Академический Документы
Профессиональный Документы
Культура Документы
GD663A-2
1001 and up
For GD663A-2, see pages prepared for GD623A-1 except two descriptions below.
1) Front axle (page 41-9) 1. Steering cylinder has both types of single cylinder and dual cylinder.
2) For rear mount ripper, see page 74-9.
2011 7
All Rights Reserved
Printed in Japan 08-11(01)
00-1
o
o
o
o
o
74- 9
GD663A-2
Outline
Ripper lifting height and digging depth can be
controlled with ripper cylinder (4). Since the point
tips cut into the ground under the load of the ripper's
heavy weight, the ripper easily performs heavy-duty
digging work that cannot be done by the scarifier.
1. Bracket
2. Rod
3. Shank
4. Ripper cylinder
Unit: mm
No.
Check Item
Criteria
Standard
Size
50
60
60
Point wear
GD610, 620
GD660, 670
Tolerance
Shaft
Hole
-0.025
-0.050
-0.030
-0.076
-0.100
-0.174
+0.142
+0.080
+0.054
0
+0.174
+0.100
Remedy
Standard
Clearance
Clearance
Limit
0.105 to 0.192
0.5
0.03 to 0.13
0.5
0.200 to 0.348
0.5
Standard Size
Repair Limit
290
150
Replace
74-9
o
90
OTHERS
GD610, 620
GD660, 670
90-1
8
AIR CONDITIONER
(if equipped)
AIR CONDITIONER PIPING
H Type (Refrigerant: for R134a)
SYSTEM DIAGRAM
1.
2.
3.
4.
5.
6.
7.
A. Vent
90-2
8
GD610, 620
GD660, 670
3. Connector
4. Refrigerant gas outlet port
1.
2.
3.
4.
SPECIFICATIONS
Type: Piston pump type
Refrigerant used: R134a
GD610, 620
GD660, 670
90-3
8
DRY RECEIVER
1. Cap
2. Body
3. Drier
90-4
8
GD610, 620
GD660, 670
GD610, 620
GD660, 670
90-5
8