Академический Документы
Профессиональный Документы
Культура Документы
1 Practise
CSWIP 3.1. I have few question not answered. I look forward to your help.
1. Which welding process could normally be considered to present a greater electrical safety hazard to operators
A. SAW
B. MIG
C. SMAW
D. GTAW
2. In which of the following welding position would you expect to find the highest heat input during the MMA
welding of a pipe fixed in the 5G position:
A. PA
B. All positions would be the same
C. PB
D. Vertical up
3. What does the term back step refer to during fabrication or welding
A. A QA term referring to ispection point
B. Use of step wedges in the root of the joint
C. Use of step wedges for radiography
D. A run sequence
4. Which of the following statements is not correct when referring to Austenitic stainless steel
a. It is prone to solidification -----ing
b. Stainless steel tooling should be used where possible
c. It has a low coefficient of thermal expansion
d. It is non magnetic
5. Which of the following methods may be restricted by codes for PWHT applications
a. Resistance
b. Hand held gas torch
c. Furnace
d. Induction.
6. Weaving is restricted in most welding applications because it may result in:
a. Poor profile
b. Magnetic arc blow
c. HAZ -----ing
d. Excessively large grain size.
7. Which of the following NDE methods would be most suitable for the detection of lack of root penetration in a
double bevel butt joint welded by MMA in low carbon steel
a. Radiography
b. Visual inspection