Академический Документы
Профессиональный Документы
Культура Документы
Fa0/1
Fa0/0
Fa0/0
Fa0/1
Fa0/2
Fa0/1
Fa0/3
Fa0/2
Fa0/4
Fa0/3
Objective
Use Packet Tracer to configure Cisco Unified Communications Manager Express (CUCME) in a basic
two site topology.
Background
Cisco Unified Communications Manager Express (CUCME) is VoIP call management software which runs
within the router IOS. In this lab you will practice some of the basic CUCME and voice related configuration
commands which would enable IP and analog phones at two locations to communicate. You will also apply
many of the configuration skills learned in your CCNA curriculum.
Note:Packet Tracer (PT) is a simulation tool not an emulation tool. Not every command and response that is
available on physical hardware is simulated. Many VoIP commands, especially show and debug commands,
which could be utilized to troubleshoot this lab are not supported in the PT environment. You may optionally
use physical hardware for a richer experience with this lab if you have access to the appropriate hardware
and software.
Note: This lab is introducing concepts which are probably not familiar to you. Be sure to read and follow all of
the directions carefully or things will probably not work as you expect.
Required Resources
You will need the following tools to complete this lab:
v1.1Developed for the Cisco Networking Academy Community by Dr. Ben Franske, Inver Hills Community College
Page 1 of 5
IP Addressing Table
Device
RouterA-1
RouterB-1
SwitchA-1
SwitchB-1
Interface
FastEthernet0/0
FastEthernet0/0.10
FastEthernet0/0.20
FastEthernet0/0.99
FastEthernet0/1
FastEthernet0/0
FastEthernet0/0.10
FastEthernet0/0.20
FastEthernet0/0.99
FastEthernet0/1
Vlan99
Vlan99
Address
n/a
172.16.10.1 /24
172.16.20.1 /24
172.16.99.1 /24
10.0.0.1/24
n/a
172.17.10.1 /24
172.17.20.1 /24
172.17.99.1 /24
10.0.0.2/24
172.16.99.2
172.17.99.2
On each switch:
On each PC:
v1.1Developed for the Cisco Networking Academy Community by Dr. Ben Franske, Inver Hills Community College
Page 2 of 5
v1.1Developed for the Cisco Networking Academy Community by Dr. Ben Franske, Inver Hills Community College
Page 3 of 5
v1.1Developed for the Cisco Networking Academy Community by Dr. Ben Franske, Inver Hills Community College
Page 4 of 5
Setup specific devices to receive specific extension (directory) numbers. For example, make sure that
IP Phone A-1 always receives extension 4001 and IP ATA B-1 always receives extension 5003
instead of allowing devices to auto register. Hint: Exploring your running configurations on the routers
after you have everything working should provide some hints about how to do this.
Setup a multiuser Packet Tracer configuration and enable calling between your two sites and a
partners two sites
Add a third site and enable calling between all three sites
Add quality of service (QoS) to the network to prioritize voice traffic over data traffic
v1.1Developed for the Cisco Networking Academy Community by Dr. Ben Franske, Inver Hills Community College
Page 5 of 5