Академический Документы
Профессиональный Документы
Культура Документы
14.5 Release
Goals
The objective of this workshop is to illustrate the process of applying initial angular velocity to a wirebond using steps. Initial angular velocity = 15 rad/sec.
Release 14.5
Project Schematic
Open the Project page.
From the Units menu verify: Project units are set to Metric (kg, m, s, C, A,N, V). Display Values in Project Units is checked (on).
Release 14.5
. . . Project Schematic
Begin a new Workbench session and, from the Project page, choose Restore Archive . . . and browse to the file W08C_Transient.wbpz and Open (location provided by instructor).
When prompted, Save using the default name in the same location as the archive file.
Release 14.5
. . . Project Schematic
1. From the Static Structural system double click (or RMB > Edit) the Model cell.
1.
2.
Release 14.5
Preprocessing
Since we will be using a remote displacement to apply the angular velocity, lets define a coordinate system at the origin where the velocity is to be applied: 3. 4. Highlight the Coordinate System under Model branch in the tree. Select the cylindrical face shown below, RMB > Insert > coordinate system.
4. 3.
Release 14.5
. . . Preprocessing
In order to apply an initial angular velocity of 15 rad/sec Initial angular displacement of 0.0015 rad The first step end time = 0.001 sec. Initial velocity of (0.0015/0.001) = 15 rad/sec.
Release 14.5
. . . Preprocessing
5. Highlight the Transient Analysis (A5) branch, Analysis Settings, and set up two load steps as shown
Make sure that time integration effects are turned off for the first step. on for the second step.
2012 ANSYS, Inc. March 28, 2013 8 Release 14.5
. . . Preprocessing
6. 7. 8. Highlight the Transient Analysis (A5) branch. Select the face as shown> RMB> Insert> Remote Displacement Under the details of Remote Displacement > Coordinate system> pick the previously defined coordinate system
7.
8.
Release 14.5
. . . Preprocessing
9. In the details of the Remote Displacement, fill in the Tabular Data as follows:
10. At the last cell under RX> RMB> Activate/Deactivate at this step!
10
Release 14.5
Solution
11. Highlight the Analysis Settings and from the details window change Large Deflection from to ON.
11
Release 14.5
. . .Solution
6. Highlight the Transient Analysis branch > RMB> Insert> Commands In the commands write kbc,0
7.
12
Release 14.5
. . .Solution
14. Solve the model:
Choose solve from the tool bar or RMB Solution branch and choose Solve.
13
Release 14.5
Postprocessing
14. Highlight the solution branch> Total Deformation
14
Release 14.5