Вы находитесь на странице: 1из 9

SOME SVDR SOLUTIONS

APower module
1 Phenomenaafter the system is rebooted,
After receive software has been started, you could observe system monitor alarm area(open receive software
>voyage data recorder system >system information >system monitor alarm area),if it do not
displayPOWER AC .6EorPOWER DC 6D,or display POWER FAULTY.
Solution: Replace the power controling PCB. Pls pay attention to how to connect the cable with the PCB.

2 PhenomenaWhy the fan still work aftr turnning off the UPS power.
Solution:The fan will stop after cut off AC power supply and DC power supply.
3 PhenomenaWhen the power supply of the batteries in UPS could not support two hours, and how to
replace the batteries in UPS.

PDF "pdfFactory Pro" www.fineprint.cn

B PDC module
How to disassemble the cable of PDC.

C,

MEU module PhenomenaWhen recording there is noise.

..

PDF "pdfFactory Pro" www.fineprint.cn

C.MIC module
How to adjust the gain of MIC.

How to debug the MIC.


For example:

PDF "pdfFactory Pro" www.fineprint.cn

PDF "pdfFactory Pro" www.fineprint.cn

D. ALARM module
PhenomenaAll lights in the alarm are actived.
Solution: 1Check PDC if the RJ45 connection of PDC is connected well with MEU, or the power of XS1 in
alarm has been connected improper.

2Connect the monitor to check the system.


3Observe the phenomena in the monitor, in our opinion,we wish you could take some photo for
our analyse.
4Restart the system.
1Shut down power unit

PDF "pdfFactory Pro" www.fineprint.cn

2 )5mins later.
3)Switch on power unit
4on/offon(meanwhile) with the key of MEU(Main Electronic Unit).
on/normalon/offon/normal(meanwhile) with the key of MEU.
5)The picture represents normal running in 5mins .

Phenomena:Receive software could not receive data from source. Eg. GPS,AIS ,GRYO,SPEEDLOG
Solution: 1, Check the correlative equipmentEg.GPS,AIS,GRYO,SPEEDLOGif the outputs are normal.
2, Check the correlative cables if they are connected well.

PDF "pdfFactory Pro" www.fineprint.cn

3, Check the PCB in Data Acquisition Unit(DAU) if the correlative lights are flash.

4, If the signal has been checked to input. But the correlative light is not flash, it may be caused by the
correlative optocouple. It had better to replace the optocouple.
PhenomenaThe system works unstable.
Solution1, the temperature of CPU is too high >60C ,pls install the additional fans.

2,Maybe there are some impurities on the golden figure of main board,or some components
have been broken.

PDF "pdfFactory Pro" www.fineprint.cn

PhenomenaIt could not record, just hear noise.


Solution: The mix board was broken, we advise to replace it.

PhenomenaIf replace the harddisk or mainboardCPU boardthe receive software could not
receive data.
Solution: 1, replace the harddisk
1.1. install win2000,CANBUS driver, Audio driver, Radar image driver, Mainboard
driver, or so on.
1.2.install Receive software; Configuration software; AIS playback software;
Watchdog; Pls reference for manual if learn about more details.
1.3.After restartingyou will watch the following picture when Receive software
automatically started.

PDF "pdfFactory Pro" www.fineprint.cn

is

PDF "pdfFactory Pro" www.fineprint.cn

Вам также может понравиться