Академический Документы
Профессиональный Документы
Культура Документы
How it works
As show figure below , there are the didoe 1N4001 D3 and D4 acting full-wave rectifier side the positive voltage. Then so filter
waveform to smooth with a capacitor C1(2,200uF) , Then entered to input of IC1(LM317T) that is a positive regulated IC, it can adjust
voltage to changing of 1.2-37 volts and provide the maximum output current of 1.5 amps
-The output voltage can change as value of resistor R2 and changes resistanes of R3 to R8, by selector switch S2 to choose the
resistance as you want , to we have a voltage level from 3, 5, 6, 9, 12 and 15 volts.
-The capacitor C7(22uF) is determined an impedance and reduce a transient on output of IC1-LM317T
-The capacitor C3(0.1uF) is used when we install the IC1 far from C1 too much.
-The capacitor C5(22uF) act reduce the ripple signal before it is amplified when the high output voltage up.
-For the capacitor C9 that act reduce the ripple that appear on the output.
-Both diode(1N4001) D5 and D7 for protects the IC1 from discharging of C7 and C5 when the input is shorted circuit.
-The negative section like the positive as above . The diode D1 and D2 are rectifier diode in full wave negative model, by has IC2LM337T is the negative DC regulated IC. For all resistors and capacitors that also act as same as the positive as described above
www.eleccircuit.com/dual-power-supply-3v5v6v9v1215v-with-lm317lm337/
1/6
11/5/13
3. admin says:
June 7, 2013 at 11:32 am
Hi, syed reza roodashty.
Thanks your comment and interesting.
This circuit do not have PCB layout.
But you can put them on Universal PCB Board.
4. admin says:
June 7, 2013 at 11:36 am
Hi, Dnis
Thanks for your comment.
The resistors you can use 0.5 watts or 0.25 watts at 5% or 1% (0.5 watts 1% are best but does not cheaper)
5. bobby says:
September 4, 2013 at 4:53 pm
thanks for posting the power supply circuit diagram
in the
Dual power supply 3V,5V,6V,9V,12,15V with LM317,LM337 circuit does the 220V apply for only over in Europe and 120V
for the usa ?
Would there be anyone willing to construct the project for me if so for how much if they supply parts ?
Thank you !
Leave a Comment
Name (required)
Mail (will not be published) (required)
Website
Submit Comment
www.eleccircuit.com/dual-power-supply-3v5v6v9v1215v-with-lm317lm337/
3/6
11/5/13
email address
Subscribe
Categories
Power supply (135)
Amplifiers (121)
Battery charger (19)
DC converter (41)
Inverters (23)
DIY projects (176)
Alarm systems (57)
Battery (11)
Audio diagram (82)
Automotive (16)
www.eleccircuit.com/dual-power-supply-3v5v6v9v1215v-with-lm317lm337/
4/6
11/5/13
Basic (53)
Circuit diagram (24)
Digitals (64)
Controls (103)
Products (6)
Lightings (62)
Meters (68)
Oscillator (46)
Radios (27)
Datasheets (10)
News (4)
Tools (6)
Detector (25)
LED Flasher (28)
Microcontroller (3)
Motor controller (12)
Timers (21)
Recent Posts
How to update new flash for firefox manually
Simple metal detector circuits
TV test pattern generator with wireless model
Door Guard Knob Alarm circuit.
The signal amplifiers can set input and output ratio.
Archives
Select Month
Blogroll
Circuits for the Hobbyist
Electrical Engineering
Electronics learning with Wikimedia
Forrest M. Mims III
POWER SUPPLY PROJECTS
LM317 voltage regulators
DC Switching Power-Supplies
www.eleccircuit.com/dual-power-supply-3v5v6v9v1215v-with-lm317lm337/
5/6
11/5/13
Like
Follow
Follow @eleccircuits
www.eleccircuit.com/dual-power-supply-3v5v6v9v1215v-with-lm317lm337/
6/6