Академический Документы
Профессиональный Документы
Культура Документы
1
Alcoholic Fuels: An
Overview
Shelley D. Minteer
Saint Louis University, Missouri
CONTENTS
Introduction ...........................................................................................................1
Methanol................................................................................................................2
Ethanol ..................................................................................................................3
Butanol ..................................................................................................................3
Propanol ................................................................................................................4
Conclusions ...........................................................................................................4
References .............................................................................................................4
Abstract
Alcohol-based fuels have been used as replacements for gasoline in
combustion engines and for fuel cells. The four alcohols that are typically used
as fuels are methanol, ethanol, propanol, and butanol. Ethanol is the most widely
used fuel due to its lower toxicity properties and wide abundance, but this chapter
introduces the reader to all four types of fuels and compares them.
INTRODUCTION
Alcohol-based fuels have been important energy sources since the 1800s. As early
as 1894, France and Germany were using ethanol in internal combustion engines.
Henry Ford was quoted in 1925 as saying that ethanol was the fuel of the future
[1]. He was not the only supporter of ethanol in the early 20th century. Alexander
Graham Bell was a promoter of ethanol, because the decreased emission to
burning ethanol [2]. Thomas Edison also backed the idea of industrial uses for
farm products and supported Henry Fords campaign for ethanol [3]. Over the
years and across the world, alcohol-based fuels have seen short-term increases
in use depending on the current strategic or economic situation at that time in
the country of interest. For instance, the United States saw a resurgence in ethanol
fuel during the oil crisis of the 1970s [4]. Alcohols have been used as fuels in
three main ways: as a fuel for a combustion engine (replacing gasoline), as a
fuel additive to achieve octane boosting (or antiknock) effects similar to the
2006 by Taylor & Francis Group, LLC
ETHANOL
Ethanol (also known as ethyl alcohol) is the most common of alcohols. It is the
form of alcohol that is in alcoholic beverages and is easily produced from corn,
sugar, or fruits through fermentation of carbohydrates. Its chemical structure is
CH
3
CH
2
BUTANOL
Butanol is the most complex of the alcohol-based fuels. It is a four-carbon alcohol
with a structure of CH
3
CH
2
CH
2
CH
2
4
Alcoholic Fuels
the efficiency of the fuel cell is poor because incomplete oxidation products easily
passivate the platinum catalyst in a traditional fuel cell.
PROPANOL
Although propanols are three carbon alcohols with the general formula C
3
O,
they are rarely used as fuels. Isopropanol (also called rubbing alcohol) is frequently
used as a disinfectant and considered to be a better disinfectant than
ethanol, but it is rarely used as a fuel. It is a colorless liquid like the other alcohols
and is flammable. It has a pungent odor that is noticeable at concentrations as
low as 3 ppm. Isopropanol is also used as an industrial solvent and as a gasoline
additive for dealing with problems of water or ice in fuel lines. It has a freezing
point of 89C and a boiling point of 83C. Isopropanol is typically produced
from propene from decomposed petroleum, but can also be produced from fermentation
of sugars. Isopropanol is commonly used for chemical synthesis or as
a solvent, so almost 2M tons are produced worldwide.
CONCLUSIONS
In todays fuel market, methanol and ethanol are the only commercially viable
fuels. Both methanol and ethanol have been blended with gasoline, but ethanol
is the current choice for gasoline blends. Methanol has found its place in the
market as an additive for biodiesel and as a fuel for direct methanol fuel cells,
which are being studied as an alternative for rechargeable batteries in small
electronic devices. Currently, butanol is too expensive to compete with ethanol
in the blended fuel market, but researchers are working on methods to decrease
cost and efficiency of production to allow for butanol blends, because the vapor
pressure difference has environmental advantages. Governmental initiatives
should ensure an increased use of alcohol-based fuels in automobiles and other
energy conversion devices.
REFERENCES
1. Ford Predicts Fuel From Vegetation,
The New York Times
, Sept. 20, 1925, p. 24.
2.
National Geographic
, 31, 131, 1917.
3. Borth, C.,
Chemists and Their Work
, Bobbs-Merrill, New York, 1928.
4. Kovarik, B., Henry Ford, Charles F. Kettering and the Fuel of the Future,
Automot.
Hist. Rev.
, 32, 727, 1998.
5.
Toxicology and Applied Pharmacology
, Academic Press, Inc., 16, 718, 1970.
6.
Raw Material Data Handbook, Vol. 1: Organic Solvents
, Nat. Assoc. Print. Ink
Res. Inst., 1, 44, 1974.
7.
National Institute for Occupational Safety and Health, U.S. Dept. of Health,
Education, and Welfare, Reports and Memoranda
, DHHS, 92100, 1992.
2006 by Taylor & Francis Group, LLC