Академический Документы
Профессиональный Документы
Культура Документы
CAR 145
Q1. For maintaining the a/c in a continued state of airworthiness, this
procedure stipulate in
a) CAR 145 b)CAR M c)As per rules and regulation given in CAR d)All the
above are correct
Q2. CAR 145 organizations involved in
a) Operation of large a/c used for commercial air transport
b) Maintenance of large a/c
c) Maintenance of light a/c or a/c used for commercial air transport and
component fitment there to
d)All the above are correct Q3.The responsibilities of Accountable
Manager are
a) Ensure all resource available to accomplish maintenance in accordance
with 145.A.05 to support the organizations approval
b) Establish and promote safety and quality policy
c) Demonstrate the basic understanding of CAR All the above are
correct---------Ans.
Q4. To ensure the safety and quality policy is the responsibility of
a) QCM
b) Accountable Manager ---- Ans.
c) Workshop Manager
d) Safety Manager
Q5. Person carry out control colour contrast dye penetrant test are in
accordance with
a) DGCA specified standard
b) Equivalent standard recognized by DGCA
c) Holding BAMEL
d) Both a and b are correct-------Ans.
c) Manufacturer
d) None
Q16. Any occurrence in the organization shall report by the organization
a) In the manner establish by the AMO-----------Ans.
b) When the organization contracted the maintenance shall report to
DGCA
c) Within 72 hours of organization identified the condition
d) All the above are correct
Q17. Minimum age of Certifying Staff
a) 18 year
b) 20 year
c) 21 year ---------ans.
d) None
Q18. Organization shall have available and use the necessary equipment,
tool and material to perform approved scope of work
a) where the manufacture specify a particular tool or equipment the
organization shall use that tool/ equipment
b) Use alternate tooling/ equipment as approved by DGCA via procedure
specified in Exposition
c) Both A and B are correct---------Ans.
d) None
Q19. Certification Authorization issued by
a) Organization Quality Manager--------Ans.
b) DGCA
c) Accountable manager
d) None
Q20. Organization shall maintain a record of all certifying staff and
support staff. This record contain
a) Detail of any a/c maintenance license
b) All relevant training completed
c) 5year
d) 10 year
Q26. CAR 21 is
a) Certification ----b) Approved ------c) Approved------d) Approved---CAR
Q27. Experience requirement for light a/c
a) TAEE 5 year
b) As in A and 6 month should be concurrent experience
c) TAEE 4 year, 12 month on type and 3 month should be recent
experience ----------ANS.
d) None
Q28. For issue of FRC w.r.t. Instrument, Electrical, Autopilot, issued by
a) Cat. A for Heavy a/c
b) Cat. A for Light a/c----------ANS.
c) Cat. B for Heavy a/c
d) None
Q29. For issue of open rating AME license in cat. C and cat. D
a) Person hold license for a continuous period of 5 year
b) Aspirated air cooled piston engine
c) At least 3 type of piston engine out of which at least 2 engine not above
300BHP
d) All the above are correct ----------ANS.
Q30. Level III competency
a) Not entitle a person to issue C of C
b) Capable of setting up and calibrate test equipment, make decision,
judgment, evaluate, interpret
d) Either A or B
Q36. Maintenance process for locating and resolving problem areas
through analytical study of malfunction or failure ,not affecting safety of
a/c
a) Hard-time maintenance
b) On-condition maintenance
c) Condition monitoring maintenance -----ANS.
d) Preventive maintenance
Q37. Reliability is a function of
a) Basic design
b) Maintenance
c) Personnel training
d) All the above are correct---ANS.
Q38. The average fuel and oil consumption of piston engine recorded in
a) Aircraft log book
b) Engine log book--------ANS.
c) Propeller log book
d) None
Q39. In determining the proven service life , factors kept in view
a) Area of operation
b) Stage length
c) Engine operating power
d) All the above are correct--------ANS.
Q40. Upward revision of TBO require prior approval of DGCA but reducing
life require prior approval of
a) DGCA
b) RAO/ S-RAO------------ANS.
c) QCM
d) None
b) No overall control-----------------ANS.
c) Hard time item can control reliability
d) On-condition can control reliability
Q52. A continued satisfactory performance of a/c and a/c component can
be determined by
a) Two consecutive maintenance of some/ different a/c are satisfactory
b) Pilot report
c) Premature removal rate within 0.3/ 1000 hour for a continuous period
of 6 month----------ANS.
d) Either A or B
Q53. Solid state equipment shall be FTD check
a) Once in 1 year
b) Twice in 1 year
c) Once in 2 year-------------ANS.
d) None
Q54. Operator can use the RVSM airspace only after
a) Comply with the requirement given in CAR-----------ANS.
b) Have approve pilot
c) Have approved maintenance organization
d) Have approved operation procedure
Q55. Repair Assessment Programme applicable to
a) a/c more than 5 year age
b) a/c more than 10 year age
c) a/c not more than 1o year age
d) older aircraft-----------ANS.
Q56. C of A issued to an aircraft
a) For test flight
b) After type certification-------ANS.
c) Either A or B
d) None
Q57. C of A issued / validated shall conform
a) Design standard
b) Condition for safe operation
c) Both A and B-------ANS.
d) None
Q58. Operator should have current and valid C of A
a) During test flight not required--------------------ANS.
b) Micro light a/c also include
c) To train the pilot
d) All of the above are correct
Q59. AME license remain lapsed for a period of 1 year, it will be renewed
a) After oral check by RAO
b) After appear in written exam of paper IV
c) With a warning to AME----------------ANS.
d) Either A or B
Q60. Piston engine parameter are recorded
a) After every 100 hours
b) Before issue of every FRC
c) After every 50 hour-------------ANS.
d) None
Q61. A large variation between approval life and observed life, then
approval life is
a) Upward
b) Downward
c) Revised
d) None
MANUAL
Q62. Airship means
Q83. AME carry out repetitive task of inspection of turbine blade, in any
condition if he feel that his performance get degrade then following
checking should be done
a) Blood alcohol level
b) Visual capability----------ANS.
c) Physical fitness
Q84. Dirty dozen means
a) Lack of confidence
b) Lack of courage
c) No limitation
d) Assertiveness
Q85. During investigation of defect
a) Viewing from the point of individual person
b) Viewing from the point of organization
c) Viewing from the point of organization known as system error
d) Either A or B
CAR M
Q86. Organization and personnel involved in continuing airworthiness of
a/c and component including maintenance shall comply with
a) CAR M
b) Requirement for licensing of a/c maintenance personnel given by DGCA
c) CAR 145
d) All the above are correct-------------ANS.
Q87. When an operator required by DGCA to hold a certificate of
commercial operation other than for commercial air transport, it shall
a) Approved in accordance with MA sub part R or 145 or contract such
organization--------ANS.
b) Approved in accordance with MA sub part R or contract such
organization
c) Approved in accordance with CAR or contract such organization
Q88. For all a/c used in commercial air transport and a/c MTOW above
2730 kg , except balloons the airworthiness review staff shall have
a) At least 5 year experience in continuous airworthiness
b) Appropriate license in engine and airframe or an aeronautical degree or
equivalent
c) Formal aeronautical training
d) All the above are correct-----ANS.
Q89. To qualify as a pilot-owner the person
a) Hold a valid pilot license
b) Own the a/c as a sole
c) Own the a/c as a joint owner
d) All the above are correct------------ANS.
Q90. For a/c not used in commercial air transport of 2730 kg MTOW and
below, and balloon, the airworthiness review staff have acquired
a) At least 3 year experience in continuing airworthiness
b) an appropriate license in compliance with DGCA Aircraft Maintenance
License requirements or an aeronautical degree or equivalent,
c) appropriate aeronautical maintenance training,
d) All the above are correct----------ANS.
Q91. CAR M
a) Provide continued airworthinessof an aircraft and its components
b) Compliance depend on size of the organization
c) Applicable to private operators (General Aviation), flying training
institutes, state governments etc.
d) All the above are correct--------------------ANS.
Q92. According to CAR M the aircraft maintenance program me and any
subsequent amendments shall be approved by
a) DGCA---------ANS.
b) RAO
c) Manufacturer
d) None
Q93. A component shall be considered unserviceable in any one of the
following circumstances
a) expiry of the service life limit as defined in the maintenance program;
b) Absence of the necessary information to determine the airworthiness
status or eligibility for installation
c) Evidence of defects or malfunctions
d) All the above are correct--------ANS.
Q94. According to CAR M the continuing airworthiness management
organization shall provide a continuing airworthiness management
exposition containing the followingInformation
a) the organizations scope of work
b) a list of M.A.707 airworthiness review staff
c) the list of approved aircraft maintenance programs
d) All the above are correct--------------ANS.
Q95. According to CAR M, An airworthiness review certificate becomes
invalid if
a) Airworthiness certificate is suspended or revoked
a) The aircraft is not on the aircraft register of DGCA
b) The type certificate under which the airworthiness certificate was
issued is suspended or revoked
c) All the above are correct------------ANS.
Q96. According to CAR M, When a lengthy capability list is used which
could be subject to frequent Amendment, then such amendment shall be
in accordance with a procedureacceptable to
a) DGCA
b) Included in maintenance exposition
c) Both A and B-----------ANS.
d) None
Q97. After receipt of finding the holder of the maintenance organization
approval shall define a corrective action plan and demonstrate corrective
action
a) Within 7 days
b) Within 72 hours
c) Within 30 days
d) Either A or C ----------------ANS.
Q98. According to CAR M, material being either raw material or
consumable material shall only be used on an aircraft or a component
when
a) Manufacture states in relevant maintenance data
b) As specified in CAR 145
c) As given in CAR
d) Either A or B----------ANS,
Q99. Material used in an a/c or component must be accompanied by
documentation clearly relating to the particular material and containing a
conformity to specification statement plus
a) Manufacturing source only
b) Supplier source only
c) Both A and B-------------------ANS.
d) None
Q100. According to CAR M, maintenance organization shall provide a
manual shall contain at least
a) Organizations scope of work
b) List of certifying staff with their scope of approval
c) maintenance organization manual amendment procedure(s)
d) All the above are correct------=============ANS.