Академический Документы
Профессиональный Документы
Культура Документы
chimney.TheenhancementinwindLoadswillbe
duetoanincreaseinthevalueofCD.Thevalueof
C,foreachchimneylocatedwithinadistanceof3
timestheeffectivediameter,maybecalculatedby
assumingthevalueofCDtobeincreasinglinearly
from0.8(foraspacingof3effectivediameters)to
avalueof2O(forahypothetical spacingof1
effective diameter which implies that the two
chimneystoucheachotheriftheyarecylindrical
andidentical).ThesevaluesofCDapplyuptothe
height of the nearest interfering chimney, if the
chimneysareofunequalheight.Itispermissibleto
obtainmoreaccuratevaluesofCnbycarryingout
properlyconductedmodeltestsinwindtunnels.
IXX=
610003/12+21048.9104+25079(5002
43.8) = 26350.45104 mm4
Section modulus, ZProv=I/y=263504.5104/500=
5270090>438310 which is alright.
Torsional constant, J=1/3bt
=2{1/3150183+1/3(150-18)183}+1/3*1000
63 =1168416mm4. Shear stress due to
torsion=T/J*max=5467.6*103/1168416*(18+6) =
112.30 N/mm2
A-6.1 AERODYNAMIC INTERFERENCEOF
TWO OR MORE CHIMNEYS
= equivalent aspect ratio = H/d
Ci c. =RMS lift coefficient to be taken as o-12
L= correlation length in diameters, which may be
taken as 1.0 in the absence of field data
01=CLd4zezeiH1 (L/2t) 1/2
Where
Zei = height in m at which d%&/J t is a
maximum in the it mode of vibration
The values of a do not exactly match the
variation of & factors of IS 875 ( Part 3 ) : 1987.
However, they have been chosen to be slightly
conservative and should be used only in A-5.3(b)
and nowhere else. Calculations should begin by
first taking zei = H and progressively decreasing
z till a maximum in qoi is observed for each
mode. However, if Vcr for any mode is more than
the maximum wind speed expected at site for ze=
H for the first mode of vibration itself, the
chimney will not experience any significant
across-wind load in that mode. For very tall
chimneys roi may not show a maximum, either in
first or the second mode at speeds less than the
maximum expected at site. In that case, the value
of ze shall be taken as the value at which the
calculated Vcr equals the maximum expected
velocity V, at ze. Now shear stress due to shear2
force= 165625/2*5079+1000*6=10.2503N/mm
and total shear
stress=112.30+10.2503 equals to
122.55N/mm2>100N/mm2(0.4*250).
ZProv=
1276861.9104/900=14187354mm3>
434989.80mm3 which is all right.
8
A-6.2 When chimneys in a cluster are of different
sizes, the magnification factors shall be established
by model tests or on the basis of observations on
closely spaced dissimilar chimneys. Such
interference in dissimilar chimneys need not be
considered if the smaller chimney is at a distance
of more than 20 times the diameter at 2/3rd height
of the nearest larger chimney. For a given
configuration of identical chimneys, the