Академический Документы
Профессиональный Документы
Культура Документы
Cautions:
1. Always make sure that the unit is plugged into a properly grounded outlet.
2. Do not remove bowl from its base unless unit is turned off.
3. At no time should you place your hands inside the working chamber while the machine is running.
Always make sure that the machine is turned off before performing this operation.
4. When machine is not in use, remove bowl from machine base.
5. Do not fill the chamber past the recommended maximum fill line to avoid spillage.
Most metals will achieve the desired effect in 30 to 40 minutes. It is good practice to check the parts progress after the
first 20 minutes. If your cycle time ends and you feel you have not reached the desired result, then go through the above
steps to set the timer for increments of 10 minutes. Always remember that machine should be turned off when reaching
into the chamber to check the parts. As you check your parts for progress, you will notice that the water solution is quite
“warm”. This is normal as the heat aids in finishing your parts. The increase in heat is not cause by the machine but by
the friction between the metal and the stainless steel media pins while processing is occurring.
It is also important to keep the machine clean during the working cycle. Therefore, we recommend that after cycle, the
bowl should be removed to clean out thoroughly. Remember that the solution will pour quite easily and the pins will stay
at the bottom of the bowl once the bowl is tipped. Do not tip to quickly as you do not want to loose the pins, as they are
difficult to pick up once spilled. It is recommended that you use your lid as a sort of stopper, as if you were pouring water
out of a cooking pan. Once cleaned, simply repeat the above steps and continue on with the next cycle. If you are going to
be doing several cycle or batches, it is recommended that you purchase a separate extra bowl so that no time is lost and
your work course will continue. The last page shows the spare bowls that are available.
Warranty
Please note that all our machines are covered under a one (1) year warranty from date of purchase in case of a problem
should occur.
Chart
Part No. Model No. Pins Supplied Ring Capacity Recommend Pin Recommended #750
Usage Compound Usage*
147.645 K140-100 250 gram 8—12 125 gram 1/2 teaspoon
147.650 K149-160 250 gram 30 250 gram 1 teaspoon
147.653 K149-230 500 gram 100 500 gram 2 teaspoon
147.656 K149-300 1000 gram 225 1000 gram 3 teaspoon
* If sudsing/foaming occurs, reduces the amount of compound used, until sudsing is reduced.
Extra Bowls
Part No. Description Price
147.646 Extra bowl for K140-100 43.50
147.651 Extra bowl for K149-160 54.50
147.654 Extra bowl for K149-230 95.50
147.657 Extra bowl for K149-300 120.50
Pins
147.660 0.5x5mm pins 250 gram 32.50
147.662 0.3x5mm pins 250 gram 37.50
147.667* 1.2mm balls 200 gram 115.00
Compound
147.777 Magnetic tumbling shot cleaning compound #750 1 lb. 6.70
* 1.2mm balls are only used in conjunction with the pins. When used by themselves they do not move, but when used with the pins, they allow the jewelry
being polished to move more freely, decreasing the time required for polishing.
Otto Frei
P.O. Box 796—126 Second Street— Oakland, CA 94607
510.832.0355 — 510.834.6217 fax