Академический Документы
Профессиональный Документы
Культура Документы
Smart questions
Smart answers
Smart people
Go
Find A Forum
Go
Home > Forums > Mechanical Engineers > Activities > Mechanical engineering other topics Forum
thread404-318794
Share This
24
Mar
12
5:19
Hello,
could someone advice on the design approach for a vessel whose design pressure is greater than 3000psi(20MP) if the client stated that the vessel
should be design to ASME BPVC Section 8 Div 1. this concern is based on this provision in the code: U-1(d) The rules of this Division have been
formulated
on the basis of design principles and construction practices
applicable to vessels designed for pressures not exceeding
3000 psi (20 MPa). For pressures above 3000 psi (20 MPa),
deviations from and additions to these rules usually are
necessary to meet the requirements of design principles
and construction practices for these higher pressures.
Regards,
143raphsea
24
Mar
12
5:35
Hello,
could someone advice on the design approach for a vessel whose design pressure is greater than 3000psi(20MP) if the client stated that the vessel should
be design to ASME BPVC Section 8 Div 1. this concern is based on this provision in the code: U-1(d) The rules of this Division have been formulated
on the basis of design principles and construction practices
applicable to vessels designed for pressures not exceeding
3000 psi (20 MPa). For pressures above 3000 psi (20 MPa),
deviations from and additions to these rules usually are
necessary to meet the requirements of design principles
and construction practices for these higher pressures.
Is section 8 Div 2 more appropriate ?
Regards,
143raphsea
Cockroach (Mechanical)
24
Mar
12
9:54
Are you asking for the design of a pressure vessel for an application that exceeds 3.0 ski, or are you inquiring on the interpretation of ASME BPVC
Section 8 Div 1, vs Div 2? You are very unclear.
Regards,
Cockroach
http://www.eng-tips.com/viewthread.cfm?qid=318794
1/2
17/10/2014
desertfox (Mechanical)
24
Mar
12
10:11
Hi 143raphsea
Have a look at this thread link below:thread794-126260: Sect. VIII Div. I Over 3000 PSI
desertfox
24
Mar
12
10:56
Thank you all. Yes, i was asking of design of a pressure vessel for an application that exceeds 3.0 ski. The thread suggested by desertfox is really helpful.
Regards,
143raphsea.
http://www.eng-tips.com/viewthread.cfm?qid=318794
2/2