Академический Документы
Профессиональный Документы
Культура Документы
Chapter 3
i~
Oil derricks
Window awnings for Group R-3 and U Occupancies when projecting not
more than 54 inches
USE
Heavy streams
Fire Department
Trained p r onn I
Cl
s ii
C lass Ill
INTENDED
Small streams
Building occiJpants
Incipient fire
Both of abov
LOCATION
- . ---
MINIMUM
WATf:R SUPPLY
2-1/2-inch connections.
1-112-inch connections.
Same as Class I
Floor
Fire-Resistive
Floor/Ceiling
Assembly
Protective Ceiling
Membrane with
Protected Openings
per Section 710.3
1. Individual protection not r quir d for be m which support only one floor
or roof.
2. Individual protection required for beams which support loads from a floor and
roof, or more than one floor.
3. All columns requiring fire protection must be protected for their full height.
Table 7-A
Item No. 2-1.2
Steel Beams and Girders
Anchor mesh to top plate
Minimum thickness
3 Hr.
2 Hr.
1 Hr.
2-1 /2
1-1/2
J? '~
\
\
*36 11
Minimum
42 11
~I
Minimum
Greater than
30" above grade
*Exception for R-3 and U-1 Occupancies and within dwelling
units or guests rooms of R-1 occupancies
,, I '
'
.
30 inches
minimum
'
'
ROOF
-
'
~.
,.J---L.,
::c:=:::r:
FOUNDATION
>
., ',
AR EA
SEPARATION
WALL
.,,
TYPE OF
OCCUPANCY
SEPARATION
MINIMUM
FIRE-RES ISTIVE
CONSTRUCTION
___
MINIMUM
OPENING
. PROTECTION .
AMOUNT OF
OPENING
PROTECTION
FOUR-HOUR
FIRE-RESISTIVE
FOUR~HOUR .
NO OPENINGS
PERMllTED
NO OPENINGS
PERMITTED
---
THREE-HOUR
THREE-HOUR
THREE-HOUR1
FIRE-RESISTIVE
TWOHOUR
FIRE-RESISTIVE
1WO-HOUR
ONE-HOUR
FIRE-RESISTIVE
ONE-HOUR
ONE AND
MAXIMUM
25'% OF WALL LENGTH
AND MAXIMUM
UNLIMITED
ONE-HALF-HOUR
ONE-HOUR
UNLIMITED
1 Applies only to openings in walls. All openings in floors shall be protected by vertical
enclosures extending above and below such openings. The walls of such vertical
enclosures shall be of not less than mo-hour fire-resistive construction and all
openings therein shall be protected by a fire assembly having a one and one-half-hour
fire-protection rating. See exception for use of a three-hour enclosure below the
occypancy separation and a one~hour enclosure above the separation .
. /"\
34" CLEAR
20 CLEAR
.I
11
MINIMUM
,,.".!
~;"///
,,
,,
~
OPE
NAB LE
/
AREA
411.1 CLEAR
r'
'
'
,..--;;-i
>-
.,..."'
MINIMUM SIZE
WINDOW FOR
20 11 CLEAR WIDTH
24 11
CLeAR
MINIMUM
',
SILL HEIGHT
44" MAXIMUM
FLOOR
Bleeping Room
Living Room
~
Smoke detector
centrally located
in corridor
Sleeping Room
Bsth
Dining
Room
Kitchen
Fl replace
Opening
2 6 Sq . Ft.
Fireplac
Opening
< 6 Sq. Ft.
)
WOOD FRAMING
MEMBERS (OR ANY
COMBUSTIBLE MATERIAL)
WOOD
ST UD
D
MINIMUM
FRO NT
VIEW
P LAN
VI EW
-=-~ 6"min .
Combustible
Trim, etc.
--- 2"
MINIMUM
'
'
!'
'I
'
1,
'
1'
'
'
'
''
10" min.
an min.
if firebrick
1/4ii max.
joints
2011 min.,
depth
I '
'. '".
\'
Fa$tener sJacing
Nails - 7" max~
Ceiling:
)
Ceiling Joists, ~
- ~Typical
Fastener Spacing
at Sidewalls:
Nails - 8" max.
Gypsum Board
Parallel to
Studs - - -1-H--+---H-
Gypsum Board Perpendicular to Studs
, r---.
---WOOD
SUBFLOOR
WOOD JOLSTS,
TYPICAL
FINISHED
GRADE
WOOD
GIRDER
1111 1111 1111
11111111
:Z
co
,....~
NATURAL
GRADE
FOOTING
UNDER-FLOOR
CLEARANCE
* WHERE FLOOR ASSEMBLIES ARE LESS THAN THE MINIMUM DIMENSIONS NOTED
FOR WOOD FLOOR JOISTS AND GIRDERS, THE ENTIRE FLOOR ASSEMBLY SHALL
BE APPROVED WOOD OF NATURAL RESISTANCE TO DECAY AS LISTED IN
SECTION 2306.4, OR TREATED WOOD.
Handrail
)
12 11
Min.
34" to 38"
12"
Min.
34 11
to 38 11
11" min.
9" min. for
private stairways
serving
<1O occupants
4" min.
7" max.
Handrails
44 11 Minimum
...
Occupant Load of 50 or More
3611 Minimum
_,,.
Occupant Load of 49 or Less "
.. Width
Determined Par 1003.2