Академический Документы
Профессиональный Документы
Культура Документы
into another format so that the message can be delivered across the appropriate
medium?
flow control
* encapsulation
encoding
multicasting
access method
2)
Refer to the graphic. Five PCs are connected through a hub. If host H1 wants to
reply to a message from host H2, which statement is true?
* H1 sends a unicast message to H2, but the hub forwards it to all devices.
Cisco-Training.net
H1 sends a unicast message to H2, and the hub forwards it directly to H2.
H1 sends a broadcast message to H2, and the hub forwards it to all devices.
H1 sends a multicast message to H2, and the hub forwards it directly to H2.
4) What does the 100 mean when referencing the 100BASE-T Ethernet
standard?
type of cable used
type of data transmission
* speed of transmission
type of connector required
maximum length of cable allowed
5) Which address does an NIC use when deciding whether to accept a frame?
source IP address
source MAC address
destination IP address
* destination MAC address
source Ethernet address
10) Which two networking devices are used to connect hosts to the access layer?
(Choose two.)
router
* hub
* switch
server
computer
11) Host A needs to learn the MAC address of Host B, which is on the same
LAN segment. A message has been sent to all the hosts on the segment asking
for the MAC address of Host B. Host B responds with its MAC address and all
other hosts disregard the request. What protocol was used in this scenario?
* ARP
DHCP
DNS
WINS
12) A switch receives a frame with a destination MAC address that is currently
not in the MAC table. What action does the switch perform?
It drops the frame.
It sends out an ARP request looking for the MAC address.
* It floods the frame out of all active ports, except the origination port.
It returns the frame to the sender.
14)
Cisco-Training.net
Refer to the graphic. What does the router do after it determines that a data
packet from Network 1 should be forwarded to Network 2?
It sends the data packet as it was received.
* It reassembles the frame with different MAC addresses than the original
frame.
It reassembles the data packet with different IP addresses than the original data
packet.
It reassembles both the packet and the frame with different destination IP and
MAC addresses.
15) Which table does a router use to make decisions on where a data packet is to
be sent?
ARP table
* routing table
network table
forwarding table
16) If the default gateway is configured incorrectly on the host, what is the
impact on communications?
The host is unable to communicate on the local network.
* The host can communicate with other hosts on the local network, but is unable
to communicate with hosts on remote networks.
The host can communicate with other hosts on remote networks, but is unable to
communicate with hosts on the local network.
There is no impact on communications.
17) What device is typically used as the default gateway for a computer?
a server hosted by the ISP
* the router interface closest to the computer
a server managed by a central IT department
the switch interface that connects to the computer
18) If a router receives a packet that it does not know how to forward, what type
of route must be configured on the router to prevent the router from dropping it?
dynamic route
* default route
destination route
default destination
Cisco-Training.net
19) Which two items are included in a network logical map? (Choose two.)
* naming scheme
* IP addressing scheme
length of cable runs
physical location of networking devices
specific layout of interconnections between networking devices and hosts
20) An integrated router can normally perform the functions of which two other
network devices? (Choose two.)
NIC
* switch
e-mail server
application server
* wireless access point
Cisco-Training.net