Академический Документы
Профессиональный Документы
Культура Документы
Dodge; Stealth
Mitsubishi; Diamante, 3000GT
INTRODUCTION
Use this article to quickly find specifications related to
servicing and on-vehicle adjustments. This is a quick reference
article to use when you are familiar with an adjustment procedure and
only need a specification.
CAPACITIES
BATTERY SPECIFICATIONS
Application Group Size CCA Rating
QUICK-SERVICE
SOHC
Alternator ..... .15-.19 (3.8-4.8) ...... .23-.31 (5.8-7.8)
P/S ............ .15-.19 (3.8-4.8) ...... .23-.31 (5.8-7.8)
A/C ............ .25-.27 (6.3-6.8) ...... .29-.33 (7.3-8.3)
DOHC
Alternator ..... .13-.15 (3.3-3.8) ...... .15-.19 (3.8-4.8)
A/C ............ .13-.15 (3.3-3.8) ...... .15-.19 (3.8-4.8)
P/S ............ .30-.35 (7.6-9.0) .... .41-.49 (10.5-12.5)
(1) - With 22 lbs. (10 kg) pressure applied midway on belt run.
BELT ADJUSTMENT - STEALTH
(1) Deflection (1) Deflection
Application New Belt - In. (mm) Used Belt - In. (mm)
SOHC
Alternator ..... .15-.19 (3.8-4.8) ...... .23-.31 (5.8-7.8)
P/S ............ .15-.19 (3.8-4.8) ...... .23-.31 (5.8-7.8)
A/C ............ .25-.27 (6.3-6.8) ...... .29-.33 (7.3-8.3)
DOHC
Alternator ..... .13-.15 (3.3-3.8) ...... .15-.19 (3.8-4.8)
P/S ............ .29-.35 (7.3-8.8) .... .41-.49 (10.4-12.4)
(1) - With 22 lbs. (10 kg) pressure applied midway on belt run.
BELT ADJUSTMENT - 3000GT
(1) Deflection (1) Deflection
Application New Belt - In. (mm) Used Belt - In. (mm)
(1) - With 22 lbs. (10 kg) pressure applied midway on belt run.
MECHANICAL CHECKS
ENGINE COMPRESSION
Check engine compression with engine at normal operating
temperature at specified cranking speed, all spark plugs removed
and throttle wide open.
COMPRESSION SPECIFICATIONS
Application (1) Specification
Compression Ratio
3.0L (VIN J) .................................... 10.0:1
3.0L (VIN K) ..................................... 8.0:1
3.0L (VIN H) .................................... 10.0:1
Compression Pressure
3.0L (VIN J) ..................... 185 psi (13.0 kg/cm )
3.0L (VIN K) ..................... 156 psi (10.9 kg/cm )
3.0L (VIN H) ..................... 171 psi (12.0 kg/cm )
Maximum Variation Between Cylinders .. 14 psi (1.0 kg/cm )
VALVE CLEARANCE
NOTE: Valve adjustment is not required on these models.
IGNITION SYSTEM
IGNITION COIL
IGNITION COIL RESISTANCE - Ohms @ 68 F (20 C)
Application Primary Secondary
SPARK PLUGS
SPARK PLUG TYPE
Application Nippondenso No.
IGNITION TIMING
IGNITION TIMING (Degrees BTDC @ RPM)
Application (1) Basic (2)(3) Actual
FUEL SYSTEM
FUEL PUMP
REGULATED FUEL PRESSURE
Application At Idle At Idle
W/ Vacuum
W/O Vacuum
psi (kg/cm ) psi (kg/cm )
INJECTOR RESISTANCE
INJECTOR RESISTANCE
Application Ohms
(1) - At idle.