Академический Документы
Профессиональный Документы
Культура Документы
PROPELLER SHAFT
Page
PRECAUTIONS ..................................................... PR-2
TROUBLESHOOTING ........................................ PR-2
PROPELLER SHAFT ............................................... PR-3
PR-2 PROPELLER SHAFT - Precautions, Troubleshooting
PRECAUTIONS
Be careful not to grip the propeller shaft tube too tightly in the
vise as this will cause deformation.
TROUBLESHOOTING
Problem Possible cause Remedy Page
PROPELLER SHAFT
COMPONENTS
Flange
1
I
Sleeve Center
6 $Lip
Yoke Bearing
I
A ;SST Matchrnarks
PRO160 PRO161
(b) Clamp the bearing outer race in a vise and tap off the
propeller shaft w i t h a hammer.
HINT: Remove the bearing on the opposite side in the
same procedure.
(e) Clamp the bearing outer race in a vise and tap off the
yoke w i t h a hammer.
HINT: Remove the bearing on the opposite side in the
same procedure.
Color -
Sleeve Yoke
I
Select the bearing according t o whether or not there is a
drill mark and "V" stamp on the yoke section.
(e) Using SST, adjust both bearings so that the snap ring
grooves are at maximum and equal widths.
-
PR-8 PROPELLER SHAFT - Propeller Shaft
y- ,,
SST (c) Using SST t o hold the flange, press the bearing into
position by tightening d o w n a new nut.
SST 0 9 3 3 0 - 0 0 0 2 1
Torque: 1.850 kg-cm ( 13 4 ft-lb, 181 N.m)
(dl Loosen the nut.
(e) Torque the nut again.
Torque: 7 0 0 kg-cm ( 5 1 ft-lb, 6 9 N.m)
(f) Using a hammer and punch, stake the nut.
Matchmarks
PR-10 PROPELLER SHAFT - Propeller Shaft