Академический Документы
Профессиональный Документы
Культура Документы
Rigger Package
F 30 2012
Included in Package:
Specified quantity of Rigging Safety Manuals:
M 50 2011.IN (Instructor Manual with Powerpoint Presentations)
M 50 2011.ST (Student Manual)
Protocol for Rigging Written Test
OSHA Fact Sheet
Roster
Qualified Rigger/Signal Person Application
Rigger/Signal Person Evaluator Qualification Verfication Form
Rigging Test
Rigging Test Answer Key
Wire Rope Quiz
Wire Rope Quiz Answer Key
INSTRUCTIONS:
Class ID
Funding
Requests for cards with any missing paperwork will not be processed.
Fact Sheet
Subpart CC Cranes and Derricks in
Construction: Qualified Rigger
This fact sheet describes the qualified rigger requirements of subpart CC Cranes
and Derricks in Construction, as specified in 29 CFR 1926.1401, 1926.1404, and
1926.1425. These provisions are effective November 8, 2010.
When is a qualified riggerrequired?
Employers must use qualified riggers during
hoisting activities for assembly and disassembly
work (1926.1404(r)(1)). Additionally, qualified
riggers are required whenever workers are within
the fall zone and hooking, unhooking, or guiding
a load, or doing the initial connection of a load to
a component or structure (1926.1425(c)).
This is one in a series of informational fact sheets highlighting OSHA programs, policies or
standards. It does not impose any new compliance requirements. For a comprehensive list of
compliance requirements of OSHA standards or regulations, refer to Title 29 of the Code of Federal
Regulations. This information will be made available to sensory impaired individuals upon request.
The voice phone is (202) 693-1999; teletypewriter (TTY) number: (877)
889-5627.
For more complete information:
www.osha.gov
(800) 321-OSHA
DOC 10/2010
ROSTER
Please check all which apply:
Rigger
Signal Person
Instructor Use
Signature
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
Approved by:
(Instructor)
(Instructor's Qualification #)
Date:
Pass
Fail
Rigger qualification will conform to OSHA regulation 29 CFR 1926.1401; 1404; 1425.
Testing will consist of a written or oral evaluation.
Signal Person -
Signal person qualification will conform to OSHA regulation 29 CFR 1926.1401; 1419;
1422; 1428. Testing will consist of a written or oral evaluation and a practical evaluation.
Date:
Qualification #:
Register #:
Name:
(Last)
Male
(First)
(Middle)
(Nickname)
Female
Address:
City:
State:
Local:
Telephone (Work):
Telephone (Home):
Telephone (Cell):
FAX:
Birthdate (optional):
Email:
I have approximately
I have approximately
(Applicant's Signature)
Approved by:
(Instructor)
(Instructor's Qualification #)
Date:
Zip Code:
(Suffix)
Register #:
Name:
(Last)
Male
(Middle)
(First)
(Nickname)
(Suffix)
Female
Address:
City:
State:
Zip Code:
Local:
Telephone (Work):
Telephone (Home):
Telephone (Cell):
FAX:
Birthdate (optional):
Email:
Please check all for which you are applying. You should make sure you meet all criteria before having your Training
Director sign to verify that you meet the qualification criteria.
Rigger Evaluator
(Signature)
Date
(Signature)
Date
Version 4.11.12
Rigging Test
Name
1.
Date
B.
C.
D.
B.
10
C. 15
D. Any sign of twist or bend
A.
Prior to use
B.
Once a week
C.
Once a month
D.
Once a year
4. If any portion of a chain is worn more than ________, the chain should be removed from
service.
A.
10%
B.
15%
C.
20%
D.
25%
5.
Which of the following markings would indicate a chain that could be used for rigging, circle
all correct answers?
A.
80
B.
C.
D.
60
6. The markings on a synthetic web sling must list the name of the manufacturer, manufacturers
code or stock number, type of material, and the _______________.
A.
Date of manufacture
B.
Place of manufacture
C.
D.
7. What is the capacity of a 3/8 grade 80 alloy lifting chain in a single vertical pick?
A.
18,400
B.
8,800
C.
7,100
D.
8. To pick 8,000 lbs. with a 2 leg wire rope slings, what weight will each leg have on it? Sling
length 20, Sling height 15
A. 10,666
B. 5,320
C. 3,000
D. 7,130
9. To pick 9,000 lbs. load, with a 4 leg bridle, what weight will each leg have on it? Sling
length 15 Sling height 10
A. 13,500
B. 6,000
C. 3,375
D. 4,500
3.5 to1
B.
4 to 1
C.
5 to 1
D.
7 to 1
11. What is the capacity of a vertical 1" EEIP-MS-IWRC wire rope choker?
A. 16,000
B. 44,000
C. 22,000
D. 11,000
13. What would the load diameter need to be with a 15:1 D/d ratio basket hitch, with a wire
A. 25
B. 15.5"
C. 12.5"
D. 25.5"
14. What is the load angle factor of two slings at a horizontal angle of 30 degrees?
A. 1.555
B. 2.00
C. 1.155
D. None of the above
17. At what percent must a custom designed lifting accessory be tested at?
A. 150%
B. 110%
C. 200%
D. 125%
18. Shackle size is measured at the?
A. Body or bow
B. Shoulder
C. Pin
D. Threads
19. To pick a 10,000 Ib. load, with a 2 leg sling, what weight will each leg have on it, both slings
30 degrees?
A. 20,000
B. 5,000
C. 10,000
D. 30,000
Version 4.11.12
Rigging Test
Name
1.
Date
B.
C.
D.
B.
10
C.
15
D.
A.
B.
Once a week
C.
Once a month
D.
Once a year
4. If any portion of a chain is worn more than ________, the chain should be removed from
service.
A.
B.
15%
C.
20%
D.
25%
5.
Which of the following markings would indicate a chain that could be used for rigging, circle
all correct answers?
A.
80
B.
C.
D.
60
6. The markings on a synthetic web sling must list the name of the manufacturer, manufacturers
code or stock number, type of material, and the _______________.
A.
Date of manufacture
B.
Place of manufacture
C.
D.
7. What is the capacity of a 3/8 grade 80 alloy lifting chain in a single vertical pick?
A.
18,400
B.
8,800
C.
D.
8. To pick 8,000 lbs. with a 2 leg wire rope slings, what weight will each leg have on it? Sling
length 20, Sling height 15
A.
10,666
B.
C.
3,000
D.
7,130
9. To pick 9,000 lbs. load, with a 4 leg bridle, what weight will each leg have on it? Sling
length 15 Sling height 10
A. 13,500
B. 6,000
C. 3,375
D.
3.5 to1
B.
4 to 1
C.
5 to 1 (ANSI B-30.9-2.2)
D.
7 to 1
11. What is the capacity of a vertical 1" EEIP-MS-IWRC wire rope choker?
A. 16,000
B. 44,000
C. 22,000 Pocket guide page 12)
D. 11,000
13. What would the load diameter need to be with a 15:1 D/d ratio basket hitch, with a wire
rope choker?
A. 25
B. 15.5"
C. 12.5" (Rigging Manual page 5-15)
D. 25.5"
14. What is the load angle factor of two slings at a horizontal angle of 30 degrees?
A. 1.555
B. 2.00 (Pocket guide page 38)
C. 1.155
D. None of the above
17. At what percent must a custom designed lifting accessory be tested at?
A. 150%
B. 110%
C. 200%
D. 125% (Rigging Manual page 4-19)
18. Shackle size is measured at the?
A. Body or bow (Rigging Manual page 4-3)
B. Shoulder
C. Pin
D. Threads
19. To pick a 10,000 Ib. load, with a 2 leg sling, what weight will each leg have on i
30 degrees?
A. 20,000
B. 5,000
C. 10,000 (Pocket guide page 38)
D. 30,000
t, both slings
Date
Date
A
E