Академический Документы
Профессиональный Документы
Культура Документы
Instalation (included)
$15,900.00
WING KIT
Main Wings (2) $1,800.00
Low Drag Wings N (add $400.00)
Outer wing mounts (2) $300.00
Bushings & seals (4) $50.00
Elevators (2) $1,200.00
Inside mounting plates (2) $250.00
Center universal joint $150.00
Swing Arm $200.00
Set Collars,pins & fasteners $75.00
Instalation (included)
$4,025.00
KEEL STRIP
Front pedal assembly $1,600.00
Custom pedal straps Y $180.00 $180.00
wing shaft center-mount $300.00
Hand control sticks (2) $320.00
hand control center-mounts (2) $100.00
hand control side-mount (2) $220.00
Bushings (3) $75.00
Forward swing arms (2) $125.00
Rear swing arms (2) $125.00
Hand control linkages (2) $160.00
Pins, fasteners, keepers $75.00
Steering cables $215.00
Elevator cable (1) $235.00
Cable guides (2) $50.00
Front toweye $95.00
Instalation (included)
$3,875.00
CANOPY HARDWARE
3/8” Acrylic Canopy (2) $3,100.00
1/2” Acrylic Y $600.00 (add $600)
Lower mounting plates (2) $180.00
Upper Frame mounts (2) $350.00
Swing Arms (2) $875.00
Bushings (4) $160.00
adjusters,fasteners,keepers $25.00
Page 1
Sheet1
Instalation (included)
$11,150.00
DRIVE
Jet Drive $2,900.00
Vectored Trim Thrust Y $850.00 (add $850)
Manual selector $360.00
Instalation (included)
$4,185.00
EXHAUST SYSTEM
3” exhaust hose (3 feet) $65.00
s/s exhaust coupler $60.00
Waterbox mod's $300.00
Manifold mod's $150.00
Instalation
$575.00
FUEL SYSTEM
9 gallon fuel tank $499.00
14 gallon fuel tank Y $250.00 (add $250)
Fill tubes, elbows, and lines $150.00
Chrome gas cap and fill spout $170.00
Tank mounts & straps $180.00
Page 2
Sheet1
Instalation
$1,534.00
ELECTRICAL SYSTEM
Battery $140.00
Battery Box $120.00
Hot bar $40.00
Ground Bar $40.00
Switch pannel (4 switches) $140.00
(add $140)
Main Ignition $30.00
Start/Stop buttons
Wiring harness $200.00
Instalation of wiring $750.00
$1,460.00
PNEUMATIC SEALS
Canopy seal $375.00
Engine hatch seal $260.00
lines, and fittings $75.00
regulater $80.00
manual pump $40.00
Electric pump Y $300.00 (add $300)
Installation $400.00
$1,530.00
SNORKEL HARDWARE
Water separator box $300.00
Vent tubes, fittings $180.00
Water sensor $65.00
Camera mount Y $125.00 $125.00
Instalation $750.00
$670.00
INTERIOR HARDWARE
Pilot's seat (fiberglass) $525.00
Seat mounts $200.00
Custom vinyl upholstery Y $800.00 (add $400/seat))
vinyl side pannels Y $500.00 (add $500)
Rear seat (fiberglass) Y $525.00 (add $525)
Sliding front seat N (add $380)
Hinging front seat Y $240.00 (add $240)
Front Seat harness Y $375.00 (add $375)
Rear seat harness Y $375.00 (add $375)
Stock dashboard $750.00
Digital gages (speedo,tach,fuel,compass,trim) $500.00
Custom dash module Y $400.00 (add $400)
Additional gages (2) Y $400.00 Approx $400)
Instalation (included)
$5,590.00
EXTERIOR HARDWARE
Engine hatch latches (4) $225.00
Bilge pump outputs $60.00
Stainless outlets Y $140.00 (add $140)
Front tow hook $60.00
Rear tow hook Y $250.00 (add $250)
Page 3
Sheet1
$69,721.00 $69,721.00
P.O.A
Page 4