Академический Документы
Профессиональный Документы
Культура Документы
ELECTRICAL SYSTEM
1) What type of electrical motor is generally used with a direct cranking engine starter
1) DC shunt wound motor 2) DC series motor
3) Dc compound wound motor 4) fully compound motor
3) MTCS
1) Anti collision light is designed to give light intensity 30 degree above & below the horizontal
2) as in ‘1’ & the reflector rotation is not less than 40 rpm and giving a frequency of not more than 100
Cps
3) as in ‘2’ & light beacons are 180 degree apart at any instant
4) as in ‘3’ & it permits the position of the a/c to be more readily determined
4) Three equal impedances are first connected in star across a balanced 3- phase supply, if connected in
delta across the same supply
1) Power consumed is increased by three fold
2) Power consumed remains same
3) Power consumed is decreased by three times
6) Two wattmeter in 2 phase circuit test reads one load is positive & the other load is negative, PF is
1) 0.8 2) 0.5 3) 0.4 4) 0.3
8) R=6 OHMS, XL = 8 OHMS, & 200 VOLT at 50 Hz is applied to the RL circuit what is the voltage drop
across
1) 120 volts 2) 200 volts 3) 150 volts
9) Tumbler switch
1) Toggle switch 2) Rocker arm switch 3) Mercury switch
13) For measurement of power at very high frequency and low power which meter is used
1) Thermocouple meter
14) The mica capacitor having color coding of RED, GREEN, BLACK & GREY, the value of capacitance
1) 25 pf 2) 0.25 pf 3) 250 pf 4) 2.5 pf
18) If electrolyte is added in a new battery, before placing it in cervice it should be allowed to stand for
1) 24 hours 2) 1 hours 3) 6 hours
23) The generator rating is 40 KVa with power factor of 0.8 the maximum amount of power that can be
dissipated
1) 40 kW 2) 56 kW 3) 4 kW 4) 32 kW
24) For general service wiring the following cables are used
1) NYVIN 2) PREN 3) TERSIL 4) both ‘1’ & ‘2’
25) For position control & speed control mechanism the feedback is by
1) A potentiometer & Tacho generator
26) Maxwell loop current method of solving electrical network
1) Uses branch current 2) utilizes Kirchhoffs Voltage law
3) is confined to single loop circuit 4) is a network reduction method
28) In electrical diagrams whill troubleshooting the circuit, the procedure of correct sequence is
1) Schematic, Location, Routing Chart 2) Location, Schematic Routing Chart
3) Routing, Schematic, Location chart 4) Schematic, Routing, Location chart
31) In a Lead Acid battery, when a pair of electrons leave the negative side of battery
1) Lead atoms to Lead sulphate 2) Lead peroxide to Lead sulphate
3) Lead sulphate to Lead peroxide
47) To find out the fault between the input & output of an IC
1) Logic probe is used 2) voltmeter 3) ‘1’ & ‘2’ 4) ‘1’ & continuity tester
49) MTCS
1) Strobe lighting system is based on the principle of a capacitor discharge flash tube
2) Depending on the size of the a/c strobe lighting may be installed in the wing tips to supplement the
conventional red beacon
3) flashing frequency is 70 per minute
4) All & high intensity lighting system
54) In ESDS
1) isolate the pins 2) Shorted the pins
56) EPR
1) Turbine inlet & compressor outlet 2) compressor inlet & turbine outlet
3) Front of the compressor & rear of the turbine