Академический Документы
Профессиональный Документы
Культура Документы
This document has been prepared to comply with OSHAs Hazard Communication Standard, 29 CFR 1910.1200
200 Mansell Court East, Suite 305 Roswell, GA 30076 Phone: (770) 645-4500 FAX: (770-645-2888 E-mail: info@BORALTRIM.com
Exposure Limits ACGIH TLV OSHA PEL 3 mg/m (except as 3 mg/m noted)
(3)
Carcinogenicity
Solid Polyurethane Coal Fly Ash(1) Crystalline Silica Fiberglass Pigments and Dyes Water-Based Acrylic (2) Primers and Paints
Notes to Table:
(2) (1)
15 mg (total) 5 (respirable) 15 mg (total) 5 (respirable) 30/% SiO2 + 2 (total) 10/% SiO2 + 2 (respirable) 15 (total) 5 (respirable) Not Applicable Not Applicable
10 (total) 3 (respirable) 10 (total) 3 (respirable) 0.025 1 fiber/cc Not Applicable Not Applicable
No No Yes No No No
(1) Coal fly ash composition is variable depending on its source. It may contain low levels of crystalline silica, but dust generation and exposure are minimized due to encapsulization in the product. (2) Pigments, dyes, primers, and paints vary with color and product type; present in low concentration, are not expected to contribute to product hazard. (3) The exposure limits set forth in the table are based on a time-weighted 8-hour, or full shift, exposure level. The formula information is provided for industrial hygiene and environmental purposes, and are not intended to represent product specifications.
Not Applicable
Vapor Pressure (mm Hg.)
1 1 0 None
Not Applicable
Vapor Density (AIR = 1)
None
Evaporation Rate (Butyl Acetate = 1)
Not Applicable
Solubility in Water pH
Insoluble
Appearance and Odor
Flash Point
LEL
UEL
Not applicable. Product will burn at > 500 F/260 C and emit thermal decomposition products
Extinguishing Media
Not Applicable
Not Applicable
Firefighters should wear self-contained breathing apparatus in accordance with the OSHA Respiratory Protection Standard 29 CFR 1910.134
Unusual Fire and Explosion Hazards
If ignited, material can burn rapidly with intense heat and dense black smoke with toxic gases. Material can melt into a burning liquid that can drip and flow.
mucous membranes. Material does not pose a hazard to skin under normal use conditions.
Inhalation: Dust can cause mechanical irritation to lungs. If ignited, decomposition products can irritate the
Material does not pose an ingestion hazard under normal use conditions.
Repeated and prolonged exposure to dust exceeding levels in Section II can cause lung irritation and lung disease.
CARCINOGENICITY: OSHA: IARC: NIOSH: NTP:
The crystalline silica component of fly ash is recognized by some agencies as a carcinogen. OSHA regulates crystalline silica as a respiratory disease hazard as indicated in Section II. IARC classifies crystalline silica as a Group 1 carcinogen. NIOSH considers respirable crystalline silica as known to be a human carcinogen. NTP has concluded that respirable crystalline silica is a known human carcinogen.
Material when waste is not hazardous waste; follow local requirements for solid waste disposal.
Precautions to be taken in handling and storing:
Hand washing with soap and water is sufficient to remove dust and prevent any skin irritation. If dust enters eyes, flush with large volumes of water for at least 15 minutes; obtain medical advice if irritation persists. Ingestion: Material is not expected to be harmful if ingested in small amounts. Inhalation: Dust inhalation should be minimized with ventilation and/or respiratory protection. If respiratory distress occurs upon exposure, medical advice should be obtained immediately.
Skin: Eyes: Medical Conditions Aggravated by Exposure:
Persons sensitive to respiratory irritants (e.g., asthmatics) should avoid dust exposure, which may aggravate their condition.
Page 3 of 3