Академический Документы
Профессиональный Документы
Культура Документы
For
P. O. Box 42842
Houston, TX 77242-2842
Global Sales/Technical Support
Tel: 281-988-1866
Fax: 281-988-1889
Watts: 1-800-654-0660
Manual Part #: 90-90-980 (Rev. A)
DISCLAIMER
Recommendations made by MI-Swaco are advisory only. MI-Swaco shall not be
liable under any guarantees or warranties, expressed or implied, in any manner or
form, AND ALL WARRANTIES, EXPRESSED OR IMPLIED, ARE HEREBY
SPECIFICALLY EXCLUDED, and MI-Swaco shall not be liable for the failure
to obtain any particular results from the use of any recommendation made by it or
from the use of this material. In no event shall MI-Swaco be liable for incidental
or consequential damages.
Table of Contents
Section 1.0:
Page
Intended Usage
1
1.1: Symbols .. 1
1.2: PPE's (Personal Protective Equipment) .. 2
1.3: Safety .. 2
Section 2.0:
3
3
4
5
6
7
8
9
10
11
12
13
14
Section 3.0:
Introduction ..
3.1: Theory of Operation Mud Cleaner .
3.2: Location of Unit .
3.3: Introduction D-Sander/D-Silter ..
3.3.1: D-Sander .
3.3.2: D-Silter
3.4: Introduction Mongoose PT Shale Shaker ...
3.5: Applications Mud Cleaner ..
3.5.1: Unweighted Muds ..
3.5.2: Weighted Muds ..
3.5.3: Oil Muds
15
15
15
16
16
17
18
20
20
20
20
Section 4.0:
21
21
21
21
21
Section 5.0:
5.2:
5.3:
5.4:
5.5:
5.6:
5.7:
5.8:
Page
Electrical Connections to Control Panel . 26
Figure 5.2a 380V/50 Hz Wiring Schematic . 27
Installation, Location and Support . 28
Figure 5.3a . 28
Typical Trough and Shale Slide Installation .. 29
Inlet Line and Bypass Line Connections 29
Figure 5.5a .. 29
Screen Installation . 30
Figure 5.6a .. 31
Screen Selection Chart 31
Movement, Shipping ... 32
Figure 5.8a - Shipping Bracket .. 32
Figure 5.8b - Shipping Bracket. 32
Procedure 1 . 33
Procedure 2 . 33
Section 6.0:
Unit Operation
6.1: Variable Deck Angle ..
Figure 6.1a .
6.2: D-Silter Bypass Operation ..
Figure 6.2a ..
6.3: Three (3) Motor Control Panel 6930007 (380V/50 Hz) .
Figure 6.3a ..
34
34
34
35
35
36
36
Section 7.0:
ii
Section 8.0:
Section 9.0:
Page
Startup and Operation . 52
8.1: Start up.. 52
8.2: Deck Angle Adjustment .. 53
Figure 8.2a ... 53
8.3: Screen Blinding ... 54
Troubleshooting 55
Section 10.0: Drawings and Parts List per Assembly 9671901-01 ...
Figure 10.0a Parts List for 9671901-01 ...
10.1: Drawings and Parts List 9671688-02 ..
Figure 10.1a Parts List for 9671688-02 ....
10.2: Drawings and Parts List per Assembly 9671843 .
Figure 10.2a Parts List for 9671843 .
10.3: Drawings and Parts List per Assembly 9671738-01 ...
Figure 10.3a Parts List for Assembly 9671738-01 ..
10.4: Drawings and Parts List per Assembly 9671906
Figure 10.4a Parts List for Assembly 9671906
10.5: Drawings and Parts List per Assembly 9622220 .
Figure 10.5a Parts List for Assembly 9622220
10.6: Recommended Spare Parts for 9671901-01.
57
57
58
58
60
60
61
61
62
62
63
63
64-66
Section 11.0: Drawings and Parts List per Assemblies 9671902-01, -02... 68
11.0.1: Assembly 9671902-01 68
69
70
70
72
72
73
73
74
74
75
75
76
77
77
78
78
79
79
iii
Page
11.8: Recommend Spare Parts for 9671902-01, -02.. 80
11.8.1: Spare Parts List for 9671902-01... 80-82
11.8.2: Spare Parts List for 9671902-02 83-85
Section 12.0: Drawings and Parts List per Assemblies 9671903-01, -02... 87
12.0.1: Assembly 9671903-01 87
12.1:
12.2:
12.3:
12.4:
12.5:
12.6:
12.7:
12.8:
Section 13.0: Drawings and Parts List per Assemblies 9671904-01, -02... 105
13.0.1: Assembly 9671904-01 105
106
107
107
108
108
109
109
iv
Page
13.4: Drawings and Parts List per Assemblies
9671966 and 9671967.. 110
13.4.1: Assembly 9671966.. 111
Figure 13.4.1a Parts List for 9671966 111
13.4.2: Assembly 9671967.. 112
Figure 13.4.2a Parts List for 9671967 112
13.5: Drawings and Parts List per Assembly 9622220 . 113
Figure 13.5a Parts List for Assembly 9622220 113
13.6: Recommend Spare Parts for 9671904-01, -02................. 114
13.6.1: Spare Parts List for 9671904-01... 114-116
13.6.2: Spare Parts List for 9671904-02 117-119
Section 14.0: Drawings and Parts List per Assemblies
9671905-01, -02, -03, -04, -05 .... 121
14.0.1: Assembly 9671905-01 121
14.1:
14.2:
14.3:
14.4:
14.5:
125
126
127
127
128
128
129
129
130
130
131
131
132
133
133
134
134
135
135
Page
14.6: Drawings and Parts List per Assembly 9671947 . 136
Figure 14.6a Parts List for Assembly 9671947 136
14.7: Drawings and Parts List per Assembly 9621280 . 137
Figure 14.7a Parts List for Assembly 9621280 137
14.8: Recommend Spare Parts for Assemblies
9671905-01, -02, -03, -04, -05..... 138
14.8.1: Spare Parts List for 9671905-01.. 138-140
14.8.2: Spare Parts List for 9671905-02 141-143
14.8.3: Spare Parts List for 9671905-03 144-146
14.8.4: Spare Parts List for 9671905-04 147-149
14.8.5: Spare Parts List for 9671905-05 150-152
Appendix 153
Appendix A: Motor Manual 154
vi
1.1: Symbols
Notes, cautions, and warnings appear throughout this manual to provide
additional information, and to advice of specific actions to protect
personnel from potential injury or fatal conditions. They also inform
actions necessary to prevent equipment damage or conditions that may
void equipment warranties.
: This symbol draws attention to the safety measures, which must be
observed to prevent personal injury.
ATTENTION! :
NOTE! :
The symbols that may be shown on the package should be noted. Their
significance is as follows.
1.3: Safety
Equipment manufactured by MI-Swaco is installed and operated in a
drilling rig environment involving hazardous operations. Proper care is
important for safe and reliable equipment operation and rig personnels
safety. Operation and service procedures described herein this manual are
recommended methods of performing proper operations and safety
methods. Consult Local or National codes for any other safety regulations
required for the type of environment.
ATTENTION! :
Before installing or performing maintenance on MISwaco equipment, read the following procedure to
avoid injuries to personnel or damage to equipment.
1. Lockout/Tagout power to unit before beginning work.
2. Do not perform maintenance or repairs to equipment while
unit is in operation.
3. Wear PPEs per Section 1.2.
4. All personnel performing installation, operations and
maintenance procedures on this equipment should be
trained on rig safety, operations and maintenance of this
equipment.
10
11
12
13
14
3.0: Introduction
3.1: Theory of Operation Mud Cleaner
Mud Cleaners are designed to concentrate most of the solids being
circulated through a mud system to a small enough volume to be handled
by a fine mesh screen. In this way, much finer screening can be done with
the Mud Cleaner than the primary shaker, which must handle the entire
circulating volume.
The capacities of the D-Silters are 600 gpm [2271 Lpm] (4T4 D-Silter),
900 gpm [3407 Lpm] (6T4 D-Silter), 1200 gpm [4542 Lpm] (8T4 DSilter), and 1500 gpm [5678 Lpm] (10T4 D-Silter). The capacities of the
D-Sander are 500 gpm [1893 Lpm] (1-12 D-Sander), 1000 gpm [3785
Lpm] (2-12 D-Sander), and 1500 gpm [5678 Lpm] (3-12 D-Sander). The
solids discard rates from the hydrocyclones is relatively low compared to
the shaker capacity. This enables fine mesh screens to be used,
minimizing the fine solids returned to the active fluid system. Long beach
lengths on the shaker enable a high fluid recovery rate.
15
The Mud Cleaner can also be used as a primary solids removal devise by
using the bypass located on the D-Silter, which will allow the mud from
the tank to flow thru the Mongoose PT Shaker.
16
3.3.2: D-Silter
The MI-Swaco D-Silter has been used extensively to remove silt
size particles from the drilling fluids. Silt refers to all particles
smaller than sand size (74 microns) and larger than colloidal
material (about 2 microns). The word silt applies here only to
size; the solids themselves may actually be shale, limestone, silica
sand, barite or any other material of silt size, which may be
present. The D-Silter removes nearly all particles larger than 25
microns. Following is the definition of particles sizes as per API
Bulletin 13C, 1974. The TWIN-CONE hydroclone design
provides easy replacement of the urethane wear resistant feed and
apex sections. The D-Silter is complete with a 6 (152 mm)
diameter feed and discharge manifolds, victaulic couplings and a
0-60 psi (4.1 bars) pressure gauge. The D-Silter also includes a
solids discharge trough with a built-in bypass mechanism and a 6
(152 mm) diameter solids discharge nipple and a 1 (25 mm) NPT
wash line connection.
Particle Size Microns
Larger Than 2000
2000-250
250-74
74-44
44-2
2-0
Classification
Coarse
Intermediate
Medium
Fine
Ultrafine
Colloidal
17
18
The new Fluid Distribution System is mounted above the screen deck.
The fluid is redirected from the inlet line through the diverter box into a
half pipe that is welded to the back of the screen deck. The flow enters the
half pipe at the bottom and spins up and back through the fluid stream.
This reduces the velocity of the fluid before it makes contact with the
screening surface.
Since the Fluid Distribution System is mounted above the screen deck, no
trap exists to collect solids. As the fluid passes through the diverter box it
sweeps the box clean.
The shaker is equipped with two (2) or three (3) explosion proof vibratory
motors. The unique mounting of these vibrators produces a true linear
motion for a two (2) motor version and a balanced elliptical motion for a
three (3) motor version. With the two (2) motor version the G-force on
the shaker will be increased by 20%. The increased force and linear
motion will result in shorter screen life if used continuously. When the
three (3) motor version is in operation, the unit will produce a balanced
elliptical deck motion slowing down the solid conveyance and resulting in
much drier discharge and longer screen life.
19
20
Weight
Length
Width
6388 lbs
(2898 Kg)
7789 lbs
(3533 Kg)
8378 lbs
(3800 Kg)
7905 lbs
(3586 Kg)
7985 lbs
(3622 Kg)
6042 lbs
(2741 Kg)
6130 lbs
(2781 Kg)
7405 lbs
(3359 Kg)
7485 lbs
(3395 Kg)
113.33
(2879 mm)
113.33
(2879 mm)
113.33
(2879 mm)
113.33
(2879 mm)
113.33
(2879 mm)
113.33
(2879 mm)
113.33
(2879 mm)
113.33
(2879 mm)
113.33
(2879 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
63.12 in
(1603 mm)
Overall
Height
97.58 in
(2479 mm)
97.58 in
(2479 mm)
97.58 in
(2479 mm)
93.82 in
(2383 mm)
92.05 in
(2339 mm)
92.05 in
(2339 mm)
92.05 in
(2339 mm)
92.05 in
(2338 mm)
92.05 in
(2338 mm)
Weir Height
35.00 in
(889 mm)
35.00 in
(889 mm)
35.00 in
(889 mm)
35.00 in
(889 mm)
35.00 in
(889 mm)
35.00 in
(889 mm)
35.00 in
(889 mm)
35.00 in
(889 mm)
35.00 in
(889 mm)
Type
Three Phase Induction Motor
Three Phase Induction Motor
Frame
60 CDX18-5900
60 CDX18-2100
Hz
50
50
HP (Watts)
2.00 (1491)
0.60 (447)
2.00 (1491)
0.60 (447)
RPM
Volts
1800
440-480
1800
220-240
HP (Watts)
1.75 (1306)
0.60 (448)
1.75 (1306)
0.60 (448)
RPM
Volts
1500
380-415
1500
220-240
5 Gs
6 Gs
21
22
SHIPPINGBRACKET
(BOTH SIDES)
(MI-SWACO P/N: 9671809)
REMOVE HARDWARE AND STORE FOR
FUTURE USE. HARDWARE IS LOCATED
ON DISCHARGE AND FEED END OF SHAKER
MOVE SHIPPING
BRACKET IN THIS
DIRECTION
LOOSEN HARDWARE
(DO NOT REMOVE)
(BOTH SIDES)
MOVE SHIPPING
BRACKET IN THIS
DIRECTION
SHIPPINGBRACKET
(BOTH SIDES)
(MI-SWACO P/N: 9671809)
Figure 5.1a: For (9671902-01, -02) and (9671903-01, -02) and (9671905-01, -02) only
23
3.
MOVE SHIPPING
BRACKET IN THIS
DIRECTION
(BOTH SIDES)
3
LABEL
LOOSEN HARDWARE
ROTATE SHIPPINGBRACKET
PER LABEL
SHIPPINGBRACKET
(MI-SWACO P/N: 9671742)
(BOTH SIDES)
Figure 5.1c
24
6.
7.
8.
WARNING! :
9.
10.
11.
12.
Figure 5.1d
25
ATTENTION! :
WARNING!
3.
4.
5.
6.
7.
8.
26
27
SHALE PIT
TYPICAL SHALE SLIDE
INSTALLATION HERE
(DO NOT WELD TO BASKET)
Figure 5.3a
28
0.0
O 1
254
O 8.0
203
O 6.0
152
0.0
O 1
254
O 8.0
203
O 6.0
152
36.0
914
10" INLET LOCATION
34.0
863
6" INLET LOCATION
16.5
419
8" BYPASS LOCATION
35.0
889
8" INLET LOCATION
17.5
444
10" BYASS LOCATION
31.6
802
15.5
394
6" BYPASS LOCATION
Figure 5.5a
29
1.
2.
3.
4.
5.
6.
7.
8.
9.
: Wear proper PPE equipment per Section 1.2. And wash down
the screen area prior to installing new screens.
Stop the flow of drilling fluid to the shaker.
While the shaker is running, wash down the screens. Clean all cuttings
and solids build up around the inside of the deck and the wedges.
Shut down shaker. Follow proper lockout/tagout procedures for
turning off power to the shaker.
Each screen is secured in place by two (2) wedges, one per side. A
rubber mallet is required to remove the wedges. A rubber mallet blows
to the end or to the top handle section can remove the wedges.
Remove screen panel. Screen panels should be removed and installed
one at a time. The following instructions apply to a single screen panel
and must be repeated for each additional panel.
Note that the wedges for the second screen from the feed end are
reversed for easier installation.
Wash down screen panel areas prior to installing new screens. Replace
any deck rubbers if worn, cracked or that may have become hard (see
Section 5.7).
Lay new screen into shaker deck. Position one wedge between the
screen edge and the support bar on the shaker side wall then position the
other wedge on the opposite side in the same manner and hammer tight, a
rubber mallet should be used to avoid damage to wedges, see Figure 5.6a
for proper location of wedges for tightness. CAUTION: Both wedges
must be in position prior to hammering them tight. Failure to due so
will prevent the second wedge from being started.
Wet down the new screens prior to actual use of drilling fluids.
30
WEDGE
BASKET SIDEWALL
BRACKET
MIN. FLUSH WITH
BRACKET FOR TIGHTNESS
.75
MAX. FOR TIGHTNESS
SCREEN AREA
Figure 5.6a
Mesh Type
Magnum
Magnum
Magnum
Magnum
Magnum
Magnum
MX
MX
MX
MX
MX
MX
HC-Magnum
HC-Magnum
HC-Magnum
HC-Magnum
HC-Magnum
HC-Magnum
HC-Magnum
Part Number
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250Pj
JMONHC325P
31
32
5.
6.
7.
33
DECK ANGLE
ADJUSTMENT NUT
1-1/4"
GREASE FITTING
FOR JACK
DECK ANGLE
INDICATOR
DECK ANGLE
POINTER
Figure 6.1a
ATTENTION! :
WARNING! :
ATTENTION! :
34
1.
2.
BYPASS SHOWN
IN BYPASS OPERATION
MODE
BYPASS SHOWN
IN FLOWLINE SHAKER
MODE
BYPASS FLUID FLOW
WHEN IN BYPASS
MODE
FLOWLINE
CONNECTION
FLOWDIRECTION
Figure 6.2a
3.
35
EMERGENCY
PUSH PULL BUTTON
SELECTOR SWITCH
ELLIPITCAL / LINEAR
RESET BUTTON
RESET BUTTON
Figure 6.3a
36
ATTENTION! :
WARNING! :
Use proper PPEs per Section 1.2 and Local and National
codes.
Item No.
Qty.
A
B
C
D
E
F
H
I
J
L
M
N
O
P
2
1
1
1
1
1
4
2
1
4
2
2
1
2
MI-Swaco
P/N
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
7152605
7518022
7518020
Description
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
Overload Heaters
Fuse
Fuses
Figure 7.1a: Control Panel 3 Motor 380V/50 Hz Parts List (MI-Swaco #: 6930007)
37
E
G
J
C
MS1
MS2
MS4
MS3
Figure 7.1b: Control Panel 3 Motor 380/50 Hz Internal and External Components
(MI-Swaco #: 6930007)
38
8.
9.
10.
39
To replace one or both deck angle adjustment jacks abide by the following
procedure.
1.
2.
3.
4.
5.
6.
SPRINGISOLATION WASHER
SPRING
SPRINGISOLATION WASHER
JACK
SPRINGSUPPORT
WELDMENT
DECK ANGLE INDICATOR
NOT SHOW. MUST BE PLACED
ON UNIT FIRST BEFORE JACK
UNIT
POINTER
Figure 7.5a
7.
8.
9.
40
ATTENTION! :
ATTENTION! :
ATTENTION! :
WARNING! :
Use proper PPEs per Section 1.2 and Local or National codes.
3.
4.
5.
41
6.
7.
8.
9.
10.
11.
Large Motor
Item #
Qty
1
4
2
4
3
4
4
4
Small Motor
5
4
6
4
7
4
8
4
MI-Swaco P/N
1407169
BM6S80043-01
05-244
1305055
Description
HHCS M20-1.5 x 120 mm lg., Grade 10.9 Yellow Chromate
Motor Washer
Lockwasher Schnorr M20
Nut, Hex M20-1.5, Grade 10.9 Yellow Chromate
1407144
9671682
05-248
1305040
42
12.
13.
14.
15.
16.
17.
18.
19.
MOTOR LIFT
POINT LOCATION
CABLE GLAND
FIGURE 1
FITTINGS TO MOTOR
JUNCTION BOX
MOTOR LIFT
POINT LOCATION
MOTOR CABLE
FIGURE 2
CABLE GLAND
43
B
A
FIGURE 3
2
3
6
8
4
7
DETAIL A
DETAIL B
44
3.
4.
5.
6.
45
H
F
2.
3.
Place the Entry onto the motor fittings or the control panel.
Determine length of cable to suit equipment.
Desired Length
4.
46
Copper Braid
Insulation
5.
6.
Copper Braid
Slide the Backnut, Middle nut, and Clamping ring over the cable.
Clamping Ring
Backnut
Middle Nut
47
7.
Push the copper braid over the clamping ring and cut the remaining
insulation at the base of the copper braid to expose the wires.
Copper Braid
Clamping Ring
Copper Braid
Insulation
Clamping Ring
Wire
Copper Braid Base
Direction
Direction
8.
Slide the Spigot over the wires and push the spigot into the copper
braid until the end of the braid is up against the shoulder of the
spigot.
Clamping Ring
Copper Braid
9.
Position the clamping ring over the copper braid and bring the
middle nut up to meet the entry.
48
10.
Hand tighten the middle nut onto the entry and then turn with a
wrench until you hear a squeak. NOTE: Do not over tighten this
can cause damage to the copper braid.
11.
Unscrew the middle nut and visually inspect that the braid has
been successfully clamped between the spigot and the clamping
ring.
12.
The epoxy compound must be mixed into the ratio of 1:1 until both
colors have blended into one, without any streaks. NOTE: Rolling
and folding is the most effective method of obtaining an even
blend. NOTE: When handling this material the gloves supplied
must be worn.
49
13.
14.
With all gaps and voids filled, bring the wires back together and
pack more compound around out-side of the wires in a cone-shape.
15.
Slide the brass pot over the spigot and remove any surplus
compound from the top of the brass pot and the joint face.
Brass Nut
Joint Face
50
16.
Hand tighten the middle nut onto the entry and then tighten with a
wrench.
17.
Hand tighten the back nut onto the middle nut and then tighten
with a wrench.
18.
51
8.1: Start up
Once all steps in Section 5.1, 5.2, 5.3 and 5.6 have be completed, follow
the below procedure for start up of the unit.
ATTENTION! :
Make sure all objects such as tools are clear from unit before
starting unit.
1.
2.
3.
4.
5.
52
DECK ANGLE
INDICATOR PLATE
POINTER
Figure 8.2a
53
2.
3.
54
9.0: Troubleshooting
Problem
Screen wedge comes
loose
Probable Cause
Wedge not properly installed
Solids under screen or wedge
Suggested Remedy
Ensure wedge is fully
engaged, see Figure 5.6a,
Section 5.6
Return bracket on basket
back to normal position
Check vibrator motor
and control panel
Reverse rotation
Level unit
Check and reinstall
wedges
Replace motor
Determine cause of
interference and fix
Locate and tighten
Caked mud
Clean
55
56
Item
#
1
2
3
4
Qty
MI-Swaco P/N
Description
1
1
2
1
9671843
9671688-02
EM3C00010
6905003
9671906
6
7
8
9
1
4
2
1
9650360
07-409
9671809
9671839
57
11
15 14
11
8
13
2x
16
7
8
8
6
6
8
ON BOTTOM OF ITEM 2
11
11
10
12
9
11
11
12
12
5
6
6
Item #
*1
2
*3
4
5
6
7
8
9
10
11
12
13
14
15
16
Qty
1
1
4
6
6
6
6
6
2
13
6
60 ft.
8
4
4
4
Description
Plate, Control Panel Mounting Adapter
Starter Assembly 380 V, 50 Hz
Mount Vibration Donut
Lockwasher, 1
Conduit Locknut, NPT
Cord Grip Straight
Reducer Bushing, MPT x FPT
Cable Connector, NPT .51-.81 Dia. Armored
Conduit Elbow, 90 Deg. x FPT
Tie Cable
Decal, Arrow Rotation
Cable Armored 4 Conductor, UL Approved
Flatwasher, M12 Regular, SST
Lockwasher, M12 Regular, SST
Hex Nut, M12, SST
HHCS, M12 x 80 mm Lg., SST
MI-Swaco P/N
9671689
6930007
5859378
05-110
01-184
01-106
5008937
6560030
5030937
8087255
9650367
7906218
05-305
05-306
03-415
04-1147
58
For proper supporting of motor cable see Cable Routing View and Table 1 below
CABLE #3
A
CABLE #1
25
REF
CABLE #2
CABLE #3
CABLE #2
CABLE #1
5.5
13.5
15
MOTOR TO
A
6
6
6
7
4.5
6
6
6
7
6.5
6
6
6
7
6
A TO
B TO
C TO
D TO
E TO
B
C
D
E
TOWER
APPROXIMATE LENGTH OF CABLE (INCHES)
35
45
46
TOTAL
LENGTH
Table 1
59
Qty
1
1
24
2
8
8
2
4
8
8
8
40
24
2
24
2
2
1
1
2
4
8
8
4
4
MI-Swaco P/N
9671790
9671738-01
04-1270
9671681
1305055
1407169
9671815
9671742
05-296
05-307
1493215
05-305
05-306
8420202
03-415
9671679
9671683
9671744
9671745
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
26
1407144
27
28
29
30
31
32
33
34
35
36
37
38
39
40
8
4
1
4
1
1
12
12
24
12
4
2
4
4
5895002
1305040
9650360
07-409
9671652-01
3916067
1493003
03-412
05-308
05-309
BM6K80098
BM6K80097
5804004
9650511
Description
Skid Weldment Mongoose Effluent
Basket Assembly, Mongoose PT
HHCS M12 x 45 mm, SS
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
Gate, Skid Slide Mongoose Effluent Design
Bracket, Shipping Metric
Flatwasher M20 Metric, SS
Lockwasher M20 Metric, SS
Screw Hex Hd, SS, M20 x 45 mm
Flatwasher M12 Metric, SS
Lockwasher M12 Split, SS
Decal MI-Swaco
Hex Nut M12 Metric, SS, M12 x 1.75, SS
Weldment, Spring Spool Mongoose Flat Panel
Indicator Pointer Mongoose PT Bolt Flg. Design
Plate, Right Indicator
Plate, Left Indicator
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Nameplate MI-Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip
Cover, Weld Flange 10 PT Mongoose
Gasket Ring ANSI Flng RF 150 LB 10 in
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
Hex Nut M24, Metric, SS
Flatwasher M24, Metric, SS
Lockwasher M24 Split, SS
Label, Lift Point
Label, PE Protective Earth
Boot, Spring
Decal Shipping Bracket Position
60
Item #
1
2
Qty:
1
1
MI-Swaco P/N
9671610
9671637-02
5895001
4
5
6
7
8
36
28
28
28
1
05-277
04-1103
05-270
03-229
9671638-02
5873004
10
11
12
4
4
1
5837001
9671640
9671925
13
32
07-415
14
32
1441471
15
BM6K80100
Description
Basket Weldment Mongoose PT
Cover, Removable Mongoose Flat Panel
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Flatwasher M10 Metric, SS
HHCS M10 x 30 Metric, SS
Lockwasher M10 Split, SS
Hex Nut M10 Metric, SS
Bar, Skirt Retainer
Skirt Mongoose Feed End High Grade Nitrile 80
Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Drip Lip Basket Mongoose
Grommet Screw .273 Sq. Panel Hole, Panel Thk.
0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg.,
SS,
Sq. Head
Label, Crush Hands
61
Qty
4
8
4
4
4
1
1
1
1
1
2
1
40
10
2
1
10
1
1
20
1
1
1
1
1
1
1
1
1
1
70
24
35
12
31
4
12
2
35
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5010134
5010135
5015029
5015030
5015031
5015052
5015053
5068261
8420200
9622220
9622532
9622585
9622595
9650360
9671652-01
9671907
9671914
9671915
9671926
9671927
9671941
9697001-13
9697001-14
05-305
05-308
03-415
03-412
04-1105
04-1106
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flng RF 150 LB. 10 in
Cap Grooved End 6 in
Cap Grooved End 8 in
Cuplng Grooved End 6 in Bolt T-Gskt 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gskt 800 PSI
Cuplng Grooved End 10 in Bolt T-Gskt 800 PSI
Cuplng Grooved End 2 in Snap T-Gskt 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gskt
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manfld Feed D-Silter 10T4 w/o Flange
Manfld Overflow D-Silter 10T4 / ALS Mud Cleaner
Elbow D-Silter 10T4 Poly 2 in Grooved End
Nameplate ID Product
Cover, MS Weld Flange 10 PT Mongoose
Weldment, 10T4 Header Box w/o Flange Mud Cleaner
Weldment, Leg Header Box D-Silter 10T4
Weldment, Leg Header Box D-Silter 10T4
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Nipple Stub Grooved End 8 in x 5 in Lg.
Nipple Stub Grooved End 10 in x 5 in Lg.
Flatwasher M12 Metric 304 SS
Flatwasher M24 Metric 304 SS
Hex Nut M12 Metric, 304 SS, M12 x 1.75
Hex Nut M24 Metric, 304 SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 40 Metric, 304 SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate Plt. Gr. 10.9 Full Thread
CVR/Plug-I/O 6 Dia. High Grade Nitrile 45-70 Shore A Hardiness
Lockwasher M12 Split 304 SS
Lockwasher M24 Split 304 SS
Item #
1
2
Qty
1
2
MI-Swaco P/N
9622221
9622312
Description
Liner Feed Urethane
Valve Apex 1/2
63
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
64
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
10.0a / 3
10.0a / 4
10.1a / 4
10.1a / 5
10.1a / 6
10.1a / 7
10.1a / 8
10.1a / 9
10.1a / 12
10.2a / 4
10.2a / 5
10.2a / 6
10.2a / 20
10.2a / 21
10.2a / 22
10.2a / 23
10.2a / 24
10.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
10.2a / 26
1407144
10.2a / 27
10.2a / 28
10.2a / 32
10.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
10.3a / 3
5895001
10.3a / 9
10.3a / 10
10.3a / 11
10.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
10.3a / 14
32
1447471
10.4a / 6
10.4a / 7
10.4a / 8
10.4a / 9
10.4a / 10
10.4a / 11
10.4a / 12
10.4a / 13
10.4a / 14
10.4a / 15
1
1
1
1
1
2
1
40
10
2
2422177
3916067
5010134
5010135
5015029
5015030
5015031
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Cnectr Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flng RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flng RF 150 LB, 10 in
Cap Grooved End 6 in
Cap Grooved End 8 in
Cuplng Grooved End 6 in Bolt T-Gskt 1000 psi
Cuplng Grooved End 8 in Bolt T-Gskt 800 psi
Cuplng Grooved End 10 in Bolt T-Gskt 800 psi
Cuplng Grooved End 2 in Bolt T-Gskt 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gskt
Plug SQ Hd. Galv. 150 psi 1 NPT
65
Qty
MI-Swaco P/N
10.4a / 17
10.4a / 18
10.4a / 19
10.4a / 20
10.4a / 29
10.4a / 30
10.4a / 46
10.5a / 1
10.5a / 2
10
1
1
20
2
1
2
1
2
9622220
9622532
9622585
9622595
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
Description
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manfld Feed D-Silter 10T4 w/o Flng
Manfld Overflow D-Silter 10T4 / ALS Mud Cleaner
Elbow D-Silter 10T4 Poly 2 in Grooved End
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
CVR/Plug I/O 6 Dia.
Liner Feed Urethane
Valve Apex 1/2
66
67
Assembly 9671902-02:
11.0.1:
Item #
Qty
1
2
3
4
1
1
2
1
MI-Swaco
P/N
9671843
9671688-02
EM3C00010
6905003
9671906
6
7
8
9
10
1
1
4
2
1
9671947
9650360
07-409
9671809
9671955
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
10T4 D-Silter Assembly w/ Header Box Mongoose PT Mud
Cleaner
2-12, D-Sander Assembly Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
Weldment, Trough 2-12 D-Sander PT Mongoose Mud Cleaner
68
11.0.2:
Item #
Qty
1
2
3
4
1
1
2
1
MI-Swaco
P/N
9671843
9671688-02
EM3C00010
6905003
9671906
6
7
8
9
10
1
1
4
2
1
9671954
9650360
07-409
9671809
9671960
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
10T4 D-Silter Assembly w/ Header Box Mongoose PT Mud
Cleaner
D-Sander 3-12 Stand w/ Clones Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
Weldment, Trough 3-12 D-Sander PT Mongoose Mud Cleaner
69
11
15 14
11
8
13
2x
16
7
8
8
6
6
8
ON BOTTOM OF ITEM 2
11
11
10
12
9
11
11
12
12
5
6
6
Item #
*1
2
*3
4
5
6
7
8
9
10
11
12
13
14
15
16
Qty
1
1
4
6
6
6
6
6
2
13
6
60 ft.
8
4
4
4
Description
Plate, Control Panel Mounting Adapter
Starter Assembly 380 V, 50 Hz
Mount Vibration Donut
Lockwasher, 1
Conduit Locknut, NPT
Cord Grip Straight
Reducer Bushing, MPT x FPT
Cable Connector, NPT .51-.81 Dia. Armored
Conduit Elbow, 90 Deg. x FPT
Tie Cable
Decal, Arrow Rotation
Cable Armored 4 Conductor, UL Approved
Flatwasher, M12 Regular, SST
Lockwasher, M12 Regular, SST
Hex Nut, M12, SST
HHCS, M12 x 80 mm Lg., SST
MI-Swaco P/N
9671689
6930007
5859378
05-110
01-184
01-106
5008937
6560030
5030937
8087255
9650367
7906218
05-305
05-306
03-415
04-1147
70
For proper supporting of motor cable see Cable Routing View and Table 1 below
CABLE #3
A
CABLE #1
25
REF
CABLE #2
CABLE #3
CABLE #2
CABLE #1
5.5
13.5
15
MOTOR TO
A
6
6
6
7
4.5
6
6
6
7
6.5
6
6
6
7
6
A TO
B TO
C TO
D TO
E TO
B
C
D
E
TOWER
APPROXIMATE LENGTH OF CABLE (INCHES)
35
45
46
TOTAL
LENGTH
Table 1
71
Qty
1
1
24
2
8
8
2
4
8
8
8
40
24
2
24
2
2
1
1
2
4
8
8
4
4
MI-Swaco P/N
9671790
9671738-01
04-1270
9671681
1305055
1407169
9671815
9671742
05-296
05-307
1493215
05-305
05-306
8420202
03-415
9671679
9671683
9671744
9671745
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
26
1407144
27
28
29
30
31
32
33
34
35
36
37
38
39
40
8
4
1
4
1
1
12
12
24
12
4
2
4
4
5895002
1305040
9650360
07-409
9671652-01
3916067
1493003
03-412
05-308
05-309
BM6K80098
BM6K80097
5804004
9650511
Description
Skid Weldment Mongoose Effluent
Basket Assembly, Mongoose PT
HHCS M12 x 45 mm, SS
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
Gate, Skid Slide Mongoose Effluent Design
Bracket, Shipping Metric
Flatwasher M20 Metric, SS
Lockwasher M20 Metric, SS
Screw Hex Hd, SS, M20 x 45 mm
Flatwasher M12 Metric, SS
Lockwasher M12 Split, SS
Decal MI-Swaco
Hex Nut M12 Metric, SS, M12 x 1.75, SS
Weldment, Spring Spool Mongoose Flat Panel
Indicator Pointer Mongoose PT Bolt Flg. Design
Plate, Right Indicator
Plate, Left Indicator
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Nameplate MI-Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip
Cover, Weld Flange 10 PT Mongoose
Gasket Ring ANSI Flange RF 150 LB 10 in
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
Hex Nut M24, Metric, SS
Flatwasher M24, Metric, SS
Lockwasher M24 Split, SS
Label, Lift Point
Label, PE Protective Earth
Boot, Spring
Decal Shipping Bracket Position
Item #
1
2
Qty
1
1
MI-Swaco P/N
9671610
9671637-02
5895001
4
5
6
7
8
36
28
28
28
1
05-277
04-1103
05-270
03-229
9671638-02
5873004
10
11
12
4
4
1
5837001
9671640
9671925
13
32
07-415
14
32
1441471
15
BM6K80100
Description
Basket Weldment Mongoose PT
Cover, Removable Mongoose Flat Panel
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Flatwasher M10 Metric, SS
HHCS M10 x 30 Metric, SS
Lockwasher M10 Split, SS
Hex Nut M10 Metric, SS
Bar, Skirt Retainer
Skirt Mongoose Feed End High Grade Nitrile 80
Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Drip Lip Basket Mongoose
Grommet Screw .273 Sq. Panel Hole, Panel Thk.
0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg.,
SS, Sq. Head
Label, Crush Hands
73
Qty
4
8
4
4
4
1
1
1
1
1
2
1
40
10
2
1
10
1
1
20
1
1
1
1
1
1
1
1
1
1
70
24
35
12
31
4
12
2
35
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5010134
5010135
5015029
5015030
5015031
5015052
5015053
5068261
8420200
9622220
9622532
9622585
9622595
9650360
9671652-01
9671907
9671914
9671915
9671926
9671927
9671941
9697001-13
9697001-14
05-305
05-308
03-415
03-412
04-1105
04-1106
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB. 10 in
Cap Grooved End 6 in
Cap Grooved End 8 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 2 in Snap T-Gasket 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Feed D-Silter 10T4 w/o Flange
Manifold Overflow D-Silter 10T4 / ALS Mud Cleaner
Elbow D-Silter 10T4 Poly 2 in Grooved End
Nameplate ID Product
Cover, MS Weld Flange 10 PT Mongoose
Weldment, 10T4 Header Box w/o Flange Mud Cleaner
Weldment, Leg Header Box D-Silter 10T4
Weldment, Leg Header Box D-Silter 10T4
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Nipple Stub Grooved End 8 in x 5 in Lg.
Nipple Stub Grooved End 10 in x 5 in Lg.
Flatwasher M12 Metric 304 SS
Flatwasher M24 Metric 304 SS
Hex Nut M12 Metric, 304 SS, M12 x 1.75
Hex Nut M24 Metric, 304 SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 40 Metric, 304 SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate Plt. Gr. 10.9 Full Thread
CVR/Plug-I/O 6 Dia. High Grade Nitrile 45-70 Shore A Hardiness
Lockwasher M12 Split 304 SS
Lockwasher M24 Split 304 SS
74
Item #
1
2
Qty
1
2
Part Number
9622221
9622312
Description
Liner Feed Urethane
Valve Apex 1/2
75
Assembly 9671954:
76
11.6.1:
Qty
1
2
2
4
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
1
1
1
32
4
8
4
16
2
8
4
4
12
2
16
2
8
4
MI-Swaco P/N
00-1614
1289105
1289140
1492031
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9650360
9671953
9671961
9671962
9671964
9671965
9671001-13
9697001-14
05-305
05-276
05-174
05-160
03-415
03-232
03-145
03-404
04-1105
04-1106
04-1451
05-306
05-285
05-176
05-236
Description
Clamping Unit, 5/8 Hose OD, 3 Hose Clamp
U-Bolt CS 8 in Pipe 5/8-11 NC x 11.37 Lg. w/ Nuts
U-Bolt CS 10 in Pipe 3/4-10 NC x 13.75 Lg. w/ Nuts
DRS #4 x 5/8, 304 SS
Gauge 0-60/0-400 KPA 2-1/2 in 1/4 NPT LM
Cuplng Grooved End 4 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Ell Grooved End 90D MI SR Sch 40 6 in
Clone Assembly Urethane 12 in Grooved End
U-Bolt 7-3/8 in ID 5/8-11 NC x 8-3/4 in Lg.
Manifold Feed ALS Mounted 2-12 Slant D-Sander
Manifold Overflow ALS Mounted 2-12 Slant D-Sander
Nameplate ID Product
Weldment, 2-12, 3-12 D-Sander Stand PT Mongoose Mud Cleaner
Bracket, Adjustment D-Sander Clones PT Mongoose Mud Cleaner
Bracket, Mating 2-12 D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 8 in x 5 in Lg.
Nipple Stub Grooved End 10 in x 5 in Lg.
Flatwasher M12 Metric 304 SS
Flatwasher M8 Metric 304 SS
Flatwasher 5/8 304 SS
Flatwasher 3/4 304 SS
Hex Nut M12 Metric 304 SS
Hex Nut M8 Metric 304 SS
Hex Nut 5/8-NC 304 SS
Hex Nut 3/4-NC 304 SS
HHCS M12 x 35 Metric 304 SS
HHCS M12 x 40 Metric 304 SS
HHCS M8 x 60 mm Metric 304 SST Hex Head Cap Screw
Lockwasher M12 Split 304 SS
Lockwasher M8 Split 304 SS
Lockwasher 5/8 Split 304 SS
Lockwasher 3/4 Split 304 SST
11.6.2:
Qty
1
2
2
4
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
1
1
1
32
4
6
4
4
16
2
8
4
4
4
12
2
16
2
6
4
4
MI-Swaco P/N
00-1614
1289140
1289171
1492031
2422177
5015026
5015029
5015031
5015032
5030860
9621280
9621289
9621325
9621326
9650360
9671953
9671961
9671963
9671964
9671965
9671001-13
9697001-14
05-305
05-276
05-174
05-160
05-238
03-415
03-232
03-145
03-404
03-405
04-1105
04-1106
04-1451
05-306
05-285
05-176
05-236
05-177
Description
Clamping Unit, 5/8 Hose OD, 3 Hose Clamp
U-Bolt CS 10 in Pipe 3/4-10 NC x 13.75 Lg. w/ Nuts
U-Bolt CS 10 in Pipe 7/8-9 NC x 16.06 Lg. w/ Nuts
DRS #4 x 5/8, 304 SS
Gauge 0-60/0-400 KPA 2-1/2 in 1/4 NPT LM
Cuplng Grooved End 4 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 12 in Bolt T-Gasket 800 PSI
Ell Grooved End 90D MI SR Sch 40 6 in
Clone Assembly Urethane 12 in Grooved End
U-Bolt 7-3/8 in ID 5/8-11 NC x 8-3/4 in Lg.
Manifold Inlet 10 Diameter 3-12 Slant Mount D-Sander
Manifold 12 Diameter 3-12 Slant Mount D-Sander
Nameplate ID Product
Weldment, 2-12, 3-12 D-Sander Stand PT Mongoose Mud Cleaner
Bracket, Adjustment D-Sander Clones PT Mongoose Mud Cleaner
Bracket, Mating 3-12 D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 8 in x 5 in Lg.
Nipple Stub Grooved End 10 in x 5 in Lg.
Flatwasher M12 Metric 304 SS
Flatwasher M8 Metric 304 SS
Flatwasher 5/8 304 SS
Flatwasher 3/4 304 SS
Flatwasher 7/8, 304 SS Type A Plain Narrow
Hex Nut M12 Metric 304 SS
Hex Nut M8 Metric 304 SS
Hex Nut 5/8-NC 304 SS
Hex Nut 3/4-NC 304 SS
Hex Nut 7/8-NC 304 SS
HHCS M12 x 35 Metric 304 SS
HHCS M12 x 40 Metric 304 SS
HHCS M8 x 60 mm Metric 304 SST Hex Head Cap Screw
Lockwasher M12 Split 304 SS
Lockwasher M8 Split 304 SS
Lockwasher 5/8 Split 304 SS
Lockwasher 3/4 Split 304 SST
Lockwasher 7/8 Split 316 SS
5
1
6
2
6
4
Item #
1
2
3
4
5
6
Qty
1
1
1
1
1
2
Part Number
9621281
9621173
9621175
9621174
9621177
9621176
Description
Feed 12 Feed Section w/ Victaulic End
Body Main 12 Close Urethane
Body Mid 12 Clone Urethane
Valve 1-1/2 Apex Clone Urethane
Clamp V-Band 16.12 I.D., 12 Clone
Clamp V-Band 9.88 I.D., 12 Clone
79
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
80
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
11.0.1a / 3
11.0.1a / 4
11.1a / 4
11.1a / 5
11.1a / 6
11.1a / 7
11.1a / 8
11.1a / 9
11.1a / 12
11.2a / 4
11.2a / 5
11.2a / 6
11.2a / 20
11.2a / 21
11.2a / 22
11.2a / 23
11.2a / 24
11.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
11.2a / 26
1407144
11.2a / 27
11.2a / 28
11.2a / 32
11.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
11.3a / 3
5895001
11.3a / 9
11.3a / 10
11.3a / 11
11.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
11.3a / 14
32
1447471
11.4a / 6
11.4a / 7
11.4a / 8
11.4a / 9
11.4a / 10
11.4a / 11
11.4a / 12
11.4a / 13
11.4a / 14
11.4a / 15
1
1
1
1
1
2
1
40
10
2
2422177
3916067
5010134
5010135
5015029
5015030
5015031
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plate M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plate M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plate M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Cap Grooved End 6 in
Cap Grooved End 8 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 10 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
81
Qty
MI-Swaco P/N
Description
11.4a / 17
11.4a / 18
11.4a / 19
11.4a / 20
11.4a / 29
11.4a / 30
11.4a / 38
11.5a / 1
11.5a / 2
11.6.1a / 1
11.6.1a / 2
11.6.1a / 3
11.6.1a / 5
11.6.1a / 6
11.6.1a / 7
11.6.1a / 8
11.6.1a / 9
11.6.1a / 10
11.6.1a / 11
11.6.1a / 12
11.6.1a / 13
11.6.1a / 14
11.7a / 1
11.7a / 2
11.7a / 3
11.7a / 4
11.7a / 5
11.7a / 6
10
1
1
20
2
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
2
9622220
9622532
9622585
9622595
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289105
1289140
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9621281
9621173
9621175
9621174
9621177
9621176
82
11.8.2:
Figure / Item #
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
83
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
11.0.2a / 3
11.0.2a / 4
11.1a / 4
11.1a / 5
11.1a / 6
11.1a / 7
11.1a / 8
11.1a / 9
11.1a / 12
11.2a / 4
11.2a / 5
11.2a / 6
11.2a / 20
11.2a / 21
11.2a / 22
11.2a / 23
11.2a / 24
11.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
11.2a / 26
1407144
11.2a / 27
11.2a / 28
11.2a / 32
11.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
11.3a / 3
5895001
11.3a / 9
11.3a / 10
11.3a / 11
11.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
11.3a / 14
32
1447471
11.4a / 6
11.4a / 7
11.4a / 8
11.4a / 9
11.4a / 10
11.4a / 11
11.4a / 12
11.4a / 13
11.4a / 14
11.4a / 15
1
1
1
1
1
2
1
40
10
2
2422177
3916067
5010134
5010135
5015029
5015030
5015031
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plate M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Cap Grooved End 6 in
Cap Grooved End 8 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 10 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
84
Qty
MI-Swaco P/N
Description
11.4a / 17
11.4a / 18
11.4a / 19
11.4a / 20
11.4a / 29
11.4a / 30
11.4a / 38
11.5a / 1
11.5a / 2
11.6.2a / 1
11.6.2a / 2
11.6.2a / 3
11.6.2a / 5
11.6.2a / 6
11.6.2a / 7
11.6.2a / 8
11.6.2a / 9
11.6.2a / 10
11.6.2a / 11
11.6.2a / 12
10
1
1
20
2
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
9622220
9622532
9622585
9622595
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289140
1289171
2422177
5015026
5015029
5015031
5015032
5030860
9621280
9621289
11.6.2a / 13
9621325
11.6.2a / 14
11.7a / 1
11.7a / 2
11.7a / 3
11.7a / 4
11.7a / 5
11.7a / 6
1
1
1
1
1
1
2
9621326
9621281
9621173
9621175
9621174
9621177
9621176
85
86
Assembly 9671903-02:
12.0.1:
Item #
Qty
1
2
3
4
5
6
7
8
9
1
1
2
1
1
1
1
4
2
MI-Swaco
P/N
9671843
9671688-02
EM3C00010
6905003
9671919
9671954
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
D-Silter 6T4 3-12 Assembly Header Box PT Mongoose
D-Sander 3-12 Stand w/ Clones Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
87
12.0.2:
Item #
Qty:
1
2
3
4
5
6
7
8
9
1
1
2
1
1
1
1
4
2
MI-Swaco
P/N
9671843
9671688-02
EM3C00010
6905003
9671920
9671954
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
D-Silter 8T4 3-12 Assembly Header Box PT Mongoose
D-Sander 3-12 Stand w/ Clones Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
88
11
15 14
11
8
13
2x
16
7
8
8
6
6
8
ON BOTTOM OF ITEM 2
11
11
10
12
9
11
11
12
12
5
6
6
Item #
*1
2
*3
4
5
6
7
8
9
10
11
12
13
14
15
16
Qty
1
1
4
6
6
6
6
6
2
13
6
60 ft.
8
4
4
4
Description
Plate, Control Panel Mounting Adapter
Starter Assembly 380 V, 50 Hz
Mount Vibration Donut
Lockwasher, 1
Conduit Locknut, NPT
Cord Grip Straight
Reducer Bushing, MPT x FPT
Cable Connector, NPT .51-.81 Dia. Armored
Conduit Elbow, 90 Deg. x FPT
Tie Cable
Decal, Arrow Rotation
Cable Armored 4 Conductor, UL Approved
Flatwasher, M12 Regular, SST
Lockwasher, M12 Regular, SST
Hex Nut, M12, SST
HHCS, M12 x 80 mm Lg., SST
MI-Swaco P/N
9671689
6930007
5859378
05-110
01-184
01-106
5008937
6560030
5030937
8087255
9650367
7906218
05-305
05-306
03-415
04-1147
Qty
1
1
24
2
8
8
2
4
8
8
8
40
24
2
24
2
2
1
1
2
4
8
8
4
4
4
8
4
1
4
1
1
12
12
24
12
4
2
4
4
MI-Swaco P/N
9671790
9671738-01
04-1270
9671681
1305055
1407169
9671815
9671742
05-296
05-307
1493215
05-305
05-306
8420202
03-415
9671679
9671683
9671744
9671745
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
1407144
5895002
1305040
9650360
07-409
9671652-01
3916067
1493003
03-412
05-308
05-309
BM6K80098
BM6K80097
5804004
9650511
Description
Skid Weldment Mongoose Effluent
Basket Assembly, Mongoose PT
HHCS M12 x 45 mm, SS
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
Gate, Skid Slide Mongoose Effluent Design
Bracket, Shipping Metric
Flatwasher M20 Metric, SS
Lockwasher M20 Metric, SS
Screw Hex Hd, SS, M20 x 45 mm
Flatwasher M12 Metric, SS
Lockwasher M12 Split, SS
Decal MI-Swaco
Hex Nut M12 Metric, SS, M12 x 1.75, SS
Weldment, Spring Spool Mongoose Flat Panel
Indicator Pointer Mongoose PT Bolt Flg. Design
Plate, Right Indicator
Plate, Left Indicator
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plate M16-1.5 x 100 mm, Grd. 10.9 Yellow Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plate M16-1.5, Grd. 10.9 Yellow Chromate
Nameplate MI-Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip
Cover, Weld Flange 10 PT Mongoose
Gasket Ring ANSI Flange RF 150 LB 10 in
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
Hex Nut M24, Metric, SS
Flatwasher M24, Metric, SS
Lockwasher M24 Split, SS
Label, Lift Point
Label, PE Protective Earth
Boot, Spring
Decal Shipping Bracket Position
Item #
Qty
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
1
1
8
36
28
28
28
1
1
4
4
1
32
32
1
MI-Swaco
P/N
9671610
9671637-02
5895001
05-277
04-1103
05-270
03-229
9671638-02
5873004
5837001
9671640
9671925
07-415
1441471
BM6K80100
Description
Basket Weldment Mongoose PT
Cover, Removable Mongoose Flat Panel
Wedge Screen Clamping Mongoose 75 Shore D Polyurethane Black
Flatwasher M10 Metric, SS
HHCS M10 x 30 Metric, SS
Lockwasher M10 Split, SS
Hex Nut M10 Metric, SS
Bar, Skirt Retainer
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Drip Lip Basket Mongoose
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq. Head
Label, Crush Hands
91
Assembly 9671920:
92
12.4.1:
Qty
8
8
8
8
4
1
1
1
2
3
1
24
6
2
1
6
1
1
12
1
1
2
1
1
1
1
1
1
1
1
1
2
78
24
39
12
31
8
12
2
39
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5008417
5010134
5015029
5015030
5015052
5015053
5068261
8420200
9622220
9622491
9622942
9622582
9650360
9671652-01
9671853
9671926
9671927
9671937
9671938
9671941
9671945
9671960
9697001-12
9677001-13
BM6K80122
05-305
05-308
03-415
03-412
04-1105
04-1270
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB. 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 2 in Snap T-Gasket 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Inlet 6T4 D-Silter ALS Mud Cleaner
Manifold OF 6T4 D-Silter ALS Mud Cleaner
Elbow Grooved End 90D Poly 2 in
Nameplate ID Product M-I Swaco
Cover, Weld Flange 10 PT Mongoose
Bracket, Mount D-Silter Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Weldment, 6T4-8T4 Header Box w/o Flange - Mud Cleaner
Weldment, Trough 3-12 D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
Label, Do Not Lift
Flatwasher, M12 Regular, SST
Flatwasher M24, Metric, SS
Hex Nut, M12, SST
Hex Nut M24, Metric, SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 45 mm, SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
CVR/Plug- I/O 6 Dia.
Lockwasher M12 Split, SS
Lockwasher M24 Split, SS
12.4.2:
Qty
8
8
8
8
4
1
1
1
1
2
1
32
8
2
1
8
1
16
1
1
1
2
1
1
1
1
1
1
1
1
1
2
78
24
39
12
31
8
12
2
39
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5008417
5010134
5015029
5015030
5015052
5015053
5068261
8420200
9622220
9622485
9622582
9622605
9650360
9671652-01
9671853
9671926
9671927
9671937
9671938
9671941
9671945
9671960
9697001-12
9677001-13
BM6K80122
05-305
05-308
03-415
03-412
04-1105
04-1270
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB. 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 2 in Snap T-Gasket 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Overflow D-Silter
Elbow Grooved End 90D Poly 2 in
Manifold Inlet D-Silter
Nameplate ID Product M-I Swaco
Cover, Weld Flange 10 PT Mongoose
Bracket, Mount D-Silter Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Weldment, 6T4-8T4 Header Box w/o Flange - Mud Cleaner
Weldment, Trough 3-12 D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
Label, Do Not Lift
Flatwasher, M12 Regular, SST
Flatwasher M24, Metric, SS
Hex Nut, M12, SST
Hex Nut M24, Metric, SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 45 mm, SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
CVR/Plug- I/O 6 Dia.
Lockwasher M12 Split, SS
Lockwasher M24 Split, SS
Item #
1
2
Qty
1
2
MI-Swaco P/N
9622221
9622312
Description
Liner Feed Urethane
Valve Apex 1/2
95
Qty:
1
2
2
4
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
1
1
1
32
4
6
4
4
16
2
8
4
4
4
12
2
16
2
6
4
4
MI-Swaco P/N
00-1614
1289140
1289171
1492031
2422177
5015026
5015029
5015031
5015032
5030860
9621280
9621289
9621325
9621326
9650360
9671953
9671961
9671963
9671964
9671965
9671001-13
9697001-14
05-305
05-276
05-174
05-160
05-238
03-415
03-232
03-145
03-404
03-405
04-1105
04-1106
04-1451
05-306
05-285
05-176
05-236
05-177
Description
Clamping Unit, 5/8 Hose OD, 3 Hose Clamp
U-Bolt CS 10 in Pipe 3/4-10 NC x 13.75 Lg. w/ Nuts
U-Bolt CS 10 in Pipe 7/8-9 NC x 16.06 Lg. w/ Nuts
DRS #4 x 5/8, 304 SS
Gauge 0-60/0-400 KPA 2-1/2 in 1/4 NPT LM
Cuplng Grooved End 4 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 12 in Bolt T-Gasket 800 PSI
Ell Grooved End 90D MI SR Sch 40 6 in
Clone Assembly Urethane 12 in Grooved End
U-Bolt 7-3/8 in ID 5/8-11 NC x 8-3/4 in Lg.
Manifold Inlet 10 Diameter 3-12 Slant Mount D-Sander
Manifold 12 Diameter 3-12 Slant Mount D-Sander
Nameplate ID Product
Weldment, 2-12, 3-12 D-Sander Stand PT Mongoose Mud Cleaner
Bracket, Adjustment D-Sander Clones PT Mongoose Mud Cleaner
Bracket, Mating 3-12 D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 8 in x 5 in Lg.
Nipple Stub Grooved End 10 in x 5 in Lg.
Flatwasher M12 Metric 304 SS
Flatwasher M8 Metric 304 SS
Flatwasher 5/8 304 SS
Flatwasher 3/4 304 SS
Flatwasher 7/8, 304 SS Type A Plain Narrow
Hex Nut M12 Metric 304 SS
Hex Nut M8 Metric 304 SS
Hex Nut 5/8-NC 304 SS
Hex Nut 3/4-NC 304 SS
Hex Nut 7/8-NC 304 SS
HHCS M12 x 35 Metric 304 SS
HHCS M12 x 40 Metric 304 SS
HHCS M8 x 60 mm Metric 304 SST Hex Head Cap Screw
Lockwasher M12 Split 304 SS
Lockwasher M8 Split 304 SS
Lockwasher 5/8 Split 304 SS
Lockwasher 3/4 Split 304 SST
Lockwasher 7/8 Split 316 SS
5
1
6
2
6
4
Item #
1
2
3
4
5
6
Qty
1
1
1
1
1
2
Part Number
9621281
9621173
9621175
9621174
9621177
9621176
Description
Feed 12 Feed Section w/ Victaulic End
Body Main 12 Close Urethane
Body Mid 12 Clone Urethane
Valve 1-1/2 Apex Clone Urethane
Clamp V-Band 16.12 I.D., 12 Clone
Clamp V-Band 9.88 I.D., 12 Clone
97
12.8.1:
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
98
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
12.0.1a / 3
12.0.1a / 4
12.1a / 4
12.1a / 5
12.1a / 6
12.1a / 7
12.1a / 8
12.1a / 9
12.1a / 12
12.2a / 4
12.2a / 5
12.2a / 6
12.2a / 20
12.2a / 21
12.2a / 22
12.2a / 23
12.2a / 24
12.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
12.2a / 26
1407144
12.2a / 27
12.2a / 28
12.2a / 32
12.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
12.3a / 3
5895001
12.3a / 9
12.3a / 10
12.3a / 11
12.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
12.3a / 14
32
1447471
12.4.1a / 6
12.4.1a / 7
12.4.1a / 8
12.4.1a / 10
12.4.1a / 11
12.4.1a / 12
12.4.1a / 13
12.4.1a / 14
1
1
1
3
1
24
6
2
2422177
3916067
5010134
5015029
5015030
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
99
Qty
MI-Swaco P/N
12.4.1a / 16
12.4.1a / 17
12.4.1a / 18
12.4.1a / 19
12.4.1a / 30
12.4.1a / 31
12.4.1a / 40
12.5a / 1
12.5a / 2
12.6a / 1
12.6a / 2
12.6a / 3
12.6a / 5
12.6a / 6
12.6a / 7
12.6a / 8
12.6a / 9
12.6a / 10
12.6a / 11
12.6a / 12
6
1
1
12
1
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
9622220
9622491
9622942
9622582
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289140
1289171
2422177
5015026
5015029
5015031
5015032
5030860
9621280
9621289
12.6a / 13
9621325
12.6a / 14
12.7a / 1
12.7a / 2
12.7a / 3
12.7a / 4
12.7a / 5
12.7a / 6
1
1
1
1
1
1
2
9621326
9621281
9621173
9621175
9621174
9621177
9621176
Description
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Inlet 6T4 D-Silter ALS Mud Cleaner
Manifold OF 6T4 D-Silter ALS Mud Cleaner
Elbow Grooved End 90 Poly 2 in
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
CVR/Plug I/O 6 Dia.
Liner Feed Urethane
Valve Apex 1/2
Clamping Unit, 5/8 Hose OD, 3 Hose Clamp
U-Bolt CS 10 in Pipe 3/4-10 NC x 13.75 Lg. w/ Nuts
U-Bolt CS 12 in Pipe 7/8-9 NC x 16.06 Lg. w/ Nuts
Gauge 0-60/0-400 KPA 2-1/2 in 1/4 NPT LM
Cuplng Grooved End 4 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 12 in Bolt T-Gasket 800 PSI
Ell Grooved End 90D MI SR Sch 40 6 in
Clone Assembly Urethane 12 in Grooved End
U-Bolt 7-3/8 in ID 5/8-11 NC x 8-3/4 in Lg.
Manifold Inlet 10 Diameter 3-12 Slant Mount DSander
Manifold 12 Diameter 3-12 Slant Mount D-Sander
Feed 12 Feed Section w/ Victaulic End
Body Main 12 Close Urethane
Body Mid 12 Clone Urethane
Valve 1-1/2 Apex Clone Urethane
Clamp V-Band 16.12 I.D., 12 Clone
Clamp V-Band 9.88 I.D., 12 Clone
100
12.8.2:
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
101
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
12.0.2a / 3
12.0.2a / 4
12.1a / 4
12.1a / 5
12.1a / 6
12.1a / 7
12.1a / 8
12.1a / 9
12.1a / 12
12.2a / 4
12.2a / 5
12.2a / 6
12.2a / 20
12.2a / 21
12.2a / 22
12.2a / 23
12.2a / 24
12.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
12.2a / 26
1407144
12.2a / 27
12.2a / 28
12.2a / 32
12.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
12.3a / 3
5895001
12.3a / 9
12.3a / 10
12.3a / 11
12.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
12.3a / 14
32
1447471
12.4.2a / 6
12.4.2a / 7
12.4.2a / 8
12.4.2a / 10
12.4.2a / 11
12.4.2a / 12
12.4.2a / 13
12.4.2a / 14
1
1
1
2
1
32
8
2
2422177
3916067
5010134
5015029
5015030
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
102
Qty
MI-Swaco P/N
12.4.2a / 16
12.4.2a / 17
12.4.2a / 18
12.4.2a / 19
12.4.2a / 30
12.4.2a / 31
12.4.2a / 40
12.5a / 1
12.5a / 2
12.6a / 1
12.6a / 2
12.6a / 3
12.6a / 5
12.6a / 6
12.6a / 7
12.6a / 8
12.6a / 9
12.6a / 10
12.6a / 11
12.6a / 12
8
1
16
1
1
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
9622220
9622485
9622582
9622605
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289140
1289171
2422177
5015026
5015029
5015031
5015032
5030860
9621280
9621289
12.6a / 13
9621325
12.6a / 14
12.7a / 1
12.7a / 2
12.7a / 3
12.7a / 4
12.7a / 5
12.7a / 6
1
1
1
1
1
1
2
9621326
9621281
9621173
9621175
9621174
9621177
9621176
Description
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Overflow D-Silter
Elbow Grooved End 90 Poly 2 in
Manifold Inlet D-Silter
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
CVR/Plug I/O 6 Dia.
Liner Feed Urethane
Valve Apex 1/2
Clamping Unit, 5/8 Hose OD, 3 Hose Clamp
U-Bolt CS 10 in Pipe 3/4-10 NC x 13.75 Lg. w/ Nuts
U-Bolt CS 12 in Pipe 7/8-9 NC x 16.06 Lg. w/ Nuts
Gauge 0-60/0-400 KPA 2-1/2 in 1/4 NPT LM
Cuplng Grooved End 4 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 12 in Bolt T-Gasket 800 PSI
Ell Grooved End 90D MI SR Sch 40 6 in
Clone Assembly Urethane 12 in Grooved End
U-Bolt 7-3/8 in ID 5/8-11 NC x 8-3/4 in Lg.
Manifold Inlet 10 Diameter 3-12 Slant Mount DSander
Manifold 12 Diameter 3-12 Slant Mount D-Sander
Feed 12 Feed Section w/ Victaulic End
Body Main 12 Close Urethane
Body Mid 12 Clone Urethane
Valve 1-1/2 Apex Clone Urethane
Clamp V-Band 16.12 I.D., 12 Clone
Clamp V-Band 9.88 I.D., 12 Clone
103
104
Assembly 9671904-02:
13.0.1:
Item #
Qty
1
2
3
4
5
6
7
8
1
1
2
1
1
1
4
2
MI-Swaco
P/N
9671843
9671688-02
EM3C00010
6905003
9671966
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
D-Silter 6T4 Assembly Header Box PT Mongoose
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
105
13.0.2:
Item #
Qty
1
2
3
4
5
6
7
8
1
1
2
1
1
1
4
2
MI-Swaco
P/N
9671843
9671688-02
EM3C00010
6905003
9671967
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
D-Silter 8T4 Assembly Header Box PT Mongoose
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
106
11
15 14
11
8
13
2x
16
7
8
8
6
6
8
ON BOTTOM OF ITEM 2
11
11
10
12
9
11
11
12
12
5
6
6
Item #
*1
2
*3
4
5
6
7
8
9
10
11
12
13
14
15
16
Qty
1
1
4
6
6
6
6
6
2
13
6
60 ft.
8
4
4
4
Description
Plate, Control Panel Mounting Adapter
Starter Assembly 380 V, 50 Hz
Mount Vibration Donut
Lockwasher, 1
Conduit Locknut, NPT
Cord Grip Straight
Reducer Bushing, MPT x FPT
Cable Connector, NPT .51-.81 Dia. Armored
Conduit Elbow, 90 Deg. x FPT
Tie Cable
Decal, Arrow Rotation
Cable Armored 4 Conductor, UL Approved
Flatwasher, M12 Regular, SST
Lockwasher, M12 Regular, SST
Hex Nut, M12, SST
HHCS, M12 x 80 mm Lg., SST
MI-Swaco P/N
9671689
6930007
5859378
05-110
01-184
01-106
5008937
6560030
5030937
8087255
9650367
7906218
05-305
05-306
03-415
04-1147
107
Qty:
1
1
24
2
8
8
2
4
8
8
8
40
24
2
24
2
2
1
1
2
4
8
8
4
4
4
8
4
1
4
1
1
12
12
24
12
4
2
4
4
MI-Swaco P/N
9671790
9671738-01
04-1270
9671681
1305055
1407169
9671815
9671742
05-296
05-307
1493215
05-305
05-306
8420202
03-415
9671679
9671683
9671744
9671745
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
1407144
5895002
1305040
9650360
07-409
9671652-01
3916067
1493003
03-412
05-308
05-309
BM6K80098
BM6K80097
5804004
9650511
Description
Skid Weldment Mongoose Effluent
Basket Assembly, Mongoose PT
HHCS M12 x 45 mm, SS
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
Gate, Skid Slide Mongoose Effluent Design
Bracket, Shipping Metric
Flatwasher M20 Metric, SS
Lockwasher M20 Metric, SS
Screw Hex Hd, SS, M20 x 45 mm
Flatwasher M12 Metric, SS
Lockwasher M12 Split, SS
Decal MI-Swaco
Hex Nut M12 Metric, SS, M12 x 1.75, SS
Weldment, Spring Spool Mongoose Flat Panel
Indicator Pointer Mongoose PT Bolt Flg. Design
Plate, Right Indicator
Plate, Left Indicator
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Nameplate MI-Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip
Cover, Weld Flange 10 PT Mongoose
Gasket Ring ANSI Flange RF 150 LB 10 in
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
Hex Nut M24, Metric, SS
Flatwasher M24, Metric, SS
Lockwasher M24 Split, SS
Label, Lift Point
Label, PE Protective Earth
Boot, Spring
Decal Shipping Bracket Position
108
Item #
Qty
1
2
3
4
5
6
7
8
9
10
11
12
13
1
1
8
36
28
28
28
1
1
4
4
1
32
MI-Swaco
P/N
9671610
9671637-02
5895001
05-277
04-1103
05-270
03-229
9671638-02
5873004
5837001
9671640
9671925
07-415
14
32
1441471
15
BM6K80100
Description
Basket Weldment Mongoose PT
Cover, Removable Mongoose Flat Panel
Wedge Screen Clamping Mongoose 75 Shore D Polyurethane Black
Flatwasher M10 Metric, SS
HHCS M10 x 30 Metric, SS
Lockwasher M10 Split, SS
Hex Nut M10 Metric, SS
Bar, Skirt Retainer
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Drip Lip Basket Mongoose
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS,
Sq. Head
Label, Crush Hands
109
Assembly 9671920:
110
13.4.1:
Qty
8
8
8
8
4
1
1
1
2
3
1
24
6
2
6
8
1
1
12
1
1
2
1
1
1
1
1
1
1
1
1
2
78
24
39
12
31
8
12
2
39
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5008417
5010134
5015029
5015030
5015052
5015053
5068261
8420200
9622220
9622491
9622492
9622582
9650360
9671652-01
9671853
9671926
9671927
9671937
9671938
9671941
9671945
9671968
9697001-12
9677001-13
BM6K80122
05-305
05-308
03-415
03-412
04-1105
04-1270
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB. 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 2 in Snap T-Gasket 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Inlet D-Silter 6T4
Manifold Overflow D-Silter 6T4
Elbow Grooved End 90D Poly 2 in
Nameplate ID Product M-I Swaco
Cover, Weld Flange 10 PT Mongoose
Bracket, Mount D-Silter Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Weldment, 6T4-8T4 Header Box w/o Flange - Mud Cleaner
Plate Cover 6T4, 8T4
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
Label, Do Not Lift
Flatwasher, M12 Regular, SST
Flatwasher M24, Metric, SS
Hex Nut, M12, SST
Hex Nut M24, Metric, SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 45 mm, SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
CVR/Plug- I/O 6 Dia.
Lockwasher M12 Split, SS
Lockwasher M24 Split, SS
13.4.2:
Qty
8
8
8
8
4
1
1
1
1
2
1
32
8
2
1
8
1
16
1
1
1
2
1
1
1
1
1
1
1
1
1
2
78
24
39
12
31
8
12
2
39
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5008417
5010134
5015029
5015030
5015052
5015053
5068261
8420200
9622220
9622485
9622582
9622605
9650360
9671652-01
9671853
9671926
9671927
9671937
9671938
9671941
9671945
9671968
9697001-12
9677001-13
BM6K80122
05-305
05-308
03-415
03-412
04-1105
04-1270
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB. 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 2 in Snap T-Gasket 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Overflow D-Silter
Elbow Grooved End 90D Poly 2 in
Manifold Inlet D-Silter
Nameplate ID Product M-I Swaco
Cover, Weld Flange 10 PT Mongoose
Bracket, Mount D-Silter Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Weldment, 6T4-8T4 Header Box w/o Flange - Mud Cleaner
Plate Cover 6T4, 8T4
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
Label, Do Not Lift
Flatwasher, M12 Regular, SST
Flatwasher M24, Metric, SS
Hex Nut, M12, SST
Hex Nut M24, Metric, SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 45 mm, SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
CVR/Plug- I/O 6 Dia.
Lockwasher M12 Split, SS
Lockwasher M24 Split, SS
Item #
1
2
Qty
1
2
MI-Swaco P/N
9622221
9622312
Description
Liner Feed Urethane
Valve Apex 1/2
113
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
114
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
13.0.1a / 3
13.0.1a / 4
13.1a / 4
13.1a / 5
13.1a / 6
13.1a / 7
13.1a / 8
13.1a / 9
13.1a / 12
13.2a / 4
13.2a / 5
13.2a / 6
13.2a / 20
13.2a / 21
13.2a / 22
13.2a / 23
13.2a / 24
13.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
13.2a / 26
1407144
13.2a / 27
13.2a / 28
13.2a / 32
13.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
13.3a / 3
5895001
13.3a / 9
13.3a / 10
13.3a / 11
13.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
13.3a / 14
32
1447471
13.4.1a / 6
13.4.1a / 7
13.4.1a / 8
13.4.1a / 10
13.4.1a / 11
13.4.1a / 12
13.4.1a / 13
13.4.1a / 14
1
1
2
3
1
24
6
2
2422177
3916067
5010134
5015029
5015030
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
115
Qty
MI-Swaco P/N
13.4.1a / 16
13.4.1a / 17
13.4.1a / 18
13.4.1a / 19
13.4.1a / 30
13.4.1a / 31
13.4.1a / 40
13.5a / 1
13.5a / 2
8
1
1
12
1
1
2
1
2
9622220
9622491
9622492
9622582
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
Description
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Inlet D-Silter 6T4
Manifold Overflow D-Silter 6T4
Elbow Grooved End 90D Poly 2 in
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
CVR/Plug I/O 6 Dia.
Liner Feed Urethane
Valve Apex 1/2
116
13.6.2:
Figure / Item #
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
117
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
13.0a / 3
13.0a / 4
13.1a / 4
13.1a / 5
13.1a / 6
13.1a / 7
13.1a / 8
13.1a / 9
13.1a / 12
13.2a / 4
13.2a / 5
13.2a / 6
13.2a / 20
13.2a / 21
13.2a / 22
13.2a / 23
13.2a / 24
13.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
13.2a / 26
1407144
13.2a / 27
13.2a / 28
13.2a / 32
13.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
13.3a / 3
5895001
13.3a / 9
13.3a / 10
13.3a / 11
13.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
13.3a / 14
32
1447471
13.4.2a / 6
13.4.2a / 7
13.4.2a / 8
13.4.2a / 10
13.4.2a / 11
13.4.2a / 12
13.4.2a / 13
13.4.2a / 14
1
1
1
2
1
32
8
2
2422177
3916067
5010134
5015029
5015030
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
118
Qty
MI-Swaco P/N
13.4.2a / 16
13.4.2a / 17
13.4.2a / 18
13.4.2a / 19
13.4.2a / 30
13.4.2a / 31
13.4.2a / 40
13.5a / 1
13.5a / 2
8
1
12
1
1
1
2
1
2
9622220
9622485
9622582
9622605
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
Description
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Overflow D-Silter
Elbow Grooved End 90D Poly 2 in
Manifold Inlet D-Silter
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
CVR/Plug I/O 6 Dia.
Liner Feed Urethane
Valve Apex 1/2
119
120
Assembly 9671905-02:
Assembly 9671905-03:
Assembly 9671905-04:
Assembly 9671905-05:
14.0.1:
Item #
Qty
1
2
3
4
5
6
7
8
9
1
1
2
1
1
1
1
4
2
MI-Swaco
P/N
9671843
9671688-02
EM3C00010
6905003
9671946
9671947
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
D-Silter Assembly 6T4-212 Header Box PT Mongoose
2-12 D-Sander Assembly Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
121
14.0.2:
Item #
Qty
1
2
3
4
1
1
2
1
MI-Swaco
P/N
9671843
9671975-02
EM3C00010
6905003
9671930
6
7
8
9
1
1
4
2
9671947
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
D-Silter Assembly 8T4 Mongoose PT 2-12 Mud Cleaner w/o
Flange
2-12 D-Sander Assembly Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
122
14.0.3:
Item #
Qty
1
2
3
4
1
1
2
1
MI-Swaco
P/N
9671843
9671975-02
EM3C00010
6905003
9671946
6
7
8
9
1
1
4
2
9671947
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 380V, 50 Hz
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V 0.60 Hp 50 Hz XP Vibrator
D-Silter Assembly 6T4 2-12 Header Box
Mongoose PT Mud Cleaner
2-12 D-Sander Assembly Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
123
14.0.4:
Item #
Qty
1
2
3
4
1
1
2
1
MI-Swaco
P/N
9671843
9671975-01
EM3C00011
6912002
9671946
6
7
8
9
1
1
4
2
9671947
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 440V, 60 Hz
Mtr. 2 Hp 220-240/440-480V, 60/3/1800
Mtr. 230/460V 0.60 Hp 60 Hz XP Vibrator
D-Silter Assembly 6T4 2-12 Header Box
Mongoose PT Mud Cleaner
2-12 D-Sander Assembly Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
124
14.0.5:
Item #
Qty
1
2
3
4
1
1
2
1
MI-Swaco
P/N
9671843
9671975-01
EM3C00011
6912002
9671930
6
7
8
9
1
1
4
2
9671947
9650360
07-409
9671809
Description
Shaker Mongoose PT Effluent Skid Less Motor, Controls
Control Assembly Kit Mongoose PT (3) Mtr. 440V, 60 Hz
Mtr. 2 Hp 220-240/440-480V, 60/3/1800
Mtr. 230/460V 0.60 Hp 60 Hz XP Vibrator
D-Silter Assembly 8T4 Mongoose PT 2-12
Mud Cleaner w/o Flange
2-12 D-Sander Assembly Mongoose PT Mud Cleaner
Nameplate ID Product M-I Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip, 304 SS
Bracket Shipping D-Silter, D-Sander Mongoose PT
125
14.1: Drawings and Parts List per Control Assembly Kit Assemblies
9671688-02 and 9671975-01 and 9671975-02
Assembly 9671688-02:
Assembly 9671975-01:
Assembly 9671975-02:
126
14.1.1:
11
15 14
11
8
13
2x
16
7
8
8
6
6
8
ON BOTTOM OF ITEM 2
11
11
10
12
9
11
11
12
12
5
6
6
Item #
*1
2
*3
4
5
6
7
8
9
10
11
12
13
14
15
16
Qty
1
1
4
6
6
6
6
6
2
13
6
60 ft.
8
4
4
4
Description
Plate, Control Panel Mounting Adapter
Starter Assembly 380 V, 50 Hz
Mount Vibration Donut
Lockwasher, 1
Conduit Locknut, NPT
Cord Grip Straight
Reducer Bushing, MPT x FPT
Cable Connector, NPT .51-.81 Dia. Armored
Conduit Elbow, 90 Deg. x FPT
Tie Cable
Decal, Arrow Rotation
Cable Armored 4 Conductor, UL Approved
Flatwasher, M12 Regular, SST
Lockwasher, M12 Regular, SST
Hex Nut, M12, SST
HHCS, M12 x 80 mm Lg., SST
MI-Swaco P/N
9671689
6930007
5859378
05-110
01-184
01-106
5008937
6560030
5030937
8087255
9650367
7906218
05-305
05-306
03-415
04-1147
127
14.1.2:
11
12 13 14
CABLE ROUTING
A
E
10
7 6
6 7
10
12 1
7
6
10
10
4 3
4 3
10
10
Item #
Qty
Description
MI-Swaco P/N
04-1179
3
4
6
6
6
7
8
9
10
11
12
13
14
*15
6
6
2
13
6
50ft
8
4
4
15
6930008
05-110
01-184
01-106
5008937
6560030
5030937
8087255
9650367
7906218
05-305
05-306
03-415
6592002
128
14.1.3:
11
12 13 14
CABLE ROUTING
A
E
10
7 6
6 7
10
12 1
7
6
10
10
4 3
4 3
10
10
Item #
Qty
Description
MI-Swaco P/N
04-1179
3
4
6
6
6
7
8
9
10
11
12
13
14
*15
6
6
2
13
6
50ft
8
4
4
15
6930020
05-110
01-184
01-106
5008937
6560030
5030937
8087255
9650367
7906218
05-305
05-306
03-415
6592002
129
Qty
1
1
24
2
8
8
2
4
8
8
8
40
24
2
24
2
2
1
1
2
4
8
8
4
4
4
8
4
1
4
1
1
12
12
24
12
4
2
4
4
MI-Swaco P/N
9671790
9671738-01
04-1270
9671681
1305055
1407169
9671815
9671742
05-296
05-307
1493215
05-305
05-306
8420202
03-415
9671679
9671683
9671744
9671745
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
1407144
5895002
1305040
9650360
07-409
9671652-01
3916067
1493003
03-412
05-308
05-309
BM6K80098
BM6K80097
5804004
9650511
Description
Skid Weldment Mongoose Effluent
Basket Assembly, Mongoose PT
HHCS M12 x 45 mm, SS
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
Gate, Skid Slide Mongoose Effluent Design
Bracket, Shipping Metric
Flatwasher M20 Metric, SS
Lockwasher M20 Metric, SS
Screw Hex Hd, SS, M20 x 45 mm
Flatwasher M12 Metric, SS
Lockwasher M12 Split, SS
Decal MI-Swaco
Hex Nut M12 Metric, SS, M12 x 1.75, SS
Weldment, Spring Spool Mongoose Flat Panel
Indicator Pointer Mongoose PT Bolt Flg. Design
Plate, Right Indicator
Plate, Left Indicator
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Nameplate MI-Swaco
Pop Rivet 1/8 D 3/16-1/4 Grip
Cover, Weld Flange 10 PT Mongoose
Gasket Ring ANSI Flange RF 150 LB 10 in
HHCS M24-3.0 x 90 mm MS, Yellow Chromate, GR 8.8
Hex Nut M24, Metric, SS
Flatwasher M24, Metric, SS
Lockwasher M24 Split, SS
Label, Lift Point
Label, PE Protective Earth
Boot, Spring
Decal Shipping Bracket Position
Item #
Qty
1
2
3
4
5
6
7
8
9
10
11
12
13
1
1
8
36
28
28
28
1
1
4
4
1
32
MI-Swaco
P/N
9671610
9671637-02
5895001
05-277
04-1103
05-270
03-229
9671638-02
5873004
5837001
9671640
9671925
07-415
14
32
1441471
15
BM6K80100
Description
Basket Weldment Mongoose PT
Cover, Removable Mongoose Flat Panel
Wedge Screen Clamping Mongoose 75 Shore D Polyurethane Black
Flatwasher M10 Metric, SS
HHCS M10 x 30 Metric, SS
Lockwasher M10 Split, SS
Hex Nut M10 Metric, SS
Bar, Skirt Retainer
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Drip Lip Basket Mongoose
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS,
Sq. Head
Label, Crush Hands
131
Assembly 9671946:
Assembly 9671930:
132
14.4.1:
Qty
8
8
8
8
4
1
1
1
2
3
1
1
24
6
2
1
6
1
1
12
1
1
2
1
1
1
1
1
1
1
1
1
2
78
24
39
12
31
8
12
2
35
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5008417
5010134
5015029
5015030
5015031
5015052
5015053
5068261
8420200
9622220
9622491
9622492
9622582
9650360
9671652-01
9671853
9671926
9671927
9671937
9671938
9671941
9671945
9671955
9697001-12
9697001-13
BM6K80122
05-305
05-308
03-415
03-412
04-1105
04-1270
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB. 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 2 in Snap T-Gasket 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Inlet 6T4 D-Silter ALS Mud Cleaner
Manifold Overflow D-Silter 6T4
Elbow D-Silter 10T4 Poly 2 in Grooved End
Nameplate ID Product
Cover, MS Weld Flange 10 PT Mongoose
Bracket, Mount D-Silter Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Weldment, 6T4-8T4 Header Box w/o Flange - Mud Cleaner
Weldment, Trough 2-12 D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
Label, Do Not Lift
Flatwasher M12 Metric 304 SS
Flatwasher M24 Metric 304 SS
Hex Nut M12 Metric, 304 SS, M12 x 1.75
Hex Nut M24 Metric, 304 SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 45 Metric, 304 SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate Plt. Gr. 10.9 Full Thread
CVR/Plug-I/O 6 Dia. High Grade Nitrile 45-70 Shore A Hardiness
Lockwasher M12 Split 304 SS
Lockwasher M24 Split 304 SS
14.4.2:
Qty
8
8
8
8
4
1
1
1
2
3
1
32
8
2
1
8
1
16
1
1
1
2
1
1
1
1
1
1
1
1
1
2
78
24
39
12
31
8
12
2
39
12
MI-Swaco P/N
1305041
1345041
1345344
1407139
1492031
2422177
3916067
5008417
5010134
5015029
5015030
5015052
5015053
5068261
8420200
9622220
9622485
9622582
9622605
9650360
9671652-01
9671853
9671926
9671927
9671937
9671938
9671941
9671945
9671955
9697001-12
9697001-13
BM6K80122
05-305
05-308
03-415
03-412
04-1105
04-1270
1493003
S48K00827-NL
05-306
05-309
Description
Nut Hex Plt. 5/8-11 NC
Washer Flat Plt. 5/8 in x 1.31 OD
Washer Lock Split Plt. 5/8 in
Screw Hex Hd Cap Plt. 5/8-11 NC x 2
Drs #4 x 5/16 304 SS
Gauge 0-60 PSI/0-400 KPA 2-1/12 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB. 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 2 in Snap T-Gasket 300 PSI
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 PSI 1 NPT
Decal MI-Swaco
Clone Twin 4 Urethane Complete w/ 1/2 Apex
Manifold Overflow D-Silter
Elbow D-Silter 10T4 Poly 2 in Grooved End
Manifold Inlet D-Silter
Nameplate ID Product
Cover, MS Weld Flange 10 PT Mongoose
Bracket, Mount D-Silter Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg HDR Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Weldment Leg Header Box Mud Cleaner w/o Bolt on Flange
Plate, Slider Bypass D-Silter PT Mongoose Mud Cleaner
Weldment, 6T4-8T4 Header Box w/o Flange - Mud Cleaner
Weldment, Trough 2-12 D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 6 in x 5 in Lg.
Nipple Stub Grooved End 8 in x 5 in Lg.
Label, Do Not Lift
Flatwasher M12 Metric 304 SS
Flatwasher M24 Metric 304 SS
Hex Nut M12 Metric, 304 SS, M12 x 1.75
Hex Nut M24 Metric, 304 SS
HHCS M12 x 35 Metric, 304 SS
HHCS M12 x 45 Metric, 304 SS
HHCS M24-3.0 x 90 mm MS, Yellow Chromate Plt. Gr. 10.9 Full Thread
CVR/Plug-I/O 6 Dia. High Grade Nitrile 45-70 Shore A Hardiness
Lockwasher M12 Split 304 SS
Lockwasher M24 Split 304 SS
Item #
1
2
Qty:
1
2
MI-Swaco P/N
9622221
9622312
Description
Liner Feed Urethane
Valve Apex 1/2
135
Qty
1
2
2
4
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
1
1
1
32
4
8
4
16
2
8
4
4
12
2
16
2
8
4
MI-Swaco P/N
00-1614
1289105
1289140
1492031
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9650360
9671953
9671961
9671962
9671964
9671965
9671001-13
9697001-14
05-305
05-276
05-174
05-160
03-415
03-232
03-145
03-404
04-1105
04-1106
04-1451
05-306
05-285
05-176
05-236
Description
Clamping Unit, 5/8 Hose OD, 3 Hose Clamp
U-Bolt CS 8 in Pipe 5/8-11 NC x 11.37 Lg. w/ Nuts
U-Bolt CS 10 in Pipe 3/4-10 NC x 13.75 Lg. w/ Nuts
DRS #4 x 5/8, 304 SS
Gauge 0-60/0-400 KPA 2-1/2 in 1/4 NPT LM
Cuplng Grooved End 4 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 6 in Bolt T-Gasket 1000 PSI
Cuplng Grooved End 8 in Bolt T-Gasket 800 PSI
Cuplng Grooved End 10 in Bolt T-Gasket 800 PSI
Ell Grooved End 90D MI SR Sch 40 6 in
Clone Assembly Urethane 12 in Grooved End
U-Bolt 7-3/8 in ID 5/8-11 NC x 8-3/4 in Lg.
Manifold Feed ALS Mounted 2-12 Slant D-Sander
Manifold Overflow ALS Mounted 2-12 Slant D-Sander
Nameplate ID Product
Weldment, 2-12, 3-12 D-Sander Stand PT Mongoose Mud Cleaner
Bracket, Adjustment D-Sander Clones PT Mongoose Mud Cleaner
Bracket, Mating 2-12 D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Weldment, Upright D-Sander PT Mongoose Mud Cleaner
Nipple Stub Grooved End 8 in x 5 in Lg.
Nipple Stub Grooved End 10 in x 5 in Lg.
Flatwasher M12 Metric 304 SS
Flatwasher M8 Metric 304 SS
Flatwasher 5/8 304 SS
Flatwasher 3/4 304 SS
Hex Nut M12 Metric 304 SS
Hex Nut M8 Metric 304 SS
Hex Nut 5/8-NC 304 SS
Hex Nut 3/4-NC 304 SS
HHCS M12 x 35 Metric 304 SS
HHCS M12 x 40 Metric 304 SS
HHCS M8 x 60 mm Metric 304 SST Hex Head Cap Screw
Lockwasher M12 Split 304 SS
Lockwasher M8 Split 304 SS
Lockwasher 5/8 Split 304 SS
Lockwasher 3/4 Split 304 SST
136
5
1
6
2
6
4
Item #
1
2
3
4
5
6
Qty
1
1
1
1
1
2
Part Number
9621281
9621173
9621175
9621174
9621177
9621176
Description
Feed 12 Feed Section w/ Victaulic End
Body Main 12 Close Urethane
Body Mid 12 Clone Urethane
Valve 1-1/2 Apex Clone Urethane
Clamp V-Band 16.12 I.D., 12 Clone
Clamp V-Band 9.88 I.D., 12 Clone
137
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
138
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
14.0.1a / 3
14.0.1a / 4
14.1.1a / 4
14.1.1a / 5
14.1.1a / 6
14.1.1a / 7
14.1.1a / 8
14.1.1a / 9
14.1.1a / 12
14.2a / 4
14.2a / 5
14.2a / 6
14.2a / 20
14.2a / 21
14.2a / 22
14.2a / 23
14.2a / 24
14.2a / 25
2
1
2
2
1
6
6
6
6
6
2
60 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
14.2a / 26
1407144
14.2a / 27
14.2a / 28
14.2a / 32
14.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
14.3a / 3
5895001
14.3a / 9
14.3a / 10
14.3a / 11
14.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
14.3a / 14
32
1447471
14.4.1a / 6
14.4.1a / 7
14.4.1a / 8
14.4.1a / 9
14.4.1a / 10
14.4.1a / 11
14.4.1a / 12
14.4.1a / 13
14.4.1a / 14
14.4.1a / 15
1
1
1
2
3
1
1
24
6
2
2422177
3916067
5008417
5010134
5015029
5015030
5015031
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 10 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
139
Qty
MI-Swaco P/N
Description
14.4.1a / 17
14.4.1a / 18
14.4.1a / 19
14.4.1a / 20
14.4.1a / 30
14.4.1a / 31
14.4.1a / 41
14.5a / 1
14.5a / 2
14.6a / 1
14.6a / 2
14.6a / 3
14.6a / 5
14.6a / 6
14.6a / 7
14.6a / 8
14.6a / 9
14.6a / 10
14.6a / 11
14.6a / 12
14.6a / 13
14.6a / 14
14.7a / 1
14.7a / 2
14.7a / 3
14.7a / 4
14.7a / 5
14.7a / 6
6
1
1
12
1
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
2
9622220
9622491
9622492
9622582
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289105
1289140
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9621281
9621173
9621175
9621174
9621177
9621176
140
14.8.2:
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
141
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
14.0.2a / 3
14.0.2a / 4
14.1.3a / 3
14.1.3a / 4
14.1.3a / 5
14.1.3a / 6
14.1.3a / 7
14.1.3a / 8
14.1.3a / 11
14.2a / 4
14.2a / 5
14.2a / 6
14.2a / 20
14.2a / 21
14.2a / 22
14.2a / 23
14.2a / 24
14.2a / 25
2
1
2
2
1
6
6
6
6
6
2
50 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
14.2a / 26
1407144
14.2a / 27
14.2a / 28
14.2a / 32
14.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
14.3a / 3
5895001
14.3a / 9
14.3a / 10
14.3a / 11
14.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
14.3a / 14
32
1447471
14.4.2a / 6
14.4.2a / 7
14.4.2a / 8
14.4.2a / 9
14.4.2a / 10
14.4.2a / 11
14.4.2a / 12
14.4.2a / 13
14.4.2a / 14
1
1
1
2
3
1
32
8
2
2422177
3916067
5008417
5010134
5015029
5015030
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
142
Qty
MI-Swaco P/N
Description
14.4.2a / 16
14.4.2a / 17
14.4.2a / 18
14.4.2a / 19
14.4.2a / 30
14.4.2a / 31
14.4.2a / 40
14.5a / 1
14.5a / 2
14.6a / 1
14.6a / 2
14.6a / 3
14.6a / 5
14.6a / 6
14.6a / 7
14.6a / 8
14.6a / 9
14.6a / 10
14.6a / 11
14.6a / 12
14.6a / 13
14.6a / 14
14.7a / 1
14.7a / 2
14.7a / 3
14.7a / 4
14.7a / 5
14.7a / 6
8
1
16
1
1
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
2
9622220
9622485
9622582
9622605
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289105
1289140
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9621281
9621173
9621175
9621174
9621177
9621176
143
14.8.3:
Figure / Item #
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
144
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
14.0.3a / 3
14.0.3a / 4
14.1.3a / 3
14.1.3a / 4
14.1.3a / 5
14.1.3a / 6
14.1.3a / 7
14.1.3a / 8
14.1.3a / 11
14.2a / 4
14.2a / 5
14.2a / 6
14.2a / 20
14.2a / 21
14.2a / 22
14.2a / 23
14.2a / 24
14.2a / 25
2
1
2
2
1
6
6
6
6
6
2
50 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
14.2a / 26
1407144
14.2a / 27
14.2a / 28
14.2a / 32
14.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
14.3a / 3
5895001
14.3a / 9
14.3a / 10
14.3a / 11
14.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
14.3a / 14
32
1447471
14.4.1a / 6
14.4.1a / 7
14.4.1a / 8
14.4.1a / 9
14.4.1a / 10
14.4.1a / 11
14.4.1a / 12
14.4.1a / 13
14.4.1a / 14
1
1
1
2
3
1
1
24
6
2422177
3916067
5008417
5010134
5015029
5015030
5015031
5015052
5015053
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. .625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 10 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
145
Qty
MI-Swaco P/N
Description
14.4.1a / 15
14.4.1a / 17
14.4.1a / 18
14.4.1a / 19
14.4.1a / 20
14.4.1a / 30
14.4.1a / 31
14.4.1a / 41
14.5a / 1
14.5a / 2
14.6a / 1
14.6a / 2
14.6a / 3
14.6a / 5
14.6a / 6
14.6a / 7
14.6a / 8
14.6a / 9
14.6a / 10
14.6a / 11
14.6a / 12
14.6a / 13
14.6a / 14
14.7a / 1
14.7a / 2
14.7a / 3
14.7a / 4
14.7a / 5
14.7a / 6
2
6
1
1
12
1
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
2
5068261
9622220
9622491
9622492
9622582
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289105
1289140
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9621281
9621173
9621175
9621174
9621177
9621176
146
14.8.4:
Figure / Item #
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
147
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
14.0.4a / 3
14.0.4a / 4
14.1.2a / 3
14.1.2a / 4
14.1.2a / 5
14.1.2a / 6
14.1.2a / 7
14.1.2a / 8
14.1.2a / 11
14.2a / 4
14.2a / 5
14.2a / 6
14.2a / 20
14.2a / 21
14.2a / 22
14.2a / 23
14.2a / 24
14.2a / 25
2
1
2
2
1
6
6
6
6
6
2
50 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00010
6905003
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
14.2a / 26
1407144
14.2a / 27
14.2a / 28
14.2a / 32
14.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
14.3a / 3
5895001
14.3a / 9
14.3a / 10
14.3a / 11
14.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
14.3a / 14
32
1447471
14.4.2a / 6
14.4.2a / 7
14.4.2a / 8
14.4.2a / 9
14.4.2a / 10
14.4.2a / 11
14.4.2a / 12
14.4.2a / 13
14.4.2a / 14
1
1
1
2
3
1
1
24
6
2422177
3916067
5008417
5010134
5015029
5015030
5015031
5015052
5015053
Overload Heaters
Fuse
Fuses
Mtr. 1.75 Hp 220-240/380-415V, 50/3/1500
Mtr. 220/380V, 0.60, 50/3/1500
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. 625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 10 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
148
Qty:
MI-Swaco P/N
Description
14.4.2a / 15
14.4.2a / 17
14.4.2a / 18
14.4.2a / 19
14.4.2a / 20
14.4.2a / 30
14.4.2a / 31
14.4.2a / 41
14.5a / 1
14.5a / 2
14.6a / 1
14.6a / 2
14.6a / 3
14.6a / 5
14.6a / 6
14.6a / 7
14.6a / 8
14.6a / 9
14.6a / 10
14.6a / 11
14.6a / 12
14.6a / 13
14.6a / 14
14.7a / 1
14.7a / 2
14.7a / 3
14.7a / 4
14.7a / 5
14.7a / 6
2
6
1
1
12
1
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
2
5068261
9622220
9622491
9622492
9622582
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289105
1289140
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9621281
9621173
9621175
9621174
9621177
9621176
149
14.8.5:
Qty
MI-Swaco P/N
7.1a / A
7.1a / B
7.1a / C
7.1a / D
7.1a / E
7.1a / F
7.1a / H
7.1a / I
7.1a / J
7.1a / L
7.1a / M
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
4
2
1
1
1
1
1
4
2
1
4
2
JMONMK010P
JMONMK020P
JMONMK030P
JMONMK040P
JMONMK024P
JMONMK038P
JMONMK050P
JMONMK070P
JMONMG084P
JMONMG110P
JMONMG140P
JMONMG175P
JMONMG210P
JMONMG250P
JMONMX084P
JMONMX110P
JMONMX140P
JMONMX175P
JMONMX210P
JMONMX250P
JMONHC084P
JMONHC110P
JMONHC140P
JMONHC175P
JMONHC210P
JMONHC250P
JMONHC325P
7573290
7573106
7573105
7790016
7519002
7117005
7150002
7150001
6930009
8071702
7152606
Description
Screen Mesh 10
Screen Mesh 20
Screen Mesh 30
Screen Mesh 40
Screen Mesh 24
Screen Mesh 38
Screen Mesh 50
Screen Mesh 70
Screen Mesh 84 MAGNUM
Screen Mesh 110 MAGNUM
Screen Mesh 140 MAGNUM
Screen Mesh 175 MAGNUM
Screen Mesh 210 MAGNUM
Screen Mesh 250 MAGNUM
Screen Mesh 84 MX
Screen Mesh 110 MX
Screen Mesh 140 MX
Screen Mesh 175 MX
Screen Mesh 210 MX
Screen Mesh 250 MX
Screen Mesh 84 HC-MAGNUM
Screen Mesh 110 HC-MAGNUM
Screen Mesh 140 HC-MAGNUM
Screen Mesh 175 HC-MAGNUM
Screen Mesh 210 HC-MAGNUM
Screen Mesh 250 HC-MAGNUM
Screen Mesh 325 HC-MAGNUM
Reset Buttons
Selector Switch
E-Stop Push-Pull
Transformer (380V)
Fuse Block
Timer
Overload Blocks
Contactors- Non. Rev.
Contactor-Reversing
Mechanical Push Rod
Overload Heaters
150
Qty
MI-Swaco P/N
Description
7.1a / N
7.1a / O
7.1a / P
14.0.5a / 3
14.0.5a / 4
14.1.2a / 3
14.1.2a / 4
14.1.2a / 5
14.1.2a / 6
14.1.2a / 7
14.1.2a / 8
14.1.2a / 11
14.2a / 4
14.2a / 5
14.2a / 6
14.2a / 20
14.2a / 21
14.2a / 22
14.2a / 23
14.2a / 24
14.2a / 25
2
1
2
2
1
6
6
6
6
6
2
50 ft.
2
8
8
2
4
8
8
4
4
7152605
7518022
7518020
EM3C00011
6912002
05-110
01-184
01-106
5008937
6560030
5030937
7906218
9671681
1305055
1407169
S48K00827-NL
9360007
05-244
BM6Y80043-01XB
9671682
05-248
14.2a / 26
1407144
14.2a / 27
14.2a / 28
14.2a / 32
14.2a / 39
8
4
1
4
5895002
1305040
3916067
5804004
14.3a / 3
5895001
14.3a / 9
14.3a / 10
14.3a / 11
14.3a / 13
1
4
4
32
5873004
5837001
9671640
07-415
14.3a / 14
32
1447471
14.4.2a / 6
14.4.2a / 7
14.4.2a / 8
14.4.2a / 9
14.4.2a / 10
14.4.2a / 11
14.4.2a / 12
14.4.2a / 13
14.4.2a / 14
1
1
1
2
3
1
32
8
2
2422177
3916067
5008417
5010134
5015029
5015030
5015052
5015053
5068261
Overload Heaters
Fuse
Fuses
Mtr. 2 Hp 220-240/440-480V, 60/3/1800
Mtr. 230/460V 0.60 Hp 60 Hz XP Vibrator
Lockwasher 1 SHKPRF Ext. MS
Locknut Electrical 3/4
Cord Grip 3/4 NPT St. 625-.750 Range Alum. Male
Bushing Conduit Redcr. EP 3/4 MPT x 1/2 FPT
Connector Cable EP 1/2 NPT, .51-.81 Dia. Armored
Ell. Conduit EP 90 3/4 MPT x 3/4 FPT
Cable Armored 4 Cond. 12 AWG w\ Jacket
Jack Assembly Lifting
Nut Hex Plt. M20-1.5 Grade 10.9, Yellow Chromate
Screw Hex Hd. Plt. M20-1.5 x 120 mm, Yellow Chromate
CVR/Plug- I/O 6 Dia.
Spring Coil 7 inch Inline Shaker
Lockwasher Schnorr M20 Metric Motor Washer
Motor Washer, SS
Washer, 16 mm Motor
Lockwasher Schnorr, M16 Metric Motor Washer
Screw Hex HD Plt. M16-1.5 x 100 mm, Grd. 10.9 Yellow
Chromate
Washer Spring Isolation High Grade Nitrile 70 Shore A
Nut Hex Plt. M16-1.5, Grd. 10.9 Yellow Chromate
Gasket Ring ANSI Flange RF 150 LB 10 in
Boot, Spring
Wedge Screen Clamping Mongoose 75 Shore D
Polyurethane Black
Skirt Mongoose Feed End High Grade Nitrile 80 Shore A
Gasket Compression P Screen Bed Mongoose
Weldment, Screen Gasket Hold Down Bar
Grommet Screw .273 Sq. Panel Hole, Panel Thk. 0.31-.156
Screw Flat HD CRSK Sheet Metal 8-32 x 1 Lg., SS, Sq.
Head
Gauge 0-60 PSI / 0-400 KPa 2-1/2 in 1/4 NPT LM
Gasket Ring ANSI Flange RF 150 LB, 10 in
Bushing Reducer Galv. 150 PSI 1/2 x 1/4 NPT
Cap Grooved End 6 in
Cuplng Grooved End 6 in Bolt T-Gasket 1000 psi
Cuplng Grooved End 8 in Bolt T-Gasket 800 psi
Cuplng Grooved End 2 in Bolt T-Gasket 300 psi
Cuplng Grooved End 2-1/2 in Snap T-Gasket
Plug SQ Hd. Galv. 150 psi 1 NPT
151
Qty
MI-Swaco P/N
Description
14.4.2a / 16
14.4.2a / 17
14.4.2a / 18
14.4.2a / 19
14.4.2a / 30
14.4.2a / 31
14.4.2a / 40
14.5a / 1
14.5a / 2
14.6a / 1
14.6a / 2
14.6a / 3
14.6a / 5
14.6a / 6
14.6a / 7
14.6a / 8
14.6a / 9
14.6a / 10
14.6a / 11
14.6a / 12
14.6a / 13
14.6a / 14
14.7a / 1
14.7a / 2
14.7a / 3
14.7a / 4
14.7a / 5
14.7a / 6
8
1
16
1
1
1
2
1
2
1
2
2
1
2
4
1
1
2
2
2
1
1
1
1
1
1
1
2
9622220
9622485
9622582
9622605
9697001-12
9697001-13
S48K00827-NL
9622221
9622312
00-1614
1289105
1289140
2422177
5015026
5015029
5015030
5015031
5030860
9621280
9621289
9621379
9621380
9621281
9621173
9621175
9621174
9621177
9621176
152
Appendix
153
154