Академический Документы
Профессиональный Документы
Культура Документы
NE Login
1. Connect the PC to the LCT port of IDU.
3. Input the IP address of the NE and WebLCT in URL Address box: http://172.17.254.253.The WebLCT login window appears, as shown
4. Input User Name: Admin, and Password: 12345678 in textbox. 5. Press OK. The WebLCT main window appears
Equipment Configuration
1. Expand Equipment Setup -> Equipment Configuration from the WebLCT menu. 2. Click the Setup.
5. Confirm that the setup parameter changes to blue, and then click OK
Radio Configuration
1. Expand Equipment Setup -> Radio Configuration from the WebLCT menu. 2. Click Setup. The Step1 Window appears
3. Input Channel Spacing /Modulation/TX frequency from Link Budget, Radio mode :High capacity, Frame ID :1, TX power control : MTPC. and then click Next button.
2. Input the E1 channels to be used, STM-1 must be 0, ETH bandwidth will be calculated automatically, and then click Next button.
TX Power Setting
1. Expand Provisioning -> MODEM Function Setting-> TX Power Setting
2. Click the MODEM1 to configure. The TX Power Setting dialog box appears.
3. Assign a proper value for each parameter. Then, click OK 4. Click OK in the pop-up Information box.
4. The default IP address is 172.18.0.1 for Near End site IDU, 172.18.0.2 for Far End site IDU.
E1 Port Setting
1. Expand Provisioning -> E1/STM-1/Cross Connect Setting -> E1 Port Setting 2. Click the Modify button. The E1 Port Setting (Main Board) dialog box appears 3. Assign
2. Click the Modify button. The E1 Port Setting (Main Board) dialog box appears
3. Assign a proper value for each parameter. Then, click OK 4. Click OK in the pop-up Information box
4. Write a name in service name and select Main Board at near end(E1/Modem) and MODEM1
6 OK
7: complete ok
2. Click the desired Port No. to configure. The ETH Port Setting dialog box appear
4.
VLAN Setting-Adding
4: Click Add VLAN ID 3 times and add 3 ID 4080, 4081 and 4082 one by one
VLAN Setting-Setting
1. Expand Provisioning-> ETH Function Setting-> VLAN Setting 2. Click Port No. button. The VLAN Setting window appears
3 Make Port Type Trunk from Access and enable all VLAN ID and press OK
7 OK
5.
2. Click MODEM1
3. Confirm the RX level is up to the design value, and the BER is better than 0.0E-8.
6.
6. Click Modem1