Академический Документы
Профессиональный Документы
Культура Документы
A. An indicating
B. A recording
C. An integrating
D. A dc meter
B. Increases
C. Decreases
D. Becomes zero
A. Iron-wave
B. Dynamometer
C. D Arsonval
D. Moving iron
A. Wattmeter
B. Voltmeter
C. Ammeter
D. Ohmmeter
A. Rest
B. Mid-position
C. Maximum position
D. Three-fourth position
A. Analog instrument
B. Digital instrument
C. Ammeter
D. Voltmeter
A. Controlling torque
B. Damping torque
D. Frictional torque
A. Never
C. If it blows
A. Copper
B. Silver
C. Aluminum
D. Gold
12. The time interval that a waveform is high (or low) is the _______ of the
signal.
A. Pulse width
B. Pulse length
C. Pulse position
D. Duty cycle
A. the ratio of resistors on one side of the bridge is one while the
ratio of resistors on the other side is infinity
B. the ratio of resistors on one side of the bridge is greater than the
ratio of resistors on the other side
A. Deflecting torque
B. Controlling torque
C. Damping torque
D. Frictional
A. Deflecting force
B. Damping force
C. Return-to-zero force
D. Controlling force
A. Damping force
B. Controlling force
C. NRZ force
D. Deflecting force
17. All voltmeters except one of the following are operated by the passage
of current.
A. Moving-iron
B. Dynamometer
C. Electrostatic
A. Pulse frequency
B. Pulse delay
C. Pulse duration
D. Pulse period
A. instantaneous
B. rms
C. peak to peak
D. average
A. Resistor
B. Transistor
C. Semiconductor
D. Fuse
A. Diode sensor
B. Thermocouple sensor
C. Thermal sensor
D. Thermistor sensor
A. uniform
B. squared
C. logarithmic
D. exponential
A. horizontal
B. diagonal
C. vertical
A. Dynamometer wattmeter
C. Hot-wire ammeter
D. Capacitor
A. ac work only
C. dc work only
28. What CRT element provides for control of the number of electrons
passing farther into the tube?
A. Cathode
B. Control grid
C. Anode
D. Phosphor screen
A. Logarithmic nulling
B. Orthogonal nulling
C. Exponential nulling
D. Linear nulling
30. When the vertical input is 0V, the electron beam may be positioned at
the _______ of the screen
A. top center
B. vertical center
C. horizontal center
D. bottom center
31. What is the reason why the scale of a permanent-magnet moving coil
instrument is uniform?
A. Thermal converters
B. Thermal sensors
C. Thermocouple sensors
D. Diode sensors
A. Voltmeter
B. Signal generator
C. Grid-dip meter
D. Absorption meter
A. Constantan
B. Silver
C. Aluminum
D. Manganin
A. 10 ma
B. 1 ma
C. 1A
D. 1 A
A. dc ammeter
B. wattmeter
C. dc voltmeter
D. ohmmeter
A. D Arsonal movement
B. Dynamometer
C. Moving-iron
D. Iron-wave
A. Moving-cell instruments
B. Moving-iron instruments
C. Electrodynamic instruments
D. Dynamometer
A. negligible
B. negative
C. positive
D. infinite
A. trigger adjust
B. scale
C. infinite adjust
D. zero adjust
A. intensity control
B. focus control
C. astigmatism control
D. position control
43. What force in analog instrument quickly brings the moving system to
rest in its final position?
A. Damping force
B. Controlling force
C. Deflecting force
D. Force at rest
A. 0.02004
B. 0.20004
C. 1
D. 2.04
A. Temperature variation
B. Hysteresis
D. Temperature inversion
A. 0.1 W to 10 mW
B. 0.1 pW to 10 mW
C. 0.1 mW to 100 W
D. 0.1 nW to 10 mW
A. Spectrum analyzer
B. Oscilloscope
D. Milliammeter
A. Owen bridge
B. Hay bridge
C. Potentiometer bridge
D. Wheatstone bridge
49. Which of the following is a dc bridge that is very useful for making
extremely accurate voltage measurements?
A. Wheatstone bridge
B. Potentiometer bridge
C. Kelvin bridge
D. Owen bridge
A. Heating effect
B. Electrostatic effect
C. Magnetic field
D. Chemical effect
A. peak
B. rms
C. average
D. instantaneous
A. ac work only
B. dc work only
53. What instrument which springs provide the controlling torque as well
as serve to lead current into and out of the operating coil?
A. Moving-iron
B. Permanent-magnet
C. Hot-wire
D. Iron-wire
54. In VTVMs, _________ refers to the smallest signal that can be reliably
measured.
A. threshold signal
B. minimum signal
C. sensitivity
D. input signal
A. VTVM
B. Tachometer
C. Spectral meter
D. Stroboscope
D. Frequency generator
A. Multimeter
B. DMM
C. Oscilloscope
D. Telescope
58. Which of the following forces does not act on the moving systems of
analog instruments?
A. A deflecting force
B. A controlling force
C. A damping force
D. An electrostatic force
A. six times
B. one-half time
C. nine times
D. three times
A. 50 mA
B. 50 nA
C. 50 A
D. 50 A
61. What instrument is used for measuring the amount of current flowing
in a circuit?
A. Voltmeter
B. Ammeter
C. Oscilloscope
D. Meter amperage
A. VOM
B. VTVM
C. DMM
D. DTMF
63. What is the typical full-scale voltage across a moving coil voltmeter?
A. 50 nV
B. 50 V
C. 50 V
D. 50 mV
A. Cathode
B. Grid
C. Anode
D. Phosphor screen
A. Uniform
B. Logarithmic
C. Squared
D. Exponential
A. Lissajous pattern
B. Nyquist pattern
C. Barkhausens criterian
D. Fermats pattern
A. 1.01 A
B. 100.1 A
C. 10.10 A
D. 10.01 A
A. A shunt
B. A multiplier
D. A series
A. Electron gun
D. Sawtooth generator
A. Horizontal
B. Diagonal
C. Vertical
D. Voltage
A. Hot-wire
B. Moving-iron
C. Dynamometer
D. Thermocouple
73. Which of the voltmeter is used for measuring high direct voltage (say
10kV)?
B. Hot-wire
C. Electrostatic
D. Moving iron
D. use thermocouple
75. What provides visual display showing the form of the signal applied as
a waveform on the front screen of a cathode ray oscilloscope?
A. Television
B. Computer
C. Meter face
D. CRT
A. voltmeters
B. ohmmeters
C. ammeters
D. wattmeters
A. 0.1 mW to 100 W
B. 0.1 W to 100 mW
C. 0.1 nW to 100 W
D. 0.1 pW to 100 nW
A. phase
B. high temperatures
C. frequency
D. power
A. Moving-iron
B. Dynamometer
C. Hot-wire
A. Induction voltmeter
C. Induction wattmeter
D. Induction ammeter
A. An integrating
B. A recording
C. An indicating
D. A power meter
82. A certain pulse measures 10ms and has a period of 50ms. The duty
cycle is
A. 20%
B. 10%
C. 5%
D. 100%
A. At beginning
B. At half of full
C. At ending
D. Any part
A. at far left
B. at far right
C. at ending
D. any part
C. Spectrum analyzer
D. VTVMs
87. The interval of a pulse from start to end is the _____ of the pulse
A. period
B. width
C. position
D. duty cycle
B. Sawtooth generator
C. Horizontal amplifier
D. Vertical amplifier
89. A material that glows when struck by the energetic electrons in a CRT.
A. Aquadag
B. Silicon
C. Germanium
D. Phosphor
90. What sensor provides a change of resistance with typical power range
of 1W to 10mW and with maximum frequency greater than 100GHz?
A. Thermal converter
B. Diode sensor
C. Thermocouple sensor
D. Thermistor sensor
A. 67.4%
B. 6.74%
C. 4.76%
D. 47.6%
92. Most AC voltmeters have an rms scale which is valid only if the input
signal being measured is a ________ signal.
A. square wave
B. triangular
C. sawtooth
D. sinusoidal
A. Wheatstone
B. Maxwell bridge
C. Hay bridge
D. Schering bridge
A. Wheatstone bridge
B. Wien bridge
C. Hay bridge
D. Maxwell bridge
A. resistance
B. frequency
C. inductance
D. capacitance
A. Maxwell bridge
B. Wheatstone bridge
C. Kelvin bridge
D. Hay bridge
A. Wien bridge
B. Maxwell bridge
C. Kelvin bridge
D. Hay bridge
A. / V
B. /A
C. V/
D. V/A
99. What is the smallest change in applied stimulus that will indicate a
detectable change in deflection in a indicating instrument called?
A. Sensitivity
B. Accuracy
C. Resolution
D. Precision
A. Ohmmeter
B. Insulation meter
C. Wien bridge
D. Megger