Академический Документы
Профессиональный Документы
Культура Документы
Quick Start
Before You Begin
Register your M-100 device at http://support.paloaltonetworks.com to obtain the latest software updates and to activate support.
Obtain an IP address for Panorama from your system administrator.
Set your computers IP address to 192.168.1.2 and the subnet mask to 255.255.255.0.
NOTE: This guide assumes the device has been properly rack-mounted and powered up as described in the M-100 Hardware
Reference Guide.
Connect your computer to the management port (MGT) using an RJ-45 Ethernet cable (provided).
Turn your computer on.
Launch an Internet browser on your computer and enter https://192.168.1.1.
The login page of the Panorama management console will appear.
4. Type admin in both the Name and Password fields.
5. Click Login.
6. Click on the admin link in the lower portion of the management console. This is next to the Logout link and will display a
dialog for you to change the administrators password.
7. Type the old password in the Old Password field.
8. Type the new password in the New Password/Confirm New Password field and store the new password in a safe location.
9. Click OK.
10. Click Commit and select Panorama as the Type. Click OK again and then proceed to the next section.
Where to Go Next
To learn about using Panorama to manage PAN-OS devices, refer to the Palo Alto Networks Administrator's Guide.
To learn about the CLI, refer to the PAN-OS Command Line Interface Reference Guide.
To obtain detailed descriptions of the M-100 hardware, refer to the M-100 Hardware Reference Guide.
Copyright 2012 Palo Alto Networks. All rights reserved.
Palo Alto Networks and PAN-OS are trademarks of Palo Alto Networks, Inc.
www.paloaltonetworks.com
P/N 810-000123-00C