Академический Документы
Профессиональный Документы
Культура Документы
Flat
Horizontal
Double Motor
Soft Fold
Top Down
Gravity Drop
Flat
Triangular
Double Motor
Bottom Up
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY. MechoShade is a registered trademark of, and SkyLighter is a trademark of, MechoShade Systems, Inc. Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
Support Cable
Drive Cable
Motor
with closure
Motor with
closure
Hembar
*Subject to length and slope angle.
Drive Cable
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY. MechoShade is a registered trademark of, and SkyLighter is a trademark of, MechoShade Systems, Inc. Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
The ElectroShade® SkyLighter™ Shade is a specialized shade A Non-Tensioned SkyLighter Soft-Fold Shade is designed
system designed for solar protection and room darkening for angled, gravity-drop or horizontal shades which have the
requirements where horizontal, inclined, angled or bottom up elegance of a traditional pleated roman shade.
type shading is required. Gravity-Drop Soft-Fold Shades: The system has only a cable
A Tensioned SkyLighter Roller Shade is a motorized shade take up tube with tubular motor with a fixed pleat at the head
designed for applications that require a taught flat shade like rail. The cable take up tube raises the shade by lifting the drive
that shown above. The system consists of two synchronized cables attached to the hembar at the bottom of the shade.
tubular motors and a special electronic control unit to control A separate set of Spacer Cables keep the pleats properly
the tautness of the shade band. One motor is for fabric roll-up, spaced to a series of 1" (25mm) tubes sealed inside the shade-
the second motor is for cable take-up. The electronic unit cloth, while a Guide Cable keeps the shade tracking straight.
controls each motor independently and maintains a dynamic Horizontal Soft-Fold Shades: The system consists of two
(moving) tension on the shadeband as well as final tension cable take up tubes, one for each direction of travel, each with
adjustment thus minimizing fabric sag while the fabric is both its own motor and drive cable and a fixed pleat at the head rail.
moving and stationary. Adjustments to both dynamic and final A separate set of Spacer Cables keep the pleats properly
tension are made via the electronic control. The size and weight spaced to a series of 1" (25mm) tubes sealed inside the shade-
of the shade will determine if idler rollers, guide cables and/or cloth, while a Guide Cable keeps the shade tracking straight.
guide track are necessary.
A Motor/Spring SkyLighter Roller Shade is a single tubular
motor and spring system for angled or horizontal shades up to
6 x 8 ft (183 x 245 cm). As the motor in the cable take up tube
Non-Tensioned
pulls the shadeband across the opening it creates resistance
SkyLighter
as it tightens the opposing spring, in the fabric tube, providing M
are necessary.
Horizontal
Soft-Fold
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY.. MechoShade and ElectroShade are registered trademarks of, and SkyLighter is a trademark of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
Fabric tube Inside of Skylight Well Reinforced Blocking (by others) in accordance
Optional low voltage with MSS shop drawing requirements
A/V interface for A/V
Reinforced
Optional Support Cables
Blocking Optional Side Channel
Dry Contact (as required)
(by others) (as required)
Closure
Shade Cloth
Direction 3/64" (1.18mm) Cable Tube
Control Module fl Stainess Steel
in an 8" x 10" x 4" of Travel Drive Cables
(203mm x 254mm
x 101mm) electrical
enclosure (by shade
contractor) –2" (50.8mm) fl Idler Rollers
with fabric sleeve to match fabric Optional Support Cables
at 1/3 points (or as required) (as required)
J-Box
(by others) Fabric Motor with lead Cable Motor with lead Flush Mount
(2.3 amp max. by Optional Side Channel (2.3 amp max. by
shade contractor) (as required) shade contractor) Typical 1 foot
120VAC motor lead
(230VAC) NOTE:
Power Supply Disconnect Plug Kit
J-Box Disconnect Plug Kit
(by shade contractor)
(by others) (by shade contractor)
Tensioned SkyLighter
Typical 5 foot motor J-Box lead
Shade Switch
(by shade contractor)
A partial list of components. Items (parts) will vary based on configuration, design and size of the SkyLighter™ Shade.
1. One Tensioned SkyLighter™ Shade control module in a 7. Two pair of mounting brackets – one for each tube (pair
8" x 10" x 4" (203mm x 254mm x 101mm) deep electrical consists of one drive end and one idle end bracket).
enclosure required for each SkyLighter Shade. 8. Two spring loaded idle-end pins.
2. One Tensioned SkyLighter Shade Switch. 9. 1/16" (1.5mm) diameter coated stainless steel drive cable.
3. One fabric shadeband attached by means of a SnapLoc® 10. Two 1/4" (6.3mm) diameter x 3" (76.2mm) long (approx.)
spline to a SnapLoc extruded aluminum tube with a aluminum drive cable attachment rods.
tubular directional motor installed inside the tube
11. Drive cable attachment screws and washers
(motor head and leads exposed).
(for attachment to cable take up tube).
4. SnapLoc extruded aluminum tube for cable take up
12. Brass, copper or lead cable fittings.
with a tubular directional motor installed inside the tube
(motor head and leads exposed). 13. Two 5' (1524mm) long j-box leads with mating disconnect
plugs (mates with motor lead). Longer leads optional.
5. One exposed hembar (shipped attached or loose).
14. Optional side channels and/or support cables as required.
6. Two hembar end caps with attachment screws.
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY.. MechoShade and SnapLoc are registered trademarks of, and SkyLighter is a trademark of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
Disconnect Plug Kit Fabric Motor with lead Inside of Skylight Well Spring inside the cable take up tube
(by shade contractor) (2.3 amp max. by to assist unwinding the shade.
Flush Mount
shade contractor)
J-Box
(by others) Optional Support Cables
Optional Side Channel
Any ElectroShade four (as required)
(as required)
motor controller in an
8" x 10" x 4"
(203mm x 254mm Shade Cloth
x 101mm) electrical 3/64" (1.18mm)
enclosure (by shade Cable Tube
Ø Stainess Steel Direction
contractor) Drive Cables of Travel
(4 or 6-conductor
flat modular cable
by contractor) ±2" (50.8mm) Ø Idler Rollers
120VAC with fabric sleeve to match fabric Optional
Optional Support
Support Cables
Cables
(230VAC) at 1/3 points (or as required) (as (as required)
required)
Power
Supply
Fabric tube Reinforced Blocking (by others) in accordance
Optional Side Channel
Dry Contact with MSS shop drawing requirements
(as required)
Closure Reinforced
Blocking
(by others)
Switch
(by shade To other
contractor) A/V
IQ/MLC’s
Optional
low voltage
interface
for A/V
A partial list of components. Items (parts) will vary based on configuration, design and size of the SkyLighter™ Shade.
1. One ElectroShade® MLC™/2 or IQ/MLC™ four motor 8. Two spring loaded idle-end pins.
controller, with RS-232 capability, in a 8" x 10" x 4" 9. 1/16" (1.5mm) diameter coated stainless steel drive cable.
(203mm x 254mm x 101mm) electrical enclosure.
10. Two 1/4" (6.3mm) diameter x 3" (76.2mm) long (approx.)
2. Up to four (4) Switches per controller. aluminum drive cable attachment rods.
3. One fabric shadeband attached by means of a SnapLoc® 11. Drive cable attachment screws and washers (for attach-
spline to a SnapLoc extruded aluminum tube with a ment to cable take up tube).
tubular directional motor installed inside the tube
12. Brass, copper or lead cable fittings.
(motor head and leads exposed).
13. One 5 ft. (1524mm) long j-box lead with mating disconnect
4. SnapLoc extruded aluminum tube for cable take up
plugs (mates with motor lead). Longer leads optional.
with a spring installed inside the tube.
14. Optional side channels and/or support cables as required.
5. One exposed hembar (shipped attached or loose).
6. Two hembar end caps with attachment screws.
7. Two pair of mounting brackets – one for each tube (pair
consists of one drive end and one idle end bracket).
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY.. MechoShade and SnapLoc are registered trademarks of, and MLC, IQ/MLC and SkyLighter are a trademarks of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
SLOPE SCHEMATIC
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY. MechoShade and ElectroShade are registered trademarks of, and SkyLighter is a trademark of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
HEMTUBE
HEMTUBE HEMTUBE
2-3/4" x 1-5/8" 3"
(69.8mm x 41.2mm) (76mm)
GP HEMTUBE WITH
GP HEMTUBE WITH GP HEMTUBE WITH SIDE CHANNEL DETAIL
GUIDE TRACK DETAIL GUIDE CABLE DETAIL A double motor system
(OPTION A) (OPTION B) with Idler Rollers.
(OPTION C)
DRIVE TUBE AND
M SHADE ASSEMBLY
(MOTOR INSIDE TUBE)
IDLER ROLLERS
45¡- 90¡
REQUIRED: 0¡- 45¡
MAY BE REQUIRED: 45¡- 90¡.
0¡- 4
ADVISE WIDTH X LENGTH
+ ANGLE.
SCHEMATIC SECTION
GUIDE TRACK *
* GP HEMTUBE
AND WHEEL ASSEMBLY
FOR GUIDE TRACK OR
GUIDE CABLE ASSEMBLY
SPECIFY OPTION A , B OR C"
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY. MechoShade and ElectroShade are registered trademarks of, and SkyLighter is a trademark of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
DRIVE TUBE
M M WITH MOTOR INSIDE
0¡ TO 45¡
SCHEMATIC SECTION
PERSPECTIVE VIEW
SLOPE SCHEMATIC
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY. MechoShade and ElectroShade are registered trademarks of, and SkyLighter is a trademark of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
FIXED PLEAT
* GP HEMTUBE
FOR GUIDE TRACK OR
GUIDE CABLE ASSEMBLY
SPECIFY OPTION A
OR OPTION B
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY. MechoShade and ElectroShade are registered trademarks of, and SkyLighter is a trademark of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com
Solar Control, LLC | 888-550-4836
NOTES
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
___________________________________________________________________________
© Copyright 2004, MechoShade Systems, Inc., Long Island City, NY. MechoShade and ElectroShade are registered trademarks of, and Suburban/2 is a trademark of, MechoShade Systems, Inc.
Specifications subject to change without notice.
http://SolarControlLLC.com