Академический Документы
Профессиональный Документы
Культура Документы
SUBMISSION
Submission of report to COMSATS Institute of Information Technology
Abbottabad as a partial fulfillment of requirements for the award of the
Degree of Bachelors of Science in Electrical Engineering.
DEDICATION
We dedicate our dissertation work to our loving parents, whose words of
encouragement and push for tenacity ring in our ears and never failed to
give us financial support for giving all our needs during the time of Degree.
We also dedicate our dissertation to our supervisor. His sage advice,
insightful criticisms, and patient encouragement aided the project in
innumerable ways.
We also dedicate this work and give special thanks to supporting teachers
and friends for being there for us throughout the entire bachelor program
DECLARATION
We hereby declare and certify that this thesis is our own work and that, to
the best of our knowledge and belief, it contains no material previously
published or written by another person nor material which to a substantial
extent has been accepted for the award of any other degree or diploma of
the university or other institute of higher learning, except due
acknowledgment has been made in the text.
ACKNOWLEDGMENTS
ABSTRACT
Nowadays, providing preventive measures is one of the challenging matters
in the world. Either it is a bank or institutions or home or real estates, the
preventive measures are most important. Among the several field, providing
the preventive measures system for voting are the tedious and expensive
one. In order to provide the inexpensive solutions to the above, the Finger
Print and RFID reader Based Electronic voting machine project is developed.
This provides the security by means of finger prints and RFID tag numbers
which are stored already in the data base. Then the finger prints which is
stored in the data base is checked. Only if both the persons and the voters
finger print are the same then the voting machine is enabled. This finger
print matching is done with the help of finger print built-in application. If
person with the correct RFID number and existed finger print is trying to vote
so he is then allowed to cast his/her vote. Nowadays with the rise in
population the need for checking the validity of the voters has become a
problem. With the Arduino based finger print technique the task looks much
simpler and also the accuracy is high. So this system provides the cost
effective as well as reliable security for the users.
Table of Contents
SUBMISSION
III
FINAL APPROVAL IV
DEDICATION
DECLARATION
VI
ACKNOWLEDGEMENTS VII
ABSTRACT VI
CHAPTER 01
1.1 OBJECTIVE 2
1.2 WORKING
3
1.3 BACKGROUND
INTRODUCTION
CHAPTER 02
HARDWARE IMPLEMENTATION
2.1 PROJECT DESIGN 4
2.2 BLOCK DIAGRAM 5
2.3 HARDWARE DESCRIPTION 6
2.3.1
ARDUINO UNO
6
2.3.2
RFID 15
2.3.3
FINGERPRINT IDENTIFICATION MODULE22
2.3.4
ARDUINO ETHERET SHIELD
26
2.3.5
XBEE SHIELD
29
CHAPTER 03
SOFTWARE 30
3.1 FLOW CHART
31
3.2 ARDUINO PROGRAMMING 31
3.3 UDP (USERS DATAGRAM PROTOCOL)
3.4 MYSQL
40
3.5 ASP.NET
41
CHAPTER 04
4.1 RESULTS
43
4.2 CONCLUSION
4.3 ADVANTAGES
4.4 APPLICATIONS
4.5 FUTURE SCOPE
APPENDIX 46
36
ARDUINO CODING 46
A.1
SLAVE ARDUINO
46
A.2
MASTER ARDUINO 57
C# CODING 65
SNAPSHOTS
46
REFERENCES
72