1.6
40
.55 14
1.6
42
.96 24
2.4
61
1.1
28
2.1
53
2.0
51
.96 24
1.3
33
.39
9.9
2.2
56
2.4
62
1.1
27
1.1
29
2.2
56
2.0
52
2.9
73
.75 19
2.5
63
5.8 147
.16
4.1
.27
7.0
.23
5.9
.17
4.3
.13
3.3
.38
9.7
.27
6.9
.45 11
.20
5.2
.39
9.9
.39
9.9
.17
4.3
.27
6.9
.16
4.0
.59 15
.54 14
.34
8.7

Lbs.

1.2
5.2
29
5.1
23
51
84
16
15
39
12
2.9
3.1
17
18
58
2.3
4.2
11
12
15
14
15
25
7.5
34
60
36
.96
33
32
11
25
5.5
34
34
13
45
25
74
19
8.8
11
63
13
39
.81
25
11
16
34
43
131
5.1
12
52
74
20
16
11
148
55
14
35
.95
3.3
12
25
6.5
8.9
1.9
15
7.5
6.7
20
6.7
31
3.3
2.3
1.9

ENDS: C - Closed

G - Ground
O - Open

5.3
23
131
23
103
229
372
72
68
174
53
13
14
75
80
258
10
18
49
51
66
64
68
112
33
153
266
158
4.2
147
142
51
110
24
153
153
59
202
110
331
84
39
49
278
57
174
3.6
110
49
70
153
190
582
23
54
233
331
91
69
49
658
246
63
157
4.2
15
53
109
29
40
8.3
68
34
30
90
30
140
15
10
8.7

Inches

mm

.22
5.7
.36
9.1
.51 13.0
.23
5.7
.44 11.2
.65 16.5
.78 19.8
.41 10.4
.47 11.9
.78 19.9
.58 14.6
.29
7.4
.29
7.5
.56 14.2
.61 15.5
.88 22.4
.25
6.4
.23
5.7
.42 10.7
.40 10.2
.51 13.0
.47 11.9
.47 11.9
.52 13.3
1.05 26.7
.50 12.7
.83 21.2
.92 23.4
.24
6.1
.92 23.4
.91 23.1
.68 17.3
.78 19.8
1.52 38.6
.98 24.8
.96 24.3
.60 15.3
.83 21.0
.80 20.3
1.26 32.0
.80 20.4
.87 22.0
.78 19.8
1.36 34.4
.82 20.8
1.40 35.6
.36
9.1
1.04 26.4
.92 23.2
1.37 34.7
1.27 32.4
1.96 49.8
2.07 52.6
.50 12.6
1.12 28.3
1.94 49.3
2.97 75.4
1.65 41.9
1.23 31.1
1.26 32.0
4.41 111.9
4.49 114.1
2.83 71.8
.37
9.3
.09
2.3
.20
5.2
.25
6.4
.37
9.4
.21
5.4
.20
5.0
.18
4.6
.25
6.2
.27
6.7
.27
6.7
.49 12.4
.42 10.6
.43 11.0
.16
4.2
.21
5.3
.41 10.4

WIRE DIA.
Inches

0.032
0.051
0.085
0.045
0.080
0.093
0.125
0.068
0.067
0.095
0.064
0.040
0.042
0.072
0.072
0.110
0.036
0.043
0.060
0.062
0.066
0.067
0.067
0.072
0.075
0.091
0.098
0.092
0.031
0.092
0.091
0.062
0.080
0.079
0.091
0.091
0.065
0.100
0.080
0.120
0.073
0.062
0.060
0.113
0.063
0.095
0.030
0.080
0.060
0.072
0.091
0.098
0.148
0.045
0.062
0.105
0.120
0.075
0.070
0.060
0.156
0.107
0.065
0.092
0.026
0.051
0.063
0.093
0.053
0.056
0.040
0.070
0.053
0.053
0.093
0.064
0.091
0.041
0.042
0.051

mm

TOTAL
MATL
COILS

0.8
1.3
2.2
1.1
2.0
2.4
3.2
1.7
1.7
2.4
1.6
1.0
1.1
1.8
1.8
2.8
0.9
1.1
1.5
1.6
1.7
1.7
1.7
1.8
1.9
2.3
2.5
2.3
0.8
2.3
2.3
1.6
2.0
2.0
2.3
2.3
1.7
2.5
2.0
3.0
1.9
1.6
1.5
2.9
1.6
2.4
0.8
2.0
1.5
1.8
2.3
2.5
3.8
1.1
1.6
2.7
3.0
1.9
1.8
1.5
4.0
2.7
1.7
2.3
0.7
1.3
1.6
2.4
1.3
1.4
1.0
1.8
1.3
1.3
2.4
1.6
2.3
1.0
1.1
1.3

6.00
7.00
6.00
5.00
5.50
6.00
6.25
6.00
6.00
8.25
8.00
6.25
7.00
7.75
8.50
8.00
6.00
5.25
7.00
6.50
6.75
7.00
7.00
7.25
13.0
5.50
8.50
10.0
7.75
10.0
10.0
10.0
8.75
18.3
10.8
10.5
9.25
8.25
9.00
9.50
11.0
14.0
12.0
12.0
13.0
14.8
12.0
13.0
15.3
19.0
14.0
20.0
14.0
11.0
18.0
18.5
24.8
22.0
17.5
20.0
28.3
42.0
42.5
4.00
2.50
4.00
3.00
4.00
4.00
3.50
4.50
3.50
4.00
4.00
5.25
5.50
3.75
4.00
5.00
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

HD
SST
SPR
SPR
SST
MW
SPR
SPR
SPR
SPR
SPR
SST
SST
SST
HD
SPR
SST
SST
SPR
SST
SPR
SST
SPR
MW
SPR
SPR
MW
SPR
SST
SST
SST
SPR
SPR
MW
SPR
SPR
SST
SPR
HD
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SST
SST
SST
SPR
SST
SST
SPR
SST
SST
HD
SST
SST
SST
SST

E
N
D
S

C
CG
CG
CG
CG
C
CG
CG
C
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
C
CG
C
CG
CG
CG
CG
CG
C
C
CG
C
C
CG
CG
C

F
N
S
H

Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
N
N
N
Z
N
N
N
GI
N
Z
N
Z
Z
GI
Z
Z
Z
N
N
N
Z
N
N
Z
Z
N
Z
Z
Z
Z
N
Z
Z
Z
Z
N
Z
GI
N
Z
Z
Z
GI
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
N
N
N
N
Z
N
N
Z
N
N
Z
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 153

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718
0.718

18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24
18.24

11458
A9-38
A14-47
12729
S-1364
10233
S-1082
A12-41
RR-33
S-878
3973
CC-80
S-1260
S-3077
10907
S-246
S-430
QQ-44
S-1034
3792
B11-4
M-145
S-69
B10-56
KK-56
3993
Q-51
B9-62
S-48
S-3252
B6-54
10565
S-1431
11252
3829
11612
10633
10070
S-370
S-285
S-849
10209
11588
2946
11756
10599
YY-33
S-1440
10257
A15-53
A13-33
2778
10867
4367
B9-56
2651
S-1630
12625
B11-53
3386
11575
N-121
3739
S-3164
1707
S-1469
10721
B9-51
2509
10396
313
4277
11660
S-3243
2894
S-3026
12637
B8-66
S-997
10698

.75
.81
.81
.87
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.13
1.16
1.22
1.22
1.25
1.31
1.31
1.31
1.31
1.34
1.38
1.38
1.38
1.41
1.50
1.50
1.50
1.59
1.59
1.63
1.63
1.63
1.63
1.69
1.69
1.75
1.75
1.81
1.81
1.88
1.88
1.91
1.94
2.00
2.00
2.00
2.00
2.03
2.06
2.13
2.13
2.13
2.19
2.22
2.22
2.31
2.38
2.50
2.53
2.56
2.63
2.63
2.75
3.00
3.25
3.38
3.41
3.50
3.50
3.53
3.84
4.50
4.50
4.81
5.13
5.75
6.25

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

19.1
20.6
20.6
22.0
22.2
22.2
25.4
25.4
25.4
25.4
25.4
25.4
26.2
28.6
29.4
31.0
31.0
31.8
33.3
33.3
33.3
33.3
34.1
34.9
34.9
34.9
35.7
38.1
38.1
38.1
40.5
40.5
41.3
41.3
41.3
41.3
42.8
42.8
44.5
44.5
46.0
46.0
47.6
47.6
48.4
49.2
50.8
50.8
50.8
50.8
51.6
52.4
54.0
54.0
54.0
55.6
56.4
56.4
58.7
60.3
63.5
64.3
65.1
66.7
66.7
69.9
76.2
82.6
85.7
86.5
88.9
88.9
89.7
97.6
114.3
114.3
122.2
130.2
146.1
158.8

I.D.
Inches

.574
.634
.478
.638
.594
.574
.638
.628
.618
.610
.574
.546
.636
.614
.628
.624
.608
.534
.634
.614
.594
.572
.610
.618
.578
.478
.568
.622
.594
.446
.654
.488
.636
.528
.508
.458
.622
.394
.654
.636
.574
.354
.598
.584
.524
.530
.628
.584
.536
.528
.582
.568
.594
.584
.556
.488
.636
.494
.588
.574
.526
.572
.558
.628
.570
.594
.478
.578
.534
.536
.636
.578
.512
.576
.574
.562
.656
.562
.640
.432

RATE
mm

14.6
16.1
12.1
16.2
15.1
14.6
16.2
16.0
15.7
15.5
14.6
13.9
16.2
15.6
16.0
15.8
15.4
13.6
16.1
15.6
15.1
14.5
15.5
15.7
14.7
12.1
14.4
15.8
15.1
11.3
16.6
12.4
16.2
13.4
12.9
11.6
15.8
10.0
16.6
16.2
14.6
9.0
15.2
14.8
13.3
13.5
16.0
14.8
13.6
13.4
14.8
14.4
15.1
14.8
14.1
12.4
16.2
12.5
14.9
14.6
13.4
14.5
14.2
16.0
14.5
15.1
12.1
14.7
13.6
13.6
16.2
14.7
13.0
14.6
14.6
14.3
16.7
14.3
16.3
11.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

51
8.9
6.4
1.1
612 107
4.1
.72
24
4.2
25
4.4
2.9
.51
6.4
1.1
7.5
1.3
11
2.0
48
8.4
98
17
3.3
.57
7.7
1.4
3.4
.60
5.0
.88
6.9
1.2
56
9.8
4.2
.73
7.9
1.4
11
1.9
43
7.6
14
2.4
7.5
1.3
23
4.0
199
35
31
5.4
6.3
1.1
11
1.9
443
77
.93
.16
118
21
2.4
.42
59
10
101
18
274
48
3.6
.63
1047 183
.90
.16
1.1
.20
12
2.2
1517 266
10
1.8
17
3.1
71
12
54
9.5
2.4
.42
13
2.3
53
9.3
57
10
15
2.6
25
4.4
13
2.2
11
1.9
27
4.8
104
18
1.5
.27
92
16
12
2.2
14
2.5
39
6.8
17
3.0
23
4.0
1.1
.18
18
3.1
7.5
1.3
100
17
12
2.1
23
4.1
32
5.6
1.5
.27
11
1.9
56
9.7
9.2
1.6
7.7
1.4
13
2.2
.30
.05
11
1.9
.42
.07
99
17

Inches

mm

.33
8.3
.59 15
.11
2.8
.67 17
.47 12
.32
8.1
.74 19
.73 19
.65 17
.67 17
.37
9.4
.28
7.2
.81 20
.81 21
.84 21
.89 23
.80 20
.38
9.6
.90 23
.90 23
.75 19
.42 11
.55 14
.84 21
.71 18
.30
7.5
.64 16
.95 24
1.0
26
.21
5.2
1.4
35
.24
6.1
1.3
34
.65 16
.51 13
.25
6.5
1.2
31
.15
3.9
1.5
38
1.3
32
.95 24
.14
3.5
1.1
28
.86 22
.58 15
.68 17
1.6
39
1.1
28
.63 16
.62 16
1.0
26
1.1
28
.96 24
1.4
34
.86 22
.62 16
1.8
46
.65 16
1.1
29
1.2
31
.96 24
1.1
28
1.1
27
1.8
45
1.1
27
1.5
38
.73 19
1.3
34
1.5
38
1.1
27
2.4
62
1.5
38
.87 22
1.7
44
2.3
58
1.7
42
4.3 110
2.1
53
4.8 121
1.2
30

ENDS: C - Closed

G - Ground
O - Open

Lbs.

17
3.8
67
2.8
11
7.9
2.2
4.7
4.9
7.5
18
28
2.6
6.3
2.9
4.5
5.5
21
3.8
7.1
8.1
18
7.5
6.3
16
59
20
6.0
11
91
1.3
28
3.2
38
51
70
4.4
161
1.4
1.4
12
212
11
15
41
37
3.7
14
34
36
15
28
12
15
23
65
2.8
60
14
18
38
18
24
1.9
19
11
73
16
35
34
3.8
16
49
16
18
21
1.3
22
2.0
117

74
17
296
12
50
35
9.7
21
22
33
79
124
12
28
13
20
25
94
17
32
36
82
33
28
73
261
89
27
49
406
5.7
127
14
171
228
311
19
718
6.1
6.4
53
941
48
67
181
165
17
63
150
158
66
124
53
67
104
287
13
266
61
79
167
82
107
8.3
85
50
325
73
155
150
17
73
216
71
79
93
5.7
100
8.8
520

Inches

mm

Inches

.40 10.1
.21
5.3
.48 12.2
.20
5.0
.29
7.5
.56 14.2
.26
6.6
.27
6.9
.35
8.9
.28
7.2
.43 11.0
.41 10.4
.23
5.7
.31
7.9
.32
8.0
.33
8.4
.42 10.7
.87 22.2
.25
6.4
.34
8.6
.56 14.2
.47 12.1
.25
6.4
.30
7.6
.53 13.3
1.08 27.4
.56 14.3
.34
8.5
.50 12.6
.95 24.2
.22
5.7
1.35 34.3
.28
7.0
.88 22.3
1.00 25.3
1.37 34.8
.48 12.2
1.22 30.9
.24
6.1
.49 12.5
.86 21.9
1.59 40.5
.57 14.5
.60 15.3
.92 23.4
.99 25.1
.45 11.4
.60 15.3
.96 24.3
.90 22.9
.60 15.1
.73 18.6
.50 12.6
.77 19.6
.79 20.1
1.50 38.0
.39
9.9
1.46 37.0
.62 15.7
.86 21.9
1.54 39.0
.80 20.4
.96 24.4
.86 21.7
.81 20.7
.67 16.9
1.92 48.8
.88 22.2
1.84 46.7
1.32 33.5
.47 12.0
.95 24.0
1.49 37.9
1.07 27.1
1.48 37.5
1.33 33.7
.47 11.8
1.72 43.6
.98 25.0
4.86 123.5

0.072
0.042
0.120
0.040
0.062
0.072
0.040
0.045
0.050
0.054
0.072
0.086
0.041
0.052
0.045
0.047
0.055
0.092
0.042
0.052
0.062
0.073
0.054
0.050
0.070
0.120
0.075
0.048
0.062
0.136
0.032
0.115
0.041
0.095
0.105
0.130
0.048
0.162
0.032
0.041
0.072
0.182
0.060
0.067
0.097
0.094
0.045
0.067
0.091
0.095
0.068
0.075
0.062
0.067
0.081
0.115
0.041
0.112
0.065
0.072
0.096
0.073
0.080
0.045
0.074
0.062
0.120
0.070
0.092
0.091
0.041
0.070
0.103
0.071
0.072
0.078
0.031
0.078
0.039
0.143

mm

TOTAL
MATL
COILS

1.8
1.1
3.0
1.0
1.6
1.8
1.0
1.1
1.3
1.4
1.8
2.2
1.0
1.3
1.1
1.2
1.4
2.3
1.1
1.3
1.6
1.9
1.4
1.3
1.8
3.0
1.9
1.2
1.6
3.5
0.8
2.9
1.0
2.4
2.7
3.3
1.2
4.1
0.8
1.0
1.8
4.6
1.5
1.7
2.5
2.4
1.1
1.7
2.3
2.4
1.7
1.9
1.6
1.7
2.1
2.9
1.0
2.8
1.7
1.8
2.4
1.9
2.0
1.1
1.9
1.6
3.0
1.8
2.3
2.3
1.0
1.8
2.6
1.8
1.8
2.0
0.8
2.0
1.0
3.6

4.50
4.00
4.00
4.88
4.75
7.75
5.50
5.00
6.00
5.25
5.00
4.75
5.50
6.00
7.00
6.00
7.67
9.50
5.00
6.50
9.00
5.50
4.67
6.00
7.50
9.00
7.50
6.00
8.00
7.00
7.00
11.8
6.75
9.25
9.50
9.50
9.00
7.50
6.50
12.0
12.0
8.75
8.50
8.00
9.50
10.5
9.00
9.00
9.50
9.50
8.75
8.75
8.00
11.5
9.75
13.0
9.50
13.0
9.50
12.0
15.0
11.0
12.0
18.0
11.0
10.8
16.0
12.5
20.0
14.5
10.5
13.5
14.5
15.0
20.5
16.0
14.0
21.0
24.3
34.0

SST
SST
SST
MW
SST
SPR
SST
MW
SPR
SST
SPR
SST
SST
SST
SST
SST
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SST
SST
MW
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
HD
SPR
HD
SPR
SPR
SST
SPR
SST
SST
SPR
SST
SPR

E
N
D
S

F
N
S
H

C
C
CG
CG
CG
CG
C
C
C
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
C
CG

N
N
N
BO
N
Z
N
Z
Z
N
Z
N
N
N
N
N
N
Z
N
GI
N
GI
N
N
N
Z
N
N
N
N
Z
Z
N
N
Z
Z
Z
Z
N
N
N
Z
Z
Z
Z
Z
N
N
Z
N
N
Z
GI
Z
N
Z
N
Z
N
Z
N
N
Z
N
Z
N
Z
N
Z
Z
Z
Z
Z
N
Z
N
N
N
N
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

153

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 154

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.719
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720

18.26
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29

U-84
71926
71926S
71951
71951S
71927
71927S
71938
71938S
71952
71952S
71963
71963S
71976
71976S
71991
71991S
72014
72014S
72029
72029S
72057
72057S
72070
72070S
72097
72097S
72110
72110S
72123
72123S
71928
71928S
71939
71939S
71953
71953S
71964
71964S
71977
71977S
71993
71993S
72015
72015S
72031
72031S
72058
72058S
72071
72071S
72098
72098S
72111
72111S
72124
72124S
71929
71929S
71940
71940S
71954
71954S
71965
71965S
71978
71978S
71995
71995S
72016
72016S
72033
72033S
72034
72034S
72059
72059S
72072
72072S
72099

.61
.63
.63
.63
.63
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.75
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

15.5
16.0
16.0
16.0
16.0
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4

MATERIAL: MW - Music Wire

154

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.637
.610
.610
.594
.594
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.558
.558
.550
.550
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.558
.558
.550
.550
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.560
.560
.558
.558
.550
.550
.528

RATE
mm

16.2
15.5
15.5
15.1
15.1
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.2
14.2
14.0
14.0
13.4

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

2.5
31
26
47
40
23
20
33
28
33
28
44
37
50
43
50
42
67
57
92
78
104
88
139
118
239
203
355
301
469
398
20
17
27
23
28
24
37
31
40
34
41
35
48
41
76
65
82
70
114
97
194
165
286
243
374
318
19
16
24
20
24
20
31
26
33
28
35
30
42
36
65
55
108
92
71
60
97
82
165

.44
5.4
4.6
8.2
7.0
4.0
3.4
5.8
4.9
5.8
4.9
7.6
6.5
8.8
7.4
8.7
7.4
12
10
16
14
18
15
24
21
42
36
62
53
82
70
3.5
3.0
4.8
4.1
4.9
4.2
6.4
5.4
7.0
6.0
7.2
6.2
8.4
7.1
13
11
14
12
20
17
34
29
50
43
66
56
3.2
2.8
4.1
3.5
4.2
3.6
5.4
4.6
5.8
4.9
6.2
5.3
7.4
6.3
11
9.6
19
16
12
11
17
14
29

.34
.38
.30
.37
.30
.51
.40
.44
.35
.47
.42
.44
.35
.42
.33
.44
.35
.37
.29
.37
.29
.34
.27
.29
.23
.23
.18
.20
.16
.18
.14
.58
.46
.53
.42
.57
.50
.52
.42
.52
.42
.53
.42
.51
.41
.44
.35
.42
.33
.35
.28
.28
.22
.25
.20
.22
.17
.63
.50
.61
.49
.66
.58
.62
.49
.63
.50
.62
.49
.59
.46
.52
.41
.31
.25
.49
.39
.41
.33
.33

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

8.7
9.7
7.7
9.5
7.5
13
10
11
8.8
12
11
11
8.9
11
8.5
11
8.9
9.3
7.4
9.3
7.3
8.6
6.8
7.3
5.8
5.9
4.6
5.1
4.0
4.5
3.5
15
12
13
11
15
13
13
11
13
11
13
11
13
10
11
8.9
11
8.5
9.0
7.1
7.2
5.6
6.4
5.0
5.7
4.3
16
13
16
12
17
15
16
13
16
13
16
12
15
12
13
10
7.9
6.3
13
9.9
11
8.3
8.5

Lbs.

.86
12
7.9
17
12
12
7.9
14
9.7
16
12
19
13
21
14
22
15
25
17
34
23
35
23
40
27
55
37
72
47
83
54
12
7.9
14
9.7
16
12
19
13
21
14
22
15
25
17
34
23
35
23
40
27
55
37
72
47
83
54
12
7.9
14
9.7
16
12
19
13
21
14
22
15
25
17
34
23
34
23
35
23
40
27
55

ENDS: C - Closed

G - Ground
O - Open

3.8
52
35
78
53
52
35
64
43
70
53
85
58
93
63
97
66
110
74
150
100
155
104
179
120
245
163
318
211
371
242
52
35
64
43
71
53
85
58
93
63
97
66
110
74
150
100
155
104
179
120
245
163
318
211
371
242
52
35
64
43
71
53
85
58
93
63
97
66
110
74
150
100
150
100
155
104
179
120
245

Inches

.27
.19
.19
.24
.24
.22
.22
.23
.23
.28
.28
.27
.27
.28
.28
.29
.29
.30
.30
.36
.36
.34
.34
.35
.35
.40
.40
.43
.43
.46
.46
.23
.23
.25
.25
.31
.31
.29
.29
.31
.31
.31
.31
.36
.36
.40
.40
.39
.39
.39
.39
.44
.44
.49
.49
.53
.53
.24
.24
.27
.27
.34
.34
.33
.33
.34
.34
.35
.35
.39
.39
.44
.44
.33
.33
.44
.44
.43
.43
.48

mm

6.8
4.9
4.9
6.0
6.0
5.6
5.6
5.8
5.8
7.0
7.0
6.8
6.8
7.0
7.0
7.3
7.3
7.5
7.5
9.1
9.1
8.7
8.7
8.9
8.9
10.1
10.1
11.0
11.0
11.7
11.7
5.9
5.9
6.4
6.4
7.8
7.8
7.4
7.4
7.9
7.9
8.0
8.0
9.1
9.1
10.2
10.2
10.0
10.0
10.0
10.0
11.3
11.3
12.3
12.3
13.5
13.5
6.1
6.1
6.9
6.9
8.6
8.6
8.3
8.3
8.7
8.7
8.9
8.9
9.8
9.8
11.2
11.2
8.4
8.4
11.1
11.1
10.8
10.8
12.2

WIRE DIA.
Inches

mm

0.041
0.055
0.055
0.063
0.063
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.080
0.080
0.081
0.081
0.085
0.085
0.096

1.0
1.4
1.4
1.6
1.6
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.0
2.0
2.1
2.1
2.2
2.2
2.4

FINISH: Z - Zinc

TOTAL
MATL
COILS
6.50
3.50
3.50
3.75
3.75
4.00
4.00
3.88
3.88
4.38
4.38
4.13
4.13
4.13
4.13
4.25
4.25
4.13
4.13
4.50
4.50
4.25
4.25
4.13
4.13
4.13
4.13
4.13
4.13
4.13
4.13
4.25
4.25
4.25
4.25
4.88
4.88
4.50
4.50
4.63
4.63
4.63
4.63
5.00
5.00
5.00
5.00
4.88
4.88
4.63
4.63
4.63
4.63
4.63
4.63
4.75
4.75
4.38
4.38
4.63
4.63
5.38
5.38
5.00
5.00
5.13
5.13
5.13
5.13
5.38
5.38
5.50
5.50
4.13
4.13
5.38
5.38
5.00
5.00
5.00

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 155

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720

18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29

72099S
72112
72112S
72125
72125S
71930
71930S
71941
71941S
71955
71955S
71966
71966S
71979
71979S
71997
71997S
72017
72017S
72036
72036S
72037
72037S
72060
72060S
72073
72073S
72100
72100S
72113
72113S
72126
72126S
71931
71931S
71942
71942S
71956
71956S
71967
71967S
71980
71980S
71999
71999S
72018
72018S
72039
72039S
72040
72040S
72061
72061S
72074
72074S
72101
72101S
72114
72114S
72127
72127S
71932
71932S
71943
71943S
71957
71957S
71968
71968S
71981
71981S
72001
72001S
72019
72019S
72042
72042S
72062
72062S
72075

1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5

I.D.
Inches

.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.560
.560
.558
.558
.550
.550
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.560
.560
.558
.558
.550
.550
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.558
.558
.550

RATE
mm

13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.2
14.2
14.0
14.0
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.2
14.2
14.0
14.0
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

140
243
206
315
268
15
12
18
16
19
16
24
21
27
23
28
23
34
29
50
42
83
70
54
46
75
63
126
107
184
157
238
203
12
9.8
15
13
15
13
20
17
22
19
22
19
26
22
41
34
67
57
44
38
61
51
102
87
149
126
192
163
9.1
7.7
13
11
13
11
17
14
18
15
19
16
22
19
34
29
37
32
51

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

25
42
36
55
47
2.5
2.2
3.2
2.7
3.3
2.8
4.2
3.6
4.7
4.0
4.8
4.1
6.0
5.1
8.7
7.4
14
12
9.5
8.1
13
11
22
19
32
27
42
35
2.0
1.7
2.6
2.2
2.6
2.2
3.5
3.0
3.9
3.3
3.9
3.3
4.6
3.9
7.1
6.0
12
10
7.7
6.6
11
9.0
18
15
26
22
34
29
1.6
1.4
2.2
1.9
2.3
1.9
2.9
2.5
3.2
2.7
3.3
2.8
3.9
3.3
6.0
5.1
6.5
5.6
8.9

Inches

.26
.30
.23
.26
.20
.80
.64
.78
.63
.86
.74
.79
.63
.77
.62
.79
.63
.73
.57
.68
.53
.41
.32
.64
.51
.54
.43
.44
.34
.39
.30
.35
.27
1.0
.81
.96
.76
1.0
.93
.96
.77
.95
.76
.97
.78
.95
.75
.83
.66
.50
.40
.79
.62
.66
.52
.54
.42
.48
.38
.44
.33
1.3
1.0
1.1
.90
1.2
1.1
1.2
.92
1.2
.93
1.1
.92
1.1
.89
.98
.78
.93
.74
.79

mm

6.6
7.5
5.8
6.7
5.2
20
16
20
16
22
19
20
16
20
16
20
16
18
15
17
14
10
8.2
16
13
14
11
11
8.7
9.9
7.7
8.9
6.8
26
21
24
19
26
24
24
19
24
19
25
20
24
19
21
17
13
10
20
16
17
13
14
11
12
9.5
11
8.5
33
26
29
23
31
27
29
23
29
24
29
23
29
22
25
20
24
19
20

ENDS: C - Closed

G - Ground
O - Open

Lbs.

37
72
47
83
54
12
7.9
14
9.7
16
12
19
13
21
14
22
15
25
17
34
23
34
23
35
23
40
27
55
37
72
47
83
54
12
7.9
14
9.7
16
12
19
13
21
14
22
15
25
17
34
23
34
23
35
23
40
27
55
37
72
47
83
54
12
7.9
14
9.7
16
12
19
13
21
14
22
15
25
17
34
23
35
23
40

163
318
211
371
242
52
35
64
43
71
53
85
58
93
63
97
66
110
74
150
100
150
100
155
104
179
120
245
163
318
211
371
242
52
35
64
43
69
53
85
58
93
63
97
66
110
74
150
100
150
100
155
104
179
120
245
163
318
211
371
242
52
35
64
43
72
53
85
58
93
63
97
66
110
74
150
100
155
104
179

Inches

.48
.54
.54
.59
.59
.28
.28
.31
.31
.39
.39
.37
.37
.39
.39
.41
.41
.44
.44
.52
.52
.38
.38
.52
.52
.50
.50
.58
.58
.64
.64
.70
.70
.32
.32
.35
.35
.46
.46
.43
.43
.45
.45
.48
.48
.54
.54
.60
.60
.43
.43
.60
.60
.58
.58
.66
.66
.74
.74
.81
.81
.38
.38
.40
.40
.51
.51
.49
.49
.52
.52
.54
.54
.61
.61
.69
.69
.68
.68
.66

mm

Inches

12.2
13.7
13.7
14.9
14.9
7.2
7.2
7.9
7.9
10.0
10.0
9.5
9.5
10.0
10.0
10.4
10.4
11.2
11.2
13.2
13.2
9.7
9.7
13.1
13.1
12.7
12.7
14.6
14.6
16.3
16.3
17.8
17.8
8.2
8.2
9.0
9.0
11.8
11.8
10.9
10.9
11.5
11.5
12.1
12.1
13.7
13.7
15.2
15.2
10.9
10.9
15.2
15.2
14.8
14.8
16.8
16.8
18.7
18.7
20.6
20.6
9.6
9.6
10.1
10.1
13.0
13.0
12.4
12.4
13.2
13.2
13.6
13.6
15.5
15.5
17.5
17.5
17.2
17.2
16.7

0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.080
0.080
0.081
0.081
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.080
0.080
0.081
0.081
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085

mm

2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.0
2.0
2.1
2.1
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.0
2.0
2.1
2.1
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2

TOTAL
MATL
COILS
5.00
5.13
5.13
5.25
5.25
5.13
5.13
5.25
5.25
6.25
6.25
5.75
5.75
5.88
5.88
6.00
6.00
6.13
6.13
6.50
6.50
4.75
4.75
6.38
6.38
5.88
5.88
6.00
6.00
6.13
6.13
6.25
6.25
5.88
5.88
6.00
6.00
7.38
7.38
6.63
6.63
6.75
6.75
7.00
7.00
7.50
7.50
7.50
7.50
5.38
5.38
7.38
7.38
6.88
6.88
6.88
6.88
7.00
7.00
7.25
7.25
6.88
6.88
6.75
6.75
8.13
8.13
7.50
7.50
7.75
7.75
7.88
7.88
8.50
8.50
8.63
8.63
8.38
8.38
7.75

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

155

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 156

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720

18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29

72075S
72084
72084S
72102
72102S
72115
72115S
72128
72128S
71933
71933S
71944
71944S
71958
71958S
71969
71969S
71982
71982S
72003
72003S
72020
72020S
72044
72044S
72063
72063S
72076
72076S
72086
72086S
72103
72103S
72116
72116S
72129
72129S
71934
71934S
71945
71945S
71959
71959S
71970
71970S
71983
71983S
72005
72005S
72021
72021S
72046
72046S
72064
72064S
72077
72077S
72088
72088S
72104
72104S
72117
72117S
72130
72130S
71935
71935S
71946
71946S
71960
71960S
71971
71971S
71984
71984S
72007
72007S
72022
72022S
72048

1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5

MATERIAL: MW - Music Wire

156

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.550
.538
.538
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.558
.558
.550
.550
.538
.538
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.558
.558
.550
.550
.538
.538
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560

RATE
mm

14.0
13.7
13.7
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.7
13.7
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.7
13.7
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2

Lbs./In.

43
56
48
86
73
124
106
160
136
8.5
7.2
11
9.4
11
9.4
14
12
16
13
16
14
20
17
30
25
32
27
44
37
49
41
74
63
107
91
138
117
7.5
6.4
9.7
8.2
11
9.4
13
11
14
12
15
12
18
15
26
22
28
24
39
33
43
36
65
55
94
80
121
103
6.8
5.7
8.7
7.4
9.9
8.4
11
9.6
14
11
13
11
16
14
23

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

7.6
9.8
8.4
15
13
22
19
28
24
1.5
1.3
1.9
1.6
1.9
1.6
2.5
2.1
2.7
2.3
2.9
2.4
3.5
3.0
5.2
4.4
5.6
4.8
7.7
6.5
8.5
7.2
13
11
19
16
24
21
1.3
1.1
1.7
1.4
1.9
1.6
2.2
1.9
2.5
2.2
2.5
2.2
3.2
2.7
4.6
3.9
5.0
4.2
6.8
5.8
7.5
6.3
11
9.6
16
14
21
18
1.2
1.0
1.5
1.3
1.7
1.5
2.0
1.7
2.4
2.0
2.3
1.9
2.8
2.4
4.1

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

.62
.84
.65
.65
.50
.58
.45
.52
.40
1.4
1.1
1.3
1.0
1.4
1.3
1.3
1.1
1.3
1.1
1.3
1.1
1.2
.97
1.1
.90
1.1
.86
.91
.72
.97
.76
.75
.58
.67
.52
.61
.47
1.5
1.2
1.5
1.2
1.6
1.3
1.5
1.2
1.4
1.2
1.5
1.2
1.4
1.1
1.3
1.0
1.2
.97
1.0
.82
1.1
.86
.85
.66
.76
.59
.69
.53
1.7
1.4
1.6
1.3
1.8
1.4
1.7
1.4
1.5
1.2
1.7
1.3
1.5
1.2
1.5

mm

16
21
17
16
13
15
11
13
10
35
28
33
26
36
32
34
27
34
27
34
27
31
25
29
23
28
22
23
18
25
19
19
15
17
13
15
12
39
31
38
30
40
32
38
30
37
29
38
30
35
27
33
26
31
25
26
21
28
22
22
17
19
15
18
13
44
35
42
33
45
36
43
34
39
31
43
34
39
31
37

Lbs.

27
47
31
55
37
72
47
83
54
12
7.9
14
9.7
16
12
19
13
21
14
22
15
25
17
34
23
35
23
40
27
47
31
55
37
72
47
83
54
12
7.9
14
9.7
17
12
19
13
21
14
22
15
25
17
34
23
35
23
40
27
47
31
55
37
72
47
83
54
12
7.9
14
9.7
17
12
19
13
21
14
22
15
25
17
34

ENDS: C - Closed

G - Ground
O - Open

120
210
139
245
163
318
211
371
242
52
35
64
43
69
53
85
58
93
63
97
66
110
74
150
100
155
104
179
120
210
139
245
163
318
211
371
242
52
35
64
43
78
53
85
58
93
63
97
66
110
74
150
100
155
104
179
120
210
139
245
163
318
211
371
242
52
35
64
43
78
53
85
58
93
63
97
66
110
74
150

Inches

.66
.82
.82
.76
.76
.84
.84
.92
.92
.40
.40
.44
.44
.58
.58
.54
.54
.59
.59
.60
.60
.66
.66
.77
.77
.76
.76
.73
.73
.92
.92
.85
.85
.95
.95
1.04
1.04
.44
.44
.49
.49
.58
.58
.60
.60
.62
.62
.65
.65
.71
.71
.85
.85
.84
.84
.82
.82
1.02
1.02
.94
.94
1.05
1.05
1.16
1.16
.47
.47
.52
.52
.64
.64
.66
.66
.65
.65
.71
.71
.78
.78
.93

mm

16.7
20.8
20.8
19.2
19.2
21.3
21.3
23.5
23.5
10.1
10.1
11.2
11.2
14.8
14.8
13.8
13.8
14.9
14.9
15.1
15.1
16.7
16.7
19.6
19.6
19.3
19.3
18.6
18.6
23.4
23.4
21.6
21.6
24.0
24.0
26.3
26.3
11.2
11.2
12.4
12.4
14.8
14.8
15.3
15.3
15.7
15.7
16.6
16.6
18.1
18.1
21.6
21.6
21.3
21.3
20.8
20.8
26.0
26.0
23.8
23.8
26.7
26.7
29.5
29.5
12.0
12.0
13.3
13.3
16.2
16.2
16.7
16.7
16.6
16.6
18.1
18.1
19.9
19.9
23.6

WIRE DIA.
Inches

0.085
0.091
0.091
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080

mm

TOTAL
MATL
COILS

2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0

7.75
9.00
9.00
7.88
7.88
8.00
8.00
8.25
8.25
7.25
7.25
7.50
7.50
9.25
9.25
8.38
8.38
8.75
8.75
8.75
8.75
9.13
9.13
9.63
9.63
9.38
9.38
8.63
8.63
10.1
10.1
8.88
8.88
9.00
9.00
9.25
9.25
8.00
8.00
8.25
8.25
9.25
9.25
9.25
9.25
9.25
9.25
9.63
9.63
9.88
9.88
10.6
10.6
10.4
10.4
9.63
9.63
11.3
11.3
9.75
9.75
10.0
10.0
10.4
10.4
8.63
8.63
8.88
8.88
10.1
10.1
10.1
10.1
9.75
9.75
10.5
10.5
10.9
10.9
11.6

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 157

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720

18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29

72048S
72065
72065S
72078
72078S
72090
72090S
72105
72105S
72118
72118S
72131
72131S
71936
71936S
71948
71948S
71961
71961S
71972
71972S
72009
72009S
72023
72023S
72050
72050S
72066
72066S
72079
72079S
72092
72092S
72106
72106S
72119
72119S
72132
72132S
71937
71937S
71950
71950S
71962
71962S
71973
71973S
71985
71985S
72011
72011S
72024
72024S
72052
72052S
72067
72067S
72080
72080S
72094
72094S
72107
72107S
72120
72120S
72133
72133S
71986
71986S
71988
71988S
72025
72025S
71975
71975S
71987
71987S
71989
71989S
72013

2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.25
3.25
3.25
3.25
3.25
3.25
3.50
3.50
3.50
3.50
3.50
3.50
3.50

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
82.6
82.6
82.6
82.6
82.6
82.6
88.9
88.9
88.9
88.9
88.9
88.9
88.9

I.D.
Inches

.560
.558
.558
.550
.550
.538
.538
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.584
.584
.576
.576
.560
.560
.558
.558
.550
.550
.538
.538
.528
.528
.510
.510
.496
.496
.610
.610
.602
.602
.594
.594
.590
.590
.586
.586
.584
.584
.576
.576
.560
.560
.558
.558
.550
.550
.538
.538
.528
.528
.510
.510
.496
.496
.586
.586
.586
.586
.576
.576
.590
.590
.586
.586
.586
.586
.584

RATE
mm

14.2
14.2
14.2
14.0
14.0
13.7
13.7
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.7
13.7
13.4
13.4
13.0
13.0
12.6
12.6
15.5
15.5
15.3
15.3
15.1
15.1
15.0
15.0
14.9
14.9
14.8
14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.7
13.7
13.4
13.4
13.0
13.0
12.6
12.6
14.9
14.9
14.9
14.9
14.6
14.6
15.0
15.0
14.9
14.9
14.9
14.9
14.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

20
25
21
35
29
38
32
58
49
84
71
107
91
6.2
5.2
7.2
6.1
8.9
7.6
10
8.5
12
9.9
15
12
21
18
23
19
31
27
34
29
52
44
75
64
97
82
5.6
4.8
6.6
5.6
8.1
6.9
9.1
7.8
11
8.9
11
9.1
13
11
19
16
21
18
28
24
31
27
47
40
69
58
88
75
9.2
7.8
11
9.1
13
11
7.8
6.6
8.5
7.2
10
8.5
9.1

3.5
4.4
3.8
6.1
5.1
6.7
5.7
10
8.6
15
12
19
16
1.1
.92
1.3
1.1
1.6
1.3
1.8
1.5
2.0
1.7
2.6
2.2
3.7
3.1
4.0
3.4
5.5
4.6
6.0
5.1
9.1
7.8
13
11
17
14
.98
.83
1.2
.98
1.4
1.2
1.6
1.4
1.8
1.6
1.9
1.6
2.3
2.0
3.3
2.8
3.6
3.1
5.0
4.2
5.5
4.7
8.3
7.1
12
10
15
13
1.6
1.4
1.9
1.6
2.3
1.9
1.4
1.2
1.5
1.3
1.8
1.5
1.6

1.1
1.4
1.1
1.2
.92
1.2
.97
.96
.75
.86
.67
.78
.60
1.9
1.5
2.0
1.6
2.0
1.6
1.9
1.5
1.9
1.5
1.7
1.3
1.6
1.3
1.5
1.2
1.3
1.0
1.4
1.1
1.1
.83
.95
.74
.86
.66
2.1
1.7
2.2
1.7
2.2
1.7
2.1
1.7
2.0
1.6
2.0
1.6
1.9
1.5
1.8
1.4
1.7
1.3
1.4
1.1
1.5
1.2
1.2
.91
1.0
.81
.95
.73
2.3
1.8
2.0
1.6
1.9
1.5
2.5
2.0
2.5
2.0
2.1
1.7
2.4

mm

29
35
28
30
23
32
25
24
19
22
17
20
15
48
38
51
40
50
40
48
39
47
38
43
34
41
32
39
31
33
26
35
27
27
21
24
19
22
17
53
42
55
44
55
44
53
42
51
40
52
41
47
37
45
35
43
34
36
28
38
30
30
23
26
21
24
18
58
46
50
40
48
38
62
50
62
50
53
42
61

ENDS: C - Closed

G - Ground
O - Open

Lbs.

23
35
23
40
27
47
31
55
37
72
47
83
54
12
7.9
14
9.7
17
12
19
13
22
15
25
17
34
23
35
23
40
27
47
31
55
37
72
47
83
54
12
7.9
14
9.7
17
12
19
13
21
14
22
15
25
17
34
23
35
23
40
27
47
31
55
37
72
47
83
54
21
14
21
14
25
17
19
13
21
14
21
14
22

100
155
104
179
120
210
139
245
163
318
211
371
242
52
35
64
43
78
53
85
58
97
66
110
74
150
100
155
104
179
120
210
139
245
163
318
211
371
242
52
35
64
43
78
53
85
58
93
63
97
66
110
74
150
100
155
104
179
120
210
139
245
163
318
211
371
242
93
63
93
63
110
74
85
58
93
63
93
63
97

Inches

.93
.92
.92
.89
.89
1.13
1.13
1.03
1.03
1.16
1.16
1.27
1.27
.51
.51
.61
.61
.69
.69
.72
.72
.78
.78
.84
.84
1.02
1.02
1.00
1.00
.97
.97
1.23
1.23
1.12
1.12
1.26
1.26
1.39
1.39
.55
.55
.66
.66
.75
.75
.78
.78
.80
.80
.84
.84
.91
.91
1.10
1.10
1.08
1.08
1.04
1.04
1.33
1.33
1.21
1.21
1.35
1.35
1.50
1.50
.89
.89
.79
.79
.93
.93
.89
.89
.95
.95
.83
.83
.96

mm

Inches

23.6
23.4
23.4
22.7
22.7
28.6
28.6
26.2
26.2
29.3
29.3
32.4
32.4
12.9
12.9
15.5
15.5
17.6
17.6
18.4
18.4
19.9
19.9
21.3
21.3
25.9
25.9
25.5
25.5
24.6
24.6
31.2
31.2
28.3
28.3
32.0
32.0
35.2
35.2
14.0
14.0
16.7
16.7
19.0
19.0
19.8
19.8
20.2
20.2
21.4
21.4
23.1
23.1
27.9
27.9
27.5
27.5
26.4
26.4
33.8
33.8
30.8
30.8
34.3
34.3
38.0
38.0
22.5
22.5
20.0
20.0
23.5
23.5
22.7
22.7
24.2
24.2
21.1
21.1
24.4

0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.068
0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.096
0.096
0.105
0.105
0.112
0.112
0.055
0.055
0.059
0.059
0.063
0.063
0.065
0.065
0.067
0.067
0.068
0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.096
0.096
0.105
0.105
0.112
0.112
0.067
0.067
0.067
0.067
0.072
0.072
0.065
0.065
0.067
0.067
0.067
0.067
0.068

mm

TOTAL
MATL
COILS

2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
1.4
1.4
1.5
1.5
1.6
1.6
1.7
1.7
1.7
1.7
1.7
1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
1.7
1.7
1.7
1.7
1.8
1.8
1.7
1.7
1.7
1.7
1.7
1.7
1.7

11.6
11.4
11.4
10.5
10.5
12.4
12.4
10.8
10.8
11.0
11.0
11.4
11.4
9.25
9.25
10.4
10.4
11.0
11.0
11.1
11.1
11.5
11.5
11.6
11.6
12.8
12.8
12.4
12.4
11.4
11.4
13.5
13.5
11.6
11.6
12.0
12.0
12.4
12.4
10.0
10.0
11.1
11.1
11.9
11.9
12.0
12.0
11.9
11.9
12.4
12.4
12.6
12.6
13.8
13.8
13.4
13.4
12.3
12.3
14.6
14.6
12.6
12.6
12.9
12.9
13.4
13.4
13.3
13.3
11.8
11.8
12.9
12.9
13.8
13.8
14.3
14.3
12.4
12.4
14.1

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

157

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 158

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.720
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734

18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.29
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64

72013S
72026
72026S
72054
72054S
72068
72068S
72081
72081S
72096
72096S
72108
72108S
72121
72121S
72134
72134S
72027
72027S
72056
72056S
72069
72069S
72082
72082S
72109
72109S
72122
72122S
72135
72135S
XX-36
S-3203
B-64
AA-54
II-67
S-1220
S-1319
NN-98
S-164
CC-99
BB-75
A10-62
S-1475
11176
3867
B12-38
S-3085
S-1343
V-26
S-310
3796
S-340
S-1373
S-403
11820
S-263
11704
11549
A11-55
3740
10517
11186
2668
10671
S-51
10080
S-330
B14-53
11554
4351
3436
12046
S-96
O-67
12102
10810
S-1636
4237
2893

3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
.50
.56
.63
.63
.66
.69
.69
.72
.72
.75
.75
.75
.75
.75
.75
.75
.88
.88
.94
1.00
1.00
1.09
1.13
1.16
1.19
1.19
1.22
1.31
1.31
1.31
1.38
1.38
1.41
1.47
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.59
1.63
1.63
1.66
1.66
1.72
1.75
1.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
12.7
14.3
15.9
15.9
16.7
17.4
17.4
18.2
18.2
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.2
22.2
23.8
25.4
25.4
27.8
28.6
29.4
30.2
30.2
31.0
33.3
33.3
33.3
34.9
34.9
35.7
37.3
38.1
38.1
38.1
38.1
38.1
38.1
38.1
40.5
41.3
41.3
42.1
42.1
43.6
44.5
44.5

MATERIAL: MW - Music Wire

158

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.584
.576
.576
.560
.560
.558
.558
.550
.550
.538
.538
.528
.528
.510
.510
.496
.496
.576
.576
.560
.560
.558
.558
.550
.550
.528
.528
.510
.510
.496
.496
.626
.544
.664
.574
.614
.524
.494
.614
.574
.694
.656
.654
.646
.638
.630
.606
.600
.574
.650
.600
.590
.380
.508
.636
.562
.494
.654
.634
.604
.534
.642
.570
.626
.656
.646
.624
.622
.614
.574
.570
.410
.524
.652
.652
.652
.548
.652
.646
.606

RATE
mm

14.8
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.7
13.7
13.4
13.4
13.0
13.0
12.6
12.6
14.6
14.6
14.2
14.2
14.2
14.2
14.0
14.0
13.4
13.4
13.0
13.0
12.6
12.6
15.9
13.8
16.9
14.6
15.6
13.3
12.5
15.6
14.6
17.6
16.7
16.6
16.4
16.2
16.0
15.4
15.2
14.6
16.5
15.2
15.0
9.7
12.9
16.2
14.3
12.5
16.6
16.1
15.3
13.6
16.3
14.5
15.9
16.7
16.4
15.8
15.8
15.6
14.6
14.5
10.4
13.3
16.6
16.6
16.6
13.9
16.6
16.4
15.4

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

7.7
1.4
11
2.0
9.6
1.7
16
2.9
14
2.4
18
3.1
15
2.6
24
4.2
21
3.6
27
4.7
23
4.0
40
7.1
34
6.0
58
10
49
8.7
75
13
63
11
9.9
1.7
8.4
1.5
14
2.5
12
2.1
15
2.7
13
2.3
21
3.7
18
3.1
35
6.1
32
5.2
51
8.8
43
7.5
65
11
55
9.6
19
3.4
265
46
5.5
.96
107
19
18
3.2
305
53
640 112
15
2.7
93
16
.08
.01
2.9
.50
3.3
.58
3.6
.62
14
2.4
17
2.9
29
5.1
34
5.9
46
8.0
4.5
.79
28
5.0
44
7.8
2069 362
213
37
4.4
.77
72
13
228
40
3.1
.55
5.6
.98
8.4
1.5
107
19
6.6
1.2
41
7.1
8.4
1.5
1.4
.24
3.2
.55
12
2.1
8.8
1.5
13
2.4
35
6.1
39
6.8
1058 185
83
14
2.2
.39
1.1
.19
2.4
.42
54
9.5
1.1
.19
3.3
.57
11
2.0

1.9
2.2
1.7
2.1
1.6
2.0
1.6
1.7
1.3
1.8
1.4
1.4
1.1
1.2
.96
1.1
.86
2.5
2.0
2.4
1.9
2.3
1.8
1.9
1.5
1.6
1.2
1.4
1.1
1.3
.99
.28
.13
.39
.21
.30
.15
.10
.36
.24
.56
.52
.55
.44
.40
.42
.38
.41
.40
.69
.49
.39
.09
.26
.81
.40
.29
.96
.91
.60
.41
1.1
.62
.93
1.1
1.2
.69
.93
.74
.67
.65
.15
.49
1.3
1.1
1.4
.65
1.2
1.4
1.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

49
56
44
52
41
50
40
42
33
45
35
35
27
31
24
28
22
64
50
61
48
58
46
49
38
40
31
36
28
33
25
7.2
3.3
10
5.3
7.5
3.9
2.6
9.1
6.0
14
13
14
11
10
11
9.7
10
10
17
12
9.9
2.2
6.6
20
10
7.3
24
23
15
10
28
16
24
27
30
17
24
19
17
17
3.8
12
33
29
35
16
31
35
29

Lbs.

15
25
17
34
23
35
23
40
27
47
31
55
37
72
47
83
54
25
17
34
23
35
23
40
27
55
37
72
47
83
54
5.5
35
2.2
22
5.3
47
65
5.4
22
.05
1.5
1.8
1.6
5.5
7.0
11
14
18
3.1
14
17
180
55
3.5
29
65
3.0
5.1
5.0
44
7.2
25
7.8
1.5
3.7
8.2
8.2
10
24
25
159
41
2.9
1.2
3.3
35
1.3
4.6
13

ENDS: C - Closed

G - Ground
O - Open

66
110
74
150
100
155
104
179
120
210
139
245
163
318
211
371
242
110
74
150
100
155
104
179
120
245
163
318
211
371
242
25
155
9.6
99
24
207
291
24
99
.21
6.6
8.1
7.0
25
31
50
62
80
14
62
77
800
244
16
130
291
13
23
22
194
32
113
35
6.5
16
37
36
45
105
113
706
180
13
5.3
15
157
5.9
20
57

Inches

.96
1.05
1.05
1.26
1.26
1.26
1.26
1.20
1.20
1.54
1.54
1.39
1.39
1.56
1.56
1.74
1.74
1.18
1.18
1.43
1.43
1.42
1.42
1.36
1.36
1.57
1.57
1.77
1.77
1.96
1.96
.22
.33
.14
.30
.36
.42
.45
.36
.40
.19
.23
.20
.31
.22
.26
.37
.30
.48
.25
.34
.36
.97
.79
.35
.52
.84
.26
.40
.72
.73
.23
.64
.41
.40
.33
.30
.42
.36
.72
.66
1.13
1.10
.32
.49
.27
.88
.49
.35
.58

mm

24.4
26.7
26.7
32.0
32.0
31.9
31.9
30.5
30.5
39.0
39.0
35.4
35.4
39.7
39.7
44.1
44.1
29.9
29.9
36.3
36.3
36.0
36.0
34.5
34.5
39.9
39.9
45.0
45.0
49.8
49.8
5.5
8.4
3.6
7.6
9.1
10.7
11.4
9.1
10.2
4.8
5.9
5.1
7.8
5.5
6.6
9.3
7.7
12.2
6.4
8.5
9.1
24.7
20.1
8.9
13.1
21.3
6.6
10.2
18.2
18.4
5.8
16.1
10.5
10.2
8.4
7.7
10.7
9.1
18.3
16.7
28.8
28.0
8.1
12.5
6.8
22.5
12.5
8.9
14.6

WIRE DIA.
Inches

0.068
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.096
0.096
0.105
0.105
0.112
0.112
0.072
0.072
0.080
0.080
0.081
0.081
0.085
0.085
0.096
0.097
0.105
0.105
0.112
0.112
0.054
0.095
0.035
0.080
0.060
0.105
0.120
0.060
0.080
0.020
0.039
0.040
0.044
0.048
0.052
0.064
0.067
0.080
0.042
0.067
0.072
0.177
0.113
0.049
0.086
0.120
0.040
0.050
0.065
0.100
0.046
0.082
0.054
0.039
0.044
0.055
0.056
0.060
0.080
0.082
0.162
0.105
0.041
0.041
0.041
0.093
0.041
0.044
0.064

mm

TOTAL
MATL
COILS

1.7
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
1.8
1.8
2.0
2.0
2.1
2.1
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
1.4
2.4
0.9
2.0
1.5
2.7
3.0
1.5
2.0
0.5
1.0
1.0
1.1
1.2
1.3
1.6
1.7
2.0
1.1
1.7
1.8
4.5
2.9
1.2
2.2
3.0
1.0
1.3
1.7
2.5
1.2
2.1
1.4
1.0
1.1
1.4
1.4
1.5
2.0
2.1
4.1
2.7
1.0
1.0
1.0
2.4
1.0
1.1
1.6

14.1
14.6
14.6
15.8
15.8
15.5
15.5
14.1
14.1
16.9
16.9
14.5
14.5
14.9
14.9
15.5
15.5
16.4
16.4
17.9
17.9
17.5
17.5
16.0
16.0
16.4
16.4
16.9
16.9
17.5
17.5
4.00
3.50
3.00
3.75
5.00
4.00
3.75
6.00
4.00
8.50
5.00
5.00
6.00
3.50
4.00
4.75
4.50
6.00
5.00
5.00
5.00
5.50
6.00
7.00
6.00
7.00
5.50
7.00
11.0
7.25
5.00
7.75
7.00
9.25
6.50
5.50
6.50
6.00
8.00
8.00
7.00
10.5
6.75
12.0
6.50
9.50
12.0
7.00
9.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SST
SST
SST
SST
SST
SST
SPR
SST
SST
SST
SST
SST
SST
SPR
SPR
SST
SST
SPR
SST
HD
SST
SST
SST
SPR
SST
SPR
SPR
SST
SPR
MW
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SST
SPR
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
C
CG
C
C
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
C
C
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N
GI
N
GI
N
N
N
Z
N
Z
Z
N
Z
N
Z
Z
N
N
GI
N
N
Z
Z
Z
Z
N
N
N
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 159

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.734
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750

18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
18.64
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05

A-42
3347
S-248
S-417
10530
11693
10981
S-493
10871
10886
1663
S-1224
3365
S-1503
2747
11333
B18-181
B11-44
3753
4126
12723
4190
1555
S-1430
3876
11937
11540
11392
11885
12609
4158
B4-20
2518
B2-57
S-1345
OO-84
CC-79
B15-66
2665
S-238
12559
S-1321
12581
KK-93
GG-64
10140
S-1301
A14-67
10448
2590
12584
N-137
B15-40
B1-65
3033
2602
S-3115
11493
WW-70
3957
S-976
10577
889
3318
3827
KK-55
S-344
S-307
B1-47
S-1259
S-884
B1-67
B8-39
B17-185
S-948
12248
11371
B17-183
HH-72
3479

O.D.

FREE LENGTH
Inches

1.75
1.88
1.91
2.00
2.06
2.09
2.19
2.34
2.44
2.50
2.63
2.69
2.75
2.94
2.94
3.00
3.00
3.25
3.50
3.50
3.50
3.50
3.50
3.56
3.69
4.63
5.00
6.13
6.31
6.38
11.5
.50
.50
.56
.56
.56
.56
.59
.59
.63
.70
.75
.75
.75
.75
.81
.88
.88
.88
.89
.91
.94
.94
.94
.94
.97
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.03
1.03
1.09
1.09
1.09
1.11
1.13
1.13
1.13
1.13
1.13

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

44.5
47.6
48.4
50.8
52.4
53.2
55.6
59.5
61.9
63.5
66.7
68.2
69.9
74.6
74.6
76.2
76.2
82.6
88.9
88.9
88.9
88.9
88.9
90.5
93.6
117.5
127.0
155.6
160.3
161.9
292.1
12.7
12.7
14.3
14.3
14.3
14.3
15.1
15.1
15.9
17.9
19.1
19.1
19.1
19.1
20.6
22.2
22.2
22.2
22.6
23.0
23.8
23.8
23.8
23.8
24.6
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
26.2
26.2
27.8
27.8
27.8
28.2
28.6
28.6
28.6
28.6
28.6

I.D.
Inches

.584
.594
.550
.552
.590
.610
.590
.532
.558
.614
.574
.626
.610
.646
.464
.578
.554
.622
.650
.640
.616
.604
.590
.574
.584
.538
.614
.484
.528
.708
.534
.650
.642
.688
.674
.650
.590
.670
.586
.550
.610
.656
.650
.636
.430
.616
.642
.636
.606
.590
.510
.672
.658
.624
.540
.646
.668
.642
.638
.626
.624
.608
.590
.540
.536
.530
.510
.500
.640
.626
.538
.640
.570
.400
.510
.644
.608
.590
.550
.500

RATE
mm

14.8
15.1
14.0
14.0
15.0
15.5
15.0
13.5
14.2
15.6
14.6
15.9
15.5
16.4
11.8
14.7
14.1
15.8
16.5
16.3
15.6
15.3
15.0
14.6
14.8
13.7
15.6
12.3
13.4
18.0
13.6
16.5
16.3
17.5
17.1
16.5
15.0
17.0
14.9
14.0
15.5
16.7
16.5
16.2
10.9
15.6
16.3
16.2
15.4
15.0
13.0
17.1
16.7
15.8
13.7
16.4
17.0
16.3
16.2
15.9
15.8
15.4
15.0
13.7
13.6
13.5
13.0
12.7
16.3
15.9
13.7
16.3
14.5
10.2
13.0
16.4
15.4
15.0
14.0
12.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

26
4.6
18
3.2
35
6.0
33
5.9
16
2.7
7.6
1.3
15
2.6
53
9.3
36
6.2
6.1
1.1
16
2.8
2.8
.49
7.0
1.2
.85
.15
185
32
18
3.2
17
3.0
6.5
1.1
1.6
.28
1.6
.28
4.0
.71
9.5
1.7
10
1.8
8.3
1.5
11
1.9
25
4.3
3.6
.63
55
9.7
23
4.1
.55 9.7
13
2.3
21
3.7
24
4.2
2.9
.50
2.9
.51
9.5
1.7
98
17
4.1
.72
193
34
182
32
40
7.0
8.8
1.5
13
2.3
13
2.3
2294 402
45
8.0
16
2.8
23
4.0
41
7.2
39
6.9
397
70
2.3
.41
6.7
1.2
25
4.3
326
57
7.3
1.3
5.0
.87
18
3.2
21
3.7
14
2.4
27
4.7
39
6.8
59
10
217
38
236
41
203
36
346
61
357
63
15
2.6
14
2.5
201
35
14
2.5
94
16
2364 414
352
62
11
2.0
15
2.6
44
7.6
88
15
479
84

.74
.88
.80
.92
1.1
1.4
1.1
.79
.88
1.8
1.3
1.9
1.7
2.1
.53
1.2
1.2
1.3
2.5
2.7
2.6
1.4
1.7
1.6
1.8
1.7
3.0
1.5
2.0
2.0
3.3
.29
.31
.43
.39
.27
.24
.41
.13
.18
.37
.52
.46
.44
.07
.32
.46
.39
.41
.33
.18
.70
.72
.46
.15
.64
.68
.42
.40
.58
.42
.42
.39
.23
.22
.25
.19
.20
.51
.66
.23
.57
.34
.08
.18
.65
.49
.53
.40
.16

mm

19
22
20
23
28
35
28
20
22
45
34
49
43
54
13
30
30
34
63
69
65
36
43
40
47
43
76
37
52
51
85
7.4
7.9
11
9.9
7.0
6.0
10
3.3
4.4
9.4
13
12
11
1.7
8.1
12
10
10
8.4
4.5
18
18
12
3.8
16
17
11
10
15
11
11
10
5.8
5.6
6.2
4.7
5.1
13
17
5.9
14
8.5
2.1
4.6
16
12
14
10
4.2

ENDS: C - Closed

G - Ground
O - Open

Lbs.

20
16
28
31
17
11
16
42
31
11
22
5.4
12
1.8
97
22
21
8.7
4.0
4.4
10
14
17
13
20
41
11
81
48
112
44
6.1
7.5
1.2
1.1
2.6
23
1.7
25
32
15
4.5
6.1
5.7
151
14
7.2
9.0
17
13
70
1.6
4.8
11
49
4.7
3.4
7.6
8.5
8.0
11
16
23
49
52
50
64
72
7.6
9.3
47
8.1
31
193
64
7.2
7.2
23
35
79

87
71
123
137
77
47
72
185
139
47
97
24
52
8.0
434
98
93
39
18
19
46
60
77
58
87
183
47
358
212
497
194
27
33
5.5
5.0
12
103
7.6
111
142
66
20
27
25
671
64
32
40
76
57
313
7.2
21
51
219
21
15
34
38
36
51
73
103
219
232
222
285
321
34
42
209
36
140
860
285
32
32
103
157
352

Inches

mm

Inches

.60 15.2
.60 15.1
1.10 28.0
1.06 26.9
.83 21.0
.70 17.7
.72 18.3
1.18 29.9
.97 24.6
.72 18.3
1.28 32.5
.76 19.2
.81 20.5
.83 21.0
1.89 48.0
1.03 26.3
1.80 45.7
.56 14.2
.48 12.3
.78 19.7
.94 24.0
.72 18.2
1.15 29.3
2.00 50.8
1.28 32.4
2.25 57.3
1.20 30.5
3.75 95.3
3.04 77.2
3.75 95
4.60 116.8
.16
4.1
.19
4.8
.13
3.4
.17
4.3
.29
7.3
.32
8.1
.18
4.6
.26
6.5
.45 11.4
.33
8.5
.24
6.0
.25
6.4
.31
8.0
.64 16.3
.27
6.8
.22
5.5
.23
5.8
.36
9.1
.56 14.2
.60 15.2
.23
5.9
.22
5.5
.35
8.8
.42 10.7
.33
8.3
.21
5.2
.27
6.9
.28
7.1
.42 10.6
.27
6.8
.43 10.8
.51 12.9
.53 13.3
.54 13.6
.61 15.4
.60 15.2
.69 17.5
.29
7.5
.37
9.4
.53 13.5
.26
6.6
.50 12.6
.88 22.2
.60 15.2
.27
6.7
.64 16.2
.52 13.2
.73 18.4
.63 15.9

0.075
0.070
0.092
0.091
0.072
0.062
0.072
0.101
0.088
0.060
0.080
0.054
0.062
0.044
0.135
0.078
0.090
0.056
0.042
0.047
0.059
0.065
0.072
0.080
0.075
0.098
0.060
0.125
0.103
0.013
0.100
0.050
0.054
0.031
0.038
0.050
0.080
0.040
0.082
0.100
0.070
0.047
0.050
0.057
0.160
0.067
0.054
0.057
0.072
0.080
0.120
0.039
0.046
0.063
0.105
0.052
0.041
0.054
0.056
0.062
0.063
0.071
0.080
0.105
0.107
0.110
0.120
0.125
0.055
0.062
0.106
0.055
0.090
0.175
0.120
0.053
0.071
0.080
0.100
0.125

mm

TOTAL
MATL
COILS

1.9
1.8
2.3
2.3
1.8
1.6
1.8
2.6
2.2
1.5
2.0
1.4
1.6
1.1
3.4
2.0
2.3
1.4
1.1
1.2
1.5
1.7
1.8
2.0
1.9
2.5
1.5
3.2
2.6
0.3
2.5
1.3
1.4
0.8
1.0
1.3
2.0
1.0
2.1
2.5
1.8
1.2
1.3
1.4
4.1
1.7
1.4
1.4
1.8
2.0
3.0
1.0
1.2
1.6
2.7
1.3
1.0
1.4
1.4
1.6
1.6
1.8
2.0
2.7
2.7
2.8
3.0
3.2
1.4
1.6
2.7
1.4
2.3
4.4
3.0
1.3
1.8
2.0
2.5
3.2

8.00
8.50
12.0
11.8
10.5
11.3
10.0
11.7
11.0
12.0
15.0
14.0
12.0
18.8
14.0
12.3
20.0
9.00
10.5
15.5
16.0
11.0
15.0
24.0
17.0
23.0
19.0
30.0
29.5
30
45.0
3.25
3.50
3.25
4.50
4.75
4.00
4.50
3.25
4.50
4.75
4.00
4.00
5.50
4.00
4.00
4.00
4.00
5.00
7.00
5.00
6.00
4.75
4.50
4.00
6.25
4.00
4.00
4.00
6.75
4.25
5.00
5.33
5.00
5.00
5.50
5.00
5.50
4.33
6.00
5.00
4.75
5.50
5.00
5.00
5.00
9.00
6.50
7.25
5.00

SPR
SPR
SST
SST
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
HD
SST
SPR
SPR
HD
MW
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
MW
SPR
SPR
HD
MW
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
HD
SPR
SPR
SPR
SST
SPR
HD
SST
SPR
SPR
SPR
SST
SPR
HD
SPR
SPR
SST
SST
SST
SST
SST
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
HD

E
N
D
S

CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
CG
C
C
C
CG
CG
C
C
CG
CG
C
CG
CG
C
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
Z
N
N
Z
Z
N
N
N
Z
Z
N
GI
N
Z
Z
N
N
Z
Z
GI
Z
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
Z
N
Z
N
N
Z
N
N
N
N
N
N
Z
N
GI
Z
Z
N
N
Z
N
Z
Z
N
Z
Z
Z
N
Z
Z
Z
N
N
N
N
N
N
N
N
Z
N
N
Z
N
Z
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

159

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 160

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750

19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05

11701
S-1448
B17-121
10933
HH-7
S-1537
12198
S-392
S-1287
EE-73
KK-72
B1-69
S-1634
10637
4284
12259
11798
12230
12224
S-439
3064
A11-64
B7-51
B18-173
3824
11516
12551
S-777
S-868
12269
S-780
M-104
11504
3165
3352
GG-78
FF-30
11946
2855
10199
2743
S-778
S-781
A11-37
S-1325
12247
DD-92
EE-62
B18-198
11495
11595
S-951
1585
3340
12228
10735
10226
S-779
S-782
66
11280
S-1353
11394
S-3228
12070
S-1036
S-415
S-1583
S-1418
10344
B10-70
A13-29
12254
11920
S-490
11875
RR-53
S-1271
S-783
11758

1.13
1.13
1.16
1.19
1.19
1.19
1.22
1.25
1.25
1.25
1.25
1.28
1.31
1.31
1.31
1.31
1.34
1.34
1.38
1.38
1.38
1.41
1.41
1.44
1.44
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.63
1.63
1.63
1.72
1.75
1.75
1.75
1.75
1.75
1.81
1.81
1.84
1.88
1.88
1.91
1.94
1.94
1.97
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.09
2.13
2.13
2.13
2.13
2.13
2.19
2.19
2.25
2.31
2.34
2.38
2.38
2.41
2.50
2.50
2.50
2.50
2.50
2.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

28.6
28.6
29.4
30.2
30.2
30.2
31.0
31.8
31.8
31.8
31.8
32.5
33.3
33.3
33.3
33.3
34.1
34.1
34.9
34.9
34.9
35.7
35.7
36.5
36.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
41.3
41.3
41.3
43.6
44.5
44.5
44.5
44.5
44.5
46.0
46.0
46.8
47.6
47.6
48.4
49.2
49.2
50.0
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
53.2
54.0
54.0
54.0
54.0
54.0
55.6
55.6
57.2
58.7
59.5
60.3
60.3
61.1
63.5
63.5
63.5
63.5
63.5
63.5

MATERIAL: MW - Music Wire

160

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.496
.480
.620
.626
.570
.514
.570
.626
.616
.590
.530
.614
.688
.622
.616
.616
.652
.608
.650
.640
.256
.648
.640
.630
.626
.682
.626
.624
.624
.620
.606
.572
.570
.51
.630
.530
.490
.490
.684
.634
.630
.624
.606
.614
.500
.624
.650
.610
.590
.568
.538
.642
.692
.686
.654
.640
.626
.624
.606
.590
.540
.662
.606
.592
.582
.558
.624
.540
.656
.540
.642
.640
.630
.674
.680
.672
.670
.626
.606
.542

RATE
mm

12.6
12.2
15.7
15.9
14.5
13.1
14.5
15.9
15.6
15.0
13.5
15.6
17.5
15.8
15.6
15.6
16.6
15.4
16.5
16.3
6.5
16.5
16.3
16.0
15.9
17.3
15.9
15.8
15.8
15.7
15.4
14.5
14.5
12.9
16.0
13.5
12.4
12.4
17.4
16.1
16.0
15.8
15.4
15.6
12.7
15.8
16.5
15.5
15.0
14.4
13.7
16.3
17.6
17.4
16.6
16.3
15.9
15.8
15.4
15.0
13.7
16.8
15.4
15.0
14.8
14.2
15.8
13.7
16.7
13.7
16.3
16.3
16.0
17.1
17.3
17.1
17.0
15.9
15.4
13.8

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

387
68
446
78
23
4.0
16
2.9
73
13
192
34
55
9.6
16
2.8
23
4.0
36
6.2
146
26
28
4.8
1.1
.18
23
4.0
19
3.4
18
3.2
6.0
1.1
26
4.5
6.5
1.1
7.7
1.4
12936 2265
6.3
1.1
10
1.8
13
2.2
16
2.9
.87
.15
12
2.1
14
2.5
15
2.6
18
3.1
24
4.2
48
8.4
77
14
206
36
10
1.8
115
20
278
49
287
50
.71
.12
7.0
1.2
11
2.0
12
2.1
20
3.4
27
4.8
156
27
11
1.9
3.5
.61
17
3.0
25
4.4
57
10
80
14
4.0
.70
.24
.04
.65
.11
3.2
.55
4.9
.86
10
1.8
11
1.8
17
2.9
25
4.4
72
13
1.7
.29
12
2.2
19
3.4
81
14
40
7.0
9.2
1.6
83
14
2.7
.47
65
11
6.0
1.1
5.8
1.0
5.7
.99
.74
.13
.29
.05
.77
.14
.75
.13
7.6
1.3
13
2.3
59
10

.21
.19
.58
.71
.40
.32
.50
.67
.60
.65
.37
.55
1.2
.55
.76
.80
1.0
.63
.93
.98
.03
.96
.77
.78
.71
1.2
.97
.79
.77
.70
.66
.66
.41
.34
1.0
.48
.28
.30
1.4
1.2
.92
.93
.81
.52
.46
1.1
1.4
.93
.92
.57
.63
1.4
1.6
1.7
1.5
1.5
1.1
1.1
.96
.92
.68
1.6
1.3
1.1
.33
.88
1.2
.55
1.9
.76
1.3
1.3
1.7
2.0
1.8
2.0
1.9
1.4
1.2
.81

5.4
4.9
15
18
10
8.1
13
17
15
17
9.5
14
29
14
19
20
25
16
24
25
.84
24
20
20
18
30
25
20
20
18
17
17
10
8.6
26
12
7.1
7.6
36
31
23
24
21
13
12
29
36
24
23
14
16
36
40
43
39
37
29
27
24
23
17
42
32
27
8.4
22
31
14
47
19
32
33
42
50
45
50
48
36
31
21

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs.

83
368
86
383
13
59
12
51
29
130
61
272
27
121
11
48
14
61
23
103
55
243
15
67
1.2
5.4
13
56
14
64
14
64
6.0
27
16
73
6.1
27
7.6
34
427 1901
6.1
27
8.1
36
9.8
44
12
51
1.0
4.6
12
51
11
51
11
51
12
55
16
71
32
141
31
140
70.0 311.4
10
46
55
243
77
344
86
382
1.0
4.5
8.6
38
10
46
11
51
16
71
14
63
72
321
12
54
4.9
22
16
70
23
103
32
145
51
226
5.7
26
.38
1.7
1.1
4.9
4.8
21
7.1
32
12
51
11
51
16
71
23
103
49
219
2.7
12
16
70
21
93
27
119
35
157
11
51
46
203
5.0
22
49
219
7.6
34
7.6
34
9.4
42
1.4
6.4
.50
2.2
1.5
6.7
1.4
6.3
11
48
16
71
48
213

ENDS: C - Closed

G - Ground
O - Open

Inches

.76
.81
.36
.43
.54
.83
.72
.40
.37
.60
.83
.37
.16
.40
.45
.47
.34
.46
.30
.36
1.30
.31
.32
.36
.37
.31
.53
.46
.39
.46
.54
.76
.65
.94
.51
.99
.98
1.04
.31
.52
.48
.50
.61
.35
1.25
.60
.48
.60
.86
.82
1.22
.53
.41
.30
.48
.55
.53
.55
.68
.78
1.16
.48
.86
.83
.42
1.10
.54
.95
.40
1.26
.43
.44
.72
.46
.74
.55
.60
.65
.81
1.40

mm

19.4
20.6
9.1
11.0
13.7
21.0
18.3
10.2
9.4
15.2
21.0
9.5
3.9
10.2
11.5
11.9
8.7
11.7
7.6
9.1
32.9
7.8
8.0
9.1
9.4
7.8
13.4
11.6
9.8
11.6
13.7
19.2
16.6
23.8
13.0
25.1
24.8
26.4
8.0
13.3
12.2
12.8
15.5
8.9
31.8
15.2
12.1
15.1
21.8
20.8
31.0
13.5
10.5
7.5
12.2
14.0
13.4
14.0
17.4
19.8
29.3
12.3
21.9
21.1
10.7
28.0
13.8
24.0
10.1
32.0
11.0
11.2
18.3
11.6
18.7
13.9
15.2
16.5
20.6
35.7

WIRE DIA.
Inches

0.127
0.135
0.065
0.062
0.090
0.118
0.090
0.062
0.067
0.080
0.110
0.068
0.031
0.064
0.067
0.067
0.049
0.071
0.050
0.055
0.247
0.051
0.055
0.060
0.062
0.034
0.062
0.063
0.063
0.065
0.072
0.089
0.090
0.120
0.060
0.110
0.130
0.130
0.033
0.058
0.060
0.063
0.072
0.068
0.125
0.063
0.050
0.070
0.080
0.091
0.106
0.054
0.029
0.032
0.048
0.055
0.062
0.063
0.072
0.080
0.105
0.044
0.072
0.079
0.084
0.096
0.063
0.105
0.047
0.105
0.054
0.055
0.060
0.038
0.035
0.039
0.040
0.062
0.072
0.104

mm

TOTAL
MATL
COILS

3.2
3.4
1.7
1.6
2.3
3.0
2.3
1.6
1.7
2.0
2.8
1.7
0.8
1.6
1.7
1.7
1.2
1.8
1.3
1.4
6.3
1.3
1.4
1.5
1.6
0.9
1.6
1.6
1.6
1.7
1.8
2.3
2.3
3.1
1.5
2.8
3.3
3.3
0.8
1.5
1.5
1.6
1.8
1.7
3.2
1.6
1.3
1.8
2.0
2.3
2.7
1.4
0.7
0.8
1.2
1.4
1.6
1.6
1.8
2.0
2.7
1.1
1.8
2.0
2.1
2.4
1.6
2.7
1.2
2.7
1.4
1.4
1.5
1.0
0.9
1.0
1.0
1.6
1.8
2.6

6.00
6.00
5.50
6.00
6.00
7.00
8.00
5.50
5.50
7.50
7.50
5.50
5.00
5.25
6.75
7.00
6.00
6.50
6.00
6.50
5.25
6.00
5.75
6.00
6.00
8.00
7.50
6.25
6.00
6.00
6.50
8.50
6.25
7.80
7.50
9.00
7.50
8.00
8.50
9.00
7.00
7.00
7.50
5.00
10.0
8.50
9.50
8.50
9.75
8.00
10.5
10.0
13.3
8.25
9.00
10.0
8.50
7.75
8.50
9.75
11.0
10.0
12.0
10.5
5.00
11.5
8.75
9.00
8.50
12.0
8.00
8.00
12.0
12.0
20.0
14.0
14.0
9.50
10.3
12.5

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SPR
SPR
SST
SST
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
HD
SPR
HD
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
HD
SPR
SPR
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
MW
MW
SPR
SPR
SPR
SST
SST
HD
SPR
SST
SPR
SST
SPR
SST
SST
SST
SST
SPR
SPR
SST
SPR
SST
SST
SPR
SST
SST
SST
SPR

E
N
D
S

CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
C
C
CG
CG
CG
C
CG
CG
CG
C
CG
C
C
C
CG
CG
C
CG
CG
C
CG
CG
CG
C
C
C
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
C

F
N
S
H

Z
N
N
N
N
N
Z
N
N
Z
N
N
N
Z
Z
Z
N
Z
N
N
Z
N
Z
N
Z
Z
N
N
N
N
N
Z
Z
Z
Z
Z
N
Z
GI
Z
Z
N
N
N
N
Z
GI
Z
GI
Z
Z
N
Z
Z
Z
Z
Z
N
N
Z
Z
N
Z
N
Z
N
N
N
N
Z
N
N
Z
N
N
N
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 161

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.750
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765

19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.05
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43

48
50
12451
3472
1873
4362
12199
3959
12079
12696
10602
S-316
S-888
4219
4255
44
11467
831
3869
10084
11377
10061
890
11406
40
1863
12306
41
11169
4175
2781
12255
3700
12553
12250
11737
12193
3932
11749
11782
10816
10060
1773
3971
854
12064
S-1174
11816
875
871
827
3122
11413
3051
11545
2905
11845
11427
11855
3126
288
879
877
S-3035
3042
12602
10443
S-454
10925
12244
3812
S-873
1589
UU-70
12577
XX-61
2848
S-30
S-302

O.D.

FREE LENGTH
Inches

2.50
2.50
2.59
2.63
2.69
2.69
2.75
2.75
2.78
2.81
3.00
3.00
3.00
3.00
3.00
3.13
3.25
3.25
3.25
3.38
3.47
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.56
3.63
3.69
3.84
3.88
4.06
4.13
4.25
4.34
4.50
4.50
4.59
4.69
4.75
4.75
4.88
5.00
5.13
5.25
6.00
6.00
6.00
6.00
6.25
6.25
6.38
7.50
7.56
8.31
10.0
10.2
11.4
12.0
12.0
12.0
13.4
13.8
.56
.63
.63
.63
.66
.69
.81
.88
.88
.91
1.00
1.00
1.00
1.00

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

63.5
63.5
65.9
66.7
68.2
68.2
69.9
69.9
70.6
71.4
76.2
76.2
76.2
76.2
76.2
79.4
82.6
82.6
82.6
85.7
88.1
88.9
88.9
88.9
88.9
88.9
88.9
88.9
90.5
92.1
93.6
97.6
98.4
103.1
104.8
108.0
110.3
114.3
114.3
116.7
119.0
120.7
120.7
123.8
127.0
130.2
133.4
152.4
152.4
152.4
152.4
158.8
158.8
161.9
190.5
192.1
211.1
254.0
258.7
288.9
304.8
304.8
304.8
339.7
349.3
14.3
15.9
15.9
15.9
16.7
17.4
20.6
22.2
22.2
23.0
25.4
25.4
25.4
25.4

I.D.
Inches

.540
.480
.536
.550
.590
.540
.640
.580
.616
.678
.654
.648
.626
.624
.540
.568
.580
.540
.500
.638
.626
.642
.590
.590
.568
.554
.520
.480
.500
.634
.458
.678
.558
.590
.678
.568
.578
.616
.608
.612
.654
.626
.620
.590
.480
.602
.590
.602
.568
.540
.510
.606
.568
.540
.568
.558
.506
.540
.540
.553
.626
.606
.590
.540
.540
.701
.709
.689
.555
.701
.605
.703
.681
.621
.565
.683
.643
.605
.525

RATE
mm

13.7
12.2
13.6
14.0
15.0
13.7
16.3
14.7
15.6
17.2
16.6
16.5
15.9
15.8
13.7
14.4
14.7
13.7
12.7
16.2
15.9
16.3
15.0
15.0
14.4
14.1
13.2
12.2
12.7
16.1
11.6
17.2
14.2
15.0
17.2
14.4
14.7
15.6
15.4
15.5
16.6
15.9
15.7
15.0
12.2
15.3
15.0
15.3
14.4
13.7
13.0
15.4
14.4
13.7
14.4
14.2
12.9
13.7
13.7
14.1
15.9
15.4
15.0
13.7
13.7
17.8
18.0
17.5
14.1
17.8
15.4
17.9
17.3
15.8
14.4
17.3
16.3
15.4
13.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

59
195
81
50
15
55
4.4
26
8.3
.72
2.8
1.8
5.2
7.0
54
25
16
44
82
3.3
5.5
3.5
14
12
22
31
65
135
74
4.1
242
.66
26
14
.66
17
18
4.7
6.5
6.7
1.9
5.6
8.4
10
93
6.3
8.1
5.8
13
23
40
5.3
12
25
8.8
15
31
11
12
11
1.5
2.6
3.8
8.0
12
3.1
1.1
2.4
270
1.3
73
1.6
4.3
34
244
3.6
11
46
276

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

10
34
14
8.7
2.6
9.7
.76
4.5
1.4
.13
.48
.31
.90
1.2
9.5
4.4
2.7
7.7
14
.58
.96
.60
2.4
2.1
3.9
5.4
11
24
13
.72
42
.12
4.6
2.4
.12
3.0
3.1
.82
1.1
1.2
.33
.97
1.5
1.8
16
1.1
1.4
1.0
2.2
4.0
7.0
.92
2.2
4.3
1.5
2.6
5.4
1.9
2.1
1.9
.27
.45
.66
1.4
2.0
.54
.19
.41
47
.22
13
.28
.75
5.9
43
.62
2.0
8.0
48

.83
.49
.64
.86
1.4
.89
1.9
1.1
1.8
2.4
2.1
2.1
2.1
1.7
.91
1.3
1.7
1.1
.81
2.5
2.0
2.2
1.7
1.8
1.5
1.3
.95
.71
.87
2.3
.49
3.4
1.5
1.7
3.7
1.9
1.6
3.1
2.5
2.4
3.1
2.9
1.6
2.3
1.0
2.9
2.7
3.2
2.6
2.2
1.8
3.2
2.6
2.0
3.7
2.5
2.2
4.2
4.1
3.8
7.5
6.6
6.2
5.7
4.2
.43
.49
.44
.17
.46
.31
.69
.63
.46
.24
.75
.57
.47
.23

mm

21
12
16
22
36
23
47
28
44
61
53
54
53
44
23
33
43
28
21
65
50
56
43
46
37
33
24
18
22
59
13
87
37
44
94
48
41
78
64
60
78
73
40
59
26
74
68
81
66
55
45
82
66
51
93
64
55
106
104
97
191
167
156
145
108
11
12
11
4.2
12
7.9
18
16
12
6.1
19
15
12
5.8

ENDS: C - Closed

G - Ground
O - Open

Lbs.

49
96
52
43
21
49
8.1
28
14
1.7
5.8
3.8
11
12
49
32
27
49
67
8.5
11
7.6
23
22
32
40
62
96
64
9.4
120
2.3
38
23
2.4
32
29
14
16
16
5.8
16
13
23
96
18
22
18
32
49
70
17
32
49
32
38
67
45
49
41
12
17
23
46
49
1.3
.54
1.0
45
.59
23
1.1
2.7
16
59
2.7
6.5
21
63

219
426
232
190
94
219
36
123
64
7.7
26
17
48
54
219
145
119
219
297
38
48
34
103
97
145
179
276
426
287
42
532
10
169
103
11
145
128
63
73
70
26
71
59
103
426
82
97
82
145
219
313
76
145
219
144
169
299
200
219
181
51
76
103
203
219
5.8
2.4
4.6
200
2.6
101
4.9
12
70
261
12
29
95
280

Inches

1.37
1.69
1.15
1.35
1.28
1.44
.66
1.02
.87
.40
.53
.87
.81
.82
1.58
1.52
1.55
1.86
2.44
.83
.84
.68
1.38
1.40
1.68
1.81
1.96
2.33
2.69
.87
2.08
.43
1.80
1.32
.43
2.00
1.46
1.44
1.49
1.21
.66
.85
.81
1.72
3.24
1.78
1.84
1.92
2.78
3.20
3.84
1.91
2.80
2.97
3.82
2.98
4.76
5.83
5.88
4.34
2.82
3.67
4.40
7.67
6.20
.14
.14
.19
.42
.19
.36
.12
.24
.36
.40
.25
.43
.44
.66

mm

Inches

34.7
42.9
29.2
34.3
32.5
36.7
16.8
25.9
22.1
10.1
13.4
22.0
20.5
20.8
40.0
38.7
39.4
47.3
61.9
21.0
21.3
17.1
35.1
35.6
42.8
46.1
49.7
59.1
68.3
22.1
52.8
11.0
45.7
33.5
11.0
50.9
37.1
36.6
37.9
30.7
16.8
21.7
20.7
43.7
82.3
45.1
46.7
48.9
70.5
81.3
97.5
48.5
71.1
75.3
97.1
75.6
120.9
148.0
149.4
110.3
71.7
93.3
111.8
194.7
157.4
3.5
3.6
4.7
10.7
4.9
9.1
3.1
6.1
9.1
10.2
6.2
10.8
11.2
16.8

0.105
0.135
0.107
0.100
0.080
0.105
0.055
0.085
0.067
0.036
0.048
0.051
0.062
0.063
0.105
0.091
0.085
0.105
0.125
0.056
0.062
0.054
0.080
0.080
0.091
0.098
0.115
0.135
0.125
0.058
0.146
0.036
0.096
0.080
0.036
0.091
0.086
0.067
0.071
0.069
0.048
0.062
0.065
0.080
0.135
0.074
0.080
0.074
0.091
0.105
0.120
0.072
0.091
0.105
0.091
0.096
0.122
0.105
0.105
0.098
0.062
0.072
0.080
0.105
0.105
0.032
0.028
0.038
0.105
0.032
0.080
0.031
0.042
0.072
0.100
0.041
0.061
0.080
0.120

mm

TOTAL
MATL
COILS

2.7
3.4
2.7
2.5
2.0
2.7
1.4
2.2
1.7
0.9
1.2
1.3
1.6
1.6
2.7
2.3
2.2
2.7
3.2
1.4
1.6
1.4
2.0
2.0
2.3
2.5
2.9
3.4
3.2
1.5
3.7
0.9
2.4
2.0
0.9
2.3
2.2
1.7
1.8
1.8
1.2
1.6
1.7
2.0
3.4
1.9
2.0
1.9
2.3
2.7
3.0
1.8
2.3
2.7
2.3
2.4
3.1
2.7
2.7
2.5
1.6
1.8
2.0
2.7
2.7
0.8
0.7
1.0
2.7
0.8
2.0
0.8
1.1
1.8
2.5
1.0
1.5
2.0
3.0

13.0
12.5
10.8
12.5
15.0
13.8
11.0
12.0
13.0
10.0
10.0
16.0
13.0
12.0
14.0
15.8
18.3
16.8
19.5
14.8
12.5
12.5
16.3
16.5
17.5
17.5
17.0
17.3
21.5
14.0
14.3
12.0
18.8
16.5
12.0
22.0
17.0
21.5
20.0
17.5
13.8
13.8
11.5
21.5
24.0
24.0
23.0
26.0
29.5
30.5
32.0
25.5
29.8
28.3
41.0
31.0
39.0
55.5
56.0
44.8
44.5
50.0
54.0
73.0
58.0
3.25
4.00
5.00
4.00
5.00
4.50
4.00
4.75
5.00
4.00
5.00
7.00
5.50
5.50

HD
HD
SPR
SPR
HD
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
HD
SPR
HD
SPR
SPR
SST
SPR
HD
SST
HD
SPR
SPR
HD
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
MW
SPR
SPR
HD
SPR
SST
SPR
HD
HD
HD
SPR
HD
SPR
SPR
SPR
SST
SST
SPR
SPR
HD
HD
HD
SST
SPR
MW
MW
SST
SST
SPR
SPR
SST
SPR
SST
MW
SPR
HD
SST
SST

E
N
D
S

CG
CG
CG
C
C
CG
C
CG
CG
C
C
C
CG
C
C
C
CG
C
CG
CG
C
CG
C
C
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
C
C
C
CG
CG
C
CG
CG
C
CG
CG
C
CG
CG
CG

F
N
S
H

Z
Z
N
Z
Z
Z
Z
Z
GI
N
Z
N
N
Z
Z
Z
Z
Z
Z
GI
N
GI
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
GI
N
Z
Z
GI
Z
Z
N
GI
Z
Z
Z
Z
Z
N
GI
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
Z
Z
Z
Z
N
Z
Z
Z
N
N
Z
Z
N
Z
N
N
Z
Z
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

161

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 162

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.765
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781

19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.43
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84

HH-76
S-3245
3682
S-1150
S-385
3152
S-187
S-1320
B11-26
B12-20
3771
12146
11599
12122
S-423
2853
S-1623
S-222
10915
S-1298
S-438
S-253
4304
3411
NN-80
CC-70
11410
4148
12164
S-308
11803
S-433
S-909
11713
3439
B8-53
11712
10731
11916
3171
3929
10322
S-3220
S-457
11859
3291
12185
11828
3030
Q-63
PP-8
2619
12319
V-64
S-29
3743
11379
LL-50
S-971
S-3254
I-61
DD-81
S-398
3208
S-357
12558
10761
WW-38
XX-65
B18-187
4282
4225
2835
KK-91
2973
3498
11909
10991
11167
B11-25

1.00
1.03
1.06
1.13
1.16
1.16
1.25
1.25
1.25
1.25
1.25
1.31
1.41
1.41
1.41
1.44
1.47
1.50
1.50
1.50
1.50
1.56
1.63
1.63
1.63
1.75
1.81
2.00
2.00
2.00
2.09
2.19
2.44
2.47
2.69
2.72
3.09
3.31
3.53
3.56
3.75
4.13
4.50
4.63
4.69
5.50
7.75
8.00
8.00
.44
.50
.69
.72
.75
.75
.88
.88
.88
.91
.91
.94
1.00
1.06
1.06
1.09
1.13
1.25
1.25
1.25
1.28
1.31
1.31
1.31
1.44
1.50
1.50
1.50
1.50
1.50
1.50

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

25.4
26.2
27.0
28.6
29.4
29.4
31.8
31.8
31.8
31.8
31.8
33.3
35.7
35.7
35.7
36.5
37.3
38.1
38.1
38.1
38.1
39.7
41.3
41.3
41.3
44.5
46.0
50.8
50.8
50.8
53.2
55.6
61.9
62.7
68.2
69.0
78.6
84.1
89.7
90.5
95.3
104.8
114.3
117.5
119.0
139.7
196.9
203.2
203.2
11.1
12.7
17.4
18.2
19.1
19.1
22.2
22.2
22.2
23.0
23.0
23.8
25.4
27.0
27.0
27.8
28.6
31.8
31.8
31.8
32.5
33.3
33.3
33.3
36.5
38.1
38.1
38.1
38.1
38.1
38.1

MATERIAL: MW - Music Wire

162

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.485
.685
.671
.525
.695
.551
.665
.641
.635
.545
.495
.585
.691
.603
.525
.663
.625
.695
.665
.629
.621
.525
.583
.555
.505
.585
.525
.641
.601
.515
.579
.641
.603
.523
.577
.655
.553
.669
.555
.635
.661
.425
.639
.621
.579
.601
.549
.643
.615
.651
.541
.687
.581
.667
.541
.699
.691
.681
.705
.541
.657
.621
.531
.399
.541
.501
.661
.657
.531
.673
.725
.639
.511
.661
.679
.651
.639
.531
.531
.409

RATE
mm

12.3
17.4
17.0
13.3
17.7
14.0
16.9
16.3
16.1
13.8
12.6
14.9
17.6
15.3
13.3
16.8
15.9
17.7
16.9
16.0
15.8
13.3
14.8
14.1
12.8
14.9
13.3
16.3
15.3
13.1
14.7
16.3
15.3
13.3
14.7
16.6
14.0
17.0
14.1
16.1
16.8
10.8
16.2
15.8
14.7
15.3
13.9
16.3
15.6
16.5
13.7
17.4
14.8
16.9
13.7
17.8
17.6
17.3
17.9
13.7
16.7
15.8
13.5
10.1
13.7
12.7
16.8
16.7
13.5
17.1
18.4
16.2
13.0
16.8
17.2
16.5
16.2
13.5
13.5
10.4

Lbs./In.

N/mm

502
88
4.3
.75
5.8
1.0
322
56
1.3
.23
165
29
3.3
.58
7.9
1.4
23
4.0
187
33
477
84
51
9.0
2.1
.37
39
6.8
172
30
5.3
.94
18
3.2
1.2
.21
2.8
.49
18
3.1
17
2.9
164
29
61
11
111
19
211
37
23
4.0
153
27
6.8
1.2
27
4.8
212
37
59
10
8.2
1.4
18
3.2
105
18
41
7.2
4.6
.80
79
14
1.2
.20
34
6.0
6.4
1.1
2.6
.46
326
57
3.4
.60
6.5
1.1
18
3.1
15
2.6
22
3.8
2.2
.38
6.2
1.1
61
11
1032 181
10
1.8
152
27
14
2.4
458
80
3.3
.59
6.6
1.1
12
2.0
2.1
.37
458
80
12
2.2
61
11
315
55
3105 544
299
52
559
98
9.9
1.7
12
2.2
249
44
7.5
1.3
.32
.06
29
5.1
443
78
6.2
1.1
2.6
.45
8.7
1.5
18
3.2
207
36
216
38
2042 358

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.16
4.1
.72 18
.82 21
.20
5.0
.96 24
.31
7.9
.83 21
.71 18
.56 14
.29
7.3
.20
5.0
.59 15
1.2
30
.61 16
.37
9.3
1.1
27
.79 20
1.3
32
.91 23
.79 20
.92 23
.38
9.7
.52 13
.44 11
.36
9.2
.49 12
.45 11
1.3
32
.90 23
.33
8.5
.58 15
1.3
33
1.2
30
.67 17
.85 22
1.7
44
.63 16
2.4
60
1.3
33
2.0
52
2.5
65
.54 14
3.3
83
2.4
61
1.9
49
1.7
43
2.4
62
4.7 118
3.1
78
.20
5.0
.07
1.7
.51 13
.22
5.5
.49 13
.14
3.4
.63 16
.65 17
.51 13
.72 18
.14
3.4
.57 14
.34
8.8
.22
5.6
.07
1.9
.21
5.3
.18
4.7
.77 20
.84 21
.31
7.8
.89 23
1.0
27
.54 14
.21
5.3
.84 21
.91 23
.79 20
.81 21
.37
9.4
.35
9.0
.10
2.6

Lbs.

80
357
3.1
14
4.8
21
63
280
1.3
5.7
51
228
2.7
12
5.6
25
13
58
54
239
94
419
30
135
2.5
11
24
105
63
280
5.8
26
14
64
1.5
6.7
2.6
11
14
62
16
69
63
280
32
142
48
215
76
338
11
49
69
307
8.5
38
24
109
71
315
34
151
11
47
22
98
71
315
35
156
7.9
35
50
222
2.8
12
45
200
13
58
6.7
30
176
782
11
50
16
70
34
151
24
109
53
234
10
45
19
84
12
53
68
302
5.2
23
33
147
6.9
31
62
275
2.1
9.3
4.3
19
5.9
26
1.5
6.7
62
275
7.0
31
21
93
70
310
227 1011
62
275
103
456
7.7
34
10
46
76
339
6.7
30
.33
1.5
16
70
92
411
5.2
23
2.4
10
6.9
31
15
65
76
339
76
339
212
941

ENDS: C - Closed

G - Ground
O - Open

Inches

.84
.16
.25
.60
.20
.64
.43
.54
.34
.66
.81
.72
.23
.57
.92
.36
.56
.25
.59
.44
.58
.96
.66
.79
1.14
1.26
1.11
.74
.86
.94
.74
.60
.90
1.57
1.13
.55
1.17
.95
1.86
.89
.73
3.32
1.20
1.26
2.05
1.31
3.67
1.54
1.84
.20
.36
.18
.50
.26
.48
.25
.23
.25
.19
.48
.37
.36
.69
.96
.60
.81
.48
.37
.88
.39
.27
.46
.81
.60
.59
.72
.50
1.00
.97
1.12

mm

21.3
4.1
6.3
15.2
5.0
16.3
10.8
13.8
8.7
16.8
20.6
18.3
5.9
14.4
23.2
9.1
14.2
6.2
14.9
11.1
14.6
24.4
16.8
20.0
28.9
32.0
28.2
18.9
21.9
23.8
18.9
15.2
22.9
40.0
28.7
14.0
29.6
24.1
47.3
22.7
18.5
84.2
30.4
32.0
52.0
33.3
93.3
39.1
46.7
5.0
9.1
4.5
12.7
6.5
12.2
6.2
5.7
6.4
4.8
12.2
9.4
9.1
17.5
24.3
15.2
20.4
12.2
9.4
22.2
9.9
6.8
11.7
20.6
15.2
15.1
18.2
12.6
25.4
24.6
28.3

WIRE DIA.
Inches

0.140
0.040
0.047
0.120
0.035
0.107
0.050
0.062
0.065
0.110
0.135
0.090
0.037
0.081
0.120
0.051
0.070
0.035
0.050
0.068
0.072
0.120
0.091
0.105
0.130
0.090
0.120
0.062
0.082
0.125
0.093
0.062
0.081
0.121
0.094
0.055
0.106
0.048
0.105
0.065
0.052
0.170
0.063
0.072
0.093
0.082
0.108
0.061
0.075
0.065
0.120
0.047
0.100
0.057
0.120
0.041
0.045
0.050
0.038
0.120
0.062
0.080
0.125
0.191
0.120
0.140
0.060
0.062
0.125
0.054
0.028
0.071
0.135
0.060
0.051
0.065
0.071
0.125
0.125
0.186

mm

TOTAL
MATL
COILS

3.6
1.0
1.2
3.0
0.9
2.7
1.3
1.6
1.7
2.8
3.4
2.3
0.9
2.1
3.0
1.3
1.8
0.9
1.3
1.7
1.8
3.0
2.3
2.7
3.3
2.3
3.0
1.6
2.1
3.2
2.4
1.6
2.1
3.1
2.4
1.4
2.7
1.2
2.7
1.7
1.3
4.3
1.6
1.8
2.4
2.1
2.7
1.5
1.9
1.7
3.0
1.2
2.5
1.4
3.0
1.0
1.1
1.3
1.0
3.0
1.6
2.0
3.2
4.9
3.0
3.6
1.5
1.6
3.2
1.4
0.7
1.8
3.4
1.5
1.3
1.7
1.8
3.2
3.2
4.7

6.00
4.00
5.25
5.00
6.00
6.00
8.50
8.75
5.25
6.00
6.00
8.00
5.33
7.00
7.75
7.00
7.00
6.00
10.8
6.50
8.00
8.00
7.25
7.50
8.75
14.0
9.25
11.0
9.50
7.50
8.00
8.75
11.0
13.0
11.0
10.0
10.0
19.8
17.8
13.8
13.0
19.5
19.0
17.5
22.0
16.0
34.0
25.3
24.5
3.00
3.00
3.75
5.00
4.50
4.00
5.00
4.00
4.00
5.00
4.00
6.00
4.50
5.50
5.00
5.00
5.75
7.00
6.00
7.00
6.25
8.50
5.50
6.00
10.0
11.8
10.0
7.00
8.00
7.75
6.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SST
SPR
SST
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SST
SST
SST
SPR
SPR
SST
SST
SPR
HD
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
HD
SPR
SST
SST
SPR
SST
SPR
SST
SST
SST
SST
SST
SPR
SST
SPR
SPR
SST
SPR
SPR
MW
SPR
SPR
SPR
SPR
SPR
SST
HD
SPR
SPR

E
N
D
S

CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
C
CG
CG
CG
CG

F
N
S
H

N
N
Z
N
N
Z
N
N
N
Z
Z
Z
Z
Z
N
Z
N
N
N
N
N
N
Z
GI
N
N
Z
Z
Z
N
Z
N
N
Z
Z
N
Z
Z
N
Z
Z
Z
N
N
N
Z
N
N
GI
N
N
Z
Z
N
N
Z
N
Z
N
N
N
N
N
Z
N
N
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 163

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.781
0.785
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796
0.796

19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.84
19.94
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22
20.22

3127
64
BB-55
S-300
11950
387
S-1198
S-1273
4204
4139
3361
3760
12322
12275
3484
YY-38
10818
3293
3305
3224
3461
4217
11533
B7-53
12037
12787
2740
1647
11810
PP-88
B11-38
MM-99
A11-32
S-491
S-804
2857
Y-28
S-870
3759
S-441
3116
B8-51
S-1142
S-1207
MM-51
A13-66
10668
S-3156
BB-28
S-234
S-1173
B8-52
10628
S-1029
LL-48
2798
10052
11594
CC-47
S-1132
M-95
1749
12165
4234
11141
10737
11647
12161
10500
10494
10667
S-232
3466
B17-202
12035
1547
3099
11778
12204
S-1584

1.63
1.63
1.63
1.88
2.00
2.25
2.38
2.44
2.50
2.63
2.69
2.75
2.78
2.84
2.88
3.38
3.50
3.50
3.50
3.56
3.63
4.00
4.00
4.19
5.56
1.31
.66
.75
.84
.97
1.00
1.03
1.06
1.06
1.19
1.22
1.28
1.31
1.31
1.31
1.34
1.38
1.50
1.50
1.50
1.50
1.50
1.56
1.63
1.69
1.75
1.91
2.00
2.00
2.00
2.00
2.00
2.03
2.28
2.31
2.50
2.50
2.63
2.75
2.78
2.78
2.88
2.94
3.00
3.00
3.13
3.25
3.25
3.34
3.38
3.50
3.50
4.25
4.31
7.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

41.3
41.3
41.3
47.6
50.8
57.2
60.3
61.9
63.5
66.7
68.2
69.9
70.6
72.2
73.0
85.7
88.9
88.9
88.9
90.5
92.1
101.6
101.6
106.4
141.3
33.3
16.7
19.1
21.4
24.6
25.4
26.2
27.0
27.0
30.2
31.0
32.5
33.3
33.3
33.3
34.1
34.9
38.1
38.1
38.1
38.1
38.1
39.7
41.3
42.8
44.5
48.4
50.8
50.8
50.8
50.8
50.8
51.6
57.9
58.7
63.5
63.5
66.7
69.9
70.6
70.6
73.0
74.6
76.2
76.2
79.4
82.6
82.6
84.9
85.7
88.9
88.9
108.0
109.5
196.9

I.D.
Inches

.641
.541
.461
.637
.461
.541
.657
.673
.699
.515
.511
.691
.609
.587
.531
.691
.731
.661
.597
.585
.657
.689
.657
.637
.589
.709
.652
.688
.674
.536
.708
.536
.612
.546
.688
.666
.596
.702
.616
.614
.526
.456
.716
.652
.596
.586
.552
.672
.676
.688
.586
.680
.672
.668
.656
.612
.484
.476
.636
.686
.698
.586
.636
.636
.612
.566
.614
.652
.668
.664
.560
.638
.586
.652
.598
.642
.604
.602
.636
.636

RATE
mm

16.3
13.7
11.7
16.2
11.7
13.7
16.7
17.1
17.8
13.1
13.0
17.6
15.5
14.9
13.5
17.6
18.6
16.8
15.2
14.9
16.7
17.5
16.7
16.2
15.0
18.0
16.6
17.5
17.1
13.6
18.0
13.6
15.5
13.9
17.5
16.9
15.1
17.8
15.6
15.6
13.4
11.6
18.2
16.6
15.1
14.9
14.0
17.1
17.2
17.5
14.9
17.3
17.1
17.0
16.7
15.5
12.3
12.1
16.2
17.4
17.7
14.9
16.2
16.2
15.5
14.4
15.6
16.6
17.0
16.9
14.2
16.2
14.9
16.6
15.2
16.3
15.3
15.3
16.2
16.2

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

19
3.4
147
26
582 102
16
2.8
605 106
103
18
9.0
1.6
4.6
.81
2.0
.35
154
27
161
28
2.6
.45
20
3.4
57
9.9
131
23
1.2
.20
.10
.02
4.1
.73
29
5.0
28
4.9
5.7
1.0
1.5
.27
2.8
.47
6.1
1.1
17
3.0
1.9
.34
34
5.9
9.0
1.6
17
2.9
463
81
3.6
.63
352
62
87
15
294
52
6.5
1.1
16
2.9
90
16
5.3
.92
60
10
55
9.7
367
64
979 171
1.3
.24
22
3.9
58
10
94
16
181
32
5.8
1.0
9.2
1.6
5.3
.93
46
8.1
7.0
1.2
5.7
.99
4.5
.78
6.7
1.2
42
7.4
481
84
523
92
21
3.7
3.1
.55
3.3
.58
59
10
20
3.5
16
2.8
34
5.9
60
11
26
4.5
5.7
.99
6.0
1.1
8.8
1.5
87
15
14
2.4
38
6.6
11
2.0
27
4.8
13
2.2
22
3.9
23
4.1
11
1.9
14
2.5

.78
.46
.22
.98
.24
.66
1.2
1.5
1.7
.58
.57
1.8
1.4
.66
.58
2.7
3.1
2.4
1.1
1.4
1.9
3.2
2.5
2.5
2.1
1.1
.30
.41
.54
.18
.76
.21
.34
.23
.86
.83
.45
.91
.50
.51
.25
.17
1.2
.68
.65
.46
.39
.94
1.0
1.3
.49
1.3
1.3
1.1
1.0
.75
.28
.27
1.0
1.7
1.7
1.1
1.1
1.4
.94
.89
1.2
1.5
2.0
1.5
.73
1.4
1.2
1.4
1.4
1.5
1.6
1.6
2.0
1.4

mm

20
12
5.7
25
6.1
17
29
38
44
15
15
45
36
17
15
70
79
62
29
36
49
80
63
64
54
27
7.5
10
14
4.5
19
5.3
8.6
5.9
22
21
11
23
13
13
6.3
4.4
29
17
16
12
9.8
24
26
33
12
32
33
28
26
19
7.1
7.0
26
42
44
28
28
35
24
23
31
38
51
38
18
36
31
36
37
39
41
40
50
37

ENDS: C - Closed

G - Ground
O - Open

Lbs.

15
68
130
15
146
68
10
6.9
3.5
89
92
4.6
28
38
76
3.2
.32
10
32
39
11
4.9
6.6
15
37
2.0
10
3.7
9.0
82
2.7
73
29
68
5.6
14
41
4.8
30
29
91
170
1.6
15
38
43
70
5.5
9.3
6.8
23
8.9
7.3
4.9
6.8
32
134
144
22
5.2
5.8
65
22
22
32
54
31
8.5
12
13
63
20
47
16
39
20
36
37
22
21

67
302
577
68
650
302
46
31
15
394
411
20
123
168
339
14
1.4
45
144
173
49
22
29
68
163
9.0
45
16
40
363
12
327
131
304
25
61
180
21
132
127
404
758
6.9
67
167
193
311
24
41
30
100
40
32
22
30
141
596
640
98
23
26
291
98
98
141
239
137
38
53
58
282
88
208
71
175
87
160
165
98
91

Inches

.49
1.08
1.28
.58
1.36
1.44
.47
.43
.29
1.70
1.76
.39
1.20
.87
1.44
.63
.39
.90
1.20
1.67
.74
.62
1.52
1.28
2.30
.26
.36
.34
.31
.65
.24
.72
.46
.69
.32
.39
.68
.22
.68
.59
.88
1.19
.34
.43
.85
.74
.95
.62
.39
.38
1.26
.45
.71
.90
.98
.83
1.37
1.60
.76
.66
.39
1.26
.80
.96
.99
1.58
1.18
1.44
.85
.66
1.45
.91
1.79
.79
1.68
1.06
1.73
1.75
1.32
.96

mm

Inches

12.4
27.4
32.5
14.6
34.5
36.6
11.8
11.0
7.3
43.1
44.6
10.0
30.6
22.2
36.5
16.0
10.0
22.9
30.4
42.3
18.9
15.8
38.6
32.5
58.5
6.5
9.1
8.7
7.7
16.5
6.1
18.2
11.7
17.5
8.2
9.9
17.1
5.7
17.1
15.0
22.3
30.2
8.6
11.0
21.6
18.7
24.0
15.7
9.9
9.6
32.0
11.4
18.1
22.8
24.9
21.0
34.7
40.6
19.3
16.8
10.0
32.0
20.3
24.4
25.1
40.2
30.0
36.6
21.5
16.8
36.7
23.1
45.3
20.1
42.7
26.9
43.9
44.3
33.5
24.4

0.070
0.120
0.162
0.072
0.160
0.120
0.062
0.054
0.041
0.133
0.135
0.045
0.086
0.097
0.125
0.045
0.025
0.060
0.092
0.098
0.062
0.046
0.062
0.072
0.096
0.038
0.072
0.054
0.061
0.130
0.044
0.130
0.092
0.125
0.054
0.065
0.100
0.047
0.090
0.091
0.135
0.170
0.040
0.072
0.100
0.105
0.122
0.062
0.060
0.054
0.105
0.058
0.062
0.064
0.070
0.092
0.156
0.160
0.080
0.055
0.049
0.105
0.080
0.080
0.092
0.115
0.091
0.072
0.064
0.066
0.118
0.079
0.105
0.072
0.099
0.077
0.096
0.097
0.080
0.080

mm

TOTAL
MATL
COILS

1.8
3.0
4.1
1.8
4.1
3.0
1.6
1.4
1.0
3.4
3.4
1.1
2.2
2.5
3.2
1.1
0.6
1.5
2.3
2.5
1.6
1.2
1.6
1.8
2.4
1.0
1.8
1.4
1.5
3.3
1.1
3.3
2.3
3.2
1.4
1.7
2.5
1.2
2.3
2.3
3.4
4.3
1.0
1.8
2.5
2.7
3.1
1.6
1.5
1.4
2.7
1.5
1.6
1.6
1.8
2.3
4.0
4.1
2.0
1.4
1.2
2.7
2.0
2.0
2.3
2.9
2.3
1.8
1.6
1.7
3.0
2.0
2.7
1.8
2.5
2.0
2.4
2.5
2.0
2.0

7.00
9.00
8.00
8.00
8.50
12.0
7.50
8.00
7.00
12.8
13.0
7.75
14.0
9.00
11.5
13.0
14.8
14.0
13.0
17.0
12.0
12.5
23.5
17.8
24.0
5.75
5.00
5.33
5.00
5.00
5.50
5.50
5.00
5.50
6.00
6.00
6.75
4.75
6.50
6.50
6.50
7.00
7.50
6.00
8.50
7.00
7.75
10.0
6.50
7.00
12.0
7.75
11.5
14.0
14.0
9.00
8.75
9.00
9.50
11.0
8.00
11.0
10.0
12.0
10.8
13.8
13.0
20.0
12.3
10.0
12.3
11.5
16.0
11.0
17.0
12.8
18.0
18.0
16.5
12.0

SPR
HD
SST
SST
SPR
HD
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
HD
SST
MW
SPR
SPR
SPR
HD
SPR
SPR
SST
SPR
MW
MW
SPR
SPR
SPR
SPR
SST
SST
SST
SST
MW
SPR
SST
SPR
SST
SPR
SPR
SST
SST
SST
SST
SPR
SST
SST
SST
SST
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SPR
MW
SPR
SPR
HD
SST
SPR
SPR
SPR
SPR
SPR
SST
HD
SPR
SPR
SPR
SPR
SPR
SPR
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG

F
N
S
H

Z
Z
N
N
Z
Z
N
N
Z
Z
Z
Z
GI
Z
Z
N
N
Z
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
N
N
N
N
N
N
Z
Z
N
Z
N
Z
Z
N
N
N
N
Z
N
N
N
N
N
Z
N
N
Z
Z
Z
Z
N
N
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
N
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

163

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 164

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.796
0.796
0.796
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812
0.812

20.22
20.22
20.22
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62
20.62

10848
3054
S-76
DD-6
BB-77
2856
FF-36
S-939
3356
DD-84
II-7
11432
H-21
12639
S-123
10340
FF-68
3038
B10-52
4160
S-1609
1918
KK-6
S-933
K-48
2680
63
S-25
10601
S-366
12554
S-3207
10788
3960
S-799
3801
2645
12605
3079
3354
3139
12490
65
2974
3282
12157
S-1215
11959
3945
B8-35
69
70
11217
12145
S-1612
12061
11188
S-3090
3459
12606
12163
12543
4173
1727
10709
3236
12492
11475
3970
4102
37
S-1400
10687
2837
12431
11248
S-966
2701
11601
2589

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

8.25
9.00
11.4
.38
.44
.47
.50
.69
.69
.72
.78
.81
.81
.88
1.00
1.00
1.00
1.03
1.13
1.19
1.22
1.22
1.25
1.28
1.38
1.38
1.38
1.50
1.50
1.50
1.50
1.53
1.63
1.63
1.66
1.69
1.75
1.75
1.75
1.75
1.78
1.81
1.88
2.00
2.00
2.13
2.13
2.16
2.19
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.66
2.75
2.75
2.88
3.00
3.00
3.00
3.00
3.19
3.19
3.38
3.75
3.88
3.88
4.25
4.25
4.50
4.75
5.13
5.13
5.19

mm

209.6
228.6
288.9
9.5
11.1
11.9
12.7
17.4
17.4
18.2
19.8
20.6
20.6
22.2
25.4
25.4
25.4
26.2
28.6
30.2
31.0
31.0
31.8
32.5
34.9
34.9
34.9
38.1
38.1
38.1
38.1
38.9
41.3
41.3
42.1
42.8
44.5
44.5
44.5
44.5
45.2
46.0
47.6
50.8
50.8
54.0
54.0
54.8
55.6
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
67.5
69.9
69.9
73.0
76.2
76.2
76.2
76.2
81.0
81.0
85.7
95.3
98.4
98.4
108.0
108.0
114.3
120.7
130.2
130.2
131.8

MATERIAL: MW - Music Wire

164

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.676
.672
.466
.762
.698
.704
.692
.668
.642
.722
.692
.662
.602
.520
.704
.686
.532
.632
.648
.496
.602
.504
.592
.686
.528
.500
.488
.758
.728
.718
.652
.602
.688
.572
.716
.602
.688
.652
.572
.572
.518
.706
.572
.730
.688
.650
.612
.744
.704
.708
.602
.572
.562
.684
.682
.652
.642
.612
.602
.542
.686
.562
.628
.708
.686
.648
.630
.672
.668
.692
.542
.668
.652
.724
.724
.592
.652
.626
.536
.488

RATE
mm

17.2
17.1
11.8
19.4
17.7
17.9
17.6
17.0
16.3
18.3
17.6
16.8
15.3
13.2
17.9
17.4
13.5
16.1
16.5
12.6
15.3
12.8
15.0
17.4
13.4
12.7
12.4
19.3
18.5
18.2
16.6
15.3
17.5
14.5
18.2
15.3
17.5
16.6
14.5
14.5
13.2
17.9
14.5
18.5
17.5
16.5
15.5
18.9
17.9
18.0
15.3
14.5
14.3
17.4
17.3
16.6
16.3
15.5
15.3
13.8
17.4
14.3
16.0
18.0
17.4
16.5
16.0
17.1
17.0
17.6
13.8
17.0
16.6
18.4
18.4
15.0
16.6
15.9
13.6
12.4

Lbs./In.

N/mm

2.3
.41
3.0
.52
88
15
.33
.06
18
3.1
11
2.0
18
3.1
56
9.9
98
17
3.2
.57
9.7
1.7
28
5.0
195
34
1474 258
11
1.9
18
3.1
497
87
61
11
42
7.3
801 140
110
19
710 124
122
21
12
2.1
389
68
670 117
721 126
.34
.06
1.4
.25
3.4
.60
26
4.6
88
15
9.9
1.7
138
24
3.8
.66
76
13
4.2
.73
27
4.8
124
22
129
23
380
67
3.8
.66
116
20
1.1
.19
5.0
.88
26
4.6
35
6.1
.52
.09
3.1
.55
2.7
.46
55
9.6
112
20
117
20
5.2
.92
4.6
.80
14
2.4
19
3.4
41
7.1
55
9.6
166
29
5.4
.94
114
20
25
4.4
3.4
.60
5.4
.94
18
3.1
22
3.8
8.4
1.5
9.1
1.6
3.0
.52
91
16
6.6
1.2
11
1.9
1.3
.23
1.3
.23
31
5.5
7.7
1.4
15
2.7
71
12
180
32

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

4.2 107
3.6
93
1.6
40
.21
5.4
.21
5.3
.23
5.7
.17
4.3
.26
6.7
.26
6.7
.47 12
.42 11
.36
9.2
.22
5.5
.07
1.7
.61 16
.62 16
.18
4.6
.48 12
.55 14
.17
4.3
.39
9.9
.18
4.5
.42 11
.84 21
.27
6.8
.28
7.0
.20
5.2
1.3
33
1.1
27
1.2
31
.77 20
.48 12
1.0
26
.47 12
1.3
34
.60 15
.82 21
1.1
27
.53 13
.51 13
.30
7.6
1.3
34
.56 14
1.5
39
1.3
32
.85 21
.93 23
1.8
46
1.5
39
1.7
44
.84 21
.58 15
.63 16
1.7
42
1.5
39
1.5
37
1.3
32
.91 23
.84 21
.75 19
2.0
51
.73 18
1.2
32
1.9
47
2.1
53
1.3
33
1.4
35
1.7
44
1.7
44
2.3
59
.99 25
2.2
57
1.9
49
3.1
79
3.1
79
1.6
41
2.6
66
2.9
74
1.3
34
.81 21

Lbs.

9.9
11
139
.07
3.7
2.5
3.0
15
26
1.5
4.1
10
43
101
6.7
11
89
29
23
137
43
127
51
10
103
184
147
.45
1.5
4.1
20
43
10
65
5.0
46
3.4
29
65
65
114
5.0
65
1.7
6.3
22
32
.94
4.8
4.6
46
65
74
8.7
6.9
20
24
37
46
125
11
83
31
6.3
11
23
30
15
16
6.9
89
15
22
4.1
4.1
51
20
45
95
147

ENDS: C - Closed

G - Ground
O - Open

44
48
619
.31
16
11
13
66
114
6.8
18
46
189
448
30
50
397
129
103
607
189
565
226
45
460
821
652
2.0
6.7
18
90
189
45
291
22
204
15
130
291
291
507
22
291
7.6
28
99
142
4.2
21
20
204
291
328
39
31
89
107
164
204
556
48
369
139
28
50
103
134
65
70
31
398
66
96
18
18
226
90
200
423
652

Inches

mm

1.38 35.1
1.30 33.1
7.26 184.4
.16
4.1
.23
5.8
.24
6.2
.33
8.4
.25
6.4
.34
8.6
.25
6.3
.36
9.1
.45 11.4
.45 11.3
.51 13.0
.23
5.8
.38
9.6
.74 18.7
.55 14.0
.49 12.5
.95 24.1
.63 16.0
.92 23.5
.77 19.6
.44 11.2
.99 25.2
1.01 25.8
1.13 28.8
.19
4.8
.42 10.7
.28
7.2
.56 14.2
.74 18.7
.47 11.8
1.02 25.9
.29
7.3
.89 22.7
.93 23.6
.68 17.3
1.11 28.2
1.20 30.5
1.18 29.9
.48 12.1
1.17 29.7
.45 11.5
.74 18.9
.65 16.5
1.20 30.5
.34
8.6
.65 16.5
.52 13.2
1.26 32.0
1.32 33.5
1.41 35.7
.83 21.1
.98 24.8
1.04 26.4
1.02 25.9
1.05 26.7
1.16 29.3
1.65 42.0
.76 19.2
1.56 39.7
1.20 30.4
.52 13.2
.82 20.8
1.01 25.7
1.27 32.4
.91 23.1
.90 22.9
1.07 27.1
2.57 65.2
1.12 28.3
1.24 31.5
.53 13.4
.53 13.4
2.37 60.1
1.51 38.4
2.02 51.4
3.73 94.6
3.56 90.5

WIRE DIA.
Inches

0.060
0.062
0.165
0.025
0.057
0.054
0.060
0.072
0.085
0.045
0.060
0.075
0.105
0.146
0.054
0.063
0.140
0.090
0.082
0.158
0.105
0.154
0.110
0.063
0.142
0.156
0.162
0.027
0.042
0.047
0.080
0.105
0.062
0.120
0.048
0.105
0.062
0.080
0.120
0.120
0.147
0.053
0.120
0.041
0.062
0.081
0.100
0.034
0.054
0.052
0.105
0.120
0.125
0.064
0.065
0.080
0.085
0.100
0.105
0.135
0.063
0.125
0.092
0.052
0.063
0.082
0.091
0.070
0.072
0.060
0.135
0.072
0.080
0.044
0.044
0.110
0.080
0.093
0.138
0.162

mm

TOTAL
MATL
COILS

1.5
1.6
4.2
0.6
1.4
1.4
1.5
1.8
2.2
1.1
1.5
1.9
2.7
3.7
1.4
1.6
3.6
2.3
2.1
4.0
2.7
3.9
2.8
1.6
3.6
4.0
4.1
0.7
1.1
1.2
2.0
2.7
1.6
3.0
1.2
2.7
1.6
2.0
3.0
3.0
3.7
1.3
3.0
1.0
1.6
2.1
2.5
0.9
1.4
1.3
2.7
3.0
3.2
1.6
1.7
2.0
2.2
2.5
2.7
3.4
1.6
3.2
2.3
1.3
1.6
2.1
2.3
1.8
1.8
1.5
3.4
1.8
2.0
1.1
1.1
2.8
2.0
2.4
3.5
4.1

22.0
20.0
44.0
5.50
4.00
4.50
4.50
3.50
4.00
5.50
6.00
6.00
4.25
3.50
4.25
5.00
5.25
6.00
6.00
6.00
6.00
6.00
7.00
6.00
7.00
6.50
7.00
6.00
9.00
6.00
7.00
7.00
6.50
8.50
6.00
8.50
14.0
7.50
9.25
9.00
8.00
8.00
9.75
10.0
12.0
8.00
12.0
9.00
11.0
10.0
11.0
10.0
11.3
13.0
14.0
13.0
11.0
10.5
11.0
11.3
12.0
11.5
13.0
9.00
12.0
11.3
14.0
12.0
12.5
16.8
19.0
14.5
15.5
11.0
11.0
21.5
19.0
20.8
26.0
22.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SST
MW
SPR
HD
SPR
SST
SPR
SST
SST
SPR
SST
SST
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
MW
HD
SST
SPR
SST
SST
SST
SST
SPR
SST
SPR
HD
MW
SPR
SPR
SPR
SST
HD
SPR
HD
SPR
SST
SST
SPR
SST
HD
HD
HD
SPR
SST
SPR
SST
SST
HD
MW
SPR
OT
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
HD
SST
SPR
SPR
SPR
SPR
SST
MW
SPR
HD

E
N
D
S

C
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
C
C
CG
C
CG
C
CG
C
CG
CG
CG
C
C
CG
CG
C
CG
CG
C
CG
C
CG
CG
C
CG
C
CG
C
C
C
CG
C
CG
C
CG
C
CG
C
C
CG
CG
C
C
CG

F
N
S
H

GI
Z
N
Z
N
Z
N
N
Z
N
N
Z
N
N
N
Z
N
GI
Z
Z
N
Z
N
N
Z
Z
Z
N
Z
N
N
N
N
Z
N
GI
Z
N
Z
Z
Z
N
Z
Z
Z
GI
N
N
Z
N
Z
Z
Z
Z
N
Z
N
N
Z
N
GI
N
N
Z
Z
Z
N
Z
Z
Z
Z
N
Z
GI
GI
Z
N
Z
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 165

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.812
0.812
0.812
0.812
0.812
0.822
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.828
0.843
0.843
0.843
0.843
0.843

20.62
20.62
20.62
20.62
20.62
20.88
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.03
21.41
21.41
21.41
21.41
21.41

2738
10214
2997
12741
4244
B2-66
11483
B14-67
KK-62
S-349
S-416
S-1111
3872
11361
11227
CC-68
2958
12430
S-3206
12315
KK-58
4333
10792
KK-97
11478
3852
11696
12176
10702
A13-64
10944
S-3163
3424
S-292
S-1080
11768
KK-35
TT-59
NN-8
10527
12211
S-339
3226
S-361
10591
11987
DD-80
11354
1903
11258
11933
10806
S-287
S-3038
S-3202
S-63
S-72
B8-38
S-3011
G-43
B9-52
3185
3679
11268
12062
11103
11620
12113
3100
11801
S-3231
1940
1705
12542
10154
U-43
B4-15
CC-40
H-38
B2-56

O.D.

FREE LENGTH
Inches

5.50
7.00
9.19
10.0
15.5
2.63
.50
.50
.50
.72
.78
.81
.81
.81
.84
.88
.91
.94
.94
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.06
1.22
1.38
1.38
1.50
1.50
1.50
1.63
1.75
1.75
1.81
1.88
1.88
1.91
1.94
2.00
2.09
2.13
2.13
2.19
2.50
2.50
2.50
2.50
2.63
2.63
2.75
2.88
3.00
3.00
3.00
3.00
3.13
3.31
3.50
3.53
3.66
3.75
3.78
3.81
3.88
3.88
5.00
5.22
6.03
6.75
9.00
10.0
10.0
.28
.50
.50
.69
.69

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

139.7
177.8
233.4
254.0
393.7
66.7
12.7
12.7
12.7
18.2
19.8
20.6
20.6
20.6
21.4
22.2
23.0
23.8
23.8
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.0
31.0
34.9
34.9
38.1
38.1
38.1
41.3
44.5
44.5
46.0
47.6
47.6
48.4
49.2
50.8
53.2
54.0
54.0
55.6
63.5
63.5
63.5
63.5
66.7
66.7
69.9
73.0
76.2
76.2
76.2
76.2
79.4
84.1
88.9
89.7
92.9
95.3
96.0
96.8
98.4
98.4
127.0
132.6
153.2
171.5
228.6
254.0
254.0
7.1
12.7
12.7
17.4
17.4

I.D.
Inches

.592
.602
.516
.558
.602
.550
.728
.672
.588
.642
.704
.764
.732
.668
.474
.648
.734
.742
.732
.764
.728
.704
.646
.608
.728
.732
.648
.516
.700
.686
.708
.708
.418
.644
.724
.648
.608
.668
.588
.532
.708
.578
.638
.668
.668
.716
.668
.668
.646
.578
.738
.658
.742
.454
.762
.758
.618
.576
.704
.746
.620
.744
.558
.672
.698
.588
.682
.600
.618
.668
.474
.646
.640
.702
.646
.805
.743
.723
.649
.649

RATE
mm

15.0
15.3
13.1
14.2
15.3
14.0
18.5
17.1
14.9
16.3
17.9
19.4
18.6
17.0
12.0
16.5
18.6
18.8
18.6
19.4
18.5
17.9
16.4
15.4
18.5
18.6
16.5
13.1
17.8
17.4
18.0
18.0
10.6
16.4
18.4
16.5
15.4
17.0
14.9
13.5
18.0
14.7
16.2
17.0
17.0
18.2
17.0
17.0
16.4
14.7
18.7
16.7
18.8
11.5
19.4
19.3
15.7
14.6
17.9
18.9
15.7
18.9
14.2
17.1
17.7
14.9
17.3
15.2
15.7
17.0
12.0
16.4
16.3
17.8
16.4
20.4
18.9
18.4
16.5
16.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

30
5.2
22
3.8
54
9.4
31
5.4
11
1.9
160
28
19
3.3
126
22
745 130
320
56
10
1.8
1.0
.18
11
1.9
71
12
2922 512
42
7.3
3.7
.64
9.0
1.6
8.1
1.4
.75
.13
9.5
1.7
16
2.8
55
9.6
112
20
9.5
1.7
4.3
.75
59
10
701 123
18
3.2
28
4.9
10
1.8
29
5.1
2100 368
35
6.1
4.3
.76
39
6.8
53
9.3
24
4.3
115
20
366
64
8.2
1.4
117
21
42
7.4
17
3.1
23
4.1
2.9
.51
15
2.7
14
2.4
25
4.4
101
18
1.8
.31
18
3.2
.88
.15
553
97
.25
.04
.31
.05
50
8.8
77
14
4.1
.72
.74
.13
28
4.8
.93
.16
110
19
9.7
1.7
4.4
.76
56
9.8
5.9
1.0
37
6.5
24
4.3
8.0
1.4
197
35
9.9
1.7
8.8
1.5
.82
.14
8.2
1.4
.33
.06
12
2.1
39
6.8
89
16
102
18

Inches

mm

1.7
44
2.1
53
2.2
55
2.5
64
4.1 105
.65 16
.29
7.4
.16
3.9
.08
2.0
.09
2.3
.41 10
.64 16
.49 12
.28
7.0
.06
1.6
.25
6.2
.62 16
.39 10
.60 15
.81 21
.58 15
.63 16
.45 12
.29
7.2
.58 15
.74 19
.49 12
.18
4.7
.64 16
.53 13
.92 23
.30
7.7
.07
1.7
.82 21
1.3
34
.73 19
.55 14
.81 21
.51 13
.31
7.9
1.2
29
.56 14
.79 20
1.1
29
.90 23
1.5
38
1.4
35
1.4
36
1.2
30
.72 18
2.2
56
1.3
33
2.2
57
.32
8.1
2.5
64
2.5
64
.83 21
.87 22
2.4
60
2.8
71
1.6
40
3.0
77
.80 20
2.0
51
2.8
70
1.1
29
2.5
63
1.5
38
1.9
47
2.6
67
.83 21
3.0
76
3.7
94
6.4 164
3.6
92
.21
5.2
.33
8.3
.24
6.1
.20
5.1
.20
5.1

ENDS: C - Closed

G - Ground
O - Open

Lbs.

51
46
116
77
46
105
5.5
20
59
29
4.3
.66
5.2
20
185
10
2.3
3.5
4.9
.60
5.5
9.9
25
32
5.5
3.2
29
130
12
15
9.5
8.9
136
28
5.8
29
29
20
59
114
9.5
66
34
20
21
4.4
21
20
30
72
3.9
24
2.0
177
.64
.79
42
68
9.8
2.1
44
2.8
88
20
12
64
15
55
45
21
164
30
33
5.3
30
.07
3.9
9.3
18
21

226
204
517
343
204
466
25
87
261
130
19
2.9
23
88
822
45
10
16
22
2.7
25
44
110
142
25
14
128
576
51
66
42
40
607
126
26
128
129
88
261
509
42
294
150
88
94
19
94
88
132
322
17
105
8.8
788
2.8
3.5
186
301
44
9.1
195
13
391
87
54
286
66
247
200
94
730
132
145
24
132
.31
17
42
80
92

Inches

2.48
2.57
6.81
5.21
4.88
1.70
.20
.23
.36
.26
.37
.18
.22
.30
.66
.63
.28
.17
.18
.19
.20
.37
.55
.72
.25
.32
.54
.94
.32
.36
.36
.48
1.44
.78
.39
.72
1.27
.56
1.02
1.18
.42
1.19
.95
.72
.72
.70
.90
.96
1.07
1.50
.41
1.02
.52
2.34
.46
.49
1.16
1.76
.74
.53
1.87
.50
2.03
1.25
.99
2.04
1.39
2.28
2.21
1.64
4.43
2.46
3.31
3.56
2.91
.08
.18
.24
.49
.49

mm

Inches

62.9
65.4
172.9
132.3
124.0
43.2
5.1
5.9
9.1
6.5
9.4
4.5
5.5
7.6
16.9
16.0
7.2
4.4
4.6
4.9
5.1
9.4
13.9
18.2
6.4
8.2
13.7
23.8
8.1
9.0
9.1
12.2
36.4
19.9
9.9
18.3
32.1
14.2
25.9
30.1
10.7
30.2
24.1
18.3
18.3
17.8
22.9
24.4
27.2
38.1
10.3
25.9
13.1
59.4
11.7
12.4
29.3
44.8
18.9
13.5
47.5
12.7
51.4
31.7
25.2
51.8
35.2
57.9
56.0
41.7
112.4
62.4
84.2
90.4
74.0
1.9
4.4
6.1
12.3
12.3

0.110
0.105
0.148
0.127
0.105
0.136
0.050
0.078
0.120
0.093
0.062
0.032
0.048
0.080
0.177
0.090
0.047
0.043
0.048
0.032
0.050
0.062
0.091
0.110
0.050
0.048
0.090
0.156
0.064
0.071
0.060
0.060
0.205
0.092
0.052
0.090
0.110
0.080
0.120
0.148
0.060
0.125
0.095
0.080
0.080
0.056
0.080
0.080
0.091
0.125
0.045
0.085
0.043
0.187
0.033
0.035
0.105
0.126
0.062
0.041
0.104
0.042
0.135
0.078
0.065
0.120
0.073
0.114
0.105
0.080
0.177
0.091
0.094
0.063
0.091
0.019
0.050
0.060
0.097
0.097

mm

TOTAL
MATL
COILS

2.8
2.7
3.8
3.2
2.7
3.5
1.3
2.0
3.0
2.4
1.6
0.8
1.2
2.0
4.5
2.3
1.2
1.1
1.2
0.8
1.3
1.6
2.3
2.8
1.3
1.2
2.3
4.0
1.6
1.8
1.5
1.5
5.2
2.3
1.3
2.3
2.8
2.0
3.0
3.8
1.5
3.2
2.4
2.0
2.0
1.4
2.0
2.0
2.3
3.2
1.1
2.2
1.1
4.7
0.8
0.9
2.7
3.2
1.6
1.0
2.6
1.1
3.4
2.0
1.7
3.0
1.9
2.9
2.7
2.0
4.5
2.3
2.4
1.6
2.3
0.5
1.3
1.5
2.5
2.5

22.5
24.5
46.0
40.0
46.5
11.5
3.00
3.00
3.00
2.75
6.00
4.50
3.50
3.75
3.75
7.00
6.00
3.00
3.75
6.00
4.00
5.00
6.00
6.50
4.00
5.75
6.00
6.00
5.00
5.00
6.00
6.00
7.00
8.50
6.50
8.00
11.5
7.00
8.50
8.00
7.00
9.50
9.00
9.00
8.00
12.5
11.3
11.0
11.8
12.0
9.00
11.0
12.0
12.5
14.0
14.0
10.0
14.0
12.0
12.0
18.0
12.0
15.0
15.0
15.3
17.0
18.0
20.0
21.0
19.5
25.0
27.0
34.3
55.5
32.0
3.00
3.50
3.00
5.00
5.00

SPR
SPR
SPR
SPR
SPR
0T
SPR
SPR
SST
SST
SST
SST
SPR
SST
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SST
SST
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SST
SST
SST
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
MW
SPR
SPR
SST
MW

E
N
D
S

CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
CL
CG
C
CG
C
CG
CG

F
N
S
H

Z
Z
Z
N
Z
N
Z
Z
N
N
N
N
Z
N
Z
N
Z
N
N
Z
Z
N
N
N
Z
Z
GI
Z
Z
GI
Z
N
Z
N
N
Z
N
N
N
N
Z
N
Z
N
Z
GI
GI
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
GI
N
N
Z
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

165

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 166

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.843
0.850
0.850
0.850
0.850
0.850

21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.41
21.59
21.59
21.59
21.59
21.59

11530
4310
S-371
XX-54
S-226
PP-48
S-150
S-1155
10028
S-255
S-1627
12668
12674
B15-22
B6-47
MM-56
QQ-59
11139
M-23
S-882
K-63
3095
2892
MM-12
S-77
11995
S-807
11784
10821
3168
1649
3214
B12-64
12612
S-54
S-1483
1775
1569
S-1478
S-3001
10703
S-824
B12-37
12613
S-82
JJ-54
MM-55
S-66
11949
10239
S-3258
11781
3501
11185
2842
B10-9
3266
11902
S-201
3388
B17-191
12246
1567
S-1631
11350
12511
S-1136
12101
10979
10541
2752
11967
3131
S-3212
3405
72136
72136S
72146
72146S
72162

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

.69
.69
.75
.81
.91
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.03
1.06
1.09
1.13
1.19
1.25
1.25
1.25
1.25
1.28
1.28
1.38
1.38
1.41
1.41
1.41
1.47
1.50
1.50
1.50
1.50
1.50
1.56
1.59
1.63
1.63
1.63
1.75
1.75
2.00
2.00
2.00
2.00
2.03
2.06
2.09
2.19
2.25
2.28
2.44
2.47
2.50
2.50
2.75
2.81
3.00
3.00
3.00
3.25
3.25
3.28
3.50
3.67
3.75
4.56
4.66
4.69
4.88
4.91
5.13
7.13
11.0
.75
.75
.75
.75
.75

mm

17.4
17.4
19.1
20.6
23.0
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
26.2
27.0
27.8
28.6
30.2
31.8
31.8
31.8
31.8
32.5
32.5
34.9
34.9
35.7
35.7
35.7
37.3
38.1
38.1
38.1
38.1
38.1
39.7
40.5
41.3
41.3
41.3
44.5
44.5
50.8
50.8
50.8
50.8
51.6
52.4
53.2
55.6
57.2
57.9
61.9
62.7
63.5
63.5
69.9
71.4
76.2
76.2
76.2
82.6
82.6
83.3
88.9
93.3
95.3
115.9
118.3
119.0
123.8
124.6
130.2
181.0
279.4
19.1
19.1
19.1
19.1
19.1

MATERIAL: MW - Music Wire

166

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.575
.573
.657
.683
.665
.783
.749
.719
.703
.693
.673
.659
.659
.723
.723
.723
.699
.661
.775
.713
.707
.693
.683
.663
.761
.715
.683
.647
.583
.735
.731
.715
.713
.683
.623
.683
.715
.763
.727
.719
.735
.683
.661
.643
.603
.503
.603
.603
.517
.661
.703
.525
.699
.633
.709
.697
.633
.579
.717
.673
.589
.731
.699
.649
.709
.727
.659
.737
.593
.583
.683
.663
.627
.701
.679
.750
.750
.740
.740
.716

RATE
mm

14.6
14.6
16.7
17.3
16.9
19.9
19.0
18.3
17.9
17.6
17.1
16.7
16.7
18.4
18.4
18.4
17.8
16.8
19.7
18.1
18.0
17.6
17.3
16.8
19.3
18.2
17.3
16.4
14.8
18.7
18.6
18.2
18.1
17.3
15.8
17.3
18.2
19.4
18.5
18.3
18.7
17.3
16.8
16.3
15.3
12.8
15.3
15.3
13.1
16.8
17.9
13.3
17.8
16.1
18.0
17.7
16.1
14.7
18.2
17.1
15.0
18.6
17.8
16.5
18.0
18.5
16.7
18.7
15.1
14.8
17.3
16.8
15.9
17.8
17.2
19.1
19.1
18.8
18.8
18.2

Lbs./In.

N/mm

743 130
1076 188
111
19
77
13
37
6.4
.96
.17
4.0
.71
19
3.4
37
6.5
26
4.6
56
9.7
81
14
108
19
17
3.0
19
3.4
9.1
1.6
18
3.2
77
14
1.2
.21
16
2.9
17
2.9
27
4.7
27
4.8
44
7.6
2.1
.37
7.3
1.3
29
5.0
71
12
227
40
5.0
.87
7.3
1.3
17
3.0
12
2.1
33
5.8
124
22
18
3.1
6.2
1.1
2.0
.36
5.8
1.0
10
1.8
5.9
1.0
14
2.5
39
6.8
58
10
110
19
499
87
93
16
112
20
409
72
66
12
11
1.9
364
64
12
2.1
62
11
7.1
1.2
12
2.2
51
9.0
110
19
5.2
.91
16
2.7
72
13
3.9
.68
9.4
1.6
26
4.5
5.5
.96
4.1
.71
14
2.5
.85
.15
49
8.5
58
10
4.7
.82
9.2
1.6
27
4.8
3.2
.56
4.1
.72
13
2.3
11
1.9
18
3.2
15
2.7
34
6.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.05
1.3
.08
2.0
.26
6.6
.25
6.4
.28
7.2
.88 22
.72 18
.50 13
.37
9.5
.60 15
.42 11
.52 13
.39
9.9
.51 13
.48 12
.72 18
.69 18
.38
9.6
1.0
27
.68 17
.82 21
.64 16
.73 19
.60 15
1.1
28
.80 20
.67 17
.51 13
.34
8.7
1.1
28
1.0
27
.66 17
.98 25
.63 16
.36
9.2
.88 22
.94 24
1.4
35
1.2
31
.94 24
1.2
30
.95 24
.75 19
.92 23
.53 13
.29
7.4
.62 16
.52 13
.31
8.0
.44 11
1.2
30
.33
8.4
1.7
44
.71 18
1.8
45
1.3
33
.87 22
.73 19
2.0
50
1.6
40
.94 24
2.0
50
1.6
41
1.3
32
2.2
56
2.9
73
2.0
50
3.1
80
1.5
37
1.3
34
2.5
62
2.6
65
1.8
45
4.3 108
5.5 138
.58 15
.46 12
.55 14
.44 11
.50 13

Lbs.

38
86
29
19
10
.85
2.9
9.7
14
16
23
42
42
8.8
9.3
6.6
13
29
1.3
11
14
17
20
26
2.4
5.8
19
36
78
5.4
7.6
11
12
21
45
16
5.8
2.8
7.1
9.7
6.8
14
29
54
58
145
58
58
128
29
13
120
21
44
13
16
44
81
10
25
68
7.6
15
33
12
12
28
2.7
71
78
12
24
48
14
22
7.5
5.1
9.9
6.7
17

ENDS: C - Closed

G - Ground
O - Open

167
385
128
87
46
3.8
13
43
62
70
103
187
187
39
42
29
56
130
5.6
50
60
76
88
116
10
26
87
161
345
24
34
50
53
92
199
70
26
12
32
43
30
61
130
239
257
643
257
257
571
130
58
532
92
197
56
70
197
361
45
110
303
34
68
145
54
52
124
12
317
345
51
105
214
61
99
33
23
44
30
76

Inches

.64
.44
.37
.28
.62
.12
.28
.25
.28
.40
.49
.46
.39
.24
.30
.38
.43
.55
.20
.32
.41
.43
.55
.59
.26
.58
.48
.64
.91
.38
.39
.38
.49
.48
.63
.68
.66
.26
.41
.36
.39
.80
.82
.90
1.11
1.53
1.14
.99
1.47
.50
.56
1.43
.72
.95
.72
.68
1.10
1.72
.69
1.11
1.84
.53
.86
1.21
.80
.60
1.56
1.43
2.69
2.80
2.42
2.34
2.16
1.70
3.12
.17
.17
.19
.19
.25

mm

16.2
11.1
9.4
7.1
15.8
3.0
7.2
6.3
7.1
10.2
12.4
11.7
9.9
6.1
7.6
9.5
11.0
13.9
5.2
8.0
10.4
11.0
14.0
14.9
6.5
14.6
12.2
16.2
23.1
9.6
10.0
9.8
12.4
12.2
16.1
17.3
16.7
6.6
10.3
9.1
10.0
20.3
20.8
22.9
28.2
38.9
29.0
25.1
37.3
12.7
14.2
36.3
18.3
24.0
18.3
17.2
28.0
43.6
17.6
28.1
46.8
13.5
21.9
30.8
20.4
15.1
39.7
36.3
68.3
71.0
61.5
59.4
54.9
43.3
79.1
4.3
4.3
4.9
4.9
6.4

WIRE DIA.
Inches

0.134
0.135
0.093
0.080
0.089
0.030
0.047
0.062
0.070
0.075
0.085
0.092
0.092
0.060
0.060
0.060
0.072
0.091
0.034
0.065
0.068
0.075
0.080
0.090
0.041
0.064
0.080
0.098
0.130
0.054
0.056
0.064
0.065
0.080
0.110
0.080
0.064
0.040
0.058
0.062
0.054
0.080
0.091
0.100
0.120
0.170
0.120
0.120
0.163
0.091
0.070
0.159
0.072
0.105
0.067
0.073
0.105
0.132
0.063
0.085
0.127
0.056
0.072
0.097
0.067
0.058
0.092
0.053
0.125
0.130
0.080
0.090
0.108
0.071
0.082
0.050
0.050
0.055
0.055
0.067

mm

TOTAL
MATL
COILS

3.4
3.4
2.4
2.0
2.3
0.8
1.2
1.6
1.8
1.9
2.2
2.3
2.3
1.5
1.5
1.5
1.8
2.3
0.9
1.7
1.7
1.9
2.0
2.3
1.0
1.6
2.0
2.5
3.3
1.4
1.4
1.6
1.7
2.0
2.8
2.0
1.6
1.0
1.5
1.6
1.4
2.0
2.3
2.5
3.0
4.3
3.0
3.0
4.1
2.3
1.8
4.0
1.8
2.7
1.7
1.9
2.7
3.4
1.6
2.2
3.2
1.4
1.8
2.5
1.7
1.5
2.3
1.3
3.2
3.3
2.0
2.3
2.7
1.8
2.1
1.3
1.3
1.4
1.4
1.7

3.75
3.25
4.00
3.50
7.00
4.00
5.00
4.00
4.00
5.33
4.75
5.00
4.25
4.00
4.00
6.25
6.00
5.00
5.00
5.00
6.00
5.75
7.00
6.50
5.25
9.00
6.00
6.50
7.00
7.00
6.00
5.00
6.50
6.00
5.75
8.50
10.3
5.50
7.00
5.75
6.25
10.0
8.00
8.00
8.25
9.00
9.50
8.25
9.00
5.50
8.00
9.00
9.00
9.00
10.8
9.25
10.5
13.0
10.0
13.0
14.5
9.50
11.0
12.5
12.0
10.3
17.0
26.0
21.5
21.5
30.3
26.0
20.0
24.0
38.0
3.38
3.38
3.50
3.50
3.75

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SST
SST
SST
SST
SST
SST
SPR
SST
SST
MW
MW
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SST
SST
SPR
SST
SPR
MW
SST
SST
SST
SST
SST
SPR
SST
SST
MW
HD
HD
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SST
SST
MW
SST
SST
HD
SPR
HD
SPR
SPR
SST
SPR
MW
SST
MW
SST
MW

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

Z
Z
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
Z
N
N
GI
Z
Z
N
N
Z
N
N
Z
Z
Z
Z
N
Z
N
N
Z
Z
N
N
Z
N
N
N
N
N
N
N
N
Z
N
N
Z
Z
Z
BO
Z
N
N
Z
N
Z
Z
N
N
T1
N
N
Z
Z
Z
Z
Z
N
Z
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 167

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850

21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59

72162S
72172
72172S
72210
72210S
72233
72233S
72246
72246S
72137
72137S
72147
72147S
72163
72163S
72173
72173S
72186
72186S
72195
72195S
72212
72212S
72234
72234S
72247
72247S
72262
72262S
72276
72276S
72138
72138S
72148
72148S
72164
72164S
72174
72174S
72187
72187S
72196
72196S
72214
72214S
72235
72235S
72248
72248S
72264
72264S
72277
72277S
72287
72287S
72297
72297S
72308
72308S
72139
72139S
72149
72149S
72165
72165S
72175
72175S
72188
72188S
72197
72197S
72216
72216S
72236
72236S
72249
72249S
72266
72266S
72278

.75
.75
.75
.75
.75
.75
.75
.75
.75
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8

I.D.
Inches

.716
.714
.714
.690
.690
.688
.688
.680
.680
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666

RATE
mm

18.2
18.1
18.1
17.5
17.5
17.5
17.5
17.3
17.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

29
36
31
67
57
68
58
84
71
11
9.2
15
13
28
24
30
25
41
35
40
34
55
47
57
48
67
57
90
76
90
77
9.4
8.0
13
11
24
21
26
22
35
30
34
29
47
40
48
41
59
50
76
65
77
65
100
85
125
106
135
115
7.3
6.2
10
8.6
19
16
20
17
27
23
27
23
36
31
37
32
45
38
58
49
59

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

5.1
6.3
5.3
12
9.9
12
10
15
12
1.9
1.6
2.6
2.2
5.0
4.2
5.2
4.4
7.1
6.0
7.0
6.0
9.6
8.2
9.9
8.4
12
10
16
13
16
13
1.6
1.4
2.3
1.9
4.3
3.6
4.5
3.8
6.1
5.2
6.0
5.1
8.2
7.0
8.4
7.1
10
8.8
13
11
13
11
18
15
22
19
24
20
1.3
1.1
1.8
1.5
3.3
2.8
3.5
2.9
4.7
4.0
4.6
3.9
6.3
5.4
6.5
5.6
7.8
6.7
10
8.7
10

Inches

.42
.50
.41
.43
.34
.43
.35
.41
.32
.69
.55
.66
.52
.60
.50
.60
.50
.52
.41
.57
.45
.52
.41
.53
.42
.50
.41
.45
.35
.45
.36
.80
.64
.77
.61
.70
.58
.69
.58
.60
.48
.65
.53
.62
.49
.61
.49
.58
.46
.53
.41
.53
.42
.50
.39
.43
.33
.46
.36
1.0
.81
.98
.78
.90
.75
.89
.75
.79
.62
.84
.68
.80
.63
.79
.63
.76
.61
.69
.54
.70

mm

11
13
11
11
8.6
11
8.8
10
8.2
17
14
17
13
15
13
15
13
13
10
14
11
13
10
13
11
13
10
11
8.9
12
9.2
20
16
19
15
18
15
18
15
15
12
16
13
16
12
15
12
15
12
14
11
13
11
13
9.9
11
8.5
12
9.0
26
21
25
20
23
19
23
19
20
16
21
17
20
16
20
16
19
15
18
14
18

ENDS: C - Closed

G - Ground
O - Open

Lbs.

12
18
13
29
19
29
20
34
23
7.5
5.1
9.9
6.7
17
12
18
13
21
14
23
15
29
19
30
20
33
23
40
27
41
28
7.5
5.1
9.9
6.7
17
12
18
13
21
14
22
15
29
19
29
20
34
23
40
27
41
28
50
33
53
35
62
41
7.5
5.1
9.9
6.7
17
12
18
13
21
14
22
15
29
19
30
20
34
23
40
27
41

54
79
56
128
86
128
89
153
103
33
23
44
30
76
54
79
56
94
63
101
68
128
86
132
89
148
103
180
119
182
123
33
23
44
30
76
54
79
56
94
63
99
68
128
86
129
89
153
103
180
119
181
123
222
148
237
157
274
181
33
23
44
30
75
54
79
56
94
63
99
68
128
86
132
89
152
103
180
119
183

Inches

.25
.26
.26
.31
.31
.32
.32
.34
.34
.18
.18
.21
.21
.28
.28
.28
.28
.29
.29
.31
.31
.35
.35
.35
.35
.38
.38
.41
.41
.43
.43
.19
.19
.22
.22
.30
.30
.31
.31
.32
.32
.35
.35
.38
.38
.39
.39
.41
.41
.46
.46
.47
.47
.50
.50
.48
.48
.54
.54
.22
.22
.25
.25
.35
.35
.36
.36
.36
.36
.41
.41
.45
.45
.46
.46
.49
.49
.53
.53
.55

mm

Inches

6.4
6.5
6.5
7.9
7.9
8.2
8.2
8.6
8.6
4.6
4.6
5.2
5.2
7.0
7.0
7.1
7.1
7.3
7.3
8.0
8.0
8.9
8.9
9.0
9.0
9.7
9.7
10.4
10.4
10.8
10.8
4.9
4.9
5.6
5.6
7.7
7.7
7.8
7.8
8.0
8.0
8.9
8.9
9.7
9.7
10.0
10.0
10.5
10.5
11.6
11.6
12.0
12.0
12.8
12.8
12.1
12.1
13.7
13.7
5.6
5.6
6.5
6.5
8.9
8.9
9.1
9.1
9.1
9.1
10.3
10.3
11.4
11.4
11.6
11.6
12.4
12.4
13.6
13.6
14.0

0.067
0.068
0.068
0.080
0.080
0.081
0.081
0.085
0.085
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092

mm

1.7
1.7
1.7
2.0
2.0
2.1
2.1
2.2
2.2
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3

TOTAL
MATL
COILS
3.75
3.75
3.75
3.88
3.88
4.00
4.00
4.00
4.00
3.63
3.63
3.75
3.75
4.13
4.13
4.13
4.13
4.00
4.00
4.25
4.25
4.38
4.38
4.38
4.38
4.50
4.50
4.50
4.50
4.63
4.63
3.88
3.88
4.00
4.00
4.50
4.50
4.50
4.50
4.38
4.38
4.75
4.75
4.75
4.75
4.88
4.88
4.88
4.88
5.00
5.00
5.13
5.13
5.13
5.13
4.75
4.75
5.13
5.13
4.38
4.38
4.63
4.63
5.25
5.25
5.25
5.25
5.00
5.00
5.50
5.50
5.63
5.63
5.63
5.63
5.75
5.75
5.88
5.88
6.00

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

167

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 168

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850

21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59

72278S
72288
72288S
72298
72298S
72310
72310S
72237
72237S
72250
72250S
72140
72140S
72150
72150S
72166
72166S
72176
72176S
72189
72189S
72198
72198S
72218
72218S
72238
72238S
72251
72251S
72267
72267S
72279
72279S
72289
72289S
72299
72299S
72312
72312S
72152
72152S
72177
72177S
72190
72190S
72200
72200S
72220
72220S
72239
72239S
72252
72252S
72268
72268S
72280
72280S
72290
72290S
72300
72300S
72314
72314S
72141
72141S
72153
72153S
72167
72167S
72178
72178S
72191
72191S
72201
72201S
72222
72222S
72240
72240S
72253

1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

31.8
31.8
31.8
31.8
31.8
31.8
31.8
35.1
35.1
35.1
35.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8

MATERIAL: MW - Music Wire

168

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.666
.654
.654
.650
.650
.640
.640
.688
.688
.680
.680
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.740
.740
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680

RATE
mm

16.9
16.6
16.6
16.5
16.5
16.3
16.3
17.5
17.5
17.3
17.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
18.8
18.8
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

50
77
65
95
81
103
87
34
29
42
36
6.0
5.1
8.3
7.1
15
13
16
14
22
19
22
18
29
25
30
26
37
31
49
42
48
41
63
53
77
65
83
70
7.1
6.0
14
12
18
16
19
16
25
21
26
22
31
26
41
35
40
34
53
45
64
55
69
59
4.4
3.8
6.1
5.2
11
9.6
12
10
16
14
16
13
21
18
22
19
26

8.8
13
11
17
14
18
15
6.0
5.1
7.4
6.3
1.1
.90
1.5
1.2
2.7
2.3
2.8
2.4
3.8
3.2
3.8
3.2
5.1
4.4
5.3
4.5
6.4
5.5
8.6
7.3
8.4
7.1
11
9.4
13
11
14
12
1.2
1.1
2.4
2.0
3.2
2.7
3.3
2.8
4.3
3.7
4.5
3.8
5.4
4.6
7.2
6.1
7.0
6.0
9.2
7.8
11
9.6
12
10
.78
.66
1.1
.91
2.0
1.7
2.1
1.8
2.8
2.4
2.8
2.4
3.7
3.2
3.8
3.2
4.6

.55
.65
.51
.56
.44
.60
.47
.88
.69
.82
.65
1.2
.99
1.2
.95
1.1
.92
1.1
.92
.97
.76
1.0
.83
.98
.77
.97
.78
.94
.74
.83
.64
.86
.68
.80
.62
.69
.54
.74
.58
1.4
1.1
1.3
1.1
1.1
.91
1.2
.95
1.2
.92
1.2
.92
1.1
.88
.99
.77
1.0
.81
.96
.75
.83
.65
.89
.69
1.7
1.3
1.6
1.3
1.5
1.3
1.5
1.3
1.3
1.0
1.4
1.1
1.3
1.1
1.3
1.1
1.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

14
17
13
14
11
15
12
22
18
21
16
32
25
30
24
28
23
28
23
25
19
26
21
25
20
25
20
24
19
21
16
22
17
20
16
18
14
19
15
36
28
33
28
29
23
31
24
30
23
29
23
28
22
25
20
26
21
24
19
21
16
23
18
43
34
41
33
38
32
38
32
33
26
36
29
34
27
34
27
33

Lbs.

28
50
33
53
35
62
41
30
20
34
23
7.5
5.1
9.9
6.7
17
12
18
13
21
14
22
15
29
19
30
20
34
23
40
27
41
28
50
33
53
35
62
41
9.9
6.7
18
13
21
14
23
15
29
19
29
20
34
23
40
27
41
28
50
33
53
35
62
41
7.5
5.1
9.9
6.7
17
12
18
13
21
14
22
15
29
19
29
20
34

ENDS: C - Closed

G - Ground
O - Open

123
222
148
237
157
274
181
133
89
153
103
33
23
44
30
76
54
78
56
94
63
100
68
128
86
131
89
153
103
180
119
182
123
224
148
237
157
274
181
44
30
78
56
94
63
102
68
128
86
131
89
153
103
180
119
182
123
224
148
237
157
274
181
33
23
44
30
75
54
78
56
94
63
100
68
128
86
129
89
151

Inches

.55
.60
.60
.56
.56
.64
.64
.49
.49
.51
.51
.24
.24
.28
.28
.39
.39
.41
.41
.41
.41
.46
.46
.51
.51
.53
.53
.56
.56
.60
.60
.64
.64
.69
.69
.65
.65
.75
.75
.32
.32
.46
.46
.47
.47
.51
.51
.58
.58
.60
.60
.63
.63
.68
.68
.72
.72
.77
.77
.73
.73
.85
.85
.30
.30
.34
.34
.49
.49
.51
.51
.51
.51
.58
.58
.64
.64
.67
.67
.71

mm

14.0
15.2
15.2
14.3
14.3
16.3
16.3
12.3
12.3
13.0
13.0
6.2
6.2
7.2
7.2
10.0
10.0
10.4
10.4
10.5
10.5
11.7
11.7
13.0
13.0
13.4
13.4
14.3
14.3
15.3
15.3
16.4
16.4
17.4
17.4
16.5
16.5
19.0
19.0
8.0
8.0
11.7
11.7
11.9
11.9
12.9
12.9
14.7
14.7
15.2
15.2
15.9
15.9
17.3
17.3
18.4
18.4
19.6
19.6
18.4
18.4
21.7
21.7
7.6
7.6
8.7
8.7
12.6
12.6
13.0
13.0
13.0
13.0
14.8
14.8
16.3
16.3
17.0
17.0
18.1

WIRE DIA.
Inches

mm

0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.081
0.081
0.085
0.085
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.055
0.055
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085

2.3
2.5
2.5
2.5
2.5
2.7
2.7
2.1
2.1
2.2
2.2
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
1.4
1.4
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2

FINISH: Z - Zinc

TOTAL
MATL
COILS
6.00
6.13
6.13
5.63
5.63
6.13
6.13
6.00
6.00
6.00
6.00
4.88
4.88
5.13
5.13
5.88
5.88
6.00
6.00
5.75
5.75
6.25
6.25
6.38
6.38
6.50
6.50
6.63
6.63
6.63
6.63
7.00
7.00
7.00
7.00
6.50
6.50
7.13
7.13
5.75
5.75
6.75
6.75
6.50
6.50
6.88
6.88
7.25
7.25
7.38
7.38
7.38
7.38
7.50
7.50
7.88
7.88
7.88
7.88
7.25
7.25
8.13
8.13
6.00
6.00
6.25
6.25
7.38
7.38
7.50
7.50
7.13
7.13
7.88
7.88
8.00
8.00
8.25
8.25
8.38

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 169

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850

21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59

72253S
72269
72269S
72281
72281S
72291
72291S
72301
72301S
72316
72316S
72155
72155S
72179
72179S
72203
72203S
72224
72224S
72241
72241S
72254
72254S
72270
72270S
72282
72282S
72292
72292S
72302
72302S
72318
72318S
72142
72142S
72156
72156S
72168
72168S
72180
72180S
72192
72192S
72204
72204S
72226
72226S
72242
72242S
72255
72255S
72271
72271S
72283
72283S
72293
72293S
72303
72303S
72320
72320S
72158
72158S
72182
72182S
72206
72206S
72228
72228S
72243
72243S
72256
72256S
72272
72272S
72284
72284S
72294
72294S
72304

2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9

I.D.
Inches

.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.740
.740
.714
.714
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.740
.740
.714
.714
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650

RATE
mm

17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
18.8
18.8
18.1
18.1
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
18.8
18.8
18.1
18.1
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

22
35
30
35
29
45
38
55
47
60
51
5.4
4.6
10
8.8
14
12
19
16
19
16
23
20
31
26
30
26
39
33
49
41
52
44
3.5
3.0
4.8
4.1
8.9
7.6
9.3
7.9
12
11
12
11
17
14
17
15
21
18
28
24
27
23
35
30
43
37
47
40
4.4
3.7
8.7
7.4
12
9.9
15
13
15
13
19
16
25
21
24
21
32
27
39

3.9
6.1
5.2
6.0
5.1
7.9
6.7
9.7
8.2
10
8.9
.95
.80
1.8
1.5
2.5
2.1
3.3
2.8
3.4
2.9
4.1
3.5
5.4
4.6
5.3
4.5
6.9
5.8
8.5
7.2
9.2
7.8
.61
.52
.85
.72
1.6
1.3
1.6
1.4
2.2
1.9
2.2
1.8
2.9
2.5
3.0
2.6
3.7
3.1
4.9
4.2
4.7
4.0
6.2
5.2
7.6
6.5
8.2
6.9
.77
.65
1.5
1.3
2.0
1.7
2.7
2.3
2.7
2.3
3.3
2.8
4.4
3.7
4.3
3.6
5.6
4.7
6.9

1.0
1.2
.90
1.2
.94
1.1
.87
.96
.75
1.0
.80
1.8
1.5
1.7
1.4
1.6
1.3
1.5
1.2
1.5
1.2
1.5
1.2
1.3
1.0
1.4
1.1
1.3
1.0
1.1
.85
1.2
.92
2.1
1.7
2.1
1.6
1.9
1.6
1.9
1.6
1.7
1.3
1.8
1.5
1.7
1.4
1.7
1.4
1.7
1.3
1.4
1.1
1.5
1.2
1.4
1.1
1.2
.96
1.3
1.0
2.3
1.8
2.1
1.7
2.0
1.6
1.9
1.5
1.9
1.5
1.8
1.4
1.6
1.3
1.7
1.3
1.6
1.2
1.4

mm

26
29
23
30
24
28
22
24
19
26
20
47
37
43
36
40
32
39
31
39
31
37
30
33
26
34
27
32
25
28
22
30
23
54
43
52
42
49
41
48
41
43
34
46
37
44
34
43
35
42
33
37
29
38
31
36
28
31
24
34
26
57
46
54
43
50
39
48
38
48
39
46
36
41
32
42
34
40
31
35

ENDS: C - Closed

G - Ground
O - Open

Lbs.

23
40
27
41
28
50
33
53
35
62
41
9.9
6.7
18
13
23
15
29
19
29
20
34
23
40
27
41
28
50
33
53
35
62
41
7.5
5.1
9.9
6.7
17
12
18
13
21
14
22
15
29
19
29
20
34
23
40
27
41
28
50
33
53
35
62
41
9.9
6.7
18
13
23
15
29
19
29
20
34
23
40
27
41
28
50
33
53

103
180
119
182
123
224
148
237
157
274
181
44
30
79
56
102
68
128
86
131
89
153
103
180
119
183
123
224
148
237
157
274
181
33
23
44
30
76
54
78
56
94
63
99
68
128
86
130
89
153
103
180
119
182
123
224
148
237
157
274
181
44
30
82
56
102
68
128
86
129
89
153
103
180
119
181
123
224
148
237

Inches

.71
.77
.77
.82
.82
.87
.87
.81
.81
.96
.96
.38
.38
.55
.55
.62
.62
.71
.71
.73
.73
.78
.78
.84
.84
.90
.90
.97
.97
.90
.90
1.06
1.06
.35
.35
.41
.41
.59
.59
.60
.60
.62
.62
.70
.70
.77
.77
.80
.80
.85
.85
.91
.91
.99
.99
1.07
1.07
.99
.99
1.17
1.17
.44
.44
.64
.64
.74
.74
.84
.84
.87
.87
.92
.92
1.00
1.00
1.08
1.08
1.15
1.15
1.08

mm

Inches

18.1
19.6
19.6
20.7
20.7
22.1
22.1
20.6
20.6
24.3
24.3
9.6
9.6
14.0
14.0
15.7
15.7
18.0
18.0
18.5
18.5
19.7
19.7
21.4
21.4
22.8
22.8
24.6
24.6
22.9
22.9
27.0
27.0
8.9
8.9
10.3
10.3
14.9
14.9
15.3
15.3
15.8
15.8
17.9
17.9
19.6
19.6
20.3
20.3
21.6
21.6
23.1
23.1
25.1
25.1
27.1
27.1
25.1
25.1
29.7
29.7
11.2
11.2
16.2
16.2
18.8
18.8
21.3
21.3
22.1
22.1
23.5
23.5
25.4
25.4
27.5
27.5
29.2
29.2
27.3

0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.055
0.055
0.068
0.068
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.055
0.055
0.068
0.068
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100

mm

TOTAL
MATL
COILS

2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
1.4
1.4
1.7
1.7
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
1.4
1.4
1.7
1.7
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5

8.38
8.50
8.50
8.88
8.88
8.88
8.88
8.13
8.13
9.13
9.13
6.88
6.88
8.13
8.13
8.38
8.38
8.88
8.88
9.00
9.00
9.13
9.13
9.25
9.25
9.75
9.75
9.88
9.88
9.00
9.00
10.1
10.1
7.00
7.00
7.38
7.38
8.75
8.75
8.88
8.88
8.63
8.63
9.50
9.50
9.63
9.63
9.88
9.88
10.0
10.0
10.0
10.0
10.8
10.8
10.9
10.9
9.88
9.88
11.1
11.1
8.00
8.00
9.38
9.38
10.0
10.0
10.5
10.5
10.8
10.8
10.9
10.9
11.0
11.0
11.8
11.8
11.8
11.8
10.8

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

169

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 170

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.850
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859

21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.59
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82

72304S
72322
72322S
72143
72143S
72159
72159S
72169
72169S
72183
72183S
72193
72193S
72207
72207S
72230
72230S
72244
72244S
72257
72257S
72273
72273S
72285
72285S
72295
72295S
72305
72305S
72324
72324S
72258
72258S
72144
72144S
72160
72160S
72170
72170S
72184
72184S
72194
72194S
72208
72208S
72232
72232S
72245
72245S
72259
72259S
72275
72275S
72286
72286S
72296
72296S
72306
72306S
72326
72326S
72145
72145S
72161
72161S
72171
72171S
72185
72185S
72260
72260S
12624
G-1
GG-83
3786
B4-22
S-915
II-85
1581
AA-59

2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.25
3.25
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
.31
.41
.44
.50
.53
.56
.63
.63
.63

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
82.6
82.6
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
7.9
10.3
11.1
12.7
13.5
14.3
15.9
15.9
15.9

MATERIAL: MW - Music Wire

170

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.650
.640
.640
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.680
.680
.750
.750
.740
.740
.716
.716
.714
.714
.706
.706
.702
.702
.690
.690
.688
.688
.680
.680
.668
.668
.666
.666
.654
.654
.650
.650
.640
.640
.750
.750
.740
.740
.716
.716
.714
.714
.680
.680
.673
.673
.675
.675
.759
.751
.715
.649
.619

RATE
mm

16.5
16.3
16.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
17.3
17.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.9
17.9
17.8
17.8
17.5
17.5
17.5
17.5
17.3
17.3
17.0
17.0
16.9
16.9
16.6
16.6
16.5
16.5
16.3
16.3
19.1
19.1
18.8
18.8
18.2
18.2
18.1
18.1
17.3
17.3
17.1
17.1
17.1
17.1
19.3
19.1
18.2
16.5
15.7

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

33
42
36
2.9
2.5
4.0
3.4
7.3
6.2
7.7
6.5
10
8.8
10
8.7
14
12
14
12
17
15
23
20
22
19
29
25
36
30
38
32
15
13
2.5
2.1
3.4
2.9
6.3
5.3
6.5
5.5
8.8
7.5
8.7
7.4
12
10
12
10
15
12
19
16
19
16
25
21
30
26
32
28
2.2
1.8
3.0
2.5
5.5
4.6
5.7
4.8
13
11
319
277
318
228
11
18
34
272
369

5.8
7.4
6.3
.51
.43
.70
.60
1.3
1.1
1.3
1.1
1.8
1.5
1.8
1.5
2.4
2.1
2.5
2.1
3.0
2.6
4.0
3.4
3.9
3.3
5.1
4.3
6.2
5.3
6.7
5.7
2.7
2.3
.43
.37
.60
.51
1.1
.93
1.1
.97
1.5
1.3
1.5
1.3
2.1
1.8
2.1
1.8
2.6
2.2
3.3
2.8
3.3
2.8
4.3
3.7
5.3
4.5
5.7
4.8
.38
.32
.52
.44
.95
.81
1.0
.85
2.2
1.9
56
49
56
40
2.0
3.2
6.0
48
65

1.1
1.5
1.1
2.6
2.0
2.5
2.0
2.3
1.9
2.3
1.9
2.0
1.6
2.2
1.8
2.1
1.6
2.1
1.7
2.0
1.6
1.8
1.4
1.8
1.5
1.7
1.4
1.5
1.2
1.6
1.3
2.1
1.8
3.0
2.4
2.9
2.3
2.7
2.3
2.7
2.3
2.4
1.9
2.6
2.1
2.4
1.9
2.4
2.0
2.4
1.9
2.2
1.7
2.2
1.7
2.0
1.6
1.8
1.4
1.9
1.5
3.5
2.8
3.3
2.7
3.1
2.6
3.1
2.6
2.7
2.1
.06
.10
.09
.13
.36
.34
.34
.15
.15

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

27
37
29
65
52
63
50
59
49
58
49
52
41
56
45
53
41
53
42
50
40
45
35
47
37
44
34
38
30
41
32
54
45
77
61
74
59
69
58
68
58
61
48
65
53
62
49
61
50
60
47
55
43
55
44
52
40
45
35
48
38
88
70
85
68
79
66
79
66
69
54
1.4
2.6
2.2
3.3
9.0
8.6
8.6
3.9
3.7

Lbs.

35
62
41
7.5
5.1
9.9
6.7
17
12
18
13
21
14
22
15
29
19
29
20
34
23
40
27
41
28
50
33
53
35
62
41
33
23
7.5
5.1
9.9
6.7
17
12
18
13
21
14
22
15
29
19
29
20
34
23
40
27
41
28
50
33
53
35
62
41
7.5
5.1
9.9
6.7
17
12
18
13
34
23
18
28
27
30
4.0
6.2
12
41
54

ENDS: C - Closed

G - Ground
O - Open

157
274
181
33
23
44
30
76
54
79
56
94
63
99
68
128
86
131
89
153
103
180
119
182
123
224
148
237
157
274
181
146
103
33
23
44
30
76
54
78
56
94
63
99
68
128
86
129
89
153
103
180
119
182
123
224
148
237
157
274
181
33
23
44
30
76
54
79
56
152
103
81
126
122
131
18
28
52
184
238

Inches

1.08
1.26
1.26
.40
.40
.47
.47
.69
.69
.71
.71
.71
.71
.81
.81
.90
.90
.93
.93
.99
.99
1.07
1.07
1.16
1.16
1.25
1.25
1.16
1.16
1.38
1.38
1.11
1.11
.46
.46
.53
.53
.78
.78
.81
.81
.81
.81
.93
.93
1.03
1.03
1.08
1.08
1.15
1.15
1.27
1.27
1.33
1.33
1.43
1.43
1.33
1.33
1.58
1.58
.51
.51
.60
.60
.88
.88
.90
.90
1.30
1.30
.26
.26
.24
.28
.18
.22
.29
.47
.48

mm

27.3
32.0
32.0
10.2
10.2
11.9
11.9
17.4
17.4
17.9
17.9
18.1
18.1
20.7
20.7
22.9
22.9
23.7
23.7
25.1
25.1
27.2
27.2
29.5
29.5
31.7
31.7
29.5
29.5
35.0
35.0
28.1
28.1
11.6
11.6
13.4
13.4
19.8
19.8
20.5
20.5
20.6
20.6
23.7
23.7
26.2
26.2
27.5
27.5
29.1
29.1
32.4
32.4
33.9
33.9
36.4
36.4
33.7
33.7
40.0
40.0
12.9
12.9
15.2
15.2
22.3
22.3
22.9
22.9
32.9
32.9
6.5
6.5
6.1
7.0
4.4
5.7
7.3
12.0
12.2

WIRE DIA.
Inches

0.100
0.105
0.105
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.085
0.085
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.072
0.072
0.074
0.074
0.080
0.080
0.081
0.081
0.085
0.085
0.091
0.091
0.092
0.092
0.098
0.098
0.100
0.100
0.105
0.105
0.050
0.050
0.055
0.055
0.067
0.067
0.068
0.068
0.085
0.085
0.093
0.093
0.092
0.092
0.050
0.054
0.072
0.105
0.120

mm

TOTAL
MATL
COILS

2.5
2.7
2.7
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
2.2
2.2
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
1.8
1.8
1.9
1.9
2.0
2.0
2.1
2.1
2.2
2.2
2.3
2.3
2.3
2.3
2.5
2.5
2.5
2.5
2.7
2.7
1.3
1.3
1.4
1.4
1.7
1.7
1.7
1.7
2.2
2.2
2.4
2.4
2.3
2.3
1.3
1.4
1.8
2.7
3.0

10.8
12.0
12.0
8.00
8.00
8.50
8.50
10.3
10.3
10.4
10.4
9.88
9.88
11.0
11.0
11.3
11.3
11.5
11.5
11.6
11.6
11.8
11.8
12.6
12.6
12.8
12.8
11.6
11.6
13.1
13.1
13.0
13.0
9.13
9.13
9.63
9.63
11.6
11.6
11.9
11.9
11.3
11.3
12.6
12.6
12.9
12.9
13.4
13.4
13.5
13.5
14.0
14.0
14.5
14.5
14.6
14.6
13.3
13.3
15.0
15.0
10.1
10.1
10.9
10.9
13.1
13.1
13.3
13.3
15.3
15.3
2.75
2.75
2.75
3.00
3.50
3.13
4.00
3.50
4.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SST
SST
SPR
SPR
SST
SST
SPR
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
Z
GI

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 171

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.859
0.875
0.875
0.875
0.875
0.875
0.875
0.875

21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
21.82
22.23
22.23
22.23
22.23
22.23
22.23
22.23

11710
11678
A13-35
S-345
10793
S-3091
12284
KK-85
12486
2951
B12-46
PP-92
N-55
K-50
S-185
B11-69
A15-52
11512
10148
12138
12225
12488
2773
S-1307
3864
B7-65
11776
10023
OO-53
B15-1
MM-88
S-73
TT-69
11435
10646
S-1175
3321
B8-33
B17-195
2776
10502
12465
S-459
KK-81
A13-39
10370
S-465
10829
11430
11174
S-381
11510
11953
2908
4305
11591
10935
A13-43
3770
2741
2593
11947
11829
1561
B18-189
B17-186
S-3067
3227
10464
12021
3101
12153
3075
2726
S-189
BB-86
3011
S-1022
S-1414
3271

.66
.72
.75
.75
.81
.88
.88
.88
.91
.91
1.00
1.00
1.03
1.13
1.25
1.25
1.25
1.25
1.25
1.25
1.28
1.28
1.41
1.44
1.44
1.50
1.50
1.50
1.50
1.53
1.59
1.63
1.63
1.63
1.63
1.75
1.88
1.94
1.97
2.00
2.00
2.00
2.06
2.25
2.34
2.38
2.44
2.50
2.50
2.53
2.63
2.63
2.69
2.75
2.75
2.78
2.84
3.00
3.00
3.25
3.41
3.56
3.63
3.75
4.00
4.19
4.63
4.69
5.25
5.50
6.75
8.56
9.00
.41
.41
.47
.56
.59
.63
.66

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

16.7
18.2
19.1
19.1
20.6
22.2
22.2
22.2
23.0
23.0
25.4
25.4
26.2
28.6
31.8
31.8
31.8
31.8
31.8
31.8
32.5
32.5
35.7
36.5
36.5
38.1
38.1
38.1
38.1
38.9
40.5
41.3
41.3
41.3
41.3
44.5
47.6
49.2
50.0
50.8
50.8
50.8
52.4
57.2
59.5
60.3
61.9
63.5
63.5
64.3
66.7
66.7
68.2
69.9
69.9
70.6
72.2
76.2
76.2
82.6
86.5
90.5
92.1
95.3
101.6
106.4
117.5
119.0
133.4
139.7
171.5
217.5
228.6
10.3
10.3
11.9
14.3
15.1
15.9
16.7

I.D.
Inches

.743
.677
.793
.699
.639
.757
.695
.639
.699
.669
.765
.725
.739
.735
.769
.753
.737
.731
.723
.699
.751
.699
.645
.725
.723
.735
.723
.719
.639
.779
.519
.751
.649
.609
.567
.505
.575
.651
.499
.673
.663
.619
.675
.539
.697
.709
.649
.699
.659
.641
.765
.563
.687
.669
.609
.643
.777
.767
.505
.707
.743
.735
.737
.629
.719
.771
.735
.609
.649
.785
.579
.609
.667
.765
.755
.725
.793
.779
.773
.775

RATE
mm

18.9
17.2
20.1
17.8
16.2
19.2
17.7
16.2
17.8
17.0
19.4
18.4
18.8
18.7
19.5
19.1
18.7
18.6
18.4
17.8
19.1
17.8
16.4
18.4
18.4
18.7
18.4
18.3
16.2
19.8
13.2
19.1
16.5
15.5
14.4
12.8
14.6
16.5
12.7
17.1
16.8
15.7
17.1
13.7
17.7
18.0
16.5
17.8
16.7
16.3
19.4
14.3
17.4
17.0
15.5
16.3
19.7
19.5
12.8
18.0
18.9
18.7
18.7
16.0
18.3
19.6
18.7
15.5
16.5
19.9
14.7
15.5
16.9
19.4
19.2
18.4
20.1
19.8
19.6
19.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

21
3.7
174
30
1.3
.23
28
4.8
162
28
5.3
.94
69
12
250
44
62
11
131
23
4.0
.71
25
4.4
9.1
1.6
21
3.7
1.2
.21
8.7
1.5
14
2.5
19
3.4
23
4.0
25
4.4
12
2.1
42
7.3
111
19
14
2.5
21
3.6
14
2.4
18
3.1
22
3.8
137
24
1.1
.19
667 117
3.3
.57
79
14
127
22
360
63
774 135
248
43
78
14
599 105
55
9.6
43
7.5
123
22
25
4.3
460
81
15
2.6
11
1.9
48
8.5
17
3.0
36
6.4
53
9.3
1.8
.31
202
35
24
4.3
26
4.6
83
14
58
10
.93
.16
1.6
.29
424
74
10
1.7
3.0
.53
8.4
1.5
3.5
.61
51
8.9
4.8
.85
1.0
.18
3.6
.64
45
7.9
23
4.0
.24
.04
55
9.7
32
5.6
8.4
1.5
24
4.2
30
5.2
89
16
4.0
.70
6.0
1.0
5.0
.88
16
2.8

Inches

mm

.39 10
.16
4.2
.59 15
.27
6.9
.27
6.9
.57 14
.32
8.0
.19
4.9
.33
8.3
.25
6.3
.71 18
.47 12
.67 17
.48 12
.76 19
.73 19
.63 16
.58 15
.59 15
.69 18
.57 15
.49 12
.58 15
.83 21
.64 16
.72 18
.75 19
.64 16
.32
8.2
1.2
30
.24
6.1
1.2
30
.51 13
.50 13
.30
7.5
.21
5.2
.40 10
.54 14
.26
6.6
.56 14
.83 21
.51 13
1.1
28
.29
7.5
1.4
35
1.5
38
.84 21
1.2
31
.96 24
.84 21
2.2
57
.55 14
1.0
26
1.2
31
.85 22
.82 21
2.4
61
2.6
65
.42 11
1.8
45
2.7
68
1.2
31
2.6
66
1.1
27
2.8
72
3.5
89
2.6
66
1.6
40
1.9
49
4.7 119
1.7
43
2.2
56
4.0 101
.24
6.1
.23
5.7
.19
4.7
.37
9.3
.35
9.0
.32
8.1
.33
8.3

ENDS: C - Closed

G - Ground
O - Open

Lbs.

8.3
29
.78
7.5
44
3.0
22
48
20
32
2.8
12
6.1
10
.90
6.3
9.1
11
13
17
6.7
20
64
12
13
10
13
14
44
1.3
160
3.8
40
63
107
159
98
42
155
31
36
62
27
135
20
16
40
20
35
45
3.9
111
25
32
70
47
2.2
4.2
180
18
8.1
10
9.1
55
14
3.7
9.5
70
44
1.1
94
70
33
5.7
6.8
17
1.5
2.1
1.6
5.2

37
127
3.5
33
196
14
98
215
91
144
13
53
27
45
4.0
28
40
49
59
76
30
91
286
53
59
45
59
61
196
5.7
713
17
180
282
474
709
438
188
689
136
158
277
122
601
88
72
180
91
156
200
17
493
112
144
312
210
9.9
19
799
78
36
45
40
245
61
16
42
312
194
5.1
420
312
149
26
30
74
6.5
9.4
7.1
23

Inches

mm

Inches

.20
5.2
.30
7.5
.17
4.2
.48 12.2
.52 13.3
.31
7.8
.33
8.3
.44 11.2
.40 10.2
.38
9.7
.29
7.5
.27
6.8
.36
9.1
.25
6.3
.50 12.6
.24
6.1
.30
7.6
.35
8.9
.32
8.2
.56 14.2
.27
6.9
.48 12.2
.64 16.3
.37
9.4
.41 10.4
.31
7.9
.44 11.2
.37
9.3
.58 14.7
.34
8.6
1.28 32.4
.45 11.3
.68 17.3
1.13 28.6
1.02 26.0
1.24 31.5
1.12 28.4
.73 18.5
1.62 41.1
.69 17.4
.88 22.4
.96 24.4
.92 23.4
1.28 32.5
.81 20.6
.88 22.4
.98 24.9
.75 19.0
1.00 25.4
1.09 27.7
.40 10.1
1.85 47.0
.77 19.7
1.14 29.0
1.59 40.5
1.19 30.2
.45 11.5
.39
9.9
2.21 56.2
.91 23.2
.73 18.4
.43 11.0
.73 18.6
1.61 40.9
1.16 29.3
.46 11.7
.81 20.5
2.72 69.1
2.10 53.3
.81 20.7
4.04 102.7
3.75 95.3
3.32 84.4
.17
4.2
.18
4.6
.23
5.7
.19
4.9
.24
6.1
.31
7.8
.20
5.1

0.058
0.091
0.033
0.080
0.110
0.051
0.082
0.110
0.080
0.095
0.047
0.067
0.060
0.062
0.045
0.053
0.061
0.064
0.068
0.080
0.054
0.080
0.107
0.067
0.068
0.062
0.068
0.070
0.110
0.040
0.170
0.054
0.105
0.125
0.146
0.177
0.142
0.104
0.180
0.093
0.098
0.120
0.092
0.160
0.081
0.075
0.105
0.080
0.100
0.109
0.047
0.148
0.086
0.095
0.125
0.108
0.041
0.046
0.177
0.076
0.058
0.062
0.061
0.115
0.070
0.044
0.062
0.125
0.105
0.037
0.140
0.125
0.096
0.055
0.060
0.075
0.041
0.048
0.051
0.050

mm

TOTAL
MATL
COILS

1.5
2.3
0.8
2.0
2.8
1.3
2.1
2.8
2.0
2.4
1.2
1.7
1.5
1.6
1.1
1.3
1.5
1.6
1.7
2.0
1.4
2.0
2.7
1.7
1.7
1.6
1.7
1.8
2.8
1.0
4.3
1.4
2.7
3.2
3.7
4.5
3.6
2.6
4.6
2.4
2.5
3.0
2.3
4.1
2.1
1.9
2.7
2.0
2.5
2.8
1.2
3.8
2.2
2.4
3.2
2.7
1.0
1.2
4.5
1.9
1.5
1.6
1.5
2.9
1.8
1.1
1.6
3.2
2.7
0.9
3.6
3.2
2.4
1.4
1.5
1.9
1.0
1.2
1.3
1.3

3.50
3.25
4.00
6.00
4.75
5.00
4.00
4.00
4.00
4.00
5.25
4.00
6.00
4.00
10.0
4.50
4.75
4.50
4.75
7.00
4.00
5.00
6.00
5.50
5.00
5.00
5.50
5.25
5.25
7.50
7.50
8.25
6.50
9.00
7.00
7.00
8.00
7.00
9.00
6.33
9.00
8.00
10.0
8.00
10.0
10.8
9.33
9.33
10.0
10.0
8.50
11.5
9.00
12.0
12.8
10.0
10.0
8.50
12.5
12.0
12.5
7.00
12.0
14.0
16.5
10.5
12.0
21.8
20.0
22.0
29.0
30.0
34.8
3.00
3.00
3.00
3.75
4.00
5.00
3.00

SPR
SPR
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
MW
SST
SPR
SPR
SPR
SPR
SST
SST
SPR
SST
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
HD
SST
SPR
SPR
SST
SST
SPR

E
N
D
S

CG
CG
C
CG
CG
C
CG
CG
C
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C

F
N
S
H

Z
Z
N
N
N
N
Z
N
N
Z
N
N
Z
N
N
Z
N
Z
Z
Z
Z
N
Z
N
Z
N
Z
Z
N
N
Z
N
N
Z
Z
N
Z
N
N
Z
Z
Z
N
Z
N
Z
N
Z
N
N
N
Z
Z
Z
Z
GI
N
N
Z
Z
GI
N
N
Z
N
N
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

171

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:28 AM Page 172

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875

22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23

10469
3702
10942
11386
S-3177
1733
S-1438
LL-3
S-1698
26
S-886
10315
4184
12133
3686
S-1437
GG-53
11118
H-37
S-127
10307
S-1446
11263
914
3167
S-1359
11550
10497
10398
4389
S-1574
S-208
S-42
11584
11999
S-1390
3525
B7-52
2588
A13-70
12264
1916
II-65
3308
3926
68
808
2825
10552
11841
12449
11205
3025
A14-66
2971
12005
S-299
11104
3895
10119
2927
3952
S-1314
11272
864
49
4142
52
2762
3096
2906
55
56
12464
DD-78
12166
3412
4293
3277
3860

.66
.66
.69
.75
.75
.75
.81
.88
.88
.88
.94
.94
1.00
1.03
1.06
1.09
1.13
1.16
1.25
1.28
1.31
1.38
1.38
1.38
1.44
1.50
1.50
1.50
1.50
1.56
1.59
1.63
1.63
1.75
1.78
1.88
1.88
1.91
1.94
1.97
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.03
2.06
2.06
2.06
2.13
2.13
2.16
2.19
2.19
2.22
2.25
2.25
2.25
2.38
2.38
2.44
2.50
2.50
2.50
2.75
2.75
2.81
2.88
2.94
3.00
3.00
3.06
3.25
3.38
3.50
3.50
3.63
3.75

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

16.7
16.7
17.4
19.1
19.1
19.1
20.6
22.2
22.2
22.2
23.8
23.8
25.4
26.2
27.0
27.8
28.6
29.4
31.8
32.5
33.3
34.9
34.9
34.9
36.5
38.1
38.1
38.1
38.1
39.7
40.5
41.3
41.3
44.5
45.2
47.6
47.6
48.4
49.2
50.0
50.8
50.8
50.8
50.8
50.8
50.8
50.8
51.6
52.4
52.4
52.4
54.0
54.0
54.8
55.6
55.6
56.4
57.2
57.2
57.2
60.3
60.3
61.9
63.5
63.5
63.5
69.9
69.9
71.4
73.0
74.6
76.2
76.2
77.8
82.6
85.7
88.9
88.9
92.1
95.3

MATERIAL: MW - Music Wire

172

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.751
.635
.605
.785
.767
.751
.825
.775
.705
.693
.793
.751
.675
.757
.715
.665
.655
.799
.785
.775
.715
.751
.693
.665
.615
.813
.789
.731
.715
.731
.775
.751
.727
.733
.665
.715
.491
.643
.693
.731
.749
.731
.695
.691
.665
.635
.521
.631
.765
.667
.633
.745
.625
.741
.691
.689
.795
.761
.725
.649
.767
.731
.665
.665
.635
.605
.663
.579
.761
.693
.715
.693
.665
.691
.695
.749
.723
.715
.551
.651

RATE
mm

19.1
16.1
15.4
19.9
19.5
19.1
21.0
19.7
17.9
17.6
20.1
19.1
17.1
19.2
18.2
16.9
16.6
20.3
19.9
19.7
18.2
19.1
17.6
16.9
15.6
20.7
20.0
18.6
18.2
18.6
19.7
19.1
18.5
18.6
16.9
18.2
12.5
16.3
17.6
18.6
19.0
18.6
17.7
17.6
16.9
16.1
13.2
16.0
19.4
16.9
16.1
18.9
15.9
18.8
17.6
17.5
20.2
19.3
18.4
16.5
19.5
18.6
16.9
16.9
16.1
15.4
16.8
14.7
19.3
17.6
18.2
17.6
16.9
17.6
17.7
19.0
18.4
18.2
14.0
16.5

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

40
6.9
346
61
1178 206
4.6
.80
15
2.7
14
2.5
.27
.05
2.8
.50
88
15
88
15
4.1
.71
26
4.6
77
14
16
2.8
59
10
111
19
157
27
1.4
.24
1.2
.22
2.5
.44
23
4.1
8.6
1.5
32
5.5
96
17
221
39
.96
.17
2.8
.50
12
2.1
18
3.2
10
1.8
3.5
.62
6.9
1.2
15
2.6
9.4
1.6
70
12
17
3.0
943 165
64
11
41
7.2
15
2.6
11
1.9
16
2.8
32
5.7
61
11
77
13
99
17
572 100
76
13
4.3
.76
46
8.0
120
21
5.4
.94
139
24
12
2.1
48
8.3
45
7.9
.92
.16
5.0
.88
11
1.9
59
10
2.2
.39
11
1.9
35
6.1
59
10
69
12
118
21
47
8.2
163
29
3.7
.65
20
3.6
12
2.1
19
3.4
34
6.0
21
3.7
14
2.5
4.7
.82
13
2.4
9.8
1.7
282
49
36
6.4

.25
.18
.07
.57
.40
.39
.66
.53
.25
.32
.72
.38
.40
.53
.34
.36
.30
.90
.74
.90
.75
1.0
.67
.45
.34
1.3
1.2
.91
.82
.90
1.2
1.2
1.0
1.0
.62
1.1
.22
.72
.69
.94
.98
.92
.84
.47
.56
.62
.31
.58
1.6
.91
.52
1.4
.50
.97
.61
.67
1.9
1.5
1.5
.87
1.7
1.4
1.1
.73
.88
.71
.94
.67
2.1
1.4
1.7
1.4
1.3
1.4
1.9
2.2
1.3
2.1
.49
1.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

6.4
4.5
1.8
14
10
10
17
13
6.5
8.2
18
9.6
10
14
8.7
9.1
7.7
23
19
22.8
19
25
17
11
8.6
34
32
23
21
23
32
30
25
26
16
28
5.7
18
17
24
25
23
21
12
14
16
7.9
15
40
23
13
36
13
25
15
17
47
39
38
22
44
35
29
18
22
18
24
17
53
35
43
37
32
35
47
56
33
52
12
35

Lbs.

9.9
61
84
2.6
6.2
5.6
.18
1.5
22
28
2.9
9.9
31
8.6
20
40
47
1.2
.92
2.28
18
8.6
21
43
75
1.3
3.5
11
15
9.2
4.4
8.2
15
9.4
43
19
212
46
28
14
10
15
27
29
43
61
177
44
6.9
42
63
7.5
69
12
29
30
1.7
7.7
17
51
3.9
15
40
43
61
84
44
109
7.7
28
20
28
43
29
27
10
17
20
138
50

ENDS: C - Closed

G - Ground
O - Open

44
271
372
12
28
25
.78
6.6
100
125
13
44
137
38
89
177
211
5.5
4.1
10.1
78
38
94
190
334
5.7
16
48
66
41
20
36
66
42
190
83
943
204
125
61
46
65
121
129
190
272
787
196
31
185
279
34
307
52
129
133
7.6
34
74
228
17
65
177
190
272
372
196
485
34
125
89
125
190
129
119
46
77
89
613
223

Inches

.25
.48
.41
.18
.18
.36
.15
.35
.30
.49
.18
.28
.60
.24
.32
.53
.55
.26
.51
.38
.56
.37
.71
.74
.85
.16
.26
.59
.68
.67
.35
.43
.52
.75
.79
.72
1.63
1.19
.64
.54
.44
.55
.81
.60
.84
1.08
1.64
1.45
.47
1.04
.97
.72
1.13
.40
.69
.65
.36
.48
.75
1.24
.64
.72
1.21
.89
1.44
1.62
1.11
1.92
.60
1.09
.95
1.14
1.39
1.13
1.40
.76
.68
1.20
2.01
1.79

mm

6.3
12.2
10.3
4.6
4.5
9.1
3.8
8.9
7.6
12.3
4.7
7.1
15.2
6.0
8.1
13.3
14.0
6.5
13.0
9.5
14.2
9.4
17.9
18.7
21.5
3.9
6.6
15.1
17.3
16.9
8.9
11.0
13.2
18.9
20.0
18.3
41.5
30.2
16.2
13.7
11.2
14.0
20.6
15.2
21.3
27.4
41.6
36.8
11.9
26.4
24.6
18.2
28.6
10.2
17.5
16.5
9.1
12.3
19.1
31.6
16.3
18.3
30.7
22.7
36.6
41.1
28.3
48.9
15.2
27.7
24.1
28.9
35.3
28.6
35.4
19.2
17.4
30.5
51.0
45.5

WIRE DIA.
Inches

0.062
0.120
0.135
0.045
0.054
0.062
0.025
0.050
0.085
0.091
0.041
0.062
0.100
0.059
0.080
0.105
0.110
0.038
0.045
0.050
0.080
0.062
0.091
0.105
0.130
0.031
0.043
0.072
0.080
0.072
0.050
0.062
0.074
0.071
0.105
0.080
0.192
0.116
0.091
0.072
0.063
0.072
0.090
0.092
0.105
0.120
0.177
0.122
0.055
0.104
0.121
0.065
0.125
0.067
0.092
0.093
0.040
0.057
0.075
0.113
0.054
0.072
0.105
0.105
0.120
0.135
0.106
0.148
0.057
0.091
0.080
0.091
0.105
0.092
0.090
0.063
0.076
0.080
0.162
0.112

mm

TOTAL
MATL
COILS

1.6
3.0
3.4
1.1
1.4
1.6
0.6
1.3
2.2
2.3
1.0
1.6
2.5
1.5
2.0
2.7
2.8
1.0
1.1
1.3
2.0
1.6
2.3
2.7
3.3
0.8
1.1
1.8
2.0
1.8
1.3
1.6
1.9
1.8
2.7
2.0
4.9
2.9
2.3
1.8
1.6
1.8
2.3
2.3
2.7
3.0
4.5
3.1
1.4
2.6
3.1
1.7
3.2
1.7
2.3
2.4
1.0
1.4
1.9
2.9
1.4
1.8
2.7
2.7
3.0
3.4
2.7
3.8
1.4
2.3
2.0
2.3
2.7
2.3
2.3
1.6
1.9
2.0
4.1
2.8

3.00
4.00
3.00
4.00
3.25
4.75
5.00
7.00
3.50
4.33
3.50
3.50
6.00
4.00
4.00
5.00
5.00
5.75
10.3
7.50
7.00
6.00
7.75
6.00
6.50
4.00
5.00
8.25
8.50
9.25
6.00
7.00
7.00
9.50
7.50
8.00
8.50
10.3
7.00
6.50
6.00
6.67
8.00
5.50
7.00
9.00
9.25
12.0
7.50
10.0
8.00
10.0
8.00
6.00
6.50
7.00
8.00
7.50
10.0
11.0
12.0
9.00
11.5
8.50
12.0
12.0
10.5
13.0
9.50
12.0
12.0
12.5
13.3
12.3
15.5
11.0
9.00
14.0
12.3
16.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
SST
SST
HD
SST
SST
SST
HD
SST
SPR
SPR
SPR
SPR
SST
SPR
MW
MW
SST
SPR
SST
SST
HD
SPR
SST
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SST
HD
SST
HD
SST
SPR
SPR
SPR
SPR
SPR
HD
HD
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
HD
HD
SPR
HD
SPR
SPR
SPR
HD
HD
SPR
SPR
SPR
SPR
SPR
SPR
SPR

E
N
D
S

C
CG
CG
CG
CG
C
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
C
C
C
CG
CG
CG
C
CG
CG
C
C
CG
C
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG

F
N
S
H

Z
Z
Z
N
N
Z
N
N
N
Z
N
Z
Z
Z
Z
N
Z
N
N
N
Z
N
N
Z
Z
N
Z
Z
Z
Z
N
N
N
Z
Z
N
Z
N
Z
N
Z
Z
Z
Z
Z
Z
Z
GI
Z
Z
N
N
Z
N
Z
Z
N
N
Z
Z
GI
Z
N
Z
Z
Z
Z
Z
GI
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
GI

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 173

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.875
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890
0.890

22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.23
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61
22.61

10808
2711
2808
891
S-460
3279
4253
12797
11151
2826
653
2732
3933
11973
883
872
865
855
818
1939
395
892
11686
11982
11525
377
10004
289
899
893
10677
4015
4037
2827
AA-64
10584
10031
1910
11919
PP-64
11232
3383
11412
S-324
11863
10293
10165
A14-54
11318
10338
11171
WW-66
10656
10488
12175
OO-88
3254
S-1218
S-3103
PP-76
11851
12027
11523
S-284
3362
MM-32
12173
S-3015
10822
12698
10967
12055
11411
3363
2995
10715
11891
3470
3473
S-173

O.D.

FREE LENGTH
Inches

4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.31
4.41
4.50
4.50
4.94
5.50
5.63
6.00
6.00
6.00
6.00
6.00
6.50
7.13
7.75
7.75
8.22
8.28
8.50
8.88
12.0
12.0
12.0
12.3
18.5
26.5
.63
.63
.91
1.00
1.00
1.09
1.38
1.38
1.38
1.38
1.38
1.41
1.44
1.44
1.50
1.50
1.50
1.50
1.63
1.63
1.69
1.78
1.88
1.88
2.00
2.00
2.00
2.03
2.03
2.22
2.25
2.25
2.25
2.25
2.31
2.38
2.50
2.75
2.88
2.88
3.00
3.13
3.25
3.38
3.50
3.50
3.63

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

101.6
101.6
101.6
101.6
101.6
101.6
101.6
109.5
111.9
114.3
114.3
125.4
139.7
142.9
152.4
152.4
152.4
152.4
152.4
165.1
181.0
196.9
196.9
208.8
210.3
215.9
225.4
304.8
304.8
304.8
311.2
469.9
673.1
15.9
15.9
23.0
25.4
25.4
27.8
34.9
34.9
34.9
34.9
34.9
35.7
36.5
36.5
38.1
38.1
38.1
38.1
41.3
41.3
42.8
45.2
47.6
47.6
50.8
50.8
50.8
51.6
51.6
56.4
57.2
57.2
57.2
57.2
58.7
60.3
63.5
69.9
73.0
73.0
76.2
79.4
82.6
85.7
88.9
88.9
92.1

I.D.
Inches

.731
.715
.715
.715
.691
.685
.665
.625
.625
.675
.521
.691
.693
.675
.693
.665
.635
.605
.579
.689
.647
.715
.661
.671
.685
.731
.635
.751
.731
.715
.645
.715
.605
.730
.630
.650
.796
.780
.682
.770
.748
.736
.680
.566
.768
.746
.578
.806
.748
.730
.730
.786
.750
.626
.620
.658
.576
.720
.710
.590
.722
.598
.732
.810
.766
.766
.678
.720
.640
.680
.640
.726
.708
.620
.650
.764
.782
.730
.726
.650

RATE
mm

18.6
18.2
18.2
18.2
17.6
17.4
16.9
15.9
15.9
17.1
13.2
17.6
17.6
17.1
17.6
16.9
16.1
15.4
14.7
17.5
16.4
18.2
16.8
17.0
17.4
18.6
16.1
19.1
18.6
18.2
16.4
18.2
15.4
18.5
16.0
16.5
20.2
19.8
17.3
19.6
19.0
18.7
17.3
14.4
19.5
18.9
14.7
20.5
19.0
18.5
18.5
20.0
19.1
15.9
15.7
16.7
14.6
18.3
18.0
15.0
18.3
15.2
18.6
20.6
19.5
19.5
17.2
18.3
16.3
17.3
16.3
18.4
18.0
15.7
16.5
19.4
19.9
18.5
18.4
16.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

6.8
1.2
8.4
1.5
7.5
1.3
9.0
1.6
16
2.8
18
3.1
27
4.7
50
8.8
58
10
17
3.0
227
40
15
2.6
12
2.1
16
2.8
9.3
1.6
16
2.8
29
5.1
46
8.0
70
12
7.6
1.3
20
3.5
4.5
.79
13
2.2
10
1.8
12
2.1
3.7
.65
18
3.2
1.2
.22
2.1
.36
2.9
.50
11
1.9
1.9
.33
10
1.8
37
6.5
468
82
261
46
2.9
.51
11
2.0
102
18
8.1
1.4
11
1.9
34
6.0
90
16
595 104
5.0
.87
14
2.5
431
75
1.8
.32
13
2.2
18
3.1
20
3.5
2.2
.39
10
1.8
154
27
185
32
57
10
341
60
17
2.9
20
3.5
245
43
17
3.0
244
43
12
2.0
.87
.15
6.2
1.1
4.8
.84
63
11
17
2.9
90
16
56
9.7
87
15
8.8
1.5
18
3.2
106
19
59
10
4.4
.78
2.6
.46
6.7
1.2
10
1.8
41
7.1

2.2
2.4
2.5
2.2
1.7
1.8
1.6
1.9
1.2
2.5
.78
2.0
2.3
3.2
3.0
2.7
2.1
1.8
1.6
3.5
2.7
4.4
3.6
3.9
2.7
3.9
3.4
8.0
7.1
7.0
5.0
11
8.2
.23
.11
.23
.67
.61
.37
1.0
.81
.52
.47
.20
.80
.93
.28
1.2
.99
.84
.90
1.1
1.0
.50
.45
.66
.36
1.2
1.0
.39
1.2
.42
1.3
1.9
1.6
1.8
.69
1.3
.76
.76
.78
1.6
1.5
.78
1.0
2.3
2.5
1.9
2.1
1.4

mm

55
61
64
56
43
46
40
49
30
64
20
50
59
81
77
67
54
46
40
88
68
113
92
98
69
100
85
204
181
177
127
272
207
5.7
2.7
5.9
17
15
9.4
26
20
13
12
5.1
20
24
7.2
32
25
21
23
28
27
13
11
17
9.2
30
26
10
31
11
32
48
40
45
18
34
19
19
20
40
38
20
26
58
63
49
52
34

ENDS: C - Closed

G - Ground
O - Open

Lbs.

15
20
19
20
27
32
43
96
69
43
177
29
28
52
28
43
61
84
109
27
53
20
45
39
32
15
61
9.9
15
20
54
20
84
8.3
49
60
2.0
6.8
38
8.3
8.9
18
42
121
4.0
13
122
2.3
12
15
18
2.5
10
77
82
38
124
20
20
97
21
103
15
1.6
9.8
8.5
43
22
68
42
68
14
28
82
60
10
6.5
13
21
55

65
89
84
89
120
142
190
428
307
193
787
129
125
231
125
190
272
372
485
118
234
89
201
175
142
65
272
44
65
89
240
89
372
37
218
268
8.7
30
169
37
40
78
187
536
18
59
542
10
56
66
81
11
47
343
367
168
552
88
90
430
95
460
66
7.3
43
38
193
98
302
187
302
61
123
367
268
46
29
58
94
245

Inches

1.01
1.52
1.49
1.28
1.36
1.62
1.81
2.33
2.16
1.99
3.58
1.52
1.73
2.10
2.18
2.81
3.12
3.75
4.11
3.02
3.41
2.32
3.88
3.57
2.28
1.66
4.80
2.17
2.83
3.49
6.33
5.24
15.8
.40
.52
.54
.33
.22
.52
.36
.57
.44
.63
.93
.61
.50
1.09
.25
.51
.66
.60
.52
.58
1.12
1.08
1.22
1.33
.81
.99
1.28
.76
1.24
.95
.36
.56
.48
.85
.81
1.34
.89
.00
1.31
1.23
1.69
1.56
.69
.54
1.56
1.23
1.92

mm

Inches

25.6
38.5
37.8
32.5
34.5
41.0
46.0
59.1
54.8
50.5
91.0
38.6
43.9
53.3
55.5
71.3
79.2
95.2
104.3
76.8
86.7
58.9
98.5
90.7
57.9
42.1
121.9
55.1
71.8
88.7
160.7
133.1
401.2
10.2
13.2
13.7
8.4
5.6
13.2
9.1
14.4
11.2
16.0
23.7
15.5
12.8
27.7
6.4
13.1
16.8
15.2
13.2
14.7
28.5
27.4
30.9
33.9
20.5
25.1
32.4
19.2
31.5
24.1
9.1
14.2
12.2
21.5
20.5
34.1
22.7
0.0
33.3
31.2
42.9
39.6
17.6
13.7
39.6
31.2
48.8

0.072
0.080
0.080
0.080
0.092
0.095
0.105
0.125
0.125
0.100
0.177
0.092
0.091
0.100
0.091
0.105
0.120
0.135
0.148
0.093
0.114
0.080
0.107
0.102
0.095
0.072
0.120
0.062
0.072
0.080
0.115
0.080
0.135
0.080
0.130
0.120
0.047
0.055
0.104
0.060
0.071
0.077
0.105
0.162
0.061
0.072
0.156
0.042
0.071
0.080
0.080
0.052
0.070
0.132
0.135
0.116
0.157
0.085
0.090
0.150
0.084
0.146
0.079
0.040
0.062
0.062
0.106
0.085
0.125
0.105
0.125
0.082
0.091
0.135
0.120
0.063
0.054
0.080
0.082
0.120

mm

1.8
2.0
2.0
2.0
2.3
2.4
2.7
3.2
3.2
2.5
4.5
2.3
2.3
2.5
2.3
2.7
3.0
3.4
3.8
2.4
2.9
2.0
2.7
2.6
2.4
1.8
3.0
1.6
1.8
2.0
2.9
2.0
3.4
2.0
3.3
3.0
1.2
1.4
2.6
1.5
1.8
2.0
2.7
4.1
1.5
1.8
4.0
1.1
1.8
2.0
2.0
1.3
1.8
3.4
3.4
2.9
4.0
2.2
2.3
3.8
2.1
3.7
2.0
1.0
1.6
1.6
2.7
2.2
3.2
2.7
3.2
2.1
2.3
3.4
3.0
1.6
1.4
2.0
2.1
3.0

TOTAL
MATL
COILS
13.0
17.5
17.8
15.0
13.8
16.0
16.3
18.6
16.0
20.0
20.3
16.5
19.0
21.0
24.0
25.8
26.0
27.8
27.8
31.5
30.0
28.0
35.3
35.0
23.0
22.0
40.0
34.0
38.3
42.7
55.0
64.5
117.0
5.00
4.00
4.50
6.00
4.00
5.00
6.00
8.00
4.75
6.00
5.75
9.00
7.00
7.00
6.00
7.25
8.25
7.50
9.00
8.25
8.50
8.00
10.5
8.50
9.50
10.0
8.50
9.00
8.50
11.0
8.00
8.00
8.00
8.00
9.50
10.8
8.50
11.0
16.0
12.5
12.5
13.0
11.0
10.0
18.5
14.0
16.0

SPR
SPR
HD
HD
SST
SPR
SPR
MW
HD
MW
HD
SPR
SPR
MW
HD
HD
HD
HD
HD
SPR
SPR
HD
SPR
SPR
SPR
HD
SPR
HD
HD
HD
SPR
HD
SPR
HD
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SPR
SST
SST
SST
SST
SPR
SPR
SST
HD
SST
SPR
SST
SPR
HD
HD
SPR
SPR
SPR
SPR
SPR
SPR
HD
SPR
SST

E
N
D
S

C
C
C
C
C
C
C
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
C
C
CG
CG
C
CG
C
C
C
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG

F
N
S
H

Z
Z
Z
Z
N
Z
Z
N
Z
GI
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
Z
Z
N
N
Z
Z
N
Z
Z
Z
N
Z
Z
N
N
Z
N
N
N
N
N
Z
N
Z
N
Z
N
Z
Z
Z
Z
Z
Z
GI
GI
N
Z
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

173

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 174

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.890
0.890
0.890
0.890
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.906
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921

22.61
22.61
22.61
22.61
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.01
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39

11962
11764
12395
12604
2766
1777
3542
12410
10008
10118
2954
A11-51
10551
2538
11847
11536
10390
1579
PP-72
10463
11121
PP-45
2881
10567
10397
S-1546
11319
10377
10345
S-1196
B17-187
10674
10842
3149
3754
11941
1603
10739
10614
11924
11853
10378
12104
53
1665
1537
2679
3463
B9-55
3233
12109
S-3042
3342
3435
1689
12677
12158
3912
3147
3150
2817
10714
11195
12711
2690
3333
10785
10766
3828
S-3029
B18-158
BB-43
10197
11250
11382
10716
10456
10706
11233
S-474

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

5.56
6.00
6.13
6.88
.50
.59
.59
.63
.63
.63
.75
.75
.81
.91
1.16
1.16
1.22
1.25
1.25
1.25
1.25
1.28
1.31
1.38
1.47
1.50
1.50
1.50
1.50
1.50
1.53
1.56
1.56
1.56
1.75
1.75
2.13
2.25
2.31
2.34
2.38
2.38
2.47
2.75
3.13
3.16
3.19
3.38
3.50
3.56
3.59
3.63
4.00
4.25
5.00
5.38
8.75
9.00
14.0
14.8
.50
.63
.66
.88
.88
.94
1.00
1.13
1.13
1.13
1.25
1.25
1.25
1.25
1.31
1.31
1.38
1.38
1.38
1.50

mm

141.3
152.4
155.6
174.6
12.7
15.1
15.1
15.9
15.9
15.9
19.1
19.1
20.6
23.0
29.4
29.4
31.0
31.8
31.8
31.8
31.8
32.5
33.3
34.9
37.3
38.1
38.1
38.1
38.1
38.1
38.9
39.7
39.7
39.7
44.5
44.5
54.0
57.2
58.7
59.5
60.3
60.3
62.7
69.9
79.4
80.2
81.0
85.7
88.9
90.5
91.3
92.1
101.6
108.0
127.0
136.5
222.3
228.6
355.6
374.7
12.7
15.9
16.7
22.2
22.2
23.8
25.4
28.6
28.6
28.6
31.8
31.8
31.8
31.8
33.3
33.3
34.9
34.9
34.9
38.1

MATERIAL: MW - Music Wire

174

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.688
.620
.650
.578
.686
.782
.780
.798
.782
.782
.786
.664
.834
.656
.812
.760
.736
.746
.746
.734
.724
.846
.782
.746
.750
.864
.750
.746
.736
.696
.734
.766
.746
.666
.696
.636
.810
.790
.746
.746
.840
.782
.550
.696
.756
.762
.724
.722
.826
.714
.760
.610
.756
.806
.746
.656
.756
.696
.724
.696
.701
.811
.813
.775
.681
.801
.775
.811
.761
.721
.817
.801
.749
.731
.813
.739
.749
.739
.739
.761

RATE
mm

17.5
15.7
16.5
14.7
17.4
19.9
19.8
20.3
19.9
19.9
20.0
16.9
21.2
16.7
20.6
19.3
18.7
18.9
18.9
18.6
18.4
21.5
19.9
18.9
19.1
21.9
19.1
18.9
18.7
17.7
18.6
19.5
18.9
16.9
17.7
16.2
20.6
20.1
18.9
18.9
21.3
19.9
14.0
17.7
19.2
19.4
18.4
18.3
21.0
18.1
19.3
15.5
19.2
20.5
18.9
16.7
19.2
17.7
18.4
17.7
17.8
20.6
20.7
19.7
17.3
20.3
19.7
20.6
19.3
18.3
20.8
20.3
19.0
18.6
20.7
18.8
19.0
18.8
18.8
19.3

Lbs./In.

16
43
27
82
417
11
19
20
35
18
15
340
2.4
368
4.9
24
27
42
23
25
33
.17
12
17
16
.03
19
16
23
49
29
9.8
20
112
68
174
1.1
4.9
12
16
.65
2.9
416
35
8.8
7.2
14
20
.52
19
8.8
115
3.7
1.4
7.1
35
2.5
13
4.0
5.7
395
20
17
33
258
7.3
30
6.8
33
90
2.8
7.3
27
59
3.3
46
23
31
38
29

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

2.8
7.5
4.8
14
73
1.9
3.3
3.5
6.2
3.1
2.7
59
.43
65
.86
4.1
4.7
7.3
4.1
4.3
5.8
.03
2.1
2.9
2.7
.01
3.3
2.8
4.0
8.6
5.0
1.7
3.5
20
12
30
.19
.85
2.0
2.8
.11
.52
73
6.2
1.5
1.3
2.4
3.5
.09
3.3
1.5
20
.65
.25
1.2
6.1
.43
2.3
.70
1.0
69
3.5
2.9
5.9
45
1.3
5.2
1.2
5.8
16
.50
1.3
4.7
10
.58
8.1
4.1
5.5
6.7
5.0

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

2.3
60
1.9
49
2.2
56
2.1
53
.11
2.8
.21
5.2
.34
8.7
.32
8.2
.27
6.9
.32
8.0
.51 13
.18
4.5
.65 17
.18
4.6
.86 22
.63 16
.62 16
.46 12
.73 19
.58 15
.57 14
.89 23
.81 21
.72 18
.84 21
1.2
31
.88 22
.82 21
.74 19
.66 17
.84 21
.93 24
.90 23
.53 13
.61 15
.47 12
1.5
38
1.6
41
1.4
36
1.2
31
2.2
55
1.5
38
.42 11
1.2
30
2.2
57
2.0
50
1.7
43
1.4
36
3.0
76
1.7
43
1.7
43
.83 21
2.2
57
3.5
90
2.7
70
1.9
48
6.2 157
3.2
81
6.8 172
7.3 185
.16
4.1
.33
8.3
.35
9.0
.58 15
.32
8.0
.58 15
.46 12
.80 20
.58 15
.36
9.2
.89 23
.89 23
.65 16
.51 13
.93 24
.58 15
.71 18
.69 18
.70 18
.62 16

Lbs.

38
82
60
171
46
2.2
6.4
6.4
9.6
5.6
7.8
61
1.6
67
4.2
15
17
19
17
14
19
.15
9.6
12
13
.04
16
13
17
33
24
9.2
18
59
41
81
1.6
7.9
17
19
1.4
4.4
175
41
20
14
23
28
1.5
32
15
95
8.2
5.1
19
67
15
41
27
41
63
6.6
5.9
20
82
4.2
14
5.4
19
33
2.5
6.5
18
30
3.1
27
17
22
27
18

ENDS: C - Closed

G - Ground
O - Open

167
367
268
759
205
9.9
29
28
43
25
35
270
7.1
297
19
66
75
86
75
64
84
.69
43
53
59
.19
73
59
74
145
107
41
80
264
184
361
7.3
35
74
86
6.2
20
777
184
87
63
104
125
6.8
142
66
424
37
23
86
297
68
184
121
184
281
29
26
87
363
19
61
24
85
146
11
29
78
135
14
119
74
96
119
80

Inches

mm

2.12 53.9
3.75 95.2
3.24 82.3
4.56 115.9
.33
8.4
.39
9.9
.25
6.4
.22
5.5
.19
4.7
.31
7.9
.24
6.1
.47 11.9
.16
4.1
.50 12.7
.19
4.8
.44 11.1
.60 15.1
.44 11.2
.52 13.2
.67 16.9
.68 17.3
.39
9.9
.31
7.9
.66 16.8
.62 15.8
.28
7.1
.62 15.8
.68 17.3
.77 19.4
.84 21.3
.60 15.3
.63 16.0
.66 16.8
.90 22.9
.74 18.7
1.08 27.4
.62 15.8
.49 12.5
.88 22.4
.68 17.3
.21
5.4
.87 22.0
1.96 49.7
1.33 33.8
.90 22.9
.88 22.4
1.48 37.6
1.15 29.2
.52 13.2
1.46 37.2
.73 18.5
2.07 52.6
1.76 44.8
.65 16.5
1.34 34.0
3.00 76.2
2.55 64.8
2.94 74.7
4.39 111.5
6.48 164.7
.33
8.4
.22
5.6
.22
5.5
.29
7.4
.51 13.0
.36
9.1
.37
9.3
.33
8.4
.40 10.2
.45 11.4
.36
9.2
.36
9.1
.60 15.3
.52 13.3
.38
9.6
.61 15.6
.67 16.9
.68 17.3
.59 15.0
.40 10.2

WIRE DIA.
Inches

0.101
0.135
0.120
0.156
0.110
0.062
0.063
0.054
0.062
0.062
0.060
0.121
0.036
0.125
0.047
0.073
0.085
0.080
0.080
0.086
0.091
0.030
0.062
0.080
0.078
0.021
0.078
0.080
0.085
0.105
0.086
0.070
0.080
0.120
0.105
0.135
0.048
0.058
0.080
0.080
0.033
0.062
0.178
0.105
0.075
0.072
0.091
0.092
0.040
0.096
0.073
0.148
0.075
0.050
0.080
0.125
0.075
0.105
0.091
0.105
0.110
0.055
0.054
0.073
0.120
0.060
0.073
0.055
0.080
0.100
0.052
0.060
0.086
0.095
0.054
0.091
0.086
0.091
0.091
0.080

mm

TOTAL
MATL
COILS

2.6
3.4
3.0
4.0
2.8
1.6
1.6
1.4
1.6
1.6
1.5
3.1
0.9
3.2
1.2
1.9
2.2
2.0
2.0
2.2
2.3
0.8
1.6
2.0
2.0
0.5
2.0
2.0
2.2
2.7
2.2
1.8
2.0
3.0
2.7
3.4
1.2
1.5
2.0
2.0
0.8
1.6
4.5
2.7
1.9
1.8
2.3
2.3
1.0
2.4
1.9
3.8
1.9
1.3
2.0
3.2
1.9
2.7
2.3
2.7
2.8
1.4
1.4
1.9
3.0
1.5
1.9
1.4
2.0
2.5
1.3
1.5
2.2
2.4
1.4
2.3
2.2
2.3
2.3
2.0

21.0
27.8
26.0
28.3
3.00
5.25
4.00
3.00
3.00
4.00
4.00
4.00
3.50
4.00
4.00
5.00
7.00
4.50
6.50
7.75
7.50
12.0
5.00
8.25
8.00
12.3
7.00
8.50
8.00
8.00
7.00
8.00
7.25
7.50
7.00
8.00
13.0
7.50
11.0
8.50
5.50
14.0
11.0
11.7
11.0
11.3
15.3
11.5
13.0
14.3
10.0
14.0
23.5
12.0
16.8
23.0
34.0
28.0
47.3
61.8
3.00
3.00
3.00
4.00
4.25
6.00
4.00
5.00
5.00
4.50
7.00
6.00
7.00
5.50
7.00
5.75
7.75
7.50
6.50
5.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
MW
SPR
HD
HD
SPR
SPR
HD
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
HD
MW
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
HD
SPR
MW
SPR
SPR
SPR
SST
SPR
SPR
HD
MW
SPR
MW
HD
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
MW
SPR
SST
MW
MW
SPR
SST
SPR
HD
SST
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST

E
N
D
S

F
N
S
H

CG
CG
C
C
CG
C
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
C
CG
C
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
C
C
C
C
CG
C
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
C
C
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG

Z
Z
Z
N
Z
Z
Z
N
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
BO
Z
Z
GI
Z
Z
Z
N
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
N
Z
Z
Z
Z
Z
N
N
N
Z
Z
N
N
Z
N
N
Z
Z
Z
N
Z
Z
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 175

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.921
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938

23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.39
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83

S-140
10254
10610
3189
11207
3815
PP-1
11637
11236
1737
S-1611
10597
3351
3070
MM-92
12103
1888
1685
12174
12040
S-462
3285
4017
3663
3687
S-3040
4235
MM-75
1855
S-902
924
11762
2609
GG-41
1617
10524
B2-59
10211
10268
S-1123
11794
11738
11724
10726
3885
10977
PP-62
3625
CC-34
11149
S-443
828
S-940
10622
11719
3683
67
S-1361
S-463
12448
10514
11598
3922
3458
12227
10046
3295
10660
11936
12084
1701
832
3939
S-3162
42
11494
4287
1541
36
10650

O.D.

FREE LENGTH
Inches

1.50
1.56
1.56
1.59
1.69
1.75
2.03
2.06
2.38
2.75
2.78
3.00
3.00
3.00
3.00
3.22
3.31
4.50
4.75
5.50
6.25
6.50
19.8
.44
.63
.75
.75
.78
.94
.94
1.13
1.16
1.19
1.22
1.25
1.25
1.25
1.38
1.38
1.38
1.38
1.38
1.41
1.50
1.50
1.50
1.50
1.50
1.50
1.59
1.66
1.75
1.78
1.78
1.84
1.94
2.00
2.00
2.03
2.06
2.13
2.13
2.25
2.25
2.41
2.50
2.63
2.66
2.78
2.84
3.00
3.00
3.00
3.25
3.25
3.38
3.63
3.75
4.00
4.19

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

38.1
39.7
39.7
40.5
42.8
44.5
51.6
52.4
60.3
69.9
70.6
76.2
76.2
76.2
76.2
81.8
84.1
114.3
120.7
139.7
158.8
165.1
501.7
11.1
15.9
19.1
19.1
19.8
23.8
23.8
28.6
29.4
30.2
31.0
31.8
31.8
31.8
34.9
34.9
34.9
34.9
34.9
35.7
38.1
38.1
38.1
38.1
38.1
38.1
40.5
42.1
44.5
45.2
45.2
46.8
49.2
50.8
50.8
51.6
52.4
54.0
54.0
57.2
57.2
61.1
63.5
66.7
67.5
70.6
72.2
76.2
76.2
76.2
82.6
82.6
85.7
92.1
95.3
101.6
106.4

I.D.
Inches

.547
.771
.703
.761
.721
.661
.621
.799
.797
.665
.731
.777
.761
.671
.541
.821
.777
.711
.711
.791
.777
.701
.631
.828
.828
.678
.668
.758
.698
.694
.728
.622
.614
.758
.826
.734
.668
.814
.814
.768
.700
.666
.754
.848
.738
.728
.718
.688
.618
.698
.838
.698
.794
.728
.666
.810
.778
.770
.698
.778
.766
.549
.738
.688
.784
.836
.624
.782
.780
.578
.794
.728
.688
.752
.524
.740
.794
.698
.642
.804

RATE
mm

13.9
19.6
17.9
19.3
18.3
16.8
15.8
20.3
20.2
16.9
18.6
19.7
19.3
17.0
13.7
20.9
19.7
18.1
18.1
20.1
19.7
17.8
16.0
21.0
21.0
17.2
17.0
19.3
17.7
17.6
18.5
15.8
15.6
19.3
21.0
18.6
17.0
20.7
20.7
19.5
17.8
16.9
19.2
21.5
18.7
18.5
18.2
17.5
15.7
17.7
21.3
17.7
20.2
18.5
16.9
20.6
19.8
19.6
17.7
19.8
19.5
13.9
18.7
17.5
19.9
21.2
15.8
19.9
19.8
14.7
20.2
18.5
17.5
19.1
13.3
18.8
20.2
17.7
16.3
20.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

1104 193
33
5.8
79
14
15
2.7
58
10
166
29
244
43
4.5
.78
2.8
.49
72
13
17
2.9
7.0
1.2
9.9
1.7
75
13
505
88
1.5
.26
7.0
1.2
25
4.3
21
3.8
2.0
.36
3.7
.65
19
3.3
20
3.5
19
3.3
19
3.3
451
79
615 108
46
8.0
218
38
260
46
86
15
755 132
605 106
46
8.0
5.2
.90
71
12
284
50
9.0
1.6
11
1.8
26
4.6
105
18
318
56
43
7.4
.97
.17
54
9.5
76
13
93
16
137
24
355
62
121
21
3.8
.66
99
17
13
2.3
54
9.4
191
33
5.8
1.0
17
3.1
15
2.7
76
13
16
2.8
23
4.0
834 146
31
5.3
109
19
16
2.8
2.8
.49
193
34
10
1.8
11
1.9
408
71
6.6
1.2
30
5.3
54
9.5
19
3.4
588 103
20
3.4
7.9
1.4
52
9.1
89
16
4.9
.85

Inches

mm

.15
3.7
.47 12
.53 14
.91 23
.57 14
.43 11
.43 11
1.5
38
1.5
38
.98 25
1.5
39
2.0
51
1.9
49
.87 22
.39 10
2.7
68
2.0
51
1.7
42
1.9
48
4.1 103
3.5
89
2.4
61
5.0 126
.27
6.9
.34
8.6
.14
3.6
.13
3.2
.33
8.4
.37
9.4
.21
5.4
.44 11
.16
4.1
.21
5.4
.52 13
.86 22
.52 13
.39
9.8
1.0
26
.88 22
.78 20
.53 14
.25
6.4
.64 16
.98 25
.64 16
.53 13
.48 12
.66 17
.31
8.0
.47 12
1.2
31
.58 15
.98 25
.69 18
.42 11
1.4
36
1.1
27
1.3
33
.69 18
1.2
29
1.0
26
.25
6.3
1.1
29
.59 15
1.1
27
1.9
47
.61 16
1.7
43
1.6
42
.41 10
2.1
53
1.3
34
1.2
30
1.3
34
.42 11
1.7
44
1.7
44
1.1
28
1.2
29
2.4
61

ENDS: C - Closed

G - Ground
O - Open

Lbs.

163
725
16
70
42
188
14
62
33
146
72
319
106
470
6.8
30
4.2
19
70
313
26
115
14
62
19
85
66
293
198
880
4.0
18
14
62
41
182
41
182
8.3
37
13
58
45
201
98
437
5.2
23
6.5
29
63
282
79
350
15
67
80
357
55
245
38
170
121
537
130
577
24
105
4.4
20
37
164
110
489
9.3
41
9.3
41
21
91
56
249
80
357
27
121
.96
4.3
35
155
40
179
45
198
90
401
111
495
57
255
4.6
20
57
255
13
57
37
166
80
357
8.1
36
19
83
20
88
52
233
19
83
23
103
208
926
35
155
65
288
17
75
5.2
23
119
528
17
77
18
80
167
744
14
61
40
179
65
288
26
116
248 1101
34
150
14
61
57
255
103
456
12
52

Inches

mm

Inches

1.03 26.1
.32
8.1
.68 17.3
.68 17.3
.60 15.2
.91 23.1
1.28 32.4
.55 13.9
.87 22.0
1.63 41.5
1.24 31.4
.86 21.9
.96 24.4
1.41 35.7
2.19 55.5
.55 14.0
.86 21.9
1.68 42.7
1.79 45.3
1.43 36.3
1.28 32.5
2.53 64.3
10.2 259.7
.17
4.2
.22
5.6
.46 11.6
.47 12.0
.45 11.4
.54 13.7
.49 12.4
.68 17.3
.71 18.1
.89 22.6
.45 11.4
.39 10.0
.59 14.9
.71 18.0
.34
8.7
.37
9.4
.60 15.1
.83 21.2
.68 17.3
.55 14.0
.52 13.1
.65 16.5
.63 16.0
.66 16.8
.84 21.4
1.12 28.4
.78 19.8
.25
6.4
1.02 25.9
.50 12.8
.74 18.7
1.09 27.6
.53 13.4
.67 16.9
.71 18.1
.99 25.1
.62 15.7
.65 16.4
1.75 44.5
1.00 25.4
1.00 25.4
.62 15.6
.41 10.4
1.81 45.9
.53 13.5
.79 20.1
1.89 48.0
.86 21.9
1.26 32.0
1.75 44.5
1.02 26.0
2.79 71.0
1.49 37.7
.68 17.4
1.62 41.1
2.63 66.7
.74 18.7

0.187
0.075
0.109
0.080
0.100
0.130
0.150
0.061
0.062
0.128
0.095
0.072
0.080
0.125
0.190
0.050
0.072
0.105
0.105
0.065
0.072
0.110
0.145
0.055
0.055
0.130
0.135
0.090
0.120
0.122
0.105
0.158
0.162
0.090
0.056
0.102
0.135
0.062
0.062
0.085
0.119
0.136
0.092
0.045
0.100
0.105
0.110
0.125
0.160
0.120
0.050
0.120
0.072
0.105
0.136
0.064
0.080
0.084
0.120
0.080
0.086
0.195
0.100
0.125
0.077
0.051
0.157
0.078
0.079
0.180
0.072
0.105
0.125
0.093
0.207
0.1
0.072
0.120
0.148
0.067

mm

TOTAL
MATL
COILS

4.7
1.9
2.8
2.0
2.5
3.3
3.8
1.5
1.6
3.3
2.4
1.8
2.0
3.2
4.8
1.3
1.8
2.7
2.7
1.7
1.8
2.8
3.7
1.4
1.4
3.3
3.4
2.3
3.0
3.1
2.7
4.0
4.1
2.3
1.4
2.6
3.4
1.6
1.6
2.2
3.0
3.5
2.3
1.1
2.5
2.7
2.8
3.2
4.1
3.0
1.3
3.0
1.8
2.7
3.5
1.6
2.0
2.1
3.0
2.0
2.2
4.9
2.5
3.2
2.0
1.3
4.0
2.0
2.0
4.6
1.8
2.7
3.2
2.4
5.3
2.5
1.8
3.0
3.8
1.7

5.50
4.25
6.25
8.50
6.00
7.00
8.50
9.00
14.0
12.8
13.0
11.0
12.0
11.3
11.5
11.0
11.0
15.0
17.0
22.0
16.8
23.0
70.5
3.00
3.00
3.50
3.50
5.00
4.50
4.00
5.50
4.50
5.50
5.00
6.00
5.75
5.25
5.50
5.00
6.00
7.00
5.00
6.00
10.5
6.50
6.00
6.00
6.75
7.00
6.50
5.00
7.50
6.00
7.00
7.00
8.25
7.33
8.50
8.25
7.75
7.50
8.00
10.0
8.00
7.00
7.00
11.5
7.50
10.0
10.5
11.0
12.0
14.0
10.0
13.5
14.0
9.50
12.5
17.8
11.0

SST
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
HD
SST
SPR
HD
SPR
SPR
SPR
HD
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
MW
SST
HD
SPR
HD
SST
SPR
SPR
MW
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
HD
SPR
MW
SST
SPR
SST
HD
SST
SST
SPR
SPR
HD
SST
SST
SPR
SPR
SPR
SPR
HD
SPR
SPR
SPR
PB
SPR
SPR
SPR
HD
SPR
SST
HD
SPR
SPR
SPR
HD
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
C
CG
C
CG
C
CG
CG

F
N
S
H

N
Z
N
GI
N
Z
Z
Z
Z
Z
N
Z
Z
GI
N
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
N
Z
N
Z
N
Z
Z
Z
N
Z
Z
N
Z
N
N
Z
Z
Z
Z
GI
Z
Z
Z
N
Z
N
Z
N
N
Z
Z
Z
N
N
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

175

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 176

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.938
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.953
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968

23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
23.83
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.21
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59

3125
S-1407
3931
4342
332
2843
S-154
11627
4149
3113
2569
11945
4233
3076
1938
NN-24
11915
KK-68
3343
3010
S-1559
12699
10683
CC-72
3396
1907
4271
N-126
2761
S-1254
12213
11385
11541
S-94
B18-140
11856
3954
3385
11492
2932
S-984
AA-72
11157
2875
10566
MM-54
S-1149
11868
2917
2914
11524
11955
3423
3335
2642
11558
3341
S-182
11911
KK-54
11692
3657
S-1476
S-1140
S-1256
PP-78
S-343
11128
12770
11183
S-1230
S-80
11819
10484
10510
11106
10496
2504
3403
3119

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

4.31
4.38
4.50
5.00
5.00
5.13
5.25
5.25
6.00
6.38
7.25
8.75
9.75
10.5
11.1
.69
.88
.94
.94
.97
.98
1.00
1.00
1.00
1.13
1.25
1.25
1.25
1.25
1.28
1.31
1.41
1.47
1.50
1.50
1.63
1.75
1.75
1.75
1.81
1.91
1.94
2.00
2.13
2.28
2.44
2.75
3.00
3.69
3.75
3.94
4.00
4.38
4.44
4.81
7.75
8.00
.69
.75
.78
1.00
1.03
1.09
1.13
1.31
1.44
1.50
1.50
1.56
1.63
1.75
1.88
2.00
2.00
2.19
2.25
2.25
2.25
2.25
2.31

mm

109.5
111.1
114.3
127.0
127.0
130.2
133.4
133.4
152.4
161.9
184.2
222.3
247.7
266.7
282.6
17.4
22.2
23.8
23.8
24.6
25.0
25.4
25.4
25.4
28.6
31.8
31.8
31.8
31.8
32.5
33.3
35.7
37.3
38.1
38.1
41.3
44.5
44.5
44.5
46.0
48.4
49.2
50.8
54.0
57.9
61.9
69.9
76.2
93.6
95.3
100.0
101.6
111.1
112.7
122.2
196.9
203.2
17.4
19.1
19.8
25.4
26.2
27.8
28.6
33.3
36.5
38.1
38.1
39.7
41.3
44.5
47.6
50.8
50.8
55.6
57.2
57.2
57.2
57.2
58.7

MATERIAL: MW - Music Wire

176

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.798
.814
.626
.742
.584
.764
.642
.642
.754
.794
.728
.810
.698
.756
.664
.633
.771
.833
.823
.771
.849
.873
.849
.833
.825
.845
.829
.797
.639
.793
.599
.743
.721
.703
.619
.805
.809
.797
.689
.739
.791
.693
.699
.717
.823
.593
.793
.783
.711
.793
.743
.763
.819
.693
.641
.793
.539
.786
.880
.688
.844
.842
.878
.882
.874
.848
.794
.614
.592
.728
.888
.808
.794
.718
.816
.874
.852
.838
.768
.844

RATE
mm

20.3
20.7
15.9
18.8
14.8
19.4
16.3
16.3
19.2
20.2
18.5
20.6
17.7
19.2
16.9
16.1
19.6
21.2
20.9
19.6
21.6
22.2
21.6
21.2
21.0
21.5
21.1
20.2
16.2
20.1
15.2
18.9
18.3
17.9
15.7
20.4
20.5
20.2
17.5
18.8
20.1
17.6
17.8
18.2
20.9
15.1
20.1
19.9
18.1
20.1
18.9
19.4
20.8
17.6
16.3
20.1
13.7
20.0
22.4
17.5
21.4
21.4
22.3
22.4
22.2
21.5
20.2
15.6
15.0
18.5
22.6
20.5
20.2
18.2
20.7
22.2
21.6
21.3
19.5
21.4

Lbs./In.

N/mm

5.3
.92
1.8
.32
122
21
15
2.7
175
31
10
1.8
55
9.7
67
12
9.0
1.6
4.1
.72
15
2.6
1.1
.19
23
4.0
6.8
1.2
29
5.0
1511 265
68
12
6.5
1.1
9.2
1.6
77
13
5.0
.88
2.8
.49
5.7
.99
13
2.3
12
2.2
4.2
.74
7.5
1.3
14
2.5
433
76
15
2.7
863 151
64
11
137
24
90
16
430
75
11
2.0
6.6
1.2
26
4.6
158
28
44
7.8
11
1.9
98
17
140
24
77
13
7.0
1.2
483
85
11
1.9
12
2.2
51
8.9
11
1.9
23
4.0
19
3.2
4.6
.81
59
10
99
17
3.3
.57
254
45
86
15
1.8
.32
486
85
9.5
1.7
15
2.7
2.2
.38
2.0
.34
3.9
.68
6.2
1.1
30
5.2
671 117
946 166
122
21
.89
.16
9.7
1.7
21
3.7
107
19
17
3.0
2.2
.39
3.9
.69
3.5
.61
38
6.7
4.1
.71

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

2.4
61
3.3
84
.95 24
2.2
55
.96 24
2.3
59
1.7
42
1.5
39
3.0
77
3.3
85
2.7
67
6.5 165
2.5
64
3.9
98
2.9
73
.08
2.1
.35
9.0
.58 15
.55 14
.34
8.6
.70 18
.82 21
.73 18
.63 16
.76 19
.93 24
.82 21
.70 18
.31
7.8
.72 18
.19
4.9
.62 16
.38
9.5
.50 13
.29
7.3
1.1
28
.92 23
.65 16
.46 12
.85 22
1.1
29
.70 18
.48 12
.70 18
1.5
38
.29
7.5
1.6
40
1.7
43
1.1
29
1.7
42
1.7
44
1.6
40
2.5
63
1.2
30
1.2
29
5.4 136
.96 24
.27
7.0
.47 12
.17
4.4
.69 18
.62 16
.82 21
.88 22
1.0
26
1.1
27
.73 19
.24
6.2
.19
4.9
.46 12
1.5
37
1.1
28
1.0
26
.59 15
.93 24
1.9
49
1.8
45
1.5
37
.88 22
1.7
43

Lbs.

13
56
6.1
27
116
518
33
146
167
743
24
107
92
411
103
456
27
121
14
61
40
179
7.1
32
57
255
26
117
82
365
124
549
24
107
3.8
17
5.0
22
26
115
3.5
16
2.3
10
4.1
18
8.3
37
9.4
42
3.9
17
6.1
27
9.9
44
133
593
11
49
165
733
39
175
51
228
45
199
124
552
12
55
6.1
27
17
76
73
323
38
168
12
55
69
307
67
297
54
240
11
47
142
633
17
77
21
92
58
258
18
82
40
176
29
131
12
51
69
309
115
511
18
78
245 1088
24
105
.86
3.8
85
378
6.6
29
9.4
42
1.8
8.0
1.7
7.7
4.0
18
6.7
30
22
97
163
724
184
820
56
248
1.3
5.7
11
48
22
97
63
280
16
70
4.3
19
6.9
31
5.1
23
34
150
6.9
31

ENDS: C - Closed

G - Ground
O - Open

Inches

mm

.84 21.3
1.05 26.8
2.43 61.6
1.64 41.7
3.60 91.4
1.31 33.1
3.55 90.2
3.37 85.5
2.02 51.4
1.19 30.2
2.42 61.3
2.24 56.9
3.24 82.3
2.34 59.5
5.00 127.0
.52 13.2
.36
9.2
.36
9.1
.39
9.9
.36
9.2
.29
7.3
.18
4.6
.27
6.9
.30
7.6
.37
9.3
.32
8.2
.43 11.0
.55 13.9
.94 23.9
.56 14.2
.97 24.7
.79 20.0
.73 18.4
1.00 25.4
1.13 28.6
.52 13.2
.83 21.0
.39
9.9
1.06 26.8
.96 24.5
.77 19.5
1.24 31.4
.86 21.8
1.09 27.7
.54 13.6
1.44 36.6
.80 20.3
.87 22.1
1.63 41.5
.88 22.4
1.63 41.3
1.24 31.4
.80 20.4
2.02 51.2
2.96 75.3
2.40 61.0
5.59 142.0
.41 10.4
.28
7.1
.56 14.2
.31
7.9
.32
8.0
.27
6.9
.25
6.3
.19
4.8
.36
9.1
.48 12.2
1.11 28.1
1.13 28.7
.72 18.3
.30
7.6
.76 19.3
.61 15.5
.94 23.8
.46 11.6
.33
8.4
.49 12.5
.78 19.8
.78 19.7
.62 15.7

WIRE DIA.
Inches

0.070
0.062
0.156
0.098
0.177
0.087
0.148
0.148
0.092
0.072
0.105
0.064
0.120
0.091
0.137
0.160
0.091
0.060
0.065
0.091
0.052
0.040
0.052
0.060
0.064
0.054
0.062
0.078
0.157
0.080
0.177
0.105
0.116
0.125
0.167
0.074
0.072
0.078
0.132
0.107
0.081
0.130
0.127
0.118
0.065
0.180
0.080
0.085
0.121
0.080
0.105
0.095
0.067
0.130
0.156
0.080
0.207
0.091
0.044
0.140
0.062
0.063
0.045
0.043
0.047
0.060
0.087
0.177
0.188
0.120
0.040
0.080
0.087
0.125
0.076
0.047
0.058
0.065
0.100
0.062

mm

TOTAL
MATL
COILS

1.8
1.6
4.0
2.5
4.5
2.2
3.8
3.8
2.3
1.8
2.7
1.6
3.0
2.3
3.5
4.1
2.3
1.5
1.7
2.3
1.3
1.0
1.3
1.5
1.6
1.4
1.6
2.0
4.0
2.0
4.5
2.7
2.9
3.2
4.2
1.9
1.8
2.0
3.4
2.7
2.1
3.3
3.2
3.0
1.7
4.6
2.0
2.2
3.1
2.0
2.7
2.4
1.7
3.3
4.0
2.0
5.3
2.3
1.1
3.6
1.6
1.6
1.1
1.1
1.2
1.5
2.2
4.5
4.8
3.0
1.0
2.0
2.2
3.2
1.9
1.2
1.5
1.7
2.5
1.6

12.0
17.0
15.8
16.8
20.3
15.0
24.0
22.8
21.0
16.5
22.0
35.0
26.0
25.8
36.5
3.25
4.00
6.00
6.00
4.00
4.50
3.50
4.25
4.00
4.75
6.00
6.00
7.00
6.00
7.00
5.50
6.50
5.25
8.00
6.75
7.00
10.5
5.00
7.00
9.00
9.50
9.50
6.75
8.25
7.25
8.00
9.00
10.3
12.5
10.0
14.5
12.0
11.0
14.5
19.0
29.0
27.0
3.50
5.33
4.00
5.00
4.00
5.00
4.75
4.00
6.00
5.50
6.25
6.00
6.00
6.50
9.50
7.00
7.50
6.00
6.00
7.50
12.0
7.75
9.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SPR
SPR
HD
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SST
MW
SST
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
SST
SST
SPR
SST
SPR
HD
SPR
SST
SST
SST
SPR
SPR
MW
SPR
HD
SPR
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
C
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
C
C
CG
C
C
C
CG
CG
CG
C
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
C

F
N
S
H

Z
N
Z
Z
Z
GI
N
Z
Z
Z
Z
Z
Z
Z
Z
GI
N
Z
Z
GI
N
N
N
Z
Z
Z
Z
N
Z
N
GI
Z
GI
N
N
N
Z
Z
GI
Z
N
Z
Z
Z
Z
N
N
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
N
GI
Z
Z
N
N
N
Z
N
Z
Z
Z
N
N
N
Z
Z
N
Z
Z
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 177

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.968
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975

24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.59
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77

2952
3018
3223
4272
A13-68
11913
S-429
B17-176
3175
11436
3106
1661
11486
11640
10655
11563
12457
3065
3077
72327
72327S
72339
72339S
72351
72351S
72367
72367S
72352
72352S
72379
72379S
72394
72394S
72403
72403S
72415
72415S
72427
72427S
72455
72455S
72467
72467S
72328
72328S
72340
72340S
72353
72353S
72368
72368S
72380
72380S
72395
72395S
72404
72404S
72416
72416S
72428
72428S
72429
72429S
72456
72456S
72468
72468S
72475
72475S
72329
72329S
72341
72341S
72354
72354S
72369
72369S
72381
72381S
72396

O.D.

FREE LENGTH
Inches

2.34
2.44
2.53
2.63
2.78
2.81
3.06
3.28
3.38
3.38
3.38
3.50
4.09
4.38
4.56
7.25
12.0
15.3
16.1
.75
.75
.75
.75
.75
.75
.75
.75
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

59.5
61.9
64.3
66.7
70.6
71.4
77.8
83.3
85.7
85.7
85.7
88.9
104.0
111.1
115.9
184.2
304.8
387.4
409.6
19.1
19.1
19.1
19.1
19.1
19.1
19.1
19.1
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8

I.D.
Inches

.824
.808
.812
.688
.832
.788
.780
.718
.878
.728
.698
.758
.808
.808
.720
.778
.728
.758
.808
.849
.849
.831
.831
.827
.827
.813
.813
.827
.827
.805
.805
.791
.791
.783
.783
.765
.765
.751
.751
.725
.725
.705
.705
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791
.791
.783
.783
.765
.765
.751
.751
.751
.751
.725
.725
.705
.705
.679
.679
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791

RATE
mm

20.9
20.5
20.6
17.5
21.1
20.0
19.8
18.2
22.3
18.5
17.7
19.3
20.5
20.5
18.3
19.8
18.5
19.3
20.5
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
21.0
21.0
20.4
20.4
20.1
20.1
19.9
19.9
19.4
19.4
19.1
19.1
18.4
18.4
17.9
17.9
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1
20.1
19.9
19.9
19.4
19.4
19.1
19.1
19.1
19.1
18.4
18.4
17.9
17.9
17.2
17.2
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

11
11
15
111
7.5
15
15
42
.94
47
83
30
8.4
5.6
49
7.7
14
5.8
2.0
26
22
40
34
40
34
61
51
33
28
54
46
72
61
85
72
119
101
155
131
247
210
357
303
18
16
28
24
28
24
44
37
52
44
61
52
74
63
101
86
131
111
151
128
207
176
298
253
459
390
14
12
22
18
22
18
34
29
40
34
47

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

1.9
1.8
2.6
19
1.3
2.7
2.7
7.4
.16
8.2
14
5.3
1.5
.98
8.6
1.3
2.4
1.0
.34
4.5
3.8
6.9
5.9
7.0
5.9
11
9.0
5.8
4.9
9.4
8.0
13
11
15
13
21
18
27
23
43
37
62
53
3.2
2.7
4.9
4.2
4.9
4.2
7.6
6.5
9.0
7.7
11
9.1
13
11
18
15
23
19
26
22
36
31
52
44
80
68
2.5
2.1
3.8
3.2
3.8
3.2
5.9
5.0
6.9
5.9
8.2

Inches

mm

1.2
32
1.6
42
1.1
28
.76 19
1.5
38
1.5
38
1.7
43
1.4
35
2.9
74
1.2
30
.92 23
1.3
33
2.2
55
3.0
77
1.2
32
3.8
96
4.1 103
6.7 171
9.3 236
.51 13
.40 10
.47 12
.37
9.4
.49 12
.40 10
.43 11
.34
8.7
.60 15
.48 12
.54 14
.44 11
.50 13
.40 10
.48 12
.38
9.7
.43 11
.35
9.0
.40 10
.31
8.0
.33
8.5
.27
6.9
.30
7.6
.23
5.7
.71 18
.57 14
.66 17
.52 13
.69 18
.56 14
.60 15
.47 12
.59 15
.46 12
.59 15
.47 12
.56 14
.44 11
.51 13
.42 11
.47 12
.37
9.4
.42 11
.32
8.2
.41 10
.32
8.2
.36
9.1
.27
6.9
.30
7.7
.23
5.8
.91 23
.73 19
.85 22
.67 17
.90 23
.73 19
.77 20
.61 15
.76 19
.60 15
.77 19

ENDS: C - Closed

G - Ground
O - Open

Lbs.

13
17
17
85
11
23
26
57
2.7
56
76
39
18
17
61
29
56
39
18
13
8.8
18
12
20
13
26
18
20
13
29
20
36
24
41
28
52
36
62
41
82
57
106
68
13
8.8
18
12
20
13
26
18
30
20
36
24
42
28
52
36
61
41
63
41
84
57
106
68
139
89
13
8.8
18
12
19
13
26
18
30
20
36

59
77
75
378
50
102
116
255
12
248
340
173
81
75
273
129
248
173
81
58
39
82
55
87
60
117
78
88
60
129
90
160
108
182
123
230
160
278
184
365
253
473
304
58
39
82
55
87
60
117
78
134
90
159
108
185
123
231
160
272
184
281
184
374
253
473
304
617
397
58
39
82
55
87
60
117
78
134
90
159

Inches

mm

Inches

.50 12.8
.80 20.3
.62 15.8
1.51 38.2
.48 12.1
.90 22.9
1.08 27.5
1.79 45.5
.45 11.4
1.50 38.1
1.62 41.1
1.26 32.0
1.04 26.4
1.36 34.5
1.67 42.5
2.47 62.7
4.38 111.3
5.15 130.7
3.60 91.4
.20
5.0
.20
5.0
.24
6.2
.24
6.2
.26
6.6
.26
6.6
.27
6.9
.27
6.9
.28
7.0
.28
7.0
.34
8.6
.34
8.6
.38
9.6
.38
9.6
.40 10.1
.40 10.1
.45 11.3
.45 11.3
.48 12.1
.48 12.1
.55 13.9
.55 13.9
.57 14.6
.57 14.6
.23
5.8
.23
5.8
.28
7.1
.28
7.1
.31
7.8
.31
7.8
.32
8.2
.32
8.2
.35
8.9
.35
8.9
.41 10.5
.41 10.5
.42 10.7
.42 10.7
.49 12.3
.49 12.3
.53 13.5
.53 13.5
.49 12.4
.49 12.4
.59 15.1
.59 15.1
.64 16.3
.64 16.3
.68 17.4
.68 17.4
.26
6.6
.26
6.6
.32
8.0
.32
8.0
.35
8.9
.35
8.9
.36
9.3
.36
9.3
.40 10.3
.40 10.3
.48 12.3

0.072
0.080
0.078
0.140
0.068
0.090
0.094
0.125
0.045
0.120
0.135
0.105
0.080
0.080
0.124
0.095
0.120
0.105
0.080
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.074
0.074
0.085
0.085
0.092
0.092
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092
0.092
0.096
0.096
0.105
0.105
0.112
0.112
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092

mm

TOTAL
MATL
COILS

1.8
2.0
2.0
3.6
1.7
2.3
2.4
3.2
1.1
3.0
3.4
2.7
2.0
2.0
3.1
2.4
3.0
2.7
2.0
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
1.9
1.9
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3

7.00
10.0
7.00
10.8
7.00
10.0
11.5
14.3
10.0
12.5
12.0
11.0
12.0
17.0
13.5
25.0
35.5
49.0
45.0
3.13
3.13
3.38
3.38
3.50
3.50
3.38
3.38
3.75
3.75
4.00
4.00
4.13
4.13
4.13
4.13
4.25
4.25
4.25
4.25
4.38
4.38
4.25
4.25
3.63
3.63
3.88
3.88
4.13
4.13
4.00
4.00
4.13
4.13
4.50
4.50
4.38
4.38
4.63
4.63
4.75
4.75
4.38
4.38
4.75
4.75
4.75
4.75
4.63
4.63
4.13
4.13
4.38
4.38
4.75
4.75
4.50
4.50
4.75
4.75
5.25

SPR
SPR
SPR
SPR
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
Z
Z
Z
N
N
N
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
GI
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

177

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 178

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975

24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77

72396S
72405
72405S
72417
72417S
72430
72430S
72457
72457S
72330
72330S
72342
72342S
72355
72355S
72370
72370S
72382
72382S
72397
72397S
72406
72406S
72418
72418S
72431
72431S
72447
72447S
72458
72458S
72469
72469S
72476
72476S
72482
72482S
72331
72331S
72343
72343S
72357
72357S
72371
72371S
72383
72383S
72384
72384S
72407
72407S
72419
72419S
72432
72432S
72440
72440S
72448
72448S
72459
72459S
72332
72332S
72344
72344S
72358
72358S
72372
72372S
72385
72385S
72398
72398S
72408
72408S
72420
72420S
72433
72433S
72441

1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8

MATERIAL: MW - Music Wire

178

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.791
.783
.783
.765
.765
.751
.751
.725
.725
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791
.791
.783
.783
.765
.765
.751
.751
.735
.735
.725
.725
.705
.705
.679
.679
.651
.651
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.805
.805
.783
.783
.765
.765
.751
.751
.745
.745
.735
.735
.725
.725
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791
.791
.783
.783
.765
.765
.751
.751
.745

RATE
mm

20.1
19.9
19.9
19.4
19.4
19.1
19.1
18.4
18.4
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1
20.1
19.9
19.9
19.4
19.4
19.1
19.1
18.7
18.7
18.4
18.4
17.9
17.9
17.2
17.2
16.5
16.5
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.4
20.4
19.9
19.9
19.4
19.4
19.1
19.1
18.9
18.9
18.7
18.7
18.4
18.4
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1
20.1
19.9
19.9
19.4
19.4
19.1
19.1
18.9

Lbs./In.

40
56
48
81
69
102
87
155
132
12
9.9
18
15
18
15
28
23
32
27
38
32
46
39
65
56
82
70
114
97
131
112
177
150
268
228
415
353
9.9
8.4
15
13
16
13
23
20
30
26
25
21
40
34
54
46
71
60
78
66
95
81
109
93
8.5
7.3
13
11
13
11
20
17
23
20
27
23
35
28
47
40
59
50
68

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

7.0
9.9
8.4
14
12
18
15
27
23
2.0
1.7
3.1
2.6
3.1
2.6
4.8
4.1
5.6
4.8
6.6
5.6
8.0
6.8
11
9.7
14
12
20
17
23
20
31
26
47
40
73
62
1.7
1.5
2.6
2.2
2.7
2.3
4.1
3.5
5.3
4.5
4.3
3.7
7.0
5.9
9.5
8.1
12
11
14
12
17
14
19
16
1.5
1.3
2.3
1.9
2.3
1.9
3.5
3.0
4.1
3.5
4.8
4.1
5.8
4.9
8.2
7.0
10
8.8
12

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

.61
.74
.57
.67
.52
.62
.48
.55
.43
1.1
.89
1.0
.83
1.1
.89
.95
.75
.94
.74
.95
.76
.91
.71
.83
.65
.77
.59
.68
.52
.66
.51
.60
.45
.52
.39
.42
.32
1.3
1.1
1.2
.98
1.3
1.0
1.1
.89
1.0
.79
1.2
.96
1.0
.82
1.0
.78
.89
.68
.88
.67
.81
.63
.80
.61
1.5
1.2
1.4
1.1
1.5
1.2
1.3
1.0
1.3
1.0
1.3
1.0
1.3
.98
1.2
.90
1.1
.82
1.0

mm

16
19
15
17
13
16
12
14
11
28
23
27
21
28
23
24
19
24
19
24
19
23
18
21
16
20
15
17
13
17
13
15
12
13
9.9
11
8.0
34
27
32
25
33
26
29
23
25
20
31
24
27
21
25
20
23
17
22
17
21
16
20
16
39
31
36
29
38
31
33
26
33
26
33
27
32
25
29
23
27
21
26

Lbs.

24
42
28
54
36
63
41
85
57
13
8.8
18
12
20
13
26
18
30
20
36
24
42
28
54
36
63
41
77
51
87
57
106
68
139
89
176
111
13
8.8
18
12
20
13
26
18
30
20
30
20
42
28
54
36
63
41
68
45
77
51
87
57
13
8.8
18
12
19
13
26
18
30
20
36
24
42
28
54
36
63
41
68

ENDS: C - Closed

G - Ground
O - Open

108
185
123
241
160
281
184
378
253
58
39
82
55
87
60
117
78
134
90
159
108
185
123
241
160
281
184
344
225
388
253
473
304
617
397
782
496
58
39
82
55
89
60
117
78
134
90
134
90
185
123
241
160
281
184
304
199
344
225
388
253
58
39
82
55
87
60
117
78
134
90
160
108
185
123
241
160
281
184
304

Inches

.48
.49
.49
.55
.55
.62
.62
.70
.70
.29
.29
.36
.36
.40
.40
.42
.42
.45
.45
.55
.55
.56
.56
.63
.63
.70
.70
.75
.75
.80
.80
.88
.88
.96
.96
1.05
1.05
.32
.32
.40
.40
.43
.43
.47
.47
.47
.47
.53
.53
.62
.62
.72
.72
.78
.78
.82
.82
.84
.84
.91
.91
.35
.35
.44
.44
.49
.49
.51
.51
.55
.55
.69
.69
.71
.71
.80
.80
.90
.90
.91

mm

12.3
12.5
12.5
14.0
14.0
15.6
15.6
17.9
17.9
7.4
7.4
9.1
9.1
10.1
10.1
10.5
10.5
11.3
11.3
14.0
14.0
14.3
14.3
16.0
16.0
17.8
17.8
19.1
19.1
20.2
20.2
22.3
22.3
24.4
24.4
26.7
26.7
8.0
8.0
10.1
10.1
10.8
10.8
11.8
11.8
11.9
11.9
13.5
13.5
15.8
15.8
18.3
18.3
19.9
19.9
20.8
20.8
21.3
21.3
23.0
23.0
8.8
8.8
11.2
11.2
12.5
12.5
12.9
12.9
14.0
14.0
17.5
17.5
18.0
18.0
20.3
20.3
22.8
22.8
23.0

WIRE DIA.
Inches

mm

0.092
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092
0.092
0.096
0.095
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.115
0.115
0.120
0.120
0.125
0.125
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092
0.092
0.096
0.096
0.105
0.105
0.112
0.112
0.115

2.3
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
2.9
2.9
3.0
3.0
3.2
3.2
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
2.9

FINISH: Z - Zinc

TOTAL
MATL
COILS
5.25
5.13
5.13
5.25
5.25
5.50
5.50
5.63
5.63
4.63
4.63
5.00
5.00
5.38
5.38
5.13
5.13
5.25
5.25
6.00
6.00
5.88
5.88
6.00
6.00
6.25
6.25
6.25
6.25
6.38
6.38
6.50
6.50
6.50
6.50
6.50
6.50
5.00
5.00
5.50
5.50
5.75
5.75
5.75
5.75
5.50
5.50
6.25
6.25
6.50
6.50
6.88
6.88
7.00
7.00
7.13
7.13
7.00
7.00
7.25
7.25
5.50
5.50
6.13
6.13
6.63
6.63
6.25
6.25
6.50
6.50
7.50
7.50
7.38
7.38
7.63
7.63
8.00
8.00
7.88

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 179

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975

24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77

72441S
72449
72449S
72460
72460S
72470
72470S
72477
72477S
72483
72483S
72333
72333S
72345
72345S
72360
72360S
72373
72373S
72386
72386S
72387
72387S
72409
72409S
72421
72421S
72434
72434S
72442
72442S
72450
72450S
72461
72461S
72334
72334S
72346
72346S
72361
72361S
72374
72374S
72388
72388S
72399
72399S
72410
72410S
72422
72422S
72435
72435S
72443
72443S
72451
72451S
72462
72462S
72471
72471S
72478
72478S
72484
72484S
72335
72335S
72347
72347S
72363
72363S
72375
72375S
72389
72389S
72390
72390S
72411
72411S
72423

2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75
2.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9
69.9

I.D.
Inches

.745
.735
.735
.725
.725
.705
.705
.679
.679
.651
.651
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.805
.805
.783
.783
.765
.765
.751
.751
.745
.745
.735
.735
.725
.725
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791
.791
.783
.783
.765
.765
.751
.751
.745
.745
.735
.735
.725
.725
.705
.705
.679
.679
.651
.651
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.805
.805
.783
.783
.765

RATE
mm

18.9
18.7
18.7
18.4
18.4
17.9
17.9
17.2
17.2
16.5
16.5
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.4
20.4
19.9
19.9
19.4
19.4
19.1
19.1
18.9
18.9
18.7
18.7
18.4
18.4
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1
20.1
19.9
19.9
19.4
19.4
19.1
19.1
18.9
18.9
18.7
18.7
18.4
18.4
17.9
17.9
17.2
17.2
16.5
16.5
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.4
20.4
19.9
19.9
19.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

58
82
70
94
80
126
107
190
161
291
248
7.5
6.4
11
9.7
12
10
18
15
23
19
19
16
30
26
41
35
54
46
59
50
71
60
82
70
6.7
5.7
10
8.6
10
8.7
16
13
18
16
22
18
26
22
36
31
46
39
52
44
64
54
73
62
98
83
147
125
224
191
6.1
5.2
9.2
7.8
9.6
8.2
14
12
18
16
15
13
24
21
33

10
14
12
16
14
22
19
33
28
51
43
1.3
1.1
2.0
1.7
2.1
1.8
3.1
2.6
4.0
3.4
3.3
2.8
5.3
4.5
7.2
6.1
9.5
8.0
10
8.8
12
11
14
12
1.2
1.0
1.8
1.5
1.8
1.5
2.8
2.4
3.2
2.7
3.8
3.2
4.5
3.9
6.4
5.4
8.0
6.8
9.1
7.7
11
9.5
13
11
17
15
26
22
39
33
1.1
.91
1.6
1.4
1.7
1.4
2.5
2.1
3.2
2.8
2.7
2.3
4.3
3.6
5.7

.77
.94
.73
.93
.71
.85
.64
.73
.55
.60
.45
1.7
1.4
1.6
1.3
1.7
1.3
1.5
1.2
1.3
1.0
1.6
1.3
1.4
1.1
1.3
1.0
1.2
.90
1.2
.89
1.1
.84
1.1
.82
1.9
1.5
1.8
1.4
1.9
1.6
1.7
1.3
1.6
1.3
1.7
1.3
1.6
1.2
1.5
1.2
1.4
1.1
1.3
1.0
1.2
.93
1.2
.92
1.1
.82
.95
.72
.78
.58
2.1
1.7
2.0
1.6
2.1
1.6
1.8
1.4
1.6
1.3
2.0
1.6
1.7
1.3
1.7

mm

20
24
18
24
18
21
16
19
14
15
11
44
35
41
33
43
34
38
30
33
26
41
32
35
27
33
26
30
23
29
23
28
21
27
21
49
39
46
36
49
39
42
33
42
33
42
34
41
32
38
29
35
27
33
26
31
24
30
23
28
21
24
18
20
15
54
43
51
40
53
42
47
37
42
33
50
40
44
34
42

ENDS: C - Closed

G - Ground
O - Open

Lbs.

45
77
51
87
57
106
68
139
89
176
111
13
8.8
18
12
20
13
26
18
30
20
30
20
42
28
54
36
63
41
68
45
77
51
87
57
13
8.8
18
12
20
13
26
18
30
20
36
24
42
28
54
36
63
41
68
45
77
51
87
57
106
68
139
89
176
111
13
8.8
18
12
20
13
26
18
30
20
30
20
42
28
54

199
344
225
388
253
473
304
617
397
782
496
58
39
82
55
89
60
117
78
134
90
134
90
185
123
241
160
281
184
304
199
344
225
388
253
58
39
82
55
87
60
117
78
134
90
160
108
185
123
241
160
281
184
304
199
344
225
388
253
473
304
617
397
782
496
58
39
82
55
89
60
117
78
134
90
134
90
185
123
241

Inches

.91
.95
.95
1.02
1.02
1.13
1.13
1.24
1.24
1.36
1.36
.38
.38
.48
.48
.52
.52
.56
.56
.56
.56
.65
.65
.77
.77
.89
.89
.95
.95
1.01
1.01
1.05
1.05
1.13
1.13
.40
.40
.51
.51
.57
.57
.61
.61
.66
.66
.83
.83
.85
.85
.97
.97
1.08
1.08
1.11
1.11
1.14
1.14
1.23
1.23
1.38
1.38
1.54
1.54
1.66
1.66
.43
.43
.56
.56
.60
.60
.65
.65
.66
.66
.77
.77
.90
.90
1.06

mm

Inches

23.0
24.0
24.0
25.8
25.8
28.7
28.7
31.5
31.5
34.5
34.5
9.6
9.6
12.1
12.1
13.2
13.2
14.1
14.1
14.3
14.3
16.5
16.5
19.5
19.5
22.7
22.7
24.2
24.2
25.6
25.6
26.7
26.7
28.6
28.6
10.2
10.2
13.0
13.0
14.6
14.6
15.4
15.4
16.7
16.7
21.0
21.0
21.6
21.6
24.7
24.7
27.4
27.4
28.1
28.1
29.0
29.0
31.4
31.4
35.1
35.1
39.0
39.0
42.2
42.2
11.0
11.0
14.2
14.2
15.3
15.3
16.5
16.5
16.7
16.7
19.4
19.4
22.9
22.9
27.0

0.115
0.120
0.120
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.115
0.115
0.120
0.120
0.125
0.125
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092
0.092
0.096
0.096
0.105
0.105
0.112
0.112
0.115
0.115
0.120
0.120
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.085
0.085
0.096
0.096
0.105

mm

TOTAL
MATL
COILS

2.9
3.0
3.0
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
2.9
2.9
3.0
3.0
3.2
3.2
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
2.9
2.9
3.0
3.0
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.2
2.2
2.4
2.4
2.7

7.88
7.88
7.88
8.13
8.13
8.38
8.38
8.38
8.38
8.38
8.38
6.00
6.00
6.63
6.63
7.00
7.00
6.88
6.88
6.63
6.63
7.63
7.63
8.00
8.00
8.50
8.50
8.50
8.50
8.75
8.75
8.75
8.75
9.00
9.00
6.38
6.38
7.13
7.13
7.75
7.75
7.50
7.50
7.75
7.75
9.00
9.00
8.88
8.88
9.25
9.25
9.63
9.63
9.63
9.63
9.50
9.50
9.88
9.88
10.3
10.3
10.4
10.4
10.3
10.3
6.88
6.88
7.75
7.75
8.13
8.13
8.00
8.00
7.75
7.75
9.00
9.00
9.38
9.38
10.1

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

179

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 180

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975

24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77

72423S
72436
72436S
72463
72463S
72336
72336S
72348
72348S
72364
72364S
72376
72376S
72391
72391S
72400
72400S
72412
72412S
72424
72424S
72437
72437S
72444
72444S
72452
72452S
72464
72464S
72472
72472S
72479
72479S
72485
72485S
72337
72337S
72349
72349S
72365
72365S
72377
72377S
72392
72392S
72401
72401S
72413
72413S
72425
72425S
72438
72438S
72445
72445S
72453
72453S
72465
72465S
72473
72473S
72480
72480S
72486
72486S
72338
72338S
72350
72350S
72366
72366S
72378
72378S
72393
72393S
72402
72402S
72414
72414S
72426

2.75
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

69.9
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6

MATERIAL: MW - Music Wire

180

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.765
.751
.751
.725
.725
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791
.791
.783
.783
.765
.765
.751
.751
.745
.745
.735
.735
.725
.725
.705
.705
.679
.679
.651
.651
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791
.791
.783
.783
.765
.765
.751
.751
.745
.745
.735
.735
.725
.725
.705
.705
.679
.679
.651
.651
.849
.849
.831
.831
.827
.827
.813
.813
.805
.805
.791
.791
.783
.783
.765

RATE
mm

19.4
19.1
19.1
18.4
18.4
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1
20.1
19.9
19.9
19.4
19.4
19.1
19.1
18.9
18.9
18.7
18.7
18.4
18.4
17.9
17.9
17.2
17.2
16.5
16.5
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1
20.1
19.9
19.9
19.4
19.4
19.1
19.1
18.9
18.9
18.7
18.7
18.4
18.4
17.9
17.9
17.2
17.2
16.5
16.5
21.6
21.6
21.1
21.1
21.0
21.0
20.7
20.7
20.4
20.4
20.1
20.1
19.9
19.9
19.4

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

28
43
37
62
53
5.6
4.7
8.4
7.1
8.4
7.1
13
11
15
13
18
15
21
18
30
25
38
32
43
37
52
44
60
51
80
68
120
102
183
155
4.7
4.0
7.1
6.1
7.1
6.0
11
9.4
13
11
15
13
18
15
26
22
32
27
36
31
44
37
50
43
67
57
101
86
154
131
4.1
3.5
6.2
5.3
6.2
5.3
9.7
8.2
12
11
13
11
16
14
22

4.9
7.5
6.4
11
9.3
.97
.83
1.5
1.2
1.5
1.3
2.3
1.9
2.6
2.3
3.1
2.6
3.7
3.2
5.2
4.4
6.6
5.6
7.5
6.4
9.1
7.7
10
8.9
14
12
21
18
32
27
.83
.71
1.2
1.1
1.2
1.1
1.9
1.7
2.3
1.9
2.6
2.2
3.2
2.7
4.5
3.8
5.6
4.8
6.3
5.4
7.7
6.5
8.8
7.5
12
10
18
15
27
23
.72
.61
1.1
.92
1.1
.92
1.7
1.4
2.2
1.9
2.3
1.9
2.8
2.4
3.9

1.3
1.5
1.1
1.3
1.1
2.3
1.9
2.2
1.7
2.3
1.9
2.0
1.6
2.0
1.6
2.0
1.6
1.9
1.5
1.8
1.4
1.7
1.3
1.6
1.2
1.5
1.1
1.5
1.1
1.3
1.0
1.2
.88
.96
.72
2.7
2.2
2.6
2.0
2.7
2.2
2.4
1.9
2.3
1.9
2.4
1.9
2.3
1.8
2.1
1.6
2.0
1.5
1.9
1.5
1.8
1.4
1.7
1.3
1.6
1.2
1.4
1.0
1.1
.85
3.2
2.5
3.0
2.3
3.1
2.6
2.7
2.1
2.4
1.9
2.8
2.2
2.6
2.0
2.4

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

33
37
29
34
27
59
47
56
44
59
48
51
40
51
40
52
41
49
39
46
36
43
33
40
31
38
29
37
29
34
26
29
22
24
18
70
56
66
52
70
57
60
47
60
47
61
48
58
45
54
42
50
39
48
37
45
34
44
34
40
30
35
26
29
22
80
64
76
60
80
65
69
54
62
49
70
56
65
51
62

Lbs.

36
63
41
84
57
13
8.8
18
12
20
13
26
18
30
20
36
24
42
28
54
36
63
41
68
45
77
51
87
57
106
68
139
89
176
111
13
8.8
18
12
19
13
26
18
30
20
36
24
42
28
54
36
63
41
68
45
77
51
87
57
106
68
139
89
176
111
13
8.8
18
12
20
13
26
18
30
20
36
24
42
28
54

ENDS: C - Closed

G - Ground
O - Open

160
281
184
372
253
58
39
82
55
87
60
117
78
134
90
160
108
185
123
241
160
281
184
304
199
344
225
388
253
473
304
617
397
782
496
58
39
82
55
87
60
117
78
134
90
160
108
185
123
241
160
281
184
304
199
344
225
388
253
473
304
617
397
782
496
58
39
82
55
87
60
117
78
134
90
159
108
185
123
241

Inches

1.06
1.13
1.13
1.41
1.41
.46
.46
.59
.59
.67
.67
.70
.70
.77
.77
.97
.97
1.00
1.00
1.14
1.14
1.26
1.26
1.29
1.29
1.34
1.34
1.45
1.45
1.64
1.64
1.81
1.81
1.96
1.96
.52
.52
.68
.68
.76
.76
.79
.79
.87
.87
1.10
1.10
1.14
1.14
1.30
1.30
1.46
1.46
1.50
1.50
1.55
1.55
1.67
1.67
1.89
1.89
2.09
2.09
2.27
2.27
.58
.58
.76
.76
.85
.85
.89
.89
.89
.89
1.24
1.24
1.26
1.26
1.46

mm

27.0
28.8
28.8
35.7
35.7
11.8
11.8
15.1
15.1
16.9
16.9
17.7
17.7
19.4
19.4
24.5
24.5
25.3
25.3
29.0
29.0
32.0
32.0
32.9
32.9
33.9
33.9
36.9
36.9
41.6
41.6
46.1
46.1
49.9
49.9
13.2
13.2
17.1
17.1
19.3
19.3
20.1
20.1
22.1
22.1
28.0
28.0
29.0
29.0
33.0
33.0
37.0
37.0
38.0
38.0
39.2
39.2
42.5
42.5
48.0
48.0
53.1
53.1
57.6
57.6
14.8
14.8
19.2
19.2
21.6
21.6
22.6
22.6
22.7
22.7
31.5
31.5
32.0
32.0
37.0

WIRE DIA.
Inches

0.105
0.112
0.112
0.125
0.125
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092
0.092
0.096
0.096
0.105
0.105
0.112
0.112
0.115
0.115
0.120
0.120
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092
0.092
0.096
0.096
0.105
0.105
0.112
0.112
0.115
0.115
0.120
0.120
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.063
0.063
0.072
0.072
0.074
0.074
0.081
0.081
0.085
0.085
0.092
0.092
0.096
0.096
0.105

mm

TOTAL
MATL
COILS

2.7
2.8
2.8
3.2
3.2
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
2.9
2.9
3.0
3.0
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7
2.7
2.8
2.8
2.9
2.9
3.0
3.0
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
1.6
1.6
1.8
1.8
1.9
1.9
2.1
2.1
2.2
2.2
2.3
2.3
2.4
2.4
2.7

10.1
10.1
10.1
11.3
11.3
7.38
7.38
8.25
8.25
9.00
9.00
8.63
8.63
9.00
9.00
10.5
10.5
10.4
10.4
10.9
10.9
11.3
11.3
11.3
11.3
11.1
11.1
11.6
11.6
12.1
12.1
12.3
12.3
12.1
12.1
8.25
8.25
9.38
9.38
10.3
10.3
9.75
9.75
10.3
10.3
12.0
12.0
11.9
11.9
12.4
12.4
13.0
13.0
13.0
13.0
12.9
12.9
13.4
13.4
14.0
14.0
14.1
14.1
14.0
14.0
9.25
9.25
10.5
10.5
11.5
11.5
11.0
11.0
10.5
10.5
13.5
13.5
13.1
13.1
13.9

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 181

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.975
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
0.984
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000

24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.77
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
24.99
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40

72426S
72439
72439S
72446
72446S
72454
72454S
72466
72466S
72474
72474S
72481
72481S
72487
72487S
3336
2832
12579
S-3104
10652
1659
11942
2635
3146
1513
B12-24
S-1048
322
S-3087
3402
11866
12041
S-183
S-3084
12205
2599
12704
S-1570
10861
II-78
S-470
S-1201
3862
B18-199
12427
S-1590
10395
11673
M-141
11752
2622
4371
1807
10429
3188
10586
11623
11630
3410
10924
11998
LL-49
11894
10287
2692
B8-41
S-1233
S-178
AA-48
4211
S-1360
11763
12402
11534
11548
11805
27
4341
S-1599
3854

4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
.72
.81
.81
.88
.94
1.00
1.00
1.00
1.03
1.06
1.06
1.19
1.19
1.25
1.25
1.31
1.34
1.41
1.47
1.50
1.50
1.63
1.72
1.75
1.75
1.78
1.81
1.88
2.09
2.16
2.25
2.25
2.38
2.47
2.50
2.72
3.00
3.00
3.50
3.63
3.75
4.00
4.00
5.00
6.94
8.06
.66
.78
.84
.88
.88
.88
.88
.94
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.13
1.16
1.19

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
18.2
20.6
20.6
22.2
23.8
25.4
25.4
25.4
26.2
27.0
27.0
30.2
30.2
31.8
31.8
33.3
34.1
35.7
37.3
38.1
38.1
41.3
43.6
44.5
44.5
45.2
46.0
47.6
53.2
54.8
57.2
57.2
60.3
62.7
63.5
69.0
76.2
76.2
88.9
92.1
95.3
101.6
101.6
127.0
176.2
204.8
16.7
19.8
21.4
22.2
22.2
22.2
22.2
23.8
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
28.6
29.4
30.2

I.D.
Inches

.765
.751
.751
.745
.745
.735
.735
.725
.725
.705
.705
.679
.679
.651
.651
.794
.800
.794
.904
.824
.860
.792
.690
.894
.914
.890
.840
.824
.894
.656
.862
.674
.784
.814
.800
.774
.796
.916
.914
.704
.688
.814
.774
.784
.884
.906
.834
.686
.484
.824
.600
.814
.774
.758
.890
.820
.626
.624
.660
.760
.564
.760
.894
.876
.906
.858
.856
.790
.820
.910
.880
.876
.852
.840
.808
.790
.730
.804
.852
.750

RATE
mm

19.4
19.1
19.1
18.9
18.9
18.7
18.7
18.4
18.4
17.9
17.9
17.2
17.2
16.5
16.5
20.2
20.3
20.2
23.0
20.9
21.8
20.1
17.5
22.7
23.2
22.6
21.3
20.9
22.7
16.7
21.9
17.1
19.9
20.7
20.3
19.7
20.2
23.3
23.2
17.9
17.5
20.7
19.7
19.9
22.5
23.0
21.2
17.4
12.3
20.9
15.2
20.7
19.7
19.3
22.6
20.8
15.9
15.8
16.8
19.3
14.3
19.3
22.7
22.3
23.0
21.8
21.7
20.1
20.8
23.1
22.4
22.3
21.6
21.3
20.5
20.1
18.5
20.4
21.6
19.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

mm

19
3.3
29
5.0
24
4.3
32
5.6
27
4.8
38
6.7
32
5.7
44
7.7
37
6.5
58
10
50
8.7
87
15
74
13
133
23
113
20
111
19
97
17
111
19
1.3
.22
29
5.1
11
1.9
44
7.6
763 134
2.5
.43
1.0
.18
2.8
.50
15
2.6
30
5.2
3.1
.54
539
94
13
2.2
485
85
53
9.2
26
4.5
32
5.6
57
10
40
7.0
.53
.09
.60
.10
153
27
209
37
9.0
1.6
37
6.4
31
5.4
3.3
.57
.58
.10
15
2.7
187
33
2367 414
10
1.7
562
98
12
2.1
22
3.9
31
5.4
1.1
.19
6.0
1.1
189
33
194
34
94
17
12
2.0
246
43
437
77
6.7
1.2
10
1.8
4.1
.71
10
1.8
11
1.8
106
19
32
5.6
2.7
.47
9.8
1.7
8.6
1.5
22
3.8
23
4.1
66
12
216
38
268
47
52
9.0
19
3.4
140
24

1.9
2.2
1.7
2.1
1.6
2.0
1.6
2.0
1.5
1.8
1.4
1.6
1.2
1.3
.99
.26
.38
.26
.64
.48
.66
.42
.18
.81
.87
.83
.83
.60
1.0
.24
.67
.23
.58
.78
.81
.67
.97
1.5
1.5
.55
.42
.79
.93
1.0
1.3
1.9
.98
.54
.16
1.7
.34
1.8
1.6
1.5
3.1
2.5
.88
.83
1.3
3.5
1.0
.12
.52
.56
.64
.45
.44
.33
.44
.75
.70
.63
.00
.50
.44
.16
.28
.59
.68
.44

48
56
43
54
42
52
40
51
39
46
35
40
31
34
25
6.5
9.5
6.5
16
12
17
11
4.5
21
22
21
21
15
26
6.1
17
5.7
15
20
20
17
25
38
38
14
11
20
24
25
34
48
25
14
4.1
43
8.7
46
40
38
79
64
22
21
34
89
26
3.1
13
14
16
11
11
8.4
11
19
18
16
.00
13
11
4.1
7.0
15
17
11

ENDS: C - Closed

G - Ground
O - Open

Lbs.

36
160
63
281
41
184
68
304
45
199
77
344
51
225
87
388
57
253
106
473
68
304
139
617
89
397
176
782
111
496
29
127
36
162
29
127
.81
3.6
14
62
7.1
32
18
82
135
600
2.0
8.9
.88
3.9
2.4
10
12
54
18
80
3.2
14
129
574
8.4
38
110
488
31
137
20
89
26
116
38
171
38
171
.79
3.5
.90
4.0
84
372
89
394
7.1
32
34
152
31
137
4.4
20
1.1
4.9
15
66
100
446
385 1714
17
75
193
859
21
95
35
157
46
205
3.3
15
15
68
166
737
161
715
124
554
41
182
248 1104
54
241
3.4
15
5.8
26
2.6
12
4.5
20
4.7
21
35
156
14
62
2.0
9.1
6.8
30
5.4
24
.00
.00
12
52
29
129
35
156
74
330
30
135
13
58
61
271

Inches

mm

Inches

1.46 37.0
1.60 40.5
1.60 40.5
1.65 42.0
1.65 42.0
1.74 44.2
1.74 44.2
1.89 48.0
1.89 48.0
2.14 54.4
2.14 54.4
2.37 60.1
2.37 60.1
2.57 65.3
2.57 65.3
.33
8.4
.41 10.5
.33
8.5
.24
6.1
.46 11.7
.34
8.7
.58 14.6
.51 13.1
.22
5.6
.19
4.9
.24
6.0
.36
9.1
.45 11.5
.23
5.7
.90 22.9
.31
7.7
.78 19.7
.55 14.0
.47 11.9
.60 15.2
.68 17.3
.66 16.7
.23
5.8
.24
6.0
1.12 28.4
1.04 26.3
1.02 25.9
.95 24.0
.90 22.9
.30
7.6
.35
8.9
.53 13.3
1.27 32.2
2.00 50.8
.80 20.3
1.73 43.9
.91 23.2
1.42 36.0
1.53 38.7
.52 13.1
1.23 31.2
3.04 77.3
3.06 77.7
3.61 91.6
3.14 79.7
5.57 141.4
.36
9.1
.27
6.7
.28
7.1
.24
6.0
.43 10.8
.43 11.0
.42 10.7
.50 12.6
.25
6.3
.30
7.6
.37
9.4
.41 10.3
.50 12.7
.53 13.4
.32
8.0
.64 16.3
.54 13.7
.41 10.3
.72 18.3

0.105
0.112
0.112
0.115
0.115
0.120
0.120
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.095
0.092
0.095
0.040
0.080
0.062
0.096
0.147
0.045
0.035
0.047
0.072
0.080
0.045
0.164
0.061
0.155
0.100
0.085
0.092
0.105
0.094
0.034
0.035
0.140
0.148
0.085
0.105
0.100
0.050
0.039
0.075
0.149
0.250
0.080
0.192
0.085
0.105
0.113
0.047
0.082
0.179
0.180
0.162
0.112
0.210
0.120
0.053
0.062
0.047
0.071
0.072
0.105
0.090
0.045
0.060
0.062
0.074
0.080
0.096
0.105
0.135
0.098
0.074
0.125

mm

TOTAL
MATL
COILS

2.7
2.8
2.8
2.9
2.9
3.0
3.0
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
2.4
2.3
2.4
1.0
2.0
1.6
2.4
3.7
1.1
0.9
1.2
1.8
2.0
1.1
4.2
1.5
3.9
2.5
2.2
2.3
2.7
2.4
0.9
0.9
3.6
3.8
2.2
2.7
2.5
1.3
1.0
1.9
3.8
6.4
2.0
4.9
2.2
2.7
2.9
1.2
2.1
4.5
4.6
4.1
2.8
5.3
3.0
1.3
1.6
1.2
1.8
1.8
2.7
2.3
1.1
1.5
1.6
1.9
2.0
2.4
2.7
3.4
2.5
1.9
3.2

13.9
14.3
14.3
14.4
14.4
14.5
14.5
15.1
15.1
15.9
15.9
16.0
16.0
15.9
15.9
3.50
3.50
3.50
5.00
4.75
4.50
6.00
3.50
5.00
4.50
5.00
5.00
4.67
4.00
5.50
4.00
5.00
5.50
5.50
6.50
6.50
6.00
5.75
5.75
8.00
7.00
12.0
9.00
8.00
5.00
8.00
6.00
8.50
8.00
10.0
9.00
10.8
13.5
13.5
10.0
15.0
17.0
17.0
22.0
28.0
26.5
3.00
4.00
4.50
4.00
6.00
6.00
4.00
5.50
4.50
4.00
5.00
4.50
5.25
4.50
3.00
4.75
5.50
4.50
5.75

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SPR
SST
SPR
SPR
SPR
MW
SPR
HD
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
MW
SST
SST
SPR
SST
SST
HD
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
HD
SPR
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
HD
SST
SST
SST
SST
SPR
SST
SPR
DD
SPR
SPR
SST
HD
SPR
SST
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
C
CG
CG
CG
C
CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
C
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
N
GI
Z
Z
Z
Z
Z
N
N
GI
N
Z
N
Z
N
N
Z
Z
N
N
N
Z
N
N
Z
N
N
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
N
Z
Z
N
Z
Z
N
N
N
N
Z
N
Z
N
Z
Z
N
Z
Z
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

181

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 182

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000

25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40

10164
10251
Q-82
S-899
OO-90
S-53
S-1573
2864
10969
S-75
10791
12523
912
11812
11751
11832
3935
S-3033
12260
S-3195
10561
S-1485
S-3021
2767
10091
1771
10321
10006
S-3226
B17-189
2662
S-395
S-1386
S-3056
S-1147
11391
FF-79
S-106
11912
10697
S-293
4141
DD-67
B17-184
375
71
S-408
4311
10964
2587
12477
4207
10358
EE-56
10741
11135
3357
57
7052
HH-79
10550
S-1491
S-3204
S-252
4106
11555
S-1617
39
2728
38
3111
2716
2968
4228
4356
10548
10777
11615
10248
12556

1.25
1.25
1.34
1.38
1.38
1.38
1.50
1.50
1.50
1.72
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.78
1.88
1.94
2.00
2.00
2.00
2.00
2.00
2.03
2.09
2.13
2.13
2.16
2.19
2.19
2.25
2.25
2.25
2.25
2.25
2.28
2.31
2.38
2.38
2.50
2.50
2.50
2.50
2.59
2.63
2.72
2.75
2.75
2.88
2.94
3.00
3.00
3.00
3.00
3.00
3.00
3.13
3.19
3.25
3.25
3.38
3.38
3.50
3.50
3.50
3.50
3.50
3.63
3.75
3.75
3.75
3.94
4.00
4.00
4.19
4.25
4.45

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

31.8
31.8
34.1
34.9
34.9
34.9
38.1
38.1
38.1
43.6
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
45.2
47.6
49.2
50.8
50.8
50.8
50.8
50.8
51.6
53.2
54.0
54.0
54.8
55.6
55.6
57.2
57.2
57.2
57.2
57.2
57.9
58.7
60.3
60.3
63.5
63.5
63.5
63.5
65.9
66.7
69.0
69.9
69.9
73.0
74.6
76.2
76.2
76.2
76.2
76.2
76.2
79.4
81.0
82.6
82.6
85.7
85.7
88.9
88.9
88.9
88.9
88.9
92.1
95.3
95.3
95.3
100.0
101.6
101.6
106.4
108.0
113.0

MATERIAL: MW - Music Wire

182

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.750
.750
.814
.930
.892
.840
.892
.790
.646
.790
.930
.884
.876
.868
.840
.790
.760
.704
.840
.798
.818
.918
.876
.840
.818
.760
.774
.676
.816
.540
.730
.898
.892
.910
.876
.860
.820
.706
.878
.814
.790
.760
.860
.800
.790
.760
.676
.704
.750
.866
.840
.816
.750
.880
.876
.816
.782
.760
.744
.880
.750
.922
.922
.876
.810
.906
.894
.760
.676
.676
.914
.856
.790
.712
.830
.838
.820
.820
.812
.734

RATE
mm

19.1
19.1
20.7
23.6
22.7
21.3
22.7
20.1
16.4
20.1
23.6
22.5
22.3
22.0
21.3
20.1
19.3
17.9
21.3
20.3
20.8
23.3
22.3
21.3
20.8
19.3
19.7
17.2
20.7
13.7
18.5
22.8
22.7
23.1
22.3
21.8
20.8
17.9
22.3
20.7
20.1
19.3
21.8
20.3
20.1
19.3
17.2
17.9
19.1
22.0
21.3
20.7
19.1
22.4
22.3
20.7
19.9
19.3
18.9
22.4
19.1
23.4
23.4
22.3
20.6
23.0
22.7
19.3
17.2
17.2
23.2
21.7
20.1
18.1
21.1
21.3
20.8
20.8
20.6
18.6

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

31
33
5.0
.52
.09
6.3
1.1
17
3.0
3.7
.64
54
9.5
595 104
41
7.2
.57
.10
4.9
.85
5.7
1.0
7.4
1.3
22
3.8
41
7.2
87
15
194
34
15
2.6
52
9.1
22
3.8
1.3
.23
3.7
.65
14
2.5
26
4.6
109
19
75
13
240
42
17
3.1
1469 257
148
26
3.3
.58
3.1
.55
1.2
.21
4.7
.83
6.1
1.1
16
2.7
171
30
4.3
.75
18
3.1
30
5.3
58
10
5.4
.94
28
4.9
35
6.1
55
9.6
260
45
131
23
62
11
5.9
1.0
9.5
1.7
15
2.7
58
10
2.7
.46
2.0
.35
11
1.9
29
5.0
45
7.9
51
8.9
2.2
.39
63
11
.54
.10
.58
.10
3.0
.52
19
3.3
1.4
.24
1.3
.23
36
6.3
240
42
153
27
.93
.16
3.9
.68
27
4.7
90
16
6.5
1.1
12
2.1
9.8
1.7
9.6
1.7
16
2.8
53
9.3

.35
.32
.69
1.1
.87
.91
1.2
.70
.27
.85
1.5
1.4
1.3
1.3
.82
.85
.62
.45
1.1
.60
1.1
1.8
1.5
1.2
.94
.69
.61
.51
1.2
.29
.50
1.4
1.7
1.9
1.7
1.6
1.4
.50
1.8
1.3
1.2
.93
1.8
1.6
1.1
.99
.42
.74
.87
1.8
1.9
1.7
1.0
2.4
2.1
1.7
1.5
1.2
1.2
2.5
.96
2.9
2.9
2.7
1.5
3.0
2.9
1.5
.51
.80
3.3
2.6
1.4
1.0
2.5
1.5
2.4
2.5
1.7
1.2

175
190
29

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

8.9
8.1
18
29
22
23
31
18
6.8
22
38
36
33
34
21
22
16
11
29
15
27
45
38
32
24
18
15
13
31
7.2
13
35
44
48
44
39
34
13
47
32
29
24
46
41
28
25
11
19
22
47
47
43
27
60
53
44
37
31
30
63
24
75
75
70
38
77
74
39
13
20
83
67
35
25
63
38
62
63
44
30

Lbs.

61
61
20

271
271
89
.59
2.6
5.4
24
15
68
4.4
20
38
168
158
704
35
156
.86
3.8
6.8
30
7.3
33
9.8
44
18
78
35
156
54
241
87
388
17
77
31
139
23
102
2.3
10
5.6
25
18
78
25
110
76
336
45
202
123
546
21
93
419 1862
74
330
4.6
20
5.4
24
2.2
9.9
8.2
36
9.5
42
21
94
86
381
7.8
35
22
99
35
156
54
241
9.7
43
45
200
38
168
54
241
109
485
97
431
53
238
11
49
18
78
26
114
61
271
6.3
28
4.1
18
19
84
42
188
54
241
60
265
5.4
24
61
271
1.6
7.1
1.7
7.6
8.2
36
28
125
4.1
18
3.8
17
54
241
123
546
123
546
3.1
14
10
45
38
168
89
398
16
72
18
81
24
107
24
107
27
121
64
285

ENDS: C - Closed

G - Ground
O - Open

Inches

.63
.59
.65
.25
.27
.47
.30
.68
1.11
.76
.24
.35
.47
.43
.44
.76
.84
1.04
.64
.56
.67
.25
.50
.59
.73
.84
.73
1.46
.92
1.84
.95
.31
.38
.36
.42
.70
.90
1.10
.43
1.04
.95
1.26
.70
.90
1.05
1.20
1.26
1.55
1.85
.54
.80
1.01
1.38
.63
.93
1.27
1.31
1.41
1.66
.66
1.41
.31
.30
.59
1.00
.42
.58
1.71
1.46
2.11
.34
1.12
1.26
2.02
1.45
.69
1.33
1.44
1.18
1.90

mm

15.9
15.1
16.5
6.2
6.9
11.9
7.5
17.3
28.2
19.3
6.0
8.8
11.8
10.9
11.2
19.3
21.3
26.3
16.3
14.1
16.9
6.2
12.6
14.9
18.5
21.3
18.7
37.0
23.4
46.7
24.0
7.8
9.6
9.1
10.6
17.8
22.9
28.0
10.8
26.5
24.0
32.0
17.8
22.9
26.7
30.5
31.9
39.5
47.0
13.6
20.3
25.7
34.9
16.0
23.6
32.4
33.2
35.8
42.3
16.8
35.7
7.9
7.7
15.0
25.3
10.7
14.8
43.4
37.0
53.5
8.7
28.3
32.0
51.2
36.7
17.5
33.7
36.6
29.8
48.1

WIRE DIA.
Inches

0.125
0.125
0.093
0.035
0.054
0.080
0.054
0.105
0.177
0.105
0.035
0.058
0.062
0.066
0.080
0.105
0.120
0.148
0.080
0.101
0.091
0.041
0.062
0.080
0.091
0.120
0.113
0.162
0.092
0.230
0.135
0.051
0.054
0.045
0.062
0.070
0.090
0.147
0.061
0.093
0.105
0.120
0.070
0.100
0.105
0.120
0.162
0.148
0.125
0.067
0.080
0.092
0.125
0.060
0.062
0.092
0.109
0.120
0.128
0.060
0.125
0.039
0.039
0.062
0.095
0.047
0.053
0.120
0.162
0.162
0.043
0.072
0.105
0.144
0.085
0.081
0.090
0.090
0.094
0.133

mm

TOTAL
MATL
COILS

3.2
3.2
2.4
0.9
1.4
2.0
1.4
2.7
4.5
2.7
0.9
1.5
1.6
1.7
2.0
2.7
3.0
3.8
2.0
2.6
2.3
1.0
1.6
2.0
2.3
3.0
2.9
4.1
2.3
5.8
3.4
1.3
1.4
1.1
1.6
1.8
2.3
3.7
1.5
2.4
2.7
3.0
1.8
2.5
2.7
3.0
4.1
3.8
3.2
1.7
2.0
2.3
3.2
1.5
1.6
2.3
2.8
3.0
3.3
1.5
3.2
1.0
1.0
1.6
2.4
1.2
1.3
3.0
4.1
4.1
1.1
1.8
2.7
3.7
2.2
2.1
2.3
2.3
2.4
3.4

5.00
4.75
7.00
6.00
4.00
6.00
5.50
6.50
6.25
7.25
5.75
6.00
6.50
6.50
5.50
7.25
7.00
7.00
7.00
5.50
7.33
5.00
8.00
7.33
7.00
6.00
6.50
9.00
9.00
8.00
7.00
5.00
6.00
7.00
6.75
9.00
10.0
7.50
7.00
10.5
9.00
9.50
10.0
9.00
9.00
10.0
7.75
10.5
10.5
8.00
10.0
11.0
11.0
9.50
15.0
14.0
12.0
11.8
12.0
11.0
10.3
8.00
7.75
9.50
10.5
8.00
11.0
14.3
9.00
13.0
8.00
14.5
11.0
13.0
17.0
8.50
14.8
15.0
11.5
13.3

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
SST
SST
SST
SST
HD
HD
SST
SST
SPR
MW
SPR
SPR
SST
SPR
SST
SPR
SST
SST
SST
SST
HD
SPR
MW
SPR
SPR
SST
MW
SPR
SST
SST
SST
SST
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
MW
HD
HD
SST
SPR
HD
HD
SPR
SPR
SPR
SST
SPR
HD
SPR
HD
SST
SST
SPR
SST
SST
SST
SPR
SPR
SST
HD
SPR
HD
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST

E
N
D
S

F
N
S
H

CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
C
CG
CG
C
CG
CG
C
C
C
CG
C
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
C

Z
Z
N
N
N
N
N
Z
BO
N
N
Z
Z
Z
Z
N
Z
N
Z
N
N
N
N
Z
Z
Z
Z
Z
N
Z
Z
N
N
N
N
Z
N
N
N
N
N
Z
Z
GI
Z
Z
N
Z
Z
Z
Z
Z
Z
N
N
Z
Z
Z
N
N
Z
N
N
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 183

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.000
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.010
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.015
1.031
1.031
1.031

25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.40
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.65
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
25.78
26.19
26.19
26.19

7001
656
1949
4365
3062
10115
333
S-3106
S-270
2605
12150
848
11617
2880
S-1251
12115
S-121
884
873
866
856
S-464
819
360
10175
2962
910
11576
901
298
341
3069
72489
72489S
72491
72491S
72493
72493S
72495
72495S
72497
72497S
72499
72499S
72501
72501S
72503
72503S
3882
S-896
12136
S-1626
11694
3390
S-1021
12059
11846
A13-62
12093
S-28
12547
B12-52
11711
S-1426
10455
12522
10301
3367
S-420
S-1618
S-962
B17-201
2810
S-1222
1823
12456
2647
S-1084
MM-98
BB-40

O.D.

FREE LENGTH
Inches

4.50
4.50
4.69
4.75
4.81
4.88
5.00
5.13
5.13
5.25
5.50
6.00
6.50
6.88
7.25
7.50
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.50
9.00
10.0
11.0
12.0
12.0
12.0
16.8
1.00
1.00
1.50
1.50
2.00
2.00
2.50
2.50
3.00
3.00
3.50
3.50
4.00
4.00
4.50
4.50
.69
.88
1.28
1.38
1.50
1.50
1.63
1.69
1.72
1.78
1.81
2.00
2.00
2.13
2.16
2.25
2.25
2.56
2.81
3.13
3.31
3.50
3.50
3.59
3.88
4.88
4.88
5.38
7.50
.63
.69
.75

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

114.3
114.3
119.0
120.7
122.2
123.8
127.0
130.2
130.2
133.4
139.7
152.4
165.1
174.6
184.2
190.5
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
215.9
228.6
254.0
279.4
304.8
304.8
304.8
425.5
25.4
25.4
38.1
38.1
50.8
50.8
63.5
63.5
76.2
76.2
88.9
88.9
101.6
101.6
114.3
114.3
17.4
22.2
32.5
34.9
38.1
38.1
41.3
42.8
43.6
45.2
46.0
50.8
50.8
54.0
54.8
57.2
57.2
65.1
71.4
79.4
84.1
88.9
88.9
91.3
98.4
123.8
123.8
136.5
190.5
15.9
17.4
19.1

I.D.
Inches

.760
.646
.704
.840
.818
.676
.646
.840
.820
.790
.700
.676
.814
.706
.818
.660
.930
.818
.790
.760
.730
.730
.704
.586
.646
.790
.790
.828
.856
.840
.616
.704
.786
.786
.786
.786
.786
.786
.786
.786
.786
.786
.786
.786
.786
.786
.786
.786
.775
.829
.889
.909
.891
.825
.907
.591
.767
.717
.781
.745
.745
.889
.845
.805
.731
.775
.641
.899
.901
.907
.825
.935
.887
.895
.691
.763
.833
.871
.731
.931

RATE
mm

19.3
16.4
17.9
21.3
20.8
17.2
16.4
21.3
20.8
20.1
17.8
17.2
20.7
17.9
20.8
16.8
23.6
20.8
20.1
19.3
18.5
18.5
17.9
14.9
16.4
20.1
20.1
21.0
21.7
21.3
15.6
17.9
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
20.0
19.7
21.1
22.6
23.1
22.6
21.0
23.0
15.0
19.5
18.2
19.8
18.9
18.9
22.6
21.5
20.4
18.6
19.7
16.3
22.8
22.9
23.0
21.0
23.7
22.5
22.7
17.6
19.4
21.2
22.1
18.6
23.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

25
4.4
153
27
74
13
6.0
1.1
12
2.1
120
21
137
24
4.7
.82
7.8
1.4
15
2.7
54
9.4
74
13
8.0
1.4
49
8.6
8.2
1.4
66
11
.15
.03
5.6
.98
9.3
1.6
15
2.7
25
4.3
21
3.7
37
6.4
183
32
114
20
8.3
1.5
7.0
1.2
3.5
.61
1.8
.32
2.4
.41
99
17
20
3.5
105
18
90
16
64
11
54
9.5
46
8.1
39
6.8
36
6.3
31
5.3
29
5.1
25
4.4
25
4.4
21
3.7
22
3.8
18
3.2
19
3.3
16
2.8
416
73
40
7.0
10
1.8
5.7
.99
4.9
.86
30
5.3
3.0
.52
1869 327
142
25
194
34
94
17
187
33
143
25
4.4
.77
11
2.0
34
5.9
146
26
59
10
344
60
3.1
.54
2.0
.34
1.3
.23
15
2.7
.43
.07
5.6
.98
1.2
.22
106
19
37
6.5
7.2
1.3
60
10
710 124
2.1
.37

2.1
1.0
1.3
2.9
2.1
1.0
1.2
3.5
2.9
2.5
1.8
1.7
3.3
1.9
2.8
1.7
7.4
4.4
4.1
3.5
3.0
3.1
2.7
1.3
1.4
4.5
5.4
6.3
7.1
7.5
1.9
4.8
.44
.44
.73
.73
1.0
1.0
1.3
1.3
1.6
1.6
1.9
1.9
2.2
2.2
2.4
2.4
.13
.41
.86
.90
1.1
.84
1.3
.13
.38
.45
.48
.35
.46
1.6
1.3
1.0
.58
.90
.51
2.3
2.8
2.9
1.7
3.1
2.3
3.8
1.1
1.7
4.7
.27
.13
.45

mm

53
26
33
74
52
26
29
89
73
63
46
42
84
49
72
44
188
113
103
90
77
79
67
33
35
115
138
160
181
190
49
123
11
11
19
19
26
26
33
33
40
40
48
48
55
55
62
62
3.3
10
22
23
27
21
33
3.4
9.6
12
12
8.9
12
41
32
26
15
23
13
58
70
73
42
80
59
96
29
42
120
6.8
3.4
11

ENDS: C - Closed

G - Ground
O - Open

Lbs.

53
234
158
704
97
431
18
78
25
110
123
546
158
704
17
73
22
99
38
168
98
437
123
546
26
118
95
423
23
102
113
502
1.1
4.9
25
110
38
168
54
241
74
330
67
297
97
431
235 1047
158
704
38
168
38
168
22
97
13
57
18
78
190
847
97
431
46
206
39
175
47
208
40
177
47
209
40
177
47
207
40
176
47
207
40
176
47
208
40
177
46
207
40
176
47
207
40
176
53
237
16
73
9.0
40
5.1
23
5.2
23
25
112
3.9
17
249 1106
54
238
88
391
45
201
66
293
66
293
7.1
32
14
64
35
154
85
377
53
237
175
776
7.0
31
5.4
24
3.8
17
26
114
1.3
6.0
13
58
4.7
21
121
539
62
274
34
152
16
71
96
425
.95
4.2

Inches

2.40
3.27
2.52
1.16
1.17
2.59
3.63
1.28
1.44
2.00
3.60
4.00
1.95
3.53
1.46
5.78
.60
2.41
2.97
3.78
4.32
4.32
4.81
6.42
4.29
3.39
3.99
2.82
2.14
2.80
7.58
8.55
.56
.56
.77
.77
.98
.98
1.20
1.20
1.41
1.41
1.62
1.62
1.85
1.85
2.06
2.06
.36
.47
.35
.21
.43
.67
.32
1.06
.74
1.04
.64
.71
.84
.50
.88
.84
1.14
1.08
2.06
.52
.55
.61
1.00
.45
.45
1.08
2.75
2.14
1.75
.24
.53
.30

mm

Inches

61.0
83.2
63.9
29.5
29.8
65.8
92.2
32.5
36.6
50.7
91.4
101.5
49.6
89.6
37.0
146.8
15.1
61.3
75.3
96.0
109.7
109.7
122.2
163.0
109.0
86.0
101.3
71.5
54.4
71.1
192.6
217.1
14.2
14.2
19.6
19.6
24.9
24.9
30.6
30.6
35.9
35.9
41.2
41.2
46.9
46.9
52.3
52.3
9.1
11.8
8.8
5.4
11.0
16.9
8.2
26.9
18.9
26.5
16.3
18.0
21.4
12.8
22.3
21.3
28.9
27.4
52.2
13.3
13.9
15.4
25.3
11.4
11.4
27.4
70.0
54.4
44.5
6.1
13.3
7.6

0.120
0.177
0.148
0.080
0.091
0.162
0.177
0.080
0.090
0.105
0.150
0.162
0.093
0.147
0.091
0.170
0.035
0.091
0.105
0.120
0.135
0.135
0.148
0.207
0.177
0.105
0.105
0.086
0.072
0.080
0.192
0.148
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.112
0.120
0.093
0.063
0.053
0.062
0.095
0.054
0.212
0.124
0.149
0.117
0.135
0.135
0.063
0.085
0.105
0.142
0.120
0.187
0.058
0.057
0.054
0.095
0.040
0.064
0.060
0.162
0.126
0.091
0.080
0.150
0.050

mm

TOTAL
MATL
COILS

3.0
4.5
3.8
2.0
2.3
4.1
4.5
2.0
2.3
2.7
3.8
4.1
2.4
3.7
2.3
4.3
0.9
2.3
2.7
3.0
3.4
3.4
3.8
5.3
4.5
2.7
2.7
2.2
1.8
2.0
4.9
3.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
2.8
3.0
2.4
1.6
1.3
1.6
2.4
1.4
5.4
3.1
3.8
3.0
3.4
3.4
1.6
2.2
2.7
3.6
3.0
4.7
1.5
1.4
1.4
2.4
1.0
1.6
1.5
4.1
3.2
2.3
2.0
3.8
1.3

19.5
18.5
17.0
14.5
13.0
16.0
20.5
16.0
16.0
18.0
24.0
24.7
20.0
24.0
16.0
34.0
16.0
25.5
28.3
30.5
32.0
32.0
32.5
31.0
24.3
31.3
37.0
31.8
28.8
34.0
39.5
57.8
5.00
5.00
6.88
6.88
8.75
8.75
10.8
10.8
12.6
12.6
14.5
14.5
16.5
16.5
18.4
18.4
3.00
5.00
4.50
4.00
7.00
7.00
6.00
5.00
5.00
7.00
5.50
5.25
6.25
8.00
10.3
8.00
8.00
9.00
11.0
8.00
10.0
11.3
10.5
10.3
7.00
17.0
17.0
16.0
19.3
3.00
3.50
6.00

HD
HD
SPR
SPR
SPR
SPR
HD
SST
SST
SPR
SPR
HD
SPR
SPR
SST
SPR
SST
HD
HD
HD
HD
SST
HD
HD
SPR
SPR
HD
SPR
HD
HD
HD
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
HD
SST
SPR
SST
SPR
SPR
SST
SPR
SST
SST
SST
SST
SST
SPR
SPR
SST
SPR
HD
SPR
SPR
SST
SST
SST
SST
MW
SST
HD
SPR
MW
SST
SPR
SST

E
N
D
S

C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
C
C
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
C
CG
CG
CG
CG

F
N
S
H

Z
Z
Z
Z
Z
N
Z
N
N
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
Z
Z
GI
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
N
Z
Z
N
Z
N
N
N
N
N
N
N
N
Z
Z
Z
Z
N
N
N
N
Z
N
Z
N
Z
N
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

183

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 184

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.031
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.046
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062

26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.19
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.57
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97

10107
S-3054
A10-65
2678
10852
3339
10740
S-1417
10659
12447
10409
10676
S-1532
10457
NN-20
10722
2730
2702
2677
10988
S-1473
3401
B18-197
1631
B9-48
12004
1895
S-1035
S-3004
10973
B18-193
A14-56
S-1444
3338
2985
S-1199
3826
12066
11561
12245
S-1496
11231
3213
S-350
3067
3757
3009
S-1425
S-3244
2744
11992
3329
11684
3427
AA-80
S-1394
S-311
4192
S-1221
12714
10516
MM-70
MM-4
10645
2854
S-3009
3234
PP-46
10864
11661
S-83
10207
10796
3007
S-3125
4388
MM-44
12311
S-1385
4352

.81
.88
1.03
1.13
1.38
1.44
1.50
1.50
1.53
1.56
1.94
1.97
2.00
2.19
2.19
2.28
2.34
2.47
2.63
2.81
3.00
3.63
3.75
3.75
3.88
9.88
.75
.81
.81
.94
1.03
1.19
1.31
1.44
1.47
1.50
1.50
1.50
1.69
1.72
1.81
1.91
2.00
2.00
2.00
2.25
2.25
2.63
2.66
3.88
4.88
4.88
7.50
8.50
.88
.88
.88
1.00
1.00
1.03
1.03
1.34
1.38
1.50
1.50
1.50
1.50
1.50
1.56
1.59
1.63
1.63
1.75
1.84
1.88
1.88
1.88
1.94
2.00
2.19

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

20.7
22.2
26.2
28.6
34.9
36.5
38.1
38.1
38.9
39.7
49.2
50.0
50.8
55.6
55.6
57.9
59.5
62.7
66.7
71.4
76.2
92.1
95.3
95.3
98.4
250.8
19.1
20.6
20.6
23.8
26.2
30.2
33.3
36.5
37.3
38.1
38.1
38.1
42.8
43.6
46.0
48.4
50.8
50.8
50.8
57.2
57.2
66.7
67.5
98.4
123.8
123.8
190.5
215.9
22.2
22.2
22.2
25.4
25.4
26.2
26.2
34.1
34.9
38.1
38.1
38.1
38.1
38.1
39.7
40.5
41.3
41.3
44.5
46.8
47.6
47.6
47.6
49.2
50.8
55.6

MATERIAL: MW - Music Wire

184

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.907
.915
.869
.849
.875
.907
.929
.857
.741
.791
.657
.807
.923
.707
.571
.747
.911
.761
.871
.657
.871
.917
.959
.851
.637
.837
.944
.806
.806
.934
.866
.916
.864
.916
.806
.930
.918
.808
.924
.884
.902
.896
.934
.836
.750
.836
.722
.896
.898
.922
.822
.722
.790
.846
.942
.938
.914
.938
.872
.822
.792
.802
.942
.838
.822
.822
.708
.662
1.010
.862
.902
.612
.826
.954
.918
.910
.882
.862
.880
.892

RATE
mm

23.0
23.2
22.1
21.6
22.2
23.0
23.6
21.8
18.8
20.1
16.7
20.5
23.4
18.0
14.5
19.0
23.1
19.3
22.1
16.7
22.1
23.3
24.4
21.6
16.2
21.3
24.0
20.5
20.5
23.7
22.0
23.3
21.9
23.3
20.5
23.6
23.3
20.5
23.5
22.5
22.9
22.8
23.7
21.2
19.1
21.2
18.3
22.8
22.8
23.4
20.9
18.3
20.1
21.5
23.9
23.8
23.2
23.8
22.1
20.9
20.1
20.4
23.9
21.3
20.9
20.9
18.0
16.8
25.7
21.9
22.9
15.5
21.0
24.2
23.3
23.1
22.4
21.9
22.4
22.7

Lbs./In.

N/mm

12
2.0
15
2.7
21
3.7
40
6.9
18
3.2
4.9
.86
5.2
.90
17
3.0
244
43
53
9.2
487
85
36
6.4
2.8
.50
224
39
1305 228
145
25
5.1
.89
111
19
12
2.1
325
57
4.8
.83
1.5
.26
.49
.09
10
1.7
325
57
4.9
.85
9.9
1.7
154
27
163
29
13
2.3
36
6.3
7.8
1.4
33
5.7
5.4
.95
94
16
2.9
.51
5.1
.89
90
16
10
1.8
14
2.4
12
2.1
13
2.3
3.8
.66
52
9.1
159
28
47
8.2
205
36
6.9
1.2
6.6
1.2
1.7
.29
21
3.7
96
17
28
4.8
8.9
1.6
6.0
1.0
7.4
1.3
26
4.5
11
1.9
20
3.6
143
25
199
35
145
25
3.7
.65
66
12
114
20
89
16
740 130
1197 210
.13
.02
29
5.1
22
3.8
1571 275
133
23
4.0
.70
5.8
1.0
13
2.3
21
3.6
29
5.1
17
3.0
16
2.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.57 14
.43 11
.63 16
.58 15
.82 21
1.0
26
.92 23
.80 20
.36
9.3
.42 11
.35
9.0
.74 19
1.7
43
.53 14
.23
5.8
.58 15
1.9
49
.91 23
1.4
37
.53 13
1.8
47
2.8
72
3.5
88
2.3
59
.62 16
6.0 151
.47 12
.31
7.8
.29
7.4
.45 11
.49 12
.83 21
.67 17
.98 25
.55 14
1.0
26
1.1
27
.56 14
.76 19
1.2
29
.96 24
1.1
27
1.6
42
.64 16
.59 15
.78 20
.58 15
1.9
48
1.9
49
2.9
73
2.0
50
1.2
31
2.3
58
3.5
89
.59 15
.60 15
.48 12
.69 18
.29
7.3
.36
9.1
.32
8.1
.43 11
.96 24
.63 16
.45 11
.53 13
.20
5.2
.17
4.3
1.4
35
.84 21
.72 18
.17
4.4
.37
9.3
1.4
35
1.2
31
1.1
27
1.1
28
1.1
27
1.3
32
1.2
31

Lbs.

6.6
29
6.5
29
13
59
23
102
15
66
5.0
22
4.7
21
14
61
89
395
22
99
172
766
27
119
4.8
21
119
531
297 1321
84
372
9.8
44
101
449
17
76
172
766
8.8
39
4.2
19
1.7
7.5
23
104
200
888
29
129
4.7
21
47
211
47
211
5.8
26
18
79
6.4
29
22
98
5.3
24
52
231
3.0
14
5.4
24
51
225
8.0
35
16
71
12
52
14
62
6.2
27
34
149
93
414
36
161
118
525
13
58
13
56
4.8
21
42
189
118
525
63
279
31
140
3.5
16
4.4
20
12
55
7.3
33
5.9
26
51
228
63
281
63
280
3.5
16
42
186
51
228
47
208
150
668
203
904
.18
.80
25
110
16
69
273 1214
49
217
5.5
24
7.1
31
14
64
23
101
31
138
22
97
20
89

ENDS: C - Closed

G - Ground
O - Open

Inches

.25
.23
.41
.55
.39
.42
.20
.70
.83
1.14
1.50
1.23
.32
1.42
1.84
1.10
.42
1.08
.62
2.06
1.16
.80
.29
1.29
2.66
3.30
.20
.50
.48
.22
.54
.36
.46
.46
.72
.46
.45
.71
.31
.57
.36
.51
.33
.58
1.18
.68
1.46
.62
.62
1.01
1.68
2.75
2.88
2.10
.29
.28
.26
.31
.71
.54
.60
.72
.42
.67
.64
.66
.84
1.00
.18
.75
.36
1.35
.53
.32
.65
.51
.63
.75
.68
.60

mm

6.3
5.9
10.3
13.9
9.9
10.6
5.2
17.7
21.2
29.0
38.0
31.3
8.2
36.0
46.7
28.0
10.7
27.4
15.7
52.2
29.5
20.3
7.3
32.8
67.6
83.8
5.2
12.6
12.2
5.7
13.7
9.1
11.6
11.6
18.3
11.8
11.4
18.1
7.7
14.4
9.1
12.9
8.4
14.7
30.1
17.3
37.0
15.7
15.7
25.6
42.7
70.0
73.2
53.3
7.2
7.1
6.6
7.9
18.1
13.7
15.2
18.2
10.7
17.1
16.1
16.8
21.4
25.4
4.6
19.1
9.1
34.3
13.5
8.2
16.5
13.0
16.0
19.1
17.3
15.1

WIRE DIA.
Inches

0.062
0.058
0.081
0.091
0.078
0.062
0.051
0.087
0.145
0.120
0.187
0.112
0.054
0.162
0.230
0.142
0.060
0.135
0.080
0.187
0.080
0.057
0.036
0.090
0.197
0.097
0.051
0.120
0.120
0.056
0.090
0.065
0.091
0.065
0.120
0.058
0.064
0.119
0.061
0.081
0.072
0.075
0.056
0.105
0.148
0.105
0.162
0.075
0.074
0.062
0.112
0.162
0.128
0.100
0.060
0.062
0.074
0.062
0.095
0.120
0.135
0.130
0.060
0.112
0.120
0.120
0.177
0.200
0.026
0.100
0.080
0.225
0.118
0.054
0.072
0.076
0.090
0.100
0.091
0.085

mm

TOTAL
MATL
COILS

1.6
1.5
2.1
2.3
2.0
1.6
1.3
2.2
3.7
3.0
4.7
2.8
1.4
4.1
5.8
3.6
1.5
3.4
2.0
4.7
2.0
1.4
0.9
2.3
5.0
2.5
1.3
3.0
3.0
1.4
2.3
1.7
2.3
1.7
3.0
1.5
1.6
3.0
1.5
2.1
1.8
1.9
1.4
2.7
3.8
2.7
4.1
1.9
1.9
1.6
2.8
4.1
3.3
2.5
1.5
1.6
1.9
1.6
2.4
3.0
3.4
3.3
1.5
2.8
3.0
3.0
4.5
5.1
0.7
2.5
2.0
5.7
3.0
1.4
1.8
1.9
2.3
2.5
2.3
2.2

4.00
3.00
5.00
5.00
5.00
6.75
4.00
7.00
5.75
9.50
8.00
10.0
6.00
8.75
8.00
7.75
6.00
8.00
7.75
11.0
14.5
13.0
7.00
13.3
13.5
34.0
3.00
4.00
4.00
3.00
5.00
5.50
5.00
7.00
6.00
7.00
7.00
6.00
4.00
7.00
5.00
5.75
6.00
5.50
8.00
6.50
9.00
8.25
8.33
15.3
15.0
17.0
22.0
21.0
4.75
4.50
3.50
4.00
7.50
4.50
4.50
5.50
7.00
6.00
5.25
5.50
4.75
5.00
6.00
7.50
4.50
6.00
4.50
5.00
8.00
5.75
7.00
7.50
7.50
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SST
HD
SST
HD
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
MW
MW
HD
HD
SST
SPR
SPR
SPR
SPR
SPR
HD
SST
SST
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
HD
SPR
SPR
SPR
SPR
SST
SST
SST
HD
SST
HD
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SPR

E
N
D
S

F
N
S
H

CG
C
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG

Z
N
N
Z
N
GI
Z
N
Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
N
Z
Z
N
N
N
Z
Z
N
Z
Z
N
Z
Z
Z
GI
N
Z
Z
N
Z
Z
Z
N
N
Z
Z
Z
Z
Z
N
N
N
Z
N
BO
N
N
Z
Z
Z
N
Z
Z
N
Z
N
Z
BO
Z
N
Z
Z
Z
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 185

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.062
1.070
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.078
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094

26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
26.97
27.18
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.38
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79

11636
CC-44
12520
3133
3942
A13-56
S-437
S-1326
3272
12436
S-444
S-3217
4108
334
2755
1936
1703
385
4170
12804
11507
12074
10525
11702
10685
11728
12318
11850
12307
A13-69
12268
1908
1739
1741
11564
S-844
S-356
11586
12156
B11-29
10992
10939
3121
11870
11165
S-129
S-3166
S-1672
B17-132
S-422
11827
10369
2649
RR-58
11759
S-95
2698
11674
10386
S-172
12131
10865
11921
1599
4028
S-111
S-1549
S-1397
S-3088
12149
A15-59
S-130
KK-44
3910
11741
2814
3034
10223
HH-98
12555

O.D.

FREE LENGTH
Inches

2.25
2.25
2.31
2.38
2.50
2.69
3.38
3.50
3.63
3.88
4.63
5.00
5.00
6.00
7.25
7.63
7.63
11.5
11.5
4.00
.78
1.00
1.00
1.13
1.13
1.13
1.19
1.34
1.47
1.47
1.50
1.50
1.63
1.75
1.81
1.88
2.00
2.00
2.00
2.00
2.00
2.06
2.13
2.13
2.13
2.19
2.25
2.25
2.50
2.50
2.50
2.50
2.50
2.75
2.84
3.00
3.75
4.00
4.00
4.25
4.84
5.00
5.94
7.50
19.0
.75
.88
.88
.94
.94
.97
1.00
1.06
1.25
1.25
1.38
1.38
1.50
1.50
1.50

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

57.2
57.2
58.7
60.3
63.5
68.2
85.7
88.9
92.1
98.4
117.5
127.0
127.0
152.4
184.2
193.7
193.7
292.1
292.1
101.6
19.8
25.4
25.4
28.6
28.6
28.6
30.2
34.1
37.3
37.3
38.1
38.1
41.3
44.5
46.0
47.6
50.8
50.8
50.8
50.8
50.8
52.4
54.0
54.0
54.0
55.6
57.2
57.2
63.5
63.5
63.5
63.5
63.5
69.9
72.2
76.2
95.3
101.6
101.6
108.0
123.0
127.0
150.8
190.5
482.6
19.1
22.2
22.2
23.8
23.8
24.6
25.4
27.0
31.8
31.8
34.9
34.9
38.1
38.1
38.1

I.D.
Inches

.842
.742
.812
.922
.766
.916
.904
.918
.848
.938
.862
.992
.822
.708
.738
.880
.738
.852
.852
.656
.934
.918
.868
.992
.908
.828
.992
.922
.958
.894
.966
.852
.782
.896
.960
.908
.988
.896
.808
.808
.754
.934
.934
.894
.782
.932
.954
.898
1.026
.894
.808
.796
.784
.998
.954
.578
.748
.996
.944
.868
.882
.918
.828
.754
.782
.800
.924
.868
.924
.910
.910
.884
.954
.912
.904
.950
.944
.902
.894
.884

RATE
mm

21.4
18.8
20.6
23.4
19.5
23.3
23.0
23.3
21.5
23.8
21.9
25.2
20.9
18.0
18.7
22.4
18.7
21.6
21.6
16.7
23.7
23.3
22.0
25.2
23.1
21.0
25.2
23.4
24.3
22.7
24.5
21.6
19.9
22.8
24.4
23.1
25.1
22.8
20.5
20.5
19.2
23.7
23.7
22.7
19.9
23.7
24.2
22.8
26.1
22.7
20.5
20.2
19.9
25.3
24.2
14.7
19.0
25.3
24.0
22.0
22.4
23.3
21.0
19.2
19.9
20.3
23.5
22.0
23.5
23.1
23.1
22.5
24.2
23.2
23.0
24.1
24.0
22.9
22.7
22.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

35
6.1
190
33
71
12
9.4
1.7
113
20
4.4
.77
4.7
.83
3.5
.61
22
3.8
2.2
.39
12
2.0
.15
.03
27
4.8
96
17
61
11
6.3
1.1
60
10
12
2.2
5.7
1.0
315
55
19
3.3
30
5.2
47
8.3
1.3
.22
27
4.8
135
24
1.3
.22
12
2.1
3.5
.62
23
4.0
3.8
.66
65
11
229
40
34
6.0
4.7
.82
14
2.4
1.6
.27
21
3.6
104
18
127
22
224
39
6.3
1.1
9.5
1.7
20
3.4
202
35
8.2
1.4
4.1
.73
14
2.5
.08
.01
18
3.1
70
12
138
24
104
18
.41
.07
1.6
.27
1075 188
127
22
.28
.05
3.3
.58
38
6.7
11
1.9
5.3
.92
19
3.3
57
10
19
3.3
687 120
51
8.9
108
19
42
7.4
41
7.2
45
7.9
79
14
16
2.8
33
5.7
39
6.9
14
2.5
16
2.8
38
6.6
42
7.3
45
7.9

Inches

mm

1.1
29
.53 13
.81 21
1.2
30
.81 21
1.9
49
2.4
60
2.6
67
1.7
44
3.1
79
2.5
62
4.5 114
1.9
47
1.6
40
1.9
49
3.7
94
1.9
49
2.9
73
6.3 159
.71 18
.42 11
.55 14
.37
9.4
.89 23
.66 17
.42 11
.91 23
.88 22
.99 25
.90 23
1.2
30
.65 16
.55 14
.68 17
1.4
36
1.3
33
1.7
44
1.1
29
.67 17
.55 14
.51 13
1.5
38
1.3
32
1.2
31
.45 11
1.4
36
1.8
47
1.4
36
2.3
58
1.2
32
.90 23
.57 14
.85 22
2.3
59
1.9
47
.28
7.2
.95 24
3.4
86
3.1
79
.86 22
2.7
67
2.9
74
2.7
70
2.0
51
4.8 122
.11
2.9
.36
9.1
.35
9.0
.43 11
.43 11
.48 12
.41 10
.68 17
.70 18
.66 17
.82 21
.83 21
.71 18
.72 18
.72 18

ENDS: C - Closed

G - Ground
O - Open

Lbs.

40
176
100
443
58
257
11
50
92
408
8.5
38
11
49
9.1
41
38
168
6.9
31
29
128
.69
3.1
51
228
150
668
116
518
23
104
116
518
36
159
36
159
223
991
8.0
36
16
73
18
78
1.1
5.0
18
79
57
253
1.2
5.1
10
46
3.5
16
21
93
4.5
20
42
188
127
564
23
103
6.7
30
18
78
2.7
12
23
103
69
308
69
308
115
511
9.4
42
12
53
24
106
91
403
12
52
7.6
34
21
92
.19
.84
22
98
62
277
79
350
89
395
.95
4.2
2.9
13
304 1352
121
539
.95
4.2
10
45
33
145
29
128
15
68
52
231
115
511
91
403
79
351
18
81
38
169
18
81
18
79
22
97
32
143
11
48
23
101
26
115
12
53
13
59
27
119
30
134
32
143

Inches

.99
1.28
1.13
.47
1.48
.77
1.02
.86
1.28
.78
1.40
.51
1.92
4.12
3.94
1.73
4.16
2.00
3.99
3.10
.36
.32
.63
.24
.47
.63
.28
.47
.48
.56
.31
.68
.85
.55
.38
.58
.27
.73
1.01
.88
1.42
.58
.43
.69
.93
.46
.39
.72
.23
.67
1.25
.99
1.47
.44
.99
2.50
2.15
.62
.70
.66
1.57
.96
2.63
3.97
7.03
.44
.28
.45
.30
.51
.37
.42
.28
.46
.48
.32
.42
.50
.55
.58

mm

Inches

25.1
32.5
28.6
12.0
37.6
19.5
25.8
21.9
32.6
19.7
35.6
12.9
48.8
104.5
100.1
43.9
105.6
50.7
101.3
78.7
9.1
8.1
16.0
6.0
11.9
15.9
7.1
11.9
12.2
14.3
7.8
17.2
21.6
13.9
9.7
14.8
6.9
18.5
25.7
22.3
36.0
14.6
11.0
17.5
23.5
11.6
9.8
18.3
5.9
16.9
31.7
25.1
37.3
11.2
25.2
63.5
54.5
15.6
17.9
16.9
39.8
24.4
66.7
100.8
178.6
11.2
7.0
11.5
7.6
12.9
9.3
10.7
7.1
11.6
12.1
8.2
10.8
12.8
14.0
14.7

0.110
0.160
0.125
0.070
0.148
0.073
0.079
0.072
0.107
0.062
0.100
0.035
0.120
0.177
0.162
0.091
0.162
0.105
0.105
0.207
0.072
0.080
0.105
0.043
0.085
0.125
0.043
0.078
0.060
0.092
0.056
0.113
0.148
0.091
0.059
0.085
0.045
0.091
0.135
0.135
0.162
0.072
0.072
0.092
0.148
0.073
0.062
0.090
0.026
0.092
0.135
0.141
0.147
0.040
0.062
0.250
0.165
0.041
0.067
0.105
0.098
0.080
0.125
0.162
0.148
0.147
0.085
0.113
0.085
0.092
0.092
0.105
0.070
0.091
0.095
0.072
0.075
0.096
0.100
0.105

mm

TOTAL
MATL
COILS

2.8
4.1
3.2
1.8
3.8
1.9
2.0
1.8
2.7
1.6
2.5
0.9
3.0
4.5
4.1
2.3
4.1
2.7
2.7
5.3
1.8
2.0
2.7
1.1
2.2
3.2
1.1
2.0
1.5
2.3
1.4
2.9
3.8
2.3
1.5
2.2
1.1
2.3
3.4
3.4
4.1
1.8
1.8
2.3
3.8
1.9
1.6
2.3
0.7
2.3
3.4
3.6
3.7
1.0
1.6
6.4
4.2
1.0
1.7
2.7
2.5
2.0
3.2
4.1
3.8
3.7
2.2
2.9
2.2
2.3
2.3
2.7
1.8
2.3
2.4
1.8
1.9
2.4
2.5
2.7

9.00
8.00
8.00
5.75
10.0
10.5
13.0
12.0
12.0
11.5
14.0
13.5
15.0
23.3
24.3
19.0
24.7
18.0
37.0
15.0
4.00
4.00
6.00
5.50
4.50
5.00
5.50
6.00
7.00
6.13
5.50
6.00
5.75
5.00
5.50
6.88
5.00
7.00
7.50
6.50
7.75
8.00
6.00
7.50
6.25
6.25
6.25
8.00
8.00
7.25
9.25
7.00
10.0
10.0
15.0
10.0
13.0
15.0
10.5
6.33
15.0
12.0
21.0
24.5
47.5
3.00
3.25
4.00
3.50
4.50
4.00
4.00
4.00
5.00
5.00
4.50
4.67
5.25
5.50
5.50

SPR
SST
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SST
SST
SPR
HD
SPR
SPR
SPR
HD
SPR
HD
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
SST
SPR
SPR
MW
HD
SPR
SST
SST
SPR
SPR
SPR
HD
SPR
SPR
SPR
SPR
SST
SST
SST
SST
SST
SST
SPR
HD
SPR
SPR
SST
SPR
SPR
SPR
SST
SPR
SST
SST
HD
SPR
SST
SST
SST
SST
SPR
SST
SST
SPR
SPR
SPR
HD
SPR
SPR
SPR
SST

E
N
D
S

CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG

F
N
S
H

Z
N
N
Z
Z
N
N
N
Z
Z
N
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
Z
N
Z
Z
Z
Z
Z
N
N
N
Z
N
Z
Z
Z
N
Z
N
N
N
N
N
N
Z
Z
Z
Z
N
Z
Z
Z
N
Z
N
N
Z
Z
N
N
N
N
Z
N
N
GI
GI
Z
Z
Z
Z
Z
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

185

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 186

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.094
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100

27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.79
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94

12111
3132
12006
1671
11278
10332
945
1577
3262
10325
S-1246
11284
3697
11971
11381
3309
S-448
10381
3913
S-1439
3163
11388
S-279
3711
3374
12169
10948
2713
11775
12312
S-3046
4130
11709
3471
1643
12180
361
72504
72504S
72514
72514S
72527
72527S
72537
72537S
72549
72549S
72560
72560S
72582
72582S
72505
72505S
72515
72515S
72528
72528S
72538
72538S
72550
72550S
72561
72561S
72572
72572S
72583
72583S
72506
72506S
72516
72516S
72529
72529S
72539
72539S
72551
72551S
72562
72562S
72584

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

1.53
1.59
1.59
1.63
1.69
1.88
2.00
2.00
2.00
2.13
2.19
2.19
2.25
2.38
2.50
2.50
2.63
2.63
2.75
2.75
2.75
3.41
3.63
4.00
4.00
4.06
4.19
4.75
4.91
5.00
5.13
5.38
6.00
7.50
7.88
8.19
11.3
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25

mm

38.9
40.5
40.5
41.3
42.8
47.6
50.8
50.8
50.8
54.0
55.6
55.6
57.2
60.3
63.5
63.5
66.7
66.7
69.9
69.9
69.9
86.5
92.1
101.6
101.6
103.2
106.4
120.7
124.6
127.0
130.2
136.5
152.4
190.5
200.0
207.9
285.8
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8

MATERIAL: MW - Music Wire

186

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.934
.894
.782
.798
.782
.810
.974
.884
.824
.810
.950
.798
1.006
.914
.944
.814
.872
.868
1.012
.992
.782
.844
.912
.984
.814
.782
.854
.894
.900
.884
.844
.914
.910
.766
.884
.888
.740
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.850
.850
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.850

RATE
mm

23.7
22.7
19.9
20.3
19.9
20.6
24.7
22.5
20.9
20.6
24.1
20.3
25.6
23.2
24.0
20.7
22.1
22.0
25.7
25.2
19.9
21.4
23.2
25.0
20.7
19.86
21.7
22.7
22.9
22.5
21.4
23.2
23.1
19.5
22.5
22.6
18.8
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.6
21.6
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.6

Lbs./In.

11
33
295
217
258
159
3.7
34
98
135
7.9
172
1.2
14
7.6
91
32
31
.43
1.4
163
38
6.3
1.2
55
115
26
11
9.7
15
24
9.3
7.9
57
7.5
6.9
46
43
36
45
38
65
55
70
59
98
83
126
107
194
165
36
31
38
33
55
46
59
50
82
70
111
94
153
130
163
139
28
24
30
25
43
36
45
38
62
53
80
68
122

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

1.9
5.7
52
38
45
28
.66
5.9
17
24
1.4
30
.20
2.5
1.3
16
5.6
5.4
.08
.24
29
6.7
1.1
.21
9.7
20
4.6
1.9
1.7
2.6
4.2
1.6
1.4
10
1.3
1.2
8.0
7.5
6.3
7.9
6.7
11
9.6
12
10
17
15
22
19
34
29
6.3
5.4
6.7
5.7
9.6
8.1
10
8.8
14
12
19
17
27
23
29
24
4.9
4.2
5.2
4.4
7.4
6.3
7.9
6.7
11
9.3
14
12
21

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

Lbs.

.93 24
.92 23
.34
8.8
.41 10
.39 10
.50 13
1.6
39
1.0
26
.69 18
.58 15
1.4
36
.52 13
1.9
49
1.4
36
1.6
42
.84 21
1.1
29
1.3
34
2.3
58
2.3
59
.62 16
1.3
34
2.2
56
3.3
83
1.4
35
.88 22.35
1.7
44
2.8
70
2.6
67
2.3
59
2.1
54
2.4
60
3.0
76
2.0
52
4.6 117
4.7 120
3.2
81
.57 14
.45 11
.57 15
.47 12
.52 13
.41 10
.52 13
.41 11
.47 12
.39
9.8
.45 11
.35
8.8
.38
9.7
.31
7.8
.67 17
.53 13
.67 17
.55 14
.62 16
.48 12
.62 16
.49 12
.57 14
.46 12
.51 13
.39
9.9
.45 11
.35
8.8
.45 12
.37
9.3
.87 22
.68 17
.88 22
.72 18
.79 20
.62 16
.81 20
.64 16
.74 19
.60 15
.69 18
.55 14
.61 15

10
30
102
89
102
79
5.8
35
68
79
11
89
2.3
20
13
76
36
42
1.0
3.1
102
51
14
3.9
76
101
45
30
25
35
51
22
24
117
35
33
146
24
16
26
18
34
22
36
25
46
32
56
37
74
51
24
16
26
18
34
22
36
25
47
32
56
37
69
45
74
51
24
16
26
18
34
22
36
25
46
32
55
37
75

ENDS: C - Closed

G - Ground
O - Open

46
134
452
397
452
352
26
154
304
352
49
397
10
91
56
338
161
186
4.4
14
452
228
62
17
338
447
202
134
113
154
228
98
105
522
154
146
651
108
72
115
80
150
100
161
109
206
142
249
164
328
227
108
72
114
80
150
100
162
109
207
142
251
164
308
201
329
227
108
72
115
80
150
100
162
109
205
142
244
164
332

Inches

mm

.60 15.2
.65 16.5
.86 21.8
.85 21.6
.94 23.8
.89 22.6
.45 11.4
.77 19.6
1.01 25.7
.99 25.2
.43 11.0
1.00 25.4
.31
7.8
.70 17.7
.53 13.3
1.26 32.0
.92 23.3
1.13 28.7
.45 11.5
.43 11.0
1.33 33.9
1.38 34.9
1.41 35.8
.72 18.2
1.89 48.0
1.72 43.69
1.56 39.6
1.55 39.4
1.33 33.9
1.58 40.0
2.00 50.8
1.08 27.4
1.38 35.1
4.18 106.2
2.73 69.3
2.68 68.0
7.43 188.8
.29
7.3
.29
7.3
.31
7.8
.31
7.8
.34
8.6
.34
8.6
.36
9.1
.36
9.1
.41 10.3
.41 10.3
.43 11.0
.43 11.0
.50 12.7
.50 12.7
.31
7.8
.31
7.8
.33
8.4
.33
8.4
.36
9.2
.36
9.2
.38
9.8
.38
9.8
.43 11.0
.43 11.0
.46 11.7
.46 11.7
.50 12.6
.50 12.6
.55 13.9
.55 13.9
.35
8.9
.35
8.9
.37
9.4
.37
9.4
.42 10.6
.42 10.6
.44 11.3
.44 11.3
.51 13.0
.51 13.0
.56 14.2
.56 14.2
.64 16.3

WIRE DIA.
Inches

0.080
0.100
0.156
0.148
0.156
0.142
0.060
0.105
0.135
0.142
0.072
0.148
0.044
0.090
0.075
0.140
0.111
0.113
0.041
0.051
0.156
0.125
0.091
0.055
0.140
0.158
0.120
0.100
0.097
0.105
0.125
0.090
0.092
0.164
0.105
0.103
0.177
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.125

mm

TOTAL
MATL
COILS

2.0
2.5
4.0
3.8
4.0
3.6
1.5
2.7
3.4
3.6
1.8
3.8
1.1
2.3
1.9
3.6
2.8
2.9
1.0
1.3
4.0
3.2
2.3
1.4
3.6
4.0
3.0
2.5
2.5
2.7
3.2
2.3
2.3
4.2
2.7
2.6
4.5
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.2

6.50
6.50
5.50
5.75
6.00
6.25
6.50
7.33
7.50
7.00
6.00
6.75
6.00
7.75
7.00
9.00
8.25
10.0
10.0
7.50
8.50
11.0
15.5
12.0
13.5
11.0
13.0
15.5
13.8
14.0
16.0
12.0
15.0
24.5
26.0
26.0
42.0
3.50
3.50
3.63
3.63
3.63
3.63
3.75
3.75
3.88
3.88
3.88
3.88
4.00
4.00
3.75
3.75
3.88
3.88
3.88
3.88
4.00
4.00
4.13
4.13
4.13
4.13
4.13
4.13
4.38
4.38
4.25
4.25
4.38
4.38
4.50
4.50
4.63
4.63
4.88
4.88
5.00
5.00
5.13

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SPR
SPR
SPR
SPR
MW
SPR
HD
SPR
SST
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SST
HD
SST
SPR
SPR
SPR
SPR
SPR
HD
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

C
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
N
Z
N
Z
Z
N
Z
N
N
Z
GI
GI
N
Z
N
Z
N
Z
Z
Z
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 187

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100

27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94

72584S
72507
72507S
72517
72517S
72530
72530S
72540
72540S
72552
72552S
72563
72563S
72573
72573S
72585
72585S
72594
72594S
72508
72508S
72519
72519S
72531
72531S
72542
72542S
72553
72553S
72564
72564S
72574
72574S
72586
72586S
72596
72596S
72605
72605S
72617
72617S
72509
72509S
72520
72520S
72532
72532S
72543
72543S
72554
72554S
72565
72565S
72575
72575S
72587
72587S
72597
72597S
72606
72606S
72618
72618S
72607
72607S
72566
72566S
72576
72576S
72588
72588S
72598
72598S
72608
72608S
72619
72619S
72510
72510S
72521

1.25
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.19
2.19
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.25
2.50
2.50
2.50

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

31.8
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
55.6
55.6
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
57.2
63.5
63.5
63.5

I.D.
Inches

.850
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.830
.830
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.816
.816
.876
.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.936
.936
.930

RATE
mm

21.6
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
20.7
20.7
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
23.8
23.8
23.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

104
23
19
24
20
34
29
37
31
50
43
68
57
93
79
105
89
137
116
19
16
21
18
29
25
31
26
42
36
56
48
77
66
86
73
113
96
150
128
175
149
17
14
17
15
25
21
26
22
36
31
49
41
66
56
74
63
98
83
129
110
149
127
100
85
43
36
58
49
65
55
88
75
111
94
130
111
13
11
14

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

18
4.0
3.4
4.2
3.6
6.0
5.1
6.4
5.4
8.8
7.5
12
10
16
14
18
16
24
20
3.3
2.8
3.6
3.1
5.1
4.3
5.3
4.5
7.4
6.3
9.9
8.4
14
11
15
13
20
17
26
22
31
26
2.9
2.5
3.0
2.6
4.4
3.7
4.6
3.9
6.3
5.4
8.5
7.2
12
9.9
13
11
17
15
23
19
26
22
18
15
7.5
6.3
10
8.6
11
9.7
15
13
19
17
23
19
2.3
1.9
2.4

Inches

.49
1.1
.84
1.1
.89
.98
.77
1.0
.79
.92
.75
.84
.64
.75
.57
.74
.57
.69
.53
1.3
1.0
1.3
1.0
1.2
.91
1.2
.95
1.1
.90
1.0
.77
.90
.69
.90
.69
.84
.63
.73
.56
.71
.54
1.5
1.2
1.5
1.2
1.4
1.1
1.4
1.1
1.3
1.0
1.2
.89
1.0
.80
1.0
.80
.97
.74
.85
.65
.83
.63
.97
.83
1.3
1.0
1.2
.92
1.2
.92
1.1
.82
.99
.75
.96
.72
1.9
1.5
1.9

mm

12
27
21
27
23
25
19
25
20
23
19
21
16
19
15
19
15
18
13
32
25
33
26
30
23
30
24
28
23
25
20
23
17
23
18
21
16
19
14
18
14
37
29
38
31
34
27
35
28
32
26
30
23
27
20
27
20
25
19
22
16
21
16
25
21
34
26
30
23
30
23
27
21
25
19
24
18
47
37
48

ENDS: C - Closed

G - Ground
O - Open

Lbs.

51
24
16
26
18
34
22
36
25
46
32
56
37
69
45
78
51
95
61
24
16
27
18
34
22
36
25
46
32
56
37
69
45
78
51
95
61
110
71
124
80
24
16
26
18
34
22
36
25
46
32
56
37
69
45
78
51
95
61
110
71
124
80
97
71
56
37
69
45
78
51
95
61
110
71
124
80
24
16
26

227
108
72
114
80
150
100
162
109
206
142
251
164
308
201
347
227
423
272
108
72
119
80
150
100
159
109
204
142
251
164
308
201
347
227
423
272
490
316
553
356
108
72
114
80
150
100
160
109
206
142
251
164
308
201
347
227
423
272
490
316
553
356
429
316
251
164
308
201
347
227
423
272
490
316
553
356
108
72
115

Inches

.64
.39
.39
.43
.43
.48
.48
.50
.50
.58
.58
.62
.62
.65
.65
.70
.70
.79
.79
.43
.43
.47
.47
.52
.52
.58
.58
.66
.66
.69
.69
.74
.74
.80
.80
.89
.89
.91
.91
.98
.98
.47
.47
.52
.52
.58
.58
.64
.64
.72
.72
.77
.77
.81
.81
.89
.89
1.01
1.01
1.01
1.01
1.09
1.09
1.22
1.22
.84
.84
.90
.90
.98
.98
1.08
1.08
1.14
1.14
1.20
1.20
.55
.55
.62

mm

Inches

16.3
9.9
9.9
10.8
10.8
12.1
12.1
12.8
12.8
14.7
14.7
15.6
15.6
16.4
16.4
17.9
17.9
20.1
20.1
10.9
10.9
11.9
11.9
13.3
13.3
14.6
14.6
16.7
16.7
17.4
17.4
18.7
18.7
20.2
20.2
22.7
22.7
23.0
23.0
24.9
24.9
12.0
12.0
13.2
13.2
14.8
14.8
16.2
16.2
18.3
18.3
19.6
19.6
20.6
20.6
22.6
22.6
25.7
25.7
25.7
25.7
27.7
27.7
31.1
31.1
21.3
21.3
22.9
22.9
25.0
25.0
27.4
27.4
28.9
28.9
30.5
30.5
14.1
14.1
15.7

0.125
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.142
0.142
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.082
0.082
0.085

mm

3.2
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
3.6
3.6
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
2.1
2.1
2.2

TOTAL
MATL
COILS
5.13
4.75
4.75
5.00
5.00
5.13
5.13
5.25
5.25
5.50
5.50
5.50
5.50
5.38
5.38
5.63
5.63
5.88
5.88
5.25
5.25
5.50
5.50
5.63
5.63
6.00
6.00
6.25
6.25
6.13
6.13
6.13
6.13
6.38
6.38
6.63
6.63
6.38
6.38
6.63
6.63
5.75
5.75
6.13
6.13
6.25
6.25
6.63
6.63
6.88
6.88
6.88
6.88
6.75
6.75
7.13
7.13
7.50
7.50
7.13
7.13
7.38
7.38
8.63
8.63
7.50
7.50
7.50
7.50
7.88
7.88
8.00
8.00
8.00
8.00
8.13
8.13
6.75
6.75
7.25

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

187

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 188

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100

27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94

72521S
72533
72533S
72544
72544S
72555
72555S
72567
72567S
72577
72577S
72589
72589S
72599
72599S
72609
72609S
72620
72620S
72610
72610S
72621
72621S
72511
72511S
72522
72522S
72534
72534S
72545
72545S
72556
72556S
72568
72568S
72578
72578S
72590
72590S
72600
72600S
72611
72611S
72622
72622S
72612
72612S
72512
72512S
72523
72523S
72535
72535S
72546
72546S
72557
72557S
72569
72569S
72579
72579S
72591
72591S
72601
72601S
72613
72613S
72623
72623S
72513
72513S
72524
72524S
72536
72536S
72547
72547S
72558
72558S
72570

2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.31
3.31
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
84.1
84.1
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6

MATERIAL: MW - Music Wire

188

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.930
.914
.914
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.816
.816
.804
.804
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.816
.816
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.936
.936
.930
.930
.914
.914
.908
.908
.890
.890
.876

RATE
mm

23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
20.7
20.7
20.4
20.4
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
20.7
20.7
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
23.8
23.8
23.6
23.6
23.2
23.2
23.1
23.1
22.6
22.6
22.3

Lbs./In.

12
20
17
21
18
28
24
38
32
52
44
58
49
76
65
98
83
115
98
88
75
104
88
11
9.1
11
9.5
16
14
17
14
23
20
31
26
42
36
47
40
62
53
80
68
94
80
64
54
9.1
7.7
9.6
8.2
14
12
14
12
20
17
26
22
36
30
40
34
52
44
67
57
79
68
7.9
6.7
8.3
7.1
12
10
13
11
17
15
23

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

2.0
3.4
2.9
3.6
3.1
5.0
4.2
6.6
5.6
9.0
7.7
10
8.6
13
11
17
15
20
17
15
13
18
15
1.9
1.6
2.0
1.7
2.8
2.4
3.0
2.5
4.1
3.5
5.4
4.6
7.4
6.3
8.3
7.0
11
9.3
14
12
16
14
11
9.5
1.6
1.4
1.7
1.4
2.4
2.0
2.5
2.1
3.4
2.9
4.6
3.9
6.3
5.3
7.0
5.9
9.1
7.7
12
10
14
12
1.4
1.2
1.5
1.2
2.1
1.8
2.2
1.9
3.0
2.5
4.0

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

1.5
1.7
1.4
1.7
1.4
1.6
1.3
1.5
1.1
1.3
1.0
1.4
1.0
1.3
.95
1.1
.85
1.1
.82
1.3
.95
1.2
.91
2.3
1.8
2.3
1.9
2.1
1.6
2.1
1.7
2.0
1.6
1.8
1.4
1.6
1.3
1.7
1.3
1.5
1.2
1.4
1.0
1.3
1.0
1.6
1.3
2.7
2.1
2.7
2.2
2.5
1.9
2.5
2.0
2.3
1.9
2.1
1.6
1.9
1.5
2.0
1.5
1.8
1.4
1.6
1.2
1.6
1.2
3.1
2.4
3.1
2.6
2.9
2.2
2.9
2.3
2.7
2.2
2.5

mm

39
44
34
44
35
41
34
38
29
34
26
34
26
32
24
29
22
27
21
32
24
30
23
57
45
58
48
54
42
54
43
51
41
46
35
42
32
42
32
39
29
35
27
34
25
39
33
68
53
68
56
63
49
64
51
60
49
54
42
49
38
50
38
46
35
42
32
40
30
78
61
79
65
72
56
73
59
69
56
63

Lbs.

18
34
22
36
25
46
32
56
37
69
45
78
51
95
61
110
71
124
80
110
71
124
80
24
16
26
18
34
22
36
25
46
32
56
37
69
45
78
51
95
61
110
71
124
80
99
71
24
16
26
18
34
22
36
25
46
32
56
37
69
45
78
51
95
61
110
71
124
80
24
16
26
18
34
22
36
25
46
32
56

80
150
100
161
109
206
142
251
164
308
201
347
227
423
272
490
316
553
356
490
316
553
356
108
72
114
80
150
100
161
109
206
142
251
164
308
201
347
227
423
272
490
316
553
356
442
316
108
72
115
80
150
100
160
109
205
142
251
164
308
201
347
227
423
272
490
316
553
356
108
72
114
80
150
100
160
109
205
142
251

ENDS: C - Closed

G - Ground
O - Open

Inches

.62
.69
.69
.76
.76
.87
.87
.92
.92
.98
.98
1.08
1.08
1.22
1.22
1.24
1.24
1.31
1.31
1.35
1.35
1.44
1.44
.64
.64
.71
.71
.80
.80
.88
.88
1.01
1.01
1.06
1.06
1.14
1.14
1.25
1.25
1.42
1.42
1.46
1.46
1.55
1.55
1.76
1.76
.72
.72
.81
.81
.91
.91
1.00
1.00
1.16
1.16
1.22
1.22
1.31
1.31
1.44
1.44
1.65
1.65
1.69
1.69
1.79
1.79
.80
.80
.90
.90
1.01
1.01
1.12
1.12
1.30
1.30
1.37

mm

15.7
17.4
17.4
19.2
19.2
22.0
22.0
23.5
23.5
24.8
24.8
27.4
27.4
30.9
30.9
31.6
31.6
33.4
33.4
34.3
34.3
36.7
36.7
16.1
16.1
18.1
18.1
20.4
20.4
22.3
22.3
25.7
25.7
27.0
27.0
29.0
29.0
31.8
31.8
36.0
36.0
37.0
37.0
39.5
39.5
44.6
44.6
18.2
18.2
20.5
20.5
23.0
23.0
25.3
25.3
29.3
29.3
30.9
30.9
33.1
33.1
36.5
36.5
42.0
42.0
42.8
42.8
45.6
45.6
20.3
20.3
22.9
22.9
25.7
25.7
28.3
28.3
33.0
33.0
34.8

WIRE DIA.
Inches

0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.142
0.142
0.148
0.148
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.142
0.142
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.082
0.082
0.085
0.085
0.093
0.093
0.096
0.096
0.105
0.105
0.112

mm

TOTAL
MATL
COILS

2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
3.6
3.6
3.8
3.8
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
3.6
3.6
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
2.1
2.1
2.2
2.2
2.4
2.4
2.4
2.4
2.7
2.7
2.8

7.25
7.38
7.38
7.88
7.88
8.25
8.25
8.25
8.25
8.13
8.13
8.63
8.63
9.00
9.00
8.75
8.75
8.88
8.88
9.50
9.50
9.75
9.75
7.75
7.75
8.38
8.38
8.63
8.63
9.13
9.13
9.63
9.63
9.50
9.50
9.50
9.50
10.0
10.0
10.5
10.5
10.3
10.3
10.5
10.5
12.4
12.4
8.75
8.75
9.50
9.50
9.75
9.75
10.4
10.4
11.0
11.0
10.9
10.9
10.9
10.9
11.5
11.5
12.3
12.3
11.9
11.9
12.1
12.1
9.75
9.75
10.6
10.6
10.9
10.9
11.6
11.6
12.4
12.4
12.3

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 189

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.100
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.109
1.125
1.125
1.125
1.125

27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
27.94
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.17
28.58
28.58
28.58
28.58

72570S
72580
72580S
72592
72592S
72602
72602S
72614
72614S
72624
72624S
72525
72525S
72548
72548S
72559
72559S
72571
72571S
72581
72581S
72593
72593S
72603
72603S
72615
72615S
72625
72625S
72526
72526S
72604
72604S
72616
72616S
72626
72626S
II-8
1869
S-1258
3752
DD-27
LL-100
S-34
11705
12160
10621
12562
S-55
HH-33
11697
2681
UU-39
S-3060
B17-150
S-1415
11864
11717
11590
S-1513
11275
10975
10503
10407
3400
4303
11222
S-1378
11618
3028
3360
S-3256
2727
394
1817
4039
A14-51
1549
S-205
S-1405

O.D.

FREE LENGTH
Inches

4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
.69
.75
1.00
1.00
1.06
1.09
1.16
1.16
1.25
1.28
1.30
1.38
1.38
1.53
1.78
1.78
2.00
2.13
2.19
2.25
2.56
2.63
2.69
2.75
2.75
2.81
2.81
2.88
3.13
3.16
3.75
3.94
4.44
4.50
4.91
5.13
8.00
10.0
19.5
.75
.81
.88
.88

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
17.4
19.1
25.4
25.4
27.0
27.8
29.4
29.4
31.8
32.5
32.9
34.9
34.9
38.9
45.2
45.2
50.8
54.0
55.6
57.2
65.1
66.7
68.2
69.9
69.9
71.4
71.4
73.0
79.4
80.2
95.3
100.0
112.7
114.3
124.6
130.2
203.2
254.0
495.3
19.1
20.6
22.2
22.2

I.D.
Inches

.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.930
.930
.908
.908
.890
.890
.876
.876
.860
.860
.850
.850
.830
.830
.816
.816
.804
.804
.930
.930
.830
.830
.816
.816
.804
.804
.869
.965
.899
.859
.769
.949
.983
.921
.919
.927
.993
.869
.809
.885
.861
.795
.813
1.013
.959
.737
.885
.783
.869
.927
.881
.885
.869
.953
.899
.813
.927
.779
.889
.909
.951
.949
.889
.899
.809
1.001
.875
1.023
.915

RATE
mm

22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
23.6
23.6
23.1
23.1
22.6
22.6
22.3
22.3
21.8
21.8
21.6
21.6
21.1
21.1
20.7
20.7
20.4
20.4
23.6
23.6
21.1
21.1
20.7
20.7
20.4
20.4
22.1
24.5
22.8
21.8
19.5
24.1
25.0
23.4
23.3
23.5
25.2
22.1
20.5
22.5
21.9
20.2
20.7
25.7
24.4
18.7
22.5
19.9
22.1
23.5
22.4
22.5
22.1
24.2
22.8
20.7
23.5
19.8
22.6
23.1
24.2
24.1
22.6
22.8
20.5
25.4
22.2
26.0
23.2

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

19
3.4
31
5.4
26
4.6
34
6.0
29
5.1
45
7.9
38
6.7
59
10
50
8.8
69
12
58
10
7.3
1.3
6.2
1.1
11
1.9
9.4
1.7
15
2.6
13
2.2
20
3.5
17
3.0
27
4.8
23
4.1
30
5.3
26
4.5
39
6.9
34
5.9
51
8.9
43
7.6
61
11
51
9.0
6.6
1.2
5.6
.98
35
6.2
30
5.3
46
8.1
39
6.8
54
9.5
46
8.1
308
54
8.7
1.5
75
13
134
23
857 150
13
2.2
2.9
.51
36
6.3
56
9.8
31
5.5
7.0
1.2
62
11
206
36
57
10
59
10
184
32
135
24
.94
.17
4.8
.84
299
52
38
6.7
171
30
54
9.4
13
2.3
32
5.6
29
5.2
54
9.4
8.1
1.4
25
4.3
153
27
7.7
1.4
127
22
21
3.7
11
1.9
4.5
.80
5.4
.95
8.8
1.5
6.4
1.1
18
3.2
9.4
1.6
351
61
2.7
.48
82
14

1.9
2.2
1.7
2.3
1.7
2.1
1.6
1.9
1.4
1.8
1.4
3.5
2.9
3.3
2.6
3.1
2.5
2.8
2.2
2.5
1.9
2.6
2.0
2.4
1.8
2.2
1.6
2.1
1.6
3.9
3.2
2.7
2.0
2.4
1.8
2.3
1.7
.16
.32
.42
.41
.13
.59
.67
.69
.45
.72
.92
.62
.43
.70
.79
.56
.59
1.7
1.5
.46
1.1
.67
.84
1.7
1.3
1.4
.92
1.8
1.4
.52
2.6
.93
1.8
2.8
3.2
4.1
4.3
6.9
4.9
.46
.22
.59
.38

mm

48
57
44
58
44
54
41
47
36
46
35
89
74
83
66
78
64
71
55
64
49
65
50
61
46
55
42
52
40
99
82
68
52
61
46
58
44
4.1
8.1
11
10
3.4
15
17
17
12
18
23
16
11
18
20
14
15
44
37
12
27
17
21
43
34
35
23
46
35
13
66
24
46
70
81
104
110
174
125
12
5.5
15
9.7

ENDS: C - Closed

G - Ground
O - Open

Lbs.

37
69
45
78
51
95
61
110
71
124
80
25
18
36
25
46
32
56
37
69
45
78
51
95
61
110
71
124
80
26
18
95
61
110
71
124
80
49
2.8
32
54
114
7.6
2.0
25
26
22
6.5
38
90
40
47
102
79
1.6
7.0
137
40
114
45
22
42
40
49
15
34
79
20
118
38
30
14
22
38
44
90
4.3
76
1.6
31

164
308
201
347
227
423
272
490
316
553
356
113
80
161
109
205
142
251
164
308
201
347
227
422
272
490
316
553
356
115
80
423
272
490
316
553
356
219
12
141
242
508
34
8.7
109
113
100
29
169
398
178
208
455
353
7.3
31
610
178
507
199
100
188
178
219
66
152
353
90
525
169
132
64
98
169
195
398
19
340
7.2
139

Inches

mm

Inches

1.37 34.8
1.47 37.3
1.47 37.3
1.63 41.3
1.63 41.3
1.86 47.1
1.86 47.1
1.88 47.8
1.88 47.8
2.02 51.2
2.02 51.2
1.01 25.6
1.01 25.6
1.24 31.4
1.24 31.4
1.44 36.7
1.44 36.7
1.53 38.8
1.53 38.8
1.64 41.5
1.64 41.5
1.81 46.0
1.81 46.0
2.09 53.1
2.09 53.1
2.13 54.1
2.13 54.1
2.26 57.3
2.26 57.3
1.09 27.8
1.09 27.8
2.30 58.3
2.30 58.3
2.34 59.5
2.34 59.5
2.48 63.0
2.48 63.0
.36
9.1
.43 11.0
.42 10.7
.59 15.1
.60 15.1
.50 12.7
.48 12.3
.47 11.9
.38
9.7
.46 11.6
.29
7.4
.76 19.3
.90 22.9
.67 17.1
.99 25.2
1.18 29.9
1.04 26.3
.38
9.8
.71 18.1
1.58 40.2
1.01 25.6
1.63 41.4
.84 21.3
.82 20.8
1.11 28.2
1.20 30.6
1.05 26.7
.62 15.8
.95 24.0
1.11 28.2
1.14 28.9
2.15 54.5
1.32 33.5
1.60 40.6
.95 24.1
1.04 26.4
2.86 72.6
3.15 80.0
7.13 181.0
.29
7.4
.50 12.7
.28
7.1
.39 10.0

0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.120
0.120
0.125
0.125
0.135
0.135
0.142
0.142
0.148
0.148
0.085
0.085
0.135
0.135
0.142
0.142
0.148
0.148
0.120
0.072
0.105
0.125
0.170
0.080
0.063
0.094
0.095
0.091
0.058
0.120
0.150
0.112
0.124
0.157
0.148
0.048
0.075
0.186
0.112
0.163
0.120
0.091
0.114
0.112
0.120
0.078
0.105
0.148
0.091
0.165
0.110
0.100
0.079
0.080
0.110
0.105
0.150
0.062
0.125
0.051
0.105

mm

TOTAL
MATL
COILS

2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.0
3.0
3.2
3.2
3.4
3.4
3.6
3.6
3.8
3.8
2.2
2.2
3.4
3.4
3.6
3.6
3.8
3.8
3.0
1.8
2.7
3.2
4.3
2.0
1.6
2.4
2.4
2.3
1.5
3.0
3.8
2.8
3.1
4.0
3.8
1.2
1.9
4.7
2.8
4.1
3.0
2.3
2.9
2.8
3.0
2.0
2.7
3.8
2.3
4.2
2.8
2.5
2.0
2.0
2.8
2.7
3.8
1.6
3.2
1.3
2.7

12.3
12.3
12.3
13.0
13.0
13.8
13.8
13.3
13.3
13.6
13.6
11.9
11.9
12.9
12.9
13.8
13.8
13.6
13.6
13.6
13.6
14.5
14.5
15.5
15.5
15.0
15.0
15.3
15.3
12.9
12.9
17.0
17.0
16.5
16.5
16.8
16.8
3.00
6.00
4.00
4.75
3.50
6.25
7.50
5.00
4.00
5.00
4.00
6.33
6.00
6.00
8.00
7.50
7.00
8.00
9.50
8.50
8.00
9.00
7.00
9.00
9.75
9.75
7.75
8.00
9.00
6.50
12.5
12.0
12.0
15.0
12.0
12.0
26.0
29.0
47.5
3.67
3.00
4.50
3.75

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
HD
SST
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
HD
SPR
SST
SST
SST
SST
SPR
SPR
SST
SPR
HD
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
MW
SPR
MW
SPR
SST
MW
SST
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
C
CG
C
CG
C
CG
C
C
C
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
N
N
N
Z
Z
Z
N
N
N
Z
Z
Z
N
N
N
N
Z
Z
N
Z
Z
Z
Z
Z
Z
N
N
Z
Z
Z
N
Z
Z
Z
Z
N
Z
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

189

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 190

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.125
1.140
1.140

28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.58
28.96
28.96

S-931
11963
10482
S-1383
3947
B17-147
S-1236
11742
12271
S-147
S-911
2945
12001
S-1249
S-1561
10624
M-80
S-3242
3302
11433
11335
CC-96
S-3239
4340
S-973
2694
S-1569
10483
S-194
1629
3965
S-466
12017
B8-67
2567
11143
11785
10540
B7-47
11203
12076
2736
825
2824
S-1131
10643
366
59
3157
11935
S-169
3180
4399
10297
2519
4274
7054
3083
S-1300
362
4121
S-1675
12068
1847
10626
12462
2723
7003
11518
814
1625
3270
374
833
826
820
867
838
S-1466
S-305

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

.97
.97
1.00
1.06
1.19
1.22
1.25
1.25
1.38
1.41
1.47
1.50
1.50
1.50
1.50
1.56
1.59
1.72
1.75
1.88
2.00
2.00
2.09
2.13
2.28
2.31
2.38
2.38
2.44
2.50
2.50
2.50
2.53
2.66
2.69
2.69
2.72
2.72
2.72
2.75
2.78
2.84
2.88
2.94
3.00
3.00
3.00
3.00
3.19
3.25
3.38
3.44
3.50
3.50
3.63
3.75
3.75
3.94
4.00
4.00
4.00
4.13
4.50
4.63
4.75
5.25
5.31
5.31
6.50
7.00
7.50
8.00
9.25
10.0
10.0
10.0
11.0
12.0
.59
1.00

mm

24.6
24.6
25.4
27.0
30.2
31.0
31.8
31.8
34.9
35.7
37.3
38.1
38.1
38.1
38.1
39.7
40.5
43.6
44.5
47.6
50.8
50.8
53.2
54.0
57.9
58.7
60.3
60.3
61.9
63.5
63.5
63.5
64.3
67.5
68.2
68.2
69.0
69.0
69.0
69.9
70.6
72.2
73.0
74.6
76.2
76.2
76.2
76.2
81.0
82.6
85.7
87.3
88.9
88.9
92.1
95.3
95.3
100.0
101.6
101.6
101.6
104.8
114.3
117.5
120.7
133.4
134.9
134.9
165.1
177.8
190.5
203.2
235.0
254.0
254.0
254.0
279.4
304.8
15.1
25.4

MATERIAL: MW - Music Wire

190

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.023
1.003
.965
.915
.941
1.005
.981
.895
.995
1.031
.981
1.017
.935
.915
.875
.815
.859
1.003
.875
.885
.829
.805
.945
.855
.965
.933
.875
.831
1.045
.965
.905
.885
.831
.875
.995
.901
.919
.895
.845
.901
.811
.855
.855
.875
.965
.943
.915
.741
.781
.965
1.031
.749
.915
.875
.899
.889
.813
.805
.975
.885
.829
.827
.823
.935
.957
.969
.961
.813
.875
.801
.801
.741
.915
.915
.855
.829
.885
.741
.858
.956

RATE
mm

26.0
25.5
24.5
23.2
23.9
25.5
24.9
22.7
25.3
26.2
24.9
25.8
23.7
23.2
22.2
20.7
21.8
25.5
22.2
22.5
21.1
20.4
24.0
21.7
24.5
23.7
22.2
21.1
26.5
24.5
23.0
22.5
21.1
22.2
25.3
22.9
23.3
22.7
21.5
22.9
20.6
21.7
21.7
22.2
24.5
24.0
23.2
18.8
19.8
24.5
26.2
19.0
23.2
22.2
22.8
22.6
20.7
20.4
24.8
22.5
21.1
21.0
20.9
23.7
24.3
24.6
24.4
20.7
22.2
20.3
20.3
18.8
23.2
23.2
21.7
21.1
22.5
18.8
21.8
24.3

Lbs./In.

1.7
4.1
26
57
31
7.7
9.6
122
4.2
.89
7.3
5.0
27
48
87
303
115
3.7
58
56
148
210
19
66
8.2
20
69
159
.72
8.6
31
59
120
64
4.3
29
28
31
82
27
175
70
60
39
5.6
14
22
275
156
3.2
.41
230
14
39
19
25
74
95
4.6
26
62
56
67
9.3
5.1
4.6
5.7
50
50
49
58
109
8.2
6.1
15
22
9.7
61
496
31

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.30
.72
4.5
10
5.5
1.4
1.7
21
.74
.16
1.3
.87
4.7
8.4
15
53
20
.64
10
9.8
26
37
3.3
11
1.4
3.6
12
28
.13
1.5
5.4
10
21
11
.75
5.1
4.8
5.3
14
4.8
31
12
10
6.8
.98
2.5
3.8
48
27
.56
.07
40
2.4
6.8
3.3
4.3
13
17
.80
4.5
11
9.9
12
1.6
.90
.81
1.0
8.8
8.8
8.6
10
19
1.4
1.1
2.7
3.8
1.7
11
87
5.4

.66
.60
.61
.55
.73
.91
.89
.35
.95
1.0
1.0
1.0
.93
.66
.57
.32
.55
1.4
.75
.87
.59
.51
1.1
.84
1.7
1.3
.72
.54
2.2
1.8
1.2
.75
.71
.86
2.1
1.4
1.2
1.4
.81
1.5
.58
1.3
1.1
1.6
2.2
1.6
1.5
.63
.84
1.8
2.7
.71
2.0
1.4
2.0
1.9
1.2
1.1
2.7
1.9
1.4
1.4
1.3
3.3
3.3
3.2
4.1
1.9
1.1
2.3
1.9
1.6
4.1
5.5
4.3
4.0
5.0
2.8
.14
.49

mm

17
15
16
14
18
23
23
8.9
24
26
26
26
24
17
15
8.1
14
34
19
22
15
13
27
21
43
32
18
14
55
47
31
19
18
22
53
35
29
36
21
37
15
34
28
40
56
39
39
16
21
46
68
18
52
36
52
47
30
28
68
48
36
36
34
85
85
80
105
49
28
57
48
40
104
141
110
101
127
72
3.4
13

Lbs.

1.1
2.5
16
31
23
7.1
8.5
43
4.0
.89
7.6
5.2
25
31
50
97
64
5.0
44
48
87
107
20
55
14
26
50
85
1.6
16
38
44
85
55
9.0
40
32
43
67
40
101
93
67
61
12
22
34
172
131
5.8
1.1
162
28
55
39
46
88
107
12
48
87
80
90
31
17
15
24
96
55
111
111
172
34
34
67
87
48
172
67
15

ENDS: C - Closed

G - Ground
O - Open

5.0
11
70
139
101
31
38
190
18
4.0
34
23
111
139
222
432
283
22
195
216
387
474
88
246
61
115
222
380
6.9
70
167
197
380
243
40
176
142
190
297
176
449
414
296
271
55
99
150
766
585
26
4.8
721
124
243
171
205
391
474
54
216
387
356
401
138
76
65
105
427
243
492
492
766
150
150
296
387
216
766
299
68

Inches

.31
.37
.32
.47
.46
.24
.36
.46
.42
.40
.43
.27
.57
.53
.69
.78
.80
.37
1.00
.87
1.04
1.12
.54
1.28
.60
.72
.81
.96
.26
.64
.94
.76
1.18
1.06
.46
1.18
.77
1.15
1.16
1.23
1.18
1.22
1.52
1.38
.80
.75
1.00
2.06
1.95
1.44
.71
2.16
1.47
1.38
1.58
1.53
2.18
2.08
.79
1.72
2.07
2.09
2.11
1.28
1.09
1.01
1.07
3.39
1.25
4.00
3.40
4.61
2.42
3.05
4.59
5.29
4.00
8.02
.42
.51

mm

7.8
9.3
8.1
12.0
11.7
6.1
9.1
11.7
10.7
10.1
11.0
6.9
14.5
13.3
17.5
19.7
20.3
9.3
25.4
22.1
26.3
28.4
13.7
32.6
15.2
18.3
20.6
24.3
6.6
16.3
23.7
19.3
29.9
27.0
11.6
29.9
19.6
29.2
29.3
31.3
29.9
30.9
38.6
34.9
20.3
19.1
25.3
52.4
49.5
36.6
17.9
54.9
37.3
34.9
40.2
39.0
55.5
52.8
20.0
43.7
52.6
53.0
53.7
32.6
27.7
25.8
27.1
86.1
31.8
101.5
86.4
117.0
61.3
77.3
116.6
134.4
101.6
203.6
10.7
12.9

WIRE DIA.
Inches

0.051
0.061
0.080
0.105
0.092
0.060
0.072
0.115
0.065
0.047
0.072
0.054
0.095
0.105
0.125
0.155
0.133
0.061
0.125
0.120
0.148
0.160
0.090
0.135
0.080
0.096
0.125
0.147
0.040
0.080
0.110
0.120
0.147
0.125
0.065
0.112
0.103
0.115
0.140
0.112
0.157
0.135
0.135
0.125
0.080
0.091
0.105
0.192
0.172
0.080
0.047
0.188
0.105
0.125
0.113
0.118
0.156
0.160
0.075
0.120
0.148
0.149
0.151
0.095
0.084
0.078
0.082
0.156
0.125
0.162
0.162
0.192
0.105
0.105
0.135
0.148
0.120
0.192
0.141
0.092

mm

TOTAL
MATL
COILS

1.3
1.5
2.0
2.7
2.3
1.5
1.8
2.9
1.7
1.2
1.8
1.4
2.4
2.7
3.2
3.9
3.4
1.5
3.2
3.0
3.8
4.1
2.3
3.4
2.0
2.4
3.2
3.7
1.0
2.0
2.8
3.0
3.7
3.2
1.7
2.8
2.6
2.9
3.6
2.8
4.0
3.4
3.4
3.2
2.0
2.3
2.7
4.9
4.4
2.0
1.2
4.8
2.7
3.2
2.9
3.0
4.0
4.1
1.9
3.0
3.8
3.8
3.8
2.4
2.1
2.0
2.1
4.0
3.2
4.1
4.1
4.9
2.7
2.7
3.4
3.8
3.0
4.9
3.6
2.3

6.00
6.00
4.00
4.50
5.00
4.00
5.00
4.00
6.50
7.50
6.00
4.00
6.00
5.00
5.50
5.00
6.00
6.00
8.00
7.25
7.00
7.00
6.00
9.50
7.50
7.50
6.50
6.50
5.50
8.00
8.50
6.33
8.00
7.50
7.00
9.50
7.50
10.0
8.25
10.0
7.50
9.00
10.3
11.0
10.0
8.25
9.50
10.8
11.3
18.0
14.0
11.5
14.0
11.0
14.0
13.0
13.0
13.0
9.50
13.3
14.0
14.0
14.0
13.5
13.0
12.0
12.0
20.5
9.00
24.7
21.0
24.0
22.0
29.0
34.0
35.8
32.3
41.8
3.00
4.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SST
SST
SST
SPR
SPR
SST
SST
SPR
SPR
SST
HD
HD
SPR
SPR
SST
SPR
SST
HD
SST
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
MW
HD
MW
SST
SPR
HD
HD
SPR
SPR
SST
SPR
SPR
SPR
HD
SPR
SST
SPR
SST
HD
SPR
SST
SPR
MW
SST
SPR
MW
HD
SPR
HD
SPR
SPR
HD
HD
HD
HD
HD
HD
SST
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
C

F
N
S
H

N
Z
N
N
Z
N
N
Z
N
N
N
Z
Z
N
N
Z
Z
N
Z
Z
Z
Z
N
Z
N
Z
N
Z
N
Z
Z
N
Z
N
Z
Z
N
Z
N
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
N
GI
N
Z
Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 191

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.140
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.156
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172

28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
28.96
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.36
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77

11907
S-1047
10889
12321
12644
S-3008
S-1203
S-254
3999
11343
3173
3156
11130
12755
S-1168
11799
10365
4312
3158
S-1458
10571
12179
10458
10376
3024
S-262
3306
10831
B8-47
Q-32
S-1018
S-1070
12237
3468
3027
PP-40
4120
PP-38
S-1183
10168
S-468
12208
11528
S-79
3013
3255
2969
3368
Y-63
3487
S-469
S-153
S-256
11624
3269
534
S-3210
10177
3143
12516
11831
B7-55
2991
10549
11685
12003
4123
S-903
3177
12587
4147
KK-60
LL-35
11389
10680
11122
S-1234
12014
11213
1539

1.09
1.25
1.31
1.50
1.83
1.88
1.94
2.00
2.25
2.41
2.56
2.63
2.84
2.84
3.00
3.13
3.19
3.88
4.00
4.88
4.88
5.16
5.25
5.31
5.63
.50
.69
.81
.88
.88
.94
1.00
1.25
1.25
1.25
1.28
1.38
1.38
1.44
1.50
1.69
1.78
1.88
1.94
2.00
2.13
2.50
2.63
2.75
2.75
2.88
3.00
3.00
3.25
3.75
3.84
3.88
4.13
4.13
4.16
4.50
5.03
5.25
5.31
5.94
6.13
7.25
.78
1.03
1.13
1.50
1.75
1.78
2.00
2.00
2.16
2.19
2.34
2.38
2.41

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

27.8
31.8
33.3
38.1
46.4
47.6
49.2
50.8
57.2
61.1
65.1
66.7
72.2
72.2
76.2
79.4
81.0
98.4
101.6
123.8
123.8
131.0
133.4
134.9
142.9
12.7
17.4
20.6
22.2
22.2
23.8
25.4
31.8
31.8
31.8
32.5
34.9
34.9
36.5
38.1
42.8
45.2
47.6
49.2
50.8
54.0
63.5
66.7
69.9
69.9
73.0
76.2
76.2
82.6
95.3
97.6
98.4
104.8
104.8
105.6
114.3
127.8
133.4
134.9
150.8
155.6
184.2
19.8
26.2
28.6
38.1
44.5
45.2
50.8
50.8
54.8
55.6
59.5
60.3
61.1

I.D.
Inches

1.012
.900
1.046
1.030
1.032
.880
.880
.756
.956
.844
.956
1.028
.756
.766
.960
.830
.844
.870
.890
.970
.890
.814
.968
.966
.786
1.062
.996
1.066
1.056
1.044
.886
.832
1.046
.980
.976
.896
.986
.896
1.052
1.048
.946
.900
1.084
1.050
1.028
.870
1.012
.946
1.028
1.026
1.048
1.048
.974
.916
.932
.860
.892
.886
.860
.964
.956
.976
1.026
.980
.832
.694
.818
1.012
1.022
.972
.818
1.032
1.032
.902
.848
.860
1.012
1.058
.876
.932

RATE
mm

25.7
22.9
26.6
26.2
26.2
22.4
22.4
19.2
24.3
21.4
24.3
26.1
19.2
19.5
24.4
21.1
21.4
22.1
22.6
24.6
22.6
20.7
24.6
24.5
20.0
27.0
25.3
27.1
26.8
26.5
22.5
21.1
26.6
24.9
24.8
22.8
25.0
22.8
26.7
26.6
24.0
22.9
27.5
26.7
26.1
22.1
25.7
24.0
26.1
26.1
26.6
26.6
24.7
23.3
23.7
21.8
22.7
22.5
21.8
24.5
24.3
24.8
26.1
24.9
21.1
17.6
20.8
25.7
26.0
24.7
20.8
26.2
26.2
22.9
21.5
21.8
25.7
26.9
22.3
23.7

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

2.9
.50
81
14
.79
.14
2.2
.38
2.4
.42
99
17
87
15
352
62
19
3.3
157
27
13
2.2
2.8
.49
270
47
232
41
8.9
1.6
124
22
76
13
51
8.9
30
5.2
5.1
.88
23
4.1
75
13
6.7
1.2
7.1
1.2
88
15
2.2
.39
32
5.5
1.9
.33
2.4
.41
9.4
1.6
223
39
584 102
2.0
.35
24
4.1
21
3.6
109
19
20
3.6
52
9.1
.80
.14
1.9
.34
26
4.6
71
12
.57
.10
1.5
.27
3.1
.54
105
18
5.5
.97
21
3.6
2.8
.49
4.0
.69
1.3
.23
1.3
.22
9.0
1.6
23
4.1
17
2.9
56
9.8
40
7.0
39
6.8
56
9.8
10
1.8
7.2
1.3
6.5
1.1
1.4
.25
7.4
1.3
54
9.4
287
50
64
11
23
3.9
6.9
1.2
42
7.4
410
72
6.1
1.1
2.1
.38
76
13
148
26
125
22
9.3
1.6
2.1
.37
92
16
43
7.5

Inches

mm

.58 15
.54 14
.94 24
1.1
29
1.5
38
.54 14
.61 16
.42 11
1.2
30
.55 14
1.7
44
2.0
52
.63 16
.77 19
2.1
53
.77 20
1.1
29
1.3
33
1.8
46
3.5
88
2.3
59
1.5
38
2.9
73
2.8
72
1.6
41
.27
6.7
.33
8.3
.59 15
.65 17
.56 14
.26
6.7
.16
4.2
.87 22
.81 21
.73 19
.53 14
.87 22
.27
6.9
.84 21
1.1
29
.95 24
.76 19
1.7
42
1.6
40
1.5
38
.73 19
2.0
50
1.6
40
2.2
56
2.2
56
2.4
61
2.5
64
2.1
53
1.5
38
2.2
55
1.5
38
1.4
35
1.7
42
1.5
38
3.0
76
2.8
71
3.2
82
4.1 105
2.7
69
2.0
51
.96 24
1.9
48
.48 12
.51 13
.65 17
.34
8.5
1.3
33
.80 20
.76 19
.62 16
.76 19
1.5
39
1.9
49
.90 23
1.1
28

ENDS: C - Closed

G - Ground
O - Open

Lbs.

1.7
7.4
44
194
.74
3.3
2.4
11
3.5
16
53
236
53
236
147
653
23
100
86
383
22
99
5.7
25
170
758
178
790
19
83
96
427
86
383
66
292
54
240
17
78
54
240
111
494
19
86
20
89
141
628
.59
2.6
10
46
1.1
5.0
1.5
6.8
5.3
23
58
260
96
426
1.7
7.6
19
85
15
68
58
258
18
78
14
62
.67
3.0
2.2
9.7
25
111
54
239
.95
4.2
2.4
11
4.6
20
77
342
11
48
33
147
6.1
27
8.7
39
3.2
14
3.2
14
19
84
35
157
36
161
85
378
55
243
65
289
85
378
31
137
20
90
21
93
5.9
26
20
91
108
480
274 1221
122
542
11
48
3.5
16
28
123
138
612
8.0
35
1.7
7.7
58
257
92
411
95
424
14
63
4.0
18
82
365
47
208

Inches

mm

Inches

.51 13.0
.60 15.2
.38
9.6
.37
9.4
.35
8.9
.72 18.2
.78 19.8
1.47 37.4
.62 15.8
.96 24.4
.83 21.0
.34
8.5
2.02 51.2
2.01 51.1
.90 22.9
1.40 35.4
1.67 42.3
1.52 38.6
1.78 45.2
1.11 28.1
2.06 52.4
2.69 68.3
1.03 26.2
1.04 26.5
3.54 89.9
.24
6.0
.36
9.1
.23
5.7
.23
5.7
.17
4.3
.51 12.9
.57 14.4
.39
9.8
.44 11.2
.52 13.1
.72 18.2
.51 13.0
1.11 28.1
.60 15.2
.36
9.3
.74 18.7
1.02 26.0
.22
5.5
.36
9.1
.51 13.0
1.07 27.2
.54 13.7
.97 24.7
.56 14.2
.52 13.2
.49 12.3
.50 12.7
.90 22.8
1.74 44.2
1.57 39.8
2.07 52.6
1.45 36.9
1.82 46.3
2.07 52.6
1.15 29.3
1.70 43.2
1.26 32.0
1.11 28.1
1.01 25.7
3.36 85.4
4.62 117.3
3.72 94.4
.30
7.6
.53 13.3
.48 12.1
.97 24.7
.44 11.1
.98 24.9
.95 24.0
1.38 35.0
1.33 33.7
.50 12.7
.41 10.5
1.48 37.6
.96 24.4

0.064
0.120
0.047
0.055
0.054
0.130
0.130
0.192
0.092
0.148
0.092
0.056
0.192
0.187
0.090
0.155
0.148
0.135
0.125
0.085
0.125
0.163
0.086
0.087
0.177
0.047
0.080
0.045
0.050
0.056
0.135
0.162
0.055
0.088
0.090
0.130
0.085
0.130
0.052
0.054
0.105
0.128
0.036
0.053
0.064
0.143
0.072
0.105
0.064
0.065
0.054
0.054
0.091
0.120
0.112
0.148
0.132
0.135
0.148
0.096
0.100
0.090
0.065
0.088
0.162
0.231
0.169
0.080
0.075
0.100
0.177
0.070
0.070
0.135
0.162
0.156
0.080
0.057
0.148
0.120

mm

TOTAL
MATL
COILS

1.6
3.0
1.2
1.4
1.4
3.3
3.3
4.9
2.3
3.8
2.3
1.4
4.9
4.7
2.3
3.9
3.8
3.4
3.2
2.2
3.2
4.1
2.2
2.2
4.5
1.2
2.0
1.1
1.3
1.4
3.4
4.1
1.4
2.2
2.3
3.3
2.2
3.3
1.3
1.4
2.7
3.3
0.9
1.3
1.6
3.6
1.8
2.7
1.6
1.7
1.4
1.4
2.3
3.0
2.8
3.8
3.4
3.4
3.8
2.4
2.5
2.3
1.7
2.2
4.1
5.9
4.3
2.0
1.9
2.5
4.5
1.8
1.8
3.4
4.1
4.0
2.0
1.4
3.8
3.0

8.00
5.00
8.00
6.75
5.50
5.50
6.00
7.67
6.75
6.50
9.00
6.00
10.5
10.8
10.0
9.00
11.3
11.3
14.0
13.0
16.5
16.5
12.0
12.0
20.0
4.00
3.50
4.00
4.50
3.00
3.75
3.50
7.00
5.00
5.75
5.50
5.00
8.50
10.5
6.75
7.00
7.00
5.00
6.75
8.00
7.50
7.50
9.25
7.75
7.00
8.00
8.25
10.0
13.5
14.0
14.0
11.0
13.5
14.0
12.0
17.0
14.0
16.0
11.5
20.8
20.0
21.0
3.75
7.00
4.75
5.50
6.25
14.0
7.00
8.50
8.50
6.25
7.25
9.00
8.00

SST
SST
SST
SPR
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
OT
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
HD
SPR
SST
SPR
SST
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SST
MW
SPR
SST
SPR
SPR
SPR
SPR
SST
HD
SST
SST
SST
SPR
SPR
SPR
SST
SPR
SPR
MW
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
MW
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SPR

E
N
D
S

CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
CG
CG
CG
CG
CG
C
C
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG

F
N
S
H

N
N
N
Z
N
N
N
N
Z
Z
Z
Z
Z
N
N
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
Z
N
N
N
N
N
Z
Z
Z
Z
Z
N
N
Z
N
Z
Z
N
Z
Z
Z
GI
N
Z
N
N
N
Z
Z
Z
N
Z
Z
Z
N
N
Z
Z
Z
Z
Z
N
Z
N
Z
Z
Z
N
Z
Z
N
Z
Z
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

191

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:29 AM Page 192

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.172
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.188
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203

29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
29.77
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.18
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56

1797
11862
B17-188
S-1244
3016
3670
11220
S-1616
10675
2742
10160
10661
S-3078
S-3178
2844
11918
1902
11632
12540
533
11259
12334
11642
3186
1849
11485
S-3058
2992
1889
12437
S-3133
S-3186
S-3012
2792
12036
11160
1924
857
11251
821
3382
869
3469
B8-64
11960
11414
11175
840
43
S-165
S-949
3673
S-362
815
11690
2704
3260
3292
809
S-250
4344
2760
4140
10638
S-1045
1894
B10-65
S-981
3055
12737
2549
12120
12281
3370
11695
10302
S-1668
S-3005
11500
11572

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

2.44
2.94
3.50
3.63
4.17
4.28
6.00
7.00
10.8
11.3
.44
.66
.75
.75
.81
1.00
1.13
1.22
1.38
1.38
1.41
1.50
1.50
1.50
1.53
1.59
1.88
1.88
2.00
2.00
2.00
2.00
2.00
2.19
2.28
2.28
2.38
2.38
2.41
2.50
2.63
2.75
2.75
3.00
3.06
3.13
3.25
3.25
3.25
3.50
3.94
4.63
4.63
4.63
4.75
4.81
5.25
5.50
6.00
6.13
6.75
7.00
11.5
.81
1.13
1.13
1.16
1.28
1.31
1.31
1.34
1.41
1.47
1.75
1.94
1.94
1.97
2.00
2.00
2.03

mm

61.9
74.6
88.9
92.1
106.0
108.7
152.4
177.8
273.1
285.8
11.1
16.7
19.1
19.1
20.6
25.4
28.6
31.0
34.9
34.9
35.7
38.1
38.1
38.1
38.9
40.5
47.6
47.6
50.8
50.8
50.8
50.8
50.8
55.6
57.9
57.9
60.3
60.3
61.1
63.5
66.7
69.9
69.9
76.2
77.8
79.4
82.6
82.6
82.6
88.9
100.0
117.5
117.5
117.5
120.7
122.2
133.4
139.7
152.4
155.6
171.5
177.8
292.1
20.6
28.6
28.6
29.4
32.5
33.3
33.3
34.1
35.7
37.3
44.5
49.2
49.2
50.0
50.8
50.8
51.6

MATERIAL: MW - Music Wire

192

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.902
1.016
1.082
1.012
.888
1.074
.788
.988
.860
.908
1.028
1.000
.928
.908
.808
1.066
1.038
1.006
1.028
.978
1.028
1.032
1.028
.774
1.006
1.020
1.068
.938
1.044
1.040
.978
.918
.774
.918
1.068
.876
1.004
.918
.864
.892
.908
.948
.918
.862
.908
.978
.892
.804
.734
1.094
.812
1.026
.978
.864
.858
1.028
.834
.834
.834
.948
.854
.864
1.008
.833
.963
.961
1.101
.933
1.113
1.043
1.017
1.079
1.075
.879
1.019
.849
.849
.849
.791
.907

RATE
mm

22.9
25.8
27.5
25.7
22.6
27.3
20.0
25.1
21.8
23.1
26.1
25.4
23.6
23.1
20.5
27.1
26.4
25.6
26.1
24.8
26.1
26.2
26.1
19.7
25.6
25.9
27.1
23.8
26.5
26.4
24.8
23.3
19.7
23.3
27.1
22.3
25.5
23.3
21.9
22.7
23.1
24.1
23.3
21.9
23.1
24.8
22.7
20.4
18.6
27.8
20.6
26.1
24.8
21.9
21.8
26.1
21.2
21.2
21.2
24.1
21.7
21.9
25.6
21.2
24.5
24.4
28.0
23.7
28.3
26.5
25.8
27.4
27.3
22.3
25.9
21.6
21.6
21.6
20.1
23.0

Lbs./In.

N/mm

66
12
9.1
1.6
.41
.07
7.9
1.4
49
8.5
.73
.13
143
25
3.3
.58
27
4.7
11
2.0
43
7.6
86
15
241
42
417
73
1256 220
4.1
.72
6.6
1.2
15
2.6
17
3.0
50
8.8
19
3.4
9.7
1.7
14
2.5
932 163
30
5.2
18
3.1
3.2
.56
65
11
6.2
1.1
7.3
1.3
28
4.9
71
12
442
77
58
10
3.1
.53
163
29
16
2.7
68
12
203
36
85
15
69
12
35
6.1
58
10
119
21
64
11
18
3.2
88
15
203
36
434
76
.46
.08
169
30
3.8
.67
8.0
1.4
64
11
77
13
3.5
.61
114
20
114
20
72
13
13
2.3
51
9.0
51
8.9
3.1
.54
1064 186
117
20
139
24
.63
.11
136
24
.84
.15
17
2.9
39
6.9
6.4
1.1
7.3
1.3
195
34
9.7
1.7
290
51
290
51
252
44
746 131
168
29

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.97 25
1.6
39
3.0
76
1.8
46
1.5
39
3.7
95
1.2
30
4.7 119
3.5
90
5.2 133
.20
5.0
.27
6.9
.21
5.4
.15
3.9
.13
3.2
.70 18
.60 15
.58 15
.86 22
.64 16
.78 20
1.0
26
1.0
26
.22
5.6
.98 25
.97 25
1.5
38
.80 20
1.5
37
1.5
37
1.1
27
.80 20
.40 10
.97 25
1.9
48
.58 15
1.4
35
.93 24
.46 12
.98 25
1.0
26
1.3
33
1.1
28
.80 20
1.1
28
1.8
44
.95 24
.81 21
.59 15
3.0
76
.79 20
3.5
89
2.8
72
1.6
42
1.4
37
3.6
91
1.2
30
1.2
30
1.9
48
3.2
80
2.2
57
2.1
52
6.6 167
.14
3.5
.36
9.0
.34
8.5
.60 15
.41 10
1.0
26
.87 22
.56 14
1.1
29
1.1
28
.53 14
1.0
26
.46 12
.41 10
.47 12
.27
6.8
.49 12

Lbs.

64
285
14
62
1.2
5.4
14
63
74
330
2.7
12
166
740
15
69
95
424
60
267
8.6
38
23
103
51
227
63
282
159
709
2.9
13
4.0
18
8.7
39
15
66
32
143
15
66
10
45
15
66
204
907
29
131
17
77
4.8
21
52
231
9.0
40
11
48
30
132
57
253
176
781
57
253
5.8
26
94
419
22
97
63
281
93
415
83
368
70
313
46
205
63
281
95
423
70
313
32
143
83
368
164
731
255 1136
1.4
6.1
133
592
13
59
23
101
105
468
111
493
12
55
136
605
136
605
136
605
42
187
115
511
105
468
20
91
146
649
42
185
47
208
.37
1.7
56
251
.86
3.8
15
65
22
99
7.3
32
8.0
36
104
462
10
45
134
598
119
531
119
531
199
885
82
364

ENDS: C - Closed

G - Ground
O - Open

Inches

mm

1.15 29.2
.51 12.9
.50 12.6
.56 14.2
1.85 46.9
.54 13.7
3.17 80.5
2.30 58.4
4.99 126.8
4.88 124.1
.24
6.1
.28
7.2
.42 10.7
.42 10.7
.67 16.9
.31
7.7
.53 13.3
.64 16.2
.44 11.2
.60 15.3
.42 10.7
.47 11.9
.40 10.2
1.04 26.3
.41 10.4
.50 12.8
.39
9.9
.81 20.6
.54 13.7
.54 13.6
.76 19.3
.95 24.0
1.55 39.4
1.22 30.9
.38
9.5
1.05 26.7
.74 18.7
1.22 30.9
.97 24.7
1.37 34.8
1.26 32.0
1.20 30.5
1.22 30.9
1.47 37.3
1.33 33.8
1.00 25.3
1.33 33.8
2.26 57.3
2.59 65.7
.52 13.1
2.12 53.7
1.13 28.8
1.79 45.3
2.63 66.9
2.48 62.9
1.24 31.5
2.48 62.9
2.48 62.9
3.72 94.4
2.16 54.9
3.76 95.4
3.24 82.3
2.34 59.4
.65 16.4
.45 11.4
.45 11.5
.56 14.2
.61 15.4
.29
7.4
.44 11.2
.37
9.4
.26
6.7
.27
6.9
1.05 26.7
.90 22.8
1.15 29.2
1.06 27.0
1.15 29.2
1.34 34.0
.96 24.4

WIRE DIA.
Inches

0.135
0.078
0.045
0.080
0.142
0.049
0.192
0.092
0.156
0.132
0.080
0.094
0.130
0.140
0.190
0.061
0.075
0.091
0.080
0.105
0.080
0.078
0.080
0.207
0.091
0.084
0.060
0.125
0.072
0.074
0.105
0.135
0.207
0.135
0.060
0.156
0.092
0.135
0.162
0.148
0.140
0.120
0.135
0.163
0.140
0.105
0.148
0.192
0.227
0.047
0.188
0.081
0.105
0.162
0.165
0.080
0.177
0.177
0.177
0.120
0.167
0.162
0.090
0.185
0.120
0.121
0.051
0.135
0.045
0.080
0.093
0.062
0.064
0.162
0.092
0.177
0.177
0.177
0.206
0.148

mm

TOTAL
MATL
COILS

3.4
2.0
1.1
2.0
3.6
1.2
4.9
2.3
4.0
3.4
2.0
2.4
3.3
3.6
4.8
1.5
1.9
2.3
2.0
2.7
2.0
2.0
2.0
5.3
2.3
2.1
1.5
3.2
1.8
1.9
2.7
3.4
5.3
3.4
1.5
4.0
2.3
3.4
4.1
3.8
3.6
3.0
3.4
4.1
3.6
2.7
3.8
4.9
5.8
1.2
4.8
2.1
2.7
4.1
4.2
2.0
4.5
4.5
4.5
3.0
4.2
4.1
2.3
4.7
3.0
3.1
1.3
3.4
1.1
2.0
2.4
1.6
1.6
4.1
2.3
4.5
4.5
4.5
5.2
3.8

8.50
6.50
11.0
7.00
13.0
10.0
16.5
24.0
32.0
36.0
3.00
3.00
3.25
3.00
3.50
5.00
7.00
7.00
4.50
4.75
4.25
6.00
5.00
5.00
4.50
5.00
5.50
6.50
6.50
6.25
6.25
7.00
7.50
9.00
6.25
6.75
7.00
8.00
6.00
9.25
9.00
9.00
9.00
9.00
9.50
9.50
9.00
11.8
11.5
11.0
11.3
14.0
17.0
16.3
15.0
14.5
14.0
14.0
21.0
18.0
22.5
20.0
25.0
3.50
4.00
3.75
11.0
4.50
6.50
4.50
4.00
4.25
4.25
6.50
9.75
6.50
6.00
6.50
5.50
5.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

HD
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
HD
SPR
SPR
SPR
SPR
MW
SPR
SST
SPR
HD
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
HD
SST
HD
SPR
HD
HD
SST
SPR
HD
SPR
HD
HD
SST
SST
SPR
SST
HD
SPR
HD
SPR
SPR
HD
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR

E
N
D
S

CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
C
C
CG
C
C
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
N
N
N
GI
Z
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
N
N
N
Z
Z
Z
GI
Z
N
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
N
N
Z
N
Z
Z
Z
Z
Z
Z
N
Z
GI
Z
Z
N
Z
N
N
Z
N
Z
Z
Z
Z
Z
Z
N
N
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 193

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.203
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.219
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225

30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.56
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
30.96
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12

12087
B18-166
S-241
S-337
10291
S-281
3626
10461
12301
4339
12090
12002
B18-201
S-306
2955
2548
1745
10974
11826
1551
S-346
11552
3444
B10-8
S-974
12701
10875
10704
12631
11353
3451
2885
11164
KK-71
10304
12096
11120
11579
4391
S-955
S-1336
11320
B18-194
11932
3404
S-3053
12328
S-1375
B18-182
4302
11858
7056
10989
283
11731
2841
4174
72627
72627S
72637
72637S
72651
72651S
72664
72664S
72679
72679S
72693
72693S
72708
72708S
72628
72628S
72638
72638S
72652
72652S
72665
72665S
72680

O.D.

FREE LENGTH
Inches

2.06
2.28
2.34
2.38
2.38
2.38
2.75
2.75
3.00
3.25
3.38
3.38
3.47
3.50
3.56
4.38
5.13
5.88
7.25
7.75
16.0
.94
.94
1.00
1.16
1.31
1.31
1.38
1.38
1.38
1.44
1.53
1.63
1.75
1.75
1.75
1.97
2.22
2.33
2.34
2.38
2.38
2.44
2.50
2.75
2.88
3.00
3.00
3.22
3.25
3.84
4.00
4.06
4.50
7.50
7.75
12.0
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
.88
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.00

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

52.4
57.9
59.5
60.3
60.3
60.3
69.9
69.9
76.2
82.6
85.7
85.7
88.1
88.9
90.5
111.1
130.2
149.2
184.2
196.9
406.4
23.8
23.8
25.4
29.4
33.3
33.3
34.9
34.9
34.9
36.5
38.9
41.3
44.5
44.5
44.5
50.0
56.4
59.1
59.5
60.3
60.3
61.9
63.5
69.9
73.0
76.2
76.2
81.8
82.6
97.6
101.6
103.2
114.3
190.5
196.9
304.8
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
22.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4
25.4

I.D.
Inches

.933
1.003
.963
.993
.907
.907
1.113
.999
1.113
.753
1.079
1.013
1.061
1.033
1.063
.983
1.079
.963
.991
.909
1.023
.949
.943
.969
.979
1.057
1.009
1.075
1.059
.895
1.035
1.017
.907
1.039
1.009
.859
.879
.951
.923
1.035
1.037
.907
1.129
.829
1.009
1.075
1.119
1.117
.725
1.009
1.043
.865
.805
.895
.895
.923
1.039
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975

RATE
mm

23.7
25.5
24.5
25.2
23.0
23.0
28.3
25.4
28.3
19.1
27.4
25.7
26.9
26.2
27.0
25.0
27.4
24.5
25.2
23.1
26.0
24.1
24.0
24.6
24.9
26.8
25.6
27.3
26.9
22.7
26.3
25.8
23.0
26.4
25.6
21.8
22.3
24.2
23.4
26.3
26.3
23.0
28.7
21.1
25.6
27.3
28.4
28.4
18.4
25.6
26.5
22.0
20.4
22.7
22.7
23.4
26.4
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

78
19
45
23
98
93

mm

14
.80 20
3.4
1.4
36
7.9
.92 23
4.0
1.3
33
17
.84 21
16
.79 20
.54
.09
2.3
58
20
3.6
1.4
36
.54
.09
2.6
66
485
85
.51 13
1.6
.28
2.8
70
14
2.5
1.6
42
2.5
.43
2.7
68
6.7
1.2
2.5
63
2.5
.44
2.7
68
14
2.4
2.6
65
.99
.17
4.0 103
15
2.6
3.1
79
8.7
1.5
3.5
88
25
4.4
3.2
81
1.6
.29
11
290
.02
.003
.88 22
275
48
.24
6.1
119
21
.39
9.9
104
18
.39 10
17
2.9
.87 22
28
4.9
.68 17
9.1
1.6
1.1
27
16
2.8
.91 23
297
52
.31
7.8
36
6.3
.59 15
37
6.5
.75 19
236
41
.39
9.9
29
5.1
.63 16
32
5.5
.99 25
384
67
.35
8.8
198
35
.60 15
60
11
1.0
25
94
16
.86 22
14
2.4
1.4
36
14
2.4
1.4
36
177
31
.52 13
.52
.09
2.0
52
387
68
.43 11
23
4.0
1.4
35
5.6
.97
1.8
46
1.0
.18
2.6
65
.59
.10
2.4
61
574 101
.47 12
16
2.8
2.0
50
7.6
1.3
2.4
61
99
17
1.2
30
255
45
.78 20
70
12
1.5
37
41
7.2
2.5
64
24
4.2
3.4
86
3.0
.52
6.7 169
37
6.4
.59 15
31
5.4
.52 13
60
10
.56 14
51
8.9
.44 11
83
14
.51 13
70
12
.41 10
105
18
.49 12
89
16
.37
9.5
161
28
.43 11
137
24
.34
8.5
219
38
.39
9.9
186
33
.30
7.5
325
57
.33
8.3
276
48
.26
6.7
31
5.4
.69 18
26
4.6
.62 16
50
8.8
.65 17
43
7.5
.52 13
70
12
.61 15
59
10
.49 12
88
15
.57 14
75
13
.44 11
134
24
.50 13
ENDS: C - Closed

G - Ground
O - Open

Lbs.

63
278
27
122
42
185
29
131
82
364
74
328
1.2
5.5
29
130
1.4
6.3
246 1096
4.4
19
24
105
6.7
30
17
74
6.7
30
35
157
4.0
18
46
202
30
135
80
357
19
83
.02
.07
66
293
46
206
41
182
15
65
19
85
9.5
42
15
65
91
406
21
94
28
124
92
409
18
82
31
139
133
593
118
526
60
269
81
360
20
87
19
85
92
409
1.1
4.7
168
747
31
139
10
44
2.6
12
1.4
6.3
267 1188
31
139
18
81
118
525
199
887
103
457
103
457
81
360
20
88
22
97
16
72
33
147
22
99
42
188
29
129
51
227
33
148
69
306
46
205
86
381
55
246
106
470
73
322
22
96
16
72
33
146
22
99
42
187
29
129
50
222
33
148
67
299

Inches

.95
.75
.78
.74
1.18
1.11
.45
.79
.41
2.36
.62
.76
.78
.85
.88
1.51
1.09
2.16
1.80
3.63
3.56
.06
.48
.50
.47
.45
.63
.32
.44
.73
.37
.49
.78
.36
.74
.99
1.23
1.21
1.18
.60
.68
.94
.41
1.37
.86
.50
.43
.61
2.72
1.05
.79
2.48
2.48
2.27
3.65
3.77
2.25
.29
.29
.32
.32
.37
.37
.39
.39
.45
.45
.49
.49
.56
.56
.31
.31
.35
.35
.39
.39
.43
.43
.50

mm

Inches

24.0
19.1
19.8
18.7
30.1
28.2
11.4
20.1
10.3
60.0
15.7
19.3
19.8
21.6
22.2
38.4
27.6
54.9
45.8
92.1
90.3
1.5
12.3
12.7
11.8
11.3
16.0
8.2
11.2
18.5
9.3
12.5
19.8
9.1
18.7
25.1
31.3
30.6
30.1
15.2
17.3
23.8
10.3
34.7
21.7
12.8
10.8
15.5
69.0
26.7
20.1
62.9
63.1
57.6
92.6
95.9
57.2
7.3
7.3
8.2
8.2
9.3
9.3
10.0
10.0
11.5
11.5
12.4
12.4
14.1
14.1
7.8
7.8
8.8
8.8
10.0
10.0
11.0
11.0
12.7

0.135
0.100
0.120
0.105
0.148
0.148
0.045
0.102
0.045
0.225
0.062
0.095
0.071
0.085
0.070
0.110
0.062
0.120
0.106
0.147
0.090
0.135
0.138
0.125
0.120
0.081
0.105
0.072
0.080
0.162
0.092
0.101
0.156
0.090
0.105
0.180
0.170
0.134
0.148
0.092
0.091
0.156
0.045
0.195
0.105
0.072
0.050
0.051
0.247
0.105
0.088
0.177
0.207
0.162
0.162
0.148
0.090
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125

mm

TOTAL
MATL
COILS

3.4
2.5
3.0
2.7
3.8
3.8
1.1
2.6
1.1
5.7
1.6
2.4
1.8
2.2
1.8
2.8
1.6
3.0
2.7
3.7
2.3
3.4
3.5
3.2
3.0
2.1
2.7
1.8
2.0
4.1
2.3
2.6
4.0
2.3
2.7
4.6
4.3
3.4
3.8
2.3
2.3
4.0
1.1
5.0
2.7
1.8
1.3
1.3
6.3
2.7
2.2
4.5
5.3
4.1
4.1
3.8
2.3
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2

7.00
7.50
6.50
7.00
8.00
7.50
9.00
7.75
9.00
10.5
10.0
8.00
11.0
9.00
11.5
13.8
16.5
18.0
16.0
24.7
38.5
3.50
3.50
4.00
4.00
4.50
6.00
4.50
4.50
4.50
4.00
5.00
5.00
4.00
6.00
5.50
7.25
8.00
8.00
6.50
6.50
6.00
9.00
7.00
8.00
6.00
7.50
11.0
11.0
10.0
9.00
13.0
12.0
14.0
22.5
25.5
24.0
3.38
3.38
3.38
3.38
3.50
3.50
3.50
3.50
3.63
3.63
3.63
3.63
3.75
3.75
3.63
3.63
3.63
3.63
3.75
3.75
3.88
3.88
4.00

SPR
SPR
SST
SST
SPR
SST
HD
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
HD
SST
SPR
SST
MW
SPR
SST
SST
SPR
SST
SST
HD
SST
HD
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SST
SST
HD
HD
SPR
HD
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
C
CG
C
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
N
N
N
Z
N
Z
Z
Z
Z
N
Z
N
N
Z
Z
Z
Z
N
Z
N
Z
Z
N
N
N
N
N
N
N
Z
Z
Z
N
Z
Z
Z
N
Z
N
N
Z
N
N
Z
N
Z
N
N
Z
N
N
Z
Z
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

193

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 194

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225

31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12

72680S
72694
72694S
72709
72709S
72729
72729S
72639
72639S
72653
72653S
72666
72666S
72681
72681S
72695
72695S
72710
72710S
72629
72629S
72640
72640S
72654
72654S
72667
72667S
72682
72682S
72696
72696S
72711
72711S
72730
72730S
72743
72743S
72751
72751S
72641
72641S
72656
72656S
72669
72669S
72683
72683S
72698
72698S
72713
72713S
72630
72630S
72642
72642S
72657
72657S
72670
72670S
72684
72684S
72699
72699S
72714
72714S
72731
72731S
72744
72744S
72752
72752S
72759
72759S
72643
72643S
72685
72685S
72721
72721S
72732

1.00
1.00
1.00
1.00
1.00
1.00
1.00
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.25
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
1.75
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.25
2.25
2.25
2.25
2.25
2.25

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

25.4
25.4
25.4
25.4
25.4
25.4
25.4
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
31.8
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
44.5
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
57.2
57.2
57.2
57.2
57.2
57.2

MATERIAL: MW - Music Wire

194

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.975
.955
.955
.929
.929
.901
.901
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.901
.901
.871
.871
.841
.841
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.901
.901
.871
.871
.841
.841
.811
.811
1.033
1.033
.975
.975
.913
.913
.901

RATE
mm

24.8
24.3
24.3
23.6
23.6
22.9
22.9
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
22.9
22.9
22.1
22.1
21.4
21.4
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
22.9
22.9
22.1
22.1
21.4
21.4
20.6
20.6
26.2
26.2
24.8
24.8
23.2
23.2
22.9

Lbs./In.

114
183
156
270
229
415
352
39
33
53
45
67
57
101
86
136
116
199
169
19
16
31
26
43
36
54
46
81
69
116
98
158
134
238
203
353
300
516
439
26
22
37
31
51
43
67
57
92
78
134
114
14
12
23
19
31
26
39
33
58
49
82
70
111
95
167
142
246
209
356
303
505
429
20
17
50
43
130
111
151

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

20
32
27
47
40
73
62
6.7
5.7
9.2
7.9
12
9.9
18
15
24
20
35
30
3.4
2.9
5.4
4.6
7.4
6.3
9.4
8.0
14
12
20
17
28
23
42
35
62
53
90
77
4.6
3.9
6.5
5.5
8.9
7.6
12
10
16
14
23
20
2.5
2.1
3.9
3.3
5.4
4.6
6.7
5.7
10
8.6
14
12
20
17
29
25
43
37
62
53
88
75
3.5
2.9
8.8
7.5
23
19
26

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

.40
.46
.36
.41
.32
.35
.26
.84
.68
.79
.64
.75
.59
.67
.54
.61
.48
.55
.43
1.1
.99
1.0
.84
.99
.80
.94
.73
.84
.67
.74
.56
.69
.54
.60
.45
.52
.39
.44
.31
1.2
1.0
1.2
.92
1.0
.77
1.0
.81
.93
.71
.84
.64
1.5
1.4
1.4
1.2
1.4
1.1
1.3
1.0
1.2
.94
1.0
.79
.96
.77
.86
.64
.75
.56
.63
.45
.55
.40
1.7
1.3
1.3
1.1
.99
.74
.95

mm

10
12
9.0
10
8.0
8.8
6.5
21
17
20
16
19
15
17
14
15
12
14
11
28
25
27
21
25
20
24
19
21
17
19
14
17
14
15
11
13
9.9
11
8.0
32
25
30
23
25
19
26
20
24
18
21
16
39
34
37
29
35
28
33
26
30
24
27
20
24
19
22
16
19
14
16
12
14
10
42
33
34
27
25
19
24

Lbs.

46
84
55
110
73
143
91
32
22
42
29
50
33
68
46
83
55
109
73
21
16
32
22
42
29
50
33
68
46
86
55
108
73
143
91
185
118
226
138
33
22
44
29
51
33
68
46
86
55
113
73
21
16
33
22
42
29
50
33
68
46
86
55
107
73
143
91
185
118
226
138
278
171
33
22
68
46
128
81
143

205
375
246
489
322
637
404
144
99
186
129
221
148
301
205
369
246
484
322
96
72
144
99
187
129
224
148
302
205
383
246
481
322
637
404
824
523
1005
613
145
99
194
129
227
148
304
205
383
246
501
322
95
72
145
99
187
129
223
148
300
205
383
246
478
322
637
404
824
523
1005
613
1237
761
145
99
301
205
571
362
637

ENDS: C - Closed

G - Ground
O - Open

Inches

.50
.54
.54
.59
.59
.65
.65
.41
.41
.46
.46
.50
.50
.58
.58
.64
.64
.70
.70
.39
.39
.46
.46
.51
.51
.56
.56
.66
.66
.69
.69
.81
.81
.89
.89
.97
.97
1.03
1.03
.50
.50
.56
.56
.59
.59
.73
.73
.81
.81
.91
.91
.48
.48
.55
.55
.63
.63
.70
.70
.83
.83
.88
.88
1.04
1.04
1.11
1.11
1.24
1.24
1.34
1.34
1.45
1.45
.60
.60
.91
.91
1.15
1.15
1.22

mm

12.7
13.7
13.7
15.0
15.0
16.5
16.5
10.4
10.4
11.7
11.7
12.8
12.8
14.7
14.7
16.3
16.3
17.9
17.9
10.0
10.0
11.6
11.6
13.0
13.0
14.2
14.2
16.7
16.7
17.6
17.6
20.7
20.7
22.6
22.6
24.7
24.7
26.2
26.2
12.8
12.8
14.3
14.3
14.9
14.9
18.7
18.7
20.6
20.6
23.0
23.0
12.1
12.1
14.0
14.0
16.0
16.0
17.8
17.8
21.0
21.0
22.3
22.3
26.3
26.3
28.3
28.3
31.5
31.5
34.1
34.1
36.8
36.8
15.2
15.2
23.0
23.0
29.2
29.2
30.9

WIRE DIA.
Inches

mm

0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.177
0.177
0.192
0.192
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.096
0.096
0.125
0.125
0.156
0.156
0.162

3.2
3.4
3.4
3.8
3.8
4.1
4.1
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
4.5
4.5
4.9
4.9
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
2.4
2.4
3.2
3.2
4.0
4.0
4.1

FINISH: Z - Zinc

TOTAL
MATL
COILS
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.25
4.25
4.38
4.38
4.50
4.50
4.63
4.63
4.75
4.75
4.75
4.75
4.63
4.63
4.75
4.75
4.88
4.88
5.00
5.00
5.25
5.25
5.13
5.13
5.50
5.50
5.50
5.50
5.50
5.50
5.38
5.38
5.25
5.25
5.38
5.38
5.25
5.25
5.88
5.88
6.00
6.00
6.13
6.13
5.63
5.63
5.75
5.75
6.00
6.00
6.25
6.25
6.63
6.63
6.50
6.50
7.00
7.00
6.88
6.88
7.00
7.00
7.00
7.00
7.00
7.00
6.25
6.25
7.25
7.25
7.38
7.38
7.50

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 195

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225

31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12

72732S
72631
72631S
72644
72644S
72658
72658S
72671
72671S
72686
72686S
72700
72700S
72715
72715S
72722
72722S
72733
72733S
72745
72745S
72753
72753S
72760
72760S
72645
72645S
72687
72687S
72632
72632S
72646
72646S
72659
72659S
72672
72672S
72688
72688S
72701
72701S
72716
72716S
72723
72723S
72734
72734S
72746
72746S
72754
72754S
72761
72761S
72633
72633S
72647
72647S
72660
72660S
72673
72673S
72689
72689S
72702
72702S
72717
72717S
72724
72724S
72735
72735S
72747
72747S
72755
72755S
72762
72762S
72725
72725S
72736

2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.75
3.75
3.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
95.3
95.3
95.3

I.D.
Inches

.901
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.913
.913
.901
.901
.871
.871
.841
.841
.811
.811
1.033
1.033
.975
.975
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.913
.913
.901
.901
.871
.871
.841
.841
.811
.811
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.913
.913
.901
.901
.871
.871
.841
.841
.811
.811
.913
.913
.901

RATE
mm

22.9
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
23.2
23.2
22.9
22.9
22.1
22.1
21.4
21.4
20.6
20.6
26.2
26.2
24.8
24.8
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
23.2
23.2
22.9
22.9
22.1
22.1
21.4
21.4
20.6
20.6
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
23.2
23.2
22.9
22.9
22.1
22.1
21.4
21.4
20.6
20.6
23.2
23.2
22.9

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

128
11
9.4
18
15
24
20
30
26
45
38
64
54
86
73
113
96
131
111
189
160
272
231
384
326
16
14
40
34
9.1
7.7
15
12
20
17
25
21
37
31
52
44
70
60
93
79
107
91
153
130
220
187
310
263
7.8
6.6
12
10
17
14
21
18
31
26
44
37
59
50
78
66
90
76
129
109
185
157
259
220
72
61
85

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

22
1.9
1.7
3.1
2.6
4.2
3.6
5.3
4.5
7.8
6.7
11
9.5
15
13
20
17
23
19
33
28
48
41
67
57
2.8
2.4
7.1
6.0
1.6
1.4
2.5
2.2
3.4
2.9
4.3
3.7
6.4
5.5
9.1
7.8
12
10
16
14
19
16
27
23
39
33
54
46
1.4
1.2
2.2
1.8
2.9
2.5
3.7
3.1
5.4
4.6
7.7
6.6
10
8.8
14
12
16
13
23
19
32
28
45
39
13
11
15

Inches

.71
1.9
1.7
1.8
1.5
1.8
1.4
1.7
1.3
1.5
1.2
1.3
1.0
1.3
.99
1.1
.85
1.1
.82
.98
.73
.83
.60
.73
.52
2.0
1.6
1.7
1.3
2.4
2.1
2.2
1.8
2.1
1.7
2.0
1.6
1.9
1.5
1.6
1.2
1.5
1.2
1.4
1.0
1.3
1.0
1.2
.90
1.0
.74
.90
.65
2.8
2.5
2.6
2.1
2.5
2.0
2.4
1.9
2.2
1.7
2.0
1.5
1.8
1.4
1.6
1.2
1.6
1.2
1.4
1.1
1.2
.88
1.1
.78
1.8
1.3
1.7

mm

18
49
44
47
38
44
36
42
33
38
31
34
26
32
25
29
22
28
21
25
19
21
15
19
13
52
42
43
34
60
53
57
46
54
44
52
40
47
37
42
32
39
31
35
26
34
25
31
23
26
19
23
17
71
62
67
54
64
52
61
48
56
44
50
38
46
37
42
31
41
30
37
27
31
22
27
20
45
34
43

ENDS: C - Closed

G - Ground
O - Open

Lbs.

91
21
16
32
22
42
29
50
33
68
46
86
55
109
73
128
81
143
91
185
118
226
138
281
171
32
22
68
46
21
16
33
22
42
29
50
33
68
46
86
55
108
73
128
81
143
91
185
118
226
138
280
171
22
16
33
22
42
29
50
33
68
46
86
55
108
73
128
81
143
91
185
118
226
138
281
171
128
81
143

404
96
72
144
99
187
129
222
148
302
205
383
246
483
322
571
362
637
404
824
523
1005
613
1248
761
144
99
302
205
95
72
145
99
186
129
223
148
304
205
383
246
480
322
571
362
637
404
824
523
1005
613
1245
761
96
72
145
99
186
129
223
148
302
205
383
246
478
322
571
362
637
404
824
523
1005
613
1248
761
571
362
637

Inches

1.22
.56
.56
.66
.66
.75
.75
.84
.84
.98
.98
1.05
1.05
1.24
1.24
1.27
1.27
1.34
1.34
1.50
1.50
1.63
1.63
1.76
1.76
.71
.71
1.06
1.06
.65
.65
.76
.76
.88
.88
.97
.97
1.14
1.14
1.23
1.23
1.46
1.46
1.48
1.48
1.56
1.56
1.77
1.77
1.92
1.92
2.10
2.10
.72
.72
.85
.85
1.00
1.00
1.11
1.11
1.31
1.31
1.40
1.40
1.68
1.68
1.70
1.70
1.82
1.82
2.04
2.04
2.23
2.23
2.41
2.41
1.81
1.81
1.90

mm

Inches

30.9
14.3
14.3
16.8
16.8
19.0
19.0
21.3
21.3
25.0
25.0
26.6
26.6
31.5
31.5
32.2
32.2
33.9
33.9
38.2
38.2
41.5
41.5
44.7
44.7
18.0
18.0
27.0
27.0
16.5
16.5
19.2
19.2
22.3
22.3
24.5
24.5
29.0
29.0
31.3
31.3
37.1
37.1
37.6
37.6
39.6
39.6
45.0
45.0
48.8
48.8
53.2
53.2
18.4
18.4
21.6
21.6
25.3
25.3
28.1
28.1
33.3
33.3
35.6
35.6
42.8
42.8
43.1
43.1
46.3
46.3
51.7
51.7
56.7
56.7
61.1
61.1
46.1
46.1
48.3

0.162
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.096
0.096
0.125
0.125
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.156
0.156
0.162

mm

TOTAL
MATL
COILS

4.1
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
2.4
2.4
3.2
3.2
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
4.0
4.0
4.1

7.50
6.63
6.63
6.88
6.88
7.13
7.13
7.50
7.50
7.88
7.88
7.75
7.75
8.38
8.38
8.13
8.13
8.25
8.25
8.50
8.50
8.50
8.50
8.50
8.50
7.38
7.38
8.50
8.50
7.63
7.63
7.88
7.88
8.38
8.38
8.63
8.63
9.13
9.13
9.13
9.13
9.88
9.88
9.50
9.50
9.63
9.63
10.0
10.0
10.0
10.0
10.1
10.1
8.50
8.50
8.88
8.88
9.50
9.50
9.88
9.88
10.5
10.5
10.4
10.4
11.4
11.4
10.9
10.9
11.3
11.3
11.5
11.5
11.6
11.6
11.6
11.6
11.6
11.6
11.8

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

195

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 196

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.225
1.234

31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.12
31.34

72736S
72634
72634S
72648
72648S
72661
72661S
72674
72674S
72690
72690S
72703
72703S
72718
72718S
72726
72726S
72737
72737S
72748
72748S
72756
72756S
72763
72763S
72635
72635S
72649
72649S
72662
72662S
72676
72676S
72691
72691S
72705
72705S
72719
72719S
72727
72727S
72738
72738S
72749
72749S
72757
72757S
72764
72764S
72636
72636S
72650
72650S
72663
72663S
72678
72678S
72692
72692S
72707
72707S
72720
72720S
72728
72728S
72739
72739S
72750
72750S
72758
72758S
72765
72765S
72740
72740S
72741
72741S
72742
72742S
11740

3.75
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.25
5.25
5.50
5.50
6.00
6.00
.69

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

95.3
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
133.4
133.4
139.7
139.7
152.4
152.4
17.4

MATERIAL: MW - Music Wire

196

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.901
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.913
.913
.901
.901
.871
.871
.841
.841
.811
.811
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.913
.913
.901
.901
.871
.871
.841
.841
.811
.811
1.055
1.055
1.033
1.033
1.015
1.015
1.001
1.001
.975
.975
.955
.955
.929
.929
.913
.913
.901
.901
.871
.871
.841
.841
.811
.811
.901
.901
.901
.901
.901
.901
1.030

RATE
mm

22.9
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
23.2
23.2
22.9
22.9
22.1
22.1
21.4
21.4
20.6
20.6
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
23.2
23.2
22.9
22.9
22.1
22.1
21.4
21.4
20.6
20.6
26.8
26.8
26.2
26.2
25.8
25.8
25.4
25.4
24.8
24.8
24.3
24.3
23.6
23.6
23.2
23.2
22.9
22.9
22.1
22.1
21.4
21.4
20.6
20.6
22.9
22.9
22.9
22.9
22.9
22.9
26.2

Lbs./In.

N/mm

72
6.7
5.7
11
9.1
15
12
18
15
27
23
41
34
51
44
68
58
78
66
111
94
159
135
223
190
6.0
5.1
9.5
8.1
13
11
18
15
24
20
32
27
45
38
60
51
69
58
98
83
140
119
196
167
5.3
4.5
8.5
7.2
12
9.8
16
14
21
18
29
25
40
34
53
45
61
52
87
74
125
106
175
148
60
51
56
48
51
43
107

13
1.2
1.0
1.9
1.6
2.5
2.2
3.2
2.7
4.7
4.0
7.1
6.0
9.0
7.6
12
10
14
12
19
17
28
24
39
33
1.1
.89
1.7
1.4
2.2
1.9
3.2
2.7
4.2
3.5
5.7
4.8
7.9
6.7
11
8.9
12
10
17
15
24
21
34
29
.93
.79
1.5
1.3
2.0
1.7
2.9
2.4
3.7
3.2
5.1
4.3
7.1
6.0
9.3
7.9
11
9.1
15
13
22
19
31
26
11
8.9
9.8
8.3
8.9
7.6
19

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

1.3
32
3.2
81
2.9
73
3.1
78
2.4
62
2.9
73
2.3
60
2.8
70
2.2
55
2.5
64
2.0
51
2.1
54
1.6
41
2.1
54
1.7
42
1.9
48
1.4
36
1.8
47
1.4
35
1.7
42
1.2
32
1.4
36
1.0
26
1.3
32
.90 23
3.6
92
3.2
81
3.5
88
2.7
70
3.3
83
2.7
67
2.8
71
2.2
55
2.9
73
2.3
58
2.7
68
2.0
51
2.4
61
1.9
48
2.1
54
1.6
41
2.1
53
1.6
40
1.9
48
1.4
36
1.6
41
1.2
29
1.4
36
1.0
26
4.0 102
3.6
92
3.8
98
3.1
78
3.6
93
3.0
75
3.1
79
2.4
61
3.2
81
2.6
65
3.0
76
2.3
57
2.7
68
2.1
54
2.4
61
1.8
46
2.3
59
1.7
44
2.1
54
1.6
40
1.8
46
1.3
33
1.6
41
1.2
29
2.4
61
1.8
45
2.6
65
1.9
48
2.8
71
2.1
53
.26
6.7

Lbs.

91
21
16
33
22
42
29
50
33
68
46
86
55
108
73
128
81
143
91
185
118
226
138
281
171
22
16
33
22
42
29
51
33
68
46
86
55
108
73
128
81
143
91
185
118
226
138
281
171
21
16
33
22
42
29
51
33
68
46
86
55
108
73
128
81
143
91
185
118
226
138
281
171
143
91
143
91
143
91
28

404
95
72
145
99
186
129
222
148
303
205
383
246
481
322
571
362
637
404
824
523
1005
613
1248
761
96
72
146
99
186
129
227
148
301
205
383
246
480
322
571
362
637
404
824
523
1005
613
1248
761
95
72
145
99
187
129
227
148
301
205
383
246
478
322
571
362
637
404
824
523
1005
613
1248
761
637
404
637
404
637
404
126

ENDS: C - Closed

G - Ground
O - Open

Inches

1.90
.81
.81
.95
.95
1.12
1.12
1.25
1.25
1.47
1.47
1.50
1.50
1.89
1.89
1.91
1.91
2.05
2.05
2.30
2.30
2.52
2.52
2.74
2.74
.89
.89
1.04
1.04
1.23
1.23
1.23
1.23
1.64
1.64
1.81
1.81
2.11
2.11
2.13
2.13
2.27
2.27
2.57
2.57
2.81
2.81
3.05
3.05
.98
.98
1.15
1.15
1.35
1.35
1.36
1.36
1.81
1.81
1.99
1.99
2.33
2.33
2.36
2.36
2.49
2.49
2.85
2.85
3.12
3.12
3.39
3.39
2.55
2.55
2.71
2.71
2.94
2.94
.31

mm

48.3
20.5
20.5
24.1
24.1
28.3
28.3
31.6
31.6
37.3
37.3
38.1
38.1
47.9
47.9
48.5
48.5
51.9
51.9
58.4
58.4
64.0
64.0
69.7
69.7
22.7
22.7
26.5
26.5
31.3
31.3
31.3
31.3
41.7
41.7
45.9
45.9
53.6
53.6
54.0
54.0
57.6
57.6
65.2
65.2
71.3
71.3
77.6
77.6
24.8
24.8
29.3
29.3
34.3
34.3
34.5
34.5
46.0
46.0
50.6
50.6
59.2
59.2
59.9
59.9
63.3
63.3
72.5
72.5
79.2
79.2
86.1
86.1
64.8
64.8
68.9
68.9
74.6
74.6
7.8

WIRE DIA.
Inches

0.162
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.085
0.085
0.096
0.096
0.105
0.105
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.162
0.162
0.162
0.162
0.162
0.162
0.102

mm

TOTAL
MATL
COILS

4.1
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
2.2
2.2
2.4
2.4
2.7
2.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
4.1
4.1
4.1
4.1
4.1
4.1
2.6

11.8
9.50
9.50
9.88
9.88
10.6
10.6
11.1
11.1
11.8
11.8
11.1
11.1
12.8
12.8
12.3
12.3
12.6
12.6
13.0
13.0
13.1
13.1
13.3
13.3
10.5
10.5
10.9
10.9
11.8
11.8
11.0
11.0
13.1
13.1
13.4
13.4
14.3
14.3
13.6
13.6
14.0
14.0
14.5
14.5
14.6
14.6
14.8
14.8
11.5
11.5
12.0
12.0
12.9
12.9
12.1
12.1
14.5
14.5
14.8
14.8
15.8
15.8
15.1
15.1
15.4
15.4
16.1
16.1
16.3
16.3
16.4
16.4
15.8
15.8
16.8
16.8
18.1
18.1
3.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 197

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.234
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250

31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.34
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75

II-92
3237
3045
1805
EE-77
12495
12094
11597
10120
10499
10913
3202
3430
2663
S-338
S-1677
S-963
EE-88
12000
2641
PP-44
10578
1759
S-3061
11787
3465
S-458
2724
2768
397
10341
BB-44
10830
2891
10971
12207
3963
2887
10231
S-3158
S-148
829
S-1436
3044
S-475
1933
807
B18-196
B17-153
I-60A
11708
3455
2936
1901
S-3247
12608
11298
10995
11848
10644
11917
72
12097
S-352
B2-58
272
3085
10710
58
60
858
S-1625
3344
S-274
11644
810
S-1166
11102
859
34

.78
.84
.88
.88
.94
1.03
1.19
1.31
1.38
1.41
1.44
1.50
1.63
1.63
1.75
1.75
1.81
2.00
2.25
2.34
2.69
2.75
2.78
3.13
3.16
3.50
3.63
4.00
4.19
5.44
6.00
.50
.50
.63
.75
.75
.75
.94
1.06
1.13
1.25
1.25
1.31
1.34
1.38
1.38
1.63
1.72
1.75
1.75
1.75
1.75
1.78
2.00
2.03
2.25
2.28
2.31
2.34
2.38
2.50
2.50
2.56
2.63
2.63
2.88
2.94
3.00
3.00
3.00
3.13
3.25
3.25
3.38
3.41
3.63
3.75
4.00
4.00
4.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

19.8
21.4
22.2
22.2
23.8
26.2
30.2
33.3
34.9
35.7
36.5
38.1
41.3
41.3
44.5
44.5
46.0
50.8
57.2
59.5
68.2
69.9
70.6
79.4
80.2
88.9
92.1
101.6
106.4
138.1
152.4
12.7
12.7
15.9
19.1
19.1
19.1
23.8
27.0
28.6
31.8
31.8
33.3
34.1
34.9
34.9
41.3
43.6
44.5
44.5
44.5
44.5
45.2
50.8
51.6
57.2
57.9
58.7
59.5
60.3
63.5
63.5
65.1
66.7
66.7
73.0
74.6
76.2
76.2
76.2
79.4
82.6
82.6
85.7
86.5
92.1
95.3
101.6
101.6
101.6

I.D.
Inches

1.074
1.082
1.110
1.080
.954
1.040
.984
.994
1.100
1.040
1.122
1.080
1.050
.910
1.110
1.026
1.066
.694
.848
1.024
1.134
1.024
1.064
1.062
.852
.794
1.110
.994
.964
.880
.820
1.176
1.070
1.126
1.060
1.050
1.046
1.130
.800
1.068
1.126
1.010
1.040
1.106
.896
.896
.866
.982
1.164
1.126
.892
.890
1.116
1.040
1.130
1.116
.910
.954
1.102
.866
1.068
.896
1.068
1.138
1.116
.980
1.122
.980
.954
.866
.974
1.106
1.036
1.100
1.124
.896
1.010
1.040
.980
.954

RATE
mm

27.3
27.5
28.2
27.4
24.2
26.4
25.0
25.2
27.9
26.4
28.5
27.4
26.7
23.1
28.2
26.1
27.1
17.6
21.5
26.0
28.8
26.0
27.0
27.0
21.6
20.2
28.2
25.2
24.5
22.4
20.8
29.9
27.2
28.6
26.9
26.7
26.6
28.7
20.3
27.1
28.6
25.7
26.4
28.1
22.8
22.8
22.0
24.9
29.6
28.6
22.7
22.6
28.3
26.4
28.7
28.3
23.1
24.2
28.0
22.0
27.1
22.8
27.1
28.9
28.3
24.9
28.5
24.9
24.2
22.0
24.7
28.1
26.3
27.9
28.5
22.8
25.7
26.4
24.9
24.2

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

38
6.7
31
5.4
7.0
1.2
33
5.7
281
49
58
10
103
18
54
9.4
3.7
.64
58
10
1.6
.29
8.7
1.5
28
4.8
268
47
2.3
.40
26
4.5
20
3.6
2132 373
272
48
24
4.3
.40
.07
20
3.5
11
2.0
10
1.8
211
37
359
63
.96
.17
21
3.7
36
6.3
94
16
174
30
1.3
.23
54
9.4
5.3
.93
67
12
47
8.3
118
21
7.4
1.3
1955 342
20
3.5
5.5
.96
89
16
40
7.1
7.9
1.4
331
58
286
50
412
72
74
13
.13
.02
1.8
.32
400
70
308
54
5.8
1.0
23
4.1
1.2
.21
4.1
.72
224
39
86
15
5.9
1.0
275
48
11
2.0
169
30
11
2.0
2.2
.39
4.4
.77
49
8.6
3.3
.58
31
5.5
71
12
194
34
49
8.7
3.9
.69
18
3.2
4.6
.80
2.3
.40
111
19
21
3.7
10
1.8
34
5.9
49
8.6

.38
.40
.63
.55
.24
.42
.49
.47
.91
.42
1.1
1.1
.76
.38
1.3
1.1
.76
.18
.59
1.5
1.9
1.5
1.5
1.7
.74
.63
2.8
2.1
1.7
1.4
1.1
.35
.23
.35
.31
.35
.24
.73
.12
.69
.94
.50
.70
.98
.35
.31
.38
.72
.80
1.1
.34
.42
1.4
1.3
1.4
1.8
.52
.92
1.8
.57
1.7
.77
1.7
2.2
2.2
1.2
2.3
1.2
1.1
.81
1.3
2.5
1.8
2.4
2.9
1.2
1.9
2.6
1.8
1.6

mm

9.5
10
16
14
6.1
11
12
12
23
11
27
27
19
9.6
33
27
19
4.6
15
38
47
39
39
42
19
16
70
54
43
36
29
8.9
5.8
9.0
7.9
8.9
6.1
18
3.1
18
24
13
18
25
8.9
8.0
9.7
18
20
29
8.5
11
37
32
36
47
13
23
46
15
42
20
42
56
56
31
59
32
28
21
33
63
46
61
74
30
48
66
46
41

ENDS: C - Closed

G - Ground
O - Open

Lbs.

14
64
12
55
4.5
20
18
80
68
302
24
109
50
223
25
113
3.3
15
24
109
1.8
7.8
9.2
41
21
93
102
452
3.0
13
28
124
16
69
390 1734
161
717
36
162
.75
3.3
31
138
17
77
17
74
156
696
226 1006
2.6
12
44
198
61
272
131
585
197
878
.46
2.1
12
55
1.9
8.4
21
94
17
74
28
125
5.4
24
239 1061
14
62
5.2
23
44
195
28
126
7.7
34
115
513
89
398
157
699
53
236
.10
.47
2.0
9.1
134
597
130
579
8.4
38
29
131
1.8
7.8
7.5
34
116
514
79
351
11
47
157
699
19
83
130
578
19
83
4.9
22
9.7
43
60
268
7.7
34
39
173
79
351
157
699
64
286
9.7
43
32
144
11
49
6.5
29
130
578
40
178
27
120
60
268
79
351

Inches

.24
.23
.24
.23
.49
.34
.56
.84
.47
.34
.37
.44
.41
.81
.43
.62
.34
1.62
1.64
.84
.83
.84
.50
.65
1.91
2.42
.87
1.59
1.62
2.61
3.31
.15
.27
.27
.29
.40
.29
.21
.84
.43
.31
.64
.47
.36
.89
1.06
1.15
.80
.95
.62
.90
1.08
.34
.74
.60
.42
1.06
1.18
.44
1.54
.64
1.55
.64
.35
.40
1.22
.47
1.76
1.52
2.02
1.33
.59
.96
.62
.50
2.18
1.26
1.39
1.65
1.85

mm

Inches

6.1
5.8
6.1
5.9
12.4
8.6
14.3
21.3
11.9
8.6
9.5
11.2
10.5
20.6
11.0
15.8
8.5
41.1
41.7
21.3
21.0
21.3
12.6
16.4
48.5
61.5
22.0
40.4
41.1
66.3
84.1
3.8
6.9
6.9
7.2
10.2
7.4
5.3
21.4
11.0
7.9
16.3
12.0
9.1
22.5
27.0
29.3
20.4
24.0
15.7
22.7
27.4
8.5
18.7
15.2
10.6
27.0
30.1
11.3
39.0
16.2
39.3
16.2
8.9
10.2
30.9
12.0
44.6
38.5
51.2
33.9
15.1
24.5
15.9
12.8
55.4
32.0
35.3
42.0
47.0

0.080
0.076
0.062
0.077
0.140
0.097
0.125
0.120
0.067
0.097
0.056
0.077
0.092
0.162
0.062
0.104
0.084
0.270
0.193
0.105
0.050
0.105
0.085
0.086
0.191
0.220
0.062
0.120
0.135
0.177
0.207
0.037
0.090
0.062
0.095
0.100
0.102
0.060
0.225
0.091
0.062
0.120
0.105
0.072
0.177
0.177
0.192
0.134
0.043
0.062
0.179
0.180
0.067
0.105
0.060
0.067
0.170
0.148
0.074
0.192
0.091
0.177
0.091
0.056
0.067
0.135
0.064
0.135
0.148
0.192
0.138
0.072
0.107
0.075
0.063
0.177
0.120
0.105
0.135
0.148

mm

TOTAL
MATL
COILS

2.0
1.9
1.6
2.0
3.6
2.5
3.2
3.0
1.7
2.5
1.4
2.0
2.3
4.1
1.6
2.6
2.1
6.9
4.9
2.7
1.3
2.7
2.2
2.2
4.9
5.6
1.6
3.0
3.4
4.5
5.3
0.9
2.3
1.6
2.4
2.5
2.6
1.5
5.7
2.3
1.6
3.0
2.7
1.8
4.5
4.5
4.9
3.4
1.1
1.6
4.5
4.6
1.7
2.7
1.5
1.7
4.3
3.8
1.9
4.9
2.3
4.5
2.3
1.4
1.7
3.4
1.6
3.4
3.8
4.9
3.5
1.8
2.7
1.9
1.6
4.5
3.0
2.7
3.4
3.8

3.00
3.00
4.00
3.00
3.50
3.50
4.50
6.00
7.00
3.50
6.67
5.75
4.50
5.00
7.00
6.00
4.00
6.00
8.50
7.00
15.5
8.00
6.00
6.50
10.0
11.0
14.0
12.3
12.0
14.8
16.0
3.00
3.00
4.33
3.00
4.00
3.00
3.50
3.75
4.75
4.00
4.33
4.50
5.00
5.00
6.00
6.00
6.00
21.0
9.00
5.00
6.00
5.00
7.00
10.0
6.25
6.25
8.00
6.00
8.00
7.00
8.75
7.00
5.25
6.00
9.00
6.33
13.0
9.25
10.5
9.67
7.25
9.00
7.33
8.00
12.3
10.5
13.3
12.3
12.5

SPR
SPR
SPR
MW
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
MW
SPR
SPR
SPR
SST
SPR
SPR
SST
HD
SPR
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SST
HD
SST
SPR
SST
SPR
HD
SST
SST
HD
SPR
SPR
SPR
SPR
SST
MW
SPR
HD
SST
SPR
SST
HD
SST
SST
MW
HD
SPR
SPR
HD
HD
HD
SST
SPR
SST
SPR
HD
SST
SPR
HD
HD

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG

N
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
N
N
N
Z
Z
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
N
Z
Z
N
N
BO
Z
Z
Z
Z
N
Z
Z
Z
N
Z
N
Z
N
N
Z
Z
Z
Z
Z
Z
Z
N
Z
N
Z
Z
N
Z
Z
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

197

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 198

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.250
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.266
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.281
1.296

31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
31.75
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.16
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.54
32.92

33
4264
3179
11681
S-954
1765
4100
3145
12772
3448
248
3043
S-959
3210
2725
12648
12658
4181
849
2996
822
3460
868
860
839
802
834
S-3047
4000
4045
S-3199
2957
10292
11212
11210
2600
11796
B18-186
11857
S-348
10169
11503
11700
11788
S-335
10515
12512
S-1128
11903
2712
11562
3283
4164
3377
B8-59
3620
S-1683
S-3031
S-291
A14-50
10459
11668
11187
3041
11944
1896
816
S-217
10528
817
S-3055
11645
11665
S-1604
S-431
1843
S-3224
2879
S-1017
4360

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

4.00
4.50
4.59
4.63
4.75
4.75
5.00
5.06
5.75
6.00
6.25
6.38
6.88
7.00
7.63
8.00
8.00
8.00
8.00
8.38
10.0
11.8
12.0
12.0
12.0
12.0
12.0
16.0
19.0
24.8
.75
1.41
1.44
1.53
1.63
1.75
1.97
2.03
2.47
2.75
2.75
2.75
3.09
3.31
4.00
4.13
4.19
4.25
5.09
6.00
7.25
8.00
8.25
9.38
.59
.69
.95
1.00
1.13
1.28
1.50
1.50
1.56
1.75
1.75
1.75
2.13
2.63
3.06
3.38
3.50
4.00
4.00
4.13
4.31
5.00
5.31
6.19
11.0
.50

mm

101.6
114.3
116.7
117.5
120.7
120.7
127.0
128.6
146.1
152.4
158.8
161.9
174.6
177.8
193.7
203.2
203.2
203.2
203.2
212.7
254.0
298.5
304.8
304.8
304.8
304.8
304.8
406.4
482.6
628.7
19.1
35.7
36.5
38.9
41.3
44.5
50.0
51.6
62.7
69.9
69.9
69.9
78.6
84.1
101.6
104.8
106.3
108.0
129.4
152.4
184.2
203.2
209.6
238.1
15.1
17.4
24.2
25.4
28.6
32.5
38.1
38.1
39.7
44.5
44.5
44.5
54.0
66.7
77.8
85.7
88.9
101.6
101.6
104.8
109.5
127.0
134.9
157.2
279.4
12.7

MATERIAL: MW - Music Wire

198

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.800
1.010
1.024
.980
1.124
1.068
.814
.896
.950
1.136
.926
.990
.956
.926
.954
1.066
1.062
1.010
.926
1.022
.954
1.066
1.010
.980
.866
.836
.800
1.070
1.000
.750
1.124
1.056
1.094
.926
.970
1.056
1.164
.766
1.128
1.016
.912
.850
1.182
1.054
.882
1.056
.922
1.142
1.144
.954
1.028
1.026
.906
1.052
1.125
1.157
.997
1.099
1.157
1.119
1.111
1.001
1.071
1.157
1.115
.987
.957
1.199
.953
.957
1.137
1.153
.965
1.155
1.121
1.171
1.101
.969
.961
1.194

RATE
mm

20.3
25.7
26.0
24.9
28.5
27.1
20.7
22.8
24.1
28.9
23.5
25.1
24.3
23.5
24.2
27.1
27.0
25.7
23.5
26.0
24.2
27.1
25.7
24.9
22.0
21.2
20.3
27.2
25.4
19.1
28.5
26.8
27.8
23.5
24.6
26.8
29.6
19.5
28.7
25.8
23.2
21.6
30.0
26.8
22.4
26.8
23.4
29.0
29.1
24.2
26.1
26.1
23.0
26.7
28.6
29.4
25.3
27.9
29.4
28.4
28.2
25.4
27.2
29.4
28.3
25.1
24.3
30.5
24.2
24.3
28.9
29.3
24.5
29.3
28.5
29.7
28.0
24.6
24.4
30.3

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

53
4.0
1.8
4.5
.74
.13
5.8
1.0
328
57
143
25
36
6.2
1.1
.20
51
9.0
19
3.2
22
3.8
57
10
26
4.6
12
2.1
4.6
.81
9.8
1.7
32
5.6
7.3
1.3
18
3.2
2.8
.48
6.7
1.2
11
1.8
55
9.6
67
12
93
16
1.5
.26
5.9
1.0
97
17
19
3.3
45
7.8
19
3.4
304
53
165
29
41
7.1
1.1
.19
1357 238
6.3
1.1
37
6.5
156
27
284
50
.81
.14
17
2.9
224
39
9.7
1.7
120
21
1.1
.19
.63
.11
37
6.4
12
2.0
9.4
1.7
51
9.0
5.5
.96
11
1.9
3.9
.68
229
40
20
3.6
5.1
.89
14
2.5
15
2.6
124
22
36
6.3
2.9
.51
13
2.3
132
23
128
22
.53
.09
107
19
76
13
2.9
.51
2.2
.39
58
10
1.1
.19
3.0
.52
.89
.16
4.1
.72
33
5.8
24
4.3
5.0
.88

.79
1.9
2.6
2.4
3.6
3.5
.69
.91
2.15
4.9
2.0
2.9
3.2
1.8
3.0
1.7
6.2
4.5
3.1
5.2
4.3
7.5
6.6
5.7
2.9
2.9
2.6
12
8.4
3.3
.49
.68
.91
.38
.47
1.0
1.6
.20
1.5
1.2
.82
.46
2.8
1.9
.60
2.7
1.4
3.4
3.9
2.4
3.7
4.6
2.5
5.8
.24
.38
.27
.59
.88
.94
1.1
.53
.83
1.3
1.2
.81
.76
2.4
.95
1.3
2.8
3.4
1.6
3.3
3.4
4.4
4.1
2.6
3.4
.35

302
23
10
26

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

20
49
65
60
90
88
18
23
56
124
50
74
81
45
76
44
158
113
80
132
110
190
167
146
73
73
65
313
214
84
12
17
23
9.5
12
26
42
5.0
38
30
21
12
72
48
15
69
35
87
100
62
93
117
64
147
6.1
9.6
6.8
15
22
24
27
13
21
33
30
20
19
61
24
33
72
86
40
84
85
112
103
67
87
8.8

Lbs.

239
44
26
60
2.6
20
226
130
77.4
5.5
100
54
70
100
79
21
29
44
100
38
79
21
44
60
157
195
239
18
50
322
9.2
30
17
114
78
42
1.7
268
9.5
45
128
131
2.3
31
134
26
165
3.6
2.5
89
42
43
129
32
2.6
1.5
62
12
4.5
13
16
66
30
3.9
15
106
98
1.3
102
98
8.2
7.5
91
3.7
10
3.9
17
88
84
1.7

ENDS: C - Closed

G - Ground
O - Open

1061
195
115
268
12
89
1007
578
344
24
447
240
310
447
351
92
128
195
447
168
351
92
195
268
699
868
1061
80
220
1431
41
134
77
508
347
188
7.8
1192
42
199
571
584
10
138
595
117
736
16
11
395
188
193
573
142
12
6.6
274
53
20
59
70
292
133
17
69
471
437
5.6
453
437
37
33
406
16
45
17
74
391
374
7.8

Inches

3.00
1.44
2.02
2.09
1.20
1.18
2.40
1.77
2.56
.63
2.75
2.31
3.23
2.51
3.18
.78
1.76
2.88
4.21
2.82
4.48
2.48
4.08
4.83
6.14
7.56
8.72
3.51
5.50
15.0
.21
.47
.39
.85
.89
.50
.33
1.38
.35
.94
1.59
2.29
.25
.95
1.56
1.42
1.89
.81
1.16
3.16
2.32
2.88
4.50
2.68
.35
.31
.50
.41
.25
.34
.43
.70
.53
.43
.42
.81
1.22
.23
1.48
1.84
.68
.58
2.05
.82
.95
.61
1.26
3.12
4.12
.15

mm

76.2
36.6
51.3
53.1
30.4
30.0
60.9
45.0
65.1
15.9
70.0
58.6
82.1
63.8
80.8
19.9
44.8
73.2
107.0
71.7
113.7
63.1
103.6
122.6
156.1
191.9
221.5
89.2
139.7
381.0
5.4
12.0
9.8
21.6
22.6
12.7
8.4
34.9
8.8
23.8
40.5
58.1
6.4
24.2
39.6
36.0
48.1
20.5
29.4
80.3
58.9
73.2
114.3
67.9
8.9
7.9
12.6
10.4
6.3
8.7
10.8
17.8
13.3
11.0
10.5
20.5
30.9
5.7
37.5
46.6
17.4
14.6
52.2
20.8
24.1
15.4
32.0
79.2
104.6
3.9

WIRE DIA.
Inches

0.225
0.120
0.113
0.135
0.063
0.091
0.218
0.177
0.148
0.057
0.162
0.130
0.147
0.162
0.148
0.092
0.094
0.120
0.162
0.114
0.148
0.092
0.120
0.135
0.192
0.207
0.225
0.090
0.125
0.250
0.071
0.105
0.086
0.170
0.148
0.105
0.051
0.250
0.069
0.125
0.177
0.208
0.042
0.106
0.192
0.105
0.172
0.062
0.061
0.156
0.119
0.120
0.180
0.107
0.078
0.062
0.142
0.091
0.062
0.081
0.085
0.140
0.105
0.062
0.083
0.147
0.162
0.041
0.164
0.162
0.072
0.064
0.158
0.063
0.080
0.055
0.090
0.156
0.160
0.051

mm

TOTAL
MATL
COILS

5.7
3.0
2.9
3.4
1.6
2.3
5.5
4.5
3.8
1.4
4.1
3.3
3.7
4.1
3.8
2.3
2.4
3.0
4.1
2.9
3.8
2.3
3.0
3.4
4.9
5.3
5.7
2.3
3.2
6.4
1.8
2.7
2.2
4.3
3.8
2.7
1.3
6.4
1.8
3.2
4.5
5.3
1.1
2.7
4.9
2.7
4.4
1.6
1.5
4.0
3.0
3.0
4.6
2.7
2.0
1.6
3.6
2.3
1.6
2.1
2.2
3.6
2.7
1.6
2.1
3.7
4.1
1.0
4.2
4.1
1.8
1.6
4.0
1.6
2.0
1.4
2.3
4.0
4.1
1.3

13.3
11.0
18.0
15.5
18.0
13.0
11.0
10.0
16.3
10.0
17.0
17.8
22.0
15.5
21.5
7.50
17.8
23.0
26.0
24.8
30.3
26.0
33.0
34.8
32.0
36.5
38.8
38.0
44.0
60.0
3.00
4.50
4.50
5.00
5.00
4.75
6.50
5.50
5.00
7.50
9.00
10.0
5.00
9.00
8.00
13.5
10.0
12.0
18.0
20.0
18.5
23.0
25.0
24.0
4.50
5.00
3.50
4.50
4.00
4.25
5.00
5.00
5.00
6.00
5.00
5.50
7.50
5.50
9.00
11.3
8.50
8.00
13.0
12.0
11.8
10.0
14.0
20.0
25.8
3.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

HD
SPR
SPR
SPR
SST
HD
SPR
SPR
HD
SPR
HD
SPR
SST
SPR
SPR
SPR
MW
SPR
HD
SPR
HD
HD
HD
HD
HD
HD
HD
SST
SPR
SPR
SST
SPR
SPR
SPR
SPR
MW
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
MW
SST
SST
SPR
SPR
HD
SPR
SPR
SST
SPR
SST
SST
SST
SST
SPR
SPR
HD
SPR
SPR
MW
HD
SST
SPR
HD
SST
SPR
SPR
SST
SST
HD
SST
SPR
SST
SPR

E
N
D
S

CG
C
CG
CG
C
CG
CG
CG
C
C
CG
CG
CG
CG
CG
C
C
C
CG
CG
CG
C
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG

F
N
S
H

Z
Z
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
GI
Z
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
Z
N
N
N
N
Z
Z
Z
Z
N
Z
N
N
N
Z
GI
Z
Z
Z
N
Z
N
N
N
N
Z
GI
Z
Z
Z
Z
Z
N
N
Z
N
Z
Z
N
N
Z
N
Z
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 199

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.296
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.312
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328
1.328

32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
32.92
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.32
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73
33.73

11527
3655
10402
3409
3955
2550
12015
10902
11771
3151
S-977
11638
1845
3359
3744
S-3017
11265
2828
11966
S-160
12128
11734
S-1657
4133
4025
S-1499
10053
3325
S-198
S-1275
S-3223
10670
271
12127
10505
3021
11986
S-1422
S-3170
3169
1877
2988
10109
3397
S-1628
12056
10044
4361
11434
2749
12144
12012
11488
3048
12108
S-456
10399
336
10410
1921
S-1416
4012
11423
11508
S-3068
S-233
11543
10364
12326
12438
11605
S-953
S-261
S-377
11625
3084
11526
10840
S-1658
3082

O.D.

FREE LENGTH
Inches

1.25
1.50
1.63
1.63
1.69
1.75
1.75
2.38
2.50
2.56
2.66
2.72
2.75
2.75
2.94
3.00
3.00
3.75
4.00
4.50
4.94
4.94
6.00
6.75
22.0
.94
1.13
1.19
1.22
1.38
1.44
1.81
1.88
1.91
1.94
1.94
2.09
2.38
2.50
2.63
2.88
2.94
3.25
3.50
3.53
3.56
3.63
4.00
4.00
4.69
4.75
4.94
5.09
5.25
5.41
5.63
6.00
6.00
6.00
7.75
8.75
23.0
1.25
1.25
1.38
1.59
2.00
2.25
2.38
2.59
2.69
2.75
3.13
4.38
5.00
5.38
5.50
5.69
6.00
8.00

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

31.8
38.1
41.3
41.3
42.8
44.5
44.5
60.3
63.5
65.1
67.5
69.0
69.9
69.9
74.6
76.2
76.2
95.3
101.6
114.3
125.4
125.4
152.4
171.5
558.8
23.8
28.6
30.2
31.0
34.9
36.5
46.0
47.6
48.4
49.2
49.2
53.2
60.3
63.5
66.7
73.0
74.6
82.6
88.9
89.7
90.5
92.1
101.6
101.6
119.0
120.7
125.4
129.4
133.4
137.3
142.9
152.4
152.4
152.4
196.9
222.3
584.2
31.8
31.8
34.9
40.5
50.8
57.2
60.3
65.9
68.2
69.9
79.4
111.1
127.0
136.5
139.7
144.4
152.4
203.2

I.D.
Inches

1.086
1.114
1.086
1.080
1.172
1.100
1.086
1.116
1.046
1.184
1.026
1.086
1.100
1.046
1.096
1.172
.972
.796
.984
1.112
1.188
1.008
1.156
.992
1.046
1.188
.812
1.072
1.102
1.112
1.152
1.102
.988
1.050
1.126
1.102
.897
1.152
1.136
.986
1.116
1.062
1.192
1.172
1.170
.952
.862
1.102
.938
.788
1.010
1.204
1.205
1.042
1.094
1.092
1.086
.958
.874
.936
.936
1.028
1.058
1.056
1.208
1.004
1.065
1.204
1.178
.956
1.088
1.202
1.226
1.058
1.226
1.058
1.116
1.114
1.088
1.016

RATE
mm

27.6
28.3
27.6
27.4
29.8
27.9
27.6
28.3
26.6
30.1
26.1
27.6
27.9
26.6
27.8
29.8
24.7
20.2
25.0
28.2
30.2
25.6
29.4
25.2
26.6
30.2
20.6
27.2
28.0
28.2
29.3
28.0
25.1
26.7
28.6
28.0
22.8
29.3
28.9
25.0
28.3
27.0
30.3
29.8
29.7
24.2
21.9
28.0
23.8
20.0
25.7
30.6
30.6
26.5
27.8
27.7
27.6
24.3
22.2
23.8
23.8
26.1
26.9
26.8
30.7
25.5
27.1
30.6
29.9
24.3
27.6
30.5
31.1
26.9
31.1
26.9
28.3
28.3
27.6
25.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

52
9.1
20
3.6
34
6.0
39
6.8
2.8
.49
22
3.9
34
6.0
7.9
1.4
55
9.6
1.2
.22
44
7.7
13
2.3
22
3.9
40
7.0
17
2.9
1.4
.25
97
17
497
87
52
9.1
5.4
.95
.80
.14
35
6.2
1.7
.29
39
6.9
3.4
.59
2.7
.47
3125 547
88
15
44
7.7
20
3.5
14
2.4
29
5.1
145
25
86
15
17
3.0
25
4.4
396
69
7.3
1.3
5.8
1.0
103
18
21
3.7
35
6.1
2.7
.47
4.5
.79
1.8
.31
116
20
319
56
11
2.0
154
27
600 105
33
5.8
.77
.13
.74
.13
24
4.3
12
2.1
7.8
1.4
10
1.8
57
9.9
188
33
70
12
53
9.3
6.0
1.0
62
11
73
13
4.0
.70
189
33
84
15
2.8
.49
3.9
.67
193
34
34
5.9
1.9
.34
.90
.16
24
4.3
.58
.10
23
4.1
11
1.9
6.2
1.1
14.0
2.4
27
4.8

.57
.94
.86
.83
1.3
1.2
.86
1.7
.88
2.1
1.2
1.7
1.5
1.2
1.5
2.4
1.0
.63
1.7
3.4
4.3
2.0
5.2
2.0
13
.60
.10
.48
.61
.83
.91
.92
.66
.62
1.2
1.2
.48
1.7
1.7
.95
1.6
1.4
2.2
2.0
2.7
1.1
.72
2.6
.90
.57
2.3
4.3
4.5
2.4
2.7
3.8
3.5
2.2
1.2
2.0
2.3
10.0
.44
.30
1.1
.45
.63
1.9
1.8
.70
1.2
2.3
2.7
2.1
4.5
2.4
2.8
3.7
2.7
3.1

mm

15
24
22
21
32
31
22
42
22
54
30
42
39
31
39
60
25
16
42
85
110
51
131
52
330
15
2.5
12
16
21
23
23
17
16
31
30
12
44
43
24
40
35
57
51
69
27
18
65
23
14
57
110
114
60
68
96
89
56
30
51
58
254
11
7.6
27
11
16
48
45
18
31
59
70
53
114
62
71
93
73.6
79

ENDS: C - Closed

G - Ground
O - Open

Lbs.

30
19
30
32
3.5
27
30
13
48
2.6
53
22
34
48
26
3.3
97
312
87
18
3.5
70
8.6
81
44
1.6
309
42
27
17
13
27
96
53
20
29
188
13
10
98
33
47
6.1
9.1
4.8
125
229
29
139
341
74
3.3
3.3
58
33
30
35
124
220
141
122
60.0
27
22
4.3
84
53
5.3
6.8
136
41
4.5
2.5
51
2.6
57
30
23
38
85

131
86
131
143
16
119
131
59
213
12
234
96
150
213
114
15
432
1389
387
80
15
314
38
358
194
7.2
1375
187
120
74
57
120
427
235
91
130
837
57
44
435
148
210
27
41
22
555
1018
130
620
1518
331
15
15
256
145
132
156
553
978
629
542
267
122
96
19
375
235
24
30
603
184
20
11
228
12
253
132
101
170
378

Inches

mm

Inches

.53 13.3
.43 11.0
.53 13.3
.54 13.7
.43 11.0
.54 13.7
.53 13.3
.72 18.3
.75 19.1
.45 11.4
1.08 27.4
1.05 26.7
.54 13.7
1.06 27.0
.70 17.8
.62 15.7
1.46 37.0
2.97 75.4
2.03 51.5
1.15 29.2
.59 15.1
1.94 49.4
.84 21.3
2.28 57.9
7.31 185.7
.34
8.7
.88 22.2
.48 12.2
.42 10.7
.55 14.0
.32
8.1
.53 13.3
1.05 26.7
.66 16.6
.51 13.0
.63 16.0
1.45 36.9
.54 13.7
.79 20.1
1.39 35.2
.64 16.2
1.08 27.4
.39
9.9
.49 12.4
.82 20.7
1.98 50.3
2.48 62.9
1.13 28.7
1.87 47.5
3.08 78.2
2.49 63.3
.59 15.1
.59 14.9
1.89 48.0
1.25 31.8
1.71 43.3
1.75 44.5
3.36 85.4
3.39 86.2
3.76 95.5
4.28 108.6
7.8 198.1
.81 20.6
.95 24.2
.30
7.6
.79 20.1
.79 20.0
.36
9.1
.60 15.2
1.49 37.8
.96 24.4
.44 11.2
.38
9.7
1.62 41.1
.51 13.0
1.89 48.0
1.31 33.2
2.01 51.0
1.50 38.1
3.32 84.2

0.105
0.091
0.105
0.108
0.062
0.098
0.105
0.090
0.125
0.056
0.135
0.105
0.098
0.125
0.100
0.062
0.162
0.250
0.156
0.092
0.054
0.144
0.070
0.152
0.125
0.062
0.250
0.120
0.105
0.100
0.080
0.105
0.162
0.131
0.093
0.105
0.208
0.080
0.088
0.163
0.098
0.125
0.060
0.070
0.071
0.180
0.225
0.105
0.187
0.262
0.151
0.054
0.054
0.135
0.109
0.110
0.113
0.177
0.219
0.188
0.188
0.142
0.135
0.136
0.060
0.162
0.132
0.062
0.075
0.186
0.120
0.063
0.051
0.135
0.051
0.135
0.106
0.107
0.120
0.156

mm

TOTAL
MATL
COILS

2.7
2.3
2.7
2.7
1.6
2.5
2.7
2.3
3.2
1.4
3.4
2.7
2.5
3.2
2.5
1.6
4.1
6.4
4.0
2.3
1.4
3.7
1.8
3.9
3.2
1.6
6.4
3.0
2.7
2.5
2.0
2.7
4.1
3.3
2.4
2.7
5.3
2.0
2.2
4.1
2.5
3.2
1.5
1.8
1.8
4.6
5.7
2.7
4.7
6.7
3.8
1.4
1.4
3.4
2.8
2.8
2.9
4.5
5.6
4.8
4.8
3.6
3.4
3.5
1.5
4.1
3.3
1.6
1.9
4.7
3.0
1.6
1.3
3.4
1.3
3.4
2.7
2.7
3.0
4.0

4.00
4.75
5.00
5.00
6.00
5.50
5.00
8.00
6.00
8.00
8.00
10.0
5.50
7.50
7.00
9.00
9.00
12.0
13.0
11.5
10.0
13.5
12.0
15.0
58.5
5.50
3.50
4.00
4.00
5.50
4.00
5.00
6.50
5.00
5.50
6.00
7.00
5.75
9.00
8.50
5.50
8.50
5.50
6.00
11.5
11.0
11.0
10.8
10.0
11.8
16.5
10.0
10.0
14.0
11.5
15.5
15.5
19.0
15.5
20.0
22.8
54.9
6.00
6.00
4.00
5.00
5.00
5.75
8.00
8.00
7.00
7.00
6.50
12.0
10.0
14.0
11.3
18.8
12.5
21.3

SPR
SPR
SPR
SPR
SPR
MW
SPR
SST
SPR
SPR
SST
SPR
MW
SPR
SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SST
SST
SST
SST
HD
SPR
SPR
SPR
SPR
SST
SST
SPR
MW
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
HD
SPR
HD
SST
SST
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SST
SPR

E
N
D
S

CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
N
N
Z
Z
N
Z
Z
N
GI
N
N
Z
Z
N
N
N
N
Z
Z
Z
Z
Z
N
N
Z
Z
Z
Z
Z
N
N
Z
Z
Z
Z
Z
Z
Z
Z
GI
N
Z
Z
Z
Z
N
N
N
Z
N
N
Z
Z
Z
N
Z
N
N
N
Z
Z
GI
Z
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

199

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 200

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.328
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.343
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.359
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375

33.73
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.11
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.52
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93

4306
2634
2774
11807
10639
2777
3061
11643
1717
11567
10425
11387
11929
4370
3278
12112
11721
3267
10658
S-1605
11904
S-155
S-353
10090
4137
10445
396
12439
1623
4014
10424
LL-79
EE-84
2664
11677
S-1261
11824
JJ-52
11551
11867
10511
B18-180
3433
11789
3747
S-3235
12514
11922
2564
S-960
3373
11409
11520
B17-171
10476
3102
S-3112
S-958
11877
S-43
11780
2859
3443
12044
S-3251
12060
S-3249
3426
11401
11997
2979
11808
BB-59
3393
GG-76
12539
11883
917
3346
12140

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

8.25
.88
1.50
1.50
1.72
1.75
1.88
1.88
2.09
2.34
2.38
2.38
2.41
2.56
2.63
2.69
3.06
3.13
3.31
4.03
4.13
4.50
4.50
5.50
5.75
5.75
7.09
10.0
10.4
15.8
.50
.50
1.19
1.19
1.22
1.25
1.28
1.28
1.31
1.47
1.50
1.50
1.88
1.94
2.13
2.19
2.25
2.28
2.63
2.69
2.75
2.75
2.75
3.00
3.13
3.25
3.25
3.25
3.34
3.50
3.50
3.50
3.69
4.50
4.75
4.88
5.00
5.75
6.13
10.4
11.1
.63
1.00
1.19
1.19
1.20
1.22
1.25
1.25
1.59

mm

209.6
22.2
38.1
38.1
43.6
44.5
47.6
47.6
53.2
59.5
60.3
60.3
61.1
65.1
66.7
68.2
77.8
79.4
84.1
102.4
104.8
114.3
114.3
139.7
146.1
146.1
180.2
254.0
263.5
400.1
12.7
12.7
30.2
30.2
31.0
31.8
32.5
32.5
33.3
37.3
38.1
38.1
47.6
49.2
54.0
55.6
57.2
57.9
66.7
68.2
69.9
69.9
69.9
76.2
79.4
82.6
82.6
82.6
84.9
88.9
88.9
88.9
93.6
114.3
120.7
123.8
127.0
146.1
155.6
265.1
282.6
15.9
25.4
30.2
30.2
30.5
31.0
31.8
31.8
40.5

MATERIAL: MW - Music Wire

200

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

.974
1.183
1.191
1.181
.843
1.193
1.155
1.151
1.233
1.205
1.217
1.163
1.111
.893
1.029
1.103
1.101
.969
1.219
1.139
1.227
1.227
1.199
.893
1.073
1.073
1.103
1.017
.989
1.049
1.177
1.159
1.099
.977
1.199
1.253
1.179
1.119
1.135
1.221
1.247
.859
1.159
1.025
1.159
1.065
1.069
1.267
1.199
1.177
1.215
1.119
1.045
1.151
1.063
1.207
1.199
1.177
1.175
1.161
1.047
.909
.945
1.035
1.239
1.175
.967
1.231
1.119
1.003
.835
1.257
1.275
1.125
.995
1.081
1.271
1.165
1.151
1.115

RATE
mm

24.7
30.0
30.3
30.0
21.4
30.3
29.3
29.2
31.3
30.6
30.9
29.5
28.2
22.7
26.1
28.0
28.0
24.6
31.0
28.9
31.2
31.2
30.5
22.7
27.3
27.3
28.0
25.8
25.1
26.6
29.9
29.4
27.9
24.8
30.5
31.8
29.9
28.4
28.8
31.0
31.7
21.82
29.4
26.0
29.4
27.1
27.2
32.2
30.5
29.9
30.9
28.4
26.5
29.2
27.0
30.7
30.5
29.9
29.8
29.5
26.6
23.1
24.0
26.3
31.5
29.8
24.6
31.3
28.4
25.5
21.2
31.9
32.4
28.6
25.3
27.5
32.3
29.6
29.2
28.3

Lbs./In.

N/mm

54
9.5
29
5.1
5.9
1.0
12
2.2
1229 215
5.8
1.0
18
3.1
25
4.4
2.5
.43
2.6
.46
2.9
.50
9.6
1.7
20
3.5
479
84
100
17
33
5.7
28
4.9
175
31
1.8
.31
8.3
1.4
1.2
.21
1.1
.19
1.6
.29
176
31
23
4.0
19
3.3
9.1
1.6
25
4.3
33
5.8
8.5
1.5
73
13
128
22
55
9.7
639 112
7.0
1.2
2.5
.44
18
3.2
78
14
58
10
5.1
.89
2.6
.45
1302 228
21
3.6
165
29
24
4.2
61
11
75
13
.15
.03
7.0
1.2
11
1.9
3.6
.63
30
5.2
94
17
19
3.3
55
9.7
4.5
.80
4.7
.82
8.4
1.5
10
1.8
7.5
1.3
70
12
311
54
314
55
48
8.4
1.4
.25
6.3
1.1
128
22
1.6
.28
13
2.2
32
5.7
257
45
4.4
.76
3.9
.68
80
14
499
87
207
36
3.0
.53
43
7.5
56
9.8
47
8.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

2.3
.45
1.0
1.1
.25
1.3
1.2
.87
1.8
1.7
2.0
1.7
1.4
.47
.86
1.3
1.5
.78
2.8
2.8
3.6
4.0
3.6
1.3
2.5
3.0
4.5
3.9
3.7
8.5
.25
.18
.41
.22
.74
1.0
.90
.52
.57
1.1
1.2
.190
1.2
.62
1.0
1.1
1.1
1.4
1.9
1.6
2.2
1.4
.90
1.3
1.3
2.5
2.6
2.0
1.9
2.5
1.2
.71
.58
1.9
3.8
3.0
1.0
4.5
3.2
3.8
1.3
.40
.85
.57
.24
.34
1.0
.65
.58
.75

mm

Lbs.

57
12
27
28
6.3
33
29
22
45
44
51
44
35
12
22
32
38
20
70
72
93
102
92
32
63
77
115
98
93
216
6.5
4.5
10
5.7
19
25
23
13
14
27
30
4.83
30
16
26
27
29
35
47
41
55
35
23
34
33
63
66
52
48
64
30
18
15
49
98
77
26
114
81
96
33
10
22
14
6.1
8.7
26
17
15
19

123
547
13
59
6.2
27
14
61
303 1348
7.5
34
21
91
22
97
4.4
20
4.5
20
5.8
26
17
74
27
122
224
998
86
381
41
182
42
187
136
607
4.9
22
23
104
4.5
20
4.3
19
5.9
26
224
998
56
251
56
251
41
182
96
426
122
541
72
322
18
82
23
101
23
100
144
638
5.2
23
2.5
11
16
73
41
180
33
147
5.3
24
3.0
14
247 1101
24
109
102
452
24
109
65
287
84
374
.20
.90
13
58
17
76
7.9
35
41
180
85
377
25
113
73
325
11
50
12
54
17
76
19
85
19
84
83
370
222
987
181
806
93
413
5.5
25
19
85
133
593
7.1
32
41
180
122
544
332 1475
1.8
7.8
3.3
15
45
201
120
536
71
315
3.1
14
28
124
33
145
35
157

ENDS: C - Closed

G - Ground
O - Open

Inches

mm

3.36 85.4
.24
6.1
.46 11.6
.36
9.3
1.38 34.9
.44 11.2
.49 12.5
.43 11.0
.30
7.7
.62 15.8
.36
9.2
.63 16.0
1.04 26.5
1.69 42.9
1.14 28.9
.84 21.3
.97 24.6
1.59 40.4
.54 13.8
1.20 30.4
.48 12.2
.48 12.2
.86 21.9
3.83 97.2
1.89 48.0
2.23 56.6
2.39 60.7
4.56 115.9
5.09 129.3
7.06 179.2
.24
6.2
.25
6.4
.78 19.8
.74 18.8
.48 12.2
.25
6.4
.38
9.7
.48 12.2
.56 14.2
.41 10.5
.31
7.8
1.190 30.23
.65 16.5
1.00 25.5
.50 12.7
1.10 28.0
1.12 28.5
.92 23.4
.48 12.2
.55 13.9
.58 14.6
.99 25.1
1.31 33.2
.62 15.8
1.33 33.8
.61 15.4
.66 16.8
.64 16.2
.64 16.4
.99 25.1
1.40 35.7
2.28 57.9
1.55 39.4
2.27 57.6
.44 11.0
1.01 25.7
2.42 61.4
.64 16.3
1.83 46.5
5.16 131.1
5.76 146.4
.22
5.6
.15
3.8
.53 13.5
.76 19.3
.70 17.7
.18
4.6
.42 10.7
.45 11.4
.85 21.5

WIRE DIA.
Inches

0.177
0.080
0.076
0.081
0.250
0.075
0.094
0.096
0.055
0.069
0.063
0.090
0.116
0.225
0.157
0.120
0.121
0.187
0.062
0.102
0.058
0.058
0.072
0.225
0.135
0.135
0.120
0.163
0.177
0.147
0.091
0.100
0.130
0.191
0.080
0.053
0.090
0.120
0.112
0.069
0.056
0.250
0.100
0.167
0.100
0.147
0.145
0.046
0.080
0.091
0.072
0.120
0.157
0.104
0.148
0.076
0.080
0.091
0.092
0.099
0.156
0.225
0.207
0.162
0.060
0.092
0.196
0.064
0.120
0.178
0.262
0.059
0.050
0.125
0.190
0.147
0.052
0.105
0.112
0.130

mm

TOTAL
MATL
COILS

4.5
2.0
1.9
2.1
6.4
1.9
2.4
2.4
1.4
1.8
1.6
2.3
2.9
5.7
4.0
3.0
3.1
4.7
1.6
2.6
1.5
1.5
1.8
5.7
3.4
3.4
3.0
4.1
4.5
3.7
2.3
2.5
3.3
4.9
2.0
1.3
2.3
3.0
2.8
1.8
1.4
6.35
2.5
4.2
2.5
3.7
3.7
1.2
2.0
2.3
1.8
3.0
4.0
2.6
3.8
1.9
2.0
2.3
2.3
2.5
4.0
5.7
5.3
4.1
1.5
2.3
5.0
1.6
3.0
4.5
6.7
1.5
1.3
3.2
4.8
3.7
1.3
2.7
2.8
3.3

19.0
3.00
6.00
4.50
5.50
6.00
5.25
4.50
4.50
8.00
5.75
7.00
9.00
7.50
7.25
7.00
8.00
8.50
7.75
10.8
8.25
8.25
12.0
17.0
14.0
16.5
20.0
27.0
28.8
48.0
2.67
2.50
6.00
4.00
6.00
3.75
4.25
4.00
4.00
5.00
4.50
4.75
5.50
6.00
5.00
7.50
6.75
19.0
6.00
6.00
7.00
7.25
7.33
6.00
9.00
7.00
7.25
7.00
7.00
10.0
9.00
10.0
7.50
14.0
7.25
10.0
11.3
9.00
14.3
29.0
22.0
3.75
3.00
4.25
4.00
3.75
3.50
4.00
4.00
6.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
SPR
SPR
MW
SPR
SPR
HD
SPR
SPR
MW
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
MW
SST
SPR
SST
HD
SPR
SPR
SST
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
HD
SPR
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
C
CG
C
CG
CG
CG
C
C
CG
CG
C
C
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
C
CG
CG
CG
CG
CG
CG
CL
CG
CG
CG
CG

F
N
S
H

Z
Z
Z
Z
GI
Z
Z
Z
Z
Z
Z
Z
Z
GI
Z
Z
Z
Z
Z
N
N
N
N
Z
Z
Z
Z
N
Z
Z
GI
N
N
Z
Z
N
N
N
Z
N
Z
N
Z
Z
Z
N
N
N
Z
N
Z
Z
Z
N
Z
Z
N
N
N
N
N
Z
Z
Z
N
Z
N
Z
Z
Z
Z
Z
N
Z
N
N
N
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 201

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.375
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.390
1.400
1.400

34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
34.93
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.31
35.56
35.56

S-1087
11628
S-326
3560
10401
12610
10299
11671
12779
4400
4343
S-1388
11839
S-450
10309
10348
12092
73
S-347
12420
269
3464
54
10742
4355
S-1209
11266
12048
1557
S-289
2591
S-103
S-1355
S-445
898
S-195
S-327
3987
861
11513
823
811
10363
S-3002
7005
389
11977
845
383
850
11489
862
824
841
803
801
10492
S-401
3492
S-143
2909
S-1594
10359
10498
10300
12124
S-942
B8-37
S-3248
S-1189
S-1245
3394
11308
12680
3398
3187
11978
12444
72766
72766S

O.D.

FREE LENGTH
Inches

1.63
1.63
1.69
1.75
1.97
2.00
2.13
2.13
2.19
2.22
2.25
2.31
2.34
2.44
2.44
2.50
2.50
2.50
2.50
2.75
2.75
2.75
2.75
2.88
2.94
3.00
3.00
3.47
3.50
3.75
3.75
3.75
3.75
3.75
3.75
3.75
3.88
4.00
4.13
4.38
4.38
4.50
4.75
5.38
5.38
6.00
6.50
8.00
9.75
10.0
10.9
12.0
12.0
12.0
12.0
12.0
.78
.94
1.00
1.13
1.13
1.69
2.06
2.22
2.25
2.72
2.75
2.75
3.06
3.25
3.25
5.50
5.75
5.88
6.50
7.00
8.00
10.0
2.25
2.25

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

41.3
41.3
42.8
44.5
50.0
50.8
54.0
54.0
55.6
56.4
57.2
58.7
59.5
61.9
61.9
63.5
63.5
63.5
63.5
69.9
69.9
69.9
69.9
73.0
74.6
76.2
76.2
88.1
88.9
95.3
95.3
95.3
95.3
95.3
95.3
95.3
98.4
101.6
104.8
111.1
111.1
114.3
120.7
136.5
136.5
152.4
165.1
203.2
247.7
254.0
277.8
304.8
304.8
304.8
304.8
304.8
19.8
23.8
25.4
28.6
28.6
42.8
52.4
56.4
57.2
69.0
69.9
69.9
77.8
82.6
82.6
139.7
146.1
149.2
165.1
177.8
203.2
254.0
57.2
57.2

I.D.
Inches

1.135
1.123
1.105
.991
1.063
1.041
1.193
1.041
1.079
1.179
1.193
1.191
1.187
1.191
1.021
1.193
1.167
1.105
1.105
1.277
1.135
1.105
1.021
1.215
1.205
1.135
1.021
1.125
1.259
1.251
1.231
1.231
1.199
1.175
1.105
1.063
1.231
1.021
1.105
1.217
1.079
1.021
1.181
1.221
1.001
1.135
.989
1.021
1.215
1.051
1.019
1.105
1.079
.991
.961
.925
1.118
1.120
1.150
1.308
1.266
1.142
1.016
1.194
1.190
1.220
1.250
.940
1.232
1.300
1.150
1.120
1.230
1.114
1.006
1.150
1.034
1.066
1.076
1.076

RATE
mm

28.8
28.5
28.1
25.2
27.0
26.4
30.3
26.4
27.4
29.9
30.3
30.3
30.1
30.3
25.9
30.3
29.6
28.1
28.1
32.4
28.8
28.1
25.9
30.9
30.6
28.8
25.9
28.6
32.0
31.8
31.3
31.3
30.5
29.8
28.1
27.0
31.3
25.9
28.1
30.9
27.4
25.9
30.0
31.0
25.4
28.8
25.1
25.9
30.9
26.7
25.9
28.1
27.4
25.2
24.4
23.5
28.4
28.4
29.2
33.2
32.2
29.0
25.8
30.3
30.2
31.0
31.8
23.9
31.3
33.0
29.2
28.4
31.2
28.3
25.6
29.2
26.3
27.1
27.3
27.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

48
41
63
393
104
141
13
141
79
15
10
6.8
7.6
7.1
164
8.5
18
48
46
.89
27
31
122
5.4
4.0
20
153
28
.89
1.5
1.6
2.6
7.0
6.0
29
63
2.6
80
27
3.7
36
70
6.8
3.3
75
13
107
44
1.1
21
32
8.6
12
35
49
79
249
143
83
.72
2.6
37
213
13
19
5.6
3.5
333
5.5
.26
25
16
2.9
18
103
12
44
21
116
99

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

8.4
7.2
11
69
18
25
2.3
25
14
2.6
1.8
1.2
1.3
1.2
29
1.5
3.2
8.4
8.0
.16
4.8
5.5
21
.95
.70
3.5
27
4.8
.16
.26
.27
.46
1.2
1.1
5.2
11
.46
14
4.7
.64
6.3
12
1.2
.59
13
2.2
19
7.8
.19
3.6
5.6
1.5
2.2
6.1
8.5
14
44
25
15
.13
.45
6.5
37
2.2
3.4
.99
.61
58
.96
.05
4.4
2.8
.51
3.2
18
2.1
7.7
3.7
20
17

.77
.81
.78
.37
.79
.71
1.4
.71
.92
1.5
1.7
1.6
1.6
1.7
.73
1.8
1.4
1.2
1.1
2.4
1.5
1.3
.98
2.3
2.0
1.8
.69
1.6
2.9
3.2
2.8
3.1
2.3
2.6
1.9
1.2
3.2
1.5
2.1
3.4
2.0
1.7
3.3
3.2
1.8
3.2
1.4
2.7
7.5
4.4
3.8
6.4
5.9
4.2
3.7
2.8
.22
.34
.48
.92
.72
.82
.62
1.6
1.2
2.0
2.3
.65
2.1
2.8
1.4
3.1
4.4
3.2
1.4
3.3
2.7
4.3
1.1
.81

mm

19
20
20
9.3
20
18
35
18
23
39
42
39
40
43
18
46
35
29
28
61
37
32
25
59
51
46
18
42
73
82
71
79
58
65
48
30
82
38
52
86
51
43
83
82
45
81
35
68
191
112
97
162
149
106
93
70
5.7
8.7
12
23
18
21
16
40
32
52
59
17
53
70
36
78
112
82
35
83
69
108
28
21

ENDS: C - Closed

G - Ground
O - Open

Lbs.

37
33
50
144
82
100
18
100
72
23
17
11
12
12
119
15
25
55
50
2.1
40
40
119
13
8.1
37
106
45
2.5
4.8
4.3
8.2
16
15
55
73
8.6
119
55
12
72
119
22
11
134
40
146
119
8.1
92
121
55
72
144
179
220
56
49
40
.66
1.9
30
132
20.3
24
11
8.1
218
12
.73
36
49
13
58
143
40
120
91
127
80

163
148
221
641
366
447
81
447
321
101
76
47
53
54
530
68
112
245
221
9.5
178
176
530
56
36
163
471
201
11
21
19
37
72
68
245
325
38
530
245
56
321
530
98
48
594
178
651
530
36
409
539
245
321
641
798
977
248
219
177
2.9
8.3
135
588
90
106
51
36
968
51
3.2
161
220
57
259
635
177
533
405
563
357

Inches

.57
.82
.74
.96
1.01
1.09
.50
1.09
1.00
.61
.59
.76
.78
.74
1.24
.68
.73
.98
.91
.34
1.02
1.49
1.55
.56
.91
1.02
1.19
1.06
.64
.53
.95
.63
.62
1.20
1.55
1.33
.63
2.17
1.53
.79
1.83
2.43
1.07
.69
3.30
1.68
2.56
3.63
2.24
4.81
5.25
4.32
4.79
6.91
7.45
7.31
.41
.47
.45
.21
.40
.87
1.26
.66
.55
.68
.40
2.03
.47
.50
.84
2.43
.88
2.45
2.50
1.68
3.65
4.54
1.05
1.05

mm

Inches

14.5
20.8
18.9
24.4
25.8
27.6
12.7
27.6
25.4
15.6
15.0
19.3
19.7
18.7
31.5
17.3
18.5
24.9
23.1
8.7
25.9
37.7
39.3
14.2
23.2
25.9
30.3
27.0
16.2
13.4
24.2
16.0
15.6
30.5
39.4
33.7
16.0
55.1
38.9
20.1
46.4
61.8
27.1
17.6
83.8
42.7
65.0
92.2
56.9
122.1
133.4
109.7
121.5
175.6
189.3
185.7
10.4
12.0
11.4
5.2
10.2
22.0
32.1
16.8
14.0
17.3
10.2
51.4
12.0
12.6
21.3
61.7
22.4
62.2
63.4
42.7
92.7
115.2
26.7
26.7

0.120
0.126
0.135
0.192
0.156
0.167
0.091
0.167
0.148
0.098
0.091
0.092
0.094
0.092
0.177
0.091
0.104
0.135
0.135
0.049
0.120
0.135
0.177
0.080
0.085
0.120
0.177
0.125
0.058
0.062
0.072
0.072
0.088
0.100
0.135
0.156
0.072
0.177
0.135
0.079
0.148
0.177
0.097
0.077
0.187
0.120
0.193
0.177
0.080
0.162
0.178
0.135
0.148
0.192
0.207
0.225
0.136
0.135
0.120
0.041
0.062
0.124
0.187
0.098
0.100
0.085
0.070
0.225
0.079
0.045
0.120
0.135
0.080
0.138
0.192
0.120
0.178
0.162
0.162
0.162

mm

TOTAL
MATL
COILS

3.0
3.2
3.4
4.9
4.0
4.2
2.3
4.2
3.8
2.5
2.3
2.3
2.4
2.3
4.5
2.3
2.6
3.4
3.4
1.2
3.0
3.4
4.5
2.0
2.2
3.0
4.5
3.2
1.5
1.6
1.8
1.8
2.2
2.5
3.4
4.0
1.8
4.5
3.4
2.0
3.8
4.5
2.5
2.0
4.7
3.0
4.9
4.5
2.0
4.1
4.5
3.4
3.8
4.9
5.3
5.7
3.5
3.4
3.0
1.0
1.6
3.1
4.7
2.5
2.5
2.2
1.8
5.7
2.0
1.1
3.0
3.4
2.0
3.5
4.9
3.0
4.5
4.1
4.1
4.1

4.75
6.50
5.50
5.00
6.50
6.50
5.50
6.50
6.75
6.25
6.50
8.25
8.25
8.00
7.00
7.50
6.00
7.25
6.75
6.00
7.50
10.0
8.75
7.00
10.8
8.50
6.75
8.50
10.0
7.50
13.3
7.75
7.00
12.0
10.5
8.50
7.75
12.3
11.3
9.00
12.3
13.8
11.0
8.00
16.3
14.0
13.3
20.5
27.0
28.7
28.5
31.0
32.3
36.0
36.0
32.5
3.00
3.50
3.75
4.00
5.50
6.00
6.75
6.75
5.50
8.00
5.75
9.00
6.00
10.0
7.00
17.0
11.0
16.8
13.0
14.0
20.5
27.0
6.50
6.50

SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
HD
SPR
SPR
SST
SST
SST
SPR
SPR
SST
HD
SST
SPR
HD
HD
HD
SPR
SPR
SST
SST
SPR
SPR
SST
HD
SST
SST
SST
HD
SST
SST
SPR
HD
SPR
HD
HD
SPR
SST
HD
HD
SPR
HD
HD
HD
HD
HD
HD
HD
HD
HD
SPR
SST
HD
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
MW
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
C
CG
CG
CG
C
CG
CG

F
N
S
H

N
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
Z
Z
N
Z
N
Z
Z
Z
Z
Z
Z
N
N
N
Z
N
Z
N
N
N
Z
N
N
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
GI
N
Z
N
Z
N
Z
Z
Z
Z
N
N
N
N
N
Z
Z
Z
Z
Z
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

201

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 202

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.400
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.406
1.421
1.421
1.421
1.421
1.421
1.421
1.421
1.421
1.421

35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.56
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
35.71
36.09
36.09
36.09
36.09
36.09
36.09
36.09
36.09
36.09

72775
72775S
72767
72767S
72776
72776S
72768
72768S
72777
72777S
72769
72769S
72778
72778S
72770
72770S
72779
72779S
72771
72771S
72780
72780S
72772
72772S
72781
72781S
72773
72773S
72782
72782S
72774
72774S
72783
72783S
S-1241
S-70
S-3246
S-3024
S-3018
S-3075
NN-77
3017
11980
3324
12192
11908
12009
S-333
S-1676
281
11424
11283
10547
S-1250
12058
1683
S-1214
3056
11914
12445
S-3233
11282
12167
11906
2756
12151
12413
12077
3490
10980
4013
S-336
S-1229
4395
S-3229
2733
1913
3328
S-3022
11930

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

2.25
2.25
2.50
2.50
2.50
2.50
3.00
3.00
3.00
3.00
3.50
3.50
3.50
3.50
4.00
4.00
4.00
4.00
4.25
4.25
4.25
4.25
4.50
4.50
4.50
4.50
5.00
5.00
5.00
5.00
5.25
5.25
5.25
5.25
.75
.88
1.00
1.00
1.13
1.13
1.22
1.25
1.25
1.28
1.34
1.50
1.50
1.50
1.63
1.75
1.91
2.13
2.13
2.50
3.16
3.25
3.75
4.00
4.00
4.13
4.25
4.25
4.41
5.75
6.00
6.66
7.00
8.00
12.5
13.5
18.5
1.19
1.38
2.19
2.50
2.50
2.75
2.75
3.00
3.03

mm

57.2
57.2
63.5
63.5
63.5
63.5
76.2
76.2
76.2
76.2
88.9
88.9
88.9
88.9
101.6
101.6
101.6
101.6
108.0
108.0
108.0
108.0
114.3
114.3
114.3
114.3
127.0
127.0
127.0
127.0
133.4
133.4
133.4
133.4
19.1
22.2
25.4
25.4
28.6
28.6
31.0
31.8
31.8
32.5
34.1
38.1
38.1
38.1
41.3
44.5
48.4
54.0
54.0
63.5
80.2
82.6
95.3
101.6
101.6
104.8
108.0
108.0
111.9
146.1
152.4
169.1
177.8
203.2
317.5
342.9
469.9
30.2
34.9
55.6
63.5
63.5
69.9
69.9
76.2
77.0

MATERIAL: MW - Music Wire

202

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.046
1.046
1.076
1.076
1.046
1.046
1.076
1.076
1.046
1.046
1.076
1.076
1.046
1.046
1.076
1.076
1.046
1.046
1.076
1.076
1.046
1.046
1.076
1.076
1.046
1.046
1.076
1.076
1.046
1.046
1.076
1.076
1.046
1.046
1.136
1.246
1.322
1.256
1.226
1.032
1.086
1.282
1.082
1.166
1.296
1.300
1.296
1.136
1.240
1.110
1.032
1.224
1.034
1.136
.992
.984
1.222
1.262
1.230
1.264
1.196
.956
1.216
1.170
1.166
1.258
1.168
.902
1.110
.970
1.046
1.203
1.321
1.249
1.275
1.171
1.211
1.001
1.109
1.211

RATE
mm

26.6
26.6
27.3
27.3
26.6
26.6
27.3
27.3
26.6
26.6
27.3
27.3
26.6
26.6
27.3
27.3
26.6
26.6
27.3
27.3
26.6
26.6
27.3
27.3
26.6
26.6
27.3
27.3
26.6
26.6
27.3
27.3
26.6
26.6
28.9
31.6
33.6
31.9
31.1
26.2
27.6
32.6
27.5
29.6
32.9
33.0
32.9
28.9
31.5
28.2
26.2
31.1
26.3
28.9
25.2
25.0
31.0
32.1
31.2
32.1
30.4
24.3
30.9
29.7
29.6
32.0
29.7
22.9
28.2
24.6
26.6
30.6
33.6
31.7
32.4
29.7
30.8
25.4
28.2
30.8

Lbs./In.

169
143
103
87
149
127
84
71
120
102
70
60
100
85
61
52
87
74
57
48
81
69
54
45
76
65
48
41
69
59
45
39
65
55
202
15
.78
9.6
18
563
288
2.5
343
47
2.1
1.6
.82
67
13
104
216
8.7
199
43
236
257
4.4
1.5
4.8
1.4
4.6
317
6.5
14
11
2.4
11
222
12
62
16
46
1.0
7.0
4.4
40
11
242
66
15

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

30
25
18
15
26
22
15
12
21
18
12
10
18
15
11
9.0
15
13
10
8.5
14
12
9.4
8.0
13
11
8.4
7.1
12
10
7.9
6.8
11
9.7
35
2.6
.14
1.7
3.2
99
50
.44
60
8.2
.37
.28
.14
12
2.3
18
38
1.5
35
7.5
41
45
.77
.26
.84
.24
.81
56
1.1
2.5
2.0
.43
2.0
39
2.1
11
2.9
8.0
.18
1.2
.78
7.1
1.9
42
12
2.7

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

.97 25
.73 18
1.2
31
.92 23
1.1
28
.82 21
1.5
39
1.1
29
1.4
35
1.0
26
1.8
46
1.3
34
1.6
42
1.2
31
2.1
53
1.6
39
1.9
48
1.4
36
2.2
57
1.7
42
2.0
51
1.5
38
2.4
60
1.8
45
2.2
55
1.6
41
2.7
67
2.0
50
2.4
60
1.8
45
2.8
71
2.1
53
2.5
64
1.9
48
.24
6.1
.60 15
.83 21
.64 16
.68 17
.20
5.1
.27
6.8
.85 22
.26
6.7
.68 17
1.0
26
1.2
31
1.0
26
.72 18
1.0
26
.68 17
.61 15
1.5
38
.65 16
1.1
29
.75 19
.72 18
2.7
70
3.0
76
3.2
81
3.2
81
2.3
59
.57 15
3.1
79
2.6
65
3.5
89
4.1 105
3.4
86
1.3
34
6.0 152
3.3
83
7.1 181
.61 16
1.1
27
1.6
41
2.0
51
1.5
39
1.8
46
.75 19
1.1
27
1.8
45

Lbs.

164
730
104
463
127
563
80
357
164
730
104
463
127
563
80
357
164
730
104
463
127
563
80
357
164
730
104
463
127
563
80
357
164
730
104
463
127
563
80
357
164
730
104
463
127
563
80
357
164
730
104
463
127
563
80
357
164
730
104
463
127
563
80
357
164
730
104
463
49
216
8.7
39
.65
2.9
6.2
27
12
54
113
501
77
343
2.1
9.4
90
401
32
142
2.2
9.9
2.0
8.7
.85
3.8
49
216
13
59
71
315
131
582
13
57
129
573
49
216
176
782
186
826
12
53
4.4
20
15
68
4.5
20
11
48
181
807
20
90
37
166
39
175
10
45
38
170
298 1327
71
315
204
908
117
521
28
125
1.1
4.8
11
50
9.0
40
61
272
20
88
182
807
71
315
27
120

ENDS: C - Closed

G - Ground
O - Open

Inches

1.17
1.17
1.15
1.15
1.26
1.26
1.34
1.34
1.48
1.48
1.52
1.52
1.73
1.73
1.72
1.72
1.92
1.92
1.80
1.80
2.04
2.04
1.90
1.90
2.15
2.15
2.09
2.09
2.32
2.32
2.19
2.19
2.46
2.46
.41
.28
.17
.36
.45
.65
.56
.40
.57
.60
.30
.29
.47
.68
.42
.79
1.22
.64
1.26
.91
1.76
1.79
1.01
1.01
.79
.92
1.92
1.86
.95
1.30
1.74
.78
1.79
4.79
4.63
7.19
9.36
.41
.30
.58
.46
.75
.95
1.79
1.17
.74

mm

29.8
29.8
29.3
29.3
32.0
32.0
33.9
33.9
37.7
37.7
38.6
38.6
43.8
43.8
43.7
43.7
48.9
48.9
45.8
45.8
51.7
51.7
48.3
48.3
54.5
54.5
53.0
53.0
59.0
59.0
55.5
55.5
62.4
62.4
10.3
7.1
4.3
9.0
11.4
16.6
14.2
10.2
14.4
15.2
7.7
7.4
11.9
17.1
10.5
20.0
30.9
16.2
31.9
23.1
44.7
45.6
25.7
25.6
20.1
23.4
48.7
47.1
24.1
33.0
44.2
19.7
45.3
121.6
117.6
182.7
237.7
10.4
7.6
14.7
11.7
19.1
24.0
45.3
29.7
18.7

WIRE DIA.
Inches

0.177
0.177
0.162
0.162
0.177
0.177
0.162
0.162
0.177
0.177
0.162
0.162
0.177
0.177
0.162
0.162
0.177
0.177
0.162
0.162
0.177
0.177
0.162
0.162
0.177
0.177
0.162
0.162
0.177
0.177
0.162
0.162
0.177
0.177
0.135
0.080
0.042
0.075
0.090
0.187
0.160
0.062
0.162
0.120
0.055
0.053
0.055
0.135
0.083
0.148
0.187
0.091
0.186
0.135
0.207
0.211
0.092
0.072
0.088
0.071
0.105
0.225
0.095
0.118
0.120
0.074
0.119
0.252
0.148
0.218
0.180
0.109
0.050
0.086
0.073
0.125
0.105
0.210
0.156
0.105

mm

TOTAL
MATL
COILS

4.5
4.5
4.1
4.1
4.5
4.5
4.1
4.1
4.5
4.5
4.1
4.1
4.5
4.5
4.1
4.1
4.5
4.5
4.1
4.1
4.5
4.5
4.1
4.1
4.5
4.5
4.1
4.1
4.5
4.5
4.1
4.1
4.5
4.5
3.4
2.0
1.1
1.9
2.3
4.7
4.1
1.6
4.1
3.0
1.4
1.3
1.4
3.4
2.1
3.8
4.7
2.3
4.7
3.4
5.3
5.4
2.3
1.8
2.2
1.8
2.7
5.7
2.4
3.0
3.0
1.9
3.0
6.4
3.8
5.5
4.6
2.8
1.3
2.2
1.9
3.2
2.7
5.3
4.0
2.7

6.63
6.63
7.13
7.13
7.13
7.13
8.25
8.25
8.38
8.38
9.38
9.38
9.75
9.75
10.6
10.6
10.9
10.9
11.1
11.1
11.5
11.5
11.8
11.8
12.1
12.1
12.9
12.9
13.1
13.1
13.5
13.5
13.9
13.9
3.00
3.50
4.00
3.75
4.00
3.50
3.50
5.50
3.50
5.00
4.50
4.50
8.50
5.00
4.00
5.33
6.50
7.00
6.75
6.75
8.50
8.50
11.0
13.0
9.00
13.0
17.3
8.25
10.0
11.0
14.5
9.50
14.0
19.0
30.5
33.0
52.0
3.75
5.00
6.75
5.33
6.00
9.00
8.50
7.50
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SST
SST
SST
SST
SST
SST
SPR
SPR
HD
SPR
SST
SPR
SST
SST
HD
SPR
HD
SPR
SST
SPR
SPR
SST
SPR
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
HD
SPR
SST
SST
SPR
SST
MW
SPR
SPR
SST
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
C
C
CG
C
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
Z
N
GI
N
N
Z
N
Z
Z
N
Z
Z
N
Z
N
Z
N
N
N
N
Z
Z
N
Z
Z
Z
Z
N
N
Z
N
Z
Z
Z
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 203

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.421
1.421
1.421
1.421
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.437
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.453
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460

36.09
36.09
36.09
36.09
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.50
36.91
36.91
36.91
36.91
36.91
36.91
36.91
36.91
36.91
36.91
36.91
36.91
36.91
36.91
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08

4194
3141
12460
4018
S-1550
DD-88
S-3059
12222
S-151
S-1033
11360
3071
S-944
12487
B17-167
11531
3909
3288
12069
3704
2753
10719
3407
S-303
10594
10823
S-369
7007
3049
10454
4236
4040
4029
3299
3297
12297
10339
4359
11791
12616
B11-63
B17-203
11238
12177
4026
4038
4032
72784
72784S
72794
72794S
72800
72800S
72810
72810S
72817
72817S
72832
72832S
72841
72841S
72785
72785S
72795
72795S
72801
72801S
72811
72811S
72819
72819S
72833
72833S
72843
72843S
72786
72786S
72796
72796S
72802

O.D.

FREE LENGTH
Inches

4.00
5.13
12.0
27.5
.56
.69
.88
1.00
1.50
1.50
1.50
1.50
1.69
1.75
1.84
2.72
2.75
2.75
2.88
3.00
3.13
3.31
3.38
3.59
3.75
4.00
4.88
5.63
6.88
8.88
14.5
20.5
23.0
1.53
1.75
1.94
2.06
2.06
2.41
2.50
2.84
2.88
3.00
3.03
20.3
21.0
22.5
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.50
2.50
2.50
2.50
2.50

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

101.6
130.2
304.8
698.5
14.3
17.4
22.2
25.4
38.1
38.1
38.1
38.1
42.8
44.5
46.8
69.0
69.9
69.9
73.0
76.2
79.4
84.1
85.7
91.3
95.3
101.6
123.8
142.9
174.6
225.4
368.3
520.7
584.2
38.9
44.5
49.2
52.4
52.4
61.1
63.5
72.2
73.0
76.2
77.0
514.4
533.4
571.5
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
63.5
63.5
63.5
63.5
63.5

I.D.
Inches

1.281
1.261
1.003
.921
1.237
1.217
1.281
1.293
1.347
1.277
1.255
1.173
1.237
1.317
1.125
1.013
1.317
1.017
1.287
1.327
1.287
1.335
1.177
1.277
1.265
1.167
1.137
1.023
1.077
1.187
1.083
1.113
1.113
1.227
1.243
1.323
1.233
1.069
1.203
1.203
1.157
1.275
1.141
1.269
1.123
1.099
1.093
1.236
1.236
1.210
1.210
1.190
1.190
1.164
1.164
1.148
1.148
1.136
1.136
1.106
1.106
1.236
1.236
1.210
1.210
1.190
1.190
1.164
1.164
1.148
1.148
1.136
1.136
1.106
1.106
1.236
1.236
1.210
1.210
1.190

RATE
mm

32.5
32.0
25.5
23.4
31.4
30.9
32.5
32.8
34.2
32.4
31.9
29.8
31.4
33.5
28.6
25.7
33.5
25.8
32.7
33.7
32.7
33.9
29.9
32.4
32.1
29.6
28.9
26.0
27.4
30.1
27.5
28.3
28.3
31.2
31.6
33.6
31.3
27.2
30.6
30.6
29.4
32.4
29.0
32.2
28.5
27.9
27.8
31.4
31.4
30.7
30.7
30.2
30.2
29.6
29.6
29.2
29.2
28.9
28.9
28.1
28.1
31.4
31.4
30.7
30.7
30.2
30.2
29.6
29.6
29.2
29.2
28.9
28.9
28.1
28.1
31.4
31.4
30.7
30.7
30.2

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

1.3
2.6
55
60
70
45
12
15
.32
5.9
12
56
26
1.0
135
234
1.8
275
3.0
1.2
3.0
.52
31
2.6
3.2
30
37
100
47
13
20
12
12
49
12
3.2
35
216
37
37
62
6.3
58
7.8
12
16
16
41
35
61
52
80
68
114
97
143
122
162
138
240
204
30
25
43
37
57
49
80
68
101
86
114
97
167
142
23
20
34
29
44

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

.22
.45
9.5
11
12
7.9
2.2
2.7
.06
1.0
2.1
9.8
4.6
.18
24
41
.31
48
.53
.22
.53
.09
5.4
.46
.56
5.2
6.5
18
8.3
2.2
3.6
2.1
2.1
8.5
2.1
.56
6.1
38
6.6
6.6
11
1.1
10
1.4
2.1
2.9
2.7
7.2
6.1
11
9.0
14
12
20
17
25
21
28
24
42
36
5.2
4.4
7.6
6.5
10
8.5
14
12
18
15
20
17
29
25
4.0
3.4
5.9
5.0
7.8

3.0
4.1
3.3
4.8
.29
.25
.52
.60
1.1
.98
1.0
.77
.82
1.2
.58
.65
2.3
.65
2.3
2.7
2.5
2.9
1.5
2.8
2.7
1.8
1.7
1.7
2.4
3.5
5.6
7.4
7.2
.65
.91
1.6
.85
.63
1.1
1.6
1.1
2.3
1.4
2.3
7.8
6.9
7.3
1.0
.80
.95
.76
.89
.69
.82
.64
.76
.57
.73
.56
.66
.49
1.4
1.1
1.3
1.1
1.2
.97
1.1
.90
1.1
.81
1.0
.80
.94
.71
1.8
1.4
1.7
1.4
1.6

mm

77
105
83
122
7.3
6.3
13
15
28
25
27
20
21
31
15
17
59
17
58
68
64
72
39
71
69
45
43
44
62
88
142
188
183
17
23
41
21
16
29
41
28
57
34
58
197
176
185
26
20
24
19
23
17
21
16
19
14
19
14
17
12
36
28
34
27
32
25
29
23
27
20
26
20
24
18
46
36
43
35
41

ENDS: C - Closed

G - Ground
O - Open

Lbs.

3.8
17
11
47
179
796
289 1285
20
89
11
49
6.4
29
9.1
40
.35
1.5
5.7
26
12
56
43
193
21
95
1.3
5.6
79
351
152
678
4.2
18
180
799
6.8
30
3.3
15
7.6
34
1.5
6.6
47
210
7.3
32
8.7
39
53
235
63
278
172
767
115
510
43
193
114
509
88
392
88
392
32
142
11
48
5.2
23
29
131
137
610
43
191
60
267
69
305
14
63
78
348
18
80
92
410
113
503
114
505
42
188
28
125
58
257
39
173
72
319
47
209
93
412
62
274
109
485
69
307
119
528
77
343
158
702
100
445
42
188
28
125
58
256
39
173
71
315
47
209
92
410
62
274
109
485
69
307
117
521
77
343
157
696
100
445
42
188
28
125
57
255
39
173
71
316

Inches

.98
1.00
6.32
15.0
.28
.44
.35
.22
.41
.52
.46
.73
.40
.54
.78
2.07
.42
1.58
.60
.33
.60
.46
1.04
.80
1.03
1.38
1.50
3.60
3.26
2.02
6.64
6.40
6.64
.45
.84
.33
.50
1.25
.75
.88
1.04
.62
1.37
.67
7.26
7.70
8.82
.48
.48
.55
.55
.61
.61
.68
.68
.72
.72
.77
.77
.84
.84
.57
.57
.67
.67
.76
.76
.85
.85
.90
.90
.97
.97
1.06
1.06
.67
.67
.80
.80
.89

mm

Inches

24.9
25.4
160.6
381.0
7.0
11.2
8.9
5.5
10.3
13.2
11.6
18.4
10.2
13.7
19.8
52.5
10.7
40.0
15.2
8.4
15.2
11.7
26.4
20.3
26.2
35.1
38.1
91.4
82.9
51.2
168.6
162.6
168.7
11.5
21.3
8.3
12.6
31.7
19.1
22.2
26.3
15.8
34.7
16.9
184.4
195.6
224.0
12.1
12.1
13.9
13.9
15.4
15.4
17.4
17.4
18.3
18.3
19.5
19.5
21.4
21.4
14.6
14.6
17.1
17.1
19.3
19.3
21.6
21.6
22.8
22.8
24.7
24.7
27.0
27.0
17.1
17.1
20.2
20.2
22.7

0.070
0.080
0.209
0.250
0.100
0.110
0.078
0.072
0.045
0.080
0.091
0.132
0.100
0.060
0.156
0.212
0.060
0.210
0.075
0.055
0.075
0.051
0.130
0.080
0.086
0.135
0.150
0.207
0.180
0.125
0.177
0.162
0.162
0.113
0.105
0.065
0.110
0.192
0.125
0.125
0.148
0.089
0.156
0.092
0.165
0.177
0.180
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.112
0.112
0.125
0.125
0.135

mm

TOTAL
MATL
COILS

1.8
2.0
5.3
6.4
2.5
2.8
2.0
1.8
1.1
2.0
2.3
3.4
2.5
1.5
4.0
5.4
1.5
5.3
1.9
1.4
1.9
1.3
3.3
2.0
2.2
3.4
3.8
5.3
4.6
3.2
4.5
4.1
4.1
2.9
2.7
1.7
2.8
4.9
3.2
3.2
3.8
2.3
4.0
2.3
4.2
4.5
4.6
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
2.8
2.8
3.2
3.2
3.4

13.0
11.5
30.3
60.0
2.75
4.00
3.50
3.00
8.00
5.50
5.00
5.50
4.00
8.00
5.00
8.75
6.00
7.50
8.00
6.00
8.00
9.00
8.00
10.0
12.0
9.25
10.0
16.3
18.0
15.8
36.5
40.0
41.0
4.00
8.00
5.00
4.50
6.50
6.00
6.00
7.00
7.00
8.75
7.25
44.0
43.5
49.0
4.25
4.25
4.38
4.38
4.50
4.50
4.63
4.63
4.63
4.63
4.75
4.75
4.75
4.75
5.13
5.13
5.38
5.38
5.63
5.63
5.75
5.75
5.75
5.75
6.00
6.00
6.00
6.00
6.00
6.00
6.38
6.38
6.63

SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
SST
SST
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
HD
SPR
SPR
SST
SPR
SPR
SST
HD
SPR
SPR
SPR
SPR
SPR
SPR
HD
SPR
SPR
SPR
SPR
MW
SPR
SST
SPR
SPR
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

C
C
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
Z
N
N
N
Z
N
Z
N
N
N
Z
N
N
N
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
Z
GI
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

203

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 204

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.460

37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.08

72802S
72812
72812S
72821
72821S
72834
72834S
72845
72845S
72856
72856S
72787
72787S
72797
72797S
72803
72803S
72813
72813S
72823
72823S
72835
72835S
72847
72847S
72857
72857S
72788
72788S
72798
72798S
72804
72804S
72814
72814S
72825
72825S
72836
72836S
72849
72849S
72858
72858S
72789
72789S
72799
72799S
72805
72805S
72815
72815S
72827
72827S
72837
72837S
72851
72851S
72859
72859S
72860
72860S
72791
72791S
72807
72807S
72829
72829S
72838
72838S
72853
72853S
72861
72861S
72793
72793S
72809
72809S
72831
72831S
72839

2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.25
4.25
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
5.00
5.00
5.00
5.00
5.00
5.00
5.00

O.D.

FREE LENGTH
mm

COMPRESSION SPRINGS

63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
108.0
108.0
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
127.0
127.0
127.0
127.0
127.0
127.0
127.0

MATERIAL: MW - Music Wire

204

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.190
1.164
1.164
1.148
1.148
1.136
1.136
1.106
1.106
1.086
1.086
1.236
1.236
1.210
1.210
1.190
1.190
1.164
1.164
1.148
1.148
1.136
1.136
1.106
1.106
1.086
1.086
1.236
1.236
1.210
1.210
1.190
1.190
1.164
1.164
1.148
1.148
1.136
1.136
1.106
1.106
1.086
1.086
1.236
1.236
1.210
1.210
1.190
1.190
1.164
1.164
1.148
1.148
1.136
1.136
1.106
1.106
1.086
1.086
1.086
1.086
1.236
1.236
1.190
1.190
1.148
1.148
1.136
1.136
1.106
1.106
1.086
1.086
1.236
1.236
1.190
1.190
1.148
1.148
1.136

RATE
mm

30.2
29.6
29.6
29.2
29.2
28.9
28.9
28.1
28.1
27.6
27.6
31.4
31.4
30.7
30.7
30.2
30.2
29.6
29.6
29.2
29.2
28.9
28.9
28.1
28.1
27.6
27.6
31.4
31.4
30.7
30.7
30.2
30.2
29.6
29.6
29.2
29.2
28.9
28.9
28.1
28.1
27.6
27.6
31.4
31.4
30.7
30.7
30.2
30.2
29.6
29.6
29.2
29.2
28.9
28.9
28.1
28.1
27.6
27.6
27.6
27.6
31.4
31.4
30.2
30.2
29.2
29.2
28.9
28.9
28.1
28.1
27.6
27.6
31.4
31.4
30.2
30.2
29.2
29.2
28.9

Lbs./In.

38
62
53
78
66
88
75
128
109
168
143
19
16
28
23
36
31
51
43
63
54
71
61
104
88
138
117
16
14
23
20
31
26
43
36
53
45
60
51
87
74
116
99
14
12
20
17
27
23
37
31
46
39
52
44
75
64
99
84
92
78
14
12
24
20
41
35
46
39
66
56
86
73
13
11
21
18
36
31
41

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

N/mm

6.6
11
9.2
14
12
15
13
22
19
29
25
3.3
2.8
4.8
4.1
6.3
5.4
8.9
7.5
11
9.4
13
11
18
15
24
21
2.8
2.4
4.1
3.5
5.4
4.6
7.5
6.4
9.4
7.9
11
8.9
15
13
20
17
2.4
2.1
3.5
3.0
4.6
3.9
6.5
5.5
8.1
6.9
9.1
7.7
13
11
17
15
16
14
2.4
2.1
4.2
3.6
7.1
6.1
8.0
6.8
12
9.9
15
13
2.2
1.9
3.7
3.2
6.4
5.4
7.1

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

1.2
1.5
1.2
1.4
1.0
1.3
1.0
1.2
.92
1.1
.76
2.2
1.7
2.1
1.7
2.0
1.5
1.8
1.4
1.7
1.3
1.6
1.3
1.5
1.1
1.3
.93
2.6
2.1
2.5
2.0
2.3
1.8
2.1
1.7
2.0
1.5
2.0
1.5
1.8
1.3
1.5
1.1
3.0
2.4
2.8
2.3
2.7
2.1
2.5
2.0
2.4
1.8
2.3
1.7
2.1
1.6
1.8
1.3
1.9
1.4
3.1
2.4
3.1
2.3
2.7
2.0
2.6
2.0
2.4
1.8
2.1
1.5
3.4
2.7
3.4
2.6
3.0
2.2
2.9

mm

32
38
30
36
27
34
26
31
23
27
19
57
44
53
42
50
39
46
36
44
33
42
32
39
29
33
24
67
52
62
50
59
46
55
43
52
39
50
38
46
34
39
28
77
61
72
58
68
53
63
50
60
45
57
44
53
40
46
33
49
35
79
61
77
59
68
51
65
50
60
45
53
38
88
67
87
66
76
57
73

Lbs.

47
92
62
109
69
118
77
156
100
179
109
42
28
57
39
71
47
92
62
109
69
117
77
158
100
179
109
42
28
57
39
71
47
92
62
109
69
118
77
157
100
179
109
42
28
57
39
71
47
92
62
109
69
117
77
156
100
179
109
179
109
43
28
73
47
109
69
118
77
156
100
179
109
43
28
73
47
109
69
117

209
409
274
485
307
526
343
693
445
795
484
188
125
255
173
317
209
409
274
485
307
522
343
701
445
795
484
188
125
254
173
316
209
408
274
485
307
524
343
698
445
795
484
188
125
256
173
316
209
409
274
485
307
522
343
695
445
795
484
795
484
192
125
324
209
485
307
524
343
694
445
795
484
192
125
324
209
485
307
522

ENDS: C - Closed

G - Ground
O - Open

Inches

.89
1.02
1.02
1.07
1.07
1.15
1.15
1.28
1.28
1.33
1.33
.77
.77
.92
.92
1.03
1.03
1.18
1.18
1.25
1.25
1.36
1.36
1.48
1.48
1.52
1.52
.87
.87
1.05
1.05
1.18
1.18
1.35
1.35
1.44
1.44
1.54
1.54
1.70
1.70
1.75
1.75
.97
.97
1.16
1.16
1.32
1.32
1.52
1.52
1.60
1.60
1.74
1.74
1.92
1.92
1.99
1.99
2.10
2.10
.97
.97
1.43
1.43
1.77
1.77
1.92
1.92
2.15
2.15
2.22
2.22
1.05
1.05
1.57
1.57
1.97
1.97
2.13

mm

22.7
25.8
25.8
27.2
27.2
29.3
29.3
32.6
32.6
33.8
33.8
19.6
19.6
23.4
23.4
26.1
26.1
30.1
30.1
31.7
31.7
34.5
34.5
37.7
37.7
38.6
38.6
22.0
22.0
26.6
26.6
30.0
30.0
34.3
34.3
36.7
36.7
39.1
39.1
43.3
43.3
44.5
44.5
24.5
24.5
29.4
29.4
33.4
33.4
38.5
38.5
40.6
40.6
44.2
44.2
48.9
48.9
50.5
50.5
53.4
53.4
24.5
24.5
36.4
36.4
45.1
45.1
48.9
48.9
54.5
54.5
56.4
56.4
26.7
26.7
39.9
39.9
50.0
50.0
54.0

WIRE DIA.
Inches

0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.187
0.187
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.187
0.187
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.187
0.187
0.112
0.112
0.125
0.125
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.187
0.187
0.187
0.187
0.112
0.112
0.135
0.135
0.156
0.156
0.162
0.162
0.177
0.177
0.187
0.187
0.112
0.112
0.135
0.135
0.156
0.156
0.162

mm

TOTAL
MATL
COILS

3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.7
4.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.7
4.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.7
4.7
2.8
2.8
3.2
3.2
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.7
4.7
4.7
4.7
2.8
2.8
3.4
3.4
4.0
4.0
4.1
4.1
4.5
4.5
4.7
4.7
2.8
2.8
3.4
3.4
4.0
4.0
4.1

6.63
6.88
6.88
6.88
6.88
7.13
7.13
7.25
7.25
7.13
7.13
6.88
6.88
7.38
7.38
7.63
7.63
8.00
8.00
8.00
8.00
8.38
8.38
8.38
8.38
8.13
8.13
7.75
7.75
8.38
8.38
8.75
8.75
9.13
9.13
9.25
9.25
9.50
9.50
9.63
9.63
9.38
9.38
8.63
8.63
9.25
9.25
9.75
9.75
10.3
10.3
10.3
10.3
10.8
10.8
10.9
10.9
10.6
10.6
11.3
11.3
8.63
8.63
10.6
10.6
11.4
11.4
11.9
11.9
12.1
12.1
11.9
11.9
9.38
9.38
11.6
11.6
12.6
12.6
13.1

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 205

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

1.460
1.460
1.460
1.460
1.460
1.460
1.460
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.468
1.484
1.484
1.484
1.484
1.484
1.484
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500

37.08
37.08
37.08
37.08
37.08
37.08
37.08
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.29
37.69
37.69
37.69
37.69
37.69
37.69
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10

72839S
72855
72855S
72862
72862S
72863
72863S
S-3052
1853
3496
3456
11426
S-1669
S-1358
S-1443
S-3192
S-1632
11881
S-987
10336
10368
10317
1743
S-1595
10048
S-3057
10204
10371
S-3165
11496
S-3222
B17-200
S-1598
S-3066
S-3184
12270
12440
S-970
S-3216
10388
11172
S-1603
S-383
3023
S-1655
12412
1735
11898
3804
12635
S-1197
S-3032
11471
12544
10405
3647
10145
12645
S-290
10569
10666
74
947
11140
11147
S-1263
10606
B17-181
S-1673
10392
3015
S-329
531
S-1602
B18-174
10372
11970
S-3230
S-1327
S-1649

5.00
5.00
5.00
5.00
5.00
5.25
5.25
.69
1.00
1.31
1.31
1.50
1.56
1.75
1.84
2.00
2.06
2.13
2.13
2.19
2.25
2.38
2.41
2.44
2.44
2.50
2.50
2.53
2.69
2.75
3.00
3.28
3.50
3.63
4.50
4.59
4.81
5.13
5.25
5.75
6.00
1.53
3.25
3.38
3.75
5.00
9.00
.84
1.25
1.56
1.75
1.75
1.75
1.75
1.94
2.06
2.13
2.25
2.25
2.44
2.50
2.50
2.50
2.56
2.56
2.63
2.69
2.75
2.78
3.00
3.06
3.25
3.25
3.31
3.31
3.63
3.75
3.78
4.00
4.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

127.0
127.0
127.0
127.0
127.0
133.4
133.4
17.4
25.4
33.3
33.3
38.1
39.7
44.5
46.8
50.8
52.4
54.0
54.0
55.6
57.2
60.3
61.1
61.9
61.9
63.5
63.5
64.3
68.2
69.9
76.2
83.3
88.9
92.1
114.3
116.7
122.2
130.2
133.4
146.1
152.4
38.9
82.6
85.7
95.3
127.0
228.6
21.4
31.8
39.7
44.5
44.5
44.5
44.5
49.2
52.4
54.0
57.2
57.2
61.9
63.5
63.5
63.5
65.1
65.1
66.7
68.2
69.9
70.6
76.2
77.8
82.6
82.6
84.1
84.1
92.1
95.3
96.0
101.6
101.6

I.D.
Inches

1.136
1.106
1.106
1.086
1.086
1.086
1.086
1.410
1.198
1.258
1.018
1.054
1.308
1.268
1.054
1.272
1.094
1.230
1.226
.718
1.084
1.068
1.304
1.258
1.054
1.284
1.084
1.068
1.258
1.048
1.172
1.232
1.310
1.298
1.268
1.298
1.032
1.240
1.310
1.030
1.028
1.072
1.274
1.172
1.070
1.380
1.160
1.230
1.290
1.184
1.380
1.374
1.340
1.188
1.274
1.376
1.086
1.340
1.250
1.098
1.264
1.230
1.086
1.260
1.086
1.318
1.032
.988
1.262
.976
1.220
1.404
1.204
1.340
1.050
1.064
1.174
1.086
1.392
1.240

RATE
mm

28.9
28.1
28.1
27.6
27.6
27.6
27.6
35.8
30.4
32.0
25.9
26.8
33.2
32.2
26.8
32.3
27.8
31.2
31.1
18.2
27.5
27.1
33.1
32.0
26.8
32.6
27.5
27.1
32.0
26.6
29.8
31.3
33.3
33.0
32.2
33.0
26.2
31.5
33.3
26.2
26.1
27.2
32.4
29.8
27.2
35.1
29.5
31.2
32.8
30.1
35.1
34.9
34.0
30.2
32.4
35.0
27.6
34.0
31.8
27.9
32.1
31.2
27.6
32.0
27.6
33.5
26.2
25.1
32.1
24.8
31.0
35.7
30.6
34.0
26.7
27.0
29.8
27.6
35.4
31.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

35
6.1
59
10
50
8.8
77
13
65
11
73
13
62
11
.30
.05
134
24
28
4.8
959 168
389
68
13
2.3
24
4.3
327
57
18
3.2
212
37
39
6.9
35
6.2
7917 1386
235
41
215
38
4.9
.85
7.9
1.4
251
44
11
2.0
235
41
215
38
12
2.1
234
41
53
9.3
17
2.9
2.3
.41
5.5
.96
7.5
1.3
3.5
.62
148
26
8.8
1.5
1.6
.28
148
26
161
28
367
64
13
2.3
61
11
125
22
.80
.14
20
3.6
125
22
32
5.6
185
32
2.0
.35
2.5
.44
6.3
1.1
140
25
27
4.7
2.4
.42
376
66
4.0
.70
59
10
204
36
25
4.4
42
7.3
244
43
28
5.0
349
61
6.8
1.2
405
71
583 102
18
3.2
595 104
40
7.0
.29
.05
43
7.5
2.8
.49
245
43
193
34
71
12
120
21
.56
.10
17
2.9

Inches

mm

2.2
57
2.7
67
2.0
51
2.3
59
1.7
42
2.4
62
1.8
45
.57 15
.39
9.8
.84 21
.22
5.5
.37
9.5
.88 22
.86 22
.45 11
1.1
27
.51 13
.94 24
1.0
25
.10
2.6
.58 15
.71 18
1.8
44
1.3
33
.67 17
1.4
36
.58 15
.71 18
2.0
50
.75 19
1.2
29
2.0
50
2.6
67
2.5
63
2.8
71
3.7
95
1.3
34
3.4
85
4.2 106
1.3
34
1.2
31
.30
7.5
1.9
47
1.3
32
1.2
29
4.4 112
4.2 107
.37
9.3
.80 20
.60 15
1.4
36
1.4
36
1.3
34
.61 15
1.1
29
1.7
43
.44 11
1.7
44
.65 16
.75 19
1.4
36
1.2
31
.68 17
1.3
33
.48 12
2.0
52
.56 14
.51 13
1.8
45
.51 13
1.4
36
2.7
70
1.6
39
2.6
65
.83 21
1.0
25
1.2
31
1.2
30
3.5
89
2.5
62

ENDS: C - Closed

G - Ground
O - Open

Lbs.

77
157
100
179
109
179
109

343
698
445
795
484
795
484

.17
.75
52
231
23
103
207
922
146
648
11
51
21
93
146
648
20
88
108
482
37
163
35
157
799 3554
136
604
153
680
8.5
38
10
46
169
752
16
73
136
604
153
680
23
104
176
784
61
272
33
145
6.1
27
14
61
21
93
13
59
196
874
30
131
6.7
30
199
886
194
864
108
481
24
107
77
341
144
641
3.5
16
86
381
46
203
26
114
110
491
2.8
12
3.5
16
8.4
37
85
380
31
137
4.0
18
166
737
6.9
31
38
169
152
677
35
156
51
226
166
737
37
164
166
737
14
62
228 1014
295 1313
33
146
305 1357
57
251
.79
3.5
67
296
7.2
32
203
905
193
857
86
384
143
635
2.0
8.8
41
182

Inches

2.13
2.35
2.35
2.45
2.45
2.55
2.55
.12
.47
.47
.90
1.04
.28
.40
1.14
.44
1.03
.60
.60
1.78
1.15
1.45
.66
1.13
1.50
.55
1.15
1.45
.74
1.89
1.04
.94
.87
.55
.85
.85
2.89
1.33
1.07
2.96
3.03
1.24
.68
1.25
2.28
.39
3.73
.45
.42
.79
.35
.34
.42
.86
.59
.37
1.09
.52
.50
1.46
.74
.88
1.45
.72
1.14
.59
1.70
1.92
.86
2.10
1.05
.50
1.26
.76
2.08
2.18
1.30
2.28
.50
1.37

mm

Inches

54.0
59.6
59.6
62.3
62.3
64.7
64.7
2.9
12.0
12.0
22.9
26.3
7.1
10.2
28.9
11.2
26.1
15.1
15.2
45.2
29.3
36.8
16.7
28.7
38.1
14.0
29.3
36.8
18.7
48.0
26.3
24.0
22.1
14.0
21.6
21.6
73.4
33.8
27.1
75.1
76.8
31.4
17.3
31.7
57.8
9.9
94.6
11.4
10.7
20.1
8.8
8.7
10.7
21.8
15.1
9.4
27.6
13.2
12.7
37.0
18.7
22.3
36.8
18.3
28.9
15.0
43.1
48.8
21.9
53.2
26.7
12.8
32.0
19.3
52.9
55.4
33.1
57.8
12.7
34.7

0.162
0.177
0.177
0.187
0.187
0.187
0.187
0.029
0.135
0.105
0.225
0.207
0.080
0.100
0.207
0.098
0.187
0.119
0.121
0.375
0.192
0.200
0.082
0.105
0.207
0.092
0.192
0.200
0.105
0.210
0.148
0.118
0.079
0.085
0.100
0.085
0.218
0.114
0.079
0.219
0.220
0.206
0.105
0.156
0.207
0.052
0.162
0.135
0.105
0.158
0.060
0.063
0.080
0.156
0.113
0.062
0.207
0.080
0.125
0.201
0.118
0.135
0.207
0.120
0.207
0.091
0.234
0.256
0.119
0.262
0.140
0.048
0.148
0.080
0.225
0.218
0.163
0.207
0.054
0.130

mm

TOTAL
MATL
COILS

4.1
4.5
4.5
4.7
4.7
4.7
4.7
0.7
3.4
2.7
5.7
5.3
2.0
2.5
5.3
2.5
4.7
3.0
3.1
9.5
4.9
5.1
2.1
2.7
5.3
2.3
4.9
5.1
2.7
5.3
3.8
3.0
2.0
2.2
2.5
2.2
5.5
2.9
2.0
5.6
5.6
5.2
2.7
4.0
5.3
1.3
4.1
3.4
2.7
4.0
1.5
1.6
2.0
4.0
2.9
1.6
5.3
2.0
3.2
5.1
3.0
3.4
5.3
3.0
5.3
2.3
5.9
6.5
3.0
6.7
3.6
1.2
3.8
2.0
5.7
5.5
4.1
5.3
1.4
3.3

13.1
13.3
13.3
13.1
13.1
13.6
13.6
3.00
3.50
4.50
4.00
5.00
3.50
4.00
5.50
4.50
5.50
5.00
5.00
4.75
6.00
7.25
7.00
9.75
7.25
5.00
6.00
7.25
7.00
8.00
7.00
8.00
10.0
6.50
8.50
10.0
13.3
11.7
13.5
13.5
12.8
5.00
6.50
8.00
11.0
6.50
23.0
3.33
4.00
4.00
4.75
4.50
5.25
4.50
5.25
5.00
5.25
6.50
4.00
7.25
6.25
6.50
7.00
6.00
5.50
6.50
7.25
7.50
7.25
8.00
7.50
9.50
8.50
8.50
9.25
10.0
8.00
11.0
8.25
10.5

SST
MW
SST
MW
SST
MW
SST
SST
SPR
SPR
SPR
SST
SST
SST
SST
SST
SST
SPR
SST
SPR
SPR
SPR
HD
SST
SPR
SST
SPR
SPR
SST
SPR
SST
SST
SST
SST
SST
SPR
SPR
SST
SST
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SST
SPR
MW
SST
SST
HD
OT
SPR
SPR
SPR
SST
SST
SPR
SPR
HD
HD
HD
SPR
SST
SPR
SPR
SST
SPR
SPR
SST
HD
SST
SPR
SPR
SPR
SST
SST
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
C
C
C
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG

F
N
S
H

N
N
N
N
N
N
N
N
Z
Z
Z
N
N
N
N
N
N
N
N
Z
Z
Z
Z
N
Z
N
Z
Z
N
Z
N
N
N
N
N
Z
Z
N
N
Z
Z
N
N
Z
N
Z
Z
N
Z
N
N
N
Z
N
N
Z
Z
N
N
Z
Z
Z
Z
Z
Z
N
Z
Z
N
Z
Z
N
Z
N
N
Z
Z
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

205

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 206

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.500
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.515
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.531
1.546
1.546
1.546
1.546
1.546
1.546
1.546
1.546
1.546
1.546
1.546
1.546
1.546
1.550
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562

38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.10
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.48
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
38.89
39.27
39.27
39.27
39.27
39.27
39.27
39.27
39.27
39.27
39.27
39.27
39.27
39.27
39.37
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67

32
11514
3380
S-3167
11976
4259
3135
12042
2847
7058
S-467
7009
3440
3378
S-985
846
12152
4222
10256
863
532
851
842
804
835
12679
S-989
S-288
11872
11178
2923
2775
11116
1519
S-3092
S-109
2706
3323
3418
3414
11262
11155
S-1648
1675
10648
S-85
S-405
11152
4397
10391
10319
10835
4242
S-3111
4115
S-449
10324
10947
1721
11156
4335
11224
S-98
12011
11979
B8-68
S-1134
4169
S-455
7010
12057
11154
10428
10318
10131
3348
3355
10333
3701
11170

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

4.00
4.16
4.25
4.50
4.50
4.50
4.56
4.59
4.88
5.00
5.13
5.88
6.00
6.75
6.88
8.00
8.63
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
1.50
1.91
2.13
2.16
2.31
2.50
2.50
2.50
2.75
3.00
3.00
4.84
6.75
6.75
8.50
1.19
1.25
1.41
1.50
1.63
2.00
2.00
2.19
2.22
2.25
2.44
3.00
3.00
3.38
4.25
6.50
1.25
1.28
1.38
1.50
1.63
1.75
2.19
2.38
3.25
4.09
4.50
6.25
7.00
4.98
1.06
1.13
1.19
1.25
1.28
1.38
1.88
2.00
2.38
2.56

mm

101.6
105.6
108.0
114.3
114.3
114.3
115.9
116.7
123.8
127.0
130.2
149.2
152.4
171.5
174.6
203.2
219.1
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
38.1
48.4
54.0
54.8
58.7
63.5
63.5
63.5
69.9
76.2
76.2
123.0
171.5
171.5
215.9
30.2
31.8
35.7
38.1
41.3
50.8
50.8
55.6
56.4
57.2
61.9
76.2
76.2
85.7
108.0
165.1
31.8
32.5
34.9
38.1
41.3
44.5
55.6
60.3
82.6
104.0
114.3
158.8
177.8
126.4
27.0
28.6
30.2
31.8
32.5
34.9
47.6
50.8
60.3
65.1

MATERIAL: MW - Music Wire

206

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.230
1.282
1.286
1.300
1.260
1.012
1.300
1.250
1.176
1.032
1.250
1.050
1.290
1.070
1.250
1.146
1.156
1.290
1.116
1.230
1.204
1.176
1.116
1.086
1.050
1.203
1.135
1.371
1.141
1.099
1.245
1.227
1.141
1.075
1.279
1.015
1.191
1.105
1.075
1.065
1.247
1.247
1.321
1.399
1.371
1.387
1.147
1.091
1.321
1.105
1.117
1.305
1.207
1.321
.907
1.147
1.276
1.276
1.402
1.134
1.266
1.310
1.172
1.276
1.262
1.296
1.452
1.246
1.366
1.096
1.322
1.266
1.266
1.250
1.250
1.418
1.312
1.148
1.444
1.188

RATE
mm

31.2
32.6
32.7
33.0
32.0
25.7
33.0
31.8
29.9
26.2
31.8
26.7
32.8
27.2
31.8
29.1
29.4
32.8
28.3
31.2
30.6
29.9
28.3
27.6
26.7
30.6
28.8
34.8
29.0
27.9
31.6
31.2
29.0
27.3
32.5
25.8
30.3
28.1
27.3
27.1
31.7
31.7
33.6
35.5
34.8
35.2
29.1
27.7
33.6
28.1
28.4
33.1
30.7
33.6
23.0
29.1
32.4
32.4
35.6
28.8
32.2
33.3
29.8
32.4
32.1
32.9
36.9
31.6
34.7
27.8
33.6
32.2
32.2
31.8
31.8
36.0
33.3
29.2
36.7
30.2

Lbs./In.

N/mm

24
4.2
11
1.9
10
1.7
7.3
1.3
22
3.8
321
56
8.3
1.4
16
2.8
57
10
161
28
9.8
1.7
125
22
4.0
.70
90
16
9.0
1.6
31
5.5
27
4.7
2.9
.50
49
8.6
7.5
1.3
11
1.8
17
2.9
29
5.0
39
6.9
57
9.9
151
26
204
36
2.5
.44
214
38
344
60
28
5.0
37
6.5
214
38
312
55
12
2.1
322
56
57
10
71
12
97
17
86
15
77
14
97
17
21
3.7
3.3
.57
6.4
1.1
3.9
.69
202
35
498
87
13
2.2
431
75
284
50
17
3.0
110
19
12
2.0
1003 176
46
8.0
113
20
62
11
5.4
.94
269
47
114
20
28
5.0
187
33
57
9.9
38
6.7
14
2.4
.13
.02
21
3.7
1.7
.29
157
27
66
12
122
21
108
19
175
31
153
27
9.3
1.6
47
8.3
250
44
1.5
.26
169
30

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

2.1
2.7
2.7
2.8
1.7
.80
2.7
2.6
1.5
1.2
3.4
1.6
4.1
2.0
4.2
3.5
3.8
7.4
2.7
6.8
6.3
5.1
4.7
4.2
3.6
.50
.54
1.7
.57
.48
1.2
1.1
.57
.660
1.8
.63
1.5
2.3
1.9
2.3
.55
.60
.93
1.1
1.2
1.6
.56
.38
1.5
.41
.57
1.6
.75
2.0
.48
2.5
.44
.64
1.0
.26
.48
1.1
.55
.87
1.5
2.7
3.7
3.1
5.4
1.3
.54
.53
.56
.42
.48
.90
.85
.64
2.1
.70

mm

Lbs.

53
68
69
72
43
20
68
67
38
30
86
41
104
52
107
89
96
189
69
172
161
130
118
107
91
13
14
42
14
12
30
29
14
16.76
45
16
37
57
50
60
14
15
24
29
31
40
14
9.5
38
10
15
41
19
51
12
63
11
16
25
6.7
12
28
14
22
38
69
94
78
137
33
14
13
14
11
12
23
21
16
52
18

51
226
29
128
27
121
21
92
37
164
257 1143
22
99
42
185
85
377
192
853
33
147
203
905
17
74
185
823
38
169
110
489
101
449
21
95
133
592
51
226
67
296
85
377
133
592
166
737
203
905
75
334
110
490
4.1
18
122
543
167
741
34
150
42
186
122
543
206
922
21
93
201
894
84
373
160
710
189
840
202
897
42
189
58
257
20
89
3.7
16
7.9
35
6.2
28
113
501
187
832
19
85
177
787
163
724
28
123
83
370
23
104
478 2128
113
501
49
219
40
176
5.3
24
71
316
55
244
31
138
103
459
49
219
57
255
37
164
.48
2.1
66
292
9.0
40
203
901
35
158
64
285
61
270
73
325
73
325
8.4
37
40
178
160
711
3.0
13
119
528

ENDS: C - Closed

G - Ground
O - Open

Inches

1.32
1.09
1.07
.83
.87
2.44
.83
1.31
1.50
3.39
1.75
3.90
1.89
3.87
1.88
3.81
3.78
2.57
3.98
3.65
4.37
4.54
6.24
6.83
7.50
.82
1.05
.47
1.03
1.14
1.31
1.37
1.03
1.69
1.24
2.38
1.46
3.69
3.96
4.95
.64
.60
.47
.37
.40
.41
1.06
1.10
.71
1.07
1.24
.71
.89
.68
2.96
3.36
.47
.64
.38
1.24
.53
.59
.98
.68
1.07
1.25
.80
2.18
1.61
3.06
.42
.59
.63
.59
.62
.31
.56
1.29
.32
1.12

mm

33.4
27.7
27.2
21.0
22.1
62.0
21.2
33.3
38.1
86.2
44.5
99.1
48.0
98.3
47.6
96.7
96.1
65.3
101.2
92.6
110.9
115.2
158.5
173.5
190.5
20.8
26.5
11.9
26.1
29.1
33.2
34.7
26.1
42.9
31.5
60.3
37.0
93.7
100.6
125.7
16.2
15.3
12.0
9.5
10.2
10.5
26.8
27.9
18.0
27.1
31.5
17.9
22.6
17.3
75.3
85.3
12.0
16.3
9.6
31.4
13.3
15.0
24.9
17.1
27.1
31.8
20.3
55.2
40.9
77.7
10.7
15.0
16.0
14.9
15.8
7.8
14.3
32.9
8.2
28.5

WIRE DIA.
Inches

0.135
0.109
0.107
0.100
0.120
0.244
0.100
0.125
0.162
0.234
0.125
0.225
0.105
0.215
0.125
0.177
0.172
0.105
0.192
0.135
0.148
0.162
0.192
0.207
0.225
0.156
0.190
0.072
0.187
0.208
0.135
0.144
0.187
0.225
0.118
0.250
0.162
0.205
0.220
0.225
0.142
0.142
0.105
0.066
0.080
0.072
0.192
0.220
0.105
0.213
0.207
0.113
0.162
0.105
0.312
0.192
0.135
0.135
0.072
0.206
0.140
0.118
0.187
0.135
0.142
0.125
0.047
0.150
0.090
0.227
0.120
0.148
0.148
0.156
0.156
0.072
0.125
0.207
0.059
0.187

mm

TOTAL
MATL
COILS

3.4
2.8
2.7
2.5
3.0
6.2
2.5
3.2
4.1
5.9
3.2
5.7
2.7
5.5
3.2
4.5
4.4
2.7
4.9
3.4
3.8
4.1
4.9
5.3
5.7
4.0
4.8
1.8
4.7
5.3
3.4
3.7
4.7
5.72
3.0
6.4
4.1
5.2
5.6
5.7
3.6
3.6
2.7
1.7
2.0
1.8
4.9
5.6
2.7
5.4
5.3
2.9
4.1
2.7
7.9
4.9
3.4
3.4
1.8
5.2
3.6
3.0
4.7
3.4
3.6
3.2
1.2
3.8
2.3
5.8
3.0
3.8
3.8
4.0
4.0
1.8
3.2
5.3
1.5
4.7

9.75
9.00
9.00
8.25
7.25
10.0
8.33
10.5
9.25
13.5
14.0
16.3
18.0
18.0
15.0
21.5
22.0
24.5
19.8
27.0
28.5
27.0
32.5
33.0
33.3
4.25
5.50
6.50
5.50
5.50
8.67
8.50
5.50
7.50
9.50
9.50
9.00
18.0
18.0
22.0
4.50
4.25
4.50
4.67
5.00
4.75
5.50
5.00
6.75
5.00
6.00
6.25
5.50
6.50
9.50
17.5
3.50
4.75
4.25
6.00
3.75
5.00
5.25
5.00
7.50
10.0
16.0
14.5
18.0
12.5
3.50
4.00
4.25
3.75
4.00
3.25
4.50
6.25
5.50
6.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

HD
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
HD
SPR
SPR
SST
HD
SPR
SPR
SPR
HD
HD
HD
HD
HD
HD
SPR
SST
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SST
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SST
SST
SPR
SST
HD
SPR
SPR
SPR
SPR
SPR
HD
HD
SPR
SPR
SPR

E
N
D
S

CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
C
C
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG

F
N
S
H

Z
Z
Z
N
Z
Z
Z
Z
Z
N
N
Z
Z
Z
N
Z
Z
Z
GI
Z
Z
Z
Z
Z
Z
N
N
N
N
Z
Z
Z
N
Z
N
N
Z
Z
Z
Z
N
Z
N
Z
Z
N
N
Z
N
Z
Z
N
Z
N
Z
N
Z
Z
Z
Z
Z
N
N
Z
Z
N
N
GI
N
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 207

Inches

mm

CENTURY
STOCK
NUMBER

1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.562
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.578
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.580
1.593
1.593
1.593
1.593
1.593
1.593
1.593
1.593
1.609
1.609
1.609
1.609
1.609
1.609
1.609
1.609
1.609
1.609
1.609
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625
1.625

39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
39.67
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.08
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.13
40.46
40.46
40.46
40.46
40.46
40.46
40.46
40.46
40.87
40.87
40.87
40.87
40.87
40.87
40.87
40.87
40.87
40.87
40.87
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28
41.28

11177
11996
852
S-314
4346
895
812
678
11669
3244
10570
S-3110
11509
911
2735
12276
11148
3358
10349
S-162
S-3227
11774
10329
11629
S-3189
10689
3486
S-298
S-3193
11965
72864
72864S
72865
72865S
72866
72866S
72867
72867S
72868
72868S
72869
72869S
72870
72870S
72871
72871S
11608
S-1600
3428
S-991
10825
3641
3109
S-359
10451
2717
11957
10507
11119
3220
11641
11757
12089
4393
3445
S-1170
4350
10893
3408
10543
1535
10045
10015
10101
10362
S-240
3294
S-84
S-275
12119

O.D.

FREE LENGTH
Inches

2.56
2.63
2.75
3.16
3.63
4.00
4.25
4.38
4.84
5.00
5.00
5.50
6.41
7.50
11.4
1.00
1.25
1.31
1.56
1.63
1.72
2.38
2.44
2.50
3.00
3.38
3.75
4.16
6.75
7.69
2.50
2.50
3.00
3.00
3.50
3.50
4.00
4.00
4.50
4.50
5.00
5.00
5.50
5.50
6.00
6.00
1.88
2.25
2.50
2.63
4.25
5.00
5.13
5.13
1.28
1.56
1.69
2.00
2.41
2.50
2.59
4.00
4.94
7.00
7.75
.50
1.00
1.03
1.19
1.28
1.58
1.63
1.63
2.25
2.44
2.50
2.63
3.50
3.75
3.84

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

65.1
66.7
69.9
80.2
92.1
101.6
108.0
111.1
123.0
127.0
127.0
139.7
162.7
190.5
290.5
25.4
31.8
33.3
39.7
41.3
43.6
60.3
61.9
63.5
76.2
85.7
95.3
105.6
171.5
195.2
63.5
63.5
76.2
76.2
88.9
88.9
101.6
101.6
114.3
114.3
127.0
127.0
139.7
139.7
152.4
152.4
47.6
57.2
63.5
66.7
108.0
127.0
130.2
130.2
32.5
39.7
42.8
50.8
61.1
63.5
65.9
101.6
125.4
177.8
196.9
12.7
25.4
26.2
30.2
32.5
40.1
41.3
41.3
57.2
61.9
63.5
66.7
88.9
95.3
97.6

I.D.
Inches

1.188
.876
1.238
1.436
1.178
.996
1.208
1.076
1.478
1.202
1.108
1.380
1.260
1.266
1.362
1.496
1.266
1.204
1.368
1.426
1.394
1.462
1.164
1.338
1.308
1.458
1.328
1.404
1.398
1.190
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.166
1.181
1.347
1.343
1.417
1.351
1.453
1.343
1.179
1.277
1.409
1.423
1.383
1.169
1.255
1.427
1.427
1.469
1.159
1.219
1.375
1.301
1.543
1.287
1.301
1.415
1.481
1.001
1.175
1.189
1.501
1.281
1.241
1.375
1.375

RATE
mm

30.2
22.3
31.4
36.5
29.9
25.3
30.7
27.3
37.5
30.5
28.1
35.1
32.0
32.2
34.6
38.0
32.2
30.6
34.7
36.2
35.4
37.1
29.6
34.0
33.2
37.0
33.7
35.7
35.5
30.2
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
29.6
30.0
34.2
34.1
36.0
34.3
36.9
34.1
29.9
32.4
35.8
36.1
35.1
29.7
31.9
36.2
36.2
37.3
29.4
31.0
34.9
33.0
39.2
32.7
33.0
35.9
37.6
25.4
29.8
30.2
38.1
32.5
31.5
34.9
34.9

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

225
39
2312 405
69
12
2.1
.37
76
13
497
87
57
10
213
37
.07
.01
54
9.5
153
27
4.7
.82
20
3.5
15
2.6
2.9
.51
.37
.07
169
30
435
76
14
2.4
2.9
.51
5.6
.97
1.9
.32
241
42
14
2.4
28
4.8
.74
.13
16
2.9
4.8
.84
1.7
.30
52
9.1
210
37
179
31
170
30
145
25
142
25
121
21
121
21
103
18
107
19
91
16
95
17
81
14
86
15
73
13
79
14
67
12
243
42
15
2.7
16
2.8
7.3
1.3
19
3.4
1.2
.21
11
1.9
108
19
208
36
8.4
1.5
5.5
.96
16
2.7
343
60
96
17
9.4
1.6
4.2
.73
1.2
.21
93
16
49
8.6
90
16
316
55
.30
.05
380
67
181
32
15
2.7
5.2
.90
3009 527
448
78
359
63
1.8
.32
117
21
115
20
14
2.4
12
2.1

.53
.26
1.2
2.6
1.3
.74
1.9
1.2
4.0
2.0
1.3
3.2
3.3
4.3
7.3
.75
.43
.27
.93
1.2
1.1
2.1
.66
1.4
1.6
2.8
2.4
2.8
5.2
2.5
1.1
.76
1.3
.94
1.6
1.1
1.8
1.3
2.1
1.5
2.4
1.7
2.6
1.9
2.8
2.0
.43
1.1
1.4
1.9
1.8
4.3
3.5
1.3
.41
.76
1.0
1.3
.44
1.1
1.7
3.2
4.2
2.1
2.7
.13
.25
.79
.23
.44
1.0
1.3
.15
.42
.50
2.2
.80
.92
2.5
2.5

mm

13
6.6
30
66
34
19
47
29
103
50
33
81
84
110
186
19
11
6.9
24
29
27
54
17
36
40
70
62
72
133
64
27
19
33
24
40
29
47
34
53
38
60
43
66
47
72
52
11
29
35
48
47
109
89
32
10
19
26
32
11
27
42
81
108
52
68
3.2
6.3
20
6.0
11
26
32
3.8
11
13
55
20
23
64
64

ENDS: C - Closed

G - Ground
O - Open

Lbs.

119
528
599 2665
82
363
5.6
25
100
446
367 1633
106
471
245 1090
.30
1.3
106
472
201
895
15
67
66
295
64
285
21
95
.28
1.3
72
322
118
523
13
57
3.3
15
6.0
27
3.9
17
158
704
20
87
44
194
2.0
9.0
40
176
14
61
8.8
39
131
583
223
994
136
606
223
994
136
606
223
994
136
606
223
994
136
606
223
994
136
606
223
994
136
606
223
994
136
606
223
994
136
606
105
467
18
78
22
97
14
62
36
159
5.3
23
39
173
135
601
85
379
6.4
28
5.7
25
20
88
151
670
103
458
16
70
13
59
5.0
22
191
849
131
581
11
50
79
350
.24
1.1
89
396
79
350
16
70
6.5
29
456 2026
189
842
179
797
4.0
18
94
417
106
474
35
156
31
138

Inches

.94
2.32
1.17
.36
2.30
3.08
2.01
2.98
.80
2.25
3.07
.71
2.47
2.74
1.78
.25
.59
.65
.63
.48
.64
.26
1.29
1.08
.95
.62
1.13
.57
1.53
3.1
1.42
1.42
1.66
1.66
1.89
1.89
2.15
2.15
2.38
2.38
2.64
2.64
2.87
2.87
3.08
3.08
1.44
1.11
1.13
.44
.97
.70
1.63
2.07
.62
.80
.65
.74
1.16
1.24
.55
.80
.70
3.83
3.32
.38
.49
.25
.51
.61
.55
.36
1.25
1.13
1.15
.35
.95
1.54
1.06
1.31

mm

Inches

23.7
58.8
29.8
9.2
58.5
78.2
51.0
75.6
20.3
57.2
77.9
17.9
62.6
69.5
45.1
6.2
14.9
16.6
16.0
12.1
16.4
6.6
32.9
27.4
24.0
15.6
28.6
14.4
38.9
78.7
36.1
36.1
42.1
42.1
48.0
48.0
54.5
54.5
60.5
60.5
67.0
67.0
73.0
73.0
78.2
78.2
36.6
28.1
28.6
11.2
24.6
17.8
41.3
52.6
15.8
20.3
16.5
18.7
29.3
31.5
13.9
20.2
17.8
97.2
84.2
9.5
12.3
6.2
12.9
15.4
14.0
9.1
31.7
28.6
29.1
8.9
24.0
39.0
27.0
33.3

0.187
0.343
0.162
0.063
0.192
0.283
0.177
0.243
0.042
0.180
0.227
0.091
0.151
0.148
0.100
0.041
0.156
0.187
0.105
0.076
0.092
0.058
0.207
0.120
0.135
0.060
0.125
0.087
0.090
0.192
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.207
0.206
0.123
0.125
0.088
0.121
0.070
0.125
0.207
0.166
0.100
0.093
0.113
0.220
0.177
0.091
0.091
0.070
0.225
0.195
0.125
0.162
0.041
0.169
0.162
0.105
0.072
0.312
0.225
0.218
0.062
0.172
0.192
0.125
0.125

mm

TOTAL
MATL
COILS

4.7
8.7
4.1
1.6
4.9
7.2
4.5
6.2
1.1
4.6
5.8
2.3
3.8
3.8
2.5
1.0
4.0
4.7
2.7
1.9
2.3
1.5
5.3
3.0
3.4
1.5
3.2
2.2
2.3
4.9
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.3
5.2
3.1
3.2
2.2
3.1
1.8
3.2
5.3
4.2
2.5
2.4
2.9
5.6
4.5
2.3
2.3
1.8
5.7
5.0
3.2
4.1
1.0
4.3
4.1
2.7
1.8
7.9
5.7
5.5
1.6
4.4
4.9
3.2
3.2

5.00
6.75
7.25
4.75
12.0
11.0
11.3
12.3
19.0
12.5
12.5
7.75
15.3
18.5
17.8
5.00
3.75
3.50
6.00
6.25
7.00
4.50
6.25
9.00
7.00
9.25
9.00
6.50
17.0
16.1
6.88
6.88
8.00
8.00
9.13
9.13
10.4
10.4
11.5
11.5
12.8
12.8
13.9
13.9
14.9
14.9
6.00
8.00
9.00
5.00
7.00
10.0
12.0
10.0
3.75
7.00
7.00
6.50
5.25
7.00
5.00
8.75
10.0
17.0
17.0
3.00
3.00
5.00
3.00
3.75
5.25
4.00
4.00
5.00
5.25
4.67
5.50
7.00
8.50
10.5

SPR
SPR
HD
SST
SPR
HD
HD
HD
SPR
SPR
SPR
SST
SPR
HD
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
HD
SST
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SST
HD
SST
SPR
HD
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR

E
N
D
S

F
N
S
H

CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
C
CG
C
CG
CG

Z
Z
Z
N
Z
Z
Z
Z
N
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
N
N
Z
Z
Z
N
Z
Z
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
N
Z
Z
Z
N
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
BO
N
Z
N
Z
Z
Z
Z
Z
Z
Z
N
Z
N
N
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

207

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 208

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.625
1.625
1.625
1.625
1.625
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.640
1.656
1.656
1.656
1.656
1.656
1.672
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687

41.28
41.28
41.28
41.28
41.28
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
41.66
42.06
42.06
42.06
42.06
42.06
42.47
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85

12725
369
2793
10393
843
S-1465
B17-193
S-965
3008
3105
S-1666
3239
S-3237
10665
S-102
4193
2990
S-319
S-1188
3174
1861
1833
3307
4404
10529
11542
10373
S-283
S-1642
12618
S-3070
1948
72872
72872S
72880
72880S
72882
72882S
72897
72897S
72898
72898S
72909
72909S
365
11380
72873
72873S
72884
72884S
72899
72899S
72910
72910S
S-3065
72874
72874S
72886
72886S
72901
72901S
72911
72911S
72917
72917S
72925
72925S
11425
72875
72875S
72888
72888S
72903
72903S
72912
72912S
72918
72918S
72926
72926S

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

4.30
4.50
5.63
7.25
12.0
1.38
1.47
1.69
1.88
2.00
2.25
2.25
2.34
2.38
3.25
3.25
3.38
3.63
3.75
4.00
4.31
4.78
5.75
8.00
1.16
2.03
2.38
2.88
9.19
4.00
1.38
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.50
1.88
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.25
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.88
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00

mm

109.2
114.3
142.9
184.2
304.8
34.9
37.3
42.8
47.6
50.8
57.2
57.2
59.5
60.3
82.6
82.6
85.7
92.1
95.3
101.6
109.5
121.4
146.1
203.2
29.4
51.6
60.3
73.0
233.4
101.6
34.9
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
38.1
47.6
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
57.2
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
73.0
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2

MATERIAL: MW - Music Wire

208

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.443
1.139
1.343
1.137
1.241
1.464
1.280
1.344
1.496
1.370
1.370
1.286
1.390
1.190
1.328
1.016
1.476
1.300
1.506
1.506
1.370
1.324
1.286
1.430
1.430
1.416
1.206
1.406
1.092
1.318
1.531
1.531
1.417
1.417
1.391
1.391
1.375
1.375
1.363
1.363
1.333
1.333
1.303
1.303
1.333
1.505
1.417
1.417
1.375
1.375
1.333
1.333
1.303
1.303
1.407
1.417
1.417
1.375
1.375
1.333
1.333
1.303
1.303
1.251
1.251
1.219
1.219
1.363
1.417
1.417
1.375
1.375
1.333
1.333
1.303
1.303
1.251
1.251
1.219
1.219

RATE
mm

36.7
28.9
34.1
28.9
31.5
37.2
32.5
34.1
38.0
34.8
34.8
32.7
35.3
30.2
33.7
25.8
37.5
33.0
38.3
38.3
34.8
33.6
32.7
36.3
36.3
36.0
30.6
35.7
27.7
33.5
38.9
38.9
36.0
36.0
35.3
35.3
34.9
34.9
34.6
34.6
33.9
33.9
33.1
33.1
33.9
38.2
36.0
36.0
34.9
34.9
33.9
33.9
33.1
33.1
35.7
36.0
36.0
34.9
34.9
33.9
33.9
33.1
33.1
31.8
31.8
31.0
31.0
34.6
36.0
36.0
34.9
34.9
33.9
33.9
33.1
33.1
31.8
31.8
31.0
31.0

Lbs./In.

N/mm

3.0
.53
200
35
13
2.3
119
21
24
4.2
13
2.3
215
38
60
11
4.0
.70
49
8.5
41
7.3
120
21
20
3.5
433
76
38
6.6
969 170
3.4
.60
43
7.5
1.3
.23
.99
.17
18
3.2
46
8.0
41
7.2
4.6
.81
51
8.9
18
3.2
457
80
21
3.7
154
27
42
7.3
3.7
.65
4.3
.75
64
11
55
9.6
90
16
76
13
112
20
95
17
126
22
107
19
178
31
151
26
247
43
210
37
142
25
12
2.2
46
8.0
39
6.8
79
14
67
12
124
22
105
18
171
30
145
25
43
7.6
36
6.2
30
5.3
61
11
52
9.1
97
17
83
14
131
23
111
19
228
40
194
34
310
54
263
46
56
9.8
29
5.1
25
4.3
50
8.7
42
7.4
79
14
67
12
106
18
90
16
181
32
154
27
249
44
211
37

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

3.2
81
1.2
30
3.5
89
2.0
51
5.1 130
.98 25
.41 10
.92 23
1.6
39
.96 24
1.0
26
.84 21
1.5
39
.43 11
1.6
42
.47 12
2.7
69
1.9
47
3.2
82
3.3
84
2.6
66
1.6
40
2.5
63
5.1 130
.55 14
1.1
29
.41 10
1.6
41
1.9
47
1.9
49
.91 23
1.1
28
.96 24
.75 19
.89 23
.70 18
.85 22
.63 16
.81 21
.63 16
.75 19
.58 15
.66 17
.49 12
.69 18
1.1
29
1.4
35
1.0
27
1.2
31
.90 23
1.0
27
.83 21
.97 25
.71 18
1.1
27
1.7
44
1.4
34
1.6
40
1.2
30
1.4
35
1.1
27
1.3
32
.93 24
1.1
27
.77 20
.94 24
.66 17
1.4
35
2.1
54
1.7
42
1.9
49
1.4
36
1.7
44
1.3
33
1.6
40
1.1
29
1.3
34
.97 25
1.2
30
.82 21

Lbs.

9.7
237
47
239
124
13
87
55
6.2
47
42
101
30
188
62
452
9.3
80
4.2
3.3
47
72
101
24
28
21
186
35
286
81
3.4
4.7
62
41
80
54
95
60
102
67
133
87
163
103
98
14
62
41
95
60
130
87
165
103
46
62
41
95
60
136
87
163
103
245
149
292
173
76
62
41
95
60
136
87
165
103
242
149
292
173

ENDS: C - Closed

G - Ground
O - Open

43
1053
209
1065
550
58
389
245
28
207
187
450
135
835
275
2011
42
355
19
15
207
322
450
105
125
92
827
154
1270
358
15
21
275
182
355
239
423
268
454
300
591
389
726
457
438
62
277
182
423
268
577
389
736
457
202
275
182
423
268
604
389
727
457
1089
663
1299
768
337
276
182
423
268
603
389
733
457
1077
663
1299
768

Inches

mm

1.09 27.7
2.79 71.0
2.12 53.7
4.45 113.1
5.66 143.9
.40 10.1
.72 18.3
.74 18.8
.32
8.2
.66 16.7
.68 17.1
1.02 25.9
.81 20.6
1.13 28.6
1.25 31.7
2.50 63.4
.66 16.7
1.64 41.7
.54 13.6
.70 17.9
1.32 33.4
1.26 32.1
2.30 58.4
1.42 36.0
.37
9.3
.90 22.9
1.07 27.2
.75 19.1
6.27 159.4
2.08 52.8
.47 11.9
.39
9.9
.54 13.7
.54 13.7
.61 15.5
.61 15.5
.64 16.3
.64 16.3
.69 17.5
.69 17.5
.75 19.1
.75 19.1
.84 21.3
.84 21.3
.86 21.9
.34
8.7
.64 16.3
.64 16.3
.78 19.8
.78 19.8
.95 24.2
.95 24.2
1.03 26.2
1.03 26.2
.70 17.8
.76 19.3
.76 19.3
.92 23.3
.92 23.3
1.11 28.1
1.11 28.1
1.25 31.7
1.25 31.7
1.42 36.0
1.42 36.0
1.52 38.6
1.52 38.6
1.13 28.8
.86 21.9
.86 21.9
1.05 26.7
1.05 26.7
1.28 32.6
1.28 32.6
1.44 36.6
1.44 36.6
1.66 42.2
1.66 42.2
1.78 45.3
1.78 45.3

WIRE DIA.
Inches

0.091
0.243
0.141
0.244
0.192
0.088
0.180
0.148
0.072
0.135
0.135
0.177
0.125
0.225
0.156
0.312
0.082
0.170
0.067
0.067
0.135
0.158
0.177
0.105
0.113
0.120
0.225
0.125
0.282
0.177
0.078
0.078
0.135
0.135
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.177
0.091
0.135
0.135
0.156
0.156
0.177
0.177
0.192
0.192
0.140
0.135
0.135
0.156
0.156
0.177
0.177
0.192
0.192
0.218
0.218
0.234
0.234
0.162
0.135
0.135
0.156
0.156
0.177
0.177
0.192
0.192
0.218
0.218
0.234
0.234

mm

TOTAL
MATL
COILS

2.3
6.2
3.6
6.2
4.9
2.2
4.6
3.8
1.8
3.4
3.4
4.5
3.2
5.7
4.0
7.9
2.1
4.3
1.7
1.7
3.4
4.0
4.5
2.7
2.9
3.0
5.7
3.2
7.2
4.5
2.0
2.0
3.4
3.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
4.5
2.3
3.4
3.4
4.0
4.0
4.5
4.5
4.9
4.9
3.6
3.4
3.4
4.0
4.0
4.5
4.5
4.9
4.9
5.5
5.5
5.9
5.9
4.1
3.4
3.4
4.0
4.0
4.5
4.5
4.9
4.9
5.5
5.5
5.9
5.9

11.0
11.5
15.0
18.3
29.5
3.50
4.00
5.00
4.50
5.00
5.00
5.75
6.50
5.00
8.00
8.00
7.00
9.67
7.00
9.50
9.75
8.00
13.0
12.5
3.25
6.50
4.75
6.00
22.3
10.8
5.00
5.00
4.00
4.00
4.13
4.13
4.13
4.13
4.25
4.25
4.25
4.25
4.38
4.38
5.00
3.75
4.75
4.75
5.00
5.00
5.38
5.38
5.38
5.38
5.00
5.63
5.63
5.88
5.88
6.25
6.25
6.50
6.50
6.50
6.50
6.50
6.50
7.00
6.38
6.38
6.75
6.75
7.25
7.25
7.50
7.50
7.63
7.63
7.63
7.63

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

HD
HD
SPR
SPR
HD
SST
SST
SST
SPR
SPR
SST
SPR
SST
SPR
SST
SPR
SPR
SST
SST
SPR
HD
HD
SPR
SPR
SPR
SPR
SPR
SST
SST
SST
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
HD
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST

E
N
D
S

C
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
Z
GI
Z
Z
N
N
N
GI
Z
N
Z
N
Z
N
Z
Z
N
N
Z
Z
GI
Z
GI
Z
GI
Z
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 209

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.687
1.703
1.703
1.703
1.703
1.703
1.703
1.703
1.703
1.703
1.703
1.718

42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
42.85
43.26
43.26
43.26
43.26
43.26
43.26
43.26
43.26
43.26
43.26
43.64

11253
72876
72876S
72890
72890S
72905
72905S
72913
72913S
72919
72919S
72927
72927S
72877
72877S
72892
72892S
72906
72906S
72914
72914S
72920
72920S
72928
72928S
S-1217
3497
72878
72878S
72894
72894S
72907
72907S
4162
72915
72915S
72921
72921S
72929
72929S
S-435
72879
72879S
1851
72896
72896S
72908
72908S
72916
72916S
72922
72922S
72930
72930S
72923
72923S
72931
72931S
72924
72924S
72932
72932S
10914
4132
10776
3276
3480
1911
4011
10208
11835
11842
S-3034
S-3109
S-956
1639
11925
10259
12459
S-1481

O.D.

FREE LENGTH
Inches

3.00
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.25
4.38
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.50
5.50
5.50
5.50
6.00
6.00
6.00
6.00
6.31
6.38
6.63
6.75
7.00
7.25
20.0
.88
1.75
1.84
4.00
4.38
4.38
7.00
9.25
10.3
20.0
1.31

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

76.2
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
108.0
111.1
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
139.7
139.7
139.7
139.7
152.4
152.4
152.4
152.4
160.3
161.9
168.3
171.5
177.8
184.2
508.0
22.2
44.5
46.8
101.6
111.1
111.1
177.8
235.0
260.4
508.0
33.3

I.D.
Inches

1.201
1.417
1.417
1.375
1.375
1.333
1.333
1.303
1.303
1.251
1.251
1.219
1.219
1.417
1.417
1.375
1.375
1.333
1.333
1.303
1.303
1.251
1.251
1.219
1.219
1.477
1.417
1.417
1.417
1.375
1.375
1.333
1.333
1.327
1.303
1.303
1.251
1.251
1.219
1.219
1.417
1.417
1.417
1.385
1.375
1.375
1.333
1.333
1.303
1.303
1.251
1.251
1.219
1.219
1.251
1.251
1.219
1.219
1.251
1.251
1.219
1.219
1.437
1.423
1.505
1.391
1.437
1.427
1.477
1.527
1.547
1.593
1.467
1.453
1.433
1.407
1.363
1.217
1.493
1.574

RATE
mm

30.5
36.0
36.0
34.9
34.9
33.9
33.9
33.1
33.1
31.8
31.8
31.0
31.0
36.0
36.0
34.9
34.9
33.9
33.9
33.1
33.1
31.8
31.8
31.0
31.0
37.5
36.0
36.0
36.0
34.9
34.9
33.9
33.9
33.7
33.1
33.1
31.8
31.8
31.0
31.0
36.0
36.0
36.0
35.2
34.9
34.9
33.9
33.9
33.1
33.1
31.8
31.8
31.0
31.0
31.8
31.8
31.0
31.0
31.8
31.8
31.0
31.0
36.5
36.1
38.2
35.3
36.5
36.2
37.5
38.8
39.3
40.5
37.3
36.9
36.4
35.7
34.6
30.9
37.9
40.0

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

290
25
21
42
36
66
56
89
75
152
129
208
176
21
18
36
31
56
47
76
65
130
111
178
151
7.7
16
19
16
32
27
49
42
55
67
57
114
97
156
133
13
17
14
21
28
24
44
37
60
51
102
87
139
118
91
77
125
106
84
71
114
97
8.4
29
3.1
20
8.8
10
1.1
14
4.0
1.2
7.2
9.7
13
15
13
83
1.1
3.8

51
4.3
3.6
7.3
6.2
12
9.9
16
13
27
23
36
31
3.7
3.2
6.3
5.4
9.8
8.3
13
11
23
19
31
27
1.3
2.9
3.3
2.8
5.6
4.7
8.6
7.3
9.6
12
10
20
17
27
23
2.4
2.9
2.5
3.6
5.0
4.2
7.7
6.5
10
8.9
18
15
24
21
16
14
22
19
15
13
20
17
1.5
5.1
.55
3.6
1.5
1.8
.19
2.4
.70
.20
1.3
1.7
2.4
2.7
2.3
14
.19
.66

.79
2.5
2.0
2.3
1.7
2.1
1.5
1.8
1.4
1.6
1.2
1.4
.98
2.9
2.3
2.6
2.0
2.3
1.8
2.2
1.6
1.8
1.3
1.6
1.1
2.8
2.8
3.3
2.6
3.0
2.2
2.7
2.1
1.8
2.4
1.8
2.1
1.5
1.9
1.3
3.0
3.7
2.9
3.0
3.3
2.5
3.0
2.3
2.7
2.0
2.4
1.7
2.1
1.5
2.6
1.9
2.3
1.6
2.9
2.1
2.6
1.8
4.5
1.5
4.8
2.9
4.2
4.0
16
.57
1.4
1.6
2.8
3.1
3.0
3.9
4.7
2.7
16
.95

mm

20
64
50
58
43
52
39
47
35
40
29
36
25
74
58
67
50
59
47
55
40
47
34
42
29
70
70
84
65
76
57
68
53
46
62
46
53
39
48
33
77
94
73
76
85
63
76
60
70
51
61
44
53
37
66
49
59
41
73
53
65
45
113
37
122
74
108
101
399
14
35
39
70
79
76
98
118
70
401
24

ENDS: C - Closed

G - Ground
O - Open

Lbs.

229
62
41
95
60
137
87
163
103
242
149
292
173
62
41
95
60
131
87
164
103
240
149
292
173
21
45
62
41
95
60
131
87
99
163
103
240
149
292
173
41
62
41
62
95
60
131
87
164
103
243
149
292
173
238
149
292
173
243
149
292
173
37
42
15
60
37
41
17
7.7
5.5
1.8
20
30
40
59
62
227
17
3.6

1018
275
182
423
268
609
389
727
457
1077
663
1299
768
275
182
423
268
581
389
731
457
1068
663
1299
768
94
202
275
182
423
268
582
389
439
727
457
1066
663
1299
768
182
275
182
274
423
268
582
389
730
457
1082
663
1299
768
1057
663
1299
768
1081
663
1299
768
165
189
67
265
165
180
77
34
25
8.0
88
135
180
263
276
1009
77
16

Inches

1.88
.98
.98
1.19
1.19
1.44
1.44
1.66
1.66
1.91
1.91
2.05
2.05
1.08
1.08
1.35
1.35
1.66
1.66
1.85
1.85
2.15
2.15
2.31
2.31
.74
1.32
1.20
1.20
1.48
1.48
1.84
1.84
1.80
2.06
2.06
2.40
2.40
2.57
2.57
1.38
1.30
1.30
1.81
1.62
1.62
2.01
2.01
2.26
2.26
2.62
2.62
2.84
2.84
2.89
2.89
3.10
3.10
3.11
3.11
3.36
3.36
1.63
.92
.89
1.62
1.56
1.65
4.31
.31
.37
.29
1.24
1.25
1.35
2.22
4.59
5.23
4.23
.36

mm

Inches

47.8
24.9
24.9
30.2
30.2
36.5
36.5
42.1
42.1
48.5
48.5
52.0
52.0
27.4
27.4
34.2
34.2
42.1
42.1
46.9
46.9
54.7
54.7
58.7
58.7
18.7
33.4
30.4
30.4
37.6
37.6
46.6
46.6
45.7
52.4
52.4
60.9
60.9
65.4
65.4
35.1
33.0
33.0
46.0
41.1
41.1
51.1
51.1
57.3
57.3
66.4
66.4
72.1
72.1
73.4
73.4
78.8
78.8
78.9
78.9
85.4
85.4
41.3
23.5
22.5
41.1
39.7
41.8
109.3
7.8
9.4
7.3
31.5
31.8
34.3
56.4
116.6
132.7
107.3
9.1

0.243
0.135
0.135
0.156
0.156
0.177
0.177
0.192
0.192
0.218
0.218
0.234
0.234
0.135
0.135
0.156
0.156
0.177
0.177
0.192
0.192
0.218
0.218
0.234
0.234
0.105
0.135
0.135
0.135
0.156
0.156
0.177
0.177
0.180
0.192
0.192
0.218
0.218
0.234
0.234
0.135
0.135
0.135
0.151
0.156
0.156
0.177
0.177
0.192
0.192
0.218
0.218
0.234
0.234
0.218
0.218
0.234
0.234
0.218
0.218
0.234
0.234
0.125
0.132
0.091
0.148
0.125
0.130
0.105
0.088
0.078
0.055
0.118
0.125
0.135
0.148
0.170
0.243
0.105
0.072

mm

TOTAL
MATL
COILS

6.2
3.4
3.4
4.0
4.0
4.5
4.5
4.9
4.9
5.5
5.5
5.9
5.9
3.4
3.4
4.0
4.0
4.5
4.5
4.9
4.9
5.5
5.5
5.9
5.9
2.7
3.4
3.4
3.4
4.0
4.0
4.5
4.5
4.6
4.9
4.9
5.5
5.5
5.9
5.9
3.4
3.4
3.4
3.8
4.0
4.0
4.5
4.5
4.9
4.9
5.5
5.5
5.9
5.9
5.5
5.5
5.9
5.9
5.5
5.5
5.9
5.9
3.2
3.4
2.3
3.8
3.2
3.3
2.7
2.2
2.0
1.4
3.0
3.2
3.4
3.8
4.3
6.2
2.7
1.8

7.75
7.25
7.25
7.63
7.63
8.13
8.13
8.63
8.63
8.75
8.75
8.75
8.75
8.00
8.00
8.63
8.63
9.38
9.38
9.63
9.63
9.88
9.88
9.88
9.88
7.00
9.75
8.88
8.88
9.50
9.50
10.4
10.4
10.0
10.8
10.8
11.0
11.0
11.0
11.0
10.3
9.63
9.63
12.0
10.4
10.4
11.4
11.4
11.8
11.8
12.0
12.0
12.1
12.1
13.3
13.3
13.3
13.3
14.3
14.3
14.4
14.4
13.0
6.00
9.75
11.0
12.5
12.7
40.0
3.50
4.75
4.25
10.5
10.0
10.0
14.0
27.0
21.5
39.3
4.00

SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
HD
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
SPR
SPR
HD
SPR
SPR
SPR
SST
SST
SST
SST
SST
SPR
SPR
SPR
SPR
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
O
CG
CG
C
CG
CG
CG
C
CG
CG
O
C

F
N
S
H

Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
Z
Z
Z
Z
N
N
N
N
N
Z
GI
Z
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

209

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 210

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.718
1.718
1.718
1.718
1.718
1.718
1.718
1.718
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.734
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.750
1.765
1.765
1.765
1.765
1.765
1.765
1.765
1.781
1.781
1.781
1.781
1.781
1.781
1.781
1.781
1.781
1.781
1.781
1.781
1.781
1.781

43.64
43.64
43.64
43.64
43.64
43.64
43.64
43.64
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.04
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.45
44.83
44.83
44.83
44.83
44.83
44.83
44.83
45.24
45.24
45.24
45.24
45.24
45.24
45.24
45.24
45.24
45.24
45.24
45.24
45.24
45.24

4315
S-1507
3934
2525
4337
S-1622
238
3176
12130
1669
S-3044
11285
10361
1595
S-382
4191
11793
12550
12681
S-967
1946
12106
S-273
S-41
3331
1799
1633
1919
11600
3301
12458
10841
10653
S-1663
11499
3447
380
31
11825
S-1294
11497
11578
S-3176
1783
S-3194
10657
12126
7011
3474
3194
1677
4323
1779
847
853
844
805
836
4047
S-126
11144
10117
B18-203
11989
11892
3006
S-3175
S-1276
3029
2697
3303
1687
S-1671
11716
S-1528
11609
S-227
2930
S-1638
3419

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

3.50
5.00
5.00
5.00
5.50
6.13
7.00
8.75
1.56
2.00
2.25
2.38
2.50
3.38
3.44
3.75
5.47
5.47
5.50
6.38
7.25
7.81
.84
1.00
1.44
1.50
1.50
1.63
1.75
2.00
2.31
2.38
2.56
2.66
3.00
3.13
3.50
4.00
4.06
4.75
4.78
4.81
5.00
5.38
6.00
6.00
6.81
7.00
7.00
7.31
7.50
8.00
10.0
10.0
12.0
12.0
12.0
12.0
21.8
.75
1.25
1.69
1.75
1.84
2.91
3.13
1.25
1.31
1.38
1.44
1.88
2.00
2.25
2.28
3.00
3.53
4.25
4.56
5.19
5.75

mm

88.9
127.0
127.0
127.0
139.7
155.6
177.8
222.3
39.7
50.8
57.2
60.3
63.5
85.7
87.3
95.3
138.9
138.9
139.7
161.9
184.2
198.4
21.4
25.4
36.5
38.1
38.1
41.3
44.5
50.8
58.7
60.3
65.1
67.5
76.2
79.4
88.9
101.6
103.2
120.7
121.4
122.2
127.0
136.5
152.4
152.4
173.0
177.8
177.8
185.7
190.5
203.2
254.0
254.0
304.8
304.8
304.8
304.8
552.5
19.1
31.8
42.8
44.5
46.8
73.8
79.4
31.8
33.3
34.9
36.5
47.6
50.8
57.2
57.9
76.2
89.7
108.0
115.9
131.8
146.1

MATERIAL: MW - Music Wire

210

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.344
1.594
1.558
1.548
1.094
1.518
1.422
1.500
1.284
1.324
1.464
1.552
1.284
1.010
1.576
1.414
1.094
1.110
1.072
1.574
1.484
1.588
1.396
1.396
1.184
1.454
1.396
1.454
1.396
1.566
1.516
1.460
1.300
1.396
1.426
1.616
1.426
1.426
1.604
1.590
1.510
1.582
1.532
1.480
1.592
1.544
1.426
1.184
1.010
1.454
1.310
1.606
1.426
1.396
1.426
1.366
1.336
1.300
1.300
1.525
1.441
1.211
1.527
1.421
1.331
1.631
1.599
1.599
1.599
1.257
1.145
1.485
1.511
1.511
1.541
1.309
1.621
1.531
1.563
1.367

RATE
mm

34.1
40.5
39.6
39.3
27.8
38.6
36.1
38.1
32.6
33.6
37.2
39.4
32.6
25.7
40.0
35.9
27.8
28.2
27.2
40.0
37.7
40.3
35.5
35.5
30.1
36.9
35.5
36.9
35.5
39.8
38.5
37.1
33.0
35.5
36.2
41.0
36.2
36.2
40.7
40.4
38.4
40.2
38.9
37.6
40.4
39.2
36.2
30.1
25.7
36.9
33.3
40.8
36.2
35.5
36.2
34.7
33.9
33.0
33.0
38.7
36.6
30.8
38.8
36.1
33.8
41.4
40.6
40.6
40.6
31.9
29.1
37.7
38.4
38.4
39.1
33.2
41.2
38.9
39.7
34.7

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

13
.71
.12
1.7
.29
2.2
.38
577 101
3.6
.63
15
2.7
4.2
.74
460
81
178
31
25
4.4
4.6
.81
238
42
1821 319
2.1
.38
30
5.3
627 110
474
83
625 109
1.3
.22
8.7
1.5
.91
.16
214
38
315
55
1460 256
56
9.8
121
21
96
17
121
21
11
2.0
9.1
1.6
35
6.2
231
40
80
14
35
6.2
1.3
.22
43
7.5
37
6.4
1.2
.21
3.1
.55
8.1
1.4
2.8
.49
5.0
.87
16
2.8
1.2
.21
5.2
.91
15
2.5
200
35
1079 189
14
2.4
63
11
.82
.14
14
2.4
19
3.3
11
2.0
21
3.7
28
4.9
39
6.9
31
5.4
58
10
120
21
1142 200
26
4.5
156
27
172
30
1.2
.22
18
3.1
12
2.1
6.1
1.1
1933 338
1878 329
53
9.2
27
4.8
21
3.7
14
2.5
161
28
1.8
.32
13
2.2
4.8
.84
68
12

1.4
4.5
4.1
4.1
.75
5.0
3.9
5.9
.39
.77
1.4
1.7
.75
.40
2.8
2.2
.74
.91
.82
5.5
4.2
6.9
.22
.27
.23
.76
.62
.60
.69
1.3
1.3
1.4
.77
1.1
1.4
2.6
1.7
2.0
3.4
3.1
3.4
4.1
3.8
3.8
5.1
4.0
3.7
1.7
.63
4.2
2.6
7.1
5.3
5.1
6.5
5.5
5.1
4.5
5.8
.39
.60
.27
1.2
.56
.95
2.6
.74
.90
.89
.14
.24
1.1
1.4
1.3
2.0
1.1
3.6
2.8
4.0
2.1

75

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

37
115
105
103
19
127
98
151
9.8
20
37
44
19
10
71
55
19
23
21
140
106
175
5.7
6.8
5.8
19
16
15
17
34
32
35
19
27
35
66
43
51
87
78
86
104
97
96
128
102
95
42
16
108
67
179
135
128
166
140
130
115
147
9.9
15
6.9
30
14
24
66
19
23
23
3.4
6.0
27
36
34
51
27
90
70
101
53

Lbs.

109
3.2
6.9
8.8
435
18
59
25
178
137
37
8.0
178
722
6.0
65
464
431
510
6.9
36
6.3
48
84
333
42
74
58
83
15
12
49
177
84
49
3.3
73
73
4.1
9.6
28
12
19
61
6.0
21
54
333
677
58
164
5.8
73
95
73
115
144
177
177
23
72
311
31
87
164
3.2
13
11
5.5
262
445
57
39
29
29
170
6.5
35
19
142

ENDS: C - Closed

G - Ground
O - Open

483
14
31
39
1934
80
260
112
793
608
163
35
793
3209
27
289
2062
1918
2269
31
161
28
213
376
1480
189
331
256
370
66
51
217
787
376
217
15
326
326
18
43
122
51
84
273
27
93
242
1480
3010
256
730
26
326
423
326
513
640
787
787
101
322
1381
137
386
729
14
59
48
24
1166
1980
252
173
127
127
755
29
157
85
630

Inches

1.59
.48
.88
.94
3.28
1.03
2.04
1.47
.97
1.23
.81
.66
1.46
2.63
.63
1.60
3.84
3.74
3.97
.88
1.46
.93
.62
.53
1.13
.74
.89
.70
1.06
.46
1.05
.85
1.46
1.06
1.62
.52
1.26
1.42
.62
.44
1.38
.71
1.20
1.35
.95
.93
3.08
5.00
4.26
2.06
3.56
.94
3.40
3.76
4.05
5.14
5.69
6.41
8.10
.36
.65
1.18
.54
.69
1.52
.52
.27
.41
.49
.79
1.43
.74
.74
.95
.72
2.48
.69
1.04
1.20
2.48

mm

40.4
12.2
22.4
23.7
83.2
26.2
51.7
37.4
24.7
31.2
20.6
16.8
37.2
66.7
16.1
40.6
97.5
95.1
100.9
22.4
37.0
23.6
15.7
13.5
28.8
18.8
22.5
17.9
27.0
11.7
26.7
21.6
37.2
27.0
41.1
13.2
31.9
36.0
15.8
11.2
35.1
18.1
30.5
34.3
24.1
23.5
78.2
127.0
108.1
52.3
90.4
23.8
86.4
95.5
102.9
130.5
144.6
162.9
205.7
9.1
16.5
29.9
13.6
17.5
38.6
13.2
6.9
10.4
12.3
20.0
36.3
18.8
18.9
24.0
18.3
62.9
17.6
26.4
30.5
63.1

WIRE DIA.
Inches

0.187
0.062
0.080
0.085
0.312
0.100
0.148
0.109
0.225
0.205
0.135
0.091
0.225
0.362
0.079
0.160
0.320
0.312
0.331
0.080
0.125
0.073
0.177
0.177
0.283
0.148
0.177
0.148
0.177
0.092
0.117
0.145
0.225
0.177
0.162
0.067
0.162
0.162
0.073
0.080
0.120
0.084
0.109
0.135
0.079
0.103
0.162
0.283
0.370
0.148
0.218
0.072
0.162
0.177
0.162
0.192
0.207
0.225
0.225
0.120
0.162
0.277
0.119
0.172
0.217
0.067
0.091
0.091
0.091
0.262
0.318
0.148
0.135
0.135
0.120
0.236
0.080
0.125
0.109
0.207

mm

TOTAL
MATL
COILS

4.7
1.6
2.0
2.2
7.9
2.5
3.8
2.8
5.7
5.2
3.4
2.3
5.7
9.2
2.0
4.1
8.1
7.9
8.4
2.0
3.2
1.9
4.5
4.5
7.2
3.8
4.5
3.8
4.5
2.3
3.0
3.7
5.7
4.5
4.1
1.7
4.1
4.1
1.9
2.0
3.0
2.1
2.8
3.4
2.0
2.6
4.1
7.2
9.4
3.8
5.54
1.8
4.1
4.5
4.1
4.9
5.3
5.7
5.7
3.0
4.1
7.0
3.0
4.4
5.5
1.7
2.3
2.3
2.3
6.7
8.1
3.8
3.4
3.4
3.0
6.0
2.0
3.2
2.8
5.3

8.50
7.75
10.0
10.0
10.5
10.3
13.8
13.0
4.33
6.00
6.00
6.25
6.50
7.25
7.00
10.0
10.5
12.0
12.0
11.0
11.7
11.8
3.50
3.00
4.00
5.00
5.00
3.75
5.00
4.00
8.00
6.00
6.50
6.00
9.00
6.75
7.75
8.75
8.50
5.50
10.5
7.50
10.0
9.00
11.0
9.00
19.0
16.6
11.5
14.0
16.3
12.0
20.0
21.3
24.0
26.8
27.5
28.5
36.0
3.00
4.00
4.25
4.50
4.00
7.00
6.75
3.00
3.50
5.33
3.00
4.50
5.00
5.50
7.00
6.00
9.50
7.67
8.25
10.0
12.0

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SST
SPR
SPR
SPR
SST
SPR
SPR
SPR
SPR
SST
SST
SPR
OT
SST
SPR
SPR
SPR
SPR
SST
SPR
SPR
SST
SST
SPR
HD
HD
SPR
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
HD
HD
SST
SST
SPR
SPR
SST
MW
SST
SPR
SPR
HD
SPR
SPR
SPR
SPR
HD
HD
HD
HD
HD
HD
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
HD
SPR
SPR
SST
SPR
SST
SPR
SST
SPR
SST
SPR

E
N
D
S

CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
C
C
CG
CG
CG
C
CG
C
C
C
C
CG
CG
C
CG
CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG

F
N
S
H

Z
N
Z
Z
Z
N
Z
Z
Z
Z
N
N
Z
Z
N
GI
Z
Z
Z
N
Z
Z
N
N
Z
Z
N
Z
Z
Z
N
N
Z
N
Z
Z
Z
Z
N
N
Z
N
N
Z
N
GI
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
Z
N
Z
Z
N
Z
N
Z
N
N
N
Z
Z
Z
N
Z
N
Z
N
Z
N
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 211

Inches

mm

CENTURY
STOCK
NUMBER

1.781
1.781
1.796
1.796
1.796
1.796
1.796
1.796
1.796
1.796
1.812
1.812
1.812
1.812
1.812
1.812
1.812
1.812
1.812
1.812
1.812
1.812
1.828
1.828
1.828
1.828
1.828
1.828
1.843
1.843
1.843
1.843
1.843
1.843
1.859
1.859
1.859
1.859
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.875
1.890
1.890
1.890
1.890
1.890
1.890
1.890
1.890
1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.906

45.24
45.24
45.62
45.62
45.62
45.62
45.62
45.62
45.62
45.62
46.02
46.02
46.02
46.02
46.02
46.02
46.02
46.02
46.02
46.02
46.02
46.02
46.43
46.43
46.43
46.43
46.43
46.43
46.81
46.81
46.81
46.81
46.81
46.81
47.22
47.22
47.22
47.22
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
47.63
48.01
48.01
48.01
48.01
48.01
48.01
48.01
48.01
48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.41

S-1005
S-3083
4153
12168
10906
B17-198
3494
S-983
11854
1621
11994
2758
1583
4349
11115
S-3171
10478
3081
3298
10990
1523
386
12075
S-1193
S-3049
11802
1801
3421
S-3173
11765
10444
3304
3381
4325
S-426
S-979
3399
S-1185
S-3064
12678
4308
S-1228
10751
10462
4273
4159
S-947
4155
S-3139
S-141
4331
S-969
11519
10360
4188
2868
4338
4077
12504
11834
S-176
S-1615
4131
S-3051
3434
S-3225
3108
S-3253
11359
S-1688
1867
12053
S-378
S-952
1667
11574
S-957
S-184
4165
1835

O.D.

FREE LENGTH
Inches

6.75
16.0
3.00
3.47
3.50
4.00
4.38
5.00
6.50
11.0
1.25
2.31
3.03
3.25
3.34
3.38
3.50
6.00
6.00
6.50
10.4
10.5
1.41
1.44
3.50
5.81
8.00
8.25
1.38
1.94
2.88
5.75
6.00
17.3
2.94
3.13
4.13
5.75
1.25
1.63
1.88
2.13
2.31
2.50
2.88
3.00
3.09
3.38
4.25
4.41
4.50
4.63
5.03
5.50
7.75
8.25
11.5
15.5
.75
1.28
2.00
4.00
4.13
4.25
5.00
5.13
1.19
1.41
1.63
1.75
1.75
1.78
1.78
1.97
2.59
2.63
2.75
3.13
4.00
4.00

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

171.5
406.4
76.2
88.1
88.9
101.6
111.1
127.0
165.1
279.4
31.8
58.7
77.0
82.6
84.9
85.7
88.9
152.4
152.4
165.1
263.5
266.7
35.7
36.5
88.9
147.6
203.2
209.6
34.9
49.2
73.0
146.1
152.4
438.2
74.6
79.4
104.8
146.1
31.8
41.3
47.6
54.0
58.7
63.5
73.0
76.2
78.6
85.7
108.0
111.9
114.3
117.5
127.8
139.7
196.9
209.6
292.1
393.7
19.1
32.5
50.8
101.6
104.8
108.0
127.0
130.2
30.2
35.7
41.3
44.5
44.5
45.2
45.2
50.0
65.9
66.7
69.9
79.4
101.6
101.6

I.D.
Inches

1.557
1.511
1.662
1.306
1.530
1.640
1.296
1.472
1.576
1.416
1.516
1.542
1.692
1.542
1.342
1.362
1.342
1.428
1.392
1.428
1.392
1.398
1.474
1.618
1.588
1.558
1.532
1.368
1.593
1.701
1.683
1.483
1.489
1.429
1.619
1.409
1.235
1.675
1.715
1.689
1.741
1.691
1.625
1.579
1.615
1.151
1.635
1.571
1.605
1.605
1.125
1.605
1.637
1.649
1.521
1.773
1.425
1.425
1.646
1.594
1.680
1.324
1.620
1.640
1.476
1.526
1.772
1.726
1.420
1.722
1.666
1.680
1.656
1.582
1.182
1.610
1.582
1.582
1.636
1.622

RATE
mm

39.5
38.3
42.2
33.2
38.9
41.7
32.9
37.4
40.0
36.0
38.5
39.2
43.0
39.2
34.1
34.6
34.1
36.3
35.4
36.3
35.4
35.5
37.4
41.1
40.3
39.6
38.9
34.7
40.5
43.2
42.7
37.7
37.8
36.3
41.1
35.8
31.4
42.5
43.6
42.9
44.2
43.0
41.3
40.1
41.0
29.2
41.5
39.9
40.8
40.8
28.6
40.8
41.6
41.9
38.6
45.0
36.2
36.2
41.8
40.5
42.7
33.6
41.1
41.7
37.5
38.8
45.0
43.8
36.1
43.7
42.3
42.7
42.1
40.2
30.0
40.9
40.2
40.2
41.6
41.2

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

6.0
1.1
3.4
.59
1.4
.25
198
35
12
2.1
1.5
.26
190
33
38
6.6
6.3
1.1
23
4.0
75
13
22
3.8
.69
.12
20
3.5
186
33
160
28
194
34
51
8.9
68
12
50
8.7
34
6.0
32
5.6
105
18
15
2.6
7.4
1.3
9.2
1.6
15
2.6
56
9.9
30
5.3
1.6
.29
1.9
.33
44
7.7
36
6.3
22
3.9
14
2.5
147
26
589 103
1.7
.30
5.9
1.0
6.6
1.2
1.1
.19
2.6
.46
22
3.8
41
7.2
18
3.2
1425 250
14
2.4
25
4.4
15
2.6
13
2.3
1203 211
9.9
1.7
8.9
1.6
6.1
1.1
29
5.0
.22
.04
59
10
32
5.5
58
10
58
10
8.9
1.6
263
46
24
4.2
11
1.9
76
13
28
4.9
3.1
.54
9.3
1.6
727 127
6.0
1.1
26
4.6
14
2.4
22
3.9
65
11
2439 427
32
5.6
36
6.3
41
7.1
15
2.6
28
5.0

3.8
9.8
2.5
1.1
2.6
3.3
1.2
1.7
3.8
4.8
.66
1.4
2.6
2.1
1.0
.90
1.0
2.2
2.1
2.2
4.3
4.4
.52
1.0
2.4
4.1
5.2
3.2
.88
1.5
2.2
2.1
2.5
6.1
1.9
.96
.69
4.6
.89
1.2
1.4
1.4
1.5
1.3
2.0
.40
2.0
2.2
2.5
2.8
.55
3.1
3.3
4.1
3.1
7.7
3.2
5.3
.38
.69
1.5
.98
1.7
2.9
1.8
2.8
.89
1.0
.28
1.3
1.1
1.1
1.1
.92
.27
1.6
1.7
1.5
2.7
2.3

mm

98
248.9
64
28
67
83
31
43
97
123
17
34
65
53
27
23
25
56
54
57
109
111
13
26
61
104
131
82
22
38
55
53
64
156
49
24
18
117
23
31
35
35
39
33
51
10
50
55
62
71
14
80
83
103
79
196
81
134
9.8
18
37
25
43
73
45
71
23
25
7.2
34
28
28
28
23
7.0
40
42
38
69
59

ENDS: C - Closed

G - Ground
O - Open

Lbs.

23
32.9
3.5
221
31
4.8
235
63
24
109
49
29
1.8
42
194
144
194
112
145
112
145
139
54
15
18
37
77
181
26
2.5
4.1
91
91
137
27
141
406
7.9
5.3
8.0
1.5
3.7
34
54
37
570
27
54
37
37
665
31
29
25
89
1.7
187
166
22
40
13
257
41
30
134
79
2.8
9.3
205
8.0
29
15
24
60
668
50
60
60
40
66

103
147
16
985
138
21
1044
282
107
486
219
130
7.9
188
865
641
865
497
646
497
646
620
242
67
80
167
343
806
117
11
18
404
403
610
122
626
1807
35
23
35
6.6
16
149
239
163
2535
121
240
164
164
2957
138
129
111
396
7.7
830
738
98
177
58
1142
181
135
596
351
12
41
911
36
130
66
107
267
2971
224
267
267
179
292

Inches

1.01
4.01
.47
2.21
.86
.73
2.50
1.17
.99
4.18
.59
.96
.48
.95
1.88
1.80
1.82
2.11
2.52
2.16
4.62
4.55
.89
.42
1.08
1.72
1.74
4.49
.50
.43
.70
1.71
1.86
6.00
.66
1.58
2.57
1.15
.36
.42
.50
.74
.63
.78
.81
2.57
.66
1.22
1.11
1.08
3.38
1.49
1.07
1.02
2.12
.52
3.60
6.30
.37
.59
.53
2.69
.83
1.03
1.91
2.18
.30
.41
.85
.41
.48
.68
.69
.73
1.72
1.04
1.05
.97
1.05
.82

mm

Inches

25.6
101.8
11.9
56.0
22.0
18.5
63.5
29.8
25.1
106.2
15.0
24.4
12.2
24.0
47.8
45.7
46.3
53.6
64.0
54.9
117.3
115.7
22.5
10.7
27.4
43.7
44.2
113.9
12.7
10.8
17.8
43.4
47.2
152.5
16.8
40.0
65.4
29.2
9.1
10.6
12.8
18.7
15.9
19.7
20.6
65.3
16.8
30.9
28.3
27.4
85.7
37.7
27.2
25.8
53.9
13.1
91.4
160.0
9.3
15.0
13.3
68.3
21.0
26.2
48.6
55.5
7.7
10.3
21.6
10.5
12.2
17.2
17.5
18.5
43.7
26.3
26.7
24.7
26.6
20.8

0.112
0.135
0.067
0.245
0.133
0.078
0.250
0.162
0.110
0.190
0.148
0.135
0.060
0.135
0.235
0.225
0.235
0.192
0.210
0.192
0.210
0.207
0.177
0.105
0.120
0.135
0.148
0.230
0.125
0.071
0.080
0.180
0.177
0.207
0.120
0.225
0.312
0.092
0.080
0.093
0.067
0.092
0.125
0.148
0.130
0.362
0.120
0.152
0.135
0.135
0.375
0.135
0.119
0.113
0.177
0.051
0.225
0.225
0.122
0.148
0.105
0.283
0.135
0.125
0.207
0.182
0.067
0.090
0.243
0.092
0.120
0.113
0.125
0.162
0.362
0.148
0.162
0.162
0.135
0.142

mm

TOTAL
MATL
COILS

2.8
3.4
1.7
6.2
3.4
2.0
6.4
4.1
2.8
4.8
3.8
3.4
1.5
3.4
6.0
5.7
6.0
4.9
5.3
4.9
5.3
5.3
4.5
2.7
3.0
3.4
3.8
5.8
3.2
1.8
2.0
4.6
4.5
5.3
3.0
5.7
7.9
2.3
2.0
2.4
1.7
2.3
3.2
3.8
3.3
9.2
3.0
3.9
3.4
3.4
9.5
3.4
3.0
2.9
4.5
1.3
5.7
5.7
3.1
3.8
2.7
7.2
3.4
3.2
5.3
4.6
1.7
2.3
6.2
2.3
3.0
2.9
3.2
4.1
9.2
3.8
4.1
4.1
3.4
3.6

9.00
29.7
6.00
9.00
6.50
8.33
10.0
7.25
9.00
22.0
4.00
7.00
7.00
7.00
8.00
7.00
7.75
11.0
12.0
11.3
22.0
22.0
5.00
4.00
9.00
12.8
11.8
19.5
4.00
6.00
7.75
9.50
10.5
29.0
5.50
7.00
8.25
11.5
3.50
4.50
6.50
8.00
5.00
5.25
6.25
7.00
5.50
8.00
7.25
8.00
9.00
10.0
8.00
9.00
12.0
9.00
16.0
28.0
3.00
4.00
5.00
9.50
6.00
7.25
9.25
12.0
3.50
3.50
3.50
4.50
4.00
5.00
4.50
4.50
4.75
6.00
6.50
6.00
7.75
5.75

SST
SST
SPR
SPR
PB
SST
SPR
SST
SPR
HD
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
HD
HD
HD
SPR
SST
SST
SPR
MW
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SST
SPR
SST
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
MW
OT
SPR
SPR
SST
SST
SST
SPR
SST
SPR
SST
SPR
SST
SPR
SST
HD
SPR
SST
SST
OT
SPR
SST
SST
SPR
MW

E
N
D
S

F
N
S
H

CG
CG
C
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
C
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG

N
N
Z
Z
N
N
Z
N
N
Z
Z
Z
Z
Z
Z
N
Z
Z
Z
Z
Z
Z
Z
N
N
GI
GI
BO
N
Z
Z
Z
Z
Z
N
N
Z
N
N
N
Z
N
Z
Z
Z
N
N
Z
N
N
GI
N
Z
Z
GI
Z
Z
N
Z
N
N
N
Z
N
GI
N
Z
N
Z
N
Z
N
N
N
Z
N
N
N
Z
Z

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

211

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 212

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.906
1.906
1.906
1.906
1.906
1.906
1.906
1.921
1.921
1.921
1.921
1.921
1.921
1.921
1.921
1.921
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937

48.41
48.41
48.41
48.41
48.41
48.41
48.41
48.79
48.79
48.79
48.79
48.79
48.79
48.79
48.79
48.79
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20

S-978
11646
3281
3148
3417
10088
3098
3142
3330
11861
S-988
S-941
3310
S-379
11505
4054
12114
72933
72933S
72942
72942S
72959
72959S
72976
72976S
72934
72934S
72944
72944S
72960
72960S
72967
72967S
72977
72977S
72985
72985S
72994
72994S
73009
73009S
12700
11804
3406
72935
72935S
72946
72946S
72961
72961S
72968
72968S
72978
72978S
72986
72986S
72996
72996S
73010
73010S
72936
72936S
72948
72948S
72962
72962S
S-3160
72969
72969S
72979
72979S
72987
72987S
72998
72998S
73011
73011S
72937
72937S
72950

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

4.25
5.75
6.13
7.00
7.50
8.75
9.31
.75
1.00
1.66
1.69
2.25
4.25
4.25
8.75
22.5
1.50
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.00
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.50
2.59
2.59
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.00
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
3.50
4.00
4.00
4.00

mm

108.0
146.1
155.6
177.8
190.5
222.3
236.5
19.1
25.4
42.1
42.8
57.2
108.0
108.0
222.3
571.5
38.1
50.8
50.8
50.8
50.8
50.8
50.8
50.8
50.8
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
63.5
65.9
65.9
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
76.2
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
88.9
101.6
101.6
101.6

MATERIAL: MW - Music Wire

212

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.636
1.662
1.420
1.532
1.340
1.562
1.456
1.721
1.731
1.609
1.597
1.739
1.651
1.651
1.577
1.471
1.563
1.641
1.641
1.625
1.625
1.613
1.613
1.553
1.553
1.641
1.641
1.625
1.625
1.613
1.613
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.433
1.433
1.767
1.641
1.641
1.625
1.625
1.613
1.613
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.641
1.641
1.625
1.625
1.613
1.613
1.583
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.641
1.641
1.625

RATE
mm

41.6
42.2
36.1
38.9
34.0
39.7
37.0
43.7
44.0
40.9
40.6
44.2
41.9
41.9
40.1
37.4
39.7
41.7
41.7
41.3
41.3
41.0
41.0
39.4
39.4
41.7
41.7
41.3
41.3
41.0
41.0
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
36.4
36.4
44.9
41.7
41.7
41.3
41.3
41.0
41.0
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
41.7
41.7
41.3
41.3
41.0
41.0
40.2
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
41.7
41.7
41.3

Lbs./In.

N/mm

14
2.5
56
9.8
141
25
35
6.2
160
28
21
3.7
48
8.4
24
4.2
19
3.4
92
16
47
8.3
4.7
.82
14
2.4
9.1
1.6
21
3.6
18
3.1
109
19
52
9.0
44
7.7
64
11
54
9.5
71
12
60
11
124
22
106
18
40
7.0
34
5.9
49
8.6
42
7.3
55
9.5
46
8.1
75
13
64
11
101
18
86
15
141
25
120
21
194
34
165
29
296
52
252
44
404
71
605 106
4.3
.75
33
5.7
28
4.8
40
7.0
34
6.0
44
7.8
38
6.6
61
11
52
9.1
82
14
70
12
118
21
100
18
156
27
133
23
237
42
202
35
27
4.8
23
4.1
34
5.9
29
5.0
37
6.5
32
5.6
47
8.3
51
8.9
43
7.6
69
12
58
10
95
17
81
14
131
23
111
19
198
35
168
29
24
4.2
20
3.5
29
5.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

mm

2.6
66
.55 14
1.4
37
2.8
71
1.9
49
3.8
98
3.4
87
.45 11
.72 18
.58 15
.82 21
1.7
43
2.9
73
2.9
74
3.9
98
9.0 229
.57 14
1.4
34
1.1
27
1.3
33
.97 25
1.3
32
.98 25
1.0
26
.86 22
1.8
45
1.4
35
1.7
43
1.3
32
1.6
42
1.3
32
1.5
39
1.2
31
1.4
36
1.0
27
1.3
33
.94 24
1.2
30
.82 21
1.0
25
.73 19
.56 14
.37
9.4
2.5
64
2.1
55
1.7
43
2.1
53
1.5
39
2.0
52
1.6
40
1.9
48
1.5
38
1.8
45
1.3
33
1.6
40
1.1
29
1.5
37
1.0
26
1.3
33
.91 23
2.6
65
2.0
51
2.5
63
1.8
47
2.4
61
1.9
47
1.6
41
2.2
57
1.8
45
2.1
53
1.5
39
1.9
49
1.4
35
1.8
45
1.2
31
1.5
39
1.1
28
2.9
75
2.3
59
2.9
72

Lbs.

36
31
205
99
309
81
163
11
14
53
39
7.9
40
26
80
162
62
70
47
83
53
90
59
129
90
70
47
83
53
90
59
114
77
144
90
185
113
229
136
296
184
224
224
11
70
47
83
53
90
59
115
77
144
90
185
113
229
136
304
184
70
47
83
53
90
59
77
114
77
143
90
185
113
229
136
303
184
70
47
83

ENDS: C - Closed

G - Ground
O - Open

162
137
911
438
1372
359
727
48
61
237
174
35
178
118
356
722
274
310
209
371
235
400
263
575
402
312
209
371
235
400
263
509
341
640
402
823
501
1020
603
1319
820
998
998
48
311
209
371
235
400
263
512
341
639
402
823
501
1020
603
1352
820
312
209
371
235
400
263
341
509
341
638
402
823
501
1020
603
1346
820
311
209
371

Inches

mm

.99 25.1
.37
9.3
2.45 62.2
2.26 57.3
4.39 111.4
2.32 59.0
4.11 104.3
.30
7.6
.29
7.2
.55 13.9
.86 21.9
.55 13.9
1.08 27.4
1.35 34.3
2.46 62.6
10.1 257.2
.94 23.7
.65 16.4
.65 16.4
.68 17.3
.68 17.3
.73 18.5
.73 18.5
.96 24.4
.96 24.4
.74 18.8
.74 18.8
.80 20.3
.80 20.3
.85 21.6
.85 21.6
.97 24.7
.97 24.7
1.08 27.4
1.08 27.4
1.16 29.6
1.16 29.6
1.29 32.9
1.29 32.9
1.50 38.1
1.50 38.1
1.26 32.0
1.01 25.6
.49 12.4
.85 21.6
.85 21.6
.90 22.8
.90 22.8
.97 24.7
.97 24.7
1.11 28.1
1.11 28.1
1.25 31.7
1.25 31.7
1.32 33.5
1.32 33.5
1.52 38.6
1.52 38.6
1.72 43.7
1.72 43.7
.94 24.0
.94 24.0
1.01 25.8
1.01 25.8
1.09 27.8
1.09 27.8
1.19 30.3
1.26 32.0
1.26 32.0
1.42 36.0
1.42 36.0
1.53 38.8
1.53 38.8
1.72 43.6
1.72 43.6
1.97 50.0
1.97 50.0
1.05 26.8
1.05 26.8
1.11 28.2

WIRE DIA.
Inches

0.135
0.122
0.243
0.187
0.283
0.172
0.225
0.100
0.095
0.156
0.162
0.091
0.135
0.135
0.172
0.225
0.187
0.148
0.148
0.156
0.156
0.162
0.162
0.192
0.192
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.252
0.252
0.085
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.148
0.148
0.156

mm

TOTAL
MATL
COILS

3.4
3.1
6.2
4.7
7.2
4.4
5.7
2.5
2.4
4.0
4.1
2.3
3.4
3.4
4.4
5.7
4.7
3.8
3.8
4.0
4.0
4.1
4.1
4.9
4.9
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
6.4
6.4
2.2
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
3.8
3.8
4.0

7.33
3.00
10.0
12.0
15.5
13.5
18.3
3.00
3.00
3.50
5.33
5.00
8.00
10.0
13.3
44.0
5.00
4.38
4.38
4.38
4.38
4.50
4.50
5.00
5.00
5.00
5.00
5.13
5.13
5.25
5.25
5.50
5.50
5.63
5.63
5.63
5.63
5.75
5.75
6.00
6.00
5.00
4.00
4.75
5.75
5.75
5.75
5.75
6.00
6.00
6.25
6.25
6.50
6.50
6.38
6.38
6.75
6.75
6.88
6.88
6.38
6.38
6.50
6.50
6.75
6.75
6.75
7.13
7.13
7.38
7.38
7.38
7.38
7.63
7.63
7.88
7.88
7.13
7.13
7.13

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SST
SST
SST
SPR
SST
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
SPR
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
Z
Z
Z
Z
Z
Z
Z
Z
N
N
N
Z
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:30 AM Page 213

Inches

mm

CENTURY
STOCK
NUMBER

Inches

1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.937
1.953
1.953
1.953
1.953

49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.20
49.61
49.61
49.61
49.61

72950S
72963
72963S
72970
72970S
72980
72980S
72988
72988S
73000
73000S
73012
73012S
3420
72938
72938S
72952
72952S
72964
72964S
72971
72971S
72981
72981S
72989
72989S
73002
73002S
73013
73013S
72939
72939S
72954
72954S
72965
72965S
72972
72972S
72982
72982S
72990
72990S
73004
73004S
73014
73014S
11895
72940
72940S
72956
72956S
72966
72966S
72973
72973S
72983
72983S
72991
72991S
73006
73006S
73015
73015S
72958
72958S
72974
72974S
72984
72984S
72992
72992S
73008
73008S
73016
73016S
S-3191
11926
12080
S-3080
S-92

4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.44
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
4.50
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.25
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
5.50
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
7.00
1.50
1.56
1.88
2.75

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
112.7
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
114.3
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
133.4
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
139.7
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
177.8
38.1
39.7
47.6
69.9

I.D.
Inches

1.625
1.613
1.613
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.371
1.641
1.641
1.625
1.625
1.613
1.613
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.641
1.641
1.625
1.625
1.613
1.613
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.583
1.641
1.641
1.625
1.625
1.613
1.613
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.625
1.625
1.583
1.583
1.553
1.553
1.523
1.523
1.487
1.487
1.437
1.437
1.711
1.579
1.829
1.657
1.579

RATE
mm

41.3
41.0
41.0
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
34.8
41.7
41.7
41.3
41.3
41.0
41.0
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
41.7
41.7
41.3
41.3
41.0
41.0
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
40.2
41.7
41.7
41.3
41.3
41.0
41.0
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
41.3
41.3
40.2
40.2
39.4
39.4
38.7
38.7
37.8
37.8
36.5
36.5
43.5
40.1
46.5
42.1
40.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

25
32
27
44
37
59
50
82
70
112
95
169
144
254
21
18
26
22
28
24
39
33
52
44
72
61
98
84
148
126
19
16
23
20
25
22
35
29
47
40
64
54
88
74
132
112
33
17
14
21
18
23
19
31
27
42
36
58
49
79
67
119
101
19
16
29
24
38
32
53
45
72
61
108
94
3.1
106
1.3
51
139

4.3
5.7
4.8
7.7
6.6
10
8.8
14
12
20
17
30
25
45
3.7
3.1
4.5
3.8
5.0
4.2
6.8
5.8
9.1
7.8
13
11
17
15
26
22
3.3
2.8
4.0
3.4
4.4
3.8
6.1
5.2
8.1
6.9
11
9.5
15
13
23
20
5.8
3.0
2.5
3.6
3.1
4.0
3.4
5.5
4.6
7.3
6.2
10
8.6
14
12
21
18
3.3
2.8
5.0
4.2
6.7
5.7
9.2
7.8
13
11
19
16.5
.54
19
.24
8.9
24

2.1
2.8
2.2
2.6
2.0
2.4
1.8
2.3
1.6
2.0
1.4
1.8
1.3
1.2
3.4
2.6
3.2
2.4
3.2
2.4
3.0
2.3
2.8
2.0
2.6
1.8
2.3
1.6
2.0
1.5
3.7
3.0
3.6
2.7
3.5
2.7
3.3
2.6
3.1
2.3
2.9
2.1
2.6
1.8
2.3
1.6
2.6
4.1
3.3
4.0
3.0
3.9
3.0
3.7
2.9
3.4
2.5
3.2
2.3
2.9
2.0
2.5
1.8
4.4
3.3
4.0
3.2
3.8
2.8
3.5
2.5
3.2
2.2
2.8
1.95
5.4
.57
1.2
.91
.60

mm

54
71
55
66
52
61
46
57
41
52
36
45
33
30
85
67
82
61
80
62
76
59
70
52
65
47
59
41
52
37
95
75
92
69
90
69
84
66
79
58
73
53
67
46
58
42
66
105
83
102
76
100
77
94
73
87
64
81
58
74
51
64
46
112
84
102
80
96
71
89
64
81
56
71
49.5
138
14
31
23
15

ENDS: C - Closed

G - Ground
O - Open

Lbs.

53
90
59
115
77
143
90
185
113
229
136
302
184
304
70
47
83
53
90
59
115
77
144
90
185
113
229
136
301
184
70
47
83
53
90
59
115
77
144
90
185
113
229
136
301
184
86
70
47
83
53
90
59
115
77
144
90
185
113
229
136
300
184
83
53
115
77
144
90
185
113
229
136
302
183
17
60
1.7
47
83

235
400
263
511
341
637
402
823
501
1020
603
1342
820
1352
312
209
371
235
400
263
513
341
642
402
823
501
1020
603
1339
820
311
209
371
235
400
263
511
341
642
402
823
501
1020
603
1337
820
384
312
209
371
235
399
263
511
341
640
402
823
501
1020
603
1335
820
371
235
511
341
640
402
823
501
1020
603
1349
817
75
267
7.4
207
369

Inches

1.11
1.22
1.22
1.39
1.39
1.58
1.58
1.71
1.71
1.91
1.91
2.22
2.22
2.83
1.15
1.15
1.23
1.23
1.34
1.34
1.53
1.53
1.73
1.73
1.89
1.89
2.14
2.14
2.47
2.47
1.26
1.26
1.33
1.33
1.46
1.46
1.68
1.68
1.90
1.90
2.07
2.07
2.33
2.33
2.72
2.72
1.73
1.35
1.35
1.44
1.44
1.58
1.58
1.81
1.81
2.06
2.06
2.25
2.25
2.56
2.56
2.97
2.97
1.56
1.56
1.97
1.97
2.23
2.23
2.41
2.41
2.76
2.76
3.2
3.2
1.58
.94
.33
.59
.75

mm

Inches

28.2
30.9
30.9
35.4
35.4
40.2
40.2
43.4
43.4
48.6
48.6
56.4
56.4
71.9
29.1
29.1
31.2
31.2
33.9
33.9
38.8
38.8
43.9
43.9
48.0
48.0
54.3
54.3
62.7
62.7
32.0
32.0
33.7
33.7
37.0
37.0
42.7
42.7
48.2
48.2
52.6
52.6
59.3
59.3
69.1
69.1
43.8
34.3
34.3
36.7
36.7
40.1
40.1
46.1
46.1
52.4
52.4
57.2
57.2
65.0
65.0
75.4
75.4
39.6
39.6
50.0
50.0
56.7
56.7
61.1
61.1
70.0
70.0
81.3
81.8
40.2
23.7
8.4
15.0
19.0

0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.283
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.177
0.148
0.148
0.156
0.156
0.162
0.162
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.156
0.156
0.177
0.177
0.192
0.192
0.207
0.207
0.225
0.225
0.250
0.250
0.113
0.187
0.062
0.148
0.187

mm

TOTAL
MATL
COILS

4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
7.2
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
4.5
3.8
3.8
4.0
4.0
4.1
4.1
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
4.0
4.0
4.5
4.5
4.9
4.9
5.3
5.3
5.7
5.7
6.4
6.4
2.9
4.7
1.6
3.8
4.7

7.13
7.50
7.50
7.88
7.88
8.25
8.25
8.25
8.25
8.50
8.50
8.88
8.88
10.0
7.75
7.75
7.88
7.88
8.25
8.25
8.63
8.63
9.00
9.00
9.13
9.13
9.50
9.50
9.88
9.88
8.50
8.50
8.50
8.50
9.00
9.00
9.50
9.50
9.88
9.88
10.0
10.0
10.4
10.4
10.9
10.9
9.75
9.13
9.13
9.25
9.25
9.75
9.75
10.3
10.3
10.8
10.8
10.9
10.9
11.4
11.4
11.9
11.9
10.0
10.0
11.1
11.1
11.6
11.6
11.6
11.6
12.3
12.3
12.8
12.8
13.0
5.00
4.33
4.00
4.00

SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SPR
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
MW
SST
SST
SPR
SPR
SST
SST

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG

N
N
N
N
N
N
N
N
N
N
N
N
N
BO
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
N

COMPRESSION SPRINGS

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

213

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 214

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

1.953
1.953
1.953
1.953
1.953
1.953
1.968
1.968
1.968
1.968
1.968
1.968
1.968
1.984
1.984
1.984
1.984
1.984
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.000
2.015
2.015
2.015
2.031
2.031
2.031
2.046
2.046
2.046
2.046
2.046
2.046
2.046
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.062
2.078
2.078

49.61
49.61
49.61
49.61
49.61
49.61
49.99
49.99
49.99
49.99
49.99
49.99
49.99
50.39
50.39
50.39
50.39
50.39
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
50.80
51.18
51.18
51.18
51.59
51.59
51.59
51.97
51.97
51.97
51.97
51.97
51.97
51.97
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.37
52.78
52.78

S-380
11985
S-3050
3375
2687
S-257
3376
12626
S-1645
4197
12552
10237
4042
3170
1681
S-3071
1875
4177
S-1243
S-120
11050
11247
S-365
11991
1795
1673
S-1650
S-982
4145
S-461
S-3113
1947
11446
3094
3485
10441
10247
4239
3489
S-3198
3124
4385
813
806
837
676
S-1665
S-1664
11975
S-3196
3413
4353
11931
10651
3379
S-1619
11607
4167
10580
S-1554
S-3141
3118
S-1562
S-3238
S-3136
S-3069
S-1019
11727
2986
S-158
11730
1839
11905
3259
4178
3261
3263
S-3014
12073
11813

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

4.13
4.88
5.25
5.25
6.38
6.38
4.00
4.25
5.50
8.00
8.00
8.00
22.0
1.22
1.25
1.50
1.69
2.88
1.75
1.88
2.00
2.41
2.50
2.50
2.94
3.50
3.63
3.63
4.00
4.50
4.63
5.09
5.63
6.13
6.50
8.00
8.50
9.25
9.88
11.0
11.1
11.8
12.0
12.0
12.0
12.0
2.34
2.44
3.41
4.66
5.25
6.75
1.53
2.53
3.13
3.75
5.63
7.38
11.0
1.91
2.13
2.25
3.19
3.19
3.25
3.50
4.00
4.97
5.00
5.00
5.25
5.50
7.09
8.88
9.00
9.00
9.19
9.75
1.75
4.34

mm

104.8
123.8
133.4
133.4
161.9
161.9
101.6
108.0
139.7
203.2
203.2
203.2
558.8
31.0
31.8
38.1
42.8
73.0
44.5
47.6
50.8
61.1
63.5
63.5
74.6
88.9
92.1
92.1
101.6
114.3
117.5
129.4
142.9
155.6
165.1
203.2
215.9
235.0
250.8
279.4
282.6
298.5
304.8
304.8
304.8
304.8
59.5
61.9
86.5
118.3
133.4
171.5
38.9
64.3
79.4
95.3
142.9
187.3
279.4
48.4
54.0
57.2
80.9
81.0
82.6
88.9
101.6
126.2
127.0
127.0
133.4
139.7
180.2
225.4
228.6
228.6
233.4
247.7
44.5
110.3

MATERIAL: MW - Music Wire

214

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.683
1.641
1.599
1.329
1.599
1.539
1.594
1.698
1.774
1.528
1.518
1.306
1.518
1.756
1.744
1.774
1.704
1.600
1.550
1.616
1.514
1.836
1.876
1.620
1.730
1.550
1.828
1.626
1.376
1.614
1.676
1.800
1.750
1.830
1.730
1.550
1.434
1.550
1.476
1.768
1.750
1.616
1.646
1.586
1.550
1.376
1.565
1.565
1.745
1.873
1.847
1.465
1.794
1.522
1.692
1.924
1.785
1.722
1.538
1.758
1.496
1.852
1.862
1.738
1.812
1.708
1.792
1.568
1.738
1.738
1.890
1.918
1.708
1.538
1.538
1.496
1.538
1.750
1.942
1.838

RATE
mm

42.7
41.7
40.6
33.8
40.6
39.1
40.5
46.4
45.1
38.8
38.6
33.2
38.6
44.6
44.3
45.1
43.3
40.6
39.4
41.0
38.5
46.6
47.7
41.1
43.9
39.4
46.4
41.3
35.0
41.0
42.6
45.7
44.5
46.5
43.9
39.4
36.4
39.4
37.5
44.9
44.5
41.0
41.8
40.3
39.4
35.0
39.8
39.8
44.3
47.6
46.9
37.2
45.6
38.7
43.0
48.9
45.3
43.7
39.1
44.7
38.0
47.0
47.3
44.1
46.0
43.4
45.5
39.8
44.1
44.1
48.0
48.7
43.4
39.1
39.1
38.0
39.1
44.5
49.3
46.7

Lbs./In.

12
15
28
385
19
36
104
12
3.1
45
50
281
20
15
23
15
88
91
229
144
370
4.6
.68
74
23
125
1.9
73
472
45
17
3.9
5.9
1.5
11
51
152
41
76
3.1
5.3
14
12
22
30
142
175
190
14
1.3
2.0
145
20
434
43
.75
6.6
14
70
26
518
5.8
5.5
30
6.0
37
15
224
25
21
1.5
.40
23
116
83
126
97
7.4
1.2
7.9

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

2.2
2.6
4.9
67
3.4
6.3
18
2.1
.55
7.9
8.7
49
3.6
2.6
4.0
2.7
15
16
40
25
65
.81
.12
13
4.0
22
.33
13
83
7.9
3.0
.68
1.0
.27
2.0
8.9
27
7.2
13
.54
.93
2.5
2.1
3.8
5.2
25
31
33
2.5
.23
.35
25
3.6
76
7.6
.13
1.2
2.4
12
4.5
91
1.0
.97
5.3
1.1
6.4
2.5
39
4.3
3.7
.25
.07
4.1
20
15
22
17
1.3
.21
1.4

2.9
3.0
2.7
1.0
3.7
3.1
.92
3.0
4.6
3.3
3.2
1.6
7.8
.71
.77
1.0
.69
1.1
.57
.61
.53
2.1
2.1
1.3
1.7
1.2
3.0
1.1
.81
2.0
3.0
4.3
4.1
5.4
3.4
3.1
1.9
3.8
3.1
7.5
5.9
6.9
6.8
5.9
5.2
2.7
.75
.69
2.5
4.0
4.3
2.0
.96
.53
1.9
3.4
4.1
4.6
3.1
1.0
.46
1.6
2.7
1.8
2.1
2.0
2.3
.89
2.5
2.7
4.5
4.4
3.5
2.2
2.8
2.6
2.7
6.7
1.4
3.4

mm

73
76
68
26
94
79
23
76
117
84
81
41
197
18
20
26
17
29
15
15
13
53
53
33
43
32
76
28
20
50
76
108
105
136
86
78
49
96
79
191
150
174
174
150
133
68
19
17
63
102
110
51
24
14
48
88
103
116
79
26
12
41
68
47
54
50
59
23
64
68
114
112
88
56
70
65
68
171
36
86

Lbs.

35
44
76
389
72
112
96
35
14
149
159
458
159
10
18
16
61
103
132
88
196
9.6
1.4
98
39
156
5.7
81
381
89
52
17
24
8.2
39
156
295
156
236
23
32
96
84
127
156
381
131
131
35
5.4
8.7
291
20
231
82
2.6
27
63
218
26
237
9.4
15
56
13
72
34
200
63
56
6.5
1.8
81
258
229
323
258
50
1.7
27

ENDS: C - Closed

G - Ground
O - Open

158
196
339
1730
321
497
425
155
64
661
706
2037
706
47
79
70
269
456
585
390
871
43
6.3
434
171
695
25
361
1694
396
232
74
109
36
171
695
1314
695
1050
103
140
429
373
565
695
1694
581
581
157
24
39
1296
88
1028
363
12
119
281
971
117
1055
42
66
247
57
322
150
888
279
247
29
7.8
362
1148
1021
1438
1148
221
7.6
120

Inches

1.03
1.87
1.73
3.12
2.66
2.90
.94
1.05
.73
3.74
3.60
5.30
8.10
.51
.48
.47
.42
1.10
1.01
.77
1.09
.33
.42
1.19
.71
1.63
.62
1.03
2.50
1.64
1.62
.84
1.50
.77
1.28
3.38
3.96
4.05
4.98
1.54
1.50
4.90
3.72
4.81
5.40
6.86
1.18
1.13
.95
.63
.92
3.79
.57
1.25
1.24
.31
1.57
2.07
4.26
.87
1.34
.63
.50
1.01
1.13
1.24
.81
1.48
1.30
1.30
.77
1.10
1.95
3.14
4.19
4.25
3.67
2.57
.35
.84

mm

26.1
47.5
43.8
79.2
67.4
73.6
23.7
26.7
18.5
95.0
91.4
134.5
205.7
13.0
12.2
12.0
10.7
28.0
25.7
19.5
27.8
8.3
10.6
30.2
18.0
41.4
15.8
26.1
63.4
41.7
41.1
21.3
38.1
19.4
32.6
85.7
100.6
102.9
126.4
39.0
38.1
124.4
94.4
122.2
137.2
174.3
30.0
28.6
24.0
16.1
23.4
96.4
14.4
31.6
31.5
7.7
39.8
52.5
108.1
22.2
34.1
16.0
12.7
25.7
28.6
31.5
20.6
37.6
33.1
32.9
19.7
27.9
49.5
79.9
106.5
107.8
93.2
65.4
8.9
21.3

WIRE DIA.
Inches

0.135
0.156
0.177
0.312
0.177
0.207
0.187
.135
0.097
0.225
0.225
0.331
0.225
0.114
0.120
0.105
0.140
0.192
0.225
0.192
0.243
0.082
0.062
0.190
0.135
0.225
0.086
0.187
0.312
0.193
0.162
0.100
0.125
0.085
0.135
0.225
0.283
0.225
0.262
0.116
0.125
0.192
0.177
0.207
0.225
0.312
0.225
0.225
0.135
0.079
0.092
0.283
0.126
0.262
0.177
0.061
0.131
0.162
0.254
0.152
0.283
0.105
0.100
0.162
0.125
0.177
0.135
0.247
0.162
0.162
0.086
0.072
0.177
0.262
0.262
0.283
0.262
0.156
0.068
0.120

mm

TOTAL
MATL
COILS

3.4
4.0
4.5
7.9
4.5
5.3
4.7
3.4
2.5
5.7
5.7
8.4
5.7
2.9
3.0
2.7
3.6
4.9
5.7
4.9
6.2
2.1
1.6
4.8
3.4
5.7
2.2
4.7
7.9
4.9
4.1
2.5
3.2
2.2
3.4
5.7
7.2
5.7
6.7
2.9
3.2
4.9
4.5
5.3
5.7
7.9
5.7
5.7
3.4
2.0
2.3
7.2
3.2
6.7
4.5
1.5
3.3
4.1
6.5
3.9
7.2
2.7
2.5
4.1
3.2
4.5
3.4
6.3
4.1
4.1
2.2
1.8
4.5
6.7
6.7
7.2
6.7
4.0
1.7
3.0

7.67
12.0
9.75
10.0
15.0
14.0
5.00
7.75
7.50
16.0
16.0
16.0
36.0
4.50
4.00
3.50
3.00
5.75
4.50
4.00
4.50
4.00
5.75
6.25
5.25
7.25
7.25
5.50
8.00
8.50
10.0
7.38
11.0
9.00
8.50
15.0
14.0
18.0
19.0
13.3
12.0
25.5
21.0
23.3
24.0
22.0
5.25
5.00
7.00
7.00
9.00
13.5
4.50
4.75
7.00
5.00
11.0
12.8
16.8
5.75
4.75
6.00
5.00
6.25
9.00
7.00
6.00
6.00
8.00
8.00
9.00
14.3
11.0
12.0
16.0
15.0
14.0
16.5
5.00
7.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SST
SPR
SST
SPR
HD
SST
SPR
SST
SST
SPR
HD
SPR
SPR
SPR
SPR
SST
MW
SPR
SST
SST
HD
MW
SST
SPR
SPR
HD
SST
SST
SPR
SST
SST
SPR
SPR
SPR
HD
SPR
SPR
SPR
SPR
SST
SPR
SPR
HD
HD
HD
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SST
SST
SST
SST
SST
SPR
SPR
SST
SPR
HD
SPR
OT
SPR
OT
OT
SST
SPR
SPR

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG

N
Z
N
Z
Z
N
Z
N
N
Z
Z
Z
Z
Z
Z
N
Z
Z
N
N
Z
N
N
Z
Z
Z
N
N
Z
N
N
Z
Z
GI
GI
N
GI
Z
Z
N
Z
Z
Z
Z
Z
Z
N
N
Z
N
Z
Z
Z
Z
GI
N
Z
Z
N
N
N
Z
N
N
N
N
N
Z
Z
N
GI
Z
N
Z
BO
Z
Z
N
Z
Z

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 215

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

Inches

2.078
2.094
2.094
2.094
2.094
2.094
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.109
2.125
2.125
2.125
2.125
2.125
2.125
2.125
2.125
2.125
2.125
2.125
2.140
2.140
2.140
2.140
2.140
2.140
2.140
2.140
2.140
2.140
2.140
2.156
2.156
2.172
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187

52.78
53.19
53.19
53.19
53.19
53.19
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.57
53.98
53.98
53.98
53.98
53.98
53.98
53.98
53.98
53.98
53.98
53.98
54.36
54.36
54.36
54.36
54.36
54.36
54.36
54.36
54.36
54.36
54.36
54.76
54.76
55.17
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55

S-1661
3372
11715
4298
11869
10400
3229
S-389
2754
12083
S-1644
3452
S-1674
2688
1615
11849
S-152
S-3023
S-3236
12627
S-3151
S-3072
10607
11860
S-3168
S-3213
12054
4332
S-1640
S-3093
S-3161
S-3211
S-89
S-101
S-3073
11604
S-174
S-447
1841
S-258
S-3019
4101
11786
S-3036
11823
3493
3059
73017
73024
73031
73038
73045
73052
73059
73066
S-1641
S-113
S-440
73018
73025
73032
73039
73046
73053
73060
73067
S-3028
73019
73026
73033
73040
73047
73054
73061
73068
3074
73020
73027
73034
73041

4.44
1.38
1.75
2.25
2.53
4.50
1.06
1.38
1.50
1.66
2.06
2.25
2.50
2.88
2.91
4.63
4.84
5.50
6.03
8.50
.69
3.63
5.38
5.38
5.50
5.66
6.03
6.50
6.75
7.00
7.00
2.34
2.63
3.13
3.25
3.50
4.38
5.16
5.75
6.38
8.88
9.00
1.47
5.50
5.75
1.75
2.13
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.09
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.50
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.38
7.00
7.00
7.00
7.00

O.D.

MATERIAL: MW - Music Wire

FREE LENGTH

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

112.7
34.9
44.5
57.2
64.3
114.3
27.0
34.9
38.1
42.1
52.4
57.2
63.5
73.0
73.8
117.5
123.0
139.7
153.2
215.9
17.4
92.1
136.5
136.5
139.7
143.7
153.2
165.1
171.5
177.8
177.8
59.5
66.7
79.4
82.6
88.9
111.1
131.0
146.1
161.9
225.4
228.6
37.3
139.7
146.1
44.5
54.0
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
104.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
139.7
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
161.9
177.8
177.8
177.8
177.8

I.D.
Inches

1.870
1.644
1.956
1.854
1.782
1.798
1.721
1.585
1.869
1.899
1.785
1.925
1.989
1.705
1.321
1.917
1.927
1.749
1.899
1.649
1.875
1.813
1.915
1.899
1.899
1.859
1.915
1.511
1.813
1.941
1.855
1.984
1.700
1.828
1.766
2.006
1.920
1.930
1.936
1.890
1.780
1.516
2.000
1.886
1.962
1.927
1.917
1.773
1.751
1.687
1.625
1.563
1.501
1.437
1.401
1.813
1.977
1.927
1.773
1.751
1.687
1.625
1.563
1.501
1.437
1.401
1.937
1.773
1.751
1.687
1.625
1.563
1.501
1.437
1.401
2.043
1.773
1.751
1.687
1.625

RATE
mm

47.5
41.8
49.7
47.1
45.3
45.7
43.7
40.3
47.5
48.2
45.3
48.9
50.5
43.3
33.6
48.7
48.9
44.4
48.2
41.9
47.6
46.1
48.6
48.2
48.2
47.2
48.6
38.4
46.1
49.3
47.1
50.4
43.2
46.4
44.9
51.0
48.8
49.0
49.2
48.0
45.2
38.5
50.8
47.9
49.8
48.9
48.7
45.0
44.5
42.8
41.3
39.7
38.1
36.5
35.6
46.1
50.2
48.9
45.0
44.5
42.8
41.3
39.7
38.1
36.5
35.6
49.2
45.0
44.5
42.8
41.3
39.7
38.1
36.5
35.6
51.9
45.0
44.5
42.8
41.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

4.3
.75
564
99
1.3
.23
14
2.5
19
3.3
17
3.0
193
34
703 123
38
6.6
14
2.5
28
4.9
4.2
.73
.55
.10
86
15
1962 344
3.8
.66
2.6
.46
17
3.0
3.8
.66
56
9.9
76
13
16
2.8
2.1
.37
5.5
.96
5.0
.88
6.1
1.1
3.3
.57
202
35
13
2.3
2.8
.50
7.0
1.2
1.7
.29
83
14
31
5.4
34
6.0
.81
.14
6.3
1.1
6.0
1.1
3.7
.64
4.1
.73
15
2.5
127
22
4.0
.69
6.3
1.1
3.5
.61
16
2.8
26
4.6
68
12
81
14
134
24
216
38
344
60
552
97
831 146
1080 189
41
7.2
2.8
.49
5.4
.94
54
9.5
63
11
103
18
167
29
267
47
423
74
637 112
825 144
4.4
.76
44
7.7
52
9.0
86
15
136
24
218
38
343
60
514
90
664 116
.68
.12
38
6.6
44
7.6
72
13
115
20

3.8
.27
1.4
1.7
1.4
2.8
.38
.26
.98
1.3
1.0
1.8
2.1
1.3
.35
3.4
4.3
3.3
4.5
2.8
.25
2.4
4.1
4.0
4.0
4.3
5.2
1.7
3.7
4.0
4.7
1.9
1.1
1.6
1.8
3.0
2.9
2.8
4.9
5.0
4.7
2.8
1.2
4.2
4.7
1.1
1.4
1.9
1.9
1.6
1.4
1.1
.92
.79
.68
1.8
4.1
3.7
2.4
2.4
2.1
1.8
1.5
1.2
1.0
.89
4.3
3.0
3.0
2.6
2.2
1.8
1.5
1.3
1.1
5.7
3.5
3.5
3.1
2.6

mm

96
6.7
36
43
35
72
9.7
6.7
25
32
27
45
54
33
8.8
88
109
83
115
71
6.3
60
105
102
102
109
132
43
93
102
118
49
28
40
45
77
75
71
125
127
119
71
30
105
120
28
34
49
48
42
35
29
23
20
17
46
103
95
61
62
54
46
38
31
26
23
108
76
75
65
56
46
38
32
28
145
88
89
78
66

ENDS: C - Closed

G - Ground
O - Open

Lbs.

16
150
1.8
24
26
48
74
186
37
18
29
7.5
1.2
112
677
13
11
57
17
159
19
38
8.6
22
20
26
17
344
48
11
33
3.2
90
48
60
2.5
18
17
18
21
68
359
4.7
26
17
17
35
131
153
220
300
396
508
657
733
74
11
20
131
153
220
300
396
508
657
733
18
131
153
220
300
396
508
657
733
3.9
131
153
220
300

72
666
8.2
105
114
215
329
826
165
82
131
33
5.2
500
3012
58
50
252
76
706
85
171
38
98
89
117
75
1531
215
51
145
14
399
213
267
11
82
75
81
92
302
1595
21
116
74
77
157
584
680
980
1335
1759
2261
2922
3262
331
51
90
584
680
980
1335
1759
2261
2922
3262
82
584
680
980
1335
1759
2261
2922
3262
17
584
680
980
1335

Inches

mm

Inches

.68 17.2
.68 17.1
.35
8.8
.57 14.5
1.17 29.7
1.11 28.2
.68 17.2
.89 22.6
.36
9.1
.37
9.3
1.01 25.7
.46 11.7
.39
9.9
1.21 30.8
2.17 55.0
.62 15.8
.55 13.9
2.25 57.2
.81 20.7
2.93 74.5
.44 11.1
1.25 31.7
1.26 32.0
.93 23.7
.79 20.1
1.36 34.6
.81 20.7
3.84 97.5
1.48 37.6
.62 15.8
1.42 36.0
.41 10.4
1.54 39.1
.78 19.7
1.50 38.0
.47 11.9
.61 15.4
.53 13.3
.82 20.7
1.38 34.9
2.52 64.0
6.08 154.5
.27
6.9
1.35 34.3
.74 18.7
.65 16.5
.56 14.1
1.45 36.8
1.58 40.2
1.94 49.2
2.25 57.1
2.50 63.4
2.66 67.5
2.91 73.8
2.95 74.9
1.26 32.1
.95 24.0
1.25 31.8
1.71 43.4
1.91 48.5
2.38 60.3
2.74 69.6
3.04 77.3
3.26 82.8
3.56 90.5
3.62 91.8
1.25 31.8
2.02 51.3
2.24 56.8
2.75 69.9
3.23 82.1
3.59 91.1
3.86 98.0
4.24 107.6
4.30 109.3
.65 16.5
2.28 57.9
2.56 65.1
3.19 80.9
3.72 94.6

0.104
0.225
0.069
0.120
0.156
0.148
0.194
0.262
0.120
0.105
0.162
0.092
0.060
0.202
0.394
0.096
0.091
0.180
0.105
0.230
0.125
0.156
0.105
0.113
0.113
0.133
0.105
0.307
0.156
0.092
0.135
0.078
0.220
0.156
0.187
0.067
0.110
0.105
0.102
0.125
0.180
0.312
0.078
0.135
0.105
0.130
0.135
0.207
0.218
0.250
0.281
0.312
0.343
0.375
0.393
0.187
0.105
0.130
0.207
0.218
0.250
0.281
0.312
0.343
0.375
0.393
0.125
0.207
0.218
0.250
0.281
0.312
0.343
0.375
0.393
0.072
0.207
0.218
0.250
0.281

mm

TOTAL
MATL
COILS

2.6
5.7
1.8
3.0
4.0
3.8
4.9
6.7
3.0
2.7
4.1
2.3
1.5
5.1
10.0
2.4
2.3
4.6
2.7
5.8
3.2
4.0
2.7
2.9
2.9
3.4
2.7
7.8
4.0
2.3
3.4
2.0
5.6
4.0
4.7
1.7
2.8
2.7
2.6
3.2
4.6
7.9
2.0
3.4
2.7
3.3
3.4
5.3
5.5
6.4
7.1
7.9
8.7
9.5
10.0
4.7
2.7
3.3
5.3
5.5
6.4
7.1
7.9
8.7
9.5
10.0
3.2
5.3
5.5
6.4
7.1
7.9
8.7
9.5
10.0
1.8
5.3
5.5
6.4
7.1

6.50
3.00
5.00
4.75
7.50
7.50
3.50
3.38
3.00
3.50
6.25
5.00
5.50
6.00
5.50
5.50
6.00
12.5
7.75
12.8
2.50
8.00
11.0
7.25
7.00
10.3
7.75
12.5
9.50
5.75
9.50
5.25
7.00
5.00
8.00
6.00
5.50
5.00
7.00
11.0
14.0
19.5
3.50
10.0
7.00
5.00
4.00
7.00
7.25
7.75
8.00
8.00
7.75
7.75
7.50
6.75
8.00
9.67
8.25
8.75
9.50
9.75
9.75
9.50
9.50
9.20
10.0
9.76
10.3
11.0
11.5
11.5
11.3
11.3
11.0
8.00
11.0
11.8
12.7
13.3

SST
SPR
SPR
SPR
SST
SPR
SPR
SST
MW
SPR
SST
SPR
SST
SPR
SPR
SST
SST
SST
SST
SPR
SST
SST
SST
SPR
SST
SST
SST
SPR
SST
SST
SST
SST
SST
SST
SST
SPR
SST
SST
MW
SST
SST
SPR
SPR
SST
SST
SPR
SPR
OT
OT
OT
OT
OT
OT
OT
OT
SST
SST
SST
OT
OT
OT
OT
OT
OT
OT
OT
SST
OT
OT
OT
OT
OT
OT
OT
OT
SPR
OT
OT
OT
OT

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
C
CG
CG
CG
CG
C
CG
C
C
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG

F
N
S
H

N
Z
GI
Z
N
Z
Z
N
Z
Z
N
Z
N
Z
Z
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
Z
N
N
Z
N
N
Z
N
N
N
Z
GI
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

215

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 216

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.187
2.203
2.219
2.219
2.219
2.219
2.234
2.250
2.250
2.250
2.250
2.250
2.250
2.250
2.250
2.250
2.250
2.250
2.250
2.250
2.266
2.281
2.281
2.296
2.296
2.296
2.312
2.312
2.312
2.312
2.312
2.312
2.312
2.312
2.312
2.312
2.328
2.328
2.343
2.343
2.343
2.343
2.343
2.343
2.343
2.343
2.359
2.359
2.375
2.375
2.375
2.375
2.375

55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.55
55.96
56.36
56.36
56.36
56.36
56.74
57.15
57.15
57.15
57.15
57.15
57.15
57.15
57.15
57.15
57.15
57.15
57.15
57.15
57.56
57.94
57.94
58.32
58.32
58.32
58.72
58.72
58.72
58.72
58.72
58.72
58.72
58.72
58.72
58.72
59.13
59.13
59.51
59.51
59.51
59.51
59.51
59.51
59.51
59.51
59.92
59.92
60.33
60.33
60.33
60.33
60.33

73048
73055
73062
73069
73021
73028
73035
73042
73049
73056
73063
73070
73022
73029
73036
73043
73050
73057
73064
73071
73023
73030
73037
73044
73051
73058
73065
73072
4276
3072
12615
11297
4227
3205
S-3219
S-3215
4394
4366
4218
S-355
1935
S-354
10161
10275
7013
10692
7015
S-1660
S-1646
10272
10984
S-1629
S-1659
12082
4198
4354
2869
3287
12721
3482
10151
10166
S-3188
11417
4009
S-239
10281
3120
3078
3284
3488
10271
S-376
10440
S-427
10367
S-1662
S-1654
4006
S-315

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

7.00
7.00
7.00
7.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
9.00
9.00
9.00
9.00
9.00
9.00
9.00
9.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
5.00
1.38
1.75
3.75
5.75
5.00
2.09
3.25
5.25
5.75
7.00
7.50
8.13
9.25
9.50
9.50
10.0
14.0
16.0
2.78
1.38
9.50
1.94
8.09
10.4
1.97
3.00
3.25
3.50
4.25
5.31
7.50
8.50
9.25
13.0
6.38
18.5
2.13
3.00
3.75
4.00
4.00
7.00
8.00
8.25
3.09
4.88
3.00
4.16
4.44
4.75
4.94

mm

177.8
177.8
177.8
177.8
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
228.6
228.6
228.6
228.6
228.6
228.6
228.6
228.6
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
127.0
34.9
44.5
95.3
146.1
127.0
53.2
82.6
133.4
146.1
177.8
190.5
206.4
235.0
241.3
241.3
254.0
355.6
406.4
70.6
34.9
241.3
49.2
205.6
263.5
50.0
76.2
82.6
88.9
108.0
134.9
190.5
215.9
235.0
330.2
161.9
469.9
54.0
76.2
95.3
101.6
101.6
177.8
203.2
209.6
78.6
123.8
76.2
105.6
112.7
120.7
125.4

MATERIAL: MW - Music Wire

216

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.563
1.501
1.437
1.401
1.773
1.751
1.687
1.625
1.563
1.501
1.437
1.401
1.773
1.751
1.687
1.625
1.563
1.501
1.437
1.401
1.773
1.751
1.687
1.625
1.563
1.501
1.437
1.401
1.933
1.695
2.035
1.907
1.949
1.820
1.954
2.040
1.750
1.374
1.926
1.980
1.836
2.010
1.726
1.684
1.500
1.876
1.500
1.832
1.987
1.715
1.796
2.058
2.058
2.188
2.122
1.588
1.982
1.892
1.752
1.988
2.072
1.700
1.588
2.058
2.094
2.047
1.843
2.073
2.093
2.093
2.019
1.681
1.779
1.793
1.909
1.875
2.063
2.063
1.501
2.165

RATE
mm

39.7
38.1
36.5
35.6
45.0
44.5
42.8
41.3
39.7
38.1
36.5
35.6
45.0
44.5
42.8
41.3
39.7
38.1
36.5
35.6
45.0
44.5
42.8
41.3
39.7
38.1
36.5
35.6
49.1
43.1
51.7
48.4
49.5
46.2
49.6
51.8
44.5
34.9
48.9
50.3
46.6
51.1
43.8
42.8
38.1
47.7
38.1
46.5
50.5
43.6
45.6
52.3
52.3
55.6
53.9
40.3
50.3
48.1
44.5
50.5
52.6
43.2
40.3
52.3
53.2
52.0
46.8
52.7
53.2
53.2
51.3
42.7
45.2
45.5
48.5
47.6
52.4
52.4
38.1
55.0

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

183
32
289
51
432
76
559
98
32
5.7
38
6.6
62
11
100
17
157
28
249
44
372
65
480
84
28
5.0
33
5.8
55
9.7
88
15
139
24
219
38
327
57
422
74
26
4.5
30
5.2
50
8.7
78
14
124
22
195
34
292
51
376
66
10
1.8
904 158
4.7
.81
24
4.2
10
1.8
47
8.2
15
2.7
6.3
1.1
134
23
1046 183
15
2.6
4.1
.71
31
5.4
2.2
.39
72
13
105
18
250
44
9.0
1.6
150
26
110
19
46
8.1
108
19
219
38
3.3
.58
3.1
.54
.47
.08
2.1
.38
888 155
31
5.4
60
11
211
37
13
2.3
4.0
.71
108
19
138
24
3.9
.69
2.3
.40
22
3.8
153
27
13
2.2
9.5
1.7
9.2
1.6
11
1.9
242
42
72
13
344
60
51
8.9
146
26
12
2.0
15
2.5
1200 210
3.2
.57

2.2
1.8
1.5
1.3
4.1
4.0
3.6
3.0
2.5
2.0
1.8
1.5
4.6
4.6
4.0
3.4
2.8
2.3
2.0
1.7
5.1
5.1
4.4
3.8
3.2
2.6
2.3
2.0
3.4
.24
1.3
2.2
3.5
2.4
1.2
2.6
1.4
.81
3.8
5.6
3.7
7.6
2.9
2.5
2.3
9.3
3.8
1.0
.85
2.4
.69
6.6
7.0
1.5
2.2
.57
1.9
1.9
1.2
4.2
6.0
2.9
2.9
4.6
9.9
1.3
1.2
2.6
2.8
2.9
5.1
1.6
2.9
.74
2.2
1.2
2.9
3.0
.67
4.3

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

55
45
39
33
103
103
91
77
64
52
45
39
118
117
101
87
72
59
51
44
130
130
112
97
81
66
57
50
87
6.0
33
55
88
62
30
65
36
21
98
143
93
192
75
64
58
236
96
26
22
62
17
167
178
39
57
14
49
49
30
107
152
75
74
116
251
33
30
66
72
75
128
41
73
19
56
31
74
76
17
109

Lbs.

396 1759
508 2261
657 2922
733 3262
131
584
153
680
220
980
300 1335
396 1759
508 2261
657 2922
733 3262
131
584
153
680
220
980
300 1335
396 1759
508 2261
657 2922
733 3262
131
584
153
680
220
980
300 1335
396 1759
508 2261
657 2922
733 3262
35
156
214
954
6.0
27
52
232
35
155
114
509
18
81
16
71
191
848
845 3759
58
256
23
102
114
505
17
75
212
942
265 1180
570 2534
83
371
570 2534
112
497
39
175
262 1165
150
669
22
97
22
97
.72
3.2
4.8
21
502 2235
59
263
115
514
251 1115
56
250
24
108
316 1405
401 1782
18
80
22
99
28
124
184
817
33
147
27
120
27
120
54
238
392 1744
209
929
254 1129
113
501
181
806
33
149
43
193
802 3569
14
62

ENDS: C - Closed

G - Ground
O - Open

Inches

4.15
4.46
4.90
4.96
2.59
2.89
3.63
4.21
4.72
5.06
5.57
5.65
2.90
3.22
4.00
4.70
5.27
5.66
6.23
6.32
3.16
3.55
4.38
5.20
5.81
6.26
6.89
7.00
.98
.79
.46
.94
.98
1.81
.93
.47
1.81
4.60
1.50
1.86
2.48
1.68
3.67
3.82
7.70
4.72
12.0
1.09
.49
3.61
1.25
1.13
1.19
.43
.76
2.08
.91
1.47
1.96
1.54
1.08
5.05
8.33
1.79
1.64
.83
1.50
.74
.80
.81
1.94
3.56
4.09
1.42
1.91
1.50
1.25
1.05
3.50
.63

mm

105.4
113.2
124.4
126.0
65.9
73.4
92.1
107.0
119.9
128.5
141.5
143.5
73.7
81.8
101.6
119.5
133.7
143.8
158.4
160.4
80.3
90.1
111.2
132.1
147.6
159.0
175.0
177.7
24.9
20.0
11.7
23.8
24.9
46.0
23.5
12.0
46.0
116.8
38.1
47.1
63.1
42.7
93.2
97.1
195.6
119.9
304.8
27.6
12.4
91.6
31.8
28.7
30.2
11.0
19.3
52.9
23.1
37.3
49.8
39.1
27.4
128.2
211.5
45.4
41.6
21.1
38.1
18.9
20.2
20.6
49.4
90.4
103.9
35.9
48.6
38.1
31.7
26.7
88.8
16.0

WIRE DIA.
Inches

0.312
0.343
0.375
0.393
0.207
0.218
0.250
0.281
0.312
0.343
0.375
0.393
0.207
0.218
0.250
0.281
0.312
0.343
0.375
0.393
0.207
0.218
0.250
0.281
0.312
0.343
0.375
0.393
0.135
0.262
0.092
0.156
0.135
0.207
0.148
0.105
0.250
0.438
0.162
0.135
0.207
0.120
0.262
0.283
0.375
0.187
0.375
0.217
0.147
0.283
0.250
0.119
0.119
0.062
0.095
0.362
0.165
0.210
0.280
0.162
0.120
0.306
0.362
0.135
0.117
0.148
0.250
0.135
0.125
0.125
0.162
0.331
0.283
0.283
0.225
0.250
0.156
0.156
0.437
0.105

mm

TOTAL
MATL
COILS

7.9
8.7
9.5
10.0
5.3
5.5
6.4
7.1
7.9
8.7
9.5
10.0
5.3
5.5
6.4
7.1
7.9
8.7
9.5
10.0
5.3
5.5
6.4
7.1
7.9
8.7
9.5
10.0
3.4
6.7
2.3
4.0
3.4
5.3
3.8
2.7
6.4
11.1
4.1
3.4
5.3
3.0
6.7
7.2
9.5
4.7
9.5
5.5
3.7
7.2
6.4
3.0
3.0
1.6
2.4
9.2
4.2
5.3
7.1
4.1
3.0
7.8
9.2
3.4
3.0
3.8
6.4
3.4
3.2
3.2
4.1
8.4
7.2
7.2
5.7
6.4
4.0
4.0
11.1
2.7

13.3
13.0
13.1
12.6
12.5
13.3
14.5
15.0
15.1
14.7
14.9
14.4
14.0
14.8
16.0
16.7
16.9
16.5
16.6
16.1
15.3
16.3
17.5
18.5
18.6
18.2
18.4
17.8
7.25
3.00
4.00
6.00
7.25
8.75
6.25
4.50
7.25
10.5
9.25
12.8
12.0
14.0
14.0
13.5
19.3
24.3
30.8
5.00
3.33
12.8
5.00
9.50
10.0
6.00
7.00
5.75
5.50
7.00
7.00
9.50
9.00
16.5
23.0
12.3
13.0
4.67
6.00
5.50
5.38
5.50
11.0
10.8
14.5
5.00
8.50
6.00
8.00
6.75
8.00
6.00

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
SPR
SST
SPR
SPR
SPR
SST
SST
SPR
SPR
SPR
SST
SPR
SST
SPR
SPR
HD
SPR
HD
SST
SST
SPR
HD
SST
SST
SPR
SPR
SPR
SPR
SPR
HD
SPR
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SPR
SPR
SST
SPR
SST
SPR
SST
SST
SPR
SST

E
N
D
S

F
N
S
H

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
C
C
C
CG
CG
C
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
N
Z
Z
Z
N
N
Z
N
N
N
Z
N
N
Z
Z
Z
Z
N
N
Z
N
N
N
Z
Z
GI
GI
Z
N
Z
Z
N
N
N
Z
N
Z
Z
Z
Z
Z
Z
N
N
N
Z
N
N
BO
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 217

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

2.375
2.375
2.375
2.375
2.375
2.375
2.390
2.406
2.406
2.406
2.406
2.406
2.406
2.406
2.406
2.406
2.406
2.406
2.421
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.437
2.468
2.468
2.468
2.500
2.500
2.500
2.500

60.33
60.33
60.33
60.33
60.33
60.33
60.71
61.11
61.11
61.11
61.11
61.11
61.11
61.11
61.11
61.11
61.11
61.11
61.49
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
61.90
62.69
62.69
62.69
63.50
63.50
63.50
63.50

S-318
S-3094
4326
12043
S-137
4405
4168
S-149
11573
4112
S-986
10582
10278
S-161
S-964
11506
S-396
S-3098
10276
4203
73073
73079
73085
73091
73097
73103
73109
73115
73074
73080
73086
73092
73098
73104
73110
73116
3110
73075
73081
73087
73093
73099
73105
73111
73117
73076
73082
73088
73094
73100
73106
73112
73118
10236
S-3232
73077
73083
73089
73095
73101
73107
73113
73119
73078
73084
73090
73096
73102
73108
73114
73120
3483
10163
4185
4129
4379
11956
10941
12591
4313

O.D.

FREE LENGTH
Inches

5.75
6.63
7.50
9.56
11.8
11.8
3.13
2.13
3.06
3.13
3.16
3.75
4.00
4.13
4.88
5.13
7.00
16.0
3.00
3.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
4.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.13
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.75
7.88
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.8
11.0
3.75
6.75
7.50
2.22
4.00
5.00
5.50

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

146.1
168.3
190.5
242.9
298.5
298.5
79.4
54.0
77.8
79.4
80.2
95.3
101.6
104.8
123.8
130.2
177.8
406.4
76.2
76.2
101.6
101.6
101.6
101.6
101.6
101.6
101.6
101.6
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
130.2
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
196.9
200.0
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
273.1
279.4
95.3
171.5
190.5
56.4
101.6
127.0
139.7

I.D.
Inches

2.165
2.063
2.051
2.079
2.063
1.751
2.036
2.110
2.242
2.052
1.992
1.882
1.882
2.094
2.196
1.972
2.166
2.094
1.855
2.083
1.875
1.813
1.751
1.713
1.687
1.651
1.625
1.563
1.875
1.813
1.751
1.713
1.687
1.651
1.625
1.563
2.125
1.875
1.813
1.751
1.713
1.687
1.651
1.625
1.563
1.875
1.813
1.751
1.713
1.687
1.651
1.625
1.563
1.847
2.137
1.875
1.813
1.751
1.713
1.687
1.651
1.625
1.563
1.875
1.813
1.751
1.713
1.687
1.651
1.625
1.563
1.987
1.813
2.132
2.054
1.806
2.174
1.376
2.202
2.000

RATE
mm

55.0
52.4
52.1
52.8
52.4
44.5
51.7
53.6
56.9
52.1
50.6
47.8
47.8
53.2
55.8
50.1
55.0
53.2
47.1
52.9
47.6
46.1
44.5
43.5
42.8
41.9
41.3
39.7
47.6
46.1
44.5
43.5
42.8
41.9
41.3
39.7
54.0
47.6
46.1
44.5
43.5
42.8
41.9
41.3
39.7
47.6
46.1
44.5
43.5
42.8
41.9
41.3
39.7
46.9
54.3
47.6
46.1
44.5
43.5
42.8
41.9
41.3
39.7
47.6
46.1
44.5
43.5
42.8
41.9
41.3
39.7
50.5
46.1
54.2
52.2
45.9
55.2
35.0
55.9
50.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

2.7
14
12
6.9
5.4
113
43
19
3.5
42
65
161
153
11
3.1
51
3.7
5.9
252
41
170
270
412
526
617
765
932
1310
132
210
315
402
472
584
704
989
17
108
169
255
325
381
472
574
794
92
142
217
273
320
396
478
664
138
11
79
123
186
235
276
342
414
575
63
98
147
186
216
268
322
448
28
105
24
23
262
32
5254
11
99

.48
2.4
2.1
1.2
.95
20
7.6
3.3
.60
7.4
11
28
27
1.9
.55
8.9
.65
1.0
44
7.1
30
47
72
92
108
134
163
229
23
37
55
70
83
102
123
173
3.0
19
30
45
57
67
83
101
139
16
25
38
48
56
69
84
116
24
2.0
14
22
33
41
48
60
72
101
11
17
26
33
38
47
56
78
5.0
18
4.1
4.0
46
5.6
920
1.9
17

5.0
3.2
4.5
6.2
8.0
2.9
1.6
1.4
2.3
1.7
1.4
1.3
1.3
2.9
4.1
2.4
5.8
7.2
.99
1.7
1.6
1.3
1.1
1.0
.97
.87
.79
.67
2.1
1.7
1.5
1.3
1.3
1.1
1.0
.89
2.8
2.5
2.1
1.8
1.7
1.6
1.4
1.3
1.1
3.0
2.5
2.1
2.0
1.9
1.7
1.5
1.3
2.0
3.3
3.4
2.9
2.5
2.3
2.2
2.0
1.8
1.5
4.3
3.7
3.1
2.9
2.8
2.5
2.3
2.0
4.6
3.0
2.5
4.3
1.4
1.5
.28
3.8
1.8

mm

128
82
114
157
203
73
41
37
59
42
36
33
33
73
105
61
146
183
25
43
41
34
28
26
25
22
20
17
52
43
37
34
32
29
26
23
72
64
54
46
42
40
36
32
28
75
64
54
50
47
43
39
34
51
84
87
74
63
58
55
50
45
39
109
93
80
74
70
63
58
50
116
77
63
108
36
38
7.2
97
44

ENDS: C - Closed

G - Ground
O - Open

Lbs.

14
43
55
43
43
326
71
27
8.1
70
92
206
199
31
13
122
21
43
248
69
271
358
461
539
597
668
733
883
271
358
461
539
597
668
733
883
48
271
358
461
539
597
668
733
883
271
358
461
539
597
668
733
883
278
38
271
358
461
539
597
668
733
883
271
358
461
539
597
668
733
883
130
319
59
97
374
47
1483
42
173

61
193
243
191
193
1451
314
122
36
312
408
914
884
139
57
545
95
191
1102
308
1207
1594
2052
2399
2657
2970
3261
3929
1207
1594
2052
2399
2657
2970
3261
3929
212
1207
1594
2052
2399
2657
2970
3261
3929
1207
1594
2052
2399
2657
2970
3261
3929
1237
168
1207
1594
2052
2399
2657
2970
3261
3929
1207
1594
2052
2399
2657
2970
3261
3929
577
1417
261
433
1664
210
6595
185
768

Inches

.71
1.04
1.54
1.63
2.26
4.91
.89
.69
.37
.89
1.10
1.64
1.70
1.25
.74
1.95
.95
2.08
1.63
.89
2.04
2.26
2.49
2.63
2.72
2.85
2.84
3.06
2.47
2.73
3.05
3.21
3.33
3.49
3.50
3.77
.98
2.89
3.24
3.60
3.80
3.94
4.13
4.11
4.48
3.29
3.74
4.11
4.39
4.55
4.77
4.77
5.19
2.95
1.01
3.74
4.22
4.68
4.98
5.16
5.40
5.38
5.85
4.55
5.14
5.74
6.10
6.38
6.67
6.69
7.27
3.15
4.84
1.01
2.48
2.90
.73
3.23
1.19
1.75

mm

Inches

18.0
26.4
39.1
41.4
57.5
124.8
22.5
17.4
9.4
22.5
28.0
41.6
43.3
31.7
18.7
49.6
24.0
52.8
41.3
22.5
51.8
57.5
63.3
66.7
69.1
72.4
72.2
77.7
62.6
69.4
77.4
81.6
84.5
88.6
88.9
95.7
24.8
73.4
82.4
91.5
96.6
100.1
104.9
104.4
113.8
83.7
95.1
104.4
111.5
115.6
121.2
121.2
131.7
74.9
25.7
95.1
107.3
118.9
126.5
130.9
137.2
136.8
148.7
115.6
130.6
145.9
155.0
162.0
169.5
169.9
184.6
80.0
122.8
25.6
63.1
73.6
18.6
82.1
30.3
44.5

0.105
0.156
0.162
0.148
0.156
0.312
0.177
0.148
0.082
0.177
0.207
0.262
0.262
0.156
0.105
0.217
0.120
0.156
0.283
0.177
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.156
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.295
0.150
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.225
0.312
0.168
0.207
0.331
0.163
0.562
0.148
0.250

mm

TOTAL
MATL
COILS

2.7
4.0
4.1
3.8
4.0
7.9
4.5
3.8
2.1
4.5
5.3
6.7
6.7
4.0
2.7
5.5
3.0
4.0
7.2
4.5
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
4.0
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
7.5
3.8
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
5.7
7.9
4.3
5.3
8.4
4.1
14.3
3.8
6.4

6.75
6.75
9.50
11.0
14.5
15.8
5.00
4.67
3.50
5.00
5.33
6.3
6.50
8.00
6.00
8.00
8.00
13.3
5.75
5.00
7.26
7.26
7.26
7.25
7.26
7.25
7.00
7.00
8.78
8.76
8.88
8.87
8.87
8.88
8.62
8.63
6.25
10.3
10.4
10.5
10.5
10.5
10.5
10.1
10.3
11.7
12.0
12.0
12.1
12.1
12.1
11.8
11.9
10.0
6.75
13.3
13.5
13.7
13.8
13.7
13.7
13.3
13.4
16.2
16.5
16.7
16.9
17.0
17.0
16.5
16.6
14.0
15.5
6.00
12.0
8.75
4.50
5.75
7.00
7.00

SST
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SST
SPR
SPR
SST
SST
SPR
SST
SST
SPR
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
SST
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG

F
N
S
H

N
N
Z
Z
N
Z
Z
N
N
Z
N
N
N
N
N
Z
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
Z
N
Z
N
N
Z

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

217

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 218

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

2.500
2.500
2.500
2.500
2.500
2.562
2.578
2.593
2.593
2.625
2.625
2.625
2.625
2.625
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.687
2.703
2.703
2.734
2.734
2.734
2.750

63.50
63.50
63.50
63.50
63.50
65.07
65.48
65.86
65.86
66.68
66.68
66.68
66.68
66.68
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.25
68.66
68.66
69.44
69.44
69.44
69.85

10286
10238
10310
S-1639
S-3082
S-1651
3391
S-410
11896
11969
S-980
S-418
S-993
4410
4135
73121
73128
73135
73142
73149
73156
73163
73170
3327
73122
73129
73136
73143
73150
73157
73164
73171
73123
73130
73137
73144
73151
73158
73165
73172
10182
73124
73131
73138
73145
73152
73159
73166
73173
73125
73132
73139
73146
73153
73160
73167
73174
73126
73133
73140
73147
73154
73161
73168
73175
S-3118
73127
73134
73141
73148
73155
73162
73169
73176
4157
12019
1920
3058
3238
S-3157

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

6.50
7.75
9.63
10.5
17.0
1.94
3.50
8.75
9.63
2.84
3.00
3.00
3.88
4.00
2.50
4.00
4.00
4.00
4.00
4.00
4.50
4.50
4.50
4.88
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.25
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
9.00
9.00
9.00
9.00
9.00
9.00
9.00
9.00
9.50
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
6.25
7.00
3.75
5.00
6.25
2.50

mm

165.1
196.9
244.5
266.7
431.8
49.2
88.9
222.3
244.5
72.2
76.2
76.2
98.4
101.6
63.5
101.6
101.6
101.6
101.6
101.6
114.3
114.3
114.3
123.8
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
158.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
228.6
228.6
228.6
228.6
228.6
228.6
228.6
228.6
241.3
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
158.8
177.8
95.3
127.0
158.8
63.5

MATERIAL: MW - Music Wire

218

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.812
1.888
1.776
2.030
2.188
2.178
1.888
2.383
2.123
2.191
2.445
2.433
2.097
1.749
2.437
2.063
2.001
1.963
1.937
1.901
1.875
1.813
1.751
2.313
2.063
2.001
1.963
1.937
1.901
1.875
1.813
1.751
2.063
2.001
1.963
1.937
1.901
1.875
1.813
1.751
2.417
2.063
2.001
1.963
1.937
1.901
1.875
1.813
1.751
2.063
2.001
1.963
1.937
1.901
1.875
1.813
1.751
2.063
2.001
1.963
1.937
1.901
1.875
1.813
1.751
2.363
2.063
2.001
1.963
1.937
1.901
1.875
1.813
1.751
2.433
2.493
2.524
2.422
2.454
2.366

RATE
mm

46.0
48.0
45.1
51.6
55.6
55.3
48.0
60.5
53.9
55.7
62.1
61.8
53.3
44.4
61.9
52.4
50.8
49.9
49.2
48.3
47.6
46.1
44.5
58.8
52.4
50.8
49.9
49.2
48.3
47.6
46.1
44.5
52.4
50.8
49.9
49.2
48.3
47.6
46.1
44.5
61.4
52.4
50.8
49.9
49.2
48.3
47.6
46.1
44.5
52.4
50.8
49.9
49.2
48.3
47.6
46.1
44.5
52.4
50.8
49.9
49.2
48.3
47.6
46.1
44.5
60.0
52.4
50.8
49.9
49.2
48.3
47.6
46.1
44.5
61.8
63.3
64.1
61.5
62.3
60.1

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

259
140
235
20
2.6
43
457
2.0
30
91
1.9
3.3
95
1012
12
226
343
437
511
631
627
877
1262
16
175
262
334
392
481
549
767
1107
143
213
271
317
389
445
618
890
7.7
120
180
228
267
327
374
517
743
104
156
196
230
281
321
445
638
91
137
173
202
247
283
390
559
8.2
81
122
154
180
220
251
347
497
6.6
2.2
1.3
12
7.3
81

45
25
41
3.6
.45
7.6
80
.35
5.3
16
.34
.57
17
177
2.0
40
60
76
90
111
110
154
221
2.8
31
46
59
69
84
96
134
194
25
37
47
56
68
78
108
156
1.3
21
31
40
47
57
65
91
130
18
27
34
40
49
56
78
112
16
24
30
35
43
50
68
98
1.4
14
21
27
32
39
44
61
87
1.2
.39
.23
2.2
1.3
14

1.6
2.1
2.0
6.0
13
.98
.87
7.1
4.6
1.2
2.5
2.5
1.6
.82
2.0
1.4
1.2
1.1
1.1
.97
1.1
.93
.78
3.2
1.9
1.6
1.5
1.4
1.3
1.2
1.1
.89
2.3
2.0
1.8
1.7
1.6
1.5
1.3
1.1
3.8
2.7
2.3
2.2
2.1
1.9
1.8
1.6
1.3
3.1
2.7
2.5
2.4
2.2
2.1
1.8
1.5
3.6
3.1
2.9
2.7
2.5
2.4
2.1
1.8
5.2
4.0
3.5
3.2
3.0
2.8
2.7
2.3
2.0
4.3
6.3
2.7
3.4
4.3
.80

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

40
53
51
152
332
25
22
180
116
31
63
64
42
21
50
37
31
29
27
25
27
24
20
81
47
41
38
35
32
31
27
23
58
50
46
44
40
38
33
28
96
70
60
55
52
48
46
40
34
80
69
64
60
55
53
46
39
92
78
73
69
63
60
53
45
133
102
88
81
77
71
68
59
50
110
160
68
87
110
20

Lbs.

404
294
469
121
34
42
396
14
139
113
4.8
8.3
155
834
23
327
422
494
547
612
673
812
988
51
327
422
494
547
612
673
812
988
327
422
494
547
612
673
812
988
29
327
422
494
547
612
673
812
988
327
422
494
547
612
673
812
988
327
422
494
547
612
673
812
988
43
327
422
494
547
612
673
812
988
29
14
3.5
43
32
65

ENDS: C - Closed

G - Ground
O - Open

1797
1307
2084
539
149
189
1762
62
618
501
21
37
688
3709
102
1456
1877
2196
2434
2723
2992
3610
4395
228
1456
1877
2196
2434
2723
2992
3610
4395
1456
1877
2196
2434
2723
2992
3610
4395
129
1456
1877
2196
2434
2723
2992
3610
4395
1456
1877
2196
2434
2723
2992
3610
4395
1456
1877
2196
2434
2723
2992
3610
4395
192
1456
1877
2196
2434
2723
2992
3610
4395
128
62
16
190
141
287

Inches

3.35
3.21
4.62
4.35
3.93
.96
2.07
.74
3.06
.98
.51
.48
1.82
3.07
.51
2.03
2.23
2.35
2.44
2.55
2.94
3.17
3.28
1.68
2.43
2.71
2.85
2.95
3.11
3.25
3.50
3.60
2.85
3.17
3.35
3.47
3.65
3.82
4.13
4.25
.91
3.28
3.64
3.85
3.98
4.21
4.38
4.76
4.91
3.67
4.08
4.34
4.50
4.76
4.97
5.40
5.57
4.12
4.55
4.84
5.02
5.31
5.53
6.03
6.22
1.54
4.53
5.04
5.34
5.53
5.86
6.13
6.67
6.88
.98
.68
1.09
.94
.89
.62

mm

85.2
81.6
117.2
110.4
99.7
24.4
52.6
18.7
77.6
24.8
12.9
12.2
46.1
77.9
13.0
51.5
56.6
59.8
61.9
64.9
74.8
80.5
83.2
42.7
61.8
68.8
72.4
75.0
78.9
82.5
88.8
91.5
72.4
80.6
85.0
88.1
92.8
96.9
104.9
108.1
23.1
83.2
92.4
97.7
101.2
106.8
111.4
121.0
124.8
93.1
103.7
110.3
114.3
120.8
126.3
137.1
141.5
104.6
115.5
123.0
127.4
134.8
140.5
153.2
158.1
39.1
115.0
128.1
135.7
140.5
148.7
155.7
169.3
174.7
24.9
17.3
27.6
23.8
22.5
15.8

WIRE DIA.
Inches

0.344
0.306
0.362
0.235
0.156
0.192
0.345
0.105
0.235
0.217
0.090
0.096
0.264
0.438
0.125
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.187
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.135
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.162
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.135
0.105
0.105
0.156
0.140
0.192

mm

TOTAL
MATL
COILS

8.7
7.8
9.2
6.0
4.0
4.9
8.8
2.7
6.0
5.5
2.3
2.4
6.7
11.1
3.2
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
4.7
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
3.4
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
4.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
3.4
2.7
2.7
4.0
3.6
4.9

9.75
10.5
12.8
18.5
25.0
5.00
6.00
7.00
13.0
4.50
4.67
4.00
7.00
7.00
4.00
6.50
6.50
6.50
6.50
6.50
7.25
7.25
7.00
9.00
7.80
7.90
7.88
7.88
7.90
8.00
8.00
7.70
9.13
9.25
9.25
9.25
9.30
9.40
9.45
9.09
5.75
10.5
10.6
10.6
10.6
10.7
10.8
10.9
10.5
11.7
11.9
12.0
12.0
12.1
12.2
12.3
11.9
13.2
13.3
13.4
13.4
13.5
13.6
13.8
13.3
8.50
14.5
14.7
14.8
14.8
14.9
15.1
15.3
14.7
6.25
6.50
9.33
6.00
6.33
3.25

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

SPR
SPR
SPR
SST
SST
SST
SPR
SST
SPR
SPR
SST
SST
SST
OT
SPR
OT
OT
OT
OT
OT
OT
OT
OT
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SST
OT
OT
OT
OT
OT
OT
OT
OT
SPR
SPR
SPR
SPR
SPR
SST

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
C
CG
CG
CG

F
N
S
H

Z
N
N
N
N
N
Z
N
N
Z
N
N
N
N
Z
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
GI
Z
Z
Z
Z
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 219

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

2.750
2.750
2.750
2.750
2.796
2.812
2.812
2.875
2.875
2.875
2.875
2.875
2.875
2.875
2.875
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906
2.906

69.85
69.85
69.85
69.85
71.02
71.42
71.42
73.03
73.03
73.03
73.03
73.03
73.03
73.03
73.03
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81
73.81

4336
4086
4093
S-3116
11890
4328
4334
S-3095
S-3159
S-86
S-995
4240
4314
S-3124
11314
3313
73177
73183
73189
73195
73201
73207
73178
73184
73190
73196
73202
73208
73213
73219
73225
73231
73237
73179
73185
73191
73197
73203
73209
73214
73220
73226
73232
73238
4080
73180
73186
73192
73198
73204
73210
73215
73221
73227
73233
73239
73181
73187
73193
73199
73205
73211
73216
73222
73228
73234
73240
73182
73188
73194
73200
73206
73212
73217
73223
73229
73235
73241
73218
73224

O.D.

FREE LENGTH
Inches

4.75
6.25
8.50
14.0
9.00
1.63
13.0
2.88
3.00
3.00
3.63
6.75
7.50
8.50
12.8
1.50
4.00
4.00
4.00
4.00
4.00
4.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.50
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

120.7
158.8
215.9
355.6
228.6
41.3
330.2
73.0
76.2
76.2
92.1
171.5
190.5
215.9
323.9
38.1
101.6
101.6
101.6
101.6
101.6
101.6
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
165.1
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8

I.D.
Inches

2.300
2.000
1.250
2.438
2.564
1.938
2.246
2.351
2.625
2.491
2.309
2.087
2.375
2.375
2.213
2.492
2.344
2.282
2.220
2.182
2.156
2.120
2.344
2.282
2.220
2.182
2.156
2.120
2.094
2.032
1.970
1.906
1.844
2.344
2.282
2.220
2.182
2.156
2.120
2.094
2.032
1.970
1.906
1.844
1.782
2.344
2.282
2.220
2.182
2.156
2.120
2.094
2.032
1.970
1.906
1.844
2.344
2.282
2.220
2.182
2.156
2.120
2.094
2.032
1.970
1.906
1.844
2.344
2.282
2.220
2.182
2.156
2.120
2.094
2.032
1.970
1.906
1.844
2.094
2.032

RATE
mm

58.4
50.8
31.8
61.9
65.1
49.2
57.0
59.7
66.7
63.3
58.6
53.0
60.3
60.3
56.2
63.3
59.5
58.0
56.4
55.4
54.8
53.8
59.5
58.0
56.4
55.4
54.8
53.8
53.2
51.6
50.0
48.4
46.8
59.5
58.0
56.4
55.4
54.8
53.8
53.2
51.6
50.0
48.4
46.8
45.3
59.5
58.0
56.4
55.4
54.8
53.8
53.2
51.6
50.0
48.4
46.8
59.5
58.0
56.4
55.4
54.8
53.8
53.2
51.6
50.0
48.4
46.8
59.5
58.0
56.4
55.4
54.8
53.8
53.2
51.6
50.0
48.4
46.8
53.2
51.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

65
11
303
53
7107 1245
6.1
1.1
1.5
.27
3913 685
33
5.7
189
33
15
2.6
39
6.8
107
19
378
66
52
9.1
39
6.8
71
12
135
24
116
20
184
32
278
49
352
62
412
72
508
89
90
16
142
25
211
37
273
48
312
55
384
67
435
76
633 111
865 151
1228 215
1625 285
73
13
116
20
172
30
218
38
255
45
313
55
351
61
507
89
692 121
977 171
1288 226
1856 325
62
11
98
17
145
25
184
32
213
37
262
46
294
51
422
74
577 101
819 143
1073 188
53
9.3
84
15
126
22
158
28
185
32
227
40
253
44
367
64
494
87
697 122
922 161
42
7.4
66
12
98
17
125
22
143
25
176
31
198
35
284
50
388
68
543
95
711 125
163
29
232
41

1.8
1.6
.36
6.2
7.8
.18
6.6
.74
1.4
1.6
1.6
1.4
2.9
3.3
4.6
.66
2.0
1.7
1.4
1.3
1.2
1.1
2.6
2.1
1.9
1.7
1.6
1.5
1.4
1.2
1.1
.87
.79
3.2
2.6
2.3
2.1
2.0
1.8
1.8
1.5
1.3
1.1
.99
.71
3.7
3.1
2.7
2.5
2.4
2.2
2.1
1.8
1.6
1.3
1.2
4.3
3.6
3.1
2.9
2.8
2.5
2.5
2.1
1.9
1.5
1.4
5.5
4.6
4.0
3.7
3.6
3.2
3.2
2.7
2.4
2.0
1.8
3.8
3.3

mm

45
40
9.2
158
197
4.5
168
19
35
40
41
35
74
84
116
17
50
42
36
33
31
29
65
54
47
43
41
38
37
30
27
22
20
80
67
58
54
51
46
45
38
34
28
25
18
94
79
69
63
61
55
54
46
41
33
30
110
92
79
74
70
64
63
52
47
39
35
139
117
102
93
90
82
80
68
60
50
46
98
83

ENDS: C - Closed

G - Ground
O - Open

Lbs.

116
514
476 2118
2563 11400
38
167
12
53
693 3082
215
958
139
617
20
90
62
275
174
775
516 2293
151
673
127
566
325 1445
89
395
230 1023
304 1353
392 1746
459 2044
509 2266
570 2536
230 1023
304 1353
392 1746
459 2044
509 2266
570 2536
627 2788
757 3368
923 4105
1074 4779
1276 5674
230 1023
304 1353
392 1746
459 2044
509 2266
570 2536
627 2788
757 3368
923 4105
1074 4779
1276 5674
1315 5849
230 1023
304 1353
392 1746
459 2044
509 2266
570 2536
627 2788
757 3368
923 4105
1074 4779
1276 5674
230 1023
304 1353
392 1746
459 2044
509 2266
570 2536
627 2788
757 3368
923 4105
1074 4779
1276 5674
230 1023
304 1353
392 1746
459 2044
509 2266
570 2536
627 2788
757 3368
923 4105
1074 4779
1276 5674
627 2788
757 3368

Inches

1.24
3.38
7.50
1.40
1.25
1.31
5.52
.98
.50
.82
1.76
3.15
2.00
2.25
5.54
.62
1.76
1.95
2.14
2.27
2.35
2.46
2.11
2.34
2.61
2.71
2.86
3.00
3.14
3.28
3.51
3.63
3.85
2.47
2.72
3.04
3.21
3.33
3.50
3.70
3.88
4.15
4.30
4.58
4.50
2.81
3.11
3.48
3.67
3.84
4.03
4.26
4.48
4.80
4.94
5.28
3.19
3.52
3.90
4.16
4.30
4.53
4.82
5.02
5.44
5.63
5.98
3.88
4.31
4.82
5.07
5.35
5.61
5.94
6.23
6.68
6.94
7.43
7.04
7.44

mm

Inches

31.4
85.7
190.5
35.7
31.7
33.3
140.2
25.0
12.7
20.7
44.6
80.1
50.8
57.2
140.8
15.8
44.8
49.5
54.5
57.6
59.6
62.4
53.6
59.4
66.2
68.9
72.6
76.1
79.9
83.3
89.2
92.1
97.8
62.7
69.2
77.3
81.6
84.5
88.9
94.1
98.5
105.5
109.2
116.3
114.2
71.3
79.0
88.4
93.3
97.5
102.3
108.3
113.8
121.8
125.4
134.2
81.0
89.5
99.1
105.6
109.3
115.0
122.5
127.5
138.3
142.9
151.8
98.5
109.6
122.5
128.7
135.8
142.5
150.8
158.3
169.6
176.3
188.8
178.8
188.9

0.225
0.375
0.750
0.156
0.116
0.437
0.283
0.262
0.125
0.192
0.283
0.394
0.250
0.250
0.331
0.207
0.281
0.312
0.343
0.362
0.375
0.393
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.281
0.312
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.406
0.437

mm

TOTAL
MATL
COILS

5.7
9.5
19.1
4.0
2.9
11.1
7.2
6.7
3.2
4.9
7.2
10.0
6.4
6.4
8.4
5.3
7.1
7.9
8.7
9.2
9.5
10.0
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
7.1
7.9
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
10.3
11.1

5.50
9.00
10.0
9.00
9.75
3.00
19.5
3.75
3.00
4.25
6.25
8.00
8.00
9.00
16.8
3.00
6.27
6.24
6.25
6.26
6.26
6.25
7.51
7.50
7.60
7.49
7.62
7.63
7.75
7.50
7.50
7.25
7.25
8.79
8.73
8.87
8.88
8.88
8.90
9.12
8.87
8.88
8.60
8.62
8.00
9.99
9.96
10.2
10.1
10.2
10.2
10.5
10.3
10.2
9.88
9.95
11.3
11.3
11.4
11.5
11.5
11.5
11.9
11.5
11.6
11.3
11.3
13.8
13.8
14.1
14.0
14.3
14.3
14.6
14.3
14.3
13.9
14.0
17.3
17.0

SPR
HD
HD
SST
SST
SPR
SPR
SST
SST
SST
SST
SPR
SPR
SST
SPR
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT

E
N
D
S

CG
CG
CG
CG
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

Z
N
N
N
N
Z
Z
N
N
N
N
Z
Z
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

219

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 220

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

2.906
2.906
2.906
2.938
2.938
2.938
2.938
2.938
2.984
3.000
3.000
3.000
3.000
3.000
3.031
3.031
3.125
3.125
3.140
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.156
3.172
3.250
3.250
3.250

73.81
73.81
73.81
74.63
74.63
74.63
74.63
74.63
75.79
76.20
76.20
76.20
76.20
76.20
76.99
76.99
79.38
79.38
79.76
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.16
80.57
82.55
82.55
82.55

73230
73236
73242
10799
12628
11779
4055
S-3153
12443
4138
11357
S-3221
S-3030
4241
S-3218
4249
11570
10819
11606
S-992
S-249
73243
73249
73255
73261
73267
73273
73279
73285
73291
4023-A
73244
73250
73256
73262
73268
73274
73280
73286
73292
73245
73251
73257
73263
73269
73275
73281
73287
73293
73246
73252
73258
73264
73270
73276
73282
73288
73294
73247
73253
73259
73265
73271
73277
73283
73289
73295
73248
73254
73260
73266
73272
73278
73284
73290
73296
S-3108
10708
S-3102
4002

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

12.0
12.0
12.0
3.25
3.38
5.81
8.00
10.5
7.00
1.75
2.00
2.72
9.00
11.0
2.25
4.63
2.09
4.69
1.50
1.88
3.19
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.00
5.50
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
6.00
2.13
4.25
4.50

mm

304.8
304.8
304.8
82.6
85.7
147.6
203.2
266.7
177.8
44.5
50.8
69.0
228.6
279.4
57.2
117.5
53.2
119.0
38.1
47.6
81.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
127.0
139.7
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
177.8
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
152.4
54.0
108.0
114.3

MATERIAL: MW - Music Wire

220

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

1.970
1.906
1.844
2.728
2.524
2.564
1.564
2.564
2.782
2.586
2.376
2.618
2.616
2.616
2.595
2.345
2.929
2.313
2.764
2.832
2.860
2.470
2.432
2.406
2.370
2.344
2.282
2.220
2.156
2.094
1.968
2.470
2.432
2.406
2.370
2.344
2.282
2.220
2.156
2.094
2.470
2.432
2.406
2.370
2.344
2.282
2.220
2.156
2.094
2.470
2.432
2.406
2.370
2.344
2.282
2.220
2.156
2.094
2.470
2.432
2.406
2.370
2.344
2.282
2.220
2.156
2.094
2.470
2.432
2.406
2.370
2.344
2.282
2.220
2.156
2.094
2.932
2.780
2.750
2.250

RATE
mm

50.0
48.4
46.8
69.3
64.1
65.1
39.7
65.1
70.7
65.7
60.4
66.5
66.4
66.4
65.9
59.6
74.4
58.8
70.2
71.9
72.6
62.7
61.8
61.1
60.2
59.5
58.0
56.4
54.8
53.2
49.9
62.7
61.8
61.1
60.2
59.5
58.0
56.4
54.8
53.2
62.7
61.8
61.1
60.2
59.5
58.0
56.4
54.8
53.2
62.7
61.8
61.1
60.2
59.5
58.0
56.4
54.8
53.2
62.7
61.8
61.1
60.2
59.5
58.0
56.4
54.8
53.2
62.7
61.8
61.1
60.2
59.5
58.0
56.4
54.8
53.2
74.5
70.6
69.9
57.2

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Lbs./In.

N/mm

Inches

317
445
583
2.7
52
11
3509
9.2
1.0
81
561
31
13
9.8
43
341
2.4
486
23
32
11
179
226
264
325
376
522
710
959
1264
2003
146
185
212
260
350
421
568
767
1011
123
156
179
220
255
352
473
639
842
105
133
156
191
218
304
408
548
718
83
105
122
150
171
237
317
426
559
69
85
100
123
140
193
260
349
456
1.5
107
60
1234

56
78
102
.48
9.1
1.8
615
1.6
.18
14
98
5.4
2.2
1.7
7.6
60
.42
85
4.1
5.6
1.9
31
40
46
57
66
91
124
168
221
351
26
32
37
46
61
74
99
134
177
22
27
31
39
45
62
83
112
148
18
23
27
33
38
53
71
96
126
15
18
21
26
30
42
56
75
98
12
15
17
21
25
34
46
61
80
.27
19
11
216

2.9
2.4
2.2
2.8
1.7
3.9
.59
6.1
6.1
1.0
.47
1.9
4.6
7.0
1.2
.98
1.6
1.1
.37
1.2
2.6
2.0
1.9
1.8
1.6
1.5
1.3
1.2
1.0
.94
.87
2.5
2.3
2.2
2.0
1.7
1.7
1.5
1.3
1.2
2.9
2.7
2.6
2.4
2.3
2.0
1.8
1.6
1.4
3.5
3.2
3.0
2.8
2.7
2.3
2.1
1.8
1.7
4.4
4.0
3.9
3.5
3.4
3.0
2.7
2.3
2.1
5.3
5.0
4.7
4.3
4.1
3.6
3.3
2.9
2.6
4.9
1.0
1.9
.70

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

74
61
56
71
43
100
15
155
156
26
12
47
118
179
29
25
41
27
9.4
29
66
52
48
45
41
39
34
31
26
24
22
63
58
57
52
42
42
38
33
30
75
69
67
61
58
51
46
40
36
88
81
77
70
68
59
53
46
42
111
103
99
90
86
75
69
60
54
134
127
120
109
105
92
84
73
66
125
27
48
18

Lbs.

923
1074
1276
7.6
88
42
2088
56
6.2
83
262
57
59
69
50
335
3.8
521
8.7
37
29
363
426
472
529
581
703
858
999
1188
1750
363
426
472
529
581
703
858
999
1188
363
426
472
529
581
703
858
999
1188
363
426
472
529
581
703
858
999
1188
363
426
472
529
581
703
858
999
1188
363
426
472
529
581
703
858
999
1188
7.5
112
113
866

ENDS: C - Closed

G - Ground
O - Open

4105
4779
5674
34
391
185
9287
249
28
368
1167
253
264
307
222
1492
17
2319
39
164
128
1616
1893
2099
2351
2585
3126
3814
4446
5286
7784
1616
1893
2099
2351
2585
3126
3814
4446
5286
1616
1893
2099
2351
2585
3126
3814
4446
5286
1616
1893
2099
2351
2585
3126
3814
4446
5286
1616
1893
2099
2351
2585
3126
3814
4446
5286
1616
1893
2099
2351
2585
3126
3814
4446
5286
33
498
503
3850

Inches

7.96
8.25
8.83
.47
.93
1.87
6.87
1.87
.86
.72
1.01
.86
1.54
2.11
1.09
1.72
.49
2.44
1.13
.49
.59
2.40
2.53
2.63
2.75
2.84
3.06
3.28
3.50
3.72
4.34
2.79
2.94
3.09
3.24
2.99
3.58
3.86
4.13
4.38
3.17
3.35
3.52
3.68
3.81
4.11
4.45
4.75
5.04
3.60
3.80
3.94
4.13
4.30
4.63
5.01
5.38
5.73
4.38
4.61
4.83
5.06
5.28
5.68
6.18
6.63
7.06
5.15
5.52
5.72
5.99
6.25
6.77
7.32
7.88
8.42
1.08
.82
1.25
2.75

mm

202.2
209.5
224.3
12.0
23.7
47.5
174.5
47.5
21.8
18.4
25.8
21.8
39.0
53.6
27.7
43.6
12.4
61.9
28.7
12.3
15.0
61.0
64.4
66.7
69.9
72.2
77.7
83.2
88.9
94.4
110.2
70.8
74.7
78.6
82.4
76.0
91.0
98.1
104.8
111.3
80.6
85.1
89.3
93.6
96.7
104.3
112.9
120.6
128.1
91.5
96.6
100.0
104.8
109.3
117.6
127.2
136.5
145.7
111.1
117.2
122.7
128.5
134.1
144.3
156.9
168.3
179.4
130.8
140.2
145.3
152.2
158.9
172.0
186.0
200.1
213.8
27.4
20.9
31.8
69.9

WIRE DIA.
Inches

0.468
0.500
0.531
0.105
0.207
0.187
0.687
0.187
0.101
0.207
0.312
0.191
0.192
0.192
0.218
0.343
0.098
0.406
0.188
0.162
0.148
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.594
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.120
0.235
0.250
0.500

mm

TOTAL
MATL
COILS

11.9
12.7
13.5
2.7
5.3
4.7
17.4
4.7
2.6
5.3
7.9
4.9
4.9
4.9
5.5
8.7
2.5
10.3
4.8
4.1
3.8
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
15.1
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
3.0
6.0
6.4
12.7

17.0
16.5
16.6
4.50
4.50
10.0
10.0
10.0
7.50
3.50
3.25
4.50
8.00
11.0
5.00
5.00
4.00
6.00
5.00
3.00
4.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.00
7.31
8.12
8.12
8.25
8.25
7.37
8.20
8.25
8.25
8.25
9.25
9.25
9.38
9.38
9.38
9.40
9.50
9.50
9.50
10.5
10.5
10.5
10.5
10.6
10.6
10.7
10.8
10.8
12.8
12.7
12.9
12.9
13.0
13.0
13.2
13.3
13.3
15.0
15.3
15.3
15.2
15.4
15.5
15.7
15.8
15.9
8.00
3.50
5.00
5.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

OT
OT
OT
SST
SPR
SPR
HD
SST
SST
SPR
SPR
SST
SST
SPR
SST
SPR
SPR
SPR
SPR
SST
SST
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SST
SPR
SST
SPR

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG

F
N
S
H

N
N
N
N
Z
Z
N
N
N
Z
Z
N
N
Z
N
Z
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 221

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

3.250
3.266
3.328
3.375
3.375
3.375
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.406
3.421
3.500
3.500
3.500
3.500
3.500
3.500
3.656

82.55
82.96
84.53
85.73
85.73
85.73
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.51
86.89
88.90
88.90
88.90
88.90
88.90
88.90
92.86

4096
S-1635
10985
4347
S-3020
4090
73297
73303
73309
73315
73321
73327
73333
73339
73345
73351
73357
73298
73304
73310
73316
73322
73328
73334
73340
73346
73352
73358
73299
73305
73311
73317
73323
73329
73335
73341
73347
73353
73359
73300
73306
73312
73318
73324
73330
73336
73342
73348
73354
73360
73301
73307
73313
73319
73325
73331
73337
73343
73349
73355
73361
73302
73308
73314
73320
73326
73332
73338
73344
73350
73356
73362
1879
4085
S-1652
4081
4084
S-3169
4050
73363

O.D.

FREE LENGTH
Inches

12.0
6.75
3.13
5.25
5.50
14.0
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
3.84
4.00
4.13
5.38
8.00
8.50
10.0
6.00

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

304.8
171.5
79.4
133.4
139.7
355.6
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
97.6
101.6
104.8
136.5
203.2
215.9
254.0
152.4

I.D.
Inches

2.250
2.330
2.828
2.991
3.125
2.501
2.720
2.682
2.656
2.620
2.594
2.532
2.470
2.406
2.344
2.282
2.220
2.720
2.682
2.656
2.620
2.594
2.532
2.470
2.406
2.344
2.282
2.220
2.720
2.682
2.656
2.620
2.594
2.532
2.470
2.406
2.344
2.282
2.220
2.720
2.682
2.656
2.620
2.594
2.532
2.470
2.406
2.344
2.282
2.220
2.720
2.682
2.656
2.620
2.594
2.532
2.470
2.406
2.344
2.282
2.220
2.720
2.682
2.656
2.620
2.594
2.532
2.470
2.406
2.344
2.282
2.220
2.921
1.750
3.010
2.976
2.000
3.064
2.250
2.932

RATE
mm

57.2
59.2
71.8
76.0
79.4
63.5
69.1
68.1
67.5
66.5
65.9
64.3
62.7
61.1
59.5
58.0
56.4
69.1
68.1
67.5
66.5
65.9
64.3
62.7
61.1
59.5
58.0
56.4
69.1
68.1
67.5
66.5
65.9
64.3
62.7
61.1
59.5
58.0
56.4
69.1
68.1
67.5
66.5
65.9
64.3
62.7
61.1
59.5
58.0
56.4
69.1
68.1
67.5
66.5
65.9
64.3
62.7
61.1
59.5
58.0
56.4
69.1
68.1
67.5
66.5
65.9
64.3
62.7
61.1
59.5
58.0
56.4
74.2
44.5
76.5
75.6
50.8
77.8
57.2
74.5

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

411
72
632 111
59
10
22
3.9
3.0
.52
207
36
121
21
152
27
177
31
209
37
241
42
341
60
473
83
637 112
855 150
1103 193
1465 257
89
16
109
19
127
22
152
27
175
31
243
43
340
60
457
80
608 106
779 136
1037 182
71
12
85
15
100
18
119
21
138
24
191
33
265
46
353
62
469
82
608 106
798 140
59
10
71
12
82
14
98
17
112
20
157
27
218
38
290
51
385
67
494
87
652 114
49
8.6
59
10
69
12
84
15
95
17
132
23
184
32
244
43
326
57
416
73
551
96
43
7.5
52
9.1
61
11
73
13
83
15
115
20
160
28
212
37
283
50
361
63
477
84
50
8.8
23293 4079
44
7.8
19
3.3
3240 567
14
2.4
1191 209
138
24

2.1
.89
1.9
2.8
4.8
2.8
2.8
2.6
2.5
2.4
2.2
1.9
1.7
1.5
1.3
1.2
1.0
3.8
3.6
3.5
3.2
3.1
2.7
2.4
2.0
1.8
1.7
1.4
4.8
4.7
4.4
4.1
3.9
3.4
3.0
2.6
2.4
2.1
1.9
5.7
5.6
5.4
5.0
4.8
4.2
3.7
3.2
2.9
2.6
2.3
6.9
6.7
6.4
5.9
5.7
5.0
4.4
3.8
3.4
3.1
2.7
7.9
7.6
7.2
6.7
6.5
5.7
5.0
4.4
3.9
3.6
3.1
2.5
.14
2.2
2.1
.67
5.4
1.3
2.7

mm

53
23
47
71
121
72
71
66
63
60
57
49
43
37
33
30
26
97
92
88
82
79
69
60
52
46
42
36
121
118
112
105
100
87
77
67
60
54
47
146
142
136
128
123
106
93
82
73
66
58
175
171
162
149
145
126
110
97
87
79
68
200
194
183
171
166
145
127
112
100
91
79
63
3.6
57
53
17
136
32
68

ENDS: C - Closed

G - Ground
O - Open

Lbs.

866 3850
562 2501
111
492
61
273
14
63
588 2614
338 1504
396 1763
440 1955
492 2191
542 2410
656 2916
800 3560
934 4154
1111 4943
1292 5746
1477 6571
338 1504
396 1763
440 1955
492 2191
542 2410
656 2916
800 3560
934 4154
1111 4943
1292 5746
1477 6571
338 1504
396 1763
440 1955
492 2191
542 2410
656 2916
800 3560
934 4154
1111 4943
1292 5746
1477 6571
338 1504
396 1763
440 1955
492 2191
542 2410
656 2916
800 3560
934 4154
1111 4943
1292 5746
1477 6571
338 1504
396 1763
440 1955
492 2191
542 2410
656 2916
800 3560
934 4154
1111 4943
1292 5746
1477 6571
338 1504
396 1763
440 1955
492 2191
542 2410
656 2916
800 3560
934 4154
1111 4943
1292 5746
1477 6571
124
552
3298 14671
99
441
40
177
2162 9616
75
332
1491 6631
371 1649

Inches

6.25
2.96
1.22
.91
.75
5.24
2.65
2.81
2.91
3.14
3.25
3.44
3.63
3.87
4.05
4.30
4.42
3.35
3.63
3.76
4.03
4.17
4.48
4.68
5.01
5.26
5.62
5.75
4.03
4.45
4.58
4.93
5.07
5.46
5.74
6.19
6.51
6.89
7.12
4.71
5.19
5.42
5.81
6.06
6.45
6.77
7.31
7.69
8.22
8.45
5.53
6.09
6.30
6.65
6.99
7.51
7.85
8.50
8.90
9.55
9.78
6.21
6.82
7.03
7.53
7.89
8.49
8.89
9.63
10.1
10.8
11.1
1.38
3.50
1.23
3.28
6.56
1.91
6.09
2.53

mm

Inches

158.8
75.2
31.0
23.2
19.1
133.2
67.3
71.3
74.0
79.8
82.5
87.4
92.1
98.4
102.8
109.2
112.2
85.2
92.2
95.6
102.3
105.9
113.7
118.8
127.1
133.7
142.8
146.1
102.4
113.1
116.3
125.1
128.7
138.6
145.7
157.1
165.3
174.9
180.9
119.7
131.7
137.6
147.7
153.8
163.8
172.0
185.7
195.4
208.7
214.6
140.5
154.8
160.0
168.9
177.7
190.6
199.4
216.0
225.9
242.5
248.4
157.7
173.1
178.5
191.4
200.4
215.5
225.8
244.7
256.2
275.1
282.3
34.9
88.9
31.1
83.2
166.7
48.5
154.8
64.4

0.500
0.468
0.250
0.192
0.125
0.437
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.343
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.250
0.875
0.245
0.262
0.750
0.218
0.625
0.362

mm

TOTAL
MATL
COILS

12.7
11.9
6.4
4.9
3.2
11.1
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
8.7
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
6.4
22.2
6.2
6.7
19.1
5.5
15.9
9.2

12.5
6.33
5.00
4.75
5.00
12.0
7.72
7.76
7.77
8.00
8.00
7.87
7.75
7.75
7.63
7.65
7.45
9.78
10.0
10.0
10.2
10.3
10.2
10.0
10.0
9.91
10.0
9.70
11.8
12.3
12.2
12.5
12.5
12.5
12.3
12.4
12.3
12.3
12.0
13.7
14.3
14.5
14.8
14.9
14.8
14.5
14.6
14.5
14.6
14.2
16.1
16.8
16.8
16.9
17.2
17.2
16.8
17.0
16.8
17.0
16.5
18.1
18.8
18.7
19.2
19.4
19.4
19.0
19.3
19.0
19.3
18.7
5.50
4.00
5.00
12.5
8.75
7.75
9.75
7.00

SPR
SST
SST
SPR
SST
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
HD
HD
SST
SPR
HD
SST
SPR
OT

E
N
D
S

CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG

F
N
S
H

N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
Z
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

221

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 222

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.656
3.687
3.750
3.750
3.750
3.750
3.828
3.875
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906

92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
92.86
93.65
95.25
95.25
95.25
95.25
97.23
98.43
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21

73369
73375
73381
73387
73393
73399
73405
73411
73417
73364
73370
73376
73382
73388
73394
73400
73406
73412
73418
73365
73371
73377
73383
73389
73395
73401
73407
73413
73419
73366
73372
73378
73384
73390
73396
73402
73408
73414
73420
73367
73373
73379
73385
73391
73397
73403
73409
73415
73421
73368
73374
73380
73386
73392
73398
73404
73410
73416
73422
S-3016
S-1508
4076
4051
4099-C
S-1643
4007
73423
73429
73435
73441
73447
73453
73459
73465
73471
73477
73424
73430
73436
73442

O.D.

FREE LENGTH
Inches

COMPRESSION SPRINGS

6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
9.38
3.00
5.50
8.25
17.0
3.50
9.50
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
8.00
8.00
8.00
8.00

mm

152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
238.1
76.2
139.7
209.6
431.8
88.9
241.3
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
203.2
203.2
203.2
203.2

MATERIAL: MW - Music Wire

222

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

2.906
2.870
2.844
2.782
2.720
2.656
2.594
2.532
2.470
2.932
2.906
2.870
2.844
2.782
2.720
2.656
2.594
2.532
2.470
2.932
2.906
2.870
2.844
2.782
2.720
2.656
2.594
2.532
2.470
2.932
2.906
2.870
2.844
2.782
2.720
2.656
2.594
2.532
2.470
2.932
2.906
2.870
2.844
2.782
2.720
2.656
2.594
2.532
2.470
2.932
2.906
2.870
2.844
2.782
2.720
2.656
2.594
2.532
2.470
3.333
3.336
3.126
2.000
3.130
3.588
3.461
3.156
3.120
3.094
3.032
2.970
2.906
2.844
2.782
2.720
2.656
3.156
3.120
3.094
3.032

RATE
mm

73.8
72.9
72.2
70.7
69.1
67.5
65.9
64.3
62.7
74.5
73.8
72.9
72.2
70.7
69.1
67.5
65.9
64.3
62.7
74.5
73.8
72.9
72.2
70.7
69.1
67.5
65.9
64.3
62.7
74.5
73.8
72.9
72.2
70.7
69.1
67.5
65.9
64.3
62.7
74.5
73.8
72.9
72.2
70.7
69.1
67.5
65.9
64.3
62.7
74.5
73.8
72.9
72.2
70.7
69.1
67.5
65.9
64.3
62.7
84.7
84.7
79.4
50.8
79.5
91.1
87.9
80.2
79.2
78.6
77.0
75.4
73.8
72.2
70.7
69.1
67.5
80.2
79.2
78.6
77.0

Lbs./In.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

Inches

161
28
197
35
228
40
299
52
405
71
544
95
713 125
922 161
1207 211
99
17
117
20
143
25
165
29
217
38
292
51
389
68
506
89
657 115
853 149
78
14
93
16
112
20
129
23
169
30
226
40
304
53
394
69
507
89
660 116
64
11
76
13
92
16
106
19
139
24
185
32
249
44
323
57
412
72
538
94
54
9.5
64
11
78
14
90
16
118
21
158
28
210
37
272
48
349
61
454
80
47
8.2
56
9.7
68
12
78
14
102
18
136
24
182
32
236
41
303
53
393
69
4.2
.74
23
4.0
96
17
5910 1035
36
6.3
.72
.13
10
1.8
136
24
171
30
190
33
258
45
339
59
455
80
595 104
767 134
978 171
1307 229
99
17
122
21
136
24
186
33

2.6
2.3
2.2
2.1
1.9
1.6
1.5
1.3
1.2
3.8
3.5
3.2
3.1
2.8
2.6
2.3
2.1
1.8
1.6
4.7
4.4
4.1
3.9
3.6
3.3
2.9
2.6
2.4
2.1
5.8
5.4
5.0
4.8
4.4
4.1
3.5
3.2
2.9
2.6
6.8
6.5
5.9
5.7
5.2
4.8
4.2
3.8
3.5
3.1
7.9
7.4
6.8
6.5
6.0
5.5
4.8
4.4
4.0
3.5
7.8
1.9
2.2
.53
5.7
2.4
6.6
2.8
2.5
2.5
2.2
2.1
1.8
1.7
1.5
1.3
1.2
3.9
3.5
3.5
3.1

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

mm

65
59
57
52
47
41
37
33
29
95
90
82
78
72
65
57
52
47
41
120
113
104
100
92
84
73
67
61
53
147
138
128
122
113
103
90
82
75
66
174
164
151
144
132
121
106
97
88
78
201
188
173
166
153
140
123
112
102
90
199
49
56
13
146
61
168
72
64
64
57
53
46
42
38
34
30
99
90
89
79

Lbs.

411 1829
461 2050
507 2256
614 2731
750 3337
876 3896
1043 4640
1214 5398
1389 6178
371 1649
411 1829
461 2050
507 2256
614 2731
750 3337
876 3896
1043 4640
1214 5398
1389 6178
371 1649
411 1829
461 2050
507 2256
614 2731
750 3337
876 3896
1043 4640
1214 5398
1389 6178
371 1649
411 1829
461 2050
507 2256
614 2731
750 3337
876 3896
1043 4640
1214 5398
1389 6178
371 1649
411 1829
461 2050
507 2256
614 2731
750 3337
876 3896
1043 4640
1214 5398
1389 6178
371 1649
411 1829
461 2050
507 2256
614 2731
750 3337
876 3896
1043 4640
1214 5398
1389 6178
33
146
44
195
212
944
3140 13967
208
927
1.7
7.6
67
299
386 1718
433 1926
477 2120
577 2568
706 3139
824 3667
982 4370
1144 5087
1310 5827
1525 6782
386 1718
433 1926
477 2120
577 2568

ENDS: C - Closed

G - Ground
O - Open

Inches

2.62
2.75
2.84
3.17
3.39
3.63
3.85
4.07
4.23
3.26
3.34
3.50
3.61
4.04
4.35
4.68
4.99
5.27
5.49
3.91
4.01
4.25
4.38
4.94
5.34
5.70
6.11
6.49
6.75
4.62
4.74
5.01
5.18
5.83
6.32
6.75
7.22
7.73
8.01
5.34
5.49
5.78
5.97
6.71
7.26
7.80
8.36
8.92
9.27
6.07
6.19
6.53
6.75
7.61
8.24
8.87
9.48
10.1
10.5
1.55
1.09
2.03
7.00
3.41
1.11
1.71
2.53
2.60
2.76
3.00
3.28
3.50
3.71
3.93
4.15
4.22
3.20
3.33
3.53
3.82

mm

66.7
69.9
72.2
80.5
86.2
92.1
97.8
103.5
107.3
82.8
84.8
88.9
91.8
102.7
110.5
118.8
126.8
133.8
139.3
99.4
101.9
107.9
111.4
125.4
135.5
144.8
155.1
164.9
171.3
117.3
120.3
127.3
131.5
148.2
160.5
171.5
183.4
196.3
203.3
135.6
139.4
146.8
151.6
170.4
184.3
198.2
212.5
226.6
235.3
154.1
157.2
165.9
171.4
193.2
209.3
225.4
240.7
256.9
267.4
39.3
27.6
51.5
177.8
86.6
28.2
43.4
64.3
66.1
70.1
76.2
83.3
88.9
94.4
99.9
105.4
107.2
81.2
84.7
89.7
97.1

WIRE DIA.
Inches

0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.362
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.177
0.207
0.312
0.875
0.310
0.120
0.207
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.375
0.393
0.406
0.437

mm

TOTAL
MATL
COILS

9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.2
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
4.5
5.3
7.9
22.2
7.9
3.0
5.3
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
9.5
10.0
10.3
11.1

7.00
7.00
7.00
7.25
7.25
7.25
7.25
7.25
7.13
9.01
8.90
8.90
8.90
9.25
9.30
9.35
9.40
9.38
9.25
10.8
10.7
10.8
10.8
11.3
11.4
11.4
11.5
11.6
11.4
12.8
12.6
12.8
12.8
13.3
13.5
13.5
13.6
13.8
13.5
14.7
14.6
14.7
14.7
15.4
15.5
15.6
15.8
15.9
15.6
16.8
16.5
16.6
16.6
17.4
17.6
17.7
17.8
18.0
17.8
8.75
4.25
5.50
8.00
11.0
9.25
7.25
6.75
6.63
6.80
6.87
7.01
7.00
7.00
7.00
7.00
6.75
8.52
8.48
8.70
8.75

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SST
SST
SPR
SPR
HD
SST
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
Z
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 223

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

CENTURY
STOCK
NUMBER

3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.906
3.968
4.000
4.000
4.000
4.000
4.000
4.125
4.125
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156

99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
99.21
100.79
101.60
101.60
101.60
101.60
101.60
104.78
104.78
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56

73448
73454
73460
73466
73472
73478
73425
73431
73437
73443
73449
73455
73461
73467
73473
73479
73426
73432
73438
73444
73450
73456
73462
73468
73474
73480
73427
73433
73439
73445
73451
73457
73463
73469
73475
73481
73428
73434
73440
73446
73452
73458
73464
73470
73476
73482
S-1596
4052
4030
4082
4020
4048
4406
11302
73483
73489
73495
73501
73507
73513
73519
73525
73531
73484
73490
73496
73502
73508
73514
73520
73526
73532
73485
73491
4099-F
73497
73503
73509
73515
73521

O.D.

FREE LENGTH
Inches

8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
3.50
4.25
6.00
6.25
6.25
10.0
4.00
4.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
88.9
108.0
152.4
158.8
158.8
254.0
101.6
101.6
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0

I.D.
Inches

2.970
2.906
2.844
2.782
2.720
2.656
3.156
3.120
3.094
3.032
2.970
2.906
2.844
2.782
2.720
2.656
3.156
3.120
3.094
3.032
2.970
2.906
2.844
2.782
2.720
2.656
3.156
3.120
3.094
3.032
2.970
2.906
2.844
2.782
2.720
2.656
3.156
3.120
3.094
3.032
2.970
2.906
2.844
2.782
2.720
2.656
3.728
2.000
3.338
2.812
2.750
2.500
3.713
3.375
3.406
3.370
3.344
3.282
3.220
3.156
3.094
3.032
2.970
3.406
3.370
3.344
3.282
3.220
3.156
3.094
3.032
2.970
3.406
3.370
3.344
3.344
3.282
3.220
3.156
3.094

RATE
mm

75.4
73.8
72.2
70.7
69.1
67.5
80.2
79.2
78.6
77.0
75.4
73.8
72.2
70.7
69.1
67.5
80.2
79.2
78.6
77.0
75.4
73.8
72.2
70.7
69.1
67.5
80.2
79.2
78.6
77.0
75.4
73.8
72.2
70.7
69.1
67.5
80.2
79.2
78.6
77.0
75.4
73.8
72.2
70.7
69.1
67.5
94.7
50.8
84.8
71.4
69.9
63.5
94.3
85.7
86.5
85.6
84.9
83.4
81.8
80.2
78.6
77.0
75.4
86.5
85.6
84.9
83.4
81.8
80.2
78.6
77.0
75.4
86.5
85.6
84.9
84.9
83.4
81.8
80.2
78.6

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

Inches

42
57
74
96
122
161
14
17
19
25
33
44
58
74
94
124
11
14
15
21
27
36
47
60
77
101
9.5
12
13
18
23
31
40
51
65
85
8.2
10
11
15
20
27
35
44
56
74
.41
.07
26620 4662
116
20
2265 397
1201 210
2208 387
17
3.0
127
22
124
22
151
27
165
29
227
40
306
53
387
68
533
93
686 120
873 153
91
16
110
19
119
21
163
29
220
39
278
49
380
67
485
85
616 108
70
12
86
15
129
23
93
16
127
22
172
30
216
38
295
52

2.9
2.5
2.3
2.1
1.9
1.7
5.0
4.5
4.5
4.0
3.7
3.3
3.0
2.7
2.4
2.1
5.9
5.5
5.4
4.8
4.6
4.0
3.6
3.3
3.0
2.6
7.2
6.6
6.4
5.8
5.4
4.7
4.3
4.0
3.6
3.1
8.2
7.6
7.4
6.6
6.2
5.4
5.0
4.6
4.1
3.6
1.9
.14
2.0
.51
1.1
.88
3.1
1.7
2.9
2.7
2.7
2.4
2.2
2.0
1.7
1.6
1.4
4.0
3.7
3.8
3.3
3.0
2.8
2.4
2.2
2.0
5.2
4.8
3.1
4.9
4.3
3.9
3.6
3.1

242
325
425
548
699
920
78
96
107
143
189
253
330
420
536
710
65
79
88
120
154
207
270
345
439
578
54
66
74
100
131
175
229
289
369
487
47
57
64
87
113
152
198
251
321
421

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

mm

74
64
59
53
48
42
126
115
113
103
95
83
76
69
62
55
151
139
138
122
116
101
92
84
76
67
182
167
164
147
137
120
109
101
90
80
209
193
189
169
159
138
126
116
104
92
49
3.5
52
13
28
22
78
42
75
69
69
61
55
51
44
40
36
102
95
96
85
77
71
62
57
51
132
121
79
123
109
98
91
80

ENDS: C - Closed

G - Ground
O - Open

Lbs.

706
824
982
1144
1310
1525
386
433
477
577
706
824
982
1144
1310
1525
386
433
477
577
706
824
982
1144
1310
1525
386
433
477
577
706
824
982
1144
1310
1525
386
433
477
577
706
824
982
1144
1310
1525

3139
3667
4370
5087
5827
6782
1718
1926
2120
2568
3139
3667
4370
5087
5827
6782
1718
1926
2120
2568
3139
3667
4370
5087
5827
6782
1718
1926
2120
2568
3139
3667
4370
5087
5827
6782
1718
1926
2120
2568
3139
3667
4370
5087
5827
6782
.80
3.5
3645 16214
238 1057
1145 5095
1327 5903
1939 8625
52
231
210
934
364 1620
408 1816
449 1999
545 2423
666 2963
778 3463
928 4129
1081 4809
1239 5511
364 1620
408 1816
449 1999
545 2423
666 2963
778 3463
928 4129
1081 4809
1239 5511
364 1620
408 1816
400 1777
449 1999
545 2423
666 2963
778 3463
928 4129

Inches

4.22
4.50
4.78
5.06
5.33
5.47
3.85
4.02
4.27
4.71
5.14
5.49
5.85
6.26
6.59
6.72
4.48
4.72
5.01
5.45
6.09
6.49
6.91
7.37
7.79
7.97
5.23
5.50
5.81
6.36
7.00
7.50
7.96
8.58
9.04
9.22
5.90
6.24
6.59
7.18
7.96
8.48
9.03
9.71
10.2
10.5
1.56
4.00
1.66
2.38
4.22
6.00
.92
2.34
2.34
2.46
2.64
2.84
3.04
3.38
3.45
3.65
3.85
2.92
3.10
3.35
3.61
3.86
4.31
4.41
4.71
4.97
3.56
3.73
3.15
4.06
4.37
4.68
5.25
5.38

mm

Inches

107.1
114.2
121.3
128.4
135.5
138.9
97.9
102.2
108.4
119.7
130.5
139.5
148.5
158.9
167.5
170.6
113.7
119.9
127.4
138.4
154.8
164.9
175.5
187.2
197.8
202.3
132.9
139.6
147.6
161.6
177.8
190.4
202.1
218.0
229.7
234.2
149.9
158.5
167.4
182.4
202.3
215.4
229.5
246.6
259.5
265.9
39.6
101.6
42.0
60.4
107.2
152.4
23.4
59.5
59.6
62.4
67.1
72.1
77.3
85.7
87.7
92.8
97.9
74.3
78.6
85.1
91.6
98.1
109.5
112.1
119.6
126.2
90.5
94.8
79.9
103.1
111.0
118.9
133.4
136.6

0.468
0.500
0.531
0.562
0.593
0.625
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.120
1.000
0.331
0.594
0.625
0.750
0.206
0.375
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.375
0.393
0.406
0.406
0.437
0.468
0.500
0.531

mm

TOTAL
MATL
COILS

11.9
12.7
13.5
14.3
15.1
15.9
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
3.0
25.4
8.4
15.1
15.9
19.1
5.2
9.5
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.5
10.0
10.3
10.3
11.1
11.9
12.7
13.5

9.01
9.00
9.00
9.00
8.99
8.75
10.3
10.2
10.5
10.8
11.0
11.0
11.0
11.1
11.1
10.7
11.9
12.0
12.4
12.5
13.0
13.0
13.0
13.1
13.1
12.7
14.0
14.0
14.3
14.6
15.0
15.0
15.0
15.3
15.2
14.8
15.7
15.9
16.2
16.4
17.0
17.0
17.0
17.3
17.2
16.8
13.0
4.00
5.00
4.00
6.75
8.00
4.50
6.25
6.25
6.25
6.50
6.50
6.50
6.75
6.50
6.50
6.50
7.80
7.88
8.25
8.25
8.25
8.63
8.31
8.38
8.38
9.50
9.50
7.75
10.0
10.0
10.0
10.5
10.1

OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SST
HD
SPR
HD
SPR
SPR
SPR
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
OT
OT
OT
OT
OT

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

223

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 224

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

O.D.

COMPRESSION SPRINGS

Inches

mm

4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.156
4.250
4.375
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.406
4.500
4.500
4.500
4.500
4.500
4.687
4.687

105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
105.56
107.95
111.13
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
111.91
114.30
114.30
114.30
114.30
114.30
119.05
119.05

CENTURY
STOCK
NUMBER
73527
73533
73486
73492
73498
73504
73510
73516
73522
73528
73534
73487
73493
73499
73505
73511
73517
73523
73529
73535
73488
73494
73500
73506
73512
73518
73524
73530
73536
4021
4022
73537
73543
73549
73555
73561
73567
73573
73538
73544
73550
73556
73562
73568
73574
73539
73545
73551
73557
73563
73569
73575
73540
73546
73552
73558
73564
73570
73576
73541
73547
73553
73559
73565
73571
73577
73542
73548
73554
73560
73566
73572
73578
4023
4041
4046
10940
4087
4079
73579

FREE LENGTH
Inches

10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
10.8
8.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
4.00
6.00
6.50
9.00
10.5
6.00
6.00

mm

254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
273.1
203.2
152.4
152.4
152.4
152.4
152.4
152.4
152.4
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
304.8
355.6
355.6
355.6
355.6
355.6
355.6
355.6
406.4
406.4
406.4
406.4
406.4
406.4
406.4
101.6
152.4
165.1
228.6
266.7
152.4
152.4

MATERIAL: MW - Music Wire

224

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

I.D.
Inches

3.032
2.970
3.406
3.370
3.344
3.282
3.220
3.156
3.094
3.032
2.970
3.406
3.370
3.344
3.282
3.220
3.156
3.094
3.032
2.970
3.406
3.370
3.344
3.282
3.220
3.156
3.094
3.032
2.970
2.250
2.499
3.532
3.470
3.406
3.344
3.282
3.220
3.156
3.532
3.470
3.406
3.344
3.282
3.220
3.156
3.532
3.470
3.406
3.344
3.282
3.220
3.156
3.532
3.470
3.406
3.344
3.282
3.220
3.156
3.532
3.470
3.406
3.344
3.282
3.220
3.156
3.532
3.470
3.406
3.344
3.282
3.220
3.156
3.250
3.376
3.564
3.820
2.500
4.187
3.901

RATE
mm

77.0
75.4
86.5
85.6
84.9
83.4
81.8
80.2
78.6
77.0
75.4
86.5
85.6
84.9
83.4
81.8
80.2
78.6
77.0
75.4
86.5
85.6
84.9
83.4
81.8
80.2
78.6
77.0
75.4
57.2
63.5
89.7
88.1
86.5
84.9
83.4
81.8
80.2
89.7
88.1
86.5
84.9
83.4
81.8
80.2
89.7
88.1
86.5
84.9
83.4
81.8
80.2
89.7
88.1
86.5
84.9
83.4
81.8
80.2
89.7
88.1
86.5
84.9
83.4
81.8
80.2
89.7
88.1
86.5
84.9
83.4
81.8
80.2
82.6
85.8
90.5
97.0
63.5
106.3
99.1

Lbs./In.

N/mm

377
66
476
83
58
10
71
12
76
13
105
18
141
25
175
31
240
42
309
54
388
68
49
8.6
60
10
65
11
89
16
120
21
150
26
204
36
260
46
328
57
43
7.5
52
9.0
56
9.9
77
13
104
18
129
23
176
31
225
39
283
50
6979 1222
6091 1067
197
34
266
47
355
62
462
81
594 104
754 132
955 167
143
25
188
33
251
44
327
57
421
74
534
94
676 118
112
20
146
26
195
34
253
44
326
57
414
72
524
92
93
16
122
21
159
28
210
37
266
47
338
59
422
74
78
14
103
18
136
24
175
31
224
39
285
50
353
62
67
12
89
16
118
21
151
26
194
34
246
43
306
54
1675 293
522
91
263
46
63
11
5588 979
21
3.8
124
22

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

2.9
2.6
6.3
5.8
5.9
5.2
4.7
4.4
3.9
3.5
3.2
7.4
6.8
6.9
6.1
5.6
5.2
4.5
4.2
3.8
8.5
7.9
8.0
7.1
6.4
6.0
5.3
4.8
4.4
.50
.47
2.6
2.4
2.1
1.9
1.7
1.6
1.4
3.6
3.4
2.9
2.7
2.4
2.2
2.0
4.6
4.3
3.8
3.5
3.1
2.8
2.6
5.5
5.2
4.6
4.2
3.9
3.5
3.2
6.6
6.1
5.4
5.0
4.6
4.1
3.9
7.7
7.1
6.2
5.8
5.3
4.8
4.5
.71
1.7
2.1
3.6
.82
4.4
2.9

mm

73
66
161
147
150
132
120
113
98
89
81
189
173
175
156
142
132
115
106
96
216
201
202
180
163
153
134
122
111
13
12
66
60
53
48
44
40
36
92
85
75
68
62
56
51
117
110
96
88
80
72
66
141
131
118
106
98
88
82
168
156
138
128
116
105
99
195
180
159
148
134
121
114
18
43
53
91
21
112
75

Lbs.

1081 4809
1239 5511
364 1620
408 1816
449 1999
545 2423
666 2963
778 3463
928 4129
1081 4809
1239 5511
364 1620
408 1816
449 1999
545 2423
666 2963
778 3463
928 4129
1081 4809
1239 5511
364 1620
408 1816
449 1999
545 2423
666 2963
778 3463
928 4129
1081 4809
1239 5511
3492 15531
2863 12733
515 2293
631 2805
737 3280
879 3912
1025 4558
1175 5226
1369 6089
515 2293
631 2805
737 3280
879 3912
1025 4558
1175 5226
1369 6089
515 2293
631 2805
737 3280
879 3912
1025 4558
1175 5226
1369 6089
515 2293
631 2805
737 3280
879 3912
1025 4558
1175 5226
1369 6089
515 2293
631 2805
737 3280
879 3912
1025 4558
1175 5226
1369 6089
515 2293
631 2805
737 3280
879 3912
1025 4558
1175 5226
1369 6089
1194 5310
893 3973
550 2444
225
999
4580 20380
94
419
364 1620

ENDS: C - Closed

G - Ground
O - Open

Inches

5.73
6.08
4.17
4.37
4.77
5.14
5.50
6.25
6.37
6.74
7.19
4.78
5.02
5.43
5.90
6.32
7.12
7.30
7.80
8.30
5.35
5.70
6.14
6.67
7.14
8.13
8.28
8.85
9.42
8.00
6.10
2.73
2.92
3.12
3.32
3.51
3.71
3.91
3.44
3.75
4.00
4.25
4.49
4.75
5.00
4.15
4.56
4.87
5.18
5.48
5.78
6.09
4.81
5.27
5.74
6.03
6.46
6.81
7.26
5.57
6.07
6.54
7.02
7.46
7.86
8.44
6.34
6.87
7.39
7.97
8.44
8.92
9.54
2.66
3.65
2.81
2.13
8.00
1.25
2.16

mm

145.6
154.4
106.0
111.1
121.1
130.5
139.7
158.8
161.8
171.3
182.6
121.5
127.4
137.9
149.9
160.5
181.0
185.4
198.1
210.9
135.8
144.7
156.0
169.3
181.4
206.4
210.4
224.9
239.1
203.2
154.9
69.4
74.2
79.3
84.3
89.2
94.2
99.2
87.3
95.2
101.7
108.0
114.2
120.6
127.0
105.3
115.7
123.6
131.7
139.1
146.8
154.7
122.3
133.8
145.8
153.1
164.0
173.0
184.4
141.5
154.1
166.2
178.4
189.4
199.6
214.2
161.1
174.6
187.7
202.4
214.3
226.4
242.3
67.5
92.8
71.3
54.0
203.2
31.8
54.9

WIRE DIA.
Inches

0.562
0.593
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.375
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
1.000
0.938
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.625
0.562
0.468
0.340
1.000
0.250
0.393

mm

TOTAL
MATL
COILS

14.3
15.1
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
9.5
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
25.4
23.8
11.1
11.9
12.7
13.5
14.3
15.1
15.9
11.1
11.9
12.7
13.5
14.3
15.1
15.9
11.1
11.9
12.7
13.5
14.3
15.1
15.9
11.1
11.9
12.7
13.5
14.3
15.1
15.9
11.1
11.9
12.7
13.5
14.3
15.1
15.9
11.1
11.9
12.7
13.5
14.3
15.1
15.9
15.9
14.3
11.9
8.6
25.4
6.4
10.0

10.2
10.3
11.1
11.1
11.7
11.8
11.8
12.5
12.0
12.0
12.1
12.8
12.8
13.4
13.5
13.5
14.2
13.7
13.9
14.0
14.3
14.5
15.1
15.3
15.3
16.3
15.6
15.8
15.9
8.00
6.50
6.26
6.25
6.25
6.25
6.25
6.25
6.25
7.86
8.01
8.01
8.01
8.00
8.01
8.00
9.49
9.73
9.73
9.76
9.74
9.75
9.74
11.0
11.3
11.5
11.4
11.5
11.5
11.6
12.8
13.0
13.1
13.2
13.3
13.3
13.5
14.5
14.7
14.8
15.0
15.0
15.0
15.3
4.25
6.50
6.00
6.25
8.00
5.00
5.50

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
SPR
SPR
SPR
HD
SPR
OT

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
Z
Z
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 225

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

mm

4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.687
4.750
4.875
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906

119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
119.05
120.65
123.83
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61

CENTURY
STOCK
NUMBER
73585
73591
73597
73603
73609
73615
73621
73627
73580
73586
73592
73598
73604
73610
73616
73622
73628
73581
73587
73593
73599
73605
73611
73617
73623
73629
73582
73588
73594
73600
73606
73612
73618
73624
73630
73583
73589
73595
73601
73607
73613
73619
73625
73631
73584
73590
73596
73602
73608
73614
73620
73626
73632
4049
4043
73633
73639
73645
73651
73657
73663
73634
73640
73646
73652
73658
73664
73635
73641
73647
73653
73659
73665
73636
73642
73648
73654
73660
73666
73637

FREE LENGTH
Inches

6.00
6.00
6.00
6.00
6.00
6.00
6.00
6.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
12.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
14.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
16.0
5.50
5.75
6.00
6.00
6.00
6.00
6.00
6.00
8.00
8.00
8.00
8.00
8.00
8.00
10.0
10.0
10.0
10.0
10.0
10.0
12.0
12.0
12.0
12.0
12.0
12.0
14.0

MATERIAL: MW - Music Wire

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

mm

152.4
152.4
152.4
152.4
152.4
152.4
152.4
152.4
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
304.8
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
355.6
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
406.4
139.7
146.1
152.4
152.4
152.4
152.4
152.4
152.4
203.2
203.2
203.2
203.2
203.2
203.2
254.0
254.0
254.0
254.0
254.0
254.0
304.8
304.8
304.8
304.8
304.8
304.8
355.6

I.D.
Inches

3.875
3.813
3.751
3.687
3.625
3.563
3.501
3.437
3.901
3.875
3.813
3.751
3.687
3.625
3.563
3.501
3.437
3.901
3.875
3.813
3.751
3.687
3.625
3.563
3.501
3.437
3.901
3.875
3.813
3.751
3.687
3.625
3.563
3.501
3.437
3.901
3.875
3.813
3.751
3.687
3.625
3.563
3.501
3.437
3.901
3.875
3.813
3.751
3.687
3.625
3.563
3.501
3.437
3.814
4.251
3.970
3.906
3.844
3.782
3.720
3.656
3.970
3.906
3.844
3.782
3.720
3.656
3.970
3.906
3.844
3.782
3.720
3.656
3.970
3.906
3.844
3.782
3.720
3.656
3.970

RATE
mm

98.4
96.9
95.3
93.6
92.1
90.5
88.9
87.3
99.1
98.4
96.9
95.3
93.6
92.1
90.5
88.9
87.3
99.1
98.4
96.9
95.3
93.6
92.1
90.5
88.9
87.3
99.1
98.4
96.9
95.3
93.6
92.1
90.5
88.9
87.3
99.1
98.4
96.9
95.3
93.6
92.1
90.5
88.9
87.3
99.1
98.4
96.9
95.3
93.6
92.1
90.5
88.9
87.3
96.9
108.0
100.8
99.2
97.6
96.1
94.5
92.9
100.8
99.2
97.6
96.1
94.5
92.9
100.8
99.2
97.6
96.1
94.5
92.9
100.8
99.2
97.6
96.1
94.5
92.9
100.8

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

Lbs./In.

137
182
245
326
398
511
648
818
89
100
130
175
233
283
363
461
574
69
78
101
136
181
220
282
351
444
58
64
83
111
148
179
230
288
362
49
54
70
94
126
152
195
244
304
42
47
61
82
109
131
169
209
263
251
41
210
280
364
466
591
746
150
200
260
333
422
520
117
156
202
250
328
399
96
127
165
206
268
329
81

WIRE DIA.

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

N/mm

24
32
43
57
70
89
113
143
16
17
23
31
41
50
64
81
101
12
14
18
24
32
38
49
62
78
10
11
14
19
26
31
40
50
63
8.5
9.4
12
16
22
27
34
43
53
7.4
8.3
11
14
19
23
30
37
46
44
7.2
37
49
64
82
103
131
26
35
46
58
74
91
20
27
35
44
57
70
17
22
29
36
47
58
14

Inches

2.9
2.7
2.4
2.1
2.1
1.9
1.7
1.6
4.1
4.0
3.7
3.4
3.0
2.9
2.7
2.4
2.3
5.3
5.1
4.8
4.4
3.8
3.8
3.4
3.2
2.9
6.3
6.2
5.9
5.3
4.7
4.6
4.2
3.9
3.6
7.5
7.5
6.9
6.3
5.5
5.5
5.0
4.6
4.3
8.6
8.5
8.0
7.3
6.4
6.3
5.7
5.3
4.9
2.1
3.7
2.7
2.4
2.2
2.0
1.8
1.7
3.8
3.3
3.1
2.8
2.5
2.4
4.9
4.3
3.9
3.7
3.2
3.1
5.9
5.2
4.8
4.5
4.0
3.8
7.0

mm

74
68
62
54
53
48
44
40
104
102
95
86
76
75
68
61
57
133
130
122
111
97
96
87
80
74
160
159
149
136
119
118
107
98
91
190
189
176
160
141
139
126
116
108
219
215
203
185
162
161
146
135
125
53
95
69
60
56
51
46
42
96
85
78
71
64
61
124
109
100
94
82
79
151
133
122
114
101
96
179

ENDS: C - Closed

G - Ground
O - Open

Lbs.

401
486
595
696
830
968
1110
1294
364
401
486
595
696
830
968
1110
1294
364
401
486
595
696
830
968
1110
1294
364
401
486
595
696
830
968
1110
1294
364
401
486
595
696
830
968
1110
1294
364
401
486
595
696
830
968
1110
1294
522
152
570
667
796
928
1064
1241
570
667
796
928
1064
1241
570
667
796
928
1064
1241
570
667
796
928
1064
1241
570

1783
2162
2646
3095
3693
4305
4938
5756
1620
1783
2162
2646
3095
3693
4305
4938
5756
1620
1783
2162
2646
3095
3693
4305
4938
5756
1620
1783
2162
2646
3095
3693
4305
4938
5756
1620
1783
2162
2646
3095
3693
4305
4938
5756
1620
1783
2162
2646
3095
3693
4305
4938
5756
2323
678
2534
2965
3539
4126
4734
5520
2534
2965
3539
4126
4734
5520
2534
2965
3539
4126
4734
5520
2534
2965
3539
4126
4734
5520
2534

Inches

2.28
2.51
2.69
2.88
3.19
3.37
3.56
3.75
2.70
2.84
3.17
3.39
3.63
4.05
4.29
4.52
4.81
3.24
3.40
3.82
4.10
4.38
4.91
5.20
5.56
5.86
3.74
3.96
4.48
4.80
5.12
5.77
6.11
6.52
6.91
4.27
4.57
5.14
5.50
5.88
6.64
7.02
7.49
7.97
4.81
5.08
5.79
6.20
6.63
7.50
7.94
8.53
9.03
2.57
2.03
2.69
2.88
3.05
3.23
3.41
3.59
3.40
3.63
3.85
4.08
4.30
4.61
4.09
4.37
4.65
5.06
5.19
5.63
4.78
5.14
5.45
5.90
6.09
6.56
5.49

mm

Inches

58.0
63.8
68.4
73.0
80.9
85.7
90.4
95.3
68.6
72.2
80.5
86.2
92.1
102.9
108.8
114.8
122.2
82.4
86.4
97.1
104.0
111.1
124.8
132.0
141.2
148.8
94.9
100.6
113.8
121.8
130.1
146.7
155.2
165.7
175.4
108.6
116.0
130.5
139.7
149.3
168.6
178.4
190.2
202.4
122.2
128.9
147.1
157.5
168.3
190.5
201.6
216.5
229.4
65.4
51.5
68.4
73.0
77.5
82.1
86.6
91.2
86.3
92.1
97.8
103.5
109.2
117.1
103.9
110.9
118.1
128.4
131.9
143.0
121.5
130.4
138.5
149.8
154.6
166.7
139.6

0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.393
0.406
0.437
0.468
0.500
0.531
0.562
0.593
0.625
0.468
0.312
0.468
0.500
0.531
0.562
0.593
0.625
0.468
0.500
0.531
0.562
0.593
0.625
0.468
0.500
0.531
0.562
0.593
0.625
0.468
0.500
0.531
0.562
0.593
0.625
0.468

mm

TOTAL
MATL
COILS

10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
10.0
10.3
11.1
11.9
12.7
13.5
14.3
15.1
15.9
11.9
7.9
11.9
12.7
13.5
14.3
15.1
15.9
11.9
12.7
13.5
14.3
15.1
15.9
11.9
12.7
13.5
14.3
15.1
15.9
11.9
12.7
13.5
14.3
15.1
15.9
11.9

5.63
5.75
5.75
5.75
6.00
6.00
6.00
6.00
6.88
7.00
7.25
7.25
7.25
7.63
7.63
7.63
7.70
8.25
8.37
8.75
8.75
8.75
9.25
9.25
9.38
9.38
9.51
9.75
10.2
10.3
10.2
10.9
10.9
11.0
11.1
10.9
11.3
11.8
11.7
11.8
12.5
12.5
12.6
12.8
12.2
12.5
13.3
13.3
13.3
14.1
14.1
14.4
14.4
5.50
5.50
5.76
5.75
5.75
5.75
5.75
5.75
7.26
7.25
7.25
7.25
7.25
7.38
8.74
8.73
8.76
9.00
8.76
9.01
10.2
10.3
10.3
10.5
10.3
10.5
11.7

OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
SPR
SPR
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT

E
N
D
S

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
Z
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N

COMPRESSION SPRINGS

O.D.
Inches

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

225

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 226

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

Inches

mm

CENTURY
STOCK
NUMBER

Inches

4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
4.906
5.000
5.000
5.000
5.000
5.250
5.500
5.500
5.750
6.000
6.000
6.000
6.060
6.125
6.250
6.250
6.500
6.500
6.500
7.250
7.250
7.500
7.750
8.000
9.000
9.250

124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
124.61
127.00
127.00
127.00
127.00
133.35
139.70
139.70
146.05
152.40
152.40
152.40
153.92
155.58
158.75
158.75
165.10
165.10
165.10
184.15
184.15
190.50
196.85
203.20
228.60
234.95

73643
73649
73655
73661
73667
73638
73644
73650
73656
73662
73668
4053
4083
4031
4088
4022-A
4036
4000-A
4097
4034
4094
4091
4099-A
4078
4099-B
4095
4089
4098
4092
4024-B
4099
4022-C
4044
4024
4027
4024-A

14.0
14.0
14.0
14.0
14.0
16.0
16.0
16.0
16.0
16.0
16.0
5.00
8.00
12.0
12.0
4.00
12.0
18.8
12.0
3.50
8.75
24.0
17.0
14.0
5.38
12.0
5.00
8.00
10.0
13.0
29.0
6.50
10.0
10.0
32.0
15.8

O.D.

FREE LENGTH
mm

355.6
355.6
355.6
355.6
355.6
406.4
406.4
406.4
406.4
406.4
406.4
127.0
203.2
304.8
304.8
101.6
304.8
476.3
304.8
88.9
222.3
609.6
431.8
355.6
136.5
304.8
127.0
203.2
254.0
330.2
736.6
165.1
254.0
254.0
812.8
400.1

I.D.
Inches

3.906
3.844
3.782
3.720
3.656
3.970
3.906
3.844
3.782
3.720
3.656
3.000
3.812
4.000
3.124
4.926
4.438
4.500
4.000
4.626
4.250
4.624
5.490
5.687
5.250
4.750
4.500
4.500
5.376
5.500
6.126
6.000
6.938
6.250
7.876
6.626

RATE
mm

99.2
97.6
96.1
94.5
92.9
100.8
99.2
97.6
96.1
94.5
92.9
76.2
96.8
101.6
79.3
125.1
112.7
114.3
101.6
117.5
108.0
117.4
139.4
144.4
133.4
120.7
114.3
114.3
136.6
139.7
155.6
152.4
176.2
158.8
200.1
168.3

Lbs./In.

N/mm

108
19
140
25
175
31
222
39
273
48
70
12
93
16
121
21
152
27
193
34
238
42
11230 1967
465
81
123
22
2767 485
4.1
.73
162
28
78
14
1818 318
2135 374
1669 292
175
31
4.9
.86
3.5
.61
291
51
547
96
4320 757
2033 356
211
37
591 104
34
6.0
370
65
39
6.9
717 126
28
4.9
2004 351

SUGG. MAX. DEFL. SUGG. MAX. LOAD SOLID LENGTH

Inches

6.2
5.7
5.3
4.8
4.5
8.1
7.2
6.6
6.1
5.5
5.2
.4
2.0
4.7
1.3
3.4
3.9
6.8
1.4
.6
1.5
7
13
12
1.8
2.7
.8
1.6
3.0
3.5
17
2.0
5.6
2.6
16
2.7

mm

157
144
135
122
115
207
182
167
155
140
132
10
51
120
33
87
100
174
36
15
38
178
338
317
46
69
20
41
76
89
422
51
141
66
418
69

Lbs.

667
796
928
1064
1241
570
667
796
928
1064
1241
4200
934
582
3600
14
635
532
2550
1220
2440
1210
65
44
529
1500
3460
3360
632
2060
569
739
219
1880
462
5370

2965
3539
4126
4734
5520
2534
2965
3539
4126
4734
5520
18690
4155
2589
16000
63
2824
2365
11350
5430
10860
5380
291
193
2354
6670
15400
14950
2811
9170
2532
3289
975
8360
2055
23890

Inches

5.86
6.24
6.74
7.10
7.65
6.21
6.65
7.05
7.59
7.99
8.59
4.00
3.86
5.00
7.50
.56
4.12
5.63
5.25
2.06
5.03
9.80
3.71
1.53
1.81
5.25
4.00
6.25
2.95
6.56
8.99
4.50
1.83
4.59
5.90
8.20

mm

148.9
158.4
171.2
180.4
194.3
157.7
168.8
179.1
192.8
203.0
218.2
101.6
98.1
127.0
190.6
14.2
104.5
142.9
133.4
52.3
127.8
249.0
94.1
38.9
46.1
133.4
101.6
158.8
74.9
166.7
228.4
114.3
46.4
116.7
149.9
208.3

mm

TOTAL
MATL
COILS

E
N
D
S

12.7
13.5
14.3
15.1
15.9
11.9
12.7
13.5
14.3
15.1
15.9
25.4
15.1
12.7
23.8
4.1
13.5
12.7
22.2
17.4
22.2
17.5
7.2
5.6
12.7
19.1
25.4
25.4
14.3
22.2
14.3
19.1
10.3
22.2
14.3
33.3

11.7
11.7
12.0
12.0
12.2
13.3
13.3
13.3
13.5
13.5
13.7
4.00
6.50
10.0
8.00
3.50
7.75
11.3
6.00
3.00
5.75
14.3
12.0
6.00
3.63
7.00
4.00
6.25
5.25
7.50
16.0
6.00
4.50
5.25
10.5
6.25

CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
C
C
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG
CG

WIRE DIA.
Inches

0.500
0.531
0.562
0.593
0.625
0.468
0.500
0.531
0.562
0.593
0.625
1.000
0.594
0.500
0.938
0.162
0.531
0.500
0.875
0.687
0.875
0.688
0.285
0.218
0.500
0.750
1.000
1.000
0.562
0.875
0.562
0.750
0.406
0.875
0.562
1.312

COMPRESSION SPRINGS
MATERIAL: MW - Music Wire

226

SPR - Spring Steel

HD - Hard Drawn
OT - Oil Tempered

SST - Stainless Steel

BC - Beryllium Copper
PB - Phosphor Bronze

ENDS: C - Closed

G - Ground
O - Open

FINISH: Z - Zinc

BO - Black Oxide
GI - Gold Irridite
N - None

OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
OT
HD
HD
SPR
HD
SST
SPR
SPR
HD
SPR
HD
HD
HD
SST
OT
HD
HD
HD
HD
SPR
HD
HD
SPR
SPR
SPR
HD

F
N
S
H

N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
N
GI
N
N
N
N
N
N
N
N
N
N
N
N
N

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 227

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

LONG LENGTH
COMPRESSION SPRINGS
The primary purpose of the 20" long stainless and 36"
long carbon steel spring bodies found in the following
tables is to offer our customers a means for creating a
desired custom length and/or spring compression travel
for a given load. Once cut, the end coils may be bent
back to touch the previous coil to create a squared end.

The spring rate constant (lbs./in.) can be determined for

any cut length by simply dividing the final length, in
inches, into the appropriate rate-inch value listed for the
spring body. The spring rate is merely the pounds it
takes to compress a spring each inch, i.e., if the rate =
5 lbs. per inch, it would take 5 pounds to compress it
one inch, 10 pounds to compress it 2 inches, 15 pounds
for 3 inches, etc..

LONG LENGTH COMPRESSION SPRINGS

STAINLESS STEEL (302) 20 INCH LENGTHS
ST2-13
ST2-15
ST2-17
ST2-20
ST3-15
ST3-17
ST3-20
ST3-26
ST4-15
ST4-17
ST4-20
ST4-26
ST4-32
ST5-20
ST5-26
ST5-32
ST5-41
ST6-32
ST6-41
ST6-54
ST7-41
ST7-54
ST8-54
ST8-72
ST9-41
ST9-54
ST9-72
ST9-91
ST10-72
ST10-91
ST12-91

O.D.
Inches

0.125
0.125
0.125
0.125
0.187
0.187
0.187
0.187
0.250
0.250
0.250
0.250
0.250
0.312
0.312
0.312
0.312
0.375
0.375
0.375
0.438
0.438
0.500
0.500
0.562
0.562
0.562
0.562
0.625
0.625
0.750

I.D.

WIRE DIA.

PITCH

RATE-INCH

mm

Inches

mm

Inches

mm

Inches

mm

Lbs.

3.18
3.18
3.18
3.18
4.75
4.75
4.75
4.75
6.35
6.35
6.35
6.35
6.35
7.92
7.92
7.92
7.92
9.53
9.53
9.53
11.13
11.13
12.70
12.70
14.27
14.27
14.27
14.27
15.88
15.88
19.05

0.099
0.095
0.091
0.085
0.157
0.153
0.147
0.135
0.220
0.216
0.210
0.198
0.186
0.272
0.260
0.248
0.230
0.311
0.293
0.267
0.356
0.330
0.392
0.356
0.480
0.454
0.418
0.380
0.481
0.443
0.568

3
2
2
2
4
4
4
3
6
5
5
5
5
7
7
6
6
8
7
7
9
8
10
9
12
12
11
10
12
11
14

0.013
0.015
0.017
0.020
0.015
0.017
0.020
0.026
0.015
0.017
0.020
0.026
0.032
0.020
0.026
0.032
0.041
0.032
0.041
0.054
0.041
0.054
0.054
0.072
0.041
0.054
0.072
0.091
0.072
0.091
0.091

0.33
0.38
0.43
0.51
0.38
0.43
0.51
0.66
0.38
0.43
0.51
0.66
0.81
0.51
0.66
0.81
1.04
0.81
1.04
1.37
1.04
1.37
1.37
1.83
1.04
1.37
1.83
2.31
1.83
2.31
2.31

.042
.040
.035
.033
.067
.066
.066
.052
.125
.117
.098
.080
.070
.150
.114
.095
.080
.130
.111
.095
.130
.117
.142
.133
.146
.166
.142
.142
.166
.160
.200

1
1
1
1
2
2
2
1
3
3
2
2
2
4
3
2
2
3
3
2
3
3
4
3
4
4
4
4
4
4
5

1.1
1.9
3.0
5.8
1.0
1.4
2.9
7.3
.60
1.0
1.6
4.2
10
1.2
2.9
7.0
15
4.4
11
32
7.6
23
18
61
3.8
14
44
128
35
99
66

4.9
8.5
13
26
4.4
6.2
13
32
2.7
4.4
7.1
19
46
5.3
13
31
66
20
49
142
34
102
80
271
17
62
196
569
156
440
294

SUGG. MAX LOAD

Lbs.

.8
1.2
1.8
2.8
.8
1.2
1.9
4
6.4
.9
1.4
3.1
5.5
1.2
2.5
4.5
8.9
3.8
7.5
16
6.5
14
12
27
5
11
24
46
22
42
35

3.6
5.3
8.0
12
3.6
5.3
8.5
18
28
4.0
6.2
14
24
5.3
11
20
40
17
33
71
29
62
53
120
22
49
107
205
98
187
156

SOLID LGTH PER

Lbs.

.32
.39
.49
.61
.21
.28
.32
.51
.13
.16
.22
.34
.42
.15
.25
.31
.53
.27
.39
.60
.34
.49
.41
.57
.31
.36
.54
.67
.47
.61
.50

8.1
9.9
12
15
5.3
7.1
8.1
13
3.3
4.1
5.6
8.6
11
3.8
6.4
7.9
13
6.9
9.9
15
8.6
12
10
14
7.9
9.1
14
17
12
15
13

COMPRESSION SPRINGS

CENTURY
STOCK
NUMBER

AVAILABLE FOR IMMEDIATE SHIPMENT

227

12-228 COMPRESSIONr2_12-228 COMPRESSIONr2 4/18/11 10:31 AM Page 228

1-800-237-5225
1-213-749-1466
Fax (213)749-3802
www.centuryspring.com

LONG LENGTH
COMPRESSION SPRINGS

LONG LENGTH COMPRESSION SPRINGS

CARBON STEEL (ASTM A227) 36 INCH LENGTHS

COMPRESSION SPRINGS
228

CENTURY
STOCK
NUMBER

Inches

mm

Inches

mm

Inches

mm

R-1
R-2
R-3
R-4
R-5
R-6
R-7
R-8
R-9
R-10
R-11
R-12
R-13
R-14
R-15
R-15-A
R-16
R-17
R-18
R-19
R-20
R-21
R-22
R-23
R-24
R-25
R-26
R-27
R-27-A
R-28
R-29
R-29-A
R-30
R-31

0.094
0.125
0.125
0.125
0.187
0.187
0.250
0.250
0.312
0.312
0.375
0.438
0.500
0.500
0.500
0.562
0.562
0.562
0.625
0.625
0.625
0.750
0.750
0.875
1.000
1.000
1.000
1.125
1.188
1.250
1.250
1.375
1.500
1.750

2.39
3.18
3.18
3.18
4.75
4.75
6.35
6.35
7.92
7.92
9.53
11.13
12.70
12.70
12.70
14.27
14.27
14.27
15.88
15.88
15.88
19.05
19.05
22.23
25.40
25.40
25.40
28.58
30.18
31.75
31.75
34.93
38.10
44.45

0.068
0.097
0.089
0.079
0.151
0.131
0.204
0.180
0.230
0.217
0.305
0.343
0.405
0.392
0.375
0.467
0.437
0.402
0.501
0.481
0.442
0.590
0.540
0.715
0.817
0.759
0.730
0.914
0.738
1.009
0.954
1.079
1.176
1.376

2
2
2
2
4
3
5
5
6
6
8
9
10
10
10
12
11
10
13
12
11
15
14
18
21
19
19
23
19
26
24
27
30
35

0.013
0.014
0.018
0.023
0.018
0.028
0.023
0.035
0.041
0.048
0.035
0.048
0.048
0.054
0.063
0.048
0.063
0.080
0.062
0.072
0.092
0.080
0.105
0.080
0.092
0.121
0.135
0.106
0.225
0.121
0.148
0.148
0.162
0.187

0.33
0.36
0.46
0.58
0.46
0.71
0.58
0.89
1.04
1.21
0.88
1.21
1.21
1.37
1.59
1.21
1.59
2.03
1.57
1.83
2.32
2.03
2.67
2.03
2.32
3.06
3.43
2.68
5.72
3.06
3.76
3.76
4.11
4.75

O.D.

I.D.

WIRE DIA.

PITCH

RATE-INCH

Inches

mm

.028
.039
.037
.036
.063
.063
.083
.072
.091
.086
.130
.130
.167
.151
.139
.132
.176
.157
.204
.181
.175
.234
.210
.300
.317
.287
.272
.382
.337
.375
.348
.340
.422
.470

1
1
1
1
2
2
2
2
2
2
3
3
4
4
4
3
4
4
5
5
4
6
5
8
8
7
7
10
9
10
9
9
11
12

Lbs.

2.2
1.6
4.6
13.7
2.0
13.8
2.9
15.6
18.6
35.8
7.1
16.7
13.8
20.9
38.0
7.4
32.0
83.0
24.5
41.5
120.0
46.0
137.0
35.2
43.9
131.0
201.6
65.5
1404
75.6
180
127
175
216

9.8
7.1
12
62
8.9
62
13
71
85
160
31
75
68
98
173
33
147
400
120
200
574
222
681
169
209
645
1032
311
7980
391
934
663
925
1183

AVAILABLE FOR IMMEDIATE SHIPMENT

SUGG. MAX LOAD

Lbs.

1
.9
1.9
3.8
1.4
5
2
7
8
12
5
9
8
12
17
4.7
15
30
14
21
40
23
49
20
26
55
75
34
252
44
78
71
84
108

4.4
4.0
6.2
17
6.2
22
8.9
31
36
53
22
40
36
53
76
31
67
133
62
93
178
102
218
89
116
245
334
151
1121
196
347
316
374
480

SOLID LGTH PER

Lbs.

.48
.38
.45
.65
.30
.46
.30
.50
.47
.57
.30
.40
.39
.39
.48
.39
.39
.55
.35
.44
.57
.39
.55
.33
.35
.49
.56
.35
.74
.40
.51
.52
.48
.51

12
9.7
11
17
7.6
12
7.6
13
12
14
7.6
10
9.9
9.9
12
9.9
9.9
14
8.9
11
14
9.9
14
8.4
8.9
12
14
8.9
19
10
13
13
12
13