Академический Документы
Профессиональный Документы
Культура Документы
1 of 4
Refer to
Make sure your interface panel power is off. Connect a switch to the input
module in slot 1, terminal 0. Connect a light to the output module in slot 2,
terminal 0. Turn on the power, download and monitor your program. Run the
program. Turn on the switch, and count the time before the light energizes.
It should be 3 seconds.
The circuit above is commonly referred to as a delay-on timer.
energizes after a time delay when the switch is closed.
The output
11/4/2014 7:12 PM
Slic500 Lab 2
2 of 4
2. In the space below, draw a ladder diagram where the output energizes
instantly when the switch is thrown, and when the switch is turned off, it will
delay 3 seconds before going off.
Use input I:1/1, output O:2/1, and timer T4:2
Enter your diagram into the computer. Add the rungs to the end of the program
that already exists. Download the program, and run the program. Monitor your
timer. When you have this working have the instructor initial your control.
11/4/2014 7:12 PM
Slic500 Lab 2
3 of 4
Program the following ladder logic into the computer. Use input I:1/2,
output 0:2/2, internal coil B3:1/0, and timers T4:2 & T4:3.
3.
I:1
B3:1
|----] [----]/[-------------------+TON-----------------+
|
|
2
0
+Timer On Delay
+-(EN)-|
|
|Timer
T4:2
+
|
|
|Time base
0.01
+-(DN) |
|
|Preset
500
|
|
|
|Accum
0
|
|
|
+--------------------+
|
|
T4:2
0:2
|
|----] [---------------------------------------( )------------|
|
DN
2
|
|
|
|
T4:2
|
|----] [--------------------------+TON-----------------+
|
|
DN
+Timer On Delay
+-(EN)-|
|
|Timer
T4:3
+
|
|
|Time base
0.01
+-(DN) |
|
|Preset
50
+
|
|
|Accum
0
+
|
|
+--------------------+
|
|
|
|
|
|
T4:3
B3:1
|
|----] [----------------------------------------( )-----------|
|
DN
0
|
11/4/2014 7:12 PM
Slic500 Lab 2
4 of 4
4. In the space below, draw a ladder diagram that will cause O:2/3 and O:2/4
to alternate on at a 0.5 second rate. This process should continue repeatedly
until input 3 is turned off. Use input I:1/3, timers T4:4 and T4:5, and
outputs O:2/3 and O:2/4.
Verify the operation of this circuit.
instructor initial your control.
DELETE ALL THE FILES YOU CREATED WHEN YOU ARE FINISHED WITH THIS LAB.
11/4/2014 7:12 PM