Академический Документы
Профессиональный Документы
Культура Документы
Page 1 of 3
Locate topic
Vectorization settings are some of the most important components of the ArcScan extension. These settings allow you to dictate which raster data can be
vectorized and how the geometry of output vector data should be constructed. No other settings in ArcScan have an impact on the outcome of the rasterto-vector conversion as do the vectorization settings.
Vectorization settings apply to both raster tracing and automatic vectorization. When performing raster tracing, you can see how the settings are applied as
you trace over the raster cells. In automatic vectorization the same will apply on even a larger scale, since a considerable portion of the raster layer will be
vectorized, if not the entire layer. The vectorization settings can be entered and applied through the modeless Vectorization Settings dialog box. You can
make changes to these settings and see the effects immediately in the map by clicking the Apply button when the Show Preview command is enabled.
Once you have established the appropriate settings for your data, you can proceed with the vectorization. The settings that you established can be saved
as styles and reused on similar data.
7/29/2015
Page 2 of 3
Compression tolerance = 1
Compression tolerance = 10
Smoothing weight = 1
Smoothing weight = 3
Smoothing weight = 10
7/29/2015
Page 3 of 3
Hole size = 0
Hole size = 5
During vectorization tracing between points, a corner will be resolved but the trace will not stop at that location.
During automatic vectorization, the corner will be resolved and it will be the start/end point of features generated around that point.
Unresolved corners
Resolved corners
Related Topics
Changing the ArcScan vectorization settings
Loading a vectorization style
Copyright 1995-2012 Esri. All rights reserved.
7/29/2015