0 оценок0% нашли этот документ полезным (0 голосов)
1K просмотров2 страницы
FS2CREW PMDG 737 TRIGGER VOICE COMMANDS ALTERNATIVES ANSWERS Captain flows and VOICE COMMANDS Run PF after setting up Main Panel LEGENDA Red text to be spoken. Crew member ask if you are ready for to boarding, YES PREFLIGHT CHECKLIST preflight checklist oxygen tested, 100 percent instrument xfer and display switches normal, auto window heat on pressurization mode selector
FS2CREW PMDG 737 TRIGGER VOICE COMMANDS ALTERNATIVES ANSWERS Captain flows and VOICE COMMANDS Run PF after setting up Main Panel LEGENDA Red text to be spoken. Crew member ask if you are ready for to boarding, YES PREFLIGHT CHECKLIST preflight checklist oxygen tested, 100 percent instrument xfer and display switches normal, auto window heat on pressurization mode selector
FS2CREW PMDG 737 TRIGGER VOICE COMMANDS ALTERNATIVES ANSWERS Captain flows and VOICE COMMANDS Run PF after setting up Main Panel LEGENDA Red text to be spoken. Crew member ask if you are ready for to boarding, YES PREFLIGHT CHECKLIST preflight checklist oxygen tested, 100 percent instrument xfer and display switches normal, auto window heat on pressurization mode selector
LEGENDA <--PF ELEC--> Red text to be spoken T+30: Set IRS to NAV, setup FMC <--Pre-Flight Events--> T+18: crew member ask if you are ready for to boarding , YES <FS2Crew Events> <--PF MAIN--> PREFLIGHT CHECKLIST PREFLIGHT CHECKLIST* Oxygen Tested, 100 percent Instrument Xfer & Display Switches Normal, Auto Window Heat On Pressurization Mode Selector Auto Flight Instrument Set* e.g.:HEADING: 220 ALTIMETERS 1013 Parking Brake Set Engine Start Levers Cutoff ARE YOU READY FOR THE DEPARTURE BRIEF? ANY QUESTIONS? T+8: Ground staff will hand you a loadsheet , THANKS T+1: FA will inform you they're ready in the back , THANKS Set STAB TRIM, arm A/T, setup MCP BEFORE START CHECKLIST BEFORE START CHECKLIST Flight Deck Doot Closed and Locked Fuel ______KGS/LBS, Pumps On* Kilograms/Tons/Pounds Pumps On Passengers Sign On Windows Locked MCP Set* e.g.: V2: 140 HEADING: 2 0 ALTITUDE: 1 2TH. Takeoff Speed Set* e.g.: V1: 1 4 0 (P) VR: 1 4 5 (P) V2: 1 4 6 CDU Preflight Completed Rudder & Aileron Trim Free and Zero Taxi & Takeoff Briefing Completed Anti Collision Lights On <S.CREW/ENG START> Setup audio control panel FLT button COCKPIT TO GROUND? (Ground crew will reply with Go Ahead) WE ARE READY FOR THE PUSHBACK AND ENGINE START (Ground crew will reply) BRAKES RELEASED START SEQUENCE IS TWO THEN ONE START ENGINE TWO START ENGINE ONE After pushback completed ground crew told you set parking brakes , BARKE SET YOU ARE CLEARED TO DISCONNECT AND GO TO HAND SIGNALS <SET TO FLAPS> FLAPS 5 BEFORE TAXI CHECKLIST BEFORE TAXI Generators On Probe Heat On Anti-Ice On* On/Off/Engine Anti-Ice On/Both On Isolation Valve Auto Engine Start Switches Continuous Recall Checked Autobrake RTO Engine Start Levers Idle Detent Flight Controls Checked Ground Equipment Clear CLEAR ON THE LEFT, begin taxi and turn on Taxi Light Switch FA will call the cockpit informing cabin is ready for takeoff, FO will answer BEFORE TAKEOFF CHECKLIST BEFORE T/O Flaps ____, Green Light e.g.: Flaps 1 (5, 10, 15, 25), Green Light Stabilizer Trim ____, Units e.g.: 4 point 0 Units At the hold short line when enter the rwy , RUNWAY ENTRY PROCEDURE <RUNWAY ENTRY PROCEDURE> After FO says Ready to Go , TAKEOFF <TAKEOFF> V1, Rotate, Positive Rate, GEAR UP, After flaps are up AFTER TAKEOFF CHECKLIST AFTER T/O Engine Bleeds On Packs Auto Landing Gear Up and Off Flaps Up, No Lights Passing TA press STD on EFIS to change altimeter to Standard pressure 50-100NM back of TOD brief the FO ARE YOU READY FOR THE APPROACH BRIEF? ANY QUESTIONS? <DESCENT> DESCENT CHECKLIST DESCENT Pressurization Landing Alt____ Recall Checked Autobrake _____ Landing Data VREF____Minimums____ Approach Briefing Completed Set TL into FMC DES FORECAST PAGE, setup ILS freq on radios Passing TL FO will call TRANSITION LEVEL, press STD and set altimeter on PFD ALTIMETERS X Y X Y Passing 10,000ft or TL call for Approach Checklist APPROACH CHECKLIST APPROACH Altimeters ____Set* e.g.: Altimeters 2 8 9 0 FO will read-back his altimeters setting, read-back yours LANDING CHECKLIST LANDING Engine Start Switches Continuous FLAPS 1, 5, 15, GEAR DOWN, LANDING CHECKLIST Speed Brake Armed Landing Gear Down Flaps ____, Green Light* e.g.: Flaps 15 (30, 40) Green Lights When cleared to land, CLEARED, when FO says Minimuns, LANDING ROLL OUT Brake manually, MANUAL BRAKING, after exit rwy, OKAY TO CLEAN UP <CLEAN UP> FO read silently After Landing Checklist, Taxi to gate, FO will tell you APU on-line PRE-SHUTDOWN Set parking brake at the gate <--P.SHUTDOWN--> FO will tell you he's ready fot shutdown, set both fuel levers to cutoff <--SHUTDOWN<<> 1st Chime: YES, FA tell you slides are disarmed PA: CABIN CREW DOORS MAY BE OPENED 2nd Chime: GO AHEAD, Ground crew let you know the chocks are in (FLT active) SHUTDOWN CHECKLIST SHUTDOWN Fuel Pumps Off Probe Heat Off Hydraulic Panel Set Flaps Up Parking Brake Released/Seto to Park Engine Start Levers Cutoff Weather Radar Off SECURE AIRCRAFT PLEASE <--SECURE--> Manually shut off the APU and turn off position lights SECURING AIRCRAFT CHECKLIST SECURING AIRCRAFT IRS's Off Emergent Exit Light Off Window Heat Off Packs Off