Академический Документы
Профессиональный Документы
Культура Документы
Manual Switches
Operation Manual - Type C (Power Model)
-1-
B-160A
B-200A
B-250A
B-315A
B-400A
160
200
250
315
400
AC 380/400V 50/60HZ
AC220V 16A
Type
Dual (D)
Connection
Surface (F)
Max. voltage
Main
Operation
Class
AC-33B
35/73.5
Mechanical life
8000
Electric lifec
3000
Weight
3P
16
17
18
18.5
19
4P
18
19
20
20.5
21
-2-
1. Mounting Installation
A. The customer should make sure that the model received conforms to the one ordered, before
installation.
B.
Visually check the appearance of the product carefully. If signs of parts falling off or broken
are found, send it back immediately for repair to avoid danger.
C.
Insulation test:
(1) Check the resistance between normal power input and conductive outer casing.
(2) Check the resistance between emergency power input and conductive outer casing.
(3) Check the resistance between the loading input terminal and conductive outer casing.
If the resistance of the above checking is less than 500K, it is not normal.
PS: The product contains a built-in electronic control circuit; therefore, using a
high-resistance tester in insulation testing is strictly prohibited, as it may damage
the electronic circuitry.
D.
Installation site
(1) Working temperature: -5~+55
(2) Relative humidity: 0~85
(3) Max. decline angle: 22.5
(4) Avoid working in environment with explosive or corrosive gas
(5) Avoid working in site with high vibration levels
(6) Avoid working in site with high dust density
(7) The distance from the center of switch lever to the floor should be at least 130 140
cm.
-3-
2. Wiring Diagram
Power supply I
Power supply II
-4-
(a1,a2)(a3,a4)(b1,b2)(b3,b4):
Aux. switches(2a2b)
Description
After being connected to 220VAC, BTS will switch to
normal power supply (operating current 16A)
BTS switches to normal power supply and connects
BTS switches to normal power supply and connects
After being connected to 220VAC, BTS will switch to
emergency power supply (operating current 16A)
BTS switches to normal power supply and connects
BTS switches to normal power supply and connects
Note:
(1) Make sure to remove the manual lever before switching on the power supply of the control
circuit to prevent accidents.
(2) The circuit of A1, A2 and B1, B2 should be designed to be electrically and interchangeably
locked to avoid concurrent power supply, which would cause damage.
(3)
(4)
-5-
X
Y
Model
3P
4P
3P
4P
G
M
B-160A
B-200A
B-250A
322
372
302
352
20
9
-6-
B-315A
352
412
332
392
30
11
B-400A
Unit: mm
Arc distance
Rubber handle
sleeve
-7-