Академический Документы
Профессиональный Документы
Культура Документы
The boundaries on which the duplicate nodes lie are assigned zone ID numbers (just like any other boundary) when the mesh files are combined, as described in Reading Multiple Mesh/Case/Data Files. You need to keep track of the zone ID numbers when t m e r g eor TGrid reports its progress or, after the complete mesh is read in, display all boundary mesh zones and use the mouse-probe button to determine the zone names (see Controlling the Mouse Button Functions for information about the mouse button functions).
3/31/2014
If all of the appropriate faces do not get fused using the default Tolerance , you should increase it and attempt to fuse the zones again. (This tolerance is the same as the matching tolerance discussed in Creating Conformal Periodic Zones.) The Tolerance should not exceed 0.5, or you may fuse the wrong nodes. When fusing face zones using the GUI, ANSYS FLUENT automatically assigns a new name to the fused interface zone. If you would like to preserve the original name of one of the face zones being fused, you can use the m e s h / m o d i f y z o n e s / f u s e f a c e z o n e stext command, as shown in the following example.
/ m e s h / m o d i f y z o n e s>f u s e f a c e z o n e s ( ) Z o n et of u s e ( 1 )[ ( ) ] t o p Z o n et of u s e ( 2 )[ ( ) ] b o t t o m . 1 Z o n et of u s e ( 3 )[ ( ) ] < E n t e r > a l l3 7 8f a c e sm a t c h e df o rz o n e s3a n d1 2 . f u s i n gc r e a t e dn e wt h r e a d ,i n t e r i o r 1 8 . T h ef u s e dz o n en a m e :( a u t o m a t i cb o t t o m . 1t o p ) E n t e rn a m e[ a u t o m a t i c ] t o p N a m eo fz o n e1 8i sc h a n g e di n t ot o p . F u s e dl i s to fz o n e s .
Important: Remember to save a new case file (and a data file, if data exists) after fusing faces.
This command will prompt you for the name or ID of each zone to be fused. (You will enter the same zone twice.) To change the node tolerance, use the m e s h / m o d i f y z o n e s / m a t c h i n g t o l e r a n c etext command.
Release 14.0 - 2011 SAS IP, Inc. All rights reserved.
https://www.sharcnet.ca/Software/Fluent14/help/flu_ug/flu_ug_FuseBoundaries.html
2/2