Академический Документы
Профессиональный Документы
Культура Документы
means:
A. Some specific areas where coastal state legislation doesn???t allow any
bilge water/slop discharges
B. Areas as defined by Annex-1 where no bilge water/slop discharges are
allowed
C. Areas as defined by Annex-1, where special mandatory methods are
adopted for the prevention of sea pollution by oil
D. Areas as defined by Coastal state regulations(e.g. OPA-90), where special
mandatory methods are adopted for the prevention of sea pollution by oil
2. In which of the following documents on board, authentic information
about the circumstances and procedures to obtain Radio Medical Advice
can be found?
A.
B.
C.
D.
6. Under OPA 90, who is responsible for mobilizing Oil Spill Removal
Organization (OSRO), in the event of spill of oil or Noxious liquid
Substances?
A.
B.
C.
D.
Master
USCG
Qualified Individual
Technical Superintendent
Crude
Crude
Crude
Crude
also
Council
Assembly
Facilitation Committee
None of the above
13.5 Kgs
23 Kgs
9 Kgs
46 Kgs
CLC 1992
Fund convention
LLMC
OPA 1990
14. As per requirements of Marpol Annex -1, all ships of 400 gross tonnage and
above:
A. Can carry fuel oil in fore peak, aft peak tanks and deep tanks
B. Cannot carry fuel oil in fore peak tank
C. Can carry fuel oil forward of collision bulkhead or aft of machinery space
forward bulkhead, but not in the cargo area in case of tankers
D. Cannot carry more than 600 m3 of oil fuel in any single fuel tank
15. Which of the following is a man overboard maneuver?
A.
B.
C.
D.
UNCLOS
UNCLOS
UNCLOS
The IMO
I, 1958
II, 1960
III, 1974
convention
17. After a person has been revived by artificial respiration, they should
be
A. walked around until he is back to normal
B. given several shots of whiskey
C. kept lying down and warm
D. allowed to do as he wishes
17. Dumping of wastes at sea is controlled by which of the following IMO
conventions?
A.
B.
C.
D.
Marpol 73/78
London convention
Hongkong convention
Kenya convention
18. The angular movement of a vessel about a horizontal line drawn from
its bow to its stern is
A.
B.
C.
D.
pitching
rolling
heaving
swaying
19. To prevent oil from escaping into the sea when ballasting through the
cargo piping system, you should FIRST
A.
B.
C.
D.
yaw
sway
surge
heave
21. Which of the following documents carried by a ship is not issued under
the MARPOL convention?
A.
B.
C.
D.
IOPP certificate
Oil Record Book
SOPEP
Safety Management Certificate.
22. When a vessel is floating upright, the distance from the keel to the
metacenter is called the
A.
B.
C.
D.
metacentric differential
height of the baseline
height of the metacenter
righting arm
23. Voyage data recorders (VDR) or simplified voyage data recorders (SVDR) are required to be installed on board certain ships as per_____________
A.
B.
C.
D.
ISPS code
ISM code
Chapter V of Solas
None of the above
Sea anchor
Fishing tackle
Drinking water cans
Life Jacket
Seven
Four
Six
Three
COLREG 1972
SAR 1979
SOLAS 1974
SALVAGE 1989
Intermittent, 1 year
Continuous, 1 year
Intermittent, 3 years
Continuous, 3 years
31. In the first 24 hours after abandoning a vessel, water should be given
only to personnel who are
A.
B.
C.
D.
thirsty
sick or injured
wet
awake
33. In which of the following conditions, the IG blower fans should shut
down automatically?
A.
B.
C.
D.
A.
B.
C.
D.
150
150
400
400
tonnes deadweight
gross tonnage
tonnes deadweight
gross tonnage
35. Life buoy self-activating smoke signals should emit smoke of visible
colour for at least ______________ in calm waters.
A.
B.
C.
D.
5 minutes
15 minutes
30 minutes
60 minutes
37. Divisions constructed of steel which can withstand a standard fire test
for 30min without passage of flame or smoke are classified
as____________________
A.
B.
C.
D.
B class divisions
A class divisions
A30 class divisions
B 30 class divisions
38. When applying chest compressions on an adult victim during CPR, the
sternum should be depressed about
A.
B.
C.
D.
A. The installation
(for mcq)
B. The installation
C. The installation
D. The installation
41. The purpose of inert gas systems aboard tank vessels is to __________.
A.
B.
C.
D.
42. In reference to accidental oil pollution, the most critical time during
bunkering is when ________
a.
b.
c.
d.
shape
shallow draft
large sail area
All of the above
49. You are fighting a fire in the electrical switchboard in the engine
room. You should secure the power, then__________.
a.
b.
c.
d.
auto-ignition point
flash point
lower explosive limit (LEL)
threshold limit value (TLV)
51. The deck water seal of the inert gas system __________.
a. cools the inert gas and prevents soot from entering the cargo tanks
0% to 1%
1% to 10%
10% to 15%
12% to 20%
53. Fuel oil tank vents are fitted with a screen which will stop __________.
a.
b.
c.
d.
1. Personnel who are moving or handling material aboard ship should NOT
follow which of the listed practices?
A. Signaling that all personnel are clear before lifting or lowering material.
B. Examining material for sharp edges or protruding points before handling.
C. Closing, tagging, or securing valves that permit entrance of steam, water,
or air into a fitting or other equipment.
D. Throwing materials from high places to the deck
2. Which of the following statements is true?
A. Ballast water exchange at mid ocean eliminates completely the risks
associated with introduction of non-native organisms and pathogens in
alien habitats.----ans
B. In the flow through method, the water pumped through a tank should be
at least 3 times the tank volume.
C. Over pressurization of a tank cannot take place during the flow through
method.
D. Air pipes on ballast tanks are designed for continuous overflow.
3. The most common cause of engine room fires is:
A.
B.
C.
D.
A.
B.
C.
D.
C. Only crude oil and black oils have restrictions on pumping out, the
remaining products can be pumped out at sea in limited quantities
D. Anything having viscosity greater than that of water is considered to be oil
10. As per Indian Merchant Shipping Act, 1958, which of the following
entries should be made in official log book of ships?
A.
B.
C.
D.
11. Which of the following instruments set out carrier's obligations and
liabilities with respect to carriage of goods?
A.
B.
C.
D.
Hague Rules
Hamburg Rules
Hague- Visby rules
All of the above
12. Where would you find a list of the lifesaving equipment onboard your
supply boat?
A.
B.
C.
D.
Ship's articles
Station bill
Certificate of Inspection
U. S. Coast Guard Regulations
14. When two people are administering CPR to a victim, how many times
per minute should the chest be compressed?
A.
B.
C.
D.
15
30
45
80
15. Which of the following codes has been issued under both SOLAS and
MARPOL conventions?
A.
B.
C.
D.
STCW code
IMDG code
IGC code
ISM code
.BWM
..
.
..
.Agent
.Broker
.Chandler
.None
A.DG shipping
B.MMD
C.Principle officer respective MMD
D.surveyer
A.ISPS
B.ISM
C.LLA
solas
20%
18%
11%
21%
SOX
NOX
Carbon oxides
All of the above
28. One of the important precautions against cold injuries and frost bite
would be:
A.
B.
C.
D.
Wear several layers of light clothing rather than one heavy layer of clothing
Wear tight fitting gloves
Rub numb areas of body to warm them up
Work while facing the wind
29. Where would you look to find out what your duties are during a fire?
A.
B.
C.
D.
Ship's articles
Station bill
Certificate of Inspection
U.S. Coast Guard Regulations
4
8
12
20
Pro-rata freight
Back Freight
Dead freight
None of the above
Halon
Dry Chemical powder
Water
CO2
B. LLMC
C. Fund convention
D. Athens Convention
35. In refrigeration system vegetable room and meat rooms are
maintained at different
A.
B.
C.
D.
36. The working duration of a 1200 litres SCBA bottle, after allowing for a
reserve of 10 mins is____________________
(if 1800litres =40mins)
A.
B.
C.
D.
30
40
20
50
mins
mins
mins
mins
*
*
*
*
watering of fire
starving of fire
cooling
smothering of fire
38. The number within bracket of a resolution, say A.526 (13) refers to
____.
a.
b.
c.
d.
The
The
The
The
CLC 1969.
MARPOL convention.
Bunker convention 2001.
CLC 1992.
40. Cyclic Up & Down Movement of Vessel Along the VERTICAL AXIS
a.
b.
c.
d.
Heaving,
yawing,
Swaying,
pitching
41. The stretcher normally used for rescue of casualties from engine room
spaces, holds, pump-rooms etc., is known as _____________________
A.
B.
C.
D.
Williamson stretcher
Neil Hobson stretcher
Neil Robertson stretcher
Stokes stretcher
42. Rolling is the angular motion of the vessel about what axis?
A.
B.
C.
D.
Longitudinal
Transverse
Vertical
Centerline
44. When the height of the metacenter has the same value as the height
of the center of gravity, the metacentric height is equal to
A.
B.
C.
D.
30 seconds
1 min
45 seconds
2 mins
46. Which of the following kinds of total flooding system is most suited for
very large spaces like car carrier car decks?
A.
B.
C.
D.
47. You are the 4th engineer of a ship. Your 3rd engineer handsover the
watch to you and informs you that the OWS is running with the ppm
showing as zero. After taking over the watch and during your rounds you
find out that the rinsing fresh water to 15 ppm device was crack open.
After closing the same you find that the ppm rose to 15 and the OWS
stopped after giving alarm. What should you do?
A. Nothing, as Marpol regulations are satisfied till the oily water is being
pumped through OWS and oil content is below 15 ppm
B. Should suspend the operation immediately, inform the Chief engineer
about the same and take appropriate action to restore correct OWS
operation
C. Should never touch OWS and any stoppages to be informed either to Chief
Engineer or 2nd engineer
D. If no visible traces of oil are seen on the sea surface and oily water
mixture is being pumped through an OWS, then there is no harm in
pumping out with fresh water crack open, to keep the OWS running as it
may give false alarm without Fresh water. This is a practical approach to
run OWS without any trouble without violating Marpol regulations
48. All entries in the Oil record Book part-I are to be:
At least in English, Spanish or national language
At least in English, Spanish or French
At least in English or Spanish
At least in English or national language
49. Plasma reduction system is a secondary method of reduction of which
of the following kinds of emissions?
A.
B.
C.
D.
SOX
Greenhouse gases
NOX
All of the above
50. Back flow towards machinery spaces of cargo vapours in an Inert gas
system is prevented by_____________________
A.
B.
C.
D.
51. Which of the following is not a requirement under MARPOL Annex VI,
for new engines?
A. All engines above 130 KW to be tested and issued with EIAPP certificate
and Nox Technical file.
B. Life boat engines and emergency diesel engines to be also tested and
issued with EIAPP certificate and Nox Technical File
C. Periodical verification of EIAPP certificate is mandatory even when there
has been no modification in the engine
D. Engines installed prior to the Nox technical code being applicable will not
be subject to certification and testing unless they undergo major
conversion
52. An oil record book Part-I shall be retained onboard for a period of:
A.
B.
C.
D.
1
1
3
3
55. The maximum capacity of an Oil fuel tank for any ship built on or after
1st Aug. 2010 as restricted by Marpol, Annex 1 is: (minimum capacity 600m3)
A.
B.
C.
D.
600 m3
1200 m3
2500 m3
3000 m3
56. Each fire pump on a MODU must have a pressure gage located
A.
B.
C.
D.
at
at
at
at
57. Which of the devices listed must be used in conjunction with the
portable in-line foam proportioner to produce foam?
A.
B.
C.
D.
58. As per the Indian Merchant Shipping Act, 1958, which of the following
statements about ownership of Indian Flag ships is False?
A. A company or body established by or under any Central or State Act, which
has its principal business in India, may be registered as owner by its name
B. Joint owners shall be considered as constituting one person
C. A person can be registered as owner of a fractional part of a share in a ship,
the number of shares being ten
D. Not more than the names of Ten individuals shall be entitled to registered at
the same time as joint owners of any one ship
59. The external flotation bladder on an immersion suit should be inflated
A.
B.
C.
D.
SECTION -3
1.
2.
3.
Greenhouse gas.
SOx
NOx
None of the above
4.
What Agreement of hire called, in which the owner agreed to
transport an agreed volume of cargo over a specific period. The charter
designates cargoes and loading date but owner nominate suitable vessel
which are not normally named in agreement.
a.
b.
c.
d.
5.
Time charter.
Voyage charter.
Bare boat charter.
Contract of frightment.
12 to 15 times/min.
16 to 18 times/min.
2 to 5 times/min.
18 to 19 times/min.
6.
Movement of ship about an imaginary line joining aft and fore
perpendicular is?
a.
b.
c.
d.
Pitching
Heaving
Sway
roll
7.
Which of the following anti fouling paint is an accepted alternative
to now banned TBT based paint.
a.
b.
c.
d.
8.
Oil or oily mixture discharge into the sea from E/R of ships of 10,000
GRT & above, in special areas is _______.
a.
b.
c.
d.
Not allowed.
Allowed, provided ship is proceeding en route & discharge through oil
filtering equipment with oil content less than 15ppm except in Atlantic
Ocean.----ans
Allowed, provided ship is proceeding en route & discharge through oil
filtering equipment with oil content less than 5ppm except in Atlantic
Ocean.
Allowed but outside 12Nm from the Nearest Land.
9.
Which of the following Convention is also known as Minimum
Standard Convention?
a.
b.
c.
d.
10.
ORB has to be regularly updated without delay and each completed
page has to be _____.
a.
b.
c.
d.
Signed
Signed
Signed
Signed
by
by
by
by
11.
Number of maximum sprinkler head in a section should be _____.
(minimum = 150)
a.
b.
c.
d.
200
150
100
250
12.
Each section on a sprinkler system should not contain more than
_____sprinkler heads.
a.
b.
c.
d.
200
150
100
250
24.
First rain water collected over canopy rain water harvesting
arrangement has to be ____.
a.
b.
c.
d.
25. In which of the following condition FD fan of Inert gas generator will
be tripped?
a. Low sea water level in Deck water seal
b. Low sea water level in scrubber tower
(and two more options... there)
26. Under following,which is not mandatory
A. LSA
B. FSS
C. BLU
D. FTP
27. sewage air compressor, freq of starting
A.
B.
C.
D.
A.every 18 hrs
B.Every 24 hrs
C.Continously
D.Once in two weeks
A.Inland water
B.terristrial water
C.Contigeous areas
D.Continental self---ans
5lt.
9lt.
20lt.
none
a.. SOLAS
b.. MARPOL
c..Load Line Convention
d.. Load line Protocol
35. A coastal can take necessary action on the high seas to mitigate,
prevent or eliminate
danger of OIL pollution to its coastline following a maritime casualty.
Which IMO instrument
guarantees this right to the coastal state?
A.
B.
C.
D.
UNCLOS
MARPOL 73/78
INTERVENTION 1969
London Convention
40. U r fighting with fire with jet hose and multiple fire where wil u first
impinge water
a)
b)
c)
d)
Increase conductivity
Reduce conductivity
Increase accumulation of charge
Reduce friction drag
CRB
ORB
Procedure and arrangement manual
Bulk carrier booklet
A.
B.
C.
D.
STCW code
ISPC
MARPOL73/78
ISM code
Annex
Annex
Annex
Annex
6
7
8----?
9
12
14
18
24
15
10--ans
20
30
CORE 1974
CLC 1969
FUND 1971
LLMC 1976
A.
B.
C.
D.
Explosive meter
O2 analyser
LEL
none
30sec
1min
3min
2min
53. Annex I collection of residue tank washing and also oily mixture to be
A.
B.
C.
D.
Bilge tank
Sludge tank
Oily bilge tank
Slop tank
Fire in metal
Fire in liquid
Fire in electrical system
None
1800L
1200L
1500L
600L
SOLAS CH-IV
SOLAS & MARPOL
SOLAS CH-IX
UNCLDS
Ratification
Acceptance
Approval
Accusation
59. in special areas any discharge of oil and oil mixtures from machinery
spaces
A.
B.
C.
D.
Prohibited
Enroute and min 12NM
En route and min 50NM
En route with oil filtering equipment----ans
200,185,15
215,183,20
205,185,50
200,183,20
1.
Recharging a previously used cartridge-operated dry chemical fire
extinguisher is accomplished by ______________.
a. authorized fire equipment servicing personnel only
b. replacing the propellant cartridge and refilling it with pyrotechnic
powder
c. puncturing the cartridge seal after installation
d. recharging the cartridge and then refilling it with powder
2.
3.
In the event of a galley fire on board a general cargo ship, most dry
chemical or carbon dioxide portable extinguishers are automatically
activated through the action of a stainless steel cable, spring and a
____________.
(a)
(b)
(c)
(d)
(e)
4.
The stability of a vessel is normally the greatest when all fuel and
water tanks are full because the _____________.
(A)
(B)
(C)
(D)
5.
6.
7.
Which of the listed systems related to an engineer's signal alarm
panel is required to be indicated by a continuously illuminated light?
(a)
(b)
(c)
(d)
8.
Which fire extinguisher is most prone to freezing when stowed in low
temperatures?
(a)
(b)
(c)
(d)
9.
Halon 1211
Carbon dioxide
Foam
Dry chemical
Bunker "C", a grade "E" combustible liquid, will _______.
(A)
(B)
(C)
(D)
10.
Which of the following statements describes the advantage of using
a Halon fire extinguisher versus a CO2 fire extinguisher?
(A)
(B)
(C)
(D)
11.
(A)
(B)
(C)
(D)
Halon
Halon
Halon
Halon
12.
In order to find out which lifeboat you are assigned, you should look
at the _____________.
(A)
(B)
(C)
(D)
13.
(A)
(B)
(C)
(D)
Certificate of Inspection
Muster stations Chart
Ship's Articles
Fire Control Plan
14.
What is the usual effect of moving weight from the main deck to a
position lower in the vessel?
(A)
(B)
(C)
(D)
The
The
The
The
15.
The inclining experiment conducted on a merchant ship is the
method for determining the exact location of the __________.
(A)
(B)
(C)
(D)
16.
A.
B.
C.
D.
17.
While wearing a demand-type self-contained breathing apparatus
the alarm bell begins ringing. Which of the following conditions does this
indicate?
A.
B.
C.
D.
18.
You are replacing a section of heavy piping on deck and using a
chain fall to lift the pipe. Which of the following precautions should be
taken to prevent personal injury?
A.
B.
C.
D.
Position several men under the pipe so they can catch it if it falls.
Attach lines to the ends of the pipe and have your helpers steady the load.
Place an old mattress under the hoist to prevent the load from hitting the
deck.
Have a first aid kit at the job site.
19.
With regards to the load line marks, the reason for the placement of
mark "WNA" is ______________.
A.
B.
C.
D.
20.
Many uninspected vessels require load lines to indicate the
maximum ______________.
A.
B.
C.
D.
21.
The safe and efficient use of the face piece of a demand-type selfcontained breathing apparatus is directly influenced by ____________.
A.
B.
C.
D.
22. immediately after abandon ship vessel, look out in life raft for
A. Survivors in water
A.Ballast bags
B.A keel
C.Strikes
D.Sea anchor
Council,
Assembly,
Safety Committee
Pollution prevention committee
Council,
Assembly,
Safety Committee
Pollution prevention committee
NEW SECTION - 1
4.50,000DWT(metric tons)
Damage suffered by a passenger in vessel
1.LLMC 1976 Convention
2.LLC 1969
3.Athens convention
4.Fund 1971
Emergency Steering Test and pre- arrival/pre departure steering tests are
requirements under: (solas chapter v reg 26 para 4)
A. COLREG 72
B. SOLAS Chapter V
C. Under USCG rules only in US waters
D. INMARSAT C 1976
Which requirement regarding Oil Record Book Part ???I is correct?
A. All entries are to be signed by Chief engineer and Master
B. All entries are to be signed by Chief engineer and each completed page by the
Master
C. All entries are to be signed by officer or officers in charge concerned and each
completed page by the Master
D. All entries are to be signed by officer or officers in charge concerned, the Chief
engineer and the Master
Which of the following IMO conventions has entered into force?
s-c, m-acd
A.
B.
C.
D.
Which of the following conditions will allow for a work vest to be substituted for a
lifejacket in the total count of the required lifesaving gear?
D. Never
A. Drop test
B. Fire test
C. Flotation test
Which of the following are resource zones and not security zones?
A. Inland waters
B. Territorial seas
C. Contiguous zone
D. Continental shelf---ans
Water Ingress Monitoring Equipment, for detecting water ingress in cargo holds is a
requirement under:
A. MARPOL convention
B. SOLAS Chapter XII----ans
C. BC code
D. BLU code
The most common cooling agent used for fighting fires on tank vessels is
A. carbon dioxide
B. flue gas
C. water
D. steam smothering
Greater the hazard, smaller the parcel size. As per this principle of IBC code what is
the allowable parcel size in Type 1 chemical tankers?
A. 3000 m3
B. 1500 m3
C. 1250 m3 ----ans
D. 1650 m3
Which of the following is considered to be the safest protection from static electric
discharge, when connecting or disconnecting cargo hoses and metal arms?
A. Insulating flange or a length of non-conducting hose
B. Switching off ICCP
C. Ship shore bonding cable
D. None of the above