Академический Документы
Профессиональный Документы
Культура Документы
R07
Set No. 2
Figure 3b
4. (a) What are the advantages and disadvantages of push pull configuration? Show
that in Class-B push pull amplifier the maximum conversion efficiency is 78.5%
[8]
1
R07
Set No. 2
[8]
5. (a) Explain why voltage regulators are required for a DC power supply operating
from an AC source?
(b) If the DC output voltage is 600V with no load attached to power supply but
decreased to 400V at full-load find the percentage voltage regulation?
(c) For the circuit shown in figure5. If Vz=10V, =100 and RL =100ohms. Find
the load voltage and load current .Assume VBE =0.5V and the zener operates
in the breakdown region.
[6+4+6)
Figure 5
6. (a) Draw the Gain versus Frequency response of uncompensated and high frequency compensated CE wide band amplifier assuming that the lower 3-dB
frequency is zero.
(b) Explain High frequency compensation and what are the methods provided to
achieve High frequency compensation in a CE amplifier?
[8+8]
7. (a) What is square law distortion? what is its effect in FET amplifiers? Compare
important characteristics of CD, CS, and CG FET amplifiers.
(b) A self biased CE amplifier circuit has RS = 10K, R1 = 100 K, R2 = 10 K, RC
= 5K, RE = 1K Find AI , AV , AV S and Ri . The h-parameters of the transistor
are hfe = 50, hie = 1.1K, hre = 2.510 - 4 , hoe = 25 A/V. Shown in figure
7b.
R07
Set No. 2
Figure 7b
8. (a) Explain the significance of Low Pass Filter in Switching Regulator
(b) What are the limitations of Switching Regulators?
(c) Why switching frequencies are limited in Switching regulator and also explain
how to overcome this.
[6+4+6]
?????
R07
Set No. 4
Figure 1b
2. (a) Explain why voltage regulators are required for a DC power supply operating
from an AC source?
(b) If the DC output voltage is 600V with no load attached to power supply but
decreased to 400V at full-load find the percentage voltage regulation?
(c) For the circuit shown in figure2. If Vz=10V, =100 and RL =100ohms. Find
the load voltage and load current .Assume VBE =0.5V and the zener operates
in the breakdown region.
[6+4+6)
R07
Set No. 4
Figure 2
3. (a) What is square law distortion? what is its effect in FET amplifiers? Compare
important characteristics of CD, CS, and CG FET amplifiers.
(b) A self biased CE amplifier circuit has RS = 10K, R1 = 100 K, R2 = 10 K, RC
= 5K, RE = 1K Find AI , AV , AV S and Ri . The h-parameters of the transistor
are hfe = 50, hie = 1.1K, hre = 2.510 - 4 , hoe = 25 A/V. Shown in figure
3b.
Figure 3b
4. (a) Draw the Gain versus Frequency response of uncompensated and high frequency compensated CE wide band amplifier assuming that the lower 3-dB
frequency is zero.
(b) Explain High frequency compensation and what are the methods provided to
achieve High frequency compensation in a CE amplifier?
[8+8]
5. (a) Differentiate between a tuned voltage amplifier and a basic voltage amplifier.
Draw the circuits of both of them. Also draw their frequency responses?
(b) Explain why tuned amplifiers cannot be used for amplification of low frequencies?
[10+6]
6. (a) Derive various Resistive parameters of Hybrid - model of a transistor in
terms of h parameters.
5
R07
Set No. 4
[8]
R07
Set No. 1
(c) For the circuit shown in figure3. If Vz=10V, =100 and RL =100ohms. Find
the load voltage and load current .Assume VBE =0.5V and the zener operates
in the breakdown region.
[6+4+6)
Figure 3
4. (a) What are the advantages and disadvantages of push pull configuration? Show
that in Class-B push pull amplifier the maximum conversion efficiency is 78.5%
[8]
(b) A transistor in a transformer coupled (Class - A) power amplifier has to deliver
a maximum of 5 Watts to a load of 4 load. The quiescent point is adjusted for
symmetrical swing, and the collector supply voltage is VCC =20 Volts. Assume
Vmin =0 volts.
R07
Set No. 1
[8]
5. (a) What is square law distortion? what is its effect in FET amplifiers? Compare
important characteristics of CD, CS, and CG FET amplifiers.
(b) A self biased CE amplifier circuit has RS = 10K, R1 = 100 K, R2 = 10 K, RC
= 5K, RE = 1K Find AI , AV , AV S and Ri . The h-parameters of the transistor
are hfe = 50, hie = 1.1K, hre = 2.510 - 4 , hoe = 25 A/V. Shown in figure
5b.
Figure 5b
6. (a) Explain the significance of Low Pass Filter in Switching Regulator
(b) What are the limitations of Switching Regulators?
(c) Why switching frequencies are limited in Switching regulator and also explain
how to overcome this.
[6+4+6]
7. (a) Differentiate between a tuned voltage amplifier and a basic voltage amplifier.
Draw the circuits of both of them. Also draw their frequency responses?
(b) Explain why tuned amplifiers cannot be used for amplification of low frequencies?
[10+6]
8. (a) State Millers theorem. Explain its significance in transistor circuit analysis.
(b) For the amplifier shown in figure8b, calculate Ri , Ro , AV , AV S and AI = - I2 / I1 .
The h-parameter values are hfe = 50, hie = 1.1K, hre = 2.5x10 - 4 , hoe = 24 A/V.
R07
Figure 8b
?????
Set No. 1
R07
Set No. 3
Figure 1b
2. (a) Explain why voltage regulators are required for a DC power supply operating
from an AC source?
(b) If the DC output voltage is 600V with no load attached to power supply but
decreased to 400V at full-load find the percentage voltage regulation?
(c) For the circuit shown in figure2. If Vz=10V, =100 and RL =100ohms. Find
the load voltage and load current .Assume VBE =0.5V and the zener operates
in the breakdown region.
[6+4+6)
10
R07
Set No. 3
Figure 2
3. (a) Differentiate between a tuned voltage amplifier and a basic voltage amplifier.
Draw the circuits of both of them. Also draw their frequency responses?
(b) Explain why tuned amplifiers cannot be used for amplification of low frequencies?
[10+6]
4. (a) Explain the significance of Low Pass Filter in Switching Regulator
(b) What are the limitations of Switching Regulators?
(c) Why switching frequencies are limited in Switching regulator and also explain
how to overcome this.
[6+4+6]
5. (a) What are the advantages and disadvantages of push pull configuration? Show
that in Class-B push pull amplifier the maximum conversion efficiency is 78.5%
[8]
(b) A transistor in a transformer coupled (Class - A) power amplifier has to deliver
a maximum of 5 Watts to a load of 4 load. The quiescent point is adjusted for
symmetrical swing, and the collector supply voltage is VCC =20 Volts. Assume
Vmin =0 volts.
i. What is the transformer turns ratio?
ii. What is the peak collector current?
[8]
6. (a) State Millers theorem. Explain its significance in transistor circuit analysis.
(b) For the amplifier shown in figure6b, calculate Ri , RI , AV , AV S and AI = - I2 / I1 .
The h-parameter values are hfe = 50, hie = 1.1K, hre = 2.5x10 - 4 , hoe = 24 A/V.
11
R07
Set No. 3
Figure 6b
7. (a) Derive various Resistive parameters of Hybrid - model of a transistor in
terms of h parameters.
(b) What is the relationship between fT and f ? Discuss the significance of fT .
[12+4]
8. (a) Draw the Gain versus Frequency response of uncompensated and high frequency compensated CE wide band amplifier assuming that the lower 3-dB
frequency is zero.
(b) Explain High frequency compensation and what are the methods provided to
achieve High frequency compensation in a CE amplifier?
[8+8]
?????
12