Академический Документы
Профессиональный Документы
Культура Документы
09
NO PARTS WARRANTY AS IS
Mopar Performance parts beginning with a P prex are sold as is unless otherwise noted. This means that parts sold by Mopar Performance carry no warranty whatsoever. Implied warranties, such as warranties of merchantability, are excluded. (An implied warranty of merchantability means that the part is reasonably t for the general purpose for which it was sold). The entire risk as to quality and performance of such parts is with the buyer. Should such parts prove defective following their purchase, the buyer and not the manufacturer, distributor or retailer, assumes the entire cost of all necessary servicing or repair. Chrysler, Jeep , Dodge and Ram vehicle and parts warranties are voided if the vehicle or parts are used for competition. The addition of performance parts does not by itself void a vehicles warranty. However, added performance parts (parts not originally supplied on the vehicle from the factory) are not covered by the vehicles warranty, and any failure that they may cause is also not covered by the vehicles warranty.
EMISSIONS STATEMENT
Federal law requires emissions parts on new vehicles to be warranted for at least two years or 24,000 miles, whichever comes rst. Federal and many state laws also prohibit the removal, modication or rendering inoperative any part that affects emissions or safety on motor vehicles used on public streets or highways. Many Mopar Performance parts are designated for track use or off-road use only. Installation of certain components may bring the vehicle out of compliance with safety and/or emissions standards. Mopar recommends that vehicles with parts designated in this fashion not be operated on public roads. Mopar Performance customers are responsible for complying with applicable state and local environmental regulations. Additionally, certain performance parts may affect the emissions characteristics of the vehicle. If you install them on the vehicle, and your vehicle consequently fails a required state or local I/M (inspection and maintenance) emissions test, including any test required to maintain or renew your vehicles registration, or if your vehicle is subject to an emissions recall, Chrysler Group LLC may not be required to repair your vehicle under the emissions performance warranty, and you may be required to remove those parts at your own expense in order to obtain repairs necessary to pass the I/M test or to perform the recall.
Select images in this catalog are used with permission of Mopar Nationals, Inc., Chrysler Historical Society, and the Walter P. Chrysler Museum.
TABLE OF CONTENTS
ENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Hemi, Gen III . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . . Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . . Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . . Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Transmission and Drivetrain . . . . . . . . . . . . . . . . . . . . . . . . Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . . Hemi, Gen II . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Installation Components . . . . . . . . . . . . . . . . . . . . . Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . . Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . . Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . . Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . . Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . . Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Big Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . . Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . . 10 10 10 11 12 12 12 12 13 14 14 15 15 17 17 19 22 22 24 25 25 26 26 27 27 28 29 30 32 34 35 37 39 42 42 42 42 43 43 44 50 51 53 Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . . Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . . Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Small Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . . Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . . Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . . Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . . Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54 56 57 60 64 64 66 69 69 70 71 74 78 82 85 87 90 93 95
RESTORATION . . . . . . . . . . . . . . . . . . . . . . 100
Fuel Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Fuel Pumps and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Vapor Separator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Six Pack Induction Systems . . . . . . . . . . . . . . . . . . . . . . . . . Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fuel Injection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . Distributors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . Electronic Ignition Systems . . . . . . . . . . . . . . . . . . . . . . . . . Ballast Resistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ignition Wires and Spark Plugs . . . . . . . . . . . . . . . . . . . . . . Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Starters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Voltage Regulators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . . Alternators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . Flex Plates and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . . Automatic Transmission Components . . . . . . . . . . . . . . . . . Transmission Overhaul Kits . . . . . . . . . . . . . . . . . . . . . . . . . Transmission Pans and Hardware . . . . . . . . . . . . . . . . . . . . 100 100 101 102 102 104 106 108 108 109 110 111 112 113 113 114 114 116 116 116 116 118 119
P. | 4
TABLE OF CONTENTS
Torque Converters and Hardware . . . . . . . . . . . . . . . . . . . . Manual Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . . Flywheels and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . Bell Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Clutch Discs, Pressure Plates and Hardware . . . . . . . . . . . Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . . Drivetrain and Rear Axle Components . . . . . . . . . . . . . . Universal Joint and Yoke Kits . . . . . . . . . . . . . . . . . . . . . . . Rear Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . . Steering, Suspension, and Brakes . . . . . . . . . . . . . . . . . . Leaf Springs and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Frame Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Torsion Bars and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Suspension Seals and Bushings . . . . . . . . . . . . . . . . . . . . . Manual Steering Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Shocks and Struts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Interior/Body . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Underhood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Grilles and Headlamp Bezels . . . . . . . . . . . . . . . . . . . . . . . . Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . . Handles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Racks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Bumpers/ Bumperettes . . . . . . . . . . . . . . . . . . . . . . . . . . . . Lamps and Lenses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Sheetmetal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheelhouse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Valence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Emblems and Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119 122 122 123 123 125 128 128 129 130 132 132 135 135 135 136 136 136 140 140 145 147 148 149 150 151 151 151 151 153 154 154 155 158 Transmission Components . . . . . . . . . . . . . . . . . . . . . . . . . Suspension Upgrades and Components . . . . . . . . . . . . . . . Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . GTS-R Engine Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . . Eight-Cylinder Late Model Vehicles . . . . . . . . . . . . . . . . . Electronic Control Modules . . . . . . . . . . . . . . . . . . . . . . . . . Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . . Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Suspension Upgrades and Components . . . . . . . . . . . . . . . Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . . Four- and Six-Cylinder Late Model Vehicles . . . . . . . . . . Turbo Service Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Engine Struts and Mounts . . . . . . . . . . . . . . . . . . . . . . . . . . Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . . Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . . Valve Train Hardware and Components . . . . . . . . . . . . . . . Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . . Suspension Upgrades and Components . . . . . . . . . . . . . . . Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . . Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Transaxle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . . Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 168 169 170 171 171 173 176 176 176 177 179 180 180 181 184 184 185 186 186 186 186 187 187 188 188 192 194 195 196 197 197 198 198 198
P. | 5
TABLE OF CONTENTS
Sprint Car / Midget / Dirt Late Model . . . . . . . . . . . . . . . . Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . . Valve Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . . Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Gear Drives and Service Parts . . . . . . . . . . . . . . . . . . . . . . Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . NASCAR / Late Model . . . . . . . . . . . . . . . . . . . . . . . . . . . Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . . Oil, Fuel, and Water Pumps . . . . . . . . . . . . . . . . . . . . . . . . . NASCAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212 212 212 213 214 214 215 215 215 216 217 217 220 220 220 221 221 221 223 223 223 223 224 Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . . Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . . Off Road Tools and Accessories . . . . . . . . . . . . . . . . . . . . . 257 258 258
MISCELLANEOUS . . . . . . . . . . . . . . . . . . . 262
Performance Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gauge Pods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gauge Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SilverStar Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Merchandise . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Diecast . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Posters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Fender Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Wheel Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262 262 270 270 274 274 278 278 280 281 282 282 283
JEEP/RAM . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Jeep/Ram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . . Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . . Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . . Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . . Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . . Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . . Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . . Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Suspension Upgrades and Components . . . . . . . . . . . . . . . Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . . Automatic Transmission Components . . . . . . . . . . . . . . . . . Transmission/Transfer Cases . . . . . . . . . . . . . . . . . . . . . . . Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . . Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 230 230 230 230 231 231 232 232 232 233 234 238 241 242 252 253 254 255 256
P. | 6
DRIVETRAIN AND REAR AXLE COMPONENTS UNIVERSAL JOINT AND YOKE KITS A. Axle Yoke Kits
Complete driveshaft pinion yoke kits include yoke, U-joint retaining straps, strap hold-down bolts, yoke retaining washer and nut, and instructions. Axle Yoke, 10 Spline, 7290 Joint, Dana 60 Axles, 8-3/4" P4876804
A.
B.
C.
D.
E.
F.
G.
P. | 128
Visit us on the Web! www.mopar.com Not legal on pollution-controlled vehicles or vehicles registered for highway use.
DRIVETRAIN AND REAR AXLE COMPONENTS REAR AXLE COMPONENTS A. Ring and Pinion Sets
These high-performance rear end Ring and Pinion Gears are manufactured with a special heat treat process. They are made with the special needs of drag race and off-road competition in mind. 1 P5249927AB Ring and Pinion Gears, Rear Axle, 3.55:1 Ratio, 12-Bolt Cover, 9 1/4"Axles
A.
B.
P5007239
C. Axle Brace
Keeps axle tubes from twisting under extreme loads, and provides strength and rigidity to Chrysler 8-3/4-inch axles. Welding required. Axle Brace, 8-3/4" Axles P4510642
R E S T O R A T I O N
P4529485
F. Crush Sleeves
C. D.
Original equipment Crush Sleeves for setting up rear axle. Includes pinion nut washer and pinion flange nut. Crush Sleeve, 8-1/4" Axles P4529700
P4529702
E.
F.
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364) Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 129
DRIVETRAIN AND REAR AXLE COMPONENTS REAR AXLE COMPONENTS A. Ring Gear Retaining Bolt Set
Complete set of 12 bolts with instructions. Bolt Package, Ring Gear, Left-Hand Thread, to 1970: 7-1/4" P5249163 and 8-3/4"; to 1971: 8-1/4" Axles Bolt Package, Ring Gear, Right Hand Thread, 1971-on: 7P4529486 1/4" and 8-3/4" Axles, 1972-on: 8-1/4" Axles
A.
B.
P3690754 P3690755
Cover, Differential, Chrome, RWD, 9-1/4" Axles, 1973 and Newer Cover, Differential, Chrome, RWD, 9-3/4" Dana 60 Axles
P5249719
Axle Shim, Rear, 1, 2pcs. Axle Shim, Rear, 2, 2pcs. Axle Shim, Rear, 3, 2pcs.
C.
D.
E.
P. | 130
Visit us on the Web! www.mopar.com Not legal on pollution-controlled vehicles or vehicles registered for highway use.
PERFORMANCE CATALOG