Академический Документы
Профессиональный Документы
Культура Документы
Laptop Configuration
1. Power Management
Set Power Management Laptop always On :
Start -> Settings -> Control Panel -> Power Options -> Set
All Power Scheme never
2. Virtual Memory
Set Virtual Memory :
Start -> Settings -> Control Panel -> System
Advance -> Performance Settings
C. TEMS Investigation :
- Workspace Configuration
After installition process, open Tems Investigation.
>> All Programs -> TEMS Investigation -> Data
Collect
This is the example workspace for 2G (Mode Dedicated-Idle).
- Map Configurations
Create Geoset : Click Geoset Manager on Map
window
1. On layer control
remove all layer except Pinpoint, Cell,
Event, AMR, RF Quality and Coverage layer
2. Add layer Route, Road, MCOM Site, and other *.tab
3. Save Geoset
4. Load Cell file : Configuration -> General -> Cellfile Load
5. Use Cell Definition File then choose cell file
-> Dial)
4.
5.
6.
7.
Video Call CS
In general cs for video call is same as voice call, but in video
10. After all route complete, wait untill call end then stop
command sequence and stop recording.
F. POST PROCESSING:
- Report Generator
1. Open TEMS Data Collection : Start -> TEMS Products ->
TEMS Investigations6.1.4 Data Collection
2. Menu Tab Logfile -> Report Generator
3. Add logfile
6. Save *.mex
7. Choose Logfile : Click Browse file
8. If there are more than one logfile we can merge it by
Merge Output
9. Choose Output directory : Click Browse dir
10. Give Prefix : Ded if Dedicated and Idle if Idle
14. Open the exported file into MapInfo : Menu Tab File ->
Open
EVENTS on RXQUAL_SUB
21. Create Events on RXQUAL_SUB
22. Open again the exported file (Ded_orinaica)
SPIDER GRAPH
29. Activate spider graph : Menu Tab Tools -> Tool Manager
30. Spider Graph Load and Autoload
31. See table structure of cell in MCOM Site : Menu Tab Table
-> Maintenance -> Table Structure -> View/Modify Table
choose MCOM Site
33. Click OK
34. Create Spider Graph : Tools -> Spider Graph -> Spider
Graph
35. Choose Origin and Destination table
36. Save the Spider Graph table : Save Copy As -> (ie.
orinaica)
37. From Spider Graph, We can analyze :
- Dominant Cells
- Overshoot Cells
- Swap Feeder
G. TROUBLESHOOTING :
- 2G Frequency Scanning
Purpose : to verify level signal each BCCH ARFCN plan
1. Setup frequency scan : Click Scan Properties
2. Select channels : Tab Scanned channels -> Manual
selection -> Select
4. Decode BSIC
- TRX Check
Purpose : to verify damage TRX in each sector
Where is TRX ?