Вы находитесь на странице: 1из 1

INSTRUCTIONS FOR USE - RELOADING SYSTEM FOR ANNULAR PERCUSSION FIREARMS H&C (RF, RIMFIRE)

AFTER SHOOTING____________________









.38 RF & .41RF :
If the neck of the cartridge is too large, it is possible to resize it when it is still empty: use a cartridge without
primer / black powder for your first trial. Insert the cartridge from 1/3 to 2/3 of its length.





















If necessary, apply assembly paste, to have the bullet going in and out the tool more easily. If, on the contrary, it is
too loose, you can use a drop of fixating quick-drying glue. It is also possible to enlarge the primers, giving them an
oval shape with a pair of pliers.
Place the bullet
head on top of the
empty cartridge
case. Put the case,
bottom down, on
the base of the
tool, then put the
sizing die (neck
downward) over
the whole.
Adjust the seating tool by mounting the first cartridge with a
mallet, forcing the bullet head down into the case until it is
shoulder deep, and only shoulder deep, in the case. Screw
the bushing down against the sizing die and fix this setting
by tightening the top-nut.

Fill the case with
black powder, leaving
enough space for the
primer.
Prime the case with a .22/6mm acorn blank
of the type used in starting pistols. Press but
dont strike the primer into position using a
block of wood, plastic, or similar material
of medium hardness. If, on the contrary, it
is too loose, you can use a drop of fixating
quick-drying glue. To fire, do not forget to
position the cartridges so that the primer is
lined up with the firing pin.
De-prime; do not
forget to clean
the case.
Re-size (lubricate
the case first)
Extract the case
from the re-sizing
die. The case is now
ready for reloading.
JUST BEFORE FIRING:
- Make sure the primer is in line with the firing pin.
- For repeating arms which use tubular magazines, these cartridges only work when loaded directly into the
breech, one at a time, single-shot fashion.
32 RF - RESIZING THE BULLET:
If needs be, it is possible to reduce the caliber of the bullet by 1/10th of a mm:
- Put the sizing die, neck uppermost, on your work surface.
- Put the bullet into it, nose downward.
- With the kits extractor rod and a mallet, tap the bullet all the way through the sizing die/sizer.
Before shooting, have your gun checked by a gunsmith.
Use BLACK POWDER ONLY
H & C
BP 28. 69563 Saint Genis-Laval cedex - France
Tl +339 71 31 05 35
www.hc-collection.com
E-mail : contact@hc-collection.com PTO
Screw vice
Sizing die

Вам также может понравиться