Академический Документы
Профессиональный Документы
Культура Документы
SUPPORTED FEATURES
Alarm Monitoring
Controlling Vista panel from Control Map/Floor Plan
o Partition Arm/Disarm
o Zone Bypass/Unbypass
o Output On/Off
Virtual Keypad
o Send key-Strokes
o Display Update
Command File Support
Video Pop-up on Vista Alarms
Operator Action Report
INDEX
Section1: Vista Panel Programming For Home Automation Protocol
A. Equipments Required
B. Connections For Home/Facility Automation Control
C. Summary of programming commands
D. Programming for the ADEMCO 4100 SM Procedure
E. Configurations
Section2: Vista Configuration in WIN-PAK
A. Installation Instructions
B. Add Comm Server
C. Add HA Port
D. Add Vista Panel
E. Configure Control Map
F. Configure Floor Plan
G. Vista Command File Support
H. Virtual Keypad
I. Operator Action Report
J. Vista Action Group and Action Messages
K. Vista Monitoring and Control
9
8
GREY
YELLOW
WHITE
VIOLET
RED
BROWN
BLUE
GREEN
BLACK
4100SM
SERIAL
MODULE
8
+ PWR
- (GND)
RXD
NOT USED
NOT USED
TXD
NOT USED
DTR
RED
BLUE
WHITE
J2 CONNECTOR
12
AUX GND.
11
AUX PWR.
TO
AUTOMATION
EQUIPMENT
(RS232 INTERFACE)
4100SM-015-V1
Find out the installer code. For 128/250 FBP it is 5140 by default.
To set defaults, enter *97
o 1 to load ADEMCO defaults; 2 to load ADT defaults; 0 to exit without changing
programming
*96 is used to set engineering defaults.
o If this is performed then you must do a *97 to set standard defaults.
To enter into program mode
o Enter installer code + [8] + [0]+ [0] +[0]
o Installer code can be modified *00 option once entered into program mode.
o Installer code must be provided in WIN-PAK from HA port page. It will be used to
perform Panel Reset from WIN-PAK.
To change to next page of program fields, press *94
E. Configurations
E. Configure Control Map Define Control Map from top-level menu Configuration -> Define>Control Area.
a. Add Vista device(s) to an appropriate branch. Filters are provided in Add Devices
dialog box.
F. Configure Floor Plan Define Floor Plan from top-level menu Configuration
Currently Floor Plan representations for Vista devices are same as Galaxy devices. Tool Tip
over the icon exhibits the correct type.
G. Vista Command File Support Vista Command Files can be configured from top-level menu
Configuration->Command Files
H. Virtual Keypad can be launched from selected partition node in Control Map. A delay of up to
6 seconds may be seen before the Virtual Keypad is updated. 2 seconds is typical. If no
response is seen with in 6 seconds, you may need to re-enter the key pad strokes. Closing
and re-launching the Virtual Keypad will force a refresh of the display (less than 2 seconds).
I.
Operator Action Report displays the summary of action taken on Vista Devices.
J. Vista Action Groups and Action Messages: Digital Video Camera and Command Files can be
associated with Vista actions.
K. Monitoring and Control from Alarm View, Control Map and Floor Plan