Академический Документы
Профессиональный Документы
Культура Документы
DESCRIPTION
Matt waterborne acrylic latex paint for use on interior walls and ceilings.
EXAMPLES OF USE
Plaster, concrete, wood, building blocks, gypsum boards and MDF, etc.
Optiva Matt Acrylic can also be used on primed metal and for repainting
interior surfaces previously coated with waterborne and alkyd paints.
TECHNICAL DATA
Colour Range
SPECIFICATIONS
Preparation
Surfaces must be clean, dry and free from grease, dirt, oil, wax, rust, all
loose material and surface contamination. Use recommended products for
mould removal and cleaning. Use suitable fillers for filling cracks, nail
holes, blemishes, etc., and leveling of uneven surfaces. Ensure that
existing glossy, gloss painted and filled surfaces are thoroughly flatted
down. Ensure that all surfaces are thoroughly prepared prior to priming
and painting.
Priming
Prime unpainted wall and ceiling surfaces overall and spot prime all bare
areas on previously painted walls and ceilings with Optiva Matt Acrylic
thinned by 10% with water. Prime all bare wood with Optiva Primer
Undercoat and bare metal surfaces with Optiva Metal Primer.
APPLICATION
Methods: Brush, roller or spray. For airless spray use a 0.015 0.021
spray tip.
Thinning:If necessary by up to 5% with water as a priming coat.
Painting Conditions
All surfaces to be painted must be dry, the temperature of the air at least
+5OC and the relative humidity of the air below 80%.
Painting
Stir the paint thoroughly and apply one or two coats of Optiva Matt Acrylic,
depending upon the condition of the substrate and possible colour change.
Always apply two coats onto surfaces which have only been primed.
Coverage
7-10m2/litre per coat. Wet film thickness approximately 100-140 m per coat,
dry film approximately 40-60m per coat. The above should only be used as
a guide as actual spreading rates will depend upon many factors including
texture, porosity and application method.
Manufacturer: TIKKURILA POLSKA S.A., ul: Mo cickiego 23, 39- 200 D bica, POLAND tel: + 48 14 680 56 00
Drying Times
At 23OC and 50% relative humidity of the air: normally touch-dry in 2 hour
and recoatable after 4 hours.
Cleaning of Tools
ENVIRONMENTAL
STORAGE AND
TRANSPORT
The above information, based on laboratory tests and practical experience, has been proved valid at the date marked on the product data sheet.
The quality of the product is ensured by our operational system, based on the requirements of ISO 9001 and ISO 14001. As a manufacturer we
cannot be responsible for any damages caused by using the product against our instructions or for inappropriate purposes.
For further information or advice contact: Valtti Specialist Coatings Ltd, Telephone (+44) 0131 334 4999 Fax (+44) 0131 334 3987