Академический Документы
Профессиональный Документы
Культура Документы
Canyon NavMaster Remove the back cover of the computer with a screwdriver, install Alarm ON / OFF Afternoon
Features the 3.0V-battery with the positive(+) pole facing up and replace the Alarm Snooze Temperature in Celsius
Altimeter cover. Remove the battery and reinsert it if the LCD displays Battery Low Temperature in Fahrenheit
3V-Battery CR2032
Selection
z with highly accuracy of +-5 degree and a resolution of 1 Display Icons & Keys Illustration
z Right after Meter/Feet selection, the Celsius digit will then
degree
start to flicker
z a magnetic distortion alerts “Err” when external magnetic
z To select or , press button C and then press button A to
interference occurs
confirm.
z automatic shut-off
the confirmation, the minute digits will start to flicker. Snooze Alarm
z To set minutes, press button C to adjust the minute digits to z To set alarm time, in Clock mode, press and hold button A until
desired value and then press button A to confirm. the alarm hour digit start to flicker. Maximum and minimum Maximum and minimum
temperature memory temperature memory reset
z Repeat the process until you get a desire value of the day of z Press button C to adjust the hour digit and then press button A
Time
Spend
confirm to enter declination setting mode “dEC”. Altimeter Reading conditioner or Heater vent.
z Right after entering the declination setting mode, a letter “E” z Unfortunately all altimeter are going to be affected by Move the unit away from the interference.
starts to flicker. Press button C to select the direction East- E barometric pressure (unless they are GPS controlled Display readout fades and Poor battery or bad contacts.
or West- W and then press button A to confirm. or similar) as this is what they use to calculate their Incorrect readings Take out battery and install again or
z An angle digit will then start to flicker. To set the angle to be height. To offset this barometric effect on altimeter, Install a new battery.
offset, press button C to adjust to the desired value and then Please keep a check and re-adjust the altimeter when Black Display Temperature too hot, or display exposed
press button A to confirm. you are at known heights or re-setting your watch to to direct sunlight too long.
z As the declination setting will affect the direction directly, for zero at sea-level. Display shows irregular Take out battery and install again.
a serious and final confirmation, press button C to turn the figures
function “on” and then press button A again to confirm.
z In order to understand the declination effect, let us quote an And the declination angles for major world cites are listed as
example, the current direction is N 10 degree, If the follows:
declination angle is set to E 30 degree, the final will change
to NE 40 degree or If the declination angle is set to W 30
degree, the final direction will change to NW 340 degree.