Академический Документы
Профессиональный Документы
Культура Документы
Project Information
Well/ Field:
Company:
Address:
Contact Person:
Phone:
Fax:
Mobile:
e-mail:
web:
Comments:
The information listed above will for most cases be available in the drilling program for the well. Copies of
these pages will fulfill most of the data requirements listed herein. Use this information sheet as a
checklist of required data. Please note that optional input will be estimated if not supplied. Fill in data in
the unit you find most convenient.
Required input is marked with yellow. Optional input is marked with gray
Well Data
Casing program
OD, inch
lb/ft
Conductor
m md
ft md
m tvd
ft tvd
Surface casing
m md
ft md
m tvd
ft tvd
Intermediate casing
m md
ft md
m tvd
ft tvd
Reservoir casing
m md
ft md
m tvd
ft tvd
m md
ft md
m tvd
ft tvd
ft
ft
OD, inch
lb/ft
Bit, OD
OD, inch
ft
Page 1 of 1
Reservoir data
Reservoir top
m tvd
ft tvd
Temperature
Reservoir pressure
bar
psi
sg
ppg
Fracture pressure
bar
psi
sg
ppg
Collapse pressure
bar
psi
sg
ppg
md
ft
ft
Skin factor, S =
non-Darcy skin, D =
1/Sm/d
(mmscfd)
Water cut
ft
Oil productivity, PI
Sm/d/bar
Stb/d/psi
Sm/d
Stb/d
Gas index, C
Sm /d/bar
MSm/d
scf/d/psi
mmscfd
Note: If Inflow Performance Curve (IPR) is already estimated please attach plot or specify.
sg
kg/m
Plastic viscosity, PV
cp
Yield value, YP
lb/100 ft
ppg
Rheological index, n =
Consistency index, K =
lb.s^n/100 ft
hhp
l/min
bpm
bar
psi
Comments:
Relief well data will usually be developed as part of the project were applicable. If some basic
data are available from the operator, please input or attach to this sheet.
Page 2 of 2
Fluid
(mole%)
Molecular
Weight
28.01
44.01
34.08
16.04
30.07
44.10
58.12
58.12
72.15
72.15
85.85
Density
g/cm
0.809
0.818
0.801
0.242
0.412
0.507
0.563
0.584
0.624
0.631
0.676
Total
kg/m
ppg
API
Gas density
kg/m
g/cm
lb/ft
Oil viscosity
cp
Gas viscosity
cp
Sm/Sm
scf/stb
stb/MMscfd
Temperature
At reservoir conditions
Pressure
bar
psi
Oil density
(or condensate)
kg/m
ppg
API
Gas density
kg/m
g/cm
lb/ft
Oil viscosity
cp
Gas viscosity
cp
Rm/Sm
Sm/Rm
Comments:
The fluid composition should be defined up to C7+ for gases. For heavy oils higher components is usually
required to obtain a good estimate of fluid properties. The physical fluid data above is not required if the
fluid composition is well defined, but can be used for quality control of the data. Please input if available.
Page 3 of 3