Академический Документы
Профессиональный Документы
Культура Документы
Question
Answer
On my 600i2 (UF-45),
the LED lights are
flashing and projector
will not power up why?
http://www2.smarttech.com/kbdoc/128329
1. Press the power button on the ECP or remote twice to put the
projector back into Standby mode. The power button light on the
ECP turns solid amber when the projector is in Standby.
2. Press and hold the up button on the remote control for
approximately 10 seconds. When the projector beeps, press and
hold the down button on the remote control for approximately 10
seconds. The lamp timer clears after another beep.
3. Press the power button on the ECP or remote to start up the
system. The power button light on the ECP turns solid green when
the system starts.
4. To confirm that the lamp timer has been reset, press the MENU
button on the remote control. Scroll to the Status Display menu
heading, and then confirm that 0 h appears in the Lamp timer field.
Your lamp reset count has increased by one.
5. Wait five minutes for the projector lamp to warm up.
6. After confirming that the lamp timer has been reset, put the
system in Standby mode by pressing the power button twice on the
ECP or remote. The power button light on the ECP turns solid
amber when the system is in standby.
7. Wait for the system to enter Standby mode, turn off the
projectors master power switch to shut off the system, and then
turn on the projectors master power switch.
8. When you are ready to use the system, press the power button
on the ECP to start up the system.
The SB680 is 47.5" (120 cm). The SB660 is 39.5" (100.3 cm)
The unit comes with an ECP and cable loom to connect from the
ECP to the projector. Since each installation may be different from
the ECP to the PC, you should provide your own cable that is
suitable