Академический Документы
Профессиональный Документы
Культура Документы
EXAM2 0 11
- -
SI. No.
F-DTN-M-DJWB
CIVIL ENGINEERING
Paper II
Time Allowed : Three Hours
Maximum Marks : 300
INSTRUCTIONS
Each question is printed both in Hindi and in English.
Answers must be written in the medium specified in the
Admission Certificate issued to you, which must be stated
clearly on the cover of the answer-book in the space
provided for the purpose. No marks will be given for the
answers written in a medium other than that specified in
the Admission Certificate.
Candidates should attempt Question Nos. 1 and 5 which
are compulsory, and any three of the remaining questions
selecting at least one question from each Section.
The number of marks carried by each part of a question is
indicated against each.
Notations/terms used have their usual meanings, unless
otherwise indicated.
If any data is considered insufficient, assume suitable
value and indicate the same clearly.
Provide diagrams in the answer-book wherever necessary.
A graph sheet is attached to this question paper, which
may be detached and used, if required. The graph sheet is
to be securely fastened to the answer-book.
Important : Whenever a Question is being attempted, all
its parts/sub-parts must be attempted contiguously. This
means that before moving on to the next Question to be
attempted, candidates must finish attempting all parts/
sub-parts of the previous Question attempted. This is to
be strictly followed.
Pages left blank in the answer-book are to be clearly
struck out in ink. Any answers that follow pages left blank
may not be given credit.
SZ 17 7 31-011 EFT frc7 re f< 7 7 -cri Prei
CR- Eg VI
tl
Section 'A'
1. (a) (i) Which building block/s you will like to
use for a sound and thermal proofing of a
studio and why ? 3
(ii) Natural/Mechanical/ A.C. Which cir-
culation and cooling system is best suited
for our country and why ? 3
(iii) Which sampling procedure/principle you
would recommend for quality control of
R.C.C. work of a mass housing project
and why ? Serial/Grid/random ? 3
(iv) Resource allocation and levelling will
completely upset and change the
optimum time schedule as obtained by
crashing of network based on costs only.
Comment. 3
(b) (i) Which cement will you recommend for
mass concrete
low permeability concrete
high strength concrete ? 3
(ii) Which type of cement concrete you
will recommend for 'blast resistance
purpose' and why ? 2
F-DTN-M-DJWB 2
(Contd.)
a
1.
3
(ii) 'Res a gf-d-e-th chid' * f r fmtl
7*-R k Th**r 741-r a-2 4-r441 ? 2
F-DTN-M-DJWB 3 (Contd.)
(iii) Illustrate briefly one estimation method
for one bedroom house. 5
(iv) Which compaction and consolidation
equipment you recommend for quick
construction of a high rise building and
why ? 2
(c) (i) Briefly discuss factors contributing to the
ownership cost of a heavy construction
equipment. 3
(ii) Briefly elaborate the factors contributing
to the rental value of a heavy construc-
tion equipment. 3
(iii) Explain the functions of 'spurs' in river
regulation. Also state the parameters on
which design of spur depends. 6
(d) During a particular stage of growth of a crop,
consumptive use of water is 3.2 mm/day.
Determine the interval between irrigations and
depth of water to be applied when the amount
of water available in the soil is (i) 35%
(ii) 75%and (iii) 0%of the maximum depth
of available water in the root zone which is
100 mm. Assume irrigation efficiency to be
60%. 12
F-DTN-M-DJWB 4 (Contd.)
(iii)
t @TZT9" WU (Ai tcfri t 197 afitt
arr*79- %.T 0-cr 4 wJR-4-
5
(iv)
than3 /4 efv -Wm- 3 /4 kg
7-rEr
47- ft arq-siwr
MIT I'?
2
(i)
7T 4re- RTifur Ei7- 3 /4 dm 3 /4
1Ti .17q141 3 /4-t-t3/4): 41 *ems
4 -1R; 441
flf-47I
3
(ii) 73/4 me- f9-147- Ei7- 3 /4 R--crErr
4Cq,1 3 /4 kg
.fticqiLi 3/473/4):3/4)- 44Er
I 3
010 9-R.0 k sta.: R4-1.T et41 I
t ? 3 /4-r 31-fl eg3/47-79- , *lei 4 Trffth
vz srm-r1- 7- ad t ?
6
(Contd.)
417 mei citil r aitift
-45 tc1:MIT WM'
PTPT tr< wt. gwrq dl t tr4't trro-r",
"csAl 4-isior" ".4suliciicb r0- w. -Far"
WI- 01w pre Q1-47147,174fftf47kim cb<
R1747
c:1101 % i-s-rwr sedia7
attr ctre *
is
n
wri, icbqf imrr
t1
12
2. () 4 9 l 0 1 keircriT kd** P-14-1 (I t 1
Rectii WIT -if RTTicia *11 -4 tiR (en
t W4
11 (10 Wf ara LiR arcrS41. cnNld
it 30 0 0 gfaff
PI4n
'T 2,00,000 t I
34-iirr* acirmft weir, fta
Tsar Ruin
agE sin
1
_
T IM M
41CtM
T
isrfaraw
*
A D& E 8 6
2000
B F
12
8 1500
C
20 19
2500
D
A 1 0 9 3000
E F A 5 3 1000
F B & F 10 9 2200
20
F-D1N-M-DAVB
(Contd.)
A
10 W s 6
th,f)1
) ---"0- 4 to
(b) (0 A part of the network is drawn as
follows :
Tabulate the dependencies as shown.
If actually Z depends on B & Y and
R depends on Y & Q only is there any
error ? If yes name this error, and redraw
the corrected network. 2+2+6=10
(ii) State and explain factors which influence
the silting of reservoirs. How this affects
the useful life of reservoir ? Also explain
the terms 'live storage', 'dead storage'
and 'effective storage' in this context.
10
F-DTN-M-DJWB
8
(Contd.)
(i) 4Z-4
1747 4:)" 7:1- 19-1g, 4 R74Thl
A
l0 5 0 C6
10 5
7
ctUw-
dp:ff1 fltqw Trg - 7714-441-F4wr
eftcr, qrq citectRici,
ti4Z tR-411 B
3i- 1T Y "TT T4TR Trlc
e
Y 311(Q ER
7E4 idii14 ? 4)- V .1111 974
4z4 4A-Feirl 47-
44 7: W97 I
2+2+6=10
(ii) 3 9'
chkchl cb) adi < Q 4
,4-r -4147
wow-0 4 fliq-era 4,1 9wr-4-6 ct,<
zt mcdwzr n-T9 9- Ltiti chit
SIST4-TAU T-k- ? winf
"tiff
(1- ) c4i-grcur" , " 4-li (7) troi"
917fr
" 9-1-Tr* Kr)\-fta-4)'ite- J-474" tFru
ttf-A7I
10
F-DTN-M-DJWB
9
(Contd.)
(c) Annual flooddata ofa river for 3 0 years
yieldedmeanannual discharge of3 0000 m3 /s
anda standarddeviationof15000 m3 lscc. For
a proposedbridge onthis river, it is decidedto
have anacceptable risk of10% andservice life
of50 years.
1. Estimate the flooddischarge for designof
bridge.
2 . Ifthe actual floodvalue adoptedinthe
designis 1,18,000 m3 /sec, what is the
safety marginfor maximum flood
discharge ?
(Giventhat ReducedmeanandStandard
deviationfor Gumbel distributionfor 3 0 years
are 0.53 80 and1119 respectively.) 2 0
3 . (a) (i) Compare andcontrast the
selfcompactingconcrete and
harsh concrete.
Where each is used? Comment onthe
workability. 10
(ii) List different type ofstone masonry.
Explainthe purpose ofthrough stones in
random nibble masonry. What is the
stichingofdistressedbigstone blocks ?
Discuss. 10
F-DTN-M-DJWB 10 (Contd.)
3 0 TinarrUtiiedZTR7Te ,:incr6FT
3i149. 61114 Pithtui 3 0000 m3 /s yet PUNT
ITRT .R979" 15000 m3 /sec fI w
1'41
T
rt
TIT
9V .TTPda. q iffq zfffar Rtrr Tim R.
ar-frrf9wq- IR- 47r 10% W4IT 50 TEI lT ;Aaictiim
1. 4-q q 3 rflim-c -z@
fri -A7
2 . <liedlenc1Ir T Icr9- ft
10
Interest rate 10%.
A
lacs Z lacs
Initial cost 2.5 3.0
Annual costs 0.5 0.3
Salvage 25 5
Useful life 5 years 5 years
Annual
quality gain Nil 2
(ii) Explain and differentiate between unit
hydrograph (UH) and Instantaneous unit
hydrograph. Also explain the computa-
tional steps for deriving 2h UH from a
6h UH. 10
(c) What are the conditions based on which the
effective length of the spillway is decided ?
What are the various methods adopted in
energy dissipation below a spillway ? Explain
the most suitable energy dissipation arrange-
ments that you would recommend for each of
the following conditions.
(i) When Jump Height Curve (JHC) is
always above Tail Water Curve (TWC).
(ii) When JHC and TWC nearly coincide,
and
(iii) When JHC is always below TWC. 20
F-DTN-M-DJWB
12
(Contd.)
(u)
(0 e arch 11 MCI qi 147 11-4
afr4
f=7 t \Ficruiff 43Tfw
10
ar~~
10%t I
A B
Mllq ewsi
alit-NTT 2.5 10
izt, ?rid 0.5 0.3
rItTINYI .5
9P-1-9-d 39 5 IN5 awl
arfif
litriffrff54
7:1" -2
(ii) PTV TWA7 424 43Tk4 141-4i PM."). 4
(i)
u,chich 1
-4514.11,t) (UH) err
(ii) TWNTT
crT 2h UH 4 6h UH ch) jcc9q dA4 k -N7
rifluid Fold, Pt oh) 4'07 I 10
(Tr) 4 TfttrfC reTfurn't f-m4k 3Trurc
Avil Aid) t ? k
ow fi-RTw faruth:
? 414 4)- '
ifa k
earl 377 c1-11 d-oir -R4-44M4 Brom
a,-a ?
(i) 74 .1-001,1 tlr15ti 74*) dqr1-1-.0
7ff (t th)
6,L
i& t 1
(ii) w 4 74*m-4 :fT4 wrwr Ow*
(iii) 7-4 4 7-q tft dur 414 *1
20
F-DTN-M-DJWB
13
(Contd.)
4. (a) (i)Sketch a drag line and explain function
of each part. 10
(ii) List the different ingredients of a brick
making clay and function of each part.
10
(b)
?
% -- 1-7 % I*
cii(lt,A ar-- 4q I
6
(37 ) (I) R----1-
14s gdiaciAut awr aff
- d-49- 1-ewk-ur
ti
-(F-47
2
F-DTN-M-DJWB
17 (Contd.)
(ii) Determine amount ofbleachingpowder
requiredannually ina water treatment
plant treating10 millionlitre per day of
water if0.2 ppm ofchlorine dose is
required. Available bleachingpowder
contains 3 0 per cent ofavailable chlorine.
10
6.
(a) (i) Define probability density function(pdf)
andcumulative density function(cdf).
Draw pdfandcdffor a Normal Distribu-
tion.
5+5=10
(ii) Define Runningspeed, Time Mean
speedandSpace Meanspeed. Explain
methodofmeasuringspot speedusing
Enoscope.
4+6=10
(b)
(i) Explaindifferent types ofroadsigns with
examples andsketches.
12
(ii) Explainsequential
transportation
planningprocess.
8
(c)
(i) Designthe spacingandsize ofthe dowel
bars at anexpansionjoint ofconcrete
pavement ofthickness 2 0 ern. Giventhe
radius ofrelative stiffness of90 cm,
designwheel load4000 kg, loadcapacity
ofdowel system is 40 per cent ofdesign
wheel load. Joint width is 3 .0 cm andthe
permissible stress inshear, bendingand
the bearingstress indowel bars are 1000,
1500 and100 kg/cm
2 respectively. 10
F-DTN-M-DJWB
18
(Contd.)
(ii) 7+ 7 qte 4, * 10 141; 144
4. 9-Rfq9. *ffi- ctrwit., .1114 W*1.
taut.. < it R.-9.* 4rxr graww
0.2 ppm 19)-(1ffTiKrq it 3 1.M4chcii t I
,vicieDJW1SiT4t3 3 t
4 3 0% t 110
6. (T) (1)
ErTO' them ONTO Mtntiv4
thci (th-acrE)*
trh rFEra- itf-4
tfractcg mir :11#7cE *f
wftrmnr
ifF97 I
5+5=10
(ii) trf-cw%41-47 trr49' Wrff, wrdwur
3 1aTi9.
WF r4e04 774r4
W-6" 9Tffa) Atcift ? 4+6=10
(q.) (i) " F`4.1V 5*R *
Trrif fikaii fqi
& i mi
aRI
e
er-47I
12
3frleTrT rift-4W 44-11 MT 4- WE
itfirg I
5
(ii) A combined sewer system is serving
20,000 persons having BOD, 70 gm per
capita and 50,000 litres industrial
effluent per day having BOD 450 mg//.
If average standard BOD of domestic
sewage is 0.08 kg/day/person, find the
population equivalent of sewage.
15
F-DTN-M-DJWB 20
(Contd.)
dr1.1051 ch a-qr al-duff Z13rR4-- *-FR
frF4g7461"q111t.kTigriThaf20cm,
ITO 9171 7.0 in 727T 39tar 31)5 t I
arrwt t I 4-mq, 9c Q-
Tzrerdwt-kt(9701711 :700 t I Af4TTTitT
n = 0.01 i:rm- ciriro:I 15
#311a
(U)
(i)arIcrra- 4=07 I 3111fiTE
Tt
th3ft-et '
7011-9" rchti Ac I& 14I 7PT, Z77 39t1ff
tt 6)cll t ? 5
8
(ii) t 4114 ITT I4m (=is' u t((;141 YoluldI 1 4
2 50 Waa Trft I ,sisi
biC4+1 9 ul dI ciT
500 m allarrTrwr araWcisb *145:Arr *,
f?1,4fikel nowr ? 8
(H) 1114 4,4-51* .-, ,Trir 81T-4" 3 qcbc-0 tvry
*rr-4gI R-ff9Th-R TrrTfTr-dt 4 T*-trc
3 T
GMI1 srmwr ' 4)Z
arni csi OH t1 ? 4
(T4) (1) 7 -4):ch-I*1 3 1- 1-( Kfq-iffi t,1 Q-F-A-7 14 *1(1
o-lti With* *CiectRui cklee.rf*)TcrE
491-47 ITRa **Thr a- i): crii,iltdfi
eve. tj 15
(10 (i) Thrd" Trtta-T aqT
RT1wur ITT fRTFT t ? 10
trTrfaTur iq i awl 41ci 4Tr t ?
utTr' 4 .-Erfrwr raft RT.r4trr ctikoqi
Q-F-47 I
1()
F-DTN-M-DJWB
2 3
F-DTN-M-DJWB
ZINTI PI 44t
5r4w-trq 11
rfr : 300
4 4 -14 cf n Wu
9.0W P7 el 3ik _3 _7 Wit t
T34 iW1 myr-4 ,4 14 wr6cr, 7 A-ff
4 P* 9)V- - 77 7 1T 4 14 t H FRZ I TT fir Far 3*(21"
ant -
9 -iffW tftc1-973. 9Z Saff Wig FP- 4 4 cir Riff unfit
WP67 I 94 4 T- 91" 97.,..iRe il;fct r keakm- WRI ft?
FTSTPT ifPi<