Академический Документы
Профессиональный Документы
Культура Документы
Shutdown SIS
Previous Screen
Product: EXCAVATOR
Model: 330 L EXCAVATOR 5YM
Configuration: 330, 330L Excavators 5YM00001-UP (MACHINE)
SENR54980028
2. Remove six bolts (1), the washers and spacers that hold cover plate (2) in position under the hydraulic oil
tank. Remove the cover plate.
3. Remove drain plug (5) to drain the oil from the hydraulic oil tank. Drain the oil from the hydraulic oil tank
into a suitable container. The capacity of the hydraulic oil tank is 310 liters (82 U.S. gal).
4. Remove four bolts (3) and the washers to disconnect pipe assembly (4) from the bottom of the hydraulic oil
tank.
Page 2 of 3
5. Remove four bolts (6) and the washers that hold the hydraulic oil tank to the frame of the machine.
9. Disconnect clip (9) from the side of the hydraulic oil tank.
10. Disconnect electrical connector (10).
11. Remove cover assembly (11) from the top of the hydraulic oil tank.
12. Fasten tool (A) and a hoist to the top of hydraulic oil tank (12) as shown. Carefully remove the hydraulic
oil from the machine. The empty weight of the hydraulic oil tank is approximately 193 kg (425 lb).
13. Put identification marks on the shims used between the frame of the machine and the hydraulic oil tank
for installation purposes. Remove the shims from the frame of the machine.
NOTE: The following steps are for the installation of the hydraulic oil tank.
14. Check the condition of all O-ring seals used in the hose assemblies and pipe assemblies that are connected
to the hydraulic oil tank. If any of the seals are worn or damaged, use new parts for replacement.
15. Put the shims for the hydraulic oil tank in their original position on the frame of the machine.
16. Fasten tool (A) and a hoist to hydraulic oil tank (12). Put the hydraulic oil tank in position on the frame of
the machine. Install four bolts (6) and the washers that hold it in place.
17. Connect electrical connector (10).
18. Reinstall clip (9) on the side of the hydraulic oil tank.
19. Connect pipe assembly (7) to the side of the hydraulic oil tank.
Page 3 of 3
20. Connect hose assembly (8) to the side of the hydraulic oil tank.
21. Connect pipe assembly (4) to the bottom side of the hydraulic oil tank.
22. Be sure drain plug (5) is tight.
23. Reinstall cover plate (2) under the hydraulic oil tank.
24. Reinstall cover assembly (11) on top of the hydraulic oil tank.
25. Fill the hydraulic oil tank with oil to the correct level. See the Operation & Maintenance Manual for the
correct filling procedure.