Академический Документы
Профессиональный Документы
Культура Документы
High strength
Non-slump
Strong adhesion
Impact-resistant
Good chemical resistance
Non-shrink
Epoxy-based
Trowels to a smooth finish
Easy to use
Supplied in pre-weighed units
No bonding agent or primer required
PACKAGING
MasterBrace ADH 2200 is available in 5kg units.
COMPOSITION
Two-component epoxy-based mortar filled with
selected fine aggregates.
TYPICAL PROPERTIES
Colour:
Mixed density:
Flashpoint:
Compressive strength
to ASTM D695:
Bond strength:
Pot life:
Tack-free time:
Full cure:
Cement grey
3
o
1750kg/m at 25 C
N/A
2
>60N/mm at 7 days
Greater than that of the
concrete
o
At 25 C: 1 hour 45 minutes
o
At 40 C: 45 minutes
o
At 25 C: 7 hours
o
At 40 C: 2 hours
o
At 25 C: 5 days
o
At 40 C: 3 days
STANDARDS
ASTM C881: Type I and IV Grade 3 Class B and C
CHEMICAL RESISTANCE
MasterBrace ADH 2200 has excellent resistance
to the following: most aqueous systems; sewage;
urine; fresh water; sea water; diluted and
concentrated alkalis; diluted acids; sulphur gases;
mineral oil; vegetable and animal oils and fats;
ammonia and formaldehyde.
APPLICATION PROCEDURE PREPARATION:
All loose particles, laitance, dust, grease, etc. must
be removed prior to application of MasterBrace
ADH 2200.
SHELF LIFE
Up to 12 months if stored in unopened containers
according to manufacturers instructions.
SAFETY PRECAUTIONS
As with all chemical products, care should be
taken, during use and storage, to avoid contact
with eyes, mouth, skin and foodstuffs. Treat
splashes to eyes and skin immediately. If
accidentally ingested, seek medical attention. Reseal containers after use. Use in well-ventilated
areas and avoid inhalation. For further information,
refer to the material safety data sheet.
NOTE
Field service, where provided, does not constitute
supervisory
responsibility.
For
additional
information,
contact
your
local
BASF
representative.
BASF reserves the right to have the true cause of
any difficulty determined by accepted test methods.
QUALITY STATEMENT
All products manufactured by BASF Egypt, or
imported from BASF affiliate companies worldwide, are manufactured to procedures certified to
conform to the quality, environment, health & safety
management systems described in the ISO
9001:2008,
ISO
14001:2004
&
OHSAS
18001:2007 standards.
* Properties listed are based on laboratory controlled tests.
BASF_CC-EG/Brace ADH_2200_09_10/v1/06_14