Академический Документы
Профессиональный Документы
Культура Документы
INTERFACE
Data Sheet
2720_en_C
1
Description
Features
WirelessHART gateway supports up to 250
WirelessHART devices
Integrated 802.11b/g with 802.11i security
Converts HART to Modbus TCP
Simple programming via embedded web server
128-bit AES encryption
WEP, WPA or WPA2/802.11i encryption
RAD-WHG/WLAN-XD
Ordering Data
Products
Description
Gateway, WirelessHART with integrated 802.11b/g and Modbus TCP
conversion
Accessories
Description
Type
Order No.
Pcs./Pkt.
RAD-WHG/WLAN-XD
2900178
Type
Order No.
Pcs./Pkt.
RAD-ISM-2400-ANT-OMNI-6-0
2885919
RAD-ISM-2400-ANT-VAN-3-0-SMA
2885867
RAD-ISM-2400-ANT-PAR-19-0
2867885
RAD-CAB-EF393-3M
2867649
CN-LAMBDA/4-5.9-BB
2838490
RAD-ADP-RSMA/F-SMA/F
2884538
Technical Data
General Data
Material
Degree of protection
IP20
Mounting
NS 35
Mounting position
Any
Dimensions (W x H x D)
45 x 99 x 114.5 mm
Weight
215 g
Operating temperature
-40 70C
Storage temperature
-40 85C
10 90%
Electrical Data
Nominal voltage
24 V DC
Supply voltage
9 30 V DC
4.1 W
7.2 W
2.40002.4835 GHz
Channel separation
5 MHz
Number of channels
15
Transmission power
0 10 dBm
Receiver sensitivity
-90 dBm
Antenna connection
RP-SMA female
LEDs
Status
2720_en_C
PHOENIX CONTACT
RAD-WHG/WLAN-XD
Channel separation
5 MHz
Number of channels
13
Transmission power
802.11b
+17 dBm
802.11g
Receiver sensitivity
802.11b
802.11g
Antenna connection
Ethernet Interface
Port connection
Transmission rate
HART Interface
Connection
Test loops
Signal
HART FSK
Indicators
ST (green)
MESH (green)
LINK (green)
On - LAN connected
DATA (yellow)
ERR (red)
Off - no errors
On - internal error
RF LINK (green)
On - WLAN connected
Flashing - No WLAN link
RF DATA (yellow)
30 V DC
150 mA
0 3.5 V DC
Approval/Conformance
Conformance
99/5/EC
2006/95/EC
2004/108/EC
94/9/EC
60079-0, 60079-15
ATEX
IECEx
2720_en_C
PHOENIX CONTACT
RAD-WHG/WLAN-XD
Application Examples
Host
Ethernet
ST
1
MESH
B(-)
A(+)
B(-)
10/100
A
+24V GND
LINK
Power
FLBL-3104-03R1
ANT 1
ERR
ANT 2
+24V GND A
Power
RF Link
A(+)
Transmit Transmit
STATUS
RS-485 RX
RS-485 TX
RF Link
RS-232 RX
RF LINK
RS-232 TX
RF DATA
WAN SPEED
5
9
4
WAN LINK
8
3
7
2
6
1
RSSI
RAD-80211-XD/HP-BUS
WLAN Access
Point
ST
MESH
10/100
LINK
ERR
+24V GND A
Power
Figure 1
RF Link
Ethernet
Host
ST
MESH
10/100
LINK
ERR
+24V GND A
Power
Figure 2
2720_en_C
RF Link
PHOENIX CONTACT
RAD-WHG/WLAN-XD
Installation Notes
WARNING:
Correct usage in potentially explosive areas.
The device is not designed for use in
atmospheres with a danger of dust
explosions.
Observe the specified conditions for use in
potentially explosive areas.
Install the device in housing (control or
distributor box) that meets the requirements
of EN/IEC 60079-15 and has at least IP54
protection (EN/IEC 60529).
Only passive antennas may be operated on
the devices.
When installing and connecting the supply
and signal circuits, observe the requirements
of EN/IEC 60079-14. Only devices which are
designed for operation in Ex zone 2 and are
suitable for the conditions at the installation
location may be connected to the circuits in
zone 2.
2720_en_C
PHOENIX CONTACT GmbH & Co. KG 32823 Blomberg Germany Phone: +49-(0) 5235-3-00
PHOENIX CONTACT P.O. Box 4100 Harrisburg PA 17111-0100 USA Phone: +717-944-1300
www.phoenixcontact.com