Вы находитесь на странице: 1из 3

9/13/2014 Electronics Engineering: ECT001 Potential Electronics Technician Board Exam Questions

http://www.electronicspectrum.com/2012/10/ect001-potential-electronics-technician.html 1/3
ECT001
Your Answers
Question. 1)Correct

What formula is used to calculate voltage in a circuit?

A. Voltage (E) equals current (I) minus resistance (R)
B. Voltage (E) equals current (I) added to resistance (R)
C. Voltage (E) equals current (I) divided by resistance (R)

D. Voltage (E) equals current (I) multiplied by resistance (R) (Your
Answer)
Question. 2)Correct

What is the voltage across a 10-ohm resistor if a current of 2 amperes
flows through it?

A. 12 volts
B. 0.2 volts
C. 20 volts (Your Answer)
D. 8 volts
Question. 3)Correct

What is the basic unit of inductance?

A. The coulomb
B. The farad
C. The henry (Your Answer)
D. The ohm
Question. 4)Correct

What is the resistance of a circuit that draws 4 amperes from a 12-volt
source?

A. 3 ohms (Your Answer)
B. 8 ohms
9/13/2014 Electronics Engineering: ECT001 Potential Electronics Technician Board Exam Questions
http://www.electronicspectrum.com/2012/10/ect001-potential-electronics-technician.html 2/3
C. 16 ohms
D. 48 ohms
Question. 5)Correct

What is component 2 in the figure?

A. Connector
B. Resistor
C. Indicator lamp
D. Transistor (Your Answer)
Question. 6)Correct

Which of the following is a good electrical conductor?

A. Rubber
B. Wood
C. Glass
D. Copper (Your Answer)
Question. 7)Correct

What term describes the number of times per second that an
alternating current reverses direction?

A. Speed
B. Wavelength
C. Frequency (Your Answer)
9/13/2014 Electronics Engineering: ECT001 Potential Electronics Technician Board Exam Questions
http://www.electronicspectrum.com/2012/10/ect001-potential-electronics-technician.html 3/3
D. Pulse rate
Question. 8)Correct

What electrical component is used to oppose the flow of current in a
DC circuit?

A. Resistor (Your Answer)
B. Transformer
C. Inductor
D. Voltmeter
Question. 9)Incorrect

What is the approximate bandwidth of a VHF repeater FM phone
signal?

A. Less than 500 Hz (Your Answer)
B. Between 5 and 15 kHz (Answer)
C. Between 50 and 125 kHz
D. About 150 kHz
Question. 10)Correct

Electrical power is measured in which of the following units?

A. Amperes
B. Watts (Your Answer)
C. Volts
D. Ohms
Embed
Embed & Share This Quiz Close X
<iframe name='proprofs' id='proprofs'
height='442' width='445' frameborder=0
marginwidth=0 marginheight=0
src='http://www.proprofs.com/quiz-
school/widget/v3/?
id=421473&bgcolor=ffffff&fcolor=000000
&tcolor=000000&w=425&h=295&ff=1&fs=med
ium&pplink=1&embedlink=1&btncolor=0000
00></iframe><div style='font-
View On
ProProfs.com

Вам также может понравиться