Академический Документы
Профессиональный Документы
Культура Документы
:
Gray C.I.
White C.I.
Malleable or Spheroidal Graphite (S.G.) Cast Iron.
MICROSCOPE:
Make_____________________________________________________
Magnification ______________________________________________
LABORATORY:
1.
Follow the complete procedure of polishing and etching.
2.
Study the microstructure and identify the constituents present with
sketches as
observed.
REMARKS:
Submit a neat sketches of iron-carbide equilibrium diagram with all details.
QUESTION:
1.
What is eutectic? What is the % of C at which it occurs for C.I.?
2.
What is the difference between S.G.C.I. & Grey C.I.?
3.
Can Grey C.I. be hardened? If not why?
4.
Why is Grey C.I. suitable for machine beds and slides?
5.
Mention the comparison of GCI, WCI and SGCI. Also mention some of their
uses.
Name:
_____________________________________________________________________________________
_____
Class: ________________________ Section: _______________________ Roll No:
________________________
Date __________________
Teacher
.
Signature of the
JADAVPUR UNIVERSITY
FACULTY OF ENGINEERING & TECHNOLOGY
Mechanical Engineering Department
METALLOGRAPHY & MATERIALS LABORATORY
EXPERIMENT NO:
304
_____________________________________________________________________________________
_____
Class: ________________________ Section: _______________________ Roll No:
________________________
Date __________________
Teacher
Signature of the
JADAVPUR UNIVERSITY
FACULTY OF ENGINEERING & TECHNOLOGY
Mechanical Engineering Department
METALLOGRAPHY & MATERIALS LABORATORY
EXPERIMENT NO:
305
Plain
Plain
Plain
Plain
carbon
carbon
carbon
carbon
steel
steel
steel
steel
%
%
%
%
C
C
C
C
=
=
=
=
MICROSCOPE:
Make _________________________________________
Magnification _________________________________
_
LABORATORY PROCEDURE:
Each student will study all the four specimens.
REMARKS:
Attach a neat sketches of S-curve and on T.S, B.H.N., % elongation Vs %
showing the properties of plain carbon steel.
QUESTION:
1.
What are the differences between hardness and hardenablitlity,
malleability and toughness. What is spheroid sing?
2.
Describe the Jominy End-Quench test.
3.
Write short note: a) Mar tempering and Austempering, b) CCT diagram.
4.
mechanical
Name:
_____________________________________________________________________________________
______
Class: ________________________ Section: _______________________ Roll No:
________________________
Date __________________
Teacher
Signature of the
JADAVPUR UNIVERSITY
FACULTY OF ENGINEERING & TECHNOLOGY
Mechanical Engineering Department
METALLOGRAPHY & MATERIALS LABORATORY
EXPERIMENT NO:
302
1.
What are the differences between microscopic and macroscopic
examinations? How is magnification changed?
2.
Why are enchants used? Name the principal enchants (not more
than five) used for ferrous and non-ferrous sample.
3.
Microstructures become clearly visible after etching ---Explain
4.
Differentiate between metallurgical microscope and biological
microscope.
Name: ___________________________________Class: ________________ Section:
_________Roll No: __________
Date __________________
Teacher
Signature of the
JADAVPUR UNIVERSITY
FACULTY OF ENGINEERING & TECHNOLGY
MECHANICAL ENGINEERING DEPARTMENT
Experiment No:
9. When the setting of powder becomes complete, there will be automatic rise
of pressure.
10.Put off the switch at this point.
11.Then by ejection the sample is taken out.
Questions:
Remarks:
1. What are the materials used for mounting irregular and awkwardly thin
specimen?
2. What is the temperature to which it is heated?
3. Why thermosetting plastics are used in mounting of the specimens?
4. Sketch the mounding press.
Name.Class
SectionRoll
Date
Signature of the teacher